American Standard 0954.000.020 Murro Wall-Mount Sink Installation Instructions

INSTALLATION INSTRUCTIONS

CARE AND MAINTENANCE

MURRO WALL HUNG BASIN

FOR CONCEALED ARM SUPPORT, REFER TO CARRIER MANUFACTURER’S INSTRUCTIONS

Thank you for selecting American Standard - the benchmark of fine quality for over 100 years. To ensure this product is installed properly, please read these instructions carefully before you begin. (Certain installations may require professional help.) Also be sure your installation conforms to local codes.

!

CAUTION: PRODUCT IS FRAGILE. TO AVOID BREAKAGE AND POSSIBLE INJURY HANDLE WITH CARE!

NOTE: Pictures may not exactly define contour of china and components.

OBSERVE LOCAL PLUMBING AND BUILDING CODES

12"

(305mm)

C L

12"

(305mm)

4-1/4"

(108mm)

DRYWALL

BARRIER FREE, UNIVERSAL ACCESS INSTALLATION:

For Universal Design Options, top of front rim may be mounted at

813 mm (32") from the finished floor to meet ADA and ANSI A117.1 requirements, except in Ontario and California. In Ontario, the code requires a height of 838 mm (33"). 864 mm (34") is required for

California Title 24 (see Figure 3). Check local codes.

MOUNTING

LEG BOLTS

8-1/2"

(216mm)

SUPPLIES

DOUBLE

2" x 8"

(50 x 203mm)

WOOD BRACE

Suggested Tools and Supplies:

Adjustable wrench, 3/4" socket wrench, No. 3 Philips screwdriver, pliers, rule, carpenter level, drill, 1/8" (3 mm) dia. & 3/8" (10 mm) dia. drill bits, basin faucet, hot/cold screwdriver stop, and drain assembly.

WASTE

26-1/2"

(673mm)

32-1/2"

(826mm)

*31-1/2"

(800mm)

*IN ONTARIO

Provide

Rough-In:

Install waste pipe. Space supplies (hot/cold screwdriver stops) 1-5/8" (41mm) to either side of centre. Firmly attach two 2" x 8" (50 x 203 mm) wood braces to wall studs. Bottom of brace should be 26-1/2" (673 mm) up for floor and extend a minimum of 12" (305 mm) to either side of waste. Complete drywall installation (see

Figure 1).

FIGURE 1

FIGURE 2

FIGURE 3

9-3/4"

(248mm)

7-3/4"

(197mm)

FINISHED FLOOR

SEMI-PEDESTAL/SHROUD

ANCHOR HOLES

7-1/2"

(191mm)

3-3/4"

(63mm)

CONCEALED ARM

CARRIER HOLES

BASIN ANCHOR

HOLES

SLOTS FOR

BASIN LEG BOLTS

BEND FLEXIBLE

SUPPLY

TUBES

Install

Mounting

Bolts:

Mark locations of 4" (102 mm) mounting lag bolts 4-1/4"

(108 mm) to either side of centre. Pre-drill mounting holes then fasten lag bolts and washers supplied. Allow each bolt head to protrude 1-1/4" (32 mm) from finished wall.

Level

Basin and

Mark

Screw

Locations:

Mount basin on protruding lag bolts and level. Mark basin anchor holes. If semi-pedestal/shroud is desired

(ordered separately), position it under lips at bottom of basin and mark anchor holes. Set fixtures aside.

Pre-drill anchor holes in wall where marked, drilling semi-pedestal/shroud holes at a 45˚ angle toward centre.

Install

Fittings:

Mount

Basin:

Install faucet and waste assembly according to manufacturer’s instructions before installing basin.

Remount basin on lag bolts and secure with 2" (51mm) wood screws and washers provided. Firm up lag bolts but do not over-tighten.

Connect

Supplies:

Connect hot/cold supplies and drain pipe. Bend flexible supplies to clear opening in semi-pedestal/shroud. Turn on water. Check for leaks.

Mount

Pedestal:

Reposition semi-pedestal/shroud. Secure to wall using

2" (51 mm) screws and washers provided.

BARRIER FREE

34"

(864mm)

*33"

(838mm)

*IN ONTARIO

WASTE

10"

(254mm)

FINISHED FLOOR

CUSTOMER SERVICE INFORMATION

In the United States:

American Standard Brands

P.O. Box 6820

Piscataway, New Jersey 08855

Attention: Director of Consumer Affairs

For residents of the United States, warranty information may also be obtained by calling the following toll free number: (800) 442-1902 www.americanstandard-us.com

In Canada:

AS Canada ULC

5900 Avebury Ave.

Mississauga, Ontario

Canada L5R 3M3

Toll Free: (800) 387-0369 www.americanstandard.ca

In Mexico:

Customer Service Manager

AS Maquila, S.A. de C.V.

Via Morelos #330

Col. Santa Clara

Ecatepec 55540 Edo. Mexico www.americanstandard.com/mx

P r o d u c t n a m e s l i s t e d h e r e i n a r e t r a d e m a r k s o f A S A m e r i c a , I n c .

© A S A m e r i c a , I n c . 2 0 1 2

7 3 0 4 6 4 - 110 Rev. A