advertisement
User Manual
SE
``
WARNING
Read the User Manual carefully before operating
AFISCOOTER S
.
If you do not fully understand any part of this manual, please contact your dealer or any of our Service Centres.
Read this manual step by step, as injury or damage may occur from misuse!
WARNING
Electromagnetic Interference
(“EMI”) can cause powered vehicles to behave erratically, which could be dangerous to the user.
For your safety and protection, it is IMPERATIVE that you take time to read
Chapter 10
(“EMI WARNING”) before operating
AFISCOOTER S
.
Serial Number and
Manufacturer’s data are fixed at the front, on the plastic mud guard cover on the metal label of the
AFISCOOTER S
.
(See 4.6 in figure 3, page 18)
WARRANTY
AFIKIM ELECTRIC VEHICLES
strives continuously to improve its products, their quality and reliability, in constant effort to ensure its customers’ satisfaction as well as its place in the market.
Warranty for
AFISCOOTER S
is subject to your local distributor's warranty.
CE CERTIFICATION
The Afikim Electric Vehicles Ref. Registration Number with the Competent
Authority (UK) Is: CA000292.
Our Authorized Representative with the Competent Authorities is:
MEDES LTD., POB 231
Stanmore, Middlesex, HA7 4YA, England
TEL/FAX: 0044-181-954-9964
2
``
CONTENTS
3
``
CHAPTER 1
– OVERVIEW OF THE
AFISCOOTER S
(MAIN FEATURES)
Congratulations on choosing the
AFISCOOTER S
as your electrically powered scooter.
AFISCOOTER S
is a scooter for elderly and disabled persons, and for fun and sport.
Scooter classification: Class B in accordance with EN12184.
AFISCOOTER S
is designed for a maximum occupant mass of 160 kg (352 lbs) with 3 wheels, and 200Kg (440 lbs) with 4 Wheels.).
AFISCOOTER S
is an outdoor scooter designed to work in normal environmental conditions from very cold temperatures (-30ºC/-22ºF) to very hot temperatures
(+45ºC/+113ºF).
AFISCOOTER S
will operate in light rain showers, but extended use is not recommended in
heavy rain or snow.
AFISCOOTER S
is easy to operate. The relatively large wheels allow the user drive on unpaved roads, over moderately rough terrain and over obstacles as high as
5” (12 cm).
Refer to Appendix A: Specification Sheet (Page 30) for the required tyre pressure.
AFISCOOTER S
maximum
safe
slope is: 11.3º (20%).
The braking system stops
AFISCOOTER S
smoothly and within a short distance after the throttle control lever is released.
AFISCOOTER S
is equipped with both front and rear shock absorbers to give the user a comfortable and smooth drive, even when using the vehicle on moderately rough roads.
A standard handbrake is also provided for backup.
The seat is spacious and comfortable, and can be rotated for easy access (standard seats). It can be adjusted forward and backward. The seat can also be adjusted up and down by a technician.
All controls are conveniently mounted on the tiller and are simple to operate.
Under normal conditions,
AFISCOOTER S
can travel approximately 45 km (30 miles) before the batteries require recharging.
After reading through this entire manual and before using
AFISCOOTER S
, do a visual check of all the parts, of the vehicle, to make sure that there is no visible damage. If you have any questions or concerns, contact your dealer.
AFISCOOTER S
was developed to use maintenance-free sealed batteries only.
A Maintenance Manual is available for trained technicians.
4
``
CHAPTER 2
– SAFETY SYMBOLS FOR THE
AFISCOOTER S
WARNING! An authorized supplier or qualified technician must perform the initial setup of this scooter, and must perform all of the procedures in this manual.
The symbols below are used throughout this user’s manual and on the scooter to identify warnings and important information. It is very important for you to read them and understand them completely.
WARNING! Indicates a potentially hazardous condition/situation. Failure to follow designated procedures can cause either personal injury, component damage, or malfunction.
On the scooter, this is a triangular black symbol.
MANDATORY! These actions must be performed as specified. Failure to perform mandatory actions can cause personal injury and/or equipment damage. On the scooter, this is a white symbol on a dark background.
PROHIBITED! These actions are prohibited. These actions must not be performed at any time or under any circumstances. Performing a prohibited action can cause personal injury and/or equipment damage. On the scooter, this is a black symbol with a circle and slash.
Please note and strictly adhere to the following Safety
Instructions. Additional Warnings and Notices are printed in this user manual; it is imperative that you read carefully all chapters of this manual before operating the
AFISCOOTER S
.
It is also advisable to refresh your memory by re-reading this manual periodically.
Get acquainted with
AFISCOOTER S
and its operational features before driving it.
Drive slowly (speed limit dial set to MIN) until you get used to
AFISCOOTER S
, its various functions, safety features, and to its braking capabilities and limitations.
Watch carefully for pedestrians and drive your
AFISCOOTER S
accordingly.
In crowded areas, always drive with the speed limit dial set to
MIN.
Drive only where permitted according to all applicable local laws and ordinances.
AFISCOOTER S
is 65 cm (25.5") wide. Take great care not to hit persons or any objects around the vehicle.
5
``
Never remove any of the
AFISCOOTER S
safety
parts such as fenders, plastic covers or emergency brake lever.
Never remove
any of the
Warning labels.
If any of the Warning labels is removed, gets worn off or painted over, etc. ask your dealer to supply you with a new label.
Never put
your hands, fingers, or legs into any moving parts or under any protective cover, since moving parts and hot surfaces are under those covers.
When making adjustments (folding the seat back, adjusting the armrest, moving the seat forward or backward, adjusting the tiller distance), as well as when squeezing the throttle control lever or handbrake, always take care that your hands and fingers are not trapped between any of the moving parts.
When moving the tiller forward or backward, be careful not to trap your fingers in the mechanism.
Never load
AFISCOOTER S
with more than 160 kg (352 lbs) or
200 kg (440 lbs), depending on the model) total load (user weight and all other loads combined, including baskets).
The load in the rear basket must not exceed 10 kg (22 lbs).
The load in the front basket must not exceed 8 kg (17.6 lbs).
AFISCOOTER S
is designed to carry ONE person only on the
Single Seat model. Never operate it with an additional person on board, including a child.
Never inflate
AFISCOOTER S
tyres more than the manufacturer’s recommended pressure, shown on the tyres.
Never use
AFISCOOTER S
on stairs.
Never try to go over an obstacle that is more than the maximum recommended slope angle and obstacle height given in the specification sheet. When driving over an obstacle, always drive so that the front of
AFISCOOTER S
is facing the obstacle.
If for any reason
AFISCOOTER S
does not stop when you release the throttle control lever, or takes longer to stop than it should (3 meters on a level surface), immediately use the handbrake to stop
AFISCOOTER S
, turn the main key switch to
OFF, and contact your dealer.
Do not use
AFISCOOTER S
in heavy rain or extreme humidity, or at temperatures below -30ºC (-22ºF) or above +45ºC (+113ºF).
6
``
The seat weighs 20 kg (44 lbs). Each battery weighs a minimum of 23 kg (50.6 lbs). Be careful when lifting the seat and the batteries.
See instruction for lifting the seat and the batteries in Chapter 8:
Maintenance, and Chapter 9: Troubleshooting and Repair.
Always lift using your knees and legs, not your back.
If the
AFISCOOTER S
is involved in any kind of an accident in which parts are damaged, you must get a qualified technician to examine it before continuing to use it.
Batteries contain lead and acid, which is very corrosive. Batteries must be disposed of in accordance with proper procedures.
When driving, always make sure that the backrest is in its fully upright position.
Use lead acid maintenance-free sealed batteries only.
WARNING!!!
Special care must be taken to prevent children from operating the
AFISCOOTER S
.
Do not allow unsupervised children to play near the
AFISCOOTER S
scooter while the batteries are charging.
Always drive carefully. Adjust your speed according to road conditions.
When turning at high speed, the
AFISCOOTER S
can become unstable. Before making sharp turns, reduce speed to minimum, to prevent roll-over.
The
AFISCOOTER S
is able to go up slopes higher than the recommended safe slope. However, do not drive on slopes whose incline you do not know. Always drive very slowly and do not drive on the side of such slopes.
Before starting to drive, make sure your emergency brake operates properly.
Do not release either the manual or the manual release lever of the electromagnetic brake (EMB) when the
AFISCOOTER S
is on a slope.
When on any sort of an incline, never place the
AFISCOOTER S
in freewheel mode while seated on it or standing next to it.
7
``
The lights of
AFISCOOTER S
should be on when visibility is reduced, day or night.
Since your seat upholstery is fire resistant, do not cover it or replace with any upholstery other than upholstery of the same kind.
When removing the battery cover, watch out for hot parts. The motor, axle, EMB, electronic cards and electronic controller might be hot, Do not touch them until you have checked their temperature.
Make sure your fingers are not squeezed between the levers and the rubber grip.
Do not use a cell phone, walkie-talkie, laptop, or other radio transmitter while operating
AFISCOOTER S
.
Removal of the grounding prong can create electrical hazard. If it is necessary to use a 3-pronged electrical outlet, properly install an approved 2-pronged adapter.
Do not connect an extension cord to the AC/DC converter or to the battery charger.
Keep tools and other metal objects away from the battery terminals. Contact with tools can cause electrical shock.
Do not sit on the
AFISCOOTER S
when it is on any type of lift/elevation product.
Explosive conditions exist
8
``
Disposal and recycling: Contact your authorized dealer for information on proper disposal of your
AFISCOOTER S
and its packaging.
Wear safety glasses.
Contains lead.
The battery charger is for indoor use only.
Flammable material. Do not expose to open flame.
At the rear of the
AFISCOOTER S
is the manual release lever of the EMB. When using this lever, be careful not to touch the surface of the motor, as it could be very hot and cause injury. See the warning label at the rear of the scooter near the lever.
9
``
CHAPTER 3
– SAFETY INSTRUCTIONS for
AFISCOOTER S
GENERAL
MANDATORY! Do not operate your new
AFISCOOTER S
scooter for the first time without reading and understanding this user manual completely.
Your
AFISCOOTER S
is a state-of-the-art life-enhancement device designed to increase mobility. We provide an extensive range of products to best fit the individual needs of the user. Please be aware that the final selection and purchasing decision regarding the type of
AFISCOOTER S
scooter to be used is the responsibility of a user who is capable of making such a decision and of his or her healthcare professional (i.e., medical doctor, physical therapist, etc.).
The contents of this manual are based on the expectation that a mobility device expert has properly fitted
AFISCOOTER S
scooter to the user and has assisted the prescribing healthcare professional and/or the authorized dealer to give instructions for the use of the product.
There are certain situations, including some medical conditions, where the user will need to practice operating the
AFISCOOTER S
in the presence of a trained attendant. A trained attendant can be defined as a family member or a professional specially trained in assisting a user in various daily living activities.
As you begin using your
AFISCOOTER S
during daily activities, you will probably encounter situations in which you will need some practice. Simply take your time and you will soon be in full and confident control as you manoeuvre through doorways, on and off elevators, up and down ramps, and over moderately rough terrain.
Below are some precautions, tips, and other safety considerations that will help you operate the
AFISCOOTER S
safely.
MODIFICATIONS
We have designed and engineered your
AFISCOOTER S
to provide maximum mobility and utility. Under no circumstances should you modify, add, remove, or disable any feature, part, or function of your
AFISCOOTER S
.
WARNING!
Do not modify your
AFISCOOTER S
in any way not authorized by the manufacturer. Do not use accessories if they have not been tested or approved by the manufacturer.
REMOVABLE PARTS
WARNING! Do not attempt to lift or move your
AFISCOOTER S
by any of its removable parts, including the armrests, seat, or shroud.
PRE-RIDE SAFETY CHECK
Get to know the feel of your
AFISCOOTER S
and its capabilities. We recommend that you perform a safety check before each use to make sure your
AFISCOOTER S
operates smoothly and safely.
Perform the following inspections prior to using your scooter:
Check for proper tyre inflation. Maintain but do not exceed the psi/bar/kPa air pressure rating indicated on each tyre.
Check all electrical connections. Make sure they are secure and not corroded.
Check all harness connections. Make sure they are secured properly.
Check the brakes.
Check the battery charge.
If you discover a problem, contact your authorized
AFISCOOTER S
dealer for assistance.
10
``
TYRE INFLATION
Your
AFISCOOTER S
is equipped with pneumatic tyres. Check the tyre pressure at least once a week. Proper inflation pressures will prolong the life of your tyres and help ensure the smooth operation of your
AFISCOOTER S
.
WARNING! It is critically important that the psi/bar/kPa air pressure indicated on each tyre is maintained at all times. Do not under-inflate or over-inflate your tyres. Under-inflation may result in loss of control, and over-inflation may burst the tyre. Failure to maintain the indicated pressure rating at all times may result in tyre and/or wheel failure.
WARNING!
Inflate your scooter tyres from a regulated air source with an attached pressure gauge
NOTE: If the tyres on your AFISCOOTER S are marked with a psi rating only, use the following conversion formulas to find the bar or kPa rating:
Bar = psi x 0.06895
kPa = psi x 6.89476.
WEIGHT LIMITATIONS
Your scooter is rated for a maximum weight capacity. Refer to Appendix A
–
Specification Sheet for details.
MANDATORY! Stay within the specified weight capacity for your
AFISCOOTER S
. Exceeding the weight capacity voids your warranty. We will not be held responsible for injuries and/or property damage resulting from failure to observe weight limitations.
WARNING! Do not carry passengers on your scooter. Carrying passengers on your
AFISCOOTER S
may result in instability.
INCLINE INFORMATION
More and more buildings have ramps with specified degrees of inclination, designed for easy and safe access. Some ramps may have turning switchbacks (180-degree turns) that require you to have good cornering skills on your
AFISCOOTER S
.
Proceed with extreme caution as you approach the downgrade of a ramp or incline.
Take wide turns with your
AFISCOOTER S
around any tight corners. If you do that, the scooter’s rear wheels will follow a wide arc. Do not cut the corner short, and do not bump into or get hung up on any railing corners.
When driving down a ramp, keep the
AFISCOOTER S
scooter’s speed adjustment set to the slowest speed setting to ensure a safely controlled descent.
Avoid sudden stops and starts.
Figure A. Maximum Recommended Incline Angle
When driving up an incline, try to keep your
AFISCOOTER S
moving. If you must stop, start up again slowly, and then accelerate cautiously. When driving down an incline, set the speed switch to MIN and drive forward only. If your
AFISCOOTER S
starts to move down the incline faster than you want, allow it to come to a complete stop by releasing the
11
`` throttle control lever, then push the throttle control lever forward slightly to ensure a safely controlled descent.
WARNING!
When on any incline, never place the
AFISCOOTER S
in freewheel mode while seated on it or standing next to it.
WARNING!
When climbing an incline, do not zigzag or drive up at an angle
.
Always drive your
AFISCOOTER S
scooter straight up the incline. This greatly reduces the possibility of tipping over or a fall. Always exercise extreme caution when climbing an incline.
WARNING!
Do not drive your
AFISCOOTER S
across an incline or diagonally up or down an incline; if possible, do not stop while driving up or down an incline.
WARNING!
Do not drive up or down a potentially hazardous incline
(e.g., areas covered with snow, ice, cut grass, or wet leaves).
WARNING!
Even though your
AFISCOOTER S
is capable of climbing slopes greater than those illustrated in Figure A, do not, under any circumstances, exceed the incline guidelines or any other specifications presented in this manual. Doing so could cause your
AFISCOOTER S
to become unstable.
Note that public accesses ramps are not subject to government regulation in all countries, and therefore do not necessarily have the same standard degree of slope. Other inclines may be natural or not be designed specifically for scooters. Figure A illustrates your
AFISCOOTER S
’s stability and its ability to climb including under various weight loads and under controlled testing conditions.
These tests were conducted with the
AFISCOOTER S
’s seat in the highest position and in its farthest rearward position. Use this information as a guideline. Your
AFISCOOTER S
’s ability to travel up inclines is affected by your weight, scooter speed, your angle of approach to the incline, and your
AFISCOOTER S
setup.
WARNING!
Any attempt to go up or down a slope steeper than shown in Figure
-
A may make your
AFISCOOTER S
unstable and cause it to tip.
WARNING!
Never carry an oxygen tank weighing more than 15 lbs (6.8 kg). Never put more than 8 Kg (17.6 lbs) in the front basket or more than 10 Kg (22 lbs) in the rear basket.
Figure B. Normal Driving Position Figure C. Increased Stability Drive Position
When you approach an incline, it is best to lean forward.
See Figures B and C
. This shifts the centre of gravity of you and your
AFISCOOTER S
towards the front of the
AFISCOOTER S
for improved stability.
NOTE: If the throttle control lever is released while you are moving forward up a ramp, the AFISCOOTER S may roll back approximately 1 foot (30 cm) before the brake engages. If the throttle control lever is released while you are moving in reverse, the AFISCOOTER S may roll back approximately 3 feet (one meter) before the brake engages.
12
``
CORNERING INFORMATION
Excessively high cornering speeds can result in tipping. Factors that affect the possibility of tipping include, but are not limited to, cornering speed, steering angle (how sharply you are turning), uneven road surfaces, inclined road surfaces, riding from an area of low traction to an area of high traction (such as passing from a grassy area to a paved area
– especially at high speed while turning), and abrupt changes of direction. High cornering speeds are not recommended. If you feel that you may tip over in a corner, reduce your speed and steering angle (i.e., lessen the sharpness of the turn) to prevent your
AFISCOOTER S
from tipping.
WARNING!
When cornering sharply, reduce your speed and maintain a stable centre of gravity. When using your
AFISCOOTER S
at higher speeds, do not corner sharply. This greatly reduces the possibility of a tip or fall. Always exercise your common sense when cornering.
BRAKING INFORMATION
Your
AFISCOOTER S
is equipped with two powerful braking systems:
Regenerative: Uses electricity to rapidly slow the vehicle when the throttle control lever returns to the centre/stop position.
Park Brake: Activates automatically after regenerative braking slows the vehicle to a near stop, or when power is removed from the system for any reason.
OUTDOOR DRIVING SURFACES
Your
AFISCOOTER S
is designed to provide optimum stability under normal driving conditions, on dry, level surfaces of concrete, tarmac, or asphalt. However, we recognize that there will be times when you will encounter other surfaces. For this reason, your
AFISCOOTER S
is designed to perform well on packed soil, grass, and gravel. Feel free to use your
AFISCOOTER S
safely on lawns and in parks.
Reduce your
AFISCOOTER S
speed when driving on uneven terrain and/or soft surfaces.
Avoid tall grass that can become tangled in the running gear.
Avoid loosely packed gravel and sand.
If you feel unsure about a driving surface, avoid it.
PUBLIC STREETS AND ROADWAYS
WARNING!
Do not operate your
AFISCOOTER S
on public streets or roadways.
It may be difficult for traffic to see you when you are seated on your
AFISCOOTER S
.
Obey all local pedestrian traffic rules. Wait until your path is clear of traffic, and then proceed with extreme caution.
STATIONARY OBSTACLES (STEPS, CURBS, ETC.)
WARNING!
Do not drive near raised surfaces, unprotected ledges, and/or drop-offs (curbs, porches, stairs, etc.).
WARNING!
Do not try to go up or down an obstacle that is too high.
WARNING!
Do not try to go backward down any step, curb, or other obstacle. This may cause the
AFISCOOTER S
to tip.
WARNING!
Be sure your
AFISCOOTER
S
is travelling perpendicular to any curb you may be required to go up or down.
WARNING!
Do not attempt to climb a curb that is higher than 12 cm (5").
13
``
PRECAUTIONS DURING INCLEMENT WEATHER
Avoid exposing your
AFISCOOTER S
to inclement weather.
If you are suddenly caught up in rain, snow, severe cold or heat while operating your
AFISCOOTER S
, proceed to shelter at the earliest opportunity. Thoroughly dry your
AFISCOOTER S
before storing, charging, or operating it.
PROHIBITED!
Operating in rain, snow, salt, mist/spray conditions, and on icy slippery surfaces can have an adverse affect on the electrical system. Maintain and store your
AFISCOOTER S
in dry and clean conditions.
WARNING!
Prolonged exposure to extreme hot or cold weather may affect the temperature
AFISCOOTER S
parts, possibly resulting in skin irritation. Exercise caution when using your
AFISCOOTER S
in extremely hot or cold conditions or when exposing your
AFISCOOTER S
to direct sunlight for prolonged periods of time.
FREEWHEEL MODE
Your
AFISCOOTER S
is equipped with a manual freewheel lever that, when pushed forward, allows the
AFISCOOTER S
to be pushed. For more information about how to place your
AFISCOOTER S
in and out of freewheel mode, see Chapter 4
– General description of the
AFISCOOTER S
.
WARNING!
When your
AFISCOOTER S
is in freewheel mode, the parking system is disengaged.
Disengage the drive motors only on a level surface.
Ensure the key is removed from the key switch.
Stand beside the
AFISCOOTER S
to engage or disengage freewheel mode. Never do this while sitting on the
AFISCOOTER S
.
After you have finished pushing your
AFISCOOTER S
, always return it to the drive mode to lock the brakes (pull the manual freewheel lever backward).
An added feature built into the
AFISCOOTER S
is
“
push-too-fast
” protection, which safeguards it against gaining excessive speed while in freewheel mode.
Push-too-fast
operates in two different modes:
If the key is in the OFF position while the
AFISCOOTER S
is in freewheel mode, the
AFISCOOTER S
’s controller activates regenerative braking when it is pushed faster than the pre-programmed maximum threshold. In this case, the controller is acting as a speed governor.
If the key is in the ON position while the
AFISCOOTER S
is in freewheel mode, you will encounter considerable resistance at any speed. This prevents the
AFISCOOTER
S
from gaining unwanted momentum should the freewheel lever be raised inadvertently while you are driving the
AFISCOOTER S
.
When using this lever, be careful not to touch the internal surface of the motor, as it could be very hot and cause injury. See the warning label at the rear of the scooter near the lever.
STAIRS AND ESCALATORS
AFISCOOTER S
scooters are not designed to travel up or down stairs or escalators.
Always use an elevator.
WARNING!
Do not use your
AFISCOOTER S
scooter to negotiate steps or escalators.
14
``
DOORS
Determine whether the door opens toward or away from you.
Use your hand to turn the knob or to push the handle or push-bar.
If the door opens away from you, drive your
AFISCOOTER S
gently and slowly forward to push the door open.
If the door opens towards you, drive your
AFISCOOTER S
gently and slowly backwards to pull the door open.
S A F E T Y
ELEVATORS
Modern elevators have a safety mechanism on the edge of the door that, when pushed, reopens the door(s).
If you are in the doorway of an elevator when the door(s) begin to close, push on the rubber door edge or allow the rubber door edge to contact the
AFISCOOTER S
; and the door will reopen.
Take care that handbags, packages, or
AFISCOOTER S
accessories do not become caught in elevator doors.
NOTE
: Sometimes manoeuvring your
AFISCOOTER S
may be difficult in elevators and building entrances. Use caution when attempting to manoeuvre your
AFISCOOTER S
in small spaces, and avoid areas that might pose a problem.
LIFTS/ELEVATION PRODUCTS
If you travel with your
AFISCOOTER S
, you may find it necessary to use a lift or elevation product to aid in transportation. We recommend that you closely review the manufacturer’s instructions, specifications, and safety information before using the lift/elevation product.
WARNING!
Never sit on your
AFISCOOTER S
when it is being used with any type of lift/elevation product. Your
AFISCOOTER S
was not designed for such use, and any damage or injury resulting from such use is your responsibility only.
BATTERIES (see also Replacing Batteries, page 28)
In addition to the following warnings below, be sure to comply with all other battery handling information.
MANDATORY!
Battery posts, terminals, and related accessories contain lead and lead compounds. Wear goggles and gloves when handling batteries, and wash hands after handling.
WARNING!
Scooter batteries are heavy
.
(See Appendix A
– Specification Sheet). If you are unable to lift that much weight, be sure to get help. Use proper lifting techniques and avoid lifting beyond your capacity.
WARNING!
Always protect the batteries from freezing and never charge a frozen battery.
WARNING!
Connect the battery cables correctly. RED (+) cables must be connected to positive (+) battery terminals/posts and BLACK (-) cables must be connected to negative
( ) battery terminals/posts. REPLACE damaged cables immediately. Protective caps must be installed over all battery terminals.
NOTE:
If the battery is damaged or cracked, immediately enclose it in a plastic bag and contact your local waste disposal agency or authorized
AFISCOOTER S
dealer for instructions for disposal or for recycling (which we recommend).
MOTOR VEHICLE TRANSPORTATION
The manufacturer recommends that you do not remain seated in your
AFISCOOTER S
while travelling in a motor vehicle. The
AFISCOOTER S
should be stowed in the boot of a car or in the back of a truck or van with the batteries removed and properly secured. In addition, all removable
AFISCOOTER S
parts, including the armrests, seat, and shroud, should be removed and/or properly secured during transportation.
WARNING!
Although your
AFISCOOTER
S
may be equipped with an optional tie-down belt, this belt is not designed to provide restraint during motor vehicle transportation.
15
``
Anyone travelling in a motor vehicle must be properly secured in the motor vehicle seat with securely fastened seat belts.
WARNING!
Do not sit on your
AFISCOOTER S
while it is in a moving vehicle.
WARNING!
Always be sure your
AFISCOOTER S
and its batteries are properly secured when it is being transported. Batteries must be secured in an upright position, and protective caps must be installed on the battery terminals. Batteries must not be transported with any flammable or combustible items.
TIE-DOWN BELT
Although your
AFISCOOTER S
may be equipped with an optional tie-down belt, this belt is not designed to provide restraint during motor vehicle transportation. Anyone travelling in a motor vehicle must be properly secured in the motor vehicle seat with securely fastened seat belts.
WARNING!
Do not sit on your
AFISCOOTER S
while it is in a moving vehicle.
WARNING!
Ensure your
AFISCOOTER S
and its batteries are properly secured during transportation.
PREVENTING UNINTENDED TRAVEL
WARNING!
If you anticipate being stationary for an extended period of time, turn off the power. This will prevent unexpected travel caused by accidentally touching the throttle control lever.
GETTING ONTO AND OFF YOUR
AFISCOOTER S
Getting onto and off your
AFISCOOTER S
requires a good sense of balance.
Please observe the following safety tips when getting on and off your
AFISCOOTER S
:
Remove the key from the key switch.
Ensure that your
AFISCOOTER S
is not in freewheel mode
(see Chapter 4 - General description of the
AFISCOOTER S
).
Ensure that the seat is secured in place.
Pivot the armrests up
WARNING!
Position yourself as far back as possible in the seat to prevent the
AFISCOOTER S
from tipping and causing injury.
WARNING!
Avoid putting all of your weight on the
AFISCOOTER S
armrests, and do not make the armrests bear weight, such as during transfers. Such use may cause the
AFISCOOTER S
to tip, resulting in a fall from the
AFISCOOTER S
and/or personal injury.
WARNING!
Avoid putting all of your weight on the floorboard. Such use may cause the
AFISCOOTER S
to tip.
REACHING AND BENDING
Avoid reaching or bending while driving your
AFISCOOTER S
. Bending forward creates the risk of accidentally contacting the throttle control lever. Bending to the side while seated creates the risk of tipping. It is important to maintain a stable centre of gravity to keep the
AFISCOOTER S
from tipping. We recommend that you determine your personal limitations and practice bending and reaching in the presence of a qualified attendant.
WARNING!
Do not bend, lean, or reach for objects if you have to pick them up from the
AFISCOOTER S
deck or from either side of the
AFISCOOTER S
such as these may change your centre of gravity and the weight distribution of the
AFISCOOTER S,
causing it to tip.
16
``
PROHIBITED!
Keep your hands away from the tyres and wheels when driving. Be aware that loose-fitting clothing can be caught in tyres and wheels.
PRESCRIPTION DRUGS/PHYSICAL LIMITATIONS
The
AFISCOOTER S
user must exercise care and common sense when operating the
AFISCOOTER S
. This includes awareness of safety issues when taking prescription/ over-the-counter drugs or when the user has specific physical limitations.
WARNING!
Consult with your physician if you are taking prescription or over-the-counter medication or if you have certain physical limitations. Some medications and limitations may impair your ability to operate your
AFISCOOTER S
in a safe manner.
ALCOHOL/SMOKING
The
AFISCOOTER S
user must exercise care and common sense when operating the
AFISCOOTER S
. This includes awareness of safety issues while under the influence of alcohol, or while smoking.
WARNING!
Do not operate your
AFISCOOTER S
while you are under the influence of alcohol, as this may impair your ability to operate the
AFISCOOTER
S
in a safe manner.
WARNING!
The manufacturer strongly recommends that you do not smoke while seated on your
AFISCOOTER S
, although the
AFISCOOTER S
seat has passed the necessary testing requirements for cigarette smoking. You must adhere to the following safety guidelines if you decide to smoke cigarettes while seated on your
AFISCOOTER S
.
Do not leave lit cigarettes unattended.
Keep ashtrays a safe distance from the seat cushions.
Always make sure cigarettes are completely extinguished before disposal.
ELECTROMAGNETIC AND RADIO FREQUENCY INTERFERENCE (EMI/RFI)
WARNING!
Laboratory tests have shown that electromagnetic and radio frequency waves can have an adverse affect on the performance of electrically powered mobility vehicles.
EMI/RFI can come from sources such as cellular phones, mobile two-way radios (such as walkie-talkies), radio stations, TV stations, amateur radio (HAM) transmitters, wireless computer links, microwave signals, paging transmitters and mediumrange mobile transceivers used by emergency vehicles. In some cases, they can cause unintended movement or damage to the control system. Every electrically powered mobility vehicle has an immunity (or resistance) to EMI.
The higher the immunity level, the greater the protection against EMI. This product has been tested and has passed at an immunity level of 20 V/M.
WARNING!
Be aware that cell phones, two-way radios, laptops, and other types of radio transmitters may cause unintended movement of your electrically powered
AFISCOOTER S
due to EMI. Exercise caution when using any of these items while operating your
AFISCOOTER S
and avoid coming into close proximity of radio and TV stations.
WARNING!
The addition of accessories or components to an electrically powered mobility vehicle can increase its susceptibility to EMI. Do not modify your
AFISCOOTER S
in any way not authorized by the manufacturer.
WARNING!
The
AFISCOOTER S
itself can interfere with other electrical devices located nearby, such as alarm systems.
NOTE:
For further information on EMI/RFI refer to chapter 10 or ask your authorized dealer.
17
``
CHAPTER 4
–
GENERAL DESCRIPTION OF THE
AFISCOOTER S
Note: The numbers in parentheses refer to the parts illustrated on Figures 1, 2, and 3.
Figure 1 Figure 2
Mirror (1.4)
Throttle control lever (1.8)
Brake lever (1.16)
Charging socket (1.12)
Handlebar adjustment lever
(1.10)
Keys/Cellphone pockets (4.5)
Plate with serial number and manufacturer’s data (4.6)
Tiller (1)
/ Handlebars (1.7)
Figure 3
Right & Left
Serial number and manufacturer’s data are on a plate on the mud guard in front of your foot.
Your
AFISCOOTER S
is designed for either hand operation, but it is delivered with right-hand controls.
Left-hand controls can be set up by your dealer.
Every
AFISCOOTER S
has either 1 or 2 rear-view mirrors.
Used to control the
AFISCOOTER S
speed.
Used to brake in emergency conditions or when needed.
Used to connect the charger plug to charge the battery. Located on the right side of the handlebar.
The handlebar can be adjusted forward or backward. Release the lever, make the adjustment, and return the lever to the locked position.
18
``
Buzzer (1.18)
Front basket (4.1)
Headlight (4.2) and front blinkers (4.3)
Front bumper (4.4)
Battery cover (2)
Fuses (2.1a, 2.1b)
EMB manual release (2.2)
Rear Bumper (2.3)
Rear pilot & brake lights (2.4)
Rear blinkers (2.5)
Seat (7)
Seat backrest (7.1)
Seat headrest (7.2)
Armrests (7.3)
Seat forward/reverse lever (7.4)
Seat rotation lever (7.5)
Seat height adjustment
Rear box (6)
Floor (4)
Used to alert the surrounding people when needed.
For carrying parcels and personal effects. Maximum load 8 kg (17.6 lbs).
(A) Headlight for poor visibility conditions
(B) Blinkers for turnings signals
Protects the power unit, electronics and batteries.
2.1a - – Main fuse 70A – Semi Automatic
2.1b - – Charge fuse 15A – Semi Automatic
Located between the rear wheel and the battery cover.
A manual release lever at the back of
AFISCOOTER S
lets you push or pull it.
Push / Pull the lever as shown on the label:
= Release (Push), = Engaged (Drive).
When the lever is in the released position
AFISCOOTER S
cannot be operated / driven.
Note
: Never release the lever when the
AFISCOOTER S
is on a slope.
AFISCOOTER S
seat is equipped with folding armrests (7.3) to allow convenient access to the seat. The seat itself can be rotated to allow easy access.
Use for comfortable entrance. May be folded upwards
Used to move the seat forward and backward.
Used to swivel the seat 45
or 90
in either direction.
The seat height must be adjusted by a qualified technician.
Maximum load 10 kg (22 lbs).
Covered with carpet that may be removed for cleaning.
19
``
CHAPTER 5
– ADJUSTMENT INSTRUCTIONS
(Numbers refer to Figures 4 and 5)
Adjusting the tiller angle (1.7)
Adjust the angle of the tiller as follows:
Release the tiller adjustment lever (1.10), by pushing it down.
Release the lever at the desired place.
Handlebar height can be adjusted about 40mm by a technician. Adjusting the handlebar height
Seating in the
AFISCOOTER S
Handlebars and hand protectors
Adjusting the shock absorbers to the user
Before attempting to drive
AFISCOOTER S
, make sure the plug is disconnected from the charging socket (1.12).
Note: While the plug is in the charging socket,
AFISCOOTER S
cannot be operated.
Use the seat rotation lever (7.5) to rotate the seat sideways, and raise the armrest (7.3) to give you easy access to the seat.
Use the seat forward/reverse lever (7.4) to adjust the location of the seat.
When driving always keep your hands on the handlebars (1.7) and within the hand protectors (1.6).
It is possible to adjust the rear shock absorber to the required load, or way of using AFISCOOTER S. If necessary, ask a technician to adjust the absorbers for your needs.
Figure 4 Figure 5
20
``
CHAPTER 6
– OPERATING INSTRUCTIONS
6.1 GENERAL
Figure 6
(Numbers refer to Figures 6 and 7)
Key switch
The main key switch is located at the top of the tiller box (1).
(1.11)
The key switch has two positions:
OFF
ON
- The
AFISCOOTER S
cannot be driven and the EMB is locked.
- Power is supplied to the
AFISCOOTER S
and the EMB is released automatically when the throttle control lever is squeezed.
To operate the
AFISCOOTER S
, insert the key in the key switch and turn it to ON (clockwise). The switch will remain in this position and the LCD (1.1) will be lit.
Note
: The key switch is used to operate
AFISCOOTER S
, not for locking.
Automatic shut off
Adjusting the handbrake
When the key switch is in ON, the control system will be shut off automatically after a few minutes (usually 20) in order to save battery energy.
In the case of automatic shut-off, turn the key switch OFF and then ON again.
The handbrake cable mechanism can be adjusted by an authorized technician.
The handbrake is part of your safety system.
DO NOT adjust it yourself
—get professional assistance!
Throttle control lever and manual handbrake
Signalling
To drive: Gently squeeze the throttle control lever (1.8) until you reach the desired speed. Your speed is directly proportional to the deflection of the throttle control lever.
To stop: Release the throttle control lever (1.16). The
AFISCOOTER S
will stop gradually, automatically.
Note: You can also use the manual handbrake for emergency stopping (1.16).
Before you turn, press the applicable turn signal switch: left or right (1.14)
To turn off the indicator, press the switch forward.
When a turn indicator is activated, the applicable LED (5.3 or 5.4) will flash.
Depending on the model, a buzzer may also sound (subject to local regulations). To turn off the indicator, press the button again.
21
``
Buzzer buttons
(1.9)
Headlight switch
Hazard button
(1.17)
Inhibit while charging
Safe driving
/
Half speed switch (1.2)
Parking
Push one of the 2 Buttons (1.9) to activate the buzzer.
The buzzer sounds automatically under the following conditions (
except where prohibited by law
),:
1. When reversing
2. When operating the left or right indicator
Remark: It is possible to change the Buzzer functionality by changing a dip switch in the front board .This needs to be done by an authorized technician.
To turn on the headlight and rear lights, press the Lights button (1.15).
When the lights are ON the lights led (5.6) is lit.
To turn off the lights, press the button again.
The Hazard button activates all the flashing lights on
AFISCOOTER S
.
To turn off the hazard lights, press the button again.
When the hazard lights are activated, both LEDs (5.3 & 5.4) flash.
When AFISCOOTER S is being charged, it is in inhibiting mode. In this mode it cannot be driven. When being charged a signal (5.13) will be lit.
When driving on ramps, high curbs and on sharp turns, drive very slowly and carefully, consider changing the Half Speed Switch (1.2) to Half speed mode. Never try to go over an obstacle that is more than the maximum recommended slope angle, and obstacle height given in the specification sheet.
Always drive carefully and adjust your speed to the road conditions.
Before making sharp turns, reduce
AFISCOOTER S
speed, to Half
Speed, to prevent side roll-over.
After stopping
AFISCOOTER S
, turn the key switch (1.11) to OFF and remove the key. The LCD will turn OFF.
Note: The EMB locks automatically when the throttle control lever is released and
AFISCOOTER S
has come to a complete stop.
6.2 LCD DISPLAY USE
Figure 7
22
``
(Numbers refer to Figures 6 and 7)
LCD Display
Key
Battery status
Indicator
Fault indicator
Light indicator
When driving and operating the AFISCOOTER S, all the required information is displayed on the LCD screen (1.1).
See details below.
The
Battery Capacity Indicator
(5.5) on the LCD screen, displays the remaining battery capacity. Like petrol gauges in cars, the indicator is not absolutely accurate; it is merely a guide to help you stop running out of fuel. The accuracy of the indicator also depends on the type and age of the batteries. When the indicator shows 2-3 bars, recharge batteries as soon as possible.
When the indicator displays one blinking bar, recharge immediately.
You can only drive a short distance (3-4 km on level surface). The accuracy of the battery indicator reading also depends on the type and age of the batteries.
AFISCOOTER S
is equipped with fault indication.
The fault indication appears as a flashing code of the battery indicator, as well as an error code on the LCD screen (5.5).
For further details see AFISCOOTER Maintenance Manual.
When the main lights are ON (front and rear) a sign will be lit (5.6).
Blinker indicators
Half speed indicator
Alarm indicator
Speed display
(5.12)
MODE and
RESET button
Setup button
When the blinkers are ON, signs will be lit (5.3 and / or 5.4).
When the Half Speed switch (1/2) is at the Half Speed position, a sign of "1/2" will be lit (5.11).
When one of the following conditions exists: Motor overheating, panic brake was operated or manual release brake is in the OPEN position, or electric EMB is opened, the alarm indicator will be lit (5.13).
The LCD screen digital area will display the speed of
AFISCOOTER S
.
The speed is shown in kph or mph. The setting can be done by a technician.
The MODE / RESET button (5.20) will change the digital reading from
Speed to Travel Distance or Time. The distance is shown in km, or miles and the time displayed in hours.
(Note: Setting the speed unit can be done by a technician.
When you push the MODE button to the modes: "travel time" and
"travel distance" and keep pushing it for more than 7 seconds, the
"travel time" and "travel distance" will reset to zero.
The Setup button 5.21 is used to set the clock.
23
``
Clock setup When changing to clock mode with the MODE button, press it for 7 seconds and you will enter the Setup mode of the clock.
Adjusting
the
clock
:
Use the left
Setup
button and the right
Mode
button as follows:
Every push on
Mode
changes the time unit and the selected unit flashes.
During the flashing, every push on
Setup
increases 1 unit.
Stage Display
1 HH:mm
Flashing
mm
2
3
4
HH:mm
DD.MM or MM.DD
DD.MM or MM.DD
HH
DD
MM
5
6
20YY YY
Saving the updated time and date
6.3 DRIVING AND GENERAL USE
Climbing an obstacle
Driving on slopes and turns
To climb an Obstacle, drive the
AFISCOOTER S
forward toward the obstacle until the front wheel touches the obstacle, then, maintaining your direction, increase speed.
Before making sharp turns, particularly on inclines, reduce speed to minimum, to prevent side roll-over.
AFISCOOTER S
is able to go up slopes steeper than the recommended safe slope. Do not drive on inclines where you are not sure about the slope degree.
However drive very slowly and avoid side angles higher than 26% (15°).
Prior to use
Controller programming
After reading through this entire manual and before using
AFISCOOTER S
, do a visual check of all the parts of the vehicle, to make sure that there is no visible damage. If you have any questions or concerns, contact your dealer.
Several parameters of
AFISCOOTER S
controller can be programmed.
Programming must be done by trained authorized technician only.
Incorrect programming can cause abnormal operation of
AFISCOOTER S
and may result in damage and personal injury.
24
``
Performance check
Prior to use
Safety belt
Securing the
AFISCOOTER S
in motor vehicle for transportation
A performance check is highly recommended when you first receive your
AFISCOOTER S
or after a period of not using the
AFISCOOTER S
, as follows:
1. Turn on the key switch.
2. Verify that the LCD display is ON.
3. Slowly squeeze the drive control lever and verify that the
AFISCOOTER S
travels at a speed that corresponds to the degree to which you are squeezing the lever.
4. Release the throttle control lever and verify that the
AFISCOOTER S
stops smoothly, and that you hear the click of the EMB engaging.
5. Check that all the buttons on the handlebar work correctly.
6. Switch off the key switch.
Your
AFISCOOTER S
is now ready to drive.
Before using the AFISCOOTER S, be sure you know your own weight and the weight of any items you will be carrying on it. The maximum total load is 160 kg (352 lbs) /200 kg (440 lbs). (Depending on the model).
Use a seat belt whenever it is needed or as required by local traffic regulations.
To transport the
AFISCOOTER S
in a motor vehicle, it must be secured (see
Figure 8).
Using standard approved tiding straps, secure the 4 tiding ear plates painted in Yellow (2 at the front and 2 at the rear of the scooter), to the car secure hooks.
Warning: When transporting the
AFISCOOTER S
, never let anyone sit on it.
Transportation
Figure 8
To reduce the height of
AFISCOOTER S
while transporting it, the seat can be removed as explained in Chapter 8 Maintenance, and the handlebar column can be folded to horizontal position.
25
``
CHAPTER 7
– CHARGING
Read the charger manual before using it.
Warning: If you use a charger other than the one supplied with your
AFISCOOTER S
, ask your dealer for instructions.
CHARGING BATTERIES
(See figure10)
1. Insert the charger plug (8) in the charging socket (9) located on the right side of the tiller column.
2. Plug the charger power cord (10) into a wall socket (11).
3. When charging is complete, remove the charger power cord (10) from the wall socket
(11) and then remove the charger plug (8) from the charging socket (9).
4. Under ideal storage conditions, batteries that were charged to full capacity and were not used should be recharged every 6 months.
. If you expect not to use your
AFISCOOTER S
for an extended period of time, we recommend charging it for two days and then disconnecting the batteries.
5. If you have not used your
AFISCOOTER S
for an extended period of time, charge the batteries for at least 24 hours before driving.
Recommended Charging routine
1. Use the sco o ter along the day as needed or until charging is low , according to the LCD battery indicator.
2. At the end of the day, recharge the scooter batteries along the night.
3. No need to disconnect the batteries at the end of the charging .
T he charger is
Automatic and stops itself.
4. No need to recharge the scooter batteries at the end of every drive, unless you are not intending to use the scooter any more on that day.
5. In case of recharge the scooter along the day, you should perform full charging.
6. It is not recommended to l ea ve the batteries uncharged for a few days as i t can reduce the travel distance and battery 's life .
As long as the charging plug is in the charging socket, the electronic control of the
AFISCOOTER S
automatically cuts all power to the electric system and it cannot be driven.
The charger supplied is suitable for charging lead acid dry/gel batteries. Use only the defined type of charger. Before using any other type of charger, check with your dealer.
26
``
Figure 10
27
``
CHAPTER 8
–
MAINTENANCE
Note:
1. Maintenance Manual is available for trained technicians.
2. The numbers in parentheses refer to the parts illustrated in figure 11.
Although the
AFISCOOTER S
requires very little maintenance, do not neglect it. When performing maintenance procedures on the
AFISCOOTER S
, make sure that it stands on a level surface and that the key is not inserted.
Periodic Maintenance Procedures
Remark
: For periodic maintenance, no special tools are needed.
No.
1
2
3
4
5
6
7
Type of Service
Check air pressure in all tyres.
Check emergency brakes
Check normal driving and stopping
Check tyre wear
Check for missing and damaged parts
(see Figures 1 through 4).
Check that all screws and parts are secure
Replace batteries
Every week
Every week
Frequency
Every Month
Every Month
When first receiving
AFISCOOTER S
or after a long time without using it.
Once a year by a technician.
Every 2-3 years,
After about 300-400 full cycles of charge/discharge,
When the distance you can travel on a single charge becomes short, or
After a technician recommends replacing it.
Note: To replace the batteries, the seat and the battery cover (which is located under the seat) must be removed.
8
Cleaning External
– when needed.
Internal
– Once a year by technician.
As-required Maintenance Procedures
Type of Service
Removing the seat and the Batteries Cover (2)
Frequency
Turn the seat by turning the lever (7.5) 45º (either direction).
The seat can be removed only at this angle.
Removing the seat -(7) Holding the seat with one hand on the backrest, and the other at the front, lift it off the seat-mounting post
.
Warning
!
The seat weighs 20 kg (44 lbs).
The seat must be lifted by two people or by an adequate lifting equipment. Replace the battery cover, re-install it over the seatmounting post, and make sure it is seated properly, and then secure it with the five screws.
28
``
Removing and replacing the battery cover (2)
Batteries
Tyres
Cleaning
Replace batteries
To replace the battery cover, re-install it over the seat-mounting post and make sure it is seated properly, then secure it with the four screws (2.6).
Each battery weighs 23 kg (50.6 lbs). The batteries must be lifted by two people or by an adequate lifting equipment.
Correct tyre pressure is essential for steering and stability.
Check the tyre pressure every two weeks
25 ±2 psi. AFISCOOTER 4W front tires: 20±2 psi. Golf wheels tires: 20±2 psi.
Use only a damp cloth and mild detergent for cleaning. Never use a hose, as this may severely damage the power and electronic components.
Note!
Batteries must be replaced by trained professionals only.
Warning!
Batteries contain high energy and can spark, resulting in a possible fire hazard.
Warning!
Working with batteries can cause damage and Injury if not done properly.
In this procedure, refer to Figure 12.
1. Remove the terminal insulating cap from one battery terminal.
2. Using a 10/13 mm key, unscrew the wiring from the terminal.
Take care not to let the key touch any other terminal or metal part, as this could cause damage or injury.
3. Repeat steps 1 and 2 for all the other terminals.
4. Remove the old batteries and install the new ones.
5. Connect the wires of the new batteries as shown in Figure 11
(also shown on the label located near the batteries).
6.
Screw down the terminals securely, and replace the insulating caps.
29
``
Figure 11
Figure 12
30
``
CHAPTER 9
– TROUBLESHOOTING AND REPAIR
The following table provides troubleshooting and repair instructions for problems that may be encountered when operating the
AFISCOOTER S
. as well as the best way to correct the problem. The table contains three columns:
Symptom
The problem you
Probable Cause
The most likely causes, in order of
Remedy
Recommended action to are experiencing probability (most likely first)
2 The battery indicator flashes and the vehicle do not move. correct each probable cause
Remember
: you can contact your dealer at any time for further professional support.
No.
Symptom
1 Flat tyre and unstable driving.
Probable Causes
Low air pressure
Puncture
Remedy
Pump tyre to normal pressure
Repair tyre
(identified by the fault code)
Call for technical support
Loose handbrake mechanism
Brake cable needs to be tight. Only by authorized technician.
4 Handbrake is fully engaged but the vehicle does not stop.
5 When throttle control lever is released on a level surface, the
AFISCOOTER S
takes longer than 3 meters to stop.
6 Key switch is turned ON but
Controller is faulty or out of adjustment
Main fuse 70A popped
Call for technical support the ON light does not come on.
or electrical fault.
(See 2.1 in Fig. 1)
Reset fuse
Note:
Do not reset fuse more than twice.
If the symptom still recurs, call your authorized dealer for support.
7
8
9
AFISCOOTER S
does not move when you squeeze the throttle control lever.
Intermittent drive.
Main or rear lights or indicator lights are inoperative.
Key switch is OFF
Charger is connected to charging socket
The release lever of the
EMB is disengaged.
Other inhibitor: Panic brake.
Control system failure
Battery capacity is low
Faulty connections
Faulty battery
Faulty LED light board or electronics fault
Turn key switch ON
Disconnect charger
Engage the EMB lever.
Turn the key switch OFF and ON again.
Call for technical support
Charge batteries for at least 18 hours
Remove battery cover and check battery connection. If terminals are corroded, clean them with a damp, clean cloth
If red LEDs are still on, contact your dealer for a replacement battery
Call technician for assistance.
Stop driving and let controller cool 10 When driving uphill or carrying heavy loads, speed reduces gradually (but scooter still moves).
The Controller became overheated
31
``
CHAPTER 10
– EMI WARNING
All types of electrically powered vehicles, such as powered wheelchairs and motorized scooters (in this text all types will be referred to as
“powered vehicles”) may be susceptible to electromagnetic interference (EMI). This is from sources such as radio and TV stations, amateur radio (HAM) transmitters, two-way radios and cellular phones. The interference (from radio wave sources) can cause the powered vehicle to release its brakes, move by itself, or move in unintended direction. It can also damage the powered vehicle’s control system. The intensity of the interfering EM energy can be measured in volts per meter (V/m).
Each powered vehicle can resist EMI interfering electromagnetic energy (EM) emitted up to a certain intensity. This is called its
“immunity level”. The higher the immunity level, the greater the protection. At this time, current technology is capable of achieving an immunity level that would provide useful protection from the more common sources of radiated
EMI. This vehicle as shipped, with no further modification, has an immunity level of 20 V/m.
There are a number of sources of relatively intense electromagnetic fields in the everyday environment. Some of these sources are obvious and easy to avoid. Others are not apparent and exposure is unavoidable. However, we believe that by following the warning listed below, your risk of EMI will be minimized.
The sources of radiated EMI can be broadly classified into three types:
1. Hand-held portable transceivers (transmitters-receivers) with the antenna mounted directly on the transmitting unit.
Examples include: citizen band (CB) radios,
“walkie talkies”, security, fire and police transceivers, cellular telephones and other personal communication devices.
NOTE:
Some cellular telephones and similar devices transmit signals while they are ON, even when not being used.
2. Medium-range mobile transceivers such as those used in police cars, fire trucks, ambulances and taxis. These usually have the antenna mounted on the outside of the vehicle.
3. Long-range transmitters and transceivers such as commercial broadcast transmitters (radio and TV broadcast antenna towers) and amateur (HAM) radios.
NOTE:
Other types of hand held devices, such as cordless phones, laptop computers, AM/FM radios, TV sets, CD players, cassette players and small appliances such as electric shavers and hair dryers, as far as we know, are not likely to cause EMI problems to your powered vehicle.
Powered Vehicle Electromagnetic Interference (EMI)
Because EM energy rapidly becomes more intense as one moves closer to the transmitting antenna, the
EM field from hand-held radio wave sources (transceivers) are of special concern. It is possible to unintentionally bring high levels of EM energy close to the powered vehicle’s control system while using these devices. This can affect powered vehicle movement and braking.
Therefore, the warnings listed below are recommended to prevent possible interference with the control system of the powered vehicle.
WARNINGS
Electromagnetic interference (EMI) from sources such as radio and TV stations, amateur radio (HAM) transmitters, twoway radios and cellular phones can affect powered vehicles.
Following the warnings listed below should reduce the chance of unintended brake release or powered vehicle movement
which could result in serious injury:
1) Do not operate hand-held transceivers (transmitters-receivers) such as citizen band (CB) radios, or turn
ON personal communication devices such as cellular phones, while the powered vehicle is ON;
2) Be aware of nearby transmitters, such as radio or TV stations and try to avoid coming close to them.
3) On appearance of unintended movements or brake release occurrences, switch the powered vehicle OFF
as it is safe to do so
.
4) Be aware that adding accessories or components, or modifying the powered vehicle, may make it more susceptible to EMI (since there is no easy way to evaluate their effect on the overall immunity level of the powered vehicle).
5) Please report to us all incidents of unintended movement or brake release and note whether there is a source of EMI nearby.
Important information
1) 20 volts per meter (V/m) is a generally achievable and useful immunity level against EMI (as of May 1994). The higher the level the greater the protection;
2) This product delivered to you has an immunity level of 20 V/m.
32
``
Appendix A
– Specification Sheet
Type: AFISCOOTER S
4
Manufacturer: Kibbutz Afikim 15148, Israel
Maximum occupant mass:
200
kg (for the tests, a
150kg
dummy according ISO 7176-11 was used, supplemented by 50 kg weights distributed approximately proportional to the dummy
’s weight distribution)
)
Disclosure information (ISO 7176-15)
4
W
3W 4W 3W
Standard reference Min.
Max.
Standard reference Min. Max.
Overall length with legrest
(A)
Overall width
(B)
Folded length
(D)
1,550 mm
680 mm
Seat plane angle
Effective seat depth
(M)
Effective seat width
(N)
4
460 mm
Folded height
(C)
Total mass
(G)
Mass of the heaviest part
(H)
Static stability downhill
(T)
Static stability uphill
(V)
155 kg
>20
13
Static stability sideways
(X)
Energy consumption
10
23 kg
Battery
>20
>20
14
25km
Seat surface height at front edge
(O)
Backrest angle
(P)
Backrest height
(Q)
430 mm
90
390 mm
Footrest to seat distance
(I)
Leg to seat surface angle
Armrest to seat distance
(K)
Front location of armrest structure
Handrim diameter
(S)
25 mm
490 m m
Dynamic stability uphill
>10
>10
Obstacle climbing
80 mm
Maximum speed forward
km/h
3,000 mm
(on the
flat)
120 mm
15.0 km/h
Horizontal location of axle
(R)
Minimum turning radius
(Y)
Minimum turn-around radius
(Z)
2,200 mm
Minimum braking distance from max speed
Pneumatic Tyres Front Tyres
Rear Tyres
"
4.10/3.50-6
3.50-10"
Charger for charging dry/gel acid battery
24VDC max charge 15 Amp.
Pressure of front tyres:
Pressure of rear tyres:
Battery type
1.7 bars
1.7 bars
Lead Acid /Gel/dry, 2x12 V 70 A h, Max.
Capacity
Charger
Dimensions
Options
Charge current 12Amp.max. Di ms. 265mm x 175mm x 230mm
Left speed lever.
Pedal operation
Twist speed lever
Canopy
Winter light sides close
Rear attach bracket.
Wide seat 22"
Seat lift column-electric
Remarks:
* All technical specifications are subject to change without prior notice.
** The maximum speed in every country is limited according local traffic regulations.
Date: May 2015
Edition: 01
Revision 04
Products:
AFISCOOTER S
, 4-Wheel and 3-Wheel
P/N of the user manual: PRS4001
33
advertisement
* Your assessment is very important for improving the workof artificial intelligence, which forms the content of this project