Belling 60T Technical data

Belling FSG 60 TC
If you smell gas:
Do not try to light any appliance. Do not touch any electrical switch.
Call the Gas Emergency Helpline at TRANSCO on:
0800 111999
In the Republic of Ireland, call the Bord Gaìs emergency line on
205050 or contact your local gas supplier.
1850
IMPORTANT NOTICE
Please note the cooling fan fitted to this appliance is an integral part of its safety and
functionality.
When the appliance is installed care must be taken that the cooling fans performance is
not impeded by any objects coming into contact with it. (Installation pipes, leads etc)
Care must also be taken that there is sufficient air flow at the rear of the appliance for the
cooling fan to run at its optimum efficiency. (Particularly Built In appliances) See clearance dimensions in the installation section of the booklet.
During use the Appliance must never be disconnected from the Mains supply as this will
seriously affect the safety and performance of the appliance, particularly in relation to surface temperatures becoming hot and gas operated parts not working efficiently.
The cooling fan is designed to run on after the control knob has been switched off to
keep the front of the appliance and the controls cool until the appliance has naturally
cooled itself.
The Gas Consumer Council (GCC) is an independent organisation which protects the
interests of gas users. If you need advice, you will find the telephone number in your local
telephone directory under Gas.
The appliance must be installed (and serviced) by a GAS SAFE registered
approved installer or a person competent to ensure that the installation is in
accordance with “The Gas Safety (Installation and Use) Regulations 1994”, and
the “The Gas Safety (Installation and Use) (Amendment) Regulations 1996”.
Failure to comply with these Regulations is a criminal offense.
Contents
User’s Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 17
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Be Safe - Not Sorry. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Using the Hob . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Using the Grill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Using the Oven . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Slow cooking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Baking guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Traditional fruit cakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Roast turkey . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Roasting guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Minute Minder (if fitted) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Installation Instructions . . . . . . . . . . . . . . . . . . . . . . .
Regulations and Standards . . . . . . . . . . . . . . . . . . . . . . . . . .
Ventilation Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Clearances & dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . .
Stability bracket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Levelling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connect to Electricity supply (mains ignition models only) . . . . .
Connect to the Gas supply. . . . . . . . . . . . . . . . . . . . . . . . . . .
Commissioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . 18 - 22
. . . . . . . . . . . 18
. . . . . . . . . . . 18
. . . . . . . . . . . 19
. . . . . . . . . . . 20
. . . . . . . . . . . 20
. . . . . . . . . . . 21
. . . . . . . . . . . 22
. . . . . . . . . . . 22
Technical Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Belling Customer Care . . . . . . . . . . . . . . . . . . . . . . . . . . . Back Page
Please keep this handbook for future reference, or for anyone else
who may use the appliance.
1
Introduction
Thank you for choosing a British
built appliance by Belling
Ventilation
The use of a gas cooking appliance
results in the production of heat and
moisture in the room in which it is
installed. Ensure that the kitchen is well
ventilated: keep natural ventilation
holes open or install a mechanical
ventilation device (mechanical extractor
hood). Prolonged intensive use of the
appliance may call for additional
ventilation, for example, opening of a
window, or more effective ventilation,
for example increasing the level of
mechanical ventilation where present.
We hope that the following information
will help you to familiarise yourself
with the features of the appliance, and
to use it successfully and safely.
Our policy is one of constant development
& improvement. Strict accuracy of
illustrations and specifications is not
guaranteed. Modification to design
and materials may be necessary
subsequent to publication.
This appliance must be installed in
accordance with the regulations in
force, and only in a well ventilated
space. Read the instructions before
installing or using this appliance.
Moving the cooker
Do not attempt to move the cooker by
pulling on the doors or handles. Open
the door and grasp the frame of the
cooker, taking care that the door does
not shut on your fingers.
Your new appliance is designed to be
installed flush to base units. Certain
features, such as oven lights, are only
available on some models.
Take care to avoid damage to soft or
uneven floor coverings when moving
the appliance. Some cushioned vinyl
floor coverings may not be designed
to withstand sliding appliances without
marking or damage.
Your 1st Year Guarantee
To fulfil the conditions of your guarantee,
this appliance must be correctly
installed and operated, in accordance
with these instructions, and only be
used for normal domestic purposes.
Please note that the guarantee, and
Service availability, only apply to the
UK and Republic of Ireland.
2
Introduction
Glass door panels
Before using the appliance for
the first time, remove any protective
polythene film and wash the oven
shelves and furniture in hot soapy
water, to remove their protective
coating of oil. Even so, when you first
turn on the oven or grill you may
notice a smell and some smoke.
To meet the relevant Standards of
Domestic cooking appliances, all the
glass panels on this appliance are
toughened to meet the fragmentation
requirements of BS3193. This ensures
that, in the unlikely event that a panel
breaks, it does so into small fragments
to minimise the risk of injury.
Stability bracket
Please take care when handling, using
or cleaning all glass panels as any
damage to the surfaces or edges may
result in the glass breaking without
warning or apparent cause at a later
date. Should any glass panel be
damaged, we strongly recommend
that it is replaced immediately.
If the cooker is to be fitted with a flexible
inlet connection, a stability bracket
should also be fitted to engage in the
back of the cooker. Make sure this is
re-engaged whenever you move the
cooker for cleaning.
The cooling fan
All models with rear lights
When the appliance is switched on,
you may hear the cooling fan come
on. This keeps the fascia and control
knobs cool during grilling / cooking
and will continue to operate for up to
15 minutes after the appliance has
been switched off.
To replace an oven light bulb WARNING - switch off the electricity
supply to the appliance at the socket,
to avoid the risk of electric shock.
Wait until the oven is cool, then
remove the oven shelves.
During oven use the fan may cycle on
and off. Should any fault occur with
the cooling fan, the appliance will
require servicing. Contact Customer
Support.
The oven light is at the rear of the oven
cavity.
Unscrew the lens cover (turn anticlockwise). Unscrew the bulb and replace.
Replace lens cover.
Please note that the oven light bulb is
not covered by guarantee.
3
Introduction
Environmental Protection
We are committed to protecting the
environment
and
operate
an
Environmental Management System
which complies with BS EN ISO
14001:1996.
Disposal of packaging
•
All our packaging materials are
recyclable and environmentally
friendly.
•
Please help us to protect our
environment by disposing of all
packaging in an environmentally
friendly manner.
•
Please contact your local authority
for the nearest recycling centre.
Caution: Packaging materials can
pose a risk of suffocation - keep away
from children.
Gas & Electrical connection
Please refer to installation instructions
for the Gas & Electrical Safety Regulations
and the Ventilation Requirements.
In your own interest, and that of safety,
it is the law that all gas appliances be
installed by competent persons. Corgi
registered installers undertake to work
to satisfactory standards.
Disconnection of gas and electric
appliances should always be carried
out by competent persons.
Warning: This appliance must be
earthed.
4
Be Safe - Not Sorry
When you are cooking, keep
children away from the vicinity
of the appliance.
the grill pan, or put items wrapped
in foil under the grill as this creates
a fire hazard.
I Do not use the oven with the door
inner glass panel removed (glass
oven doors only).
This product is designed as a domestic
cooking appliance for the preparation
and cooking of domestic food
products, and should not be used for
any other purpose.
I Use oven gloves when removing
hot food / dishes from the oven or
grill. The oven / grill and utensils
will be very hot when in use.
I Remove all packaging, protective
films and oils from the appliance
before using for the first time.
I Do not use foil on oven shelves or
allow it to block the oven flue, as
this creates a fire hazard, and prevents heat circulation.
I Make sure you read and
understand the instructions before
using the appliance.
I Keep electrical leads short so they
do not drape over the appliance
or the edge of the worktop.
I Switch off the electricity supply
before replacing the oven light
bulb (if fitted) to avoid the risk of
electric shock.
I Keep all flammable materials (such
as curtains, furnishings & clothing)
away from the appliance.
I When cooking heavy items - eg;
turkeys - do not pull the oven shelf
out with the item still on the shelf.
I Parts of the appliance may be hot
during or immediately after use.
Allow sufficient time for the appliance
to cool after switching off.
Drop-down door models: Do not
place items on the door when open.
I When you have finished cooking
check that all controls are in the
“off” position.
I Never use the appliance for
heating a room.
I Do not drape tea towels over the
flue vents or door, as this creates a
fire hazard.
All installation, servicing and
maintenance work should be carried
out by a competent person who will
comply with current Regulations,
Standards and Requirements.
I When opening the appliance
door, take care to avoid skin
contact with any steam which may
escape from the cooking.
As with all gas appliances, it is
recommended that your appliance is
serviced regularly.
I Do not use aluminium foil to cover
5
Using the Hob
Ignition
such as change in flame appearance,
or the operation of controls - seek
expert advice.
Push in and turn the selected control
knob anticlockwise to the ‘full on’ position
and press the ignition switch (if fitted),
or hold a lighted match or taper to the
burner, until the burner lights. Hold the
control knob in for 15 seconds. Do
not hold the control knob in for longer
that 15 seconds. If the burner fails to
light within this time, release the control knob and wait one minute before
attempting further ignition. Turn the
control knob to the required setting.
Pans
For optimum safety and performance, we
recommend the use of flat bottomed pans
with a base diameter of minimum 100mm
(4”) and maximum 250mm (10”).
Do not use double pans, rim based
pans, old misshapen pans or any pan
which is unstable when placed on a
flat surface.
Adjust the burner flame so that it does
not extend over the pan base.
Position pans over the centre of the
burners, resting on the pan supports.
If positioned off centre, smaller pans
may be unstable.
To turn off, push in the control knob
and turn clockwise until the dot on the
control knob is below the dot on the
facia panel.
When cooking with fat or oil, never
leave unattended.
To simmer
Turn pan handles to a safe position,
so they are out of reach of children,
not overhanging the appliance, and
cannot be caught accidentally.
The simmer position is marked by the
small flame symbol.
Once lit turn the selected control knob
anticlockwise past the large flame
symbol (FULL ON) to the small flame
symbol.
Commercial simmering aids should
not be used as they create excessive
temperatures that can damage the surface and may cause a hazard.
You may hear a slight popping noise
when the hob burners are operating
and this is quite normal, but if anything
about the cooker appears unusual,
6
Using the Hob
Pan supports
Always make sure the pan supports
are replaced correctly, and located in
the hob spillage well.
To save gas
I Use the size of pan most suited to
the size of the burner - ie; larger
pans on the larger burners, smaller
pans on the smaller burners.
I Adjust the flames so that they do
not lick up the sides of the pan.
I Put lids on saucepans and only heat
the amount of liquid you need.
I When liquids boil, reduce the control
setting to maintain a simmer.
I Consider the use of a pressure
cooker for the cooking of a
complete meal.
I Potatoes and vegetables will cook
quicker if chopped into smaller
pieces.
7
Using the Grill
Caution: Accessible parts may
be hot when the grill is used.
Young children should be kept
away.
Place the handle over the edge of the
grill pan, at the narrow side edges.
Slide the handle to the centre, and
locate between the handle position
indicators.
Ignition
Open the grill door.
Push in and turn the grill control knob
anticlockwise to the “full-on” position.
Hold the control knob in and press the
ignition switch (if fitted), or hold a
lighted match or taper to the burner,
until the burner lights. Hold the control
knob in for 15 seconds. Do not hold
the control knob in for longer that 15
seconds. If the burner fails to light
within this time, release the control
knob and wait one minute before
attempting further ignition.
The handle should be removed from
the pan during grilling, to prevent
overheating.
Important: Keep the grill door open
when the grill is on.
The handle is designed for removing /
inserting the grill pan under the grill
when grilling.
To turn off, push in the control knob
and turn it clockwise to the “off” position.
If cleaning the grill pan when it is hot,
use oven gloves to move it. Do not use
the handle to pour hot fats from the
grill pan.
Detachable grill pan handle
Food for grilling should be positioned
centrally on the trivet.
Preheating
For best cooked results, always
preheat the grill for about 3 minutes.
8
Using the Grill
Aluminium foil
Using aluminium foil to cover the grill
pan, or putting items wrapped in foil
under the grill creates a fire hazard.
Using the grill
Push the grill pan towards the back of
the shelf, to position it under the grill.
Variation in grilling can be achieved
by setting the grill between the large
and
small
flame
symbols.
Important: Never operate the grill
between the large flame and the off
position.
The speed of grilling can also be
controlled by selecting a higher or
lower shelf position.
For toasting, and for grilling foods
such as bacon, sausages or steaks,
use a higher shelf position.
For thicker foods such as chops or
chicken joint pieces, use a middle to
low shelf position.
The grill trivet, inside the grill pan, can
be inverted to give a high or low
position, or it may be removed.
When you have finished grilling,
check that the control knob is
returned to the off position.
9
Using the Oven
Caution: Accessible parts may
be hot when the appliance is in
use, young children should be
kept away.
Zones of heat
The temperature at the centre of the
oven corresponds with the selected gas
mark and is slightly higher towards the
top of the oven and slightly lower
towards the oven base.
Ignition
Open the oven door. Push in and turn
the oven control knob to the full on
position (gas mark 9).
These zones of heat can be useful as
different dishes requiring different
temperatures can be cooked at the
same time, when more than one shelf
is used.
Hold the control knob in and press the
ignition switch (if fitted), or hold a
lighted match or taper to the burner,
until the burner lights. Hold the control
knob in for 15 seconds. Do not hold
the control knob in for longer that 15
seconds. If the burner fails to light
within this time, release the control
knob and wait one minute before
attempting further ignition.
The temperature at the oven base is
suitable for cooking baked vegetables,
baked fruit, milk pudding etc, and for
warming bread rolls, soup, coffee, or
ovenproof plates and dishes.
If you find that over a period of time,
the oven becomes hotter when used at
a particular gas mark, the thermostat
may need to be replaced.
Preheating
The oven must be preheated for 15 20 minutes when cooking frozen or
chilled foods, and we recommend preheating for yeast mixtures, batters,
soufflés, whisked sponges and pastry.
If you are not preheating the oven, the
cooking times in the following guides
may need to be extended, as they
are based on a preheated oven.
10
Using the Oven
Baking tray and roasting tins
Slow cooking
For best cooked results and even
browning, the maximum size baking
trays and roasting tins that should be
used are as follows;
Make sure that frozen foods are
thoroughly THAWED before cooking.
Baking tray
Do not slow cook joints of meat or
poultry weighing more than 21⁄4kg / 41⁄2lb.
Always use the top half of the oven for
slow cooking.
350mm x 280mm
This size of baking tray will hold up to
16 small cakes.
Roasting tin
For roasting joints of meat or poultry,
and for pot roasts preheat the oven to
gas mark 6 and cook for 30 minutes,
then adjust the oven control to the ‘S’
slow setting for the remainder of the
cooking time.
370mm x 320mm
We recommend that you use good
quality cookware. Poor quality trays
and tins may warp when heated,
leading to uneven baking results.
Slow cooking times will be about three
times as long as conventional cooking
times.
Oven light (if fitted)
The oven light is operated by the oven
light switch, located on the facia.
Shelf positions
The oven shelf must be positioned with
the upstand at the rear of the oven and
facing upwards.
Position baking trays and roasting tins
on the middle of the shelves, and leave
1 clear shelf position between shelves,
to allow for circulation of heat.
When cooking 2 trays or items,
remove the top item when it is cooked
and raise the lower item to the higher
shelf to finish cooking, or where
additional browning of the bases is
required - eg; pies and pastries,
interchange part way through cooking.
If you prefer darker cooked results,
cook on a higher shelf, for paler results
use a lower shelf.
11
Using the Oven
Baking guide
Dish
Recommended
gas mark
Shelf
position
Approximate
cooking time
Scones
Meringues
7
“S” slow setting
top to middle
middle to bottom
8 - 15 mins
3 - 4 hours
5
5
6
4
middle
middle
middle
middle
to
to
to
to
top
top
top
top
15 - 25 mins
20 - 30 mins
8 - 15 mins
20 - 35 mins
4
3
2
1 or 2
2 or 3
middle
middle
middle
middle
middle
to
to
to
to
bottom
bottom
bottom
bottom
20 - 30 mins
11⁄4 - 11⁄2 hours
1 - 11⁄2 hours
depends on recipe
21⁄2 - 3 hours
Pastry
Rough puff & Flaky / Puff
Shortcrust & Flan
Choux
7
6
6
middle to top
middle to top
middle to top
15 - 45 mins
15 - 45 mins
20 - 45 mins
Biscuits
Shortbread fingers
Nut brownies
Flapjacks
Ginger nuts
3
3
4
5
middle
middle
middle
middle
to
to
to
to
top
bottom
top
top
20 - 30 mins
12 - 18 mins
20 - 40 mins
7 - 12 mins
Puddings
Rice pudding
Baked custard
Bread and butter
Hot soufflé
Fruit crumble
2
2 or 3
3
4
5
middle
middle
middle
middle
middle
to bottom
to bottom
to top
to top
2 - 21⁄2 hours
1 - 11⁄4 hours
1 - 11⁄4 hours
40 - 50 mins
30 50 mins
Bread (2 x 500g)
Bread (1 x 1kg)
7
7
middle to top
middle to top
20 - 40 mins
30 - 45 mins
Cakes
Small cakes
Whisked sponge
Swiss roll
Victoria sandwich
(2 x 180mm / 7”)
Genoese sponge
Madeira (180mm/7”)
Gingerbread
Very rich fruit cake (205mm/8”)
Semi-rich fruit cake (205mm/8”)
Note: The cooking times given above are based on cooking
in a pre-heated oven.
Please note that the times and temperatures stated in the
baking guide are only intended for reference only - refer to
your recipe.
12
Using the Oven
Traditional fruit cakes
Roast turkey
It should be remembered that ovens
can vary over time, therefore cooking
times can vary, making it difficult to be
precise when baking fruit cakes.
Roasting turkey involves cooking two
different types of meat - the delicate
light breast meat, which must not be
allowed to dry out, and the darker leg
meat, which takes longer to cook.
It is necessary therefore, to test the
cake before removal from the oven.
Use a fine warmed skewer inserted
into the centre of the cake. If the
skewer comes out clean, then the cake
is cooked.
The turkey must be roasted long
enough for the legs to cook, so
frequent basting is necessary. The
breast meat can be covered once
browned.
I Do not attempt to make Christmas
cakes larger than the oven can cope
with, you should allow at least
25mm (1 inch) space between the
oven walls and the tin.
I Always make sure that the turkey
is completely thawed and that
the giblets are removed before
cooking.
I Turkey should be roasted at gas
mark 4 for 20 minutes per 1lb,
plus 20 minutes, unless packaging
advises otherwise.
I Always follow the temperatures
recommended in the recipe.
I To protect a very rich fruit cake
during cooking, tie 2 layers of
brown paper around the tin.
I The turkey can be open roasted,
breast side down, for half of the
cook time, and then turned over for
the remainder of the cooking time.
I We recommend that the cake tin is
not stood on layers of brown
paper, as this can hinder effective
circulation of air.
I If the turkey is stuffed, add 5
minutes per lb to the cooking time.
I Do not use soft tub margarine for
rich fruit cakes, unless specified in
the recipe.
I If roasting turkey covered with
foil, add 5 minutes per 1lb to the
cooking time.
I Always use the correct size and
shape of tin for the recipe quantities.
To test if the turkey is cooked, push a
fine skewer into the thickest part of the
thigh. If the juices run clear, the turkey
is cooked. If the juices are still pink,
the turkey will need longer cooking.
13
Using the Oven
Roasting guide
Notes:
I When cooking stuffed meat or
poultry, calculate the cooking time
from the total weight of the meat
plus the stuffing.
The times given in the roasting guide
are only approximate, because the
size and age of the bird will influence
cooking times as will the shape of a
joint and the proportion of the bone.
I For joints cooked in foil or covered
roasters, and for lidded casseroles,
add 5 minutes per 450g (1lb) to
the calculated cooking time.
Frozen meat should be thoroughly
thawed before cooking. For large
joints it is advisable to thaw overnight.
I Smaller joints weighing less than
1.25kg (21⁄2lb) may require 5
minutes per 450g (1lb) extra
cooking time.
Frozen poultry should be thoroughly
thawed before cooking. The time
required depends on the size of the
bird - eg; a large turkey may take up
to 48 hours to thaw.
I Position the oven shelf so that the
meat or poultry will be in the
centre of the oven.
Use of a trivet with a roasting tin will
reduce fat splashing and will help to keep
the oven interior clean. Alternatively,
to help reduce fat splashing, potatoes
or other vegetables can be roasted
around the meat / poultry.
I It is recommended that the appliance
is cleaned after open roasting.
Cook in oven at Gas Mark 5
Approximate Cooking Time
(preheated oven)
Beef
Rare
Medium
Well done
20 minutes per 450g (1lb), plus 20 minutes
25 minutes per 450g (1lb), plus 20 minutes
30 minutes per 450g (1lb), plus 30 minutes
Lamb
Medium
Well done
25 minutes per 450g (1lb), plus 25 minutes
30 minutes per 450g (1lb), plus 30 minutes
Pork
35 minutes per 450g (1lb), plus 35 minutes
Poultry
20 minutes per 450g (1lb), plus 20 minutes
14
Minute Minder (if fitted)
Initial display
Setting the minute minder
1. Press and release the plus button
to change the display from clock
to minute minder - the bell symbol
will light.
2. Use the plus and minus buttons to
set the length of time before the
alarm tone will sound. The display
will increase / decrease in units of
10 seconds up to 99 minutes 50
seconds, and in units of 1 minute
from 1 hour 40 minutes upwards.
The maximum period which may
be set is 10 hours.
The digital timer enables you to set the
time of day (24 hour clock) and the
minute minder alarm.
The display format will change
after 99 minutes and 50 seconds
to 1 hour and 40 minutes.
Setting the “Time of Day”
1. Switch on the electricity supply to
the appliance.
During countdown, the minute
minder has priority on the display,
which will show (in minutes :
seconds, or hours : minutes) the
time remaining.
The display will flash.
2. Press and release the time of day
button.
3. Set the time of day with the plus
and minus buttons.
When countdown is complete, the
tone will sound for 7 minutes, or it
can be reset with one touch of
any button.
4. The time will be set 7 seconds after
the last plus or minus operation.
Alarm tones
To cancel the minute minder at
any other time, run down the set time
with the minus button.
After setting the time of day, you can
select one of three alarm tones.
Press the minus button to listen to the
first tone, then release the minus button
and press it again to listen to the
second tone, etc.
The display will revert to show the
time of day.
Releasing the minus button after a tone
has sounded will automatically select
that tone.
15
Cleaning
Caution: Any cleaning agent
used incorrectly may damage
the appliance.
Burner caps and heads
Important: Allow burners to cool
before cleaning.
Always let the cooker cool
before cleaning.
Caution: Hotplate burners can be
damaged by soaking, automatic
dishwashers (or dishwasher powders
/ liquids), caustic pastes, hard
implements, coarse wire wool, and
abrasive cleaning pastes.
Some cooking operations generate
considerable amount of grease, this
combined with spillage can become a
hazard if allowed to accumulate on
the cooker through lack of cleaning.
In extreme cases this may amount to
misuse of the appliance and could
invalidate your guarantee.
Clean with a moist soapy pad - eg;
“Brillo”.
For the burners to work safely, the slots
in the burner head where the flames
burn need to be kept clear of deposit.
Clean with a nylon brush, rinse, and
dry thoroughly.
It is recommended that the appliance
is cleaned after open roasting.
Do not use caustic, corrosive or
abrasive cleaning products, products
containing bleach, coarse wire wool
or any hard implements, as they will
damage the surfaces.
Important: The burner caps and
heads must be repositioned correctly
so that they sit squarely onto the hob
as shown.
All parts of the appliance can be safely
cleaned with a cloth wrung out in hot
soapy water.
Painted, plastic and metal finish
parts (if fitted)
(if fitted), OVEN DOOR
& HANDLE, GRILL PAN HANDLE, FACIA
& CONTROL KNOBS
METAL DOOR PANEL
FRAME
PANEL
Only use a clean cloth wrung out in
hot soapy water.
16
Cleaning
Vitreous Enamel parts
GRILL PAN, HOB TOP
Note: These items may also be
cleaned in a dishwasher.
& PAN SUPPORTS, OVEN
COMPARTMENT FLOOR, OVEN COMPARTMENT
(WIPE-CLEAN
OVENS)
Use a mild cream cleaner - eg; “Cif”.
Stubborn marks may be removed with
a moistened “Brillo” pad.
The pan supports and grill pan may be
cleaned in a dishwasher, or with a
nylon brush in hot soapy water.
Glass parts
GLASS DOOR PANELS
Do not use abrasives or polishes as
they will scratch and damage the glass.
Use a mild cream cleaner - eg; “Cif”.
Rinse away excess cleaner and dry
with a soft cloth.
Warning: Do not operate the appliance
without the glass panel correctly fitted.
Important: the inner door glass
panel can be removed for cleaning but
it must be replaced the right way up
(so the reflective side - if fitted - faces
inwards), and pushed fully in to the
stop position. To remove the glass
panel, open the door wide, hold the
top and bottom edges and slide out.
Chrome plated parts
OVEN SHELF
&
SHELF RUNNERS, GRILL PAN
RUNNERS, GRILL PAN TRIVET
Use a moist soap pad - eg; “Brillo”.
Note: Oven shelf runners (if fitted) can
be removed for cleaning. Grasp the
runners and slide out of the hanging
holes as shown.
17
Installation Instructions
Before you start: Please read the
instructions. Planning your installation will
save you time and effort.
accordance with all local gas and electrical
regulations. In the Republic of Ireland,
Installers should refer to IS813 Domestic
Gas Appliances.
Prior to installation, ensure that the local
distribution conditions (nature of the gas and
gas pressure) and the adjustment of the
appliance are compatible. The adjustment
conditions are stated on the data badge.
Ventilation Requirements
The room containing the appliance should
have an air supply in accordance with
BS 5440: Part 2: 1989:
• All rooms require an openable window,
or equivalent, and some rooms will
require a permanent vent as well.
• For room volumes up to 5m3 an air
vent of 100cm2 is required.
• If the room has a door that opens directly
to the outside, or the room exceeds
10m3, NO AIR VENT is required.
• For room volumes between 5m3 and
10m3 an air vent of 50cm2 is required.
• If there are other fuel burning appliances
in the same room, BS 5440: Part 2:
1989 should be consulted to determine
the air vent requirements.
• This appliance must not be installed in
a bed sitting room of less than 20m3 or
in a bathroom or shower room.
Windows and permanent vents should
therefore not be blocked or removed without
first consulting a GAS SAFE gas installer.
This appliance is not connected to a combustion
evacuation device. It shall be installed and
connected in accordance with current
installation regulation. Particular attention
shall be given to the relevant requirements
regarding ventilation.
In your own interest and that of safety, it is
the law that all gas appliances be installed
and serviced by competent persons. GAS
SAFE registered installers undertake to
work to satisfactory standards.
Where regulations or standards have been
revised since this handbook was printed,
always use the latest edition.
In the UK the regulations and
standards are as follows:
1. Gas
Safety
Regulations
1996
(Installation and Use).
2. Building Regulations - Issued by the
Department of the Environment.
3. Building
Standards
(Scotland)
(Consolidated) - Issued by the Scottish
Development Department.
4. The current I.E.E. Wiring Regulations.
5. Electricity at Work Regulations 1989.
6. BS 6172 Installation of Domestic Gas
cooking Appliances
7. Installation & Servicing Instructions for
this appliance.
In the Republic of Ireland, refer to relevant Irish
Standards for correct ventilation requirements.
Failure to install appliances correctly is
dangerous and could lead to prosecution.
For installation in countries other than the
UK, the appliance must be connected in
18
Installation Instructions
Whilst every care is taken to eliminate
burrs and raw edges from this product,
please take care when handling - we
recommend the use of protective
gloves during installation.
Clearances
Moving the cooker
No shelf or overhang or cooker hood
should be closer than a minimum of
650mm, but check with cooker hood
manufacturer’s recommendations.
Please note that the weight of this
appliance
is
approximately
60kg(unpacked).
The cooker must have a side
clearance above hob level of 90mm
up to a height of 400mm.
Take care if the appliance needs to be
lifted during installation - always use
an appropriate method of lifting.
This cooker may be fitted flush to
base units. However, for models with
side opening doors, we recommend a
side clearance of 60mm between the
cooker and any side wall.
Do not attempt to move the cooker by
pulling on the doors or handles. Open
the door and grasp the frame of the
cooker, taking care that the door does
not shut on your fingers.
Take care to avoid damage to soft or
uneven floor coverings when moving
the appliance. Some cushioned vinyl
floor coverings may not be designed
to withstand sliding appliances without
marking or damage.
Clearances & dimensions
Appliance dimensions
All sizes are nominal - some variation
is to be expected. The ‘depth’ of the
cooker, as given below, is to the front
of the door & excluding knobs & handles.
depth:
600mm
width:
600mm
height:
900 - 915mm
19
Installation Instructions
Stability bracket
4. Fix the bracket to the floor.
Measure from
If the cooker is fitted with a flexible
connection, a stability bracket should
be fitted to engage in the back of the
cooker. A stability bracket can be
bought from your local supplier.
LEVEL to
in the back of
the cooker and add 3mm.
FLOOR
ENGAGEMENT EDGE
5. Assemble the underside of the top
part of the bracket to this height.
A stability bracket can be fitted as
follows:
Levelling
1. Place the cooker in position and
draw a PENCIL LINE level with the
front edge.
Place a spirit level on a baking sheet
onto an oven shelf.
The cooker is fitted with levelling feet
at the front and rear.
2. Mark the centre of the cooker to
give the CENTRE LINE for the bracket.
3. Remove the cooker and mark off
450mm from the PENCIL LINE to
locate the front edge of the lower
bracket.
20
Installation Instructions
Connect to the electricity supply
As the colours of the wires in the
mains lead for the appliance may
not correspond with the coloured
markings identifying the terminals in
your plug, proceed as follows:
Warning: This appliance must be
earthed.
The flexible mains lead is supplied
connected to a BS 1363 fused plug,
having a fuse of 3 amp capacity.
1. The wire which is coloured green
and yellow must be connected to
the terminal marked E
(Earth)
or coloured Green.
If this plug does not fit the socket in
your home, it should be replaced with
a suitable plug as outlined below.
2. The wire which is coloured blue
must be connected to the terminal
marked N (Neutral), or coloured
Black.
E (Earth)
GREEN / YELLOW
N (Neutral)
BLUE
3. The wire which is coloured brown
must be connected to the terminal
marked L (Live), or coloured Red.
L (Live)
BROWN
The plug and socket must
accessible after installation.
be
Should the mains lead of the
appliance ever require replacing, we
recommend that this is carried out by
a qualified electrician who will
replace it with a lead of the same size
and temperature rating.
Use a 3 amp fuse
in a 13 amp plug.
The wires in the mains lead are
coloured in accordance with the
following code:
Important: - ensure that you route
all mains and electrical cables and
flexible tubing well clear of any
adjacent heat source. Under no circumstances should the electrical mains
lead be allowed to come into contact
with the vertical oven flue tubes on the
rear of the appliance.
Green and yellow = Earth,
Blue = Neutral,
Brown = Live.
21
Installation Instructions
Connect to the gas supply
ing the ignition switch or holding a
lighted match or taper to the burner.
Hold the control knob in for 15 seconds. Do not hold the control knob in
for longer that 15 seconds. If the burner fails to light within this time, release
the control knob and wait one minute
before attempting further ignition..
The inlet to the cooker is ⁄2” BSP
internal situated at the rear right corner.
1
Fit the bayonet connection. This should
be located so as to ensure the flexible
connector hose does not kink.
Under no circumstances should the flexible connector be allowed to come into
contact with the vertical oven flue tubes
on the rear of the appliance.
Hob - Turn the control knob to the FULL
position, wait a second before
pressing the ignition switch or holding
a lighted match or taper to the burner.
Hold the control knob in for 15 seconds. Do not hold the control knob in
for longer that 15 seconds. If the burner fails to light within this time, release
the control knob and wait one minute
before attempting further ignition.
ON
Use a 900mm - 1125mm length of
flexible connector.
Ensure that all pipe work is of the correct
rating for both size and temperature.
Natural Gas - Flexible connections
should comply with BS 669. Parts of
the appliance likely to come into
contact with a flexible connector have
a temperature rise of less than 70˚C.
Oven - Open the oven door. Push in
and turn the control knob to the full on
position (gas mark 9). Hold the control
knob in and operate the ignition
button.Hold the control knob in for 15
seconds. Do not hold the control knob
in for longer that 15 seconds. If the
burner fails to light within this time,
release the control knob and wait one
minute before attempting further ignition.
After installation, make sure all
connections are gas sound.
Commissioning
Burner aeration
All burners have fixed aeration and no
adjustment is possible.
Pressure setting
G20 Natural Gas @ 20 mbar
Before leaving the installation
1. Place all the loose parts of the
cooker into position.
Pressure test point
Use the oven injector
2. Show the customer how to operate
the cooker and give them this
handbook. Thank you.
Grill - Open the grill door, push the
control knob in and turn to the FULL ON
position. Wait a second before press22
Technical Data
Data badge - Lower part of front frame
caps which are removable for cleaning.
Concealed electrodes to each burner.
Type of gas
This cooker must only be used on Natural
Gas only.
Oven - Oven burner is sheet steel, with
pierced ports in stainless steel flame strip.
Spark Gap: 3 - 4mm. Flame supervision:
Thermoelectric type. Thermostat phial:
Rear right hand side of oven.
Gas category
Natural Gas - I2H.
Electrical supply (models with ignition)
Pressure setting
G20 Natural Gas @ 20 mbar
220 - 240V ~ 50Hz
Warning: This cooker must be earthed.
Pressure test point
Use the oven injector
Aeration - Fixed
Appliance class
Class 1, Freestanding
Countries of destination
GB - Great Britain, IE - Ireland
Grill - Grill burner is surface combustion
type. Spark gaps 3 - 4mm.
Hob - Burners have burner heads and
Gas
Burner
Nominal
Rate Qn
Injector
Size
Grammes per hour
Butane
Propane
Natural
Gas
Grill
Hob - LHF
Hob - LHR & RHR
Hob - RHF
Oven
Total heat input
2.4kW
1.0kW
2.0kW
3.0kW
2.5kW
∑Qn 12.9kW
115
77
104
130
180 amal
-
-
23
-
Notes
08 27426
Notes
08 27426
Belling Customer Care
Please keep this handbook in a safe place as the information inside may be of
use should you sell, or pass on the appliance. Please fill in the model number
and serial number in the spaces provided below as they will assist us should you
need to call.
0844 815 3746
When you dial this number you will hear a recorded message and be given a
number of options. This indicates that your call has been accepted and is being
held in a queue. Calls are answered in strict rotation as our Customer Care
Representatives become available.
Enter appliance numbers here for future reference:
Model No
4
4 4
Serial No
These numbers can be found on your appliances data badge.
Outside the UK and Northern Ireland, refer to your local supplier.
Stoney Lane, Prescot, Merseyside, L35 2XW
0827426 02 © 11.2010