CD-C662
SERVICE MANUAL
No. S4917CDC662//
CD-C662
CD-C662 mini component system consisting of CD-C662 (Main unit)
and CP-C662 and (Speaker system).
• In the interests of user-safety the set should be restored to its
original condition and only parts identical to those specified be
used.
CONTENTS
Page
IMPORTANT SERVICE NOTES (FOR U.S.A. ONLY) ....................................................................................................... 2
SPECIFICATIONS ............................................................................................................................................................. 2
NAMES OF PARTS ........................................................................................................................................................... 3
OPERATION MANUAL ...................................................................................................................................................... 5
QUICK GUIDE (FOR U.S.A. ONLY) .................................................................................................................................. 6
DISASSEMBLY .................................................................................................................................................................. 7
REMOVING AND REINSTALLING THE MAIN PARTS ................................................................................................... 10
ADJUSTMENT ................................................................................................................................................................. 10
NOTES ON SCHEMATIC DIAGRAM .............................................................................................................................. 13
WAVEFORMS OF CD CIRCUIT ...................................................................................................................................... 14
BLOCK DIAGRAM ........................................................................................................................................................... 15
SCHEMATIC DIAGRAM/WIRING SIDE OF P.W.BOARD ................................................................................................ 18
TROUBLESHOOTING (CD SECTION) ........................................................................................................................... 36
FUNCTION TABLE OF IC ................................................................................................................................................ 41
FL DISPLAY ...................................................................................................................................................................... 48
REPLACEMENT PARTS LIST/EXPLODED VIEW
PACKING OF THE SET (FOR U.S.A. ONLY)
SHARP CORPORATION
–1–
This document has been published to be used
for after sales service only.
The contents are subject to change without notice.
CD-C662
FOR A COMPLETE DESCRIPTION OF THE OPERATION OF THIS UNIT, PLEASE REFER
TO THE OPERATION MANUAL.
IMPORTANT SERVICE NOTES (FOR U.S.A. ONLY)
BEFORE RETURNING THE AUDIO PRODUCT
(Fire & Shock Hazard)
Before returning the audio product to the user, perform the
following safety checks.
1. Inspect all lead dress to make certain that leads are not
pinched or that hardware is not lodged between the chassis
and other metal parts in the audio product.
2. Inspect all protective devices such as insulating materials,
cabinet, terminal board, adjustment and compartment covers
or shields, mechanical insulators etc.
3. To be sure that no shock hazard exists, check for leakage
current in the following manner.
* Plug the AC line cord directly into a 120 volt AC outlet.
* Using two clip leads, connect a 1.5k ohm, 10 watt resistor
paralleled by a 0.15µF capacitor in series with all exposed
metal cabinet parts and a known earth ground, such as
conduit or electrical ground connected to earth ground.
* Use a VTVM or VOM with 1000 ohm per volt, or higher,
sensitivity to measure the AC voltage drop across the
resistor (See diagram).
* Connect the resistor connection to all exposed metal parts
having a return path to the chassis (antenna, metal cabinet,
screw heads, knobs and control shafts, escutcheon, etc.)
and measure the AC voltage drop across the resistor.
VTVM
AC SCALE
1.5k ohms
10W
0.15 µ F
TO EXPOSED
METAL PARTS
TEST PROBE
CONNECT TO
KNOWN EARTH
GROUND
All check must be repeated with the AC line cord plug connection
reversed.
Any reading of 0.3 volt RMS (this corresponds to 0.2 milliamp.
AC.) or more is excessive and indicates a potential shock
hazard which must be corrected before returning the audio
product to the owner.
SPECIFICATIONS
CD-C662
General
Power source:
Power consumption:
Dimensions:
Weight:
Amplifier section
Output power:
Output terminals:
Input terminal:
Tuner section
Frequency range:
Compact disc player section
Type:
3-disc multi-play compact disc
player
Signal readout:
Non-contact, 3-beam semiconductor laser pickup
D/A Converter:
1-bit D/A converter
Frequency response:
20 - 20,000 Hz
Dynamic range:
90 dB (1 kHz)
AC 120 V, 60 Hz
Stand-by; 0.3 W
Power on; 210 W
Width; 10-5/8" (270 mm)
Height; 13" (330 mm)
Depth; 14-1/8" (358 mm)
22.0 lbs. (10.0 kg)
CP-C662
150 watts minimum RMS per
channel into 6 ohms from 60 Hz
to 20 kHz, 10 % total harmonic
distortion
Speakers; 6 ohms
Headphones; 16-50 ohms
(recommended; 32 ohms)
CD digital output (optical)
Video/Auxiliary (audio signal);
500 mV/47 kohms
Speaker section
Type:
Maximum input power:
Rated input power:
Impedance:
Dimensions:
Weight:
FM; 87.5 - 108 MHz
AM; 530 - 1,720 kHz
2-way type [7-7/8" (200 mm)
woofer and 3-1/8" (80 mm)
tweeter]
300 W
150 W
6 ohms
Width; 9-13/16" (250 mm)
Height; 13" (330 mm)
Depth; 13-1/14" (335 mm)
13.4 lbs. (6.1 kg)/each
Specifications for this model are subject to change without
prior notice.
Cassette deck section
Frequency response:
50 - 14,000 Hz (Normal tape)
Signal/noise ratio:
55 dB (TAPE 1, playback)
50 dB (TAPE 2, recording/
playback)
Wow and flutter:
0.15 % (WRMS)
–2–
CD-C662
NAMES OF PARTS
1
CD-C662
2 3
45
Front Panel
1. Disc Number Selector Buttons
2. Disc Tray
3. Multi Indicator
4. Disc Skip Button
5. Open/Close Button
6
7
8
6. Extra Bass Indicator
7. FM Stereo Mode Indicator
8. FM Stereo Indicator
9. (CD) Repeat Indicator
10. (CD) Play Indicator
11. (CD) Pause Indicator
12. Spectrum Analyzer/Volume Level Indicator
13. (TAPE 2) Record Indicator
14. (CD) Disc Number Indicators
15. (CD/TUNER) Memory Indicator
16. Timer Play Indicator
17. Timer Record Indicator
18. Sleep Indicator
19. (CD) Track Down/Review Button
(TUNER) Preset Down Button
(TAPE 2) Rewind Button
20. (CD/TAPE) Stop Button
21. (TAPE) Play Button
(CD) Play/Repeat Button
22. (CD) Track Up/Cue Button
(TUNER) Preset Up Button
(TAPE 2) Fast Forward Button
23. Timer/Sleep Button
24. Clock Button
25. Timer Set Indicator
26. Power Button
27. Function Selector Buttons
28. Equalizer Mode Selector Button
29. Dimmer Button
30. Extra Bass/Demo Mode Button
31. Headphones Socket
32. (TAPE 2) Record Pause Button
33. Memory/Set Button
34. Tuning and Time Up/Cue Buttons
35. Volume Control
19
9
10
11
12 13 14
20
15
16
17
18
21 22
23
28
24
29
25
30
26
27
31 32 33
36
34 35
37
36. (TAPE 1) Cassette Compartment
37. (TAPE 2) Cassette Compartment
Rear Panel
38. CD Digital Output Socket
39. AC power lead
40. FM/AM Loop Aerial Socket
41. Video/Auxiliary (Audio Signal) Input Sockets
42. Speaker Terminals
38
40
39
41
42
–3–
CD-C662
CP-C662
Front Speaker
1. Tweeter
2. Woofer
3. Bass Reflex Ducts
4. Speaker Terminals
1
3
4
2
Remote Control
1. Remote Control Transmitter LED
1
CD Control section
2. Disc Number Select Buttons
3. Memory Button
4. Pause Button
5. Clear Button
6. Track Down/Review Button
7. Track Up/Cue Button
8. Disc Skip Button
9. Play/Repeat Button
10. Stop Button
11. Random Button
Tuner control section
12. Preset Up/Down Buttons
Tape control section
13. (TAPE 1) Play Button
14. (TAPE 2) Record Pause Button
15. (TAPE 1/2) Stop Button
16. (TAPE 2) Play Button
17. (TAPE 2) Rewind Button
18. (TAPE 2) Fast Forward Button
2
8
3
9
4
5
6
7
10
11
12
13 14 15 16 17 18
19
20
Common section
19. Equalizer Mode Selector Button
20. Function Selector Buttons
21. Power Button
22. Extra Bass Button
23. Volume Up/Down Buttons
21
22
–4–
23
–5–
9
8
7
6
5
4
3
2
AM 12:00
POWER
MEMORY/
SET
CLOCK
AM 0:00
0:00
TUNING/
TIME
(
)
In this example, the clock is set for the
12-hour (AM 12:00) system.
(Main unit operation)
SETTING THE CLOCK
or
) button to adjust the hour.
or
) button to adjust the
The clock starts operating from "0" seconds.
(Seconds are not displayed.)
Press the MEMORY/SET button.
Press the TUNING/TIME (
or
) button once to advance
the time by 1 minute. Hold it down to change the time in 5
minute intervals.
The hour setting will not advance even if minutes advance from
"59" to "00".
Press the TUNING/TIME (
minutes.
Press the MEMORY/SET button.
Press the TUNING/TIME (
or
) button once to advance
the time by 1 hour. Hold it down to advance continuously.
When the 12-hour display is selected, "AM" will change automatically to "PM".
Press the TUNING/TIME (
Press the MEMORY/SET button.
Press the TUNING/TIME ( or ) button to select the time
display mode.
"AM 12:00" → The 12-hour display will appear.
.
(AM 12:00 - PM 11:59)
"AM 0:00" → The 12-hour display will appear.
(AM 0:00 - PM 11:59)
"0:00"
→ The 24-hour display will appear.
(0:00 - 23:59)
Note that this can only be set when the unit is first installed
or it has been reset.
Within 5 seconds, press the MEMORY/SET button.
Press the CLOCK button.
Press the POWER button to enter the stand-by mode.
2 Perform steps 1 - 9 above.
MICROCOMPUTER", on page 15.
To change the time display mode:
1 Perform steps 1 - 2 in the section "RESETTING THE
Press the CLOCK button.
The time display will appear for about 5 seconds.
To see the time display:
3 Perform steps 6 - 9 above.
2 Within 5 seconds, press the MEMORY/SET button.
1 Press the CLOCK button.
To change the clock time:
Note:
In the event of a power failure or when the AC power cord is
disconnected, the clock display will go out.
When the AC power supply is restored, the clock display will
flash on and off to indicate the time when the power failure
occurred or when the AC power cord was disconnected.
If this happens, follow the procedure below to change the clock
time.
9
7
8
5
6
1
2
3
4
1,2
2
RESETTING THE MICROCOMPUTER
While pressing down the
button and the
button, hold down the POWER button for at least 1 second.
Press the POWER button to enter the stand-by mode.
Caution:
The operation explained above will erase all data stored in
memory including clock and timer settings, and tuner and CD
presets.
1
2
Reset the microcomputer under the following conditions:
To erase all of the stored memory contents (clock and timer
settings, and tuner and CD presets).
If the display is not correct.
If the operation is not correct.
CD-C662
OPERATION MANUAL
FM/AM loop antenna x 1
Antena de cuadro de
FM/AM x 1
–6–
AC 120 V, 60 Hz
120 V de CA, 60 Hz
AM Loop Antenna
Antena de cuadro
de AM
POWER
Turning the power on and off
Conexión y desconexión de la alimentación
FM Antenna
Antena de FM
Antenna connection
Conexión de las antenas
LEFT
Red
Rojo
15
15
Remote Sensor
Sensor remoto
8” - 20’ (0.2m - 6m)
0,2m - 6m
Black
Negro
RATED SPEAKER INPEDANCE :
6 OHMS MIN.
RIGHT
Batteries are not included.
Las pilas no están incluidas.
2 “AA” batteries
Dos pilas “AA”
Red
Rojo
SPEAKERS
Black
Negro
Remote control
Controlador remoto
Red
Rojo
Right speaker
Altavoz derecho
Left speaker
Altavoz izquierdo
Speaker wire x 2
Cable de altavoz x 2
Speaker connection
Conexión de los altavoces
2 Preparation for use / Preparación para su uso
Remote control x 1
Controlador remoto x 1
1 Check the supplied accessories / Compruebe los accesorios suministrados
MINI COMPONENT SYSTEM
Quick Guide/Guía rápida CD-C662
TAPE 2
To stop the playback
Para detener la reproducción
To stop the playback
Para detener la reproducción
TAPE 2
Volume
Volumen
VOLUME
CD recording
starts.
La grabación de
CD empieza.
Extra bass (X-BASS)
Graves extra (X-BASS)
7 Sound control / Control del sonido
Load the disc to be
recorded.
Introduzca el disco
que va a grabar.
SOFT-2
FLAT
SOFT-1
HEAVY-1
VOCAL
HEAVY-2
Pre-programmed equalizer
Ecualizador preprogramado
To stop the recording
Para detener la grabación
6 Recording from CDs / Grabaciones de discos CD
5 Listening to the radio / Audición de la radio
TAPE 1
4 Listening to a tape / Audición de una cinta
Label facing up
Etiqueta hacia arriba
3 Listening to a CD / Audición de discos CD
CD-C662
CD-C662
DISASSEMBLY
Caution on Disassembly
Follow the below-mentioned notes when disassembling
the unit and reassembling it, to keep it safe and ensure
excellent performance:
1. Take cassette tape and compact disc out of the unit.
2. Be sure to remove the power supply plug from the wall
outlet before starting to disassemble the unit.
3. Take off nylon bands or wire holders where they need to
be removed when disassembling the unit. After servicing
the unit, be sure to rearrange the leads where they were
before disassembling.
4. Take sufficient care on static electricity of integrated
circuits and other circuits when servicing.
CD-C662
Top Cabinet
Front Panel
(A1)x2
ø3x12mm
Side Panel
(Right)
(B1)x2
ø3x10mm
CD-C662
STEP
REMOVAL
PROCEDURE
FIGURE
1
Top Cabinet
1. Screw ..................... (A1) x4
7-1
2
Side Panel
(Left/right)
1. Screw ..................... (B1) x8
7-1
3
CD Player Unit/
CD Tray Cover
1. Turn on the power supply,
open the disc tray, take out
the CD cover, and close.
(Note 1)
2. Screw ..................... (C1) x1
3. Hook ....................... (C2) x3
4. Hook ....................... (C3) x2
5. Socket .................... (C4) x3
7-2
Side Panel
(Left)
(A1)x2
ø3x12mm
Back Board
(B1)x2
ø3x10mm
(B1)x4
ø3x10mm
Figure 7-1
CD Tray Cover
(C3) x1
4
Rear Panel
(with Digital
Output PWB)
1. Screw ..................... (D1) x5
7-2
5
Main PWB
1. Screw ..................... (E1) x1
2. Socket .................... (E2) x4
3. Flat Cable .............. (E3) x1
8-1
Pull
Hook
(C2) x3
1
(C4) x3
1
6
Front Panel
1. Screw ..................... (F1) x3
2. Socket .................... (F2) x1
8-1
7
Power Amp. PWB 1. Screw ..................... (G1) x7
2. Socket .................... (G2) x2
3. PWB Holder ........... (G3) x1
8-2
8
Power Supply PWB 1. Screw ..................... (H1) x4
8-2
9
Display PWB/
Switch PWB
1. Screw ..................... (J1) x13
2. Socket .................... (J2) x1
8-3
10
Tape Mechanism 1. Open the cassette holder.
2. Screw...................... (K1) x6
8-3
11
Turntable
1. Screw ..................... (L1) x1
2. Cover ..................... (L2) x1
8-4
12
Disc Tray
1. Screw ..................... (M1) x2
2. Guide ..................... (M2) x2
8-4
13
CD Servo PWB
(Note 2)
1. Screw ..................... (N1) x1
2. Socket .................... (N2) x4
8-5
14
CD Changer
Mechanism
1. Screw ..................... (P1) x4
8-6
15
CD Mechanism
1. Screw ..................... (Q1) x1
8-6
CD Player
Unit
2
(C3) x1
(C1) x1
ø3x10mm
(D1) x3
ø3x6mm
(D1)x1
ø3x10mm
(D1) x1
ø3x10mm
Rear Panel
Figure 7-2
LOCK
LEVER
Note 1:
How to open the changer manually. (Fig. 7-3)
1. Change, turn fully the lock lever in the arrow direction
through the hole on the loading chassis bottom in this state.
After that, push forward the CD player base.
Note 2:
1. After removing the connector for the optical pickup from the
connector, wrap the conductive aluminium foil around the
front end of connector to protect the optical pickup from
electrostatic damage.
Figure 7-3
–7–
CD-C662
(L1) x1
ø3 x10mm
Front Panel
(L2) x1
(E2)x2
Washer
(E2)x1
(E3)x1
Turntable
(F2)x1
Power Supply
PWB
Main PWB
Disc Tray
(M1) x1
ø3 x10mm
(E1)x1
ø3x10mm
(M2) x1
(F1)x3
ø3x10mm
Power Amp.
PWB
(M1) x1
ø3 x10mm
Main
(E2)x1
PWB
Power Amp.
PWB
CD Player Unit
Figure 8-1
(M2) x1
Figure 8-4
(H1)x4
ø4x8mm
(N1) x1
ø3 x10mm
(G1)x2
ø3x6mm
(G1)x5
ø3x10mm
CD Servo PWB
(G2)x2
(N2) x2
(G3)x1
1
Push
Power
Supply
PWB
1
Push
2 Pull
Power Amp.
PWB
Main
Chassis
(N2) x2
CD Player Unit
Figure 8-5
PowerAmp. PWB
(P1) x4
ø3 x12mm
Figure 8-2
(J2)x1
(Q1) x1
ø2.6 x10mm
Switch PWB
Front Panel
(J1)x2
ø3x10mm
Shift Lever
CD Changer
Mechanism
(J1)x11
ø3x10mm
Display
PWB
Open
Cassette
Holder
(K1)x6
ø3x10mm
CD Player Base
CD Mechanism
Be careful when installing the CD changer mechanism.
Install the CD changer mechanism on the CD player base after
the shift lever has been set in the highest position.
Tape Mechanism
Figure 8-3
Figure 8-6
–8–
CD-C662
CP-C662
STEP
1
PROCEDURE
REMOVAL
Front Panel
1. Net ..........................
2. Rubber ...................
3. Screw .....................
4. Tip ..........................
FIGURE
(A1) x1
(A2) x4
(A3) x4
(A4) x2
9-1
9-2
2
Woofer
1. Screw ..................... (B1) x4
9-2
3
Tweeter
1. Screw ..................... (C1) x4
9-2
Front Panel
Front Panel
(A1)x1
Tweeter
(C1)x4
ø3x10mm
(A4)x2
(A3)x4
ø4x16mm
Woofer
(B1)x4
ø4x16mm
(A2)x4
Figure 9-1
Figure 9-2
–9–
CD-C662
REMOVING AND REINSTALLING THE MAIN PARTS
CD MECHANISM SECTION
Loading/Up/Down
Motor
Perform steps 1, 2, 3, 11, 12, 13, 14 and 15 of the disassembly
method to remove the CD mechanism.
Motor
PWB
How to remove the loading motor
(See Fig. 10-1)
1. Remove the screws (A1) x 2 pcs., to remove the loading
motor.
(A1) x2
ø2.6 x5mm
Figure 10-1
How to remove the pickup (See Fig. 10-2)
1. Remove the screws (B1) x 2 pcs., to remove the shaft (B2).
2. Remove the stop washer (B3) x 1 pc., to remove the gear
(B4).
3. Remove the pickup.
Stop Washer
(B1) x2
(B3) x1
ø2.6 x6mm
Pickup
Note
After removing the connector for the optical pickup from the
connector, wrap the conductive aluminium foil around the
front end of connector to protect the optical pickup from
electrostatic damage.
Shaft
(B2) x1
CD Mechanism
Gear
(B4) x1
Figure 10-2
ADJUSTMENT
MECHANISM SECTION
• Tape Speed
• Driving Force Check
Torque Meter
Specified Value
Play: TW-2412
Tape 1: Over 80 g
Tape 2: Over 80 g
Normal
speed
• Torque Check
Torque Meter
Adjusting
Point
Specified
Value
MTT-111
Volume in
motor.
(MM1)
3,000 ±
30 Hz
Specified Value
Tape 1
Play: TW-2111
Test Tape
30 to 60 g. cm
Tape 2
TAPE MECHANISM
30 to 60 g.cm
Fast forward: TW-2231
—
60 to 120 g.cm
Rewind: TW-2231
—
60 to 120 g.cm
MM 1
Motor
Volume in motor
Figure 10-3
– 10 –
Instrument
Connection
Speaker
terminal
(Load
resistance:
8 ohms)
CD-C662
• VCO Frequency
TUNER SECTION
98.00 MHz
(60 dB)
Test Stage Frequency
Frequency
Display
Setting/ Instrument
Adjusting Connection
Parts
IF
450 kHz
1,720 kHz
T351
Band
Coverage
—
530 kHz
(fL): T333 *2
1.1 ± 0.1 V
Tracking
990 kHz
990 kHz
(fL): T331
*1. Input: Antenna,
*2. Input: Antenna,
*1
*1
Band
Coverage
—
87.50 MHz
RF
98.00 MHz 98.00 MHz
(10-30 dB)
L303(fL):
*1
3.4 V ± 50 mV
*2
*1. Input: Antenna, Output: TP301
*2. Input: Antenna, Output: Speaker terminal
• Detection
Signal generator: 10.7 MHz, FM sweep generator
Frequency Frequency
Display
Detection 10.7 MHz
IF
10.7 MHz
98.00 MHz
98.00 MHz
Adjusting
Parts
T352
Instrument
Connection
State Code
Cannot detect puin SW
Tray close operation error
Tray close operation error
Tray open operation error
Tray open operation error
Disc skip operation error
Disc skip operation error
0307
Disc skip operation error
Pin 13 of IC303
Input: Pin 1 of
IC303
Output: TP302
G
T301(Turn Input: Pin 1 of
the core of IC301
transformer Output: TP302
T352 fully
counterclookwise.)
Pin 21 of IC303
D
FET : 2SK19 or 2SK54
TO FREQUENCY
COUNTER
S
10 kΩ
Figure 11-2
MAIN PWB
1
BF301
IC301
L303
FM BAND
COVERAGE fL
R381
T301
FM IF
L302
FM RF
T351
TP301
AM TRACKING
fL
1
T333
AM BAND
COVERAGE fL
IC303
21
T352
FM DET
VR351
VCO
AM LOOP
ANTENNA
T331
AM IF
13
Pin 13, Pin 21
and ground
of IC303
Error
0001
0101
0105
0201
0203
0304
0305
CNP301
Test
Stage
VR351*
When a malfunction occurs during CD operation, an error
code will be displayed to identify the function in CD operation
which failed.
Instrument
Connection
L302
98.00 MHz
Instrument
Connection
CD ERROR CODE DESCRIPTION
• FM RF
Signal generator: 1 kHz, 75 kHz dev., FM modulated
Serring/
Adjusting
Point
Adjusting
Parts
* Adjust for 76 kHz ± 200 Hz.
Notes:
After preparing the test circuit shown in Fig 11-2, connect the
Pin 13 , Pin 21 and ground of the IC303 with test circuit, and
measure the Value.
At this time, apply a standard unmodulated signal input and
adjust the VCO.
Output: TP302
Output: TP301
Test Stage Frequency Frequency
Display
Frequency
Display
Frequency
fL: Low-range frequency
fH: High-renge frequency
• AM IF/RF
Signal generator: 400 Hz, 30%, AM modulated
R360
TP302
Figure 11-1 ADJUSTMENT POINTS
– 11 –
CD-C662
TEST MODE
• Setting the test mode
Any one of test mode can be set by pressing several keys as follows.
<REC. PAUSE> + <DISC. SKIP> + <POWER>
TEST: CD operation test
• TEST mode
Function — CD test mode
Setting of TEST mode
Indication of CD TST mode (Fig. 12-1)
IL is not performed.
OPEN/CLOSE operation is manual operation.
The pickup can be moved by using the (
<MEMORY>
LASER ON
<MEMORY>
Tracking on the spot.
SERVO OFF PLAY
<PLAY> key input
) or (
) key.
<MEMORY>
Tracking on the spot.
SERVO ON PLAY
<STOP>
STOP
TOC. IL is performed, and the ordinary PLAY is performed.
If the following key is pressed during PLAY, it is possible
to specify directly any Track No.
<Disc Number 1> key: Track 4
<Disc Number 2> key: Track 9
<Disc Number 3> key: Track 15
Note:
Only in STOP state it is possible to slide the pickup with the (
VOL. --- Last memory
BAL. --- CENTER
R.GEQ. --- FLAT
X-BAS --- OFF
1
2
) or (
Press <STOP> key.
Stop
) key.
3
Canceling method - POWER OFF
Figure 12-1
CD SECTION
Since this CD system incorporates the following automatic adjustment function, when the pickup is replaced, it is not necessary
to readjust it.
Since this CD unit does not need adjustment, the combination of PWB and laser pickup unit is not restricted.
• Automatic adjustment item
1. Focus offset (Fig. 12-2)
2. Tracking offset (Fig. 12-3)
3. E/F balance (tracking error balance) (Fig. 12-4)
4. RF level AGC function (HF level: constant)
5. RF level automatic follow-up of the tracking gain
This automatic adjustment is performed each time a disc is changed. Therefore,
each disc is played back using the optimal settings.
Enlarged
View
10ms
0.50 V
IC1 20 FE
0.1s
0.50 V
IC1 20 FE
FOCUS
OFF-SET
ADJUST
10ms
0.50 V
IC1 7 TE
0.1s
0.50 V
IC1 7 TE
TRACKING
OFF-SET
1 ADJUST
TRACKING
OFF-SET
1 ADJUST
2
2
Figure 12-3
Figure 12-2
TRACKING/
ERROR
BARANCE
1 ADJUST
200 ms
1V/diV
IC 1 15
TO
200 ms
1V/diV
IC 1 7
TE
2
Figure 12-4
– 12 –
CD-C662
NOTES ON SCHEMATIC DIAGRAM
• Resistor:
To differentiate the units of resistors, such symbol as K and
M are used: the symbol K means 1000 ohm and the symbol
M means 1000 kohm and the resistor without any symbol is
ohm-type resistor. Besides, the one with “Fusible” is a fuse
type.
• Capacitor:
To indicate the unit of capacitor, a symbol P is used: this
symbol P means micro-micro-farad and the unit of the
capacitor without such a symbol is microfarad. As to
electrolytic capacitor, the expression “capacitance/withstand
voltage” is used.
(CH), (TH), (RH), (UJ): Temperature compensation
(ML): Mylar type
(P.P.): Polypropylene type
• Schematic diagram and Wiring Side of P.W.Board for this
model are subject to change for improvement without prior
notice.
REF. NO
DESCRIPTION
• The indicated voltage in each section is the one measured
by Digital Multimeter between such a section and the chassis with no signal given.
1. In the tuner section,
( ) indicates AM
< > indicates FM stereo
2. In the main section, a tape is being played back.
3. In the deck section, a tape is being played back.
( ) indicates the record state.
4. In the power section, a tape is being played back.
5. In the CD section, the CD is stopped.
• Parts marked with “
”(
) are important for
maintaining the safety of the set. Be sure to replace these
parts with specified ones for maintaining the safety and
performance of the set.
POSITION
REF. NO
DESCRIPTION
POSITION
JOG701
VOLUME JOG
ON—OFF
SW713
STOP
ON—OFF
SW1
OPEN/CLOSE
ON—OFF
SW714
TUNER (BAND)
ON—OFF
SW2
MECHA UP
ON—OFF
SW715
VIDEO/AUX
ON—OFF
SW3
DISC NUMBER
ON—OFF
SW716
TAPE
ON—OFF
SW4
PICKUP IN
ON—OFF
SW717
CD
ON—OFF
SW701
POWER
ON—OFF
SW722
FF
ON—OFF
SW703
CLOCK
ON—OFF
SW723
TUNING UP
ON—OFF
SW704
TIMER/SLEEP
ON—OFF
SW724
TUNING DOWN
ON—OFF
SW705
DISC 1
ON—OFF
SW725
PLAY
ON—OFF
SW706
DISC 2
ON—OFF
SW728
X-BASS/DEMO
ON—OFF
SW707
DISC 3
ON—OFF
SW729
EQUALIZER
ON—OFF
SW708
DISC SKIP
ON—OFF
SW730
DIMMER
ON—OFF
SW709
OPEN/CLOSE
ON—OFF
SWM 3
FOOL PROOF
ON—OFF
SW710
REV
ON—OFF
SWM 4
F.A.S.
ON—OFF
SW711
REC PAUSE
ON—OFF
SWM 5
CAM
ON—OFF
SW712
MEMORY/SET
ON—OFF
FRONT VIEW
FRONT
VIEW
E C B
(S) (G) (D)
(1) (2) (3)
2SA1015 GR
2SA1318
2SC3331
2SC535 C
KRA102 M
KRA109 M
KRC102 M
KRC104 M
KRC107 M
KTA1266
KTA1271
KTA1273
KTA1274
KTD2058
KTC3199
KTC3200
KTC3203
GR
Y
Y
Y
L1154GT4
SLI342YCB
SLI342DCB
SLI342UCB
SLI342YCJ
GR
GR
Y
Figure 13 TYPES OF TRANSISTOR AND LED
– 13 –
CD-C662
WAVEFORMS OF CD CIRCUIT
STOP
FOCUS
1
2
PLAY
SERCH
5ms
0.50 V
IC1 20 F.E
5ms
5.0 V
IC1 54 DRF
0.5ms
10.0 V
JP+
7
0.5ms
10.0 V
JP-
8
0.5ms
0.50 V
JP
9
0.5ms
1.00 V
TE
3
1
3
6
PLAY
CUE
0.5ms
1.00 V
HF
4
0.5ms
5.0 V
HFL
1
5
0.5ms
5.0 V
TES
3
3
0.5ms
1.00 V
HF
NORMAL DISC
TN0=01
10
20ms
1.00 V
SPO
11
20ms
2.00 V
CLV+
2
REVIEW
PLAY
TCD-712 (140mm)
TN0=01
4
5
0.5ms
5.0 V
HFL
1
0.5ms
5.0 V
TES
3
6
50ms
10.0 V
JP+
7
50ms
10.0 V
JP-
8
50ms
0.50 V
JP
9
2
0.5ms
10.0 V
JP+
7
0.5ms
10.0 V
JP-
8
0.5ms
0.50 V
JP
9
0.5ms
1.00 V
TE
6
50ms
10.0 V
JP+
7
50ms
10.0 V
JP-
8
50ms
0.50 V
JP
9
50ms
1.00 V
TE
50ms
1.00 V
SPO
11
50ms
2.00 V
CLV+
CUE
PLAY
TCD-712
12
50ms
1.00 V
TE
6
10
5s
100mV
SLD
1
12
0.5s
100mV
SLD
REVIEW
1
– 14 –
– 15 –
Figure 15 BLOCK DIAGRAM (1/3)
M
M
PICKUP IN
SW4
M1
SPINDLE
MOTOR
M2
SLED
MOTOR
TRACKING COIL
FOCUS COIL
15
16
26
27
6
7
4
5
23
1
2
3
4
20 25
8 ~ 14 21 22 29 ~ 35
IC3
M63001FP
FOCUS/
TRACKING/
SPIN/SLED
DRIVER
1 2 7
28
39
38
37
36
20
40
24
18
42
41
30 31 54
15 16 27 23 29
FIN2
FIN1
E
F
IC1
LA9241M
SERVO AMP.
64
VCC1
62
LD0
TO
FD
SPO
NC
SLD
22
JP– 32
Q52
CV+ 40
SLC 43
SL1 44
~
Q1
SL–
SL+
DRF
PU-IN SW
+B5
+B1
SL+. SL–. DRF
6
23 36 41 43
+5V
51 62 ~ 64
20 JP–
53 ~ 58
27
37
38
39
40
31
CONT2 25
CONT1 24
LCHO
LVSS
RVSS
RCHO
26 33 38 39 46
RES. CQCK. COIN
SQOUT. RWC. WRQ
10 EFMIN
12 CLV+
IC2
LC78622NE
SERVO/SIGNAL
11
CONTROL
9 EFMO
2
4
8
44
XOUT
45
XL1
XIN
CL, DAT, SELIAL CONTROL/CE
51 52 53
+B1
~
+5V
CL
DAT
CE
VVDD
VDD
LVDD
RVDD
XVDD
PICKUP UNIT
+4.3V
Q51
2
1
BI1B
Q81
+5V
CNS10
9
8
7
6
5
4
3
2
1
+7.3V (+B1)
MECHA UP
GND (D)
DISK NO.
OPEN/CLOSE
GND (D)
M–
M+
GND (M)
CNP10
9
8
7
6
5
4
3
2
1
10
SOLM1
M3
LOADING
TO MAIN
SECTION
M
SW1
OPEN/CLOSE
SW3
DISC No.
SW2
MECHA UP
TO MAIN SECTION
(TO IC601)
10 GND (D)
1
2
3
4
5
6
CNP11
REGULATOR
2
1
BI1A
3
2
1
CNP99
CD-C662
CD-C662
SWM3
FOOL PROOF
SWM4
F.A.S
SOLM1
SOLENOID
AM LOOP
FM
ANTENNA ANTENNA
BF301
IC301
TA7358AP
FM FRONT END
1
FM B.P.F
FM IF
6
+B4
+B4
CF301
T301
SWM5
CAM
9
4
5
8
7
L302
T351
FM IF IN
FM OSC
FM RF
VR351
MPX VCO ADJ
AM IF
T352
CF351
1 3
AM MIX
20
22
AM+B
AM OSC IN
23
15
13
3
5
VCO MO/ST
7
6 7
11
3
8
20
22
1
OSC
4
CL
DI
3
11
5
IC302
LC72131
PLL (TUNER)
7
FM +B
16
CE
AM IN
15
FM IN
T333
3 IC704
2
1
VOLTAGE
REGURATER
6
+B4
17
21
10
FM
Q344
SWITCHING
JK601
VIDEO/AUX
L
AUX
R
TAPE
CNS11
TUNER
CD
IC101
AN7345K
PLAYBACK AND RECORD
/PLAYBACK AMP.
L(T1) 1
R(T1) 24
L-CH
R-CH
REC
P.B
L-CH
TAPE 2
R-CH
REC PB HEAD
SWITCHING
Q103~Q106
4 L
21 R
L NF 3
R NF 4
20
H/N
NOR/
HIGH
5
4
17
3
18
2
IC601
M62439SP
AUDIO PROCESSOR
19
1 20
+B4
PB
Q121
Q122
MUTING
L REC
R
8 L NF
17 R NF
10 ALC
7
19
Q111
Q109
SWITCHING
9
Q113
Q114
SWITCHING
Q107
Q108
10
16
T1/T2
15
SWITCHING
L
R
L
R
L
R
L
R
18
REF 14
12
–B4
11
5
T1/T2
L REC 9 REC
R REC 16
AC BIAS
ERASE
HEAD
13
P.B.
L(T2) 2
R(T2) 23
POP REDUCE 6
BIAS
OCS
4
+B5 –B1
FM/AM
SWITCHING
+B7
X352
4.5MHz
TAPE 1
PB HEAD
IC562
KIA4558
OPE AM
Q343
VT
FROM CD SECTION
CNP11
4
IC563
KIA4558
OPE AM
FM/AM
16
17
AM BAND
COVERAGE
1
2
3
8
L 9
R 10
MPX IN
DET OUT
STEREO
24
AM RF IN
FMOSC
Q302
OSC BUFF
T331
–B
MONO/ST
6
5
AM IF GND FM+B FM DET
21
IC303
LA1805
FM/AM IF MPX.
AM TRACKING
+B5
FM DET
L303
DO
3
FM
OSC
2
Q110
Q128
L104
SWITCHING
BAIS
Q124
L103
Q126
Figure 16 BLOCK DIAGRAM (2/3)
– 16 –
13 R
8 L
1
CD-C662
FL701
DISPLAY
Q702
Q703
M
+B5
–B1
8
4
+B5
1 2 3 4 ~ 15 16 ~ 25 26 ~ 28
29 ~ 36
37 38 39
MM1
TAPE MOTOR
Q705
Q706
Q707
NO/ST
3
5
IC563
KIA4558P
OPE AMP. 1
9
6 7
10
51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80
IC562
KIA4558P
OPE AMP.
8
4
+B7
1
+B5 –B1
1
+B7
1
RX701 3
2
+B7
IC701
IX0280AW
SYSTEM CONTROL
MICROCOMPUTER
VDD
3
50
49
48
47
46 VDD
45
44
43
42
41
40
39
38
37
36
35
34 AVDD
33
32
31
VDD
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
UNSWITCH
+B7
MEMORY
BACK UP
30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
+B5
KEY
SW701,
SW703~SW717,
SW722~SW725,
SW728~SW730
TO CD
SECTION
+B7
PHM1
XL701
4.19MHz
Q910
Q911
Q908
Q909
18
22
8 L
Q603
Q604
+B5
RL901
Q901
Q902
13
IC901
STK40704
POWER AMP.
VH+ VH–
VL+ VL– 1 8
7
4
15 L-OUT
14 R-OUT
+B1
+B4
+7.3V
Q851
FRONT
SPEAKER
D810
F804
5A/125V
Q852
+12V(ANALOG)
SO901
SPEAKER
TERMINAL
Q903
Q904
2
VOLTAGE
REGULATOR
REC
M901
FAN MOTOR
JK671
HEADPHONES
Q905
Q601
Q602
M
Q907
Q704
+B5
–B4
13 R
+B1
D809
F801
5A/125V
F805
5A/125V
VOLTAGE
REGULATOR
RL801
D811~D814
+B5
+12V(MOTOR)
Q853
Q850
VOLTAGE
REGULATOR
AC POWER
SUPPLY CORD
VOLTAGE
REGULATOR
ZD802
D815
~D817
Q803
T1/T2
T.F
Q802
BAIS
+B7
F806
2A/250V
AC 120V, 60Hz
T801
POWER
TRANSFORMER
UNSWITCH
Q801
D802~D805
Figure 17 BLOCK DIAGRAM (3/3)
– 17 –
T802
POWER
TRANSFORMER
CD-C662
A
MAIN PWB-A1(2/2)
FM SIGNAL
CD SIGNAL
PLAYBACK SIGNAL
RECORD SUGNAL
C601
4.7/50
P22 2 - E
TO POWER AMP.PWB
CNP901
10
11
12
13
R_CH
GND
–15V
SP_RLY
M_GND
M_+12V
SP_DET
HP-L CH
HP_GND
HP-R CH
HP_RLY
C626
0.001
R620
2.2K
–B
IC601
M62439SP
AUDIO PROCESSOR
19
18
17
16
15
14
11
C622
10/50
R626
2.2K
C628
0.22
R624
330
R630 560(1/2W)
12
R623
5.6K
ZD601
MTZJ2.4B
C606 @4.7/50
13
C617
10/50
C619
0.022
1.5K
1.5K
1.5K
1.5K
0.033
0.22
R612
15K C616
4.7P
C620
10/50
C618
0.022
10
R602
R604
R606
R608
C612
C614
R610
10K
R653
100K
C634
8200P
R629
560(1/2W)
R638
220K
R637
220K
R625
22K
C629
22/25
R628
22K
+B
–B
+B
+B
+B
L601
2.2µH
R155
150
+B
0V
0V
R103
2.2K
R107
47K
0.7V
56
C154
47/16
C156
3.3/50
R136
18K
C130
470P
C132
0.001 R140
560
R142
C136
56
0.082
C140
0.0033
C142
1/50
R146
10K
C145
22/25
C146
220/16
R138
6.8K
8
7
6
5
C121
1/50
R125
5.6K
C119
560P
9
10
11
12
C133
22/25
Q103
KTC3200 GR
13
C141
1/50
R145
10K
R111 10K
H
• NOTES ON SCHEMATIC DIAGRAM can be found on page 13.
1
2
3
4
Figure 18 SCHEMATIC DIAGRAM (1/10)
– 18 –
5
6
0V
R162
14
11.6V
15
R164
56K
Hich=CHROME
+ 56K
–
NC
C115
R117 C113 47/25
1K 330P
IC101
AN7345K
PLAYBACK AND
RECORD/
PLAYBACK
AMP. R119
–
+
ALC RIPPLE
4
16
17
GND Vcc
3
18
ALC
NC
Nor/CrO2
2
19
R158
220
2
11.6V
Q12
KTC320
0V
0V
R168
12
L104 330µH
G
L C111
330P
1
20
NC
0V
0.7V
Q121
0V
KTC3199 GR
MUTING
C151
0.027(ML)
0V
0V
0V
R105
3.3K
112K
Hich=T1
+ 112K
–
R153
10K
Q124
2SA1015 GR
L103 SWITCHING
C150 R166 R167
R160
0.0039 47K 100K 150 (1/2W) 100µH
11.7V
C105
180P
21
–
+
R157
220K
Q122
KTC3199 GR
C129
470P
C131
R139 0.001
560
R141
C135
56
0.082
C139
0.0033
Q105
0V KTC3200 GR
0.7V
22
REC_L
REC_R
C134
22/25
R137
6.8K
0V
R106
3.3K
Q106
KTC3200 GR
0V
23
0V
R135 18K
0V
0.7V
R156
220K
0V MUTING
R154
0.7V 10K
C128
3.3/50
0V
0V
R131
33K
0.7V
R
C112
330P 24
R121
100K
R123
3.9K
R108
47K
R104
2.2K
C117
0.033
R-CH
L-CH
0V
C108
0.001
C106
180P
1
2
3
4
5
6
7
CNP102
TAPE2
RECORD/
PLAYBACK HEAD
R126
5.6K
R124
3.9K
C116
R118 C114 47/25
C122
1K 330P
1/50
Q108
KTC3199 GR
SWITCHING
C101
0.001
R132
33K
C120
560P
C118
0.033
R122
100K
R101
1K
C107
0.001
CNS102
1 M_GND
2 ERASE
3 T2_R2
4 A_GND
5 T2_R1
6 T2_L1
7 T2_L2
R120
56
R102
1K
R110
4.7K
ERASE
HEAD
C102
0.001
Q107
KTC3199 GR
SWITCHING
CNP101
2
R109
4.7K
TAPE1
PLAYBACK HEAD
CNS101
1 T1_R 1
2 A_GND 2
3 T1_L 3
9.3V
Q104
KTC3200 GR
L-CH
R-CH
MECHA BASE
0V
Q109
2SA1318
SWITCHING
R172
220K
R134 68K
1 3.4V
3
Q111
KRC104 M
SWITCHING
R112
10K
8.6V
R171
220K
R170
1.8K
0V
9.3V
E
3
1
R115
4.7K
R
R173
Q113
KTC3199 GR 5.6K
C603
4.7/50
C604
4.7/50
Q114
KTC3199 GR R174
5.6K
D102
1SS133
0V
2
R113
10K
L
+B
3.4V
R169
1.8K
D101
1SS133
R114
10K
C153
100/16
C109
0.047
CHASSIS
Q110
KRC104 M
SWITCHING
+B
C155
3.3/50
C103
0.01
R175
1K
C127
0.022
D
F
R609
2.2K
C624
0.001 R618
2.2K
Q602
KTC3199 GR
R614
10K
R652
100K
C625
0.001
Q601
C621
KTC3199 GR
R617 10/50
2.2K
C623
0.001
C602
4.7/50
20
ZD602
MTZJ2.4B
C
R619
2.2K
C627
22/25
CNS901
L_CH
A_GND
1
2
3
4
5
6
7
8
9
R616
4.7K
R636
330
Q604
Q603
KTC3199 GR KTC3199 GR
R615
4.7K
R635
330
R611
330
R613
10K
C635
8200P
C615
0.22
C605
4.7/50
B
1
2
3
4
5
6
7
8
9
R601 1.5K
R603 1.5K
R605 1.5K
R607 1.5K
C611 0.033
C613 0.22
CD-C662
BI99
R639 @22K
JK601
R651
1K
R650
1K
C632
390P
R631
8.2K
C631
390P
R642
47K
R574
330
–B D556
1SS133
4
1
R573
560K
R157
220K
R578
100K
C568
2.2/50
DI
CE
DO
CLK
HP-R CH
HP_RLY
HP_GND
ZD551
MTZJ6.2C
0V
0.7V
Q121
0V
TC3199 GR
MUTING
HP-L CH
SPEANA1
SPEANA2
SPEANA3 NC
M_+12V NC
SP_DET
SPN_P NC
SP_RLY
HI_CUT
S_MUTE
T_T1 T2
T_BIAS
REC/PLAY
C145
22/25
C146
220/16
+B
+B
A_GND
BI11
CD_GND
C859
0.1(ML)
1 2 3 4 5 6
C860
47/25
+B
R851
33
R850
3.3(1/2W)
Q851
KIA7812P
3
1
2
C856
0.1(ML)
Q852 KIA7806P
3
1
2
D850
1SS133
D851
1SS133
R855
3.3
(1/2W)
C855
0.1(ML)
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
CNP701
+B
1
1
GND
2
2
+5V
3
3
+B
BI801 CNS801
+B
C858
0.1(ML)
C641
0.001
C851
22/25
C853
0.047(ML)
TUN_SM
SUR_ON/OFF
D_GND
+5V
+B
Q850
KTD2058Y
C857
47/25
A_+12V
R853
22K
M_GND
R854
10K
0V
R168
12
+B
R-CH
A_GND
L-CH
CD_GND
+7V
+12V
0V
BIAS OCS
0V
3
2
C854
47/25
0V
Q126
KRC104 M
Q128
BIAS
KTC3203 Y
D853
1SS133
11.6V
1
R852
22K
3
C852
0.047(ML)
+B
1 0V
2
+B
Q853
AN78L05
D852
1SS133
11.6V
R162
47K
M_+12V
C152
47/25
5
K
R164
4.7K
12
C151
0.027(ML)
GND Vcc
11
0V
L104 330µH
13
Q124
2SA1015 GR
L103 SWITCHING
C150 R166 R167
R160
0.0039 47K 100K 150 (1/2W) 100µH
11.7V
14
ALC RIPPLE
R158
220
24
23
CNS701
8
7
R579
100K
IC563
KIA4558P
OPE AMP.
OPE AMP.
REC_L
C566
2.2/50
D555
1SS133
8
7
2
R555 C556
3
56K 0.0068
C561 R572
R560
0.022 2.2M
470K
5
SPA SIG
R567
6
R561 C562 270K
15K 0.022
+B
D554
1SS133
IC562
KIA4558P
R566
2.2M
4
5
8
7
6
9
1
R580
100K
C555
0.0068
D551
1SS133
4
1
C567
2.2/50
+B
–B
C563
0.022
+B
C553
0.0027
–B
R564
390K
R551
10K
R575
330
C551 R562
270P 390K
R568 2
220K
R556 C557
3
270P
33K
R570
220K
C559
R558
5
68K 0.0027
6
R553
12K
R637
220K
3
+B
–15V
–B
CHASIS
2
3
1 2 3 4 5 6 CNS11
CNP11
P25 12 - B
TO POWER SUPPLY PWB
7
8
9
10
Figure 19 SCHEMATIC DIAGRAM (2/10)
– 19 –
11
12
P20 1 - D
TO DISPLAY PWB
+12V
+B
TUN_L
DO
CE
DI
CLK
D_GND
A_+12V
C569
0.022
R638
220K
EC_R
R-CH
D601
1SS133
D602
1SS133
C630
0.001
TUN_R
A_GND
R626
2.2K
C628
0.22
R624
330
L-CH
VIDEO/AUX
IN
R633
39K
C850
3300/25
@4.7/50
R634
39K
CNP801
P23 7 - F
TO POWER SUPPLY PWB
R641
22K
R632
8.2K
P26 5 - A
TO TUNER SECTION
R640
47K
3
2
1
IC99
DIGITAL OUTPUT PWB-A4
D_OUT 1 C99
C98
3
3
100/10 0.022
+4.3V
2
2
L99
1
1
2.2µH
CNS99
CD GND
P25 12 - D
CNP99
TO CD SERVO PWB
CD-C662
DISPLAY PWB-A2
F2
F2
F2
S22
S21
S20
S19
S18
S17
S16
S15
S14
S13
S12
S11
S10
S09
S08
S07
S06
S05
S04
S03
S02
S01
G11
G10
G09
G08
G07
G06
G05
FL701
A
R722
100K
R723
100K
81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96
80
79
78
+B
80 S10
79 VLOAD
76 S13
78 S11
74 S15
IC701
CD
IX0301AW
SYSTEM CONTROL
MICROCOMPUTER
73 S16
72 S17
71 S18
CNS701
DI
CE
23
DO
22
CLK
21
HP-R CH
20
HP_RLY
19
HP_GND
18
HP-L CH
70 S19/DIST1
69 S20/DIST2
24
CD
65 SPN_P
53 T-BIAS
64 SP-DET
52 REC/PLAY
63 SP_RLY
51 AC RLY-CON
CD
62 POWER
61 HI-CUT
CD
C
60 NC
H:ECHO START
L:DEMO START 28 SPEAN
29 TUN SM
30 T2 RUN
54 T_T1T2
53
52
51
1K
10K
+B
+B
+B
R752
10K
R753
10K
+B
+B
R760
10K
+B
Q702
KTA1273 Y
12V
0V
12V
Q703
KTA1271 Y
FWM1
2
+
_
MM1
TAPE MOTOR
1
CNPM1
M
G
PHM1
RUN PALS
SENSOR
SWM3
F.P.
CNPM2
SWM4
F.A.S
SOLM1
SOLENOID
SWM5
CAM
FWM2
R758
1.2K
CNSM1
1
2
3
4
5
6
7
8
9
1
2
3
4
5
6
7
8
9
10
11
12
10
11
12
1
2
3
4
5
6
7
8
MOTOR
GND
+12V
T2 RUN
FPA
T1 RUN
SOLENOID
CAM SW
R759
10K
12V
12V
0V
C705
47/16
D716
1SS133
+B
BI702
TAPE MECHANISM
PWB-F
H
• NOTES ON SCHEMATIC DIAGRAM can be found on page 13.
1
2
3
4
Figure 20 SCHEMATIC DIAGRAM (3/10)
– 20 –
5
+B
R755
10K
R756
10K
R
R754
10K
F
R750
10K
R748
10K
LED722
R747 SLI342UCJ
10K
+B
+B
R741
1K
50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35
R738
R739
R740
1K
+B
D714
D715
1SS133 1SS133
22K
1K
1K
1K
57 KEY JOG B
56 KEY JOG A
55 DIST0
R749
10K
D_GND
+5V
R712
R713
R714
R715
DIST0
58 S MUTE
2.2K
2.2K
1.8K
1K
1K
JOG701
VOLUME
JOG
B
A
1K
1K
1K
R733
R734
R735
R736
R737
HI_CUT
S.MUTE
T_T1 T2
T_BIAS
REC/PLAY
TUN SM
R709
R710
R711
1K
1K
1K
+B
59 NC
R730
R731
R732
E
1K
R729
10K
9
8
7
6
5
4
3
2
1
R705
R728
10K
11
10
1K
1K
1K
C704
0.001
12
R701
R702
R703
JK671
HEADPHONES
C703
0.001
13
66 DISTOUT
+B
10K
10K
10K
P19 12 - E
TO MAIN PWB
CNP701
14
R724
R726
R727
15
10K
10K
10K
16
D
SPEANA1
SPEANA2
SPEANA3
M_+12V
SP_DET
SPN_P
SP_RLY
67 S22/DIST4
C673
0.01
R717
R719
R720
17
68 S21/DIST3
D703
1SS133
H/P
FPA
T1FAS
CAM SW
VDD
T_MOT
T_SOL
FFC701
1 VDD
2 NC
3 DO
75 S14
R716
33
C
77 S12
TIMER LED
U/D SW
DNO SW
VSS
REMOCON
SYS STOP
O/C SW
PUIN SW
AVREF
R706
1K
R707
1K
R708
1K
C702
1/50
C720
47/50
S9
S8
S7
S6
S5
S4
S3
S2
S1
G11
G10
G9
G8
G7
G6
G5
R721
100K
Q707
KTC3199 GR
Q705
KTC3199 GR
B
Q706
KTC3199 GR
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32
6
CD-C662
F1
F1
F1
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36
37 38 39
RWC(DSP)
WRQ(DSP)
CO IN(DSP)
SQ OUT(DSP)
CQ CK(DSP)
RES(DSP)
DRF(ASP)
D_GND
SLD+
SLD–
PUIN SW
OPEN/CLOSE
DISC NO
UP/DOWN
PCCL
S05
S04
S03
S02
S01
G11
G10
G09
G08
G07
G06
G05
G04
G03
G02
G01
P25 7 - G
TO CD SERVO PWB
CNP12
CNS12
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
BI12
C706
1/50
C709
+B 0.022
R773
R772
R771
10
XL701
11
4.19MHz
12
NC
NC
0.022
47/25
C717
C716
TUNER
(BAND)
RD15
3.3K
VIDEO/
AUX
SW710 SW711 SW712 SW713 SW714 SW715
RD01
820
RD02
1.2K
RD03
1.5K
RD04
1.8K
6
6
SW701
RD05
2.2K
RD06
3.3K
RD07
3.9K
SW705 SW706 SW707
SW703 SW704
TIMER/
SLEEP
CLOCK
DISC1
DISC2
7
8
9
DISC3
RD09
6.8K
SW708 SW709
DISC
SKIP
OPEN
/CLOSE
1
Q6
Q5
RIDER
RIDER
RIDER
RIDER
RS701~RS705:1K
LED704,LED705:SLI342UCB
NIGHT
NIGHT
NIGHT
NIGHT
FW703
1
NIGHT RIDER 6 LED706
SLI342YCB
LED707
L1154GT4
NIGHT RIDER 7
NC
NC
NC
NC
1 2 3 4 5 6 7 8 9
CD
TAPE
SW716 SW717
1
2
3
4
POWER
RD16
3.9K
RS705
STOP
RD14
2.2K
18 17 16 15 14 13 12 11 10
LED704
LED705
REC
MEMORY/
PAUSE
SET
RD13
1.8K
EQUALIZER DIMMER
10
Figure 21 SCHEMATIC DIAGRAM (4/10)
– 21 –
11
12
NIGHT RIDER 5
RD12
1.5K
NC
SW728 SW729 SW730
X-BASS/
DEMO
PLAY
IC703
BU2092F
INPUT/OUTPUT
EXPANDER
RS702
RS703
RS704
REW
RD11
1.2K
+B
LED702
SLI342YCB
LED703
SLI342DCB
RD10
820
TUNING
DOWN
TUNING
UP
CNP704
P23 7 - G
TO POWER SUPPLY PWB
BI704
FF
RD28
6.8K
VSS VDD
DATA OE
CLOCK Q11
LCK Q10
SW722 SW723 SW724 SW725
RD27
3.9K
Q9
Q8
Q7
RD26
3.3K
C719
0.022
RD24 RD25
2.2K
1.8K
C718
47/25
RD23
1.5K
RS712
1.2K
RD22
1.2K
D720
1SS133
RS711
1.5K
1 2 3
C714
0.022
RD21
820
+B
SWITCH PWB-A3
+B
R798
100
REMOTE D719
+B SENSOR 1SS133
RX701
N63H380A
C722
10/50
C713
0.022
C711
0.01
C723
0.1/50
1
R797
100K
R757
10K
R754
10K
D718
1SS133
D717
1SS133
+B
+B
+B
R799
4.7K
5V BACK UP
IC704
D705
KIA7042AP
1SS133
1 RESET 3
Q704
KRC102 M C712
3.3/50
2
2
3
3 AC_RLY CON
2 UN_SW 5V
1 D_GND
C715
47/16
R744
1K
R743
1K
R745
1K
L702
100µH
R795
47K
R755
10K
R756
10K
CNS704
6 VF2
5 –VP
4 VF1
6
5
4
3
2
1
+B
R751
3.3K
R741
1K
R750
10K
R738
R739
R740
1K
R749
10K
R748
10K
R752
10K
R753
10K
R742
1K
1K
10K
2.2K
2.2K
1.8K
1K
1K
R733
R734
R735
R736
R737
LED722
R747 SLI342UCJ
10K
B
+B
NC
29
30
+B
LED716,LED717,
LED721,LED723,LED724:SLI342YCJ
LED718:SLI325YC
LED719,LED20:SLI342YCE
RS706
1K
27
28
RS707
1K
26
46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31
+B
NC
NC
10 11 12 13 14 15 16 17 18
25
Q0
Q1
Q2
Q3
Q4
23
RS701
22
24
9 8 7 6 5 4 3 2 1
LED701
L1154GT4
21
NC
20
IC702
BU2092F
INPUT/OUTPUT
EXPANDER
+B
LED718
LED719
LED720
LED721
VDD
T_MOT
T_SOL
ST0
19
1K
1K
1K
1K
1K
1K
1K
1K
Q4
Q5
Q3
Q6
Q2
Q7
Q1
Q8
Q0
Q9
Q10 LCK
Q11 CLOCK
OE DATA
VDD VSS
18
TIMER LED
U/D SW
DNO SW
VSS
REMOCON
SYS STOP
O/C SW
PUIN SW
AVREF
AVDD
KEYIN1
KEYIN2
KEYIN3
17
51 AC RLY-CON
1K
R769
R768
R767
R766
R765
R764
R763
R762
1K
1K
1K
1K
1K
1K
PCCL
CD DSP COIN
SQOUT
CD DSP CQCK
CD DSP RES
FRF(DRF)
H:ECHO START
SPEANA1
28
SLD+
L:DEMO START
29 TUN SM
SLD–
30 T2 RUN
AVSS
SPEANA3
SPEANA2
52 REC/PLAY
R770
LED716
LED717
53 T-BIAS
C708
18P
13
14
CD DSP WRQ 15
VDD 16
R787
R786
R785
R784
R783
R782
DSP RWC
RESET
X2
X1
VPP
XT2
+B
STOP
PLAY
CD
TUNER
TAPE
VIDEO
IC701
CD
IX0301AW
SYSTEM CONTROL
MICROCOMPUTER
R780
10K +B
C710
220/10
1K
1K
1K
1K
1K
1K
1K
1K C707
15P
R781
820
78 S11
DI
CE
CLK
LCK1
LCK2
R778
R777
R776
R775
R774
LED723
1 VDD
2 NC
3 DO
80 S10
79 VLOAD
1
2
3
4
5
6
7
8
9
LED724
S5
S4
S3
S2
S1
G11
G10
G9
G8
G7
G6
G5
G4
G3
G2
G1
85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100
16
15
14
13
12
11
10
9
7
VH+
8
VL+
VL–
17
6
5
4
3
C925
47/50
Q904
KTC3199 GR
R915
3.9K
D905
1N5402M
ZD902
MTZJ8.2C
D904
1SS133
R916
3.9K
R961
39K
R919
1.5K
Q901
KTC3199 GR
D907
1SS133
R921
4.7K
C918 R911
2.2/50 33K
Q911
Q910
KRC107 M KRC107 M
R959
8.2K
C955
22/25
R956
1K
R957
100K
2
3
D913
1SS133
1
3
R962
39K
D910
1SS133
1
C904
4700/35
VL–
–B
R913
100(1/4W)
Fusible
R958
680
R928
10(1/2W)
R926
10(1/2W)
C901
3300/71
2
R960
10K
Q909
KTC3199 GR
C924
0.022(ML) R920
1.5K
R918
0.1(3W)
C903
4700/35
R955
1K
D908
1SS133
R922
4.7K
C902
3300/71
VH–
SP DET
D902
1N4004S
–B
C952
220/25
C951
0.022
(ML)
D901
1N4004S
C920
100/100
C957
47/100
VL+
Q902
KTC3199 GR
Q908
KTC3199 GR
R954
3.3K
–B
D906
1N5402M
B
C922
47/50
C956
47/100
C923
0.022(ML)
Q903
D909
1SS133 KTC3199 GR
D903
1SS133
ZD901
MTZJ8.2C
R912
100(1/4W)
Fusible
R906
1K
R910
56K
C
1
R917
0.1(3W)
C919
100/100
C912
47P
R953
3.3K
2
VH+
R902
1K
C921
47/50
C917
2.2/50
R909
56K
18
R901
1K
19
R903
56K
C915
47/50
C911
47P
R905
1K
21 20
C913
33P
C914
33P
22
R907
390
R908 C916
R904
390 47/50
56K
A
IC901
STK4113E
POWER AMP.
+
–
+
–
VH–
CD-C662
–B
R943
ZD951
MTZJ13B 680(2W)
D
PO
+B
+B
E
5 6
VL+
BI802
7 8
VH+
4
CNP802
CNS901
P18 1 - C
TO MAIN PWB
3
GND
2
VH–
1
VL–
CNP901
HP_RLY
HP_GND
GND
9 10 11 12 13
HP-R-CH
R-CH
7 8
SP_DET
A_GND
6
5
HP-L-CH
4
M_GND
3
M_+12V
2
–15V
SP_RLY
1
L-CH
+B
CNS802
F
VH+
8
8
7
7
6
6
5
5
4
4
3
3
2
2
1
1
P19 12 - G
CNS801
1
TO MAIN PWB
3
2
VL+
GND
VL–
VH–
CNP80
+B
GND
+5V
CNP70
6
P21 12 - E
CNS704
TO DISPLAY PWB
5
4
3
2
G
1
H
• NOTES ON SCHEMATIC DIAGRAM can be found on page 13.
1
2
3
4
Figure 22 SCHEMATIC DIAGRAM (5/10)
– 22 –
5
6
CD-C662
POWER AMP.PWB-B2
VH+
RL901
L901
0.29µH
Q903
D909
1SS133 KTC3199 GR
L-CH
6ohms
R-CH
Q905
KRC107 M
D911
1SS133
R931
4.7(1/2W)
R923
56K
C925
47/50
C929
0.1(ML)
R929
56K
R927
10(1/2W)
Q904
KTC3199 GR
D905
1N5402M
+
–
–
+
R925
10(1/2W)
SO901
SPEAKER
TERMINAL
2
1
R934
4.7K
C930
0.1(ML)
R930
56K
R935
220(1/2W)
+B
3
R928
10(1/2W)
R926
10(1/2W)
R933
4.7K
L902
0.29µH
1
C903
4700/35
D901
1N4004S
C943
10/50
2
C945
47/25
R936
220(1/2W)
D912
1SS133
R937
15K
R942
560
(2W)
CNP903
R939
3.9K
R938
68K
CNS903
+
1
2
–
M
M903
FAN MOTOR
Q907
KTC3199 GR
R932
4.7(1/2W)
R941
560(2W)
POWER SUPPLY PWB-B1
+B
BI802
T801
POWER TRANSFORMER
~
8
7
7
6
6
5
5
4
4
3
3
2
2
1
1
D809
TS6B04GM
–
~
VH+
F804
5A/125V
C811
0.22(ML)
VL+
GND
1
C813
0.047
(ML)
C816
100/50
C815
100/50
T.F
D817
1N4004S
Q803
KTA1274 Y
VOLTAGE
REGULATOR
+B
C801
0.0047
D_GND
D807
1SS133
+B
D801
1SS133
R804
1K
D808
1SS133
Q802
KTC3199 GR
8
C805
2200/6.3
+B
7
C817
220/50
R802
2.2K
UN_SW_5V
F801
5A/125V
F806
2A/250V
9
Q801
AN78L05
1
D804
1N4004S
C802
0.047
(ML)
D802
1N4004S
T802
POWER
TRANSFORMER
3
2
C803
470/25
2
R805
ZD802
MTZJ6.2A 10
VF1
AC_RLY_CON
D806
1SS133
3
L802
–VP 100µH
R801
100
TO DISPLAY PWB
4
CNP704
VF2
C804
10/16
P21 12 - E
CNS704
5
ZD801
MTZJ30C
+B
R803
12K
6
D812
1N4004S
GND
+5V
C818
47/50
3
2
C819
47/50
TO MAIN PWB
CNP801
+B
D811
1N4004S
C814
0.047
(ML)
VH–
D816
1N4004S
–B
D813
1N4004S
D815
1N4004S
VL–
C820
100/35
1
F805
5A/125V
C810
0.22
D814
1N4004S
P19 12 - G
CNS801
C809
0.22
C812
0.22
(ML)
8
+
CNP802
CNS802
D810
BR102J02
RL801
7 8
VH+
6
AC POWER
SUPPLY CORD
(249)
AC 120V/60Hz
D805 D803
1N4004S 1N4004S
10
Figure 23 SCHEMATIC DIAGRAM (6/10)
– 23 –
11
12
CD-C662
+
VCR
+
IC1
LA9241M
SERVO AMP.
R29
56K
R45
4.7K
C29
4.7/50
CL
CLK
DEF
CE
DAT
SLOF
SL–
R43
56K
R38
470
HF
TP1
C23
0.0027
40
39
38
6
C22
220P
R36
220K
R33 R32
1.2K 10K
C21
0.0033
SPO
SPG
R28
10K
C16
0.0047
C13
330P
REF
FE1
REF
AGND
SP
REF
SPI
FA–
R23
10K
C20
47/16
NC
C18
0.47/50
C12
0.1
42
37
TES
36
TOFF
35
TGL
34
JP+
33
SLD
29 30 31 32
R34
3.3K
VREF
R42
47K
C25 R39
27P 1K
R40
5.6K
C19
1/50
S.Q.R
REF
–
FE–
C10
180P
REF
–
R19
1K
R41
47K
43
41
R44
33K
C26
0.033
HFL
–
–
–
R27 R31
39K 1.2K
R25
1.5K
C17
0.001
R30
6.8K
SLOF
5
–
–
R21 R20
1.5K 1K
44
C24
2.2P
–
R24
47K
1
R26
82K
C14
0.01
CV+
CV–
+
C11 R18
0.1 15K
REF
SLEO
SP–
24 25 26
27 28
FD– FA
FE
17 18 19 20 21 22 23
4
JP+
JPCLO
SLOF SLOF
OR
10
+
RFSM
RF
SL+
JP–
–
–
REF +
CV+
JP–
–
REF
+
+
JP
FSC
REF FOSTA
TO
GEN
REF
+
GEN
REF
+
FSTA REF
JP
–
REF
SLC
–
CV–
+
+
REF
–
R22
820
3
RFS–
+
TD
R17
33K
8/12CM
+
+
FO–
TR–
ACTUATOR
GEN
45
+
D
TGL1
+
FO+
TD–
SLI
CL
VCC
THDL GL
+
TR+
TR–
TR+
FO+
FO–
GND
PD
VR
LD
REF
THD
14 JP
TO +
15
FD
16
8
REF
SLOF
+
1
2
3
4
5
6
7
8
13
FSTA
+
–
LT0H30M1
K
E
A
B
F
11
LASER
46
DGND
2FREQ
REF
C7
0.1/50 TH
10
C8
0.068
12
FSC
CE
C28
0.1
C27
0.001
–
VCR
EFBAL
FOSTA
TOSTA
–
5
4
3
2
1
A
F
C
R15
R14
12K
27K
R16
3.3K
DRF
NC 48
TBC 47
LATOH
+
VCR
+
LD
MON
K
E
B
LD GND
FSS
DRF
HFL
–
R10 C5
2.2K 0.033
8 TESI
C6
0.033
9 SCI
R12
100
R13 C9
1K 0.047
VCC2
–
VCR
REF –
REF
R11
6.8K
REF1
DEF
REF
+
+
+
FE1
7
C54
0.001
VR
LF2
PHI
BHI
LDO
VCC1
+
+
–
REF –
6 TE–
TE
55 54 53 52 51 50 49
REF
5 TB
R8
15K
56
2
+
R9
100K
57
–
C4
0.1/50
TE
C
C30
0.1/50
C31
220/6.3
R46
560
C2
0.01
3
4 F
58
–
CNS1A
59
–
CNS1B
61 60
RF
–
1
2
3
4
5
CNP1
–
1 FIN2
REF –
2 FIN1
EREF –
–
1
2
3
4
5
64 63 62
LDS
9
K
A
B
E
F
+
B
5
4
3
2
1
+
K
E
A
B
F
R1
22
C3
1/50
C33
0.47/50
C32
0.01
C1
47/16
Q1
2SA1318
C15
0.01
C34
0.33/50
R2
1K
A
7
R35
220K
C57
0.001
GND
C35
1/50
PICKUP UNIT
TR–
TR+
FO+
FO–
M2
SLED
MOTOR
SW4
PICKUP
IN
M
M
–
+
–
6
5
4
3
2
1
6
5
4
3
2
1
FO (GAIN)
FO+
FO–
TR+
TR–
12
14
15 SL–
16 SL+
M– 38
SOL– 37
SOL+ 36
35
GND 32
31
30
R56
22K
+B
C82
100/16
C77
100/16
+B
29
VCC3 28
+B
SP+ 27
SP– 26
21 MUTE
+B
34
33
SPO 25
20 Vref
+B
M+ 39
18 VCC1
C55
100/16
+B
VCC4 40
17 SLD
19 STANDBY
CNP3
6
5
4
3
2
1
LD_M– 41
13
CD_GND
6
5
4
3
2
1
CNS3A
CNS3B
CNP3A
+
LD_M+ 42
FD
10
11 GND
C36
100/16
M1
SPINDLE
MOTOR
TO
(SPN)VCC2 24
SOLD 23
SOL– 22
+B
+B
SP+
SP–
SL_+
SL_–
CD_PUIN
RWC(DSP)
WRQ(DSP)
CO IN(DSP)
SQ OUT(DSP)
CQ CK(DSP) R47
10K
RES(DSP)
DRF(ASP)
D_GND
C37
0.022
SLD+
SLD–
PD
C76
0.022
CNS2B CNS2A
TR– 1
1
1
TR+ 2
2
2
FO+ 3
3
3
FO– 4
4
4
GND 5
5
5
PD
6
6
6
VR
7
7
7
LD
8
8
8
LD
CNP2
CD MOTOR PWB-D
G
1
2
3
4
5
6
7
8
9
IC3
M63001FP
FOCUS/TRACKING/SPIN
/SLED DRIVER
E
F
D1
+B 1SS133
R37
82K
CNP12 1 2
3 4 5 6 7 8 9 10
CNS12
P21 10 - A
TO DISPLAY P
H
• NOTES ON SCHEMATIC DIAGRAM can be found on page 13.
1
2
3
4
Figure 24 SCHEMATIC DIAGRAM (7/10)
– 24 –
5
6
CD-C662
R57 1K
R58 1K
R59 1K
C49
100P(CH)
C48
100P
C47
100P(CH)
C44
100P(CH)
C46
100P
(CH)
R60
1K
C38
0.01
C45
100P(CH)
CD SIGNAL
R61 1K
R62 1K
R63 1K
+B
+B
+B
R66
220
R64
22
C75
0.001
+5V
32
CD_LCH
P19 8 - H
CNS11
TO MAIN PWB
Q52
KTC3203 Y
R55
+B
C43 100
330/6.3
R65
1K
L61
0.82µH
+B
C50
0.022
1
2
3
4
5
6
L-CH
D-GND
+7V
+12V
A_GND
C73
220P
C52
100/16
DOUT
C74
220P
R74
100K
R71 C71 R73
2.7K 10/50 100K
DIGITAL
OUT
R-CH
A_GND
CD_RCH
ZD61
MTZJ5.6B
R72
2.7K
RVSS 39
TEST4 33
24 25 26 27 28 29 30 31
D82
1SS133
C72
10/50
34
CONT5
NC
EMPH
NC
C2F
NC
CONT4
EXTERNAL
OUTPUT
CNP11
R93
220
44
LVSS 38
LCHO
37
LVDD 36
MUTEL
NC 35
IC2
LC78622NE
SERVO/SIGNAL
CONTROL
17 18 19 20 21 22 23
45
C51
100/16
XOUT
SYNC-DETECT
EFM DEMODULATE
PCK
NC
FSEQ
NC
VDD
JP_
JP+
EFMIN
11
C42
15P
XL1
16.934 MHz
D81
1SS133
SBCK
SFSY
NC
WRQ
RWC
FSX NC
COIN
SQOUT
4FS
DIGITAL
FILTER
VSS
EFMO
TOFF
TGL
C22
220P
/CQCK
VVDD
FR
SLICE
LEVEL
CONTROL
TEST2
11
CLV+
CLV
12
CLV_ DIGITAL
13
SERVO
V/P
14
HLF
15
SERVO
TES COMMAND
16
10
XVSS 46
XVDD 43
MUTER
NC 42
RVDD 41
RCHO
40
ERROR COERECT
FLAG CONTROL
CONT3
R53
1.2K
2KX8
RAM
CONT2
6
7
8
9
X-TAL
GENERATOR
1BIT @DAC
4 VVSS
5 ISET
C40
0.047
R52
27K
C41
12P
TEST3
NC
3 PDO
C39 R50
0.047 680
EFLG
NC 48
SBSY 47
NC
XIN
CONT1
2
K
SUB-CODE
µ-COM
INTERFACE
C83
0.022
1
2 TA1
R51
3.3M
VCO CLOCK
OSC CONTROL
4
K
16M
NC
TEST11 NC
/RES
/CS
TEST5
4M
TEST1
DEF1
PW
NC
49
64 63 62 61 60 59 58 57 56 55 54 53 52 51 50
+B
R88 1.2K
R89 1.2K
R90 220
R91 1K
+B
+B
R54
330
C56
0.022
+B
BI1A
2
1
2
1
+B
BI1B
CNP99
+B
C57
0.001
+B
P19 10 - A
CNS99
TO DIGITAL
OUTPUT PWB
3
2
1
+B
133
+B
+B
R80
820
R83
390
D92
1SS133
R82
390
2
CD SERVO PWB-C
R81
820
3
D93
1SS133 1
SOLM2
SOLENOID
R84
2.2K
LOCK
D91
1SS133
Q51
KRC102 M
BIM05
1
2
3
4
5
6
1
SOL+
2
SOL–
3
M–
M+
4
GND(D)
5
DISC NO. 6
OPEN CLOSE 7
GND(D)
8
MECHA UP 9
10
10 GND(D)
CNP10
CNS10
1
2
3
4
5
CD_D_NO 6
7
8
9
–
M
+
M3
T/T
UP/DOWN
LOADING
SW1
OPEN
CLOSE
SENSOR PWB-E
SW2
MECHA UP
1
2
PCCL
PUIN SW
CO IN(DSP)
SQ OUT(DSP)
CQ CK(DSP) R47
10K
RES(DSP)
DRF(ASP)
D_GND
C37
0.022
SLD+
SLD–
M–
M+
1
2
DISC NO
SW3
DISC NUMBER
CNS5
OP/CLOS
DISC NO.
UP/DOWN
2 3 4 5 6 7 8 9 10 11 12 13 14 15
CNS12
P21 10 - A
TO DISPLAY PWB
• The numbers 1 to 12 are waveform numbers shown in page 14.
7
8
9
10
Figure 25 SCHEMATIC DIAGRAM (8/10)
– 25 –
11
12
H
1
1
2
3
1
2
3
CNP301
1
G
3
5
C313
0.022
6
2
D301
C305
15P(CH)
VD302
SVC211C
R301
33K
R303 100K
L302
FM RF
C309 4.7P
(UJ)
1SS133
3
7 8
PD
CL
5
A IN
DI
4
BO4
X OUT
X352
4.5MHz
VSS
C312
0.001
C311
0.022
C308
0.0047
Figure 26 SCHEMATIC DIAGRAM (9/10)
– 26 –
4
9 10 11
IO1
IO2
A OUT CE
6
AM IN
FM IN BO1
VDD DO
3
IF IN
D305
1SS133
R379
2.2K
X IN
1 2
+B
1
3 0.2V
2 10.9V
+B
L343
100µH
1
R369
2.2K
3
R366
820
C382
15P
(CH)
C333
0.022
ZD351
MTZJ5.1B
+B
C365
1/50
22 21 20 19 18 17 16 15 14 13 12
R381
10K
C383
0.022
C369
47/16
2
AM IF
R367
820
D304
1SS133
C393
1/50
R380
1.5K
C338
100P
CF351
9 10
C366
1/50
C381
12P(CH)
C320
0.001
+B
C334
22P
(UJ)
C392
0.001
C316
100P
Q302
2SC535 C
OSC BUFF
C360
0.022
R313
47
0V
4.4V
AM
MIX
15 14
C364
0.015
T351
C361
22/16
7 8
C363
TUN 0.015
IND
ST
IND
GND
AM
IF
5 6
MPX L CH
-IN
C359
0.022
+B
FM
DET
4
R CH
3
16
R359
47K
11
8.4V
D342
1SS133
R365
680
R361
10K
FM/AM
SWITCHING
Q343
KRA109 M
3
1 5.1V
12
VR351
6.8K(B)
VCO
C358
0.0015
R352
15K
R350
47K
R375
1.2K
13
C367
1/50
2
4.4V
AM
/FM
0.7V
R323
68K
R312
680
R317
820
FM
+B
AM
RF
AM
+B
AM
OSC
2
17
R360
1.5K
IC303
LA1805 FM/AM IF MPX.
C353
0.018
FM IF
IN
1
18
DET
OUT
2
C332
0.022
TP301
20 19
R347
3.9K
FM DET.
C349
0.022
24 23 22 21
R348
33K
C354
220P
FM–
M/ST
R316
4.7K
R314
C318 10K
22P(CH)
VD303
CF301
SVC211C
3
C330
8.2P(UJ)
C331
0.047
C335
560P AM OSC.
R321
120
T352
C355
3.3/50
R311
220K
1
R320
10K
VD331
SVC348S
T333
+B
+B
R371
1K
R372
1K
R373
1K
R374
1K
5
D_GND
CE
DI
CLK
DO
TUN_L
A_GND
TUN_R
A_+12V
C395
0.001
R362
390
AM SIGNAL
C314
10/16
C319
0.022
L303
+B
C337
10/50
C306
C317
18P(CH) 3.9P(UJ)
+B
E
C356
3.3/50
VCO
FM SIGNAL
9
R306
10
C350
220/10
FM OSC.
T301
FM IF
7 8
D
C304
4.7P
(CH)
4
TP302
C357
3.3/50
R302
22
3
+B
C351
0.0022
C310
0.001
2
AM ANT.
T331
C
R305 C303
0.01
82
C302 1
10P(CH)
IC301 TA7358AP
FM FRONT END
F
2
BF301
B
MAIN PWB-A1(1/2)
A
FM ANT
AM LOOP ANT
9
8
7
6
5
4
3
2
1
CHASSIS
GND
CD-C662
P19 12 - C
TO MAIN/DECK SECTION
R356
10K
Q344
KRA102 M
SWITCHING
11V
IC302
LC72131
PLL(TUNER)
C307
0.0047
D303
1SS133
D302
1SS133
• NOTES ON SCHEMATIC DIAGRAM can be found on page 13.
6
CD-C662
IC1
PIN
NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
IC3
IC2
VOLTAGE
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
0V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.3V
2.3V
0V
0V
5.0V
5.0V
0V
0V
5.0V
0V
0V
1.6V
2.4V
2.4V
2.4V
0V
2.5V
2.5V
0V
0V
2.4V
4.6V
4.6V
0V
0V
5.0V
5.0V
2.5V
2.5V
1.0V
1.0V
2.2V
4.2V
0V
5.0V
7
PIN
NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
PIN
NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
VOLTAGE
0V
0V
0V
0V
1.9V
5.0V
0V
0V
2.5V
2.4V
0V
0V
0V
5.0V
0V
0V
5.0V
5.0V
0V
0V
2.5V
0V
5.0V
0V
0V
0V
0V
0V
0V
5.0V
2.5V
0V
0V
0V
5.0V
4.6V
1.9V
0V
0V
1.9V
4.6V
5.0V
5.0V
2.1V
2.1V
0V
0.1V
2.3V
0V
2.5V
0V
2.5V
0V
0V
0V
4.6V
4.6V
4.7V
0V
2.3V
2.3V
0V
0V
0V
2.5V
2.6V
2.9V
3.3V
3.3V
3.3V
3.3V
0V
0V
0V
0V
0V
0V
0V
3.3V
3.3V
3.0V
7.2V
5.0V
2.5V
0V
0V
0V
7.2V
2.5V
3.3V
3.3V
11.2V
0V
0V
0V
0V
0V
0V
0V
5.3V
5.3V
3.3V
3.3V
7.2V
0.1V
0.1V
8
PIN
NO.
1
2
3
4
5
6
7
8
9
VOLTAGE
0.9V (0V)
1.6V (0V)
5.8V (0.4V)
1.6V (0V)
0V (0V)
5.9V (0.4V)
5.2V (0.2V)
5.8V (0.3V)
5.9V (0.3V)
IC562
PIN
NO.
1
2
3
4
5
6
7
8
VOLTAGE
0.2V
0.2V
0.2V
–7.7V
0V
0V
0V
6.3V
IC563
PIN
NO.
1
2
3
4
5
6
7
8
VOLTAGE
0V (0V)
0V (0V)
0.5V (0.5V)
4.3V (4.3V)
0V (0V)
1.2V (1.3V)
0V (0V)
0.6V (0.6V)
4.2V (4.2V)
4.1V (4.1V)
0V (0V)
0V (0V)
8.3V (8.3V)
4.8V (4.8V)
0V (0V)
4.1V (4.1V)
0.6V (0.6V)
0V (0V)
0.8V (0.8V)
0.8V (0.8V)
4.3V (4.3V)
0.5V (0.5V)
0V (0V)
0V (0V)
PIN
NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
VOLTAGE
0.1V
0.2V
0.1V
–7.7V
0.1V
0.2V
0.1V
6.3V
IC901
IC101
PIN
NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
IC302
IC301
VOLTAGE
PIN
NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
VOLTAGE
56.0V
0V
24.4V
25.0V
15.9V
–16.0V
–24.9V
–55.9V
–24.3V
–24.3V
–24.3V
0V
4.2V
0V
0V
–54.5V
54.6V
–0.15V
–0.15V
–53.1V
–0.15V
–0.15V
IC704
PIN
NO.
1
2
3
9
VOLTAGE
5.0V
0V
5.0V
VOLTAGE
2.6V (2.6V)
0V (0V)
0V (0V)
0V (0V)
4.4V (4.4V)
4.8V (4.8V)
0.2V (11.9V)
0V (0V)
0V (0V)
0V (0V)
5.2V (5.2V)
0V (0V)
0V (0V)
0V (0V)
0V (2.6V)
2.5V (0V)
5.2V (5.2V)
0.9V (0.9V)
0.9V (0.9V)
1.3V (1.1V)
0V (0V)
2.6V (2.6V)
IC601
PIN
NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
IC303
PIN
NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
VOLTAGE
0V
0V
0V
0V
–0.2V
0V
0V
0V
0V
2.6V
0.1V
–2.6V
0V
0V
0V
0V
0V
0V
0V
0V
VOLTAGE
1.6V (1.7V)
1.6V (1.7V)
7.0V (8.4V)
0.3V (0.6V)
1.6V (1.7V)
0V (0V)
5.2V (5.2V)
0V (0V)
2.2V (2.3V)
2.4V (2.5V)
6.3V (8.3V)
0.9V (0.9V)
1.1V (0V)
1.8V (1.7V)
0.9V (1.2V)
1.7V (1.7V)
1.5V (1.7V)
1.6V (1.6V)
0.4V (0.5V)
7.0V (8.4V)
7.0V (8.4V)
1.6V (1.7V)
1.6V (1.7V)
1.6V (1.7V)
IC703
PIN
NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
VOLTAGE
0V
0V
0.4V
0V
0.4V
0.4V
0.4V
0.4V
0.4V
0.4V
0.4V
9.6V
9.6V
9.6V
12.9V
10.9V
0V
5.0V
IC702
PIN
NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
VOLTAGE
0V
0V
0.4V
0V
0V
0V
0V
0V
0V
0.4V
0.4V
0.4V
9.6V
9.6V
9.6V
0V
0V
4.8V
10
Figure 27 SCHEMATIC DIAGRAM (10/10)
– 27 –
PIN
NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
IC701
PIN
NO.
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
VOLTAGE
4.8V
4.8V
4.8V
0V
0V
0V
0V
0V
0V
4.8V
2.3V
2.2V
0V
4.9V
0V
4.9V
0V
4.8V
0V
4.8V
4.8V
0V
0V
0V
0V
0V
0V
0V
0V
4.8V
5.1V
5.1V
5.1V
4.8V
5.0V
4.7V
0V
5.0V
5.0V
0V
4.7V
0V
3.8V
11.3V
11.3V
4.8V
4.7V
4.7V
4.7V
0V
Q850
PIN
NO.
1
2
3
VOLTAGE
11.3V
18.1V
11.9V
11
VOLTAGE
7.3V
1.3V
19.0V
4.8V
4.8V
0V
4.8V
0V
0V
0V
4.8V
4.9V
4.9V
0V
4.8V
4.8V
5.1V
5.1V
–21.5V
–20.0V
–19.5V
–21.3V
–21.3V
–21.3V
–27.5V
0V
–0.7V
–20.7V
–18.0V
–23.3V
0V
–28.7V
–0.1V
–20.4V
–20.6V
–0.1V
–23.3V
–18.5V
–21.1V
0V
–0.5V
–20.5V
–25.8V
–25.8V
–25.8V
–25.8V
–25.8V
–25.8V
–25.8V
–25.8V
–25.8V
–25.8V
–25.8V
Q851
PIN
NO.
1
2
3
Q852
PIN
NO.
1
2
3
VOLTAGE
VOLTAGE
11.9V
0V
19.1V
Q853
PIN
NO.
1
2
3
12
VOLTAGE
6.3V
1.2V
11.3V
CD-C662
P31 7 - H
TO DISPLAY PWB
CNS701
A
FFC701
1
R371
R379
C369
D342
R350
C366
23
R638
C601
C367
Q343
C350
R361
C363
C364
19
21
R366
3
2
1
D305
C358
D304
C602
R641
R640
R642
R639
R620
C626
R616
R619
R611
C621
R613
C617 ZD601
B
C
E
C627
R635
R636
B
C
E
R615
C629
C625
Q603
R617
C611
C613
C615
ZD602
C619
C618
R628
C623
Q604
C561
R567
R574
Q601
B C E
E C B
C624
4
C620
Q602
C634
5
C556
R560
3
D556
R572
6
R580
2
R623
R630
C568
7
R556
1
C616
R614
IC562
8
R578
R652
R626
R612
C555
R566
R573
R610
R555
C635
R608
R625
C612
C614
C628
R606
1 R601
2 R603
3
4 R605
5
6 R607
7
8
9
10
IC601
20
19
18
17
16
15
14
13
12
11
R604
R653
R375
C622
R602
C566
C569
C562
C563
17
C606
VR351
VCQ
ZD551
D554
R551
D551
R558
11
13
15
R650
R352
C353
R348
C551
R562
R568
4 C557
7
9
R367
R561
3
R579
R570
C559
2
C567
5
D555
L343
C381 C382
L303
CF351
C365
24
R618
C333
IC563
C553
R564
7
6
R575
22
C604
R553
F
20
R624
1
16
18
C356
8
14
C357
R632
C631
C632
R634
E
12
R381
R-CH
L-CH
10
R637
24 2322 21 20 19 1817 16 15 14 13
R347
R360
C355
TP302
5
6
R362
1 2 3 4 5 6 7 8 9 10 11 12
C354
R359
4
ZD351
CNP701
R372
R373
R374
C305
Q302
C306
C317
VD303
C360
C359
C361
R631
D602
IC302
3
8
22 2120 19 18 17 1615 14 13 12
C316
C392
1
2
3
C351
R633
C383
R380
T351
C337
T352
C630
D601
C320
1
2
1 2 3 4 5 6 7 8 9 10 11
IC303
C349
D
X352
R311
R306
R312
C313
VD331
CF301
T333
C338
C330
C331
C335
1
2
3
R365
R369
R356
C393
R320
C
JK601
VIDEO/AUX
B
C
E
Q344
3 2 1
R317
R313
C311
R314
R316
R303
C310
TP301
C332
T331
VD302
C312
C309
D301
C334
8 9
C318
T301
C308
R323
7
R302
C307
R321
5 6
R301
1
D302
1
FM
ANTENNA
D303
3
2
CNP301
3
2
3 4
C303
L302
AM LOOP
ANTENNA
C395
B
1 2
IC301
R305
BF301
3
2
1
C319
C304
C302
C314
MAIN PWB-A1
G
CNS901
1 2 3 4 5 6 7 8 9 10 11 12 13
CNP901
P33 12 - E
TO POWER AMP. PWB
H
1
2
3
4
Figure 28 WIRING SIDE OF P.W.BOARD (1/8)
– 28 –
5
6
CD-C662
P31 7 - H
O DISPLAY PWB
CNS701
24
P35 12 - E
TO CD SERVO
PWB
CNP11
CNP701
1
2
3
4
5
6
7
9
R140
C132
C134
C140
R138
E
C
B
R629
Q111
C117
C121
R121
C119
C127
R123
C128
C133
C139
R137
C129
R135
R169
B C E
B C E
R157
R174
R172
Q852
Q851
Q121
Q850
3 2 1
3 2 1
B C E
RED
OR
ORANGE
YL
YELLOW
GR
GREEN
Q113
R852
BLUE
VL
VIOLET
GY
GRAY
WHITE
BK
BLACK
PK
PINK
CNS801
3
WH
GY
RD
Q853
C853
C854
D853
3
2
1
BI801
C851
D852
C855
BL
R850
C852
C857
BROWN
WH(W)
R851
C859
C860
RD(R)
R175
R158
R173
R854
D851
BR
R139
R141
C135
C155
C145
R153
R613
R636
R131
B C E
D850
C627
COLOR TABLE
R125
C131
C154
R170
R853
Q124
R164
R115
C153
R109
R110
C113
CNS101
TO TAPE MECHANISM
TAPE1 HEAD
C111
R102
1
2
3
4
5
6
7
8
9
10
11
12
R146
C156
P34 4 - D
C115
Q114
R154
TO TAPE MECHANISM
TAPE2 HEAD
R101
R145
C146
C142
Q122
C605
R156
3
2
1
R119
C141
C611
R134
C136
R611
B
C
E
R142
C102
C107
IC101
R111
C130
C858
R619
C621
ZD602
C619
R615
C629
C625
C122
R609
C617 ZD601
R628
C635
R653
C E
C108
E C B
24
23
22
21
20
19
18
17
16
15
14
13
R124
R136
C603
Q603
601
R132
C615
C613
IC601
C618
C620
1
3
P32 1 - G
2
CNP801
1
TO POWER SUPPLY
PWB
R855
L601
C850
D102
CNS901
C103
R625
R126
1 R601
2 R603
3
4 R605
5
6 R607
7
8
9
10
C101
E C B R107
R117
C112
C118
C120
R651
P34 5 - D
CNS102
Q108
R120
R122
R162
R155
R639
B C E
E
C
B
R108
1
2
3
4
5
6
7
CNP101
R105
C151
B C E
L104
R103
Q103
C150
B C E
C106
B C E
R112
Q106
1 2 3
R171
R642
L103
R160
Q107
R640
Q126
3 2 1
R168
R104
Q104
Q105
Q110
3 2 1
C109
R118
C601
C641
R641
B C E
R106
BI11
B C E
C105
CNP102
23
R113
R114
Q128
R167
1
24
19
21
C114
22
Q109
17
C116
20
C856
18
13
15
C152
14
16
CNS11
R166
12
1 2 3 4 5 6
11
6
10
RD
WH
WH
WH
WH
WH
8
D101
4 5 6 7 8 9 10 11 12 13
CNP901
P33 12 - E
POWER AMP. PWB
7
8
9
10
Figure 29 WIRING SIDE OF P.W.BOARD (2/8)
– 29 –
11
12
CD-C662
SWITCH PWB-A3
A
SW708
DISC SKIP
9
RS707
LED707
LED706
RS706
C719
LED705
RS703
LED704
RS704
L
RS705
RD09
RS711
C718
SW709
OPEN/
CLOSE
IC703
10
1
18
RS712
B
DISPLAY PWB-A2
36 35 34 33 32 31 30 29 28 27 26
39 38 37
R795
25 24 23 22 21 20 19 18
R721
C711
D705
RD28
C713
SW729
EQUALIZER
R722
R771
65
5
10
IC701
60
5
45
C709
20
25 35
40
30
R762
SW728
X-BASS/DEMO
R763
R741
XL701
31
R744
R757
R743
R773
R772
R776
R778
C707
R764
C723
SW722
FF
R775
C708
L702
RD27
70
95
15
R774
E
C
B
Q705
E
C
B
90
100
1
R777
D
Q707
D720
C710
C722
1 2 3
IC704
E
C
B
Q706
D717
80
85 75
R708
R706
C720
C712
R799
81
R707
1
2
3
R716
C706
R797
D718
SW730
DIMMER
Q704
C
C702
R723
D719
R75
C717
RD21
1
R760
C705
R728
15
1
D715
Q703
R724
BI12
E
C
B
D716
R729
D714
B
C
E
Q702
R758
R759
C703
C704
JOG701
VOLUME
JOG
1
SW725
PLAY
RD23
LED723
F
10
LED717
LED716
9
SW724
TUNING
DOWN
RD24
LED724
BI704
R781
SW713
STOP
R786
RD22
R749
6
18
IC702
SW723
TUNING
UP
R787
R765
R768
R766
RD25
R770
RD26
R767
E
R769
C716
BI702
8
1
CNS704 1 2 3 4 5 6
H
1
1
RD
BL
BL
BL
BL
BL
BL
BL
BL
BL
BL
BL
BL
BL
BL
GR
WH
WH
WH
WH
WH
G
CNS12
CNSM1 12 11 10 9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
CNP704
CNP12
CNPM1
P32 1 - F
TO POWER
SUPPLY PWB
P34 12 - B
TO CD SERVO PWB
P34 6 - A
TO TAPE MECHANISM
PWB
2
3
4
Figure 30 WIRING SIDE OF P.W.BOARD (3/8)
– 30 –
5
CNP701
P28 6 - A
TO MAIN PW
6
CD-C662
RS703
LED703
LED702
SW707
DISC3
LED701
SW706
DISC2
RS701
RS702
RD07
FW703
RD06
1
6
SW705
DISC1
RD05
7
6 5
4
3 2
SW704
TIMER/SLEEP
1
D703
8
LED722
FL701
22 21 20 19 18 17 16 15 14 13 12 11 10 9
RD03
SW703
CLOCK
RX701
RD02
C715
80
1
RD04
85 75
70
R798
1
FW703
R710
R711
R712
R713
R714
R730
R702
R703
R717
6
RD01
R735
R705
R720
R736
R740
R739
R737
31
R741
30
40
R715
25 35
R701
50
R731
45
20
R726
51
55
1
C714
R709
60
15
R732
IC701
3 2
R727
65
R738
R742
R719
R750
SW701
POWER
R748
R747
R752
R753
R745
SW711
REC/
PAUSE
R754
R780
R734
LED718
RD13
RD15
RD14
LED720
SW712
MEMORY/
SET
SW716
TAPE
LED719
LED716
RD12
R733
R751
RD11
SW713
STOP
RD16
SW717
CD
RD10
R756
SW710
REW
R755
SW714
TUNER(BAND)
COLOR TABLE
CNS701
1
7 9 11 13 15 17 19 21 23
5
3
2
4
R783
6
LED721
8 10 12 14 16 18 20 22 24
BR
BROWN
R D ( R)
RED
OR
ORANGE
YL
YELLOW
GR
GREEN
C673
FFC701
24
R782
R784
SW715
VIDEO/
AUX
R785
57
R743
44
CNP701
JK671
HEADPHONES
P28 6 - A
TO MAIN PWB
7
8
9
10
Figure 31 WIRING SIDE OF P.W.BOARD (4/8)
– 31 –
11
BL
BLUE
VL
VIOLET
GY
GRAY
WH ( W)
WHITE
BK
BLACK
PK
PINK
12
CD-C662
A
F801
5A/125V
AC POWER
SUPPLY CORD
(249)
AC120V, 60Hz
B
C801
D801
C
T.F
RL801
D
T802
POWER TRANSFORMER
R803
C820
B
C
E
E
T801
POWER TRANSFORMER
ZD802
C802
Q802
D804
D802
D803
D805
F804
5A/125V
F805
5A/125V
R804
C818
C819
ZD801
R802
C810
CNS704
L802
1
2
3
4
5
6
R805
C804
D808
TO DISPLAY PWB
F806
2A/250V
C812
D806
R801
P30 1 - H
Q803
D807
F
C817
1
2
3
Q801
B C E
C803
C805
C809
C816
D809
D810
D817
CNP704
D816
CNP802
CNP801
P29 12 - F
D811
3
2
1
CNS801
TO MAIN PWB
C813
D813
C814
D812
C815
C811
G
D815
D814
H
1
2
3
4
5
6
7
8
POWER SUPPLY PWB-B1
1
2
3
4
Figure 32 WIRING SIDE OF P.W.BOARD (5/8)
– 32 –
5
6
CD-C662
6ohms
R-CH
R959
R960
R934
1 2 3
RL901
D911
E C B Q903
R930
R928
D907
D908
R926
3
2
1
Q911
Q910
3
2
1
C930
R929
C929
R932
R916
R915
D903
L902
ZD901
D905
B C E Q904
R923
R931
R925
R927
L901
D906
R942
D909
ZD902
C922
E C B Q901
Q902 E C B
R920
IC901
C924
R941
C957
Q905
C925
D904
1
2
3
4
5
6
C923
R922
R918
R919
R921
R917
C919
C920
R912
R904
R902
C912
R962
R961
C914
R901
R903
R906
P28 6 - H
CNS901
TO MAIN PWB
C913
C916
R908
C918
R910
C911
R913
CNP901
1 2 3 4 5 6 7 8 9 10111213
R911
20
21
22
SO901
SPEAKER
TERMINAL
R933
D910
C956
C921
7
8
9
10
11
12
13
14
15
16
17
18
19
L-CH
R958
C952
R953
D913
R954
R905
M901
FAN MOTOR
C917
R909
C915
C951
ZD951
E
C
B
R907
Q908
B C E Q909
C955
R956
BR
R955
R957
RD
R943
CNS903
2
1
COLOR TABLE
C901
C903
CNS802
1
2
3
4
5
6
7
8
RD
RD
WH
GY
GY
WH
GY
GY
R935
R936
RED
OR
ORANGE
YL
YELLOW
GR
GREEN
R938
R939
C904
C902
1
2 1
C943
BI802
CNP903
8
BL
BLUE
VL
VIOLET
B C E
GY
GRAY
Q907
WH(W)
WHITE
BK
BLACK
PK
PINK
D902
C945
POWER AMP. PWB-B2
7
8
9
10
Figure 33 WIRING SIDE OF P.W.BOARD (6/8)
– 33 –
BROWN
R937
D912
D901
BR
RD(R)
11
12
CD-C662
SWM3
F. P. (260-9)
2 1
A
FWM2
FWM1
PHM1
4
3
SWM4
F. A. S
(260-10)
WH
BK
CNPM2
BK
WH
SOLM1
SOLENOID
(260-8)
+
TAPE MECHANISM
PWB-F
-
1
2
P30 5 - H
CNSM1
TO DISPLAY PWB
R
12 11 10 9 8 7 6 5 4 3 2 1
CNPM1
1 2
MM1
TAPE MOTOR(260-7)
SWM5
CAM(260-11)
TAPE MECHANISM
ASSEMBLY
B
TAPE 1
PLAYBACK HEAD(260-6)
TAPE 2
RECORD/PLAYBACK
HEAD(260-6)
ERASE HEAD(260-5)
PICKUP UNIT(306)
WH
WH
BK
YL
BK
GY
RD
WH
GY
WH
GY
WH
GY
WH
1
2
3
4
5
6
7
8
D
BK
WH
PK
YL
BL
1
2
3
4
5
CNS2B
BK
1234567
CNP102
CNP101
TO MAIN PWB
P29 12 - D
1
2
3
4
5
6
7
8
GY
WH
PK
BK
WH
YL
BL
CNS102
BL
PK
WH
YL
BK
CNS101
PK
1
2
3
4
5
321
CNS1A
CNS1B
GY
BK
WH
GY
C
PK
WH
BL
PK
TO MAIN PWB
P29 12 - C
CNS2A
COLOR TABLE
CD MOTOR PWB-D
E
RD
WH
GY
WH
GY
WH
1
2
3
4
5
6
+
CNP3A
1
2
3
4
5
6
1
2
3
4
5
6
CNS3A
M2
SLED MOTOR
BR
SW4
PICK UP IN
CNS3B
+
-
M1
SPINDLE MOTOR
F
CNS5
SW2
MECHA UP
2
1
ORANGE
YL
YELLOW
GR
GREEN
BL
BLUE
VL
VIOLET
GY
GRAY
WH(W)
WHITE
BK
BLACK
PK
PINK
SENSOR PWB-E
M3
T/T UP/DOWN LOADING
OR
BR
WH
GY
WH
GY
WH
GY
WH
RD
1
-
SOLENOID
SOLM2
BIM5
CNS10
10
9
8
7
6
5
4
3
2
1
RED
OR
SW3
DISC NUMBER
2
1
SW1
OPEN/CLOSE
G
BROWN
RD(R)
+
6
H
1
2
3
4
Figure 34 WIRING SIDE OF P.W.BOARD (7/8)
– 34 –
5
6
CD-C662
11
CNP2
CNP99
C18
1
2
3
6
Q51
R81
R80
R83
1
2
3
4
5
6
D92
C55
R84
21
1
20
C77
5
15 10
IC3
8 7 6 5 4 3 2 1
25
30
35
CNP3
CNP10
40
1 2 3 4 5 6 7 8 9 10
42
22
C36
1
C82
10
D91
7
C98
IC99
1
2
3
1
3
L99
CNS99
1
2
3
DIGITAL OUTPUT PWB-A4
• The numbers 1 to 12 are waveform numbers shown in page 14.
8
CNS12
BI1A
Q52
R32
R66
R64
C75
C52
D93
R37
7
P30 3 - H
TO DISPLAY PWB
R17
R18
R23
R24
R29
R56
8
ZD61
2 1
R82
R13
1 2 3 4 5 6
B
3
1
2
CNP11
R14
C9
R16
R25
C14
R20
C11
R21
C76
C35
R26
R22
C6
R10
C10
R15
C8
C54
C4
R12
C7 R8
R9
R11
C5
C19
17
16
1 2 3 4 5
C13
C51
BI99
C15
R2
C2
15
E
C
R31
10
32
25
20
R33
IC1
C20
5
33
35
30
C17
R30
1
40
C16
R27
R28
C1
60
R34
45
R19
E
C83
D81
C71
48
55
64
C3
Q1
C
C12
2
CNP1
R36
R35
C33
C32
C34
C31
49
CNS11
R89
C29
P29 8 - B
TO MAIN PWB
17
R71
16
C22
C28
R46
R1
C74
R74
C73
R73
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
R91
L61
C24
C21
B
R65
R44
50
9
1
2
C72
C99
R43
32
C50
C56
R72
R54
R55
1
33
BI1B
64
CNP12
40
60
IC2 35
30
5
25
10
20
15
R90
R88
R53
R93
45
R45
4
C43
48
55
R50
C57
C23
R39
C30
D1
5
3
R38
C25
R40
D82
49
R52
C26
R42
R41
C27
C41
C44
XL1
50
C39
R51
C40
C42
R61
C49
R57
R62
R63
R58
C45
R59
C47
C38
C46
R60
C37
R47
C48
CD SERVO PWB-C
9
10
Figure 35 WIRING SIDE OF P.W.BOARD (8/8)
– 35 –
11
12
CD-C662
TROUBLESHOOTING (CD SECTION)
When the CD does not function
When the CD section does not operate when the objective lens of the optical pickup is dirty, this section may not operate. Clean
the objective lens, and check the playback operation. When this section does not operate even after the above step is taken, check
the following items.
Remove the cabinet and follow the troubleshooting instructions.
"Track skipping and/or no TOC (Table Of Contents) may be caused by build up of dust other foreign matter on the laser pickup
lens. Before attempting any adjustment make certain that the lens is clean. If not, clean it as mentioned below."
Turn the power off.
Gently clean the lens with a lens cleaning tissue and a small amount of isopropyl alcohol.
Do not touch the lens with the bare hand.
Dust gradually accumulates on the objective lens during use, and it may degrade performance.
To avoid this problem, use a cleaning disc designed for CD optical pickup lenses.
HOW TO USE
1. Using the brush in the cleaner cap, apply 1 or 2 drops of the cleaning fluid to the brush on the CD cleaner disc which has
the mark next to it.
2. Place the CD cleaner disc onto the CD disc tray with the brush side down, then press the play button.
3. You will hear music for about 20 seconds and the CD player will automatically stop. If it continues to turn, press the stop button.
CAUTION
The CD lens cleaner should be effective for 30 - 50 operations, however if the brushes become worn out earlier then please
replace the cleaner disc.
If the CD cleaner brushes become very wet then wipe off any excess fluid with a soft cloth.
Do not drink the cleaner fluid or allow it to come in contact with the eyes. In the event of this happening then drink and / or
rinse with clean water and seek medical advice.
The CD cleaner disc must not be used on car CD player or on computer CD ROM drives.
All rights reserved. Unauthorized duplicating, broadcasting and renting product is prohibited by law.
Cleaning Disc
PARTS CODE:
UDSKA0004AFZZ
Cleaner Liquid
Figure 36
– 36 –
CD-C662
• When the turntable fails to stop.
5V
Is from 2.5V
5 V till 2.5V down pulse (approx. 300 ms)
0V
No
input into the IC701 pin 21 when the turntable is rotating?
Check the SWM3 and the wiring from the IC701 pin 21 to the
SWM3.
Yes
Is there following voltage input on the IC701 pin 21 in the
specific state?
When the CD mechanism is moved up: 0V
In other states: 4.3V
No
Check the MECHA UP SW and the wiring from the IC701 pin
21 to the MECHA UP SW.
Yes
Check IC2 pin26 the periphery.
Yes
IC701 defective.
• When turntable fails to move.
Is there following voltage input on the IC701 pin 21 in the
specific state?
When the CD mechanism is moved up: 0V
In other states: 4.3V
No
Check the MECHA UP SW and the wiring from the IC701 pin
21 to the MECHA UP SW.
Yes
Is L output from the IC2 pin 26 during SEC when the disc skip
switch is pressed?
Check the wiring of IC2 pin 26.
No
OK
Yes
IC2 defective.
Check turntable motor and turntable mechanism.
– 37 –
CD-C662
• When the CD tray fails to open or close.
Is there following voltage input in specific state of IC701 pin 19?
Open state: 0V
Close state: 0V
Intermediate state between open state and close state: 4.3V
Check the OPEN CLOSE SW and the wiring from the IC701
pin 19 to the OPEN CLOSE SW.
No
Yes
Is H output to IC2 pin 24 or 25 for 7 seconds when the OPEN/
CLOSE key is pressed?IC91 is defective. Replace it.
Check the wiring of the IC2 pins 24 and 25, IC91 pins 1 and 3.
No
OK
IC2 defective.
Yes
Is 4V output between IC91 pins 3 and 7 during operation
stated above?
Check the periphery of IC91.
No
OK
Yes
IC91 defective.
Check the loading motor (M1) and the loading mechanism.
• The CD function will not work.
The CD operating keys don't work.
Yes
Check the CD, DSP, power supply, and 16.93 MHz clock, and
reset terminal.
Yes
Check the waveform of SCK, SO (DATA) and SI (COMM).
Yes
See if the pick-up is in the PICKUP IN SW position.
Yes
Focus search is
performed two
times when play
operation is done
without disc.
0.5s
0.50 V
IC1 16 FD
If the items mentioned above are OK, check the main
microcomputer IC701.
• The CD operating keys work.
0.5s
0.50 V
IC1 7 TE
Check the Focus - HF system.
1
Playback can be performed without a disc.
2
Figure 38
Yes
Does the pick-up move up and down twice?
Yes
Focus search OK
No
Does the output waveform of IC1(16)(FD) match that shown in
Fig. 38?
Check the area around IC5-CNP2.
Yes
No
Check the IC1(50)(CLK) line, 4MHz.
Check the microcomputer data on pins (51)(CL), (52)(DAT)
and (53)CE.
– 38 –
CD-C662
• Playback can only be performed when a disc is
loaded.
Is the Focus servo active? (Can you hear it working?)
No
Check the laser diode driver.
Check the area around IC1(16) - (21) (focus servo circuit).
No
If the disc is not turning, the DRF
should not change to "H".
Yes
Yes
Does the DRF signal change from "L" to "H"?
Check the spin system.
Yes
Yes
No
Is HF waveform normal (see the Fig. 39-1, 2)?
Check the periphery of
IC1 pins 41 and 42.
Level is abnormal.
Yes
Yes
Check the spin system.
Waveform is unstable.
Check the tracking system.
HF
1.0V/DIV
0.5µsec/DIV(DC)
(When playing
back the disc)
Waveform in case of
normal play-back
0.5s
1.00 V
IC1 16 FD
0.5s
10.0 V
IC2 13 CLV+
2
1
3
0.5s
10.0 V
IC1 54 DRF
4
0.5s
2.00 V
IC1 7 TE
Figure 39-1
Figure 39-2
• Check the tracking system.
Check waveform of IC1 pin 7 (TE).
The waveform shown in Fig.
39-3 appears, and no-disc
state appears soon.
Play is possible in
TEST mode.
Yes
Yes
Data cannot be read.
Tracking servo is
inoperative.
Yes
Although IL is possible,
play is impossible.
Yes
Yes
Check the periphery of IC 1
pin 8 to pin 15, and IC 5 to
CNP2.
Normal jump is impeded,
and the program top
cannot be reached.
Check the VCO-PLL system.
5ms
1.00 V
IC1 7 TE
4
5 ms
5.0 V
IC1 54 DRF
3
Figure 39-3
– 39 –
Yes
Check the periphery
of IC 1 pin 14.
CD-C662
• Checking the spin system.
Play operation is performed without disc.
Yes
Yes
The turntable rotates a little.
The spin driver circuit is normal.
No
Yes
The turntable fails to rotate or rotates at high speed.
Check the periphery of IC1 pins 23 to 27, pin 39, and pin 40, IC2
pin 12 and pin 13, IC5 to CNP3.
• Checking the VCO-PLL system
Play operation is performed when disc exits.
Yes
Although HF waveform is normal, TOC data cannot be read.
Yes
Check PDO waveform (Fig. 40).
Abnormal
Check the IC1 pins 43 and 44, IC2 pins 3, 5, 7, 10, and 11.
Stop --> Play
As VCO frequency is locked at
4.32 M Hz, voltage
of PDO rises and
stabilizes.
0.5s
1.00 V
IC2 3 PDO
2
0.5s
1.00 V
IC2 16 FD
3
Figure 40
• Although HF waveform is normal and the time
indication is normal, no sound is emitted.
No
Check IC 2 pin 48 (EFLG).
Yes
Check IC2 pins 37, 40.
Abnomal
Check IC 401 and POWER AMP IC 801.
– 40 –
Usually, the number of pulses of flawless disc is 100 pulses/sec
or less.
CD-C662
FUNCTION TABLE OF IC
IC1 VHiLA9241M/-1: Servo Amp. (LA9241M) (1/2)
Pin No.
Function
Port Name
1
FIN2
Connection pin for photodiode of pickup.
RF signal is generated through addition with FIN pin, and FE signal is generated through subtraction.
2
FIN1
Connection pin for photodiode of pickup.
3
E
Connection pin for photodiode of pickup. TE signal is generated through subtraction with F pin.
4
F
Connection pin for photodiode of pickup.
5
TB
Pin for input of DC component of TE signal.
6
TE-
Pin to connect gain setting resistor of TE signal to TE signal.
7
TE
TE signal output pin.
8
TESI
TES (Track error sense) comparator input pin. TE signal is band-passed and input.
9
SCI
Input pin for shock detection.
10
TH
Pin to set time constant of tracking gain.
11*
TA
TA amplifier output pin.
12
TD-
Pin to compose tracking phase compensation constant between TD and VR pins.
13
TD
Pin to set tracking phase compensation.
14
JP
Pin to set amplitude of tracking jump signal (kick pulse).
15
TO
Tracking control signal output pin.
16
FD
Focusing control signal output pin.
17
FD-
Pin to compose focusing phase compensation constant between FD and FA pins.
18
FA
Pin to compose focusing phase compensation constant between FD-/FA-pins.
19
FA-
Pin to compose focusing phase compensation constant between FA and FE pins.
20
FE
Output pin of FE signal.
21
FE-
Pin to connect gain setting resistor of FE signal across TE pin.
22
AGND
GND for analog signal.
23
NC
No connect.
24
SPI
Spindle amplifier input.
25
SPG
Pin to connect gain setting resistor in the 12cm mode of spindle.
26
SP-
Pin to connect spindle phase compensation constant together with SPD pin.
27
SPD
Spindle control signal output pin.
28
SLEQ
Pin to connect thread phase compensation constant.
29
SLD
Thread control signal output pin.
30
SL-
Input pin of thread feed signal from micro computer.
31
SL+
Input pin of thread feed signal from micro computer.
32
JP-
Input pin of tracking jump signal from DSP.
33
JP+
Input pin of tracking jump signal from DSP.
34
TGL
Input pin of tracking gain control signal from DSP. TGL = Gain low at "H"
35
TOFF
Input pin of tracking off control signal from DSP. TOFF = Off at "H"
36
TES
Output pin of TES signal to DSP.
37
HFL
(HIGH FREQUENCY LEVEL) is used to judge whether main beam is positioned on the bit or on the mirror.
38
SLOF
Thread servo off control input pin.
39
CV-
Pin to input CLV error signal from DSP.
40
CV+
Pin to input CLV error signal from DSP.
41
RFSM
RF output pin.
42
RFS-
Pin to set gain of RF and set 3T compensation constant together with RFSM pin.
43
SLC
(SLICE LEVEL CONTROL) is the output pin to control of the level of the data slice with RF waveform DSP.
44
SLI
Input pin to control the level of data slice with DSP.
45
DGND
GND pin in the digital system.
46
FSC
Output pin for focus search smoothening capacitor.
47
TBC
(Tracking Balance Control) Pin to set EF balance variable range.
48*
NC
No connect.
49
DEF
Defect detection output pin of disk.
50
CLK
Reference clock input pin. 4.23MHz of DSP is input.
In this unit, the terminal with asterisk mark (*) is (open) terminal which is not connected to the outside.
– 41 –
CD-C662
IC1 VHiLA9241M/-1:Servo Amp. (LA9241M) (2/2)
Pin No.
Function
Port Name
51
CL
Micro computer command clock input pin.
52
DAT
Micro computer command data input pin.
53
CE
Micro computer command chip enable input pin.
54
DRF
(DETECT RF) RF level detection output.
55
FSS
(Focus Serch Select) Pin to switch focus search mode. (± search/+ search for reference voltage)
56
VCC2
VCC pin for servo system and digital system.
57
REFI
Pin to connect pass control for reference voltage.
58
VR
Reference voltage output pin.
59
LF2
Pin to set defect detection time constant of disk.
60
PH1
Pin to connect capacitor for peak hold of RF signal.
61
BH1
Pin to connect capacitor for bottom hold of RF signal.
62
LDD
APC circuit output pin.
63
LDS
APC circuit output pin.
64
VCC1
RF system VCC pin.
LDS
63
VCC1
64
LDD
62
BH1
61
PH1
60
APC
FIN2
1
FIN1
2
3
F
4
TB
5
TE-
6
TE
7
TESI
8
SCI
9
VR
58
REFI
57
VCC2
56
FSS DRF CE DAT CL CLK
55 54 53 52 51 50
DEF
49
REF
RF DET
48 NC
47 TBC
VCA
I/V
E
LP2
59
46 FSC
BAL
µ-COM
VCA
45 DGND
SLC
INTER FACE
44 SLI
43 SLC
42 RFS-
TE
41 RFSM
RF AMP
40 CV+
39 CV-
T.SERVO & T.LOGIC
38 SLOF
TH 10
37 HFL
36 TES
TA 11
35 TOFF
34 TGL
TD- 12
F.SERVO & F.LOGIC
SPINDLE SERVO
33 JP+
SLED SERVO
TD 13
JP 14
TO 15
FD 16
17
FD-
18
FA
19
FA-
20
FE
21
22 23
NC
FE- AGND SP
24
SPI
Figure 42 BLOCK DIAGRAM OF IC
– 42 –
25
SPG
26
SP-
27
SPD
28
SLEQ
29
SLD
30 31
SL- SL+
32
JP-
CD-C662
IC2 VHiLC78622N-1: Servo/Signal Control (LC78622N) (1/2)
Pin
No.
Terminal Name Input/Output
Function
1
DEFI
Input
Defect detection signal (DFF) input terminal. (When this terminal is not used, connect it to 0V.)
2
TAI
Input
For PLL Input terminal for test. Pull-down resistor built in. Be sure to connect this terminal to 0V.
3
PDO
4
VVSS
—
5
ISET
Input
6
VVDD
—
7
FR
8
VSS
9
EFMO
Output
10
EFMIN
Input
11
TEST2
Input
12
CLV+
Outout
13
CLV-
Output
Output for disc motor control. 3-value output is enabled according to command.
14
V/P
Output
Rough servo/phase control automatic selection monitor output terminal.
"H": Rough servo, "L": Phase servo
15
HLF
Intput
Track detection signal input terminal. Schmidt input.
16
TES
Input
Tracking error signal input terminal. Schmidt input.
17
TOFF
18
19
Output
Input
—
Phase comparison output terminal for external VCO control.
Grounding terminal for built-in VCO. Be sure to connect this terminal to 0V.
Resistor connection terminal for adjustment of PDO output current.
Power terminal for built-in VCO.
For VCO frequency range adjustment.
Digital system grounding terminal. Be sure to connect this terminal to 0V.
For slice level control EFM signal output terminal.
EFM signal input terminal.
Input terminal for test. Pull-down resistor built-in. Be sure to connect this terminal to 0V.
Output for disc motor control. 3-value output is enabled according to command.
Output
Tracking OFF output terminal.
TGL
Output
Output terminal for tracking gain selection. "L": Gain raising.
JP+
Output
Output for track jump control. 3-value output is enabled according to command.
20
JP-
Output
Output for track jump control. 3-value output is enabled according to command.
21*
PCK
Output
Clock monitor terminal for EFM data play-back. Phase lock: 4.3218 MHz.
22*
FSEQ
Output
Sync signal detection output terminal.
When the sync signal detected from the EFM signal coincides with the internally generated sync
signal: "H"
23
VDD
24
CONT1
Input/Output General-use input/output terminal 1.
25
CONT2
Input/Output General-use input/output terminal 2.
26
CONT3
Input/Output General-use input/output terminal 3.
27
CONT4
Input/Output General-use input/output terminal 4.
28*
CONT5
Input/Output General-use input/output terminal 5.
29*
EMPH/CONT6
Output
Deemphasis monitor terminal. "H": Deemphasis disc play-back. General-use output terminal 6.
30*
C2F
Output
C2 flag output terminal.
31
DOUT
Output
Digital OUT output terminal. (EIAJ format)
32*
TEST3
Input
Input terminal for test. Pull-down resistor built-in. Be sure to connect this terminal to 0V.
33
TEST4
Input
Input terminal for test. Pull-down resistor built-in. Be sure to connect this terminal to 0V.
34
PCCL
Input
General-use input/output command recognition terminal. Pull-down resistor built in.
When this terminal is used for the same function as that of LC78622E, open or connect this
terminal to 0V.
H: Only the general-use input/output port command is controllable.
L: All command controls are enabled.
35*
MUTEL/CONT7
36
LVDD
—
37
LCHO
Output
38
LVSS
—
39
RVSS
—
40
RCHO
Output
41
RVDD
—
42*
MUTER/CONT8
43
XVDD
—
44
XOUT
Output
16.9344 MHz crystal oscillator connection terminal.
45
XIN
Input
16.9344 MHz crystal oscillator connection terminal.
46
XVSS
—
Output
Output
—
Digital system power terminal.
L channel 1-bit DAC
Control with serial data command from microcomputer.
When this terminal is not used, set it as an input terminal
and connect to 0V or set it as an output terminal and
open.
Mute output terminal for L channel. General-use output terminal 7.
Power terminal for L channel.
L channel output terminal.
Grounding terminal for L channel. Be sure to connect this terminal to 0V.
R channel 1-bit DAC
Grounding terminal for R channel. Be sure to connect this terminal to 0V.
R channel output terminal.
Power terminal for R channel.
Mute output terminal for R channel. General-use output terminal 8.
Power terminal for crystal oscillation.
Grounding terminal for crystal oscillation. Be sure to connect this terminal to 0V.
In this unit, the terminal with asterisk mark (*) is (open) terminal which is not connected to the outside.
– 43 –
CD-C662
IC2 VHiLC78622N-1: Servo/Signal Control (LC78622N) (2/2)
Pin
No.
Terminal Name Input/Output
Function
47*
SBSY
Output
Sub-code clock sync signal output terminal.
48*
EFLG
Output
C1, C2, single, double correction monitor terminal.
49*
PW
Output
Sub-code P, Q, R, S, T, U, and W output terminal.
50*
SFSY
Output
Sub-code frame sync signal output terminal. Falling occurs when the sub-code is in standby state.
Input
Sub-code read clock input terminal. Schmidt input (When this terminal is not used, connect it to 0V.)
51
SBCK
52*
FSX
Output
7.35 kHz sync signal (frequency-divided from crystal oscillation) output terminal.
53
WRQ
Output
Sub-code Q output standby output terminal.
54
RWC
55
SQOUT
56
COIN
Input
Command input terminal from microcomputer.
57
CQCK
Input
Command input taking-in clock or sub-code taking-out (from SQOUT) clock input terminal.
Schmidt input
58
RES
Input
LSI resetting input terminal. When power is turned on, once "L" is set.
59*
TEST11
Output
Output terminal for test. Use this terminal in open state (usually "L" output).
60*
16M
Output
16.9344 MHz output terminal.
61
4.2M
Output
4.2336 MHz output terminal.
62
TEST5
Input
Input terminal for test. Pull-down resistor built-in. Be sure to connect this terminal to 0V.
63
CS
Input
Chip selection input terminal. Pull-down resistor built-in.
In noncontrol state connect this terminal to 0V.
64
TEST1
Input
Input terminal for test. Pull-down resistor is not provided. Be sure to connect this terminal to 0V.
Input
Read/Write control input terminal. Schmidt input.
Output
Sub-code Q output terminal.
Note: The same potential must be supplied to the power terminals (VDD, VVDD, LVDD, RVDD, XVDD).
DEFI
EFMIN
FSEQ
Slice level
control
Vss
VDD
TAI
TST11
TEST1
TEST2
TEST3
TEST4
TEST5
PCK
FR
I SET
PDO
VVDD
VVss
EFMO
In this unit, the terminal with asterisk mark (*) is (open) terminal which is not connected to the outside.
RAM address
generator
2K x 8bit
RAM
VCO colck oscillation
clock control
Sync detection
EFM demodulation
Interpolation mute
C2F
Bilingual
Digital OUT
CLV+
CLV-
CLV
Digital servo
Flag processing of C1/C2
error detection and correction
Digital
attenuator
V/P
PW
SBCK
SBSY
SFSY
CS
WRQ
SQOUT
Subcode division
QCRC
X4 oversampling
digital filter
µCOM
Interface
1bitDAC
CQCK
Figure 44 BLOCK DIAGRAM OF IC
– 44 –
MUTEL/CONT8
LVss
LVDD
LCHO
RCHO
EFLG
EMPH/CONT6
TGL
PCCL
CONT1
CONT2
CONT3
CONT4
CONT5
JPJP+
RES
RWC
HFL
TES
TOFF
L.P.F
XTAL system timing
generator
General-use port
RVss
RVDD
MUTER/CONT7
Servo commander
16M
4.2M
XVss
FSX
XIN
XOUT
XVDD
COIN
DOUT
CD-C662
IC3 VHiM63001FP-1: Focus/Tracking/Spin/Slide Driver (M63001FP)
1
2
3
4
5
6
7
8-14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29-35
36
37
38
39
40
41
42
Terminal
Name
Function
IN2IN1AIN1BOUT1OUT1+
OUT2OUT2+
GND
OUT3+
OUT3IN3VCC1
STANDBY
VRFE
MUTE
IN5IN5+
VCC2
IN4OUT4OUT4+
VCC3
GND
OUT5+
OUT5OUT6+
OUT6VCC4
IN6IN6+
CH2 inverted input.
CH1 inverted input.
CH1 output offset control.
CH1 inverted output.
CH1 non-inverted output.
CH2 inverted output.
CH2 non-inverted output.
GND
CH3 non-inverted output.
CH3 inverted output.
CH3 inverted input.
Power supply 1 (CH1, CH2, CH3)
STANDBY signal input.
CH1-CH4 Reference voltage input.
Mute signal input (CH6).
CH5 inverted input.
CH5 non-inverted input.
Power supply 2 (CH4).
CH4 inverted input.
CH4 inverted output.
CH4 non-inverted output.
Power supply 3 (CH5).
GND
CH5 non-inverted output.
CH5 inverted output.
CH6 non-inverted output.
CH6 inverted output.
Power supply 4 (CH6).
CH6 inverted input.
CH6 non-inverted input.
IN2–
1
42
IN6+
IN1A–
2
41
IN6–
IN1B–
3
40
VCC4
OUT1–
4
39
OUT6–
OUT1+
5
38
OUT6+
OUT2–
6
37
OUT5–
OUT2+
7
36
OUT5+
1
–IN A
2
+IN A
3
VEE
4
A
–
+
+
B
–
8
VCC
7
OUT E
6
–IN B
5
+IN B
GND
INB1 3
18 INB2
INC1 4
17 INC2
IND1 5
TONE1 6
TONEL1 7
OUT1 8
GND 9
Vcc 10
M62439FP
19 INA2
34
11
32
GND
31
13
30
14
29
15
28
VCC3
OUT3–
16
27
OUT4+
IN3–
17
26
OUT4–
VCC1
18
25
IN4–
STANDBY
19
24
VCC2
VTEF
20
23
IN5+
21
22
IN5–
MUTE
16 IND2
15 TONE2
14 TONEL2
13 OUT2
12 Vss
11 CONT
Figure 45 BLOCK DIAGRAM OF IC
– 45 –
33
OUT3+
20 REC OUT2
INA1 2
9
12
IC601 VHiM62439SP-1: Audio Processor (M62439SP)
REC OUT1 1
35
10
IC562,563 VHiKiA4558P-1: Ope Amp. (KIA4558P)
OUT A
8
M63001FP
Pin No.
CD-C662
IC701 RH-iX0301AWZZ:System Microcomputer (IX0301AW) (1/2)
Pin No.
Port Name
Terminal Name
Input/Output
1
VDD
VDD
—
2*
P37
ENA
Output
3
P36
DO
Input
4
P35
DI
Output
DATA OUTPUT
5
P34
CE
Output
CE OUTPUT
6
P33
CLK
Output
CLOCK OUTPUT
7,8
P32, P31
LCK1, LCK2
Output
9
P30
RWC
Output
10
RESET
RESET
11
X2
X2
Output
MAIN CLOCK
12
X1
X1
Input
MAIN CLOCK
13
Vpp
VPP
—
POWER SUPPLY TERMINAL
14*
XT2
XT2
—
OPEN
15
P04
WRQ
Input
16
VDD
VDD
—
17
P27
PCCL
Output
CD DSP PCCL
18
P26
COIN
Outout
CD DSP COMAND
19
P25
SQOUT
Input
20
P24
CQCK
Output
21
P23
DSP RES
Output
22
P22
FRF (DRF)
Input
23
P21
SLD+
Output
CD SLIDE MOTOR +
24
P20
SLD-
Output
CD SLIDE MOTOR -
25
AVss
AVSS
—
ANALOG GROUND
26
ANI7
SPEANA3
Input
27
ANI6
SPEANA2
Input
SPEANA DATA INPUT 1 KHz
28
ANI5
SPEANA1
Input
SPEANA DATA INPUT 63 Hz
29*
ANI4
TUN SM
Input
TUNER SIGNAL METER INPUT
30
ANI3
T2 RUN
Input
TAPE2 RUN PULSE INPUT
31-33
ANI2-ANI0
KEYIN3-KEYIN1
Input
34
AVDD
AVDD
35
AVREF
AVREF
36
P03
PUIN SW
Input
CD PUIN SWITCH
37
P02
O/C SW
Input
CD OPEN/CLOSE SWITCH
38
INTP1
SYS STOP
Input
SYSTEM STOP INPUT
39
INTP0
REMOCON
Input
REMOCON INPUT
40
Vss
VSS
41
P74
DNO SW
Input
CD DISC NO. SWITCH
42
P73
U/D SW
Input
CD UP/DOWN SWITCH
43
P72
TIMER LED
Output
TIMER LED CONTROL
44
P71
T_SOL
Output
TAPE SOLENOID CONTROL
45
P70
T_MOT
Output
TAPE MOTOR CONTROL
46
VDD
VDD
47
P127
48
P126
49
Input
Function
(+) POWER SUPPLY
DOLBY PROLOGIC ENABLE TERMINAL
DATA INPUT
CD DSP READ WRITE CONTROL
RESET
CD DSP WRITE REQUEST
(+) POWER SUPPLY
CD DSP CODE Q OUT
CD DSP CLOCK
CD DSP RESET
CD RF LEVEL DETECTION
SPEANA DATA INPUT 16 KHz
KEY INPUT
—
ANALOG VDD
—
ANALOG REF VOLTAGE
—
GROUND VOLTAGE
—
(+) POWER SUPPLY
CAM SW
Input
TAPE CAM SWITCH
TIFAS
Input
TAPE1 FULL AUTOSTOP PULSE INPUT
P125
FPA
Input
TAPE2 A-SIDE FULL PROOF
50
P124
H/P
51
P123
AC RLY_CONT
52
P122
REC/PLAY
Output
TAPE REC/PLAY CHANGE
53
P121
T_BIAS
Output
TAPE Record bias control
54
P120
T_T1T2
Output
TAPE T1/T2 CHANGE
55
P117
DISTO
Input
DISTINATION INPUT
Input
HEADPHONE INPUT
Output
AC RELAY CONTROL
In this unit, the terminal with asterisk mark (*) is (open) terminal which is not connected to the outside.
– 46 –
CD-C662
IC701 RH-iX0301AWZZ:System Microcomputer (IX0301AW) (2/2)
Pin No.
Port Name
Terminal Name
Input/Output
56
P116
KEY JOG A
Input
KEY JOG INPUT A
57
P115
KEY JOG B
Input
KEY JOG INPUT B
58
P114
S MUTE
Output
59*
P113
C MUTE
Output
CENTER MUTE
60*
P112
SR MUTE
Output
SURROUND MUTE
61
P111
HI-CUT
Output
HI-CUT OUTPUT
62*
P110
POWER
Output
POWER OUTPUT
63
P107
SP_RLY
Output
SPEAKER OUTPUT RELAY CONTROL
Function
SYSTEM MUTE
64
P106
SP_DET
Input
SPEAKER OUTPUT DETECTION
65
P105
SPN_P
Input
TUNER SPAN CHANGE
66
P104
DISTOUT
Output
DISTINATION OUTPUT
67
P103/FIP32
DIAT4/P22
Input/Output
FL DISPLAY SEGMENT DRIVER
DISTINATION INPUT
68
P102/FIP31
DIAT3/P21
Input/Output
FL DISPLAY SEGMENT DRIVER
DISTINATION INPUT
69
P101/FIP30
DIAT2/P20/P15
Input/Output
FL DISPLAY SEGMENT DRIVER
DISTINATION INPUT
70
P100/FIP29
DIAT1/P19/P16
Input/Output
FL DISPLAY SEGMENT DRIVER
DISTINATION INPUT
71-78
FIP28-FIP21 P18/P13-P11/P7
79
VLOAD
VLOAD
80-100
FIP20-FIP0
P10/P6-G1/9G
Output
—
Output
FL DISPLAY SEGMENT DRIVER
FL DRIVER (–) POWER SUPP, –30V
FL DISPLAY SEGMENT DRIVER
In this unit, the terminal with asterisk mark (*) is (open) terminal which is not connected to the outside.
– 47 –
CD-C662
FL701 VVKBJ685GNK-1: FL Display
11G
9G
10G
SI
S1
S5 S4
S3
S2
CO
Dp
B7 B6 B5
B4
B3
B1
B1
B2
1G
2G
3G
4G
5G
6G
7G
8G
a
h
B7
B8
B9
B10
B11
B12
B13
B14
B21
B20
B19
B18
B17
B16
B15
j
f
B6
B5
b
k
g
m
n
r
B4
B3
B2
e
p
c
d
B1
[ 1G~8G ]
[ 10G ]
ANODE CONNECTION
1G
2G~6G
7G
8G
9G
10G
11G
P1
Dp
Dp
Dp
Dp
S1
S1
S1
P2
d
d
d
d
B1
B1
B1
P3
c
c
c
c
B2
B2
B2
P4
n
n
n
n
B3
B3
B3
P5
p
p
p
p
B4
B4
B4
P6
r
r
r
r
B5
B5
B5
P7
e
e
e
e
B6
B6
B6
P8
m
m
m
m
B7
B7
B7
P9
g
g
g
g
B8
co
P10
B9
P11
b
b
b
b
B10
P12
k
k
k
k
B11
P13
j
j
j
j
B12
P14
h
h
h
h
B13
P15
f
f
f
f
P16
a
a
a
a
B15
P17
S2
S2
S2
S2
B16
P18
S3
S3
S3
S3
B17
P19
S4
S4
S4
S4
B18
P20
S5
S5
S5
S5
B19
(LOWER)
B14
P21
B20
P22
B21
Figure 48 FL DISPLAY
– 48 –
B2
B3
B4
B5 B6 B7
CD-C662
PARTS GUIDE
CD-C662
MODEL
CD-C662 mini component system consisting of CD-C662 (Main unit)
and CP-C662 and (Speaker system).
“HOW TO ORDER REPLACEMENT PARTS”
To have your order filled promptly and correctly, please furnish the
following information.
1. MODEL NUMBER
2. REF. No.
3. PART NO.
4. DESCRIPTION
For U.S.A. only
Contact your nearest SHARP Parts Distributor to order.
For location of SHARP Parts Distributor,
Please call Toll-Free;
1-800-BE-SHARP
MARK: SPARE PARTS-DELIVERY SECTION
Explanation of capacitors/resistors parts codes
Capacitors
Resistors
VCC ....................... Ceramic type
VCK ........................ Ceramic type
VCT ........................ Semiconductor type
VC • • MF ............... Cylindrical type (without lead wire)
VC • • MN ............... Cylindrical type (without lead wire)
VC • • TV ................ Square type (without lead wire)
VC • • TQ ............... Square type (without lead wire)
VC • • CY ............... Square type (without lead wire)
VC • • CZ ............... Square type (without lead wire)
VC • • • • • • • • • J .. The 13th character represents capacity difference.
("J" ±5%, "K" ±10%, "M" ±20%, "N" ±30%,
"C" ±0.25 pF, "D" ±0.5 pF, "Z" +80-20%.)
VRD ....................... Carbon-film type
VRS ........................ Carbon-film type
VRN ....................... Metal-film type
VR • • MF ............... Cylindrical type (without lead wire)
VR • • MN ............... Cylindrical type (without lead wire)
VR • • TV ................ Square type (without lead wire)
VR • • TQ ............... Square type (without lead wire)
VR • • CY ............... Square type (without lead wire)
VR • • CZ ............... Square type (without lead wire)
VR • • • • • • • • • J .. The 13th character represents error.
("J" ±5%, "F" ±1%, "D" ±0.5%.)
If there are no indications for the electrolytic capacitors, error is ±20%.
If there are no indications for other parts, the resistors are ±5%
carbon-film type.
NOTE:
Parts marked with “
” are important for maintaining the safety of the set.
Be sure to replace parts with specified ones for maintaining the safety and performance of the set.
– 49 –
CD-C662
NO.
PRICE
RANK
PARTS CODE
DESCRIPTION
CD-C662
INTEGRATED CIRCUITS
IC1
IC2
IC3
VHILA9241M/-1
VHILC78622N-1
VHIM63001FP-1
J
J
J
IC101
VHIAN7345K/-1
J
IC301
IC302
IC303
IC562,563
IC601
IC701
VHITA7358AP-1
VHILC72131/-1
VHILA1805//-1
VHIKIA4558P-1
VHIM62439SP-1
RH-IX0301AWZZ
J
J
J
J
J
J
IC702,703
IC704
IC901
VHIBU2092F/-1
VHIKIA7042AP1
VHISTK4113E-1
J
J
J
AS Servo Amp.,LA9241M
AY Servo/Signal Control,LC78622N
AX Focus/Trackig/Spin/Slide Driver,
M63001FP
AM Playback and Record/Playback
Amp.,AN7345K
AG FM Front End,TA7358AP
AP PLL (Tuner),LC72131
AM FM/AM IF MPX.,LA1805
AC Ope Amp.,KIA4558P
AG Audio Processor,M62439SP
System Control Microcomputer,
IX0301AW
AM Input/Output Expander,BU2092F
AC Reset,KIA7042AP
BL Power Amp.,STK4113E
TRANSISTORS
Q1
Q51
Q52
Q103~106
Q107,108
Q109
Q110,111
Q113,114
Q121,122
Q124
Q126
Q128
Q302
Q343
Q344
Q601~604
Q702
Q703
Q704
Q705~707
Q801
VSKTA1266GR-1
VSKRC102M//-1
VSKTC3203Y/-1
VSKTC3200GR-1
VSKTC3199GR-1
VS2SA1318//-1
VSKRC104M//-1
VSKTC3199GR-1
VSKTC3199GR-1
VS2SA1015GR-1
VSKRC104M//-1
VSKTC3203Y/-1
VS2SC535-C/-1
VSKRA109M//-1
VSKRA102M//-1
VSKTC3199GR-1
VSKTA1273Y/-1
VSKTA1271Y/-1
VSKRC102M//-1
VSKTC3199GR-1
VHIAN78L05/-1
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
AB
AC
AC
AC
AB
AC
AC
AB
AB
AB
AC
AC
AC
AC
AC
AB
AE
AC
AC
AB
AE
Q802
Q803
Q850
Q851
Q852
Q853
Q901~904
Q905
Q907~909
Q910,911
VSKTC3199GR-1
VSKTA1274Y/-1
VSKTD2058Y/-1
VHIKIA7812P-1
VHIKIA7806P-1
VHIKIA78L05-1
VSKTC3199GR-1
VSKRC107M//-1
VSKTC3199GR-1
VSKRC107M//-1
J
J
J
J
J
J
J
J
J
J
AB
AE
AE
AG
AF
AB
AC
AB
AC
Silicon,PNP,KTA1266 GR
Digital,NPN,KRC102 M
Silicon,NPN,KTC3203 Y
Silicon,NPN,KTC3200 GR
Silicon,NPN,KTC3199 GR
Silicon,PNP,2SA1318
Digital,NPN,KRC104 M
Silicon,NPN,KTC3199 GR
Silicon,NPN,KTC3199 GR
Silicon,PNP,2SA1015 GR
Digital,NPN,KRC104 M
Silicon,NPN,KTC3203 Y
Silicon,NPN,2SC535 C
Digital,PNP,KRA109 M
Digital,PNP,KRA102 M
Silicon,NPN,KTC3199 GR
Silicon,PNP,KTA1273 Y
Silicon,PNP,KTA1271 Y
Digital,NPN,KRC102 M
Silicon,NPN,KTC3199 GR
Constant Voltage Regulator,
AN78L05
Silicon,NPN,KTC3199 GR
Silicon,PNP,KTA1274 Y
Silicon,NPN,KTD2058 Y
Voltage Regulator,KIA7812P
Voltage Regulator,KIA7806P
Voltage Regulator,KIA78L05
Silicon,NPN,KTC3199 GR
Digital,NPN,KRC107 M
Silicon,NPN,KTC3199 GR
Digital,NPN,KRC107 M
!
D1
D81,82
D91~93
D101,102
D301~305
D342
D551
D554~556
D601,602
D703
D705
D714~720
D801
D802~805
D806~808
D809
D810
D811~817
D850~853
D901,902
D903,904
D905,906
D907~913
DESCRIPTION
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
AB
AC
AC
AC
AC
AC
AB
AC
AB
AC
AC
AC
AC
AG
AK
AD
AC
AC
AB
AC
AA
AB
AC
LED,Green,L1154GT4
LED,Orange,SLI342YCB
LED,Yellow,SLI342DCB
LED,Red,SLI342UCB
LED,Orange,SLI342UCB
LED,Yellow,SLI342YCB
LED,Green,L1154GT4
LED,Yellow,SLI342YCJ
LED,Yellow,SLI325YC
LED,Yellow,SLI342YCE
LED,Yellow,SLI342YCJ
LED,Red,SLI342UCJ
LED,Yellow,SLI342YCJ
Silicon,SVC211C,Variable Cap
Variable Capacitance,SVC348S
Zener,5.6V,MTZJ5.6B
Zener,5.1V,MTZJ5.1B
Zener,6.2V,MTZJ6.2C
Zener,2.4V,MTZJ2.4B
Zener,30V,MTZJ30C
Zener,6.2V,MTZJ6.2A
Zener,8.2V,MTZJ8.2C
Zener,13V,MTZJ13B
J
J
J
AE Band Pass Filter
AD FM IF,10.7 MHz
AE AM IF
RCILI0017AWZZ
RCILA0052AWZZ
RCILB0058AWZZ
RCILI0015AWZZ
RCILI0016AWZZ
RTRNP0245AWZZ
RTRNP0239AWZZ
J
J
J
J
J
J
J
AB
AE
AC
AE
AC
BM
AP
FM IF
AM Antenna
OSC,AM
AM IF
FM Detection
Power
Power
VP-XHR82K0000
VP-DH2R2K0000
VP-DH101K0000
VP-MK331K0000
RCILR0029AWZZ
RCILB0060AWZZ
VP-DH101K0000
VP-DH2R2K0000
VP-DH101K0000
VP-DH101K0000
RCILZ0137AFZZ
J
J
J
J
J
J
J
J
J
J
J
AC
AB
AB
AB
AA
AC
AB
AB
AB
AB
AA
0.82 µH
2.2 mmH,Peaking
100 µH,Choke
330 µH,Choke
FM RF
OSC,FM
100 µH,Choke
2.2 mmH,Peaking
100 µH,Choke
100 µH,Choke
0.29 µH
J
AC 6.8 kohms (B),Semi-VR [VCO]
PARTS CODE
LED701
LED702
LED703
LED704
LED705
LED706
LED707
LED716,717
LED718
LED719,720
LED721
LED722
LED723,724
VD302,303
VD331
ZD61
ZD351
ZD551
ZD601,602
ZD801
ZD802
ZD901,902
ZD951
VHPL1154GT4-1
VHPSLI342YCB1
VHPSLI342DCB1
VHPSLI342UCB1
VHPSLI342DCB1
VHPSLI342YCB1
VHPL1154GT4-1
VHPSLI342YCJ1
VHPSLI325YC-1
VHPSLI342YCE1
VHPSLI342YCJ1
VHPSLI342UCJ1
VHPSLI342YCJ1
VHCSVC211C/-1
VHCSVC348S/-1
VHEMTZJ5R6B-1
VHEMTZJ5R1B-1
VHEMTZJ6R2C-1
VHEMTZJ2R4B-1
VHEMTZJ300C-1
VHEMTZJ6R2A-1
VHEMTZJ8R2C-1
VHEMTZJ130B-1
RFILR0008AWZZ
RFILF0124AFZZ
92LFILTA1768A
FILTERS
BF301
CF301
CF351
TRANSFORMERS
!
!
T301
T331
T333
T351
T352
T801
T802
COILS
L61
L99
L103
L104
L302
L303
L343
L601
L702
L802
L901,902
VARIABLE RESISTOR
VR351
DIODES
PRICE
RANK
NO.
RVR-M0025AWZZ
VIBRATORS
VHD1SS133//-1
VHD1SS133//-1
VHD1SS133//-1
VHD1SS133//-1
VHD1SS133//-1
VHD1SS133//-1
VHD1SS133//-1
VHD1SS133//-1
VHD1SS133//-1
VHD1SS133//-1
VHD1SS133//-1
VHD1SS133//-1
VHD1SS133//-1
VHD1N4004S/-1
VHD1SS133//-1
VHDTS6B04GM-1
VHDBR102J02-1
VHD1N4004S/-1
VHD1SS133//-1
VHD1N4004S/-1
VHD1SS133//-1
VHD1N5402M/-1
VHD1SS133//-1
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AP
AM
AB
AA
AB
AA
AE
AA
Silicon,1SS133
Silicon,1SS133
Silicon,1SS133
Silicon,1SS133
Silicon,1SS133
Silicon,1SS133
Silicon,1SS133
Silicon,1SS133
Silicon,1SS133
Silicon,1SS133
Silicon,1SS133
Silicon,1SS133
Silicon,1SS133
Silicon,1N4004S
Silicon,1SS133
Silicon,TS6B04GM
Silicon,BR102J02
Silicon,1N4004S
Silicon,1SS133
Silicon,1N4004S
Silicon,1SS133
Silicon,1N5402M
Silicon,1SS133
X352
XL1
XL701
RCRSP0002AWZZ J
RCRSP0005AWZZ J
RCRSP0003AWZZ J
AH Crystal,4.5 MHz
AF Crystal,16.934 MHz
AH Crystal,4.19 MHz
CAPACITORS
C1
C2
C3
C4
C5,6
C7
C8
C9
C10
C11,12
C13
C14,15
C16
C17
C18
C19
–1–
VCEAZA1CW476M
VCKYTV1HB103K
VCEAZA1HW105M
VCEAZA1HW104M
VCTYPA1CX333K
VCEAZA1HW104M
VCTYPA1CX683K
VCTYPA1CX473K
VCCSTV1HL181J
VCTYPA1CX104K
VCKYTV1HB331K
VCKYTV1HB103K
VCKYTV1HB472K
VCKYTV1HB102K
VCEAZA1HW474M
VCEAZA1HW105M
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
AB
AA
AB
AB
AA
AB
AA
AA
AA
AB
AA
AA
AA
AA
AB
AB
47 µF,16V,Electrolytic
0.01 µF,50V
1 µF,50V,Electrolytic
0.1 µF,50V,Electrolytic
0.033 µF,16V
0.1 µF,50V,Electrolytic
0.068 µF,16V
0.047 µF,16V
180 pF,50V
0.1 µF,16V
330 pF,50V
0.01 µF,50V
0.0047 µF,50V
0.001 µF,50V
0.47 µF,50V,Electrolytic
1 µF,50V,Electrolytic
CD-C662
NO.
C20
C21
C22
C23
C24
C25
C26
C27
C28
C29
C30
C31
C32
C33
C34
C35
C36
C37
C38
C39,40
C41
C42
C43
C44~47
C48
C49
C50
C51,52
C54
C55
C56
C57
C71,72
C73,74
C75
C76
C77
C82
C83
C98
C99
C101,102
C103
C105
C106
C107,108
C109
C111~114
C115,116
C117,118
C119,120
C121,122
C127
C128
C129,130
C131,132
C133,134
C135,136
C139,140
C141,142
C145
C146
C150
C151
C152
C153
C154
C155,156
C302
C303
C304
C305
C306
C307,308
C309
C310
C311
C312
C313
C314
C316
C317
PARTS CODE
VCEAZA1CW476M
VCKYTV1HB332K
VCCSPA1HL221J
VCKYTV1HB272K
VCCSTV1HL2R2C
VCCSTV1HL270J
VCTYPA1CX333K
VCKYTV1HB102K
VCTYPA1CX104K
VCEAZA1HW475M
VCEAZA1HW104M
VCEAZA0JW227M
VCKYTV1HB103K
VCEAZA1HW474M
VCEAZA1HW334M
VCEAZA1HW105M
VCEAZA1CW107M
VCKZPA1HF223Z
VCKYTV1HB103K
VCKZPA1HF473K
VCCSPA1HL120J
VCCSPA1HL150J
VCEAZA0JW337M
VCCCTV1HH101J
VCCSPA1HL101J
VCCCTV1HH101J
VCKYTV1EF223Z
VCEAZA1CW107M
VCKYTV1HB102K
VCEAZA1CW107M
VCKYTV1EF223Z
VCKYBT1HB102K
VCEAZA1HW106M
VCKYTV1HB221K
VCKYTV1HB102K
VCKZPA1HF223Z
VCEAZA1CW107M
VCEAZA1CW107M
VCTYBT1EF223Z
VCKZPA1HF223Z
VCEAZA1AW107M
VCKYMN1HB102K
VCKYPA1HB103K
VCKYBT1HB181K
VCKYMN1HB181K
VCKYMN1HB102K
VCKZPA1HF473Z
VCKYMN1HB331K
VCEAZA1EW476M
VCTYPA1EX333K
VCKYMN1HB561K
VCEAZA1HW105M
VCTYMN1EF223Z
VCEAZA1HW335M
VCKYMN1HB471K
VCKYMN1HB102K
VCEAZA1EW226M
VCTYPA1CX823K
VCTYMN1CX332K
VCEAZA1HW105M
VCEAZA1EW226M
VCEAZA1CW227M
VCQPKA2AA392J
VCQYKA1HM273K
VCEAZA1EW476M
VCEAZA1CW107M
VCEAZA1CW476M
VCEAZA1HW335M
VCCCMN1HH100J
VCTYMN1CY103N
VCCCMN1HH4R7C
VCCCMN1HH150J
VCCCMN1HH180J
VCTYMN1CX472K
VCCUMN1HJ4R7D
VCKYMN1HB102K
VCTYMN1EF223Z
VCKYMN1HB102K
VCTYMN1EF223Z
VCEAZA1CW106M
VCKYBT1HB101K
VCCUMN1HJ3R9K
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
PRICE
RANK
DESCRIPTION
AB
AA
AA
AA
AB
AA
AA
AA
AB
AB
AB
AC
AA
AB
AB
AB
AC
AA
AA
AA
AA
AA
AC
AA
AA
AA
AA
AC
AA
AC
AA
AA
AB
AA
AA
AA
AC
AC
AA
AA
AB
AA
AA
AA
AA
AA
AA
AA
AB
AA
AA
AB
AA
AB
AA
AA
AB
AB
AA
AB
AB
AC
AB
AB
AB
AC
AB
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AC
AA
AA
47 µF,16V,Electrolytic
0.0033 µF,50V
220 pF,50V
0.0027 µF,50V
2.2 pF,50V
27 pF,50V
0.033 µF,16V
0.001 µF,50V
0.1 µF,16V
4.7 µF,50V,Electrolytic
0.1 µF,50V,Electrolytic
220 µF,6.3V,Electrolytic
0.01 µF,50V
0.47 µF,50V,Electrolytic
0.33 µF,50V,Electrolytic
1 µF,50V,Electrolytic
100 µF,16V,Electrolytic
0.022 µF,50V
0.01 µF,50V
0.047 µF,50V
12 pF,50V
15 pF,50V
330 µF,6.3V,Electrolytic
100 pF (CH),50V
100 pF,50V
100 pF (CH),50V
0.022 µF,25V
100 µF,16V,Electrolytic
0.001 µF,50V
100 µF,16V,Electrolytic
0.022 µF,25V
0.001 µF,50V
10 µF,50V,Electrolytic
220 pF,50V
0.001 µF,50V
0.022 µF,50V
100 µF,16V,Electrolytic
100 µF,16V,Electrolytic
0.022 µF,25V
0.022 µF,50V
100 µF,10V,Electrolytic
0.001 µF,50V
0.01 µF,50V
180 pF,50V
180 pF,50V
0.001 µF,50V
0.047 µF,50V
330 pF,50V
47 µF,25V,Electrolytic
0.033 µF,25V
560 pF,50V
1 µF,50V,Electrolytic
0.022 µF,25V
3.3 µF,50V,Electrolytic
470 pF,50V
0.001 µF,50V
22 µF,25V,Electrolytic
0.082 µF,16V
0.0033 µF,16V
1 µF,50V,Electrolytic
22 µF,25V,Electrolytic
220 µF,16V,Electrolytic
0.0039 µF,100V,Polypropylene
0.027 µF,50V,Mylar
47 µF,25V,Electrolytic
100 µF,16V,Electrolytic
47 µF,16V,Electrolytic
3.3 µF,50V,Electrolytic
10 pF (CH),50V
0.01 µF,16V
4.7 pF (CH),50V
15 pF (CH),50V
18 pF (CH),50V
0.0047 µF,16V
4.7 pF (UJ),50V
0.001 µF,50V
0.022 µF,25V
0.001 µF,50V
0.022 µF,25V
10 µF,16V,Electrolytic
100 pF,50V
3.9 pF (UJ),50V
NO.
–2–
C318
C319
C320
C330
C331
C332,333
C334
C335
C337
C338
C349
C350
C351
C353
C354
C355~357
C358
C359,360
C361
C363,364
C365~367
C369
C381
C382
C383
C392
C393
C395
C551
C553
C555,556
C557
C559
C561~563
C566~568
C569
C601~606
C611,612
C613~615
C616
C617
C618,619
C620~622
C623~626
C627
C628
C629
C630
C631,632
C634,635
C641
C673
C702
C703,704
C705
C706
C707
C708
C709
C710
C711
C712
C713,714
C715
C716
C717
C718
C719
C720
C722
C723
C801
C802
C803
C804
C805
C809,810
C811,812
C813,814
C815,816
C817
C818,819
PRICE
RANK
PARTS CODE
VCCCMN1HH220J
VCTYMN1EF223Z
VCKYPA1HB102K
VCCUMN1HJ8R2D
VCKZPA1HF473Z
VCTYMN1EF223Z
VCCUMN1HJ220J
VCCSPA1HL561J
VCEAZA1HW106M
VCKYMN1HB101K
VCTYMN1EF223Z
VCEAZA1AW227M
VCTYMN1CX222K
VCTYMN0JY183M
VCKYMN1HB221K
VCEAZA1HW335M
CPU100V1500PJ
VCTYMN1EF223Z
VCEAZA1CW226M
VCTYPA1EX153K
VCEAZA1HW105M
VCEAZA1CW476M
VCCCMN1HH120J
VCCCMN1HH150J
VCTYMN1EF223Z
VCKYMN1HB102K
VCEAZA1HW105M
VCKYMN1HB102K
VCKYMN1HB271K
VCTYMN1CX272K
VCTYMN1CX682K
VCKYMN1HB271K
VCTYMN1CX272K
VCTYMN1EF223Z
VCEAZA1HW225M
VCTYMN1EF223Z
VCEAZA1HW475M
VCTYPA1EX333K
VCFYDA1HA224J
VCCSMN1HL4R7K
VCEAZA1HW106M
VCTYMN1EF223Z
VCEAZA1HW106M
VCKYMN1HB102K
VCEAZA1EW226M
VCFYDA1HA224J
VCEAZA1EW226M
VCKYMN1HB102K
VCKYMN1HB391K
VCTYMN1CX822K
VCKYPA1HB102K
VCKYPA1HB103K
VCEAZA1HW105M
VCKYMN1HB102K
RC-EZD476AF1C
VCEAZA1HW105M
VCCSMN1HL150J
VCCSMN1HL180J
VCTYBT1EF223Z
VCEAZA1AW227M
VCTYMN1CY103N
VCEAZA1HW335M
VCTYMN1EF223Z
RC-EZD476AF1C
VCEAZA1EW476M
VCTYBT1EF223Z
VCEAZA1EW476M
VCTYMN1EF223Z
VCEAZA1HW476M
RC-EZD106AF1H
VCEAZA1HW104M
RC-KZ001LAWZZ
VCQYKA1HM473J
VCEAZA1EW477M
VCEAZA1CW106M
VCEAZV0JW228M
VCFYDA1HA224J
VCQYKA2AM224K
VCQYKA1HM473J
VCEAZA1HW107M
VCEAZA1HW227M
VCEAZA1HW476M
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AA
AC
AA
AA
AA
AB
AC
AA
AC
AA
AB
AB
AA
AA
AA
AA
AB
AA
AA
AA
AA
AA
AA
AA
AB
AA
AB
AA
AB
AA
AB
AA
AB
AA
AB
AB
AB
AA
AA
AA
AA
AA
AB
AA
AC
AB
AA
AA
AA
AC
AA
AB
AA
AC
AB
AA
AB
AA
AB
AB
AB
AB
AB
AD
AC
AB
AB
AC
AC
AB
DESCRIPTION
22 pF (CH),50V
0.022 µF,25V
0.001 µF,50V
8.2 pF (UJ),50V
0.047 µF,50V
0.022 µF,25V
22 pF (UJ),50V
560 pF,50V
10 µF,50V,Electrolytic
100 pF,50V
0.022 µF,25V
220 µF,10V,Electrolytic
0.0022 µF,16V
0.018 µF,6.3V
220 pF,50V
3.3 µF,50V,Electrolytic
0.0015 µF,100V, Polypropylene
0.022 µF,25V
22 µF,16V,Electrolytic
0.015 µF,25V
1 µF,50V,Electrolytic
47 µF,16V,Electrolytic
12 pF (CH),50V
15 pF (CH),50V
0.022 µF,25V
0.001 µF,50V
1 µF,50V,Electrolytic
0.001 µF,50V
270 pF,50V
0.0027 µF,16V
0.0068 µF,16V
270 pF,50V
0.0027 µF,16V
0.022 µF,25V
2.2 µF,50V,Electrolytic
0.022 µF,25V
4.7 µF,50V,Electrolytic
0.033 µF,25V
0.22 µF,50V,Polyester
4.7 pF,50V
10 µF,50V,Electrolytic
0.022 µF,25V
10 µF,50V,Electrolytic
0.001 µF,50V
22 µF,25V,Electrolytic
0.22 µF,50V,Polyester
22 µF,25V,Electrolytic
0.001 µF,50V
390 pF,50V
0.0082 µF,16V
0.001 µF,50V
0.01 µF,50V
1 µF,50V,Electrolytic
0.001 µF,50V
47 µF,16V,Electrolytic
1 µF,50V,Electrolytic
15 pF,50V
18 pF,50V
0.022 µF,25V
220 µF,10V,Electrolytic
0.01 µF,16V
3.3 µF,50V,Electrolytic
0.022 µF,25V
47 µF,16V,Electrolytic
47 µF,25V,Electrolytic
0.022 µF,25V
47 µF,25V,Electrolytic
0.022 µF,25V
47 µF,50V,Electrolytic
10 µF,50V,Electrolytic
0.1 µF,50V,Electrolytic
0.0047 µF,250VAC,Ceramic
0.047 µF,50V,Mylar
470 µF,25V,Electrolytic
10 µF,16V,Electrolytic
2200 µF,6.3V,Electrolytic
0.22 µF,50V,Polyester
0.22 µF,100V,Mylar
0.047 µF,50V,Mylar
100 µF,50V,Electrolytic
220 µF,50V,Electrolytic
47 µF,50V,Electrolytic
CD-C662
NO.
C820
C850
C851
C852,853
C854
C855,856
C857
C858,859
C860
C901,902
C903,904
C911,912
C913,914
C915,916
C917,918
C919,920
C921,922
C923,924
C925
C929,930
C943
C945
C951
C952
C955
C956,957
PRICE
RANK
PARTS CODE
VCEAZA1VW107M
VCEAZW1EW338M
VCEAZA1EW226M
VCQYKA1HM473K
VCEAZA1EW476M
VCQYKA1HM104K
VCEAZA1EW476M
VCQYKA1HM104K
VCEAZA1EW476M
RC-EZ0029AWZZ
VCEAEA1VW478M
VCCSPA1HL470J
VCCSPA1HL330J
VCEAZA1HW476M
VCEAZA1HW225M
VCEAZV2AW107M
VCEAZA1HW476M
VCQYKA1HM223J
VCEAZA1HW476M
VCQYKA1HM104J
VCEAZA1HW106M
VCEAZA1EW476M
VCQYKA1HM223J
VCEAZA1EW227M
VCEAZA1EW226M
VCEAZV2AW476M
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
AC
AG
AB
AB
AB
AB
AB
AB
AB
AN
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AB
AB
AB
AB
AC
AB
AB
AB
AC
AB
DESCRIPTION
100 µF,35V,Electrolytic
3300 µF,25V,Electrolytic
22 µF,25V,Electrolytic
0.047 µF,50V,Mylar
47 µF,25V,Electrolytic
0.1 µF,50V,Mylar
47 µF,25V,Electrolytic
0.1 µF,50V,Mylar
47 µF,25V,Electrolytic
3300 µF,71V,Electrolytic
4700 µF,35V,Electrolytic
47 pF,50V
33 pF,50V
47 µF,50V,Electrolytic
2.2 µF,50V,Electrolytic
100 µF,100V,Electrolytic
47 µF,50V,Electrolytic
0.022 µF,50V,Mylar
47 µF,50V,Electrolytic
0.1 µF,50V,Mylar
10 µF,50V,Electrolytic
47 µF,25V,Electrolytic
0.022 µF,50V,Mylar
220 µF,25V,Electrolytic
22 µF,25V,Electrolytic
47 µF,100V,Electrolytic
RESISTORS
R1
R2
R8
R9
R10
R11
R12
R13
R14
R15
R16
R17
R18
R19
R20
R21
R22
R23
R24
R25
R26
R27
R28
R29
R30
R31
R32
R33
R34
R35,36
R37
R38
R39
R40
R41,42
R43
R44
R45
R46
R47
R50
R51
R52
R53
R54
R55
R56
R57
R58~60
R61~63
R64
VRD-MN2BD000C
VRS-TV2AB000J
VRS-TV2AB220J
VRD-ST2CD102J
VRS-TV2AB153J
VRS-TV2AB104J
VRS-TV2AB222J
VRD-ST2CD682J
VRD-ST2CD101J
VRS-TV2AB102J
VRS-TV2AB273J
VRS-TV2AB123J
VRS-TV2AB332J
VRS-TV2AB333J
VRS-TV2AB153J
VRD-ST2CD102J
VRS-TV2AB102J
VRS-TV2AB152J
VRS-TV2AB821J
VRS-TV2AB103J
VRS-TV2AB473J
VRS-TV2AB152J
VRS-TV2AB823J
VRS-TV2AB393J
VRS-TV2AB103J
VRS-TV2AB563J
VRS-TV2AB682J
VRS-TV2AB122J
VRS-TV2AB103J
VRS-TV2AB122J
VRS-TV2AB332J
VRS-TV2AB224J
VRD-ST2CD823J
VRS-TV2AB471J
VRD-ST2CD102J
VRS-TV2AB562J
VRS-TV2AB473J
VRS-TV2AB563J
VRS-TV2AB333J
VRS-TV2AB472J
VRS-TV2AB561J
VRD-ST2CD103J
VRS-TV2AB681J
VRD-ST2CD335J
VRS-TV2AB273J
VRS-TV2AB122J
VRD-ST2CD331J
VRD-ST2CD101J
VRS-TV2AB223J
VRD-ST2CD102J
VRS-TV2AB102J
VRD-ST2CD102J
VRS-TV2AB220J
0 ohm,Jumper,ø1.4×3.5mm,Ivory
0 ohm,Jumper,1.25×2mm,Green
22 ohms,1/10W
1 kohm,1/6W
15 kohms,1/10W
100 kohm,1/10W
2.2 kohms,1/10W
6.8 kohms,1/6W
100 ohm,1/6W
1 kohm,1/10W
27 kohms,1/10W
12 kohms,1/10W
3.3 kohms,1/10W
33 kohms,1/10W
15 kohms,1/10W
1 kohm,1/6W
1 kohm,1/10W
1.5 kohms,1/10W
820 ohms,1/10W
10 kohm,1/10W
47 kohms,1/10W
1.5 kohms,1/10W
82 kohms,1/10W
39 kohms,1/10W
10 kohm,1/10W
56 kohms,1/10W
6.8 kohms,1/10W
1.2 kohms,1/10W
10 kohm,1/10W
1.2 kohms,1/10W
3.3 kohms,1/10W
220 kohms,1/10W
82 kohms,1/6W
470 ohms,1/10W
1 kohm,1/6W
5.6 kohms,1/10W
47 kohms,1/10W
56 kohms,1/10W
33 kohms,1/10W
4.7 kohms,1/10W
560 ohms,1/10W
10 kohm,1/6W
680 ohms,1/10W
3.3 Mohms,1/6W
27 kohms,1/10W
1.2 kohms,1/10W
330 ohms,1/6W
100 ohm,1/6W
22 kohms,1/10W
1 kohm,1/6W
1 kohm,1/10W
1 kohm,1/6W
22 ohms,1/10W
NO.
R65
R66
R71,72
R73,74
R80,81
R82,83
R84
R88,89
R90
R91
R93
R101
R102
R103,104
R105,106
R107,108
R109,110
R111,112
R113,114
R115
R117,118
R119,120
R121,122
R123,124
R125,126
R131,132
R134
R135,136
R137
R138
R139,140
R141,142
R145,146
R153,154
R155
R156
R157
R158
R160
R162
R164
R166
R167
R168
R169
R170
R171,172
R173,174
R175
R301
R302
R303
R305
R306
R311
R312
R313
R314
R316
R317
R320
R321
R323
R347
R348
R350
R352
R356
R359
R360
R361
R362
R365
R366,367
R369
R371~374
R375
R379
R380
R381
R551
R553
–3–
PRICE
RANK
PARTS CODE
VRD-ST2CD102J
VRS-TV2AB221J
VRD-ST2CD272J
VRS-TV2AB104J
VRD-ST2CD102J
VRS-TV2AB122J
VRD-ST2CD222J
VRD-ST2CD122J
VRD-ST2CD221J
VRD-ST2CD102J
VRS-TV2AB221J
VRD-MN2BD102J
VRD-ST2CD102J
VRD-MN2BD222J
VRD-MN2BD332J
VRD-MN2BD473J
VRD-MN2BD472J
VRD-ST2CD103J
VRD-MN2BD103J
VRD-MN2BD472J
VRD-MN2BD102J
VRD-ST2CD560J
VRD-MN2BD104J
VRD-MN2BD392J
VRD-MN2BD562J
VRD-MN2BD333J
VRD-MN2BD683J
VRD-MN2BD183J
VRD-MN2BD682J
VRD-ST2CD682J
VRD-MN2BD561J
VRD-MN2BD560J
VRD-MN2BD103J
VRD-MN2BD103J
VRD-ST2EE151J
VRD-ST2CD224J
VRD-MN2BD224J
VRD-ST2EE221J
VRD-ST2EE151J
VRD-MN2BD473J
VRD-MN2BD472J
VRD-MN2BD473J
VRD-MN2BD104J
VRD-MN2BD120J
VRD-MN2BD182J
VRD-ST2CD182J
VRD-MN2BD224J
VRD-MN2BD562J
VRD-ST2CD102J
VRD-MN2BD333J
VRD-ST2CD220J
VRD-MN2BD104J
VRD-MN2BD820J
VRD-MN2BD100J
VRD-MN2BD224J
VRD-MN2BD681J
VRD-MN2BD470J
VRD-MN2BD103J
VRD-MN2BD472J
VRD-ST2EE821J
VRD-ST2CD103J
VRD-MN2BD121J
VRD-MN2BD683J
VRD-MN2BD392J
VRD-MN2BD333J
VRD-ST2CD473J
VRD-MN2BD153J
VRD-ST2CD103J
VRD-MN2BD473J
VRD-MN2BD152J
VRD-MN2BD103J
VRD-ST2EE391J
VRD-ST2EE681J
VRD-ST2CD821J
VRD-MN2BD222J
VRD-MN2BD102J
VRD-ST2CD122J
VRD-MN2BD222J
VRD-MN2BD152J
VRD-ST2CD103J
VRD-MN2BD103J
VRD-ST2CD123J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
DESCRIPTION
1 kohm,1/6W
220 ohms,1/10W
2.7 kohms,1/6W
100 kohm,1/10W
1 kohm,1/6W
1.2 kohms,1/10W
2.2 kohms,1/6W
1.2 kohms,1/6W
220 ohms,1/6W
1 kohm,1/6W
220 ohms,1/10W
1 kohm,1/8W
1 kohm,1/6W
2.2 kohms,1/8W
3.3 kohms,1/8W
47 kohms,1/8W
4.7 kohms,1/8W
10 kohm,1/6W
10 kohm,1/8W
4.7 kohms,1/8W
1 kohm,1/8W
56 ohms,1/6W
100 kohm,1/8W
3.9 kohms,1/8W
5.6 kohms,1/8W
33 kohms,1/8W
68 kohms,1/8W
18 kohms,1/8W
6.8 kohms,1/8W
6.8 kohms,1/6W
560 ohms,1/8W
56 ohms,1/8W
10 kohm,1/8W
10 kohm,1/8W
150 ohms,1/4W
220 kohms,1/6W
220 kohms,1/8W
220 ohms,1/4W
150 ohms,1/4W
47 kohms,1/8W
4.7 kohms,1/8W
47 kohms,1/8W
100 kohm,1/8W
12 ohms,1/8W
1.8 kohms,1/8W
1.8 kohms,1/6W
220 kohms,1/8W
5.6 kohms,1/8W
1 kohm,1/6W
33 kohms,1/8W
22 ohms,1/6W
100 kohm,1/8W
82 ohms,1/8W
10 ohm,1/8W
220 kohms,1/8W
680 ohms,1/8W
47 ohms,1/8W
10 kohm,1/8W
4.7 kohms,1/8W
820 ohms,1/4W
10 kohm,1/6W
120 ohms,1/8W
68 kohms,1/8W
3.9 kohms,1/8W
33 kohms,1/8W
47 kohms,1/6W
15 kohms,1/8W
10 kohm,1/6W
47 kohms,1/8W
1.5 kohms,1/8W
10 kohm,1/8W
390 ohms,1/4W
680 ohms,1/4W
820 ohms,1/6W
2.2 kohms,1/8W
1 kohm,1/8W
1.2 kohms,1/6W
2.2 kohms,1/8W
1.5 kohms,1/8W
10 kohm,1/6W
10 kohm,1/8W
12 kohms,1/6W
CD-C662
NO.
R555
R556
R558
R560
R561
R562
R564
R566
R567
R568
R570
R572
R573
R574,575
R578~580
R601~608
R609
R610
R611
R612
R613,614
R615,616
R617~620
R623
R624
R625
R626
R628
R629,630
R631,632
R633,634
R635,636
R637,638
R639
R640
R641
R642
R650,651
R652,653
R701~703
R705~708
R709~711
R712
R713~715
R716
R717
R719,720
R721~723
R724
R726~729
R730~732
R733,734
R735
R736,737
R738
R739
R740~743
R744,745
R747,748
R749,750
R751
R752~754
R755,756
R757
R758
R759,760
R762~778
R780
R781
R782~785
R786
R787
R795
R797
R798
R799
R801
R802
R803
R804
R805
R850
PRICE
RANK
PARTS CODE
VRD-ST2CD563J
VRD-MN2BD333J
VRD-ST2CD683J
VRD-ST2CD474J
VRD-ST2CD153J
VRD-MN2BD394J
VRD-MN2BD394J
VRD-MN2BD225J
VRD-MN2BD274J
VRD-MN2BD224J
VRD-MN2BD224J
VRD-MN2BD225J
VRD-MN2BD564J
VRD-ST2EE331J
VRD-MN2BD104J
VRD-MN2BD152J
VRD-MN2BD222J
VRD-MN2BD103J
VRD-MN2BD331J
VRD-MN2BD153J
VRD-MN2BD103J
VRD-MN2BD472J
VRD-MN2BD222J
VRD-ST2CD562J
VRD-MN2BD331J
VRD-MN2BD223J
VRD-MN2BD222J
VRD-MN2BD223J
VRD-RT2HD561J
VRD-MN2BD822J
VRD-MN2BD393J
VRD-MN2BD331J
VRD-ST2CD224J
VRD-MN2BD223J
VRD-MN2BD473J
VRD-MN2BD223J
VRD-MN2BD473J
VRD-ST2CD102J
VRD-MN2BD104J
VRD-ST2CD102J
VRD-ST2CD102J
VRD-MN2BD102J
VRD-MN2BD223J
VRD-MN2BD102J
VRD-ST2CD330J
VRD-MN2BD103J
VRD-MN2BD103J
VRD-MN2BD104J
VRD-MN2BD103J
VRD-ST2CD103J
VRD-MN2BD102J
VRD-ST2CD222J
VRD-ST2CD182J
VRD-MN2BD102J
VRD-ST2CD102J
VRD-MN2BD103J
VRD-MN2BD102J
VRD-ST2CD102J
VRD-ST2CD103J
VRD-MN2BD103J
VRD-ST2CD332J
VRD-ST2CD103J
VRD-MN2BD103J
VRD-ST2CD103J
VRD-MN2BD122J
VRD-MN2BD103J
VRD-ST2CD102J
VRD-ST2CD103J
VRD-MN2BD821J
VRD-ST2CD102J
VRD-MN2BD102J
VRD-ST2CD102J
VRD-MN2BD473J
VRD-MN2BD104J
VRD-MN2BD101J
VRD-MN2BD472J
VRD-ST2CD101J
VRD-ST2CD222J
VRD-ST2CD123J
VRD-ST2CD102J
VRD-ST2EE100J
VRD-RT2HD3R3J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
DESCRIPTION
NO.
56 kohms,1/6W
33 kohms,1/8W
68 kohms,1/6W
470 kohms,1/6W
15 kohms,1/6W
390 kohms,1/8W
390 kohms,1/8W
2.2 Mohms,1/8W
270 kohms,1/8W
220 kohms,1/8W
220 kohms,1/8W
2.2 Mohms,1/8W
560 kohms,1/8W
330 ohms,1/4W
100 kohm,1/8W
1.5 kohms,1/8W
2.2 kohms,1/8W
10 kohm,1/8W
330 ohms,1/8W
15 kohms,1/8W
10 kohm,1/8W
4.7 kohms,1/8W
2.2 kohms,1/8W
5.6 kohms,1/6W
330 ohms,1/8W
22 kohms,1/8W
2.2 kohms,1/8W
22 kohms,1/8W
560 ohms,1/2W
8.2 kohms,1/8W
39 kohms,1/8W
330 ohms,1/8W
220 kohms,1/6W
22 kohms,1/8W
47 kohms,1/8W
22 kohms,1/8W
47 kohms,1/8W
1 kohm,1/6W
100 kohm,1/8W
1 kohm,1/6W
1 kohm,1/6W
1 kohm,1/8W
22 kohms,1/8W
1 kohm,1/8W
33 ohms,1/6W
10 kohm,1/8W
10 kohm,1/8W
100 kohm,1/8W
10 kohm,1/8W
10 kohm,1/6W
1 kohm,1/8W
2.2 kohms,1/6W
1.8 kohms,1/6W
1 kohm,1/8W
1 kohm,1/6W
10 kohm,1/8W
1 kohm,1/8W
1 kohm,1/6W
10 kohm,1/6W
10 kohm,1/8W
3.3 kohms,1/6W
10 kohm,1/6W
10 kohm,1/8W
10 kohm,1/6W
1.2 kohms,1/8W
10 kohm,1/8W
1 kohm,1/6W
10 kohm,1/6W
820 ohms,1/8W
1 kohm,1/6W
1 kohm,1/8W
1 kohm,1/6W
47 kohms,1/8W
100 kohm,1/8W
100 ohm,1/8W
4.7 kohms,1/8W
100 ohm,1/6W
2.2 kohms,1/6W
12 kohms,1/6W
1 kohm,1/6W
10 ohm,1/4W
3.3 ohms,1/2W
!
R851
R852,853
R854
R855
R901,902
R903,904
R905,906
R907,908
R909,910
R911
R912,913
R915,916
R917,918
R919,920
R921,922
R923
R925~928
R929,930
R931,932
R933,934
R935,936
R937
R938
R939
R941,942
R943
R953,954
R955,956
R957
R958
R959
R960
R961,962
RD01
RD02
RD03
RD04
RD05
RD06
RD07
RD09
RD10
RD11
RD12
RD13
RD14
RD15
RD16
RD21
RD22
RD23
RD24
RD25
RD26
RD27
RD28
RS701~703
RS704,705
RS706
RS707
RS711
RS712
PRICE
RANK
PARTS CODE
VRD-ST2CD330J
VRD-ST2CD223J
VRD-ST2CD103J
VRD-RT2HD3R3J
VRD-ST2CD102J
VRD-ST2CD563J
VRD-ST2CD102J
VRD-ST2CD391J
VRD-ST2CD563J
VRD-ST2CD333J
VRG-ST2EC101J
VRD-ST2CD392J
VRN-VV3LAR10J
VRD-ST2CD152J
VRD-ST2CD472J
VRD-ST2CD563J
VRD-RT2HD100J
VRD-ST2CD563J
VRD-RT2HD4R7J
VRD-ST2CD472J
VRD-RT2HD221J
VRD-ST2CD153J
VRD-ST2CD683J
VRD-ST2CD392J
VRS-VV3DA561J
VRS-VV3DA681J
VRD-ST2CD332J
VRD-ST2CD102J
VRD-ST2CD104J
VRD-ST2CD681J
VRD-ST2CD822J
VRD-ST2CD103J
VRD-ST2CD393J
VRD-ST2CD821J
VRD-MN2BD122J
VRD-MN2BD152J
VRD-MN2BD182J
VRD-MN2BD222J
VRD-MN2BD332J
VRD-ST2CD392J
VRD-MN2BD682J
VRD-MN2BD821J
VRD-MN2BD122J
VRD-MN2BD152J
VRD-ST2CD182J
VRD-ST2CD222J
VRD-MN2BD332J
VRD-ST2CD392J
VRD-MN2BD821J
VRD-MN2BD122J
VRD-ST2CD152J
VRD-ST2CD182J
VRD-MN2BD222J
VRD-ST2CD332J
VRD-MN2BD392J
VRD-MN2BD682J
VRD-MN2BD102J
VRD-ST2CD102J
VRD-MN2BD102J
VRD-ST2CD102J
VRD-ST2CD152J
VRD-MN2BD122J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
DESCRIPTION
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AC
AC
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
33 ohms,1/6W
22 kohms,1/6W
10 kohm,1/6W
3.3 ohms,1/2W
1 kohm,1/6W
56 kohms,1/6W
1 kohm,1/6W
390 ohms,1/6W
56 kohms,1/6W
33 kohms,1/6W
100 ohm,1/4W,Fusible
3.9 kohms,1/6W
0.1 ohm,3W
1.5 kohms,1/6W
4.7 kohms,1/6W
56 kohms,1/6W
10 ohm,1/2W
56 kohms,1/6W
4.7 ohms,1/2W
4.7 kohms,1/6W
220 ohms,1/2W
15 kohms,1/6W
68 kohms,1/6W
3.9 kohms,1/6W
560 ohms,2W
680 ohms,2W
3.3 kohms,1/6W
1 kohm,1/6W
100 kohm,1/6W
680 ohms,1/6W
8.2 kohms,1/6W
10 kohm,1/6W
39 kohms,1/6W
820 ohms,1/6W
1.2 kohms,1/8W
1.5 kohms,1/8W
1.8 kohms,1/8W
2.2 kohms,1/8W
3.3 kohms,1/8W
3.9 kohms,1/6W
6.8 kohms,1/8W
820 ohms,1/8W
1.2 kohms,1/8W
1.5 kohms,1/8W
1.8 kohms,1/6W
2.2 kohms,1/6W
3.3 kohms,1/8W
3.9 kohms,1/6W
820 ohms,1/8W
1.2 kohms,1/8W
1.5 kohms,1/6W
1.8 kohms,1/6W
2.2 kohms,1/8W
3.3 kohms,1/6W
3.9 kohms,1/8W
6.8 kohms,1/8W
1 kohm,1/8W
1 kohm,1/6W
1 kohm,1/8W
1 kohm,1/6W
1.5 kohms,1/6W
1.2 kohms,1/8W
AF
AF
AL
AG
AG
AF
AE
AG
AL
AB
AB
AC
AC
AC
AC
AG
AC
Connector Ass’y,2Pin
Connector Ass’y,6/6Pin
Connector Ass’y,15/15Pin
Connector Ass’y,3/3Pin
Connector Ass’y,8/12Pin
Connector Ass’y,6/6Pin
Connector Ass’y,3/3Pin
Connector Ass’y,8/8Pin
Connector Ass’y,6/10/2Pin
Plug,5Pin
Plug,8Pin
Plug,6Pin
Plug,6Pin
Plug,10Pin
Plug,6Pin
Plug,15Pin
Plug,3/2Pin
OTHER CIRCUITRY PARTS
BI1B
BI11/CNS11
BI12/CNS12
BI99/CNS99
BI702/CNSM1
BI704/CNS704
BI801/CNS801
BI802/CNS802
BIM5/CNS10/CNS5
CNP1
CNP2
CNP3
CNP3A
CNP10
CNP11
CNP12
CNP99/BI1A
–4–
QCNWN1473AWZZ
QCNWN1487AWZZ
QCNWN1381AWZZ
QCNWN1486AWZZ
QCNWN1386AWZZ
QCNWN1426AWZZ
QCNWN1428AWZZ
QCNWN1429AWZZ
QCNWN1184AWZZ
92LCONE5P53253
QCNCM705HAFZZ
92LCONE6P53253
92LCONE6P53254
QCNCM705KAWZZ
QCNCM704FAWZZ
QCNCM704QAWZZ
QCNCM704CAWZZ
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
CD-C662
NO.
!
!
!
PRICE
RANK
PARTS CODE
CNP101
CNP102
CNP301
CNP701
CNP704
CNP801
CNP802
CNP901
CNP903
CNPM1
CNPM2
CNS1A/B
CNS2A/B
CNS3A/B
CNS101
CNS102
CNS701
CNS901
CNS903
F801
F804,805
F806
FFC701
FL701
FW703
FWM1
FWM2
IC99
92LCONE3P53253 J
92LCONE7P53253 J
92LCONE-3P5268 J
QCNCWZG24AWZZ J
QCNCM705FAFZZ J
QCNCM035CAWZZ J
QCNCM035HAWZZ J
QCNCM010NAWZZ J
92LCONE2P53253 J
QCNCM932MAFZZ J
QCNCM030BAWZZ J
QCNWN1181AWZZ J
QCNWN1182AWZZ J
QCNWN1183AWZZ J
QCNWN1187AWZZ J
QCNWN1188AWZZ J
QCNCWZF24AWZZ J
QCNCW010NAWZZ J
QCNWN1452AWZZ J
QFS-D502CSJNI
J
QFS-D502CSJNI
J
QFS-D202DSJNI
J
QCNWN1453AWZZ J
VVKBJ685GNK-1
J
QCNWN1427AWZZ J
QCNWN1274AWZZ J
QCNWN0338AWZZ J
VHPGP1F32T/-1
J
AB
AC
AC
AE
AB
AB
AB
AC
AB
AE
AB
AK
AH
AG
AG
AM
AE
AC
AC
AC
AC
AD
JK601
JK671
JOG701
LUG901
M1
M2
M3
QSOCJ0213AWZZ
QJAKM0008AWZZ
QSW-Z0007AWZZ
QLUGP0001AWZZ
92LMTR1858CASY
92LMTR1854BASY
92LMTR3022AS1
J
J
J
J
J
J
J
AE
AF
AC
AS
AP
AU
M901
MM1(260-7)
PHM1
PIN103
RL801
RL901
RX701
SO901
SOLM1(260-8)
SOLM2
SW1
SW2
92LMTR1810A
RMOTV0006AWM1
VHPI31535CD-1
QLUGP0002AWZZ
RRLYD0012AWZZ
RRLYD0004AWZZ
VHLN63H380A-1
QTANA0401AWZZ
RPLU-0002AWZZ
RPLU-0002AWZZ
QSW-P0004AWZZ
QSW-F0001AWZZ
J
J
J
J
J
J
J
J
J
J
J
J
AK
AR
AG
AB
AM
AP
AK
AG
AH
AH
AE
AD
SW3
SW4
SW701
SW703
SW704
QSW-P0005AWZZ
QSW-F9001AW01
92LSWICH1401AT
92LSWICH1401AT
92LSWICH1401AT
J
J
J
J
J
AD
AD
AC
AC
AC
SW705
SW706
SW707
SW708
SW709
92LSWICH1401AT
92LSWICH1401AT
92LSWICH1401AT
92LSWICH1401AT
92LSWICH1401AT
J
J
J
J
J
AC
AC
AC
AC
AC
SW710
SW711
SW712
92LSWICH1401AT J
92LSWICH1401AT J
92LSWICH1401AT J
AC
AC
AC
SW713
SW714
92LSWICH1401AT J
92LSWICH1401AT J
AC
AC
SW715
SW716
SW717
SW722
SW723
SW724
92LSWICH1401AT
92LSWICH1401AT
92LSWICH1401AT
92LSWICH1401AT
92LSWICH1401AT
92LSWICH1401AT
J
J
J
J
J
J
AC
AC
AC
AC
AC
AC
SW725
SW728
92LSWICH1401AT J
92LSWICH1401AT J
AC
AC
SW729
SW730
SWM3(260-9)
92LSWICH1401AT J
92LSWICH1401AT J
92LM-SW1676A
J
AC
AC
AC
AV
AD
AC
AD
AP
DESCRIPTION
Plug,3Pin
Plug,7Pin
Plug,3Pin
Socket,24Pin
Plug,6Pin
Plug,3Pin
Plug,8Pin
Plug,13Pin
Plug,2Pin
Plug,12Pin
Pin Header,2Pin
Connector Ass’y,5/5Pin
Connector Ass’y,8/8Pin
Connector Ass’y,6/6Pin
Socket,3Pin
Socket,7Pin
Socket,24Pin
Socket,13Pin
Socket,2Pin
Fuse,5A/125V
Fuse,5A/125V
Fuse,2A/250V
Flat Cable,24Pin
FL Display
Flat Wire,6Pin
Flat Cable,2Pin
Flat Cable,2Pin
Optical Fiber Data Link,
GP1F32T
Jack,Video/AUX
Jack,Headphones
Switch,Push Type [Volume Jog]
Lug Terminal
Motor with Chassis [Spindle]
Motor with Gear [Sled]
Motor with Worm Pulley
[T/T Up/Down Loading]
Motor,Air Cooling Fan
Motor with Pulley [Tape]
Photo Interrupter
Lug Pin
Relay
Relay
Remote Sensor,N63H380A
Terminal,Speaker
Solenoid Ass’y [Tape]
Solenoid Ass’y [CD]
Switch,Push Type [Open/Close]
Switch,Leaf/Skeleton Type
[Mecha Up]
Switch,Push Type [Disc Number]
Switch,Leaf Type [Pickup In]
Switch,Key Type [POWER]
Switch,Key Type [CLOCK]
Switch,Key Type
[TIMER/SLEEP]
Switch,Key Type [DISC 1]
Switch,Key Type [DISC 2]
Switch,Key Type [DISC 3]
Switch,Key Type [DISC SKIP]
Switch,Key Type
[OPEN/CLOSE]
Switch,Key Type [REW]
Switch,Key Type [REC PAUSE]
Switch,Key Type
[MEMORY/SET]
Switch,Key Type [STOP]
Switch,Key Type
[TUNER (BAND)]
Switch,Key Type [VIDEO/AUX]
Switch,Key Type [TAPE]
Switch,Key Type [CD]
Switch,Key Type [FF]
Switch,Key Type [TUNING UP]
Switch,Key Type
[TUNING DOWN]
Switch,Key Type [PLAY]
Switch,Key Type
[X-BASS/DEMO]
Switch,Key Type [EQUALIZER]
Switch,Key Type [DIMMER]
Switch,Leaf Type [Fool Proof]
NO.
PRICE
RANK
PARTS CODE
SWM4(260-10) QSW-F9003AWZZ
SWM5(260-11) 92LM-SW1658A
DESCRIPTION
J
J
AG Switch,Leaf Type [F.A.S.]
AB Switch,Leaf Type [CAM]
CD MECHANISM PARTS
!
301
302
303
304
305
306
306- 1
NGERH0011AWZZ
NGERH0012AWZZ
MLEVP0010AWZZ
NSFTM0002AWFW
92LM-CUSN1524A
92LHPC1MASY
————
J
J
J
J
J
J
AC
AC
AC
AE
AC
BG
—
Gear,Middle
Gear,Drive
Rail,Guide
Shaft,Guide
Cushion
Pickup Unit Ass’y
Pickup Unit
(Not Replacement Item)
Gear,Rack
Spring,Rack
Screw,ø2.6×6mm
Screw,ø2×5mm
Screw,ø2×3mm
Washer,ø1.5×ø3.8×0.25mm
Motor with Chassis [Spindle]
Motor with Gear [Sled]
Switch,Leaf Type [Pickup In]
306- 2
306- 3
701
702
703
704
M1
M2
SW4
NGERR0043AFZZ
MSPRC0961AFZZ
XBSSD26P06000
XHBSD20P05000
XBBSD20P03000
LX-WZ1070AFZZ
92LMTR1858CASY
92LMTR1854BASY
QSW-F9001AW01
J
J
J
J
J
J
J
J
J
AC
AA
AA
AA
AA
AA
AS
AP
AD
AM CD Player Base
BB Front Panel Ass’y
— Front Panel
(Not Replacement Item)
AE Button,Disc No.
AE Button,Open/Close/Disc Skip
AE Button,Power
AE Button,X-BASS/Demo
AG Button,FF/REW/Tuning
AD Button,Timer/Sleep/Clock
AD Button,Dimmer/Equalizer
AK Button,Function
AC Operation Ring A
AF Operation Ring B
AD Cap,Operation Center
AD Cover,LED
AE Panel,Center Cap
AH Panel,Decoration
AF Decoration,Play Button
AE Decoration,Stop Button
AH Panel,AMP.
AC Panel,Play Decoration
AC Panel,Stop Decoration
AC Sheet,Reflector
AN Cassette,Holder Ass’y,Tape 1
— Cassette Holder,Tape 1
(Not Replacement Item)
AH Cassette Cover,Tape 1
AD Panel,Cassette,Tape 1
AN Cassette,Holder Ass’y,Tape 2
— Cassette Holder,Tape 2
(Not Replacement Item)
AH Cassette Cover,Tape 2
AD Panel,Cassette,Tape 2
Button,Volume Ass’y
— Button,Volume
(Not Replacement Item)
AA Spring,Ring
Refelector B
AB Spring,Cassette,Tape 1
AB Spring,Cassette,Tape 2
AB Stabilizer Ass’y
— Stabilizer
(Not Replacement Item)
AF Magnet,Stabilizer
AA Support,Stabilizer Magnet
AC Lever,Lock
AG Chassis,CD Mechanism
AB Support,Pitch
AE Lever,Shift
AB Lever,Change
AB Spring,Solenoid
AC Belt,Drive
AD Gear,Cam
AB Gear,Turntable
AC Gear,Drive
CABINET PARTS
201
202
202- 1
GCAB-1044AWSA
92LCAB3081AS1
————
J
J
202- 2
202- 3
202- 4
202- 5
202- 6
202- 7
202- 8
202-10
202-11
202-12
202-13
202-14
202-15
202-16
202-17
202-18
202-19
202-20
202-21
202-22
203
203- 1
JKNBZ0557AWSA
JKNBZ0558AWSA
JKNBZ0559AWSA
JKNBZ0560AWSA
JKNBZ0563AWSA
JKNBZ0622AWSA
JKNBZ0621AWSA
KNOB3051AASY1
HDECQ0412AWSA
HDECQ0413AWSA
HDECQ0414AWSA
HDECQ0415AWSA
HDECQ0417AWSA
HDECQ0418AWSC
HDECQ0419AWSA
HDECQ0420AWSA
HDECQ0467AWSA
HDECQ0457AWSA
HDECQ0458AWSA
PSHEP0031AWZZ
92LMEC3051CTS1
————
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
203- 2
203- 3
204
204- 1
GCOVA1221AWSB J
HDECQ0408AWSA J
92LMEC3051CTS2 J
————
204- 2
204- 3
205
205- 1
GCOVA1222AWSB J
HDECQ0409AWSA J
92LKNOB3081BS1 J
————
205- 2
205- 3
206
207
208
208- 1
92LCSPR1431C
GCOVA1233AWZZ
MSPRD0092AWFJ
MSPRD0093AWFJ
92LHOLD3022AS1
————
J
J
J
J
J
208- 2
208- 3
209
210
211
212
213
214
215
216
217
218
PMAGF0001AWZZ
92LSUPT1749D
MLEVP0067AWZZ
LCHSZ0011AWZZ
LHLDZ1141AWZZ
MLEVP0066AWZZ
MLEVP0068AWZZ
MSPRC0024AWFW
NBLTK0033AWZZ
NGERH0064AWZZ
NGERH0065AWZZ
NGERK0003AWZZ
J
J
J
J
J
J
J
J
J
J
J
J
–5–
CD-C662
NO.
!
!
PRICE
RANK
PARTS CODE
219
220
221
222
223
224
225
226
227
228
229
230
231
232
233
233- 1
NGERK0004AWZZ
NGERK0005AWZZ
NGERW0006AWZZ
NPLYD0002AWZZ
LANGF0032AWZZ
LCHSZ0010AWZZ
LHLDZ1140AWZZ
MLEVP0070AWZZ
MSPRC0020AWFJ
MSPRD0044AWFJ
NROLP0009AWZZ
NTNT-0018AWSA
PCOVZ1013AWZZ
PCUSG0022AWZZ
92LCOV3022AS1
————
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
AB
AB
AC
AC
AC
AM
AB
AB
AB
AB
AB
AK
AB
AB
AM
—
233- 2
233- 3
233- 4
234
235
236
239
240
240- 1
92LBADGE1671A
GCOVA1224AWSA
GCOVA1225AWSA
GCAB-1052AWSA
GCOVA1232AWZZ
92LN-BAND1318A
PCUSG0022AWZZ
92LCAB3081BS1
————
J
J
J
J
J
J
J
J
AC
AE
AE
AP
AC
AA
AB
240- 2
241
241- 1
PCUSG0022AWZZ J
92LCAB3081CS1
J
————
AB
241- 2
242
243
245
246
247
247
248
249
250
252
253
254
255
256
257
258
259
260
260- 1
260- 2
260- 3
260- 4
260- 5
260- 6
260- 7(MM1)
260- 8(SOLM1)
260- 9(SWM3)
260-10(SWM4)
260-11(SWM5)
262
263
264
266
267
601
603
604
605
606
607
608
610
611
612
613
614
615
616
617
618
PCUSG0022AWZZ
LANGK0059AWFW
LBSHC0005AWZZ
LCHSM0088AWFW
NFANP0001AWZZ
GITAR0462AWSA
GITAR0466AWSA
QFSHD0001AWZZ
QACCD0022AWZZ
PRDAR0095AWFW
PRDAR0140AWFW
92LCSPR1431C
LHLDZ1226AWZZ
LHLDZ1227AWZZ
LHLDZ1228AWZZ
LHLDZ1229AWZZ
LHLDZ1213AWZZ
LHLDZ1204AWSA
92LMEC2744AS1
NBLTK0011AWZZ
NBLTK0012AWZZ
NBLTK0030AWZZ
NROLY0002AWZZ
RHEDA0001AWZZ
92LMRPH1746A
RMOTV0006AWM1
RPLU-0002AWZZ
92LM-SW1676A
QSW-F9003AWZZ
92LM-SW1658A
MLIFP0006AWZZ
LANGK0057AWFW
LANGK0058AWFW
LHLDF1001AWZZ
QCNWN1481AWZZ
XJBSF30P10000
XJBSD30P08000
XJBSD30P10000
LX-HZ0082AFZZ
LX-JZ0010AFFD
XBBSD20P04000
XJBSF30P10000
XESSD30P10000
XJSSF30P10000
XWHJZ62-09510
XEBSD30P10000
LX-JZ0002AWFD
LX-EZ0005AWFD
XEBSD30P12000
XBPSD26P05JSO
LX-TZ0019AFZZ
AB
AD
AD
AR
AD
AN
—
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
—
AB
AM
BB
AG
AA
AC
AC
AC
AC
AE
AD
BK
AC
AB
AC
AF
AG
AM
AR
AH
AC
AG
AB
AE
AE
AE
AC
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AA
AA
AA
AB
AB
DESCRIPTION
NO.
Gear,Bevel
Gear,Loading
Gear,Worm Wheel
Pulley
Support,T/T Lock Lever
Chassis,Loading
Guide
Lever,T/T Lock
Spring,T/T Lock Lever
Spring,Lock Lever
Roller
Turntable
Cover,Wire
Cushion,Leg
CD Tray Cover Ass’y
Cover,CD Tray
(Not Replacement Item)
Badge,SHARP
Cover,CD Tray Panel,Left
Cover,CD Tray Panel,Right
Top Cabinet
Cover,Volume Refector A
Nylon Band,80mm
Cushion,Leg
Side Panel Ass’y,Left
Side Panel,Left
(Not Replacement Item)
Cushion,Leg
Side Panel Ass’y,Right
Side Panel,Right
(Not Replacement Item)
Cushion,Leg
Bracket,Motor Fan Support
Bushing,AC Power Supply Cord
Main Chassis
Rotary Fan
Rear Panel [For U.S.A.]
Rear Panel [Except for U.S.A.]
Holder,Fuse
AC Power Supply Cord
Heat Sink,Main
Heat Sink,Sub
Spring,Ring
Holder,Multi Indicator
Holder,Volume
Holder,Play,Stop
Holder,Function
Holder,FL
Bracket,Stabilizer
Tape Mechanism Ass’y
Belt,Main
Belt,Main
Belt,Sub
Pinch Roller Ass’y
Head,Erase
Head,Record/Playback
Motor with Pulley [Tape]
Solenoid Ass’y [Tape]
Switch,Leaf Type [Fool Proof]
Switch,Leaf Type [F.A.S.]
Switch,Leaf Type [CAM]
Damper,Cassette Holder
Bracket,Heat Sink,A
Bracket,Heat Sink,B
Holder,PWB
Lug Wire
Screw,ø3×10mm
Screw,ø3×8mm
Screw,ø3×10mm
Screw,ø4×8mm
Screw,ø3×10mm
Screw,ø2×4mm
Screw,ø3×10mm
Screw,ø3×10mm
Screw,ø3×10mm
Washer,ø6.2×ø10×0.9mm
Screw,ø3×10mm
Screw,ø3×10mm
Screw,Special
Screw,ø3×12mm
Screw,ø2.6×5mm
Screw,Special
–6–
619
621
622
623
624
625
PRICE
RANK
PARTS CODE
XEBSD26P12000
XHBSD30P06000
XJBSF30P06000
XEBSF30P10000
XJSSD30P10000
XJBSD30P16000
DESCRIPTION
J
J
J
J
J
J
AA
AA
AA
AA
AA
AA
Screw,ø2.6×12mm
Screw,ø3×6mm
Screw,ø3×6mm
Screw,ø3×10mm
Screw,ø3×10mm
Screw,ø3×16mm
QANTL0007AWZZ
TCAUS0042AWZZ
TINSE0249AWZZ
TINSZ0419AWZZ
J
J
J
J
TINSZ0420AWZZ
TLABZ0558AWZZ
TLABZ0559AWZZ
TLABZ0560AWZZ
RRMCG0177AWSA
GFTAB1022AWSA
92L291-0084
J
J
J
J
J
J
J
AK AM/FM Loop Antenna
Caution,Energy Star
AE Operation Manual [For U.S.A.]
Operation Manual
[Except for U.S.A.]
AB Quick Guide [For U.S.A. Only]
AB Label,Feature,Tape 1
AB Label,Feature,Tape 2
Label,Feature,Amp.
AS Remote Control
Battery Lid,Remote Control
Speaker Cord Ass'y
ACCESSORIES
P.W.B. ASSEMBLY (Not Replacement Item)
PWB-A1~4
92LPWB3081MANS J
PWB-B1,2
92LPWB3081PWRS J
PWB-C
PWB-D
PWB-E
PWB-F
92LPWB3022CDUS
QPWBF0027AWZZ
QPWBF0341AWZZ
QPWBF0106AWZZ
—
J
J
J
J
Main/Display/Switch/Digital
Output (Combined Ass’y)
— Power Supply/Power Amp.
(Combined Ass’y)
— CD Servo
AD CD Motor (PWB Only)
AB Sensor (PWB Only)
AF Tape Mechanism (PWB Only)
J
AZ
Cabinet Ass’y
Front Panel
Support,Woofer
Net Frame Ass’y
Speaker Cord Ass’y with
Capacitors
Screw,ø3×10mm
AB Screw,ø4×16mm
AC Screw,ø4×16mm
Paper Pipe
AE Catching Holder
Felt
Label,Specification
Cushion
Woofer
Tweeter
OTHER SERVICE PART
UDSKA0004AFZZ
CD Pickup Lens Cleaner
CP-C662
SPEAKER BOX PARTS
901
902
903
904
905
92L051-0075
92L312-0077
92L302-0016
92L121-0173
92L122-0047
J
J
J
J
J
907
908
909
910
911
912
913
914
SP1,2
SP3,4
92L372-0109
92L372-0064
92L372-0100
92L316-0072
92L319-0027
92L391-0056
92L351-0333
92L394-0053
VSP0020WBA56A
VSP0080TBP36A
J
J
J
J
J
J
J
J
J
J
CD-C662
CD-C662
306-2
A
306
306-1
701
306-3
B
304
701
302
704
C
702
702
301
D
303
703x2
703x2
E
M1
F
305
M2
305x2
G
SW4
H
PWB-D
1
2
3
4
Figure 7 CD MECHANISM EXPLODED VIEW
–– 56
7 ––
5
6
CD-C662
CD-C662
240
PWB-A3
A
608x2
623x2
610x2
622x3
240-1
606
257
601x5
247
PWB-A2
B
PWB-A4
254
240-2
610x11
258
FL701
256
PWB-A1
202-14
255
202-15
202-13
C
202-11
202-6
Q852
202-7
Q851
608x2
202-5
202-4
202-12
202-21
202-18
D
603x3
202-2 202-10
Q850
202-3
252
202-20
202-17
249
PWB-F
267
202-8
Silicon
Grease
262
610x6
243
202-16
IC901 Silicon
Grease
202-19
250
625x2
E
606 604x2
202-1
260(260-1, 260-2, 260-3,
260-4, 260-5, 260-6,
260-7, 260-8, 260-9,
260-10, 260-11)
264
621
262
202-22
202
606
205
F
203-1
203-2
235
205-2
205-3
205-1
604x2
239x2
624x3
248x2
PWB-B1
621
621x2
M901
263
607x2
606x3
PWB-B2
606x2
253
206
G
605x4
242
248
x6
246
204-1
606
241
203-3
204-2
203
H
241-1
204
204-3
207
266
236
241-2
608x2
245
Note: Only the unit and consumale parts are supplied as aprts supply for the Tape mechanism.
1
2
3
4
Figure 8 CABINET EXPLODED VIEW (1/2)
–– 57
8 ––
5
6
CD-C662
CD-C662
259
611
208
A
208-3
208-2
601x2
208-1
612
234
230
B
226
SW3
229
C
229
227
229
233-3
601x2
233-2
233-1
233
233-4
D
201
614
228
CD
MECHANISM
618
E
619
217
613
223
225
229x2
603
215
211
218
209
219
229
618
219
216
615
F
222
221
231
212
213
SW2
225
220
232
617x2
G
229
224
613 210
M3
214
616x4
PWB-C
PWB-E
H
613
1
229
2
3
4
Figure 9 CABINET EXPLODED VIEW (2/2)
–– 58
9 ––
SOLM2
5
6
CD-C662
CP-C662
905
A
(with
Capacitor C1,2)
907x4
913
SP3,4
902
B
901
C
912
910
D
909x4
911x4
904
908x4
SP1,2
E
903
TWEETER
SP3(L-CH)
SP4(R-CH)
F
914
908x4
TWEETER
SP3(L-CH)
SP4(R-CH)
G
C1,2
Capacitor
3.3µF,100V,
Electrolytic (N.P.)
C1,2
Capacitor
BK
BK
RED
WOOFER
SP1(L-CH)
SP2(R-CH)
WOOFER
SP1(L-CH)
SP2(R-CH)
RED
BK
H
1
2
3
4
Figure 10 SPEAKER EXPLODED VIEW
59 ––
–– 10
5
6
CD-C662
PACKING OFF THE SET (FOR U.S.A. ONLY)
Setting position of switches and knobs
Tape Mechanism
STOP
UNIT
SPAKP0032AWZZ
Polyethylene bag
92LBAG1460C1
Polyethylene Bag.,
Accessories
FM/AM Loop Antenna
Quick Guide
Operation Manual
Energy Star Caution
Speaker Cord
SPAKA0214AWZZ
Packing Add.,(Left/Right)
SPAKZ0507AWZZ
Mira Mat
Bottom
FRONT SIDE OF
SPEAKERS
REMOTE
CONTROL
TOP
A
Feature Label
FRONT
Front Speaker(L/R)
CP-C662
B
A
92L411-0111
Polyethylene bag
SPAKZ0517AWZZ
Bottom Pad
TLABR1023AWZZ
Bar Code Label
92L414-0031
Sheet,Mira Mat
92L411-0130
Packing Add.
(Top/Bottom)
CK
BA
92L416-0064
Center Pad
SPAKC0764AWZZ
Packing Case
B
Not Replacement Item
COPYRIGHT © 1999 BY SHARP CORPORATION
SHARP CORPORATION
Communication Systems Group
Quality & Reliability Control Center
Higashihiroshima, Hiroshima 739-0192, Japan
Printed in Japan
ALL RIGHTS RESERVED.
No part of this publication may be reproduced,
stored in a retrieval system, or transmitted in
any form or by any means, electronic, mechanical,
photocopying, recording, or otherwise, without
prior written permission of the publisher.
A9904-2627NS•HA•M
SC • LAG
– 14
60 –
CD-C662
PACKING OFF THE SET (FOR U.S.A. ONLY)
Setting position of switches and knobs
Tape Mechanism
STOP
UNIT
SPAKP0032AWZZ
Polyethylene bag
92LBAG1460C1
Polyethylene Bag.,
Accessories
FM/AM Loop Antenna
Quick Guide
Operation Manual
Energy Star Caution
Speaker Cord
SPAKA0214AWZZ
Packing Add.,(Left/Right)
SPAKZ0507AWZZ
Mira Mat
Bottom
FRONT SIDE OF
SPEAKERS
REMOTE
CONTROL
TOP
A
Feature Label
FRONT
Front Speaker(L/R)
CP-C662
B
A
92L411-0111
Polyethylene bag
SPAKZ0517AWZZ
Bottom Pad
TLABR1023AWZZ
Bar Code Label
92L414-0031
Sheet,Mira Mat
92L411-0130
Packing Add.
(Top/Bottom)
CK
BA
92L416-0064
Center Pad
SPAKC0764AWZZ
Packing Case
B
Not Replacement Item
COPYRIGHT © 1999 BY SHARP CORPORATION
SHARP CORPORATION
Communication Systems Group
Quality & Reliability Control Center
Higashihiroshima, Hiroshima 739-0192, Japan
Printed in Japan
ALL RIGHTS RESERVED.
No part of this publication may be reproduced,
stored in a retrieval system, or transmitted in
any form or by any means, electronic, mechanical,
photocopying, recording, or otherwise, without
prior written permission of the publisher.
A9904-2627NS•HA•M
SC • LAG
– 14
60 –