Acer laptop_ Technical information

Acer
Aspire 4710/4310
Service Guide
Service guide files and updates are available
on the ACER/CSD web; for more information,
please refer to http://csd.acer.com.tw
PRINTED IN TAIWAN
Revision History
Please refer to the table below for the updates made on Travelmate 4720/4320 service guide.
Date
ii
Chapter
Updates
Copyright
Copyright © 2007 by Acer Incorporated. All rights reserved. No part of this publication may be reproduced,
transmitted, transcribed, stored in a retrieval system, or translated into any language or computer language, in
any form or by any means, electronic, mechanical, magnetic, optical, chemical, manual or otherwise, without
the prior written permission of Acer Incorporated.
iii
Disclaimer
The information in this guide is subject to change without notice.
Acer Incorporated makes no representations or warranties, either expressed or implied, with respect to the
contents hereof and specifically disclaims any warranties of merchantability or fitness for any particular
purpose. Any Acer Incorporated software described in this manual is sold or licensed "as is". Should the
programs prove defective following their purchase, the buyer (and not Acer Incorporated, its distributor, or its
dealer) assumes the entire cost of all necessary servicing, repair, and any incidental or consequential
damages resulting from any defect in the software.
Acer is a registered trademark of Acer Corporation.
Intel is a registered trademark of Intel Corporation.
Core Duo and Core 2 Duo are trademarks of Intel Corporation.
Other brand and product names are trademarks and/or registered trademarks of their respective holders.
iv
Conventions
The following conventions are used in this manual:
SCREEN
MESSAGES
Denotes actual messages that appear on screen.
NOTE
Gives bits and pieces of additional information related to the current topic.
WARNING
Alerts you to any damage that might result from doing or not doing specific
actions.
CAUTION
Gives precautionary measures to avoid possible hardware or software
problems.
IMPORTANT
Reminds you to do specific actions relevant to the accomplishment of
procedures.
v
Preface
Before using this information and the product it supports, please read the following general information.
vi
1.
This Service Guide provides you with all technical information relating to the BASIC CONFIGURATION
decided for Acer's "global" product offering. To better fit local market requirements and enhance product
competitiveness, your regional office MAY have decided to extend the functionality of a machine (e.g.
add-on card, modem, or extra memory capability). These LOCALIZED FEATURES will NOT be covered
in this generic service guide. In such cases, please contact your regional offices or the responsible
personnel/channel to provide you with further technical details.
2.
Please note WHEN ORDERING FRU PARTS, that you should check the most up-to-date information
available on your regional web or channel. If, for whatever reason, a part number change is made, it will
not be noted in the printed Service Guide. For ACER-AUTHORIZED SERVICE PROVIDERS, your Acer
office may have a DIFFERENT part number code to those given in the FRU list of this printed Service
Guide. You MUST use the list provided by your regional Acer office to order FRU parts for repair and
service of customer machines.
Table of Contents
System Specification
Features
Your Acer Notebook Tour
Front View
Closed Front View
Left View
Right View
Rear Panel
Bottom Panel
Indicators
Easy-launch Buttons
Touchpad
Touchpad Basics
Using the Keyboard
Lock Keys and Embedded Numeric Keypad
Windows Keys
Hotkeys
Special Keys
Acer Empowering Technology
Empowering Technology Password
Acer eNet Management
Acer ePower Management
Acer eAudio Management
Acer ePresentation Management
Acer eDataSecurity Management
Acer eLock Management
Acer eRecovery Management
Acer eSettings Management
Windows Mobility Center
Using the System Utilities
Acer GridVista (dual-display compatible)
Launch Manager
Norton Internet Security
Hardware Specifications and Configurations
System Utilities
BIOS Setup Utility
Entering BIOS Setup
BIOS Setup Primary Menus
BIOS Setup Navigation Keys
Information Menu
Main Menu
Security Menu
Boot Menu
Exit Menu
Machine Disassembly and Replacement
Disassembly Requirements
General Information
Pre-disassembly Instructions
Disassembly Process
1
1
4
4
5
6
7
7
8
9
10
11
11
13
13
14
15
16
17
17
18
20
22
23
24
25
26
27
28
29
29
30
31
32
39
39
39
39
39
40
41
42
44
45
47
47
48
48
49
vii
External Module Disassembly Process
External Modules Disassembly Flowchart
Removing the Battery Pack
Removing the SD Dummy Card
Removing the Express Dummy Card
Removing the Lower Cover
Removing the DIMM
Removing the WLAN Board Module
Removing the Hard Disk Drive Module
Removing the Optical Drive Module
Main Unit Disassembly Process
Main Unit Disassembly Flowchart
Removing the CPU Heatsink Module
Removing the CPU
Removing the Keyboard
Removing the Middle Cover
Removing the Power Board
Removing the LCD Module
Separating the Upper Case from the Lower Case
Removing the Speaker Modules
Removing the Launch Board
Removing the Touchpad Board Module
Removing the Bluetooth Board
Removing the USB board
Removing the Mainboard
Removing the Modem Board
Removing the RTC Battery
LCD Module Disassembly Process
LCD Module Disassembly Flowchart
Removing the LCD Bezel
Removing the Inverter Board
Removing the LCD with Brackets
Removing the LCD Brackets
Removing the LCD Module Hinges
Removing the Antennas
Removing the Microphone
Troubleshooting
System Check Procedures
External CD/DVD-ROM Drive Check
Keyboard or Auxiliary Input Device Check
Memory Check
Power System Check
Touchpad Check
Power-On Self-Test (POST) Error Message
Index of Error Messages
Phoenix BIOS Beep Codes
Index of Symptom-to-FRU Error Message
Intermittent Problems
Undetermined Problems
System Block Diagram and Connector Locations
System Block Diagram
Board Layout
Top View
viii
50
50
51
52
52
53
54
55
56
57
59
59
60
61
62
63
64
64
66
69
70
72
73
74
76
77
79
81
81
82
83
84
87
87
88
89
91
92
92
92
92
93
94
95
96
98
102
106
107
109
109
110
110
Bottom View
FRU (Field Replaceable Unit) List
Aspire 4710/4310 Exploded Diagram
Aspire 4710 FRU List
Aspire 4710G FRU List
Aspire 4310 FRU List
Model Definition and Configuration
Aspire 4710/4310
Test Compatible Components
Microsoft® Windows® Vista™ Compatibility Test
Online Support Information
111
115
116
117
126
135
144
144
147
148
153
ix
x
Chapter 1
System Specification
Features
Below is a brief summary of the computer’s many feature:
Platform
T
Intel® Core™2 Duo Mobile Processor T7200/T7400/T7600 (4 MB L2 cache, 2/2.16/2.33 GHz, 667 MHz
FSB), T5300/T5500/T5600 (2 MB L2 cache, 1.73/1.66/1.83 GHz, 667 MHz FSB), T2350/2450 (2 MB L2
cache, 1.86/2 GHz), and Celeron M 520/530(1 MB L2 cache, 1.6/1.73 GHz supporting Intel 64
architecture
T
Mobile Intel PM945 Express chipset
T
Intel PRO/Wireless 3945ABG (dual-band tri-mode 802.11a/b/g) or 3945BG (dual-mode 802.11b/g)
Wi-Fi CERTIFIED® network connection, supporting Acer SignalUp™ wireless technology
Display and Graphics
T
14.1" WXGA high brightness (200-nits) Acer CrystalBrite™ TFT LCD, 1280 x 800 pixel resolution,
supporting simultaneous multi-window viewing via Acer GridVista™
T
ATI Mobility™ Radeon® HD2300 with up to 896 MB of HyperMemory™ (128 MB of dedicated GDDR2
VRAM, up to 768 MB of shared memory) supporting Microsoft® DirectX® 9 and PCI Express®
T
Dual independent display support
T
16.7 million colors
T
MPEG-2/DVD hardware-assisted capability (full decode)
T
S-video/TV-out (NTSC/PAL) support
T
Acer Arcade™ featuring Acer CinemaVision™ and Acer ClearVision™ technologies
Storage Subsystem
T
80/120/160 GB or larger hard disk drive
T
DVD-Super Multi double-layer drive
T
5-in-1 card reader supporting Secure Digital (SD), MultiMediaCard (MMC), Memory Stick® (MS),
Memory Stick PRO™ (MS PRO), xD-Picture Card™ (xD)
Audio
T
Dolby®-certified surround sound system with two built-in stereo speakers
T
Dolby Home Theater audio enhancement featuring Dolby Digital, Dolby Digital Live, Dolby PRO
LOGIC® II, Dolby Digital Stereo Creator, Dolby Headphone and Dolby Virtual Speaker technologies
T
Intel High Definition Audio support
T
S/PDIF (Sony/Philips Digital Interface) support for digital speakers
T
MS-Sound compatible
T
Acer PureZone technology with two built-in stereo microphones featuring beam forming, echo
cancellation, and noise suppression technologies
Chapter 1
1
Input Devices
T
88-/89-/93-key keyboard, with inverted "T" cursor layout; 2.5 mm (minimum) key travel
T
Seamless touchpad with 4-way scroll button
T
12 function keys, four cursor keys, two Windows® keys, hotkey controls, embedded numeric keypad,
international language support, independent US and Euro dollar sign keys, media control keys
T
Empowering Key
T
Easy-launch buttons: WLAN, Internet, email, Bluetooth, Acer Arcade™
Communication
T
Acer Video Conference featuring:
t
Integrated Acer CrystalEye webcam supporting Acer PrimaLite™ technology
t
Acer PureZone technology
t
Optional Acer Xpress VoIP phone
T
WLAN: Intel PRO/Wireless 3945ABG (dual-band tri-mode 802.11a/b/g), or 3945BG (dual-mode
802.11b/g) Wi-Fi CERTIFIED® network connection, supporting Acer SignalUp™ wireless technology
T
WPAN: Bluetooth® 2.0+EDR (Enhanced Data Rate) (for selected models)
T
LAN: Gigabit Ethernet; Wake-on-LAN ready
T
Modem: 56K ITU V.92 with PTT approval; Wake-on-Ring ready
I/O Interface
T
ExpressCard™/54 slot
T
5-in-1 card reader (SD™/MMC/MS/MS PRO/xD)
T
Four USB 2.0 ports
T
IEEE 1394 port
T
External display (VGA) port
T
S-video/TV-out (NTSC/PAL) port
T
Headphones/speaker/line-out port with S/PDIF support
T
Microphone-in jack
T
Line-in jack
T
Ethernet (RJ-45) port
T
Modem (RJ-11) port
T
DC-in jack for AC adapter
Power Subsystem
T
ACPI 3.0 CPU power management standard: supports Standby and Hibernation power-saving modes
T
44.4 W 4000 mAh Li-ion battery pack (6-cell)
T
3-pin 90 W AC adapter supporting Acer QuicCharge™ technology (for selected models):
t
80% charge in 1 hour
t
2-hour rapid charge system-off
t
3-hour charge-in-use
Dimensions and weight
2
T
Width: 344 mm (13.5 inches)
T
Depth: 246 mm (9.7 inches)
Chapter 1
T
Height: 37/42 mm (1.45/1.65 inches)
T
Weight (approximately, with 6-cell battery): 2.65 kg (6.0 lbs.) (configuration may vary by models)
Environment
T
T
Chapter 1
Temperature:
t
Operating: 5 ° C to 35 ° C
t
Non-operating: -20 ° C to 65 ° C
Humidity (non-condensing):
t
operating: 20% to 80%
t
Non-operating: 20% to 80%
3
Your Acer Notebook Tour
After knowing your computer features, let us show you around your new Aspire computer.
Front View
4
#
Item
Description
1
Acer PureZone
Internal microphone for sound recording.
2
Display screen
Also called Liquid-Crystal Display (LCD), displays computer output.
3
Power button
Turns the computer on and off.
4
Status indicators
Light-Emitting Diodes (LEDs) that light up to show the status of the
computer's functions and components.
5
Empowering key
Launch Acer Empowering Technology.
6
Easy-launch buttons
Buttons for launching frequently used programs.
7
Palmrest
Comfortable support area for your hands when you use the computer.
8
Status indicators
Light-Emitting Diodes (LEDs) that light up to show the status of the
computer's functions and components.
9
Click buttons (left, center
and right)
The left and right buttons function like the left and right mouse buttons;
the center button serves as a 4-way scroll button.
10
Touchpad
Touch-sensitive pointing device which functions like a computer mouse.
11
Keyboard
For entering data into your computer.
12
Speakers
Left and right speakers deliver stereo audio output.
Chapter 1
Closed Front View
#
1
Icon
Item
Description
Unlimited volume control
wheel
Adjust the volume of the audio-out.
2
Latch
Locks and releases the lid.
3
Line-in jack
Accepts audio line-in devices (e.g., audio CD player, stereo
walkman, mp3 player)
4
Microphone jack
Accepts inputs from external microphones.
5
Headphones/speaker/
line-out jack with
S/PDIF support
Connects to audio line-out devices
(e.g., speakers, headphones).
Chapter 1
5
Left View
#
6
Icon
Item
Description
1
Kensington lock slot
Connects to a Kensington-compatible computer security
lock.
2
External display (VGA)
port
Connects to a display device
(e.g., external monitor, LCD projector).
3
Modem (RJ-11) port
Connects to a phone line.
4
Ethernet (RJ-45) port
Connects to an Ethernet 10/100/1000-based network.
5
S-video/TV-out (NTSC/
PAL) port
Connects to a television or display device with S-video input.
6
2 USB 2.0 ports
Connect to USB 2.0 devices (e.g., USB mouse, USB
camera).
7
4-pin IEEE 1394 port
Connects to IEEE 1394 devices.
8
ExpressCard/54 slot
Accepts one ExpressCard/54 module.
9
5-in-1 card reader
Accepts Secure Digital (SD), MultiMediaCard (MMC),
Memory Stick (MS), Memory Stick Pro (MS PRO), and xDPicture Card.
Note: Only one card can operate at any given time.
Chapter 1
Right View
#
Icon
Item
Description
1
Optical drive
Internal optical drive; accepts CDs or DVDs.
2
Optical disk access
indicator
Lights up when the optical drive is active.
3
Optical drive eject button
Ejects the optical disk from the drive.
4
Emergency eject hole
Ejects the optical drive tray when the computer is turned off.
5
USB 2.0 ports
Connect to USB 2.0 devices (e.g., USB mouse, USB
camera).
6
DC-in jack
Connects to an AC adapter.
Rear Panel
#
Item
Description
1
Ventilation slots
Enable the computer to stay cool, even after prolonged use.
Chapter 1
7
Bottom Panel
#
8
Icon
Item
Description
1
Battery bay
Houses the computer's battery pack.
2
Battery release latch
Releases the battery for removal.
3
Battery lock
Locks the battery in position.
4
Memory compartment
Houses the computer's main memory.
5
Hard disk bay
Houses the computer’s hard disk (secured with screws)
6
Ventilation slots and
cooling fan
Enable the computer to stay cool, even after prolonged use.
Note: Do not cover or obstruct the opening of the fan.
Chapter 1
Indicators
The computer has four easy-to-read status indicators:
The front panel indicators are visible even when the computer cover is closed up.
Icon
Function
Description
Power
Indicates the computer's power status.
Battery
Indicates the computer's batttery status.
HDD
Indicates when the hard disk drive is active.
Num lock
Lights up when Num Lock is activated.
Caps lock
Lights up when Caps Lock is activated.
NOTE: Battery LED status during charging:
• Amber: Charging.
• Green: Charging complete.
Chapter 1
9
Easy-launch Buttons
There are several conveniently located easy-launch buttons. They are: mail, Web browser, Empowering Key
<
> and one user-programmable button.
Press <
> to run the Acer Empowering Technology. The mail and Web browser buttons are pre-set to email
and Internet programs, but can be reset by users. To set the Web browser, mail and programmable buttons,
run the Acer Launch Manager.
Icon
10
Function
Description
Wireless communication button/
indicator
Enables/disables the wireless function. Indicates the
status of wireless LAN communication.
Web browser
Internet browser (user-Programmable)
Mail
Email application (user-Programmable)
Bluetooth communication
button/indicator
Enables/disables the Bluetooth function. Indicates the
status of Bluetooth communication.
Empowering Technology
Launch Acer Empowering Technology.
(user-programmable)
Acer Arcade
Launch Acer Arcade utility
Chapter 1
Touchpad
The built-in touchpad is a pointing device that senses movement on its surface. This means the cursor
responds as you move your finger across the surface of the touchpad. The central location on the palmrest
provides optimum comfort and support.
Touchpad Basics
The following teaches you how to use the touchpad:
T
Move your finger across the touchpad (2) to move the cursor.
T
Press the left (1) and right (4) buttons located beneath the touchpad to perform selection and execution
functions. These two buttons are similar to the left and right buttons on a mouse. Tapping on the
touchpad is the same as clicking the left button.
T
Use the 4-way scroll (3) button (for selected models) or Acer BioProtect fingerprint reader (3) supporting
Acer FingerNav 4-way control function (for selected models) to scroll up or down and move left or right a
page. This button or fingerprint reader mimics your cursor pressing on the right scroll bar of Windows
applications.
Chapter 1
11
Right Button
(4)
Function
Left Button (1)
Execute
Click twice
quickly.
Tap twice (at the same
speed as double-clicking
the mouse button).
Select
Click once.
Tap once.
Drag
Click and hold,
then use finger to
drag the cursor
on the touchpad
Tap twice (at the same
speed as double-clicking
a mouse button) then
hold finger to the
touchpad on the second
tap to drag the cursor.
Access context
menu
Scroll
Main touchpad (2)
Center button (3)
Click once
Click and hold to
move up/down/left/
right.
NOTE: When using the touchpad, keep it - and your fingers - dry and clean. The touchpad is sensitive to finger
movement; hence, the lighter the touch, the better the response. Tapping too hard will not increase the
touchpad’s responsiveness.
NOTE: By default, vertical and horizontal scrolling is enabled on your touchpad. It can be disabled under
Mouse settings in Windows Control Panel.
12
Chapter 1
Using the Keyboard
The keyboard has full-sized keys and an embedded keypad, separate cursor keys, two Windows keys and
twelve function keys, and two special keys.
Lock Keys and Embedded Numeric Keypad
The keyboard has three lock keys which you can toggle on and off.
Lock Key
Description
Caps Lock
When Caps Lock is on, all alphabetic characters typed are in uppercase.
Num Lock
<Fn> + <F11>
When Num Lock is on, the embedded keypad is in numeric mode. The keys function as a
calculator (complete with the arithmetic operators +, -, *, and /). Use this mode when you
need to do a lot of numeric data entry. A better solution would be to connect an external
keypad.
Scroll Lock
<Fn> + <F12>
When Scroll Lock is on, the screen moves one line up or down when you press the up or
down arrow keys respectively. Scroll Lock does not work with some applications.
The embedded numeric keypad functions like a desktop numeric keypad. It is indicated by small characters
located on the upper right corner of the keycaps. To simplify the keyboard legend, cursor-control key symbols
are not printed on the keys.
Desired Access
Num Lock On
Num Lock Off
Number keys on embedded
keypad.
Type numbers in a normal
manner.
N/A
Cursor-control keys on embedded
keypad
Hold <Shift> while using cursorcontrol keys.
Hold <Fn> while using cursorcontrol keys.
Main keyboard keys
Hold <Fn> while typing letters on
embedded keypad.
Type the letters in a normal
manner.
Chapter 1
13
Windows Keys
The keyboard has two keys that perform Windows-specific functions.
Key
Windows key
Icon
Description
Pressed alone, this key has the same effect as clicking on the Windows
Start button; it launches the Start menu.
It can also be used with other keys to provide a variety of functions:
<
> : Open or close the Start menu
<
> + <D>: Display the desktop
<
> + <E>: Open Windows Explore
<
> + <F>: Search for a file or folder
<
> + <G>: Cycle through Sidebar gadgets
<
> + <L>: Lock your computer (if you are connected to a network
domain), or switch users (if you're not connected to a
network domain)
<
> + <M>: Minimizes all windows
<
> + <R>: Open the Run dialog box
<
> + <T>: Cycle through programs on the taskbar
<
> + <U>: Open Ease of Access Center
<
> + <X>: Open Windows Mobility Center
<
> + <BREAK>: Display the System Properties dialog box
<
> + <SHIFT+M>: Restore minimized windows to the desktop
<
> + <TAB>: Cycle through programs on the taskbar by using
Windows Flip 3-D
<
> + <SPACEBAR>: Bring all gadgets to the front and select
Windows Sidebar
<CTRL> + <
> + <F>: Search for computers (if you are on a network)
<CTRL> + <
> + <TAB>: Use the arrow keys to cycle through
programs on the taskbar by using Windows
Flip 3-D
Note: Depending on your edition of Windows Vista, some shortcuts may
not function as described.
Application key
14
This key has the same effect as clicking the right mouse button; it opens
the application's context menu.
Chapter 1
Hotkeys
The computer employs hotkeys or key combinations to access most of the computer's controls like screen
brightness, volume output and the BIOS utility.
To activate hotkeys, press and hold the <Fn> key before pressing the other key in the hotkey combination.
Hot Key
Function
Description
Fn-F1
Hot key help
Displays help on hot keys.
Fn-F2
Acer eSettings
Launches the Acer eSettings in Acer eManager.
Fn-F3
Acer ePower
Management
Launches the Acer ePowerManagement in Acer
eManager.
Fn-F4
Sleep
Puts the computer in Sleep mode.
Fn-F5
Display toggle
Switches display output between the display screen,
external monitor (if connected) and both.
Fn-F6
Screen blank
Turns the display screen backlight off to save power.
Press any key to return.
Fn-F7
Touchpad toggle
Turns the internal touchpad on and off.
Fn-F8
Speaker toggle
Turns the speakers on and off.
Fn-w
Volume up
Increases the speaker volume.
Fn-y
Volume down
Decreases the speaker volume.
Fn-x
Brightness up
Increases the screen brightness.
Fn-z
Brightness down
Decreases the screen brightness
Chapter 1
Icon
15
Special Keys
You can locate the Euro symbol and the US dollar sign at the upper-center and/or bottom-right of your
keyboard.
The Euro symbol
1.
Open a text editor or word processor.
2.
Either press < > at the bottom-right of the keyboard, or hold <Alt Gr> and then press the <5> key at the
upper-center of the keyboard.
NOTE: Some fonts and software do not support the Euro symbol. Please refer to www.microsoft.com/
typography/faq/faq12.htm for more information.
The US dollar sign
1.
Open a text editor or word processor.
2.
Either press < > at the bottom-right of the keyboard, or hold <Shift> and then press the <4> key at the
upper-center of the keyboard.
NOTE: This function varies according to the language settings.
16
Chapter 1
Acer Empowering Technology
The Empowering Technology toolbar makes it easy for you to access frequently used functions and manage
your new Acer system. Displayed by default in the upper half of your screen, it provides access to the following
utilities:
T
Acer eNet Management hooks up to location-based networks intelligently.
T
Acer ePower Management optimizes battery usage via customizable power plans.
T
Acer ePresentation Management connects to a projector and adjusts display settings.
T
Acer eDataSecurity Management protects data with passwords and encryption.
T
Acer eLock Management limits access to external storage media.
T
Acer eRecovery Management backs up and recovers data flexibly, reliably
and completely.
T
Acer eSettings Management accesses system information and adjusts settings easily.
For more information, right click on the Empowering Technology toolbar, then select the "Help" or "Tutorial"
function.
Empowering Technology Password
Before using Acer eLock Management and Acer eRecovery Management, you must initialize the Empowering
Technology password. Right-click on the Empowering Technology toolbar and select "Password Setup" to do
so. If you have not initialized the Empowering Technology password and run Acer eLock Management or Acer
eRecovery Management, you will be asked to create it.
NOTE: If you lose the Empowering Technology password, there is no way to reset it except by reformatting
your system. Make sure to remember or write down your password!
Chapter 1
17
Acer eNet Management
Acer eNet Management helps you quickly connect to both wired and wireless networks in a variety of
locations. To access this utility, select "Acer eNet Management" from the Empowering Technology toolbar or
run the program from the Acer Empowering Technology program group in Start menu. You can also set Acer
eNet Management to start automatically when you boot up your PC.
Acer eNet Management automatically detects the best settings for a new location, while offering you the option
to manually adjust the settings to match your needs.
18
Chapter 1
Acer eNet Management can save network settings for a location to a profile, and automatically switch to the
appropriate profile when you move from one location to another. Settings stored include network connection
settings (IP and DNS settings, wireless AP details, etc.), as well as default printer settings. Security and safety
concerns mean that Acer eNet Management does not store username and password information.
Chapter 1
19
Acer ePower Management
Acer ePower Management features a straightforward user interface for configuring your power management
options. To access this utility, select "Acer ePower Management" from the Empowering Technology toolbar,
run the program from the Acer Empowering Technology program group in Start menu, or right-click the
Windows power icon in the system tray and select "Acer ePower Management".
Using Power Plans
Acer ePower Management comes with three predefined power plans: Balanced, High performance and Power
saver. You can also create customized power plans. You can create, switch between, edit, delete and restore
power plans, as described below.
View and adjust settings for On Battery and Plugged In modes by clicking the appropriate tabs. You can open
Windows power options by clicking "More Power Options".
NOTE: You cannot delete the predefined power plans.
To create a new power plan:
Creating customized power plans allows you to save and quickly switch to a personalized set of power
options.
1.
Click the Create Power Plan icon.
2.
Enter a name for your new power plan.
3.
Choose a predefined power plan to base your customized plan on.
4.
If necessary, change the display and sleep settings you want your computer to use.
5.
Click "OK" to save your new power plan.
To switch between power plans:
1.
Select the power plan you wish to switch to from the drop-down list.
2.
Click "Apply".
To edit a power plan:
Editing a power plan allows you to adjust system settings like LCD brightness and CPU speed. You can also
turn on/off system components to extend battery life.
1.
Switch to the power plan you wish to edit
2.
Adjust settings as required.
3.
Click "Apply" to save your new settings.
To delete a power plan:
You cannot delete the power plan you are currently using. If you want to delete the active power plan, switch to
another one first.
20
1.
Select the power plan you wish to delete from the drop-down list.
2.
Click the Delete Power Plan icon.
Chapter 1
Battery status
For real-time battery life estimates based on current usage, refer to the panel in the upper half of the window.
Click the
Chapter 1
to view estimated battery life in sleep and hibernate modes.
21
Acer eAudio Management
Acer eAudio Management allows you to easily control the enhanced sound effects of Dolby® Home Theater™
on your system. Select "Movie" or "Game" mode to experience the awesome realism of 5.1-channel surround
sound from just 2 speakers, via Dolby Virtual Speaker technology. "Music" mode lets you enjoy your favorite
tunes, in vivid detail.
22
Chapter 1
Acer ePresentation Management
Acer ePresentation Management lets you project your computer's display to an external display device or
projector using the hotkey: <Fn> + <F5>. If auto-detection hardware is implemented in the system and the
external display supports it, your system display will be automatically switched out when an external display is
connected to the system. For projectors and external devices that are not auto-detected, launch Acer
ePresentation Management to choose an appropriate display setting.
NOTE: If the restored resolution is not correct after disconnecting a projector, or you need to use an external
resolution that is not supported by Acer ePresentation Management, adjust your display settings using
Display Properties or the utility provided by the graphics vendor.
Chapter 1
23
Acer eDataSecurity Management
Acer eDataSecurity Management is an encryption utility that protects your files from being accessed by
unauthorized persons. It is conveniently integrated with Windows Explorer as a shell extension for quick data
encryption/decryption and also supports on-the-fly file encryption for Lotus Notes and Microsoft Outlook.
The Acer eDataSecurity Management setup wizard will prompt you for a supervisor password and default
encryption password. This password will be used to encrypt files by default, or you can choose to enter your
own password when encrypting a file.
NOTE: The password used to encrypt a file is the unique key that the system needs to decrypt it. If you lose
the password, the supervisor password is the only other key capable of decrypting the file. If you lose
both passwords, there will be no way to decrypt your encrypted file! Be sure to safeguard all related
passwords!
24
Chapter 1
Acer eLock Management
Acer eLock Management is simple yet effective utility that allows you to lock removable storage, optical and
floppy drive devices to ensure that data can't be stolen while your system is unattended.
T
Removable Storage Devices — includes USB disk drives, USB pen drives, USB flash drives, USB MP3
drives, USB memory card readers, IEEE 1394 disk drives, and any other removable storage devices
that can be mounted as a file system when plugged into the system.
T
Optical Drive Devices — includes any kind of CD-ROM, DVD-ROM, HD-DVD or Blu-ray drive devices.
T
Floppy Drive Devices — 3.5-inch floppy drives only.
To use Acer eLock Management, the Empowering Technology password must be set first. Once set, you can
apply locks to any of the devices types. Lock(s) will immediately be set without any reboot necessary, and will
remain after rebooting, until removed.
NOTE: If you lose the Empowering Technology password, there is no method to reset it except by reformatting
your system. Make sure to remember or write down your password.
Chapter 1
25
Acer eRecovery Management
Acer eRecovery Management is a versatile backup utility. It allows you to create full or incremental backups,
burn the factory default image to optical disc, and restore from previously created backups or reinstall
applications and drivers. By default, user-created backups are stored to the D:\ drive.
Acer eRecovery Management provides you with:
T
Password protection (Empowering Technology password)
T
Full and incremental backups to hard disk or optical disc
T
Creation of backups:
T
t
Factory default image
t
User backup image
t
Current system configuration
t
Application backup
Restore and recovery:
t
Factory default image
t
User backup image
t
From previously-created CD/DVD
t
Reinstall applications/drivers
NOTE: If your computer did not come with a Recovery CD or System CD, please use Acer eRecovery
Management's "System backup to optical disc" feature to burn a backup image to CD or DVD. To
ensure the best results when recovering your system using a CD or Acer eRecovery Management,
detach all peripherals (except the external Acer ODD, if your computer has one), including your Acer
ezDock.
26
Chapter 1
Acer eSettings Management
Acer eSettings Management allows you to inspect hardware specifications, set BIOS passwords and modify
boot options.
Acer eSettings Management also:
T
Provides a simple graphical user interface for navigation.
T
Prints and saves hardware specifications.
T
Lets you set an asset tag for your system.
Chapter 1
27
Windows Mobility Center
The Windows Mobility Center collects key mobile-related system settings in one easy-to-find place, so you can
quickly configure your Acer system to fit the situation as you change locations, networks or activities. Settings
include display brightness, power plan, volume, wireless networking on/off, external display settings, display
orientation and synchronization status.
Windows Mobility Center also includes Acer-specific settings like Bluetooth Add Device (if applicable), sharing
folders overview/sharing service on or off, and a shortcut to the Acer user guide, drivers and utilities.
To launch Windows Mobility Center:
28
T
Use the shortcut key <
> + <X>
T
Start Windows Mobility Center from the Control panel
T
Start Windows Mobility Center from the Accessories program group in the Start menu
Chapter 1
Using the System Utilities
Acer GridVista (dual-display compatible)
To enable the dual display feature of your notebook, first ensure that a second display is connected, then,
open the Display Settings properties box using the Control Panel or by right-clicking the Windows desktop
and selecting Personalize. Select the secondary monitor (2) icon in the display box and then click the check
box Extend the desktop onto this monitor. Finally, click Apply to confirm the new settings and click OK to
complete the process.
Acer GridVista is a handy utility that offers four pre-defined display settings so you can view multiple windows
on the same screen. To access this function, please go to Start, All Programs and click on Acer GridVista.
You may choose any one of the four display settings indicated below:
1
2
1
2
1
3
2
3
1
3
2
4
Double (vertical), Triple (primary at left), Triple (primary at right), or Quad
Acer Gridvista is dual-display compatible, allowing two displays to be partitioned independently.
Acer GridVista is simple to set up:
1.
Run Acer GridVista and select your preferred screen configuration for each display from the taskbar.
2.
Drag and drop each window into the appropriate grid.
3.
Enjoy the convenience of a well-organized desktop.
Chapter 1
29
NOTE: Please ensure that the resolution setting of your second monitor is set to the manufacturer's
recommended value.
Launch Manager
Launch Manager allows you to set the four easy-launch buttons located above the keyboard.
You can access the Launch Manager by clicking on Start, All Programs, and then Launch Manager to start
the application.
30
Chapter 1
Norton Internet Security
Norton Internet Security is an anti-virus utility that can protect against viruses, keeping your data safe and
secure.
How do I check for viruses?
1.
Double-click the Norton Internet Security icon on the Windows desktop.
2.
Select Tasks & Scans.
3.
Select Run Scan to scan your system.
4. When the scan is complete, review the results of the scan.
NOTE: For optimal security, run a Full System Scan when scanning your computer for the first time.
You can schedule customized virus scans that run unattended on specific dates and times or at periodic
intervals. If you are using the computer when the scheduled scan begins, it runs in the background so that you
do not have to stop working.
For more information refer to the Norton Internet Security help files.
Chapter 1
31
Hardware Specifications and Configurations
Processor
Item
Specification
CPU type
Intel
Core 2
Duo
T7200
Mobile
Proces
sor
Intel
Core 2
Duo
T7400
Mobile
Proces
sor
Intel
Core 2
Duo
T7600
Mobile
Proces
sor
Intel
Core 2
Duo
T5300
Mobile
Proces
sor
Intel
Core 2
Duo
T5500
Mobile
Proces
sor
Intel
Core 2
Duo
T5600
Mobile
Proces
sor
Intel
Core 2
Duo
T2080
Mobile
Proces
sor
Intel
Celero
nM
440
Mobile
Proces
sor
Intel
Celero
nM
520
Mobile
Proces
sor
Intel
Celero
nM
530
Mobile
Proces
sor
Clock
Speeds
2 GHz
2.16
GHz
2.33
GHz
1.73
GHz
1.66
GHz
1.83
GHz
1.73
GHz
1.86
GHz
1.6
GHz
1.73
GHz
L2 Cache
4 MB
4 MB
4 MB
2 MB
2 MB
2 MB
1 MB
1 MB
1 MB
1 MB
Front Side
Bus
667
MHz
667
MHz
667
MHz
533
MHz
667
MHz
667
MHz
533
MHz
533
MHz
533
MHz
533
MHz
System Board Major Chips
Item
Specification
System core logic
Intel 945PM Express + Intel ICH7M chipsets
HDD controller
Intel ICH7M chipset
Memory controller
Intel 945PM Express chipset
Video controller
Intel 945PM Express chipset
Audio controller
Codec ALC268
PCMCIA controller
OZ129
LAN controller
Intel ICH7M + Broadcom 5787MKMLG chipsets
Modem controller
Intel ICH7M chipset
Bluetooth controller
Intel ICH7M chipset
Keyboard controller
Winbond WPC8768L
Hard Disk Drive Interface
32
Item
Specification
Product
Hitachi Travelstar
5K160
Toshiba
Model Name
HTS
5416
80J9
SA0
0
HTS
5416
12J9
SA0
0
HTS
5416
16J9
SA0
0
MK8
037
GSX
MK1
237
GSX
Capacity (GB)
80
120
160
80
120
Form factor and
Interface type
2.5 inch Serial ATA
Bytes per sector
512
512
N/A
512
Data heads
4
4
N/A
3
Data disks
2
2
N/A
2
Spindle speed
(RPM)
5400
5400
5400
5400
Western Digital
Seagate
MK1
637
GSX
WD8
00B
EVS
WD1
200B
EVS
WD1
600B
EVS
ST9
8081
1AS
ST9
1208
22A
S
ST9
1608
21A
S
160
80
120
160
80
120
160
Chapter 1
Hard Disk Drive Interface
Item
Specification
Buffer size (MB)
8
8.192
8
8
Media transfer
rate (Mbytes/s,
max)
540
300
600
N/A
Interface transfer
rate (Mbytes/s,
max)
150 MB/s
N/A
150 MB/s
150 MB/s
Voltage
tolerance
5V(DC) +/- 5%
5V(DC) +/- 5%
5V(DC) +/- 5%
5V(DC) +/- 5%
BIOS
Item
Specification
BIOS vendor
Phoenix
BIOS Version
v0.25
Supported protocols
ACPI 1.0b/2.0/3.0 compliance, PCI 2.2, System/HDD Password
Security Control, INT 13h Extenstions, PnP BIOS 1.0a, SMBIOS 2.4,
BIOS Boot Specification, Simple Boot Flag 1.0, Boot Block, PCI Bus
Power Management Interface Specification, USB Specification 1.1/2.0,
IEEE 1394 1.0, USB/1394 CD-ROM Boot Up support, PC Card
Standard 1995 (PCMCIA 3.0 Compliant Device), IrDA 1.0, HD audio,
WfM 2.0, Preboot Execution Environment 2.1, Boot Integrity Service
Application Program Interface (BIS) 1.0, PC2002/2005 compliant, Intel
Enhanced SpeedStep Technology, Intel DPST support, ASF 2.0, TPM
v1.2, AHCI support, iAMT 2.5
System Memory
Item
Specification
Memory controller
Intel 945PM Express chipset
DIMM socket number
2 sockets
Supports maximum
memory size
2 GB for 32 bit OS, 4 GB for 64bit OS
Vendor
Samsung
Hynix
Nanya
Powerchip
Promos
Model name
M470T2953
EZ3-CE6
HYMP512S
64CP8-Y5
NT512T64U
H8B0FN-3C
AS6E8E63B-6E1A
V916764B24
QBFW-F5
512 MB
512 MB
512 MB
DIMM type
DDR2 Synchronous DRAM
DIMM speed (MHz)
667
DIMM size
1GB
1GB
Video
Item
Specification
VGA controller
Intel 945PM Express chipset with integrated 3D graphics
Features
ATI Mobility Radeon HD2300 with up to 896 MB of HyperMemory (128
MB of dedicated GDDR2 VRAM, up to 760 MB of shared system
memory) supporting Microsoft DirectX 9 and PCI Express
Chapter 1
33
Audio
Item
Specification
Audio controller
Realtek ALC268 Codec
Features
Two built-in stereo speakers, Supports high definition audio, Built-in
microphone, MS-sound compatible
PCMCIA Port
Item
Specification
PCMCIA controller
TI7412
Card type support
Type-II
Number of slot
One
LAN
Item
Specification
LAN controller
Intel ICH7M + Broadcom 5785KMLG chipsets
LAN connector type
RJ45
Features
Onboard Gigabit Ethernet, PCI-E interface, support ASF 2.0
Wireless LAN module
Item
Specification
Vendor
Intel
Model name
Wireless WiFi
Link 4965AGN
Data throughput
54 Mbps
Protocol
802.11a/b/g
Interface
PCI bus (mini PCI socket for wireless module)
Foxconn
PRO/Wireless
3945ABG
PRO/Wireless
3945BG
Broadcom 4311
802.11 a/b/g
802.11 b/g
802.11 b/g
Modem
Item
Specification
Modem controller
Intel 945PM Express chipset
Vendor
Liteon
Foxconn
Model name
MDC-003#A8B
MDC 1.5 T60M955.00
Baud rate
56 K
Modem connector type
RJ11
Bluetooth Module
34
Item
Specification
Bluetooth controller
Intel ICH7M chipset
Vendor
Foxconn BCM2045
Model name
T60H928.01
Protocol
Bluetooth 2.0
Connector type
Mini USB
Chapter 1
Keyboard and Input Devices
Item
Specification
Keyboard controller
Winbond WPC8768L
Model name
Acer FineTouch keyboard
Features
5-degree curve, 88-/89- key, inverted “T” cursor layout, 2.5 mm (minimum) key
travel, touchpad pointing device with 4-way scroll button or Acer BioProtect
fingerprint reader supporting Acer Finger Nav 4-way control function, hotkey
controls, embedded numeric keypad, multi-language support, three easylaunch buttons, three productivity keys, and two front-access communication
switches
Combo Drive Interface
Item
Specification
Vendor
Sony
Philips BenQ
Model name
Slim Combo CRX880A
DS-24CZP
Drive type
Internal Slim CD-RW/DVD combo drive
Data transfer rate
Write:
Read:
•
CD-R: 24X
•
DVD-ROM: 8X
•
CD-RW: 24X
•
CD-ROM: 24X
Buffer Memory
2 MB
Interface
IDE
Applicable disc format
CD-R, CD-RW (Multi speed, High speed, Ultra-speed and Ultra-speed plus)
CD-DA, CD-ROM (mode 1), CD-ROM XA (Mode 2, Form 1, Form 2), CD-I,
CD-i Bridge, Video-CD, Karaoke CD, Photo CD, Enhanced CD, CD Plus,
CD Extra, i-trax CD, CD-Text DVD-ROM, DVD-Video, DVD-Audio, SACD
(Hybrid), UDF DVD, DVD-R/RW, DVD+R/RW, DVD+/-R DL, DVD-RAM
V1.0/V2.1
Power supply
5 V DC
Chapter 1
N/A
35
DVD Drive Interface
Item
Specification
Vendor
Sony
Pioneer
Philips BenQ
Panasonic
Model name
AD-7560A
DVR-K17RS
DS-8A1P
UJ-850
Drive type
Internal Slim DVD/CD writer
Data transfer rate
Write:
Write:
N/A
Write:
•
CD-R: 24X
CAV
•
CD-R: 24X
•
CD-R: 24X
•
CD-RW: 24X
•
CD-RW: 16X
CD-RW: 24X
CAV
•
DVD-RW: 6X
•
DVD-R: 8X
DVD+RW/RW (single
layer): 8X, 6X
ZCLV
•
DVD-R/+R/
+RW: 8X
•
DVD-RW: 4X
•
DVD-RAM: 5X
Read:
•
DVD+R(DL):
2.4X
DVD-R/+R
(single layer):
8X CAV
•
DVD+R: 8X
•
DVD+RW: 4X
•
DVD-R/+R
(double layer):
4X ZCLV
•
CD-R/RW/
ROM: 24X
•
DVD-RAM: 5X
ZCLV
•
DVD-R/RW/
ROM: 8X
•
•
•
•
DVD-RAM: 5X
Read:
Read:
36
•
CD-R/RW/
ROM: 24X
Max
•
DVD-ROM
(single layer):
8X CAV
•
DVD-ROM
(double layer):
6X CAV
•
DVD-RAM: 5X
ZCLV
•
DVD-R/+R/
+RW/-RW
(single layer):
8X CAV
•
DVD-R/+R
(double layer):
6X CAV
Buffer Memory
2 MB
Interface
Enhanced IDE(ATAPI) compatible
Applicable disc format
DVD-RAM, DVD-R/RW, DVD+R (SL, DL)/RW, CD-R/RW, DVD-ROM, DVDRAM, DVD-R, DVD-RW, DVD+R (SL, DL), DVD+RW; CD-R, CD-RW, CDROM, CD-ROM XA, CD-DA, CD-I, CD-Extra, CD-Text, Photo CD, Video CD
Power supply
5V DC
Chapter 1
Battery
Item
Specification
Vendor
Panasonic
Sanyo
Sony
Simplo
Battery Type
Li-ion
Li-ion
Li-ion
Li-ion
Pack capacity
6 cell:
2.0 mAh
6 cell:
2.4 mAh
6 cell:
2.0 mAh
6 cell:
2.4 mAh
6 cell:
2.0 mAh
6 cell:
2.4 mAh
6 cell:
2.0 mAh
6 cell:
2.4 mAh
LCD
Item
Specification
Vendor
AUO
CMO
LG
Model name
B141EW04
(Non-glare)
N141I3-L02
(Glare)
LP141WX1TLA1 (Nonglare)
LP141WX3TLB1(Glare)
LTN141W3L01-G (Glare)
B141EW04V4 (Glare)
Samsung
Screen diagonal (mm)
14.1” WXGA
Display resolution (pixels)
1280 x 800
1280 x 800
1280 x 768
N/A
1280 x 800
Aspect ratio
16:10
N/A
15:9
N/A
N/A
Active area (mm)
303.36 x
189.6
N/A
305.8 x 183.2
N/A
303.4 x 189.6
Pixel pitch (mm)
0.237
N/A
0.2385 (107)
N/A
0.237
Mode
TN
N/A
N/A
N/A
N/A
Number of colors
262 K
262 K
262,144 (6
bit)
N/A
262 K
Color saturation (NTSC%)
45
N/A
45%
N/A
N/A
Typical white luminance (cd/
m2) also called brightness
200
220
185 (typ.5p)
200
200
Contrast ratio
400:1
300:1
500:1
N/A
500:1
Response time (optical rise
time + fall time) (msec)
16
16
25
16
16
Power consumption (watt)
5.1
5.3
N/A
N/A
N/A
Supply voltage (v)
3.3
N/A
N/A
N/A
N/A
Backlight
1 CCFL
N/A
N/A
N/A
N/A
Outline dimensions (mm)
319.5 x 205.5
x 5.2
319.5 x 205
.5 x 5.2
320.0 x 199.0
x 5.5
N/A
319.5 x205.5
x 5.5
Weight (g)
400
400
400
N/A
390
LCD Inverter Board
Item
Specification
Vendor
YEC
Foxconn
RoHS
Model name
YNV-W06S
T621240.02
VK.21189.406
Chapter 1
37
AC Adapter
Item
Specification
Vendor
Delta
Lite-On
Model Name
ADP-90SB BBDAF
PA-1900-24 AR
ADP-90SB BBEA LF
PA-1900-04 WR
Output rating
19 V/4.74 A, 90 W
19 V , 90 W
Input (Vac)
90 ~ 270
100 ~ 240
System Power Management
ACPI mode
Power Management
Off
•
Mech. Off (G3): All devices in the system are turned off
completely.
•
Soft Off (G2/S5): OS initiated shutdown. All devices in the system
are turned off completely.
•
Working (G0/S0): Individual devices such as the CPU and hard
disc may be power managed in this state.
•
Suspend to RAM (S3): CPU set power down, VGA Suspend,
PCMCIA Suspend, Audio Power Down, Hard Disk Power Down,
CD-ROM Power Down, and Super I/O Low Power mode.
•
Save to Disk (S4): Also called Hibernation Mode. System saves
all system states and data onto the disc prior to system shutdown.
On
38
Chapter 1
Chapter 2
System Utilities
BIOS Setup Utility
The BIOS Setup Utility is a hardware configuration program built into your system’s BIOS (Basic Input/Output
System). Since most systems are already properly configured and optimized, there is no need to run this utility.
The BIOS setup utility stores basic settings for your system. You will need to run this utility if you encounter
configuration problems. Refer to Chapter 4 Troubleshooting when problem arises.
Entering BIOS Setup
Power on the system to start the system POST process. During bootup, press F2 to enter the BIOS setup
screen.
NOTE: You must press F2 while the system is booting. This key does not work during any other time.
BIOS Setup Primary Menus
There are several tabs on the setup screen corresponding to the six primiary BIOS menus.
T
T
T
T
T
Information
Main
Security
Boot
Exit
In the descriptive table following each of the screen illustrations, settings in boldface are the default and
suggested parameter settings.
BIOS Setup Navigation Keys
Note the following reminders when moving around the Setup utility.
Use the Left and Right arrow keys to move to the next page or to return to the previous screen.
Use the Up and Down arrow keys to select an item.
T
Use the + and - keys to select an option.
NOTE: You can configure a parameter that is enclosed in square brackets. Grayed-out items have fixed
settings and are not user-configurable.
T
T
Use the Enter key to display a submenu screen.
NOTE: When a parameter is preceeded by an arrow or (>), it means that a submenu screen is available.
T
Press F1 for General Help using the BIOS setup.
Press F9 to load the default configuration.
T
Press F10 to save changes and close the BIOS setup.
T
Press Esc to close the BIOSe setup.
NOTE: The parameters on the screens shown in this Guide display default system values. These values may
not be the same as those in the system. System information is subject to different models.
T
T
Chapter 2
39
Information Menu
Parameter
Description
CPU Type
Type of processor currently installed in the system.
CPU Speed
Speed of the processor currently installed in the system.
IDE0 Model Name
Model name of HDD installed on the primary IDE channel.
IDE0 Serial Number
Serial number of HDD installed on the primary IDE channel.
ATAPI Model Name
Model name of the ATAPI CD/DVD-ROM drive installed in the system.
System BIOS Version
Version number of the BIOS setup utility.
VGA BIOS Version
Version number of the VGA firmware.
KBC Version
Version number of the keyboard controller.
Serial Number
Serial number of the system.
Asset Tag Number
Asset tag number of the system.
Product Name
Product name of the system.
Manufacturer Name
Name of the manufacturer of this system.
UUID
Visible only when an internal LAN device is present.
UUID=32bytes
NOTE: The system configuration information varies in different models.
40
Chapter 2
Main Menu
Parameter
Description
Format/Option
System Time
Set the system time following the hour-minute-second format.
Format: HH:MM:SS
(hour:minute:second)
System Date
Set the date following the weekday-month-day-year format.
Format MM/DD/YYYY
(month/day/year)
System Memory
Total size of system memory detected during POST.
Extended Memory
Total size of extended memory during POST.
Video Memory
Total size of VGA memory.
Quiet Boot
When Enabled, the BIOS splash screen is displayed during
startup.
Enabled
Disabled
Network Boot
When Enabled, the system can be booted from another PC on
your LAN, such as a remote server.
Disabled
F12 Boot Menu
When Enabled, pressing the F12 key during POST brings up a
menu of devices that you can select to boot.
D2D Recovery
Enables or disables disk-to-disk recovery. D2D recovery is a
method of restoring the system to factory configurations without
using recovery CDs.
Chapter 2
Enabled
Disabled
Enabled
Enabled
Disabled
41
Security Menu
Parameter
Description
Option
Supervisor Password Is
Indicates whether a supervisor password has been
assigned.
Clear or Set
User Password Is
Indicates whether a user password has been
assigned.
Clear or Set
HDD Password Is
Indicates whether a hard disk drive password has
been assigned.
Clear or HDD Password Set
Set Supervisor Password
Press Enter to configure the supervisor password.
Set User Password
Press Enter to configure the user password.
Set HDD Password
Press Enter to configure the hard disk drive
password.
Password on Boot
Enables or disables security check during POST.
Disabled or Enabled
NOTE: Refer to the “Removing a System Password” section for more information on how to remove a
password.
42
Chapter 2
Setting a System Password
1.
Use the up/down keys to select a password parameter (Set Supervisor Password, Set User Password, or
Set Secondary MAS.Disk Password), then press Enter. A Password box will appear.
2.
Type a password then press Enter.
The password may consist of up to six alphanumeric characters (A-Z, a-z, 0-9).
3.
Retype the password to verify the first entry then press Enter again.
4.
Press F10.
5.
Select Yes to save the new password and close the Setup Utility.
Changing a System Password
1.
Use the up/down keys to select a password parameter (Set Supervisor Password, Set User Password, or
Set Secondary MAS.Disk Password), then press Enter.
2.
Type the original password then press Enter.
3.
Type a new password then press Enter.
4.
Retype the password to verify the first entry then press Enter again.
5.
Press F10.
6.
Select Yes to save the new password and close the Setup Utility.
Removing a System Password
1.
Use the up/down keys to select a password parameter (Set Supervisor Password, Set User Password, or
Set Secondary MAS.Disk Password), then press Enter.
2.
Enter the current password then press Enter.
3.
Press Enter twice without entering anything in the new and confirm password fields.
4.
After doing this, the system automatically sets the related password parameter to Clear.
Chapter 2
43
Boot Menu
This menu allows you to set the drive priority during system boot-up. The system will attempt to boot from the
first device on the list. If the first device is not available, it will continue down the list until it reaches an available
device. BIOS setup will display an error message if the drive(s) specified is not bootable.
44
Chapter 2
Exit Menu
Parameter
Description
Exit Saving Changes
Save changes made and close the BIOS setup.
Exit Discarding Changes
Discards changes made and close the BIOS setup.
Load Setup Defaults
Loads the default settings for all BIOS setup parameters. Setup Defaults are quite
demanding in terms of resources consumption. If you are using low-speed memory chips or
other kinds of low-performance components and you choose to load these settings, the
system might not function properly.
Discard Changes
Discards all changes made in the BIOS setup.
Save Changes
Saves changes made in the BIOS setup.
Chapter 2
45
46
Chapter 2
Chapter 3
Machine Disassembly and Replacement
This chapter contains step-by-step procedures on how to disassemble the notebook computer for
maintenance and troubleshooting.
Disassembly Requirements
To disassemble the computer, you need the following tools:
T
Wrist grounding strap and conductive mat for preventing electrostatic discharge
T
Flat screwdriver
T
Philips screwdriver
T
Hex screwdriver
T
Plastic flat-blade screwdriver
Plastic tweezers
NOTE: The screws for the different components vary in size. During the disassembly process, group the
screws with the corresponding components to avoid mismatch when putting back the components.
T
Chapter 3
47
General Information
Pre-disassembly Instructions
Before proceeding with the disassembly procedure, make sure that you do the following:
48
1.
Turn off the power to the system and all peripherals.
2.
Unplug the AC adapter and all power and signal cables from the system.
3.
Place the system on a flat, stable surface.
4.
Remove the battery pack. See “Removing the Battery Pack” on page 51.
Chapter 3
Disassembly Process
The disassembly process is divided into the following stages:
T
External module disassembly
T
Main unit disassembly
T
LCD module disassembly
The flowcharts provided in the succeeding disassembly sections illustrate the entire disassembly sequence.
Observe the order of the sequence to avoid damage to any of the hardware components. For example, if you
want to remove the mainboard, you must first remove the keyboard, then disassemble the inside assembly
frame in that order.
Main Screw List
Item
Screw
Color
Part No.
A
M2 x L4 (torque 1.6)
Black
86.00F24.724
Silver
86.9A554.4R0
M2 x L4 (torque 3.0)
B
M3 x L4
C
M2 x L6
Black
86.00F58.726
D
M2 x L2.5
Silver
86.00F22.722
E
M2 x L4
F
M2.5 x L8
G
M2.5 x L6
H
I
Chapter 3
86.9A552.3R0
Black
86.00E34.738
M2 x L3
Silver
86.00C07.220
M2 x L2.5
Silver
86.9A552.6R0
86.00E33.736
49
External Module Disassembly Process
External Modules Disassembly Flowchart
The flowchart below gives you a graphic representation on the entire disassembly sequence and instructs you
on the components that need to be removed during servicing. For example, if you want to remove the
mainboard, you must first remove the keyboard, then disassemble the inside assembly frame in that order.
EXTERNAL MODULE DISASSEMBLY
TURN OFF POWER
AND PERIPHERALS
UNPLUG POWER
CABLES
Cx1
Ax8
OPTICAL DISK
DRIVE MODULE
LOWER
COVER
Ax2
WLAN
BOARD
DIMM
MODULES
Ax1
HARD DISK
DRIVE
MODULE
Dx2
OPTICAL
LOCKER
BRACKET
OPTICAL DISK
DRIVE
HDD
MODULE
Ax2
HARD DISK
DRIVE
BRACKET
HARD DISK
DRIVE
Screw List
50
Item
Screw
Part No.
A
M2 x L4
86.00F24.724
B
M3 x L4
86.9A554.4R0
C
M2 x L6
86.00F58.726
D
M2 x L2.5
86.00F22.722
Chapter 3
Removing the Battery Pack
1.
Turn base unit over.
2.
Slide the battery lock/unlock latch to the unlock position (1).
3.
Slide and hold the battery release latch to the release position (2).
4.
Remove the battery from the main unit (3).
Chapter 3
51
Removing the SD Dummy Card
1.
See “Removing the Battery Pack” on page 51.
2.
Push against the card, as if you were pushing it further into the slot, letting the card spring out.
3.
Remove the card from the slot.
Removing the Express Dummy Card
52
1.
See “Removing the Battery Pack” on page 51.
2.
Push against the card,as if you were pushing it further into the slot, letting the card spring out.
Chapter 3
3.
Remove the card from the slot.
Removing the Lower Cover
1.
See “Removing the Battery Pack” on page 51.
2.
Turn the base unit over, then loosen the eight screws (A) on the lower cover.
3.
Step
Size (Quantity)
Color
Torque
1~8
M2 x L4
Black
1.6 kgf-cm
Use a plastic flat-blade screwdriver to pry open the lower cover.
Chapter 3
53
4.
Remove the lower cover from the lower case.
Removing the DIMM
54
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the Lower Cover” on page 53.
3.
Push out the latches on both sides of the DIMM socket to release the DIMM.
4.
Remove the DIMM module.
Chapter 3
Removing the WLAN Board Module
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the Lower Cover” on page 53.
3.
Detach the wireless board barcode label from the WLAN board.
4.
Disconnect the two antenna cables from the WLAN board, then move the antennas away from the board.
5.
Remove the two screws (A) on the WLAN board to release the WLAN board.
Chapter 3
Step
Size (Quantity)
Color
Torque
1~2
M2 x L4 (2)
Black
1.6 kgf-cm
55
6.
Detach the WLAN board from the WLAN socket.
NOTE: When attaching the antennas back to the WLAN board, make sure the cable are routed properly.
Removing the Hard Disk Drive Module
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the SD Dummy Card” on page 52.
3.
See “Removing the Express Dummy Card” on page 52.
4.
See “Removing the Lower Cover” on page 53.
5.
Remove the screw (A) securing the HDD assembly to the unit.
6.
Step
Size (Quantity)
Color
Torque
1
M2 x L4 (1)
Black
3 kgf-cm
Pull the HDD module out by pulling on the mylar attached to it, gently slide-out the HDD module from its
bay.
NOTE: To prevent damage to device, avoid pressing down on it or placing heavy objects on top of it.
56
Chapter 3
7.
8.
Remove the two screws (A) on the HDD bracket.
Step
Size (Quantity)
Color
Torque
1~2
M2 x L4 (2)
Silver
3.0 kgf-cm
Remove the hard disk drive.
Removing the Optical Drive Module
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the Lower Cover” on page 53.
3.
Remove the screw (C) on the bottom side of the unit, as shown.
Chapter 3
Step
Size (Quantity)
Color
Torque
1
M2 x L6 (1)
Black
3 kgf-cm
57
58
4.
Using the flat-blade screwdriver, press the end of the module forward, then slide out the optical drive
module from the main unit.
5.
Remove the two screws (D) securing the optical bracket and remove the locker bracket from the optical
disk drive module.
Step
Size (Quantity)
Color
Torque
1-2
M2 x L2.5 (2)
Silver
1.6 kgf-cm
Chapter 3
Main Unit Disassembly Process
Main Unit Disassembly Flowchart
MAIN UNIT DISASSEMBLY
MAIN
UNIT
KEYBOARD
CPU HEATSINK
MODULE
MIDDLE COVER
CPU
Ax3
POWER BOARD
Fx4
LCD MODULE
Ax3, Cx11
UPPER CASE
Screwx3
SPEAKERS
Ax2
Ax4
TOUCHPAD BRACKET
ASSEMBLY
LAUNCH
BOARD BRACKET
TOUCHPAD BOARD
LAUNCH
BOARD
Ax3
Ax2
MAINBOARD
BLUETOOTH BOARD
Ax1
USB BOARD
Ax2
MODEM BOARD
RTC BATTERY
LOWER CASE
Chapter 3
59
Screw List
A
Screw
Part No.
M2 x L4
86.00F24.724
C
M2 x L6
86.00F58.726
F
M2.5 X L8
86.00E34.738
Removing the CPU Heatsink Module
60
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the Lower Cover” on page 53.
3.
Detach the heatsink cable from the mainboard.
4.
Loosen the four spring-loaded screws on the heatsink in the order shown.
5.
Remove the heatsink module.
Chapter 3
Removing the CPU
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the Lower Cover” on page 53.
3.
See “Removing the CPU Heatsink Module” on page 60.
4.
Using a flat screwdriver, turn the CPU socket latch to the unlock position by aligning the latch to the unlock
symbol, then remove the CPU.
NOTE: When installing the CPU, make sure to install the CPU with PIN 1 at the corner as shown.
Chapter 3
61
Removing the Keyboard
62
1.
See “Removing the Battery Pack” on page 51.
2.
Press the plastic flat-blade screwdriver to the notches, shown below, to disengage the keyboard from the
main unit.
3.
Carefully pry up and out the keyboard and turn it over.
4.
Disconnect the keyboard cable from the mainboard to remove the keyboard.
Chapter 3
Removing the Middle Cover
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the Keyboard” on page 62.
3.
Open the LCD screen all the way to facilitate the easy removal of the middle cover.
4.
Carefully insert the flat screwdriver between the middle cover and lower case and gently pry up the middle
cover.
5.
Continue prying the middle cover until the full length of the cover releases from the main unit, then turn it
over.
6.
Detach the power board cable from the power board, then remove the middle cover.
Chapter 3
63
Removing the Power Board
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the Keyboard” on page 62.
3.
See “Removing the Middle Cover” on page 63.
4.
Remove the three screws (A) from the power board.
5.
Step
Size (Quantity)
Color
Torque
1~3
M2 x L4 (3)
Black
1.6 kgf-cm
Remove the power board.
Removing the LCD Module
64
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the Lower Cover” on page 53.
3.
See “Removing the Keyboard” on page 62.
4.
See “Removing the Middle Cover” on page 63.
5.
Disconnect the microphone cable from the mainboard.
Chapter 3
6.
Disconnect the LCD coaxial cable from the mainboard.
7.
Pull out the antenna cables as shown.
8.
Turn the system over and remove the two screws (F) from the base of the unit.
Chapter 3
Step
Size (Quantity)
Color
Torque
1~2
M2.5 x L8 (2)
Black
4.0 kgf-cm
65
9.
Remove the two screws (F) from the left and right hinge of the LCD module.
Step
Size (Quantity)
Color
Torque
1~2
M2.5 x L8 (2)
Black
4.0 kgf-cm
10. Carefully remove the LCD module from the base unit.
NOTE: Make sure the cables are routed well before connecting the cables back to the unit.
Separating the Upper Case from the Lower Case
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the SD Dummy Card” on page 52.
3.
See “Removing the Express Dummy Card” on page 52.
4.
See “Removing the Lower Cover” on page 53.
5.
See “Removing the DIMM” on page 54.
6.
See “Removing the WLAN Board Module” on page 55.
7.
See “Removing the Hard Disk Drive Module” on page 56.
8.
See “Removing the Optical Drive Module” on page 57.
9.
See “Removing the CPU Heatsink Module” on page 60.
10. See “Removing the CPU” on page 61.
11. See “Removing the Keyboard” on page 62.
12. See “Removing the Middle Cover” on page 63.
13. See “Removing the LCD Module” on page 64.
66
Chapter 3
14. Remove the three screws (A) on the upper case.
Step
Size (Quantity)
Color
Torque
1~3
M2 x L4 (3)
Black
1.6 kgf-cm
15. Disconnect the speaker cable from the mainboard.
16. Detach the launch board cable from the mainboard.
Chapter 3
67
17. Detach the touchpad cable from the mainboard.
18. Detach the power board cable from the mainboard.
19. Turn the system over and remove the eleven screws (C) on the lower case.
68
Step
Size (Quantity)
Color
Torque
1~11
M2 x L6 (11)
Black
3.0 kgf-cm
Chapter 3
20. Gently detach the upper case from the lower case.
Removing the Speaker Modules
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the SD Dummy Card” on page 52.
3.
See “Removing the Express Dummy Card” on page 52.
4.
See “Removing the Lower Cover” on page 53.
5.
See “Removing the DIMM” on page 54.
6.
See “Removing the WLAN Board Module” on page 55.
7.
See “Removing the Hard Disk Drive Module” on page 56.
8.
See “Removing the Optical Drive Module” on page 57.
9.
See “Removing the CPU Heatsink Module” on page 60.
10. See “Removing the CPU” on page 61.
11. See “Removing the Keyboard” on page 62.
12. See “Removing the Middle Cover” on page 63.
13. See “Removing the LCD Module” on page 64.
14. See “Separating the Upper Case from the Lower Case” on page 66.
15. Remove the four screws on the speaker modules.
Chapter 3
Step
Size (Quantity)
Color
Torque
1~4
N/A
Silver
1.6 kgf-cm
69
16. Remove the speakers.
Removing the Launch Board
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the SD Dummy Card” on page 52.
3.
See “Removing the Express Dummy Card” on page 52.
4.
See “Removing the Lower Cover” on page 53.
5.
See “Removing the DIMM” on page 54.
6.
See “Removing the WLAN Board Module” on page 55.
7.
See “Removing the Hard Disk Drive Module” on page 56.
8.
See “Removing the Optical Drive Module” on page 57.
9.
See “Removing the CPU Heatsink Module” on page 60.
10. See “Removing the CPU” on page 61.
11. See “Removing the Keyboard” on page 62.
12. See “Removing the Middle Cover” on page 63.
13. See “Removing the LCD Module” on page 64.
14. See “Separating the Upper Case from the Lower Case” on page 66.
15. Remove the two screws (A) from the launch board bracket.
70
Step
Size (Quantity)
Color
Torque
1~2
M2 x L4 (2)
Black
1.6 kgf-cm
Chapter 3
16. Remove the bracket.
17. Remove the three screws (A) from the launch board.
Step
Size (Quantity)
Color
Torque
1~3
M2 x L4 (3)
Black
1.6 kgf-cm
18. Remove the launch board.
Chapter 3
71
Removing the Touchpad Board Module
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the SD Dummy Card” on page 52.
3.
See “Removing the Express Dummy Card” on page 52.
4.
See “Removing the Lower Cover” on page 53.
5.
See “Removing the DIMM” on page 54.
6.
See “Removing the WLAN Board Module” on page 55.
7.
See “Removing the Hard Disk Drive Module” on page 56.
8.
See “Removing the Optical Drive Module” on page 57.
9.
See “Removing the CPU Heatsink Module” on page 60.
10. See “Removing the CPU” on page 61.
11. See “Removing the Keyboard” on page 62.
12. See “Removing the Middle Cover” on page 63.
13. See “Removing the LCD Module” on page 64.
14. See “Separating the Upper Case from the Lower Case” on page 66.
15. Remove the two screws (A) on the touchpad bracket.
Step
Size (Quantity)
Color
Torque
1~2
M2 x L4 (2)
Black
1.6 kgf-cm
16. Remove the touchpad bracket from the upper case.
72
Chapter 3
17. Carefully insert the flat screwdriver under the side of the touchpad board and gently pry up the board.
18. Continue prying the board until it releases from the upper case, then remove the board.
Removing the Bluetooth Board
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the SD Dummy Card” on page 52.
3.
See “Removing the Express Dummy Card” on page 52.
4.
See “Removing the Lower Cover” on page 53.
5.
See “Removing the DIMM” on page 54.
6.
See “Removing the WLAN Board Module” on page 55.
7.
See “Removing the Hard Disk Drive Module” on page 56.
8.
See “Removing the Optical Drive Module” on page 57.
9.
See “Removing the CPU Heatsink Module” on page 60.
10. See “Removing the CPU” on page 61.
11. See “Removing the Keyboard” on page 62.
12. See “Removing the Middle Cover” on page 63.
13. See “Removing the LCD Module” on page 64.
14. See “Separating the Upper Case from the Lower Case” on page 66.
Chapter 3
73
15. Disconnect the Bluetooth cable from the mainboard.
16. Carefully detach the Bluetooth board from the lower case.
Removing the USB board
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the SD Dummy Card” on page 52.
3.
See “Removing the Express Dummy Card” on page 52.
4.
See “Removing the Lower Cover” on page 53.
5.
See “Removing the DIMM” on page 54.
6.
See “Removing the WLAN Board Module” on page 55.
7.
See “Removing the Hard Disk Drive Module” on page 56.
8.
See “Removing the Optical Drive Module” on page 57.
9.
See “Removing the CPU Heatsink Module” on page 60.
10. See “Removing the CPU” on page 61.
11. See “Removing the Keyboard” on page 62.
12. See “Removing the Middle Cover” on page 63.
13. See “Removing the LCD Module” on page 64.
14. See “Separating the Upper Case from the Lower Case” on page 66.
74
Chapter 3
15. Disconnect the USB FFC (flat flexible cable) from the mainboard.
16. Pull out the AC input cable and move away from the USB board.
17. Remove the screw (A) on the USB board.
Chapter 3
Step
Size (Quantity)
Color
Torque
1~2
M2 x L4 (2)
Black
1.6 kgf-cm
75
18. Remove the USB board.
Removing the Mainboard
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the SD Dummy Card” on page 52.
3.
See “Removing the Express Dummy Card” on page 52.
4.
See “Removing the Lower Cover” on page 53.
5.
See “Removing the DIMM” on page 54.
6.
See “Removing the WLAN Board Module” on page 55.
7.
See “Removing the Hard Disk Drive Module” on page 56.
8.
See “Removing the Optical Drive Module” on page 57.
9.
See “Removing the CPU Heatsink Module” on page 60.
10. See “Removing the CPU” on page 61.
11. See “Removing the Keyboard” on page 62.
12. See “Removing the Middle Cover” on page 63.
13. See “Removing the LCD Module” on page 64.
14. See “Separating the Upper Case from the Lower Case” on page 66.
15. See “Removing the Bluetooth Board” on page 73.
16. See “Removing the USB board” on page 74.
17. Detach the power board cable from the lower case.
76
Chapter 3
18. Remove the two screws (A) holding the mainboard to the lower case.
Step
Size (Quantity)
Color
Torque
1~2
M2 x L4 (2)
Black
1.6 kgf-cm
19. Carefully detach the mainboard from the lower case.
Removing the Modem Board
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the SD Dummy Card” on page 52.
3.
See “Removing the Express Dummy Card” on page 52.
4.
See “Removing the Lower Cover” on page 53.
5.
See “Removing the DIMM” on page 54.
6.
See “Removing the WLAN Board Module” on page 55.
7.
See “Removing the Hard Disk Drive Module” on page 56.
8.
See “Removing the Optical Drive Module” on page 57.
9.
See “Removing the CPU Heatsink Module” on page 60.
10. See “Removing the CPU” on page 61.
11. See “Removing the Keyboard” on page 62.
12. See “Removing the Middle Cover” on page 63.
13. See “Removing the LCD Module” on page 64.
14. See “Separating the Upper Case from the Lower Case” on page 66.
15. See “Removing the Bluetooth Board” on page 73.
16. See “Removing the USB board” on page 74.
Chapter 3
77
17. See “Removing the Mainboard” on page 76.
18. Disconnect the modem cable from the mainboard.
19. Detach the masking tape from the mainboard.
20. Remove the two screws (A) on the modem board.
78
Step
Size (Quantity)
Color
Torque
1~2
M2 x L4 (2)
Silver
1.6 kgf-cm
Chapter 3
21. Detach the modem board from the mainboard.
Removing the RTC Battery
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the SD Dummy Card” on page 52.
3.
See “Removing the Express Dummy Card” on page 52.
4.
See “Removing the Lower Cover” on page 53.
5.
See “Removing the DIMM” on page 54.
6.
See “Removing the WLAN Board Module” on page 55.
7.
See “Removing the Hard Disk Drive Module” on page 56.
8.
See “Removing the Optical Drive Module” on page 57.
9.
See “Removing the CPU Heatsink Module” on page 60.
10. See “Removing the CPU” on page 61.
11. See “Removing the Keyboard” on page 62.
12. See “Removing the Middle Cover” on page 63.
13. See “Removing the LCD Module” on page 64.
14. See “Separating the Upper Case from the Lower Case” on page 66.
15. See “Removing the Bluetooth Board” on page 73.
16. See “Removing the USB board” on page 74.
17. See “Removing the Mainboard” on page 76.
18. Detach the battery cable from the mainboard.
Chapter 3
79
19. Carefully detach the RTC battery from the SD card slot.
80
Chapter 3
LCD Module Disassembly Process
LCD Module Disassembly Flowchart
LCD MODULE DISASSEMBLY
LCD MODULE
Gx6
LCD BEZEL
Gx2
INVERTER BOARD
LCD ASSEMBLY
Gx2
Hx2
Hx2
LCD FPC
CABLE
RIGHT LCD
BRACKET
LEFT LCD
BRACKET
Gx1
Gx1
LEFT
RIGHT
HINGE
MAIN
ANTENNA
MICROPHONE
HINGE
AUXILIARY
ANTENNA
LCD BACK PANEL
Main Screw List
Chapter 3
Item
Screw
Part No.
G
M2.5 x L6
86.00E33.736
H
M2 x L3
86.00C07.220
81
Removing the LCD Bezel
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the Lower Cover” on page 53.
3.
See “Removing the DIMM” on page 54.
4.
See “Removing the WLAN Board Module” on page 55.
5.
See “Removing the Hard Disk Drive Module” on page 56.
6.
See “Removing the Optical Drive Module” on page 57.
7.
See “Removing the CPU Heatsink Module” on page 60.
8.
See “Removing the CPU” on page 61.
9.
See “Removing the Keyboard” on page 62.
10. See “Removing the Middle Cover” on page 63.
11. See “Removing the LCD Module” on page 64.
12. Remove the six rounded screw caps as shown.
13. Remove the six screws (G) on the LCD module.
82
Step
Size (Quantity)
Color
Torque
1~4
M2.5 x L6 (6)
Black
3.0 kgf-cm
Chapter 3
14. Carefully pry open the LCD bezel and remove the bezel from the LCD module.
Removing the Inverter Board
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the Lower Cover” on page 53.
3.
See “Removing the DIMM” on page 54.
4.
See “Removing the WLAN Board Module” on page 55.
5.
See “Removing the Hard Disk Drive Module” on page 56.
6.
See “Removing the Optical Drive Module” on page 57.
7.
See “Removing the CPU Heatsink Module” on page 60.
8.
See “Removing the CPU” on page 61.
9.
See “Removing the Keyboard” on page 62.
10. See “Removing the Middle Cover” on page 63.
11. See “Removing the LCD Module” on page 64.
12. See “Removing the LCD Bezel” on page 82.
13. Remove the screw (G) that holds the inverter board to the panel.
Chapter 3
Step
Size (Quantity)
Color
Torque
1~2
M2.5 x L6 (2)
Black
3 kgf-cm
83
14. Turn the inverter board over.
15. Disconnect the 2P cable from the inverter board, then disconnect the inverter board cable from its
connector.
16. Remove the inverter board.
Removing the LCD with Brackets
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the Lower Cover” on page 53.
3.
See “Removing the DIMM” on page 54.
4.
See “Removing the WLAN Board Module” on page 55.
5.
See “Removing the Hard Disk Drive Module” on page 56.
6.
See “Removing the Optical Drive Module” on page 57.
7.
See “Removing the CPU Heatsink Module” on page 60.
8.
See “Removing the CPU” on page 61.
9.
See “Removing the Keyboard” on page 62.
10. See “Removing the Middle Cover” on page 63.
11. See “Removing the LCD Module” on page 64.
12. See “Removing the LCD Bezel” on page 82.
13. See “Removing the Inverter Board” on page 83.
84
Chapter 3
14. Remove the two screws (G) securing the left and right LCD brackets to the LCD back cover.
Step
Size (Quantity)
Color
Torque
1~2
M2.5 x L6 (2)
Silver
2.5 kgf-cm
15. Detach the LCD with the brackets from the back cover, then turn it over.
16. Detach the acetic tapes holding the cables to the back panel.
Chapter 3
85
17. Detach the acetic tapes holding the FPC cable to the edge of the LCD panel.
18. Detach the acetic tape securing the FPC connector.
19. Disconnect the FPC cable from the LCD panel.
86
Chapter 3
Removing the LCD Brackets
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the Lower Cover” on page 53.
3.
See “Removing the DIMM” on page 54.
4.
See “Removing the WLAN Board Module” on page 55.
5.
See “Removing the Hard Disk Drive Module” on page 56.
6.
See “Removing the Optical Drive Module” on page 57.
7.
See “Removing the CPU Heatsink Module” on page 60.
8.
See “Removing the CPU” on page 61.
9.
See “Removing the Keyboard” on page 62.
10. See “Removing the Middle Cover” on page 63.
11. See “Removing the LCD Module” on page 64.
12. See “Removing the LCD Bezel” on page 82.
13. See “Removing the Inverter Board” on page 83.
14. See “Removing the LCD with Brackets” on page 84.
15. Remove the four screws (H) securing the left and right LCD brackets to remove the brackets.
Step
Size (Quantity)
Color
Torque
1~4
M2 x L3 (4)
Silver
1.6 kgf-cm
Removing the LCD Module Hinges
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the Lower Cover” on page 53.
3.
See “Removing the DIMM” on page 54.
4.
See “Removing the WLAN Board Module” on page 55.
5.
See “Removing the Hard Disk Drive Module” on page 56.
6.
See “Removing the Optical Drive Module” on page 57.
7.
See “Removing the CPU Heatsink Module” on page 60.
8.
See “Removing the CPU” on page 61.
9.
See “Removing the Keyboard” on page 62.
10. See “Removing the Middle Cover” on page 63.
11. See “Removing the LCD Module” on page 64.
12. See “Removing the LCD Bezel” on page 82.
13. See “Removing the Inverter Board” on page 83.
14. See “Removing the LCD with Brackets” on page 84.
Chapter 3
87
15. See “Removing the LCD Brackets” on page 87.
16. Remove the two screws (G) securing the left and right LCD module hinges.
Step
Size (Quantity)
Color
Torque
1~2
M2.5 x L6 (2)
Black
3.0 kgf-cm
17. Remove the left and right hinges from the LCD back cover.
Removing the Antennas
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the Lower Cover” on page 53.
3.
See “Removing the DIMM” on page 54.
4.
See “Removing the WLAN Board Module” on page 55.
5.
See “Removing the Hard Disk Drive Module” on page 56.
6.
See “Removing the Optical Drive Module” on page 57.
7.
See “Removing the CPU Heatsink Module” on page 60.
8.
See “Removing the CPU” on page 61.
9.
See “Removing the Keyboard” on page 62.
10. See “Removing the Middle Cover” on page 63.
11. See “Removing the LCD Module” on page 64.
12. See “Removing the LCD Bezel” on page 82.
13. See “Removing the Inverter Board” on page 83.
14. See “Removing the LCD with Brackets” on page 84.
88
Chapter 3
15. Detach the gasket tape holding the right antenna in place, remove the antenna bracket, then carefully
remove the antenna.
16. Detach the gasket tape holding the left antenna in place, remove the antenna bracket, then carefully
remove the antenna.
Removing the Microphone
1.
See “Removing the Battery Pack” on page 51.
2.
See “Removing the Lower Cover” on page 53.
3.
See “Removing the DIMM” on page 54.
4.
See “Removing the WLAN Board Module” on page 55.
5.
See “Removing the Hard Disk Drive Module” on page 56.
6.
See “Removing the Optical Drive Module” on page 57.
7.
See “Removing the CPU Heatsink Module” on page 60.
8.
See “Removing the CPU” on page 61.
9.
See “Removing the Keyboard” on page 62.
10. See “Removing the Middle Cover” on page 63.
11. See “Removing the LCD Module” on page 64.
12. See “Removing the LCD Bezel” on page 82.
Chapter 3
89
13. See “Removing the Inverter Board” on page 83.
14. See “Removing the LCD with Brackets” on page 84.
15. See “Removing the Antennas” on page 88.
16. Carefully remove the microphone cable from underneath the adhesive aluminum foil.
17. Remove the microphone.
90
Chapter 3
Chapter 4
Troubleshooting
Use the following procedure as a guide for computer problems.
NOTE: The diagnostic tests are intended to test only Acer products. Non-Acer products, prototype cards, or
modified options can give false errors and invalid system responses.
1.
Obtain the failing symptoms in as much detail as possible.
2.
Verify the symptoms by attempting to recreate the failure by running the diagnostic tests or repeating the
same operation.
3.
Do not use any power sources when performing an assembly or disassembly procedures.
4.
If any problems occur, you can perform the following visual inspection before you continue.
Chapter 4
T
Power cords are properly connected and secured.
T
There are no obvious shorts or opens.
T
There are no burned or heated components.
T
All components appear normal.
91
System Check Procedures
External CD/DVD-ROM Drive Check
Perform the following procedures to isolate the possible problem a controller, drive, or CD-ROM.
NOTE: Make sure that the CD-ROM does not have any label attached to it. The label may damage the drive or
cause drive failure.
1.
Boot from the diagnostic disc and start the diagnostic programs.
2.
See if CD-ROM Test is passed when the program runs the CD-ROM Test.
3.
Follow onscreen instructions.
If an error occurs, reconnect the drive to the connector on the mainboard. If the error persists, do the following:
1.
Reconnect the CD/DVD-ROM drive.
2.
Replace the CD/DVD-ROM drive.
3.
Replace the mainboard.
Keyboard or Auxiliary Input Device Check
Remove the external keyboard if the internal keyboard is to be tested.
If the internal keyboard does not work or an unexpected error occurs, make sure that the flexible cable
extending from the internal keyboard is correctly connected to the mainboard. If the keyboard cable
connection is correct, run the Keyboard Test.
If the tests detect a keyboard problem, do the following procedures in sequence to correct the problems. Do
not replace a non-defective FRU:
1.
Reconnect the keyboard cable.
2.
Replace the keyboard.
3.
Replace the mainboard.
The following auxiliary input devices are supported by this computer:
T
Numeric keypad
T
External keyboard
If any of these devices do not function, reconnect the cable and repeat above procedures.
Memory Check
NOTE: Make sure that the DIMM is properly installed into the connector. A loose connection can cause an
error.
Do the following:
92
1.
Boot from the diagnostic diskette and start the diagnostic program.
2.
Go to the diagnostic memory in the test items.
3.
Press F2 in the test items.
4.
Follow onscreen instructions.
Chapter 4
Power System Check
Do the following:
1.
Remove the battery pack.
2.
Connect the power adapter and check the power supply.
3.
Disconnect the power adapter and install the battery pack; then check that power supply.
If you suspect a power problem, see the appropriate power supply check in the following list:
T
“Check the Power Adapter” on page 93
T
“Check the Battery Pack” on page 93
Check the Power Adapter
Unplug the power adapter cable from the system and measure the output voltage at the plug of the power
adapter cable.
1.
If the voltage is not correct, replace the power adapter.
2.
If the voltage is within range, do the following:
a.
Replace the System board.
b.
If the problem is not resolved, see “Undetermined Problems” on page 107.
c. If the voltage is not correct, go to the next step.
NOTE: An audible noise from the power adapter does not always indicate a defect.
3.
If the power-on indicator does not light up, check if the adapter’s power cord is properly connected to the
system.
4.
If the operational charge does not work, see “Check the Battery Pack” on page 93.
Check the Battery Pack
Do the following:
Using the software to identify whether a problem occurs while the battery pack during recharge or discharge:
1.
Open Power Management in the Control Panel.
2.
In Power Meter, confirm if the parameters for Current Power Source and Total Battery Power Remaining
are correct.
3.
Repeat the steps 1 and 2 for both battery and adapter.
Using the hardware to identify whether you should replace the battery pack or not:
1.
Power off the system.
2.
Remove the battery pack and measure the voltage between terminals one (+) and seven (-). There are
seven terminals totally.
3.
If the voltage is still less than 7.5 Vdc after recharging, replace the battery.
If the battery status indicator does not light up, remove the battery pack . If the charge indicator still does not
light up, replace the AC/DC charger board.
Chapter 4
93
Touchpad Check
If the touchpad doesn’t work, do the following procedures in sequence to correct the problem. Do not replace
a non-defective FRU:
1.
After rebooting, run Tracking Pad PS2 Mode Driver. For example Syn touch driver.
2.
Run utility with the PS/2 mouse function and check if the mouse is working.
3.
If the PS/2 mouse does not work, then click if the main board to switch board FPC is connected properly.
4.
If the main board to switch board FPC is connected correctly, then check if the FFC on the touch pad PCB
is connected properly.
5.
If the FFC on the touch pad PCB is connected correctly, check if LS851 JP1 Pin6 = 5V are pules. If yes,
then replace switch board. If not, then go to the next step.
6.
Replace the touch pad PCB.
7.
If the touch pad still does not work, then replace the FPC on Track Pad PCB.
After you use the touchpad, the pointer drifts on the screen for a short time. This self-acting pointer movement
will occur when a slight, steady pressure is applied to the touchpad pointer. This symptom is not a hardware
problem. No actions are necessary to be taken if the pointer movement stops in a short period of time.
94
Chapter 4
Power-On Self-Test (POST) Error Message
The POST error message index lists the error message and their possible causes.
NOTE: Perform the FRU replacement or actions in the sequence shown in FRU/Action column, if the FRU
replacement does not solve the problem, put the original part back in the computer. Do not replace a
non-defective FRU.
The error messages are listed in the coming pages to indicate the BIOS signals on the screen and the error
symptoms classified by functions. If the symptom is not included on the list, please refer to “Undetermined
Problems”.
NOTE: Most of the error messages occur during POST. Some of them display information about a hardware
device, e.g., the amount of memory installed. Others may indicate a problem with a device, such as the
way it has been configured.
NOTE: If the system fails after you make changes in the BIOS Setup Utility menus, reset the computer, enter
Setup and install Setup defaults or correct the error.
Chapter 4
95
Index of Error Messages
Error Message List
Error Messages
Check or do the following in sequence:
Stuck Key
See “Keyboard or Auxiliary Input Device Check” on page 92.
System CMOS checksum bad - Default
configuration used
T
Real time clock error
T
T
T
T
Previous boot incomplete - Default
configuration used
T
T
T
Invalid System Configuration Data
T
T
Operating system not found
T
T
T
T
Power-on indicator turns off and LCD is
blank.
T
T
T
T
Power-on indicator turns on and LCD
is blank.
T
T
T
T
T
T
T
Power-on indicator turns on and LCD
is blank. But you can see POST on an
external CRT.
T
T
T
T
T
Power-on indicator turns on and a
blinking cursor shown on LCD during
POST.
T
Failure Fixed Disk
T
T
T
T
T
96
RTC battery.
Run the BIOS Setup Utility to reconfigure the system time,
then reboot system.
RTC battery
Run the BIOS Setup Utility to reconfigure system time, then
reboot system.
Mainboard
Run “Load Setup Defaults” in BIOS Setup Utility.
RTC battery
Mainboard
Run “Load Setup Defaults” in BIOS Setup Utility.
Mainboard
Run the BIOS Setup Utility to check if the fixed disk and drive
A are properly identified.
CD/DVD-ROM drive
Hard disk drive
Mainboard
Power source (battery pack and power adapter.) See “Power
System Check” on page 93.
Ensure every connector is connected tightly and correctly.
Reconnect the DIMM
Mainboard
Power source (battery pack and power adapter.) See “Power
System Check” on page 93.
Reconnect the LCD connector
Hard disk drive
LCD cable
LCD inverter board
LCD
Mainboard
Reconnect the LCD connectors.
LCD cable
LCD inverter board
LCD
Mainboard
Ensure every connector is connected tightly and correctly.
Mainboard
Reconnect the hard disk drive connector.
Run “Load Setup Defaults” in BIOS Setup Utility.
Hard disk drive
Mainboard
Chapter 4
Error Message List
Error Messages
No beep, power-on indicator turns off and
LCD is blank.
Check or do the following in sequence:
T
T
T
T
T
No beep, power-on indicator turns on and
LCD is blank.
T
T
T
T
T
T
T
T
No beep, power-on indicator turns on and
LCD is blank. But you can see POST on an
external CRT.
T
T
T
T
T
T
No beep, power-on indicator turns on and a
blinking cursor shown on LCD during
POST.
T
No beep during POST but system runs
correctly.
T
Chapter 4
T
T
Power source (battery pack and power adapter). See “Power
System Check” on page 93.
Ensure every connector is connected tightly and correctly.
Reconnect the DIMM.
LED board
Mainboard
Power source (battery pack and power adapter). See “Power
System Check” on page 93.
Reconnect the LCD connector
Hard disk drive
LCD inverter ID
LCD cable
LCD Inverter board
LCD
Mainboard
Reconnect the LCD connectors.
LCD inverter ID
LCD cable
LCD inverter board
LCD
Mainboard
Ensure every connector is connected tightly and correctly.
Mainboard
Speaker
Mainboard
97
Phoenix BIOS Beep Codes
Code
Beeps
02h
Verify Real Mode
03h
Disable Non-Maskable Interrupt (NMI)
04h
Get CPU type
06h
Initialize system hardware
08h
Initialize chipset with initial POST values
09h
Set IN POST flag
0Ah
Initialize CPU registers
0Bh
Enable CPU cache
0Ch
Initialize caches to initial POST values
0Eh
Initialize I/O component
0Fh
Initialize the local bus IDE
10h
Initialize Power Management
11h
Load alternate registers with initial POST values
12h
Restore CPU control word during warm boot
13h
Initialize PCI Bus Mastering devices
14h
Initialize keyboard controller
16h
1-2-2-3
17h
BIOS ROM checksum
Initialize cache before memory autosize
18h
8254 timer initialization
1Ah
8237 DMA controller initialization
1Ch
Reset Programmable Interrupt Controller
20h
1-3-1-1
Test DRAM refresh
22h
1-3-1-3
Test 8742 Keyboard Controller
24h
Set ES segment register to 4 GB
26h
Enable A20 line
28h
Autosize DRAM
29h
Initialize POST Memory Manager
2Ah
Clear 215 KB base RAM
2Ch
1-3-4-1
RAM failure on address line xxxx*
2Eh
1-3-4-3
RAM failure on data bits xxxx* of low byte of memory bus
1-4-1-1
RAM failure on data bits xxxx* of high byte of memory bus
2Fh
30h
98
POST Routine Description
Enable cache before system BIOS shadow
32h
Test CPU bus-clock frequency
33h
Initialize Phoenix Dispatch Manager
36h
Warm start shut down
38h
Shadow system BIOS ROM
3Ah
Autosize cache
3Ch
Advanced configuration of chipset registers
3Dh
Load alternate registers with CMOS values
42h
Initialize interrupt vectors
45h
POST device initialization
Chapter 4
Code
46h
Beeps
2-1-2-3
48h
POST Routine Description
Check ROM copyright notice
Check video configuration against CMOS
49h
Initialize PCI bus and devices
4Ah
Initialize all video adapters in system
4Bh
QuietBoot start (optional)
4Ch
Shadow video BIOS ROM
4Eh
Display BIOS copyright notice
50h
Display CPU type and speed
51h
Initialize EISA board
52h
Test keyboard
54h
58h
Set key click if enabled
2-2-3-1
Test for unexpected interrupts
59h
Initialize POST display service
5Ah
Display prompt “Press F2 to enter SETUP”
5Bh
Disable CPU cache
5Ch
Test RAM between 512 and 640 KB
60h
Test extended memory
62h
Test extended memory address lines
64h
Jump to User Patch1
66h
Configure advanced cache registers
67h
Initialize Multi Processor APIC
68h
Enable external and CPU caches
69h
Setup System Management Mode (SMM) area
6Ah
Display external L2 cache size
6Bh
Load custom defaults (optional)
6Ch
Display shadow-area message
6Eh
Display possible high address for UMB recovery
70h
Display error messages
72h
Check for configuration errors
76h
Check for keyboard errors
7Ch
Set up hardware interrupt vectors
7Eh
Initialize coprocessor if present
80h
Disable onboard Super I/O ports and IRQs
81h
Late POST device initialization
82h
Detect and install external RS232 ports
83h
Configure non-MCD IDE controllers
84h
Detect and install external parallel ports
85h
Initialize PC-compatible PnP ISA devices
86h
Re-initialize onboard I/O ports
87h
Configure Motherboard Configurable Devices (optional)
88h
Initialize BIOS Data Area
89h
Enable Non-Maskable Interrupts (NMIs)
Chapter 4
99
Code
Beeps
8Ah
Initialize Extended BIOS Data Area
8Bh
Test and initialize PS/2 mouse
8Ch
Initialize floppy controller
8Fh
Determine number of ATA drives (optional)
90h
Initialize hard-disk controllers
91h
Initialize local-bus hard-disk controllers
92h
Jump to UserPatch2
93h
Build MPTABLE for multi-processor boards
95h
Install CD-ROM for boot
96h
Clear huge ES segment register
97h
98h
Fixup Multiprocessor table
1-2
Search for option ROMs. One long, two short beeps on checksum
failure.
99h
Check for SMART drive (optional)
9Ah
Shadow option ROMs
9Ch
Set up Power Management
9Dh
Initialize security engine (optional)
9Eh
Enable hardware interrupts
9Fh
Determine number of ATA and SCSI drives
A0h
Set time of day
A2h
Check key lock
A4h
Initialize Typematic rate
A8h
Erase F2 prompt
AAh
Scan for F2 key stroke
ACh
Enter SETUP
AEh
Clear Boot flag
B0h
Check for errors
B2h
POST done- prepare to boot operating system
B4h
100
POST Routine Description
1
One short beep before boot
B5h
Terminate QuietBoot (optional)
B6h
Check password (optional)
B9h
Prepare Boot
BAh
Initialize DMI parameters
BBh
Initialize PnP Option ROMs
BCh
Clear parity checkers
BDh
Display MultiBoot menu
BEh
Clear screen (optional)
BFh
Check virus and backup reminders
C0h
Try to boot with INT 19
C1h
Initialize POST Error Manager (PEM)
C2h
Initialize error logging
C3h
Initialize error display function
Chapter 4
Code
Beeps
POST Routine Description
C4h
Initialize system error handler
C5h
PnPnd dual CMOS (optional)
C6h
Initialize notebook docking (optional)
C7h
Initialize notebook docking late
C8h
Force check (optional)
C9h
Extended checksum (optional)
D2h
Unknown interrupt
* If the BIOS detects error 2C, 2E, or 3O (base 512K RAM error), it displays an additional word-bitmap (xxxx) indicating
the address line or bits that failed. For example, "2C 0002" means address line 1 (bit one set) has failed. "2E 1020"
means data bits 12 and 5 (bits 12 and 5 set) have failed in the lower 16 bits. Note that error 30 cannot occur on 386SX
systems because they have a 16 rather than 32-bit bus. The BIOS also sends the bitmap to the port-80 LED display. It
first displays the check point code, followed by a delay, the high-order byte, another delay, and then the low-order byte
of the error. It repeats this sequence continuously.
BIOS Beep Codes for Boot Block in Flash ROM
Code
Beeps
For Boot Block in Flash ROM
E0h
Initialize the chipset
E1h
Initialize the bridge
E2h
Initialize the CPU
E3h
Initialize the system timer
E4h
Initialize system I/O
E5h
Check force recovery boot
E6h
Checksum BIOS ROM
E7h
Go to BIOS
E8h
Set Huge Segment
E9h
Initialize Multiprocessor
EAh
Initialize OEM special code
EBh
Initialize PIC and DMA
ECh
Initialize Memory type
EDh
Initialize Memory size
EEh
Shadow Boot Block
EFh
System memory test
F0h
Initialize interrupt vectors
F1h
Initialize Run Time Clock
F2h
Initialize video
F3h
Initialize System Management Mode
F4h
1
Output one beep before boot
F5h
Boot to Mini DOS
F6h
Clear Huge Segment
F7h
Boot to Full DOS
Chapter 4
101
Index of Symptom-to-FRU Error Message
LCD-Related Symptoms
Symptom / Error
LCD backlight doesn't work
LCD is too dark
LCD brightness cannot be adjusted
LCD contrast cannot be adjusted
Check or do the following in sequence
T
T
T
T
T
T
T
T
Unreadable LCD screen
Missing pels in characters
Abnormal screen
Wrong color displayed
T
T
T
T
T
T
LCD has extra horizontal or vertical lines
displayed.
T
T
T
T
T
Run “Load Setup Defaults” in BIOS Setup Utility, then reboot
system.
Reconnect the LCD connectors.
Keyboard (if contrast and brightness function key doesn't
work).
LCD inverter ID
LCD cable
LCD inverter board
LCD
Mainboard
Reconnect the LCD connector
LCD inverter ID
LCD cable
LCD inverter board
LCD
Mainboard
LCD inverter ID
LCD inverter board
LCD cable
LCD
Mainboard
Indicator-Related Symptoms
Symptom / Error
Indicator incorrectly remains off or on, but
system runs correctly
Check or do the following in sequence
T
T
Reconnect the LCD inverter board.
Mainboard
Power-Related Symptoms
Symptom / Error
Power shuts down during operation
Check or do the following in sequence
T
T
T
T
T
The system doesn’t power-on.
T
T
T
T
T
102
Power source (battery pack and power adapter). See “Power
System Check” on page 93.
Battery pack
Power adapter
Hard disk drive & battery connection board
Mainboard
Power source (battery pack and power adapter). See “Power
System Check” on page 93.
Battery pack
Power adapter
Hard disk drive & battery connection board
Mainboard
Chapter 4
Power-Related Symptoms
Symptom / Error
The system doesn’t power-off.
Check or do the following in sequence
T
T
T
Battery can’t be charged
T
T
T
Power source (battery pack and power adapter). See “Power
System Check” on page 93.
Hold and press the power switch for more than 4 seconds.
Mainboard
See “Check the Battery Pack” on page 93.
Battery pack
Mainboard
PCMCIA-Related Symptoms
Symptom / Error
Check or do the following in sequence
PCMCIA slot assembly
Mainboard
System cannot detect the PC Card
(PCMCIA)
T
PCMCIA slot pin is damaged.
PCMCIA slot assembly
T
Memory-Related Symptoms
Symptom / Error
Memory count (size) appears different from
actual size.
Check or do the following in sequence
T
T
T
Run “Load Setup Defaults” in BIOS Setup Utility, then reboot
system.
DIMM
Mainboard
Speaker-Related Symptoms
Symptom / Error
In Windows, multimedia programs, no
sound comes from the computer.
Check or do the following in sequence
T
T
T
Internal speakers make noise or emit no
sound.
T
T
Audio driver
Speaker
Mainboard
Speaker
Mainboard
Power Management-Related Symptoms
Symptom / Error
The system will not enter hibernation
Check or do the following in sequence
T
T
T
T
The system doesn't enter hibernation mode
and four short beeps every minute.
T
T
T
T
T
T
The system doesn’t enter standby mode
after closing the LCD
Chapter 4
T
T
See “Save to Disk (S4)” on page 44.
Keyboard (if control is from the keyboard)
Hard disk drive
Mainboard
Press Fn+o and see if the computer enters hibernation
mode.
Touchpad
Keyboard
Hard disk connection board
Hard disk drive
Mainboard
See “Save to Disk (S4)” on page 44.
Mainboard
103
Power Management-Related Symptoms
Symptom / Error
The system doesn't resume from
hibernation mode.
Check or do the following in sequence
T
T
T
T
The system doesn't resume from standby
mode after opening the LCD.
T
Battery fuel gauge in Windows doesn’t go
higher than 90%.
T
T
T
T
T
System hangs intermittently.
T
T
T
See “Save to Disk (S4)” on page 44.
Hard disk connection board
Hard disk drive
Mainboard
See “Save to Disk (S4)” on page 44.
Mainboard
Remove battery pack and let it cool for 2 hours.
Refresh battery (continue use battery until power off, then
charge battery).
Battery pack
Mainboard
Reconnect hard disk/CD-ROM drives.
Hard disk connection board
Mainboard
Peripheral-Related Symptoms
Symptom / Error
System configuration does not match the
installed devices.
Check or do the following in sequence
T
T
Run “Load Setup Defaults” in BIOS Setup Utility, then reboot
system.
Reconnect hard disk/CD-ROM/diskette drives.
T
Press Fn+F5 to switch to LCD or CRT
Mainboard
USB does not work correctly
T
Mainboard
Print problems.
T
Run printer self-test.
Printer driver
Printer cable
Printer
Mainboard
External display does not work correctly.
T
T
T
T
T
Keyboard/Touchpad-Related Symptoms
Symptom / Error
Keyboard (one or more keys) does not
work.
Check or do the following in sequence
T
T
T
Touchpad does not work.
T
T
T
104
Reconnect the keyboard cable.
Keyboard
Mainboard
Reconnect touchpad cable.
Touchpad board
Mainboard
Chapter 4
Modem-Related Symptoms
Symptom / Error
Internal modem does not work correctly.
Check or do the following in sequence
T
T
T
Modem phone port
Modem combo board
Mainboard
NOTE: If you cannot find a symptom or an error in this list and the problem remains, see “Undetermined
Problems” on page 107.
Chapter 4
105
Intermittent Problems
Intermittent system hang problems can be caused by a variety of reasons that have nothing to do with a
hardware defect, such as: cosmic radiation, electrostatic discharge, or software errors. FRU replacement
should be considered only when a recurring problem exists.
When analyzing an intermittent problem, do the following:
106
1.
Run the advanced diagnostic test for the mainboard in loop mode at least 10 times.
2.
If no error is detected, do not replace any FRU.
3.
If any error is detected, replace the FRU. Rerun the test to verify that there are no more errors.
Chapter 4
Undetermined Problems
The diagnostic problems does not identify which adapter or device failed, which installed devices are incorrect,
whether a short circuit is suspected, or whether the system is inoperative.
NOTE: Verify that all attached devices are supported by the computer.
NOTE: Verify that the power supply being used at the time of the failure is operating correctly. (See “Power
System Check” on page 93.)
Follow procedures below to isolate the failing FRU. Do not isolate non-defective FRU.
1.
Power off the computer.
2.
Visually check them for damage. If any problems are found, replace the FRU.
3.
Remove or disconnect all of the following devices:
T
Non-Acer devices
T
Printer, mouse, and other external devices
T
Battery pack
T
Hard disk drive
T
DIMM
T
CD/DVD-ROM drive
T
PC cards
4.
Power on the computer.
5.
Determine if the problem has been resolved.
6.
If the problem does not recur, reconnect the removed devices one at a time until you find the failed FRU.
7.
If the problem persists, replace the following FRU one at a time. Do not replace a non-defective FRU.
Chapter 4
T
System board
T
LCD assembly
107
108
Chapter 4
Chapter 5
System Block Diagram and Connector Locations
System Block Diagram
Chapter 5
109
Board Layout
Top View
110
#
Item
#
Item
1
LCD connector
6
Power board cable connector
2
Internal microphone cable connector
7
USB board cable connector
3
Speaker cable connector
8
ExpressCard/54 slot
4
Keyboard cable connector
9
ICH8-M chipset (south bridge)
5
Touchpad cable connector
10
Launch board cable connector
Chapter 5
Bottom View
#
Item
#
Item
1
AC-in jack
11
5-in-1 card reader
2
Mini-card connector
12
RTC battery cable connector
3
Battery cable connector
13
Modem board
4
CPU
14
Volume control wheel
5
Intel PM965 Express chipset (north bridge)
15
Line-in jack
6
CRT port
16
Microphone jack
7
RJ11+RJ45 port
17
Line-out jack
8
S-video port
18
ODD connector
9
USB ports
19
HDD connector
10
1394 port
20
DIMM slot
Chapter 5
111
Switch Setting
Short G68 to clear password.
112
Chapter 5
Standard Operation Procedures of Password Bypassing and BIOS Recovery
For RD and CSD to debug easily, the system provide one hardware DIP switch for Bypassing Password
Check, and one Hotkey to enable BIOS Recovery.
1.
DIP Switches:
DIP
SW1 (G68)
2.
Default Setting
Disabled (High)
Description
Bypassing Password Check
Hotkey to enable BIOS Recovery: Fn+ESC, then Power Button. To use this function, it is strongly
recommended that the AC adapter is connected to the system and plug-in to a wall outlet and the Battery
is also in the system
Bypassing Password Check (SW1): If the user has set Password (power-on or setup password) for security
reason, BIOS will check password during POST or when entering the BIOS setup menu. However, if it is
necessary to ignore the password check, the user may enable DIP SW1 to bypass password check.
BIOS Recovery: Boot Block is a special block of BIOS. It is used to boot up the system with minimum BIOS
initialization. The user can enable this feature to restore the BIOS to a successful one if previous BIOS flashing
process fails.
1.
DIP Location:
RD/CSD can enable or disable this function by switching the DIP. The DIP switch is located as shown in the
figure below:
G68
2.
Clear Password
DIP SW1: Bypassing Password Check, Disabled by default. Switching it to ON then powering on the system
will force the BIOS to clear Supervisor and User passwords. The power-on, setup password, and the HDD
password are all cleared.
Chapter 5
113
3.
Restore BIOS by the Crisis Disk
Enable this function by pressing the combination: Fn+ESC, and pressing the Power Button. To use this
function, it is strongly recommended that the AC adapter is connected to the system and plug-in to a wall outlet
and the Battery is also in the system. If this function is enabled, the system will force the BIOS to enter a
special BIOS block, called BootBlock. RD/CSD can use this special BIOS code to recover the BIOS to a
successful one if previous BIOS flashing process fails. However, before doing this, one Crisis Disk should be
prepared in WinXP. Detailed steps are as the followings:
a.
Prepare the Crisis Disk in WinXP.
b.
Insert the Crisis Disk to a USB floppy drive which is attached to the failed machine.
c.
While the system is turned off, press and hold Fn+ESC, then press Power Button. The system
should be powered on with Crisis Recovery process.
d.
BootBlock BIOS starts to restore the failed BIOS code. Short beeps should be heard when flashing.
e.
If the flashing process is finished, a long beep should be heard.
f.
Power down the system after you hear the long beep.
If the crisis recovery process is finished, the system should be powered on with the successful BIOS. RD/CSD
can then update the BIOS to a workable one by regular BIOS flashing process.
114
Chapter 5
Chapter 6
FRU (Field Replaceable Unit) List
This chapter offers the FRU (Field Replaceable Unit) list in global configuration of Aspire 4710/4310. Refer to
this chapter whenever ordering the parts to repair or for RMA (Return Merchandise Authorization).
NOTE: When ordering FRU parts, check the most up-to-date information available on your regional web or
channel. For whatever reasons a part number is changed, it will NOT be noted on the printed Service
Guide. For Acer authorized service providers, your Acer office may have a different part number code
from those given in the FRU list of this printed Service Guide. You MUST use the local FRU list provided
by your regional Acer office to order FRU parts for service.
NOTE: To scrap or to return the defective parts, follow the local government ordinance or regulations on how
to dispose it properly, or follow the rules set by your regional Acer office on how to return it.
Chapter 6
115
Aspire 4710/4310 Exploded Diagram
116
Chapter 4
Aspire 4710 FRU List
Category
Part Name
Description
Acer Part No.
Adapter
Adapter 65W Delta ADP-65KB
DFA LF
ADT 65W SADP-65KB DFA LF
Delta
AP.06501.013
Adapter 65W Liteon PA-165002WR
ADT 65W Liteon PA-165002WR
AP.06503.011
Adapter 65W Liteon PA-165002AC LF
ADT 65W PA-1650-02AC LF
AP.06503.016
Battery Pack Li+6 cell 2.0mAh
Sanyo
BTY Pack Li+6C 2.0Ah Sanyo
BT.00603.036
Battery Pack Li+6 cell 2.4mAh
Sanyo
BTY Pack LI+6C 2.4Ah Sanyo
BT.00603.037
Battery Pack Li-ion 6 cell
2.0mAh Sony
BTY Pack Li+6C 2.0Ah Sony
BT.00604.022
Battery Pack Li-ion 6 cell
2.4mAh Sony
BTY Pack Li+6C 2.4Ah Sony
BT.00604.023
Battery Pack Li-Mn 6 cell
2.0mAh Panasonic
BTY Pack Li+6C 2.0Ah PANA
BT.00605.018
Battery Pack Li-Mn 6 cell
2.4mAh Panasonic
BTY Pack Li+6C 2.4Ah PANA
BT.00605.019
Battery Pack Li-Mn 6 cell 2.0
Simplo
BTY Pack Li+6C 2.0Ah SMP
BT.00607.013
Battery Pack Li-ion 6 cell
2.4mAh Simplo
BTY Pack PANA Li 6C 2.4
SMP
BT.00607.014
Bluetooth board Foxconn
BCM2045 V01
BT Module Foxconn BCM2045
V01
56.25020.003
Modem board
Modem MDC003 A8B
B85244300G
54.09027.091
Modem board Foxconn MDC1.5
T60M955.00 3.3V
Modem MDC1.5 T60M955.00
3.3V
54.09018.051
Touchpad board Synaptics
TM00450-000
Touchpad Synaptics TM00450000
56.17024.001
Launch board
Tahoe LAU-BD 06626-1 PD
(D)
55.4T902.001G
USB board
Tahoe USB-BD 06628-1 PD
(D)
55.4T904.001G
Battery
Boards
Chapter 4
117
Category
Part Name
Description
Acer Part No.
Power board
Volvi PWR-BD 06627-1 (D) PD
55.4U703.001G
Wireless LAN 802.11ABGN
Kedron MOW1
WLAN 802.11ABGN Kedron
MOW1
KI.KDN01.001
Wireless LAN 802.11ABGN
Kedron MOW2
WLAN 802.11ABGN Kedron
MOW2
KI.KDN01.002
Wireless LAN 802.11ABGN
Kedron ROW
WLAN 802.11ABGN Kedron
ROW
KI.KDN01.003
Wireless LAN Board 802.11ABG
Intel 3945 MW1
WLAN 802.11ABG Intel 3945
MW1
KI.GLN01.001
Wireless LAN Board 802.11ABG
Intel 3945 MW2
WLAN 802.11ABG Intel 3945
MW2
KI.GLN01.002
Wireless LAN Board 802.11ABG
Intel 3945 RW
WLAN 802.11ABG Intel 3945
RW
KI.GLN01.003
Wireless LAN Board 802.11BG
Intel 3945BG
WLAN PRO/Wireless 3945BG
KI.GLN01.005
Wireless LAN 802.11BG
Foxconn BCM4311
WLAN 802.11BG BCM4311
WW SKU
54.AEFV1.001
Wireless LAN board
Cables
118
Bluetooth cable HL
C.A. B.T HL
50.4T910.001
Bluetooth cable MEC
C.A. B.T MEC
50.4T910.011
Power board cable
C.A. power board FFC
50.4T905.001
USB cable HL
C.A. USB HL
50.4T906.001
USB cable MEC
C.A. USB MEC
50.4T906.011
Touchpad cable
C.A. T/P FFC
50.4T903.001
Launch board cable
C.A. launch board FFC
50.4T904.001
DC-in cable HL
C.A. DC-in HL
50.4T908.001
DC-in cable MEC
C.A. DC-in MEC
50.4T908.011
Modem cable
C.A. MDC HL
50.4T909.001
Power cord 10A 125V US
Code US 10A 125V BK
27.01518.521
Power cord 10A 125V 3-pin US
BK
Code 10A 125V 3P US BK
27.01518.641
Power cord 2.5A 125V USA
Code USA/W CNS 2.5A 125V
8121
27.01518.781
Power cord 3A 250V 3-pin UK
Code UK 3A 250V 3P BK
27.01518.541
Power cord 5A 250V 3-pin UK
BK
Code 5A 250V 3P UK BK
27.03118.001
Power cord 10A 3-pin BK
Denmark
Code Denmark 10A 3P BK
27.01518.561
Power cord 10A 250V 3-pin
Denmark BK
Code 10A 250V 3P Denmark
BK
27.01518.671
Power cord 10A 250V 3-pin
South Africa
Code South Africa 10A 250V
BK
27.01518.571
Chapter 4
Category
Cables (cont.)
Part Name
Description
Acer Part No.
Power cord 16A 250V South
Africa BK
Code 16A 250V South Africa
BK
27.01518.681
Power cord 10A 250V Swiss
Code Swiss Power 10A 250V
BK
27.01518.581
Power cord 10A 250V 3-pin
Swiss BK
Code 10A 250V 3P Swiss Bk
27.01518.691
Power cord 10A 250V 3-pin
China
Cord China 10A 250V 3P
27.01518.591
Power cord 10A 250V 3-pin
China BK
Cord 10A 250V 3P China BK
27.01518.701
Power cord 220V 3-pin EUR
Cord EUR 220V 3P BK
27.01518.601
Power cable 16A 250V 3-pin
EUR BK
Cord 16A 250V 3P EUR BK
27.01518.731
Power cord 10A 250V 3-pin Italy
Cord Italy 10A 250V 3P BK
27.01518.611
Power cord 10A 250V 3-pin Italy
BK
Cord 10A 250V 3P Italy BK
27.01518.711
Power cord 2.5A 250V South
Africa BK (India)
Cord 2.5A 250V South Africa
Bk
27.01518.631
Power cord 10A 250V South
Africa BK (India)
Cord 10A 250V South Africa
BK
27.01518.721
Power cord 250V 10A 3-pin
Israel
Cord 250V 10~16A 3P Israel
27.01518.761
Power cord ACA/ACNZ
Power cord ACA/ACNZ Annie
27.03218.021
LCD latch bracket
LCD latch ASSY
60.4T906.001
SD dummy card
SD dummy card
42.TKJ01.001
New card dummy card
Dummy new card
42.4T924.001
Lowercase
ASSY L-Case
60.4U704.001
Unitload cover
ASSY big door
60.4T908.001
E-key cover
ASSY E-key
60.4U703.001
Support bracket left
Support L ASSY
60.4T905.001
Touchpad bracket
TP bracket ASSY
60.4T904.001
Middle cover
ASSY M-cover
60.4U701.001
Upper case w/ speaker
U-Case ASSY AS4710
60.4U709.001
System case/cover/bracket/assembly
Chapter 4
119
Category
Part Name
Description
Acer Part No.
Memory
SDIMM 1GB Hynix
HYMP512S64CP8-Y5 AB
SODIMM 1G
HYMP512S64CP8-Y5 AB
KN.1GB0G.006
SDIMM 1GB Nanya
NT1GT64U8HB0BN-3C
SODIMM 1G
NT1GT64U8HB0BN-3C
KN.1GB03.014
SDIMM 1GB Samsung
M470T2953EZ3-CE6
SODIMM 1GB
M470T2953EZ3-CE6
KN.1GB0B.011
SDIMM 512MB Hynix
HYMP564S64CP6-Y5 AB
SODIMM 512M
HYMP564S64CP6-Y5 AB
KN.5120G.019
SDIMM 512MB Nanya
NT512T64UH8B0FN-3C
SODIMM 512M
NT512T64UH8B0FN-3C
KN.51203.032
SDIMM 512MB Samsung
M470T6554EZ3-CE6 LF
SODIMM 512M
M470T6554EZ3-CE6
KN.5120B.023
SDIMM 512MB PSC
AS6E8E63B-6E1A
SODIMM 512M AS6E8E63B6E1A
KN.5120E.004
SDIMM 512MB DDRII667
Promos V916764B24QBFW-F5
LF
SODIMM 512M
V916764B24QBFW-F5
KN.5120M.004
Combo module 24X
ODD NCB24X combo
G2.OPAHQ.001
Optical bracket
BRKT ODD
33.4T910.001
Combo bezel
ASSY ODD bezel combo
60.4T914.001
Combo module 24X PDBS DS24CZP w/o bezel
Combo 24X PDBS DS-24CZP
KO.02409.029
Combo module 24X Sony
CRX880A LF w/o bezel
Combo 24X Sony/CRX880A
Myall2
KO.0240E.005
DVD-RW Super Multi module 8X
ODD NSM8X Super-multi drive
TA
G2.OPAHQ.002
Optical bracket
BRKT ODD
33.4T910.001
Super Multi bezel
ASSY ODD bezel S-Multi
60.4T915.001
DVD-RW drive 8X Super Mult
Pioneer DVR-K17RS LF w/o
bezel
S-Mult 8X PIO/DVR-K17RS
KU.00805.038
DVD-RW drive 8X Super Mult
Panasonic UJ-850UAA1-A w/o
bezel
S-Mult PAN/UJ-850UAA1-A
KU.00807.055
DVD-RW drive 8X Super Multi
PDBS DS-8A1P
8X S-Multi PDBS/DS-8A1P
KU.00809.010
DVD-RW drive 8X Super Mult
Sony AD-7560A
8X S-Mult Sony/AD-7560A
KU.0080E.005
Combo module
DVD module
120
Chapter 4
Category
Part Name
Description
Acer Part No.
HDD/Hard Disk Drive
HDD bracket
ASSY HDD bracket
60.4T918.001
HDD module 80G 5400RPM
SATA
HDD N80GB5.4KS Bracket
G2.HDAHQ.001
HDD 80GB SATA Hitachi
HTS541680J9SA00
HDD 80GB SATA
HTS541680J9SA00
KH.08007.021
HDD 80GB Seagate
ST980811AS
HDD 80GB SGT ST980811AS
KH.08001.030
HDD 80GB 5400RPM SATA
Toshiba MK8037GSX Gemini
BS LF F/W:DL230
HDD 80GB Toshiba
MK8037GSX
KH.08004.010
HDD 80GB 5400RPM SATA WD
WD800BEVS-22RST0 ML80 LF
F/W:04.01G04
HDD 80GB WD WD800BEVS22RST0
KH.08008.033
HDD module 120G 5400RPM
SATA
HDD N120GB5.4KS
G2.HDAHQ.002
HDD 120GB SATA Hitachi
HTS541612J9SA00
HDD 120GB SATA
HTS541612J9SA00
KH.12007.010
HDD 120GB Seagate
ST9120822AS
HDD 120GB SGT
ST9120822AS
KH.12001.031
HDD 120GB 5400RPM SATA
Toshiba MK1237GSX Gemini
BS LF F/W:DL130J
HDD 120GB Toshiba
MK1237GSX
KH.12004.006
HDD 120GB WD
WD1200BEVS-22RST0
HDD 120GB WD
WD1200BEVS-22RST0
KH.12008.018
HDD module 160G 5400RPM
SATA
HDD N160GB5.4KS
G2.HDAHQ.003
HDD 160GB SATA Hitachi
HTS541616J9SA00
HDD 160GB SATA
HTS541616J9SA00
KH.16007.011
HDD 160GB Seagate
ST9160821AS
HDD 160GB SGT
ST9160821AS
KH.16001.026
HDD 160GB 5400RPM SATA
Toshiba MK1637GSX Gemini
BS LF F/W:DL030J
HDD 160GB Toshiba
MK1637GSX
KH.16004.001
HDD 160GB WD
WD1600BEVS-22RST0
HDD 160GB WD
WD1600BEVS-22RST0
KH.16008.019
CPU heatsink w/ fan
ASSY Thermal UMA Foxconn
60.4T927.001
CPU Heatsink
Chapter 4
121
Category
Part Name
Description
Acer Part No.
CPU/Processor
CPU Merom T5500 1.66GHz
Intel
IC CPU Merom T5500 1.66G
PGA B
KC.55001.DTP
CPU Merom T5300 1.73GHz
Intel
IC CPU Merom T5300 1.73G
PGA
KC.53001.DTP
CPU Merom T5500 1.66GHz
Intel
IC CPU Merom T5500 1.66G
PGA
KC.55L01.DTP
CPU Merom T5600 1.83GHz
Intel
IC CPU Merom T5600 1.83
PGA
KC.56L01.DTP
CPU Merom T7200 2.0GHz
Intel
IC CPU Merom T7200 2.0G
PGA B2
KC.72001.DTP
CPU Merom T7400 2.16GHz
Intel
IC CPU Merom T7400 2.16G
PGA B
KC.74001.DTP
CPU Merom T7600 2.33GHz
Intel
IC CPU Merom T7600 2.33G
PGA
KC.76001.DTP
CPU Yonah T2350 1.86GHz
Intel
IC CPU Yonah T2350 1.86G
PGA
KC.23501.DTP
CPU Yonah T2450 2.0GHz Intel
IC CPU Yonah T2450 2.0G
PGA D0
KC.24501.DTP
CPU Merom Cel-M 530
1.73GHz Intel
IC CPU Merom Cel-M 530
1.73G
KC.N0001.530
CPU Merom Cel-M 520 1.6GHz
Intel
IC CPU merom Cel-M 520
1.6G
KC.N0001.520
CPU Yonah 440 1.86GHz Intel
IC CPU Yonah 440 1.86G PGA
D0
KC.ND001.440
CPU Yonah T2080 1.73GHz
Intel
IC CPU Yonah T2080 1.73G
PGA
KC.20801.DTP
Keyboard 88 key Darfon NSKH3V1D UI US-IN
KB Darfon NSK-H3V1D UI USIN88
9J.N5982.V1D
Keyboard 88 key Darfon NSKH3V02 TW Taiwan
KB Darfon NSK-H3V02 TW
Taiwa88
9J.N5982.V02
Keyboard 88 key Darfon NSKH3V03 TI Thailand
KB Darfon NSK-H3V03 TI
Thai88
9J.N5982.V03
Keyboard 88 key Darfon NSKH3V0A Ar Arabic
KB Darfon NSK-H3V0A AR
Arabi88
9J.N5982.V0A
Keyboard 88 key Darfon NSKH3V0H HB Hebrew
KB Darfon NSK-H3V0H HB
Hebre88
9J.N5982.V0H
Keyboard 88 key Darfon NSKH3V0K KO Korean
KB Darfon NSK-H3V0K KO
Korea88
9J.N5982.V0K
Keyboard 88 key Darfon NSKH3V0L GK Greek
KB Darfon NSK-H3V0L GK
Greek88
9J.N5982.V0L
Keyboard 88 key Darfon NSKH3V0R RU Russian
KB Darfon NSK-H3V0R RU
Russi88
9J.N5982.V0R
Keyboard 88 key Darfon NSKH3V0X Blank US
KB Darfon NSK-H3V0X BL84K(88)
9J.N5982.V0X
Keyboard 89 key Darfon NSKH3V06 PO Portuguese
KB Darfon NSK-H3V06 PO
Portu89
9J.N5982.V06
Keyboard
122
Chapter 4
Category
Keyboard (cont.)
Part Name
Description
Acer Part No.
Keyboard 89 key Darfon NSKH3V0C CZ Czech
KB Darfon NSK-H3V0C
Czech89
9J.N5982.V0C
Keyboard 89 key Darfon NSKH3V0D DM Danish
KB Darfon NSK-H3V0D DM
Danis89
9J.N5982.V0D
Keyboard 89 key Darfon NSKH3V0E IT Italian
KB Darfon NSK-H3V0E IT
Itali89
9J.N5982.V0E
Keyboard 89 key Darfon NSKH3V0FFR French
KB Darfon NSK-H3V0F FR
Rehcn89
9J.N5982.V0F
Keyboard 89 key Darfon NSKH3V0G GR German
KB Darfon NSK-H3V0G GR
Germa89
9J.N5982.V0G
Keyboard 89 key Darfon NSKH3V00 SW Swiss
KB Darfon NSK-H3V00 SW
Swiss89
9J.N5982.V00
Keyboard 89 key Darfon NSKH3V0M Canadian
KB Darfon NSK-H3V0M CF
FR.CA89
9J.N5982.V0M
Keyboard 89 key Darfon NSKH3V0N NW Norwegian
KB Darfon NSK-H3V0N NW
Norwe89
9J.N5982.V0N
Keyboard 89 key Darfon NSKH3V0Q HG Hungarian
KB Darfon NSK-H3V0Q HG
Huga89
9J.N5982.V0Q
Keyboard 89 key Darfon NSKH3V0S SP Spanish
KB Darfon NSK-H3V0S SP
Spani89
9J.N5982.V0S
Keyboard 89 key Darfon NSKH3V0T TR Turkish
KB Darfon NSK-H3V0T TR
Turki89
9J.N5982.V0T
Keyboard 89 key Darfon NSKH3V0U UK UK
KB Darfon NSK-H3V0U UK
UK89
9J.N5982.V0U
Keyboard 89 key Darfon NSKH3V0W SD Swedish
KB Darfon NSK-H3V0W SD
Swedi89
9J.N5982.V0W
Keyboard 89 key Darfon NSKH3V1A BE Belgian
KB Darfon NSK-H3V1A BE
Belgian
9J.N5982.V1A
Keyboard 89 key Darfon NSKH3V01B BP Brazilian
KB Darfon NSK-H3V1B BP
BR-PO89
9J.N5982.V1B
Keyboard 89 key Darfon NSKH3V1F SK Slovenian
KB Darfon NSK-H3V1F SK
Slove89
9J.N5982.V1F
Keyboard 89 key Darfon NSKH3V0Y BL-85K
KB Darfon NSK-H3V0Y BL85K(89)
9J.N5982.V0Y
Keyboard 92 key Darfon NSKH3V0J JA Japanese
KB Darfon NSK-H3V0J JA
Japan92
9J.N5982.V0J
LCD module 14.1” WXGA glare
w/ antenna and camera
LCD 14.1” camera 0.3M
PC+ABS
G2.LDAHQ.001
Inverter board 17" FOXCONN
T62I240.02 V.00
Inverter 17” T62I240.02 V.00
19.TK501.001
Inverter board 17” YEC YNVW06S
Inverter 17” YNV-W06S
19.21072.013
Inverter board 17” Darfon
VK.21189.406
Inverter 17” ROHS
VK.21189.406
19.21066.034
LCD cable 14.1: WXGA HL
C.A. LCD WXGA HL
50.4T901.001
LCD cable 14.1: WXGA MEC
C.A. LCD WXGA MEC
50.4T901.011
LCD module
Chapter 4
123
Category
LCD module
(cont.)
Part Name
Description
Acer Part No.
Camera CMOS 0.3M Suyin
CN0314-OV03 U
Camera CMOS 0.3M CN0314OV03 U
57.TK901.001
Camera CMOS 0.3M Bison
BN30V40717300
Camera CMOS 0.3M
BN30V40717300
57.TK501.001
LCD bracket right
Bracket LCD R
33.4T904.001
LCD bracket left
Bracket LCD L
33.4T905.001
LCD bezel 14.1”
ASSY bezel
60.4U707.001
LCD panel 14.1”
ASSY LCD panel
60.4U705.001
Wireless antenna left/right
Anttenna
25.90480.001
LCD 14.1” WXGA AU
B141EW04 non-glare
LCD 14.1” WXGA AU
B141EW04 NG
LK.14105.019
LCD 14.1” WXGA AU
B141EW04-V4 LF glare 200 nits
16ms
LCD 14.1” WXGA AU
B141EW04-V4 G
LK.14105.018
LCD 14.1” WXGA LG
LP141WX3-TLA1 non-glare
LCD 14.1” WXGA LG
LP141WX3-TLA1
LK.14108.009
LCD 14.1” WXGA LG
LP141WX3-TLA1 non-glare
LCD 14.1” WXGA LG
LP141WX3-TLA1
LK.14108.011
LCD 14.1” WXGA LG
LP141WX3-TLB1glare
LCD 14.1” WXGA LG
LP141EWX3-TLB1
LK.14108.012
LCD 14.1” WXGA LG
LP141WX3-TLB1 glare
LCD 14.1” WXGA LG
LP141WX3-TLB1
LK.14108.010
LCD 14.1” WXGA Samsung
LTN141W3-L01-G LF Glare 200
nits 16ms
LCD 14.1” WXGA Samsung
LTN141W3
LK.14106.011
Microphone SAB
Microphone cable SAB
23.42126.001
Microphone FORG
Microphone cable FORG
23.42127.001
Microphone SHAN
Microphone cable SHAN
23.42128.001
Speaker pack left/left
Speaker
23.40309.001
Mainboard Volvi w/ RTC battery
and PCMCIA slot & modem &
modem cable w/o CPU and
DIMM
Volvi MB 945 07200-1 w/o
modem
55.4U701.051G
RTC battery
BTY RTC Mitsubishi ROHS
23.TDMV1.001
RTC battery
BTY RTC Panasonic ROHS
(UP)
23.22059.001
CONN Cardbus 4P 10057913-
21.H0153.001
Speaker
Mainboard
RTC Battery
PCMCIA slot/PC card slot
PCMCIA slot
124
Chapter 4
Category
Part Name
Description
Acer Part No.
Miscellaneous
LCD screw rubber
Rub circle LCD
47.4U702.001
Name plate
Name plate AS4710
42.4U706.001
Screw
Screw M2xL3 (white)
86.00C07.220
Screw
Screw M2.5xL6 nylok CR3+
86.00E33.736
Screw
Screw M2.5xL8 nylok CR3+
86.00E34.738
Screw
Screw WAF M2x4 BZnylok
CR3+
86.00E92.724
Screw
Screw M2x2.5 nylok
86.00F22.722
Screws
Chapter 4
Screw
Screw M2x4 nylok H0.3
86.00F24.724
Screw
Screw 2x6 nylok
86.00F58.726
Screw
Screw Ni M2x6L
86.9A552.6R0
Screw
Screw Mach Wafer M3xL4 Ni
86.9A554.4R0
Screw
Screw wafer nylok Ni M2xL3
86.9A552.3R0
125
Aspire 4710G FRU List
Category
Part Name
Description
Acer Part No.
Adapter
Adapter 90W Delta ADP-90SB
BBEA LF
ADP 90W Delta ADP-90SB
BBEA LF
AP.09001.013
Adapter 90W Delta ADP-90SB
BBDAF
ADT 90W Delta ADP-90SB
BBDAF
AP.09001.010
Adapter 90W Liteon PA-190024AR
ADT 90W Liteon PA-190024AR
AP.09003.011
Adapter 90W Liteon PA-190004WR
ADT 65W PA-1900-04WR
AP.09003.005
Battery Pack Li+6 cell 2.0mAh
Sanyo
BTY Pack Li+6C 2.0Ah Sanyo
BT.00603.036
Battery Pack Li+6 cell 2.4mAh
Sanyo
BTY Pack LI+6C 2.4Ah Sanyo
BT.00603.037
Battery Pack Li-ion 6 cell
2.0mAh Sony
BTY Pack Li+6C 2.0Ah Sony
BT.00604.022
Battery Pack Li-ion 6 cell
2.4mAh Sony
BTY Pack Li+6C 2.4Ah Sony
BT.00604.023
Battery Pack Li-Mn 6 cell
2.0mAh Panasonic
BTY Pack Li+6C 2.0Ah PANA
BT.00605.018
Battery Pack Li-Mn 6 cell
2.4mAh Panasonic
BTY Pack Li+6C 2.4Ah PANA
BT.00605.019
Battery Pack Li-Mn 6 cell 2.0
Simplo
BTY Pack Li+6C 2.0Ah SMP
BT.00607.013
Battery Pack Li-ion 6 cell
2.4mAh Simplo
BTY Pack PANA Li 6C 2.4
SMP
BT.00607.014
Bluetooth board Foxconn
BCM2045 V01
BT Module Foxconn BCM2045
V01
56.25020.003
VGA board MXM-1N M66M
MXM71-1N Infineon VGA BD
(D)
55.TKA01.001
Modem board
Modem MDC003 A8B
B85244300G
54.09027.091
Modem board Foxconn MDC1.5
T60M955.00 3.3V
Modem MDC1.5 T60M955.00
3.3V
54.09018.051
Touchpad board Synaptics
TM00450-000
Touchpad Synaptics TM00450000
56.17024.001
Launch board
Tahoe LAU-BD 06626-1 PD
(D)
55.4T902.001G
Battery
Boards
126
Chapter 4
Category
Part Name
Description
Acer Part No.
USB board
Tahoe USB-BD 06628-1 PD
(D)
55.4T904.001G
Power board
Volvi PWR-BD 06627-1 (D) PD
55.4U703.001G
Wireless LAN 802.11ABGN
Kedron MOW1
WLAN 802.11ABGN Kedron
MOW1
KI.KDN01.001
Wireless LAN 802.11ABGN
Kedron MOW2
WLAN 802.11ABGN Kedron
MOW2
KI.KDN01.002
Wireless LAN 802.11ABGN
Kedron ROW
WLAN 802.11ABGN Kedron
ROW
KI.KDN01.003
Wireless LAN Board 802.11ABG
Intel 3945 MW1
WLAN 802.11ABG Intel 3945
MW1
KI.GLN01.001
Wireless LAN Board 802.11ABG
Intel 3945 MW2
WLAN 802.11ABG Intel 3945
MW2
KI.GLN01.002
Wireless LAN Board 802.11ABG
Intel 3945 RW
WLAN 802.11ABG Intel 3945
RW
KI.GLN01.003
Wireless LAN Board 802.11BG
Intel 3945BG
WLAN PRO/Wireless 3945BG
KI.GLN01.005
Wireless LAN 802.11BG
Foxconn BCM4311
WLAN 802.11BG BCM4311
WW SKU
54.AEFV1.001
Bluetooth cable HL
C.A. B.T HL
50.4T910.001
Bluetooth cable MEC
C.A. B.T MEC
50.4T910.011
Power board cable
C.A. power board FFC
50.4T905.001
USB cable HL
C.A. USB HL
50.4T906.001
USB cable MEC
C.A. USB MEC
50.4T906.011
Touchpad cable
C.A. T/P FFC
50.4T903.001
Launch board cable
C.A. launch board FFC
50.4T904.001
DC-in cable HL
C.A. DC-in HL
50.4T907.001
DC-in cable MEC
C.A. DC-in MEC
50.4T907.011
Modem cable
C.A. MDC MEC
50.4T909.011
Power cord 10A 125V US
Code US 10A 125V BK
27.01518.521
Power cord 10A 125V 3-pin US
BK
Code 10A 125V 3P US BK
27.01518.641
Power cord 2.5A 125V USA
Code USA/W CNS 2.5A 125V
8121
27.01518.781
Power cord 3A 250V 3-pin UK
Code UK 3A 250V 3P BK
27.01518.541
Power cord 5A 250V 3-pin UK
BK
Code 5A 250V 3P UK BK
27.03118.001
Power cord 10A 3-pin BK
Denmark
Code Denmark 10A 3P BK
27.01518.561
Power cord 10A 250V 3-pin
Denmark BK
Code 10A 250V 3P Denmark
BK
27.01518.671
Wireless LAN board
Cables
Chapter 4
127
Category
Cables (cont.)
Part Name
Description
Acer Part No.
Power cord 10A 250V 3-pin
South Africa
Code South Africa 10A 250V
BK
27.01518.571
Power cord 16A 250V South
Africa BK
Code 16A 250V South Africa
BK
27.01518.681
Power cord 10A 250V Swiss
Code Swiss Power 10A 250V
BK
27.01518.581
Power cord 10A 250V 3-pin
Swiss BK
Code 10A 250V 3P Swiss Bk
27.01518.691
Power cord 10A 250V 3-pin
China
Cord China 10A 250V 3P
27.01518.591
Power cord 10A 250V 3-pin
China BK
Cord 10A 250V 3P China BK
27.01518.701
Power cord 220V 3-pin EUR
Cord EUR 220V 3P BK
27.01518.601
Power cable 16A 250V 3-pin
EUR BK
Cord 16A 250V 3P EUR BK
27.01518.731
Power cord 10A 250V 3-pin Italy
Cord Italy 10A 250V 3P BK
27.01518.611
Power cord 10A 250V 3-pin Italy
BK
Cord 10A 250V 3P Italy BK
27.01518.711
Power cord 2.5A 250V South
Africa BK (India)
Cord 2.5A 250V South Africa
Bk
27.01518.631
Power cord 10A 250V South
Africa BK (India)
Cord 10A 250V South Africa
BK
27.01518.721
Power cord 250V 10A 3-pin
Israel
Cord 250V 10~16A 3P Israel
27.01518.761
Power cord ACA/ACNZ
Power cord ACA/ACNZ Annie
27.03218.021
System case/cover/bracket/assembly
128
LCD latch bracket
LCD latch ASSY
60.4T906.001
SD dummy card
SD dummy card
42.TKJ01.001
New card dummy card
Dummy new card
42.4T924.001
Lower case
ASSY L-Case
60.4U704.001
Unitload cover
ASSY big door
60.4T908.001
E-key cover
ASSY E-key
60.4U703.001
Support bracket left
Support L ASSY
60.4T905.001
Touchpad bracket
TP bracket ASSY
60.4T904.001
Chapter 4
Category
Part Name
Description
Acer Part No.
Middle cover
ASSY M-cover
60.4U701.001
VGA bracket
ASSY MXM BRT
60.4T933.002
Upper case w/ speaker
U-Case ASSY AS4710
60.4U709.001
SDIMM 1GB Hynix
HYMP512S64CP8-Y5 AB
SODIMM 1G
HYMP512S64CP8-Y5 AB
KN.1GB0G.006
SDIMM 1GB Nanya
NT1GT64U8HB0BN-3C
SODIMM 1G
NT1GT64U8HB0BN-3C
KN.1GB03.014
SDIMM 1GB Samsung
M470T2953EZ3-CE6
SODIMM 1GB
M470T2953EZ3-CE6
KN.1GB0B.011
SDIMM 512MB Hynix
HYMP564S64CP6-Y5 AB
SODIMM 512M
HYMP564S64CP6-Y5 AB
KN.5120G.019
SDIMM 512MB Nanya
NT512T64UH8B0FN-3C
SODIMM 512M
NT512T64UH8B0FN-3C
KN.51203.032
SDIMM 512MB Samsung
M470T6554EZ3-CE6 LF
SODIMM 512M
M470T6554EZ3-CE6
KN.5120B.023
SDIMM 512MB PSC
AS6E8E63B-6E1A
SODIMM 512M AS6E8E63B6E1A
KN.5120E.004
SDIMM 512MB DDRII667
Promos V916764B24QBFW-F5
LF
SODIMM 512M
V916764B24QBFW-F5
KN.5120M.004
Memory
Combo module
Combo module 24X
ODD NCB24X combo
G2.OPAHQ.001
Optical bracket
BRKT ODD
33.4T910.001
Combo bezel
ASSY ODD bezel combo
60.4T914.001
Combo module 24X PDBS DS24CZP w/o bezel
Combo 24X PDBS DS-24CZP
KO.02409.029
Combo module 24X Sony
CRX880A LF w/o bezel
Combo 24X Sony/CRX880A
Myall2
KO.0240E.005
DVD-RW Super Multi module 8X
ODD NSM8X Super-multi drive
TA
G2.OPAHQ.002
Optical bracket
BRKT ODD
33.4T910.001
Super Multi bezel
ASSY ODD bezel S-Multi
60.4T915.001
DVD-RW drive 8X Super Mult
Pioneer DVR-K17RS LF w/o
bezel
S-Mult 8X PIO/DVR-K17RS
KU.00805.038
DVD-RW drive 8X Super Mult
Panasonic UJ-850UAA1-A w/o
bezel
S-Mult PAN/UJ-850UAA1-A
KU.00807.055
DVD-RW drive 8X Super Multi
PDBS DS-8A1P
8X S-Multi PDBS/DS-8A1P
KU.00809.010
DVD-RW drive 8X Super Mult
Sony AD-7560A
8X S-Mult Sony/AD-7560A
KU.0080E.005
DVD module
Chapter 4
129
Category
Part Name
Description
Acer Part No.
HDD/Hard Disk Drive
HDD bracket
ASSY HDD bracket
60.4T918.001
HDD module 80G 5400RPM
SATA
HDD N80GB5.4KS Bracket
G2.HDAHQ.001
HDD 80GB SATA Hitachi
HTS541680J9SA00
HDD 80GB SATA
HTS541680J9SA00
KH.08007.021
HDD 80GB Seagate
ST980811AS
HDD 80GB SGT ST980811AS
KH.08001.030
HDD 80GB 5400RPM SATA
Toshiba MK8037GSX Gemini
BS LF F/W:DL230
HDD 80GB Toshiba
MK8037GSX
KH.08004.010
HDD 80GB 5400RPM SATA WD
WD800BEVS-22RST0 ML80 LF
F/W:04.01G04
HDD 80GB WD WD800BEVS22RST0
KH.08008.033
HDD module 120G 5400RPM
SATA
HDD N120GB5.4KS
G2.HDAHQ.002
HDD 120GB SATA Hitachi
HTS541612J9SA00
HDD 120GB SATA
HTS541612J9SA00
KH.12007.010
HDD 120GB Seagate
ST9120822AS
HDD 120GB SGT
ST9120822AS
KH.12001.031
HDD 120GB 5400RPM SATA
Toshiba MK1237GSX Gemini
BS LF F/W:DL130J
HDD 120GB Toshiba
MK1237GSX
KH.12004.006
HDD 120GB WD
WD1200BEVS-22RST0
HDD 120GB WD
WD1200BEVS-22RST0
KH.12008.018
HDD module 160G 5400RPM
SATA
HDD N160GB5.4KS
G2.HDAHQ.003
HDD 160GB SATA Hitachi
HTS541616J9SA00
HDD 160GB SATA
HTS541616J9SA00
KH.16007.011
HDD 160GB Seagate
ST9160821AS
HDD 160GB SGT
ST9160821AS
KH.16001.026
HDD 160GB 5400RPM SATA
Toshiba MK1637GSX Gemini
BS LF F/W:DL030J
HDD 160GB Toshiba
MK1637GSX
KH.16004.001
HDD 160GB WD
WD1600BEVS-22RST0
HDD 160GB WD
WD1600BEVS-22RST0
KH.16008.019
CPU heatsink w/ fan
ASSY Thermal DIS Foxconn
60.4T928.001
CPU heatsink w/ fan
ASSY Thermal DIS Robin
60.4T926.001
CPU heatsink w/ fan
ASSY Thermal DIS Forcecon
60.4T930.001
CPU Heatsink
130
Chapter 4
Category
Part Name
Description
Acer Part No.
CPU/Processor
CPU Merom T5500 1.66GHz
Intel
IC CPU Merom T5500 1.66G
PGA B
KC.55001.DTP
CPU Merom T5300 1.73GHz
Intel
IC CPU Merom T5300 1.73G
PGA
KC.53001.DTP
CPU Merom T5500 1.66GHz
Intel
IC CPU Merom T5500 1.66G
PGA
KC.55L01.DTP
CPU Merom T5600 1.83GHz
Intel
IC CPU Merom T5600 1.83
PGA
KC.56L01.DTP
CPU Merom T7200 2.0GHz
Intel
IC CPU Merom T7200 2.0G
PGA B2
KC.72001.DTP
CPU Merom T7400 2.16GHz
Intel
IC CPU Merom T7400 2.16G
PGA B
KC.74001.DTP
CPU Merom T7600 2.33GHz
Intel
IC CPU Merom T7600 2.33G
PGA
KC.76001.DTP
CPU Yonah T2350 1.86GHz
Intel
IC CPU Yonah T2350 1.86G
PGA
KC.23501.DTP
CPU Yonah T2450 2.0GHz Intel
IC CPU Yonah T2450 2.0G
PGA D0
KC.24501.DTP
CPU Merom Cel-M 530
1.73GHz Intel
IC CPU Merom Cel-M 530
1.73G
KC.N0001.530
CPU Merom Cel-M 520 1.6GHz
Intel
IC CPU merom Cel-M 520
1.6G
KC.N0001.520
CPU Yonah 440 1.86GHz Intel
IC CPU Yonah 440 1.86G PGA
D0
KC.ND001.440
CPU Yonah T2080 1.73GHz
Intel
IC CPU Yonah T2080 1.73G
PGA
KC.20801.DTP
Keyboard 88 key Darfon NSKH3V1D UI US-IN
KB Darfon NSK-H3V1D UI USIN88
9J.N5982.V1D
Keyboard 88 key Darfon NSKH3V02 TW Taiwan
KB Darfon NSK-H3V02 TW
Taiwa88
9J.N5982.V02
Keyboard 88 key Darfon NSKH3V03 TI Thailand
KB Darfon NSK-H3V03 TI
Thai88
9J.N5982.V03
Keyboard 88 key Darfon NSKH3V0A Ar Arabic
KB Darfon NSK-H3V0A AR
Arabi88
9J.N5982.V0A
Keyboard 88 key Darfon NSKH3V0H HB Hebrew
KB Darfon NSK-H3V0H HB
Hebre88
9J.N5982.V0H
Keyboard 88 key Darfon NSKH3V0K KO Korean
KB Darfon NSK-H3V0K KO
Korea88
9J.N5982.V0K
Keyboard 88 key Darfon NSKH3V0L GK Greek
KB Darfon NSK-H3V0L GK
Greek88
9J.N5982.V0L
Keyboard 88 key Darfon NSKH3V0R RU Russian
KB Darfon NSK-H3V0R RU
Russi88
9J.N5982.V0R
Keyboard 88 key Darfon NSKH3V0X Blank US
KB Darfon NSK-H3V0X BL84K(88)
9J.N5982.V0X
Keyboard 89 key Darfon NSKH3V06 PO Portuguese
KB Darfon NSK-H3V06 PO
Portu89
9J.N5982.V06
Keyboard
Chapter 4
131
Category
Keyboard (cont.)
Part Name
Description
Acer Part No.
Keyboard 89 key Darfon NSKH3V0C CZ Czech
KB Darfon NSK-H3V0C
Czech89
9J.N5982.V0C
Keyboard 89 key Darfon NSKH3V0D DM Danish
KB Darfon NSK-H3V0D DM
Danis89
9J.N5982.V0D
Keyboard 89 key Darfon NSKH3V0E IT Italian
KB Darfon NSK-H3V0E IT
Itali89
9J.N5982.V0E
Keyboard 89 key Darfon NSKH3V0FFR French
KB Darfon NSK-H3V0F FR
Rehcn89
9J.N5982.V0F
Keyboard 89 key Darfon NSKH3V0G GR German
KB Darfon NSK-H3V0G GR
Germa89
9J.N5982.V0G
Keyboard 89 key Darfon NSKH3V00 SW Swiss
KB Darfon NSK-H3V00 SW
Swiss89
9J.N5982.V00
Keyboard 89 key Darfon NSKH3V0M Canadian
KB Darfon NSK-H3V0M CF
FR.CA89
9J.N5982.V0M
Keyboard 89 key Darfon NSKH3V0N NW Norwegian
KB Darfon NSK-H3V0N NW
Norwe89
9J.N5982.V0N
Keyboard 89 key Darfon NSKH3V0Q HG Hungarian
KB Darfon NSK-H3V0Q HG
Huga89
9J.N5982.V0Q
Keyboard 89 key Darfon NSKH3V0S SP Spanish
KB Darfon NSK-H3V0S SP
Spani89
9J.N5982.V0S
Keyboard 89 key Darfon NSKH3V0T TR Turkish
KB Darfon NSK-H3V0T TR
Turki89
9J.N5982.V0T
Keyboard 89 key Darfon NSKH3V0U UK UK
KB Darfon NSK-H3V0U UK
UK89
9J.N5982.V0U
Keyboard 89 key Darfon NSKH3V0W SD Swedish
KB Darfon NSK-H3V0W SD
Swedi89
9J.N5982.V0W
Keyboard 89 key Darfon NSKH3V1A BE Belgian
KB Darfon NSK-H3V1A BE
Belgian
9J.N5982.V1A
Keyboard 89 key Darfon NSKH3V01B BP Brazilian
KB Darfon NSK-H3V1B BP
BR-PO89
9J.N5982.V1B
Keyboard 89 key Darfon NSKH3V1F SK Slovenian
KB Darfon NSK-H3V1F SK
Slove89
9J.N5982.V1F
Keyboard 89 key Darfon NSKH3V0Y BL-85K
KB Darfon NSK-H3V0Y BL85K(89)
9J.N5982.V0Y
Keyboard 92 key Darfon NSKH3V0J JA Japanese
KB Darfon NSK-H3V0J JA
Japan92
9J.N5982.V0J
LCD module 14.1” WXGA nonglare w/ antenna and camera
LCD 14.1” camera 0.3M
PC+ABS
G2.LDAHQ.001
Inverter board 17" FOXCONN
T62I240.02 V.00
Inverter 17” T62I240.02 V.00
19.TK501.001
Inverter board 17” YEC YNVW06
Inverter 17” YNV-W06
19.21072.013
Inverter board 17” Darfon
VK.21189.406
Inverter 17” ROHS
VK.21189.406
19.21066.034
LCD cable 14.1: WXGA HL
C.A. LCD WXGA HL
50.4T901.001
LCD cable 14.1: WXGA MEC
C.A. LCD WXGA MEC
50.4T901.011
LCD module
132
Chapter 4
Category
LCD module
(cont.)
Part Name
Description
Acer Part No.
Camera CMOS 0.3M Suyin
CN0314-OV03 U
Camera CMOS 0.3M CN0314OV03 U
57.TK901.001
Camera CMOS 0.3M Bison
BN30V40717300
Camera CMOS 0.3M
BN30V40717300
57.TK501.001
LCD bracket right
Bracket LCD R
33.4T904.001
LCD bracket left
Bracket LCD L
33.4T905.001
LCD bezel 14.1”
ASSY bezel
60.4U707.001
LCD panel 14.1”
ASSY LCD panel
60.4U705.001
Wireless antenna left/right
Anttenna
25.90480.001
LCD 14.1” WXGA AU
B141EW04 non-glare
LCD 14.1” WXGA AU
B141EW04 NG
LK.14105.019
LCD 14.1” WXGA AU
B141EW04-V4 LF glare 200 nits
16ms
LCD 14.1” WXGA AU
B141EW04-V4 G
LK.14105.018
LCD 14.1” WXGA LG
LP141WX3-TLA1 non-glare
LCD 14.1” WXGA LG
LP141WX3-TLA1
LK.14108.009
LCD 14.1” WXGA LG
LP141WX3-TLA1 non-glare
LCD 14.1” WXGA LG
LP141WX3-TLA1
LK.14108.011
LCD 14.1” WXGA LG
LP141WX3-TLB1glare
LCD 14.1” WXGA LG
LP141EWX3-TLB1
LK.14108.012
LCD 14.1” WXGA LG
LP141WX3-TLB1 glare
LCD 14.1” WXGA LG
LP141WX3-TLB1
LK.14108.010
LCD 14.1” WXGA Samsung
LTN141W3-L01-G LF Glare 200
nits 16ms
LCD 14.1” WXGA Samsung
LTN141W3
LK.14106.011
Microphone SAB
Microphone cable SAB
23.42126.001
Microphone FORG
Microphone cable FORG
23.42127.001
Microphone SHAN
Microphone cable SHAN
23.42128.001
Speaker pack left/left
Speaker
23.40309.001
Mainboard Volvi w/ RTC battery
and PCMCIA slot & modem &
modem cable w/o CPU and
DIMM
Volvi MB DIS 07200-1 w/o
modem
55.4U701.061G
RTC battery
BTY RTC Mitsubishi ROHS
23.TDMV1.001
RTC battery
BTY RTC Panasonic ROHS
(UP)
23.22059.001
CONN Cardbus 4P 10057913-
21.H0153.001
Speaker
Mainboard
RTC Battery
PCMCIA slot/PC card slot
PCMCIA slot
Chapter 4
133
Category
Part Name
Description
Acer Part No.
Miscellaneous
LCD screw rubber
Rub circle LCD
47.4U702.001
Name plate
Name plate AS4710
42.4U706.001
Screw
Screw M2xL3 (white)
86.00C07.220
Screw
Screw M2.5xL6 nylok CR3+
86.00E33.736
Screw
Screw M2.5xL8 nylok CR3+
86.00E34.738
Screw
Screw WAF M2x4 BZnylok
CR3+
86.00E92.724
Screw
Screw M2x2.5 nylok
86.00F22.722
Screws
134
Screw
Screw M2x4 nylok H0.3
86.00F24.724
Screw
Screw 2x6 nylok
86.00F58.726
Screw
Screw Ni M2x6L
86.9A552.6R0
Screw
Screw Mach Wafer M3xL4 Ni
86.9A554.4R0
Screw
Screw wafer nylok Ni M2xL3
86.9A552.3R0
Chapter 4
Aspire 4310 FRU List
Category
Part Name
Description
Acer Part No.
Adapter 65W Delta SADP-65KB
DFA LF
ADT 65W SADP-65KB DFA LF
Delta
AP.06501.013
Adapter 65W Liteon PA-165002WR
ADT 65W Liteon PA-165002WR
AP.06503.011
Adapter 65W Liteon PA-165002AC LF
ADT 65W PA-1650-02AC LF
AP.06503.016
Battery Pack Li+6 cell 2.0mAh
Sanyo
BTY Pack Li+6C 2.0Ah Sanyo
BT.00603.036
Battery Pack Li+6 cell 2.4mAh
Sanyo
BTY Pack LI+6C 2.4Ah Sanyo
BT.00603.037
Battery Pack Li-ion 6 cell
2.0mAh Sony
BTY Pack Li+6C 2.0Ah Sony
BT.00604.022
Battery Pack Li-ion 6 cell
2.4mAh Sony
BTY Pack Li+6C 2.4Ah Sony
BT.00604.023
Battery Pack Li-Mn 6 cell
2.0mAh Panasonic
BTY Pack Li+6C 2.0Ah PANA
BT.00605.018
Battery Pack Li-Mn 6 cell
2.4mAh Panasonic
BTY Pack Li+6C 2.4Ah PANA
BT.00605.019
Battery Pack Li-Mn 6 cell 2.0
Simplo
BTY Pack Li+6C 2.0Ah SMP
BT.00607.013
Battery Pack Li-ion 6 cell
2.4mAh Simplo
BTY Pack PANA Li 6C 2.4
SMP
BT.00607.014
Bluetooth board Foxconn
BCM2045 V01
BT Module Foxconn BCM2045
V01
56.25020.003
Modem board
Modem MDC003 A8B
B85244300G
54.09027.091
Modem board Foxconn MDC1.5
T60M955.00 3.3V
Modem MDC1.5 T60M955.00
3.3V
54.09018.051
Touchpad board Synaptics
TM00450-000
Touchpad Synaptics TM00450000
56.17024.001
Launch board
Tahoe LAU-BD 06626-1 PD
(D)
55.4T902.001G
USB board
Tahoe USB-BD 06628-1 PD
(D)
55.4T904.001G
Adapter
Battery
Boards
Chapter 4
135
Category
Part Name
Description
Acer Part No.
Power board
Volvi PWR-BD 06627-1 (D) PD
55.4U703.001G
Wireless LAN 802.11ABGN
Kedron MOW1
WLAN 802.11ABGN Kedron
MOW1
KI.KDN01.001
Wireless LAN 802.11ABGN
Kedron MOW2
WLAN 802.11ABGN Kedron
MOW2
KI.KDN01.002
Wireless LAN 802.11ABGN
Kedron ROW
WLAN 802.11ABGN Kedron
ROW
KI.KDN01.003
Wireless LAN Board 802.11ABG
Intel 3945 MW1
WLAN 802.11ABG Intel 3945
MW1
KI.GLN01.001
Wireless LAN Board 802.11ABG
Intel 3945 MW2
WLAN 802.11ABG Intel 3945
MW2
KI.GLN01.002
Wireless LAN Board 802.11ABG
Intel 3945 RW
WLAN 802.11ABG Intel 3945
RW
KI.GLN01.003
Wireless LAN Board 802.11BG
Intel 3945BG
WLAN PRO/Wireless 3945BG
KI.GLN01.005
Wireless LAN 802.11BG
Foxconn BCM4311
WLAN 802.11BG BCM4311
WW SKU
54.AEFV1.001
Wireless LAN board
Cables
136
Bluetooth cable HL
C.A. B.T HL
50.4T910.001
Bluetooth cable MEC
C.A. B.T MEC
50.4T910.011
Power board cable
C.A. power board FFC
50.4T905.001
USB cable HL
C.A. USB HL
50.4T906.001
USB cable MEC
C.A. USB MEC
50.4T906.011
Touchpad cable
C.A. T/P FFC
50.4T903.001
Launch board cable
C.A. launch board FFC
50.4T904.001
DC-in cable HL
C.A. DC-in HL
50.4T908.001
DC-in cable MEC
C.A. DC-in MEC
50.4T908.011
Modem cable
C.A. MDC HL
50.4T909.001
Power cord 10A 125V US
Code US 10A 125V BK
27.01518.521
Power cord 10A 125V 3-pin US
BK
Code 10A 125V 3P US BK
27.01518.641
Power cord 2.5A 125V USA
Code USA/W CNS 2.5A 125V
8121
27.01518.781
Power cord 3A 250V 3-pin UK
Code UK 3A 250V 3P BK
27.01518.541
Power cord 5A 250V 3-pin UK
BK
Code 5A 250V 3P UK BK
27.03118.001
Power cord 10A 3-pin BK
Denmark
Code Denmark 10A 3P BK
27.01518.561
Power cord 10A 250V 3-pin
Denmark BK
Code 10A 250V 3P Denmark
BK
27.01518.671
Power cord 10A 250V 3-pin
South Africa
Code South Africa 10A 250V
BK
27.01518.571
Chapter 4
Category
Cables (cont.)
Part Name
Description
Acer Part No.
Power cord 16A 250V South
Africa BK
Code 16A 250V South Africa
BK
27.01518.681
Power cord 10A 250V Swiss
Code Swiss Power 10A 250V
BK
27.01518.581
Power cord 10A 250V 3-pin
Swiss BK
Code 10A 250V 3P Swiss Bk
27.01518.691
Power cord 10A 250V 3-pin
China
Cord China 10A 250V 3P
27.01518.591
Power cord 10A 250V 3-pin
China BK
Cord 10A 250V 3P China BK
27.01518.701
Power cord 220V 3-pin EUR
Cord EUR 220V 3P BK
27.01518.601
Power cable 16A 250V 3-pin
EUR BK
Cord 16A 250V 3P EUR BK
27.01518.731
Power cord 10A 250V 3-pin Italy
Cord Italy 10A 250V 3P BK
27.01518.611
Power cord 10A 250V 3-pin Italy
BK
Cord 10A 250V 3P Italy BK
27.01518.711
Power cord 2.5A 250V South
Africa BK (India)
Cord 2.5A 250V South Africa
Bk
27.01518.631
Power cord 10A 250V South
Africa BK (India)
Cord 10A 250V South Africa
BK
27.01518.721
Power cord 250V 10A 3-pin
Israel
Cord 250V 10~16A 3P Israel
27.01518.761
Power cord ACA/ACNZ
Power cord ACA/ACNZ Annie
27.03218.021
LCD latch bracket
LCD latch ASSY
60.4T906.001
SD dummy card
SD dummy card
42.TKJ01.001
New card dummy card
Dummy new card
42.4T924.001
Lowercase
ASSY L-Case
60.4U704.001
Unitload cover
ASSY big door
60.4T908.001
E-key cover
ASSY E-key
60.4U703.001
Support bracket left
Support L ASSY
60.4T905.001
Touchpad bracket
TP bracket ASSY
60.4T904.001
Middle cover
ASSY M-cover
60.4U701.001
Upper case w/ speaker
U-Case ASSY AS4710
60.4U708.001
System case/cover/bracket/assembly
Chapter 4
137
Category
Part Name
Description
Acer Part No.
Memory
SDIMM 1GB Hynix
HYMP512S64CP8-Y5 AB
SODIMM 1G
HYMP512S64CP8-Y5 AB
KN.1GB0G.006
SDIMM 1GB Nanya
NT1GT64U8HB0BN-3C
SODIMM 1G
NT1GT64U8HB0BN-3C
KN.1GB03.014
SDIMM 1GB Samsung
M470T2953EZ3-CE6
SODIMM 1GB
M470T2953EZ3-CE6
KN.1GB0B.011
SDIMM 512MB Hynix
HYMP564S64CP6-Y5 AB
SODIMM 512M
HYMP564S64CP6-Y5 AB
KN.5120G.019
SDIMM 512MB Nanya
NT512T64UH8B0FN-3C
SODIMM 512M
NT512T64UH8B0FN-3C
KN.51203.032
SDIMM 512MB Samsung
M470T6554EZ3-CE6 LF
SODIMM 512M
M470T6554EZ3-CE6
KN.5120B.023
SDIMM 512MB PSC
AS6E8E63B-6E1A
SODIMM 512M AS6E8E63B6E1A
KN.5120E.004
SDIMM 512MB DDRII667
Promos V916764B24QBFW-F5
LF
SODIMM 512M
V916764B24QBFW-F5
KN.5120M.004
Combo module 24X
ODD NCB24X combo
G2.OPAHQ.001
Optical bracket
BRKT ODD
33.4T910.001
Combo bezel
ASSY ODD bezel combo
60.4T914.001
Combo module 24X PDBS DS24CZP w/o bezel
Combo 24X PDBS DS-24CZP
KO.02409.029
Combo module 24X Sony
CRX880A LF w/o bezel
Combo 24X Sony/CRX880A
Myall2
KO.0240E.005
DVD-RW Super Multi module 8X
ODD NSM8X Super-multi drive
G2.OPAHQ.002
Optical bracket
BRKT ODD
33.4T910.001
Super Multi bezel
ASSY ODD bezel S-Multi
60.4T915.001
DVD-RW drive 8X Super Mult
Pioneer DVR-K17RS LF w/o
bezel
S-Mult 8X PIO/DVR-K17RS
KU.00805.038
DVD-RW drive 8X Super Mult
Panasonic UJ-850UAA1-A w/o
bezel
S-Mult PAN/UJ-850UAA1-A
KU.00807.055
DVD-RW drive 8X Super Multi
PDBS DS-8A1P
8X S-Multi PDBS/DS-8A1P
KU.00809.010
DVD-RW drive 8X Super Mult
Sony AD-7560A
8X S-Mult Sony/AD-7560A
KU.0080E.005
Combo module
DVD module
HDD/Hard Disk Drive
138
Chapter 4
Category
Part Name
Description
Acer Part No.
HDD bracket
ASSY HDD bracket
60.4T918.001
HDD module 80G 5400RPM
SATA
HDD N80GB5.4KS Bracket
G2.HDAHQ.001
HDD 80GB SATA Hitachi
HTS541680J9SA00
HDD 80GB SATA
HTS541680J9SA00
KH.08007.021
HDD 80GB Seagate
ST980811AS
HDD 80GB SGT ST980811AS
KH.08001.030
HDD 80GB 5400RPM SATA
Toshiba MK8037GSX Gemini
BS LF F/W:DL230
HDD 80GB Toshiba
MK8037GSX
KH.08004.010
HDD 80GB 5400RPM SATA WD
WD800BEVS-22RST0 ML80 LF
F/W:04.01G04
HDD 80GB WD WD800BEVS22RST0
KH.08008.033
HDD module 120G 5400RPM
SATA
HDD N120GB5.4KS
G2.HDAHQ.002
HDD 120GB SATA Hitachi
HTS541612J9SA00
HDD 120GB SATA
HTS541612J9SA00
KH.12007.010
HDD 120GB Seagate
ST9120822AS
HDD 120GB SGT
ST9120822AS
KH.12001.031
HDD 120GB 5400RPM SATA
Toshiba MK1237GSX Gemini
BS LF F/W:DL130J
HDD 120GB Toshiba
MK1237GSX
KH.12004.006
HDD 120GB WD
WD1200BEVS-22RST0
HDD 120GB WD
WD1200BEVS-22RST0
KH.12008.018
HDD module 160G 5400RPM
SATA
HDD N160GB5.4KS
G2.HDAHQ.003
HDD 160GB SATA Hitachi
HTS541616J9SA00
HDD 160GB SATA
HTS541616J9SA00
KH.16007.011
HDD 160GB Seagate
ST9160821AS
HDD 160GB SGT
ST9160821AS
KH.16001.026
HDD 160GB 5400RPM SATA
Toshiba MK1637GSX Gemini
BS LF F/W:DL030J
HDD 160GB Toshiba
MK1637GSX
KH.16004.001
HDD 160GB WD
WD1600BEVS-22RST0
HDD 160GB WD
WD1600BEVS-22RST0
KH.16008.019
CPU heatsink w/ fan
ASSY Thermal UMA Foxconn
60.4T927.001
CPU Heatsink
Chapter 4
139
Category
Part Name
Description
Acer Part No.
CPU/Processor
CPU Merom T5500 1.66GHz
Intel
IC CPU Merom T5500 1.66G
PGA B
KC.55001.DTP
CPU Merom T5300 1.73GHz
Intel
IC CPU Merom T5300 1.73G
PGA
KC.53001.DTP
CPU Merom T5500 1.66GHz
Intel
IC CPU Merom T5500 1.66G
PGA
KC.55L01.DTP
CPU Merom T5600 1.83GHz
Intel
IC CPU Merom T5600 1.83
PGA
KC.56L01.DTP
CPU Merom T7200 2.0GHz
Intel
IC CPU Merom T7200 2.0G
PGA B2
KC.72001.DTP
CPU Merom T7400 2.16GHz
Intel
IC CPU Merom T7400 2.16G
PGA B
KC.74001.DTP
CPU Merom T7600 2.33GHz
Intel
IC CPU Merom T7600 2.33G
PGA
KC.76001.DTP
CPU Yonah T2350 1.86GHz
Intel
IC CPU Yonah T2350 1.86G
PGA
KC.23501.DTP
CPU Yonah T2450 2.0GHz Intel
IC CPU Yonah T2450 2.0G
PGA D0
KC.24501.DTP
CPU Merom Cel-M 530
1.73GHz Intel
IC CPU Merom Cel-M 530
1.73G
KC.N0001.530
CPU Merom Cel-M 520 1.6GHz
Intel
IC CPU merom Cel-M 520
1.6G
KC.N0001.520
CPU Yonah 440 1.86GHz Intel
IC CPU Yonah 440 1.86G PGA
D0
KC.ND001.440
CPU Yonah T2080 1.73GHz
Intel
IC CPU Yonah T2080 1.73G
PGA
KC.20801.DTP
Keyboard 88 key Darfon NSKH3V1D UI US-IN
KB Darfon NSK-H3V1D UI USIN88
9J.N5982.V1D
Keyboard 88 key Darfon NSKH3V02 TW Taiwan
KB Darfon NSK-H3V02 TW
Taiwa88
9J.N5982.V02
Keyboard 88 key Darfon NSKH3V03 TI Thailand
KB Darfon NSK-H3V03 TI
Thai88
9J.N5982.V03
Keyboard 88 key Darfon NSKH3V0A Ar Arabic
KB Darfon NSK-H3V0A AR
Arabi88
9J.N5982.V0A
Keyboard 88 key Darfon NSKH3V0H HB Hebrew
KB Darfon NSK-H3V0H HB
Hebre88
9J.N5982.V0H
Keyboard 88 key Darfon NSKH3V0K KO Korean
KB Darfon NSK-H3V0K KO
Korea88
9J.N5982.V0K
Keyboard 88 key Darfon NSKH3V0L GK Greek
KB Darfon NSK-H3V0L GK
Greek88
9J.N5982.V0L
Keyboard 88 key Darfon NSKH3V0R RU Russian
KB Darfon NSK-H3V0R RU
Russi88
9J.N5982.V0R
Keyboard 88 key Darfon NSKH3V0X Blank US
KB Darfon NSK-H3V0X BL84K(88)
9J.N5982.V0X
Keyboard 89 key Darfon NSKH3V06 PO Portuguese
KB Darfon NSK-H3V06 PO
Portu89
9J.N5982.V06
Keyboard
140
Chapter 4
Category
Keyboard (cont.)
Part Name
Description
Acer Part No.
Keyboard 89 key Darfon NSKH3V0C CZ Czech
KB Darfon NSK-H3V0C
Czech89
9J.N5982.V0C
Keyboard 89 key Darfon NSKH3V0D DM Danish
KB Darfon NSK-H3V0D DM
Danis89
9J.N5982.V0D
Keyboard 89 key Darfon NSKH3V0E IT Italian
KB Darfon NSK-H3V0E IT
Itali89
9J.N5982.V0E
Keyboard 89 key Darfon NSKH3V0FFR French
KB Darfon NSK-H3V0F FR
Rehcn89
9J.N5982.V0F
Keyboard 89 key Darfon NSKH3V0G GR German
KB Darfon NSK-H3V0G GR
Germa89
9J.N5982.V0G
Keyboard 89 key Darfon NSKH3V00 SW Swiss
KB Darfon NSK-H3V00 SW
Swiss89
9J.N5982.V00
Keyboard 89 key Darfon NSKH3V0M Canadian
KB Darfon NSK-H3V0M CF
FR.CA89
9J.N5982.V0M
Keyboard 89 key Darfon NSKH3V0N NW Norwegian
KB Darfon NSK-H3V0N NW
Norwe89
9J.N5982.V0N
Keyboard 89 key Darfon NSKH3V0Q HG Hungarian
KB Darfon NSK-H3V0Q HG
Huga89
9J.N5982.V0Q
Keyboard 89 key Darfon NSKH3V0S SP Spanish
KB Darfon NSK-H3V0S SP
Spani89
9J.N5982.V0S
Keyboard 89 key Darfon NSKH3V0T TR Turkish
KB Darfon NSK-H3V0T TR
Turki89
9J.N5982.V0T
Keyboard 89 key Darfon NSKH3V0U UK UK
KB Darfon NSK-H3V0U UK
UK89
9J.N5982.V0U
Keyboard 89 key Darfon NSKH3V0W SD Swedish
KB Darfon NSK-H3V0W SD
Swedi89
9J.N5982.V0W
Keyboard 89 key Darfon NSKH3V1A BE Belgian
KB Darfon NSK-H3V1A BE
Belgian
9J.N5982.V1A
Keyboard 89 key Darfon NSKH3V01B BP Brazilian
KB Darfon NSK-H3V1B BP
BR-PO89
9J.N5982.V1B
Keyboard 89 key Darfon NSKH3V1F SK Slovenian
KB Darfon NSK-H3V1F SK
Slove89
9J.N5982.V1F
Keyboard 89 key Darfon NSKH3V0Y BL-85K
KB Darfon NSK-H3V0Y BL85K(89)
9J.N5982.V0Y
Keyboard 92 key Darfon NSKH3V0J JA Japanese
KB Darfon NSK-H3V0J JA
Japan92
9J.N5982.V0J
LCD module 14.1” WXGA glare
w/ antenna and camera
LCD 14.1” camera 0.3M
PC+ABS
G2.LDAHQ.001
Inverter board 17" FOXCONN
T62I240.02 V.00
Inverter 17” T62I240.02 V.00
19.TK501.001
Inverter board 17” YEC YNVW06S
Inverter 17” YNV-W06S
19.21072.013
Inverter board 17” Darfon
VK.21189.406
Inverter 17” ROHS
VK.21189.406
19.21066.034
LCD cable 14.1: WXGA HL
C.A. LCD WXGA HL
50.4T901.001
LCD cable 14.1: WXGA MEC
C.A. LCD WXGA MEC
50.4T901.011
LCD module
Chapter 4
141
Category
LCD module
(cont.)
Part Name
Description
Acer Part No.
Camera CMOS 0.3M Suyin
CN0314-OV03 U
Camera CMOS 0.3M CN0314OV03 U
57.TK901.001
Camera CMOS 0.3M Bison
BN30V40717300
Camera CMOS 0.3M
BN30V40717300
57.TK501.001
LCD bracket right
Bracket LCD R
33.4T904.001
LCD bracket left
Bracket LCD L
33.4T905.001
LCD bezel 14.1”
ASSY bezel
60.4U707.001
LCD panel 14.1”
ASSY LCD panel
60.4U705.001
Wireless antenna left/right
Anttenna
25.90480.001
LCD 14.1” WXGA AU
B141EW04 non-glare
LCD 14.1” WXGA AU
B141EW04 NG
LK.14105.019
LCD 14.1” WXGA AU
B141EW04-V4 LF glare 200 nits
16ms
LCD 14.1” WXGA AU
B141EW04-V4 G
LK.14105.018
LCD 14.1” WXGA LG
LP141WX3-TLA1 non-glare
LCD 14.1” WXGA LG
LP141WX3-TLA1
LK.14108.009
LCD 14.1” WXGA LG
LP141WX3-TLA1 non-glare
LCD 14.1” WXGA LG
LP141WX3-TLA1
LK.14108.011
LCD 14.1” WXGA LG
LP141WX3-TLB1glare
LCD 14.1” WXGA LG
LP141EWX3-TLB1
LK.14108.012
LCD 14.1” WXGA LG
LP141WX3-TLB1 glare
LCD 14.1” WXGA LG
LP141WX3-TLB1
LK.14108.010
LCD 14.1” WXGA Samsung
LTN141W3-L01-G LF Glare 200
nits 16ms
LCD 14.1” WXGA Samsung
LTN141W3
LK.14106.011
Microphone SAB
Microphone cable SAB
23.42126.001
Microphone FORG
Microphone cable FORG
23.42127.001
Microphone SHAN
Microphone cable SHAN
23.42128.001
Speaker pack left/left
Speaker
23.40309.001
Mainboard Volvi w/ RTC battery
and PCMCIA slot & modem &
modem cable w/o CPU and
DIMM
Volvi MB 943 07200-1 PD (D)
55.4U701.031G
RTC battery
BTY RTC Mitsubishi ROHS
23.TDMV1.001
RTC battery
BTY RTC Panasonic ROHS
(UP)
23.22059.001
CONN Cardbus 4P 10057913-
21.H0153.001
Speaker
Mainboard
RTC Battery
PCMCIA slot/PC card slot
PCMCIA slot
142
Chapter 4
Category
Part Name
Description
Acer Part No.
Miscellaneous
LCD screw rubber
Rub circle LCD
47.4U702.001
Name plate
Name plate AS4310
42.4U705.001
Screw
Screw M2xL3 (white)
86.00C07.220
Screw
Screw M2.5xL6 nylok CR3+
86.00E33.736
Screw
Screw M2.5xL8 nylok CR3+
86.00E34.738
Screw
Screw WAF M2x4 BZnylok
CR3+
86.00E92.724
Screw
Screw M2x2.5 nylok
86.00F22.722
Screws
Chapter 4
Screw
Screw M2x4 nylok H0.3
86.00F24.724
Screw
Screw 2x6 nylok
86.00F58.726
Screw
Screw Ni M2x6L
86.9A552.6R0
Screw
Screw Mach Wafer M3xL4 Ni
86.9A554.4R0
Screw
Screw wafer nylok Ni M2xL3
86.9A552.3R0
143
Appendix A
Model Definition and Configuration
Aspire 4710/4310
Model
Appendix A
RO
Count
ry
Acer
Part
no
Descriptio
n
CPU
LCD
DIMM
1
DIMM
2
HDD 1
(GB)
ODD
Wireless
LAN
Bluetoot
h
144
145
Appendix A
Appendix A
146
Appendix B
Test Compatible Components
This computer’s compatibility is tested and verified by Acer’s internal testing department. All of its system
functions are tested under Windows® Vista™ Business, Vista Home Premium, and Vista Home Basic
environment.
Refer to the following lists for components, adapter cards, and peripherals which have passed these tests.
Regarding configuration, combination and test procedures, please refer to the Aspire 4710/4310 Vista
Compatibility Test Report released by the Acer Mobile System Testing Department.
Appendix B
147
Microsoft® Windows® Vista™ Compatibility Test
I/O Peripheral Compatibility Test
Vendor
Device Description
Result
External CRT
Acer
211c21”
P
ViewSonic
G220F
P
PF790 19”
P
Sony
TV Trinitron (S-video)
P
External LCD
Acer
FP751 17” TFT LCD
P
1
P
AL17211
P
15” LCD Monitor (DVI) Model: AL1521
17” LCD Monitor (DVI) Model:
ViewSonic
20” LCD VD201b(DVI-I), (DVI-D),
Westinghouse
W37G (HDMI)
P
HP
LP2065 20” TFT Monitor (DVI)
P
S9500 19” Monitor (DVI)
P
3300MP projector
P
Microsoft
Natural keyboard Pro
P
Logicool
USB mouse (OWCM-USB)
P
Logitech
USB wheel mouse
P
First wheel mouse
P
(D-sub)1
P
Projector
DELL
USB keyboard or mouse
DELL
HP
Belkin
USB keyboard
P
Dell by Logitech
P
Internet navigator keyboard
P
Smart card keyboard
P
USB optical Austin mouse
P
HP USB optical mouse (RB129AA)
P
Miniglow optical USB mouse
P
USB printer/scanner
Canon
Canon Scanner D1250 (USB 2.0) (JP OS only)
P
HP
450wbt deskjet printer (USB/Bluetooth)
P
2400 Scanjet (USB 1.1)
P
Aiwa
Multimedia digital speaker (SC-UC78)
P
Logitech
WingMan RumblePad (G-UA3)
P
USB speaker/joystick
Peripheral
Dolby Headphone 5.1 channel
P
Panasonic
USB speaker EAB-MPC57USB
P
JS
iFun USB speaker
P
Intel
Easy PC Camera (A20953-001)
P
Orange
Micro USB 2.0 Web Cam
P
USB camera
148
Appendix B
I/O Peripheral Compatibility Test
Vendor
Device Description
Result
USB storage device
Iomega
USB zip 250MB
P
Fujitsu
MO-1300 1.3G USB 2.0
P
Transcend
80GB HDD USB 2.0+IEEE 1394
P
PQI
6-in-1 Flash card reader/writer 2
P
Plextor
DVD+R/RW USB 2.0
P
Galileo
Mass storage 2.5 travel kit with 1394
P
LG
DVD+R/RW 16X USB 2.0+IEEE 1394
P
Sony
DVD+R/RW 16X USB 2.0+IEEE 1394
P
Sony
Memory key 128MB
P
Micro Bault Pro USD-5G 5GB USB flash
P
Apacer
Handy drive the USB flash drive
P
IBM
128MB USB 2.0 memory key
P
512MB USB 2.0 memory key
P
A TEN
4 port hub USB 2.0 UH-204
P
IOGEAR
4 port hub USB 2.0
P
Corega
Wireless LAN USB stick 11 USB 1.1 CG-WLUSBST11
P
CD-RW + DVD-ROM combo USB interface
P
USB flash drive
USB hub and others
USB ODD
Logitech
LG
DVD+R/RW 16X USB 2.0+IEEE 1394
P
Sony
DVD+R/RW 16X USB 2.0+IEEE 1394
P
2.5” portable 80GB hard disk
P
DVD+R/RW 16X USB 2.0+IEEE 1394
P
Sony
DVD+R/RW 16X USB 2.0+IEEE 1394
P
Transcend
2.5” portable 80GB hard disk
P
DV
P
FireWire expansion hub 6-port IEEE 1394 hub FH-600
P
Aironet 350
P
Aironet 1230
P
Intel
Pro/Wireless 5000
P
NetGear
54Mbps 802.11a Access point model: HE 102
P
Building networks people WiFi certified a/b/g wireless 108AG
P
Rangebooster N 650 Router Wireless-802.11n
P
USB HDD
Transcend
1394 storage drive
LG
1394 camera
Sony
1394 hub
Aten
Access point 802.11b
Cisco
Access point 802.11a
Access point 802.11g
D-Link
Access point 802.11n
D-Link
Buffalo
Air Station Wireless IEEE 802.11n/g/b WZR-G144N
P
MIMO
Belkin N1MIMO Wireless router high performance Wireless 802.11n
P
Appendix B
149
I/O Peripheral Compatibility Test
Vendor
Device Description
Result
Bluetooth access point
X Bridge
Bluetooth access point BT300
P
Sony Ericsson
Wireless headset
P
T610
P
X Bridge
Bluetooth access point BT300
P
Epson
Bluetooth print adapter
P
HP
Deskjet 450wbt
P
AmbiCom
Bluetooth wireless compact Flash card with PC card adapter
P
5-in-1 adapter express card reader
P
GigaLAN express card
P
Bluetooth device
Express card
Abcom
Sunix
ECF2400 2 ports 1394A express card
P
Serial ATA External SATAII express card
P
IK Kouwell
IK Kouwell IEEE1394+USB2.0 express card
P
SIIG
SIIG express card 11-in R/W easily add a memory card reader/writer to
express card equipped systems
P
1 If system support s DVI, a D-sub interface supplemental test is required.
2 PQI 6-in-1 flash card reader/writer is not compatible with USB 2.0 systems.
Memory Card Compatibility Test
Vendor
Device Description
Result
Multimedia card
Sandisk
Transcend
Multimedia card 32MB
P
RS-MMC 128MB memory card
P
Multimedia card 64/128MB
P
Multimedia card 128MB
P
Multimedia card 256MB
P
Multimedia card 512MB
P
Apacer
Multimedia card 128MB
P
PQI
RS-MMC mobile 256MB memory card
P
A-Data
Turbo 200x 2GB MMC card
P
SD card
Apacer
SD card 128/256MB
P
SD card 2GB (150X Hi-Speed)
P
Transcend
SD card 256MB
P
SanDisk
SD card 256MB
P
SD card 1GB
P
KINGMAX
SD card 1GB (66X Hi-Speed)
P
RiData
SD 4GB SD Pro memory card
P
Memory stick
150
I-O data
Memory stick 64MB
P
Apacer
Memory stick 128MB
P
Appendix B
Memory Card Compatibility Test
Vendor
Lexar
Device Description
Result
High speed 512MB memory stick Pro Duo
P
High speed 1GB memory stick Pro Duo
P
SanDisk
MS Pro 1GB memory card
P
Sony
Memory stick Pro 512MB
P
MS Pro Duo 2GB high speed
P
MS Pro 2GB memory card
P
Apacer
Compact Flash card 256/512MB
P
SanDisk
Compact Flash card 2GB
P
Olympus
XD-Picture card 512MB
P
XD card
Game Test
Vendor
Blizzard
Atari
ID Software
Activision
EA
Microsoft
Sierra
Item Description
Result
WarCraft III CD-04-062
N/A
WarCraft III- Frozen Throne Expansion Pack CD-04-157
P
Neverwinter Nights + Patch v1.62 CD-04-220/WKS
P
Unreal Tournament 2004 CD-04-194
P
Quake III Arena CD-04-057
P
Quake III CD-04-197
P
Call of Duty 2 CD-04-203
P
Doom3 CD-04-194
P
Star Wars Jedi Knight: Jedi Army CD-04-192
P
Battlefield 1942 CD-04-107/WKS
P
Battlefield 2 CD-04-207
P
Command & Conquer Generals CD-04-222/WKS
P
Madden NFL 2006 CD-04-216
P
Nascar Thunder 2004 CD-04-113
P
Nascar SimRacing CD-04-228
P
NBA Live 2006 CD-02-214
P
Tiger Woods PGA Tour 2006 CD-04-199
P
Medal of Honor Allied Assault Spearhead Expansion Pack CD-04-122-1
P
FIFA World Cup Germany 2006 CD-04-234
P
Sports FIFA 2006 Soccer CD-04-236
P
Flight Simulator 2004 A Century of Flight CD-04-074
P
HALO CD-04-078
P
Rise of Nations 1.0 CD-04-079/WKS
P
Half-Life 2 CD-04-237
P
Crytek
Far Cry CD-04-154
P
Interwise
Silent Hunter III CD-04-226
P
Ubisoft
Tom Clancy’s Splinter Cell: Chaos Theory CD-04-230
P
EA games
Need for Speed - Under Ground II
P
Online game
Lineage II: Chronicle 3
P
World of WarCraft
P
RF Online
P
Appendix B
151
SW Utility and Application Test
Item Description
152
Result
PowerDVD
P
Windows DVD Maker
P
NTI-CD Maker
P
NIS
P
Launch Manager
P
Wireless AP
P
Bluetooth AP
P
Acrobat Reader
P
Office
P
Appendix B
Appendix C
Online Support Information
This section describes online technical support services available to help you repair your Acer Systems.
If you are a distributor, dealer, ASP or TPM, please refer your technical queries to your local Acer branch
office. Acer Branch Offices and Regional Business Units may access our website. However some information
sources will require a user i.d. and password. These can be obtained directly from Acer CSD Taiwan.
Acer's Website offers you convenient and valuable support resources whenever you need them.
In the Technical Information section you can download information on all of Acer's Notebook, Desktop and
Server models including:
T
Service guides for all models
T
User's manuals
T
Training materials
T
BIOS updates
T
Software utilities
T
Spare parts lists
T
TABs (Technical Announcement Bulletin)
For these purposes, we have included an Acrobat File to facilitate the problem-free downloading of our
technical material.
Also contained on this website are:
T
Detailed information on Acer's International Traveler's Warranty (ITW)
T
Returned material authorization procedures
T
An overview of all the support services we offer, accompanied by a list of telephone, fax and email
contacts for all your technical queries.
We are always looking for ways to optimize and improve our services, so if you have any suggestions or
comments, please do not hesitate to communicate these to us.
Appendix C
153
154
Appendix C