Bosch MUM 6630 UC Owner`s manual

Owner’s Manual
Universal Series Kitchen Machines
for models:
MUM 6610 UC • MUM 6622 UC
MUM 6630 UC
READ THIS MANUAL
thoroughly for important safety and operating
instructions before using this appliance.
1
IMPORTANT SAFEGUARDS
WARNING: A risk of fire and electrical shock exists in all electrical appliances and may
cause personal injury or death.
When using electrical appliances, basic safety precautions should always be followed,
including the following:
1. Read all instructions before using the kitchen machine.
2. To protect against risk of electric shock, do not put the drive unit in or under water or
other liquid.
3. This appliance is not for use by children.
4. Close supervision is necessary when any appliance is used near children.
5. Do not leave appliances unattended during operation.
6. Unplug from outlet when not in use, before putting on or taking off parts and
before cleaning.
7. To disconnect: switch appliance off then remove plug from power supply.
8. Avoid contacting moving parts. Keep hands, hair, clothing, as well as spatulas
and other utensils away from whisks, beaters, blades, disc, dough hook and/or other
moving parts during operation to reduce the risk of injury to persons and/or
damage to the appliance or its attachments.
9. Do not operate any appliance with a damaged cord or plug, or after the appliance
malfunctions or is dropped or damaged in any manner. Return appliance to the
nearest authorized service facility for examination, repair or electrical or mechanical
adjustment.
10. The use of attachments not recommended or sold by the appliance manufacturer
may cause fire, electric shock or injury and is therefore prohibited.
11. Do not use outdoors or when standing in a damp area.
12. Do not let cord hang over edge of table or counter, or touch hot surfaces.
13. Always operate appliance with covers in place.
14. Blades are sharp. Handle carefully due to risk of injury.
15. Remove beaters from mixing bowl before washing.
NOTE: ALSO BE SURE TO READ THE WARNINGS AND CAUTIONS THAT ARE
PROVIDED BEFORE EACH ATTACHMENT’S OPERATING INSTRUCTION.
SAVE THESE INSTRUCTIONS
2
TABLE OF CONTENTS
IMPORTANT SAFEGUARDS .................................................................. 2
Table of contents ..................................................................................... 3
ABOUT YOUR KITCHEN MACHINE ....................................................... 4
Bosch Universal Series Kitchen Machine ................................................ 4
Unpacking ............................................................................................... 4
Electrical specifications ............................................................................ 4
Before using for the first time .................................................................. 4
Getting to know your Bosch Kitchen Machine .......................................... 4
Special accessories ..................................................................... 6
Power unit features ................................................................................. 6
Getting started ..................................................................................... 7-9
STANDARD ATTACHMENTS ................................................................... 9
Mixing bowl w/twin beating whisks and dough hook ................................ 9
How to use dough hook ......................................................... 10-11
Placing into operation with dough hook ....................................... 11
How to use twin beating whisks .................................................. 11
Use of mixing bowl with twin beating whisks ............................... 11
Operation with dough hook and whisk assembly .......................... 12
Placing into operation with twin beating whisks .......................... 13
Care and cleaning of bowl and its accessories ........................... 14
Blender with unbreakable plastic jar ........................................................ 14
How to use blender ...................................................................... 15
Placing blender into operation ...................................................... 16
Example of use of blender ........................................................... 16
Care and cleaning of blender ........................................................ 17
Slicer/shredder with unbreakable bowl and “Universal” beater ................. 17
Slicer/shredder, intended use ...................................................... 18
Placing slicer/shredder into operation .......................................... 19
How to use “Universal” beater ..................................................... 20
Placing into operation with “Universal” beater .............................. 21
Care and cleaning of slicer/shredder with “Universal” beater ......... 21
Stainless steel bowl with dough hook ..................................................... 22
How to use dough hook ............................................................... 22
Use of stainless steel bowl and dough hook ................................ 22
Placing into operation with dough hook ....................................... 23
Care and cleaning of stainless steel bowl ................................... 23
SERVICE and REPAIR .......................................................................... 24
TROUBLESHOOTING ................................................................. 25
SAMPLE RECIPES .......................................................................... 26-27
SPECIAL ACCESSORIES ..................................................................... 28
BOSCH small appliance warranty ........................................................... 31
HOUSEHOLD USE ONLY
3
Unpacking
Carefully remove the power unit from its
packaging and place it on the counter so it
is ready to use. As you remove the
accessories from the carton, check them
against figure 1 to assure that all the
standard parts are present.
ABOUT YOUR KITCHEN MACHINE
Congratulations on having selected one of
the Bosch Universal Series Kitchen
Machines. A series of kitchen machines that
we and—thankfully—cooking professionals
the world over, feel are the best householdtype kitchen machines available.
Electrical Specifications
Check to make sure that the voltage on
which your kitchen machine is to operate
is the same as specified on the rating plate.
Standard North American models have an
electrical power rating of 700-watt maximum
power rating with the attachment that draws
the most power (some attachments may
draw less power).
As you read through these instructions,
please pay particular attention to the
IMPORTANT SAFEGUARDS. Specific
safeguards for the attachments, as well as
warnings and cautions, are provided in each
section describing the operation of that
particular attachment.
Before Using for the First Time
Before using any of the attachments for the
first time it is recommended they be washed,
rinsed well and dried. Of the attachments
supplied with the systems in this manual,
all parts, except the whisk holder for the
twin beating whisks and the blender’s
blade/base assembly, are dishwasher safe:
Bosch Universal Series Kitchen
Machine
The Bosch Universal Series Kitchen
Machine is available in 3 models:
• The MUM 6610 UC
comprised of the electronic power unit
with integral cord storage, six-quart
capacity mixing bowl, splash ring and
cover (MUZ 6 KR3), twin beating whisks,
dough hook and motor drive cover.
> The whisk holder should be hand
washed in warm soapy water, rinsed
and dried.
> The blender’s blade/base assembly
should be washed under running water
and dried.
• The MUM 6622 UC
comprised of the electronic power unit
with integral cord storage, six-quart
capacity mixing bowl, splash ring and
cover (MUZ 6 KR3), twin beating whisks,
dough hook, six-cup capacity blender
(MUZ 6 MX2) and motor drive cover.
Note: It is recommended that the
blender’s blade/base assembly
never be left to stand in water or
soap solution, to prevent the bearing
lubricant from being washed out.
• The MUM 6630 UC
comprised of the electronic power unit
with integral cord storage, six-quart
capacity mixing bowl, splash ring and
cover (MUZ 6 KR3), stainless steel
mixing bowl (MUZ 6 ER1), twin beating
whisks, dough hook, slicer/shredder
(MUZ 6 RR2) with universal beater (MUZ
6 RG3) and motor drive cover.
Getting to Know Your Bosch Kitchen
Machine
The Bosch Universal Series Kitchen
Machines are comprised of various
attachments, depending on the system
purchased (see above). In addition to the
attachments listed on the previous pages
that are available with the standard systems,
Bosch offers many special accessories.
4
MUM 6610 UC
MUM 6622 UC
MUM 6630 UC
Figure 1
5
Electronic speed control
Five-position rotary switch (figure 2a) is
located at the front of the power unit: 3
speeds plus a momentary pulse function
and a stop position “O/Off,” see figure 2a.
Special Accessories
To allow you to get the most service from
your Bosch Universal Series Kitchen
Machine, Bosch engineers have designed
a line of special accessories to expand the
usefulness of your machine. In addition to
the attachments that come with the various
Universal Series Kitchen Machines, there
are optional accessories that can be ordered
separately. These accessories include a
food and meat grinder, grain mills and citrus
juicer, plus additional attachments that can
be used with the meat grinder: fancy cookie
attachment, fruit pulper, pasta-making disks
and grater attachment. See SPECIAL
ACCESSORIES, at the back of this
booklet, page 28. Or, to view all currently
available accessories, visit our Web site at
Built-in Safety Cutout
The Universal Series Kitchen Machines are
provided with a built-in safety cutout switch
(figure 2b) to protect the motor against
overheating.
If the safety cutout trips:
a. Turn the machine to the off position
“O/Off” and unplug.
b. Wait a few minutes to allow the motor
to cool.
c. Depress the manual reset button.
You will find the reset button on the
bottom of the machine, see figure
2b.
www.boschsmallappliances.com
After allowing the machine to cool and
resetting the safety cutout switch, the
machine is again ready for use. The motor
should then start when plugged in and turned
to one of its 3 speeds or when turned on
and placed in momentary contact position.
Our work on expanding the usefulness of
the Bosch Kitchen Machine is a continuing
process. If there is some type of accessory
in which you are interested in, that is not
included at the back of the book, please
either write us at:
•
Dual drives
The Universal Series Kitchen Machines
come with two drives:
1. A high-speed drive directly coupled to
the motor, used to drive the blender, food
processor and other special
accessories.
2. A high-torque drive used to drive the
stirring/beating whisks, dough hook,
meat grinder and other special
accessories.
Bosch Small Appliances
Customer Support
BSH Home Appliances
5551 McFadden Avenue
Huntington Beach, CA 92649
Power Unit Features
All MUM 6000 power units have the following
features, refer to figure 2:
Motor drive cover
Used to cover drive that is not in use, see
figure 2c.
700-watt motor
The most powerful motor offered with any
household kitchen machine.
Convenient cord storage
Convenient cord storage is located on the
back of the power unit, see 2d.
6
Integrated hand grips
Side recesses molded into each end of the
power unit housing provide for easy lifting
and carrying of power unit when not in use,
see 2e.
Getting Started
The operation of your Bosch Universal
Series Kitchen Machine is summarized
below.
Specific instructions for using each of the
attachments, provided with the kitchen
machine systems covered by this manual,
follow the summarized instructions. Please
read the specific instructions thoroughly
before using that attachment, paying
particular attention to the IMPORTANT
SAFEGUARDS and WARNINGS provided.
Four rubber feet
Four rubber feet provide the ultimate in
stability, while also serving to isolate the
power unit from the hard surface to minimize
noise and vibration.
Figure 2.
7
1.
2.
3.
4.
Place power unit on suitable work
surface.
Before using the machine with any of
the attachments, the power unit should
be placed on a suitable work surface.
The surface should be sturdy, smooth
and clean; make sure that there is no
flour or oil on the surface. A clean,
smooth surface will provide the best
footing for the suction cup feet on
the power unit and will limit slipping
and/or “walking.”
rotary switch at the front of the power
unit. See figure 2a. The rotary switch
has five positions:
a. “M,” a momentary “pulse” position
that provides full speed and power
for the time it is held in position.
b. “O/Off,” the off position.
c. Four speeds labeled 1, 2 and 3.
Speed 1 is the lowest speed. The
speed increases with each
succeeding step up to the highest
speed, speed 3.
Plug power unit into power supply.
Unwind the power unit’s cord to
appropriate length and plug it into
a convenient nearby receptacle.
All models of the Bosch Universal
Series Kitchen Machines incorporate
a built-in safety cutout switch to
protect the motor against overheating.
If the safety becomes activated, the
power unit will stop. If power unit
should stop even though there is power
to the unit see TROUBLESHOOTING
at the back of this manual .
Remove motor drive cover.
If necessary, remove motor drive cover
from drive that will be used and place
it on drive that will not be used. The
cover, when placed on the high-speed
drive, can be locked in position by
pressing down and turning
counterclockwise, see figure 2c.
6.
Select attachment to be used.
Select the attachment you wish to use
and place on power unit. See specific
instructions for attachment selected.
Specific instructions are located on
pages listed below:
Turn power unit off.
When your work with the attachment
is completed or the capacity of the
batch-feed attachment has been
reached, turn the power unit to the Off
position, “O/Off,” and unplug.
7.
Remove the attachment.
Remove the attachment from the
power unit, per instructions for the
specific attachment being used.
8.
Continue use.
If the attachment was of the batch-feed
type and you wish to continue using
the attachment, empty the bowl or jar
of the attachment per its specific
instructions and reinstall the
attachment as before. Repeat steps
5 through 7 as often as necessary to
complete work.
Attachment
Pages
Mixing bowl w/dough hook ........ 9–11
Mixing bowl w/twin whisks ....... 11–14
Blender ..................................... 14–17
Slicer/shredder ......................... 17–21
Stainless steel bowl ................. 22–23
Table 1.
5.
Operate unit with rotary switch.
Once the attachment is in place, the
speed of its moving components can
be controlled through the use of the
8
9.
STANDARD ATTACHMENTS
Following are the specific instructions for
the standard attachments provided with the
Bosch Universal Series Kitchen Machines
covered by this manual.
Work completed,
remove attachment.
If the attachment is of the continuous
feed type or is the batch type and you
have completed the work you wished
to perform with the attachment,
remove the attachment from the power
unit per the instructions for the specific
attachment being used.
Mixing Bowl with Twin Beating Whisks
and Dough Hook
(MUZ 6 KR3)
10. Place contents (batch-feed type).
If the attachment is the batch feed
type, disassemble per the specific
attachment’s instructions and place
the contents in a suitable container.
WARNING
1. There is a risk of injury from rotating
tools when using the mixing bowl with
the dough hook or the twin beating
whisks.
2. Avoid contact with moving parts. Keep
hands, hair and clothing, as well as
spatulas, bowl scrapers and other
utensils away from dough hook and
whisks during operation to prevent
injury and/or damage to the power unit
or accessories.
3. Always work with the bowl lid and
splash ring fitted in place.
4. Do not change tools until the power unit
has come to a complete stop; when
switched Off, the power unit will continue
to turn for a brief period.
11. Care and cleaning.
Once you have completed working
with the Bosch Kitchen Machine, the
next step is to disassemble and clean
the attachments. If you wish to use
another attachment, please return to
step 4, above.
Power unit
With the power unit turned Off and
unplugged, it should be cleaned only with
a clean, damp cloth. Then wipe off the motor
drive cover and reinstall on the power unit.
Never use coarse or caustic cleaning
products to clean the power unit. Never
immerse the power unit in water.
All models of the Bosch Universal Series
Kitchen Machines are provided with a sixquart mixing bowl with twin beating whisks
and dough hook. The MUM 6630 UC also
comes with a stainless-steel bowl MUZ 6
ER1, see figure 1. If additional mixing bowls
are desired, they are available as accessory
items under the part numbers: MUZ 6 ER1
and/or MUZ 6 KR3, refer to the SPECIAL
ACCESSORIES section at the back of this
manual. The mixing bowl with dough hook
and twin beating whisks consists of the
following components, dependent upon the
system you have, see figure 3:
The power unit may be left on the counter
or stored for future use. If the unit will be
stored, wind the cord around the cord holder
and, using the carry grips, lift the power
unit and place in your chosen storage area.
Attachments
The attachment(s) that have been used
should be disassembled and washed, per
their specific instructions, dried and stored
for future use.
9
surface and switched to the Off position,
“O/Off,” and that you have, if necessary,
moved the motor drive cover to the drive
that will not be used.
1. Before using the mixing bowl and
dough hook for the first time, it
is recommended that the bowl,
cover, splash ring and dough hook be
washed. All components of the mixing
bowl and the dough hook are
dishwasher safe. Or they may be
washed in warm soapy water. After
washing, rinse well and dry before
using.
2. If you have not already done so, move
the motor drive cover to the high-speed
drive. Place the mixing bowl on the drive
of the power unit and turn the bowl
counterclockwise with a slight
downward pressure until bowl is firmly
seated, see figure 4a.
Figure 3.
3a. Bowl with cover and splash ring
3b. Dough hook
Figure 4.
3c. Twin beating whisks
CAUTION
How to Use Dough Hook
The dough hook and mixing bowl are
intended to be used to knead yeast doughs
and to mix cookie and pastry doughs, and
also when adding nuts, chocolate chips,
dried fruit, hard butter or shortening,
hardened brown sugar, etc. to batters.
Failure to make sure that the bowl is
properly seated on the drive coupling before
the power unit is turned On can result in
damage to the bowl and/or coupling.
3. Engage the dough hook on the
driveshaft of the mixing bowl by placing
it over the center column, as shown in
figure 4b. Once in place, check to make
sure dough hook has engaged the
driveshaft by turning the dough hook
Use of mixing bowl with dough hook
Before beginning to attach this or any other
attachment, make sure that the power unit
is on a smooth, clean, suitable work
10
How to Use Twin Beating Whisks
All Bosch Universal Series Kitchen
Machines come with a twin beating whisk
assembly, see figure 4c.
clockwise while pushing down until it
stops.
4. Place the splash ring on the bowl,
making sure the tabs on the bowl fit
into the recesses in the splash ring,
and turn counterclockwise, see figure
5a. Then place the cover on the splash
ring so that the tabs on the splash ring
fit into the recesses in the bowl cover
and turn the cover counterclockwise to
fasten the bowl cover to the bowl. See
figure 5b.
The twin beating whisks and mixing bowl
are intended to be used for very light
substances, such as cream, egg whites,
sauces, batters and light pastry doughs
that are thin enough to pour.
The dough hook should be used for all
heavier substances such as cookie doughs,
yeast doughs, pastry doughs and other
heavy doughs. The dough hook should
always be used when adding nuts,
chocolate chips, dried fruits, hard butter or
other fats, hardened brown sugar, etc. to a
mixture.
The splash ring and cover should be in
place whenever the power unit is in
operation. The splash ring and cover
serve to prevent the escape of flour
dust at the beginning of the stirring and
kneading process, and also serves to
prevent accidental contact with the
moving dough hook.
Use of mixing bowl with twin beating whisks
Before beginning to attach this or any other
attachment, make sure that the power unit
is on a smooth, clean, suitable surface and
switched to off position, “O/Off,” and that
you have moved the motor drive cover.
1. Before using the mixing bowl and twin
beating whisk assembly for the first
time, it is recommended that the bowl,
anti-splash cover, filling funnel cap and
twin beating whisk assembly be
washed. All components of the mixing
bowl and the twin beating whisk
assembly are dishwasher safe, except
the whisk holder.
Figure 5.
Placing into Operation w/Dough Hook
Make sure that the power unit is on a
smooth, clean, suitable work surface and
switched to the Off position, “O/Off.” Unwind
the electrical cord to the necessary length
and plug into a convenient outlet. The mixing
bowl with dough hook is now ready for
operation. See table 1 for examples
demonstrating the use of the dough hook
attachment. Sample recipes may also be
found in the recipe section, at the back of
this manual.
The whisks may be removed from the
whisk holder as shown in figure 7a, and
washed in the dishwasher along with
the mixing bowl and other components.
The whisk holder should be washed in
warm soapy water. After washing, rinse
well and dry the whisk holder before
reattaching the whisks as shown in
figure 7b.
11
OPERATION WITH DOUGH HOOK AND WHISK ASSEMBLY
Below you will find a table listing examples of how the dough hook and the whisk
assembly are to be used for various typical applications.
Attachment Ingredients
Twin beating
whisks
Speed
3
2 min.
(approx.)
20 eggs
(approx.)
Whipping cream
3
2 min.
6 cups
(approx.)
Sponge cake (any recipe)
Combine all ingredients
Whip
1
3
1/2 min.
Mix
Basic cake batter
Combine all ingredients
Mix
Dough hook
Max.
Amount
Egg whites (2)
Fold in flour mixture
Twin beating
whisks/dough
hook
Time
Cookie dough
Cream soft butter or shortening
and sugar using twin
beating whisks
Combine flour alternately with
liquid using dough hook
Stir in nuts, chocolate chips,
etc. using dough hook
Yeast dough
Combine all wet ingredients
Add flour in portions
M
(pulse)
3
4–6 min.
1
1/2 min.
3
3 min.
1
1/2 min.
3
3 min.
(approx.)
3x basic
recipe
(6 layers)
3 min
(approx.)
3x basic
recipe
(6 layers)
3x basic
recipe
(9 dozen
cookies)
2 or 3
1
1 or 2
1/2 min.
5 min.
(approx.)
3x basic
recipe
(10, 1 lb.
loaves)
Table 1. Examples of operation using whisk assembly and dough hook. Speed 1 should
be used for initial stirring and combining. Place all ingredients into the mixing bowl, liquids
first. Shortening must be soft (room temperature).
12
The splash ring and cover should be in
place whenever the power unit is in
operation. The splash ring and cover
serve to prevent the escape of flour
dust at the beginning of the stirring and
kneading process, and also serves to
prevent accidental contact with the
moving whisks.
2. If you have not already done so, move
the motor drive cover to the high-speed
drive. Place the mixing bowl on the drive
of the power unit and turn the bowl
counterclockwise with a slight
downward pressure until bowl is firmly
seated, see figure 4a.
CAUTION
Failure to make sure that the bowl is
properly seated on the drive coupling before
the power unit is turned on can result in
damage to the bowl and/or coupling.
Placing into Operation w/Twin Beating
Whisks
Make sure that the switch is in the off
position, “O/Off.” Unwind the electrical cord
to the necessary length and plug into the
wall outlet. The bowl with whisk assembly
is now ready for operation. See table 1 for
examples demonstrating the use of the twin
beating whisks.
3. Place and engage the twin beating
whisk assembly on the driveshaft of the
mixing bowl as shown in figure 6.
Mixing bowl tips:
1. When using the mixing bowl to knead
or mix a recipe designed to be
prepared by hand, you will find that with
the Bosch Kitchen Machine you can
usually place all the ingredients in the
mixing bowl at once. When doing this,
always place the liquids in first. This
will assure more thorough mixing.
2. When adding ingredients to a mixture:
a. Turn the rotary switch to a lower
speed;
b. Remove the cover from the splash
ring;
c. Add the ingredients through the
cover opening and replace the
cover.
Figure 6.
4. Place the splash ring on the cover,
making sure the tabs on the bowl fit
into the recesses in the splash ring,
and turn counterclockwise, see figure
5a. Then place the cover on the splash
ring so that the tabs on the splash ring
fit into the recesses in the bowl cover
and turn the cover counterclockwise to
fasten the bowl cover to the bowl. See
figure 5b.
3. If a large batch of dough is to be left in
the mixing bowl and allowed to rise, the
cover and splash ring should be
removed and placed loosely on the bowl
so that it is free to move if the dough
should begin to press on it.
13
Blender with Unbreakable Plastic Jar
(MUZ 7 MX1)
Removing Contents
Before beginning to remove the contents
from the mixing bowl, make sure that the
power unit has been turned to the Off
position, “O/Off.” Remove the cover and
splash ring by turning clockwise and lifting
off. Once the cover and splash ring have
been removed, the dough hook or the twin
beating whisks may be removed by turning
the hook or whisk assembly clockwise while
lifting.
WARNING
1. There is a risk of injury from sharp
blades when using the blender
attachment.
2. Keep hands and utensils out of the
blender jar while it is attached to the
power unit.
3. Blades are sharp. Handle carefully.
4. To avoid injury, never place blade
assembly on power unit without
blender jar properly attached.
5. Always operate the blender with the
cover in place. Always hold cover in
place while operating the blender to
prevent cover from coming loose.
6. The use of attachments, including
canning jars, not recommended by
the manufacturer, may cause a risk
of personal injury.
7. When blending hot and/or frothing
liquids, process a maximum of 18 fluid
ounces (0.5 litres) at a time.
The mixing bowl can be removed from the
power unit by turning the bowl clockwise
while lifting.
The contents may now be used as desired.
Care and Cleaning
of Bowl and Its Accessories
Except for the whisk holder and the dough
hook, the mixing bowl and its accessories
are dishwasher safe.
It is recommended that the whisk holder
and the dough hook be washed by hand in
warm soapy water, rinsed well and dried
after each use. The whisks can be removed
from the whisk holder by simply pulling them
off, see figure 7a.
Figure 7.
After washing, rinsing and drying, the
whisks may be placed back on the whisk
holder by reversing the action to remove
them, see figure 7b. Press them on until
they snap into place.
Figure 8.
The power unit of the kitchen machine
should be cleaned using a clean, damp
cloth only. Never use coarse or caustic
cleaning products to clean this appliance.
Never immerse the power unit in water.
8a.
8b.
8c.
8d.
8e.
14
Cover closure/funnel
Cover
Blender jar
Gasket
Blade/base assembly
The MUM 6622 UC Bosch Universal Series
Kitchen Machine includes the MUZ 6 MX2
blender accessory. The blender accessory
consists of, figure 8.
How to Use Blender
The blender has been designed for crushing
ice; mixing liquids; pureeing vegetables;
preparing special diet and infant foods;
pulverizing fruit, vegetables, nuts and dried
bread (for bread crumbs); and preparing
mayonnaise and sauces.
Figure 9.
2. To assemble or reassemble blade/base
assembly into the blender, insert the
blade/base assembly into the blender
jar and press down on the blade/base
assembly. Turn clockwise to the stop,
see figure 11. The blade/base assembly
is then back in place.
Before beginning to use this or any other
attachment, make sure that the power unit
is on a clean, smooth, suitable work
surface and switched to off position, “O/Off,”
and that you have removed the motor drive
cover.
1. Before using the blender for the first
time, it is recommended that the
blender jar cover, closure/funnel and
blade/base assembly be washed. All
components, except the blade/base
assembly, are dishwasher safe.
Remove the blade/base assembly from
the blender, see figure 9.
CAUTION
Blade/base assembly is very sharp.
Handle with care.
The blade/base assembly may be
easily removed by inverting the blender
and using the blender cover to fit over
the tabs on the blade/base assembly.
Turn it counterclockwise until it stops,
see figure 9a, and then lift up, figure 9b.
Figure 10.
Wash the blade/base assembly under
running water. Do not place the blade/
base assembly in the dishwasher or
allow it to stand in water. This will tend
to wash out the lubricant. After
cleaning, rinse thoroughly and dry
before using.
3. If you have not already done so, move
the motor drive cover to the high-speed
drive. Place the blender on the hightorque drive of the power unit and turn
the blender counterclockwise with a
slight downward pressure until the jar
is firmly seated, see figure 11.
15
Example of Use of Blender
To familiarize you with the operation of the
blender, a sample recipe for mayonnaise is
provided below:
1
1/3
2
1
1/2
1/2
2/3
Figure 11.
Placing Blender into Operation
Make sure that the switch is in the off
position, “O/Off.” Unwind the electrical cord
to the necessary length and plug into wall
outlet. The blender is now ready for
operation.
Normally when blending, the blender jar
should be filled with the entire amount of
material to be blended, if possible, before
switching the appliance on. The cover and
cover closure should always be in place after
filling the blender jar and before switching
the power unit to On. Any subsequent
additions to the blended material should be
made through the cover opening, see figure
12. For solids and/or granular material,
remove the cover closure/funnel to add the
material, as shown in figure 12a. For liquids,
the closure/funnel may be left in place and
the liquids added by pouring it into the
closure/funnel, see figure 12b.
Mayonnaise Recipe
whole egg
cup of vegetable oil
tablespoons lemon juice or light
vinegar
teaspoon sugar
teaspoon dry mustard
teaspoon of salt
cup of vegetable oil
Mix all ingredients, except final 2/3’s cup
of oil, for a few seconds at speed 1, then
quickly pour the oil in through the opening
in the cover in a uniformly thick stream, as
shown in figure 14b. Operate the blender at
speeds 1 or 4 until mixture is thick and
smooth (approximately 10-20 seconds).
Makes 1 1/4 cups.
Figure 12.
Tips:
The blender should be operated with careful
consideration as to what is required and/or
desired. The speed at which the blender is
operated and the length of operation for a
given job will depend upon the degree of
fineness desired or the amount being
blended.
Everything Kitchens 1-866-852-4268
When the blender is being used on dry
materials, such as nuts or dry bread, the
best results will be obtained when the
blender jar is filled with approximately 1/2
cup of material to be blended.
Slicer/Shredder, w/Unbreakable Bowl
(MUZ 6 RR2) and “Universal” Beater
(MUZ 6 RG3)
If the blender does not start (even after trying
the highest speed) and it is humming or
not functioning at all, the blade has become
blocked by the contents. The power unit
should be:
1. Blades on discs are sharp. Handle
carefully. Do not grip the discs by the
blades.
2. When operating slicer/shredder keep
hands clear of filling tube. Only work
with pusher.
3. Always operate the slicer/shredder with
the cover in place.
WARNING
1. Switched to off, “O/Off,” and unplugged.
2. The mixture should be removed and the
contents at the bottom of the jar
loosened.
The MUM 6630 UC Bosch Universal Series
Kitchen Machine includes the MUZ 6 RR2
slicer/shredder attachment with the MUZ
6 RG3 “Universal” beater. The slicer/
shredder and beater attachment consists
of, figure 13:
See TROUBLESHOOTING section.
Removing Contents
Before beginning to remove the contents
from the blender, make sure that the power
unit has been turned to the Off position,
“O/Off.” Remove the blender from the power
unit by turning the blender clockwise while
lifting. With the blender removed from the
power unit, the contents of the blender may
now be poured into a suitable container or
bowl, as desired.
Care and Cleaning of Blender
All components of the blender, except the
blade/base assembly, are dishwasher safe.
It is recommended that the blade/base
assembly be cleaned only under flowing
water rather than in the dishwasher. Soap
and detergent will tend to wash out the
bearing lubricant of the blade/base
assembly. Do not use scouring cleaners on
any of the blender parts.
Figure 13.
a.
b.
c.
d.
e.
The power unit of the kitchen machine
should be cleaned with a clean, damp cloth
only. Never use coarse or caustic cleaning
products to clean this appliance. Never
immerse the power unit in water.
f.
17
Cover closure/pusher
Cover
Unbreakable 12-cup capacity bowl
disc holder
3 slicer/shredder discs:
• reversible slicing disc
• reversible shredding disc
• grating disc
“Universal” beater
Slicer/shredder, intended use
The slicer/shredder attachment has been
designed for slicing, shredding and/or
grating of vegetables, as well slicing/
shredding of soft cheeses and sausages
or meat and grating of vegetables and hard
cheese.
After removing the small gear wheel
the large gear wheel can be easily
removed by hand.
2.The driveshaft can be readily removed
from the slicer/shredder bowl by
turning the bowl over and pressing
against the driveshaft, as shown in
figure 15, until the gear disengages
and then pulling the driveshaft out.
Use of Slicer/Shredder
Before beginning to use this or any other
attachment, make sure that the power unit
is on a smooth, clean, suitable work
surface and switched to the Off position,
“O/Off,” and that you have moved the motor
drive cover to the drive that will not be used,
see figure 17a.
1. Before using the slicer/shredder for the
first time, it is recommended that the
bowl, cover, closure/pusher, discs, disc
holder and “Universal” beater be
washed.
Figure 15.
WARNING
The blades on the discs are very sharp.
Handle with care.
All components of the slicer/shredder
are dishwasher safe. After washing,
rinse well and dry. Then reassemble
“Universal” whisk. When reassembling
the “Universal” whisk, be sure reinstall
the large gear wheel first, then press
the small gear wheel onto the short
axle, until it engages, see figure 16,
then insert the whisk. After
reassembling the “Universal” whisk,
reinsert driveshaft in bowl before using.
Figure 14.
To facilitate cleaning it is recommended
that the “Universal” beater be
disassembled and that the driveshaft
be removed from the slicer/shredder
bowl:
1.The “universal” beater can be
disassembled as shown in figure 14.
First remove the whisk from its
holder, as shown in 14a. Then, using
a long flat object, like the handle of a
teaspoon, pry up the small gear wheel
and remove, as shown in figure 14b.
Figure 16.
18
Placing Slicer/Shredder into Operation
Make sure the power unit is on a smooth,
clean, suitable work surface and switched
to the Off position, “O/Off.” Unwind the
electrical cord to the necessary length and
plug into a convenient outlet. The slicer/
shredder is now ready for use.
Place items to be sliced, shredded or
grated in feeding funnel and be sure to use
the pusher to feed items into the discs when
in operation.
Learning how to feed food properly into the
feed funnel is the most important factor for
proper slicing and grating:
1. For long slices or long shreds, place
food into the feeding funnel lengthwise.
2. For short or circular slices, place food
in the feeding tube on end. For
example, if you wish to have circular
slices of zucchini or carrots:
• cut to length not to extend above the
top of the feeding tube.
• place the cut zucchini or carrots in
the feeding tube on end until the
feeding tube is packed.
Figure 17.
2. To assemble the slicer/shredder:
a. Place slicer/shredder bowl on the
power unit by placing over the hightorque drive and, while pressing
down, turn it counterclockwise to
stop and lock the bowl in place,
see figure 17b.
c. Select disc to be used and place
on disc holder and place over
driveshaft, see figure 18a.
d. Then place cover on bowl, making
sure the tabs on the cover enter
the recesses in the bowl, and turn
counterclockwise to stop, see
figure 18b.
To slice a single narrow item, a carrot for
example:
• place the carrot in the feeding funnel
opposite the cutting edge of the disc.
The wall of the feeding funnel will then serve
to hold the piece vertical.
When using the slicer/shredder be sure to
watch the level in the bowl and stop the
slicing, shredding or grating before the level
of the material being sliced, shredded or
grated reaches the level of the disc holder.
Slicer/shredder tips:
1. Shopping for fruits and vegetables that
will fit into the feeding funnel will simplify
food preparation.
Figure 18.
19
heavy doughs. The dough hook should
always be used when adding nuts,
chocolate chips, dried fruits, hard butter or
other fats, hardened brown sugar, etc. to a
mixture.
2. Foods that are to be used together may
be sliced together. This can be used to
your advantage. For example, green
onions and celery are often used
together, but feeding the green onions
into the feeding funnel alone is difficult.
Try slicing the green onions at the same
time as the celery by interspersing
them in the feeding funnel with the
celery.
3. Use the slicing disc to shred lettuce.
4. Do not overcook potatoes that are to
be sliced. Also it is recommended that
you let them cool first. Potatoes must
be cool and firm to obtain the regular
slices.
If the slicer/shredder does not start (even
after trying the highest speed) and it is
humming or not functioning at all, the disc
has become blocked by the contents. The
power unit should be:
Use of “universal” beater with slicer/shredder
bowl
Before beginning to attach this or any other
attachment, make sure that the power unit
is on a smooth, clean, suitable surface and
switched to the Off position, “O/Off,” and
that you have moved the motor drive cover
to the drive that will not be used.
1. Before using the slicer/shredder bowl
with the “Universal” beater for the first
time, it is recommended that the bowl,
cover, closure/pusher and “Universal”
beater be washed. All these
components are dishwasher safe.To
facilitate cleaning it is recommended
that the “Universal” beater be
disassembled and that the driveshaft
be removed from the slicer/shredder
bowl, see Use of Slicer/Shredder
instructions on page 18.
1. Switched to the Off position, “O/Off,”
and unplugged.
2. The top cover should be removed and
the items causing the blockage
removed.
See TROUBLESHOOTING section.
How to Use “Universal” Beater
The Bosch MUM 6630 UC also comes with
the “Universal” beater (MUZ 6 RG3), see
figure 13f.
The “Universal” beater and slicer/shredder
bowl are intended to be used for very light
substances, such as cream, egg whites,
sauces, batters and light pastry doughs
that are thin enough to pour.
The dough hook should be used for all
heavier substances such as cookie doughs,
yeast doughs, pastry doughs and other
Figure 19.
20
2. To assemble the slicer/shredder with
the “Universal” beater:
a. Place slicer/shredder bowl on the
power unit by placing over hightorque drive. While pressing down,
turn it counterclockwise to stop
and lock the bowl in place, see
figure 17b.
c. Pick up the “Universal” beater and
place it over driveshaft, see figure
19.
d. Then place cover on bowl, making
sure the tabs on the cover enter
the recesses in the bowl, and turn
counterclockwise to stop, see
figure 18b.
b. Remove the cover closure/pusher
from the filling funnel
c. Add the ingredients through the
funnel opening and replace the
cover closure/pusher
Removing Contents
Before beginning to remove the contents
from the slicer/shredder bowl, make sure
that the power unit has been turned to the
Off position, “O/Off.” Remove the slicer/
shredder from the power unit by turning the
slicer/shredder bowl clockwise while lifting.
With the slicer/shredder removed from the
power unit, remove the top cover, by turning
it clockwise while lifting. Next remove the
disc holder and disc by grasping the knob
of the disc holder that is protruding through
the center of the disc or remove the
“Universal” beater from of the bowl. The
contents of the slicer/shredder bowl may
now be poured into a suitable container or
bowl, as desired.
Placing into Operation w/”Universal”
Beater
Make sure that the switch is in the Off
position, “O/Off.” Unwind the electrical cord
to the necessary length and plug it into the
wall outlet. The bowl with whisk assembly
is now ready for operation. See table 1 for
examples demonstrating the use of the twin
beating whisks.
Care and Cleaning of Slicer/Shredder
with “Universal” Beater
All components of the slicer/shredder and
the “Universal” beater are dishwasher safe.
Do not use scouring cleaners on any of the
slicer/shredder parts.
Mixing tips:
1.When using the slicer/shredder bowl to
mix a recipe designed to be prepared
by hand, you will find that with the
Bosch Kitchen Machine you can
usually place all the ingredients in the
bowl at once. When doing this, always
place the liquids in first. This will
assure more thorough mixing.
To facilitate cleaning:
> The “Universal” beater should be
disassembled, see figure 14.
> The driveshaft should be removed from
the slicer/shredder bowl, see figure 15;
The power unit of the kitchen machine
should be cleaned with a clean, damp cloth
only. Never use coarse or caustic cleaning
products to clean this appliance. Never
immerse the power unit in water.
2. When adding ingredients to a mixture:
a. Turn the rotary switch to a lower
speed
21
Stainless Steel Bowl with Dough Hook
(MUZ 6 ER1)
drive pin with gasket be washed. All
components of the mixing bowl and the
dough hook are dishwasher safe. Or
they may be washed in warm soapy
water. After washing, rinse well and dry
before using.
WARNING
1. There is a risk of injury from rotating
tools when using the mixing bowl with
the dough hook.
2. Avoid contact with moving parts. Keep
hands, hair and clothing, as well as
spatulas, bowl scrapers and other
utensils away from dough hook and
during operation to prevent injury and/
or damage to the power unit or
accessories.
3. Always work with the bowl lid and
splash ring fitted in place.
4. Do not change tools until the power unit
has come to a complete stop; when
switched Off, the power unit will continue
to turn for a brief period.
The MUM 6630 UC Bosch Universal Series
Kitchen Machine includes the MUZ 6 ER1
stainless steel bowl with dough hook. The
stainless steel bowl attachment consists
of, figure 20:
How to Use Dough Hook
The dough hook and stainless steel bowl
are intended to be used to knead yeast
doughs and to mix cookie and pastry
doughs.
Figure 20.
Use of stainless steel bowl with dough hook
Before beginning to attach this or any other
attachment, make sure that the power unit
is on a smooth, clean, suitable work
surface and switched to the Off position,
“O/Off,” and that you have, if necessary,
moved the motor drive cover to the drive
that will not be used.
20a.
Bowl cover
20b.
Splash ring
20c.
Dough hook
20d.
Stainless steel bowl
20e.
Drive pin w/gasket
2. If you have not already done so, move
the motor drive cover to the high-speed
drive. Place the stainless bowl on the
drive of the power unit and turn the bowl
counterclockwise with a slight
downward pressure until bowl is firmly
seated. See figure 21a.
1. Before using the mixing bowl and
dough hook for the first time, it
is recommended that the bowl,
cover, splash ring, dough hook and
22
Placing into Operation w/Dough Hook
Make sure that the power unit is on a
smooth, clean, suitable work surface and
switched to the Off position, “O/Off.” Unwind
the electrical cord to the necessary length
and plug into a convenient outlet. The mixing
bowl with dough hook is now ready for
operation. See table 1 for examples
demonstrating the use of the dough hook
attachment. Sample recipes may also be
found in the recipe section, at the back of
this manual.
CAUTION
Failure to make sure that the bowl is
properly seated on the drive coupling before
the power unit is turned On can result in
damage to the bowl and/or coupling.
Removing Contents
Before beginning to remove the contents
from the stainless steel bowl, make sure
that the power unit has been turned to the
Off position, “O/Off.” Remove the cover and
splash ring by turning clockwise and lifting
off. Once the cover and splash ring have
been removed, the dough hook may be
removed by turning the hook clockwise
while lifting.
Figure 21.
3. Engage the dough hook on the
drive pin by placing it in bowl, as shown
in figure 21b, and turning the dough
hook clockwise while pushing down until
it stops.
The mixing bowl can be removed from the
power unit by turning the bowl clockwise
while lifting.
Figure 22.
The contents may now be used as desired.
4. Place the splash ring on the bowl,
making sure the tabs on the bowl fit
into the recesses in the splash ring,
and turn counterclockwise, see figure
22a. Then place the cover on the splash
ring so that the tabs on the splash ring
fit into the recesses in the bowl cover
and turn the cover counterclockwise to
fasten the bowl cover to the bowl. See
figure 22b.
Care and Cleaning
of Stainless Steel Bowl
The stainless steel bowl and its components
are dishwasher safe. It is recommended
that the drive pin be removed from the bowl
for cleaning, and that the pin, its gasket
and the inner bearing surface, where the
drive pin rides, be cleaned after every use.
After cleaning, a little vegetable oil placed
on the drive pin gasket will help to lubricate
the surface.
The splash ring and cover should be in
place whenever the power unit is in
operation. The splash ring and cover
serve to prevent the escape of flour
dust at the beginning of the stirring and
kneading process, and also serves to
prevent accidental contact with the
moving dough hook.
The power unit of the kitchen machine
should be cleaned using a clean, damp
cloth only. Never use coarse or caustic
cleaning products to clean this appliance.
Never immerse the power unit in water.
23
TROUBLESHOOTING
Problem
Power
unit does
not
function
Power
unit hums
but
nothing is
moving
Possible Cause
Remedy
1.A circuit breaker may have
tripped or a fuse has blown
in the power supply circuit.
Reset circuit breaker or
replace fuse.
2.The built-in safety cutout
may have tripped.
If the safety has tripped due to
overheating:
> Turn the power unit to the Off
position, “O/Off,” and unplug.
> Remove the attachment that was
in use when safety tripped, and
correct whatever the situation
is that caused the safety to trip.
> Wait a few minutes (minimum 30
minutes recommended) to allow
the motor to cool.
> Depress the manual reset button
on the bottom of the power unit,
see figure 2b.
> Reinstall the attachment and
resume use per attachment’s
instructions.
1.The motor has become
blocked; that is, the
attachment being used has
become jammed.
> Turn the power unit to the Off
position, “O/Off,” and unplug.
> Remove the attachment
that was in use and correct
whatever the situation is that
is causing the blockage.
> Reinstall the attachment and
resume use per attachments
instructions.
25
Sample Recipes
Fruit Smoothies
Salsa
2
2
1/2
1
1–2
1
Chop the following ingredients in Bosch
blender or food processor, on speed 3 or 4:
1–4
1
1/8
8
Dried Arabol Chilies
(start with one, add more for
increased spiciness)
clove garlic
cup water
ounces tomato sauce (add
half)
cups fruit juice
cups frozen fruit
can frozen juice concentrate
cup fruit-flavored yogurt
cups of ice
fresh banana
Place all ingredients in Bosch blender and
mix until smooth, on speed 3 or 4.
Experiment with different flavor
combinations such as tropical, berry or
melon.
Next add:
1 1/2 teaspoons oregano
3/4
teaspoons cumin
1
bunch of fresh cilantro
pinch of salt
second half of tomato sauce
French Bread
Blend all ingredients, on speed 1 or 2, until
smooth.
4
4
6
2
1
10–12
4
Pesto
1
cup loosely packed basil
leaves
1/2
cup grated Parmesan
1/3-1/2 cup olive oil (enough for
desiredconsistency)
1–2
cloves garlic
1/4
cup shelled pinenuts
tablespoons active dry yeast
cups hot water
tablespoons sugar
tablespoons salt
cup vegetable oil
cups of flour (white or wheat)
tablespoons gluten
Place all ingredients in Bosch mixing bowl.
Thoroughly knead on speed 1 or 2 (8–10
minutes). Let rise in the bowl 10 minutes,
then punch down. Punch down 4 or 5 times.
Divide into 3–4 regular loaf pans or shape
into rounds. Slash tops with sharp knife and
brush with egg wash. Let raise until doubled
in size. Bake 30 minutes at 400° F.
Lightly toast pinenuts. Let cool. Place olive
oil in Bosch blender or food processor. Turn
on power and gradually add Parmesan
cheese, garlic and basil leaves. Process,
on speed 1 or 2, until smooth. Add pinenuts
and blend thoroughly.
Toss with cooked pasta or spread on bread
or crackers.
26
Oatmeal-Chocolate Chip Cookies
2
1
2
1
1–3/4
1
1/2
3
1
cups packed brown sugar
cup shortening
eggs
teaspoon vanilla
cups flour
teaspoon baking soda
teaspoon salt
cups quick-cooking rolled oats
cup chocolate chips
Cream the brown sugar, shortening, eggs
and vanilla in the mixing bowl, on speed 1
or 2. Add flour, baking soda and salt. Blend
well, stir in rolled oats and chocolate chips
by hand. Drop by spoonfuls onto greased
baking sheets. Bake in a 350° F oven for 8–
10 minutes. Cool before removing from pan.
Makes 5 dozen.
Acknowledgments:
The sample recipes listed above were submitted by:
Salsa - Caroline Ciarelli, BSH Home
Appliances
Pesto - Kitchen Resource
Fruit Smoothies - Marni Rader, BSH
Appliances
French Bread - Kitchen Resource
Oatmeal-Chocolate Chip Cookies Kitchen Resource
27
SPECIAL ACCESSORIES
28
Important Notes
29
Important Notes
30
BOSCH Small Appliance Warranty
BSH Home Appliances (“BOSCH”) warrants all new small appliances to be free from original
defects in design, materials and workmanship for one (1) year after the sale to the original
owner.
Within the stated warranty period, BOSCH will repair or replace, at its sole option, any
small appliance or parts thereof which prove defective under the conditions of normal use
and service at no charge to you. It is the owner’s responsibility to return the appliance for
repair. Repaired and replacement small appliances and parts shall be the same or as
close in appearance as possible to the original for the purposes of this warranty.
Should you require service of your BOSCH small appliance, please contact customer
service at 1-866-44-BOSCH. Repair of BOSCH appliances should only be performed by
qualified technicians.
This warranty is limited to the original consumer purchase and is not transferable. Specifically
excluded from this warranty are failures caused by accident, misuse, neglect, abuse,
including tampering, use of frequency or voltage other than marked on the product, and
use for commercial purposes.
To the extent allowed by law, this warranty sets out your exclusive remedies, whether for
negligence or otherwise. BOSCH will not be liable for any consequential or incidental
damages, losses or expenses. THIS WARRANTY IS IN LIEU OF ALL OTHER EXPRESSED
WARRANTIES. ANY WARRANTY IMPLIED BY LAW, WHETHER FOR
MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR OTHERWISE,
SHALL BE EFFECTIVE ONLY FOR THE PERIOD THAT THIS EXPRESSED WARRANTY
IS EFFECTIVE. BOSCH DOES NOT ASSUME ANY RESPONSIBILITY FOR INCIDENTAL
OR CONSEQUENTIAL DAMAGES.
No attempt to alter, modify or amend this warranty shall be effective unless authorized in
writing by an officer of BOSCH. Some states do not allow limitations on how long implied
warranties last or the exclusion or limitation of incidental or consequential damages, so
the foregoing limitations and exclusions may not apply to you. This warranty gives you
specific legal rights and you may also have other rights which vary from state to state.
31
Looking for more information about BOSCH products?
Call 1-866-852-4268
www.everythingkitchens.com
32