Siemens MCM 21T1 Service manual

MCM 21T1
SERVICE MANUAL
AEP Model
Chassis No. SCC-L04S-A
N3 CHASSIS
SPECIFICATIONS
COLOR Monitor
MCM 21T1
SAFETY CHECK-OUT
After correcting the original service problem, perform the following safety checks before releasing the set to the customer:
1. Check the area of your repair for unsoldered or poorly-soldered connections. Check the entire board surface for solder
splashes and bridges.
2. Check the interboard wiring to ensure that no wires are
“pinched” or contact high-wattage resistors.
3. Check that all control knobs, shields, covers, ground straps,
and mounting hardware have been replaced. Be absolutely
certain that you have replaced all the insulators.
4. Look for unauthorized replacement parts, particularly transistors, that were installed during a previous repair. Point
them out to the customer and recommend their replacement.
5. Look for parts which, though functioning, show obvious
signs of deterioration. Point them out to the customer and
recommend their replacement.
6. Check the line cords for cracks and abrasion. Recommend
the replacement of any such line cord to the customer.
7. Check the B+ and HV to see if they are specified values.
Make sure your instruments are accurate; be suspicious of
your HV meter if sets always have low HV.
8. Check the antenna terminals, metal trim, “metallized”
knobs, screws, and all other exposed metal parts for AC
Leakage. Check leakage as described below.
To Exposed Metal
Parts on Set
0.15 µF
1.5 k Ω
AC
Voltmeter
(0.75 V)
LEAKAGE TEST
The AC leakage from any exposed metal part to earth ground
and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500
microampers).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or
RCA WT-540A. Follow the manufacturers’ instructions to
use these instruments.
2. A battery-operated AC milliammeter. The Data Precision
245 digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a
VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate lowvoltage scale. The Simpson 250 and Sanwa SH-63Trd are
examples of a passive VOMs that are suitable. Nearly all
battery operated digital multimeters that have a 2 V AC
range are suitable. (See Fig. A)
WARNING!!
NEVER TURN ON THE POWER IN A CONDITION IN
WHICH THE DEGAUSS COIL HAS BEEN REMOVED.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY SHADING AND MARK
¡ ON THE SCHEMATIC DIAGRAMS, EXPLODED
VIEWS AND IN THE PARTS LIST ARE CRITICAL FOR
SAFE OPERATION. REPLACE THESE COMPONENTS
WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. CIRCUIT ADJUSTMENTS THAT ARE CRITICAL FOR SAFE OPERATION
ARE IDENTIFIED IN THIS MANUAL. FOLLOW THESE
PROCEDURES WHENEVER CRITICAL COMPONENTS
ARE REPLACED OR IMPROPER OPERATION IS SUSPECTED.
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
CAUTION ON DAS (ECS) CONNECTOR
• The connector for DAS (ECS) adjustment is provided inside
the cover shown below. Be careful with an electrical shock
when connecting the connector with the power supplied. Also,
return the removed cover to the home position.
Rear side
–2–
MCM 21T1
POWER SAVING FUNCTION
This monitor meets the power-saving guidelines set by VESA and
Energy Star, as well as the more stringent NUTEK .
If the monitor is connected to a computer or video graphics board
that is VESA DPMS (Display Power Management Signaling)
compliant, the monitor will automatically reduce power consumption in three stages as shown below.
You can set the delay time before the monitor enters the power
saving mode using the OSD. Set the time according to “Setting
the power saving delay time”.
Note
If no video signal is input to the monitor, the “NO INPUT SIGNAL” message appears. After the delay time has passed, the
power saving function automatically puts the monitor into the active-off mode and the indicator lights up orange. Once the horizontal and vertical sync signals are detected, the monitor automatically resumes its normal operation mode.
Vertical
sync signal
present
present
Power
consumption
≤ 160 W
≤ 100 W
Recovery time
u indicator
active
blank
Horizontal
sync signal
present
absent
—
Approx. 3 sec.
Suspend (2nd mode)
blank
present
absent
≤ 15 W
Approx. 3 sec.
Active-off (3rd mode)
Power-off
blank
—
absent
—
absent
—
≤5W
0W
Approx. 10 sec.
—
Green
Green and orange
alternate
Green and orange
alternate
Orange
Off
Screen
1
2
Power consumption
mode
Normal operation
Standby (1st mode)
3
4
5
DIAGNOSIS
Failre
+B failure
Horizontal / Vertical Deflection
failure, Thermal protector
ABL protector
HV failure
Aging / Self Test
Orange →
(0.5 sec)
Orange →
(1.5 sec)
Orange →
(0.5 sec)
Orange →
(0.25 sec)
Orange →
(0.5 sec)
Power LED
Off
(0.5 sec)
Off
(0.5 sec)
Off
(1.5 sec)
Off
→ Orange →
Off
(0.25 sec)
(0.25 sec) (1.25 sec)
Off
→
Green →
Off
(0.5 sec)
(0.5 sec)
(0.5 sec)
Aging Mode (Video Aging) : During Power Save, press “MENU” key for longer than 2 second.
Self Test (OSD Color Bar) : During Power Save, press “CONTRAST” + (/) key for longer than 2 second.
Reliability Check Mode
: During Power Save, press “CONTRAST” – (?) key for longer than 2 second.
–3–
MCM 21T1
TIMING SPECIFICATION
MODE AT PRODUCTION
MODE FOR CUSTOMER
MODE 1
MODE 2
MODE 3
VGA
E-VGA
VGA
VESA
VESA
SNI-100Hz
VESA
VESA
SNI-100Hz
MGA
720 X 400
720 X 400
640 X 480
640 X 480
640 X 480
640 X 480
800 X 600
800 X 600
800 X 600
800 X 600
28.325 MHz
36.082 MHz
25.175 MHz
31.500 MHz
36.000 MHz
40.500 MHz
49.500 MHz
56.250 MHz
67.500 MHz
81.000 MHz
31.472 kHz
37.822 kHz
31.469 kHz
37.5 kHz
43.269 kHz
50.625 kHz
46.875 kHz
53.674 kHz
63.92 kHz
76.705 kHz
usec
usec
usec
usec
usec
usec
usec
usec
usec
usec
H. TOTAL
31.774
26.44
31.778
26.667
23.111
19.753
21.333
18.631
15.644
13.037
H. BLK
6.355
6.485
6.356
6.349
5.333
3.951
5.172
4.409
3.793
3.16
H. FP
0.635
0.748
0.636
0.508
1.556
0.395
0.323
0.569
0.474
0.395
H. SYNC
3.813
1.247
3.813
2.032
1.556
1.58
1.616
1.138
0.948
1.185
H. BP
1.906
4.49
1.907
3.81
2.222
1.975
3.232
2.702
2.37
1.58
H. ACTIV
25.419
19.955
25.422
20.317
17.778
15.802
16.162
14.222
11.852
9.877
70.094 Hz
84.236 Hz
59.94 Hz
75 Hz
85.008 Hz
100.049 Hz
75 Hz
85.061 Hz
100.032 Hz
120.038 Hz
lines
lines
lines
lines
lines
lines
lines
lines
lines
lines
V. TOTAL
449
449
525
500
509
506
625
631
639
639
V. BLK
49
49
45
20
29
26
25
31
39
39
V. FP
13
9
10
1
1
1
1
1
1
2
V. SYNC
2
3
2
3
3
3
3
3
3
3
RESOLUTION
CLOCK
— HORIZONTAL —
H-FREQ
— VERTICAL —
V. FREQ(HZ)
V. BP
34
37
33
16
25
22
21
27
35
34
V. ACTIV
400
400
480
480
480
480
600
600
600
600
— SYNC —
INT(G)
EXT(H/V)/POLARITY
EXT(CS) /POLARITY
INT/NON INT
SIZE(21")
NO
NO
NO
NO
NO
NO
NO
NO
NO
NO
YES N/P
YES N/P
YES N/N
YES N/N
YES N/N
YES N/N
YES P/P
YES P/P
YES P/P
YES N/N
NO
NO
NO
NO
NO
NO
NO
NO
NO
NO
NON INT
NON INT
NON INT
NON INT
NON INT
NON INT
NON INT
NON INT
NON INT
NON INT
388x291 mm 388x291 mm 388x291 mm 388x291 mm 388x291 mm 388x291 mm 388x291 mm 388x291 mm 388x291 mm 388x291 mm
MODE AT PRODUCTION
MODE 5
MODE 6
MODE 7
VESA
SNI-100Hz
MGA
VESA
SNI-110Hz
VESA
VESA
1024 X 768
1024 X 768
1024 X 768
1152 X 864
1152 X 864
94.5 MHz
111.2 MHz
131 MHz
108 MHz
157 MHz
135 MHz
68.677 kHz
80.814 kHz
97.47 kHz
67.5 kHz
100.128 kHz
usec
usec
usec
usec
usec
H. TOTAL
14.561
12.374
10.26
14.815
H. BLK
3.725
3.165
2.443
H. FP
0.508
0.288
0.244
MODE FOR CUSTOMER
RESOLUTION
CLOCK
MODE 4
MODE 8
MODE 9
SNI-100Hz
VESA
VESA
1280 X 1024
1600 X 1200
1600 X 1200
157.5 MHz
184.9 MHz
202.5 MHz
229.5 MHz
79.976 kHz
91.146 kHz
107 kHz
93.75 kHz
106.25 kHz
usec
usec
usec
usec
usec
9.987
12.504
10.971
9.346
10.667
9.412
4.148
2.65
3.022
2.844
2.423
2.765
2.44
0.593
0.204
0.119
0.406
0.173
0.316
0.279
1280 X 1024 1280 X 1024
— HORIZONTAL —
H-FREQ
H. SYNC
1.016
1.151
0.977
1.185
0.815
1.067
1.016
0.692
0.948
0.837
H. BP
2.201
1.727
1.221
2.37
1.631
1.837
1.422
1.558
1.501
1.325
H. ACTIV
10.836
9.209
7.817
10.667
7.338
9.481
8.127
6.923
7.901
6.972
84.997 Hz
99.894 Hz
120.334 Hz
75 Hz
110.03 Hz
75.025 Hz
85.024 Hz
99.91 Hz
75 Hz
85 Hz
lines
lines
lines
lines
lines
lines
lines
lines
lines
lines
V. TOTAL
808
809
810
900
910
1066
1072
1071
1250
1250
V. BLK
40
41
42
36
46
42
48
47
50
50
V. FP
1
2
2
1
2
1
1
2
1
1
V. SYNC
3
3
3
3
3
3
3
3
3
3
V. BP
36
36
37
32
41
38
44
42
46
46
V. ACTIV
768
768
768
864
864
1024
1024
1024
1200
1200
— VERTICAL —
V. FREQ(HZ)
— SYNC —
INT(G)
EXT(H/V)/POLARITY
EXT(CS) /POLARITY
INT/NON INT
SIZE(21")
NO
NO
NO
NO
NO
NO
NO
NO
NO
NO
YES P/P
YES N/N
YES N/N
YES P/P
YES N/N
YES P/P
YES P/P
YES P/P
YES P/P
YES P/P
NO
NO
NO
NO
NO
NO
NO
NO
NO
NO
NON INT
NON INT
NON INT
NON INT
NON INT
NON INT
NON INT
NON INT
NON INT
NON INT
388X291 mm 388X291 mm 388X291 mm 388X291 mm 388X291 mm 364X291 mm 364X291 mm 364X291 mm 388X291 mm 388X291 mm
’98.06.05 Ver.
–4–
MCM 21T1
TABLE OF CONTENTS
Section
Title
Page
1. GENERAL ................................................................. 1-1
2. DISASSEMBLY
2-1.
2-2.
2-3.
2-4.
2-5.
2-6.
2-7.
2-8.
2-9.
Cabinet Removal ...............................................
D Board Removal ..............................................
G Board Removal ..............................................
A Board Removal ..............................................
L Board Removal ..............................................
I/O TERMINAL Board Assy Removal .............
Service Position ..................................................
H and J Boards Removal ...................................
Picture Tube Removal .......................................
2-1
2-1
2-2
2-2
2-3
2-3
2-4
2-4
2-5
3. SAFETY RELATED ADJUSTMENT ............. 3-1
4. ADJUSTMENTS ..................................................... 4-1
5. DIAGRAMS
5-1.
5-2.
5-3.
5-4.
(1)
(2)
(3)
5-5.
Block Diagrams ..................................................
Frame Shcematic Diagram .................................
Circuit Boards Location .....................................
Schematic Diagrams and Printed Wiring
Boards .................................................................
Schematic Diagram of D Board ........................
Schematic Diagrams of G, GA, H, J and
L Boards ............................................................
Schematic Diagram of A Board ........................
Semiconductors .................................................
5-1
5-7
5-9
5-9
5-13
5-17
5-24
5-29
6. EXPLODED VIEWS
6-1.
6-2.
6-3.
Chassis ............................................................... 6-1
Picture Tube ...................................................... 6-2
Packing Materials ............................................... 6-3
7. ELECTRICAL PARTS LIST ............................ 7-1
Note: Hand degauss must be used on stand-by or power-off condition.
This model has an automatic earth magnetism correction function by using an earth
magnetism sensor and a LCC coil. When using a hand degauss while monitor (LCC
coil) is being operated, it sometimes gets magnetized, and the system may not work
properly as a result.
–5–
The operating instructions mentioned here are partial abstracts
from the Operating Instruction Manual. The page numbers of
the Operating Instruction Manual remain as in the manual.
SECTION 1
GENERAL
1-1
1-2
1-3
1-4
1-5
1-6
1-7
1-8
1-9
1-10
1-11
MCM 21T1
SECTION 2
DISASSEMBLY
2-1. CABINET REMOVAL
3
5
6
1
Four screws
(+ BVTT 4 x 8)
Four screws
(+ BVTP 4 x 16)
Screw cover
Two claws
Top cover
2
4
7
8
Screw cover
Cabinet
Four screws
(+ BVTT 4 x 8)
Video shield
2-2. D BOARD REMOVAL
4
Screw
(+ P 3.5 x 20)
5
Two screws
(+ BVTP 3 x 10)
1
6
D board
Screw
(+ BVTT 4 x 8)
2
Two screws
(+ BVTT 4 x 8)
B
Three hooks
3
2-1
A
Open the D block in the direction
of the arrow A . and remove of
the arrow B .
MCM 21T1
2-3. G BOARD REMOVAL
4
1
Two screws
(+BVTP 3 x 10)
Screw
(+ BVTT 4 x 8)
5
G shield
7
G board
Two screws
(+ BVTT 4 x 8)
2
B
A
Three hooks
3
Open the G block in the direction
of the arrow A . and remove of
the arrow B .
6
Two printed circuit board holders
2-4. A BOARD REMOVAL
3
2
A board (2/2)
A board (1/2)
2-2
1
Three screws
(+BVTT 4 x 8)
MCM 21T1
2-5. L BOARD REMOVAL
CN5001
CN5004
CN5002
CN5003
2
1
Four printed circuit board holders
2-6. I/O TERMINAL BOARD ASSY REMOVAL
CN511
1
CN401
CN402
Three screws
(+ BVTT 3 x 8)
2
I/O terminal board assy
2-3
L board
MCM 21T1
2-7. SERVICE POSITION
CAUTION : SHORT
D,G boards
Rear shield
If the claw is hooked,
* opening
and closing
the board is impossible.
Do not try to do it by force.
D board (Refer to 2-2.)
A board (Refer to 2-4.)
If the claw is hooked,
* opening
and closing
G board
(Refer to 2-3.)
the board is impossible.
Do not try to do it by force.
2-8. H AND J BOARDS REMOVAL
1
Four screws
(Tapping screw 5)
CN891
5
Shaft
CN801
Claw
6
J board
Two screws
(+ BVWHTP 3 x 12)
7
3
4
H board
Claw
2
Bezel
2-4
Claw
MCM 21T1
2-9. PICTURE TUBE REMOVAL
1
4
Open the D block
(Refer to 2-2.)
6
Four screws
(+ BVTT 4 x 8)
Two connectors
6P (DY)
3
A board
10P (DY)
5
Anode cap
2
8
9
7
Neck assy
Open the G block
(Refer to 2-3.)
Deflection yoke
Picture tube
• REMOVAL OF ANODE-CAP
NOTE: Short circuit the anode of the picture tube and the anode cap to the metal chassis, CRT shield or carbon painted on the CRT, after
removing the anode.
• REMOVING PROCEDURES
c
b
a
Anode Button
1 Turn up one side of the rubber cap in
the direction indicated by the arrow a.
2 Using a thumb pull up the rubber cap
firmly in the direction indicated by the
arrow b.
• HOW TO HANDLE AN ANODE-CAP
1 Don’t hurt the surface of anode-caps with shartp shaped
material!
2 Don’t press the rubber hardly not to hurt inside of anode-caps!
A material fitting called as shatter-hook terminal is built in the
rubber.
3 Don’t turn the foot of rubber over hardly!
The shatter-hook terminal will stick out or hurt the rubber.
2-5
3 When one side of the rubber cap is
separated from the anode button, the
anode-cap can be removed by turning
up the rubber cap and pulling up it in the
direction of the arrow c.
MCM 21T1
SECTION 3
SAFETY RELATED ADJUSTMENT
When replacing or repairing the shown below table, the
following operational checks must be performed as a
safety precaution against X-rays emissions from the unit.
a) HV Regulator Circuit Check
1) Confirm that the voltage of the pin 2 of CN901 on
D board is within the voltage range shown below.
Standard: 9.00 ± 0.065 VDC
Part Replaced (])
HV Regulator
Circuit Check
D Board IC901, T902
• Mounted D board
HV Protector
Circuit Check
D Board Q660, Q661, D916,
D935, C924, R665,
R667, R940, R980,
T902
• Mounted D board
G Board PH680, Q680, Q683,
D680, R680, R685,
R686, R687, R688,
R689
• Mounted G board
Beam Current
Protector Circuit
Check
b) HV Protector Circuit Check
1) Confirm that the HV protector circuit works and TV
Raster disappears when apply the voltage as shown
below between pin 3 of CN901 on D board and
GND using an external DC power supply.
Check Condition: Less than 34.10 VDC
c) Beam Current Protector Circuit Check-1
1) Measure HV voltage and record that value.
2) Shorted between pin 1 and pin 4 of CN901 on D
board.
3) Connect to the Constant Current Jig (A) between pin
1 of CN901 on D board and GND, confirm that the
Beam Current Protector Circuit works and HV go
down more than 1.25 kV from the value of (1).
Check Condition: 1.50 mA
D Board IC901, D904, D907,
D908, R011, R908,
R909, R921, R925,
R926, R929, R930,
T902
• Mounted D board
Check Condition
d) Beam Current Protector Circuit Check-2
Input voltage : 100 ~ 240 VAC
Input signal : White Cross Hatch at 107 kHz
Beam control : BRT and CONT → Minimum
B+ voltage : 195 ~ 205 VDC
1) Connect to the Constant Current Jig (B) between pin
1 of CN901 on D board and GND, confirm that the
Beam Current Protector Circuit works and TV Raster disappears.
Check Condition: 1.59 mA
e) Voltage of 3rd winding of FBT
1) Confirm that the voltage of pin 3 of CN901 on D
board is within the voltage range shown below.
Standard: more than 28.0 VDC
3-1
MCM 21T1
SECTION 4
ADJUSTMENTS
Note: Hand degauss must be used on stand-by or power-off condition.
This model has an automatic earth magnetism correction function by using an earth magnetism sensor
and a LCC coil. When using a hand degauss while monitor (LCC coil) is being operated, it sometimes
gets magnetized, and the system may not work properly as a result.
• Landing Rough Adjustment
1. Enter the full white signal. (or the full black dots signal).
2. Adjust the contrast to the maximum.
3. Make the screen monogreen.
Note: Off the outputs from R ch and B ch of SG.
4. Reverse the DY, and adjust coarsely the purity magnet so
that a green raster positions in the center of screen.
5. Adjust the tilt of DY, and fix lightly with a clamp.
Note: “TILT” shall be set at 0.
6. Adjust the DY position and purity, and the DY tilt, and landing of the center and 4 corners with the landing checker.
After adjustment, set “LCC SW” to “13”.
• Write terrestrial magnetism sensor reading VX and VY to
“LCC VX” and LCC VY” respectively. Adjust the landing by moving “LCC NS”, “LCC LT”, “LCC LB”, “LCC
RT” and “LCC RB”. However, the register adjustment
must be limited within the following range.
“LCC NS”
128 ± 15
“LCC LT”, “LCC LB”, “LCC RT”, “LCC RB”
128 ± 40
Save the service data.
• Landing Fine Adjustment
1. Put the set inside the Helmholtz coil. (“LCC SW” = “12”)
2. Input the single green signal and set the CONT control to
MAX.
Note: After the W/B adjustment with 9300K, measure an average of ΣIk when a full white signal is entered in the CONT
MAX/BRT CENT status. Then make adjustment so that
the specified screen can be attained after aging for 2 hours
with Ik equivalent to 30% of the average value.
3. Demagnetize the metal part of the chassis with the hand degausser and coil degausser, and the CRT surface with the
hand degausser.
Input AC 230V to AC IN, turn on and off the power to perform auto degaussing. (Perform auto degaussing by setting
“MON CON REG2”=152. Return to the original value after
use.)
Demagnetize the CRT surface with the hand degausser
again.
Note:
(1) Hand degauss must be used on stand-by or power-off condition.
This model has an automatic earth magnetism correction
function by using an earth magnetism sensor and a LCC coil.
When using a hand degauss while monitor (LCC coil) is being operated, it sometimes gets magnetized, and the system
may not work properly as a result.
(2) Adjust in a non-magnetic field. BV=45uT.
(3) If adjusting in a magnetic fields, add the shift from the nonmagnetic field in your estimation.
4. Attach the wobbling coil to the designated part of the CRT
neck.
5. Attach the sensor of the landing adjustment unit on the CRT
surface.
<Specifications>
Adjust so that the green is within
the specification given right.
4 corner adjust target : within ± 1
The red and blue must be within
the specification given right with
respect to the green.
A difference between red and blue
must be within the specification
given right.
(µm)
0 ± 3 0 ± 7.5 0 ± 3
0±5 0±5
0±5
0 ± 3 0 ± 7.5 0 ± 3
±6
±6
(µm)
±6
±6
±4
±6
±6
±6
±6
(µm)
10
10
10
10
7
10
10
10
10
* Adjustment and measurement should be made at the points
one inch inside the fluorescent screen.
7. For the up/down swing, swing the DY and insert a wedge so
that the up and down pins are equal at the top and bottom.
Adjust the DY TLV VR so that the horizontal trapezoid is
equal at the left and right. Insert the wedge firmly so that the
DY does not shake.
8. Check the landing of each corner, and if it does not satisfy
the specification, adjust the landing of four corners using
“LCC LT“, “LCC LB”, “LCC RT” and “LCC RB”.
However, the register adjustment must be limited within the
following range.
“LCC NS”
128 ± 15
“LCC LT”, “LCC LB”, “LCC RT”, “LCC RB”
128 ± 40
After adjustment, save the service data.
9. Remove the sensor and wobbling coil.
10. Switch the signal to R.G.B., and check that each color is
pure.
11. Check that the DY is not tilting.
4-1
MCM 21T1
Connect the communication cable of the computer to the connector located on the D board on the monitor. Run the service software
and then follow the instruction.
1 1-690-391-21
2 A-1500-819-A
Interface Unit
3 3-702-691-01
Connector Attachment
IBM AT Computer
as a Jig
To BUS CONNECTOR
D-sub
(9 Pin [female])
mini Din
(8Pin)
*The parts above ( 1
4 Pin
• Convergence Specification
Phospher edge
C
A
60 kHz
V
fH<
60 kHz
H
Zone
N. Hemisphere S. Hemisphere
A Zone
0.24 mm
0.24 mm
B Zone
0.24 mm
0.28 mm
C Zone
0.32 mm
0.32 mm
A Zone
0.24 mm
0.28 mm
B Zone
0.32 mm
0.36 mm
C Zone
0.36 mm
0.40 mm
• White Balance Adjustment Specification
(1) 9300K
x = 0.281 ± 0.005
y = 0.311 ± 0.005
(All White)
(2) 6500K
x = 0.313 ± 0.005
y = 0.329 ± 0.005
(All White)
XBV
XCV
APH
• Vertical and Horizontal Position and Size
Specification
60°
*
MODE
fH>
B
TLV
YCH
YBH
Fig. 1
4 Pin
3 ) are necessary for DAS adjustment.
• Convergence Rough Adjustment
(1) Receive an image of the white crosshatch signals (white
lines on black).
(2) Place the protrusions of the 6-fold poles magnet attached to
the CRT neck upon each other. (Fig. 1)
(3) Make rough adjustment of the H and V direction convergence by using 4-fold poles magnet.
(4) Make a rough adjustment of the V direction convergence by
using “V. STAT”.
Protrusions
4 Pin
Fig. 2
Fig. 3
A
* Set so that the protruding parts of
the 2 magnet rings agree with
each other.
b
b
H. AMP
R
B
XBV
R
XCV
a
a
B
B
R
B
YCH
B
H. TILT (TLH)
R
B
a
b
R
1-5,9
6-8
A
388 mm
364 mm
B
291 mm
291 mm
3.2 mm
3.2 mm
• Focus adjustment
Adjust the focus volume 1 and 2 (HDK 1 and 2) for the optimum focus.
YBH
B
MODE
R
FBT
R
B
R
B
HDK1 (V)
HDK2 (H)
4-2
SECTION 5
DIAGRAMS
5-1. BLOCK DIAGRAMS
TO FBT
FV1 FV2 HV
IC402
RGB PRE-AMP
IC401
RGB SWITCH
CN402
R IN 2 1
G IN 2 3
B IN 2 6
7
5
2
17
27
R_IN2
G_IN2
B_IN2
R_OUT
R_IN
G_OUT
16
13
11
R_IN1
G_IN1
B_IN1
HFBP
OSD_SEL
MOSI
CLK
VRET
19
SW
VD
HD
B
G
R
5BNC
I
CN403
INPUT SW
GREEN
CLP
C.BLK
VIDEO
LOWB DET
G.SYNC
Q401-Q403
6
4
1
3
8
2
Q101
42
Q201
G_OUT
B_IN
B_OUT
51
Q301
25
G.SYNC
5
6
7
8
22
27
HFLB
SS
MOSI
CLK
VFLB
R
26
G
25
B
24
FBKG
23
14
9
1
26
28
R_OSD
G_OSD
B_OSD
OSD_BLK
H
CN407
ASC_SW
OSD_SEL
MOSI
CLK
DAC_SEL
HFBP
VRET
CN2
KR
KG
KB
HEATER(+)
KR
KG
KB
HEATER(+)
13
R_IN
G_IN
B_IN
R_OUT
5
G_OUT
3
B_OUT
5
3
1
7
5
3
1
7
CLP
BLK
IC410
D/A CONVERTER
R_DRV
G_DRV
B_DRV
BRT
MAIN CONT
OSD CONT
18
13
4
27
25
52
DAC_SEL
CLK
MOSI
VIDEO OUT
Q405
G
11
7
1
V901
PICTURE TUBE
CN1
IC404
OSD
HD15
5
4
3
2
1
10 9
8
7
6
15 14 13 12 11
G_IN
3
35
37
R_OUT
12
BUFFER
Q202
30
B_OUT
CN401
R IN 1 1
G IN 1 3
B IN 1 5
IC403
RGB OUT
6
7
8
9
12
13
15
16
17
3
R_DRV
G_DRV
B_DRV
BRT
CONT
OSDCONT
LD
CLK
MOSI
R_CUTOFF
4
G_CUTOFF
5
B_CUTOFF
IC409(1/4) R_CUTOFF
Q105,106
IC409(2/4)
G2
G_CUTOFF
Q205,Q206
B_CUTOFF
Q305,Q306
IC409(3/4)
IC406
12V REG
+12V
I
9
1
3
5
6
CN405
HEATER(+)
+200V
+80V
+15V
STBY 8V
1
CN406
1KV
IC408
5V REG
G2 CONTROL
Q406,Q410
+5V
O
I
SW
Q408,409
A(VIDEO AMP,RGB OUT)
B-SS9030<NH.>-B/D-P1
J
K
CN5002
H CONV
V CONV
VX
VY
6
7
IC5401(1/2)
2
3
4
5
4
3
3
4
1
2
CN5004
H STAT(+)
H STAT(-)
V STAT(+)
V STAT(-)
1
2
3
4
5
6
7
8
9
10
CN5003
LCC-LT(+)
LCC-LT(-)
LCC-LB(+)
LCC-LB(-)
LCC-RT(+)
LCC-RT(-)
LCC-RB(+)
LCC-RB(-)
LCC-NS(+)
LCC-NS(-)
9
1
IC5401(2/2)
GS5001
GEOMAGNETIC
SENSOR
6
7
L
1
6
7
9
4
3
1
IC5101(2/2)
1
2
L
V.STAT,H,STAT,LCC
GEO MAGNETIC SENSOR
5-1
ROTATION
H STAT
V STAT
IC5301(1/2)
4
3
IC5101(1/2)
5
6
7
8
9
ROTATION(+)
ROTATION(-)
H STAT(+)
H STAT(-)
V STAT(+)
V STAT(-)
9
IC5301(2/2)
CN5001
LCC-RB
LCC-RT
LCC-LB
LCC-LT
LCC-NS
5
6
3
4
1
2
4
IC5201
LCC-LT
LCC-LB
LCC-RT
LCC-RB
LCC-NS
5-2
B
IC409(4/4)
19
G2
Q404
1
2
3
4
5
6
7
O
+200V
+80V
5-3
M
D(U-COM,DEFLECTION)
4
5
2
3
IC012
ROM
G
CN520
VX
VY
H CONV
V CONV
1
2
3
4
K
CN504
DGC
POWER
HTR_SW
STBY 8V
5
6
7
8
9
D
CN512
LLC_RB
LLC_RT
LLC_LB
LLC_LT
LLC_LB
J(POWER
SW)
CN891
L
AC L IN
AC L OUT
S891
POWER
3
1
5
SDA
7
CS1
VS1
CS2
VS2
6
AC L IN
AC L OUT
1
2
3
4
6
8
9
11
7
10
V CLK
SCL
PS504
IC002
ROM
IC001
CPU
IC006
5V REG
I
O
STBY5V
40
7
V CLK
VX
46
VY
74
H CONV
6
SCL
47
P70/IRQ0
30
DDC_SDA_1
31
4
V CONV
5
32
DDC_SDA_2
33
Q660
DDC_SCL_2
HV_PROT
96
LLC_LT
LLC_RT
LLC_LB
LLC_RB
LLC_NS
5V REG
Q006
F
EEP SDA
EEP SCL
9V-2
25
EEP_SDA
26
EEP_SCL
D035
12
13
14
15
39
44
1
2
3
4
5
8
LED0
LED1
LED2
LED3
KEY_DET
P65/AN5
5
4
1
S CAP
CHANGE
Q522-Q525
Q527,Q528
1
3
4
D611
L610
1
8
12
9
1
T503
HST
RY501
+200V
+80V
-15V
+15V
IC502
H CENT OUT
2
RELAY
DRIVE
Q509
IC005
WDT
5
Q510
VCC
H CENT
CONTROL
Q511
PIN AMP
Q517
T504
HCC
2
-VIN
IC008
9V REG
2
4
5
7
PS503
11
PS502
9
1
2
3
CN502
+200V
+200V
+80V
-15V
+15V
HCENT H
HCENT N
HCENT L
1
IC630
+200V SHUNT REG
T640
PIT
D610
4
5
H.DY
R674
D670
C611
6
7
8
CN603
DGC 4
DGC 1
DGC
PS670
D672
4
5
7
9
11
1
3
2
CN671
+200V
+200V
+80V
+15V
-15V
H CENT H
H CENT L
H CENT N
1
3
5
6
9
CN672
+200V
+80V
+15V
STBY 8V
HEATER(+)
1
2
CN690
USB 6.5V
USB 6.5V
4
2
3
1
CN673
STBY 8V
POWER SW
HEATER SW
DGC SW
9
PS671
THP601
3
10
11
2
A
R675
BOOST
CONV OUT
Q610
RY601
3
S5
8
3
TH601
T601
2
3
5
77
AC INLET
F601
6.3A
2
5
RESET
78
WDT
CN604
AC L 1
AC N 3
L503
HLC
S0
S1
S2
S3
S4
69
70
71
72
73
V.DY
CN508
V.DY C
V.DY H
H.DY C
H.DY C
H.DY H
H.DY H
RY602
VRET
PROT DET
5
6
2
Q661
D034
7
IC702
V OUT
VDC
IC004
EEP ROM
2
3
5
6
9
10
IC703
V SHAPE
100
DGC
99
HTR SW
98
POWER SW
DDC_SCL_1
CN501
LED0
LED1
CONT VR
BRT VR
KEY DET
ANV_DRV
G(POWER SUPPLY)
5
SDA
CN605
3
1
CN511
C.SYNC_1
V.SYNC_1
C.SYNC_2
V.SYNC_2
DDC_SDA_1
DDC_SCL_1
DDC_SDA_2
DDC_SCL_2
HOST+5V_1
HOST+5V_2
RELAY
DRIVE
Q690
RELAY
DRIVE
Q660
D663
D677
D673
PS674
D674
1
12
A
D682
PS673
4
OUT
RESET
CK
9V-1
O
I
1
ABL_DET
HV_DET
38
ABL DET
93
HV DET
+VIN
H CENT
H SHAPBAL
CN503
ASC_SW
OSD_SEL
MOSI
CLK
DAC_SEL
HFLB
VRET
H
9V-2
S0
S1
S2
S3
S4
S5
XTALO
20
RXD
19
TXD
85
86
87
88
89
90
82
+200V
PS501
+200V
83
1
DMP
DMP
DMP
DMP
6
3
IC009
5
CLK
DO
DI
ID
10
60
65
21
22
24
17
53
79
DAC SEL
HFBP
VRET
DMP_CLK
DMP_DO
DMP_DI
DMP_ID
LOWB_DET
INPUT SEL
PIN OUT
Q507
1
5
CN507
1KV
2
AC SENCE
L SENCE
DRIVE
I SENCE
V SENCE
M
PIN DRIVE
Q501-Q503
17
2
T502
HOC
HPLL
IIC SDA
IIC SCL
HS
VS
ASC
4
9
10
7
28
14
AFC1
SDA
SCL
HSYNC
H PHASE
PWM RFE
H DRIVE
Q504-Q506
24
HD OUT
25
FBP
PROTECTOR
Q7501-Q7504
CN7501
(B TO B)
LPV
AC SENCE
L SENCE
DRIVE
I SENCE
V SENCE
OPV
VCC
GND
GND
10
8
7
3
4
6
9
5
1
2
10
8
7
3
4
6
9
5
1
2
CN610
(B TO B)
LPV
AC SENCE
L SENCE
DRIVE
I SENCE
V SENCE
OPV
VCC
GND
GND
VCC SW
Q615
IC660
REG SW
11
T701
DFT
5
7
G
8
2
6
5
V DF OUT
Q707,Q708
4
2
4
5
I
PH660
Q005
DMP
DMP
DMP
DMP
CS1
VS1
CS2
VS2
9
8
13
12
11
CLK
DO
DI
ID
10
1
2
CLP OUT
CBLK OUT
SONG
VIDEO
INPUT_SEL
CLK
DO
DI
ID
FBPIN
HS/CS1
VS1
HS/CS2
VS2
HTIM
VIDEO OUT
VS OUT
HS OUT
VDF
HCENT
H SHAPE BAL
V SHAPE
VDC
V CONV
MOIRE
2
8
48
47
28
32
29
19
26
27
34
T902
FBT
1
HV DRIVE
Q901,Q904,Q905
7
ERR IN
HD IN
HV OUT
Q909
1
HV REG SW
Q908
2
5
6
5
15
7
2
3
19
1
IC505
BTC IN
8
ERR REF VREG9
6
HV_DET
TO PICTURE TUBE
FV1
16
FV1
5
FV2
HV_PROT
7
-
CN901
1ST IK PROT
HV ADJ
X RAY DET
IK DET
+15V
6
OUT2
+
D820
POWER
G
R
LED DRIVE
Q801,802
1
2
5
8
11
CN801
LED 0
LED 1
KEY_DET
TEMP_DRI
F
ABL_DET
4
2
3
1
B-SS9057<AEP>-B/D-P2
S802-S806,
S818,S820
STBY+5V
TH801
H(USER CONTROL)
5-4
POWER SW
Q680-Q682
HEATER
SW
Q691
B-SS9057<AEP>-B/D-P3
18
17
PS901
FV2
IC701
CURRENT AMP
2
IC691
Q902
30
1
3
14
15
12
J
V.S2
2
HV
TILT
8
3
HV
T901
HRC
+200V
33
9
1
PWM OUT
H SHAPE
31
H SIZE
IC013
CN509
ROTATION(-) 2
ROTATION(+) 1
4
4
2
IC901
HV CONTROL
5-5
B
3
IC690
HEATER
REG
IC007
DPU
39
38
46
7
45
9
11
10
12
6
41
43
42
44
SOFT START
Q683
O
3
2
6
1
3
4
8
D678
D691
1
ABL_DET
CN506
LOWB_DET
INPUT_SW
CLP
C.BLK
GREEN
VIDEO
6
PH680
I
VRET
2
5
T660
2
7
3
4
REG SW
Q641,Q642
H OUT
Q508
H DF OUT
Q701,Q703-Q706
1
CONV OUT
Q640
Q003
19
DF OUT
23
HVD OUT
T641
PRT
C647
GA(POWER SENSOR)
T501
HDT
41
28
29
59
63,64
66
3
5
7
4
1
8
VCC
PMW OUT
7
I
IC010
SYNC PROCESS
XTALI
43
+B DET
OSD_SEL
O
H SIZEEFB
X001
4MHz
9
ASC SW
16
1
2
3
4
5
6
7
IC7501
SENSOR
3
P66/AN6
CN505
RXD 3
TXD 4
IC003
9V REG
VEE
45
5-6
C
D
5-3. CIRCUIT BOARDS LOCATION
L
D
Note: The components identified by shading and mark
! are critical for safety. Replace only with part
number specified.
A
5-2. FRAME SCHEMATIC DIAGRAM
•
•
•
•
CONNECTOR PANEL
1
2
3
4
5
6
5
15
2
3
4
9
10
8
14
7
13
R IN 1
R GND 1
G IN 1
G GND 1
B IN 1
B GND 1
1
2
3
4
5
6
7
R IN 2
R GND 2
G IN 2
G GND 2
NC
B IN 2
B GND 2
1
2
3
4
5
6
7
8
CLP
BKGP
C.BLK
GREEN
GND
INPUT SW
GND
VIDEO
1
2
3
4
5
6
7
ASC_SW
OSD_SEL
MOSI
CLK
DAC_SEL
HFBP
VRET
G
CN401
6P
WHT-L
:S-MICRO
CN1
14P
KB
KB
GND
GND
KG
KG
GND
GND
KR
KR
GND
G1
GND
HEATER +
CN402
7P
WHT-L
:S-MICRO
1
6
12
11
A
CN403
8P
WHT-L
:S-MICRO
VIDEO AMP,
RGB OUT
1
2
3
4
5
6
7
8
9
10
11
12
13
14
GND
G2
GND
•
•
•
•
C BLOCK
CN2
14P
1
2
3
4
5
6
7
8
9
10
11
12
13
14
G2
KB
KB
GND
GND
KG
KG
GND
GND
KR
KR
GND
G1
GND
HEATER +
Terminal name of semiconductors in silk screen
printed circuit ( )
GA
RCV
All voltages are in V.
Readings are taken with a 10 M digital multimeter.
Readings are taken with a color-bar signal input.
Voltage variations may be noted due to normal production
tolerances.
* : Can not be measured.
Circled numbers are waveform references.
s : B + bus.
S : B – bus.
H
Device
H
KB KR G2 G4
KG G1 GM
1
*
Printed symbol
Base
HV
J
2
Circuit
Terminal name
Collector
Transistor
Transistor
Emitter
Collector
Base
Emitter
FV1
CN405
9P
WHT-L
:S-MICRO
CN406
2P
WHT
:VH
1
2
3
4
5
6
7
8
9
AC L OUT
NC
AC L IN
1
2
3
AC L OUT
NC
AC L IN
J
G
CN610
10P
B-TO-B
(POWER SUPPLY)
CN603
4P
WHT
:VH
AC L
NC
AC N
DGUS SW
POWER SW
HEATER SW
STBY+8V
GND
CN604
3P
WHT
:VH
GND
GND
DRIVE
I SENCE
VCC
V SENCE
L SENCE
AC SENCE
OVP
LVP
1
2
3
4
5
6
7
8
9
10
1
2
3
1
2
3
4
5
1
2
3
POWER SW
(POWER SW)
CN673
5P
WHT
:S-MICRO
1
2
3
4
5
CN891
3P
WHT
:VH
CN605
3P
DGC
NC
NC
DGC
DGC
POWER
HTR_SW
STBY 8V
GND
H CENT H
H CENT N
H CENT L
+200V
+200V
NC
+80V
GND
+15V
GND
-15V
+200V
NC
+80V
GND
+15V
STBY+8V
GND
NC
HEATER+
1
2
3
4
5
6
7
8
9
10
11
1
2
3
4
USB_TX
USB_RX
GND
1
2
3
CN510
3P
WHT
:S-MICRO
1
2
3
CN514
3P
WHT
:S-MICRO
LUMI
STBY+5
GND
CN501
9P
YEL
:S-MICRO
LED0
LED1
CONT VR
BRT VR
KEY_DET
D GND
STBY+5V
ANV_DRI
D GND
CN901
5P
WHT
:S-MICRO
FV2
HV
FV1
1
2
3
4
5
6
7
ASC_SW
OSD_SEL
MOSI
CLK
DAC_SEL
HFLB
VRET
1
2
1
2
3
4
5
6
7
8
CLP
BKGP
C.BLK
GREEN
GND
INPUT_SW
GND
VIDEO
1KV
NC
1
2
3
4
CN512
9P
WHT
:S-MICRO
1
2
3
4
5
6
7
8
9
10
11
CN504
5P
WHT
:S-MICRO
1
2
3
4
5
6
7
8
9
CN509
2P
WHT
:S-MICRO
FBT
CN507
2P
WHT
:VH
HCENT H
HCENT N
HCENT L
+200V
+200V
NC
+80V
GND
+15V
GND
-15V
CN672
9P
WHT
:S-MICRO
1
2
3
4
5
6
7
8
9
10
GND
GND
DRIVE
I SENCE
VCC
V SENCE
L SENCE
AC SENCE
OVP
LVP
CN7501
10P
B-TO-B
GA
(POWER SENSOR)
LCC-NS
1
LED0
2
LED1
3
LED2
4
LED3
KEY_DET 5
6
D GND
STBY+5V 7
TEMP_DRI 8
9
GND
10
GND
11
GND
1
2
3
4
5
6
7
8
9
STAT+
STATSTAT+
STAT-
LCC-RB
LCC-LB(+)
CN5003
LCC-LB(-)
10P
WHT
LCC-RT(+) :S-MICRO
LCC-RT(-)
LCC-RB(+)
LCC-RB(-)
LCC-NS(+)
LCC-NS(-)
V
V
H
H
LCC-RT
1
2
3
4
5
6
7
8
9
10
DGC
AC INLET
CN5001
9P
WHT
:S-MICRO
L
5-7
6
V.STAT,H.STAT,
LCC,GEO,
MAGNETIC SENSOR
7
8
9
0
!¡
HV Regulator
Circuit Check
D Board
HV Protector
Circuit Check
D Board
H
G Board
(USER CONTROL)
CN5004
4P
WHT
:VH
Beam Current
Protector Circuit
Check
5-8
D Board
Diode
(NC)
Anode
(NC)
Diode
Anode
Diode
Cathode
Common
Anode
Cathode
Common
Diode
Anode
Anode
Common
Diode
Anode
Anode
Common
Diode
Cathode
Cathode
Common
Diode
!™
Diode
!£
Transistor
(FET)
Cathode
Anode
Anode
Cathode
Drain
Cathode
Cathode
Anode
Anode
Source
Gate
D
Source
Gate
!¢
Transistor
(FET)
!∞
Transistor
(FET)
Source
Drain
Gate
Transistor
Emitter
Collector
Base
!§
–
IC901, T902
• Mounted D board
Q660, Q661, D916,
C924, R665, R667,
R980, T902
• Mounted D board
PH680, Q680, Q683,
R680, R685, R686,
R688, R689
• Mounted G board
Anode
D
G
Part replaced ( ] )
1
2
3
4
LCC-LB
+15V
GND
-15V
GND
LCC-RB
LCC-RT
LCC-LB
LCC-LT
LCC-NS
1
2
3
4
5
6
GND
H CONV
V CONV
VX
VY
GND
LCC-LT
CN5002
6P
LCC-LT(+)
WHT
LCC-LT(-) :S-MICRO
CN801
11P
WHT
:S-MICRO L
Diode
Common
B-SS3414<U/C>-KESSENZU
(CRT SHIELD)
Anode
Cathode
5
• All resistors are in ohms.
• f : nonflammable resistor.
• Ï : fusible resistor.
¢ : internal component.
•
• p : panel designation, and adjustment for repair.
• All variable and adjustable resistors have characteristic curve B,
unless otherwise noted.
e : earth-ground.
•
•
E : earth-chassis.
• The components identified by [ in this basic schematic diagram
have been carefully factory-selected for each set in order to
satisfy regulations regarding X-ray radiation.
Should replacement be required, replace only with the value
originally used.
• When replacing components identified by ] , make the
necessary adjustments indicated. (See page 3-1)
• When replacing the part in below table, be sure to perform the
related adjustment.
FASTEN
Cathode
Cathode
• All capacitors are in µF unless otherwise noted. (pF: µµF)
Capacitors without voltage indication are all 50 V.
• Indication of resistance, which does not have one for rating
electrical power, is as follows.
TO ECS
ROTATION+
ROTATION-
CN508
9P
WHT
:VH
CN520
6P
WHT
:S-MICRO
1
2
3
4
5
6
V.STA
2
1
CN503
7P
WHT
:S-MICRO
D
1
IK DET
2
HV ADJ
3 X RAY DET
4 1ST IK PROT
5
GND
H.STA
6
5
4
3
2
1
CN506
8P
WHT
:S-MICRO
µ-COM,
DEFLECTION
+15V
GND
-15V
GND
LCC_RB
LCC_RT
LCC_LB
LCC_LT
LCC_NS
ROTATION
ROTATION+
ROTATIONH STAT+
H STATV STATV STAT+
GND
V.DY C
V.DY H
NC
H.DY C
H.DY C
NC
NC
H.DY H
H.DY H
CN505
4P
WHT
1
2
3
4
5
6
7
8
9
V.DY
FASTEN
D GND
STBY+5V
RXD
TXD
C.SYNC_1 1
V.SYNC_1 2
C.SYNC_2 3
V.SYNC_2 4
5
GND
DDC_SDA_1 6
HOST+5V_1 7
DDC_SCL_1 8
DDC_SDA_2 9
HOST+5V_2 10
DDC_SCL_2 11
V.DY
1
2
3
4
5
6
7
8
9
10
GND
H CONV
V CONV
VX
VY
GND
H.DY
CN511
11P
WHT
:S-MICRO
CN671
11P
WHT
:S-MICRO
Diode
Note:
Pitch: 5 mm
Rating electrical power 1/4 W (CHIP : 1/10 W)
CN502
11P
WHT
:S-MICRO
3
4
HSTAT
+200V
NC
+80V
GND
+15V
STBY+8V
GND
NC
HEATER+
1KV
NC
FV2
CN407
7P
WHT-L
:S-MICRO
1
2
3
4
5
6
7
8
9
1
2
5-4. SCHEMATIC DIAGRAMS AND PRINTED
WIRING BOARDS
HSTAT
Drain
D680,
R687,
IC901, D904, D907, D908,
R011, R908, R909, R921,
R925, R926, R929, R930,
T902
• Mounted D board
5-9
S
S
D
D
G
G
S
S
Discrete semiconductot
(Chip semiconductors that are not actually used are included.)
D935,
R940,
G
Ver.1.5
— D BOARD (Conductor Side) —
1
2
3
D
4
µ-COM,
DEFLECTION
— D BOARD (Component Side) —
1
2
3
• D BOARD SEMICONDUCTOR LOCATION
IC
Component
( Conductor
Side ) ( Side )
IC001
IC002
IC003
IC004
IC005
IC006
IC007
IC008
IC009
IC010
IC011
IC013
IC502
IC505
IC701
IC702
IC703
IC901
A
B
D–2
E–2
D–3
E–1
D–1
E–1
A–4
D–1
E–4
E–3
A–2
E–2
E–3
D–3
E–4
D–3
D–3
D–2
E–4
E–4
E–3
A–1
D–3
D–4
E–1
Component
( Conductor
Side ) ( Side )
C
D
D–4
D–4
E–1
D–3
D–4
A–3
B–3
A–3
D–4
D–4
D–4
A–4
C–4
D–3
C–3
A–3
D–4
D–2
D–2
D–3
D–3
D–3
C–3
C–3
D–1
C–1
C–1
C–1
D–1
C–1
C–2
A–3
C–2
D–1
A–1
C–1
A–2
D–2
D–3
D–2
D–2
D–2
D–2
C–2
C–2
C–3
D–3
C–3
D–3
D–2
C–2
(
D–1
D–2
D–2
D–4
C–4
C–4
C–4
D–4
D–3
C–3
2
2
–
–
–
–
–
2
–
1
2
1
2
–
–
2
DIODE
TRANSISTOR
Q001
Q003
Q004
Q005
Q006
Q007
Q501
Q502
Q503
Q504
Q505
Q506
Q507
Q508
Q509
Q510
Q511
Q512
Q517
Q522
Q523
Q524
Q525
Q526
Q527
Q528
Q660
Q661
Q701
Q703
Q704
Q705
Q706
Q707
Q708
Q901
Q902
Q904
Q905
Q908
Q909
Q911
*
2
1
2
1
1
2
1
1
1
1
1
–
–
–
1
1
–
2
1
–
–
–
–
–
–
–
D004
D009
D010
D012
D013
D014
D015
D016
D019
D020
D025
D026
D027
D028
D029
D032
D033
D035
D050
D501
D502
D503
D504
D505
D506
D507
D508
D509
D510
D511
D512
Conductor
Side
) (Component
Side )
E–2
E–2
E–2
E–2
E–2
E–2
E–2
E–2
E–1
E–4
D–4
E–2
E–2
E–2
E–2
D–2
E–2
D–3
E–1
B–4
B–4
D–4
D–4
C–3
B–3
B–3
B–3
D–4
C–3
B–3
C–4
B–1
D–1
C–1
B–2
B–2
B–2
D–1
C–2
B–2
C–1
*
7
3
3
7
7
7
7
7
6
7
3
6
6
6
6
3
3
8
3
3
–
3
–
–
–
–
–
–
–
–
–
D513
D514
D516
D517
D518
D519
D520
D521
D660
D701
D704
D705
D706
D709
D713
D714
D715
D718
D720
D721
D901
D902
D903
D904
D905
D906
D907
D908
D909
D910
D911
D913
D915
D916
D917
D919
D921
D922
D923
D924
D935
D1501
D1502
D1503
E–1
A–4
A–3
B–4
B–3
B–3
A–1
D–2
D–2
B–1
B–2
D–2
D–4
D–5
D–1
E–4
E–4
C–1
C–1
C–1
C–2
D–1
A–2
A–2
A–2
A–2
A–2
A–2
A–2
C–2
B–2
A–2
B–2
A–2
A–2
E–3
A–2
A–2
E–1
C–4
C–4
C–4
D–4
C–3
D–4
C–3
A–2
B–3
C–3
A–3
A–2
B–3
A–3
A–2
E–2
B–2
D–3
D–2
D–2
3
–
3
3
3
–
–
3
3
3
3
3
3
–
–
–
–
3
–
–
3
3
–
3
3
3
3
3
3
–
3
3
–
–
–
–
3
3
3
3
3
3
3
3
A
B
C
CRYSTAL
Component
( Conductor
Side ) ( Side )
X001
D–3
D–2
*: Refer to Terminal name of semiconductors in silk screen printed circuit (see page 5-9)
E
D
E
NOTE:
The circuit indicated as left contains high voltage of over
600 Vp-p. Care must be paid to prevent an electric shock in
inspection or repairing.
5-10
5-11
5-12
4
(1) Schematic Diagram of D Board
1
2
3
4
5
7
6
8
9
10
11
12
14
13
15
16
17
18
19
20
21
22
• D BOARD VOLTAGE LIST
• D BOARD WAVEFORMS
+15V
GND
-15V
GND
LCC_RB
LCC_RT
LCC_LB
LCC_LT
LCC_NS
1
2
3
4
5
6
7
8
9
VX
VY
D513
MA111
C025
1
R043
4.7k
:CHIP
C037
220
16V
DFOUT
22
PWMOUT
VCC2
PWMREF
PWMFIL
PWMNF
R013
10k :RN-CP
R042
47k :CHIP
C031
R037 0.01
3.3k B:CHIP
:CHIP
21
SOFTSTR
HSAW
16
GND3
R038
4.7k :CHIP
C082
10
C021
0.015
25V
B:CHIP
R071 1k :CHIP
VSHPC
VSHAPE
VSHPLVL
PEAKDET
VCC2
PWMOUT
TESTMODE
GND2
2
3
4
5
6
7
8
9 10 11 12
PINDRV
R054
10k
:RN-CP
R066
100
:CHIP
R065
100
:CHIP
C068
10
14 13 12 11 10 9
R053
10k
:RN-CP
8
IC013
TC74HCT04AF(EL)
INV
1
2
VS2
R901
2.2k
:CHIP
R922
470
:CHIP
R981
100
:CHIP
VCC
OUT1 V.S2
OUT2
-
+
-
+
VEE
R057 C060
15k
10
:RN-CP
C062
0.1
25V
B:CHIP
C063
0.1
:PT
C903 R904
220p 2.2k
CH:CHIP:CHIP
9
10
D519
FMQG5GS
1
2
4
5
6
1
2
10
9
8
FB901
1.1UH
5
C066
0.01
B:CHIP
Q904
2SC2411K
HV DRIVE
D901
MA111
R920
47
:FPRD
9
D911
UDZ-16B
R924
22
:FPRD
C912
1000p
CH:CHIP
6
5
2
3
4
5
6
DMP_ID
DMP_DO
DMP_DI
ASC
VIDEO
HFBP2
DMP_CLK
HTIM
R058
3.3k
:RN-CP
C074
1000p
B:CHIP
R059
4.7k
:CHIP
7
C072
1
R937
68
10W
C916
2200p
1.2kV
:PP
C923
0.0047
100V
:PT
C924
0.1
100V
:PT
14
D903
1SS119
C915
C917 0.01
220 B:CHIP
25V
L903
100µH
+15V
C945
47
C067
47p
CH:CHIP
R930
220
:CHIP
R929
220
:CHIP
C930
0.01
B:CHIP
+VIN2
10
6
CURRENT
CONTROLLED
CIRCUIT
CURRENT
CONTROLLED
CIRCUIT
5
7
15
16
17
R548
8.2k
Q509
DTC114GKA
RELAY
DRIVE
C551
0.001
B:CHIP
R549
10k
:RN-CP
C540
0.001
200V
:PT
2
R519
2.2
3W
:RS
1
4
19
IC013
1
2
8
9
10
11
13
0
4.9
0.6
3.6
4.9
0
5.7
5
R933
22k
:RN-CP
R934
4.7k
:RN-CP
C516
0.1
:PT
R547
3.3k
:RN-CP
1
3
5
9
10
12
13
14
15
3.5
3.5
2.7
0
0.1
4.9
4.9
3.2
3.9
1
2
3
4
5
6
8
9
13
0.5
4.2
0.5
0.5
0
0
0
0
0
1
2
3
4
5
41.4
41.4
33.7
42.3
48.3
1
2
3
5
6
7
4.5
0
0
0
0
–10.0
1
2
3
4
6
7
8
9
14.2
14.2
0
3.6
3.0
3.0
–0.7
–0.7
2
3
4
5
7
0.4
13.5
1.2
1.2
–13.0
1
2
3
5
6
7
1.2
1.6
1.6
2.8
2.8
2.8
1
2
4
6
7
8
10
9.3
5.6
5.0
1.1
0.9
9.3
0
R557
220k
:RN-CP
R564
82k
:RN-CP
C906
0.1
100V
:PT
R913
4.7k
1/2W
FV1 :SURGE
FV1
TO A BOARD
SK401
SG702
12
11
10
9
2
3
4
5
470
:FPRD
D715
1SS119
Q706
2SA1358
H DF OUT
C717
22
100V
L701
100µ
J
IC701
Q701
2SC2362K
H DF OUT
K
R743
1k
:CHIP
R742
1.5k
IC702
+15V
FV2
TO A BOARD
SK401
9
D919
1SS119
D720
RGP02-17
C926
0.22
100V
:PT
R755
680k
1/2W
:SURGE
12
L
R748
22k C750
:RN-CP 10
R752
D721
C729
RGP02-17 470p
IC703
R751
4.7k
:CHIP
11
R730
1k
1/2W
:SURGE
1000V
R754
680k
R756
270k
1/2W
:SURGE 1/2W
R753
10M
1W
27k
Q708
:CHIP
2SC4686A
V DF OUT Q707
2SA1037K
V DF OUT
R749
100
:CHIP
R759
120k
:RN-CP
R750
2.2k
:CHIP
D718
UDZ-5.1B
R784
5.6k
:CHIP
IC901
+80V
M
B-SS9057<AEP>-D..-05
R910
10k
:CHIP
CN550
1P
1
C014
1000
25V
:HT
D913
UDZ-12B
GND
C015
1000
25V
:HT
C931
0.01
B:CHIP
D904
MA111
IC505
Q705
2SA1049-GR
H DF OUT
R734
15
2W
:RS
FV2
Q902
C910 R909
39k
2SA1037K 0.01
SW
B:CHIP:CHIP
R926
R925
1.2k
1.2k
:RN-CP :RN-CP
IC502
D714
R739 1SS119
R738
0.47
:FPRD
7
16
R927
R919 10k
100 :CHIP
:CHIP
H
D713
1SS119
R737
0.47
:FPRD
17
R908
56k
:CHIP
R911
1k
:CHIP
IC015
R741
12k
Q704
2SC3421
H DF OUT
T701
DFT
R733
1k
1/2W
:SURGE
13
D935
UDZ-TE-17-5.1B
C929
100
25V
G
I
C715
47
100V
C909 R915
R914 0.0033 47k
470k 200V
1/2W :PT
SG901 :SURGE
8
R918
100k
:CHIP
IC014
H.DY
10
1
R551
2.2k
:RN-CP
Q703
2SC2459-GR
H DF OUT
7
20
F
V.DY
8
D917 R916
RD16ES 10k
15
3
GND
V.DY C
V.DY H
NC
H.DY C
H.DY C
NC
NC
H.DY H
H.DY H
PS701
1.0A
2
R980
1k
:CHIP
1
6
80V
6
1
2
3
4
5
6
7
8
9
10
2
C557
0.033
B:CHIP
SG701
R912
C928
680k
0.01
C919 B:CHIP
:RN-CP C921
47p
0.01
CH:CHIP B:CHIP
R917
10k
:CHIP
C927
2.2
3
R520
2.2
3W
:RS
2kV
B
18
4
5
Q511
2SC3209LK
H CENT
HCENT
R540 C535
10k 0.01
:CHIP B:CHIP
D518
MA111
CN508
10P
:VH
N
L001
100µH
R921
5.1k
:RN-CP
L002
100µH
PS502
2.0A
PS503
2.0A
+200V
200V
1
2
3
4
5
6
7
8
9
10
11
CN502
11P
WHT
:S-MICRO
HCENT H
HCENT N
HCENT L
+200V
+200V
NC
+80V
GND
+15V
GND
-15V
1ST IK PROT 4
5
GND
CN901
5P
WHT
:S-MICRO
1
IK DET
2
HV ADJ
X RAY DET 3
D908
UDZ-TE-17-12B
O
TO G BOARD
CN671
5-14
0.6
3.9
4.1
1KV
NC
15V
5-13
5
6
7
9 VSENCE2
E
HDF
VDF
R544
68
1/2W
D915
RD5.1ESB2
D907
UDZ-TE-17-12B
O
IC012
8 VOUT2
T504
HCC
18
D902
MA111
D905
MA111
VCC
4
HBLK2
C515
220
25V
:HT
C513
0.0047
B:CHIP
R517
4.7k
:CHIP
14
S
Q909
2SK1120
HV OUT
D906
MA111
+5V
C069
0.01
B:CHIP
13
4.0
3.0
2.8
2.3
2.6
0.6
4.8
4.8
5.4
4.5
4.5
5.4
1.0
0
5.1
3.7
0.8
2.5
–0.1
4.0
4.0
4.4
IC502
C514
LA6500-FA R518
100k 0.01
H CENT OUT :CHIP B:CHIP
HBLK
R550
0.47
1/2W
:FPRD
C925
0.022
:PT
10
12
T503
:HST
HV
IC901
BA9756FS-E2
HV CONTROL
11
D514
RD6.2ESB2
R545
22k
:RN-CP
1
L902
15µH
C913 R907
0.1
100
25V :CHIP
B:CHIP
3
R527
100
1/2W
:RN
T902
FBT
C914
1000p
CH:CHIP
4
R526
100
1/2W
:RN
R528
100
1/2W
:RN
TO PICTURE TUBE
C908
0.22
:MPS
C911
1000p
CH:CHIP
7
+VIN1
TO A BOARD
CN406
6
5
1
HSIZEFB
S0
C531
0.01
B:CHIP
R530
47k
R940 4
D916
10
1SS120TD :FPRD
Q905
2SA1036K
HV DRIVE
R905
100
:CHIP
8
1
3
4
5
6
7
9
10
12
14
15
16
17
18
19
20
23
24
25
26
27
28
D507
1SS119
HV
6
D923
MA111
10
L503
:HLC
C512
220
25V
:HT
3
5
R906
4.7k
:CHIP
C085
0.1
25V
B:PT
Q522
2SK2098
S-CAP CHANGE
R573
100k
:CHIP
R531
47k
R538
1k
:CHIP
R546
0.47
1/2W
:FPRD
S
C534
0.01
B:CHIP
R532
47k
R537
1k
:CHIP
T901
:HRC
Q908
2SJ449(1)
HV REG SW
Q901
2SC1623
AMP
C905
220
16V
–0.1
4.7
4.5
0.3
0.3
4.5
IC701 LA6510
3
D508
RD5.1ESB2
R515
10k
:RN-CP
R516
220
R542
100
1W
:RS
S5
C533
0.01
B:CHIP
R533
47k
R536
1k
:CHIP
D922
MA111
C065
22
1
2
C517
4700p
2kV
B
Q517
2SA1037K
PIN AMP
D509 1SS119
C536
100
25V
C529
2.2
250V
:HR:HT
C521
47p
500V
:CH
L504
:HLC
L505 R595
4.7mH 47k
C524 L502
0.056 1mH
250V
:PP R529
56
1/2W
:FPRD
S
≠≠≠≠≠≠
HV_DET
≠≠≠≠≠
R535
1k
:CHIP
C902
0.047
25V R903
B:CHIP 10k
:CHIP
C904
0.01
250V
:PT
1
2
3
5
6
7
-VIN1 VEE -VIN2
C559
470p
2kV
:B
+VIN
-VIN
VEE
OUT
VCC
SDA
24
23
22
21
20
19
18
17
16
15
14
13
R902
4.7k
:CHIP
D512
ERA34-10
C563
1000p
2kV
D506
1SS119
4
D511
1SS119
R539
1k
:CHIP
S
C532
0.01
B:CHIP
C907
33
400V
:HR
PIN_FB
R068
100
:CHIP
S
C530
0.01
B:CHIP
R923
10k
:CHIP
R576
100k
:CHIP
R575
100k
:CHIP
S
PS901 L901
1.6A 100µH
C518
4700p
1.8kV
:PP
R525 C523
18k
:RN-CP 0.01
:PT
R541 R594
C539
68
47k
4.7 250V :HR:HT 1/2W
:FPRD
R568
1.5k
S1
PINDRV
HD
S4
HVD
R900
6.8
3W
:RS
R577
2.2k
:CHIP
+9V
CS2
HDF VS1
Q003
2SA1037K
BUFFER
C538
0.24
400V
:PP
C922
0.33
250V
:PT
GND1
VDC
VCONV
VSHPR
1
5
D910
D909
UDZ-13B YG911S3R
R070 10k :RN-CP
R060 1k :CHIP
VDF
HSHAPE
HSHPBAL
HSIZE
TILT
MOIRE
BKGPOUT
CLPW
VSPDM
CS1
R083
2.2k
:CHIP
R1011
10k
:CHIP
R072 1k :RN-CP
R073 0 :CHIP
R074 10k :RN-CP
R081 10k :RN-CP
R006 1k :CHIP
R067
100
:CHIP
V.S1
SCL
NC
Vss
ABL_DET
TH_DET
VSHAPE
HSHAPEBAL
VDF
V CONV
VDC
MOIRE
ROTATION
HCENT
S_ON_G
HTRIG
HD
VSOUT
VCC1
HVD
20
VDFIN
SCL
18
SDA
17
9
GND2
10
STBY+5
R587
1k
:CHIP
CN507
2P
WHT
:VH
D505
ERA34-10 1000V
D510
ERA91-02
5
4
RY501
2
R574
100k
:CHIP
C550
0.01
B:CHIP
R586
1k
:CHIP
D520
RGP02-20
7
C555 R580
0.022 10k
B:CHIP :CHIP
C556
0.001
B:CHIP
T501
HDT
C564
4.7
S
R534
47k
C522
100p
2kV
:B
R524
1k
1W
:RS
C519
100p
2kV
B
C520
0.0015
630V
:PP
R523
4.7k
:FPRD
TH502
R572
100k
:CHIP
C549
0.01
B:CHIP
0.4
0
1.5
4.8
D
VOUT1 2
-15V
R047
10k :CHIP
R567
100
:CHIP
Q512
2SC2412K
TH DET
R589
100k
:CHIP
1
3
7
8
R725
1.8
1/2W
:RN
+9V
+15V
C030
0.1
C084
0.1 25V B:CHIP 25V
B:CHIP HBLK
C087
R069 0.1
47 25V
INPUT_SEL_D :CHIPB:CHIP
4
R582
10k
:CHIP
D517
UDZ-TE-17-6.2B
R552
2.2k
:CHIP
C058
10
IREF1
IC007
CXA2043Q
DEFLECTION
PROCESS
2
:CHIP
D516
+15V
UDZ-TE-17-6.2B
Q527
C528
2SK2098 0.82 250V :PP
C525
C527
C526
Q528S-CAP CHANGE
Q526
Q525
0.1
0.22
0.39
2SK2098
2SK2098
2SK2098
250V
250V Q523
250V Q524
:PP
:PP 2SK2098
S-CAP CHANGE
S-CAP CHANGE S-CAP CHANGE :PP 2SK2098
S-CAP CHANGE S-CAP CHANGE
R588
100k
:CHIP
R056
6.8k
:RN-CP C059
0.01
B:CHIP
R724
1.8
1/2W
:RN
R585
22k
:CHIP
C537
1.2 250V :PP
R555
4.7k
:CHIP
R553
1.5k
:CHIP
C901
220
25V
ID
C028
2200p
CH:CHIP
37 GNDP
38 CBLKOUT
39 CLPOUT
40 VCCP
41 HS/CS1
42 HS/CS2
43 VS1
44 VS2
45 INPUT_SEL
46 SONG
47 HSOUT
48 VSOUT
R511
2.2
10W
:RN
R514
1
1/2W
:FUSE
470
25V
TH501
DO_A
CLK_A
TXD
RXD
DMP_CLK
DMP_DO
OSD_SEL
≠≠≠≠≠≠≠
≠≠≠≠≠≠
DMP_ID
Q004
2SA1037K R055
47k
C027
0.1
25V
B:CHIP
19
GND1
15
C035
120p
CH:CHIP
C036
0.1
25V
B:CHIP
MOIRE
DO
HVDOUT
C092
0.01
C093 B:CHIP
10
D503
MA111 C509
8
3
R584
22k
:CHIP
R581
10k
:CHIP
C554
R583 0.022
25V
12k
:RN-CP B:CHIP
-15V
36 35 34 33 32 31 30 29 28 27 26 25
HSOUT
8
Q001
DTA124EKA
SOFT START
SW
R064 100 :CHIP
Q007
2SC2412K
R509
2.2k
:CHIP
C561
0.47
:MPS
R032
10k
:RN-CP
DI
HSYNC
11
C541 C542
47p 47p
CH:CHIP
CH:CHIP
Q505
2SA1036K
H DRIVE
C510
0.0047
:PT
C544
0.0047
:PT
R513
33
1W
:RS
Q506
2SC3746
H DRIVE
3
R508
100
:CHIP
S
CLK
VCC4
HDOUT
R044
82k
:CHIP
R045 C029
10k 1
:CHIP
23
HFREQ
1
C508
0.022
B:CHIP
C506
0.22
:MPS
R046
10k
:RN-CP
R063 100 :CHIP
CBLK
CLP
R571
0.22 D504
3W SB560
:RS
9V-1
R503
470
:CHIP
R512
100
:CHIP
C050
0.047 25V B:CHIP
R729
220
1W
:RS
D709
RGP15G
Q508
R522 2SC5047CA
27
H OUT
1W
Q510
2SC2412K
H CENT
C504
0.01
250V
:PT
Q503
2SA1036K
PIN DRIVE
Q504
2SC2412K
H DRIVE
IC005
:RS
R506
22
:FPRD
D521
MA111
4.8
4.8
IC010
• D BOARD
C711
220
35V
:HT
15V
C056
0.047 25V B:CHIP
-15V
+9V
ROTATION
D1501
UDZ-TE-17-5.1B
R501
4.7k
:CHIP
R502
2.2k
:CHIP
4
VIDEOOUT
FBP
12
C039
10
SCL_D
Q501
2SC2412K
PIN DRIVE
IC004
24LC16BT/SN
EEP ROM
C052
0.047 25V B:CHIP
C003
0.0068 B:CHIP
HPLL
L507
4.7mH T502
HOC
R566
39
1/2W
:FPRD
5
6
2.0 Vp-p (V)
C
R721
4.7k
:RN-CP
C707
0.01
B:CHIP
R723
3.3k
:RN-CP
C714
47
D502
YG911S3R
50.0 Vp-p (V)
IC004
C710
0.0068
B:CHIP
VSHAPE
HV_PROT
ABL_DET
3
7
R521
470
:FPRD
S2
EEP_SDA
VSS
EEP_SCL
TEST
A2
VCC
2
5
G
S
IIC_SCL
C
IIC_SDA
R089
2.2k
:CHIP
D
C503
0.22
:MPS
5
VIDEO
AFC1
13
SDA_D
D701
UDZ-TE-17-5.6B
Vcc
Vclk
NC
Vss
NC
SDA
NC
D035
MA151WK-TX
SCL
NC
1
C747
0.01 R779
B:CHIP 1k
:CHIP
R710
10k
:CHIP
120 Vp-p (H)
1.1
4.2
0
IC009
FB502
1.1UH
Q507
2SJ449(2)
C507
0.47
:MPS
6
3
D706
UDZ-TE-17-5.1B
S
R510
4.7k
:CHIP
R504 R505
470
2.2k
:CHIP :CHIP
C553
4.7
R579
7.5k
:RN-CP
D704
MA111
1
R726
C706 10k
0.01 :RN-CP
B:CHIP
R778 C751
4.7k 0.01
:RN-CP B:CHIP
R709
56
3W
:RS
7
5
6
7
IC702
LA7841L
V DY OUT
R722
47k
:RN-CP
4
6
600 Vp-p (H)
Pin No. Voltage [V]
IC002
R728
1.0
:FPRD
6
HSHAPEBAL
LC_SDA_1
VCLK1
Vcc
Vclk
NC
MD2
HSTX
MD2
P52/SDA1
P51/SCL0
P50/SDA0
C
P47
P46/ADTG
P45/SIN1
DMP_DI
EEP_SCL
EEP_SDA
VCC
DMP_DO
RXD
TXD
DMP_CLK
DMP-ID
OSD_SEL
LED3
LED2
R011
100k
:CHIP
SCL_D
7
3
B
D501
UDZ-TE-17-13B PIN OUT
FB501
1.1UH
C511
33
250V
:HR
Q502
C502 2SC1623
220p PIN DRIVE
FBPIN
27
DUTYDET
24
IREF
14
5V
D025
UDZ-TE-17-7.5B
PS501 L501
1.6A 100µH
C501
47
R088
2.2k
:CHIP
C012
C013
0.1
47
25V
B:CHIP
HV_PROT
HSIZEFB
5
2
4
2.0 Vp-p (H)
4.3 Vp-p (H)
C713
1000
25V
VSENCE1 1
C008
C020 C070 C081 0.1
0.01 0.01 0.01 25V
B:CHIP B:CHIP B:CHIP B:CHIP
VCC3
28
AFC2
C038
0.1 25V B:CHIP
R041
4.7k
:CHIP
D921
MA111
R562
47
:FPRD
4
4
1
2
R731 C709
10k
0.1
:CHIP :PT
KEY_DET
IREF2
HPHASE
26
VCC1
25
1
SLOPE
6
C040
4.7
R061
4.7k
C077
0.1
25V
L007
100µH
15V
HPLL
VX
R101
1k :CHIP
FIK32
C026
0.022
:PT
IC010
CXA2044M
SYNC PROCESS
O
7
Q005
2SA1037K
BUFFER
HSOUT
R1502
≠≠≠≠≠≠
≠≠≠≠≠
10k :CHIP+B_DET
DDC_SDA_1
HCENT
3
3
C705
1000
25V
VRET
C051
1.0
C920 1000p
5
C080
47
C1501
0.01
B:CHIP
C054
4.7
5
2
R777
18k
:RN-CP
VDC
VY
C1502
D1503 2200 D1502 R1501
2.2k
MA111 10V MA111 :CHIP
CH:CHIP
JR002
0 :CHIP
JR001
0 :CHIP
LED0
LED1
ASC_SW
DAC_SEL
6
1
C735
0.1
:PT
R708
10k
:CHIP
IC701 LA6510 CURRENT AMP
R715
15k
:CHIP
C1003 R1503
0.01 1.5M
B:CHIP :CHIP
HTIM
C045
680p
CH:CHIP
C047
220
G
C048
0.0022
CH:CHIP
C049
R1017
680p
C099
4.7k
CH:CHIP
0.1
:CHIP
25V
C046
0.1
B:CHIP
25V
B:CHIP
R051
15k
:RN-CP
R1016
1k
C022
:CHIP
100
16V
I
9V-2
R1504
100k
:CHIP
C055
4.7
C041
R052
1 10k :CHIP
9V-1
R1015 IC011
0 µPC78L05J
HTIM
N
+9V
6
C746
0.001
B:CHIP
5
R732
10k
:CHIP
C076
0.047 25V B:CHIP
R563
3k
:RN-CP
7
JR003
0
:CHIP
-15V
C032
0.0068
B:CHIP
8
6
IC703
NJM4558M-TE2
BUFFER/AMP
R719
1.5
:FPRD
R507
4.7k
:CHIP
C078
0.1
25V
B:CHIP
9
7
C712
0.22
100V
:PT
ANV_DRI
R026
10k :CHIP
R049
1k
:CHIP
2
C505
100p
CH:CHIP
R005
10k
:CHIP
L008
100µH
G
P53/SCL1
8
R928
4.7k
:RN
+9V
M
JR004
0
:CHIP
R027
10k :CHIP
R558 C547
47
R596 22k
22k :RN-CP
:RN-CP
B:CHIP
IC003
NJM78L09A-T3
9V REG
C079
47
C096
0.01
B:CHIP
HOST+5V_2
R1021
1k
:CHIP
9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
IC505
NJM4558M-TE2
PIN FB AMP
1
Q661
DTC114GKA
C666 PROT DET
0.01
C057
47
VCC
P44/SOT1
P43/SCK1
P42/SIN0
P41/SOT0
P40/SCK0
P36/RDY
P35/HAKX
P34/HRQ
P33/WRHX
P32/WRLX
VSS
P31/RDX
P30/ALE
P27/A23
8
VSS
7
LED1
6
P26/A22
P25/A21
P24/A20
5
LED0
4
DAC_SEL
3
P23/A19
P22/A18
P21/A17
P54/SDA2
7
R561
22k
:RN-CP
Q660
DTA114GKA
SW
C042
47
HSTX
AVCC
P55/SCL2
R565
6.8k :RN-CP
R665
1k
:CHIP
O
P72/IRQ2
AVRH
R556
R543 9.1k
360
:CHIP :RN-CP
8
C667
47
P73/IRQ3
AVSS
AVRL
R590
10k :RN-CP
C044
47
D660
UDZ-TE-17-24B
P74/IRQ4
P62/AN2
P60/AN0
R035
1k
:CHIP
C562
R591 C545
47
0.01
10k
B:CHIP :RN-CP
+5V
G
R667
470
:CHIP
P75/IRQ5
P63/AN3
P61/AN1
ASC_SW
4
STBY+8V
O
4
R082
1k
:CHIP
A1
3
R554
10k :RN-CP
C043
47
P76/IRQ6
IC001
MB90553PF
CPU
STBY+5V
IC006
TA7805S
5V REG
O
P77/IRQ7
P80/TIN0
P81/TIN1
P82/TOT0
P83/TOT1
VSS
PIN_FB
+B_DET
≠≠≠≠≠≠
≠≠≠≠≠
≠≠≠≠≠≠≠≠
PROT_DET
≠≠≠≠≠≠≠
R012 100 :CHIP
I
R028 4.7k :CHIP
VS
VS
P85/IN1
P86/IN2
P87/IN3
P90/OUT0
P91/OUT1
P92/PPG0
P93/PPG1
P94/PPG2
P95/PPG3
P96/PPG4
PA0
P97/PPG5
P64/AN4
HOST+5V_2
HOST+5V_1
HTR_SW
G
C024 0.01 B:CHIP
HS
HFBP
VRET
ASC
LCC_LT
LCC_RB
LCC_RT
LCC_LB
H_CONV
LCC_NS
RESET
PA1
PA2
RSTX
PA4/CKOT
PA3
P65/AN5
50 MD1
49 MD0
48
47
46 VY
45
44
43
42 VSS
41 HPLL
40 VX
39 KEY_DET
38 ABL_DET
37 AVSS
36 AVR35 AVR+
34 AVCC
33 DDC_SCL_2
32 DDC_SDA_2
31 DDC_SCL_1
A0
2
HFBP2
R001 100 :CHIP
I
3
R705
2.2
10
8
R707
2.2k
R706
68k :CHIP
C702
0.1 :PT
R703
33k
:CHIP
2
HFBP1
HBLK2
DGC
+15V
2
R1001
10k
:CHIP
R036 100 :CHIP
R050 100 :CHIP
IC008
NJM78M09FA
9V REG
1
LCC_RB
LCC_RT
LCC_LB
LCC_LT
LCC_NS
5
R048
1k
:CHIP
DIGITAL GND
DAC_SEL
R663
360k
:RN
5
IC002
24LC21A ROM
C1009
1
R1020
1k
:CHIP
MD1
P66/AN6
2
R085 100 :CHIP
I
6
-15V
D705
MA111
L702
5.6µH
C1005
0.01
B:CHIP
C034
0.01
B:CHIP
1
VIDEO
ASC_SW
≠≠≠≠≠≠≠
OSD_SEL
≠≠≠≠≠≠
DO_A
CLK_A
L003
100µH
7
S3
6
INPUT_SEL_A
PS504
2.0A
LC_SCL_1
HFBP1
HTRIG
ASC
VSOUT
H_CONV
LCC_NS
LCC_RB
LCC_LB
LCC_RT
LCC_LT
R1028
1k :CHIP
R1003
1k :CHIP
R1004
1k :CHIP
R1005
1k :CHIP
R1006
1k :CHIP
R1007
1k :CHIP
INPUT_SEL_A
INPUT_SEL_D
INPUT_SEL
8
7
7
IC009
TC7W04FU(TE12R)
INV
D050
MA111
R669
6.8k
:RN-CP
L
6
WDT
CBLK
S_ON_G
R578
100
:CHIP
R664
39k
:RN
K
8
2
CN504
5P
WHT
:S-MICRO
1
2
3
4
5
8
SDA_D
3
DGC
POWER
HTR_SW
STBY 8V
GND
4
P67/AN7
C097
C075 C005 C004 C007
0.01
0.01 0.01 0.01 0.01
B:CHIP B:CHIP B:CHIP B:CHIP B:CHIP
4
TO G BOARD
CN673
3
P70/IRQ0
R1513
1k
R034 100 :CHIP
2
R1027
4.7k
:CHIP
STBY5V
CN503
7P
WHT
:S-MICRO
I
J
CONT
BRT
POWER_SW
TO A BOARD
CN407
1
2
3
4
5
6
7
1
P71/IRQ1
R084 100 :CHIP
ASC_SW
OSD_SEL
MOSI
CLK
DAC_SEL
HFLB
VRET
IC012
24LC21A ROM
MD0
CLP
CN506
8P
WHT
:S-MICRO
H
1
RXD
TXD
R040 1k :CHIP
R023
100
:CHIP
5
GND3
TO A BOARD
CN403
1
2
3
4
5
6
7
8
6
C006
1
DMP_DI
G
CLP
LOWB_DET
C.BLK
GREEN
GND
INPUT_SW
GND
VIDEO
VSS
R020
1k
:CHIP
C001
0.01
B:CHIP
D020
1PS226
-115
R039 1k :CHIP
X001
4MHz
DDC5V_DET_1
TO ECS
7
R704
1.5 :FPRD
Ref.
4
µ-COM,
DEFLECTION
R727
1
1/2W
:FPRD
R720
1
1/2W
:FPRD
R776
1k
:CHIP
R701
1.5
:FPRD
R702
2.2k
:CHIP
STBY 5V
P20/A16
C098
0.01
B:CHIP
D019
1PS226-115
1
2
3
4
8
D
15V
-15V
V CONV
C701
47
C1008
0.01
DDC5V_DET_2
D007
D008
D009
D010
R1014
CN505
4P
WHT
2
4
CONT
BRT
F
R025
0
:CHIP
+9V
R008
47k :CHIP
R1514
1k
:CHIP
81 VSS
XTAL0 82 X0
1
XTAL1 83 X1
R096
C011
22p CH:CHIP 0 :CHIP
VCC 84 VCC
S0
S0 85 P00/AD00
S1
S1 86 P01/AD01
S2
S2 87 P02/AD02
S3
S3 88 P03/AD03
S4
S4 89 P04/AD04
S5
S5 90 P05/AD05
D924
PIN_GAIN_SW 91 P06/AD06
UDZ-TE-17-5.1B
92 P07/AD07
R004
HV_DET
≠≠≠≠≠≠
HV_DET
≠≠≠≠≠
1k :CHIP
93 P10/AD08
P11/AD09
R1013 94
TH_DET
1k :CHIP 95 P12/AD10
≠≠≠≠≠≠≠≠
PROT_DET
≠≠≠≠≠≠≠
PROT_DET 96 P13/AD11
R002 1k :CHIP
97 P14/AD12
R018
POWER_SW
1k :CHIP
POWER 98 P15/AD13
R017
HTR_SW
1k :CHIP HEATER_SW 99 P16/AD14
DGC
DGC 100 P17/AD15
LED0
LED1
CONT
BRT
KEY_DET
D012
1k
1PS226-115 :CHIP
VCC
C017
C010
0.1
22p
25V
B:CHIP CH:CHIP
C019
47
D013 D014 D015 D016
D004
1PS226 1PS226 1PS226 1PS226 1PS226-115
-115 -115 -115 -115 ANV_DRI
L004
100µH
GND
VS
RCT
C016
0.001 R1012
1k
B:CHIP :CHIP
C009
0.1
R031
25V
10k
:CHIP B:CHIP
H_CONV
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51
C094
0.01 B:CHIP
C095
0.01 B:CHIP
2
R077 1k :CHIP
3
R078 1k :CHIP
4
R003 1k :CHIP
5
C061
0.01 B:CHIP
6
7
8
9
CK
RESET
L006
100µH
UDZ-TE-17-5.1B
UDZ-TE-17-5.1B
UDZ-TE-17-5.1B
UDZ-TE-17-5.1B
C1007
0.01
B:CHIP
NC
3
R097
2.2k
:CHIP
R094
2.2k
:CHIP
C018
0.1
25V
B:CHIP
D033 UDZ-TE-17-5.1B
C1006 0.01 B:CHIP
D032 UDZ-TE-17-5.1B
R092
2.2k
:CHIP
R075 1k :CHIP
1
R076 1k :CHIP
D GND
STBY+5V
RXD
TXD
TC
5
1
HOST+5V_2
IC005
MM1170BFB
WDT
R1025 4.7 :FPRD
R029
47k
:CHIP
VRET
R033 47 :CHIP
D034
MA151WK-TX
C1503 R024
220p 47k
:CHIP
R1024
0
:CHIP
R030 47 :CHIP
CN501
9P
YEL
:S-MICRO
TO H BOARD
CN801
LC_SDA_1
HOST+5V_1
LC_SCL_1
R079 47 :CHIP
D
E
C023
0.001 B:CHIP
R1026 4.7 :FPRD
R090
2.2k
:CHIP
LED0
LED1
CONT VR
BRT VR
KEY_DET
D GND
STBY+5V
ANV_DRI
D GND
R1023
0
:CHIP
P84/IN0
R009
100
:CHIP
C1004
0.01
B:CHIP
HOST+5V_1
Q006
2SC2412K
5V REG
R010
22k
:CHIP
C086
10
P37/CLK
C002
0.001
B:CHIP
5
-15V
1
CS1
VS1
CS2
VS2
R007
100 :CHIP
R080
47
:CHIP
5.0 Vp-p (4MHz)
5
4
3
C
VCLK1
C.SYNC_1 1
V.SYNC_1 2
C.SYNC_2 3
V.SYNC_2 4
5
GND
TO CONNECTOR
DDC_SDA_1 6
PANEL
HOST+5V_1 7
DDC_SCL_1 8
DDC_SDA_2 9
HOST+5V_2 10
DDC_SCL_2 11
CN509
2P
WHT
:S-MICRO
+15V
CN511
11P
WHT
:S-MICRO
3
2
A
2
B
ROTATION+
ROTATION-
GND
H CONV
V CONV
VX
VY
GND
1
2
3
4
5
6
R1022
0 :CHIP
D026
D027
D028
D029
1PS226-115 1PS226-115 1PS226-115 1PS226-115
CN512
9P
WHT
:S-MICRO
1
ROTATION+
ROTATION-
1
2
TO L BOARD
CN5001
A
CN520
6P
WHT
:S-MICRO
6
5
TO L BOARD
CN5002
5-15
5-16
Ref.
Pin No. Voltage [V]
11
12
15
16
19
0
11.2
0
8.4
9.2
Q003
B
C
E
5.1
0
5.7
Q005
B
C
E
2.5
0
3.1
Q501
B
C
E
11.2
13.8
10.8
Q502
B
C
0.2
11.2
Q503
B
E
11.2
10.9
Q504
B
C
E
2.5
12.0
2.5
Q505
B
E
2.5
2.4
Q506
B
C
E
–14.0
–0.2
–14.0
Q507
G
D
197.4
41.8
Q508
B
C
–1.4
41.0
Q509
B
C
0
14.1
Q510
B
E
4.5
3.9
Q511
B
C
E
3.2
33.5
2.6
Q517
B
E
4.6
5.1
Q522
G
D
0
15.2
Q523
G
D
4.7
0
Q524
G
D
4.7
0
Q525
G
D
4.7
0
Q527
G
D
4.7
0
Q528
G
D
4.7
0
Q660
B
C
E
4.2
0
4.2
Q661
B
C
0
4.2
Q701
B
C
E
5.7
36.0
5.1
Q703
B
E
37.9
37.4
Q704
B
E
37.4
37.0
Q705
B
E
36.0
36.6
Q706
B
E
36.6
37.0
Q707
B
C
E
–0.6
–5.0
0
Q708
B
C
0.6
477.0
Q901
B
C
0.1
9.9
Q902
B
C
E
9.0
0
9.0
Q904
B
C
E
8.6
13.0
8.4
Q905
B
E
8.6
8.4
Q908
G
D
196.6
40.1
Q909
G
D
8.4
40.4
(2) Schematic Diagrams of G, GA, H, J and L Boards
1
2
3
4
5
7
6
8
9
10
11
12
14
13
15
16
17
18
19
20
21
22
23
24
26
25
27
29
28
30
A
A
STBY+5V
(POWER SENSOR)
+15V
B
CN7501
10P
B-TO-B
R7509
10k
:CHIP
R7513
68k
:CHIP
R7502
10k
:CHIP
L SENCE
GND
2
I SENSE
DRIVE
1
5
AC SENSE
V SENCE
IC7501
MC33262P
SENSOR
6
CMPNS
C
7
VCC
8
3
D7501
RD22ESB2
R7507
47k
:CHIP
R7506
10k
:CHIP
C7502
0.22
:MPS
R7505
8.2k
:RN-CP
Q7502
2SC2412K
SW
C7505
0.1
25V
B:CHIP
R7503
470
:CHIP
4
R7501
100
R7504 C7503 :CHIP
Q7501
1000p
10k
2SA1037AK
:RN-CP B:CHIP
D
Ref.
1
GND
2
GND
3
DRIVE
4
I SENSE
5
VCC
6
V SENCE
7
L SENCE
8 AC SENSE
9
OVP
10
LVP
TO G BOARD
CN610
R7510
10k
:CHIP
C7504
0.1
:PT
Q7501
Q7502
R7511
10k
:CHIP
Q7503
Q7503
2SC2412K
SW
R7508
10k
:CHIP
1
2
3
4
5
7
2.6
2.5
1.7
0.2
0
8.6
B
C
E
14.0
0
14.0
B
C
0.7
0.1
B
C
0
14.0
Q802
2SC3311A
LED DRIVE
CN801
11P
:S-MICRO L
R814
10k
1
2
3
4
5
6
7
8
9
10
11
R815
10k
R827
150
POWER
R826
180
D820
SPR-325MVW
R810
3.3k
:RN
R809
2.2k
:RN
R808
1k
:RN
R807
1k
:RN
R806
680
:RN
R805
470
:RN
R804
470
:RN
R803
330
:RN
R802
330
:RN
R801
3.3k
:RN
B
TO D BOARD
CN501
• L BOARD
LED0
LED1
LED2
LED3
KEY_DET
D GND
STBY+5V
TEMP_DRI
GND
GND
GND
TO PICTURE TUBE
SHIELD
S820
S806
S818
S805
S804
S803
R7512
47k
:CHIP
Q7504
B
IC5101, 5301, 5401 LA6510
+VIN1
VCC
+VIN2
4
10
6
C
VOUT1 2
CURRENT
CONTROLLED
CIRCUIT
S802
VSENCE1 1
D7502
1SS119
C7506
0.1
25V
B:CHIP
Q801
2SC3311A
LED DRIVE
Pin No. Voltage [V]
IC7501
OVP
C7501
0.01
B:CHIP
C811
47
16V
• GA BOARD
VOLTAGE LIST
G
Q7504
2SA1037AK
SW
R
GA
CURRENT
CONTROLLED
CIRCUIT
8 VOUT2
9 VSENCE2
D
RESET
13.4
ASC
INPUT BRT-
BRT+
MENU CONT- CONT+
B-SS9017<U/C>-GA.
3
5
7
-VIN1 VEE -VIN2
TH801
R819
100k
CN891
3P
WHT
:VH
E
C805
47
16V
R818
10k
:RN
E
AC L OUT 1
NC 2
AC L IN 3
TO G BOARD
CN605
S891
POWER
H(USER CONTROL)
F
IC630
DM-60
+200V REG
7
2
6
C644
470p
500V
:HR
D617
MA111
4
4
4
2
8
6
C695
330p
500V
3
C693
0.1
:PT
1
15V
THP601
R694
10k
:CHIP
D691
D5LC20U
D662
AG01AV0
1
I
C661
100
10V
R664
22
2
R666
6.8k
:RN
5
D681
MA111
D680
MA111
R682
4.7k
:CHIP
Q680 R689
10k
2SC2412K :CHIP
PROTECT
R685
10k
:CHIP
Q642
Q660
Q691
2SA1037AK
HEATER SW
3
4
R698
10k
:CHIP
D693
MA111
Q680
IC691
µPC1093J-T
REG
O
G
R691
10k
:CHIP
1
C697
0.1
:MPS
R667
3.3k
:RN
B
C
E
B1
C1
B2
C2
E2
B
C
E
B
C
13.6
14.2
14.3
–2.0
199.2
196.8
408.0
199.2
1.1
–2.0
2.0
–1.8
–2.0
C691
47
25V
R697
820
:RN-CHIP
G
D666
UDZ-TE-17-6.2B
R665
220
:CHIP
GEOMAGNETIC
SENSOR
B
E
11.7
11.7
B
C
7.5
8.3
Q690
B
C
0
15.0
Q691
B
C
E
8.6
5.3
6.7
DGUS SW
POWER SW
HEATER SW
STBY+8V
GND
R669
2.2k
1
2
3
4
5
2
PH660
PC123FY2
1
2
3
4
CN604
3P
WHT
:VH
DGC
NC
NC
DGC
AC L 1
NC 2
AC N 3
3
CN603
4P
WHT
:VH
N
CN673
5P
WHT
:S-MICRO
DGC
R5501
2.2k
:CHIP
R5201
1.5
:FPRD
1
2
R5208
6.2k
:RN-CP
C5206
0.1 25V B:CHIP
R5207
10k
:CHIP
C5501
220
10V
IC5201
LA6500
AMP
3
4
5
C5203
0.1
25V
B:CHIP
R5203
1.5
:FPRD
C5205
0.22
16V
B:CHIP
C5202
47
25V
C5201
47
25V
OUT2
-
+
VEE
2
3
4
5
R5316
10k
:CHIP
R5503
62k
:RN-CP
R5506
6.2k
:RN-CP
R5101
1.5 R5102
:FPRD 1.5
:FPRD
C5308
0.1
25V
B:CHIP
D5201
MA153
R5204
100k
:FPRD
R5205
10k
:CHIP
R5110
10k
:CHIP
C5204
0.1
:PT
C5405
47
25V
IC5401
LA6510
AMP
C5412
0.1
25V
B:CHIP
10
9
8
7
C5407
0.1
:PT
2
3
4
5
2
3
4
5
100k
:FPRD
1
2
3
4
C5408
330p
B:CHIP
C5403
0.01
B:CHIP
R5419
47k
:CHIP
V
V
H
H
STAT(+)
STAT(-)
STAT(+)
STAT(-)
LCC-LT(+)
LCC-LT(-)
LCC-LB(+)
LCC-LB(-)
LCC-RT(+)
LCC-RT(-)
LCC-RB(+)
LCC-RB(-)
LCC-NS(+)
LCC-NS(-)
1
2
4
1.2
1.2
1.1
1
2
3
4
6
7
8
9
–0.2
–0.2
1.2
1.2
1.2
1.2
0.4
0.4
1
2
3
4
6
7
8
9
0.6
0.6
3.4
3.4
1.8
1.8
0.4
0.4
IC5301
IC5401
D5103
MA153
I
J
K
L
C5110
47
25V
R5119
10k
:CHIP
R5120
1.5
:FPRD
R5122
22
2W
:RS
V.STAT,H.STAT,LCC
GEO MAGNETIC SENSOR
M
1
2
3
4
V
V
H
H
STAT(+)
STAT(-)
STAT(+)
STAT(-)
N
NTC COILS
R5420
1.5
:FPRD
1.0
1.0
1.2
1.2
1.2
1.2
–0.2
–0.2
IC5201
R5121 C5111
100k 0.1
:FPRD :PT
C5103
0.1
25V
B:CHIP
1
2
3
4
6
7
8
9
B-SS9017<U/C>-L..
CN5004
4P
WHT
:S-MICRO
D5403
MA153 R5421
R5417 R5407
4.7
18k
C5410
:CHIP :CHIP
47
25V
R5423
C5409
220k
:CHIP 0.1 25V B:CHIP
6
L
6
1
7
1
C5108
0.1
25V
B:CHIP
C5107
0.1
:PT
1
2
3
4
5
6
7
8
9
10
R5115
22
2W
:RS
R5116
10k
:CHIP
R5415
100
2W
:RS
R5411
4.7
:CHIP
8
C5109
0.1
25V
B:CHIP
IC5101
LCC COILS
C5104
0.1 25V B:CHIP
9
R5108
4.7
:CHIP
2.8
2.8
CN5003
10P
WHT
:S-MICRO
R5113
10k
:CHIP
R5111
4.7
:CHIP
R5414
100k
:FPRD
C5406
0.1
C5404
25V
0.1
B:CHIP R5406
39k
25V
:CHIP B:CHIP
R5409
4.7
:CHIP
C5106
0.1
25V
B:CHIP
R5206
22
1W
:RS
R5117
4.7
:CHIP
R5413
100k
:CHIP
R5319
10k
:CHIP
R5114
100k
:FPRD
R5109
4.7
:CHIP
C5105
47
25V
D5401
MA153
C5401
R5410 0.1 R5412
47k
1.5
25V
:CHIP B:CHIP :FPRD
C5310
47
25V
R5320
1.5
:FPRD
C5311
0.1
:PT
R5322
22
2W
:RS
C5101
0.1
25V R5112
B:CHIP 1.5
:FPRD
R5505
5.6k
:CHIP
R5402
1.5
:FPRD
C5303
0.1
25V
B:CHIP
R5321
100k
:FPRD
D5101
MA153
IC5101
LA6510
AMP
R5504
68k
:RN-CP
R5401
1.5
:FPRD
C5309
0.1
25V
B:CHIP
R5317
4.7
:CHIP
5
6
D5303
MA153
H
Pin No. Voltage [V]
GS5001
6
1
R5308
4.7
:CHIP
D5501
UDZ-4.7B
7
+
8
-
9
R5502
18k
:RN-CP
R5315
22
2W
:RS
C5304
0.1
25V
B:CHIP
10
10
R5416
15k
:CHIP
AC INLET
R5309
4.7
:CHIP
7
IC5301
LA6510
AMP
R5202
1.5
:FPRD
R5408
4.7
:CHIP
TO D BOARD
CN504
6
R5011
10k
:CHIP
C5005
47
25V
1
2
3
4
5
6
7
8
9
(POWER SUPPLY)
1
5
-15V
VDR602
4
C5009
0.1
25V
B:CHIP
R5003
0
:CHIP
+15V
0.3
11.7
4
C5003 C5002
100
22
16V
1
2
3
4
5
6
TO D BOARD
CN520
+15V
GND
-15V
GND
LCC-RB
LCC-RT
LCC-LB
LCC-LT
LCC-NS
R5006
10k
:CHIP
C5004
47
25V
R5001
1.5
:FPRD
CN5002
6P
WHT
:S-MICRO
B
C
Q683
R5009
0
:CHIP
3
VCC
R5008
R5007 0
1k :CHIP
:CHIP
2
R5010
0
:CHIP
R5311
4.7
:CHIP
Ref.
C5307
0.1
:PT
R5314
100k
:FPRD
R5313
10k
:CHIP
C5306
0.1
25V
B:CHIP
V.S2
R5005
39k
:CHIP
GND
H CONV
V CONV
VX
VY
GND
R5312
1.5
:FPRD
C5305
47
25V
D5002
MA151WK
TO D BOARD
CN512
Q682
B
C
0.9
0.3
8
• L BOARD
VOLTAGE LIST
D5301
MA153
C5301
0.1
25V
B:CHIP
GS5001
R5015
1k
:CHIP
CN5001
9P
WHT
:S-MICRO
Q681
R699
22k
:CHIP
B
C
14 13 12 11 10 9
R5310
10k
:CHIP
OUT1
8.7
102.4
0.2
R5012
0
:CHIP
C5008
47
25V
0.8
0
1
2
R668
47
+15V
Q641
B-SS3414<U/C>-G..
M
G
D
S
STBY+8V
R696
180
:RN-CHIP
5
2
Q640
R680
10k
:CHIP
C682
4.7
3
3
Q681
2SC2458
POWER SW
Q683
2SA1309A
PROTECT
IC690
SI-3050F
HEATER REG
C692
1200
10V
IC660
TOP223Y
REG SW
R693
4.7k
:CHIP
2
L691
22µH
C690
47
25V
Q690
2SC3311A
RELAY DRIVE
R681
1k
:CHIP
R688
10k
:CHIP
D692
1SS119
5
F601
6.3A
Q610
Q615
C684
0.01
:PT
R686
1k
:CHIP
T660
SRT
C660
120
25V
T601
:LFT
R692
68
1/2W
R687
1k
:CHIP
FB612
0.45UH
+15V
6
1.3
0.1
0
0.1
D684
RD22ESB2
C681
4.7
5
D660
P6KE200AG23
D661
UF4005PKG23
R683
100
:CHIP
Q682
2SA1309A
POWER SW
C646
0.15
:MPS
1
RY602
1
2
3
4
PH680
TO A BOARD
CN405
D678
1SS119
3
R631
100
R604
150
1/2W
C604
1.0
250V
CN672
9P
WHT
:S-MICRO
PS673
2.0A
D677
1SS119
C645
0.15
:MPS
4
L
1
PH680
PC123FY2
R601
330k 1/2W :SURGE
3
-15V
4
PRT
3
2
C678
47
25V
R5013 0 :CHIP
V.S1
2
3
T641
R635
10k
:CHIP
R661
3.3
:FPRD
4
PS670
2.0A
PS671
2.0A
C680
D674
D2S4MTA1 REG(-) 2200
10V
VDR601
1
C676
47
25V
5
R632
10k
:CHIP
C602
470p
250V
C603
1.0
250V
4.5
3.3
6.1
16.7
+
K
L673
22µH
R646
10k
:CHIP
TO GA BOARD
CN7501
C601
470p
250V
1
2
3
4
PH660
VEE
LVP
TO J BOARD
CN891
+15V
+200V
NC
+80V
GND
+15V
STBY+8V
GND
NC
HEATER+
R5301
1.5 :FPRD
R5302
1.5 :FPRD
-
OVP
5.0
6.7
5.3
OUT2
AC SENSE
1
2
3
2
3
4
+
L SENSE
IC690
-
V SENSE
C677
2200
25V
C679
D673
D2S4MTA1 REG(+) 2200
10V
Q615
2SA1037AK
VCC SW
6
VCC
D683
1SS119
Q642
2SC3311A
REG SW
7
R663
10k
Q660
:CHIP
2SC3311A
RELAY DRIVE
D663
RD12ESB2
8
RY601
C675
2200
25V
C685
47
D640
MA111
9
I SENSE
C616
47
25V
C643
0.33
:MPS
1
2
3
4
5
6
7
8
9
12
R695
D682 0.47
D1NL20 :FPRD
10
DRIVE
C642
0.33
:MPS
6.1
410.0
VCC
R645
22k
:CHIP
L672
22µH
1
IN
OUT
V.S2
R629
47k
:RN
+15V
GND
C663
22
AC L OUT
NC
AC L IN
R621
330k
:RN
R647
100k
R651
2.2
1W
:RS
R675
1
1/2W
:FPRD
D672
D4SBS4
+15V REG
11
C647
0.027
630V
:PP
R648
2.2
1W
:RS
IC660
OUT1
GND
R644 R655
220k 10k
:CHIP :CHIP
R620
470k
:RN
1
R618
220k
:RN
R662 C662
10k 0.1
:CHIP :PT
R619
470k
:RN
CN610
10P
B-TO-B
VDR640
Q641
2SA1309A
REG SW
2.5
11.6
TO D BOARD
CN502
R652
2.2
1/2W
:RF
C640
470p
500V
:HR
3
4
V.S1
R612
220k
:RN
I
CN605
3P
R643
22k
10
IC630
VCC
R625
4.7
R613
220k
:RN
J
9
2
D614
UDZ-TE-17-10B
D613
RD18ESB2
TH601
R642
100k
1W
:RS
C674
4.7
100V
C673
330
100V
D671
D1NL20-TR
R650
100k
1W
:RS
PS674
2.0A
C607
470p
250V
+80V
G
Pin No. Voltage [V]
VEE
R617
330k
:RN
15V
L671
22µH
8
R633
330k
:RN
R611
0.33
3W
:RS
C672
3.3
250V
Ref.
VO
R623
1k
C671
220
250V
7
H CENT H
H CENT N
H CENT L
+200V
+200V
NC
+80V
GND
+15V
GND
-15V
VT(-)
C612
0.47
R610
0.33
3W
:RS
+200V
-
H
1
2
3
4
5
6
7
8
9
10
11
+
R622
1k
R674
0.47
:FPRD
6
R641
100k
1W
:RS
R628
330k
:RN
R673
470
:FPRD
VEE
R624
6.8k
R616
150k
:RN
R626
10k
R649
100k
1W
:RS
3
S
D670
D4SBL40
+200V REG
L670
22µH
Q640
MX0841AB-F C641
REG OUT 470p
START-UP 500V
:HR
R627
270k
:RN
C670
0.01 :PT
5
• G BOARD
VOLTAGE LIST
OUT2
Q610
2SK2195
BOOST CONV OUT
R615
150k
:RN
C611
330
450V
CN671
11P
WHT
:S-MICRO
1
-
C606
0.0047
250V
4
FB611
0.45UH
C610
1.0
400V
R614
150k
:RN
D611
D5L60
2
VCC
FB610
0.45UH
L611
68µH
R640
0.1
1/2W
:RF
3
R671 C683 R672
470k 2200p 1k
:CHIP 500V :CHIP
V.S2
8
3
4
5
1
C605
0.0047
250V
G
4
T640
PIT
VT(+)
15
14
13
12
11
10
9
5
D610
D4SB60L
AC RECT
+
R676
470
L610
F
B-SS3414<U/C>-J..
OUT1
1
CN601
TAB
B-SS9057<AEP>-H..
V.S1
GND
J(POWER SW)
D612
RM11A
R5422
68
2W
:RS
O
O
Schematic diagrams
G(ga)
H
(ga)H
JL boards l
Schematic diagram
Ò D board
5-17
5-18
5-19
5-20
G
POWER SUPPLY
H
USER CONTROL
(ga)
L
POWER SENSOR
— G BOARD —
— L BOARD (Conductor Side) —
V.STAT, H.STAT, LLC,
GEO MAGNETIC SENSOR
— L BOARD (Component Side) —
G BOARD
Terminal name of semiconductors
in silk screen printed circuit (*)
Ref.
*
Q615, Q680, Q691
1
D614, D617, D640,
D666, D680, D681,
D693
3
*: Refer to Terminal name of
semiconductors in silk screen
printed circuit (see page 5-9)
— GA BOARD —
GA BOARD
Terminal name of semiconductors
in silk screen printed circuit (*)
Ref.
Q7501–Q7504
*
1
*: Refer to Terminal name of
semiconductors in silk screen
printed circuit (see page 5-9)
L BOARD
Terminal name of semiconductors
in silk screen printed circuit (*)
Ref.
— H BOARD —
A
B
C
D
E
F
G
H
*
D5501
3
D5101, D5103,
D5201, D5301,
D5303, D5401,
D5403
6
D5002
8
*: Refer to Terminal name of
semiconductors in silk screen
printed circuit (see page 5-9)
Schematic diagram
A
5-21
5-22
5-23
board
l
(3) Schematic Diagram of A Board
GND
R_IN1
H_IN1
V_IN1
VS.OUT
GND
SW
R128
1M
:CHIP
C121
0.01
B:CHIP
R139
10k
:CHIP
C130
0.01
B:CHIP
C403
47
25V
R473
10k
:CHIP
C410
0.01
B:CHIP
NC
NC
OSDB_DRV
B_GND1
B_GND2
G_VCC1
G_OUT
G_IN
G_VCC2
G_DRV
G_HOLD
G_OSD
OSDG_DRV
G_GND1
G_GND2
R_VCC1
R_OUT
R_IN
R_VCC2
R_DRV
R_HOLD
NC
NC
NC
NC
NC
NC
NC
OSDR_DRV
R_OSD
NC
R_GND1
R_GND2
MAIN CONT
BLK
CLP
BRT
CN403
8P
WHT-L
:S-MICRO
1
2
3
4
5
6
7
8
R426 C431
100
0.01
:CHIP B:CHIP
R427
100
:CHIP
1
2
3
4
5
6
7
R214
270
:CHIP
R433
100
:CHIP
35.0 Vp-p (H)
9
CLK
NC
VDD
NC
CLK
AO7
LD
AO8
MISO
C451 C452
10 0.01
B:CHIP
B_DRV
BRT
AO2
R132
R116
270
47
:CHIP
:CHIP
AO9
AO12
AO10
AO11
VDD
Vcc
C466
10
NC
NC
NC
NC
NC
NC
NC
NC
PWM0
PWM1
CN2
8P
KB
GND
KG
GND
KR
GND
HEATER +
GND
KB
GND
KG
GND
KR
GND
HEATER +
GND
1
2
3
4
5
6
7
8
R117
3.9k
:CHIP
FV
FGND
G1
3
1
FC 13
10
G2
Q101
2SA1738
BUFFER
VCC
R_OUT
+200V
R330
100k :CHIP R333
1k
R337 :CHIP
100k :CHIP
R329
1M :RN-CP
R367
1M :CHIP
C320
2.2
200V
R325
56k
:RN-CP 2
12V
4
FB201
0
:CHIP
H
H1
4 H2
5
SG401
6 GND
Ref.
IC402
1.1
2.8
3.7
1.1
2.8
3.8
1.1
2.8
3.9
1.1
3.3
0.7
2.4
1.2
4.4
2.7
4.4
2.7
4.4
2.7
2.1
1
2
3
5
6
7
8
10
11
12
13
3.4
2.8
53.6
52.7
2.9
3.4
9.8
9.8
3.5
2.9
52.3
Q101
B
E
2.8
3.5
Q105
B
C
7.3
112.6
HV
TO D BOARD
FBT
*V901
9
SG201
21SRG
SG101
SG402
C417
10000p
2kV
F
R418
220k
1/2W
C115
0.22
250V
R121
100k
:CHIP
L101
0.15µH
:ALI
(G2)
G2
FB101
0
:CHIP
C485
10
250V
D105
1SS376
R334 100k :CHIP
+80V
R336 100k :CHIP
B_CUTOFF
D104
1SS376
Q306
2SA10910
BUFFER
IC406
TA7812S
12V REG
12V
Q305
2SC4015
B CUT OFF
AMP
3
PS401
R461 1A
100k
O +12V I
G
C465
10
FB405 C460
1.1UH 1000p
500V
B
R479
1
:FPRD
R480
1
:FPRD
C461
0.01
B:CHIP
IC408
TA78L05S
5VREG
5V
CN405
9P
WHT-L
:S-MICRO
C484
1000p R478
500V
1
B
:FPRD
FB406
1.1UH
+200V
1
2
3
4
5
6
7
8
9
TO G BOARD
CN672
11
R326 R308
100k 120k
:CHIP :CHIP
IC409(1/4)
LM324M-FL63
R230
B CUT OFF 100k :CHIP R233
1k
R229 AMP
R340
2.2M
:CHIP
:CHIP
R237
100k :CHIP
1M :RN-CP
R267
1M :CHIP
C220
2.2
200V
R234 100k :CHIP
R231
2.2k
:CHIP
Q206
2SA1091O
BUFFER
R209
270k
:CHIP
R137
:CHIP
100k :CHIP
1M :RN-CP
R167
1M :CHIP
C217
0.01
B:CHIP
C120
2.2
200V
C434
0.001
500V
:B
12V
R470
4.7k
:CHIP
OSD_CONT
8
R126
100k
:CHIP
R108
120k
:CHIP
C127
0.01
B:CHIP
R109
270k
:CHIP
R131
2.2k
:CHIP
10
12V
R140
2.2M
:CHIP
C471
1000p
500V
B
FB403
1.1UH
C487
10
C486
0.01
B:CHIP
R456
47k
:CHIP
R134 100k :CHIP R471
6.8k
R136 100k :CHIP :CHIP
R_CUTOFF
+200V
IC409(3/4)
LM324M-FL63
R CUT OFF
AMP
1
2
R459 R458
10M 2.2M
1W
1W
:RN :RN
23
12V
Q410
2SC5022-02 R442
G2 CONT 2.2k
C457
0.01
B:CHIP
B
CN406
2P
WHT
:VH
1KV
N.C.
Ref.
Pin No. Voltage [V]
E
6.8
Q106
B
E
112.6
113.3
Q201
B
E
2.7
3.5
Q205
B
C
E
7.4
109.9
6.8
Q206
B
E
109.9
110.4
Q301
B
E
2.7
3.4
Q305
B
C
E
7.4
113.1
6.8
Q306
B
E
113.1
113.7
Q401
B
C
E
3.6
0.7
4.3
Q406
B
E
7.9
9.0
Q410
B
C
E
9.7
484.0
9.1
SK401
KR
KG
KB
G2
H2
87.0
87.0
87.0
474.0
6.5
C
D
E
F
TO D BOARD
CN507
C478
4700p
2kV
F
C479
470p
:CHIP
Q106
2SA1091O
BUFFER
• A BOARD
G
IC402 M52722P
D408
MA111
:RN-CP
Q105
2SC4015
R CUT OFF
CONT
R462
47k
:CHIP
15V
+5V
R457
10M
1W
:RN
12V
12V
R125
56k
:RN-CP 9
C463
0.01
B:CHIP
1KV
IC409(2/4)
LM324M-FL63
R130
G CUT OFF 100k :CHIP R133
1k
R129 AMP
R240
2.2M
:CHIP
C468
10
R236 100k :CHIP
G_CUTOFF
Q205
2SC4015
G CUT OFF
CONT
5
12V
R226 R208
100k 120k
:CHIP :CHIP
O +5V I
G
C469
10
IC403
+200V
NC
+80V
GND
+15V
STBY+8V
GND
NC
HEATER+
Pin No. Voltage [V]
1
3
4
9
12
13
14
17
18
23
25
26
27
28
35
37
40
42
49
51
52
KB KR G2 G4
KG G1 GM
L402
22µH
7 KR
8
KG
8
C464
10
R331
2.2k
:CHIP
22
• A BOARD VOLTAGE LIST
V901
PICTURE
TUBE
R221
100k
:CHIP
D204
1SS376
L201
0.15µH
:ALI
9
KB
GND
C419
1000p
500V
D405
MA111
D406
MA111
C420
47
C421
10
C424
Q408
0.1
DTA124EKA
25V
Q409
B:CHIP
SW
2SC2412K
SW
D409
R451
MA111
100
:CHIP
R452
4.7k
:CHIP
R453
10k
:CHIP
R454
10k
:CHIP
13
12
C481
D407 0.01
MA111 B:CHIP
R463
120k
:CHIP
R464
2.2k
:CHIP
14
IC409(4/4)
LM324M-FL63
G2 CONT
R419
33k
:RN-CP
R420
47k
:RN-CP
12V
R466
10k
:RN-CP
C454
100
25V
R428
1k
:CHIP
H
Q406
DTA124EKA
G2 CONT
B-SS9030<NH.>-A..-05
35.0 Vp-p (H)
21
TO D BOARD
T902(FBT)
RCV
SK401
D404
1SS376
D107
1SS376
D103
MA111
CONT
20
SG301
7
D205
1SS376
R111
2.2k
:CHIP
D106
1SS376
I
I
37.0 Vp-p (H)
5
J
FOCUS2
FOCUS1
R324
22 1/2W :SURGE
R224
22 1/2W :SURGE
R124
22 1/2W :SURGE
CN1
8P
R120
100k
:CHIP
7
C467
0.01
B:CHIP
D304
1SS376
C215
0.22
250V
R211
2.2k
:CHIP
R113
22
:CHIP
C111
4700p
B:CHIP
G2
19
(GND)
R220
100k
:CHIP
D207
1SS376
R119
22
:CHIP
R225
56k
:RN-CP 6
11 12 13 14 15 16 17 18 19 20
1
2
3
4
5
AO6
6
24
23
G_DRV
22
VFLB
MOSI
R321
100k
:CHIP
C112
0.1
25V
B:CHIP
D303 D203
MA111 MA111
21
MOSI
INT
AO1
AO5
7
25
B_CUTOFF
20
5
SS
FBKG
AO4
8
26
G_CUTOFF
R_DRV
HFLB
AO3
10 9
B
R_CUTOFF
GND
18
A
GND 11
12V
Vss
17
(G2)
C317
0.01
B:CHIP
28
4
VDDA
D306
1SS376
D307
1SS376
R319
22
:CHIP
D206
1SS376
1
27
1
2
3
G
C315
0.22
250V
1
2
3
4
5
6
7
8
FB301
0
:CHIP
0.15µH
:ALI
R104 R102
100 100
:CHIP:CHIP
R219
22
:CHIP
+200V
R320
100k
:CHIP
D305
L301 1SS376
Q201
2SA1738
BUFFER
12V
19
R432
100
:CHIP
R
RP
VSS
16
12V
IC410
M62352GP-75ED
D/A CONVERTER
18
R441
100
:CHIP
VCO
6
R430
100
:CHIP
VSSA
7
R431
100
:CHIP
R436
5.6k
:CHIP
R438
1.5k R439
:CHIP 1.5k
:CHIP C409
22p
C448
0.1
CH:CHIP
25V
C450
B:CHIP
22p
CH:CHIP
C447
0.1 25V B:CHIP
R_E.P.
R118 R112
39
2.2k
:CHIP :RN-CP
17
C444
47p
CH:CHIP
R429
100
:CHIP
C459
22
100V
C483
0.1
:CHIP
R311
2.2k
:CHIP
R213
22
:CHIP
R115
270
:CHIP
C414 R415
5p
4.7k
CH:CHIP :CHIP
R_IN
9 10 11 12 13 14
C489
0.1
25V
B:CHIP
R227
270
:CHIP
R232
R216 270
47 :CHIP
:CHIP
(GND)
C415
47
100V
C482
0.1
:CHIP
R444
2.2k
:CHIP
R215
270
:CHIP
R110
0
:CHIP
VBB
VBB
R202
100
:CHIP
R443
470
:CHIP
C212
0.1
25V
B:CHIP
C211 R114
4700p 270
B:CHIP :CHIP
R416
1k
:CHIP
GND
G_IN
R223
120
:CHIP
12V
R210
0
:CHIP
R413
4.7k
:CHIP
Q405
D403
MA111 2SB709A
BUFFER
STBY+5V
C446
IC404
0.1
LSC4380DW2R2
25V
OSD
B:CHIP
16
4
R222
120
:CHIP
R302
100
:CHIP
12V
R421
180k
:CHIP
6
+80V
R312
68
R141
:RN-CP 100
:CHIP
R323
C310
C309
22p
120
1000p
:CHIP CH:CHIP CH:CHIP
12V
5V
L401
100µH
15
3.0 Vp-p (H)
8
R309
270k
:CHIP
8
C442
47p
CH:CHIP
8
3
7
R127
270
:CHIP
Q402
2SC2412
G SYNC
9
H
6
R437
100µH
C438
47p
CH:CHIP
35.0 Vp-p (H)
Q403
2SB709A
G SYNC
5
:CHIP
R335
330
:CHIP
D401
MA111
R423
47k
:CHIP
4
R318
2.2k
:CHIP
D410
MA111
C491
0.01
B:CHIP
C407 C408
0.01
10 B:CHIP
C405
10p CH:CHIP
R410
1k
:CHIP
R435
1M
:CHIP
C455
47p
CH:CHIP
35.0 Vp-p (H)
R411
4.7k
:CHIP
Q401
2SB709A
G SYNC
C416
47
25V
C440
47p
CH:CHIP
7
R409
1k
:CHIP
10
2
37.0 Vp-p (H)
R322
120
:CHIP
C488
47
25V
C122
0.1
25V
B:CHIP
3
R241 R204
100 100
:CHIP:CHIP
C311
4700p
B:CHIP
C108
2.2
2
R122
120
:CHIP
R123
120
:CHIP
12V
R446
100
:CHIP
C436
47p
CH:CHIP
3.0 Vp-p (H)
R408
100k
:CHIP
C435
0.01
B:CHIP
TO D BARD
CN503
G
R407
47k
:CHIP
11
6
R317
3.9k
:CHIP
R417 C453
47k 0.01
:CHIP B:CHIP
Q404
DTC124EKA
ASC SW
R406
1k :CHIP
R434
4.7k :CHIP
R412
1.5k
:CHIP
12
1
C404
10
R425 C429
47
10p
:CHIP CH:CHIP
13
• A BOARD WAVEFORMS
R310
0
:CHIP
C208
2.2
12V
R424
100
:CHIP
CN407
7P
WHT-L
:S-MICRO
ASC_SW
OSD_SEL
MOSI
CLK
DAC_SEL
HFBP
VRET
R440
47k
:CHIP
R422
100
:CHIP
TO D BARD
CN506
F
R235
330
:CHIP
R341
100
:CHIP
5
1
Q301
2SA1738 R304
BUFFER 100
D402
UDZ-TE-17-5.1B
14
E
C222
0.1
25V
B:CHIP
R332
R316 270
47 :CHIP
:CHIP
R217
3.9k
:CHIP
R477
22k
:CHIP
CLP
LOWB_DET
C.BLK
GREEN
GND
INPUT SW
GND
VIDEO
R135
330
:CHIP
C308
2.2
3
C109
27p
CH:CHIP
C221
0.01
B:CHIP
C230
0.01
B:CHIP
NC
R313
22
:CHIP
4
G_E.P.
B_OSD
NC
R327
270
:CHIP
2
G_OUT
NC
B_HOLD
1
R315
270
:CHIP
GND
NC
B_VCC2
C322
0.1
25V
B:CHIP
B_OUT
NC
B_OUT
15
C BLOCK
C110
1000p
CH:CHIP
C107
0.1
25V
B:CHIP
C330
0.01
B:CHIP
OSD CONT
R314
270
:CHIP
14
13
IC403
FA4111
RGB OUT
C210
R218
1000p CH:CHIP 2.2k :CHIP
C209
R212
27p CH:CHIP 56 :RN-CP
C106
0.01
B:CHIP
C458
10 12V
50V
C312
0.1
25V
B:CHIP
B_E.P
B:CHIP
R475
10k
:CHIP
12
B_IN
36
31
30
29
25
NC
HS.OUT
1
NC
R228
1M
:CHIP
28
26
G.SYNC
VCC
2
D302
1PS226-115
GND
G_IN1
R243
560
:CHIP
27
GND
R_OUT
NC
35
33
34
2
4
7
B_IN1
3
R303
75
C103
:RN 0.01 B:CHIP
C104
47 25V
C303
0.01 B:CHIP
C304
47 25V
D
GND
4
5BNC
D202
1PS226-115
R_VCC2
5
R306
47
:CHIP
V_IN2
B_DRV
6
R203
75
:RN
C203
0.01 B:CHIP
C204
47 25V
R
3
1
R206
47
:CHIP
GND
B_IN
7
B
C401
10
G_OUT
C321
0.01
B:CHIP
Q202
2SC3545
BUFFER
R239
C207 10k
0.1 :CHIP
25V
B:CHIP
24
G
R103
75
:RN
H_IN2
R328 C319
1M
47
:CHIP 25V
23
R
C206
0.01
B:CHIP
22
1
2
3
4
5
6
8
6
D102
1PS226-115
G_VCC2
R_IN2
9
D301
1SS226-TE85L
R106
47
:CHIP
NC
5V
R305
47
:CHIP
R301
82
:RN
NC
R_VCC1
B_VCC1
8
G
R201
82
:RN
C307
0.1
25V
B:CHIP
21
R IN 1
R GND 1
G IN 1
G GND 1
B IN 1
B GND 1
G_IN2
10
HD15
NC
OSDBLK
26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
B
B
C105
0.01
B:CHIP
R205
47
:CHIP
GND
R339
10k
:CHIP
C306
0.01
B:CHIP
11
IC402
C412
M52722P RGB DRIVE 0.01
+12V
20
HD
G
R101
82
:RN
CN401
6P
WHT-L
:S-MICRO
TO D BOARD
CN511
VD
R
G_VCC1
B_OUT
11
C
5
4
3
2
1
10 9
8
7
6
15 14 13 12 11
1
2
3
4
5
6
7
C205
0.01
B:CHIP
R105
47
:CHIP
B_VCC2
B_IN2
13
B
R IN 2
R GND 2
G IN 2
G GND 2
NC
B IN 2
B GND 2
C302
47 16V
B_VCC1
5
D101
1SS226-TE85L
D201
C301
0.01 B:CHIP
1SS226-TE85L
10
+12V
32
C305
0.01
B:CHIP
12
CONNECTOR
RANEL
IC401
5V
M52755FP-TP RGB PRE-AMP
9
STBY+5V
C402
47
25V
C201
0.01 B:CHIP
C202
47 16V
CN402
7P
WHT-L
:S-MICRO
8
27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52
+5V
C101
0.01 B:CHIP
C102
47 16V
14
A
7
6
19
5
15
4
16
3
17
2
18
1
A
(VIDEO AMP,RGB OUT)
J
3.0 Vp-p (H)
5-24
5-25
5-26
A
VIDEO AMP
RGB OUT
— A BOARD (Conductor Side) —
• A BOARD
SEMICONDUCTOR
LOCATION
— A BOARD (Component Side) —
IC
1
2
3
1
Component
( Conductor
Side ) ( Side )
IC401
IC402
IC403
IC404
IC406
IC408
IC409
IC410
B–3
B–3
A–1
A–1
2
A–1
B–1
B–1
A–2
A–3
A–3
C–1
A–2
A
A
TRANSISTOR
Component
( Conductor
Side ) ( Side )
Q101
Q105
Q106
Q201
Q202
Q205
Q206
Q301
Q305
Q306
Q401
Q402
Q403
Q404
Q405
Q406
Q408
Q409
Q410
B
B–3
D–3
D–3
B–3
A–3
C–3
C–3
B–3
C–3
C–3
A–2
*
D–1
D–1
C–1
C–1
C–1
C–1
A–1
A–2
B–2
B–2
D–1
D–3
D–3
D–1
D–3
1
–
–
1
1
–
–
1
–
–
1
2
2
2
2
1
1
1
–
B
DIODE
Component
( Conductor
Side ) ( Side )
D101
D102
D103
D104
D105
D106
D107
D201
D202
D203
D204
D205
D206
D207
D301
D302
D303
D304
D305
D306
D307
D401
D402
D403
D404
D405
D406
D407
D408
D409
D410
C
D
A–1
A–1
B–3
C–1
C–3
B–3
B–3
A–1
A–1
B–3
C–1
C–3
B–3
B–3
A–2
A–1
B–3
C–1
C–2
B–2
B–3
B–2
B–3
B–2
C–3
D–3
D–3
D–1
D–1
D–1
B–2
*
7
7
3
3
3
3
3
7
7
3
3
3
3
3
7
7
3
3
3
3
3
3
3
3
3
3
3
3
3
3
3
C
D
*: Refer to Terminal name of
semiconductors in silk screen
printed circuit (see page 5-9)
NOTE:
The circuit indicated as left contains high voltage of over
600 Vp-p. Care must be paid to prevent an electric shock in
inspection or repairing.
5-27
5-28
3
5-4. SEMICONDUCTORS
BA9756FS-E2
M62352GP-75E
M62352GP-75ED
LA6510
NJM4558M
µPC4558G2
24LC16BT/SN
24LC21AT/SN
µPC1093J
2SA1091-O
2SC2362K-G
1
1
10
TOP VIEW
1
8 pin SOP
LA7841L
CXA2043Q
48
µPC78L05J
2SA1175-HFE
2SA1309A-QRSTA
2SC2784
2SC2785-HFE
2SC3311A-QRSTA
MARKING SIDE VIEW
NJM78L05A
NJM78L09A
TA78L05S
TA78L09S
37
1
36
1
13
24
TOP VIEW
LM324M
TC74HCT04AF
CXA2044M-T6
LSC4380DW2R2
3
1
2
1
NJM78M09FA
TA7805S
TA7812S
TOP VIEW
14 pin SOP
TOP VIEW
28 pin SOP
MB90553PF-G-120-BND
80
DM-60
51
81
50
INDEX
1
N
LETTER SIDE
7 pin SIP
25
12
1
E C
B
TOP VIEW
20 pin SOP
31
100
1
MARKING SIDE VIEW
• pin
1 N=5
• Mt (one side, both side)
DTA114GKAT146
DTA124EKA-T146
DTC114GKA
DTC114GKAT146
DTC124EK
DTC124EKA-T146
2SA1036K-Q
2SA1036K-T-146-Q
2SA1037AK-T146-QR
2SA1037AK-T146-R
2SA1037K-T-146-QR
2SA1162G
2SA1462-Y33
2SA1738-TX
2SB709A-QRS-TX
2SC1623-L5L6
2SC2411K-CQ
2SC2411K-T-146-CQ
2SC2412K-T-146-QR
2SC3545-T43
E C
B
2SA1358-Y
2SC3421-Y
EC
B
2SC2362KG-AA
SI-3050F
C
30
B
E
MC33262P
MM1170BFB
FA4111
1
3
E C
B
2
MARKING SIDE VIEW
1
4 5
2SC3209LK
MX0841AB-F
TOP VIEW
TC7W04FU
8 pin DIP
1
14 pin SIP
E C
B
M52722P
LA6500-FA
1
5 pin CHIP
1
TOP VIEW
52 pin DIP
TOP223Y-BB
2SA1049-GR
2SC2458-YGR
2SC2459-GR
1
5
M52755FP-TP
SOURCE
CONTROL
1
DRAIN
TOP VIEW
36 pin SOP
5-29
E
C
B
2SC3746
2SC5022-02
2SJ449
2SJ449 (1)
2SJ449 (2)
2SC4015TV2
2SC5047-CA
DTZ-TT11-16B
DTZ10B
DTZ13B
DTZ24B
DTZ33B
DTZ4.7C
DTZ5.1B
MA111
RD12SB2
RD5.6SB
UDZ-TE-17-10B
UDZ-TE-17-12B
UDZ-TE-17-13B
UDZ-TE-17-16B
UDZ-TE-17-24B
UDZ-TE-17-33B
UDZ-TE-17-4.7B
UDZ-TE-17-5.1B
UDZ-TE-17-5.6B
UDZ-TE-17-6.2B
D5LC20U
P6KE200AG23
CATHODE
ANODE
EGP20G
ERA34-10
RGP02-17EL-6433
RGP02-17PKG23
RGP02-20EG23
RGP02-20EL-6394
RGP15GPKG23
UF4005PKG23
RD6.2M-B1
B
C
CATHODE
E
2SK1120LBSONY2
2SK2098-01MR
RM11A
RM11C
ANODE
CATHODE
ANODE
G
D
S
2SK2195F04
D1NL20-TR
GMA01
RD12ES-B2
RD16ES-B2
RD16ES-B3
RD18ES-B2
RD22ES-B2
RD5.1ES-B2
RD6.2ESB2
1SS119-25TD
1SS119-25
1SS120TD
E
CATHODE
C
CATHODE
FMQ-G5GS
D5L60
ANODE
SB560
CATHODE MARK
MA151WK
1SS184
B
YG911S3R
AG01A-V0
ERA91-02
S2LA20F
ANODE
CATHODE
D2S4MF
D2S4MTA1
CATHODE
CATHODE
MA153-TX
1SS226
ANODE
ANODE
1PS226-115
ANODE
D4SBS4
D4SBS4-F
D4SBL40
D4SB60L
PC123F2
PC123FY2
1SS376TE-17
+
~
~
ANODE
–
+
~
~
–
CATHODE
5-30
MCM 21T1
SECTION 6
EXPLODED VIEWS
• Items with no part number and no
description are not stocked because they
are seldom required for routine service.
• The construction parts of an assembled
part are indicated with a collation number
in the remark column.
• Items marked " * " are not stocked since
they are seldom required for routine
service. Some delay should be
anticipated when ordering these items.
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
6-1. CHASSIS
4
p
®
¢
7-685-647-79
7-685-663-71
7-685-872-09
7-685-881-09
+BVTP 3X10
+BVTP 4X16
+BVTT 3X8
+BVTT 4X8
24
23
25
17
16
14
15
18
23
28
13
6
22
11
12
9 10
26
8
27
20
7
18
17
5
21
4
2
3
REF.NO. PART NO.
19
1
DESCRIPTION
BEZEL ASSY
BUTTON, POWER
SPRING, COMPRESSION
H BOARD, COMPLETE
SCREW (3X12), (+) BVWHTP
REMARK
REF.NO. PART NO.
1
2
3
4
5
* X-4035-957-1
* 4-061-970-51
4-042-593-01
* 8-933-283-00
4-029-432-01
2, 3
15
6
7
8
9
10
4-365-808-01
* 1-694-313-12
4-389-025-01
¡ 1-251-382-11
4-052-345-01
SCREW (5), TAPPING
TERMINAL BOARD ASSY, I/O
SCREW (M4) (EXT TOOTH WASHER)
INLET, AC 3P(WITH NOISE FILTE)
SCREW, (3X8) (+K), TAPPING
11
12
13
14
4-060-368-12
* 8-933-296-00
* 8-933-311-00
¡ X-4035-170-1
SHEET, CONNECTOR
A BOARD, COMPLETE
D BOARD, COMPLETE
TRANSFORMER ASSY, FLYBACK
(NX-4142//J1D4)
6-1
DESCRIPTION
REMARK
4-062-115-01 SCREW +P 3.5X20 TYPE2
16
17
18
19
20
* 4-060-359-01
* 3-701-903-11
* 4-382-848-01
* 3-703-141-00
* 8-933-277-00
HOLDER, PRINTED CIRCUIT BOARD
HOLDER, PRINTED CIRCUIT BOARD
HOLDER, PRINTED CIRCUIT BOARD
HOLDER, PRINTED CIRCUIT BOARD
G BOARD, COMPLETE
21
21
22
23
24
25
* 8-933-269-00
* 4-061-604-61
* 4-061-605-61
* 4-060-358-71
* 4-066-979-01
GA BOARD, COMPLETE
CABINET
COVER, SCREW
COVER, ECS
LABEL, INFORMATION
26
27
28
2-132-434-01 CLIP, WIRE
* 4-061-694-01 SHEET, INSULATE
* 4-063-711-01 SUPPORT, HV CABLE
MCM 21T1
6-2. PICTURE TUBE
p
¢
π
7-685-663-71
7-685-881-09
7-685-883-01
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
+BVTP 4X16
+BVTT 4X8
+BVTT 4X12
60
62
61
73
74
57
59
75
63
72
64
54
58
65
67
57
52
55
56
66
68
53
69
51
71
REF.NO. PART NO.
DESCRIPTION
REMARK
REF.NO. PART NO.
DESCRIPTION
70
REMARK
51
52
53
54
55
¡ 8-738-796-81 ITC ASSY (21SRG-R2)
52-54
¡ 1-452-932-11 NECK ASSEMBLY, PICTURE TUBE
¡ 8-451-493-41 DEFLECTION YOKE (Y21SRL-M4)
64
65
66
67
68
* 8-933-279-00
4-031-646-01
* X-4035-959-1
4-061-396-01
* 4-061-938-81
56
57
58
59
60
¡ 1-416-437-11 COIL, DEMAGNETIC
¡ 1-416-140-31 COIL, LANDING CORRECTION
¡ 1-416-438-31 COIL, LANDING CORRECTION
69
70
71
72
73
4-063-397-01
4-041-621-01
4-047-474-01
4-051-736-21
4-308-870-00
74
75
1-452-032-00 MAGNET, DISK ; 10mmφ
1-452-094-00 MAGNET, ROTATABLE DISK ; 15mmφ
61
62
63
4-050-492-01 SPACER, DY
* 4-047-316-01 SPRING, TENSION
4-062-670-01 SPACER, PICTURE TUBE
* 8-933-297-00 L BOARD, COMPLETE
* 4-321-929-00 HOLDER, PRINTED CIRCUIT BOARD
* 3-703-141-00 HOLDER, PRINTED CIRCUIT BOARD
* 4-061-603-71 COVER, BOTTOM
6-2
J BOARD, COMPLETE
SHAFT
STAND ASSY
STOPPER (A)
SLIDER
67-71
RING, TILT SWIVEL
STOPPER (B)
FOOT, RUBBER
PIECE A (90), CONV.CORRECT
CLIP, LEAD WIRE
MCM 21T1
6-3. PACKING MATERIALS
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
107
104 105
101
106
102
103
REF.NO. PART NO.
101
102
103
104
105
* 4-061-809-01
* 4-066-565-01
* 4-061-810-01
* 3-864-571-11
¡ 1-765-719-21
DESCRIPTION
REMARK
REF.NO. PART NO.
CUSHION (UPPER) (ASSY)
INDIVIDUAL CARTON
CUSHION (LOWER) (ASSY)
MANUAL, INSTRUCTION
CORD SET, POWER (10A/250V)
106
107
6-3
DESCRIPTION
REMARK
* 4-041-927-31 BAG, POLYETHYLENE
1-777-743-11 CABLE ASSY (15P D SUB X2
CONNECTOR)
MCM 21T1
MEMO
6-4
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
REF.NO. PART NO.
NOTE:
(a)
ELECTRICAL PARTS LIST
DESCRIPTION
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
When indicating parts by reference
number, please include the board name.
REF.NO. PART NO.
MCM 21T1
SECTION 7
REMARK
REF.NO.
PARThave
NO. • Items
DESCRIPTION
REMARK
• All variable
and adjustable
resistors
marked " * " are not stocked
since
characteristic curve B, unless otherwise they are seldom required for routine
service. Some delay should be
noted.
anticipated when ordering these items.
RESISTORS
• CAPACITORS
• All resistors are in ohms
• F : nonflammable
MF : µF
• COILS
UH : µH
DESCRIPTION
REMARK
REF.NO. PART NO.
* 8-933-296-00 A BOARD, COMPLETE
****************************
4-382-854-11 SCREW (M3X10), P, SW (+) (IC403)
<CAPACITOR>
C101
C102
C103
C104
C105
1-163-021-91
1-104-664-11
1-163-021-91
1-104-664-11
1-163-021-91
CERAMIC CHIP 0.01MF
ELECT
47MF
CERAMIC CHIP 0.01MF
ELECT
47MF
CERAMIC CHIP 0.01MF
10%
20%
10%
20%
10%
50V
25V
50V
25V
50V
C106
C107
C108
C109
C110
1-163-021-91
1-164-004-11
1-107-903-11
1-163-237-11
1-163-275-11
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.1MF
ELECT
2.2MF
CERAMIC CHIP 27PF
CERAMIC CHIP 0.001MF
10%
10%
20%
5%
5%
50V
25V
50V
50V
50V
C111
C112
C115
C120
C121
1-163-017-00
1-164-004-11
1-104-514-11
1-107-949-11
1-163-021-91
CERAMIC CHIP 0.0047MF
CERAMIC CHIP 0.1MF
FILM
0.22MF
ELECT
2.2MF
CERAMIC CHIP 0.01MF
10%
10%
10%
20%
10%
50V
25V
250V
200V
50V
C122
C127
C130
C201
C202
1-164-004-11
1-163-021-91
1-163-021-91
1-163-021-91
1-104-664-11
CERAMIC CHIP 0.1MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
ELECT
47MF
10%
10%
10%
10%
20%
25V
50V
50V
50V
25V
C203
C204
C205
C206
C207
1-163-021-91
1-104-664-11
1-163-021-91
1-163-021-91
1-164-004-11
CERAMIC CHIP 0.01MF
ELECT
47MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.1MF
10%
20%
10%
10%
10%
50V
25V
50V
50V
25V
C208
C209
C210
C211
C212
1-107-903-11
1-163-237-11
1-163-275-11
1-163-017-00
1-164-004-11
ELECT
2.2MF
CERAMIC CHIP 27PF
CERAMIC CHIP 0.001MF
CERAMIC CHIP 0.0047MF
CERAMIC CHIP 0.1MF
20%
5%
5%
10%
10%
50V
50V
50V
50V
25V
C215
C217
C220
C221
C222
1-104-514-11
1-163-021-91
1-107-949-11
1-163-021-91
1-164-004-11
FILM
0.22MF
CERAMIC CHIP 0.01MF
ELECT
2.2MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.1MF
10%
10%
20%
10%
10%
250V
50V
200V
50V
25V
7-1
DESCRIPTION
REMARK
C230
C301
C302
C303
C304
1-163-021-91
1-163-021-91
1-104-664-11
1-163-021-91
1-104-664-11
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
ELECT
47MF
CERAMIC CHIP 0.01MF
ELECT
47MF
10%
10%
20%
10%
20%
50V
50V
25V
50V
25V
C305
C306
C307
C308
C309
1-163-021-91
1-163-021-91
1-164-004-11
1-107-903-11
1-163-235-11
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.1MF
ELECT
2.2MF
CERAMIC CHIP 22PF
10%
10%
10%
20%
5%
50V
50V
25V
50V
50V
C310
C311
C312
C315
C317
1-163-275-11
1-163-017-00
1-164-004-11
1-104-514-11
1-163-021-91
CERAMIC CHIP 0.001MF
CERAMIC CHIP 0.0047MF
CERAMIC CHIP 0.1MF
FILM
0.22MF
CERAMIC CHIP 0.01MF
5%
10%
10%
10%
10%
50V
50V
25V
250V
50V
C319
C320
C321
C322
C330
1-107-888-11
1-107-949-11
1-163-021-91
1-164-004-11
1-163-021-91
ELECT
47MF
ELECT
2.2MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.1MF
CERAMIC CHIP 0.01MF
20%
20%
10%
10%
10%
25V
200V
50V
25V
50V
C401
C402
C403
C404
C405
1-126-964-11
1-104-664-11
1-104-664-11
1-126-964-11
1-163-227-11
ELECT
10MF
ELECT
47MF
ELECT
47MF
ELECT
10MF
CERAMIC CHIP 10PF
20% 50V
20% 25V
20% 25V
20% 50V
0.5PF 50V
C407
C408
C409
C410
C412
1-126-964-11
1-163-021-91
1-163-235-11
1-163-021-91
1-163-021-91
ELECT
10MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 22PF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
20%
10%
5%
10%
10%
C414
C415
C416
C417
C419
1-163-222-11
1-128-562-11
1-104-664-11
1-115-349-51
1-162-318-11
CERAMIC CHIP 5PF
ELECT
47MF
ELECT
47MF
CERAMIC
0.01MF
CERAMIC
0.001MF
0.25PF 50V
20% 100V
20% 25V
2KV
10% 500V
C420
C421
C424
C429
C431
1-126-967-11
1-126-964-11
1-164-004-11
1-163-227-11
1-163-021-91
ELECT
47MF
ELECT
10MF
CERAMIC CHIP 0.1MF
CERAMIC CHIP 10PF
CERAMIC CHIP 0.01MF
20% 50V
20% 50V
10% 25V
0.5PF 50V
10% 50V
C434
1-162-318-11 CERAMIC
0.001MF
50V
50V
50V
50V
50V
10% 500V
MCM 21T1
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
(a)
REF.NO. PART NO.
DESCRIPTION
REMARK
REF.NO. PART NO.
DESCRIPTION
REMARK
C435
C436
C438
C440
1-163-021-91
1-163-243-11
1-163-243-11
1-163-243-11
CERAMIC CHIP 0.01MF
CERAMIC CHIP 47PF
CERAMIC CHIP 47PF
CERAMIC CHIP 47PF
10%
5%
5%
5%
50V
50V
50V
50V
D102
D103
D104
D105
8-719-062-51
8-719-404-49
8-719-052-12
8-719-052-12
DIODE 1PS226-115
DIODE MA111
DIODE 1SS376TE-17
DIODE 1SS376TE-17
C442
C443
C444
C445
C446
1-163-243-11
1-163-243-11
1-163-243-11
1-163-009-11
1-164-004-11
CERAMIC CHIP 47PF
CERAMIC CHIP 47PF
CERAMIC CHIP 47PF
CERAMIC CHIP 0.001MF
CERAMIC CHIP 0.1MF
5%
5%
5%
10%
10%
50V
50V
50V
50V
25V
D106
D107
D201
D202
D203
8-719-052-12
8-719-052-12
8-719-062-51
8-719-062-51
8-719-404-49
DIODE 1SS376TE-17
DIODE 1SS376TE-17
DIODE 1PS226-115
DIODE 1PS226-115
DIODE MA111
C447
C448
C450
C451
C452
1-164-004-11
1-164-004-11
1-163-235-11
1-126-964-11
1-163-021-91
CERAMIC CHIP 0.1MF
CERAMIC CHIP 0.1MF
CERAMIC CHIP 22PF
ELECT
10MF
CERAMIC CHIP 0.01MF
10%
10%
5%
20%
10%
25V
25V
50V
50V
50V
D204
D205
D206
D207
D301
8-719-052-12
8-719-052-12
8-719-052-12
8-719-052-12
8-719-062-51
DIODE 1SS376TE-17
DIODE 1SS376TE-17
DIODE 1SS376TE-17
DIODE 1SS376TE-17
DIODE 1PS226-115
C453
C454
C455
C457
C458
1-163-021-91
1-104-665-11
1-163-243-11
1-163-021-91
1-126-964-11
CERAMIC CHIP 0.01MF
ELECT
100MF
CERAMIC CHIP 47PF
CERAMIC CHIP 0.01MF
ELECT
10MF
10%
20%
5%
10%
20%
50V
25V
50V
50V
50V
D302
D303
D304
D305
D306
8-719-062-51
8-719-404-49
8-719-052-12
8-719-052-12
8-719-052-12
DIODE 1PS226-115
DIODE MA111
DIODE 1SS376TE-17
DIODE 1SS376TE-17
DIODE 1SS376TE-17
C459
C460
C461
C463
C464
1-107-930-91
1-162-318-11
1-163-021-91
1-163-021-91
1-107-906-11
ELECT
22MF
CERAMIC
0.001MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
ELECT
10MF
20%
10%
10%
10%
20%
100V
500V
50V
50V
50V
D307
D401
D402
D403
D404
8-719-052-12
8-719-404-49
8-719-976-99
8-719-404-49
8-719-052-12
DIODE 1SS376TE-17
DIODE MA111
ZENER DIODE DTZ5.1B
DIODE MA111
DIODE 1SS376TE-17
C465
C466
C467
C468
C469
1-107-906-11
1-126-964-11
1-163-021-91
1-126-964-11
1-126-964-11
ELECT
10MF
ELECT
10MF
CERAMIC CHIP 0.01MF
ELECT
10MF
ELECT
10MF
20%
20%
10%
20%
20%
50V
50V
50V
50V
50V
D405
D406
D407
D408
D409
8-719-404-49
8-719-404-49
8-719-404-49
8-719-404-49
8-719-404-49
DIODE MA111
DIODE MA111
DIODE MA111
DIODE MA111
DIODE MA111
C471
C478
C479
C481
C482
1-162-318-11
1-115-350-51
1-163-133-00
1-163-021-91
1-115-339-11
CERAMIC
0.001MF
CERAMIC
0.0047MF
CERAMIC CHIP 470PF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.1MF
10% 500V
2KV
5% 50V
10% 50V
10% 50V
D410
8-719-404-49 DIODE MA111
C483
C484
C485
C486
C487
1-115-339-11
1-162-318-11
1-107-652-11
1-163-021-91
1-126-964-11
CERAMIC CHIP 0.1MF
CERAMIC
0.001MF
ELECT
10MF
CERAMIC CHIP 0.01MF
ELECT
10MF
10%
10%
20%
10%
20%
C488
C489
C491
1-104-664-11 ELECT
47MF
1-164-004-11 CERAMIC CHIP 0.1MF
1-163-021-91 CERAMIC CHIP 0.01MF
<FERRITE BEAD>
FB101
FB201
FB301
FB403
FB405
50V
500V
250V
50V
50V
1.1UH
1.1UH
FB406 1-412-911-31 INDUCTOR, FERRITE BEAD
1.1UH
<IC>
IC401
IC402
IC403
IC404
IC406
<CONNECTOR>
CN401*1-564-521-11
CN402*1-564-522-11
CN403 1-564-523-11
CN405 1-564-524-11
CN406*1-766-179-11
SHORT
0
SHORT
0
SHORT
0
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
20% 25V
10% 25V
10% 50V
1-216-295-91
1-216-295-91
1-216-295-91
1-412-911-31
1-412-911-31
PLUG, CONNECTOR 6P
PLUG, CONNECTOR 7P
PLUG, CONNECTOR 8P
PLUG, CONNECTOR 9P
PIN, CONNECTOR (PC BOARD) 2P
8-759-522-86
8-759-468-63
8-749-013-74
8-759-525-20
8-759-231-58
IC M52755FP-TP
IC M52722P
IC FA4111
IC LSC4380DW2R2
IC TA7812S
IC408 8-759-239-14 IC TA78L05S
IC409 8-759-502-82 IC LM324M
IC410 8-759-635-27 IC M62352GP-75E
CN407*1-564-522-11 PLUG, CONNECTOR 7P
<COIL>
<DIODE>
D101
L101
L201
8-719-062-51 DIODE 1PS226-115
7-2
1-412-478-11 INDUCTOR
1-412-478-11 INDUCTOR
0.15UH
0.15UH
MCM 21T1
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
REF.NO. PART NO.
L301
L401
L402
(a)
DESCRIPTION
1-412-478-11 INDUCTOR
1-408-615-31 INDUCTOR
1-412-529-11 INDUCTOR
REMARK
REF.NO. PART NO.
0.15UH
100UH
22UH
<IC LINK>
PS401 ¡1-533-590-31LINK, IC (1A/90V AC, 60V DC)
<TRANSISTOR>
Q101
Q105
Q106
Q201
Q202
8-729-112-65
8-729-041-66
8-729-200-17
8-729-112-65
8-729-107-31
TRANSISTOR 2SA1462-Y33
TRANSISTOR 2SC4015TV2
TRANSISTOR 2SA1091-O
TRANSISTOR 2SA1462-Y33
TRANSISTOR 2SC3545-T43
Q205
Q206
Q301
Q305
Q306
8-729-041-66
8-729-200-17
8-729-112-65
8-729-041-66
8-729-200-17
TRANSISTOR 2SC4015TV2
TRANSISTOR 2SA1091-O
TRANSISTOR 2SA1462-Y33
TRANSISTOR 2SC4015TV2
TRANSISTOR 2SA1091-O
Q401
Q402
Q403
Q404
Q405
8-729-216-22
8-729-120-28
8-729-216-22
8-729-901-00
8-729-216-22
TRANSISTOR 2SA1162-G
TRANSISTOR 2SC1623-L5L6
TRANSISTOR 2SA1162-G
TRANSISTOR DTC124EK
TRANSISTOR 2SA1162-G
Q406
Q408
Q409
Q410
8-729-027-31
8-729-027-31
8-729-120-28
8-729-032-61
TRANSISTOR DTA124EKA-T146
TRANSISTOR DTA124EKA-T146
TRANSISTOR 2SC1623-L5L6
TRANSISTOR 2SC5022-02
<RESISTOR>
DESCRIPTION
REMARK
R126
1-216-097-91 RES,CHIP
100K
5%
R127
R128
R129
R130
R131
1-216-035-00 RES,CHIP
1-216-121-91 RES,CHIP
1-218-776-11 METAL CHIP
1-216-097-91 RES,CHIP
1-216-057-00 RES,CHIP
270
1M
1M
100K
2.2K
5% 1/10W
5% 1/10W
0.50%1/10W
5% 1/10W
5% 1/10W
R132
R133
R134
R135
R136
1-216-035-00 RES,CHIP
1-216-049-91 RES,CHIP
1-216-097-91 RES,CHIP
1-216-037-00 RES,CHIP
1-216-097-91 RES,CHIP
270
1K
100K
330
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R137
R139
R140
R141
R144
1-216-097-91 RES,CHIP
1-216-073-00 RES,CHIP
1-216-129-00 RES,CHIP
1-216-025-91 RES,CHIP
1-216-295-91 SHORT
100K
10K
2.2M
100
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R167
R201
R202
R203
R204
1-216-121-91 RES,CHIP
1-215-395-00 METAL
1-216-025-91 RES,CHIP
1-215-395-00 METAL
1-216-025-91 RES,CHIP
1M
82
100
82
100
5%
1%
5%
1%
5%
1/10W
1/4W
1/10W
1/4W
1/10W
R205
R206
R208
R209
R210
1-216-017-91
1-216-017-91
1-216-099-00
1-216-107-00
1-216-295-91
47
47
120K
270K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R211
R212
R213
R214
R215
1-216-057-00 RES,CHIP
1-216-621-11 METAL CHIP
1-216-009-00 RES,CHIP
1-216-035-00 RES,CHIP
1-216-035-00 RES,CHIP
2.2K
56
22
270
270
5% 1/10W
0.50%1/10W
5% 1/10W
5% 1/10W
5% 1/10W
47
3.9K
2.2K
22
100K
5%
5%
5%
5%
5%
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
SHORT
1/10W
R101
R102
R103
R104
R105
1-215-395-00
1-216-025-91
1-215-395-00
1-216-025-91
1-216-017-91
METAL
RES,CHIP
METAL
RES,CHIP
RES,CHIP
82
100
82
100
47
1%
5%
1%
5%
5%
1/4W
1/10W
1/4W
1/10W
1/10W
R216
R217
R218
R219
R220
1-216-017-91
1-216-063-91
1-216-057-00
1-216-009-00
1-216-097-91
R106
R108
R109
R110
R111
1-216-017-91
1-216-099-00
1-216-107-00
1-216-295-91
1-216-057-00
RES,CHIP
RES,CHIP
RES,CHIP
SHORT
RES,CHIP
47
120K
270K
0
2.2K
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
R221
R222
R223
R224
R225
1-216-097-91 RES,CHIP
1-216-027-00 RES,CHIP
1-216-027-00 RES,CHIP
1-219-497-11 CARBON
1-216-693-11 METAL CHIP
100K
120
120
22
56K
5% 1/10W
5% 1/10W
5% 1/10W
5% 1/2W
0.50%1/10W
R112
R113
R114
R115
R116
1-216-617-11
1-216-009-00
1-216-035-00
1-216-035-00
1-216-017-91
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
39
22
270
270
47
0.50%1/10W
5% 1/10W
5% 1/10W
5% 1/10W
5% 1/10W
R226
R227
R228
R229
R230
1-216-097-91 RES,CHIP
1-216-035-00 RES,CHIP
1-216-121-91 RES,CHIP
1-218-776-11 METAL CHIP
1-216-097-91 RES,CHIP
100K
270
1M
1M
100K
5% 1/10W
5% 1/10W
5% 1/10W
0.50%1/10W
5% 1/10W
R117
R118
R119
R120
R121
1-216-063-91
1-216-057-00
1-216-009-00
1-216-097-91
1-216-097-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
3.9K
2.2K
22
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R231
R232
R233
R234
R235
1-216-057-00 RES,CHIP
1-216-035-00 RES,CHIP
1-216-049-91 RES,CHIP
1-216-097-91 RES,CHIP
1-216-037-00 RES,CHIP
2.2K
270
1K
100K
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R122
R123
R124
R125
1-216-027-00
1-216-027-00
1-219-497-11
1-216-693-11
RES,CHIP
RES,CHIP
CARBON
METAL CHIP
120
120
22
56K
5% 1/10W
5% 1/10W
5% 1/2W
0.50%1/10W
R236
R237
R239
R240
1-216-097-91
1-216-097-91
1-216-073-00
1-216-129-00
100K
100K
10K
2.2M
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
7-3
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1/10W
1/10W
1/10W
1/10W
1/10W
MCM 21T1
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
(a)
REF.NO. PART NO.
DESCRIPTION
REMARK
REF.NO. PART NO.
DESCRIPTION
REMARK
R241
1-216-025-91 RES,CHIP
100
5%
1/10W
R417
1-216-089-91 RES,CHIP
47K
5%
R243
R244
R267
R301
R302
1-216-043-91
1-216-295-91
1-216-121-91
1-215-395-00
1-216-025-91
RES,CHIP
SHORT
RES,CHIP
METAL
RES,CHIP
560
0
1M
82
100
5%
1/10W
5%
1%
5%
1/10W
1/4W
1/10W
R418
R419
R420
R421
R422
1-260-127-11
1-216-687-11
1-216-691-11
1-216-103-00
1-216-025-91
CARBON
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
220K
33K
47K
180K
100
5% 1/2W
0.50%1/10W
0.50%1/10W
5% 1/10W
5% 1/10W
R303
R304
R305
R306
R308
1-215-395-00
1-216-025-91
1-216-017-91
1-216-017-91
1-216-099-00
METAL
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
82
100
47
47
120K
1%
5%
5%
5%
5%
1/4W
1/10W
1/10W
1/10W
1/10W
R423
R424
R425
R426
R427
1-216-089-91
1-216-025-91
1-216-017-91
1-216-025-91
1-216-025-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
47K
100
47
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R309
R310
R311
R312
R313
1-216-107-00
1-216-295-91
1-216-057-00
1-216-623-11
1-216-009-00
RES,CHIP
SHORT
RES,CHIP
METAL CHIP
RES,CHIP
270K
0
2.2K
68
22
5%
1/10W
5% 1/10W
0.50%1/10W
5% 1/10W
R428
R429
R430
R431
R432
1-216-049-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1K
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R314
R315
R316
R317
R318
1-216-035-00
1-216-035-00
1-216-017-91
1-216-063-91
1-216-057-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
270
270
47
3.9K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R433
R434
R435
R436
R437
1-216-025-91
1-216-065-91
1-216-121-91
1-216-067-00
1-412-963-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
INDUCTOR
100
4.7K
1M
5.6K
100UH
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R319
R320
R321
R322
R323
1-216-009-00
1-216-097-91
1-216-097-91
1-216-027-00
1-216-027-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
22
100K
100K
120
120
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R438
R439
R440
R441
R442
1-216-053-00
1-216-053-00
1-216-089-91
1-216-025-91
1-216-659-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
1.5K
1.5K
47K
100
2.2K
5% 1/10W
5% 1/10W
5% 1/10W
5% 1/10W
0.50%1/10W
R324
R325
R326
R327
R328
1-219-497-11
1-216-693-11
1-216-097-91
1-216-035-00
1-216-121-91
CARBON
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
22
56K
100K
270
1M
5% 1/2W
0.50%1/10W
5% 1/10W
5% 1/10W
5% 1/10W
R443
R444
R446
R451
R452
1-216-041-00
1-216-057-00
1-216-025-91
1-216-025-91
1-216-065-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
470
2.2K
100
100
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R329
R330
R331
R332
R333
1-218-776-11
1-216-097-91
1-216-057-00
1-216-035-00
1-216-049-91
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1M
100K
2.2K
270
1K
0.50%1/10W
5% 1/10W
5% 1/10W
5% 1/10W
5% 1/10W
R453
R454
R456
R457
R458
1-216-073-00
1-216-073-00
1-216-089-91
1-219-720-11
1-211-885-21
RES,CHIP
RES,CHIP
RES,CHIP
METAL
METAL
10K
10K
47K
10M
2.2M
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1W
1W
R334
R335
R336
R337
R339
1-216-097-91
1-216-037-00
1-216-097-91
1-216-097-91
1-216-073-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100K
330
100K
100K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R459
R461
R462
R463
R464
1-219-720-11
1-249-441-11
1-216-089-91
1-216-099-00
1-216-057-00
METAL
CARBON
RES,CHIP
RES,CHIP
RES,CHIP
10M
100K
47K
120K
2.2K
5%
5%
5%
5%
5%
1W
1/4W
1/10W
1/10W
1/10W
R340
R341
R344
R367
R406
1-216-129-00
1-216-025-91
1-216-295-91
1-216-121-91
1-216-049-91
RES,CHIP
RES,CHIP
SHORT
RES,CHIP
RES,CHIP
2.2M
100
0
1M
1K
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R466
R470
R471
R473
R475
1-216-675-11
1-216-065-91
1-216-069-00
1-216-073-00
1-216-073-00
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10K
4.7K
6.8K
10K
10K
0.50%1/10W
5% 1/10W
5% 1/10W
5% 1/10W
5% 1/10W
R407
R408
R409
R410
R411
1-216-089-91
1-216-097-91
1-216-049-91
1-216-049-91
1-216-065-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
47K
100K
1K
1K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R477
R478
R479
R480
1-216-081-00
1-249-381-11
1-249-381-11
1-249-381-11
RES,CHIP
CARBON
CARBON
CARBON
22K
1
1
1
5%
5%
5%
5%
R412
R413
R415
R416
1-216-053-00
1-216-065-91
1-216-065-91
1-216-049-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1.5K
4.7K
4.7K
1K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
<SPARK GAP>
SG101 1-517-499-21 GAP, SPARK
SG201 1-517-499-21 GAP, SPARK
7-4
1/10W
1/10W
1/4W F
1/4W F
1/4W F
MCM 21T1
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
REF.NO. PART NO.
(a)(ga)(g)
DESCRIPTION
REMARK
REF.NO. PART NO.
SG301 1-517-499-21 GAP, SPARK
SG401 1-519-526-11 LAMP, NEON
SG402 1-519-422-11 GAP, SPARK
R7512 1-216-089-91 RES,CHIP
R7513 1-216-093-00 RES,CHIP
<SOCKET>
<CAPACITOR>
1/10W
1/10W
<CAPACITOR>
CERAMIC CHIP 0.01MF
FILM
0.22MF
CERAMIC CHIP 0.001MF
FILM
0.1MF
CERAMIC CHIP 0.1MF
C7506 1-164-004-11 CERAMIC CHIP 0.1MF
10%
5%
10%
5%
10%
50V
50V
50V
50V
25V
10% 25V
<CONNECTOR>
CN7501*1-774-512-11CONNECTOR, BPARD TO BOARD 10P
<DIODE>
D7501 8-719-110-57 ZENER DIODE RD22ESB2
D7502 8-719-911-19 DIODE 1SS119-25
<IC>
IC7501 8-759-482-62 IC MC33262P
<TRANSISTOR>
8-729-026-49
8-729-120-28
8-729-120-28
8-729-026-49
5%
5%
4-382-854-11 SCREW (M3X10), P, SW (+)
(Q610, Q640, D610, D611, D672)
* 7-322-065-72 RUBBER, RTV (SE-9168) (130G)
(C671, C682, VDR640)
7-682-947-01 SCREW +PSW 3X6 (IC660)
* 8-933-269-00 GA BOARD, COMPLETE
******************************
Q7501
Q7502
Q7503
Q7504
47K
68K
* 8-933-277-00 G BOARD, COMPLETE
****************************
*******************************************************************************
1-163-021-91
1-136-169-00
1-163-009-11
1-136-165-00
1-164-004-11
REMARK
********************************************************************************
SK401¡1-251-640-11SOCKET, PICTURE TUBE
C7501
C7502
C7503
C7504
C7505
DESCRIPTION
TRANSISTOR 2SA1037AK-T146-R
TRANSISTOR 2SC1623-L5L6
TRANSISTOR 2SC1623-L5L6
TRANSISTOR 2SA1037AK-T146-R
<RESISTOR>
C601¡
C602¡
C603¡
C604¡
C605¡
1-113-900-51
1-113-900-51
1-107-533-51
1-107-533-51
1-113-926-91
CERAMIC
CERAMIC
FILM
FILM
CERAMIC
470PF
470PF
1MF
1MF
0.0047MF
C606¡
C607
C610
C611
C612
1-113-926-91 CERAMIC
1-113-900-11 CERAMIC
1-137-479-11 FILM
1-117-849-11 ELECT
1-126-959-11 ELECT
0.0047MF
470PF
1MF
330MF
0.47MF
10%
10%
20%
20%
250V
250V
400V
450V
50V
C616
C640
C641
C642
C643
1-107-888-11
1-104-330-91
1-104-330-91
1-136-171-00
1-136-171-00
47MF
470PF
470PF
0.33MF
0.33MF
20%
10%
10%
5%
5%
25V
1kV
1kV
50V
50V
C644
C645
C646
C647
C660
1-104-330-91 CERAMIC
1-136-167-00 FILM
1-136-167-00 FILM
1-129-719-00 FILM
1-111-057-11 ELECT
470PF
0.15MF
0.15MF
0.027MF
120MF
10%
5%
5%
5%
20%
1kV
50V
50V
630V
25V
C661
C662
C663
C670
C671
1-128-526-11
1-130-495-00
1-126-965-11
1-137-370-11
1-107-966-51
ELECT
FILM
ELECT
FILM
ELECT
100MF
0.1MF
22MF
0.01MF
220MF
20%
5%
20%
5%
20%
16V
50V
50V
50V
250V
C672
C673
C674
C675
C676
1-107-959-11
1-107-935-11
1-107-928-11
1-107-890-11
1-107-888-11
ELECT
ELECT
ELECT
ELECT
ELECT
3.3MF
330MF
4.7MF
2200MF
47MF
20%
20%
20%
20%
20%
250V
100V
100V
25V
25V
ELECT
CERAMIC
CERAMIC
FILM
FILM
10%
10%
20%
20%
250V
250V
250V
250V
250V
R7501
R7502
R7503
R7504
R7505
1-216-025-91
1-216-073-00
1-216-041-00
1-216-675-11
1-216-673-11
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
100
10K
470
10K
8.2K
5% 1/10W
5% 1/10W
5% 1/10W
0.50%1/10W
0.50%1/10W
C677
C678
C679
C680
C681
1-107-890-11
1-107-888-11
1-126-927-11
1-126-927-11
1-107-905-11
ELECT
ELECT
ELECT
ELECT
ELECT
2200MF
47MF
2200MF
2200MF
4.7MF
20%
20%
20%
20%
20%
25V
25V
10V
10V
50V
R7506
R7507
R7508
R7509
R7510
1-216-073-00
1-216-089-91
1-216-073-00
1-216-073-00
1-216-073-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10K
47K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C682
C683
C684
C685
C690
1-126-963-11
1-164-646-11
1-137-370-11
1-107-909-11
1-107-888-11
ELECT
CERAMIC
FILM
ELECT
ELECT
4.7MF
2200PF
0.01MF
47MF
47MF
20%
10%
5%
20%
20%
50V
500V
50V
50V
25V
R7511 1-216-073-00 RES,CHIP
10K
5%
1/10W
C691
1-107-888-11 ELECT
47MF
20% 25V
7-5
MCM 21T1
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
(g)
REF.NO. PART NO.
C692
C693
C695
C697
1-111-016-11
1-130-495-00
1-164-644-11
1-136-165-00
DESCRIPTION
ELECT
FILM
CERAMIC
FILM
REMARK
0.0012F
0.1MF
330PF
0.1MF
20%
5%
10%
5%
REF.NO. PART NO.
10V
50V
500V
50V
DESCRIPTION
REMARK
<IC>
IC630
IC660
IC690
IC691
8-749-013-03
8-759-470-64
8-749-011-42
8-759-140-85
IC DM-60
IC TOP223Y-BB
IC SI-3050F
IC UPC1093J
<CONNECTOR>
CN603*1-580-689-11
CN604 1-691-960-11
CN605 1-691-960-11
CN610*1-774-511-11
CN671*1-564-514-11
PIN, CONNECTOR (PC BOARD) 4P
PIN, CONNECTOR (PC BOARD) 3P
PIN, CONNECTOR (PC BOARD) 3P
CONNECTOR, BOARD TO BOARD 10P
PLUG, CONNECTOR 11P
<COIL>
CN672*1-564-512-11 PLUG, CONNECTOR 9P
CN673*1-564-508-11 PLUG, CONNECTOR 5P
L610
L611
L670
L671
L672
1-416-409-11
1-411-674-11
1-412-529-11
1-412-529-11
1-412-529-11
COIL, CHOKE
COIL, CHOKE
INDUCTOR
INDUCTOR
INDUCTOR
L673
L691
1-412-529-11 INDUCTOR
1-412-529-11 INDUCTOR
68UH
22UH
22UH
22UH
22UH
22UH
<DIODE>
D610 ¡ 8-719-510-53
D611 8-719-029-04
D612 8-719-304-63
D613 8-719-110-49
D614 8-719-977-28
DIODE D4SB60L
DIODE D5L60
DIODE RM11C
ZENER DIODE RD18ESB2
ZENER DIODE DTZ10B
D617
D640
D660
D661
D662
8-719-404-49
8-719-404-49
8-719-059-23
8-719-979-64
8-719-058-91
DIODE MA111
DIODE MA111
DIODE P6KE200AG23
DIODE UF4005PKG23
DIODE AG01A-V0
D663
D666
D670
D671
D672
8-719-110-31
8-719-105-99
8-719-064-49
8-719-510-64
8-719-052-91
ZENER DIODE RD12ESB2
ZENER DIODE RD6.2M-B1
DIODE D4SBL40
DIODE S2LA20F
DIODE D4SBS4-F
D673
D674
D677
D678
D680
8-719-022-97
8-719-022-97
8-719-911-19
8-719-911-19
8-719-404-49
DIODE D2S4MF
DIODE D2S4MF
DIODE 1SS119-25
DIODE 1SS119-25
DIODE MA111
D681
D682
D683
D684
D691
8-719-404-49
8-719-510-64
8-719-911-19
8-719-110-57
8-719-510-37
DIODE MA111
DIODE S2LA20F
DIODE 1SS119-25
ZENER DIODE RD22ESB2
DIODE D5LC20U
D692
D693
8-719-911-19 DIODE 1SS119-25
8-719-404-49 DIODE MA111
<PHOTO COUPLER>
PH660 8-749-010-64 PHOTO COUPLER PC123F2
PH680 8-749-010-64 PHOTO COUPLER PC123F2
<IC LINK>
PS670¡1-533-593-31LINK, IC (2A/90V AC, 60V DC)
PS671¡1-533-593-31LINK, IC (2A/90V AC, 60V DC)
PS673¡1-533-593-31LINK, IC (2A/90V AC, 60V DC)
PS674¡1-533-593-31LINK, IC (2A/90V AC, 60V DC)
<TRANSISTOR>
8-729-041-65
8-729-026-49
8-729-041-12
8-729-119-76
8-729-119-78
TRANSISTOR 2SK2195F04
TRANSISTOR 2SA1037AK-T146-R
TRANSISTOR MX0841AB-F
TRANSISTOR 2SA1175-HFE
TRANSISTOR 2SC2785-HFE
Q660
Q680
Q681
Q682
Q683
8-729-119-78
8-729-120-28
8-729-230-45
8-729-119-76
8-729-119-76
TRANSISTOR 2SC2785-HFE
TRANSISTOR 2SC1623-L5L6
TRANSISTOR 2SC2458-YGR
TRANSISTOR 2SA1175-HFE
TRANSISTOR 2SA1175-HFE
Q690
Q691
8-729-119-78 TRANSISTOR 2SC2785-HFE
8-729-026-49 TRANSISTOR 2SA1037AK-T146-R
<RESISTOR>
<FUSE>
F601 ¡ 1-576-233-11 FUSE (H.B.C.) (6.3A/250V)
1-533-223-11 HOLDER, FUSE ; F601
<FERRITE BEAD>
FB610 1-410-396-41 FERRITE
FB611 1-410-396-41 FERRITE
FB612 1-410-396-41 FERRITE
Q610
Q615
Q640
Q641
Q642
0.45UH
0.45UH
0.45UH
7-6
R601 ¡ 1-220-825-91
R604 1-260-089-11
R610 1-216-383-11
R611 1-216-383-11
R612 1-215-477-00
CARBON
CARBON
METAL OXIDE
METAL OXIDE
METAL
330K
150
0.33
0.33
220K
5%
5%
5%
5%
1%
1/2W
1/2W
3W F
3W F
1/4W
R613
R614
R615
R616
R617
1-215-477-00
1-215-473-00
1-215-473-00
1-215-473-00
1-215-481-00
METAL
METAL
METAL
METAL
METAL
220K
150K
150K
150K
330K
1%
1%
1%
1%
1%
1/4W
1/4W
1/4W
1/4W
1/4W
R618
R619
1-215-477-00 METAL
1-215-485-00 METAL
220K
470K
1%
1%
1/4W
1/4W
MCM 21T1
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
REF.NO. PART NO.
(g)(d)
DESCRIPTION
REMARK
REF.NO. PART NO.
1/4W
1/4W
1/10W
DESCRIPTION
REMARK
R620
R621
R622
1-215-485-00 METAL
1-215-481-00 METAL
1-216-049-91 RES,CHIP
470K
330K
1K
1%
1%
5%
R623
R624
R625
R626
R627
1-216-651-11
1-216-671-11
1-249-389-11
1-249-429-11
1-215-479-00
METAL CHIP
METAL CHIP
CARBON
CARBON
METAL
1K
6.8K
4.7
10K
270K
0.50%1/10W
0.50%1/10W
5% 1/4W
5% 1/4W
1% 1/4W
R628
R629
R631
R632
R633
1-215-481-00
1-215-461-00
1-247-807-31
1-216-073-00
1-215-481-00
METAL
METAL
CARBON
RES,CHIP
METAL
330K
47K
100
10K
330K
1%
1%
5%
5%
1%
1/4W
1/4W
1/4W
1/10W
1/4W
R635
R640
R641
R642
R643
1-216-073-00
1-202-933-61
1-218-642-11
1-218-642-11
1-247-863-91
RES,CHIP
FUSIBLE
METAL OXIDE
METAL OXIDE
CARBON
10K
0.1
100K
100K
22K
5%
10%
5%
5%
5%
1/10W
1/2W F
1W F
1W F
1/4W
R644
R645
R646
R647
R648
1-216-105-91
1-216-081-00
1-216-073-00
1-249-441-11
1-216-353-00
RES,CHIP
RES,CHIP
RES,CHIP
CARBON
METAL OXIDE
220K
22K
10K
100K
2.2
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/4W
1W F
R649
R650
R651
R652
R655
1-218-642-11
1-218-642-11
1-216-353-00
1-212-942-00
1-216-073-00
METAL OXIDE
METAL OXIDE
METAL OXIDE
FUSIBLE
RES,CHIP
100K
100K
2.2
2.2
10K
5%
5%
5%
5%
5%
1W F
1W F
1W F
1/2W F
1/10W
R661
R662
R663
R664
R665
1-249-387-11
1-216-073-00
1-216-073-00
1-247-791-91
1-216-033-00
CARBON
RES,CHIP
RES,CHIP
CARBON
RES,CHIP
3.3
10K
10K
22
220
5%
5%
5%
5%
5%
1/4W F
1/10W
1/10W
1/4W
1/10W
R666
R667
R668
R669
R671
1-215-441-00
1-215-433-00
1-249-401-11
1-216-057-00
1-216-113-00
METAL
METAL
CARBON
RES,CHIP
RES,CHIP
6.8K
3.3K
47
2.2K
470K
1%
1%
5%
5%
5%
1/4W
1/4W
1/4W
1/10W
1/10W
R672
R673
R674
R675
R676
1-216-049-91
1-249-413-11
1-249-377-11
1-260-292-11
1-249-413-11
RES,CHIP
CARBON
CARBON
CARBON
CARBON
1K
470
0.47
1
470
5%
5%
5%
5%
5%
1/10W
1/4W F
1/4W F
1/2W
1/4W
R680
R681
R682
R683
R685
1-216-073-00
1-216-049-91
1-216-065-91
1-216-025-91
1-216-073-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10K
1K
4.7K
100
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R686
R687
R688
R689
R691
1-216-049-91
1-216-049-91
1-216-073-00
1-216-073-00
1-216-073-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1K
1K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C001
C002
C003
C004
C005
1-163-021-91
1-163-009-11
1-163-019-00
1-163-021-91
1-163-021-91
R692
R693
R694
1-260-085-11 CARBON
1-216-065-91 RES,CHIP
1-216-073-00 RES,CHIP
68
4.7K
10K
5%
5%
5%
1/2W
1/10W
1/10W
C006
C007
C008
1-126-960-11 ELECT
1MF
1-163-021-91 CERAMIC CHIP 0.01MF
1-164-004-11 CERAMIC CHIP 0.1MF
R695
R696
1-249-443-11 CARBON
1-216-633-11 METAL CHIP
0.47
180
5% 1/4W F
0.50%1/10W
R697
R698
R699
1-216-649-11 METAL CHIP
1-216-073-00 RES,CHIP
1-216-081-00 RES,CHIP
820
10K
22K
0.50%1/10W
5% 1/10W
5% 1/10W
<RELAY>
RY601¡1-515-669-21RELAY
RY602¡1-755-031-11RELAY
<TRANSFORMER>
T601¡
T640
T641
T660
1-429-180-11 TRANSFORMER, LINE FILTER
1-431-538-11 TRANSFORMER, CONVERTER (PIT)
1-429-992-11 TRANSFORMER, CONVERTER (PRT)
1-431-565-11 TRANSFORMER, CONVERTER (SRT)
<THERMISTOR>
TH601 ¡ 1-809-260-11THERMISTOR, POWER
THP601¡1-809-827-11THERMISTOR, POSITIVE
<VARISTOR>
VDR601 ¡1-801-268-51VARISTOR TNR14V471K660
VDR602 ¡1-810-622-21VARISTOR
VDR640 1-810-974-21VARISTOR TNR10V431K660
*******************************************************************************
* 8-933-311-00 D BOARD, COMPLETE
****************************
4-040-989-01 SPRING (A), TR RETAINER (IC702, R511)
4-040-992-01 SPRING (AA), TR RETAINER
(IC502, Q507)
4-040-994-01 SPRING (BB), TR RETAINER
(Q508, D519)
4-047-285-01 SHEET, INSULATING (Q909)
4-060-720-01 SHEET, INSULATE (Q508)
4-060-844-01 SHEET, INSULATING (IC702)
4-382-854-01 SCREW (M3X8), P, SW (+) (R937)
4-382-854-11 SCREW (M3X10), P, SW (+)
(IC702, Q704, Q706, Q908, Q909)
7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
(IC502, Q507, Q508, D519, R511)
<CAPACITOR>
7-7
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.001MF
CERAMIC CHIP 0.0068MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
20% 50V
10% 50V
10% 25V
MCM 21T1
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
(d)
REF.NO. PART NO.
DESCRIPTION
REMARK
REF.NO. PART NO.
DESCRIPTION
REMARK
C009
C010
1-164-004-11 CERAMIC CHIP 0.1MF
1-163-237-11 CERAMIC CHIP 27PF
10% 25V
5% 50V
C069
C070
1-163-021-91 CERAMIC CHIP 0.01MF
1-163-021-91 CERAMIC CHIP 0.01MF
10% 50V
10% 50V
C011
C012
C013
C014
C015
1-163-237-11
1-164-004-11
1-126-967-11
1-107-914-11
1-107-914-11
CERAMIC CHIP 27PF
CERAMIC CHIP 0.1MF
ELECT
47MF
ELECT
1000MF
ELECT
1000MF
5%
10%
20%
20%
20%
50V
25V
50V
25V
25V
C072
C074
C075
C076
C077
1-126-960-11
1-163-009-11
1-163-021-91
1-163-809-11
1-164-004-11
ELECT
1MF
CERAMIC CHIP 0.001MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.047MF
CERAMIC CHIP 0.1MF
20%
10%
10%
10%
10%
50V
50V
50V
25V
25V
C016
C017
C018
C019
C020
C021
1-163-009-11
1-164-004-11
1-164-004-11
1-126-967-11
1-163-021-91
1-163-023-00
CERAMIC CHIP 0.001MF
CERAMIC CHIP 0.1MF
CERAMIC CHIP 0.1MF
ELECT
47MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.015MF
10%
10%
10%
20%
10%
10%
50V
25V
25V
50V
50V
50V
C078
C079
C080
C081
C082
1-164-004-11
1-126-967-11
1-126-967-11
1-163-021-91
1-126-964-11
CERAMIC CHIP 0.1MF
ELECT
47MF
ELECT
47MF
CERAMIC CHIP 0.01MF
ELECT
10MF
10%
20%
20%
10%
20%
25V
50V
50V
50V
50V
C022
C023
C024
C025
C026
1-126-933-11
1-163-009-11
1-163-021-91
1-126-960-11
1-137-372-11
ELECT
100MF
CERAMIC CHIP 0.001MF
CERAMIC CHIP 0.01MF
ELECT
1MF
FILM
0.022MF
20%
10%
10%
20%
5%
16V
50V
50V
50V
50V
C083
C084
C085
C086
C087
1-130-495-00
1-164-004-11
1-130-495-00
1-126-964-11
1-164-004-11
FILM
0.1MF
CERAMIC CHIP 0.1MF
FILM
0.1MF
ELECT
10MF
CERAMIC CHIP 0.1MF
5%
10%
5%
20%
10%
50V
25V
50V
50V
25V
C027
C028
C029
C030
C031
1-164-004-11
1-164-695-11
1-126-960-11
1-164-004-11
1-163-021-91
CERAMIC CHIP 0.1MF
CERAMIC CHIP 0.0022MF
ELECT
1MF
CERAMIC CHIP 0.1MF
CERAMIC CHIP 0.01MF
10%
5%
20%
10%
10%
25V
50V
50V
25V
50V
C090
C092
C093
C094
C095
1-109-982-11
1-163-021-91
1-126-964-11
1-163-021-91
1-163-021-91
CERAMIC CHIP 1MF
CERAMIC CHIP 0.01MF
ELECT
10MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
10%
10%
20%
10%
10%
10V
50V
50V
50V
50V
C032
C034
C035
C036
C037
1-163-019-00
1-163-021-91
1-163-253-11
1-164-004-11
1-126-934-11
CERAMIC CHIP 0.0068MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 120PF
CERAMIC CHIP 0.1MF
ELECT
220MF
10%
10%
5%
10%
20%
50V
50V
50V
25V
16V
C096
C097
C098
C099
C501
1-163-021-91
1-163-021-91
1-163-021-91
1-164-004-11
1-107-909-11
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.1MF
ELECT
47MF
10%
10%
10%
10%
20%
50V
50V
50V
25V
50V
C038
C039
C040
C041
C042
1-164-004-11
1-126-964-11
1-126-963-11
1-126-960-11
1-126-967-11
CERAMIC CHIP 0.1MF
ELECT
10MF
ELECT
4.7MF
ELECT
1MF
ELECT
47MF
10%
20%
20%
20%
20%
25V
50V
50V
50V
50V
C502
C503
C504
C505
C506
1-163-259-91
1-136-169-00
1-137-605-11
1-163-251-11
1-136-169-00
CERAMIC CHIP 220PF
FILM
0.22MF
FILM
0.01MF
CERAMIC CHIP 100PF
FILM
0.22MF
5%
5%
10%
5%
5%
50V
50V
250V
50V
50V
C043
C044
C045
C046
C047
1-126-967-11
1-126-967-11
1-163-137-00
1-164-004-11
1-126-934-11
ELECT
47MF
ELECT
47MF
CERAMIC CHIP 680PF
CERAMIC CHIP 0.1MF
ELECT
220MF
20%
20%
5%
10%
20%
50V
50V
50V
25V
16V
C507
C508
C509
C510
C511
1-136-173-00
1-163-037-11
1-126-941-11
1-137-368-11
1-117-398-11
FILM
0.47MF
CERAMIC CHIP 0.022MF
ELECT
470MF
FILM
0.0047MF
ELECT
33MF
5%
10%
20%
5%
20%
50V
50V
25V
50V
250V
C048
C049
C050
C051
C052
1-164-695-11
1-163-137-00
1-163-809-11
1-126-960-11
1-163-809-11
CERAMIC CHIP 0.0022MF
CERAMIC CHIP 680PF
CERAMIC CHIP 0.047MF
ELECT
1MF
CERAMIC CHIP 0.047MF
5%
5%
10%
20%
10%
50V
50V
25V
50V
25V
C512
C513
C514
C515
C516
1-107-889-11
1-163-017-00
1-163-021-91
1-107-889-11
1-130-495-00
ELECT
220MF
CERAMIC CHIP 0.0047MF
CERAMIC CHIP 0.01MF
ELECT
220MF
FILM
0.1MF
20%
10%
10%
20%
5%
25V
50V
50V
25V
50V
C054
C055
C056
C057
C058
1-126-963-11
1-126-963-11
1-163-809-11
1-107-909-11
1-126-934-11
ELECT
4.7MF
ELECT
4.7MF
CERAMIC CHIP 0.047MF
ELECT
47MF
ELECT
220MF
20%
20%
10%
20%
20%
50V
50V
25V
50V
16V
C517
C518
C519
C520
C521
1-104-574-11
1-117-959-11
1-107-444-11
1-136-553-11
1-107-597-11
CERAMIC
FILM
CERAMIC
FILM
CERAMIC
0.0047MF
4700PF
100PF
0.0015MF
22PF
10%
3%
5%
5%
5%
2KV
1.8KV
2KV
630V
500V
C059
C060
C061
C063
C065
1-163-021-91
1-126-964-11
1-163-021-91
1-130-495-00
1-126-965-11
CERAMIC CHIP 0.01MF
ELECT
10MF
CERAMIC CHIP 0.01MF
FILM
0.1MF
ELECT
22MF
10%
20%
10%
5%
20%
50V
50V
50V
50V
50V
C522
C523
C524
C525
C526
1-107-444-11
1-137-370-11
1-113-694-11
1-107-846-11
1-115-514-11
CERAMIC
FILM
FILM
FILM
FILM
100PF
0.01MF
0.056MF
0.1MF
0.22MF
5%
5%
5%
5%
5%
2KV
50V
250V
250V
250V
C066
C067
C068
1-163-021-91 CERAMIC CHIP 0.01MF
1-163-243-11 CERAMIC CHIP 47PF
1-126-964-11 ELECT
10MF
C527
C528
C529
C530
1-115-517-11
1-115-521-11
1-107-683-11
1-163-021-91
FILM
0.39MF
FILM
0.82MF
ELECT
2.2MF
CERAMIC CHIP 0.01MF
5%
5%
0
10%
250V
250V
250V
50V
10% 50V
5% 50V
20% 50V
7-8
MCM 21T1
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
REF.NO. PART NO.
DESCRIPTION
(d)
REMARK
REF.NO. PART NO.
DESCRIPTION
REMARK
C531
1-163-021-91 CERAMIC CHIP 0.01MF
10% 50V
C532
C533
C534
C535
C536
1-163-021-91
1-163-021-91
1-163-021-91
1-163-021-91
1-128-526-11
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
ELECT
100MF
10%
10%
10%
10%
20%
50V
50V
50V
50V
25V
C537
C538
C539
C540
C541
1-115-523-71
1-117-958-11
1-107-960-11
1-106-343-00
1-163-243-11
FILM
1.2MF
FILM
0.24MF
ELECT
4.7MF
MYLAR
0.001MF
CERAMIC CHIP 47PF
5%
5%
20%
10%
5%
250V
400V
250V
200V
50V
C542
C544
C545
C547
C549
1-163-243-11
1-137-368-11
1-126-967-11
1-126-967-11
1-163-021-91
CERAMIC CHIP 47PF
FILM
0.0047MF
ELECT
47MF
ELECT
47MF
CERAMIC CHIP 0.01MF
5%
5%
20%
20%
10%
50V
50V
50V
50V
50V
C550
C551
C553
C554
C555
1-163-021-91
1-163-009-11
1-126-963-11
1-163-037-11
1-163-037-11
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.001MF
ELECT
4.7MF
CERAMIC CHIP 0.022MF
CERAMIC CHIP 0.022MF
10%
10%
20%
10%
10%
50V
50V
50V
50V
50V
C556
C557
C559
C561
C562
1-163-009-11
1-115-185-11
1-162-134-11
1-136-173-00
1-163-021-91
CERAMIC CHIP 0.001MF
CERAMIC CHIP 0.033MF
CERAMIC
470PF
FILM
0.47MF
CERAMIC CHIP 0.01MF
10%
10%
10%
5%
10%
50V
50V
2KV
50V
50V
C563
C564
C666
C667
C701
1-117-214-11
1-126-963-11
1-163-021-91
1-126-967-11
1-126-967-11
CERAMIC
0.001MF
ELECT
4.7MF
CERAMIC CHIP 0.01MF
ELECT
47MF
ELECT
47MF
10%
20%
10%
20%
20%
2KV
50V
50V
50V
50V
C702
C705
C706
C707
C709
1-130-495-00
1-126-942-61
1-163-021-91
1-163-021-91
1-130-495-00
FILM
0.1MF
ELECT
1000MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
FILM
0.1MF
5%
20%
10%
10%
5%
50V
25V
50V
50V
50V
C710
C711
C712
C713
C714
1-163-019-00
1-107-894-11
1-106-228-00
1-126-942-61
1-126-967-11
CERAMIC CHIP 0.0068MF
ELECT
220MF
MYLAR
0.22MF
ELECT
1000MF
ELECT
47MF
10%
20%
10%
20%
20%
50V
35V
100V
25V
50V
CN501*1-564-512-11
CN502*1-564-514-11
CN503*1-564-510-11
CN504*1-564-508-11
CN505*1-508-879-11
PLUG, CONNECTOR 9P
PLUG, CONNECTOR 11P
PLUG, CONNECTOR 7P
PLUG, CONNECTOR 5P
BASE POST
C715
C717
C729
C735
C746
1-107-932-11
1-107-930-91
1-162-134-11
1-130-495-00
1-163-009-11
ELECT
47MF
ELECT
22MF
CERAMIC
470PF
FILM
0.1MF
CERAMIC CHIP 0.001MF
20%
20%
10%
5%
10%
100V
100V
2KV
50V
50V
CN506*1-564-511-11
CN507 1-764-101-11
CN508*1-778-955-11
CN509 1-564-505-11
CN511*1-564-514-11
PLUG, CONNECTOR 8P
PIN, CONNECTOR (PC BOARD) 2P
PIN, CONNECTOR (PC BOARD) 10P
PLUG, CONNECTOR 2P
PLUG, CONNECTOR 11P
C747
C750
C751
C901
C902
1-163-021-91
1-126-964-11
1-163-021-91
1-107-889-11
1-163-809-11
CERAMIC CHIP 0.01MF
ELECT
10MF
CERAMIC CHIP 0.01MF
ELECT
220MF
CERAMIC CHIP 0.047MF
10%
20%
10%
20%
10%
50V
50V
50V
25V
25V
CN512*1-564-512-11 PLUG, CONNECTOR 9P
CN520*1-564-509-11 PLUG, CONNECTOR 6P
CN901*1-564-520-11 PLUG, CONNECTOR 5P
C903
C904
C905
C906
C907
1-163-259-91
1-137-605-11
1-104-653-11
1-106-220-00
1-119-748-11
CERAMIC CHIP 220PF
FILM
0.01MF
ELECT
220MF
MYLAR
0.1MF
ELECT
33MF
5%
10%
20%
10%
20%
50V
250V
16V
100V
400V
C908
C909
C910
C911
C912
1-136-169-00
1-106-355-12
1-163-021-91
1-163-275-11
1-163-275-11
FILM
0.22MF
MYLAR
0.0033MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.001MF
CERAMIC CHIP 0.001MF
5%
10%
10%
5%
5%
50V
200V
50V
50V
50V
C913
C914
C915
C916
C917
1-164-004-11
1-163-275-11
1-163-021-91
1-136-064-00
1-107-889-11
CERAMIC CHIP 0.1MF
CERAMIC CHIP 0.001MF
CERAMIC CHIP 0.01MF
FILM
2200PF
ELECT
220MF
10%
5%
10%
3%
20%
25V
50V
50V
1.2KV
25V
C919
C920
C921
C922
C923
1-163-021-91 CERAMIC CHIP 0.01MF
1-163-009-11 CERAMIC CHIP 0.001MF
1-163-243-11 CERAMIC CHIP 47PF
1-115-516-71 FILM
0.33MF
1-106-359-00 MYLAR
0.0047MF
10%
10%
5%
5%
10%
50V
50V
50V
250V
100V
C924
C925
C926
C927
C928
1-106-220-00
1-137-372-11
1-106-228-00
1-107-903-11
1-163-021-91
10%
5%
10%
20%
10%
100V
50V
100V
50V
50V
C929
C930
C931
C945
C1003
1-128-526-11 ELECT
100MF
1-163-021-91 CERAMIC CHIP 0.01MF
1-163-021-91 CERAMIC CHIP 0.01MF
1-107-909-11 ELECT
47MF
1-163-021-91 CERAMIC CHIP 0.01MF
20%
10%
10%
20%
10%
25V
50V
50V
50V
50V
C1004
C1005
C1006
C1007
C1008
1-163-021-91
1-163-021-91
1-163-021-91
1-163-021-91
1-163-021-91
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.01MF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C1009
C1501
C1502
C1503
1-126-960-11
1-163-021-91
1-117-722-11
1-163-001-11
ELECT
1MF
CERAMIC CHIP 0.01MF
ELECT
2200MF
CERAMIC CHIP 220PF
20%
10%
20%
10%
50V
50V
10V
50V
MYLAR
0.1MF
FILM
0.022MF
MYLAR
0.22MF
ELECT
2.2MF
CERAMIC CHIP 0.01MF
<CONNECTOR>
<DIODE>
D004
D007
D008
D009
7-9
8-719-062-51
8-719-976-99
8-719-976-99
8-719-976-99
DIODE 1PS226-115
ZENER DIODE DTZ5.1B
ZENER DIODE DTZ5.1B
ZENER DIODE DTZ5.1B
MCM 21T1
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
(d)
REF.NO. PART NO.
DESCRIPTION
D010
8-719-976-99 ZENER DIODE DTZ5.1B
D012
D013
D014
D015
D016
8-719-062-51
8-719-062-51
8-719-062-51
8-719-062-51
8-719-062-51
DIODE 1PS226-115
DIODE 1PS226-115
DIODE 1PS226-115
DIODE 1PS226-115
DIODE 1PS226-115
D019
D020
D025
D026
D027
8-719-062-51
8-719-062-51
8-719-976-99
8-719-062-51
8-719-062-51
DIODE 1PS226-115
DIODE 1PS226-115
ZENER DIODE DTZ5.1B
DIODE 1PS226-115
DIODE 1PS226-115
D028
D029
D032
D033
D034
8-719-800-76
8-719-800-76
8-719-976-99
8-719-976-99
8-719-801-78
DIODE 1SS226
DIODE 1SS226
ZENER DIODE DTZ5.1B
ZENER DIODE DTZ5.1B
DIODE 1SS184
D035
D050
D501
D502
D503
8-719-801-78
8-719-404-49
8-719-977-40
8-719-063-89
8-719-404-49
DIODE 1SS184
DIODE MA111
ZENER DIODE DTZ13B
DIODE YG911S3R
DIODE MA111
D504
D505
D506
D507
D508
8-719-984-73
8-719-018-82
8-719-911-19
8-719-911-19
8-719-109-85
DIODE SB560
DIODE RGP02-20EL-6394
DIODE 1SS119-25
DIODE 1SS119-25
ZENER DIODE RD5.1ESB2
D509
D510
D511
D512
D513
8-719-911-19
8-719-951-30
8-719-911-19
8-719-018-82
8-719-404-49
DIODE 1SS119-25
DIODE ERA91-02
DIODE 1SS119-25
DIODE RGP02-20EL-6394
DIODE MA111
D514
D516
D517
D518
D519
8-719-109-93
8-719-105-99
8-719-105-99
8-719-404-49
8-719-066-36
ZENER DIODE RD6.2ESB2
ZENER DIODE RD6.2M-B1
ZENER DIODE RD6.2M-B1
DIODE MA111
DIODE FMQ-G5GS
D520
D521
D660
D701
D704
8-719-031-34
8-719-404-49
8-719-977-69
8-719-158-15
8-719-404-49
DIODE RGP02-20EG23
DIODE MA111
ZENER DIODE DTZ24B
ZENER DIODE RD5.6SB
DIODE MA111
D705
D706
D709
D713
D714
8-719-404-49
8-719-976-99
8-719-979-85
8-719-911-19
8-719-911-19
DIODE MA111
ZENER DIODE DTZ5.1B
DIODE EGP20G
DIODE 1SS119-25
DIODE 1SS119-25
D715
D718
D720
D721
D901
8-719-911-19
8-719-976-99
8-719-028-72
8-719-028-72
8-719-404-49
DIODE 1SS119-25
ZENER DIODE DTZ5.1B
DIODE RGP02-17EL-6433
DIODE RGP02-17EL-6433
DIODE MA111
D902
D903
D904
D905
D906
8-719-404-49
8-719-911-19
8-719-404-49
8-719-404-49
8-719-404-49
DIODE MA111
DIODE 1SS119-25
DIODE MA111
DIODE MA111
DIODE MA111
REMARK
REF.NO. PART NO.
DESCRIPTION
REMARK
D907
D908
D909
D910
D911
8-719-158-49
8-719-158-49
8-719-977-40
8-719-063-89
8-719-978-69
ZENER DIODE RD12SB2
ZENER DIODE RD12SB2
ZENER DIODE DTZ13B
DIODE YG911S3R
ZENER DIODE DTZ-TT11-16B
D913
D915
D916
D917
D919
8-719-158-49
8-719-109-85
8-719-939-79
8-719-110-46
8-719-911-19
ZENER DIODE RD12SB2
ZENER DIODE RD5.1ESB2
DIODE GMA01-BT
ZENER DIODE RD16ESB3
DIODE 1SS119-25
D921
D922
D923
D924
D935
8-719-404-49
8-719-404-49
8-719-404-49
8-719-976-99
8-719-977-81
DIODE MA111
DIODE MA111
DIODE MA111
ZENER DIODE DTZ5.1B
ZENER DIODE DTZ33B
D1501 8-719-976-99 ZENER DIODE DTZ5.1B
D1502 8-719-404-49 DIODE MA111
D1503 8-719-404-49 DIODE MA111
<FERRITE BEAD>
FB501 1-410-397-21
FB502 1-410-397-21
FB901 1-410-397-21
FB10251-414-232-11
FB10261-414-232-11
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
<IC>
IC001
IC002
IC003
IC004
IC005
8-759-531-24
8-759-442-20
8-759-168-20
8-759-454-79
8-759-162-80
IC MB90553PF-G-120-BND
IC 24LC21AT/SN
IC TA78L09S
IC 24LC16BT/SN
IC MM1170BFB
IC006
IC007
IC008
IC009
IC010
8-759-231-53
8-752-078-46
8-759-701-59
8-759-082-57
8-752-083-83
IC TA7805S
IC CXA2043Q
IC NJM78M09FA
IC TC7W04FU
IC CXA2044M-T6
IC011
IC012
IC013
IC502
IC505
8-759-708-05
8-759-442-20
8-759-233-66
8-759-803-42
8-759-100-96
IC NJM78L05A
IC24LC21AT/SN
IC TC74HCT04AF
IC LA6500-FA
IC UPC4558G2
IC701
IC702
IC703
IC901
8-759-822-38
8-759-444-82
8-759-100-96
8-759-467-70
IC LA6510
IC LA7841L
IC UPC4558G2
IC BA9756FS-E2
<CHIP CONDUCTOR>
JR001
JR002
JR003
JR004
7-10
1-216-295-91
1-216-295-91
1-216-295-91
1-216-295-91
SHORT
SHORT
SHORT
SHORT
0
0
0
0
1.1UH
1.1UH
1.1UH
0UH
0UH
MCM 21T1
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
REF.NO. PART NO.
(d)
DESCRIPTION
REMARK
REF.NO. PART NO.
<COIL>
L001
L002
L003
L004
L006
1-406-665-11
1-406-665-11
1-412-537-31
1-412-537-31
1-410-482-31
COIL, CHOKE
COIL, CHOKE
INDUCTOR
INDUCTOR
INDUCTOR
100UH
100UH
100UH
100UH
100UH
L007
L008
L501
L502
L503
1-412-537-31
1-412-537-31
1-412-537-31
1-406-671-11
1-416-455-11
INDUCTOR
100UH
INDUCTOR
100UH
INDUCTOR
100UH
COIL, CHOKE 1.0MMH
COIL, HORIZONTAL LINEARITY
L504
L505
L507
L701
L702
1-416-456-11
1-406-675-11
1-406-675-11
1-412-537-31
1-412-522-31
COIL, HORIZONTAL LINEARITY
COIL, CHOKE 4.7MMH
COIL, CHOKE 4.7MMH
INDUCTOR
100UH
INDUCTOR
5.6UH
L901
L902
L903
1-412-537-31 INDUCTOR
1-406-660-41 COIL, CHOKE
1-412-537-31 INDUCTOR
8-729-043-41
8-729-033-26
8-729-033-25
8-729-800-32
8-729-178-43
TRANSISTOR 2SK2098-01MR-F119
TRANSISTOR DTA114GKAT146
TRANSISTOR DTC114GKA
TRANSISTOR 2SC2362K-G
TRANSISTOR 2SC2784-E
Q704
Q705
Q706
Q707
Q708
8-729-207-82
8-729-204-91
8-729-207-89
8-729-216-22
8-729-020-07
TRANSISTOR 2SC3421-Y
TRANSISTOR 2SA1049-GR
TRANSISTOR 2SA1358-Y
TRANSISTOR 2SA1162-G
TRANSISTOR 2SC4686A(LBSONY)
Q901
Q902
Q904
Q905
Q908
8-729-120-28
8-729-216-22
8-729-901-87
8-729-901-97
8-729-035-54
TRANSISTOR 2SC1623-L5L6
TRANSISTOR 2SA1162-G
TRANSISTOR 2SC2411K-CQ
TRANSISTOR 2SA1036K-Q
TRANSISTOR 2SJ449
Q909
Q911
8-729-033-91 TRANSISTOR 2SK1120LBSONY2
8-729-033-25 TRANSISTOR DTC114GKA
<RESISTOR>
LINK, IC (1.6A/90V AC, 60V DC)
LINK, IC (2A/90V)
LINK, IC (2A/90V)
LINK, IC (2A/90V)
LINK, IC (1A/90V AC, 60V DC)
PS901¡ 1-533-592-31 LINK, IC (1.6A/90V AC, 60V DC)
<TRANSISTOR>
Q001
Q003
Q004
Q005
Q006
8-729-027-31
8-729-216-22
8-729-216-22
8-729-216-22
8-729-120-28
TRANSISTOR DTA124EKA-T146
TRANSISTOR 2SA1162-G
TRANSISTOR 2SA1162-G
TRANSISTOR 2SA1162-G
TRANSISTOR 2SC1623-L5L6
Q007
Q501
Q502
Q503
Q504
8-729-120-28
8-729-120-28
8-729-120-28
8-729-901-97
8-729-120-28
TRANSISTOR 2SC1623-L5L6
TRANSISTOR 2SC1623-L5L6
TRANSISTOR 2SC1623-L5L6
TRANSISTOR 2SA1036K-Q
TRANSISTOR 2SC1623-L5L6
Q505
Q506
Q507
Q508
Q509
8-729-901-97
8-729-820-73
8-729-035-54
8-729-031-87
8-729-033-25
TRANSISTOR 2SA1036K-Q
TRANSISTOR 2SC3746
TRANSISTOR 2SJ449
TRANSISTOR 2SC5047-CA
TRANSISTOR DTC114GKA
Q510
Q511
Q512
Q517
Q522
8-729-120-28
8-729-140-50
8-729-120-28
8-729-216-22
8-729-043-41
TRANSISTOR 2SC1623-L5L6
TRANSISTOR 2SC3209LK
TRANSISTOR 2SC1623-L5L6
TRANSISTOR 2SA1162-G
TRANSISTOR 2SK2098-01MR-F119
Q523
Q524
Q525
Q526
Q527
8-729-043-41
8-729-043-41
8-729-043-41
8-729-043-41
8-729-043-41
TRANSISTOR 2SK2098-01MR-F119
TRANSISTOR 2SK2098-01MR-F119
TRANSISTOR 2SK2098-01MR-F119
TRANSISTOR 2SK2098-01MR-F119
TRANSISTOR 2SK2098-01MR-F119
REMARK
Q528
Q660
Q661
Q701
Q703
100UH
15UH
100UH
<IC LINK>
PS501¡ 1-533-592-31
PS502¡ 1-532-984-91
PS503¡ 1-532-984-91
PS504¡ 1-532-984-91
PS701¡ 1-533-590-31
DESCRIPTION
7-11
R001
R002
R003
R004
R005
1-216-025-91 RES,CHIP
1-216-049-91 RES,CHIP
1-216-049-91 RES,CHIP
1-216-049-91 RES,CHIP
1-216-073-00 RES,CHIP
100
1K
1K
1K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R006
R007
R008
R009
R010
1-216-049-91 RES,CHIP
1-216-025-91 RES,CHIP
1-216-089-91 RES,CHIP
1-216-025-91 RES,CHIP
1-216-081-00 RES,CHIP
1K
100
47K
100
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R011
R012
R013
R017
R018
1-216-097-91 RES,CHIP
1-216-025-91 RES,CHIP
1-216-675-11 METAL CHIP
1-216-049-91 RES,CHIP
1-216-049-91 RES,CHIP
100K
100
10K
1K
1K
5% 1/10W
5% 1/10W
0.50%1/10W
5% 1/10W
5% 1/10W
R020
R023
R024
R025
R026
1-216-049-91 RES,CHIP
1-216-025-91 RES,CHIP
1-216-089-91 RES,CHIP
1-216-295-91 SHORT
1-216-073-00 RES,CHIP
1K
100
47K
0
10K
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
R027
R028
R029
R030
R031
1-216-073-00
1-216-065-91
1-216-089-91
1-216-017-91
1-216-073-00
10K
4.7K
47K
47
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R032
R033
R034
R035
R036
1-216-675-11 METAL CHIP
1-216-017-91 RES,CHIP
1-216-025-91 RES,CHIP
1-216-049-91 RES,CHIP
1-216-025-91 RES,CHIP
10K
47
100
1K
100
0.50%1/10W
5% 1/10W
5% 1/10W
5% 1/10W
5% 1/10W
R037
R038
R039
R040
R041
1-216-686-11 METAL CHIP
1-216-685-11 METAL CHIP
1-216-049-91 RES,CHIP
1-216-049-91 RES,CHIP
1-216-065-91 RES,CHIP
30K
27K
1K
1K
4.7K
0.50%1/10W
0.50%1/10W
5% 1/10W
5% 1/10W
5% 1/10W
R042
1-216-089-91 RES,CHIP
47K
5%
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1/10W
MCM 21T1
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
(d)
REF.NO. PART NO.
DESCRIPTION
REMARK
R043
R044
R045
R046
1-216-065-91
1-216-095-00
1-216-073-00
1-216-675-11
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
4.7K
82K
10K
10K
5% 1/10W
5% 1/10W
5% 1/10W
0.50%1/10W
R047
R048
R049
R050
R051
1-216-073-00
1-216-049-91
1-216-049-91
1-216-025-91
1-216-679-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
10K
1K
1K
100
15K
5% 1/10W
5% 1/10W
5% 1/10W
5% 1/10W
0.50%1/10W
R052
R053
R054
R055
R056
1-216-073-00
1-216-675-11
1-216-675-11
1-216-089-91
1-216-671-11
RES,CHIP
METAL CHIP
METAL CHIP
RES,CHIP
METAL CHIP
10K
10K
10K
47K
6.8K
5% 1/10W
0.50%1/10W
0.50%1/10W
5% 1/10W
0.50%1/10W
R057
R058
R059
R060
R061
1-216-679-11
1-216-663-11
1-216-065-91
1-216-025-91
1-216-065-91
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
15K
3.3K
4.7K
100
4.7K
0.50%1/10W
0.50%1/10W
5% 1/10W
5% 1/10W
5% 1/10W
R063
R064
R065
R066
R067
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
R068
R069
R070
R071
R072
1-216-025-91
1-216-017-91
1-216-675-11
1-216-049-91
1-216-651-11
RES,CHIP
RES,CHIP
METAL CHIP
RES,CHIP
METAL CHIP
100
47
10K
1K
1K
5% 1/10W
5% 1/10W
0.50%1/10W
5% 1/10W
0.50%1/10W
R073
R074
R075
R076
R077
1-216-295-91
1-216-675-11
1-216-049-91
1-216-049-91
1-216-049-91
SHORT
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
0
10K
1K
1K
1K
0.50%1/10W
5% 1/10W
5% 1/10W
5% 1/10W
R078
R079
R080
R081
R082
1-216-049-91
1-216-017-91
1-216-017-91
1-216-675-11
1-216-049-91
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
RES,CHIP
1K
47
47
10K
1K
5% 1/10W
5% 1/10W
5% 1/10W
0.50%1/10W
5% 1/10W
R083
R084
R085
R086
R088
1-216-057-00
1-216-025-91
1-216-025-91
1-216-049-91
1-216-057-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
2.2K
100
100
1K
2.2K
5%
5%
5%
5%
5%
R089
R090
R092
R094
R096
1-216-057-00
1-216-057-00
1-216-057-00
1-216-057-00
1-216-671-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
2.2K
2.2K
2.2K
2.2K
6.8K
5% 1/10W
5% 1/10W
5% 1/10W
5% 1/10W
0.50%1/10W
R097
R101
R501
R502
R503
1-216-057-00
1-216-049-91
1-216-065-91
1-216-057-00
1-216-041-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
2.2K
1K
4.7K
2.2K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R504
R505
1-216-057-00 RES,CHIP
1-216-041-00 RES,CHIP
2.2K
470
5%
5%
1/10W
1/10W
REF.NO. PART NO.
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
7-12
DESCRIPTION
REMARK
R506
R507
R508
1-249-397-11 CARBON
1-216-065-91 RES,CHIP
1-216-025-91 RES,CHIP
22
4.7K
100
5%
5%
5%
1/4W F
1/10W
1/10W
R509
R510
R511
R512
R513
1-216-057-00
1-216-065-91
1-219-726-11
1-216-627-11
1-215-860-11
RES,CHIP
RES,CHIP
METAL
METAL CHIP
METAL OXIDE
2.2K
4.7K
2.2
100
33
5% 1/10W
5% 1/10W
5% 10W
0.50%1/10W
5% 1W F
R514
R515
R516
R517
R518
1-211-796-11
1-216-675-11
1-247-815-91
1-216-065-91
1-216-097-91
FUSIBLE
METAL CHIP
CARBON
RES,CHIP
RES,CHIP
1
10K
220
4.7K
100K
5% 1/2W F
0.50%1/10W
5% 1/4W
5% 1/10W
5% 1/10W
R519
R520
R521
R522
R523
1-216-393-00
1-216-393-00
1-249-413-11
1-216-423-11
1-249-421-11
METAL OXIDE
METAL OXIDE
CARBON
METAL OXIDE
CARBON
2.2
2.2
470
27
2.2K
5%
5%
5%
5%
5%
R524
R525
R526
R527
R528
1-215-869-11
1-216-681-11
1-214-840-00
1-214-840-00
1-214-840-00
METAL OXIDE
METAL CHIP
METAL
METAL
METAL
1K
18K
100
100
100
5% 1W F
0.50%1/10W
1% 1/2W
1% 1/2W
1% 1/2W
R529
R530
R531
R532
R533
1-260-313-51
1-249-437-11
1-249-437-11
1-249-437-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
56
47K
47K
47K
47K
5%
5%
5%
5%
5%
1/2W
1/4W
1/4W
1/4W
1/4W
R534
R535
R536
R537
R538
1-249-437-11
1-216-049-91
1-216-049-91
1-216-049-91
1-216-049-91
CARBON
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
47K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/10W
1/10W
1/10W
1/10W
R539
R540
R541
R542
R543
1-216-049-91
1-216-073-00
1-260-314-11
1-215-863-11
1-216-640-11
RES,CHIP
RES,CHIP
CARBON
METAL OXIDE
METAL CHIP
1K
10K
68
100
360
5% 1/10W
5% 1/10W
5% 1/2W
5% 1W F
0.50%1/10W
R544
R545
R546
R547
R548
1-260-085-11
1-216-683-11
1-260-288-11
1-216-663-11
1-215-443-00
CARBON
METAL CHIP
CARBON
METAL CHIP
METAL
68
22K
0.47
3.3K
8.2K
5% 1/2W
0.50%1/10W
5% 1/2W
0.50%1/10W
1% 1/4W
R549
R550
R551
R552
R553
1-216-675-11
1-260-288-11
1-216-659-11
1-216-057-00
1-216-655-11
METAL CHIP
CARBON
METAL CHIP
RES,CHIP
METAL CHIP
10K
0.47
2.2K
2.2K
1.5K
0.50%1/10W
5% 1/2W
0.50%1/10W
5% 1/10W
0.50%1/10W
R554
R555
R556
R557
R558
1-216-675-11
1-216-065-91
1-216-674-11
1-218-760-11
1-216-683-11
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
4.7K
9.1K
220K
22K
0.50%1/10W
5% 1/10W
0.50%1/10W
0.50%1/10W
0.50%1/10W
R561
R562
R563
1-216-683-11 METAL CHIP
1-249-401-11 CARBON
1-216-662-11 METAL CHIP
22K
47
3K
0.50%1/10W
5% 1/4W F
0.50%1/10W
3W
3W
1/4W
1W
1/4W
F
F
F
F
F
MCM 21T1
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
REF.NO. PART NO.
(d)
DESCRIPTION
REMARK
R564
R565
1-216-697-91 METAL CHIP
1-216-671-11 METAL CHIP
82K
6.8K
0.50%1/10W
0.50%1/10W
R566
R567
R568
R571
R572
1-260-311-11
1-216-627-11
1-216-655-11
1-216-381-11
1-216-097-91
CARBON
METAL CHIP
METAL CHIP
METAL OXIDE
RES,CHIP
39
100
1.5K
0.22
100K
5% 1/2W
0.50%1/10W
0.50%1/10W
5% 3W F
5% 1/10W
R573
R574
R575
R576
R577
1-216-097-91
1-216-097-91
1-216-097-91
1-216-097-91
1-216-057-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100K
100K
100K
100K
2.2K
5%
5%
5%
5%
5%
R578
R579
R580
R581
R582
1-216-025-91
1-216-672-11
1-216-073-00
1-216-073-00
1-216-073-00
RES,CHIP
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
7.5K
10K
10K
10K
5% 1/10W
0.50%1/10W
5% 1/10W
5% 1/10W
5% 1/10W
R583
R584
R585
R586
R587
1-216-677-11
1-216-081-00
1-216-081-00
1-216-049-91
1-216-049-91
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
12K
22K
22K
1K
1K
0.50%1/10W
5% 1/10W
5% 1/10W
5% 1/10W
5% 1/10W
R588
R589
R590
R591
R594
1-216-097-91
1-216-097-91
1-216-675-11
1-216-675-11
1-249-437-11
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
CARBON
100K
100K
10K
10K
47K
5% 1/10W
5% 1/10W
0.50%1/10W
0.50%1/10W
5% 1/4W
R595
R596
R663
R664
R665
1-249-437-11
1-216-683-11
1-215-482-00
1-215-459-00
1-216-049-91
CARBON
METAL CHIP
METAL
METAL
RES,CHIP
47K
22K
360K
39K
1K
5% 1/4W
0.50%1/10W
1% 1/4W
1% 1/4W
5% 1/10W
R667
R669
R701
R702
R703
1-216-041-00
1-216-671-11
1-249-383-11
1-216-057-00
1-216-085-00
RES,CHIP
METAL CHIP
CARBON
RES,CHIP
RES,CHIP
470
6.8K
1.5
2.2K
33K
5% 1/10W
0.50%1/10W
5% 1/4W F
5% 1/10W
5% 1/10W
R704
R705
R706
R707
R708
1-249-383-11
1-249-385-11
1-216-093-00
1-249-421-11
1-216-073-00
CARBON
CARBON
RES,CHIP
CARBON
RES,CHIP
1.5
2.2
68K
2.2K
10K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/10W
1/4W
1/10W
R709
R710
R715
R719
R720
1-216-473-11
1-216-073-00
1-216-077-00
1-249-383-11
1-260-292-11
METAL OXIDE
RES,CHIP
RES,CHIP
CARBON
CARBON
56
10K
15K
1.5
1
5%
5%
5%
5%
5%
3W F
1/10W
1/10W
1/4W F
1/2W
R721
R722
R723
R724
R725
1-216-667-11
1-216-691-11
1-216-663-11
1-214-798-21
1-214-798-21
METAL CHIP
METAL CHIP
METAL CHIP
METAL
METAL
4.7K
47K
3.3K
1.8
1.8
0.50%1/10W
0.50%1/10W
0.50%1/10W
1% 1/2W
1% 1/2W
R726
R727
R728
R729
1-216-675-11
1-260-292-11
1-249-381-11
1-215-865-11
METAL CHIP
CARBON
CARBON
METAL OXIDE
10K
1
1
220
0.50%1/10W
5% 1/2W
5% 1/4W F
5% 1W F
REF.NO. PART NO.
1/10W
1/10W
1/10W
1/10W
1/10W
7-13
DESCRIPTION
REMARK
R730
1-219-746-11 CARBON
1K
5%
1/2W
R731
R732
R733
R734
R737
1-216-073-00 RES,CHIP
1-216-073-00 RES,CHIP
1-219-746-11 CARBON
1-215-881-11 METAL OXIDE
1-249-377-11 CARBON
10K
10K
1K
15
0.47
5%
5%
5%
5%
5%
1/10W
1/10W
1/2W
2W F
1/4W F
R738
R739
R741
R742
R743
1-249-377-11 CARBON
1-249-413-11 CARBON
1-249-430-11 CARBON
1-249-419-11 CARBON
1-216-049-91 RES,CHIP
0.47
470
12K
1.5K
1K
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W
1/10W
R748
R749
R750
R751
R752
1-216-683-11 METAL CHIP
1-216-049-91 RES,CHIP
1-216-057-00 RES,CHIP
1-216-065-91 RES,CHIP
1-216-083-00 RES,CHIP
22K
1K
2.2K
4.7K
27K
0.50%1/10W
5% 1/10W
5% 1/10W
5% 1/10W
5% 1/10W
R753
R754
R755
R756
R759
1-219-720-11 METAL
1-219-754-11 CARBON
1-219-754-11 CARBON
1-220-824-11 CARBON
1-218-754-11 METAL CHIP
10M
680K
680K
270K
120K
5% 1W
5% 1/2W
5% 1/2W
5% 1/2W
0.50%1/10W
R776
R777
R778
R779
R784
1-216-049-91 RES,CHIP
1-216-681-11 METAL CHIP
1-216-667-11 METAL CHIP
1-216-049-91 RES,CHIP
1-216-081-00 RES,CHIP
1K
18K
4.7K
1K
22K
5% 1/10W
0.50%1/10W
0.50%1/10W
5% 1/10W
5% 1/10W
R900
R901
R902
R903
R904
1-216-399-00
1-216-057-00
1-216-065-91
1-216-073-00
1-216-057-00
6.8
2.2K
4.7K
10K
2.2K
5%
5%
5%
5%
5%
3W F
1/10W
1/10W
1/10W
1/10W
R905
R906
R907
R908
R909
1-216-025-91 RES,CHIP
1-216-065-91 RES,CHIP
1-216-025-91 RES,CHIP
1-216-091-00 RES,CHIP
1-216-689-11 RES,CHIP
100
4.7K
100
56K
39K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R910
R911
R912
R913
R914
1-216-073-00 RES,CHIP
1-216-049-91 RES,CHIP
1-218-768-11 METAL CHIP
1-219-748-11 CARBON
1-219-510-11 CARBON
10K
1K
470K
4.7K
470K
5% 1/10W
5% 1/10W
0.50%1/10W
5% 1/2W
5% 1/2W
R915
R916
R917
R918
R919
1-249-437-11 CARBON
1-249-429-11 CARBON
1-216-073-00 RES,CHIP
1-216-097-91 RES,CHIP
1-216-025-91 RES,CHIP
47K
10K
10K
100K
100
5%
5%
5%
5%
5%
R920
R921
R922
R923
R924
1-249-401-11 CARBON
1-216-668-11 METAL CHIP
1-216-041-00 RES,CHIP
1-216-675-11 METAL CHIP
1-249-397-11 CARBON
47
5.1K
470
10K
22
5% 1/4W F
0.50%1/10W
5% 1/10W
0.50%1/10W
5% 1/4W F
R925
R926
R927
R928
R929
1-216-653-11
1-216-653-11
1-216-073-00
1-216-667-11
1-216-033-00
1.2K
1.2K
10K
4.7K
220
0.50%1/10W
0.50%1/10W
5% 1/10W
0.50%1/10W
5% 1/10W
METAL OXIDE
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
RES,CHIP
METAL CHIP
RES,CHIP
1/4W
1/4W
1/10W
1/10W
1/10W
MCM 21T1
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
(d)(h)
REF.NO. PART NO.
DESCRIPTION
REMARK
REF.NO. PART NO.
DESCRIPTION
REMARK
R930
R933
R934
R937
R940
1-216-033-00
1-216-683-11
1-216-667-11
1-219-727-11
1-249-393-11
RES,CHIP
METAL CHIP
METAL CHIP
METAL
CARBON
220
22K
4.7K
68
10
5% 1/10W
0.50%1/10W
0.50%1/10W
5% 10W
5% 1/4W F
T902¡ X-4035-170-1 TRANSFORMER ASSY, FLYBACK
(NX-4142//J1D4)
R941
R980
R981
R1001
R1003
1-216-073-00
1-216-049-91
1-216-025-91
1-216-073-00
1-216-049-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10K
1K
100
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
TH501 1-807-796-11 THERMISTOR
TH502 1-807-796-11 THERMISTOR
R1004
R1005
R1006
R1007
R1009
1-216-049-91
1-216-049-91
1-216-049-91
1-216-049-91
1-216-097-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1K
1K
1K
1K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
X001
R1011
R1012
R1013
R1014
R1015
1-216-073-00
1-216-049-91
1-216-049-91
1-216-049-91
1-216-295-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
SHORT
10K
1K
1K
1K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R1016
R1017
R1020
R1021
R1022
1-216-049-91
1-216-065-91
1-216-049-91
1-216-049-91
1-216-295-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
SHORT
1K
4.7K
1K
1K
0
5%
5%
5%
5%
R1023
R1024
R1025
R1026
R1027
1-216-295-91
1-216-295-91
1-249-389-11
1-249-389-11
1-216-065-91
SHORT
SHORT
CARBON
CARBON
RES,CHIP
0
0
4.7
4.7
4.7K
5%
5%
5%
1/4W F
1/4W F
1/10W
R1028
R1501
R1502
R1503
1-216-049-91
1-216-057-00
1-216-073-00
1-216-125-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1K
2.2K
10K
1.5M
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R1504 1-216-097-91 RES,CHIP
R1513 1-216-049-91 RES,CHIP
R1514 1-216-049-91 RES,CHIP
100K
1K
1K
5%
5%
5%
1/10W
1/10W
1/10W
<THERMISTOR>
<CRYSTAL>
1-567-781-61 VIBRATOR, CRYSTAL
********************************************************************************
* 8-933-283-00 H BOARD, COMPLETE
****************************
<CAPACITOR>
C805
C811
1/10W
1/10W
1/10W
1/10W
1-124-589-11 ELECT
1-124-589-11 ELECT
47MF
47MF
20% 16V
20% 16V
<CONNECTOR>
CN801*1-564-526-11 PLUG, CONNECTOR 11P
<DIODE>
D820
8-719-064-11 DIODE SPR-325MVW
<TRANSISTOR>
Q801
Q802
8-729-119-78 TRANSISTOR 2SC2785-HFE
8-729-119-78 TRANSISTOR 2SC2785-HFE
<RESISTOR>
<RELAY>
RY501 1-755-137-11 RELAY
R801
R802
R803
R804
R805
1-215-433-00
1-215-409-00
1-215-409-00
1-215-413-00
1-215-413-00
METAL
METAL
METAL
METAL
METAL
3.3K
330
330
470
470
1%
1%
1%
1%
1%
1/4W
1/4W
1/4W
1/4W
1/4W
R806
R807
R808
R809
R810
1-215-417-00
1-215-421-00
1-215-421-00
1-215-429-00
1-215-433-00
METAL
METAL
METAL
METAL
METAL
680
1K
1K
2.2K
3.3K
1%
1%
1%
1%
1%
1/4W
1/4W
1/4W
1/4W
1/4W
R814
R815
R818
R819
R826
1-249-429-11
1-249-429-11
1-215-445-00
1-249-441-11
1-249-408-11
CARBON
CARBON
METAL
CARBON
CARBON
10K
10K
10K
100K
180
5%
5%
1%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R827
1-249-407-11 CARBON
150
5%
1/4W
<SPARK GAP>
SG701 1-519-422-11 GAP, SPARK
SG702 1-519-422-11 GAP, SPARK
SG901 1-517-499-21 GAP, SPARK
<TRANSFORMER>
T501
T502
T503
T504
T701
1-429-303-21
1-416-401-11
1-431-413-11
1-416-257-11
1-431-414-11
TRANSFORMER, FERRITE (HDT)
COIL, CHOKE 5.0MH
TRANSFORMER, FERRITE (HST)
COIL, CHOKE (HCC)
2.0MH
TRANSFORMER, FERRITE (DFT)
T901
1-416-402-11 COIL, CHOKE
500UH
7-14
MCM 21T1
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
REF.NO. PART NO.
(h)(j)(l)
DESCRIPTION
REMARK
REF.NO. PART NO.
<SWITCH>
S802
S803
S804
S805
S806
1-692-431-21
1-692-431-21
1-692-431-21
1-692-431-21
1-692-431-21
SWITCH, TACTILE (CONT+)
SWITCH, TACTILE (CONT-)
SWITCH, TACTILE (MENU)
SWITCH, TACTILE (BRT+)
SWITCH, TACTILE (BRT-)
S818
S820
1-692-431-21 SWITCH, TACTILE (ASC)
1-692-431-21 SWITCH, TACTILE (RESET)
<THERMISTOR>
TH801 1-807-796-11 THERMISTOR
*******************************************************************************
* 8-933-279-00 J BOARD, COMPLETE
****************************
<CONNECTOR>
DESCRIPTION
REMARK
C5205
C5206
C5301
C5303
C5304
1-164-489-11
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
CERAMIC CHIP 0.22MF
CERAMIC CHIP 0.1MF
CERAMIC CHIP 0.1MF
CERAMIC CHIP 0.1MF
CERAMIC CHIP 0.1MF
10%
10%
10%
10%
10%
16V
25V
25V
25V
25V
C5305
C5306
C5307
C5308
C5309
1-104-664-11
1-164-004-11
1-130-495-00
1-164-004-11
1-164-004-11
ELECT
47MF
CERAMIC CHIP 0.1MF
FILM
0.1MF
CERAMIC CHIP 0.1MF
CERAMIC CHIP 0.1MF
20%
10%
5%
10%
10%
25V
25V
50V
25V
25V
C5310
C5311
C5401
C5403
C5404
1-104-664-11
1-130-495-00
1-164-004-11
1-163-021-91
1-164-004-11
ELECT
47MF
FILM
0.1MF
CERAMIC CHIP 0.1MF
CERAMIC CHIP 0.01MF
CERAMIC CHIP 0.1MF
20%
5%
10%
10%
10%
25V
50V
25V
50V
25V
C5405
C5406
C5407
C5408
C5409
1-104-664-11
1-164-004-11
1-130-495-00
1-163-003-11
1-164-004-11
ELECT
47MF
CERAMIC CHIP 0.1MF
FILM
0.1MF
CERAMIC CHIP 330PF
CERAMIC CHIP 0.1MF
20%
10%
5%
10%
10%
25V
25V
50V
50V
25V
C5410 1-104-664-11 ELECT
47MF
C5412 1-164-004-11 CERAMIC CHIP 0.1MF
C5501 1-126-934-11 ELECT
220MF
CN891*1-691-961-11 PIN, CONNECTOR (PC BOARD) 2P
<SWITCH>
20% 25V
10% 25V
20% 10V
<CONNECTOR>
S891 ¡ 1-571-433-31 SWITCH, PUSH (AC POWER)
CN5001*1-564-512-11PLUG, CONNECTOR 9P
CN5002*1-564-509-11PLUG, CONNECTOR 6P
CN5003 1-564-513-11PLUG, CONNECTOR 10P
CN5004*1-564-507-11PLUG, CONNECTOR 4P
*******************************************************************************
* 8-933-297-00 L BOARD, COMPLETE
****************************
<DIODE>
<CAPACITOR>
C5002
C5003
C5004
C5005
C5008
1-126-964-11
1-126-933-11
1-104-664-11
1-104-664-11
1-104-664-11
ELECT
ELECT
ELECT
ELECT
ELECT
10MF
100MF
47MF
47MF
47MF
20%
20%
20%
20%
20%
50V
16V
25V
25V
25V
C5009
C5101
C5103
C5104
C5105
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
1-104-664-11
CERAMIC CHIP 0.1MF
CERAMIC CHIP 0.1MF
CERAMIC CHIP 0.1MF
CERAMIC CHIP 0.1MF
ELECT
47MF
10%
10%
10%
10%
20%
25V
25V
25V
25V
25V
C5106
C5107
C5108
C5109
C5110
1-164-004-11
1-130-495-00
1-164-004-11
1-164-004-11
1-104-664-11
CERAMIC CHIP 0.1MF
FILM
0.1MF
CERAMIC CHIP 0.1MF
CERAMIC CHIP 0.1MF
ELECT
47MF
10%
5%
10%
10%
20%
25V
50V
25V
25V
25V
C5111
C5201
C5202
C5203
C5204
1-130-495-00
1-104-664-11
1-104-664-11
1-164-004-11
1-130-495-00
FILM
0.1MF
ELECT
47MF
ELECT
47MF
CERAMIC CHIP 0.1MF
FILM
0.1MF
5%
20%
20%
10%
5%
50V
25V
25V
25V
50V
D5002
D5101
D5103
D5201
D5301
8-719-801-78
8-719-800-76
8-719-800-76
8-719-800-76
8-719-800-76
DIODE 1SS184
DIODE 1SS226
DIODE 1SS226
DIODE 1SS226
DIODE 1SS226
D5303
D5401
D5403
D5501
8-719-800-76
8-719-800-76
8-719-800-76
8-719-976-96
DIODE 1SS226
DIODE 1SS226
DIODE 1SS226
ZENER DIODE DTZ4.7C
<SENSOR>
GS50011-475-592-11 SENSOR UNIT, MAGNETIC
<IC>
IC5101
IC5201
IC5301
IC5401
8-759-822-38
8-759-803-42
8-759-822-38
8-759-822-38
IC LA6510
IC LA6500-FA
IC LA6510
IC LA6510
<RESISTOR>
R5001 1-249-383-11 CARBON
7-15
1.5
5%
1/4W F
MCM 21T1
The components identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
(l)
DESCRIPTION
REMARK
R5003
R5005
R5006
R5007
1-216-295-91
1-216-689-11
1-216-073-00
1-216-049-91
SHORT
RES,CHIP
RES,CHIP
RES,CHIP
0
39K
10K
1K
R5008
R5009
R5010
R5011
R5012
1-216-295-91
1-216-295-91
1-216-295-91
1-216-073-00
1-216-295-91
SHORT
SHORT
SHORT
RES,CHIP
SHORT
0
0
0
10K
0
R5013
R5015
R5101
R5102
R5108
1-216-295-91
1-216-049-91
1-249-383-11
1-249-383-11
1-216-308-00
SHORT
RES,CHIP
CARBON
CARBON
RES,CHIP
R5109
R5110
R5111
R5112
R5113
1-216-308-00
1-216-073-00
1-216-308-00
1-249-383-11
1-216-073-00
R5114
R5115
R5116
R5117
R5119
REF.NO. PART NO.
DESCRIPTION
REMARK
R5310
R5311
R5312
R5313
R5314
1-216-073-00
1-216-308-00
1-249-383-11
1-216-073-00
1-249-441-11
RES,CHIP
RES,CHIP
CARBON
RES,CHIP
CARBON
10K
4.7
1.5
10K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/4W F
1/10W
1/4W F
5%
1/10W
R5315
R5316
R5317
R5319
R5320
1-215-882-00
1-216-073-00
1-216-308-00
1-216-073-00
1-249-383-11
METAL OXIDE
RES,CHIP
RES,CHIP
RES,CHIP
CARBON
22
10K
4.7
10K
1.5
5%
5%
5%
5%
5%
2W F
1/10W
1/10W
1/10W
1/4W F
0
1K
1.5
1.5
4.7
5%
5%
5%
5%
1/10W
1/4W F
1/4W F
1/10W
R5321
R5322
R5401
R5402
R5406
1-249-441-11
1-215-882-00
1-249-383-11
1-249-383-11
1-216-689-11
CARBON
METAL OXIDE
CARBON
CARBON
RES,CHIP
100K
22
1.5
1.5
39K
5%
5%
5%
5%
5%
1/4W F
2W F
1/4W F
1/4W F
1/10W
RES,CHIP
RES,CHIP
RES,CHIP
CARBON
RES,CHIP
4.7
10K
4.7
1.5
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/4W F
1/10W
R5407
R5408
R5409
R5410
R5411
1-216-079-00
1-216-308-00
1-216-308-00
1-216-089-91
1-216-308-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
18K
4.7
4.7
47K
4.7
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1-249-441-11
1-215-882-00
1-216-073-00
1-216-308-00
1-216-073-00
CARBON
METAL OXIDE
RES,CHIP
RES,CHIP
RES,CHIP
100K
22
10K
4.7
10K
5%
5%
5%
5%
5%
1/4W F
2W F
1/10W
1/10W
1/10W
R5412
R5413
R5414
R5415
R5416
1-249-383-11
1-216-097-91
1-249-441-11
1-215-886-11
1-216-077-00
CARBON
RES,CHIP
CARBON
METAL OXIDE
RES,CHIP
1.5
100K
100K
100
15K
5%
5%
5%
5%
5%
1/4W F
1/10W
1/4W F
2W F
1/10W
R5120
R5121
R5122
R5201
R5202
1-249-383-11
1-249-441-11
1-215-882-00
1-249-383-11
1-249-383-11
CARBON
CARBON
METAL OXIDE
CARBON
CARBON
1.5
100K
22
1.5
1.5
5%
5%
5%
5%
5%
1/4W
1/4W
2W
1/4W
1/4W
R5417
R5419
R5420
R5421
R5422
1-216-308-00
1-216-089-91
1-249-383-11
1-249-441-11
1-215-885-00
RES,CHIP
RES,CHIP
CARBON
CARBON
METAL OXIDE
4.7
47K
1.5
100K
68
5%
5%
5%
5%
5%
1/10W
1/10W
1/4W F
1/4W F
2W F
R5203
R5204
R5205
R5206
R5207
1-249-383-11
1-249-441-11
1-216-073-00
1-215-859-00
1-216-073-00
CARBON
CARBON
RES,CHIP
METAL OXIDE
RES,CHIP
1.5
100K
10K
22
10K
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/10W
1W F
1/10W
R5423
R5501
R5502
R5503
R5504
1-216-105-91
1-216-057-00
1-216-681-11
1-216-681-11
1-216-093-00
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
RES,CHIP
220K
2.2K
18K
18K
68K
5% 1/10W
5% 1/10W
0.50%1/10W
0.50%1/10W
5% 1/10W
R5208
R5301
R5302
R5308
R5309
1-216-670-11
1-249-383-11
1-249-383-11
1-216-308-00
1-216-308-00
METAL CHIP
CARBON
CARBON
RES,CHIP
RES,CHIP
6.2K
1.5
1.5
4.7
4.7
0.50%1/10W
5% 1/4W F
5% 1/4W F
5% 1/10W
5% 1/10W
R5505 1-216-067-00 RES,CHIP
R5506 1-216-670-11 METAL CHIP
5.6K
6.2K
5% 1/10W
0.50%1/10W
F
F
F
F
F
9-978-623-01
1/10W
1/10W
1/10W
5%
5%
5%
MCM 21T1
REF.NO. PART NO.
98FL05013-1
9-978-623-01
–7-16
74 –
English
98FL05013-1
Printed in Japan
 1998.6