. xiaoyu163. com QQ376315150 99 28 94 29 8

http://www.xiaoyu163.com
XR-M313
QQ 376315150 892498299
U
TEL
TEL
BASIC CD MECHANISM : DA11B3
SYSTEM
COMPACT
DISC
SPEAKER
REMOTE
CONTROLLER
XR–M313
CX–LM313
SX–LM313
RC–AAT15(W)
• This Service Manual is the “Revision Publishing” and replace “Simple Manual”
XR-M313<U>, (S/M Code No. 09-014-445-0T1).
www
.
xiaoy u163. com
S/M Code No. 09-016-445-0R1
http://www.xiaoyu163.com
N
O
SI
I
V TA
E
R
A
D
376315150 892498299
376315150 892498299
COMPACT DISC STEREO SYSTEM
QQ
QQ
376315150 892498299
13942296513
13942296513
SERVICEQQ MANUAL
TEL 13942296513
http://www.xiaoyu163.com
SPECIFICATIONS
QQ 376315150 892498299
TUNER
FM tuning range:
87.5 MHz to 108 MHz
FM usable sensitivity(IHF):
13.2 dBf
FM antenna terminals:
75 ohms (unbalanced)
AM tuning range:
530 kHz to 1710 kHz (10 kHz step)
531 kHz to 1602 kHz (9 kHz step)
AM usable sensitivity:
350 mV/m
AM antenna:
Loop antenna
GENERAL
Power requirements:
120 V AC, 60 Hz
Power consumption:
22 W
Power consumption in standby mode:
With ECO mode on: 1.6 W
With ECO mode off: 5.4 W
Dimensions ( W x H x D): 166 x 162 x 256.2 mm
(6 5/8 x 6 1/2 x 10 1/8 in.)
Weight:
2.5 kg (5 lbs 8 oz)
AMPLIFIER
Power output:
SPEAKERS
Speaker system:
2 way, bass reflex (magnetic shielded)
Impedance:
6 ohms
Dimensions (W x H x D): 166 x 157 x 224.5 mm
( 6 5/8 x 6 1/4 x 8 7/8 in.)
Weight:
0.8 kg (1 lbs 12 oz)
5.5 W + 5.5 W (50 Hz – 20 kHz, THD
less than 1 %, 6 ohms)
7 W + 7 W (1 kHz, THD less than
10 %, 6 ohms)
Total harmonic distortion: 0.15 % (3.5 W, 1 kHz, 6 ohms, DIN AUDIO)
Input:
AUX IN: 600 mV
Outputs:
SPEAKERS: 6 ohms or more
PHONES: 16 ohms or more
SUPER WOOFER: 0.85 V
TEL
TEL
Semiconductor laser (l = 780 nm)
1 bit dual
85 dB (1 kHz, 0 dB)
0.08 % (1 kHz, 0 dB)
Unmeasurable
REF. NO. PART NO.
1
2
3
4
KANRI
DESCRIPTION
NO.
8B-CL7-903-110
IB,U(ESF)M
87-043-115-010
FEEDER-ANT,FM
87-A90-030-010
ANT,LOOP AM-NC C
8B-CL7-951-010
UNIT,RC-AAT15(W)
www
.
xiaoy u163. com
–2–
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
ACCESSORIES / PACKAGE LIST
13942296513
13942296513
CD PLAYER
Laser:
D/A converter:
Signal-to-noise ratio:
Harmonic distortion:
Wow and flutter:
• Design and specifications are subject to change without notice.
http://www.xiaoyu163.com
PROTECTION OF EYES FROM LASER BEAM DURING SERVICING
QQ 376315150 892498299
This set employs laser. Therefore, be sure to follow carefully
the instructions below when servicing.
WARNING!!
WHEN SERVICING, DO NOT APPROACH THE LASER
EXIT WITH THE EYE TOO CLOSELY. IN CASE IT IS
NECESSARY TO CONFIRM LASER BEAM EMISSION.
BE SURE TO OBSERVE FROM A DISTANCE OF MORE
THAN 30cm FROM THE SURFACE OF THE OBJECTIVE
LENS ON THE OPTICAL PICK-UP BLOCK.
CAUTION
Use of controls or adjustments or performance of procedures other than those specified herin may result in
hazardous radiation exposure.
ATTENTION
L’utillisation de commandes, réglages ou procédures
autres que ceux spécifiés peut entraîner une dangereuse
exposition aux radiations.
ADVARSEL
s
Caution: Invisible laser radiation when
open and interlocks defeated avoid
exposure to beam.
Advarsel: Usynlig laserståling ved åbning,
når sikkerhedsafbrydere er ude af funktion.
Undgå udsættelse for stråling.
Usynlig laserståling ved åbning, når sikkerhedsafbrydereer
ude af funktion. Undgå udsættelse for stråling.
VAROITUS!
CLASS 1
KLASSE 1
LUOKAN 1
KLASS 1
QQ 376315150 892498299
Precaution to replace Optical block
(SF–P101NR)
Body or clothes electrostatic potential could
ruin laser diode in the optical block. Be sure
ground body and workbench, and use care the
clothes do not touch the diode.
PICK-UP ASSY PWB
1) After the connection, remove solder shown in
right figure.
www
.
xiaoy u163. com
Solder
–3–
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
VARNING!
Om apparaten används på annat sätt än vad som
specificeras i denna bruksanvising, kan användaren
utsättas för osynling laserstrålning, som överskrider
gränsen för laserklass 1.
LASER PRODUCT
LASER PRODUKT
LASER LAITE
LASER APPARAT
13942296513
13942296513
Laiteen Käyttäminen muulla kuin tässä käyttöohjeessa
mainitulla tavalla saataa altistaa käyt-täjän
turvallisuusluokan 1 ylittävälle näkymättömälle
lasersäteilylle.
TEL
TEL
This Compact Disc player is classified as a CLASS 1
LASER product.
The CLASS 1 LASER PRODUCT label is located on the
rear exterior.
http://www.xiaoyu163.com
ELECTRICAL MAIN PARTS LIST
QQ 376315150 892498299
REF. NO. PART NO.
KANRI
NO.
DESCRIPTION
REF. NO. PART NO.
IC
8B-CL7-612-010
87-A21-881-010
87-A21-245-010
87-A20-446-010
87-A21-319-010
C-IC,LC877256V-5V22
IC,LA4636
IC,RPM6938-V4
C-IC,LA9241ML
C-IC,LC78622NE
87-A21-093-010
87-A21-416-040
87-A21-928-010
87-A20-913-010
IC,LA6541D
C-IC,M61500FP
IC,LC72131D-N
IC,LA1837NL
TRANSISTOR
87-A30-515-080
87-A30-287-040
87-A30-288-040
89-318-155-080
87-026-290-080
TR,2SA1979O/Y
C-TR,DTC114TKA
C-TR,DTC114YKA
TR,2SC1815GR
TR,DTA124XS
87-026-291-080
87-A30-432-040
87-A30-072-080
87-A30-152-080
87-026-245-080
TR,DTC124XS
C-TR,DTC124XKA
C-TR,RT1P 144C
TR,2SC5395F
TR,DTC114ES
89-109-521-080
TR,2SA952K
DIODE
DIODE,1SS133 (110MA)
C-DIODE,MC2838
C-DIODE,MC2836
ZENER,MTZJ6.8C
DIODE,1N4003 SEM
87-A40-345-080
87-A40-337-080
87-070-345-080
87-A40-648-080
87-A40-313-080
ZENER,MTZJ10C
ZENER,MTZJ 6.8B
DIODE,IN4148
ZENERT,MTZJ8.2A
C-DIODE,MC 2840
87-A40-430-080
87-070-022-010
ZENER,HZS2C2
DIODE,IN5402 (RECT)
MAIN C.B
C219
C220
C227
C228
C234
87-012-278-080
87-012-278-080
87-010-491-040
87-010-491-040
87-010-497-040
C-CAP,U 2200P-50 B
C-CAP,U 2200P-50 B
CAP,E 0.22-50 GAS
CAP,E 0.22-50 GAS
CAP,E 4.7-35 GAS
C265
C266
C267
C268
C270
87-A10-307-080
87-A10-307-080
87-A10-307-080
87-A10-307-080
87-010-248-080
CAP,M 0.1-50 J
CAP,M 0.1-50 J
CAP,M 0.1-50 J
CAP,M 0.1-50 J
CAP, ELECT 220-10V
C271
C272
C273
C274
C275
87-010-260-080
87-010-378-080
87-010-388-080
87-010-831-080
87-010-981-040
CAP, ELECT 47-25V
CAP, ELECT 10-16V
CAP ELECT 1000-25V SME
C-CAP,U,0.1-16F
CAP,E 22-35 5L SRE
C276
C277
87-010-981-040
87-010-406-080
www
.
87-010-555-040
87-012-286-080
87-012-270-080
87-010-496-040
87-A10-189-040
CAP,E 100-10 GAS
CAP, U 0.01-25
CAP, U 470P-50
CAP,E 3.3-50 GAS
CAP,E 220-10 M 5L
C503
C504
C515
C516
C517
87-A10-189-040
87-012-286-080
87-010-369-080
87-010-369-080
87-016-460-080
CAP,E 220-10 M 5L
CAP, U 0.01-25
C-CAP,S 0.033-25 K B
C-CAP,S 0.033-25 K B
C-CAP,S 0.22-16 B
C518
C519
C520
C525
C526
87-016-460-080
87-016-460-080
87-016-460-080
87-010-490-040
87-010-490-040
C-CAP,S 0.22-16 B
C-CAP,S 0.22-16 B
C-CAP,S 0.22-16 B
CAP, ELECT 0.1-50
CAP, ELECT 0.1-50
C545
C562
C563
C581
C582
87-010-831-080
87-012-288-080
87-012-288-080
87-010-400-080
87-010-400-080
C-CAP,U,0.1-16F
C-CAP,U 120P-50 J UJ
C-CAP,U 120P-50 J UJ
CAP, ELECT 0.47-50V
CAP, ELECT 0.47-50V
C585
C586
C587
C588
C701
87-010-401-080
87-010-401-080
87-010-401-080
87-010-401-080
87-010-381-080
CAP,
CAP,
CAP,
CAP,
CAP,
C702
C703
C704
C705
C706
87-010-404-080
87-012-286-080
87-012-286-080
87-A10-592-080
87-A10-592-080
CAP, ELECT 4.7-50V
CAP, U 0.01-25
CAP, U 0.01-25
C-CAP,S 0.015-50 J B
C-CAP,S 0.015-50 J B
C709
C711
C714
C717
C719
87-012-195-080
87-010-260-080
87-012-286-080
87-012-286-080
87-012-286-080
C-CAP,U 100P-50CH
CAP, ELECT 47-25V
CAP, U 0.01-25
CAP, U 0.01-25
CAP, U 0.01-25
C720
C721
C722
C723
C725
87-012-195-080
87-012-176-080
87-012-176-080
87-012-274-080
87-012-274-080
C-CAP,U 100P-50CH
CAP 15P
CAP 15P
CHIP CAP,U 1000P-50B
CHIP CAP,U 1000P-50B
C727
C728
C729
C731
C733
87-010-196-080
87-010-248-080
87-012-274-080
87-012-286-080
87-010-987-080
CHIP CAPACITOR,0.1-25
CAP, ELECT 220-10V
CHIP CAP,U 1000P-50B
CAP, U 0.01-25
C-CAP,S 1500P-50 CH
C734
C735
C736
C737
C738
87-010-987-080
87-010-987-080
87-010-987-080
87-A10-592-080
87-A10-592-080
C-CAP,S
C-CAP,S
C-CAP,S
C-CAP,S
C-CAP,S
C751
C752
C756
C757
C758
87-012-365-080
87-012-365-080
87-012-286-080
87-012-188-080
87-012-167-080
C-CAP,S 0.027-25VBK
C-CAP,S 0.027-25VBK
CAP, U 0.01-25
C-CAP,U 47P-50 CH
C-CAP,U 5P-50 CH
C763
C764
C765
C768
C769
87-010-829-080
87-012-337-080
87-012-286-080
87-012-286-080
87-010-260-080
CAP, U 0.047-16
C-CAP,U 56P-50 CH
CAP, U 0.01-25
CAP, U 0.01-25
CAP, ELECT 47-25V
ELECT
ELECT
ELECT
ELECT
ELECT
1-50V
1-50V
1-50V
1-50V
330-16V
QQ 376315150 892498299
TEL 13942296513
87-020-465-080
87-A40-270-080
87-A40-269-080
87-A40-509-080
87-070-274-080
C322
C323
C330
C360
C501
1500P-50
1500P-50
1500P-50
0.015-50
0.015-50
xiaoy u163. com
CAP,E 22-35 5L SRE
CAP, ELECT 22-50
–4–
http://www.xiaoyu163.com
CH
CH
CH
J B
J B
376315150 892498299
376315150 892498299
C-TR,2SA1235F
C-TR,2SC3052F
TR,KTA1046Y
TR,2SD1933
TR,2SA933AS(R)
C-CAP,U, 0.1-25F
CAP,E 100-16 GAS
C-CAP,U, 0.1-25F
CAP, ELECT 47-50V
CAP,E 100-16 GAS
QQ
QQ
87-A30-075-080
87-A30-076-080
87-A30-476-010
87-A30-256-010
87-A30-216-080
87-010-759-080
87-016-044-040
87-010-759-080
87-010-408-080
87-016-044-040
13942296513
13942296513
C-TR,CMBT5401
CHIP TR,2SC3326B
C-FET,2SK2158
C-TR,RT1N 141C
TR,KTC3198GR
C302
C303
C304
C308
C309
TEL
TEL
87-A30-107-070
89-333-266-080
87-A30-087-080
87-A30-073-080
87-026-610-080
C278
C297
C298
C299
C301
KANRI
DESCRIPTION
NO.
87-010-406-080
CAP, ELECT 22-50
87-A12-068-080
CAP,E 470-16 SMG
87-010-405-080
CAP, ELECT 10-50V
87-010-405-080
CAP, ELECT 10-50V
87-010-263-080
CAP, ELECT 100-10V
http://www.xiaoyu163.com
C221
C222
C241
C242
C243
87-012-274-080
87-010-498-040
87-010-493-040
87-A10-189-040
87-010-831-080
CHIP CAP,U 1000P-50B
CAP,E 10-16 GAS
CAP,E 0.47-50 GAS
CAP,E 220-10
C-CAP,U,0.1-16F
C780
C781
C782
C783
C784
87-010-196-080
87-010-405-080
87-010-405-080
87-012-286-080
87-012-286-080
CHIP
CAP,
CAP,
CAP,
CAP,
CN101
CN102
CN121
CN301
D151
87-A60-077-010
87-A60-076-010
87-A60-078-010
87-A60-666-010
87-A92-077-010
CONN,10P H 9604S-10F
CONN,12P H 9604S-12F
CONN,09P H 9604S-09F
CONN,2P H 2MM JMT
LED,SMLU1BE16C-SLF73 BLU/UMB
C785
C786
C789
C790
C791
87-010-401-080
87-010-401-080
87-012-275-080
87-012-275-080
87-010-405-080
CAP, ELECT 1-50V
CAP, ELECT 1-50V
C-CAP,U 1200P-50 B
C-CAP,U 1200P-50 B
CAP, ELECT 10-50V
D152
D153
D154
D263
FFC101
87-A92-077-010
87-A92-078-010
87-A92-078-010
87-A40-647-010
88-910-201-110
LED,SMLU1BE16C-SLF73 BLU/UMB
LED,SELU1D10CXM-SLF38 GR
LED,SELU1D10CXM-SLF38 GR
LED,SEL2210R RED
FF-CABLE,10P 1.25 200MM
C793
C794
C795
C796
C799
87-012-273-080
87-010-406-080
87-010-596-080
87-010-403-080
87-010-829-080
C-CAP,U 820P-50 B
CAP, ELECT 22-50
CAP, S 0.047-16
CAP, ELECT 3.3-50V
CAP, U 0.047-16
FFC107
FFC121
LCD101
S301
S302
88-912-201-110
88-909-181-110
8B-CL7-611-010
87-A91-704-080
87-A91-704-080
FF-CABLE,12P 1.25
FF-CABLE,9P 1.25 180MM
LCD,AIW4269-30PIN
SW,TACT EVQ 214 05R
SW,TACT EVQ 214 05R
C812
C820
C821
C822
C823
87-012-286-080
87-010-260-080
87-012-286-080
87-012-286-080
87-012-286-080
CAP,
CAP,
CAP,
CAP,
CAP,
U 0.01-25
ELECT 47-25V
U 0.01-25
U 0.01-25
U 0.01-25
S303
S304
S305
S306
87-A91-704-080
87-A91-704-080
87-A91-704-080
87-A91-704-080
SW,TACT
SW,TACT
SW,TACT
SW,TACT
QQ
C828
C829
C959
C960
C961
87-010-196-080
87-010-196-080
87-010-196-080
87-010-196-080
87-012-170-080
CHIP CAPACITOR,0.1-25
CHIP CAPACITOR,0.1-25
CHIP CAPACITOR,0.1-25
CHIP CAPACITOR,0.1-25
C-CAP,U 8P-50 CH
CD C.B
C963
C996
C999
CF801
CF802
87-010-196-080
87-010-831-080
87-010-385-080
87-008-261-010
87-008-261-010
CHIP CAPACITOR,0.1-25
C-CAP,U,0.1-16F
CAP,E 220-25 M SME
FILTER, SFE10.7MA5-A
FILTER, SFE10.7MA5-A
CN101
CN102
CN107
CN301
CNA104
87-A60-058-010
87-A60-060-010
87-A60-056-010
87-A60-989-010
8B-CL7-641-010
CONN,10P V 9604S-10C
CONN,07P V 9604S-07C
CONN,12P V 9604S-12C
CONN,06P V BLK TAC-L06X-A3
CONN ASSY,3P V AUX
CNA110
CNA302
FFC102
FFE801
J201
8B-CL7-644-010
8B-CL7-642-010
88-907-221-110
A8-8ZA-194-030
87-A60-420-010
CONN ASSY,4P V WO
CONN ASSY,3P V RELAY
FF-CABLE,7P 1.25 220MM
8ZA-1 FEMUNM
JACK,3.5 ST (MSC)
J202
J801
L771
L772
L981
87-A60-659-010
87-A60-702-010
87-A50-266-010
87-A91-110-010
8Z-ZA1-667-010
TERMINAL,SPKR 4P HSP-134V-05Z
TERMINAL,ANT 4P CJ-9036
COIL,FM DET-2N(TOK)
FLTR,PCFJZH-450 (TOK)
COIL,AM PACK 4F(TOK)
PR601
R368
X721
87-A90-246-080
87-A00-261-080
87-A70-306-010
PROTECTOR,0.25A 60V
RES,M/F 0.56-1W J
VIB,XTAL 4.500MHZ CSA-309ST
C150
C151
C152
C153
C154
87-010-555-040
87-010-555-040
87-010-555-040
87-010-831-080
87-010-831-080
CAP,E 100-10 GAS
CAP,E 100-10 GAS
CAP,E 100-10 GAS
C-CAP,U,0.1-16F
C-CAP,U,0.1-16F
C155
C156
C157
C158
87-010-831-080
87-010-831-080
87-010-831-080
87-010-831-080
C-CAP,U,0.1-16F
C-CAP,U,0.1-16F
C-CAP,U,0.1-16F
C-CAP,U,0.1-16F
CAPACITOR,0.1-25
ELECT 10-50V
ELECT 10-50V
U 0.01-25
U 0.01-25
376315150 892498299
TEL 13942296513
.
214
214
214
214
05R
05R
05R
05R
QQ 376315150 892498299
FRONT C.B
www
EVQ
EVQ
EVQ
EVQ
C401
C402
C403
C404
C405
87-015-697-040
87-012-286-080
87-010-263-040
87-010-248-040
87-012-286-080
CAP,E 3.3-50 7L
CAP, U 0.01-25
CAP,E 100-10
CAP,E 220-10 SME
CAP, U 0.01-25
C406
C407
C408
C409
C410
87-010-374-040
87-012-274-080
87-010-787-080
87-010-248-040
87-010-263-040
CAP,E 47-10
CHIP CAP,U 1000P-50B
CAP, U 0.022-25
CAP,E 220-10 SME
CAP,E 100-10
C412
C414
C415
C416
C417
87-015-695-040
87-015-699-040
87-010-831-080
87-015-692-040
87-012-268-080
E/CAP 1UF 50V TAPG
CAP,E 10-50 7L
C-CAP,U,0.1-16F
E/CAP 0.22-50V TAPG
C-CAP,U 330P-50 B
C418
C420
C422
C423
C424
87-010-785-080
87-A11-070-080
87-012-280-080
87-A10-504-080
87-016-460-080
C-CAP,U0.015-25BK
C-CAP,U 0.033-16 K B
CAP, U 3300P-50
C-CAP,U 0.047-16 K B
C-CAP,S 0.22-16 B
C425
C426
C427
C429
C430
87-012-272-080
87-A10-201-080
87-012-195-080
87-012-282-080
87-012-199-080
C-CAP,U 680P-50 B
C-CAP,S0.33-16 KB
C-CAP,U 100P-50CH
CAP, U 4700P-50
CAP 220P
C431
C432
C433
C434
C435
87-010-491-040
87-010-553-040
87-010-494-040
87-012-280-080
87-012-286-080
CAP,E 0.22-50 GAS
CAP,E 47-16 GAS
CAP,E 1-50 GAS
CAP, U 3300P-50
CAP, U 0.01-25
C436
C437
C438
C439
C440
87-010-374-040
87-015-698-040
87-A10-260-080
87-012-274-080
87-012-162-080
CAP,E 47-10
CAP,E 4.7-50 7L
C-CAP,U 0.1-16 K B
CHIP CAP,U 1000P-50B
C-CAP,U 1P-50 CK
C441
C442
C443
87-012-286-080
87-012-178-080
87-012-195-080
CAP, U 0.01-25
C-CAP,U 18P-50 CH
C-CAP,U 100P-50CH
xiaoy u163. com
–5–
http://www.xiaoyu163.com
376315150 892498299
CAP,E 4.7-35 GAS
CAP, U 0.01-25
CAP,E 0.47-50 GAS
CAP,E 1-50 GAS
CAP,E 1-50 GAS
QQ
87-010-497-040
87-012-286-080
87-010-493-040
87-010-494-040
87-010-494-040
13942296513
C775
C776
C777
C778
C779
!
REF. NO. PART NO.
TEL
C201
C203
C204
C205
C206
KANRI
DESCRIPTION
NO.
87-012-184-080
C-CAP,U 33P-50 CH
87-A11-073-080
CAP,TC U 22P-50 J CH
87-010-787-080
CAP, U 0.022-25
87-010-831-080
C-CAP,U,0.1-16F
87-010-831-080
C-CAP,U,0.1-16F
TEL
C770
C771
C772
C773
C774
KANRI
DESCRIPTION
NO.
87-010-829-080
CAP, U 0.047-16
87-010-383-080
CAP, ELECT 33-25V
87-010-829-080
CAP, U 0.047-16
87-010-196-080
CHIP CAPACITOR,0.1-25
87-010-555-040
CAP,E 100-10 GAS
13942296513
QQ 376315150 892498299
REF. NO. PART NO.
http://www.xiaoyu163.com
QQ 376315150 892498299
REF. NO. PART NO.
REF. NO. PART NO.
C-CAP,U 100P-50CH
CAP, U 470P-50
CAP 220P
CAP,E 100-10
C-CAP,U 100P-50CH
C457
C458
C459
C460
C461
87-012-176-080
87-012-176-080
87-010-263-040
87-015-819-080
87-012-286-080
CAP 15P
CAP 15P
CAP,E 100-10
CAPACITOR,0.01
CAP, U 0.01-25
C462
C463
C465
C467
C469
87-010-248-040
87-A11-132-080
87-010-404-040
87-010-263-040
87-012-197-080
CAP,E 220-10 SME
CAP,TC U 0.01-50 K B
CAP,E 4.7-50 SME
CAP,E 100-10
C-CAP,U 150P-50 CH
C470
C471
C472
C473
C474
87-015-691-040
87-010-831-080
87-010-831-080
87-010-831-080
87-010-831-080
CAP,E0.1-50 SRA
C-CAP,U,0.1-16F
C-CAP,U,0.1-16F
C-CAP,U,0.1-16F
C-CAP,U,0.1-16F
C475
C476
C477
C478
C479
87-012-286-080
87-010-236-080
87-012-286-080
87-010-263-040
87-012-286-080
CAP, U 0.01-25
CAP,E 1000-10 SME
CAP, U 0.01-25
CAP,E 100-10
CAP, U 0.01-25
C480
C481
C482
C489
C490
87-010-221-040
87-010-405-040
87-010-405-040
87-010-831-080
87-010-831-080
CAP,E 470-10 SME
CAP,E 10-50
CAP,E 10-50
C-CAP,U,0.1-16F
C-CAP,U,0.1-16F
C491
C492
C493
C494
C495
87-010-260-040
87-010-831-080
87-012-286-080
87-A11-132-080
87-A11-116-080
CAP,E 47-25 SME
C-CAP,U,0.1-16F
CAP, U 0.01-25
CAP,TC U 0.01-50 K B
CAP,TC U 1500P
C496
C497
C498
CN401
CN403
87-010-831-080
87-010-382-040
87-012-286-080
87-A60-424-010
87-A60-078-010
C-CAP,U,0.1-16F
CAP,E 22-25 SME
C-CAP,U 0.01-25 K B
CONN,16P V TOC-B
CONN,09P H 9604S-09F
CN404
CN502
CNA402
FFC401
JW444
87-A60-080-010
87-A60-619-010
88-805-061-020
8B-CL7-647-010
87-003-098-080
CONN,07P H 9604S-07F
CONN,2P V 2MM JMT
CONN ASSY,6P
FF-CABLE,16P 1 100MM
COIL,2.2UH
L401
L404
SFR430
X401
87-003-102-080
87-003-152-080
87-024-437-080
81-592-641-010
COIL, 10UH
COIL, 100UH
SFR100K,RH063EC
VIB,CER 16.93MHZ
C912
C923
C924
CN901
CN902
87-010-387-080
87-010-405-080
87-A10-479-080
87-099-043-010
87-A60-620-010
CAP,E 470-25 SME
CAP, ELECT 10-50V
CAP,CER 2200P-250 M E KH
CONN 2P EH
CONN,3P V 2MM JMT
PR905
PR910
PT901
PT905
RY904
87-A90-210-080
87-A91-276-080
8B-CL7-604-010
8Z-NF8-661-010
87-A91-390-010
FUSE,7A 125V 251
FUSE,125MA 125V F 251
PT,U
PT,SUB ZNF-8(U)
RELAY,AC12V G5PA-1-8
T905
T906
87-A60-317-010
87-A60-317-010
POWER C.B
C101
C903
C904
C911
C912
87-010-780-090
87-018-209-080
87-018-209-080
87-018-209-080
87-018-209-080
CAP,
CAP,
CAP,
CAP,
CAP,
ELECT 6800-25V
CER 0.1-50V
CER 0.1-50V
CER 0.1-50V
CER 0.1-50V
CN904
CNA903
87-A61-004-010
8B-CL7-643-010
CONN,06P H BLK TAC-L06P-A3
CONN ASSY,2P V AC
88-803-021-690
87-A91-704-080
87-A91-704-080
87-A92-046-010
CONN ASSY,2P
SW,TACT EVQ 214 05R
SW,TACT EVQ 214 05R
SW,TACT 1-5 SKQUCAA010
C207
CN105
CN111
CN112
CN113
87-A11-132-080
87-A60-620-010
81-754-629-010
81-754-629-010
87-A60-621-010
CAP,TC U 0.01-50 K B
CONN,3P V 2MM JMT
CONNECTOR, 2P
CONNECTOR, 2P
CONN,4P V 2MM JMT
J101
87-099-802-010
JACK,PIN 3P BRW
88-803-022-290
87-036-109-010
CONN ASSY,2P 220MM
PUSH SWITCH
KEY C.B
CNA301
S321
S322
S331
AUX C.B
DOOR C.B
CNA502
S401
CD MOTOR C.B
376315150 892498299
M1
M2
PIN3
SW1
S0-M10-A09-700
9X-262-576-910
S2-369-750-000
S4-S13-A01-600
MOTOR SLED ASSY
MOTOR GEAR ASSY
PLUG,6P
SW,LEAF
LDSP L C.B
C101
CN101
D101
87-A11-144-080
87-A60-666-010
87-A40-678-010
CAP,TC U 0.1-50 K B
CONN,2P H 2MM JMT
LED,SELU1E10CXM BLUE-DEF
LDSP R C.B
C102
CN102
D102
87-A11-144-080
87-A60-666-010
87-A40-678-010
CAP,TC U 0.1-50 K B
CONN,2P H 2MM JMT
LED,SELU1E10CXM BLUE-DEF
PT C.B
!
!
!
!
!
!
!
!
www
.
xiaoy u163. com
TERMINAL, 1P MSC
TERMINAL, 1P MSC
–6–
http://www.xiaoyu163.com
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
QQ
QQ
87-012-195-080
87-012-270-080
87-012-199-080
87-010-263-040
87-012-195-080
DESCRIPTION
13942296513
13942296513
C449
C450
C451
C455
C456
KANRI
NO.
TEL
TEL
C444
C445
C446
C447
C448
KANRI
DESCRIPTION
NO.
87-012-195-080
C-CAP,U 100P-50CH
87-010-831-080
C-CAP,U,0.1-16F
87-010-831-080
C-CAP,U,0.1-16F
87-010-831-080
C-CAP,U,0.1-16F
87-012-182-080
C-CAP,U 27P-50 CH
http://www.xiaoyu163.com
QQ 376315150 892498299
CHIP RESISTOR PART CODE
Chip Resistor Part Coding
8 8
A
Figure
Resistor Code
Value of resistor
Chip resistor
L
W
t
:A
Resistor Code : A
1.0
0.5
0.35
104
Dimensions (mm)
Wattage
1/16W
Type
1005
Tolerance
5%
Symbol
CJ
1/16W
1/10W
1608
2125
5%
5%
CJ
CJ
1/8W
3216
5%
CJ
Form
L
t
W
1.6
0.8
0.45
108
2
1.25
0.45
118
3.2
1.6
0.55
128
TEL
TEL
13942296513
13942296513
TRANSISTOR ILLUSTRATION
B C E
2SA933AS (R)
KTC3198GR
2SA1979O/Y
DTA124XS
DTC124XS
B C E
B C E
2SD1933
KTA1046Y
D
C
B C E
E C B
2SA952K
2SC1815GR
2SC5395F
DTC114ES
www
.
B
2SA1235F
2SC3052F
2SC3326B
CMBT5401
DTC114TKA
G
E
DTC114YKA
DTC124XKA
RT1N141C
RT1P144C
xiaoy u163. com
–7–
http://www.xiaoyu163.com
S
2SK2158
376315150 892498299
376315150 892498299
E C B
QQ
QQ
QQ 376315150 892498299
TEL 13942296513
http://www.xiaoyu163.com
WIRING – 1 (MAIN)
QQ 3 7 6 3 1 5 1 5 0
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
8 9 2 4 9 8 2 9 9
A
B
C
D
E
F
I
J
QQ
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
K
L
M
N
O
P
Q
R
S
www
.
x
i
a o y u 1 6 3
–8–
http://www.xiaoyu163.com
.
c o
m
T
U
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
13942296513
13942296513
H
TEL
TEL
G
http://www.xiaoyu163.com
WIRING – 2 (POWER / AUX / LDSP L / LDSP R)
QQ 3 7 6 3 1 5 1 5 0
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
8 9 2 4 9 8 2 9 9
A
B
C
D
E
F
I
J
QQ
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
K
L
M
N
O
P
Q
R
S
www
.
x
i
a o y u 1 6 3
–9–
http://www.xiaoyu163.com
.
c o
m
T
U
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
13942296513
13942296513
H
TEL
TEL
G
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM – 1 (MAIN 1 / 2 / AUX / LDSP L / LDSP R)
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
www
.
x
i
QQ
3 7 6 3 1 5 1 5 0
a o y u 1 6 3
– 10 –
http://www.xiaoyu163.com
.
c o
m
8 9 2 4 9 8 2 9 9
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM – 2 (MAIN 2 / 2 : TUNER)
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
www
.
x
i
QQ
3 7 6 3 1 5 1 5 0
a o y u 1 6 3
– 11 –
http://www.xiaoyu163.com
.
c o
m
8 9 2 4 9 8 2 9 9
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM – 3 (POWER)
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com
– 12 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
WIRING – 3 (FRONT / KEY)
QQ 3 7 6 3 1 5 1 5 0
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
8 9 2 4 9 8 2 9 9
A
B
C
D
E
F
I
J
QQ
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
K
L
M
N
O
P
Q
R
S
www
.
x
i
a o y u 1 6 3
– 13 –
http://www.xiaoyu163.com
.
c o
m
T
U
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
13942296513
13942296513
H
TEL
TEL
G
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM – 4 (FRONT / KEY)
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
www
.
x
i
QQ
3 7 6 3 1 5 1 5 0
a o y u 1 6 3
– 14 –
http://www.xiaoyu163.com
.
c o
m
8 9 2 4 9 8 2 9 9
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
http://www.xiaoyu163.com
WIRING – 4 (CD / DOOR) <1 / 2>
QQ 3 7 6 3 1 5 1 5 0
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
8 9 2 4 9 8 2 9 9
A
B
C
D
E
F
I
J
QQ
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
K
L
M
N
O
P
Q
R
S
www
.
x
i
a o y u 1 6 3
– 15 –
http://www.xiaoyu163.com
.
c o
m
T
U
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
13942296513
13942296513
H
TEL
TEL
G
http://www.xiaoyu163.com
WIRING – 4 (CD) <2 / 2>
QQ 3 7 6 3 1 5 1 5 0
1
A
B
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
8 9 2 4 9 8 2 9 9
C
D
E
F
TEL
TEL
G
13942296513
13942296513
H
I
J
1 3 9 4 2 2 9 6 5 1 3
QQ
3 7 6 3 1 5 1 5 0
L
8 9 2 4 9 8 2 9 9
M
N
O
P
Q
R
S
T
U
www
.
x
i
a o y u 1 6 3
– 16 –
http://www.xiaoyu163.com
.
c o
m
376315150 892498299
376315150 892498299
T E L
QQ
QQ
K
http://www.xiaoyu163.com
WIRING – 5 (CD MOTOR)
1515
0 C.B892498299
QQ 3763
I CD
MOTOR
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
A
B
M1
+
C
M1
(SLED MOTOR)
D
SW1
(INSIDE LIMIT SW)
E
F
1
SW1
G
_
(RED)
+
H
I
J
K
L
M
N
O
P
Q
1
R
S
www
16
.
xiaoy u163. com
FC401
FROM CD C.B CN401
– 17 –
http://www.xiaoyu163.com
T
U
376315150 892498299
376315150 892498299
PICK UP ASSY
SF-P101NR
QQ
M2
3763(SPINDLE
15150 MOTOR)
892498299
QQ
QQ
TEL 13942296513
13942296513
13942296513
3
M2
PIN3
6
5
TEL
TEL
FROM CD C.B CNA402
_
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM – 5 (CD / DOOR / CD MOTOR)
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
www
.
x
i
QQ
3 7 6 3 1 5 1 5 0
a o y u 1 6 3
– 18 –
http://www.xiaoyu163.com
.
c o
m
8 9 2 4 9 8 2 9 9
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
http://www.xiaoyu163.com
WIRING – 6 (PT)
QQ 3 7 6 3 1 5 1 5 0
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
8 9 2 4 9 8 2 9 9
A
B
C
D
E
F
I
J
QQ
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
K
L
M
N
O
P
Q
R
S
www
.
x
i
a o y u 1 6 3
– 19 –
http://www.xiaoyu163.com
.
c o
m
T
U
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
13942296513
13942296513
H
TEL
TEL
G
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM – 6 (PT)
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
www
.
x
i
QQ
3 7 6 3 1 5 1 5 0
a o y u 1 6 3
– 20 –
http://www.xiaoyu163.com
.
c o
m
8 9 2 4 9 8 2 9 9
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
http://www.xiaoyu163.com
IC BLOCK DIAGRAM
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
www
.
x
i
QQ
3 7 6 3 1 5 1 5 0
a o y u 1 6 3
– 21 –
http://www.xiaoyu163.com
.
c o
m
8 9 2 4 9 8 2 9 9
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
http://www.xiaoyu163.com
LCD DIAGRAM
QQ 376315150 892498299
TEL
TEL
SEGMENT SIDE
13942296513
13942296513
COMMON SIDE
www
.
xiaoy u163. com
– 22 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
IC DESCRIPTION
QQ 376315150 892498299
IC, LC877256V-5V22
-
Not connected.
5
I-WRQ
I
CD WRQ input.
6
I-DRF
I
CD DRF input.
7
I-CDDO
I
CD sub code input.
8
O-VOL CTL
O
Volume control output.
9
O-AON
O
Main power ON/OFF control output.
10
O-CKSFT
O
Clock shift.
11
RST
I
Micon reset input.
12
I-ACOFF
I
Hold A/D input.
13
I-TU-SIG
I
RDS signal level A/D input. (Connected to GND through a resistor.)
14
VSS1
-
GND.
15
CF1
-
9.43 MHz oscillator circuit.
13942296513
16
CF2
17
VDD1
-
Power supply.
18
I-KEY0
I
Key0 A/D input.
19
I-KEY1
I
Key1 A/D input.
20
I-DOOR
I
CD door SW ON/OFF input.
21
I-LVL
I
Not used.
22
I-TUDO
I
Tuner tune IFC input.
23
I-STEREO
I
Tuner stereo input.
24
I-COLOR
I
Color A/D input.
25
I-INT2
I
Initial A/D input.
26
I-TMBASE
I
Time base clock base input.
27
I-RDSCLK
I
RDS clock input. (Connected to GND through a resistor.)
28
I-RDSDATA
I
RDS data input. (Not used)
29
I-RMC
I
Remote control input.
30
O-PLLCE
O
PLL chip enable output.
31
O-TPCLK
I
Test point input.
32
O-LDBL
O
Back light blue output.
33
O-LDUM
O
Back light umber output.
34
O-LDGR
O
Back light green output.
35
O-LDTOP
O
Not used.
36
O-LDSP
O
SPKR LED ON/OFF control.
37 ~ 38
NC
-
Not connected.
39 ~ 53
S9 ~ S23
O
LCD segment output.
54
VDD2
-
Power supply.
55
VSS2
-
GND.
56 ~ 77
S24 ~ S45
O
LCD segment output.
78 ~ 82
NC
-
Not connected.
83 ~86
COM0 ~ COM3
O
LCD segment output.
87 ~ 88
NC
-
Not connected.
376315150 892498299
TEL 13942296513
www
.
QQ 376315150 892498299
xiaoy u163. com
– 23 –
http://www.xiaoyu163.com
376315150 892498299
NC
QQ
1~4
TEL
Description
13942296513
I/O
TEL
Pin Name
QQ
Pin No.
http://www.xiaoyu163.com
QQ 376315150 892498299
Pin Name
I/O
Description
89
VSS3
-
GND.
90
VDD3
-
Power supply.
91
O-P.ON
O
Power ON/OFF control.
92
O-MUTE
O
Mute ON/OFF control output.
93
O-TUON
O
Tuner ON/OFF control output.
94
O-CDON
O
CD ON/OFF control output.
95
O-CDDATA
O
CD data output.
96
O-CDCE
O
CD enable output.
97
O-CDCLK
O
CD clock output.
98
O-PLLCLK
O
PLL clock output.
99
O-PLLDATA
O
PLL data output.
100
NC
-
Not connected.
TEL
TEL
Pin No.
13942296513
13942296513
.
xiaoy u163. com
– 24 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
QQ 376315150 892498299
IC, LA9241ML
Description
FIN2
I
2
FIN1
I
3
E
I
4
F
I
Connects to the pickup's photo diode.
5
TB
I
Input for DC component of TE signal.
6
TE–
I
Connects to the resistor between this pin and TE pin for setting the gain of TE signal.
7
TE
O
Output for TE signal.
8
TESI
I
Input for TES (Track Error Sense) comparator, TE signal is band-passed and inputted.
9
SCI
I
Input for shock detection.
10
TH
I
For setting tracking gain time constant.
11
TA
O
TA amplifier output pin.
12
TD–
I
For constructing tracking phase compensation constant between TD and VR pins.
13
TD
O
For setting tracking phase compensation.
14
JP
I
For setting the amplifier of tracking jump signal (kick pulse).
15
TO
O
Output for tracking control signal.
16
FD
O
Output for focusing control signal.
17
FD–
I
For constructing focusing phase compensation constant between FD and FA pins.
18
FA
O
For constructing focusing phase compensation constant between FD– and FA– pins.
19
FA–
I
For constructing focusing phase compensation constant between FA and FE pins.
20
FE
O
Output for FE signal.
21
FE–
I
Connects to the gain-setting resistor of FE signal between this pin and FE pin.
22
A-GND
–
GND for analog signals.
23
SP
24
SPI
O
Single end output of CV+ and CV– pin input signal.
25
SPG
I
Connects to the gain-setting resistor during spindle 12cm mode. (Not used)
26
SP–
I
Connects to spindle phase compensation constant together with SPD pin.
27
SPD
O
Output for spindle control signal.
28
SLEQ
I
Connects to sled phase compensation constant.
29
SLD
O
Output for sled control signal.
30
SL–
I
Input for sled-sending signal from microcontroller.
31
SL+
I
Input for sled-sending signal.
32
JP–
I
Input for tracking-jump signal from DSP.
33
JP+
34
TGL
I
Input for tracking gain control signal from DSP; gain is low if TGL = "H".
35
TOFF
I
Input for tracking off control signal from DSP; off if TOFF = "H".
36
TES
O
Outputs TES signal to DSP.
37
HFL
38
SLOF
Connects to the pickup's photo diode; adding this pin to pin FIN1 generates RF signal,
and subtracting it generates FE signal.
Connects to the pickup's photo diode.
Connects to the pickup's photo diode; subtracting this pin from pin F generates
TE signal.
QQ 376315150 892498299
TEL 13942296513
www
.
xiaoy u163. com
O
I
HIGH FREQUENCY LEVEL; used to determine whether the main beam is on a pit or
on a mirror.
Input for sled servo off control.
– 25 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
1
QQ
QQ
I/O
13942296513
13942296513
Pin Name
TEL
TEL
Pin No.
http://www.xiaoyu163.com
QQ 376315150 892498299
39
CV–
40
CV+
41
I/O
Description
Input for CLV error signal from DSP.
RFSM
O
Output for RF.
42
RFS–
O
For setting RF gain and 3T compensation constant together with RFSM.
43
SLC
O
44
SLI
I
Input for controlling the data slice level of DSP.
45
D-GND
–
GND for digital system.
46
FSC
O
Output pin for focus search smoothing capacitor.
47
TBC
I
(Tracking Balance Control) EF balance variable range setting pin.
48
NC
–
Not connected.
49
DEF
O
Output for disk defect detection.
50
CLK
I
Standard clock input; DSP's 4.23MHz is inputted.
51
CL
I
Clock input for microcontroller command.
52
DAT
I
Data input for microcontroller command.
53
CE
I
Chip-enable input for microcontroller command.
54
DRF
O
Detect RF; output for RF level detection.
55
FSS
I
56
VCC2
–
VCC pin for servo and digital systems.
57
REFI
I
For connecting pass capacitor to reference voltage.
58
VR
O
Reference voltage output.
59
LF2
–
For setting disk defect-detection time constant.
60
PHI
–
Connects to capacitor for RF signal peak hold.
61
BHI
–
Connects to capacitor for RF signal bottom hold.
62
LDD
O
Output for APC circuit.
63
LDS
I
Input for APC circuit.
64
VCC1
–
VCC pin for RF system.
SLICE LEVEL CONTROL; output for controlling the data slice level of DSP with
RF waveform.
www
.
QQ 376315150 892498299
xiaoy u163. com
– 26 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
(Not used)
13942296513
(Focus Search Mode) = search/+search against reference voltage switching pin.
TEL
QQ
I
13942296513
Pin Name
TEL
Pin No.
http://www.xiaoyu163.com
QQ 376315150 892498299
IC, LC78622NE
Description
1
DEFI
I
Defect detection signal (DEF) input.
2
TAI
I
Test input. A pull-down resistor is built in. Must be connected to 0V.
3
PDO
O
External VCO control phase comparator output.
4
VVSS
–
Internal VCO ground. Must be connected to 0V.
5
ISET
O
PDO output current adjustment resistor connection.
6
VVDD
–
Internal VCO power supply.
7
FR
–
VCO frequency range adjustment.
8
VSS
–
Digital system ground. Must be connected to 0V.
9
EFMO
O
Slice level control; EFM signal output.
10
EFMIN
I
Slice level control; EFM signal input.
T2
I
Test input. A pull-down resistor is built in. Must be connected to 0V.
12
CLV+
14
V/P
O
15
HFL
I
Track detection signal input. This is a Schmitt input.
16
TES
I
Tracking error signal input. This is a Schmitt input.
17
TOFF
O
Tracking off output.
18
TGL
O
Tracking gain switching output. Increase the gain when low.
19
JP+
Disc motor control output.
Three-value ouput is also possible when specified by microprocessor command.
Rough servo/phase control automatic switching monitor output. Outputs a high level
during rough servo and a low level during phase control.
20
JP–
21
PCK
O
Track jump output.
QQ 376315150 892498299
Three-value output is also possible when specified by microprocessor command.
EFM data playback clock monitor. Outputs 4.3218 MHz when the phase is locked.
(Not used)
Synchronization signal detection ouput. Outputs a high level when the synchronization
22
FSEQ
O
signal detected from the EFM signal and the internally generated synchronization signal
agree. (Not used)
23
VDD
–
Digital system power supply.
24
SL+
25
SL–
O
Serial data command sled signal output terminal from microprocessor.
26
NC
–
Not used.
27
PU IN
I
CD pickup inside limit switch.
28
CD R/W
O
CD R/W gain ON/OFF signal.
29
EMPH
O
30
C2F
O
C2 flag output. (Not used)
31
DOUT
O
Digital output (EIAJ format). (Not used)
32
T3
I
Test input. A pull-down resistor is built in. Must be connected to 0V.
33
T4
34
NC
35
MUTEL
36
LVDD
www
.
De-emphasis monitor pin. A high level indicates playback of a de-emphasis disk.
(Not used)
xiaoy u163. com
–
Not connected.
O
Left channel one-bit D/A converter mute output. (Not used)
–
Left channel one-bit D/A converter power supply.
– 27 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
O
QQ
CLV–
O
13942296513
13
QQ
11
TEL
I/O
13942296513
Pin Name
TEL
Pin No.
http://www.xiaoyu163.com
Pin Name
I/O
37
LCHO
O
Left channel one-bit D/A converter output.
38
LVSS
–
Left channel one-bit D/A converter ground. (Must be connected to 0V)
39
RVSS
–
Right channel one-bit D/A converter ground. (Must be connected to 0V)
40
RCHO
O
Right channel one-bit D/A converter output.
41
RVDD
–
Right channel one-bit D/A converter power supply.
42
MUTER
O
Right channel one-bit D/A converter mute ouput. (Not used)
43
XVDD
–
Crystal oscillator power supply.
44
XOUT
O
45
XIN
I
46
XVSS
–
Crystal oscillator ground. Must be connected to 0V.
TEL
47
SBSY
O
Subcode block synchronization signal output. (Not used)
48
EFLG
O
C1, C2 single and double error correction monitor pin. (Not used)
13942296513
QQ 376315150 892498299
Pin No.
Description
49
PW
O
Subcode P, Q, R, S, T, U, V and W output. (Not used)
50
SFSY
O
51
SBCK
I
52
FSX
O
53
WRQ
O
Subcode Q output standby output.
54
RWC
I
Readwrite control input. This is a Schmitt input.
55
SQOUT
O
Subcode Q output.
56
COIN
I
Command input from the control microprocessor.
57
CQCK
I
58
RES
I
Chip reset pin. (This pin must be set low briefly after power is first applied)
59
T11
O
Test output. Leave open. (Normally outputs a low level). (Not used)
60
16M
O
16.9344 MHz output. (Not used)
61
4.2M
O
4.2336 MHz output.
62
T5
I
Test input. A pull-down resistor is built in. (Must be connected to 0V)
63
CS
I
Chip select input. A pull-down resistor is built in. (Must be connected to 0V.)
64
T1
I
Test input. No pull-down resistor. (Must be connected to 0V)
Connections for a 16.934MHz crystal oscillator element.
Subcode readout clock input. This is a Schmitt input.
(Must be connected to 0V.)
Output for the 7.35 kHz synchronization signal divided from the crystal oscillator.
www
.
QQ 376315150 892498299
Input for both the command input acquisition clock and the SQOUT pin subcode
readout clock input. This is a Schmitt input.
xiaoy u163. com
– 28 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
(Not used)
13942296513
the standby state. (Not used)
TEL
Subcode frame synchronization signal output. This signal falls when the subcode are in
http://www.xiaoyu163.com
ADJUSTMENT – 1 <TUNER / FRONT>
QQ 376315150 892498299
< TUNER SECTION >
1. Clock frequency Check
Settings : • Test point :
TP3 (CLK)
Method : Set to AM 1710 kHz and check that the test point is
2160 kHz ± 45 Hz.
2. AM VT Check
Settings : • Test point :
TP4 (VT)
Method : Set to AM 1710 kHz and check that the test point is less
than 8.5 V. Then set to AM 530 kHz and check that the
test point is more than 0.6 V.
3. AM Tracking Adjustment
Settings : • Test point :
TP8 (Rch), TP9 (Lch)
• Adjustment location : L981 (1/3)
Method : Set to AM 1000 kHz and adjust L981 (1/3) so that the
test point becomes maximum.
xiaoy u163. com
– 29 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
.
QQ
QQ
QQ 376315150 892498299
7. DC Balance / Mono Distortion Adjustment
Settings : • Test point :
TP5, TP6 (DC Balance)
TP8 (Rch), TP9 (Lch)
(Mono Distortion)
• Adjustment location : L771
• Input level :
60 dBµV
Method : Set to FM 98.0 MHz and adjust L771 so that the voltage
between TP5 and TP6 becomes 0 V ± 0.04 V with
minimum distortion.
www
TP1 (KEY-SCAN)
TP2 (GND)
• Adjustment location : L201
Method : Insert AC plug while pressing of "POWER" key and
"TUNER" function key.
Connect a frequency counter across TP5 and TP6.
Then adjust L201 so that the test point becomes
97.257 Hz ± 0.097 Hz.
[ Manual Reset ]
Make up for RESET after adjustment.
* Reset is to press "POWER" key while pressing of
"CLEAR (STOP)" key.
13942296513
13942296513
1. µ-CON OSC Adjustment
Settings : • Test point :
TEL
TEL
< FRONT SECTION >
5. FM VT Check
Settings : • Test point :
TP4 (VT)
Method : Set to FM 87.5 MHz check that the test point is more
than 0.5 V. Then set to FM 108.0 MHz and check that
the test point is less than 8.0 V.
TEL 13942296513
<FM>
Settings : • Test point :
TP8 (Rch), TP9 (Lch)
• Input level :
60 dBµV
Method : Set to FM 98.0MHz and check that the test point is
600 mV ± 3 dB.
9. FM Separation Check
Settings : • Test point :
TP8 (Rch), TP9 (Lch)
• Input level :
60 dBµV
Method : Set to FM 98.0 MHz and check that the test point is
more than 25 dB.
4. AM IF Adjustment
Settings : • Test point :
TP8 (Rch), TP9 (Lch)
• Adjustment location :
L772 ................................................... 450 kHz
6. FM Tracking check
Settings : • Test point :
TP8 (Rch), TP9 (Lch)
Method : Set to FM 98.0 MHz and check that the test point
is less than 9 dBµV.
8. Output Level Check
<AM>
Settings : • Test point :
TP8 (Rch), TP9 (Lch)
• Input level :
74 dBµV
Method : Set to AM1000 kHz and check that the test point is
140 mV ± 3 dB.
http://www.xiaoyu163.com
ADJUSTMENT – 2 (CD)
QQ 376315150 892498299
CD C.B (PATTERN SIDE)
GND
.
xiaoy u163. com
– 30 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ
QQ
QQ
TEL 13942296513
4
23
VREF
14
FOCUS BIAS
1
376315150 8924918299
SF R430
32
TE
13942296513
13942296513
R402
RF SM
TEL
TEL
6
http://www.xiaoyu163.com
QQ 376315150 892498299
CD Adjustment Method
• Perform the adjustments after the machine enters the test mode.
• Place the CD mechanism horizontally level.
• Equipment and tools required
Measuring equipment: Oscilloscope (Use the probe of 10:1)
Digital VOM (Use it in the DC Volt range.)
Jitter meter (Kikusui 6235 or equivalent)
Test disc:
TCD-782
ATD-001
1. FOCUS BIAS Adjustment
Connect a digital VOM to the test point (FOCUS BIAS), (VREF).
Play back the 2nd track of the TCD-782.
Adjust SFR430 until the VOM indicates 0 +/-10 mV.
V
+
--
FOCUS BIAS
VREF
TEL
TEL
1)
2)
3)
DIGITAL MULTIMETER
OSCILLOSCOPE
1)
2)
3)
1.8 Vp-p
Connect an oscilloscope to test point (RF SM), (GND).
Play back the 2nd track of the TCD-782.
Check to see that the RF waveform has the maximum amplitude
and the center of the wedge waveform has the clear blank.
0V
OUTPUT
+
EYE PATTERN
must be CLEAR and MAX.
--
VOLT/DIV: 500mV
RF SM
TIME/DIV: 0.5µS
VREF
3. Jitter Check
TEL 13942296513
2)
3)
4)
OSCILLOSCOPE
QQ 376315150 892498299
JITTER METER
OUTPUT
+
INPUT
ns
--
RF SM
VREF
4. Tracking Balance Check
1)
2)
3)
Connect an oscilloscope to test point (TE), (VREF).
Play back the 2nd track of the TCD-782 and press the PAUSE
button.
Check to see that the traverse waveform on an oscilloscope is
vertically symmetrical.
OSCILLOSCOPE
A
VREF
B
OUTPUT
+
A=B
--
VOLT/DIV: 500mV
TE
VREF
TIME/DIV: 1mS
5. Play-ability Check
1)
Play back the 3rd, 8th and 13th track of ATD-001. Check to see
that noise does not occur and sound skipping does not occur.
6. Laser Current Check
DIGITAL MULTIMETER
*Do not perform this measurement unless the laser is suspected to be
defective.
1) Connect a digital VOM across the resistor R402 (10 ohms).
2) Play back the TCD-782 and check the DC voltage value on a digital
VOM.
3) Calculate the laser current (Iop) by dividing the DC voltage across
R402 by the resistor value (R402 = 10 ohms).
Laser current (Iop) = DC voltage across R402 divided by the
resistor value (10 ohms).
Check to see that the laser current (Iop) is 80 mA or less.
www
.
V
+
--
R402
xiaoy u163. com
– 31 –
http://www.xiaoyu163.com
R402
376315150 892498299
376315150 892498299
While an oscilloscope is kept connected in the same test point
as in the 2. RF Waveform Check, connect the output terminal
of an oscilloscope to the input terminal of a jitter meter.
Set the VOLT range selector of an oscilloscope to 500 mV
range or lower.
Play back the 2nd track of the TCD-782.
Check to see that a jitter meter indicates 28.0 ns or less.
QQ
QQ
1)
13942296513
13942296513
2. RF Waveform Check
http://www.xiaoyu163.com
CD TEST MODE
QQ 376315150 892498299
1. How to Start the CD Test Mode
While pressing the FUNCTION button, insert the AC plug to the power outlet.
When the test mode is started, the message [CD TEST] is displayed.
2. How to Exit the CD Test Mode
Press the POWER button or press the FUNCTION button or disconnect the AC plug.
3. Function Descriptions and Application of the CD Test Mode
In order to use the test mode, short-circuit the switch S401.
No
Mode
1
Start mode
Operation
Display
Function
All CD TEST
Checking item
• Microprocessor check
indicators light
2
STOP
mode
button
TOC READ
• LD illuminates all the time
• APC circuit check
• Focus search continuous
• Laser current measurement
operations *1
• Focus search waveform check
TEL
TEL
Search
• Spindle motor continuous kick • Focus error waveform check
3
Play mode Play button
Normal
• Normal playback
• Each servo circuit is checked
• If TOC cannot be read, focus
• DRF check
search is continued
4
PAUSE
mode
button
Normal
• Tracking servo OFF/ON
Released by the STOP
button.
Sled mode FF button
RWD button
CD TEST
QQ 376315150 892498299
• Pickup moves to the inner
circumference *2
CD TEST
• Pickup moves to the outer
circumference *2
• Sled circuit check
• Tracking circuit check
• Mechanism operation check
• Pickup check
*1: The driver IC heats up and the protection circuit starts working when the focus search is continued for 10 minutes or longer.
There can be a case that operations cannot be performed correctly.
In such a case, turn off the main power. After cooling down the machine, restart the machine.
*2: Be careful not to damage the gear because the sled motor rotates while the FF or RWD button is being pressed even if the
pick-up is located in the innermost track or the outermost track.
www
.
xiaoy u163. com
– 32 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
5
• Tracking balance check
QQ
QQ
Traverse
13942296513
13942296513
(DRF in the search mode is
ignored)
http://www.xiaoyu163.com
MECHANICAL EXPLODED VIEW 1 / 1
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
L
16
14
18
17
PWB
15
K
M
J
20
30
K
K
21
13
19
C
22
E
PWB
28
M
36
21
12
E
25
11
K
23
HT-SINK, SUB
I
PWB
E
E
C
HT-SINK, MAIN
E
9
1 3 9 4 2 2 9 6 5 101 3
LCD101
QQ
26
26
3 7 6 3 1 5 1E 5 0
PWB
H
34
H
7
27
29
E
WIRE,BINDER
PWB
D
6
P
5
E
E
G
C
B
8 9 2 4 9 8 2 9 9
PWB
a
2
31
A
4
PWB
N
3
1
32
B
b
CHAS, MAIN
www
A
.
O
A
x
i
a o y u 1 6 3
E
– 33 –
http://www.xiaoyu163.com
35
33
.
F
c o
m
376315150 892498299
376315150 892498299
T E L8
QQ
QQ
DA11B3
13942296513
13942296513
a
TEL
TEL
24
http://www.xiaoyu163.com
MECHANICAL PARTS LIST 1 / 1
QQ 376315150 892498299
REF. NO. PART NO.
1
2
3
4
5
KANRI
DESCRIPTION
NO.
8B-CJ7-006-010
WINDOW,FR U
8B-CL7-001-010
CABI,FR U(L)
8B-CL7-008-010
LENS,SENSOR
8B-CL7-021-010
BTN,VOL(L)
8B-CL7-022-010
BTN,FUNC(L)
REF. NO. PART NO.
!
31
32
33
34
35
KANRI
DESCRIPTION
NO.
87-A80-110-010
AC CORD ASSY,U SPT-2W
87-085-189-010
BUSHING, CORD (U)
8B-CJ7-025-010
FOOT,REAR
8B-CJ7-010-010
GUIDE,LENS
8Z-NB8-254-010
COVER, PL M3
36
A
B
C
D
87-A90-193-010
87-721-094-410
87-721-095-410
87-B10-294-010
87-723-074-410
HLDR,CV100 (B)
QT2+3-6 GLD
QT2+3-8GLD W/O SLOT
BVT2+2.6-8
QT2+2.6-8 W/O SLOT BLK
BTN,POWER(L)
REFLECTOR,POWER
GUIDE,LCD COVER
LENS,LCD
GUIDE,LCD
11
12
13
14
15
8B-CJ7-018-010
8B-CJ7-014-010
8B-CL7-002-010
8B-CL7-010-010
8B-CL7-006-010
BTN,SOUND
KEY,ENTER
PANEL,TOP (L)
WINDOW,CD (L)
BOX,CD U (L)
E
F
G
H
I
87-067-579-010
87-067-584-010
87-B10-315-010
8Z-CK5-222-010
87-B10-316-010
TAPPING SCREW, BVT2+3-8
TAPPING SCREW, BVT2+3-6
BVIT3B+3-8 R W/O
S-SCREW,CD+2.6-6 F9
BVIT3B+3-10 R W/O
16
17
18
19
20
8B-CL7-007-010
8B-CL7-016-010
8B-CJ7-209-010
8Z-NF6-210-010
8B-CL7-004-010
BTN,EJECT CD (L)
LENS,REAR (L)
SPR-T,CD
DMPR,150 N
CHAS,CD U (L)
J
K
L
M
N
87-721-096-410
87-743-094-410
87-067-761-010
87-743-096-410
85-NF7-599-010
QT2+3-10 W/O SLOT
UT2+3-6BLK
TAPPING SCREW, BVT2+3-10
TAPPING SCREW,UT2+3-10 BLK
PVCW3.2-8-0.3
21
22
23
24
25
8B-CJ7-207-010
8B-CJ7-205-010
8Z-CDB-169-010
8B-CL7-647-010
88-909-181-110
HLDR,CHAS CD
LEVER,EJECT CD
PANEL,CD SANYO
FF-CABLE,16P 1 100MM
FF-CABLE, 9P 1.25 180MM
O
P
87-741-095-410
87-761-095-410
UT2+3-8 GLD
VFT2+3-8 W/O SLOT
26
27
28
29
30
88-CH6-220-010
88-907-221-110
88-910-201-110
88-912-201-110
8B-CL7-003-010
CUSHION,CD A
FF-CABLE,7P 1.25 220MM
FF-CABLE, 10P 1.25 200MM
FF-CABLE,12P-1.25
CABI,REAR U (L)
COLOR NAME TABLE
Basic color symbol
Color
Basic color symbol
Color
Basic color symbol
Color
B
Black
C
Cream
D
Orange
G
Green
H
Gray
L
Blue
LT
Transparent Blue
N
Gold
P
Pink
R
Red
S
Silver
ST
Titan Silver
T
Brown
V
Violet
W
White
WT
Transparent White
Y
Yellow
YT
Transparent Yellow
LM
Metallic Blue
LL
Light Blue
GT
Transparent Green
LD
Dark Blue
DT
Transparent Orange
GM
Metallic Green
YM
Metallic Yellow
DM
Metallic Orange
PT
Transparent Pink
LA
Aqua Blue
GL
Light Green
HT
Transparent Gray
www
.
xiaoy u163. com
– 34 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
13942296513
13942296513
8B-CL7-020-010
8B-CJ7-029-010
8B-CJ7-206-010
8B-CJ7-023-010
8B-CJ7-204-010
TEL
TEL
6
7
8
9
10
http://www.xiaoyu163.com
CD MECHANISM EXPLODED VIEW 1 / 1
QQ 376315150 892498299
1
A
2
M2
SW1
PWB
PIN 3
CD MECHANISM PARTS LIST 1 / 1
REF. NO. PART NO.
1
2
3
4
A
KANRI
DESCRIPTION
NO.
M8-AZK-M90-070
DA11B3
S2-121-A28-400
COVER GEAR
S2-511-A21-000
GEAR MIDDLE
S2-511-A21-100
GEAR,DRIVE
S1-PN2-03R-OSE
SCR PAN PCS 2-3
www
.
xiaoy u163. com
– 35 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
M1
QQ
QQ
QQ 376315150 892498299
TEL 13942296513
13942296513
13942296513
4
TEL
TEL
3
http://www.xiaoyu163.com
SPEAKER DISASSEMBLY INSTRUCTIONS
QQ 376315150 892498299
2.
Remove the four screws and remove the speaker.
3.
Remove the screw and remove the foot.
4.
Press the two claws and remove the PWB.
TEL
Remove the four screws with Allen wrench.
TEL
1.
xiaoy u163. com
– 36 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
.
QQ
QQ
www
QQ 376315150 892498299
13942296513
13942296513
TEL 13942296513
http://www.xiaoyu163.com
SPEAKER PARTS LIST (SX-LM313<YJSM>)
QQ 376315150 892498299
REF. NO. PART NO.
1
2
3
4
5
KANRI
DESCRIPTION
NO.
8B-CJ7-007-010
CABI,SPKR FR U
8B-CJ7-008-010
CABI,SPKR REAR U
8B-CL7-019-010
NET,SPKR ASSY (L)
8B-CJ7-009-010
FRAME,NET U
8B-CL7-018-010
NET,SPKR (L)
6
7
8
9
10
8B-CJ7-026-010
8B-CL7-017-010
8B-CL7-616-010
8Z-CL1-034-010
87-721-074-410
FOOT,SPKR UPPER
FOOT,SPKR LOWER (L)
SPKR,10 60HM
S-SCREW,ZCL1
QT2+2.6-8 W/O SLOT
11
12
13
87-067-822-010
87-067-703-010
87-661-097-410
BVT2+3-20 W/O SLOT
BVT2+3-10 W/O SLOT
VFT1+3-12
REF. NO. PART NO.
KANRI
NO.
DESCRIPTION
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com
– 37 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
9820572 921338
.
xiaoy u163. com
2–11, IKENOHATA 1–CHOME, TAITO-KU, TOKYO 110, JAPAN TEL:03 (3827) 3111
Printed in Singapore
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513