Emerson 1100W Product data

DeltaV Product Data Sheet
April 2015 – Page 1
DeltaV Workstation Hardware
DeltaV™ Workstation Hardware
The DeltaV™ Operator Workstations are available to support multiple versions of DeltaV Systems.






Pre-installed Operating System software for
ease of deployment
Available with Microsoft XP, Windows 7, and
Server 2008
Easy control network installation all network
cards pre-installed and ready to plug and play
Choice of client and server workstation
hardware to optimize your cost/performance
Choices for tower and rack-mount computers
including RAID drive options
Supports single, dual and quad monitors
Introduction
DeltaV™ software runs on a limited variety of Dell Intelbased computers. Available using workstation hardware
with single, dual or quad monitors or using server
hardware with a single monitor, the selection of DeltaV
workstation hardware provides the performance you need
to engineer your control strategy and operate your
process.
www.DeltaV.com
DeltaV workstations run on a specific set of preselected
Dell computer hardware specifically chosen to provide the
best cost performance solution for your DeltaV system.
We provide you with a guaranteed solution to deliver the
performance required.
We have pre-tested the DeltaV system with both the
hardware configuration and the operating system
configuration so you can be sure that DeltaV will always
operate correctly. You will never be bothered with
incompatible drivers, bad or overwritten DLLs, or
substandard hardware. You will not waste time in no-value
system setup engineering and troubleshooting. Instead,
you can focus on your process control functions.
DeltaV Product Data Sheet
April 2015 – Page 2
DeltaV Workstation Hardware
Benefits
Workstation Hardware
Pre-installed software. When ordered through a DeltaV
system integrator who can pre-load the correct DeltaV
software version, the pre-loaded workstation, monitor,
keyboard, and mouse are delivered ready to plug and play
in your DeltaV system. This is hassle-free hardware
delivery. No third-party interfaces, compatibility problems,
nor software versions to worry you. A trouble-free system
is guaranteed.
Plenty of horsepower. All workstations use state-of-theart processors well suited to provide the performance
required for DeltaV software.
Easy control network installation. The workstation ships
from the factory with the appropriate DeltaV control
network cards preinstalled—no cases to open or network
drivers to set up. Just plug a control network segment into
the workstation and the other end into the DeltaV control
area network (ACN), and you’ve just set up a new DeltaV
network node.
Choose between PCs and servers to optimize your
cost/performance. Some systems are served well with
PC workstations. But when larger systems demand higher
levels of performance, the servers provide exactly what
you need.
Flexible options. Match our options with your
requirements for towers, servers, dual monitors and RAID
storage. We provide recommendations, but the choice is
yours. Either way, the operating system is pre-loaded and
ready to roll.
Lots of memory. All computers come with sufficient
memory to handle DeltaV applications.
Secure data and fast recovery from hard drive failures.
Workstations with RAID1 drives provide higher availability
and fast recovery from failures. Servers in RAID 10
configurations maximize data protection and help enhance
the performance of the server.
Crystal clear video. DeltaV software works at 1024 x
768, 1280x1024 or 1680x1050 [wide screen] pixel
resolution (DeltaV v10.3 and later only). [Please see
monitors section for details]. You can increase your
viewing space with dual monitors or quad monitors.
[servers now support wide screen]
Alarm Annunciation. Audible alarms use the on-board
sound cards included on the motherboards of all operator
workstations. (Sound is not available on server-class
computers.)
64 bit O/S only supported for DeltaV v13.3. Move up to
Windows 64 bit O/S for both workstations and servers.
DeltaV v13.3 is a 64 bit O/S only DeltaV system.
Legendary support. Emerson Process Management
consistently receives top honors in service from our
customers. This service is extended with a variety of
optional support plans. When you subscribe to one of
these plans, you are supplied with an external modem.
This modem enables the factory to perform remote
diagnostics on your workstation should the need arise.
Product Description
Communications redundancy. The DeltaV system is
The workstation hardware described in this document is
subject to improvements at any time. It is the policy of
Emerson Process Management to ship workstation
hardware that is current with industry standards.
We want you to enjoy the benefits of the increasing
performance and decreasing costs inherent with using
state-of-the-art, off-the-shelf equipment as much as
possible. DeltaV performs testing to help eliminate the
risks associated with new platforms, and we continue to
focus on measures that extend the life of installed
hardware.
solid, secure, and safe. The DeltaV control network is fully
redundant, and the workstations are equipped to take
advantage of this redundancy.
System Backups- All workstations come with a DVDRW drive that can be used for storing backup data.
Monitor Options- Choose standard or widescreen flat
panel monitors to display your process graphics. Choose
dual or quad monitors for maximum viewing area.
DeltaV Product Data Sheet
April 2015 – Page 3
DeltaV Workstation Hardware
Monitor Specifications
The DeltaV system supports the Dell Professional P2213 22-inch Widescreen Flat Panel Monitor with a 16:10 aspect ratio
in a 1680x1050 resolution in DeltaV 10.3 or newer systems. [DeltaV does not support 16:9 aspect ratio monitors]
Wide screen monitors are supported on all DeltaV Workstations including server class computers as noted below. Wide
screen monitors must be connected to the computer prior to making wide screen resolution selections.
The DeltaV system also supports the SE2803 19" LCD Monitor (Dell Model 1913S) (5:4 aspect ratio 1280x1024 resolution
only) on workstations and servers. (This SE2803 monitor does not support 1600x1200 resolutions).
Touch screen is supported on DeltaV workstations however touch screen monitors are not longer supported as a standard
offering. Touchscreen monitors must be sourced locally as part of the project using the 3M touchscreen technology listed
in the Touchscreen product data sheet. Monitors selected for touchscreen should match the aspect ratio and Optimal
resolution of the supported Dell P2213 monitor.
Monitor physical appearances change periodically and without notice from monitor suppliers. We cannot guarantee
that physically compatible monitors will be available at all times. If you require that any spare or replacement
monitors be physically compatible with installed monitors, then spare or replacement monitors must all be ordered
at the same time the initial workstation is ordered.
Specifications Common to all Computers
(applies to all computers with exceptions noted under computer specifications)
Please refer to the Emerson Process Management Product Support Guidelines for complete details on available DeltaV
Workstation hardware and software support. Consult our local Emerson support office or Representative or visit us at
www.SureService.com).
All computers must be installed in a dust-free, contaminant-free environment. These computers are not suitable for
mounting
in industrial environments unless they are mounted in enclosures that provide the necessary dust-free and contaminantfree
environment. Environment must meet Class G1 level for airborne contaminants per the ISA standard ISA–71.04–1985,
Environmental Conditions for Process Measurement and Control Systems: Airborne Contaminants.
It is the responsibility of the user to insure their environment is compatible with G1. Due to compliance to RoHS
requirements newer computers may not survive in the same environment as older models. If there is any chance of sulfur
in the environment computers must be protected in environmental enclosures or relocated to a sulfur free environment.
Temperature: Operating 10° to 35°C (50° to 95°F) Storage –40° to 65°C (–40° to 149°F)
Relative humidity: 20% to 80% (non-condensing)
Altitude : Operating –15.2 to 3048 m (–50 to 10,000 ft.), Storage –15.2 to 10,668 m (–50 to 35,000 ft.)
Computer Restore Image: All computers come with an operating system restore image DVD for fast recovery of
the O/S when restoring a computer. Operating Systems install disks are not provided.
Unless specifically listed in the individual computer specifications floppy Drives are no longer included
with computers. Files can be transferred using portable USB media rather than floppy drives. If a floppy
drive is required a USB floppy drive can be supplied locally.
Note on the use of Uninterruptible Power Supplies with DeltaV Workstations
For workstations and servers that will be used as a DeltaV ProfessionalPlus Workstation the use of an Uninterruptible Power
Supply is required to prevent possible database corruption due to a sudden power loss on the ProfessionalPlus.
In addition it is strongly suggested that all DeltaV Workstations including Operator workstations be connected to a UPS
system to prevent possible corruption of the O/S, DeltaV software, or other data (such as historians) duing a sudden power
loss. Critical devices on the DeltaV network should always be protected by the use of an UPS system from possible damage
due to sudden power loss
DeltaV Product Data Sheet
April 2015 – Page 4
DeltaV Workstation Hardware
SE2532 DeltaV Operator Workstation – single monitor [based on Dell Optiplex 3020 desktop
computer]
[This workstation does not support Windows XP]
•
Small Form Factor chassis
•
3 Network Interface Ports, 1 onboard plus two add-in NICs
•
Single Intel processor CORE i5-4590 Quad core 3.3GHz Turbo
•
Memory: 4.0GB
•
Drives: 500GB or larger
•
8x Slimline DVD +/- RW SATA drive
•
On-board integrated audio
•
On-board integrated video, HD Graphic 4600 (single-monitor only)
•
Speakers
•
USB Optical mouse (2 button w/scroll)
•
USB Local country keyboard
•
Local power cord option
•
The SE2532 ships with Windows 7 Windows for Embedded Systems 64 bit installed and includes a Windows 7 32
bit and 64 bit image DVD to field convert the workstation to a 32 bit O/S. This computer will support both English
and non-English versions of DeltaV and includes the language MUI DVD required for installing a localized nonEnglish version of DeltaV. This unit does not come with a Windows 7 O/S reinstall DVD. The image DVD is the
only method available to reinstall the O/S on this computer. This computer does not support Windows XP
•
Dimensions (H x W x D) Inches/(cm) : 14.2 x 6.9 x 16.4 / (36.0 x 17.5 x 41.7)
•
Weight (lbs/kg) : 20.68 / 9.4
•
Power Supply Unit (PSU) : Standard 290W PSU Active PFC
•
Maximum vibration: Operating 0.25 G at 3 to 200 Hz at 0.5 octave/min, Storage 0.5 G at 3 to 200 Hz at 1
octave/min
•
Maximum shock: Operating Bottom half-sine pulse with a change in velocity of 50.8 cm/sec (20 inches/sec),
Storage 27-G faired square wave with a velocity change of 508 cm/sec (200 inches/sec)
Note: The SE2532 does not contain a COM port or build in P/S2 ports. There are no unused card slots to accept add-in
cards for these functions.
DeltaV Product Data Sheet
April 2015 – Page 5
DeltaV Workstation Hardware
SE2525 or VE2555 —DeltaV Rack Mount Workstation – Single and Dual Monitor workstation [based
on Dell R5500XL]
The rack mounted workstation is only supported on DeltaV v9.3 and newer versionsquad monitor is supported only on v11.3 and newer
•
3 network interface ports
•
CPU: Single Intel Xeon Quad Core processor
•
Memory: 4GB,
•
Drives: Qty 2- 500GB in a RAID 1 configuration
•
8x DVD +/- RW Drive
•
On-board integrated audio
•
Video: Qty 1 - ATI FirePro V2270 dual DVI graphics card (dual-monitor capable). The video card provides one
DVI output using an included splitter cable to provide dual DVI outputs. There are no VGA ports available on the
video card. There are no DVI to VGA adaptors included.
•
Speakers: Dell two-piece stereo speakers
•
USB Optical mouse (2 button w/scroll), Local USB country keyboard, local power cord option
•
Rack Rails: Rack chassis with Sliding/Versa Rails and Cable Management Arm
•
The SE2525 ships with Windows 7 Windows for Embedded Systems 32 bit installed and includes a Windows 7
32 and 64 bit image DVD to field convert the workstation to a 64 bit O/S. [Note: the SE2523 will continue to be
shipped with 32 bit installed]. This computer will support both English and non-English versions of DeltaV and
includes the language MUI DVD required for installing a localized non-English version of DeltaV. This unit does
not come with a Windows 7 O/S reinstall DVD. The image DVD is the only method available to reinstall the O/S
on this computer. Note that Windows for Embedded Systems licenses do not support downgrade rights this
computer cannot be converted to XP as we do not provide an XP license kit for this purpose.
•
The VE2555 ships with Windows XP Embedded OEM (32bit only) installed and includes a Windows XP image
DVD. This computer will support both English and non-English versions of DeltaV. This unit does not come with
a Windows XP O/S reinstall DVD. The image DVD is the only method available to reinstall the O/S on this
computer. Note that Embedded OEM licenses do not support downgrade rights. This computer is licensed for XP
only and is not Windows 7 downgraded to XP. Future upgrades of this computer to any new O/S version will
require purchase of a new Microsoft Windows license. Windows 7 cannot be installed on this computer unless a
Windows 7 upgrade kit is purchased to obtain the proper Microsoft O/S licensing.
•
Chassis: 2U rack mount
•
Height: 3.40 in (86.3mm), Width: 17.34in (440.60mm), Depth: With front bezel 28.84 in (732.54mm)
•
Weight: With front bezel 52.71 lb. (23.91 kg)
•
Power supply: Dual redundant power supplies (hot swappable). Each supply 1100W 92% plus efficiency
Maximum heat dissipation for 1100W power supply: 1819.1 BTU/hr with 15 amp power cables
•
Maximum vibration (using a random-vibration spectrum that simulates user environment) -
•
o
Operating: 5 to 350Hz at 0.0002G/Hz
o
Storage: 5 to 500Hz at 0.001 to 0.01G/Hz
Maximum shock o
Operating: 40G +/- 5% with pulse duration of 2msec +/- 10% (equivalent to 20in/sec [51cm/sec])
o
Storage: 105G +/- 5% with pulse duration of 2msec +/- 10% (equivalent to 50in/sec [127cm/sec])
DeltaV Product Data Sheet
DeltaV Workstation Hardware
April 2015 – Page 6
SE2525 or VE2555 —DeltaV Rack Mount Workstation – Single and Dual Monitor workstation [based
on Dell R5500XL]
The rack mounted workstation is only supported on DeltaV v9.3 and newer versionsquad monitor is supported only on v11.3 and newer
E2525 or VE2555 —DeltaV Rack Mount Workstation—Single and Dual Monitor workstation [based on
Dell R5500XL]
The rack mounted workstation is only supported on DeltaV v9.3 and newer versionsquad monitor is supported only on v11.3 and newer
Specifications for the Wyse® P25 Zero Client
One P25 Remote Access Device (KVM)
I/O Peripheral Support
The P25 Zero Client
has dual video
outputs and will
support DeltaV Dual
Monitor workstations
Button / LEDs
Networking
Display
Single Link DVI-I port, One DisplayPort (1 DisplayPort to DVI adapter included)
Four External USB 2.0 ports (2 front; 2 back)
Multi-Function power button LED
10/100/1000 Base-T Gigabit Ethernet
VESA monitor support with Display Data Control (DDC) for automatic setting of resolution and refresh rate
Audio
Physical Characteristics
Composite Audio 1/8-inch mini jack, One Line out / speaker 1/8-inch mini jack
Height: 1.14 inches (29 mm), Width: 6.97 inches (177 mm) Depth: 4.57 inches (116 mm)
Shipping Weight
Mounting
Device Security
Power
8.15 lbs. (3.7 kg)
Horizontal feet standard also doubling as VESA mounting bracket
Built-in Kensington security slot (cable sold separately)
Worldwide auto-sensing 100-240 VAC, 50/60 Hz. power supply
Average power usage with device connected to 1 keyboard with 1 mouse and 1 monitor: less than 8 watts
Operating: 32° to 104° F (10° to 40° C), horizontal and vertical positions.
Storage: 14° to 140° F (-10° to 60° C)
20% to 80% condensing, 10% to 95% non-condensing
Temperature Range
Humidity
Installation Note:
If the rack mounted workstation is installed within 100m of the monitor/mouse/keyboard, then using dedicated point to
point Ethernet-wired connections between the PC and P25 is required..
If distance is longer than 100m, then dedicated point to point fiber connections using media converters are required to
extend length.
The use of patch panels as part of the wiring between the PC and P25 is strongly discouraged due to possible network
issues introduced using these devices. Dedicated wiring runs are strongly recommended for P25 connections.
We only support dedicated point to point connections from the PC to the P25 device. If a switched network solution will be
used between multiple workstations and remote P25 devices it must be a network dedicated to serving the P25 devices
and must not be shared with any other communications and Ethernet network planning and design will be required for a
successful implementation. Consult Emerson Process Management SureService to obtain a quotation for assistance with
this network planning.
Replacement part kit for the FX100 or P25 KVM
SE2500KIT-1 Dual Monitor KVM Kit for dual monitor rack mount workstations: Provides the interface card, cables and Wyse
P25 KVM as a spare part for or to upgrade an FX100 KVM to a Wyse P25 KVM. See the DeltaV KBA # NK-1300-0245 for
instructions. [This kit is for the SE2525 or VE2555 (Dell R5500XL) only. Not supported on earlier versions of the DeltaV
Workstations)
DeltaV Product Data Sheet
DeltaV Workstation Hardware
April 2015 – Page 7
SE2513 —DeltaV Rack Mount Quad Monitor workstation [based on Dell R5500XL]
The quad monitor rack mounted workstation is only supported on DeltaV v11.3 and newer versions
•
3 network interface ports
•
CPU: Single Intel Xeon Quad Core processor
•
Memory: 4GB,
•
Drives: Qty 2- 500GB in a RAID 1 configuration
•
8x DVD +/- RW Drive
•
On-board integrated audio
•
Video: Qty 2 - ATI FirePro V2270 dual DVI graphics card (quad-monitor capable) (Note—Enabling the use of
more than 2 monitors requires the use of a DeltaV 4 monitor license). The video card provides one DVI output
using an included splitter cable to provide dual DVI outputs. There are no VGA ports available on the video card.
There are no DVI to VGA adaptors included. Each video card supports up to 2 monitors.
•
External KVM Extenders must be purchased separately using the KVM solutions provided in the Alliance
program. (The SE2513 does not support an FX100 or Wyse P25 Zero Client and the Wyse/Dell KVM interface
card is not installed on this computer)
•
Speakers: Dell two-piece stereo speakers
•
USB Optical mouse (2 button w/scroll), Local USB country keyboard, local power cord option
•
Rack Rails: Rack chassis with Sliding/Versa Rails and Cable Management Arm
•
The SE2513 ships with Windows 7 Windows for Embedded Systems 32 bit installed and includes a Windows 7 32
and 64 bit image DVD to field convert the workstation to a 64 bit O/S. [Note the SE2513 will continue to be
shipped with 32 bit installed]This computer will support both English and non-English versions of DeltaV and
includes the language MUI DVD required for installing a localized non-English version of DeltaV. This unit does
not come with a Windows 7 O/S reinstall DVD. The image DVD is the only method available to reinstall the O/S
on this computer. Note that Windows for Embedded Systems licenses do not support downgrade rights and XP
cannot legally be installed on this computer.
•
Chassis: 2U rack mount
•
Height: 3.40 in (86.3mm), Width: 17.34in (440.60mm), Depth: With front bezel 28.84 in (732.54mm)
•
Weight: With front bezel 52.71 lb. (23.91 kg)
•
Power supply: Dual redundant power supplies (hot swappable). Each supply 1100W 92% plus efficiency
Maximum heat dissipation for 1100W power supply: 1819.1 BTU/hr. with 15 amp power cables
•
Maximum vibration (using a random-vibration spectrum that simulates user environment)
o
o
•
Operating: 5 to 350Hz at 0.0002G/Hz
Storage: 5 to 500Hz at 0.001 to 0.01G/Hz
Maximum shock
o
o
-
-
Operating: 40G +/- 5% with pulse duration of 2msec +/- 10% (equivalent to 20in/sec [51cm/sec])
Storage: 105G +/- 5% with pulse duration of 2msec +/- 10% (equivalent to 50in/sec [127cm/sec])
DeltaV Product Data Sheet
April 2015 – Page 8
DeltaV Workstation Hardware
SE2515 or VE2554—DeltaV Dual/Quad Monitor Workstation [based on Dell T3600 workstation]
(DeltaV has consolidated the dual and quad workstations into a single computer)
• 3 Network Interface Ports
• Intel Quad Core processor
• Memory: 4GB
• Drives: 2 - 250GB or greater hard-drives – installed in a RAID 1 configuration.
• DVD+/--RW
• On-board integrated audio
• Video: Qty:2 Dell’s OEM version of the ATI FirePro V4900 card, dual DVI or DisplayPort
graphics card (dual-monitor capable) Each video card provides one DVI and 2- DisplayPort
outputs. A DisplayPort to DVI adaptor is included to create dual DVI outputs. There are no
VGA ports available on the video card. There is 1 DVI to VGA adaptor included. If more VGA outputs are required a
DisplayPort to VGA adaptor must be purchased locally. Video card supports up to 2 monitors - either 2 DisplayPort
outputs or one DisplayPort and one DVI port. (Please contact Emerson for the latest information on the approved
adaptor)
• Speakers: stereo speakers
• USB Optical mouse (2 button w/scroll)
• Local USB country keyboard (for languages supported)
• Local power cord option
• The SE2515 ships with Windows 7 Windows for Embedded Systems 64 bit installed and includes a Windows 7 32 and
64 bit image DVD to field convert the workstation to a 32 bit O/S. This computer will support both English and nonEnglish versions of DeltaV and includes the language MUI DVD required for installing a localized non-English version
of DeltaV. This unit does not come with a Windows 7 O/S reinstall DVD. The image DVD is the only method available
to reinstall the O/S on this computer. Note that Windows for Embedded Systems licenses do not support downgrade
rights and XP cannot legally be installed on this computer. If you need an XP based computer you MUST order the VE
number version. Windows 7 computers cannot be converted to XP as we do not offer an XP license kit for this
purpose.
• The VE2554 ships with Windows XP Windows for Embedded Systems (32 bit only) installed and includes a Windows
XP image DVD. This computer will support both English and non-English versions of DeltaV. This unit does not come
with a Windows XP O/S reinstall DVD. The image DVD is the only method available to reinstall the O/S on this
computer. Note that Windows for Embedded Systems licenses do not support downgrade rights. This computer is
licensed for XP only and is not Windows 7 downgraded to XP. Future upgrades of this computer to any new O/S
version will require purchase of a new Microsoft Windows license. Windows 7 cannot be installed on this computer
unless a Windows 7 upgrade kit is purchased to obtain the proper Microsoft O/S licensing.
• Chassis: Convertible Mini-tower
(H x W x D): 16.3" x 6.8" x 18.54" (H x W x D): 41.4cm x 17.3cm x 47.1cm
Weight: 29.1 lb. (16.3 kg)
• Power—635-watt power supply
• See the single monitor workstation specifications for environmental requirements.
DeltaV Product Data Sheet
DeltaV Workstation Hardware
April 2015 – Page 9
SE2409 DeltaV Workstation—General Specifications [based on a Dell T630 server]
(This workstation is compatible only with DeltaV v11.3 and newer)
•
Four Ethernet ports (two on-board + Intel i350 DP 1GB server adaptor dual NIC
ports)
•
Single CPU Quad Core Intel® Xeon® E5-2609 1.9 GHz
•
Integrated VGA Controller
•
Memory RDIMM, 2133MT Memory : 4GB
•
Hard drive : hot pluggable 15K RPM SAS 6Gbps 2.5 hard drives w/ 3.5" Hybrid
Carrier: PERC H730 RAID Controller: Drives included: Two 300GB setup in a RAID
1 configuration
•
DVD+/-RW drive
•
USB Optical mouse (2 button w/scroll), Local USB country keyboard, Local power
cord option
•
SE2409 includes Windows Server 2008 license and a Server 2008 R2 image DVD. Windows Server 2008 64 bit
operating system comes pre-installed and includes a Server 2008 32 and 64 bit image restore DVD to field
convert the DeltaV Workstation to a 32 bit O/S. Includes 5 server CAL licenses. Language support included with
DeltaV over-pack.
•
Height
443.5 mm (17.5 inch) with feet / 434.5 mm (17.1 inch) without feet
•
Width
304.5 mm (11.98 inch) with feet opened / 217.9 mm (8.57 inch) with feet closed
•
Depth
692.8 mm (27.27 inch) without bezel / 708.7 mm (27.9 inch) with bezel
•
Weight (maximum configuration)
•
Single, hot-pluggable 750W power supply Note: UPS required if used as a ProfessionalPlus to protect the system in
51.0 kg (112.43 lb) for 3.5 inch hard-drive chassis
the event of an unplanned power loss.
•
Vibration: Operating: 0.26G at 5Hz to 350Hz for 2 minutes , Storage: 1.54Grms Random Vibration at 10Hz to
250Hz for 15 minutes
•
Shock: Operating Shock: 1 shock pulse of 41G for up to 2ms, Storage: 6 shock pulses of 71G for up to 2ms
•
Note: Servers do not have PS/2 ports or parallel ports. Requires the use of a USB dongle.
This server does support wide screen monitor resolutions, but does not support multi-monitors or sound cards (no
speakers provided with servers)
NOTE: This server does not support the Server 2003 Operating System
Servers for use with Server 2003 must be purchased using the refurbished computer hardware available from DeltaV please consult with Installed Base
support for information on the refurbished computer program
DeltaV Product Data Sheet
DeltaV Workstation Hardware
April 2015 – Page 10
SE2408 DeltaV Workstation—General Specifications [based on the Dell T630 server]
(This workstation is compatible only with DeltaV v11.3 and newer)
•
Four Ethernet ports (two on-board + Intel i350 DP 1GB server adaptor dual NIC
ports)
•
Integrated VGA Controller
•
Memory: RDIMM, 2133MT
•
Hard drive : hot pluggable 15K RPM SAS 6Gbps 2.5 hard drives w/ 3.5" Hybrid
Carrier: PERC H730 RAID Controller
•
DVD+/-RW drive
•
USB Optical mouse (2 button w/scroll), Local USB country keyboard, Local power
cord option
•
SE2408 includes Windows Server 2008 license and a Server 2008 R2 image DVD.
Windows Server 2008 64 bit operating system comes pre-installed and includes a Server 2008 32 and 64 bit
image restore DVD to field convert the DeltaV Workstation to a 32 bit O/S. Includes 5 server CAL licenses.
Language support included with DeltaV over-pack.
•
Height
443.5 mm (17.5 inch) with feet / 434.5 mm (17.1 inch) without feet
•
Width
304.5 mm (11.98 inch) with feet opened / 217.9 mm (8.57 inch) with feet closed
•
Depth
692.8 mm (27.27 inch) without bezel / 708.7 mm (27.9 inch) with bezel
•
Weight (maximum configuration) 51.0 kg (112.43 lb) for 3.5 inch hard-drive chassis
•
Single, hot-pluggable 750W power supply Note: UPS required if used as a ProfessionalPlus to protect the system in
the event of an unplanned power loss.
•
Vibration: Operating: 0.26G at 5Hz to 350Hz for 2 minutes , Storage: 1.54Grms Random Vibration at 10Hz to
250Hz for 15 minutes
•
Shock: Operating Shock: 1 shock pulse of 41G for up to 2ms, Storage: 6 shock pulses of 71G for up to 2ms
•
Note: Servers do not have PS/2 ports or parallel ports. Requires the use of a USB dongle.
This server does support wide screen monitor resolutions, but does not support multi-monitors or
sound cards (no speakers provided with servers) NOTE: This server does not support the Server
2003 Operating System
Servers for use with Server 2003 must be purchased using the refurbished computer hardware available from DeltaV please consult with Installed Base support for
information on the refurbished computer program
SE2406C1-Tower Chassis Single Xeon Six Core CPU Server
•
•
•
Drives: Two 600GB or greater SAS hard-drives in a RAID 1 Array
Single CPU - Intel Xeon E5-2620 2.00GHz 6 cores
Memory: 16GB
SE2406C2- Tower Chassis Dual Xeon Six Core CPU Server
•
•
•
Drives: Six 600GB or greater 15K RPM SAS hard-drives in RAID 10 Array
Two CPUs - Intel Xeon E5-2620 2.00GHz 6 cores
Memory: 16GB
DeltaV Product Data Sheet
DeltaV Workstation Hardware
April 2015 – Page 11
SE2405- Rack-mount Xeon Six Core CPU Server General Specifications [based on Dell R720 server]
(This workstation is compatible only with DeltaV v11.3 and newer)
•
2U Rack-mountable chassis with sliding ready rails and cable management arm
•
16GB Memory
•
4 Ethernet ports all on the motherboard [no add-in NIC cards]
•
4 USB ports – 2 back panel and 2 on front panel
•
Integrated graphics controller with wide screen support (wide screen has been tested using our supported Dell
P2213 monitor at 1680x1050 resolution and 16 bit color depth using a direct connection to the VGA port. Other
monitors and KVM solutions may function without issues but have not been tested and may not be supported)
•
Hot-pluggable drive backplane
•
Redundant, hot-pluggable 750W power supplies Note: UPS required if used as a ProfessionalPlus.
•
SE2405 includes Windows Server 2008 Standard Edition licensed under Server 2008 for Embedded Systems.
Server 2008 64 bit is pre-installed and includes Server 2008 32 and 64 bit image DVD to field convert the
workstation to a 32 bit O/S. The SE2405 version should be ordered for use with Server 2008 versions of DeltaV.
Includes 10 server CAL licenses. For Server 2008 - MUI is not required. Language support included with DeltaV
overpack
•
DVD+/- R/W drive
•
USB mouse (2 button w/ scroll)
•
Local USB country keyboard
•
Local power cord option
•
Rack Server Dimensions 29.31" (74.4cm) D x 17.5" (44.43cm) W x 3.4" (8.64cm) H with bezel attached
•
Rack Server Weight 50.71 lbs. (23 Kg), maximum configuration
•
Note: Servers do not have PS/2 ports or parallel ports. Will require the use of a USB DeltaV dongle.
Environmental
•
Vibration: Operating: 0.26G at 5Hz to 350Hz for 2 minutes, Storage: 1.54Grms Random Vibration at 10Hz to
250Hz for 15 minutes
•
Shock: Operating: 1 shock pulse of 41G for up to 2ms, Storage: 6 shock pulses of 71G for up to 2ms
Servers do not support multi-monitors, sound cards (no speakers provided with servers)
NOTE:This server does not support the Server 2003 Operating System
Servers for use with Server 2003 must be purchased using the refurbished computer hardware available from DeltaV please consult with Installed Base
support for information on the refurbished computer program
SE2405C1- Rack mount Single Xeon Six Core CPU Server
•
Two SAS hard-drives, 600GB or greater in a RAID1 Array
•
Single CPU - Intel Xeon E5-2620 2.00GHz, 6 cores
SE2405C2 - Rack-mount Dual Xeon Six Core CPU Server
•
Six SAS hard-drives 600GB (or greater) drives in a RAID10 Array.
•
Two CPUs- Intel Xeon E5-2620 2.00GHz, 6 cores
DeltaV Product Data Sheet
April 2015 – Page 12
DeltaV Workstation Hardware
Information on the “Windows for Embedded Systems” operating systems
"Windows for Embedded Systems" is a version of the Windows Operating systems specifically created and
licensed for vendors who are purchasing the operating system for resale as part of a solution such as
DeltaV. The Windows for Embedded Systems O/S software is exactly the same as the Dell OEM version.
The Windows for Embedded Systems license does introduce the following situations:
Computers supplied with "Windows for Embedded Systems" licenses are licensed only for the operating
system purchased with the computer and do not have “downgrade rights”. Any change to the license
shipped with the computer requires the purchase of a new O/S license.
The DeltaV SE and VE numbered computers using the "Windows for Embedded Systems" license must
only be used as a DeltaV workstation or for DeltaV related tasks. These computers may not be purchased
for use as general purpose computer or used for applications where DeltaV or DeltaV related tasks are not
primary use for the computer.
As a Windows for Embedded Systems licensed vendor Emerson can continue to provide Windows XP
licenses on new computers (even though XP is no longer available from other suppliers) and to provide
Windows 7 and Server 2008 Upgrade kits which can only be purchased from Emerson.
Use of KVM (Keyboard, Video and Mouse) extenders and switches on DeltaV Workstations
Only the specific KVM products listed in the DeltaV Alliance program are supported with DeltaV.
If you have requirements for a KVM extender or switch that cannot be met by these KVM solutions you must
submit an engineering request for a supported solution. Please note the video card information on the
workstation computers. The video output connectors have changed and special adaptors must be used
[that may not be supplied] or new KVM equipment may have to be obtained to use these computers in existing
systems where KVMs are installed. These computers no longer have VGA connectors and the use of VGA
adaptors may not be supported by existing KVM devices
Computer Ordering Information
Ordering numbers (VE and SE numbers) are listed in the sections above. These specifications are subject to
change without notice. We guarantee that the computers sold for use with the DeltaV system will provide
performance and storage space needed to support DeltaV solutions. We do not guarantee that the hardware
specifications of the computers will remain unchanged during the sales life of a specific DeltaV SE or VE number.
The DeltaV Workstation specifications provided in this data sheet describe the products sold by Emerson for use
with DeltaV Control Systems. These specifications are not provided to allow users to purchase similar computers
directly from Dell or other PC vendors. The DeltaV system is supported only on the specific Dell computer
configurations specified in this document and sold from our pricebook. The DeltaV system is not supported on
other Dell computers or other computer configurations or on non-Dell computers unless specifically noted
otherwise. Any use of non-supported computers will affect our ability to provide technical support and will involve
additional costs for technical support.
NOTE: Hardware specifications of these computers especially as related to: size, backplane connection types
(such as COM ports or P/S2 ports), number of slots, etc. are not guaranteed to be available on newer DeltaV
workstations as these specifications can change from the vendor. It may not be possible to provide the same
capabilities from one version of a DeltaV Workstation to a succeeding version.
DeltaV Product Data Sheet
April 2015 – Page 13
DeltaV Workstation Hardware
To order the computers in this document with specifications different than those listed requires a customer special
configuration to be quoted by Emerson. Changing computer specification requires testing the new configuration
for compatibility with DeltaV software.
Note about modifying DeltaV Workstation Hardware configurations
DeltaV workstations are delivered with sufficient memory, hard drives and network interface cards and other
hardware to support all DeltaV applications. No additional hardware changes are required to support DeltaV
applications and standard installations. As such we do not support the field installation of additional memory,
additional hard drives, added NIC cards, different video cards or other field implemented hardware modifications
without consultation with Emerson. Failure to consult with Emerson on any hardware modifications may result in
poor DeltaV performance and make it difficult to provide technical support for those workstations that have been
modified. Hardware modifications can also require changes to the Windows O/S configuration that may impact
the performance of the workstation or the network.
DeltaV Product Data Sheet
DeltaV Workstation Hardware
April 2015 – Page 14
This page intentionally left blank
To locate a sales office near you, visit our website at:
www.EmersonProcess.com/DeltaV
Or call us at:
Asia Pacific: 65.6777.8211
Europe, Middle East: 41.41.768.6111
North America, Latin America:
+1 800.833.8314 or
+1 512.832.3774
© Emerson Process Management 2013. All rights reserved. For Emerson Process Management trademarks and service marks, go to:
http://www.emersonprocess.com/home/news/resources/marks.pdf.
The contents of this publication are presented for informational purposes only, and while every effort has been made to ensure their accuracy, they are not to be
construed as warrantees or guarantees, express or implied, regarding the products or services described herein or their use or applicability. All sales are governed
by our terms and conditions, which are available on request. We reserve the right to modify or improve the design or specification of such products at any time
without notice.
www.DeltaV.com