Samsung LA32C450 Service manual

! "#$ %
&'()"* &'()"* +,-.
+,-.
+,-. /0(/1 23/1 45678 49
56 /1 :; <=> ?@
AB> CD>
D>
CD> EC EC CD FG>(HIJ KHIJ
KHIJ
LMNOPQ
RSTUVWS XYZ[\]^MN_`ab]cd(ecfgh
ij PQ
RSTUV
k[WS
lc?@
1. Precautions
1. Precautions
1-1. Safety Precautions
Follow these safety, servicing and ESD precautions to prevent damage and to protect against potential hazards such as
electrical shock.
1-1-1. Warnings
1. For continued safety, do not attempt to modify the circuit board.
2. Disconnect the AC power and DC power jack before servicing.
1-1-2. Servicing the LCD TV
1. When servicing the LCD TV, Disconnect the AC line cord from the AC outlet.
2. It is essential that service technicians have an accurate voltage meter available at all times.
Check the calibration of this meter periodically.
1-1-3. Fire and Shock Hazard
Before returning the LCD TV to the user, perform the following safety checks:
1. Inspect each lead dress to make certain that the leads are not pinched or that hardware is not lodged between the
chassis and other metal parts in the LCD TV.
2. Inspect all protective devices such as nonmetallic control knobs, insulating materials, cabinet backs, adjustment and
compartment covers or shields, isolation resistorcapacitor networks, mechanical insulators, etc.
3. Leakage Current Hot Check (Figure 1-1):
WARNING : Do not use an isolation transformer during this test.
Use a leakage current tester or a metering system that complies with American National Standards Institute (ANSI
C101.1, Leakage Current for Appliances), and Underwriters Laboratories (UL Publication UL1410, 59.7).
(READING SHOULD)
NOT BE ABOVE 0.5mA
LEAKAGE
CURRENT
TESTER
DEVICE
UNDER
TEST
TEST ALL
EXPOSED METAL
SURFACES
2-WIRE CORD
*ALSO TEST WITH
PLUG REVERSED
(USING AC ADAPTER
PLUG AS REQUIRED)
EARTH
GROUND
Figure 1-1. Leakage Current Test Circuit
4. With the unit completely reassembled, plug the AC line cord directly into a 120V AC outlet. With the unit’s AC switch
first in the ON position and then OFF, measure the current between a known earth ground (metal water pipe, conduit,
etc.) and all exposed metal parts, including: metal cabinets, screwheads and control shafts.
The current measured should not exceed 0.5 milliamp.
Reverse the power-plug prongs in the AC outlet and repeat the test.
1-1-4. Product Safety Notices
Some electrical and mechanical parts have special safetyrelated characteristics which are often not evident from visual
inspection. The protection they give may not be obtained by replacing them with components rated for higher voltage,
on schematics and parts lists. A substitute
wattage, etc. Parts that have special safety characteristics are identified by
replacement that does not have the same safety characteristics as the recommended replacement part might create
shock, fire and/or other hazards. Product safety is under review continuously and new instructions are issued whenever
appropriate.
1-1
1. Precautions
1-2. Servicing Precautions
WARNING: An electrolytic capacitor installed with the wrong polarity might explode.
Caution:
Before servicing units covered by this service manual, read and follow the Safety Precautions section of
this manual.
Note:
If unforeseen circumstances create conflict between the following servicing precautions and any of the
safety precautions, always follow the safety precautions.
1-2-1 General Servicing Precautions
1. Always unplug the unit’s AC power cord from the AC power source and disconnect the DC Power Jack before
attempting to:
(a) remove or reinstall any component or assembly, (b) disconnect PCB plugs or connectors, (c) connect a test
component in parallel with an electrolytic capacitor.
2. Some components are raised above the printed circuit board for safety. An insulation tube or tape is sometimes
used. The internal wiring is sometimes clamped to prevent contact with thermally hot components. Reinstall all such
elements to their original position.
3. After servicing, always check that the screws, components and wiring have been correctly reinstalled. Make sure that
the area around the serviced part has not been damaged.
4. Check the insulation between the blades of the AC plug and accessible conductive parts (examples: metal panels,
input terminals and earphone jacks).
5. Insulation Checking Procedure: Disconnect the power cord from the AC source and turn the power switch ON.
Connect an insulation resistance meter (500 V) to theblades of the AC plug.
The insulation resistance between each blade of the AC plug and accessible conductive parts (see above) should be
greater than 1 megohm.
6. Always connect a test instrument’s ground lead to the instrument chassis ground before connecting the positive lead;
always remove the instrument’s ground lead last.
1-3. Electrostatically Sensitive Devices (ESD) Precautions
Some semiconductor (solid state) devices can be easily damaged by static electricity. Such components are commonly
called Electrostatically Sensitive Devices (ESD). Examples of typical ESD are integrated circuits and some field-effect
transistors. The following techniques will reduce the incidence of component damage caused by static electricity.
1. Immediately before handling any semiconductor components or assemblies, drain the electrostatic charge from your
body by touching a known earth ground. Alternatively, wear a discharging wrist-strap device. To avoid a shock hazard,
be sure to remove the wrist strap before applying power to the LCD TV.
2. After removing an ESD-equipped assembly, place it on a conductive surface such as aluminum foil to prevent
accumulation of an electrostatic charge.
3. Do not use freon-propelled chemicals. These can generate electrical charges sufficient to damage ESDs.
4. Use only a grounded-tip soldering iron to solder or desolder ESDs.
5. Use only an anti-static solder removal device. Some solder removal devices not classified as “anti-static” can generate
electrical charges sufficient to damage ESDs.
6. Do not remove a replacement ESD from its protective package until you are ready to install it. Most replacement ESDs
are packaged with leads that are electrically shorted together by conductive foam, aluminum foil or other conductive
materials.
7. Immediately before removing the protective material from the leads of a replacement ESD, touch the protective
material to the chassis or circuit assembly into which the device will be installed.
Caution: Be sure no power is applied to the chassis or circuit and observe all other safety precautions.
8. Minimize body motions when handling unpackaged replacement ESDs. Motions such as brushing clothes together,
or lifting your foot from a carpeted floor can generate enough static electricity to damage an ESD.
1-2
1. Precautions
1-4. Installation Precautions
1. For safety reasons, more than a people are required for carrying the product.
2. Keep the power cord away from any heat emitting devices, as a melted covering may cause fire or electric shock.
3. Do not place the product in areas with poor ventilation such as a bookshelf or closet. The increased internal
temperature may cause fire.
4. Bend the external antenna cable when connecting it to the product. This is a measure to protect it from being exposed
to moisture. Otherwise, it may cause a fire or electric shock.
5. Make sure to turn the power off and unplug the power cord from the outlet before repositioning the product. Also check
the antenna cable or the external connectors if they are fully unplugged. Damage to the cord may cause fire or electric
shock.
6. Keep the antenna far away from any high-voltage cables and install it firmly. Contact with the highvoltage cable or the
antenna falling over may cause fire or electric shock.
7. When installing the product, leave enough space (0.4m) between the product and the wall for ventilation purposes.
A rise in temperature within the product may cause fire.
1-3
2. Product specifications
2. Product specifications
2-1. Feature & Specifications
Model
LA19D400E1
Feature
ሪሪ ATV, 1-HDMI, 1-Component, 1-A/V, D-SUB, 1-USB2.0
ሪሪ Brightness : 250cd/m2
ሪሪ High Contrast Ratio : 1,000:1
ሪሪ Response Time : 5ms
Specifications
Item
Description
LCD Panel
19inch HD
Scanning Frequency
Horizontal : 37.13 kHz ~ 59.25 kHz (Automatic)
Vertical : 50 Hz ~ 75 Hz (Automatic)
Display Colors
16.7M color
Maximum resolution
Horizontal : 1366 Pixels
Vertical : 768 Pixels
Input Signal
Analog 0.7 Vp-p ± 5% positive at 75Ω , internally terminated
Input Sync Signal
H/V Separate, TTL, P. or N.
Maximum Pixel Clock rate
89 MHz (Typ 67.1 MHz)
Active Display
Horizontal/Vertical
16.13 x 9.07 inches (409.8 (H) x 230.4 (V) mm)
AC power voltage & Frequency
AC 110V ~ 120V, 60 Hz
Power Consumption
Under 35W (Under 0.3W, Stand by)
Set Dimensions (W x D x H)
18.2 x 6.3 x 13.7 nchs (461.3 x 160.7 x 346.8 mm)_with stand
18.2 x 2.4 x 11.8 inchs (461.3 x 61.2 x 299.7 mm)_without stand
Set Weight
8.8 Ibs (4.0kg)_with stand
8.4 Ibs (3.8kg)_without stand
Stand Dimensions (W x D x H)
12.0 x 6.3 x 2.9 inchs (303.7 x 160.7 x 72.6 mm)
Stand Weight
0.5 Ibs (0.21kg)
TV System
Tunning
Frequency Synthesize (Refer to detailed Frequency Table)
System
PAL, SECAM, NT4.43
Sound
BG, DK, L/L’, NICAM, MPEG1, DD, DD+, HE-AAC
Environmental Considerations
Operating Temperature : 50˚F ~ 104˚F (10˚C ~ 40˚C)
Operating Humidity : 10% ~ 80%, non-condensing
Storage temperature : -13˚F ~ 113˚F (-25˚C ~ 45˚C)
Storage Humidity : 5% ~ 95%, non-condensing
Audio Spec.
- MAX Internal speaker Out : Right => 3W, Left => 3W
- BASS Control Range : -8 dB ~ + 8dB
- TREBLE Control Range : -8 dB ~ +8 dB
- Headphone Out : 10 mW MAX
- Output Frequency : RF : 80 Hz ~ 15 kHz
A/V : 80 Hz ~ 20 kHz
Note: Dolby Digital+, Game Mode, Film Mode, Energy Saving, Anynet+
2-1
2. Product specifications
Model
LA22D400E1R
Feature
ሪሪ ATV, 1-HDMI, 1-Component, 1-A/V, D-SUB, 1-USB2.0
ሪሪ Brightness : 300cd/m2
ሪሪ High Contrast Ratio : 1,000:1
ሪሪ Response Time : 5ms
Specifications
Item
Description
LCD Panel
22inch FHD
Scanning Frequency
Horizontal : 60 kHz ~ 73 kHz (Automatic)
Vertical : 50 Hz ~ 75 Hz (Automatic)
Display Colors
16.7M color
Maximum resolution
Horizontal : 1920 Pixels
Vertical : 1080 Pixels
Input Signal
Analog 0.7 Vp-p ± 5% positive at 75Ω , internally terminated
Input Sync Signal
H/V Separate, TTL, P. or N.
Maximum Pixel Clock rate
97.98 MHz (Typ 74.25 MHz)
Active Display
Horizontal/Vertical
18.77 x 10.56 inches (476.64 (H) x 268.11 (V) mm)
AC power voltage & Frequency
AC 110V ~ 120V, 60 Hz
Power Consumption
Under 60W (Under 1W, Stand by)
Set Dimensions (W x D x H)
21.0 x 6.8 x 15.4 nchs (533.2x171.6x390.0 mm)_with stand
21.0 x 6.8 x 15.4 nchs (533.2x171.6x390.0 mm)_with stand
Set Weight
11.2 Ibs (5.1kg)_with stand
10.8 Ibs (4.9kg)_without stand
Stand Dimensions (W x D x H)
13.8 x 6.8 x 3.0 inchs (351.7 x 171.6 x 75.3 mm)
Stand Weight
0.5 Ibs (0.25kg)
TV System
Tunning
Frequency Synthesize (Refer to detailed Frequency Table)
System
PAL, SECAM, NT4.43
Sound
BG, DK, L/L’, NICAM, MPEG1, DD, DD+, HE-AAC
Environmental Considerations
Operating Temperature : 50˚F ~ 104˚F (10˚C ~ 40˚C)
Operating Humidity : 10% ~ 80%, non-condensing
Storage temperature : -13˚F ~ 113˚F (-25˚C ~ 45˚C)
Storage Humidity : 5% ~ 95%, non-condensing
Audio Spec.
- MAX Internal speaker Out : Right => 3W, Left => 3W
- BASS Control Range : -8 dB ~ + 8dB
- TREBLE Control Range : -8 dB ~ +8 dB
- Headphone Out : 10 mW MAX
- Output Frequency : RF : 80 Hz ~ 15 kHz
A/V : 80 Hz ~ 20 kHz
Note: Dolby Digital+, Game Mode, Film Mode, Energy Saving, Anynet+
2-2
2. Product specifications
Model
LA26D400E1
Feature
ሪሪ ATV, 2-HDMI, 2-Component, 2-A/V, D-SUB, 1-USB2.0
ሪሪ Brightness : 450cd/m2
ሪሪ High Contrast Ratio : 3,000:1
ሪሪ Response Time : 8.5ms
Specifications
Item
Description
LCD Panel
26inch HD
Scanning Frequency
Horizontal : 43 kHz ~ 53 kHz (Automatic)
Vertical : 47 Hz ~ 63 Hz (Automatic)
Display Colors
16.7M color
Maximum resolution
Horizontal : 1366 Pixels
Vertical : 768 Pixels
Input Signal
Analog 0.7 Vp-p ± 5% positive at 75Ω , internally terminated
Input Sync Signal
H/V Separate, TTL, P. or N.
Maximum Pixel Clock rate
82 MHz (Typ 76 MHz)
Active Display
Horizontal/Vertical
22.67 x 12.74 inches (575.769 (H) x 323.712 (V) mm)
AC power voltage & Frequency
AC 110V ~ 120V, 60 Hz
Power Consumption
Under 85W (Under 1W, Stand by)
Set Dimensions (W x D x H)
Set Weight
25.5 x 8.7 x 19.3 inchs (646.5x222.1x489.5 mm)_with stand
25.5 x 3.5 x 16.6 inchs (646.5x78.8x421.3 mm)_without stand
14.6 Ibs (6.6kg)_with stand
13.7 Ibs (6.2kg)_without stand
Stand Dimensions (W x D x H)
17.2 x 8.7 x 3.2 inchs (437.1 x 222.1 x 82.0 mm)
Stand Weight
1.0 Ibs (0.47kg)
TV System
Tunning
Frequency Synthesize (Refer to detailed Frequency Table)
System
PAL, SECAM, NT4.43
Sound
BG, DK, L/L’, NICAM, MPEG1, DD, DD+, HE-AAC
Environmental Considerations
Operating Temperature : 50˚F ~ 104˚F (10˚C ~ 40˚C)
Operating Humidity : 10% ~ 80%, non-condensing
Storage temperature : -13˚F ~ 113˚F (-25˚C ~ 45˚C)
Storage Humidity : 5% ~ 95%, non-condensing
Audio Spec.
- MAX Internal speaker Out : Right => 5W, Left => 5W
- BASS Control Range : -8 dB ~ + 8dB
- TREBLE Control Range : -8 dB ~ +8 dB
- Headphone Out : 10 mW MAX
- Output Frequency : RF : 80 Hz ~ 15 kHz
A/V : 80 Hz ~ 20 kHz
Note: Dolby Digital+, Game Mode, Film Mode, Energy Saving, Anynet+
2-3
2. Product specifications
Model
LA32D400E1
Feature
ሪሪ ATV, 2-HDMI, 2-Component, 2-A/V, D-SUB, 1-USB2.0
ሪሪ Brightness : 450cd/m2
ሪሪ High Contrast Ratio : 3,500:1
ሪሪ Response Time : 8.5ms
Specifications
Item
Description
LCD Panel
32inch HD
Scanning Frequency
Horizontal : 43 kHz ~ 53 kHz (Automatic)
Vertical : 47 Hz ~ 63 Hz (Automatic)
Display Colors
16.7M color
Maximum resolution
Horizontal : 1366 Pixels
Vertical : 768 Pixels
Input Signal
Analog 0.7 Vp-p ± 5% positive at 75Ω , internally terminated
Input Sync Signal
H/V Separate, TTL, P. or N.
Maximum Pixel Clock rate
82 MHz (Typ 76 MHz)
Active Display
Horizontal/Vertical
27.47 x 15.44 inches (697.685 (H) x 392.256 (V) mm)
AC power voltage & Frequency
AC 110V ~ 120V, 60 Hz
Power Consumption
Under 110W (Under 1W, Stand by)
Set Dimensions (W x D x H)
30.9 x 9.9 x 22.3 inchs (784.4x251.7x565.6 mm)_with stand
30.9 x 3.1 x 19.8 inchs (784.4x78.8x502.8 mm)_without stand
Set Weight
23.6 Ibs (10.7kg)_with stand
18.7 Ibs (8.5kg)_without stand
Stand Dimensions (W x D x H)
19.8 x 9.9 x 7.1 inchs (503.7 x 251.7 x 181.6 mm)
Stand Weight
5.0 Ibs (2.25kg)
TV System
Tunning
Frequency Synthesize (Refer to detailed Frequency Table)
System
PAL, SECAM, NT4.43
Sound
BG, DK, L/L’, NICAM, MPEG1, DD, DD+, HE-AAC
Environmental Considerations
Operating Temperature : 50˚F ~ 104˚F (10˚C ~ 40˚C)
Operating Humidity : 10% ~ 80%, non-condensing
Storage temperature : -13˚F ~ 113˚F (-25˚C ~ 45˚C)
Storage Humidity : 5% ~ 95%, non-condensing
Audio Spec.
- MAX Internal speaker Out : Right => 10W, Left => 10W
- BASS Control Range : -8 dB ~ + 8dB
- TREBLE Control Range : -8 dB ~ +8 dB
- Headphone Out : 10 mW MAX
- Output Frequency : RF : 80 Hz ~ 15 kHz
A/V : 80 Hz ~ 20 kHz
Note: Dolby Digital+, Game Mode, Film Mode, Energy Saving, Anynet+
2-4
2. Product specifications
2-2. Detail Factory Option
※※ If you replace the main board with new one, please change the factory option as well.
The options you must change are “Type”.
 LD400
Model Name
Panel
SMPS
LA19D400E1
LA22D400E1R
LA26D400E1
Vendor
CPT
CMI
CMI
CMI
CODE
BN07-00941A
BN07-00888A
BN07-00950A
BN07-00951B
SPEC
CLAA185WA03-A
M215H1-L03
V260B3-L08
V315B5-L13
Vendor
PowerNet
SEM
DYREL
SEM
CODE
BN44-00436A
BN44-00437A
BN44-00438C
BN44-00438A
SPEC
I19HD_BPN
I22HD_BSM
I2632F1_BDY
I2632F1_BSM
Byte
Item
Adjustment Range
1
Factory Reset
-
2
Type
3
Model
4
TUNER
5
Ch Table
6
Local set
7
P&P
Language
LA32D400E1
19A6TH0C/22P6TH0C/22I6TH0
C/26P6AH0C/32P6AH0C/32A6A
H0C/19I6TH0C/32D6AH0C/32A
6AH1C/32L6AH0C
LD400/LD400_19/LD400_FHD
XUGUANG/SEMCO
SUWON/SESK/SEH/TTSEC/
SEIN/SDMA/TSED/SAVINA/
SIEL_C/SIEL_N/TSE
East Aisa/Africa/Vietnam/China/
India/Iran/Israel/Middle Asia
English/Thai/
China/Vietnam/Indonisia
ASIA Ready
19I6TH0C
22P6TF0C
26P6AH0C
32P6AH0C
LD400
XUGUANG
LD400
LD400
LD400
XUGUANG
XUGUANG
XUGUANG
-
-
-
-
East Aisa
East Aisa
East Aisa
East Aisa
English
English
English
English
LA19D400E1
LA22D400E1R
LA26D400E1
LA32D400E1
 LD400 (India, Vietnam)
Model Name
Panel
SMPS
Byte
Item
1
Factory Reset
2
Type
3
Model
4
TUNER
5
Ch Table
6
Local set
7
P&P
Language
Vendor
CPT
CMI
CMI
CMI
CODE
BN07-00941A
BN07-00888A
BN07-00950A
BN07-00951B
V315B5-L13
SPEC
CLAA185WA03-A
M215H1-L03
V260B3-L08
Vendor
PowerNet
SEM
SEM
SEM
CODE
BN44-00436B
BN44-00437C
BN44-00438E
BN44-00438E
SPEC
II19HD_BPN
HD_BSM
II2632F1_BSM
II2632F1_BSM
Adjustment Range
ASIA Ready
-
19A6TH0C/22P6TH0C/22I6TH0
C/26P6AH0C/32P6AH0C/32A6A
H0C/19I6TH0C/32D6AH0C/32A
6AH1C/32L6AH0C
LD400/LD400_19/LD400_FHD
XUGUANG/SEMCO
SUWON/SESK/SEH/TTSEC/
SEIN/SDMA/TSED/SAVINA/
SIEL_C/SIEL_N/TSE
East Aisa/Africa/Vietnam/China/
India/Iran/Israel/Middle Asia
English/Thai/
China/Vietnam/Indonisia
19I6TH0C
22P6TF0C
LD400
XUGUANG
LD400
LD400
LD400
XUGUANG
XUGUANG
XUGUANG
-
-
-
-
India
India
India
India
English
English
English
English
26P6AH0C
32P6AH0C
2-5
2. Product specifications
2-3. Specification Comparison to Old Models
※※O : application, X : non-application
D400 (LA**D400)
D400 (LA32D400)
Display Type
LCD TV
LCD TV
Built-in Tuner
O
O
Resolution
1366X768 (22" : 1920X1080)
1366X768
LCD Panel
TFT LCD Panel 60Hz
TFT LCD Panel 60Hz
Screen Size
19"/22"/26"/32"
32"
Picture ratio
16 : 9
16:9
Model
Design
Dimensions (W x H x D)
Weight
19"
18.2 x 6.3 x 13.7 inchs _with stand
22"
21.0 x 6.8 x 15.4 inchs _with stand
26"
25.5 x 8.7 x 19.3 inchs _with stand
32"
30.9 x 9.9 x 22.3 inchs _with stand
19"
8.8 Ibs_with stand
22"
11.2 Ibs_with stand
26"
14.6 Ibs_with stand
32"
23.6 Ibs_with stand
Dynamic Contrast Ratio
30.9 x 22.0 x 9.7 inchs _with stand
21.16 Ibs_with stand
High Contrast
High Contrast
No (DNIe : SEMS)
No (DNIe : SEMS)
Equalizer
O
O
Auto Volume Control
O
O
SRS TheaterSound HD
SRS TruSound HD
Picture Engine
Sound System
Speaker Output
19"/22"
3W + 3W
26"
5W + 5W
32"
10W + 10W
5W + 5W
PIP
X
O
Double Window
X
X
TTX
X
X
Entertainment Mode
X
X
Game Mode
O
O
Energy Saving
O
O
Anynet+
X
X
Antenna
1(Air)
1(Air)
2-6
2. Product specifications
2-4. New Features explanation
2-4-1. Media_Play
„„ Advanced Features
2-7
2. Product specifications
„„ Advanced Features
2-8
2. Product specifications
2-9
2. Product specifications
2-10
2. Product specifications
2-5. Accessories
Product
Description
Model
Code. No
Remote Control & Batteries
(AAA x 2)
400
AA59-00499A
4301-000121
Power Cord
ALL
3903-000607
400
19" : BN90-03252A
22" : BN90-03253A
26" : BN90-03267B
32" : BN90-03268B
Stand
Screw
(M4 x L16)
400
6002-001294
Quick Start Guide
400
BN68-03417A
Cleaning Cloth
ALL
BN63-01798B
Warranty Card / Registration
Card / Safety Guide Manual
(Not available in all locations)
ALL
BN68-00774D
AA68-03242M
Remark
Samsung Electronics
Service center
2-11
!"#$%&'
&'
(
)*+ ,
&'-./01
.>?@AB89CD
23456789:;<=
E&'2EDFGH
IJK/LMNOPQORJS
TUS VWX TU ?@SVWX
YZ?@
[\]^_`
abS VWX bS VWX
TUcS VWX
YZdb
efg
WXhi
WXhi
jk
IJK/LMNOPQORJS TUS VWX TU ?@SWX VWX VWX YZ?@
abSWX VWX VWX bSWX VWX TUlmcSWX VWX VWX db(# WX VWX [\]^_`
YZTUlmc
YZdb
efg
WXhi
WXhi
jk
Exploded Views and Parts List
1. Exploded View & Part List
Exploded View
Copyright© 1995-2011 SAMSUNG. All rights reserved.
1
Exploded Views and Parts List
Parts List
No.
Parent
Lvl.
Loc.
Material Code
Description & Specification
SNA
1
BN90-03317B
2
F001A
BN96-16964B
ASSY COVER P-FRONT;
LD400,32,CHINA,PMMA/A
SA
1
2
BN91-06785A
2
PANEL
BN07-00951B
LCD-PANEL;
V315B5-L13,CM31B53,8bits,31.5i
SA
1
3
BN91-06407F
2
P001A
BN44-00438A
AC VSS(I)-TV;
PSIV121411A,I2632F1_BSM,63k
SA
1
4
BN91-06837A
2
M0014
BN94-04622A
ASSY PCB MAIN; LA32D400E1XXT
SA
1
5
BN98-03239A
3
BN61-07374A
HOLDER-SIDE AV;
LD400,32,HIPS,BK0020,HB
SNA
1
6
BN90-03321D
2
R001A
BN96-16972D
ASSY COVER P-REAR;
LD400,32,CHINA(Ready),
SA
1
7
BN91-06407F
2
T0910
BN96-13341A
ASSY BRACKET P-STAND LINK;
LC530 32,SECC,
SA
1
8
BN90-03268B
2
SG03A
BN96-16985A
ASSY STAND P-GUIDE;
LD400/450,W/W,PC+G/F,
SA
1
9
BN90-03268B
2
SB04A
BN96-16990B
ASSY STAND P-BASE;
LD400/450,32,PMMA/ABS,
SA
1
10
BN96-16964B
3
FB21A
BN96-18314E
ASSY BOARD P-TOUCH FUNCTION
& IR; LA32D400_
SA
1
2
Qty.
Copyright© 1995-2011 SAMSUNG. All rights reserved.
Exploded Views and Parts List
2. Exploded View & Part List
Level
Loc.
Part Code
Description & Specification
Qty.
SA/SNA
LA32D400E1XXZ (HN01)
1
S001A BN90-03268B
ASSY STAND;LD450,32,W/W
1
SNA
.2
SG03A BN96-16985A
ASSY STAND P-GUIDE;LD400/450,W/W,PC+G/F,
1
SA
..3
T0524
6902-001048
BAG PE;LDPE,T0.05,W160,L300,TRP,4g
1
SNA
..3
SG03
BN61-07147A
GUIDE-STAND;LD450,32,PC+G/F,20%,V2,BK000
1
SNA
..3
BN68-03392C
MANUAL FLYER-02,STAND GUIDE;L450(32),SAM
1
SNA
..3
BN96-18013B
ASSY ACCESSORY-SCREW;6002-001294,4EA,ALL
2
SNA
...4
T0081
6002-001294
SCREW-TAPPING;BH,+,,M4,L16,ZPC(BLK)
8
SA
...4
T0524
6902-000341
BAG PE;LDPE,T0.05,L90,W70,TRP,,,PE MARK
2
SNA
.2
SB04A BN96-16990B
ASSY STAND P-BASE;LD400/450,32,PMMA/ABS,
1
SA
..3
M0081 6003-000003
SCREW-TAPTYPE;BH,+,-,B,M4,L10,ZPC(BLK),S
3
SA
..3
M0081 6003-001239
SCREW-TAPTYPE;FH,+,B,M4,L10,ZPC(WHT),SWR
4
SA
..3
6902-000337
BAG PE;LDPE,T0.05,W450,L700,TRP,8,2-
1
SNA
..3
BN61-07270A
BRACKET-STAND BOTTOM;LD450 32",SECC,T1.2
1
SNA
..3
BN61-07272A
GUIDE-STAND, NECK;LD450,32,PC+G/F,20%,V2
1
SNA
BN63-02183D
COVER-SHEET;Rhcm,PE Vinyl,T0.05,680mm,20
0
SNA
..3
BN63-04755N
COVER-SHEET;32LC350,PE,T0.05,W180mm,200M
1
SNA
..3
BN63-07893B
COVER-STAND BASE;LD450,32,PMMA/ABS,HB,BK
1
SNA
..3
M0019 BN73-00052C
RUBBER-FOOT;LCD TV,CR RUBBER,T2.0 DIA19,
4
SNA
ASSY COVER FRONT;LD400,32,CHINA
1
SNA
..3
CCM1
1
BN90-03317B
.2
SP01A BN96-12871D
ASSY SPEAKER P;6ohm,4pin,10W,11year LCD
1
SA
.2
F001A BN96-16964B
ASSY COVER P-FRONT;LD400,32,CHINA,PMMA/A
1
SA
..3
BN60-00162V
SPACER-FOAM;FOAM,50000mm,Dark Gray,0.5T,
4
SNA
..3
AB326 BN61-04661A
BRACKET-STOPPER;L650,SK-5,T0.4,Plating,H
2
SNA
..3
CCM1
BN63-02183F
COVER-SHEET;Rhcm,PE Vinyl,T0.05,900mm,20
1
SNA
..3
CCM1
BN63-02183Q
COVER-SHEET;AMBER,PE,T0.08,845,200,CLEAR
1
SNA
..3
F001
BN63-08322B
COVER-FRONT;LD400,32,CHINA,ABS+PMMA,HB,R
1
SNA
..3
FB21A BN96-18314E
ASSY BOARD P-TOUCH FUNCTION & IR;LA32D400_
1
SA
..3
BN96-18834B
ASSY HOLDER P-BOSS BOTTOM;LD400,32,ABS,H
1
SNA
...4
BN61-04692A
BOSS-PRIMER;#94,clear,35cps
0
SNA
...4
BN61-04731B
BOSS-TAPE;AMBER,ACRYL,T1.1,W12.0mm,WHITE
1
SNA
...4
BN61-07615B
HOLDER-BOSS BOTTOM;LD400 32",ABS,WT0034,
1
SNA
1
SNA
1
R001A BN90-03321D
ASSY COVER REAR;LD400,32,CHINA(Ready)
.2
T0081
SCREW-TAPPING;BH,+,,M4,L16,ZPC(BLK)
.2
R001A BN96-16972D
..3
6002-001294
10
SA
ASSY COVER P-REAR;LD400,32,CHINA(Ready),
1
SA
BN60-00163T
SPACER-FOAM;FOAM,50000mm,Dark Gray,0.35T
1
SNA
..3
T0101
BN61-04816A
BRACKET-WALL;40, B610,SECC,T1.2
4
SNA
..3
R001
BN63-08244A
COVER-REAR;LD400,32,HIPS,HB,BK0020
1
SNA
Copyright© 1995-2011 SAMSUNG. All rights reserved.
3
Exploded Views and Parts List
Level
Loc.
Part Code
Description & Specification
..3
T0071
BN64-01577D
INLAY-TERMINAL;LD400,32,CHINA,PS SHEET,H
1
SNA
..3
T0139
BN65-00002A
CLAMPER CORE;BORDEAUX,LDPE,BLK
1
SNA
BN91-06407F
ASSY SHIELD;LA32D400E1XXT
1
SNA
6001-002284
SCREW-MACHINE;BH,+,M4,L8,ZPC(WHT),SWRCH1
1
.2
T0081
.2
SCREW 6003-001782
.2
EC13
.2
Qty.
SA/SNA
11
SA
SCREW-TAPTYPE;BH,+,B,M4,L12,ZPC(BLK),SWR
7
SA
LEAD CONNECTOR;LN32D550,Lead Connector A
1
SNA
P001A BN44-00438A
AC VSS(I)-TV;PSIV121411A,I2632F1_BSM,63k
1
SA
.2
M0230 BN96-13227A
ASSY CABLE P-FFC;LA32C450,FFC,1mm PITCH,
1
SA
.2
T0910
BN96-13341A
ASSY BRACKET P-STAND LINK;LC530 32,SECC,
1
SA
..3
BN61-02429K
STUD-PEM;PNB,M3.8,D7,L14.9,ZPC(SIL),SUM2
2
SNA
..3
BN61-05281A
HOLDER-CLAMP;LCD,NYLON 66,WHT
2
SNA
..3
M0115 BN61-06024A
BRACKET-STAND LINK;LC550 32",SECC,T1.2
1
SNA
.2
BN98-03239A
ASSY K/D-SHIELD AV;D400,ready
1
SNA
BN39-01449A
LEAD CONNECTOR;LN32D550,Lead Connector A
1
SA
..3
BN61-07374A
HOLDER-SIDE AV;LD400,32,HIPS,BK0020,HB
1
SNA
1
BN91-06785A
ASSY LCD;LA32D450G1MXXY
1
SNA
.2
PANEL BN07-00951B
LCD-PANEL;V315B5-L13,CM31B53,8bits,31.5i
1
SA
1
M0017 BN91-06837A
ASSY CHASSIS;LA32D400E1XXT
1
SNA
.2
M0014 BN94-04622A
ASSY PCB MAIN;LA32D400E1XXT
1
SA
..3
EC13
BN39-01448E
..3
0202-001463
SOLDER-WIRE;LFC2-W3.0,-,D3,99.79Sn/0.2Cu
3
SNA
..3
0202-001608
SOLDER-WIRE FLUX;LFC7-107,D0.8,99.3Sn/0.
0
SNA
..3
0204-002420
SOLVENT;1M-1000,C3H70H,96
3
SNA
..3
0204-002607
FLUX;DF-234U,13%,14KG,Gravity 0.82
2
SNA
..3
BN97-00688A
ASSY HDCP;BN46-00018A,PS-42V6S,D73A,GENE
1
SNA
...4
BN46-00018A
KEY CODE-CERTIFICATE;(HDCP KEY)PPM42M5S,
1
SNA
..3
BN97-05495A
ASSY SMD;LA32D400E1XXT,BN41-01621A
1
SNA
...4
0202-001477
SOLDER-CREAM;LST309-M,D20~45um,96.5Sn/3A
3
SNA
...4
DS01A 0401-000116
DIODE-SWITCHING;MMSD914T1,100V,200mA,SOD
5
SA
...4
D1
0401-001099
DIODE-SWITCHING;1N4148WS,75V,150mA,SOD-3
2
SA
...4
D0254
0402-000553
DIODE-SCHOTTKY;SS24/B240,40V,2000mA,DO-2
2
SA
...4
0403-001416
DIODE-ZENER;MMSZ5227B,3.42-3.78V,500MW,S
1
SA
...4
0403-001779
DIODE-ZENER;MMSZ5234BT1G,5.89/6.51V,500m
1
SA
...4
0403-001783
DIODE-ZENER;BZB84-C6V2,5.8/6.6V,300mW,SO
6
SNA
...4
D0254
0404-001404
DIODE-SCHOTTKY;BAT721C,40V,200mA,SOT-23,
2
SA
...4
T0139
0406-001200
DIODE-TVS;RCLAMP0504F,6/-/-V,150W,SC-70
1
SA
...4
T0139
0406-001271
DIODE-TVS;RCLAMP0524P,6/-/-V,150W,SLP251
2
SNA
...4
SD3
0407-000114
DIODE-SWITCHING;KDS184,80V,100mA,SOT-23,
1
SNA
...4
Q101
0501-000445
TR-SMALL SIGNAL;KTC3875S-Y,NPN,150mW,SOT
8
SA
...4
CEQ2
0505-000110
FET-SILICON;2N7002,N,60V,115mA,7.5ohm,0.
6
SA
...4
Q409
0505-002560
FET-SILICON;AO6415,P,-20V,-3.3A,0.15ohm,
1
SA
4
Copyright© 1995-2011 SAMSUNG. All rights reserved.
Exploded Views and Parts List
Level
Loc.
Part Code
Description & Specification
Qty.
SA/SNA
...4
IC112
1103-001310
IC-EEPROM;24LC02B,256X8BIT,SOIC,8P,3.91X
2
SNA
...4
1103-001487
IC-EEPROM;AT24C256C-SSHL-T,256Kbit,32Kx8
1
SA
...4
1105-002127
IC-DDR2 SDRAM;K4T51163QI-HCE7,512Mbit,32
1
SA
...4
T0085
1201-002849
IC-AUDIO AMP;DRV603,TSSOP,14P,5x4.4mm,DU
1
SA
...4
T0124
1201-002993
IC-POWER AMP;TAS5715,HTQFP,48P,7x7mm,DUA
1
SA
1203-004364
IC-VOL. DETECTOR;RT9818C-42PV,SOT-23,3P,
1
SA
...4
...4
T0087
1203-006135
IC-POSI.FIXED REG.;AP1117D-33-GZ-13-89,T
1
SA
...4
IC012
1203-006138
IC-POSI.ADJUST REG.;AP1117DGZ-13-89,TO-2
1
SA
1203-006142
IC-DC/DC CONVERTER;BD8924G,5P,2.9x1.6x1.
1
SA
1203-006239
IC-POSI.ADJUST REG.;AP1117EGZ-13-89,SOT-
2
SA
...4
1203-006619
IC-DC/DC CONVERTER;AOZ1033AI,SO-8,8P,4.9
1
SA
...4
1204-003249
IC-DECODER;SEMS04-LF,LQFP,256P,28x28mm,P
1
SA
...4
1205-003201
IC-BUS SWITCH;TC7WB125FK,SSOP,8P,2x2.3mm
4
SA
...4
1205-003479
IC-SWITCH;TPS2051BDBVR,SOT-23,5P,2.9x1.6
1
SA
...4
1405-001185
VARISTOR;24Vdc,1.6x0.8x0.36mm,TP
1
SA
...4
1405-001233
VARISTOR;30Vdc,5A,1.6x0.8x0.8mm,TP
6
SA
...4
1405-001271
VARISTOR;20Vdc,5A,1.0x0.5x0.6mm,TP
8
SA
...4
...4
IC012
...4
DR1
2007-000043
R-CHIP;1Kohm,1%,1/10W,TP,1608
2
SA
...4
PR4
2007-000052
R-CHIP;10Kohm,1%,1/10W,TP,1608
2
SA
...4
MROP1 2007-000090
R-CHIP;10Kohm,5%,1/10W,TP,1608
1
SA
...4
ZPR3
2007-000106
R-CHIP;220Kohm,5%,1/10W,TP,1608
1
SA
...4
R105
2007-000138
R-CHIP;100ohm,5%,1/16W,TP,1005
32
SA
...4
AR49
2007-000140
R-CHIP;1Kohm,5%,1/16W,TP,1005
2
SNA
...4
MR306 2007-000141
R-CHIP;2.2Kohm,5%,1/16W,TP,1005
4
SNA
...4
R319
2007-000143
R-CHIP;4.7Kohm,5%,1/16W,TP,1005
12
SNA
...4
R104
2007-000148
R-CHIP;10Kohm,5%,1/16W,TP,1005
31
SA
...4
HDR2
2007-000151
R-CHIP;15Kohm,5%,1/16W,TP,1005
4
SNA
...4
MR36
2007-000153
R-CHIP;22Kohm,5%,1/16W,TP,1005
6
SNA
...4
AR43
2007-000155
R-CHIP;27Kohm,5%,1/16W,TP,1005
1
SNA
...4
RZ07
2007-000156
R-CHIP;30Kohm,5%,1/16W,TP,1005
4
SA
...4
MR13
2007-000157
R-CHIP;47Kohm,5%,1/16W,TP,1005
1
SNA
...4
R509
2007-000170
R-CHIP;1Mohm,5%,1/16W,TP,1005
1
SNA
...4
R111
2007-000171
R-CHIP;0ohm,5%,1/16W,TP,1005
18
SNA
...4
HDR17 2007-000172
R-CHIP;10ohm,5%,1/16W,TP,1005
4
SNA
...4
R338
2007-000173
R-CHIP;22ohm,5%,1/16W,TP,1005
12
SNA
...4
UR23
2007-000174
R-CHIP;47ohm,5%,1/16W,TP,1005
6
SNA
...4
MR39
2007-000242
R-CHIP;1.5Kohm,5%,1/16W,TP,1005
1
SNA
...4
PPR2
2007-000343
R-CHIP;120ohm,1%,1/10W,TP,1608
1
SA
...4
KR7
2007-000402
R-CHIP;150ohm,5%,1/10W,TP,1608
1
SA
...4
MR9
2007-000455
R-CHIP;18Kohm,1%,1/10W,TP,1608
1
SA
Copyright© 1995-2011 SAMSUNG. All rights reserved.
5
Exploded Views and Parts List
Level
Loc.
Part Code
Description & Specification
Qty.
SA/SNA
...4
FR6
2007-000536
R-CHIP;200ohm,1%,1/10W,TP,1608
1
SA
...4
R38
2007-000640
R-CHIP;270ohm,1%,1/10W,TP,1608
1
SA
...4
S0F0522 2007-000691
R-CHIP;3.3Mohm,5%,1/10W,TP,1608
1
SA
...4
2007-000736
R-CHIP;30Kohm,1%,1/10W,TP,1608
1
SA
...4
R19
2007-000763
R-CHIP;330ohm,1%,1/10W,TP,1608
1
SNA
...4
DR37
2007-000932
R-CHIP;470ohm,5%,1/16W,TP,1005
6
SNA
...4
R3505
2007-000950
R-CHIP;47ohm,5%,1/4W,TP,3216
3
SA
...4
AAR20 2007-001002
R-CHIP;510ohm,5%,1/10W,TP,1608
2
SNA
...4
2007-001168
R-CHIP;75ohm,5%,1/4W,TP,3216
1
SA
...4
2007-001237
R-CHIP;910ohm,1%,1/10W,TP,1608
1
SA
...4
2007-001285
R-CHIP;5.6ohm,5%,1/16W,TP,1005
2
SA
...4
OTR1
2007-001292
R-CHIP;33ohm,5%,1/16W,TP,1005
4
SNA
...4
R326
2007-001325
R-CHIP;3.3Kohm,5%,1/16W,TP,1005
3
SNA
2007-001329
R-CHIP;7.5Kohm,5%,1/16W,TP,1005
1
SNA
...4
...4
R1
2007-002425
R-CHIP;1ohm,5%,1/10W,TP,1608
7
SNA
...4
TR30
2007-007009
R-CHIP;75ohm,5%,1/16W,TP,1005
7
SNA
...4
R365
2007-007107
R-CHIP;100Kohm,1%,1/16W,TP,1005
5
SNA
2007-007136
R-CHIP;4.7Kohm,1%,1/16W,TP,1005
1
SNA
2007-007142
R-CHIP;10Kohm,1%,1/16W,TP,1005
3
SNA
...4
2007-007297
R-CHIP;110ohm,1%,1/10W,TP,1608
1
SA
...4
2007-007318
R-CHIP;1Kohm,1%,1/16W,TP,1005
2
SNA
...4
2007-007319
R-CHIP;390ohm,1%,1/16W,TP,1005
1
SNA
2007-007721
R-CHIP;560ohm,1%,1/10W,TP,1608
1
SA
...4
...4
DR4
...4
R8
...4
DAR09 2011-001262
R-NETWORK;22ohm,5%,1/16W,L,CHIP,8P,TP,2.
9
SA
...4
2011-001264
R-NETWORK;10ohm,5%,1/16W,L,CHIP,8P,TP,2.
2
SNA
2011-001344
R-NETWORK;100ohm,5%,1/16W,L,CHIP,8P,TP,2
8
SA
2011-001345
R-NETWORK;10Kohm,5%,1/16W,L,CHIP,8P,TP,2
4
SA
...4
HRP2
...4
...4
AC1
2203-000125
C-CER,CHIP;1.2nF,10%,50V,X7R,TP,1608,-
4
SA
...4
PC43
2203-000233
C-CER,CHIP;0.1nF,5%,50V,C0G,TP,1005
5
SA
...4
C258
2203-000236
C-CER,CHIP;0.1nF,5%,50V,C0G,TP,1608
2
SA
...4
DC54
2203-000278
C-CER,CHIP;0.01nF,0.5pF,50V,C0G,TP,1005
2
SA
...4
C254
2203-000438
C-CER,CHIP;1nF,10%,50V,X7R,TP,1005
6
SA
...4
C507
2203-000489
C-CER,CHIP;2.2nF,10%,50V,X7R,TP,1005
6
SA
...4
V1233
2203-000575
C-CER,CHIP;220nF,10%,25V,X7R,TP,2012
6
SNA
...4
MC9
2203-000627
C-CER,CHIP;0.022nF,5%,50V,C0G,TP,1005
2
SNA
...4
DC25
2203-000812
C-CER,CHIP;0.033nF,5%,50V,C0G,TP,1005
3
SA
...4
AD480 2203-000995
C-CER,CHIP;0.047nF,5%,50V,C0G,TP,1005
3
SA
...4
AD480 2203-001412
C-CER,CHIP;0.03nF,5%,50V,NP0,1005
2
SNA
...4
AD480 2203-001428
C-CER,CHIP;470nF,10%,50V,X7R,TP,2012
2
SNA
...4
AD480 2203-002285
C-CER,CHIP;10nF,10%,50V,X7R,TP,1005
4
SNA
6
Copyright© 1995-2011 SAMSUNG. All rights reserved.
Exploded Views and Parts List
Level
Loc.
Part Code
...4
AD480 2203-002525
C-CER,CHIP;0.56nF,10%,50V,X7R,TP,1005
4
SNA
...4
AAC1
C-CER,CHIP;100nF,10%,50V,X7R,TP,1608
10
SNA
...4
AD480 2203-005968
C-CER,CHIP;4.7nF,10%,50V,X7R,TP,1005,0.5
3
SNA
...4
AD480 2203-006126
C-CER,CHIP;47nF,10%,16V,X7R,TP,1005
17
SNA
...4
C102
C-CER,CHIP;100nF,10%,16V,X7R,TP,1005,0.5
70
SNA
...4
AD480 2203-006336
C-CER,CHIP;10000nF,10%,25V,X5R,TP,3216
3
SA
...4
C802
2203-006348
C-CER,CHIP;1000nF,10%,25V,X5R,TP,1608
2
SA
...4
C125
2203-006361
C-CER,CHIP;10000nF,10%,10V,X5R,TP,2012
19
SC
...4
C234
2203-006378
C-CER,CHIP;4700nF,10%,6.3V,X5R,TP,1608
5
SA
...4
AD480 2203-006460
C-CER,CHIP;2200nF,10%,16V,X5R,TP,1608,-
1
SA
...4
PC23
C-CER,CHIP;22000nF,10%,10V,X5R,-,3225,-
1
SA
...4
HDC11 2203-006562
C-CER,CHIP;1000nF,10%,10V,X5R,TP,1005
7
SNA
...4
AD480 2203-006698
C-CER,CHIP;1000nF,10%,25V,X7R,1608
2
SNA
...4
AD480 2203-006992
C-CER,CHIP;0.33nF,5%,50V,C0G,TP,1005
2
SNA
...4
AD480 2203-007176
C-CER,CHIP;10000nF,10%,16V,X5R,TP,2012
10
SNA
...4
AD480 2203-007513
C-CER,CHIP;10000nF,10%,10V,X5R,TP,1608
5
SA
...4
T0052
2703-000158
INDUCTOR-SMD;1uH,10%,2012
4
SA
...4
VL6
2703-000398
INDUCTOR-SMD;10uH,10%,3225
2
SA
...4
T0052
2703-001778
INDUCTOR-SMD;3.3uH,20%,3225
1
SA
...4
T0052
2703-003149
INDUCTOR-SMD;2.2uH,20%,5050
1
SA
...4
2703-003890
INDUCTOR-SMD;47uH,10%,3225
1
SA
...4
2703-003930
INDUCTOR-SMD;4.7uH,20%,5050
4
SA
2203-005249
2203-006158
2203-006560
Description & Specification
Qty.
SA/SNA
...4
X202
2801-003773
CRYSTAL-SMD;12MHz,30ppm,28-AAN,20pF,50oh
1
SA
...4
F103
2901-001506
FILTER-EMI SMD;5V,0.13A,0pF,2x1x0.5mm,TP
2
SA
...4
DR32
3301-000314
BEAD-SMD;120ohm,1.6x0.8x0.8mm,-,-,-
2
SNA
...4
T0568
3301-001082
BEAD-SMD;60ohm,3225,TP,43ohm/40MHz,83ohm
1
SNA
...4
T0568
3301-001236
BEAD-SMD;60ohm,1608
3
SNA
...4
T0568
3301-001404
BEAD-SMD;30ohm,2012,TP,15.9OHM/30MHz,-
...4
T0568
3301-002039
...4
16
SA
BEAD-SMD;26ohm,1608,TP
9
SA
3701-001591
CONNECTOR-HDMI;19P,2ROW,FEMALE,SMD-S,AU
1
SA
...4
3701-001746
CONNECTOR-DSUB;15P,3ROW,FEMALE,STARAIGHT
1
SNA
...4
AC510 3708-001150
CONNECTOR-FPC/FFC/PIC;30P,1mm,SMD-A,SN,Y
1
SA
...4
EH01
3711-007582
HEADER-BOARD TO CABLE;BOX,8P,1R,2.0mm,AN
1
SA
...4
3711-007585
CONNECTOR-HEADER;BOX,4P,1R,2.5mm,ANGLE-D
1
SA
...4
3711-007741
CONNECTOR-HEADER;BOX,14P,2R,2.0mm,ANGLE,
1
SNA
...4
3722-003213
JACK-PIN;J/B 5P + Screw hole,NI+SN,BLK,S
1
SA
...4
3722-003225
JACK-USB;4P/1C,Au,BLK,SMD-A(DIP),A
1
SNA
...4
3722-003226
JACK-PHONE;7P/1C,SN,BLK
2
SNA
BN40-00142C
TUNER;HTM-8B/23B5S,HTM-8B/23B5S,PAL B/G,
1
SA
BN41-01628A
PCB MAIN;D400_LOLA4,FR-4,4,A,1.2,192x122
1
SNA
...4
...4
ET01
Copyright© 1995-2011 SAMSUNG. All rights reserved.
7
Exploded Views and Parts List
Level
Loc.
...4
Part Code
Description & Specification
Qty.
SA/SNA
BN97-05259B
ASSY MICOM;T-LL4MEAMH
1
SNA
....5
IC115
1107-001777
IC-FLASH MEMORY;MX25L6405DMI-12G,64Mbit,
1
SNA
..3
T0066
BP62-00017A
HEAT SINK-ES;SP-50L2HX,A6063S,T2.0,26.2,
1
SNA
1
ACCE1 BN92-07543F
ASSY ACCESSORY;LA32D400E1XXZ
1
SNA
.2
ACCE4 BN96-16912A
ASSY ACCESSORY-MANUAL;LA32D400E1XXZ
1
SNA
6902-000476
BAG PE;LDPE,T0.03,W250,L350,TRP,Recycle,
1
SNA
AA68-03184A
LEAFLET-CARD-09;ALL MODEL,CHINESE,212,29
1
SNA
..3
AA68-03184C
LEAFLET-SERVICE CARD;comm,Samsung,SC,CHI
1
SNA
..3
BN68-03402G
MANUAL USERS-IB;Comm,Samsung,SC,Asia_Rea
1
SNA
.2
ACCE2 BN96-16912P
ASSY ACCESSORY-CABLE;LA32D400E1XXZ
1
SNA
..3
T0268
3903-000604
CBF-POWER CORD;DT,CHINA,LSG-21L,250V,2.5
1
SNA
6902-001340
BAG PE;LDPE,T0.05,W250,L350,TRP,RECYCLE
1
SNA
REMOCON;TM940,39,3V,CHINA,400R
1
SA
BATTERY;BM1L,BATTERY,MN,600mAh,7.9g
2
SNA
..3
..3
T0059
..3
..3
REMO2 AA59-00517A
..3
BN43-00004A
..3
M9889 BN63-01798B
CLOTH-CLEAN;cloth,180,200,sea blue,ToC
1
SNA
..3
T0527
BN68-00513A
LABEL-E,PASS;ALL MODEL,YUPO(110G),50X15,
1
SNA
BN92-07544E
ASSY LABEL;LA32D400E1XXZ
1
SNA
BN68-01176A
LABEL RATING;W/W,SS,PET POLYESTER,T0.05,
1
SNA
1
BN92-08006D
ASSY BOX;LD400,32,CHINA(Ready)
1
SNA
.2
BH68-00662A
LABEL BOX-00;ALL MODEL,MOJO 90G,60,110,W
1
SNA
.2
BN68-03352B
LABEL-STICKER;LA32D400E1R,CHINA,ART PAPE
1
SNA
.2
BN69-05963E
BOX-SET;32LD400,CB,A-01,SW2,YEL,W988,D14
1
SNA
1
BN92-08378B
ASSY P/MATERIAL-P/M;LA32D460E1TXXZ
1
SNA
.2
6902-000061
BAG AIR;LDPE,T0.2,W500,L1000,TRP,370.000
1
SNA
.2
6902-000379
BAG AIR;LDPE,T0.2,W1000,L1800,TRP,1260.0
1
SNA
6902-000519
BAG PE;HDPE/NITRON,T0.015/T0.5(DOUBLE),W
1
SNA
.2
6902-000604
BAG WRAPPING;LDPE,T0.02,W500,L10000,TRP,
4222
SNA
.2
6902-000609
BAG ROLL;LDPE,T0.05,W2400,L1000,TRP,30.0
0
SNA
.2
6902-001178
BAG SHEET;HDPE/NITRON,T0.015/T01.0,W400,
1
SNA
6922-000013
BAND PP;PP,W18,L2300/L2900,TRP
1
SNA
.2
BH69-40303L
PACKING PALLET-00;COMM,WOOD,1020,994,120
1
SNA
.2
BN69-00391Q
PAD-ANGLE;PAPER,T4,50,1800,YEL
1
SNA
.2
BN69-05634A
CUSHION-SET;32LD400/450,EPS,MOLD REAR
1
SNA
.2
BN74-00008D
TAPE-OPP MASKING;OPP,T0.05,W75,L800M,CLR
2
SNA
1
.2
.2
.2
8
CCM1
T0524
M040
Copyright© 1995-2011 SAMSUNG. All rights reserved.
! "#
56
$% &'( )*+,-.
$% /0,-. 1234 789$ :; $% &'( /0
)*+9-. <=>
? ?@A 12BCDE FGHIJ KL MN $ O
!"#
%&' PQ
< (-.R& ST
#$ ()*+,- ./0 123 UC
VC
"#
56
WXYZ
[\](,^*_'
`
$a' %
bcKd=>
? @AB C B
DAE % & '()*
O
X
+,-
!"#$ Y
,-.
/.0 !"#$ :"(; <=>: PQ
< (-.R& ST
123456789 UC
VC
n
!ef ! "#
o
Kef
"#
56
WXYZ
[\](,^*_'
`
gN0 $a' %
bcKd=>
? @AB FAE % & '()* O
Z
!!!"#"#$
%&'('
+,-
! !!" !"#$ Y
,./.0 !"#$ PQ
:"(; <=>: < (-.R& ST
123456789 UC
p
!ef$%&$%#
o
Kef
"#
56
WXYZ
[\](,^*_'
'" `
' $a' %
bcKd=>
? @AB FAE ) % & ) '()*
) O
*+,- '#" # +,- !. //. !"#$ Y
,-.
/.0 :"(; <=>: PQ
< (-.R& ST
!"#$ 123456789 UC
o
Kef
"#
56
O
WXYZ
[\](,^*_'
h " `
$a' %
q
bcKd=>
? @AB FAE % &'()*
%'
0
+,- .0 !"#$ Y
,-./.0 !"#$ :"(; <=>:
PQ
123456789 < (-.R& ST
UC
VC
q
"
Kef!("#
o
Kef
"#
56
WXYZ
[\](,^*_'
ij`
$a' %
bcKd=>
4 '/5 6%78 9()%&
():;< =():;#$
!"#"#>? O
@A/5<BC
$%&'
r
&'&'(
()$
:;DE ))*+, )*+
Y
DFDE ()
&#
() #$ ()"# GHIJKLMNO
123 PQ
< (-.R& ST
UC
VC
r
)*+&%,klmn# - mop#
o
Kef
"#
56
WXYZ
[\](,^*_'
$qW00r $WXsCi9ct. qW0:; ()<=()PQ#$"#
>?
-.
R /'
#
GH% 1
D,-GH.0 O
! !"#$ 2/
.
+,- / !"#$ s
+,-GH.0 "GHJK; IG;#$ PQ
< (-.R& ST
123456789 UC
VC
s
qW0
Kef
uZ omvwxyz<{|%}~€
1‚ƒ
7„l
…†a‡ˆ‰Š ‹ŒŽ‘’“”• . z5Y–—˜™š / ›œž Ÿ ¡¢0£K¤efbc‹x&¥ž $¦!n§ef%
f£¨0©ª«8 9b‹n§e
0 yb¬x­®¯°±²(nŽLa³´µ¶( 1 $x2·2DE% 9b
2 ¼½¾¿ÀÁI ‹ŒÃÄÅL0
STH¸<MN¹ºFG%»?
!"#$%
!"#$%
7ÆÇ!
bÈ?@ÉÊÈ?ËÌÍ
34
)5
78Î-ÏËÌ0
Ð2 eÑ ÒÓ
ÔX &'!"%
&'!"%
‹ŒÕÖËÌ
‹ŒÕÖËÌ
Ð2בؼÙ2ÚÛ ÈÜÉÊÈ?ËÌÈÝ Ð2eÑÒÓÔXbÞ2 . 2×Ç!­ßàÚÛ =bcz5áâãä6å%æ / È?ÈÝçK×èéê­èé0ë 78Ç!ßàÚÛìí îï(ðŠñaŠñ 0 òóô ßàÚÛ^* DE
7 7ºÇ!­õƒ-ÏÚÛ Ç!­-ÏÚÛ
- ö÷øùúû „ü 4 ÈÍ ! 6868686
77 õýÒÓ „ü
1 <ßàÚÛëÈÝþ.
ÒÓ
ÿCÒÓ^* ö÷­ÒÓ
Íc d uö÷núûA
Íe f úA~ `
u
!
­12 Ç
#$(
#$(
úA
†
Ì
)*+,)*+ ,-
,
)*+ )*+./
)*+ ./
./
.†
l
mö
mö
mö
l
m
m
m
†€D
!"?#
bÞ<-ÏÚÛ?€m . †
$¼€%aê%& !'( ÞST< " ij a ÚÛ?€
!"- . <)*‘Ø?˜ØÚÛ+,%
.A&^*\/0a1'( ‘’ 6
.¼n
2 99201:; ††
y$3‘’«84«8¯ 5b‹Œ67‘’
‘Ø8ô%æ 16 i9
†€a:÷‘Ø
:/ 1ƌ:; :÷€ 26+ :/ 1ƌ:; :÷€ 26+ " :/ 1ƌ:; :÷€ 78< ÚÛ?;< €=n>43 ÚÛ??‰ †:÷€
€@n
€1
<.#
† „
l „ 95AQ# <6=& #
0123
0123 ¦!BCDGEü >" F÷0­x¯CGC >" ¥H( Ç!-ÏÚÛ .úûÌaIúA /ÅM >" Eü,JDE 0ÐK×Jx 1&C )*+LMNO 278Eü;< xLMP÷J÷ 45
45
STU
VW
XSTU
Y;
STU
XSTU
6789
6789
QR
QR S TU
TU
UC
UC
VC
VC
V fW0
W0
W0
;?
XY
XY
"//66/.1 ;%"
V fW0
W0
W0
?
XY
XY
"//66/.2 %"
V fW0
W0
W0
1?
XY
XY
"//66/.@ 1.=%",
V fW0
W0
W0
.?
XY
XY
"//66/.@ 1.=%"
5. Wiring Diagram
5. Wiring Diagram
5-1. Wiring Diagram
„„ 26"/32"
CN1001_26
CN7001_HD
Main Board
CN4007 CN2005
SPEAKER
Function & IR
TCON
SMPS
Panel
Inverter
SPEAKER
5-1
5. Wiring Diagram
„„ 19"/22"
Function & IR
SMPS
SPEAKER
TCON
CN1002_22
19” : CN7001_HD
22” : CN1603_FHD
Main
i Board
B
d
CN4007 CN2005
SPEAKER
5-2
5. Wiring Diagram
5-2. Connector
„„ 26"/32"
POWER IN (option by inch)
LVDS OUT (option by inch)
19"/22" (CN1001_22)
22" (CN1603_FHD)
1
PWM_DIMMING
6
A5V
1
Panel_VCC
16
EVEN[1]-
2
A13V
7
A5V
2
Panel_VCC
17
GND
3
GND
8
A18V or NC
3
Panel_VCC
18
EVEN[0]+
4
GND
9
SW_INVERTER
4
NC
19
EVEN[0]-
5
GND
5
NC
20
ODD[3]+
6
NC
21
ODD[3]-
26"/32" (CN1001_26)
1
B5V
8
GND
7
GND
22
ODDCLK+
2
SW_POWER
9
B12VS
8
EVEN[3]+
23
ODDCLK-
3
B5V
10
SW_INVERTER
9
EVEN[3]-
24
GND
4
A5V
11
B13V
10
EVENCLK+
25
ODD[2]+
5
GND
12
NC
11
EVENCLK-
26
ODD[2]-
6
GND
13
B13V
12
EVEN[2]+
27
ODD[1]+
7
B12VS
14
PWM_DIMMING
13
EVEN[2]-
28
ODD[1]-
14
GND
29
ODD[0]+
15
EVEN[1]+
30
ODD[0]-
LVDS OUT (option by inch)
19"/26"/32" (CN7001_HD)
FUNCTION (CN4007)
1
Panel_VCC
16
ODDCLK+
2
Panel_VCC
17
ODDCLK-
1
IR
5
GND
3
Panel_VCC
18
GND
2
GND
6
KEY_IN1
4
Panel_VCC
19
ODD[2]+
3
3.3V
7
KEY_IN2
5
Panel_VCC
20
ODD[2]-
4
GND
8
LED_STB
6
GND
21
GND
7
GND
22
ODD[1]+
8
GND
23
ODD[1]-
9
TCON_WP
24
GND
10
FORMAT
25
ODD[0]+
11
NC
26
ODD[0]-
12
GND
27
GND
13
ODD[3]+
28
SDA_TCON
14
ODD[3]-
29
SCL_TCON
15
GND
30
NC
SPEAKER (CN2005)
1
R+
3
L+
2
R-
4
L-
PC (CN401)
1
PC_RED
9
PC_5V
2
PC_GREEN
10
IDENT_PC
3
PC_BLUE
11
R_FANET
4
T_FANET
12
DSDA
5
GND
13
PC_HS
6
GND
14
PC_VS
7
GND
15
DSCL
8
GND
1
GND
5
NC
2
PC_SR_IN
6
NC
3
PC_SL_IN
7
NC
4
NC
PC/DIV SOUND (CN450)
USB (CN801~802)
1
5V
3
USB_DP
2
USB_DM
4
GND
5-3
5. Wiring Diagram
HEADPHONE/MONITOR OUT (CN2001)
1
GND
5
NC
2
HP_R
6
GND
3
HP_L
7
IDENT_HP
4
GND
HDMI (CN501/CN550)
1
RX2+
11
GND
2
GND
12
RXCLK-
3
RX2-
13
HDMI_CEC
4
RX1+
14
NC
5
GND
15
SCL
6
RX1-
16
SDA
7
RX0+
17
GND
8
GND
18
5V / IDENT
9
RX0-
19
HPD
10
RXCLK+
COMPONENT/AV (CN601)
1
GND
9
COMP_PR
2
COMP_Y/AV_CVBS
10
GND
3
IDENT_AV
11
SL_IN
4
GND
12
SR_IN
5
COMP_PB
13
GND
6
IDENT_COMP
14
SR_IN
7
GND
15
SL_IN
8
COMP_PR
1
RF_AGC
9
NC
2
5V
10
SIF
3
GND
11
SCL
4
33V
12
SDA
5
GND
13
NC
6
NC
14
NC
7
NC
15
NC
8
CVBS
TUNER (BN40-00142C)
5-4
NC
5. Wiring Diagram
5-3. Connector Functions
Connector
Functions
Main IP (14p)
Supply main power and dimming signal from IP board to Main Board.
Main T-CON (30p LVDS)
The LVDS signal transfered from Main Board to Panel .
IP Panel (12p)
Supply power from IP board to Driver Board.
5-4. Cables
Use
LEAD (Main-IP 14P)
LEAD (IP-Driver B'D 12P)
Code
D400 26 : BN39-01449E (125mm)
D400 32" : BN39-01449A (200mm)
D400 26/32" : BN39-01448A (70mm)
Photo
Use
Code
LVDS (Main - TCON)
D400 26" : BN96-12469D
D400 32" : BN96-13227A
D400 19" : BN96-12453D
D400 22" : BN96-12447M
Photo
5-5