Drive Medical sport rider Owner`s manual

US
UK
DE
Drive Medical Design & Manufacturing, NY 11050
Drive Medical Ltd, HX5 9JP
Drive Medical GmbH & Co. KG, D-88316 Isny
Part No. SR001
www.drivemedical.co.uk
The team at Drive Medical develops its products to give our customers the freedom to live
independently. This encompasses their daily home life and provides them with the
opportunity to enjoy an outing with family and friends. Our goal is to develop a range that
will provide individuals with a chance to enjoy every day life..
sport rider
owner’s handbook
SPORT RIDER OWNER’S HANDBOOK
1.
PREFACE AND INTRODUCTION
2.
SAFETY NOTICE
3.
PARTS INTRODUCTION
4.
OPERATION
5.
BATTERY CHARGING AND CARE
6.
INSPECTION AND MAINTENANCE
7.
TROUBLE SHOOTING
8.
SPECIFICATION
9.
WARRANTY
1. PREFACE AND INTRODUCTION
Please carefully read this owner’s handbook before using the scooter. Improper use of the scooter
could result in harm, injury or traffic accidents. Therefore for maximum pleasure while using the
scooter please read this owner’s manual.
♦
This owner’s manual includes operation instructions for every aspect of the scooter, assembly
instructions, as well as instructions for how to deal with possible accidents.
♦
The symbols used in this manual are explained below:
Read especially the notes marked with these symbols:
1
)
Warning
Improper usage could result in serious injury or death.
Attention
Improper usage could lead to injury and/or damage to your scooter.
Suggestion
Follow these instructions to keep your scooter in a good operating order.
Sport Rider Owner’s Handbook
Part Code SR001 (Page 1)
♦
This manual includes a copy of repair and maintenance record chart and warranty information.
Please keep it in a safe place or in the scooter.
♦
If someone else uses the scooter, please make sure that you provide them with the instruction
manual for his or her consideration.
♦
As designs change some illustrations and pictures in the manual may not correspond to the
scooter that you purchased. We reserve the right to make design modifications.
Our scooters have been designed and manufactured to provide a comfortable and secure yet
affordable solution for some mobility requirements.
Suggestion
To maximize your battery efficiency and life span, please fully recharge your new
battery before using.
2. SAFETY NOTICE
2.1 BEFORE DRIVING
The user needs to be familiar with the usage and operation of this scooter before driving. Therefore,
please always keep the following safety notices in mind.
■ The same traffic rules apply to the use of this scooter as apply to pedestrians
For your safety, please follow the rules that apply to pedestrians.
♦
Please do not drive your scooter after consuming alcohol or when you are tired.
♦
Please be careful when driving your scooter in low light. It has not been designed for use at
night.
♦
Do not remove any safety parts like Anti-tip devices, bumpers, or Emergency Brake lever.
■ Practice operating your scooter
Before using the scooter in busy or potentially dangerous areas, familiarize yourself with the
operation of your scooter. Please practice in a wide and open area like a park. In order to avoid
accidents with your scooter while driving, please bare in mind driving motions, such as
accelerating, stopping, turning, reversing, and travelling on gradients.
♦
Drive slowly (place indoor / outdoor switch in to the ‘indoor’ position) until you get used to the
scooter.
♦
Watch carefully for pedestrians and drive your scooter accordingly. On public footpaths and
in crowded areas always drive with the scooter switched to ‘Indoor’ speed.
♦
Drive only where permitted according to all applicable local laws and ordinances.
♦
Be sure someone accompanies you for safety when driving on the roads for the first time.
Sport Rider Owner’s Handbook
Part Code SR001 (Page 2)
♦
The higher ‘Outdoor’ speed setting can only be used on highways or on private land. Using
the Outdoor speed setting on a public footpath is an offence.
■ The scooter is designed and built to carry a single occupant only.
♦ Never operate it with an additional person on board, not even a child.
■ Do not use this scooter to carry or haul goods
♦ Do not exceed the maximum weight limit of 180kg (28 stone).
2.2 WHILE DRIVING
■ Please carry out daily inspections. Refer to the section entitled “DAILY CHECKING”
■ Do not move your body out of the scooter while moving
♦
Pay attention that your clothes do not tangle in the wheels.
♦
Such action may cause you to lose balance and risk injury from falling.
■ It is advised that you do not use your scooter under the circumstances below.
♦
On roads with heavy traffic or roads that are muddy, gravelled, bumpy, narrow, snowed over,
icy, or canal towpaths not guarded by any fence or hedge. Keep away from places where you
might get the wheels stuck.
♦
Do not drive when it is snowing, misty, or windy.
♦
Do not drive your scooter in an “S” pattern or make erratic turnings.
♦
Never use the scooter for climbing up or riding down stairs.
■ About Mobile Phones and other electrical equipment
♦ Do not use a mobile phone or other wireless communication devices while driving.
♦ Always switch off the scooter and remove the ignition key before using a mobile phone.
♦ Do not charge the mobile phone or any other electrical devices from your scooter’s battery.
■ Automatic Power Shut Down
In order to avoid accidental battery run down, your scooter is equipped with an automatic power
shut down facility. If the scooter is switched on, after remaining undisturbed for a period of thirty
minutes it will automatically turn off. Should this occur, simply switch your scooter off and back on
and it will be ready to use once again.
Sport Rider Owner’s Handbook
Part Code SR001 (Page 3)
■ Ramps, inclines and drops
♦ Do not drive onto steep ramps greater than 10º.
♦ Always use a low speed setting when ascending or descending a gradient.
♦ Do not drive on roads with large drops or potholes.
♦ Do not cross water gutters where the width is too big and where is a risk of getting the
wheels struck.
♦ Please slow down when driving on roads with inclines.
♦ Do not make sudden turns when driving on gravel roads or ramps.
♦ Always lean forward when climbing a steep gradient.
■ Starting and Driving
1. Make sure the seat is installed properly.
2. Make sure the tiller has been secured properly.
3. Fold down the armrests so you can rest your arms on them.
4. Turn the power switch to “ON”. If necessary, turn on the headlights.
5. Check battery indicator to see whether there is enough power for your journey. If you have any
doubt about the remaining power, please recharge the batteries before departure.
6. Set the speed dial to a position you feel safe and comfortable with.
7. Check the forward/reverse speed lever works correctly.
8. Make sure the electromagnetic brake works correctly.
Warning
♦
♦
♦
1
♦
♦
♦
Sport Rider Owner’s Handbook
Do not set in the freewheel mode when driving on a gradient.
Do not change the speed selector position while driving.
Do not turn the key switch to “OFF” position while in motion; this is may cause
abrupt and excessive deceleration which in turn may cause injury to the user and
damage to the scooter.
Always re-engage the Freewheel device before use. Failure to do so may result in
injury.
To protect your safety, the power will automatically cut off and electromagnetic
brake system will activate while you are driving down a steep gradient. This will
limit the speed to a safe level. Turn the power on again to re-start your scooter.
Maximum User Weight Limit – 180kg (28 stone)
Overloading past the weight limit may lead to damage of your scooter or cause it
to malfunction and will endanger your safety. The warranty does not cover this
type of damage.
Part Code SR001 (Page 4)
Attention
1.
2.
)
3.
4.
5.
6.
Do not set to the Outdoor speed setting while driving indoors.
Do not place magnetic devices near the area of the operation handle as this could
affect the safe operation of your scooter.
Do be careful while driving in heavy traffic or crowded areas.
While reversing the scooter, beware of people or objects behind you.
Do not release the manual release lever of electromagnetic brake when the scooter
is on the slope.
If for any reason the scooter does not stop when you release the operating lever ,
immediately use the hand brake to the stop the scooter and turn the key switch to
“OFF”.
■ Stopping
1. Release the speed control lever completely. The scooter will naturally brake and stop.
2. Turn the power switch to (OFF). Then pull out the key.
2.3 LABELING
Please carefully read all labels on the scooter before driving it. For your future reference, do not
remove them.
2.4 EMI
1.
Scooters may be susceptible to electromagnetic interference (EMI) from sources such as
mobile phones, walkie-talkies, TV and radio broadcast stations and amateur radio sets. In
some cases, there is a risk this interference may cause involuntary movement of the scooter.
The scooter has been tested and passed to withstand interference to a level of 20V per metre.
2. Be aware that the above sources may cause involuntary movement due to EMI. Exercise
caution whilst using the aforementioned devices and avoid close proximity to TV and Radio
broadcast stations.
3. The addition of components or accessories may affect the EMI susceptibility of the scooter. Do
not fit accessories other than Drive Medical authorised accessories.
Note: Other types of hand-held devices, such as cordless phones, laptop computers, AM/FM
radios, TV sets, CD player, and cassette players, and small appliances, such as electric shavers
and hair dryers, so far as we know, are not likely to cause EMI problems to your powered
scooter.
Sport Rider Owner’s Handbook
Part Code SR001 (Page 5)
3. PARTS INTRODUCTION
HAND BRAKE
LEVER
SEAT BACK
THROTTLE
LEVER
ARM REST
HEAD LAMP
FRONT
INDICATOR
RECLINE
LEVER
SEAT LEVER
REAR MUD
GUARD
FRONT MUD
GUARD
FREEWHEEL
LEVER
FOOT WELL
REAR
INDICATOR
REAR LIGHT
REAR
REFLECTOR
Sport Rider Owner’s Handbook
Part Code SR001 (Page 6)
4. OPERATION
4.1 TILLER POD LAYOUT
1.
2.
3.
4.
5.
6.
7.
Indicator Stalk
Head Light Button
Horn Button
Indoor / Outdoor Switch
Forward / Reverse Selector
Hazard Button
Power Switch
1
4
6
7
5
3
2
4.2 INSTRUMENT PANEL (FUNCTION)
1
1. Speedometer (bar graph)
2. Speedometer (numerical)
3. Functions Display
4. Indicator Display LED
5. MODE button
2
3
4
4
6
5
6. RESET button
MODE BUTTON
1. Press the MODE button to
move from on function to
another.
2. The display will alternate
between speed and trip
distance every 10 seconds
unless the button is pressed.
RESET BUTTON
Hold in the RESET button to reset
the values stored to zero. Please
note the odometer (ODO) will not
reset.
Sport Rider Owner’s Handbook
Part Code SR001 (Page 7)
FUNCTIONS EXPLAINED
BAR SPD: This shows the current speed (bar graph)
SPD: This shows the current speed (as a numerical value)
MAX: This shows the maximum speed achieved since the panel was last reset.
TRIP: Shows the distance travelled since the since the panel was last reset.
ODO: Shows the distance travelled by the scooter in total (cannot be reset)
RT: Shows the time the scooter has been ridden for since the last reset.
4.2 INSTRUMENT PANEL (VOLTAGE)
1.
Voltmeter (bar graph)
2.
Voltmeter (numerical)
3.
Time and other function Display
4.
Fault indicator LED
5.
Headlight LED
6.
MODE button
7.
RESET button
1
3
2
4
5
7
6
TO SET THE TIME:
1. Press both the MODE and RESET button simultaneously to enter the time setting mode.
2. Press the MODE button to cycle through the AM/PM, hours, minutes and seconds function
3. Press the RESET button to alter the time settings.
4. Press the RESET button for 2 seconds to set the time and exit the setting mode.
4.3 HOW TO OPERATE THE SCOOTER
Key Ignition:
To start the scooter, insert the key and turn the key 90º away from you.
To switch off the scooter, turn the key 90º towards you and remove the key. The key can only be
removed once the scooter has been switched off.
Operating the Throttle
The throttle lever is located on the right side of the handlebars. Squeeze the lever to operate. The
more that you squeeze the lever, the faster the scooter will travel. Release the lever and the scooter
will automatically stop.
Sport Rider Owner’s Handbook
Part Code SR001 (Page 8)
Forward and Reverse
Press the side of the button marked “F” to allow forward travel. The scooter will only travel when the
throttle lever is operated. Press the side of the button marked “R” to allow reserving. An alerting
alarm will sound automatically when the scooter is reversing.
Emergency Braking
An emergency cable brake is fitted to the scooter. To use the emergency brake, squeeze the brake
lever on the left hand side of the handlebar.
Parking Brakes
As default, the electromagnetic brake is used as a parking brake when the scooter is switched off
and the key removed.
1
Warning
The freewheel lever should always be set to “DRIVE” when the scooter is in use or
parked. Failure to engage the freewheel lever could result in damage and/or injury.
Indicators (Signalling)
Before turning, press the indicator stalk (located on left hand side of the handlebar) in the required
direction of travel. The indicator lights will flash and beep, and the relevant indicator LED on the
instrument panel will light. To switch off the indicator, push the stalk to the centre position.
Horn
Press the Horn button to sound the horn. Release the button to stop the horn.
Lights
Press the Head Light button on the left hand side of the handlebar to switch the lights on and off.
Hazard Warning
Press the Hazard Warning button to switch the function on and off. When switched on, all the lights
will flash to alert passers-by of the hazard.
Seat
There are two seat adjustment levers located underneath the front right hand corner of the seat.
Push the protruding lever to swivel the seat. The seat can swivel 360º, and locks in position in 45º
intervals. Push the smaller lever to allow the seat to move backwards and forwards.
The seat can also recline. Press the Recline lever by the rear left hand corner of the seat to change
the angle of the backrest.
1
Warning
Always ensure the seat is locked in the forward position before operating the scooter.
Sport Rider Owner’s Handbook
Part Code SR001 (Page 9)
Armrest Width
To adjust the width of the armrests; firstly loosen the knobs at the back of the seat frame. Then adjust
the armrest width by sliding the armrest to the required width. Finish by tightening the knobs and
checking that the armrests are secured in position.
Freewheel Lever
Drive mode.
Pull the lever back to engage DRIVE mode.
Freewheel mode.
Push the lever forward to engage FREEWHEEL mode.
Warning
1
Never operate the freewheel lever whilst on a gradient or seated on the scooter.
The freewheel lever should always be left in DRIVE unless the scooter is being moved
manually.
Main Circuit Breaker (Reset Buttons)
When the voltage in your scooter’s batteries becomes
low or the scooter is heavily strained because of
excessive loads or steep inclines, the main circuit
breaker may trip to protect the motor and electronics
from damage. The location of the circuit breaker is
shown by the arrow on the photograph right
Sport Rider Owner’s Handbook
Part Code SR001 (Page 10)
5. BATTERY CHARGING AND CARE
5.1
CHARGING THE BATTERY
Follow the procedure below step by step:
1.
Switch the scooter off at the ignition
2. Connect the charger’s power cord into the
mains socket.
3. Open the charging socket located on the left
hand side of the instrument panel. Connect the
round plug on the charger to the open socket.
4. Switch on the charger.
5. Both the charger’s lights will be lit during
operation. When bulk charging is complete the
orange light will turn green.
6. For optimum battery performance we recommend that the batteries are charged for 10 hours.
We do not recommend that the batteries are charged for less than 6 hours or more than 24 hours
as this can cause damage or shorten the lifespan of the batteries.
7. After charging, switch off the charger and the mains socket then remove the charger from the
socket and the scooter.
Suggestion
1.
2.
3.
4.
5.
6.
Sport Rider Owner’s Handbook
Do not disconnect the charger cord if charging is not completed. The battery
life will be seriously shortened or decayed if the battery is repeatedly used
without being fully charged. Therefore be sure to charge the battery fully every
time.
Always complete the charging until the orange LED light turns green. NEVER
stop charging before it is complete.
When fully charged, the battery charger will still trickle charge the battery to
ensure optimum range.
If you do not use your scooter for a long time, it should be charged at least every
week to keep the battery in a fully usable condition.
Charging time will be affected by the ambient temperature. Charging time will
be longer in the winter.
After charging, do not leave the charger socket plugged in to the scooter, as
this will cause a power drain on the scooter and temporarily reduce its range.
The batteries carry a one year manufacturer's warranty. This warranty only
covers issues relating to manufacturing faults, and not faults relating to failure
to recharge the batteries as instructed above.
Part Code SR001 (Page 11)
Attention
1.
2.
)
3.
4.
5.
6.
Always recharge the battery to its full capacity.
Only use the charger supplied with the scooter. You could damage the battery
and scooter if the incorrect charger is used. Do not disassemble or modify the
charger.
Charge in a well-ventilated space where it is not exposed to sunlight, humidity
or moisture.
Do not cover the scooter whilst charging.
Keep away from flammable objects while charging as this may lead to fire or
explosion.
Never connect or disconnect the plug or cord with wet hands or in wet
conditions as this could result in electric shock.
The scooter is immobilized whilst the charger is plugged in to the scooter.
Both the chargers red and orange lights will be illuminated during charging. The orange light will turn
green when charging completed. If only the red light is lit during charging then there is a problem
with the scooter and/or charger. In this instance contact the outlet from where the scooter was
purchased.
Warning
1
The charger light is lit orange the internal fan on the charger should operate. If the fan
has not started to operate after 2 minutes, unplug and remove the charger and contact
your dealer. Charging the battery with the fan operating can result in overheating and
fire.
5.2 ABOUT THE BATTERIES
•
Do not expose or charge the batteries in temperatures below -10ºC or above 50ºC. Extreme
temperatures can cause the battery to freeze, overheat, or shorten the battery lifespan.
•
The batteries are sealed and there is no need to monitor or replenish water levels.
•
The batteries do require charging on a regular basis, even if the scooter is not in use. The
batteries should be charged at least once a week, irrespective of use.
•
The batteries should be replaced when the battery range is about half the range of when the
batteries were new. Please contact dealer for more information about changing the batteries.
•
The batteries should be cleaned periodically, usually when the scooter is serviced. We
recommend this is done by your dealer who may charge a fee for this. If the battery terminals
are covered in water, battery acid, dust or other substances they will discharge quickly. Ensure
the scooter is switched off and the batteries are disconnected before cleaning. Use clean cloth
to wipe the soiled area. If the terminal is covered by a white powder, use a little warm water a
clean cloth.
1
Warning
Do not open the battery case, as this can cause damage or injury.
Sport Rider Owner’s Handbook
Part Code SR001 (Page 12)
6. INSPECTION AND MAINTENANCE
Suggestion
1.
2.
3.
4.
5.
AND
If necessary, ask for help from your dealer for advice about maintaining and
replacing the battery.
Make sure the terminals are installed properly and put the cover back on.
Do not use the battery to charge telecom equipment or other items.
Battery efficiency will vary with outside conditions; the driving distances will be
shorter in the winter. If the scooter is not used for a long time, please charge the
battery at least every week.
Replace both batteries together.
CARE
INSPECTION
INSPECTION
Check following items before driving:
Item
Inspection Content
Handlebar
♦ Is there any looseness?
♦ Can it turn left and right smoothly?
Speed Lever
♦ Does the scooter move when the lever pressed down?
♦ Does the scooter stop when the lever is released completely?
Motor
♦ Are there an abnormal noise coming from the motor?
♦ Do the electromagnetic brakes work properly?
Freewheel Mode
♦ Does the freewheel mode lever work properly?
Battery Indicator
♦ Is the light on when the power is switched on?
♦ Is the remaining power enough for your trip?
Horn
♦ Does the horn work?
Seat
♦ Can the seat swivel smoothly?
Reflector
♦ Is the reflector present and correct?
Tyres
♦ Are there any cracks or other damage to the tires?
♦ Check the tyre tread depth.
Other
♦ Are there any abnormal noises?
♦ Is there oil leakage from transmission box?
)
Attention
Consult your dealer should you find anything wrong during the tests above.
Sport Rider Owner’s Handbook
Part Code SR001 (Page 13)
REGULAR CHECKING RECORD
To make sure your scooter is correctly serviced, take it to your dealer for regular maintenance checks.
This should be at intervals of six months after the first inspection after one month. Your dealer may
charge a fee for this service. A copy of the service record is located at the back of this handbook.
FUSES
• If the battery charger is turned on and no lights are lit, check the fuse in the plug and the charger.
TYRES
Please check the tread depth regularly. Replace the tires when the tread depth is less than 0.5 mm.
Attention
)
When tread depth is below 0.5mm it can easily lead to scooter slippage, making braking
distances longer. Therefore replace the tires as early as possible when they do not have
insufficient tread depth.
The tyre pressure shall be kept at about 26 PSI (approx. 1.8KG/cm) for the best ride and
handling.
Attention
•
)
•
•
Switch off the scooter at the ignition and remove any power cords before conducting
any maintenance on your scooter.
Do not hose down or splash water on to your scooter to clean as this can damage the
scooter.
Do not use wax, petrol, solvents or vaporizing solutions as these can damage the
body shrouds.
STORING THE SCOOTER
Store the scooter in a location away from direct sunlight or moisture. Store with the scooter switched
off, the key removed and the seat in the forward position. If the scooter is being stored for a long
time, disconnect the batteries. Ask your dealer for advice on how to do this.
MANUALLY MOVING THE SCOOTER
Before manually moving the scooter, switch it off at the key ignition.
The scooter is very heavy so if possible put the scooter in to freewheel mode and push the scooter.
If you do need to lift the scooter, lift by the chassis and not the bumpers as this can cause damage or
injury. You will need at least 3 people to lift the scooter.
Sport Rider Owner’s Handbook
Part Code SR001 (Page 14)
7. TROUBLESHOOTING
You can inspect the following before taking you scooter to the dealer.
Symptom
Remedy
•
•
The scooter switches on, but the •
scooter will not move.
•
The scooter will not switch on
•
•
The seat turns when in operation •
The handlebar appears loose
•
The scooter appears slow
•
•
•
•
Involuntarily horn sounds
Try recharging the battery
Check the fuse and circuit breaker in the scooter
Ensure there is enough power in the batteries. If not,
recharge the batteries.
Ensure the freewheel lever is engaged in the ‘DRIVE’
position.
Check the battery power level and recharge
Check the speed dial is not set to slow.
Slowly rotate the seat until it drops in to place and is secure
Tighten the height adjustment handle to secure the
handlebar
Ensure that the wigwag paddle is released.
Switch the scooter off and on.
Recharge the batteries.
If problem persists contact your dealer.
If the above does not resolve the problem or the problem keeps occurring, contact your dealer.
8. SPECIFICATION
Model
SR001BLK
Battery
100ah 12V x 2
Dimensions
165cm x 78cm x 112cm
Controller
160A Dynamic Rhino
(L x W x H)
65” x 31” x 44”
Front Tyre
2.75-14 x 1
Weight
100kg (220lb)
Rear Tyre
2.75-14 x 1
Turning Radius
157cm (62”)
Drive System
Rear wheel direct drive
Max. Angle
10º
Primary Braking
Electromagnetic
Cruising Range
31 miles (50km)
Secondary Braking Cable brake
Weight Limit
180kg (400lb)
Control method
Throttle lever
Max Speed
8mph (12.9km)
Motor (4-pole)
1300W 4300rpm (1.75hp)
The manufacturer reserves the right to modify the specification if necessary. The final
specification is subject to the individual scooter you purchase from your dealer.
Note:
Maximum driving distance is based on an ambient temperature of 20°C, a 100kg driver and a brand
new fully charged battery by a constant driving speed at 6 km/h with 70% battery power discharged.
Sport Rider Owner’s Handbook
Part Code SR001 (Page 15)
3.
VIN NUMBER
To ensure the correct after sales service and warranty
service support, please write down the scooter serial
number. The serial number is located on the back
right-hand side of the frame.
VIN Number
Note:
Controller S/No.
Telephone
WARRANTY
There is a comprehensive twelve-month warranty from
the date on which your new scooter is delivered. The
warranty covers the scooter for repairs or replacement
during this period. For more detail, please see the
Warranty Conditions below.
Warranty Conditions:
1.
Any work or replacement part installation must be
carried out by an authorized Drive Medical dealer
/ service agent.
2.
To apply the warranty should your scooter require
attention please contact the designated service
agent listed above.
others):
6.
The above warranty conditions apply to brand new
scooter purchased at the full retail price. If you are
unsure whether your scooter is covered, check with
the service agent.
7.
Under normal circumstances, no responsibility will
be accepted where the scooter has failed as a
direct result of:
Address
Postcode
Consumable items supplied will not generally be
covered during the normal warranty period unless
such items require repair or replacement clearly as
a direct result of a manufacturing or material
defect.
Such
items
include
(among
upholstery, tyres and batteries.
Also, note your Drive Medical dealer below:
Dealer
This guarantee is not transferable
4. Any repaired or replaced parts will be covered by
this warranty for the balance of the warranty
period on the scooter.
5.
Motor S/No.
Should any part of the scooter require repair or full
or part replacement, as a result of a manufacturing
or material defect within twelve months of
receiving the scooter, replacement parts will be
supplied free of charge.
a) The scooter or part not having been
maintained in accordance with the
manufacturer’s recommendations.
b) Failure to use the manufacturer’s specified
parts
c) The scooter or part having been damaged due
to neglect, accident or improper use
d) The scooter or part having been altered from
the manufacturer’s specifications or repairs
having been attempted before the service
agent is notified
Please note your local service agent’s contact details
in the previous box. In the event of your scooter
requiring attention, contact them and give all relevant
details so they can act quickly.
The manufacturer reserves the right to alter without
notice any weights, measurements or other technical
data shown in this manual. All figures, measurements
and capacities shown in this manual are approximate
and do not constitute specifications.
Sport Rider Owner’s Handbook
Part Code SR001 (Page 16)
APPENDIX: SERVICE RECORD
YEAR
1
2
3
4
5
YEAR
Service Dates
Service Dates
Controller
Upholstery
On/off switch
Seat
Control Lever
Back
Braking
Armrests
Recharge point
Electrics
Batteries
Connections
condition
Capacities
Lights
Connections
Test run
Discharge test
Forwards
Wheels
Tyres
Reverse
and
Wear
Emergency stop
Pressure
Left turn
Bearings
Right turn
Wheel nuts
Slope test
Motors
Over obstacles
Wiring
List Items repaired
1
2
3
4
5
Noise
Connections
Brake
Brushes
Chassis
Condition
Steering
Sport Rider Owner’s Handbook
Part Code SR001 (Page 17)
C
Sport Rider Owner’s Handbook
Part Code SR001 (Page 18)