Electrolux E23CS75DSS1 Troubleshooting guide

Product Information
and Technical Guide
Side by Side and Top Mount Refrigerators
January 2004 - March 2004
®
®
5995413308
White-Westinghouse
®
July 2004
TABLE OF CONTENTS
Safe Servicing Practices ------------------------------------------------------------------------------------------ 2
Service Data Sheet, Refrigerant Charge & Energy Efficiency Rating Indexes ------------------- 3 - 7
Troubleshooting Guide --------------------------------------------------------------------------------------------- 8- 12
Appendix A - Service Data Sheets
240379007 --------------------------------------------------------------------------------------------------------- A1 - A2
240379011 --------------------------------------------------------------------------------------------------------- A3 - A4
240379012 --------------------------------------------------------------------------------------------------------- A5 - A6
240379013 --------------------------------------------------------------------------------------------------------- A7 - A8
240379014 --------------------------------------------------------------------------------------------------------- A9 - A10
240379015 --------------------------------------------------------------------------------------------------------- A11 - A12
241588200 --------------------------------------------------------------------------------------------------------- A13 - A14
240389613 --------------------------------------------------------------------------------------------------------- A15 - A16
240389615 --------------------------------------------------------------------------------------------------------- A17 - A18
240389016 --------------------------------------------------------------------------------------------------------- A19 - A20
240389618 --------------------------------------------------------------------------------------------------------- A21- A22
241532603 --------------------------------------------------------------------------------------------------------- A23 - 24
1
SAFE SERVICING PRACTICES - ALL APPLIANCES
To avoid personal injury and/or property damage, it is important that Safe Servicing
Practices be observed. The following are some limited examples of safe practices:
1. DO NOT attempt a product repair if you have any doubts as to your ability to
complete it in a safe and satisfactory manner.
2. Before servicing or moving an appliance:
• Remove the power cord from the electrical outlet, trip the circuit breaker to the
OFF position, or remove the fuse.
• Turn off the gas supply.
• Turn off the water supply.
3. Never interfere with the proper operation of any safety device.
4. USE ONLY REPLACEMENT PARTS CATALOGED FOR THIS APPLIANCE.
SUBSTITUTIONS MAY DEFEAT COMPLIANCE WITH SAFETY
STANDARDS SET FOR HOME APPLIANCES.
5. GROUNDING: The standard color coding for safety ground wires is GREEN, or
GREEN with YELLOW STRIPES. Ground leads are not to be used as current
carrying conductors. It is EXTREMELY important that the service technician
reestablish all safety grounds prior to completion of service. Failure to do so will
create a hazard.
6. Prior to returning the product to service, ensure that:
• All electrical connections are correct and secure
• All electrical leads are properly dressed and secured away from sharp edges,
high-temperature components, and moving parts
• All non-insulated electrical terminals, connectors, heaters, etc. are adequately
spaced away from all metal parts and panels
• All safety grounds (both internal and external) are correctly and securely
connected
• All panels are properly and securely reassembled
ATTENTION!!!
This service manual is intended for use by persons having electrical and mechnical
training and a level of knowledge of these subjects generally considered acceptable in the
appliance repair trade. Electrolux Home Products, Inc. cannot be responsible, nor assume
any liability, for injury or damage of any kind arising from the use of this manual.
© 2004 Electrolux Home Products, Inc.
2
Model
CRTE151AQ1
CRTE151AW1
CRTE171AQ1
CRTE171AW1
CRTE183AQ0
CRTE183AW0
CRTE187AK0
CRTE187AS0
E23CS75DSS1
FRS23BH6CS2
FRS23F4CB5
FRS23F4CQ4
FRS23F4CQ5
FRS23F4CW4
FRS23F4CW5
FRS23FCDB0
FRS23FCDQ0
FRS23FCDW0
FRS23H5DSB0
FRS23H7CB2
FRS23H7CQ2
FRS23H7CW2
FRS23KF6CB2
FRS23KF6CQ2
FRS23LH5DS0
FRS23LH5DW0
FRS23R4CB4
FRS23R4CB5
FRS23R4CQ4
FRS23R4CQ5
FRS23R4CW4
FRS23R4CW5
FRS23W3AQB
FRS23W3AQC
FRS23W3AWB
FRS23W3AWC
FRS26BH6CW4
FRS26DR7DS0
FRS26F4CB2
FRS26F4CB3
FRS26F4CQ2
FRS26F4CQ3
FRS26F4CW2
FRS26F4CW3
FRS26FCDB0
FRS26FCDQ0
FRS26FCDW0
FRS26H7CQ4
FRS26H7CW4
FRS26HF6BB6
FRS26HF6BQ6
FRS26HR4DB0
FRS26HR4DQ0
FRS26HR4DW0
FRS26LF7DS0
FRS26LF8CB1
Service Data Sheet
240379011
240379011
240379011
240379011
240379011
240379011
240379013
240379013
241532603
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389618
240389615
240389615
240389615
240389615
240389615
240389616
240389616
240389615
240389616
240389615
240389616
240389615
240389616
240389615
240389616
240389615
240389616
240389615
240389618
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389615
240389615
240389615
240389615
240389616
240389616
240389616
240389616
240389615
Charge
4.5
4.5
4.5
4.5
4.25
4.25
4.25
4.25
5.75
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
3
Energy Efficiency Rating
Brand
443
Crosley
443
Crosley
460
Crosley
460
Crosley
479
Crosley
479
Crosley
479
Crosley
479
Crosley
687
Electrolux
583
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
583
Frigidaire
583
Frigidaire
583
Frigidaire
583
Frigidaire
583
Frigidaire
583
Frigidaire
583
Frigidaire
583
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
618
Frigidaire
618
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
618
Frigidaire
618
Frigidaire
618
Frigidaire
618
Frigidaire
618
Frigidaire
618
Frigidaire
618
Frigidaire
618
Frigidaire
618
Frigidaire
Model
FRS26LF8CQ1
FRS26LH5DB0
FRS26LH5DQ0
FRS26LH5DS0
FRS26LH5DW0
FRS26R2AQ7
FRS26R2AQ8
FRS26R2AW7
FRS26R2AW8
FRS26R4CB2
FRS26R4CB3
FRS26R4CQ3
FRS26R4CW2
FRS26R4CW3
FRS26RBCW2
FRS26RBCW3
FRS26RLECS1
FRS26RLECS2
FRS26W2AQ7
FRS26W2AW8
FRS26W2AW9
FRT14A2AW4
FRT14A2AZ4
FRT15A2DW0
FRT15A2DZ0
FRT15B1BW2
FRT15B3AQ5
FRT15B3AT5
FRT15B3AW5
FRT15B3AZ5
FRT15G4BQ3
FRT15G4BW3
FRT15HB3DQ0
FRT15HB3DW0
FRT15HB3DZ0
FRT17A2AQ4
FRT17A2AW4
FRT17A2AZ4
FRT17B3AQ5
FRT17B3AT5
FRT17B3AW5
FRT17B3AZ5
FRT17G4BD3
FRT17G4BQ3
FRT17G4BW3
FRT18B1BW4
FRT18B4AQA
FRT18B4AWA
FRT18B4AZA
FRT18B5ABB
FRT18B5AQB
FRT18B5AWB
FRT18B6CB7
FRT18G4AQC
FRT18G4AWC
FRT18G7CW4
Service Data Sheet
240389615
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389616
240389613
240389616
240389616
240379015
240379015
240379015
240379015
240379015
240379015
240379015
240379015
240379015
240379015
240379015
240379015
240379015
240379015
240379011
240379011
240379011
240379011
240379011
240379011
240379011
240379011
240379011
240379011
240379015
240379015
240379015
240379015
240379014
240379014
240379014
240379014
240379011
240379011
240379015
Charge
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
5.25
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.25
4.25
4.25
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.25
4.25
4.25
4.25
4.5
4.5
4.5
4
Energy Efficiency Rating
Brand
618
Frigidaire
618
Frigidaire
618
Frigidaire
618
Frigidaire
618
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
440
Frigidaire
440
Frigidaire
443
Frigidaire
443
Frigidaire
443
Frigidaire
443
Frigidaire
443
Frigidaire
443
Frigidaire
443
Frigidaire
443
Frigidaire
443
Frigidaire
376
Frigidaire
376
Frigidaire
376
Frigidaire
460
Frigidaire
460
Frigidaire
460
Frigidaire
460
Frigidaire
460
Frigidaire
460
Frigidaire
460
Frigidaire
460
Frigidaire
460
Frigidaire
460
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
Model
FRT18H6CB5
FRT18H6CQ5
FRT18H6CSB4
FRT18H6CSK4
FRT18H6CW5
FRT18HB5DW0
FRT18HS6AB5
FRT18HS6DB1
FRT18HS6DQ0
FRT18HS6DW0
FRT18IB4AQA
FRT18IB4AWA
FRT18IB4AZ8
FRT18IB4AZA
FRT18IG4AQA
FRT18IG4ATA
FRT18IG4AWA
FRT18IG4AZA
FRT18IL6DQ0
FRT18IL6DS0
FRT18IL6DW0
FRT18IS6CB1
FRT18KB2CW4
FRT18KG3CW4
FRT18KG4CW4
FRT18LN5BQ6
FRT18LN5BW6
FRT21BH8CB2
FRT21BH8CS2
FRT21BH8CW2
FRT21BSDSB0
FRT21C5AQ9
FRT21C5AW9
FRT21FG3CQ3
FRT21FG3CW3
FRT21FG4CQ3
FRT21FG4CW3
FRT21G3CW2
FRT21G3CW3
FRT21G4BQ7
FRT21G4BW7
FRT21H7ASB5
FRT21H7ASK4
FRT21H8CB2
FRT21H8CQ2
FRT21H8CSB2
FRT21H8CSK2
FRT21H8CW2
FRT21HS6AW6
FRT21HS6DB0
FRT21HS6DQ0
FRT21HS6DW0
FRT21IL5DQ0
FRT21IL5DW0
FRT21KG3CW3
FRT21KG4CW3
Service Data Sheet
240379014
240379014
240379015
240379015
240379014
240379015
240379014
240379014
240379015
240379015
240379015
240379015
240379011
240379015
240379015
240379015
240379015
240379015
240379015
240379015
240379015
240379007
240379015
240379015
240379015
240379015
240379015
240379014
240379014
240379014
241588200
240379014
240379014
240379014
240379014
240379014
240379014
240379012
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
Charge
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.25
4.25
4.25
4.25
4.5
4.5
4.5
4.5
4.5
4.25
4.25
4.25
4.5
4.5
4.5
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.5
4.5
4.25
4.25
4.5
4.5
4.5
4.25
4.25
4.25
4.25
5
Energy Efficiency Rating
Brand
407
Frigidaire
407
Frigidaire
407
Frigidaire
407
Frigidaire
407
Frigidaire
407
Frigidaire
407
Frigidaire
407
Frigidaire
407
Frigidaire
407
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
432
Frigidaire
432
Frigidaire
432
Frigidaire
432
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
432
Frigidaire
432
Frigidaire
432
Frigidaire
432
Frigidaire
432
Frigidaire
432
Frigidaire
432
Frigidaire
432
Frigidaire
432
Frigidaire
432
Frigidaire
432
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
Model
FRT21KS6CQ3
FRT21LR7AB9
FRT21LR7AQ9
FRT21LR7AW9
FRT21LR8DS0
FRT21P5ABA
FRT21P5AQA
FRT21P5AWA
FRT21P6CQ3
FRT21P6CSB3
FRT21P6CSK3
FRT21P6CW3
FRT21S6AB8
FRT21S6AW8
GLHS237ZCW2
GLHS269ZCB4
GLRS237ZCB4
GLRS237ZCB5
GLRS237ZCQ4
GLRS237ZCQ5
GLRS237ZCW4
GLRS237ZCW5
GLRS267ZCB2
GLRS267ZCB3
GLRS267ZCQ2
GLRS267ZCQ3
GLRS267ZCW2
GLRS267ZCW3
GLRT183TDB1
GLRT183TDB3
GLRT183TDQ0
GLRT183TDW0
GLRT184TCB7
GLRT185TDB1
GLRT185TDB3
GLRT185TDK0
GLRT185TDQ0
GLRT185TDS0
GLRT185TDW0
GLRT212IDB0
GLRT212IDB1
GLRT212IDQ0
GLRT212IDQ1
GLRT212IDW0
GLRT212IDW1
GLRT214TCB3
GLRT214TCQ3
GLRT214TCW3
GRS23R4CQ3
GS18HTZCQ2
GS18HTZCW2
GS18HTZDB1
GS18HTZDSB0
GS18HTZDSK0
GS18HTZDW0
GS23HSZCC3
Service Data Sheet
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240379014
240389016
240389015
240389015
240389016
240389015
240389016
240389015
240389016
240389616
240389616
240389616
240389616
240389616
240389616
240379013
240379014
240379015
240379015
240379014
240379012
240379014
240379015
240379015
240379015
240379015
240379012
240379014
240379012
240379014
240379012
240379014
240379014
240379014
240379014
240389613
240379011
240379011
240379014
240379015
240379015
240379015
240389615
Charge
4.5
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
5
5.25
5
5
5
5
5
5
5.25
5.25
5.25
5.25
5.25
5.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
4.25
5
4.25
4.25
4.25
4.25
4.25
4.25
5
6
Energy Efficiency Rating
Brand
509
Frigidaire
432
Frigidaire
432
Frigidaire
432
Frigidaire
458
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
583
Frigidaire
618
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
686
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
727
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
479
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
509
Frigidaire
686
Frigidaire
431
Frigidaire
431
Frigidaire
407
Frigidaire
407
Frigidaire
407
Frigidaire
407
Frigidaire
583
Frigidaire
Model
GS23HSZCQ2
GS26HSZCC5
GS26HSZCQ4
PLHT189CSB4
PLHT189CSK4
PLHT219TCB4
PLHT219TCK4
FSC23F7DB0
PHSC239DSB0
GRT15B3BW3
GRT17B3BQ3
GRT17B3BW3
GRT17G4BQ3
GRT17G4BW3
GRT21G3CW3
GRT21S6CW3
WRS23MF5ASA
WRS23MW3AQA
WRS23MW3AW9
WRS23MW3AWA
WRS23W0AWA
WRS23W0AWB
WRT15A0AW4
WRT15MB3AW4
WRT15MG4BQ1
WRT17MB3AW4
WRT17MG4BQ1
WRT18A0AWA
WRT21MG3AQ6
WRT21MG3AW6
WRT21MP5AQ7
WRT21MP5AW7
WRT21MR7AS6
WRT21S4AW6
Service Data Sheet
240389615
240389616
240389616
240379015
240379015
240379014
240379014
241532603
241532603
240379011
240379011
240379011
240379011
240379011
240379014
240379014
240389616
240389616
240389615
240389616
240389615
240389616
240379015
240379015
240379011
240379015
240379011
240379015
240379014
240379014
240379014
240379014
240379014
240379014
Charge
5
5
5
4.25
4.25
4.25
4.25
5.75
6
4.5
4.5
4.5
4.5
4.5
4.5
4.5
5
5
5
5
5
5
4.5
4.25
4.25
4.25
4.25
4.5
4.25
4.25
4.25
4.25
4.25
4.25
7
Energy Efficiency Rating
Brand
583
Frigidaire
583
Frigidaire
583
Frigidaire
407
Frigidaire
407
Frigidaire
432
Frigidaire
432
Frigidaire
687
Frigidaire-CD
584
Frigidaire-CD
443
Gibson
460
Gibson
460
Gibson
460
Gibson
460
Gibson
509
Gibson
509
Gibson
686
W/W
686
W/W
686
W/W
686
W/W
686
W/W
686
W/W
443
W/W
443
W/W
443
W/W
460
W/W
460
W/W
479
W/W
509
W/W
509
W/W
509
W/W
509
W/W
509
W/W
509
W/W
TROUBLESHOOTING
GUIDE
PROBLEM
Compressor will not run.
Compressor runs but does not cool.
CAUSE
No voltage at wall receptacle.
Check circuit breaker, fuse or GFCI
(Ground Fault Circuit Interruptor - It
is not recommended to connect
your refrigerator to a GFCI.)
Service cord defective or unplugged
at wall receptacle.
Check service cord.
Low voltage causing compressor to
cycle on overload.
Voltage fluctuation should not
exceed ± 10% of 115 vac (104-127)
Control thermostat knob in OFF
position.
Turn control thermostat knob to ON
position.
Inoperative control thermostat.
Replace control thermostat
Compressor stuck.
Replace compressor.
Compressor windings open.
Replace compressor.
Defrost timer stuck in defrost mode.
Replace defrost timer. (if equipped)
ADC (Adaptive Defrost Control) not
turning on compressor after defrost.
Replace ADC.
Compressor overload stuck open.
Replace compressor overload. (if
equipped – compressor starter relay
& overload may be plugged into
each other)
Relay lead loose.
Repair or replace lead.
Relay loose or inoperative.
Repair or replace relay. (if equipped)
Service cord pulled out of harness.
Repair connection.
Faulty cabinet wiring.
Repair wiring.
System out of refrigerant.
Check for leaks. *
Compressor not pumping.
Replace compressor. *
Restricted filter drier.
Replace filter drier. *
Restricted capillary tube.
Replace heat exchanger
evaporator assembly.
Moisture in system.
See NOTE. *
* NOTE:
•
•
•
•
•
SOLUTION
Repair or replace component that is leaking.
Replace the compressor if the system is contaminated.
Blow out remaining part of system with dry Nitrogen.
Pump down and recharge per listing on product serial label.
Always replace filter drier when repairing sealed system.
8
and
PROBLEM
Compressor short cycles.
Compressor runs too much.
Noisy.
*
CAUSE
SOLUTION
Erratic control thermostat.
Replace control thermostat.
Faulty relay.
Replace relay or starter.
Restricted air flow over condenser.
Ensure air flow is unobstructed over
condenser.
Low voltage … fluctuation exceeds ±
10% of 115 vac (104-127).
Call qualified electrician.
Compressor draws excessive watts.
Replace compressor.
Inoperative condenser fan motor.
Replace condenser fan motor.
Control thermostat is erratic or not
properly set.
Replace control thermostat or reset to
normal position.
Refrigerator exposed to high heat.
(110° or higher)
Move refrigerator to cooler location.
High room temperature.
(110° F or higher)
Advise customer not to install
refrigerator where temperature will rise
above 110°F because compressor will
not maintain proper temperatures.
Low pumping capacity compressor.
Replace compressor.
Door gaskets not sealing.
Adjust doors or replace door gaskets.
System undercharged.
Check for leaks. *
System overcharged.
Charge per listing on product serial
plate. *
Interior light stays on.
Check
door
adjustment.
Contaminants in system.
Flush out system. Replace filter drier,
evacuate, and recharge. *
Capillary tube kinked or partially
restricted.
Replace
heat
exchanger
evaporator assembly. *
Filter drier partially restricted.
Replace filter drier. *
Refrigerator
and/or
freezer
compartment overloaded … poor air
circulation
Advise customer.
Restricted air flow over condenser.
Ensure air flow is unobstructed over
condenser.
Condenser fan motor is inoperative.
(Forced air condenser models only)
Replace condenser fan motor.
Tubing vibrates.
Adjust tubing.
Internal compressor noise.
Replace compressor.
Loose parts.
Check shelving.
Compressor operating at high head
pressure due to restricted air flow
over condenser.
Ensure air flow is unobstructed over
condenser.
See NOTE at bottom of page 8)
9
switch
and
door
and
PROBLEM
Freezer compartment too warm.
Fig. A
Freezer compartment too cold.
*
CAUSE
SOLUTION
Inoperative evaporator fan motor.
Check wiring and evaporator fan motor.
(Check ADC on Side-by-Sides.)
Improperly positioned fan blade.
Position fan blade properly. See Figure
A.
Evaporated frosted up.
Check
defrost
system,
adjustments, and door gaskets.
Inoperative condenser fan motor.
(Forced air condenser models
only)
Replace condenser fan motor.
Restricted air flow over condenser
– On static condensers, be sure
you have 1” between condenser
and wall, and 3” over top, or 1
side of condenser is clear.
Clean
only.)
Freezer compartment overloaded
– poor air circulation.
Advise customer.
Low room temperature.(55°)
Advise
customer
not
to
install
refrigerator where temperature will drop
below 60°F. Compressor will not
maintain proper temperatures.
Freezer
or
refrigerator
compartment doors left open.
Advise customer.
Control
thermostat
calibration.
Replace control thermostat.
out
of
condenser.
(Dynamic
door
models
Door gaskets not sealing.
Adjust doors or replace door gaskets.
Control thermostat capillary tube
improperly positioned.
Reposition
element.
Shortage of refrigerant.
Check for leaks. *
Restricted filter drier or capillary
tube.
Check for leaks and burnt compressor
windings. *
Evaporator fan motor covered in
ice.
Check seal around ice maker fill spout.
Check seal between evaporator cover
and liner. (Side-by-sides only)
Inoperative cold control. (Top
mount-No Frost or Side-by-Side
freezer cold control)
Replace cold control.
Freezer compartment inlet air
duct is loose or restricted. Door is
loose.
Re-install air duct or remove obstruction
from inlet air duct. Adjust door.
Food compartment air return duct
blocked (Top Mount only)
If foam block is frozen, replace block. If
duct is blocked, remove obstruction.
Diffuser (foam block) in top of
food compartment is broken.
(Foam block located in control
housing.)
5
Replace diffuser. (Top Mount only)
Freezer compartment cold control
installed
incorrectly.
(Side-by-Sides
only)
See NOTE at bottom of page 8
10
temperature
sensing
PROBLEM
Refrigerator
warm.
compartment
too
Refrigerator compartment too cold.
*
CAUSE
SOLUTION
Inoperative evaporator fan motor.
Check wiring and evaporator fan motor.
(Check ADC on Side-by-Sides.)
Improperly positioned fan blade.
Position fan blade properly. See page
10, Figure A.
Evaporated frosted up.
Check
defrost
system,
adjustments, and door gaskets.
Refrigerator
compartment
overloaded – poor air circulation.
Advise customer.
Low room temperature. (55°)
Advise
customer
not
to
install
refrigerator where temperature will drop
below 60°F. Compressor will not
maintain proper temperatures.
Freezer
or
refrigerator
compartment doors left open.
Advise customer.
Damper control out of calibration
or not opening.
Replace damper control.
Shortage of refrigerant.
Check for leaks. *
Restricted filter drier or capillary
tube.
Check for leaks and burnt compressor
windings. *
Refrigerator compartment inlet air
duct loose or restricted. Door is
loose.
Re-install air duct or remove obstruction
from air duct. Adjust door.
Freezer compartment return air
duct restricted.
Remove obstruction from return air duct.
Control thermostat knob set at too
warm a position.
Set control knob to a colder position.
Inoperative
or
erratic
refrigerator/freezer compartment
door switch.
Replace door switch.
Freezer compartment inlet air
duct is loose or restricted. Door is
loose.
Re-install air duct or remove obstruction
from inlet air duct. Adjust door.
Food compartment air return duct
blocked (Top Mount only)
If foam block is frozen, replace block. If
duct is blocked, remove obstruction.
Inoperative cold control.
Replace cold control.
Refrigerator compartment inlet air
duct loose or restricted. Door is
loose.
Re-install air duct or remove obstruction
from air duct. Adjust door.
Diffuser (foam block) in top of
food compartment is broken.
(Foam blocked located in control
housing.)
Replace diffuser. (Top Mounts only)
See NOTE at bottom of page 8.
11
door
PROBLEM
Refrigerator compartment too cold.
(Continued)
CAUSE
SOLUTION
Inoperative cold control.
Replace cold control.
Refrigerator compartment inlet air
duct loose or restricted. Door is
loose.
Re-install air duct or remove obstruction
from air duct. Adjust door.
Diffuser (foam block) in top of
food compartment is broken.
(Foam blocked located in control
housing)
Replace diffuser. (Top Mounts only)
Door in damper control not
closing or not closing all the way.
Replace damper control.
Check freezer control bulb for correct
positioning to ensure it is installed
correctly.
Evaporator blocked with ice. (See
Adaptive defrost Control)
Frozen drain.
Adaptive Defrost Control (ADC) not
responding correctly.
Cold air blowing into food
compartment with damper door
closed all the way.
Check foam seal between damper
housing and cabinet liner. Check to see
that the control box is mounted flush
against the cabinet liner.
Inoperative defrost timer.
Check wiring. Repair or replace defrost
timer.
Defrost thermostat terminates too
early. Thermostat is open.
Check for correct positioning of defrost
thermostat. Repair or replace.
Refrigerator/Freezer compartment
doors left open.
Advise customer.
Open defrost heater.
Replace heater.
Air leak around ice maker fill tube,
or opening.
Seal with permagum.
Ice maker water line and wiring
harness openings not sealed.
Seal water line and wiring harness
openings.
Drain trough not properly formed.
Ensure drain trough is at 90° angle to
back of freezer and that lip is up on front
and ends.
Divider (foam block) frozen.
Replace divider. Check drain trough.
Faulty ADC board.
Replace ADC board.
Bad wire between ADC, defrost
heater, and limiter.
Check wiring and wiring connectors.
12
PERFORMANCE DATA
NO LOAD AND NO DOOR OPENINGS AT MID-POINT CONTROL SETTING
SERVICE DATA SHEET
65°F (18°C) Ambient
90°F (32°C) Ambient
25 to 35%
45 to 55%
2° to 8°F
-17° to -13°C
0° to 5°F
-18° to -15°C
Refrigerature Temperature
35° to 40°F
2° to 4°C
35° to 40°F
2° to 4°C
Low Side Pressure (cut-in)
8 to 16 psig
55 to 110 kPa
8 to 16 psig
55 to 110 kPa
Low Side Pressure (cut-out)
1 to 4 psig
7 to 28 kPa
1 to 4 psig
7 to 28 kPa
110 to 120 psig
758 to 827 kPa
150 to 175 psig
1034 to 1207 kPa
Wattage (Last 1/3 of cycle)
140 to 185
140 to 185
Amps (Running)
1.1 to 1.6
1.1 to 1.6
Base Voltage
115 VAC
115 VAC
Type A With Run Capacitor
Operating Time
Freezer Temperature
High Side Pressure (Last 1/3 of cycle)
The information provided herein is designed to assist qualified repair
personnel only. Untrained persons should not attempt to make
repairs due to the possibility of electrical shock. Disconnect power
cord before servicing.
IMPORTANT
If any green grounding wires are moved during servicing, they
must be returned to their original position and properly secured.
Heater
Cabinet Size
Cut-out
Watts
Ohms
18' & 21'
25°F
-4°C
47°F
8°C
375
35
14', 15' & 17'
25°F
-4°C
47°F
8°C
325
41
Mechanical Timer - Defrost 30 Minutes Ever y 10 Hours of Compressor Run Time
Electronic Timer (ADC) Defrost Up To 24 Minutes Ever y 6 - 72 Hours of Compressor Run Time
CONDENSER FAN MOTOR
Watts
RPM
Amps
2.3
1100 CW Opposite Shaft
.15 Running
ICE MAKER SPECIFICATIONS
115 Volts
60 Her tz
Opens at 48°F (9°C)
Closes at 15°F (-9°C)
165
ICE MAKER CONNECTOR PLUG CONNECTIONS
Wire Number
Wire Color
Connects to:
1
Green/Yellow
Ground
2
Yellow
Water Valve
3
Black
Line
4
Lt. Blue
Neutral
from torch flame. Do not allow torch to contact insulation; it
will char at 200°F and flash ignite (burn) at 500°F. Excessive
heat will distort the plastic liner.
NOTE: This product comes equipped with an Electronic
Defrost Control. To initiate defrost, depress the fresh food light
switch 5 times in 6 seconds (light bulb must be working). To
terminate defrost, depress the fresh food light switch 5 times
in 6 seconds.
Test Cycling
Remove cover by inserting screwdriver in notch at bottom and prying
cover from housing. Use screwdriver to rotate motor gear
counterclockwise until Holding Switch circuit is completed. All
components of ice maker should function to complete the cycle.
Water Fill Volume
The water fill adjustment
screw will change the fill
time. One full turn is
equal to 20cc (.68 oz.).
The correct fill is 95 to
105cc (3.2 to 3.6 oz.).
When a water valve is
replaced, the fill volume
must be checked.
A-1
Cut-in
Heater Wattage
240379007
CAUTION: All electrical parts and wiring must be shielded
Thermostat
Thermostat
P/N:
IMPORTANT SAFETY NOTICE
DEFROST SPECIFICATIONS
Electrical
STANDARD - AUTOMATIC
DEFROST TOP FREEZER
MODELS
(R134a)
ICE MAKER INFORMATION
Pictorial Schematic
Ladder Schematic
A-2
Compressor Wiring
PERFORMANCE DATA
NO LOAD AND NO DOOR OPENINGS AT MID-POINT CONTROL SETTING
Type A With Run Capacitor
SERVICE DATA SHEET
65°F (18°C) Ambient
90°F (32°C) Ambient
25 to 35%
45 to 55%
2° to 8°F
-17° to -13°C
0° to 5°F
-18° to -15°C
Refrigerature Temperature
35° to 40°F
2° to 4°C
35° to 40°F
2° to 4°C
Low Side Pressure (cut-in)
8 to 16 psig
55 to 110 kPa
8 to 16 psig
55 to 110 kPa
Low Side Pressure (cut-out)
1 to 4 psig
7 to 28 kPa
1 to 4 psig
7 to 28 kPa
110 to 120 psig
758 to 827 kPa
150 to 175 psig
1034 to 1207 kPa
Wattage (Last 1/3 of cycle)
140 to 185
140 to 185
Amps (Running)
1.1 to 1.6
1.1 to 1.6
115 VAC (127 VAC Max)
115 VAC (127 VAC Max)
Operating Time
Freezer Temperature
High Side Pressure (Last 1/3 of cycle)
Base Voltage
DEFROST SPECIFICATIONS
Thermostat
Heater
Cabinet Size
Cut-out
Watts
Ohms
18' & 21'
25°F
-4°C
47°F
8°C
375
35
14', 15' & 17'
25°F
-4°C
47°F
8°C
325
41
Mechanical Timer - Defrost 30 Minutes Every 10 Hours of Compressor Run Time
Electronic Timer (ADC) Defrost Up To 24 Minutes Every 6 - 72 Hours of Compressor Run Time
CONDENSER FAN MOTOR
Watts
RPM
Amps
2.3
1100 CW Opposite Shaft
.15 Running
Test Cycling
P/N: 240379011
IMPORTANT SAFETY NOTICE
The information provided herein is designed to assist qualified
repair personnel only. Untrained persons should not attempt to
make repairs due to the possibility of electrical shock. Disconnect
power cord before servicing.
IMPORTANT
If any green grounding wires are moved during servicing, they
must be returned to their original position and properly secured.
Remove cover by inserting screwdriver in notch at bottom
and prying cover from housing. Use screwdriver to rotate motor
gear counterclockwise until holding switch circuit is completed.
All components of ice maker should function to complete the
cycle.
Water Fill Volume
The water fill adjustment screw will change the fill time. One
full turn is equal to 20cc (.68 oz.). The correct fill is 102 to
130cc (3.4 to 4.3 oz.). When a water valve is replaced, the fill
volume must be checked.
CAUTION: All electrical parts and wiring must be shielded
from torch flame. Do not allow torch to contact insulation;
it will char at 200°F and flash ignite (burn) at 500°F. Excessive
heat will distort the plastic liner.
A-3
Cut-in
STANDARD - AUTOMATIC
DEFROST TOP FREEZER
MODELS
(R134a)
ICE MAKER INFORMATION
NOTE: This product comes equipped with an Electronic Defrost
Control. To initiate defrost, depress the fresh food light switch 5
times in 6 seconds (light bulb must be working). To terminate
defrost, depress the fresh food light switch 5 times in 6 seconds.
ICE MAKER SPECIFICATIONS
ICE MAKER
Heater Wattage
P-3
165
THERMAL
CUT-OUT
Yellow
Ground
Water Valve
3
Black
Line
4
Lt. Blue
Neutral
RED
HOLD
SWITCH
ICE MAKER
Connects to:
NC
C
YEL
NO
RED
THERMOSTAT
NO
BLU
BLK
C
GRN / YEL
2
Green/Yellow
MOTOR
MOLD HEATER
165 WATTS
P-4
NC
NO
SHUT-OFF
SWITCH
NC
LT. BLU
GRN / YEL
C
P-1
MOLD
MOUNTING
PLATE
WATER FILL
SWITCH
P-2
WATER VALVE
1
Wire Color
BLK
ICE MAKER CONNECTOR PLUG CONNECTIONS
Wire Number
ICE MAKER
BRN
BLK
YEL
Closes at 15°F (-9°C)
NEUTRAL
POWER
YEL
Opens at 48°F (9°C)
LINE
RED
60 Her tz
BLK
Thermostat
115 VAC (127 VAC Max)
ICE MAKER
Electrical
Pictorial Schematic
Ladder Schematic
A-4
NOTE:
_ _ _ _ _ _ DENOTES NOT ON ALL MODELS
COMPRESSOR WIRING
Induction Run Compressor with Relay
SERVICE PARTS
Compressor / Kit *
Starter/PTC *
Run Capacitor *
Relay
Overload
Temperature Control
Timer (if applicable)
ADC (if applicable)
Defrost Heater Kit
Defrost Thermostat Kit
Evaporator Fan Motor
Condenser Fan Motor
15 & 17 CUBIC FOOT
STATIC
DYNAMIC
E-STAR
5303918264 5303918264 5303918295
218721120
218721120
218721120
218909913
218909913
218909912
N/A
N/A
N/A
N/A
N/A
N/A
5304421256 5304421256 5304421256
215846606
215846606
215846606
N/A
N/A
N/A
5303918203 5303918203 5303918203
5303918202 5303918202 5303918202
240369701
240369701
240369701
N/A
240523601
240523601
STATIC
240435705
218721120
218909913
5304433579
5304433578
5304421256
215846606
N/A
5303918208
5303918202
240369701
N/A
18 CUBIC FOOT
DYNAMIC
E-STAR
240435705 5303918295
218721120
218721120
218909913
218909912
5304433579
N/A
5304433578
N/A
5304421256 5304421256
215846606
215846606
N/A
N/A
5303918208 5303918208
5303918202 5303918202
240369701
240369701
240523601
240523601
21 CUBIC FOOT
DYNAMIC
E-STAR
5303918264 5303918295
218721120 218721120
218909913 218909912
N/A
N/A
N/A
N/A
5304421256 5304421256
215846606 215846606
N/A
N/A
5303918247 5303918247
5303918202 5303918202
240369701 240369701
240334001 240334001
PERFORMANCE DATA
NO LOAD AND NO DOOR OPENINGS AT MID-POINT CONTROL SETTING
Type A With Run Capacitor
SERVICE DATA SHEET
65°F (18°C) Ambient
90°F (32°C) Ambient
25 to 35%
45 to 55%
2° to 8°F
-17° to -13°C
0° to 5°F
-18° to -15°C
Refrigerature Temperature
35° to 40°F
2° to 4°C
35° to 40°F
2° to 4°C
Low Side Pressure (cut-in)
8 to 16 psig
55 to 110 kPa
8 to 16 psig
55 to 110 kPa
Low Side Pressure (cut-out)
1 to 4 psig
7 to 28 kPa
1 to 4 psig
7 to 28 kPa
110 to 120 psig
758 to 827 kPa
150 to 175 psig
1034 to 1207 kPa
Wattage (Last 1/3 of cycle)
140 to 185
140 to 185
Amps (Running)
1.1 to 1.6
1.1 to 1.6
115 VAC (127 VAC Max)
115 VAC (127 VAC Max)
Operating Time
Freezer Temperature
High Side Pressure (Last 1/3 of cycle)
Base Voltage
DEFROST SPECIFICATIONS
Thermostat
Heater
Cabinet Size
Cut-out
Watts
Ohms
18' & 21'
25°F
-4°C
47°F
8°C
375
35
14', 15' & 17'
25°F
-4°C
47°F
8°C
325
41
Mechanical Timer - Defrost 30 Minutes Every 10 Hours of Compressor Run Time
Electronic Timer (ADC) Defrost Up To 24 Minutes Every 6 - 72 Hours of Compressor Run Time
CONDENSER FAN MOTOR
Watts
RPM
Amps
2.3
1100 CW Opposite Shaft
.15 Running
Test Cycling
P/N: 240379012
IMPORTANT SAFETY NOTICE
The information provided herein is designed to assist qualified
repair personnel only. Untrained persons should not attempt to
make repairs due to the possibility of electrical shock. Disconnect
power cord before servicing.
IMPORTANT
If any green grounding wires are moved during servicing, they
must be returned to their original position and properly secured.
Remove cover by inserting screwdriver in notch at bottom
and prying cover from housing. Use screwdriver to rotate motor
gear counterclockwise until holding switch circuit is completed.
All components of ice maker should function to complete the
cycle.
Water Fill Volume
The water fill adjustment screw will change the fill time. One
full turn is equal to 20cc (.68 oz.). The correct fill is 102 to
130cc (3.4 to 4.3 oz.). When a water valve is replaced, the fill
volume must be checked.
CAUTION: All electrical parts and wiring must be shielded
from torch flame. Do not allow torch to contact insulation;
it will char at 200°F and flash ignite (burn) at 500°F. Excessive
heat will distort the plastic liner.
A-5
Cut-in
STANDARD - AUTOMATIC
DEFROST TOP FREEZER
MODELS
(R134a)
ICE MAKER INFORMATION
NOTE: This product comes equipped with an Electronic Defrost
Control. To initiate defrost, depress the fresh food light switch 5
times in 6 seconds (light bulb must be working). To terminate
defrost, depress the fresh food light switch 5 times in 6 seconds.
ICE MAKER SPECIFICATIONS
ICE MAKER
Heater Wattage
P-3
165
THERMAL
CUT-OUT
Yellow
Ground
Water Valve
3
Black
Line
4
Lt. Blue
Neutral
RED
HOLD
SWITCH
ICE MAKER
Connects to:
NC
C
YEL
NO
RED
THERMOSTAT
NO
BLU
BLK
C
GRN / YEL
2
Green/Yellow
MOTOR
MOLD HEATER
165 WATTS
P-4
NC
NO
SHUT-OFF
SWITCH
NC
LT. BLU
GRN / YEL
C
P-1
MOLD
MOUNTING
PLATE
WATER FILL
SWITCH
P-2
WATER VALVE
1
Wire Color
BLK
ICE MAKER CONNECTOR PLUG CONNECTIONS
Wire Number
ICE MAKER
BRN
BLK
YEL
Closes at 15°F (-9°C)
NEUTRAL
POWER
YEL
Opens at 48°F (9°C)
LINE
RED
60 Her tz
BLK
Thermostat
115 VAC (127 VAC Max)
ICE MAKER
Electrical
Pictorial Schematic
Ladder Schematic
A-6
NOTE:
_ _ _ _ _ _ DENOTES NOT ON ALL MODELS
COMPRESSOR WIRING
Induction Run Compressor with Relay
SERVICE PARTS
Compressor / Kit *
Starter/PTC *
Run Capacitor *
Relay
Overload
Temperature Control
Timer (if applicable)
ADC (if applicable)
Defrost Heater Kit
Defrost Thermostat Kit
Evaporator Fan Motor
Condenser Fan Motor
15 & 17 CUBIC FOOT
STATIC
DYNAMIC
E-STAR
5303918264 5303918264 5303918295
218721120
218721120
218721120
218909913
218909913
218909912
N/A
N/A
N/A
N/A
N/A
N/A
5304421256 5304421256 5304421256
215846606
215846606
215846606
N/A
N/A
N/A
5303918203 5303918203 5303918203
5303918202 5303918202 5303918202
240369701
240369701
240369701
N/A
240523601
240523601
STATIC
5303918297
N/A
N/A
5304433579
5304433578
5304421256
215846606
N/A
5303918208
5303918202
240369701
N/A
* Typical compressor kit includes compressor, electrical components, and filter-drier
18 CUBIC FOOT
DYNAMIC
E-STAR
5303918297 5303918251
N/A
218721119
N/A
218909913
5304433579
N/A
5304433578
N/A
5304421256 5304421256
215846606
215846606
N/A
N/A
5303918208 5303918208
5303918202 5303918202
240369701
240369701
240523601
240523601
21 CUBIC FOOT
DYNAMIC
E-STAR
5303918297 5303918251
N/A
218721119
N/A
218909913
5304433579
N/A
5304433578
N/A
5304421256 5304421256
215846606
215846606
N/A
N/A
5303918247 5303918247
5303918202 5303918202
240369701
240369701
240334001
240334001
PERFORMANCE DATA
NO LOAD AND NO DOOR OPENINGS AT MID-POINT CONTROL SETTING
Type A With Run Capacitor
SERVICE DATA SHEET
65°F (18°C) Ambient
90°F (32°C) Ambient
25 to 35%
45 to 55%
2° to 8°F
-17° to -13°C
0° to 5°F
-18° to -15°C
Refrigerature Temperature
35° to 40°F
2° to 4°C
35° to 40°F
2° to 4°C
Low Side Pressure (cut-in)
8 to 16 psig
55 to 110 kPa
8 to 16 psig
55 to 110 kPa
Low Side Pressure (cut-out)
1 to 4 psig
7 to 28 kPa
1 to 4 psig
7 to 28 kPa
110 to 120 psig
758 to 827 kPa
150 to 175 psig
1034 to 1207 kPa
Wattage (Last 1/3 of cycle)
140 to 185
140 to 185
Amps (Running)
1.1 to 1.6
1.1 to 1.6
115 VAC (127 VAC Max)
115 VAC (127 VAC Max)
Operating Time
Freezer Temperature
High Side Pressure (Last 1/3 of cycle)
Base Voltage
DEFROST SPECIFICATIONS
Thermostat
Heater
Cabinet Size
Cut-out
Watts
Ohms
18' & 21'
25°F
-4°C
47°F
8°C
375
35
14', 15' & 17'
25°F
-4°C
47°F
8°C
325
41
Mechanical Timer - Defrost 30 Minutes Every 10 Hours of Compressor Run Time
Electronic Timer (ADC) Defrost Up To 24 Minutes Every 6 - 72 Hours of Compressor Run Time
CONDENSER FAN MOTOR
Watts
RPM
Amps
2.3
1100 CW Opposite Shaft
.15 Running
Test Cycling
P/N: 240379013
IMPORTANT SAFETY NOTICE
The information provided herein is designed to assist qualified
repair personnel only. Untrained persons should not attempt to
make repairs due to the possibility of electrical shock. Disconnect
power cord before servicing.
IMPORTANT
If any green grounding wires are moved during servicing, they
must be returned to their original position and properly secured.
Remove cover by inserting screwdriver in notch at bottom
and prying cover from housing. Use screwdriver to rotate motor
gear counterclockwise until holding switch circuit is completed.
All components of ice maker should function to complete the
cycle.
Water Fill Volume
The water fill adjustment screw will change the fill time. One
full turn is equal to 20cc (.68 oz.). The correct fill is 102 to
130cc (3.4 to 4.3 oz.). When a water valve is replaced, the fill
volume must be checked.
CAUTION: All electrical parts and wiring must be shielded
from torch flame. Do not allow torch to contact insulation;
it will char at 200°F and flash ignite (burn) at 500°F. Excessive
heat will distort the plastic liner.
A-7
Cut-in
STANDARD - AUTOMATIC
DEFROST TOP FREEZER
MODELS
(R134a)
ICE MAKER INFORMATION
NOTE: This product comes equipped with an Electronic Defrost
Control. To initiate defrost, depress the fresh food light switch 5
times in 6 seconds (light bulb must be working). To terminate
defrost, depress the fresh food light switch 5 times in 6 seconds.
ICE MAKER SPECIFICATIONS
ICE MAKER
Heater Wattage
P-3
165
THERMAL
CUT-OUT
Yellow
Ground
Water Valve
3
Black
Line
4
Lt. Blue
Neutral
RED
HOLD
SWITCH
ICE MAKER
Connects to:
NC
C
YEL
NO
RED
THERMOSTAT
NO
BLU
BLK
C
GRN / YEL
2
Green/Yellow
MOTOR
MOLD HEATER
165 WATTS
P-4
NC
NO
SHUT-OFF
SWITCH
NC
LT. BLU
GRN / YEL
C
P-1
MOLD
MOUNTING
PLATE
WATER FILL
SWITCH
P-2
WATER VALVE
1
Wire Color
BLK
ICE MAKER CONNECTOR PLUG CONNECTIONS
Wire Number
ICE MAKER
BRN
BLK
YEL
Closes at 15°F (-9°C)
NEUTRAL
POWER
YEL
Opens at 48°F (9°C)
LINE
RED
60 Her tz
BLK
Thermostat
115 VAC (127 VAC Max)
ICE MAKER
Electrical
Pictorial Schematic
Ladder Schematic
A-8
NOTE:
COMPRESSOR WIRING
Induction Run Compressor with Relay
SERVICE PARTS
Compressor / Kit *
Starter/PTC/TSD *
Run Capacitor *
Relay
Overload
Temperature Control
Timer (if applicable)
ADC (if applicable)
Defrost Heater Kit
Defrost Thermostat Kit
Evaporator Fan Motor
Condenser Fan Motor
15 & 17 CUBIC FOOT
STATIC
DYNAMIC
E-STAR
5303918264 5303918264 5303918299
218721120
218721120
241527802
218909913
218909913
218909915
N/A
N/A
N/A
N/A
N/A
N/A
5304421256 5304421256 5304421256
215846606
215846606
215846606
N/A
N/A
N/A
5303918203 5303918203 5303918203
5303918202 5303918202 5303918202
240369701
240369701
240369701
N/A
240523601
240523601
STATIC
5303918297
N/A
N/A
5304433579
5304433578
5304421256
215846606
N/A
5303918208
5303918202
240369701
N/A
* Typical compressor kit includes compressor, electrical components, and filter-drier
18 CUBIC FOOT
DYNAMIC
E-STAR
5303918297 5303918299
N/A
241527802
N/A
218909915
5304433579
N/A
5304433578
N/A
5304421256 5304421256
215846606
215846606
N/A
N/A
5303918208 5303918208
5303918202 5303918202
240369701
240369701
240523601
240523601
21 CUBIC FOOT
DYNAMIC
E-STAR
5303918297 5303918299
N/A
241527802
N/A
218909915
5304433579
N/A
5304433578
N/A
5304421256 5304421256
215846606
215846606
N/A
N/A
5303918247 5303918247
5303918202 5303918202
240369701
240369701
240334001
240334001
PERFORMANCE DATA
NO LOAD AND NO DOOR OPENINGS AT MID-POINT CONTROL SETTING
2° to 8°F
-17° to -13°C
0° to 5°F
-18° to -15°C
Refrigerature Temperature
35° to 40°F
2° to 4°C
35° to 40°F
2° to 4°C
Low Side Pressure (cut-in)
8 to 16 psig
55 to 110 kPa
8 to 16 psig
55 to 110 kPa
Low Side Pressure (cut-out)
1 to 4 psig
7 to 28 kPa
1 to 4 psig
7 to 28 kPa
110 to 120 psig
758 to 827 kPa
150 to 175 psig
1034 to 1207 kPa
Wattage (Last 1/3 of cycle)
140 to 185
140 to 185
Amps (Running)
1.1 to 1.6
1.1 to 1.6
115 VAC (127 VAC Max)
115 VAC (127 VAC Max)
Freezer Temperature
High Side Pressure (Last 1/3 of cycle)
Base Voltage
IMPORTANT SAFETY NOTICE
Test Cycling
Remove cover by inserting screwdriver in notch at bottom and prying
cover from housing. Use screwdriver to rotate motor gear
counterclockwise until Holding Switch circuit is completed. All
components of ice maker should function to complete the cycle.
The information provided herein is designed to assist qualified repair
personnel only. Untrained persons should not attempt to make
repairs due to the possibility of electrical shock. Disconnect power
cord before servicing.
Water Fill Volume
The water fill adjustment
screw will change the fill
time. One full turn is
equal to 20cc (.68 oz.).
The correct fill is 95 to
105cc (3.2 to 3.6 oz.).
When a water valve is
replaced, the fill volume
must be checked.
IMPORTANT
If any green grounding wires are moved during servicing, they
must be returned to their original position and properly secured.
DEFROST SPECIFICATIONS
Thermostat
P/N: 240379014
CAUTION: All electrical parts and wiring must be shielded
Heater
Cut-out
Watts
Ohms
18' & 21'
25°F
-4°C
47°F
8°C
375
35
from torch flame. Do not allow torch to contact insulation; it
will char at 200°F and flash ignite (burn) at 500°F. Excessive
heat will distort the plastic liner.
14', 15' & 17'
25°F
-4°C
47°F
8°C
325
41
NOTE: Some products come equipped with an Electronic
Mechanical Timer - Defrost 30 Minutes Ever y 10 Hours of Compressor Run Time
Electronic Timer (ADC) Defrost Up To 24 Minutes Ever y 6 - 72 Hours of Compressor Run Time
CONDENSER FAN MOTOR
RPM
Amps
2.3
1100 CW Opposite Shaft
.15 Running
Defrost Control.To initiate defrost, depress the fresh food light
switch 5 times in 6 seconds (light bulb must be working). To
terminate defrost, depress the fresh food light switch 5 times
in 6 seconds.
ICE MAKER SPECIFICATIONS
ICE MA KER
Opens at 48°F (9°C)
Closes at 15°F (-9°C)
Heater Wattage
P-3
165
2
Green/Yellow
Yellow
Connects to:
Ground
Water Valve
RED
Black
Line
4
Lt. Blue
Neutral
YEL
T HERMOSTAT
BLU
MOLD HEATER
SHUT-OF F
SWITCH
GRN / YEL
LT. BLU
P-1
MOLD
3
HO LD
SW ITCH
BLK
GRN / YEL
1
Wire Color
MOTOR
WATER FILL
S WITCH
MOUN TING
PLATE
P-4
P-2
WATER VALV E
ICE MAKER CONNECTOR PLUG CONNECTIONS
Wire Number
THER MAL
CUT-OUT
BLK
60 Her tz
ICE M AKER
Thermostat
115 VAC (127 VAC Max)
ICE MAKER
BRN
B LK
Electrical
NEUT RAL
POWER
LINE
BLK
Watts
A-9
Cut-in
Cabinet Size
YEL
45 to 55%
LT. BLU
25 to 35%
Operating Time
STANDARD - AUTOMATIC
DEFROST TOP FREEZER
MODELS
(R134a)
YEL
90°F (32°C) Ambient
RED
65°F (18°C) Ambient
ICE MAKER INFORMATION
ICE MAKER
Capacitor Run or Induction Run
SERVICE DATA SHEET
Pictorial Schematic
Ladder Schematic
A - 10
NOTE:
_ _ _ _ _ _ DENOTES NOT ON ALL MODELS
COMPRESSOR WIRING
Induction Run Compressor with Relay
SERVICE PARTS
Compressor / Kit *
Starter/PTC/TSD *
Run Capacitor *
Relay
Overload
Temperature Control
Timer (if applicable)
ADC (if applicable)
Defrost Heater Kit
Defrost Thermostat Kit
Evaporator Fan Motor
Condenser Fan Motor
15 & 17 CUBIC FOOT
STATIC
DYNAMIC
E-STAR
5303918264 5303918264 5303918299
218721120
218721120
241527802
218909913
218909913
218909915
N/A
N/A
N/A
N/A
N/A
N/A
5304421256 5304421256 5304421256
215846606
215846606
215846606
N/A
N/A
N/A
5303918203 5303918203 5303918203
5303918202 5303918202 5303918202
240369701
240369701
240369701
N/A
240523601
240523601
STATIC
5303918297
N/A
N/A
5304433579
5304433578
5304421256
215846606
N/A
5303918208
5303918202
240369701
N/A
18 CUBIC FOOT
DYNAMIC
E-STAR
5303918297 5303918299
N/A
241527802
N/A
218909915
5304433579
N/A
5304433578
N/A
5304421256 5304421256
215846606
215846606
N/A
N/A
5303918208 5303918208
5303918202 5303918202
240369701
241537301
240523601
240523601
* Typical compressor kit includes compressor, electrical components, and filter-drier
21 CUBIC FOOT
DYNAMIC
E-STAR
5303918297 5303918299
N/A
241527802
N/A
218909915
5304433579
N/A
5304433578
N/A
5304421256 5304421256
215846606
215846606
N/A
N/A
5303918247 5303918247
5303918202 5303918202
240369701
240369701
240523601
241538001
PERFORMANCE DATA
NO LOAD AND NO DOOR OPENINGS AT MID-POINT CONTROL SETTING
2° to 8°F
-17° to -13°C
0° to 5°F
-18° to -15°C
Refrigerature Temperature
35° to 40°F
2° to 4°C
35° to 40°F
2° to 4°C
Low Side Pressure (cut-in)
8 to 16 psig
55 to 110 kPa
8 to 16 psig
55 to 110 kPa
Low Side Pressure (cut-out)
1 to 4 psig
7 to 28 kPa
1 to 4 psig
7 to 28 kPa
110 to 120 psig
758 to 827 kPa
150 to 175 psig
1034 to 1207 kPa
Wattage (Last 1/3 of cycle)
140 to 185
140 to 185
Amps (Running)
1.1 to 1.6
1.1 to 1.6
115 VAC (127 VAC Max)
115 VAC (127 VAC Max)
Freezer Temperature
High Side Pressure (Last 1/3 of cycle)
Base Voltage
IMPORTANT SAFETY NOTICE
Test Cycling
Remove cover by inserting screwdriver in notch at bottom and prying
cover from housing. Use screwdriver to rotate motor gear
counterclockwise until Holding Switch circuit is completed. All
components of ice maker should function to complete the cycle.
The information provided herein is designed to assist qualified repair
personnel only. Untrained persons should not attempt to make
repairs due to the possibility of electrical shock. Disconnect power
cord before servicing.
Water Fill Volume
The water fill adjustment
screw will change the fill
time. One full turn is
equal to 20cc (.68 oz.).
The correct fill is 95 to
105cc (3.2 to 3.6 oz.).
When a water valve is
replaced, the fill volume
must be checked.
IMPORTANT
If any green grounding wires are moved during servicing, they
must be returned to their original position and properly secured.
DEFROST SPECIFICATIONS
Thermostat
P/N: 240379015
CAUTION: All electrical parts and wiring must be shielded
Heater
Cut-out
Watts
Ohms
18' & 21'
25°F
-4°C
47°F
8°C
375
35
from torch flame. Do not allow torch to contact insulation; it
will char at 200°F and flash ignite (burn) at 500°F. Excessive
heat will distort the plastic liner.
14', 15' & 17'
25°F
-4°C
47°F
8°C
325
41
NOTE: Some products come equipped with an Electronic
Mechanical Timer - Defrost 30 Minutes Ever y 10 Hours of Compressor Run Time
Electronic Timer (ADC) Defrost Up To 24 Minutes Ever y 6 - 72 Hours of Compressor Run Time
CONDENSER FAN MOTOR
RPM
Amps
2.3
1100 CW Opposite Shaft
.15 Running
Defrost Control.To initiate defrost, depress the fresh food light
switch 5 times in 6 seconds (light bulb must be working). To
terminate defrost, depress the fresh food light switch 5 times
in 6 seconds.
ICE MAKER SPECIFICATIONS
ICE MA KER
Opens at 48°F (9°C)
Closes at 15°F (-9°C)
Heater Wattage
P-3
165
Wire Color
Connects to:
1
Green/Yellow
Ground
Yellow
Water Valve
RED
Black
Line
4
Lt. Blue
Neutral
YEL
T HERMOSTAT
BLU
MOLD HEATER
SHUT-OF F
SWITCH
GRN / YEL
LT. BLU
P-1
MOLD
3
HO LD
SW ITCH
BLK
GRN / YEL
Wire Number
MOTOR
WATER FILL
S WITCH
MOUN TING
PLATE
P-4
P-2
WATER VALV E
ICE MAKER CONNECTOR PLUG CONNECTIONS
2
THER MAL
CUT-OUT
BLK
60 Her tz
ICE M AKER
Thermostat
115 VAC (127 VAC Max)
ICE MAKER
BRN
B LK
Electrical
NEUT RAL
POWER
LINE
BLK
Watts
A - 11
Cut-in
Cabinet Size
YEL
45 to 55%
LT. BLU
25 to 35%
Operating Time
STANDARD - AUTOMATIC
DEFROST TOP FREEZER
MODELS
(R134a)
YEL
90°F (32°C) Ambient
RED
65°F (18°C) Ambient
ICE MAKER INFORMATION
ICE MAKER
Capacitor Run or Induction Run
SERVICE DATA SHEET
Pictorial Schematic
Ladder Schematic
A - 12
NOTE:
_ _ _ _ _ _ DENOTES NOT ON ALL MODELS
COMPRESSOR WIRING
Induction Run Compressor with Relay
SERVICE PARTS
Compressor / Kit *
Starter/PTC/TSD *
Run Capacitor *
Relay
Overload
Temperature Control
Timer (if applicable)
ADC (if applicable)
Defrost Heater Kit
Defrost Thermostat Kit
Evaporator Fan Motor
Condenser Fan Motor
15 & 17 CUBIC FOOT
STATIC
DYNAMIC
E-STAR
240550915
240550915
5303918299
N/A
N/A
241527802
N/A
N/A
218909915
5304433579 5304433579
N/A
5304433578 5304433578
N/A
5304421256 5304421256 5304421256
215846606
215846606
215846606
N/A
N/A
N/A
5303918203 5303918203 5303918203
5303918202 5303918202 5303918202
240369701
240369701
240369701
N/A
240523601
240523601
STATIC
240550915
N/A
N/A
5304433579
5304433578
5304421256
215846606
N/A
5303918208
5303918202
240369701
N/A
18 CUBIC FOOT
DYNAMIC
E-STAR
240550915
5303918299
N/A
241527802
N/A
218909915
5304433579
N/A
5304433578
N/A
5304421256 5304421256
215846606
215846606
N/A
N/A
5303918208 5303918208
5303918202 5303918202
240369701
240369701
240523601
240523601
* Typical compressor kit includes compressor, electrical components, and filter-drier
21 CUBIC FOOT
DYNAMIC
E-STAR
240550915
5303918299
N/A
241527802
N/A
218909915
5304433579
N/A
5304433578
N/A
5304421256 5304421256
215846606
215846606
N/A
N/A
5303918247 5303918247
5303918202 5303918202
240369701
240369701
240334001
240334001
PERFORMANCE DATA
NO LOAD AND NO DOOR OPENINGS AT MID-POINT CONTROL SETTING
2° to 8°F
-17° to -13°C
0° to 5°F
-18° to -15°C
Refrigerature Temperature
35° to 40°F
2° to 4°C
35° to 40°F
2° to 4°C
Low Side Pressure (cut-in)
8 to 16 psig
55 to 110 kPa
8 to 16 psig
55 to 110 kPa
Low Side Pressure (cut-out)
1 to 4 psig
7 to 28 kPa
1 to 4 psig
7 to 28 kPa
110 to 120 psig
758 to 827 kPa
150 to 175 psig
1034 to 1207 kPa
Wattage (Last 1/3 of cycle)
140 to 185
140 to 185
Amps (Running)
1.1 to 1.6
1.1 to 1.6
115 VAC (127 VAC Max)
115 VAC (127 VAC Max)
Freezer Temperature
High Side Pressure (Last 1/3 of cycle)
Base Voltage
IMPORTANT SAFETY NOTICE
Test Cycling
Remove cover by inserting screwdriver in notch at bottom and prying
cover from housing. Use screwdriver to rotate motor gear
counterclockwise until Holding Switch circuit is completed. All
components of ice maker should function to complete the cycle.
The information provided herein is designed to assist qualified repair
personnel only. Untrained persons should not attempt to make
repairs due to the possibility of electrical shock. Disconnect power
cord before servicing.
Water Fill Volume
The water fill adjustment
screw will change the fill
time. One full turn is
equal to 20cc (.68 oz.).
The correct fill is 95 to
105cc (3.2 to 3.6 oz.).
When a water valve is
replaced, the fill volume
must be checked.
IMPORTANT
If any green grounding wires are moved during servicing, they
must be returned to their original position and properly secured.
DEFROST SPECIFICATIONS
Thermostat
P/N: 241588200
CAUTION: All electrical parts and wiring must be shielded
Heater
Cabinet Size
Cut-out
Watts
Ohms
18' & 21'
25°F
-4°C
47°F
8°C
375
35
14', 15' & 17'
25°F
-4°C
47°F
8°C
325
41
Mechanical Timer - Defrost 30 Minutes Ever y 10 Hours of Compressor Run Time
Electronic Timer (ADC) Defrost Up To 24 Minutes Ever y 6 - 72 Hours of Compressor Run Time
CONDENSER FAN MOTOR
RPM
Amps
2.3
1100 CW Opposite Shaft
.15 Running
NOTE: Some products come equipped with an Electronic
Defrost Control.To initiate defrost, depress the fresh food light
switch 5 times in 6 seconds (light bulb must be working). To
terminate defrost, depress the fresh food light switch 5 times
in 6 seconds.
ICE MAKER SPECIFICATIONS
ICE MA KER
Opens at 48°F (9°C)
Closes at 15°F (-9°C)
Heater Wattage
P-3
165
Wire Color
Connects to:
1
Green/Yellow
Ground
Yellow
Water Valve
RED
Black
Line
4
Lt. Blue
Neutral
YEL
T HERMOSTAT
BLU
MOLD HEATER
SHUT-OF F
SWITCH
GRN / YEL
LT. BLU
P-1
MOLD
3
HO LD
SW ITCH
BLK
GRN / YEL
Wire Number
MOTOR
WATER FILL
S WITCH
MOUN TING
PLATE
P-4
P-2
WATER VALV E
ICE MAKER CONNECTOR PLUG CONNECTIONS
2
THER MAL
CUT-OUT
BLK
60 Her tz
ICE M AKER
Thermostat
115 VAC (127 VAC Max)
ICE MAKER
BRN
B LK
Electrical
NEUT RAL
POWER
LINE
BLK
Watts
from torch flame. Do not allow torch to contact insulation; it
will char at 200°F and flash ignite (burn) at 500°F. Excessive
heat will distort the plastic liner.
A - 13
Cut-in
YEL
45 to 55%
LT. BLU
25 to 35%
Operating Time
STANDARD - AUTOMATIC
DEFROST TOP FREEZER
MODELS
(R134a)
YEL
90°F (32°C) Ambient
RED
65°F (18°C) Ambient
ICE MAKER INFORMATION
ICE MAKER
Capacitor Run or Induction Run
SERVICE DATA SHEET
A - 14
COMPRESSOR WIRING
SERVICE PARTS
Compressor / Kit *
Starter/PTC/TSD *
Run Capacitor *
Relay
Overload
Temperature Control
Timer (if applicable)
ADC (if applicable)
Defrost Heater Kit
Defrost Thermostat Kit
Evaporator Fan Motor
Condenser Fan Motor
15 & 17 CUBIC FOOT
STATIC
DYNAMIC
E-STAR
240550915
240550915
5303918299
N/A
N/A
241527802
N/A
N/A
218909915
5304433579 5304433579
N/A
5304433578 5304433578
N/A
5304421256 5304421256 5304421256
215846606
215846606
215846606
N/A
N/A
N/A
5303918203 5303918203 5303918203
5303918202 5303918202 5303918202
240369701
240369701
240369701
N/A
240523601
240523601
18 CUBIC FOOT
STATIC
DYNAMIC
E-STAR
240550915
240550915
5303918299
N/A
N/A
241527802
N/A
N/A
218909915
5304433579 5304433579
N/A
5304433578 5304433578
N/A
5304421256 5304421256 5304421256
215846606
215846606
215846606
N/A
N/A
N/A
5303918208 5303918208 5303918208
5303918202 5303918202 5303918202
240369701
240369701
240369701
N/A
240523601
240523601
* Typical compressor kit includes compressor, electrical components, and filter-drier
21 CUBIC FOOT
DYNAMIC
E-STAR
240550915
5303918299
N/A
241527802
N/A
218909915
5304433579
N/A
5304433578
N/A
5304421256 5304421256
215846606
215846606
N/A
N/A
5303918247 5303918247
5303918202 5303918202
240369701
240369701
240334001
240334001
Induction Run Compressor with Relay
PERFORMANCE DATA
NO LOAD AND NO DOOR OPENINGS AT MID-POINT CONTROL SETTING
Type A With Run/Star t Capacitor
65°F (18°C) Ambient
90°F (32°C) Ambient
32 to 40%
55 to 65%
0° to 4°F
-18° to -16°C
-1° to 3°F
-18° to -16°C
Refrigerator Temperature
34° to 39°F
1° to 4°C
34° to 39°F
1° to 4°C
Low Side Pressure (cut-in)
5 to 12 psig
34 to 83 kPa
5 to 12 psig
34 to 83 kPa
Low Side Pressure (cut-out)
-2 to 2 psig
-14 to 14 kPa
-2 to 2 psig
-14 to 14 kPa
90 to 115 psig
621 to 793 kPa
130 to 155 psig
896 to 1069 kPa
Wattage (Last 1/3 of cycle)
120 to 150
130 to 160
Amps (Running)
1.2 to 1.5
1.2 to 1.5
115 vac (127 vac max)
115 vac (127 vac max)
Operating Time
Freezer Temperature
High Side Pressure (Last 1/3 of cycle)
Base Voltage
DEFROST SPECIFICATIONS
Thermostat
Heater
Cabinet Size
Cut-out
Watts
Ohms
25°F
-4°C
47°F
8°C
450
30
IMPORTANT SAFETY NOTICE
The information provided herein is designed to assist qualified
repair personnel only. Untrained persons should not attempt to
make repairs due to the possibility of electrical shock. Disconnect
power cord before servicing.
IMPORTANT
If any green grounding wires are moved during servicing, they
must be returned to their original position and properly secured.
ICE MAKER INFORMATION
Test Cycling
Remove cover by inserting screwdriver in notch at bottom
and prying cover from housing. Use screwdriver to rotate motor
gear counterclockwise until holding switch circuit is completed.
All components of ice maker should function to complete the
cycle.
Water Fill Volume
The water fill adjustment screw will change the fill time. One full
turn is equal to 20cc (.68 oz.). The correct fill is 102 to 130cc
(3.4 to 4.3 oz.). When a water valve is replaced, the fill volume
must be checked.
CAUTION: All electrical parts and wiring must be shielded
from torch flame. Do not allow torch to contact insulation;
it will char at 200°F and flash ignite (burn) at 500°F. Excessive
heat will distort the plastic liner.
A - 15
23' & 26'
Cut-in
SERVICE DATA SHEET - 240389613
R134a
ICE & WATER - AUTOMATIC DEFROST
SIDE BY SIDE MODELS
Electronic Timer - (ADC) Defrost 24 minutes every 6 to 72 hours of compressor run time.
CONDENSER FAN MOTOR
Watts
RPM
Amps
7
1100 CW Opposite Shaft
.1 Running
ICE MAKER SPECIFICATIONS
Electrical
Thermostat
115 vac (127 vac max)
60 Her tz
Opens at 48°F (9°C)
Closes at 15°F (-9°C)
Heater Wattage
NOTE: This product comes equipped with an Electronic Defrost
Control. To initiate defrost, depress the fresh food light switch 5
times in 6 seconds (light bulb must be working). To terminate
defrost, depress the fresh food light switch 5 times in 6 seconds.
P-3
165
ICE MAKER CONNECTOR PLUG CONNECTIONS
Wire Number
Wire Color
Connects to:
1
Green/Yellow
Ground
2
Yellow
Water Valve
3
Black
Line
4
Lt. Blue
Neutral
GREEN/YELLOW
P-4
GREEN/YELLOW
P-1
P-2
A - 16
SERVICE PARTS
Compressor Kit *
Starter/PTC *
Run Capacitor *
Temp. Control-Refr
Temp. Control-Frzr
Timer (if applicable)
ADC (if applicable)
Defrost Heater Kit
Defrost Thermostat Kit
Evaporator Fan Motor
Condenser Fan Motor
23 CUBIC FOOT
STANDARD E-STAR
5303918251 5303918251
218721119 218721119
216787800 216787800
241507701 241507701
450226-07 450226-07
N/A
N/A
241508001 241508001
5303918253 5303918253
5303918214 5303918214
240315803 240315802
240397101 240334001
26 CUBIC FOOT
STANDARD E-STAR
5303918254 5303918254
218721119 218721119
218909901 218909901
241507701 241507701
450226-07 450226-07
N/A
N/A
241508001 241508001
5303918253 5303918253
5303918214 5303918214
240315803 240315802
240397101 240334002
* Typical compressor kit includes compressor, electrical components, and filter-drier
PERFORMANCE DATA
NO LOAD AND NO DOOR OPENINGS AT MID-POINT CONTROL SETTING
Type A With Run/Star t Capacitor
65°F (18°C) Ambient
90°F (32°C) Ambient
32 to 40%
55 to 65%
0° to 4°F
-18° to -16°C
-1° to 3°F
-18° to -16°C
Refrigerator Temperature
34° to 39°F
1° to 4°C
34° to 39°F
1° to 4°C
Low Side Pressure (cut-in)
5 to 12 psig
34 to 83 kPa
5 to 12 psig
34 to 83 kPa
Low Side Pressure (cut-out)
-2 to 2 psig
-14 to 14 kPa
-2 to 2 psig
-14 to 14 kPa
90 to 115 psig
621 to 793 kPa
130 to 155 psig
896 to 1069 kPa
Wattage (Last 1/3 of cycle)
120 to 150
130 to 160
Amps (Running)
1.2 to 1.5
1.2 to 1.5
115 vac (127 vac max)
115 vac (127 vac max)
Operating Time
Freezer Temperature
High Side Pressure (Last 1/3 of cycle)
Base Voltage
DEFROST SPECIFICATIONS
Thermostat
Heater
Cabinet Size
Cut-out
Watts
Ohms
25°F
-4°C
47°F
8°C
450
30
ICE MAKER INFORMATION
R134a
ICE & WATER - AUTOMATIC DEFROST
SIDE BY SIDE MODELS
Test Cycling
IMPORTANT SAFETY NOTICE
The information provided herein is designed to assist qualified
repair personnel only. Untrained persons should not attempt to
make repairs due to the possibility of electrical shock. Disconnect
power cord before servicing.
IMPORTANT
If any green grounding wires are moved during servicing, they
must be returned to their original position and properly secured.
Remove cover by inserting screwdriver in notch at bottom
and prying cover from housing. Use screwdriver to rotate motor
gear counterclockwise until holding switch circuit is completed.
All components of ice maker should function to complete the
cycle.
Water Fill Volume
The water fill adjustment screw will change the fill time. One full
turn is equal to 20cc (.68 oz.). The correct fill is 102 to 130cc
(3.4 to 4.3 oz.). When a water valve is replaced, the fill volume
must be checked.
CAUTION: All electrical parts and wiring must be shielded
from torch flame. Do not allow torch to contact insulation;
it will char at 200°F and flash ignite (burn) at 500°F. Excessive
heat will distort the plastic liner.
A - 17
23' & 26'
Cut-in
SERVICE DATA SHEET - 240389615
Electronic Timer - (ADC) Defrost 24 minutes every 6 to 72 hours of compressor run time.
CONDENSER FAN MOTOR
Watts
RPM
Amps
7
1100 CW Opposite Shaft
.1 Running
ICE MAKER SPECIFICATIONS
Electrical
Thermostat
115 vac (127 vac max)
60 Her tz
Opens at 48°F (9°C)
Closes at 15°F (-9°C)
Heater Wattage
NOTE: This product comes equipped with an Electronic Defrost
Control. To initiate defrost, depress the fresh food light switch 5
times in 6 seconds (light bulb must be working). To terminate
defrost, depress the fresh food light switch 5 times in 6 seconds.
P-3
165
ICE MAKER CONNECTOR PLUG CONNECTIONS
Wire Number
Wire Color
Connects to:
1
Green/Yellow
Ground
2
Yellow
Water Valve
3
Black
Line
4
Lt. Blue
Neutral
GREEN/YELLOW
P-4
GREEN/YELLOW
P-1
P-2
A - 18
23 CUBIC FOOT
26 CUBIC FOOT
SERVICE PARTS
STANDARD
E-STAR
STANDARD
E-STAR
Compressor Kit *
5303918251 5303918299 5303918254 5303918298
Starter/PTC/TSD *
218721119 241527802 218721119 241527801
Run Capacitor *
218909912 218909915 218909912 218909915
Temp. Control-Refr
241507701 241507701 241507701 241507701
Temp. Control-Frzr
450226-07
450226-07
450226-07
450226-07
Timer (if applicable)
N/A
N/A
N/A
N/A
ADC (if applicable)
241508001 241508001 241508001 241508001
Defrost Heater Kit
5303918253 5303918253 5303918253 5303918253
Defrost Thermostat Kit 5303918214 5303918214 5303918214 5303918214
Evaporator Fan Motor
240369701 240369701 240369701 241537301
Condenser Fan Motor
240397101 241538001 240397101 241538001
* Typical compressor kit includes compressor, electrical components, and filter-drier
PERFORMANCE DATA
NO LOAD AND NO DOOR OPENINGS AT MID-POINT CONTROL SETTING
Type A With Run/Star t Capacitor
65°F (18°C) Ambient
90°F (32°C) Ambient
32 to 40%
55 to 65%
0° to 4°F
-18° to -16°C
-1° to 3°F
-18° to -16°C
Refrigerator Temperature
34° to 39°F
1° to 4°C
34° to 39°F
1° to 4°C
Low Side Pressure (cut-in)
5 to 12 psig
34 to 83 kPa
5 to 12 psig
34 to 83 kPa
Low Side Pressure (cut-out)
-2 to 2 psig
-14 to 14 kPa
-2 to 2 psig
-14 to 14 kPa
90 to 115 psig
621 to 793 kPa
130 to 155 psig
896 to 1069 kPa
Wattage (Last 1/3 of cycle)
120 to 150
130 to 160
Amps (Running)
1.2 to 1.5
1.2 to 1.5
115 vac (127 vac max)
115 vac (127 vac max)
Operating Time
Freezer Temperature
High Side Pressure (Last 1/3 of cycle)
Base Voltage
The information provided herein is designed to assist qualified repair
personnel only. Untrained persons should not attempt to make
repairs due to the possibility of electrical shock. Disconnect power
cord before servicing.
Test Cycling
Remove cover by inserting screwdriver in notch at bottom and prying
cover from housing. Use screwdriver to rotate motor gear
counterclockwise until holding switch circuit is completed. All
components of ice maker should function to complete the cycle.
Water Fill Volume
The water fill adjustment
screw will change the fill
time. One full turn is
equal to 20cc (.68 oz.).
The correct fill is 102 to
130cc (3.4 to 4.3 oz.).
When a water valve is
replaced, the fill volume
must be checked.
IMPORTANT
If any green grounding wires are moved during servicing, they
must be returned to their original position and properly secured.
A - 19
from torch flame. Do not allow torch to contact insulation; it
will char at 200°F and flash ignite (burn) at 500°F. Excessive
heat will distort the plastic liner.
Heater
Cabinet Size
23' & 26'
IMPORTANT SAFETY NOTICE
ICE MAKER INFORMATION
CAUTION: All electrical parts and wiring must be shielded
DEFROST SPECIFICATIONS
Thermostat
SERVICE DATA SHEET - 240389616
R134a
ICE & WATER - AUTOMATIC DEFROST
SIDE BY SIDE MODELS
Cut-in
Cut-out
Watts
Ohms
NOTE: This product comes equipped with an Electronic Defrost
25°F
-4°C
47°F
8°C
450
30
Control. To initiate defrost, depress the fresh food light switch 5
times in 6 seconds (light bulb must be working). To terminate
defrost, depress the fresh food light switch 5 times in 6 seconds.
Electronic Timer - (ADC) Defrost 24 minutes every 6 to 72 hours of compressor run time.
CONDENSER FAN MOTOR
Watts
RPM
Amps
7
1100 CW Opposite Shaft
.1 Running
P-3
ICE MAKER SPECIFICATIONS
Electrical
Thermostat
115 vac (127 vac max)
60 Her tz
Opens at 48°F (9°C)
Closes at 15°F (-9°C)
Heater Wattage
165
P-4
Wire Number
Wire Color
Connects to:
1
Green/Yellow
Ground
2
Yellow
Water Valve
3
Black
Line
4
Lt. Blue
Neutral
GREEN/YELLOW
ICE MAKER CONNECTOR PLUG CONNECTIONS
GREEN/YELLOW
P-1
P-2
A - 20
23 CUBIC FOOT
26 CUBIC FOOT
SERVICE PARTS
STANDARD
E-STAR
STANDARD
E-STAR
Compressor Kit *
5303918303 5303918299 5303918303 5303918298
Starter/PTC/TSD *
241524604 241527802 241524604 241527801
Run Capacitor *
218909913 218909915 218909913 218909915
Temp. Control-Refr
241507701 241507701 241507701 241507701
Temp. Control-Frzr
450226-07
450226-07
450226-07
450226-07
Timer (if applicable)
N/A
N/A
N/A
N/A
ADC (if applicable)
241508001 241508001 241508001 241508001
Defrost Heater Kit
5303918253 5303918253 5303918253 5303918253
Defrost Thermostat Kit 5303918214 5303918214 5303918214 5303918214
Evaporator Fan Motor
240369701 240369701 240369701 241537301
Condenser Fan Motor
240523601 241538001 240523601 241538001
* Typical compressor kit includes compressor, electrical components, and filter-drier
PERFORMANCE DATA
NO LOAD AND NO DOOR OPENINGS AT MID-POINT CONTROL SETTING
Type A With Run/Star t Capacitor
65°F (18°C) Ambient
90°F (32°C) Ambient
32 to 40%
55 to 65%
0° to 4°F
-18° to -16°C
-1° to 3°F
-18° to -16°C
Refrigerator Temperature
34° to 39°F
1° to 4°C
34° to 39°F
1° to 4°C
Low Side Pressure (cut-in)
5 to 12 psig
34 to 83 kPa
5 to 12 psig
34 to 83 kPa
Low Side Pressure (cut-out)
-2 to 2 psig
-14 to 14 kPa
-2 to 2 psig
-14 to 14 kPa
90 to 115 psig
621 to 793 kPa
130 to 155 psig
896 to 1069 kPa
120 to 150
130 to 160
Operating Time
Freezer Temperature
High Side Pressure (Last 1/3 of cycle)
Wattage (Last 1/3 of cycle)
Amps (Running)
Base Voltage
ICE MAKER INFORMATION
R134a
ICE & WATER - AUTOMATIC DEFROST
SIDE BY SIDE MODELS
Test Cycling
Press the momemtary contact on the ON/OFF switch for
approximately 15 seconds. Ice maker will continue to complete
the cycle.
Water Fill Volume
IMPORTANT SAFETY NOTE
The information provided herein is designed to assist
qualified repair personnel only. Untrained persons should
not attempt to make repairs due to the possibility of
electrical shock. Disconnect power cord before servicing
this appliance.
IMPORTANT
1.2 to 1.5
1.2 to 1.5
115 vac (127 vac max)
115 vac (127 vac max)
DEFROST SPECIFICATIONS
If any green grounding wires are removed during
servicing, they must be returned to their original position
and properly secured.
Remove cover by inserting screwdriver in notch at bottom and
prying cover from housing. The water fill adjustment screw will
change the fill time. One turn is equal to 20cc (.68 oz.). The
correct fill is 102 to 110cc (3.25 to 3.5 oz.). When a water valve
is replaced, the fill volume must be checked
Water Fill
Adjustment
Motor
Gear
TU
R
N
Heater
Mounting
Plate
Screws
Cabinet Size
23' & 26'
Cut-in
Cut-out
Watts
Ohms
25°F
-4°C
47°F
8°C
450
30
Electronic Timer - (ADC) Defrost 24 minutes every 6 to 72 hours of compressor run time.
CONDENSER FAN MOTOR
Watts
RPM
Amps
7
1100 CW Opposite Shaft
.1 Running
ICE MAKER SPECIFICATIONS
Electrical
Thermostat
115 vac (127 vac max)
60 Her tz
Opens at 48°F (9°C)
Closes at 15°F (-9°C)
Heater Wattage
Mounting
Plate
Screw
CAUTION
All electrical parts and wiring must be shielded from torch
flame. DO NOT allow torch to touch insulation; it will char
at 200°F and flash ignite (burn) at 500°F. Excessive heat
will distort the plastic liner.
165
ICE MAKER CONNECTOR PLUG CONNECTIONS
Wire Number
Wire Color
Connects to:
1
Green/Yellow
Ground
2
Yellow
Water Valve
3
Black
Line
4
Lt. Blue
Neutral
NOTE
This product comes equipped with an Electronic Defrost
Control. To initiate defrost, depress the fresh food light switch
5 times in 6 seconds (light bulb must be working). To terminate
defrost, depress the fresh food light switch 5 times in 6
seconds.
Timing
Gear
Ice Maker
ON/OFF
Switch
A - 21
Thermostat
SERVICE DATA SHEET - 240389618
A - 22
23 CUBIC FOOT
26 CUBIC FOOT
SERVICE PARTS
STANDARD
E-STAR
STANDARD
E-STAR
Compressor Kit *
5303918303 5303918299 5303918303 5303918298
Starter/PTC/TSD *
241524604 241527802 241524604 241527801
Run Capacitor *
218909913 218909915 218909913 218909915
Temp. Control-Refr
241507701 241507701 241507701 241507701
Temp. Control-Frzr
450226-07
450226-07
450226-07
450226-07
Timer (if applicable)
N/A
N/A
N/A
N/A
ADC (if applicable)
241508001 241508001 241508001 241508001
Defrost Heater Kit
5303918253 5303918253 5303918253 5303918253
Defrost Thermostat Kit 5303918214 5303918214 5303918214 5303918214
Evaporator Fan Motor
240369701 240369701 240369701 241537301
Condenser Fan Motor
240523601 241538001 240523601 241538001
* Typical compressor kit includes compressor, electrical components, and filter-drier
SERVICE DATA SHEET
241532603
ICE & WATER - AUTOMATIC DEFROST
PERFORMANCE DATA
NO LOAD AND NO DOOR OPENINGS AT MID-POINT CONTROL SETTING
65°F (18°C) Ambient
Type A with Run/Start Capacitor
COUNTER DEPTH SIDE BY SIDE - R134a
90°F (32°C) Ambient
Standard
Variable Speed
Standard
74 to 84%
32 to 40%
100%
55 to 65%
-2° to 2°F
-19° to -17°C
0° to 4°F
-18° to -16°C
-1° to 3°F
-18° to -16°C
-1° to 3°F
-18° to -16°C
Refrigerator Temperature
34° to 39°F
1° to 4°C
34° to 39°F
1° to 4°C
34° to 39°F
1° to 4°C
34° to 39°F
1° to 4°C
Low Side Pressure (cut-in)
5 to 12 psig
43 to 83 kPa
5 to 12 psig
43 to 83 kPa
N/A
5 to 12 psig
43 to 83 kPa
Low Side Pressure (cut-out)
-2 to 2 psig
-14 to 14kPa
-2 to 2 psig
-14 to 14kPa
-2 to 2 psig
-14 to 14kPa
-2 to 2 psig
-14 to 14kPa
90 to 105 psig
621 to 724 kPa
90 to 115 psig
621 to 793 kPa
120 to 135 psig
827 to 931 kPa
130 to 155 psig
896 to 1069 kPa
Wattage (last 1/3 cycle)
60 to 65
120 to 150
65 to 80
130 to 160
Amps (running)
.7 to 1.1
1.0 to 1.4
.9 to 1.3
1.1 to 1.5
Operating Time
Freezer Temperature
High Side Pressure (last 1/3 cycle)
Base Voltage
115 vac (127 vac max)
115 vac (127 vac max)
Thermostat
Cabinet Size
23’
Heater
Cut-in
Cut-out
Watts
Ohms
25°F (-4°C)
47°F (8°C)
450
30
Electronic Timer – (ADC) Defrost 24 minutes every 6 – 96 hours of compressor run time.
CONDENSER FAN MOTOR
Watts
RPM
Amps
2.8
950 CW Opposite Shaft
.1 Running
ICE MAKER SPECIFICATIONS
Electrical
115 vac (127 vac max)
Thermostat
Opens at 48°F (9°C)
Heater Voltage
Closes at 15°F (-9°C)
85 vac
ICE MAKER CONNECTOR PLUG CONNECTIONS
Wire Number
Wire Color
Connects to:
1
Green/Yellow
Ground
2
Yellow
Water Valve
3
Black
Line
4
Light Blue
Neutral
IMPORTANT
Please return this sheet to its original location.
The information provided herein is designed to assist
qualified repair personnel only. Untrained persons should
not attempt to make repairs due to the possibility of electrical
shock. Disconnect power cord before servicing this
appliance.
IMPORTANT
If any green grounding wires are removed during servicing,
they must be returned to their original position and properly
secured.
CAUTION
All electrical parts and wiring must be shielded from torch
flame. DO NOT allow torch to touch insulation; it will char at
200°F and flash ignite (burn) at 500°F. Excessive heat will
distort the plastic liner.
NOTE
This product comes equipped with an Adaptive Defrost
Control (ADC). To activate manual defrost, press and hold
the Freezer temperature UP (WARMER) key while pressing
the Fresh Food temperature DOWN (COLDER) key 5 times
within 6 seconds. A “d” in the freezer temperature window
and “F” in the refrigerator temperature window will display
when the heater is activated. To deactivate manual defrost,
press and hold Freezer temperature UP (WARMER) key while
pressing the Fresh Food temperature DOWN (COLDER) key
5 times within 6 seconds. “d” and “F” will be displayed until
the defrost cycle is complete. (approx. 8 minutes)
Press the momemtary contact on the ON/OFF switch for
approximately 15 seconds. Ice maker will continue to
complete the cycle.
Water Fill Volume
Water Fill
Adjustment
Remove cover by
Motor
inserting screwdriver
Gear
in notch at bottom
TU
R
Mounting
Ice Maker
and prying cover from
Plate
ON/OFF
Screws
Switch
housing. The water fill
adjustment screw will
Mounting
change the fill time.
Plate
Screw
Timing
One turn is equal to
Gear
20cc (.68 oz.). The
correct fill is 102 to
110cc (3.25 to 3.5 oz.). When a water valve is replaced,
the fill volume must be checked
A - 23
DEFROST SPECIFICATIONS
IMPORTANT SAFETY NOTE
Test Cycling
N
Variable Speed
ICE MAKER INFORMATION
1
2
1
115 VAC
2 TO 5 VDC
2
VARIABLE SPEED COMPRESSOR
Variable Speed
FOR E-STAR
Compressor
and E-Star only
A - 24
23 CUBIC FOOT
STANDARD 1
E-STAR 2
Compressor Kit *
5303918298
241547601
Power Board (Sigma Main)
N/A
241511102
Inverter
N/A
241577501
Starter/PTC
241527801
N/A
Run Capacitor
218909915
N/A
Sensor, Temperature
240597201
240597201
Damper Assembly
241518401
241518401
Defrost Heater Kit
5303918253
5303918253
Defrost Thermostat Kit
5303918214
5303918214
Evaporator Fan Motor
241509401
241509401
Condenser Fan Motor
241537901
241537901
* Typical Compressor Kit includes compressor, electrical
components and filter-drier.
SERVICE PARTS