宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
VOX Service Manual
1 of 70
Page
VOX
Service Manual
HTC Proprietary
Confidential Treatment Requested
Rev. A01
Feb 12,2007
HTC Corp.
Engineering Mobility
REVISION CONTROL TABLE
Rev
A01
Date
02/12
Contents
First draft
Dept
PSE
Revised
REV.
A01
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
VOX Service Manual
Page
A01
2 of 70
Table of Contents
CHAPTER 1 – INTRODUCTION
P3
1.1 Product Specification
1.2 Definition
CHAPTER 2 – DEVICE ASSEMBLING AND DISASSEMBLING PROCEDURE
P3
P9
P11
2.1 Assembling procedure
2.2 Disassembling procedure
CHAPTER 3 – DIAGNOSTICS PROGRAM AND WINCE TEST ITEM
P15
P26
P32
3.1 Test Plan
3.2 How to enter Diagnostic mode and Boot-loader mode
3.3 Test procedure
CHAPTER 4 – LEAKAGE CURRENT MEASUREMENT
P32
P33
P34
P41
CHAPTER 5 – COSMETIC INSPECTION CRITERIA
P44
5.1
5.2
5.3
5.4
REV.
Definition of Cosmetic Standard
Visual Inspection Requirements
Definition of Inspection Defects and Areas
Cosmetic Criteria Table
CHAPTER 6 – OS, GSM ROM IMAGE RE-FLASH PROCEDURE
P44
P44
P44
P45
P46
6.1 OS upgrade thru RUU
6.2 OS upgrade thru SD card
CHAPTER 7 – GENERIC TROUBLESHOOTING
P46
P50
P51
CHAPTER 8 – GENERIC SPARE PART LIST AND PHOTOS (FOR REFERENCE ONLY)
P55
APPENDIX P
GENERIC LABELING PLAN
P59
RF ANTENNA TEST SPECIFICATION
P67
BOARD LEVEL 2.5 REPAIRS
P69
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
Page
REV.
A01
3 of 70
INTRODUCTION
This manual provides the technical information to support the service activities of the Smart Phone Monet.
This document contains highly confidential information, so any or all of this document should not be
revealed to any third party.
1.1 Product Specification/Feature
Platform
Bar type form factor integrated quad band EDGE/GPRS/GSM, SIP/VoIP, Bluetooth, WiFi, 2 mega-pixel
camera
One stop sliding QWERTY keyboard
OS: Windows Mobile Crossbow Platform
Dimension
101.5mm (L) x 50mm(W) x 18.6mm(T)
Weight: 134g (with battery)
Processor/Chipset
TI OMAP850, 200Mhz
Memory
ROM: 128 MB ROM
RAM: 64 MB DDR
LCD Module
2.4” QVGA, 64K colors Transmissive LCD
LED backlight
GSM/EDGE Function
Internal antenna
Quad-band (850/900/1800/1900)
850: 824-849, 869-894MHz
900: 880-915, 925-960MHz
1800: 1710-1785, 1805-1880MHz
1900: 1850-1910, 1930-1990MHz
Generic Services
Call Holding, Waiting, Forwarding
Call Barring
CLI (Calling Line Identity)
SMS (Short Message Service)
SMSMT, SMSMO, SM Reply, SM Replace, SM Acknowledgement, 8 Bits SMS Data
Concatenated messages, up to 640 characters
Display own number, telephone number storage capability in terminal and SIM card
Network selection
Cell broadcast
Multi-party conference capability
Phase 2+ Unstructured Supplementary Service Data
Audio Codec: AMR/EFR/FR/HR
Network Lock
CPHS partial
E-GPRS Function
EGPRS class B
Multi-slot standard class 10
MO/MT SMS over GPRS
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
Page
REV.
A01
4 of 70
PBCCH
SIM
1.8 / 3V of UICC
SIM Application Tool Kit release 98 class 3 and 99 partial
Over the Air (OTA) programming
Fixed Dialing Number (FDN)
Abbreviation Dial Number (ADN)
Security Pin 1 & 2 control
SIM+/ EAP-SIM support
Camera (manufacture option)
Color CMOS 2 mega-pixel camera
Preview mirror
Keyboard/button/Switch
2 soft keys
Home key
Back key
Send phone button
Quick press: Start a phone call
Long press (Press & Hold): Switch on or off the Loud Speaker
End phone button
Short press: End a phone call
Long press (press & hold): turn on Key-lock
Camera capture button (position: top-right)
5-way navigation pad
Power button (position: on top of device)
Volume Up and Volume Down button (position: top-left)
PoC or VC/VR button (position: left & below volume button)
PoC case: (Cingular requirement)
VD/ VR case (others)
Short press: Voice Dialer
Long press: Voice Record
Numerical dialing pad (12 buttons)
QWERTY keyboard with 2 additional soft keys
Cap and Function mode indicator on QWERTY keyboard
Auto sound effect when sliding out/ close
Auto display on when sliding out
Light sensor control for backlight
Notification
One bi-color LED (Green and Red) for GSM/GPRS/EDGE standby, GSM/GPRS/EDGE network status,
Event Notification, Power Charging status, and Low battery
One bi-color LED (Blue and Green) for Bluetooth (blue) and WiFi (Green) connectivity status
Notification by LED, Sound, Message, Vibration
Audio
Built-in microphone
Receiver
Speaker
Loud speaker for Hands-Free supported
Full duplex
Audio sampling rate
16-bits with 8KHz, 11KHz, 22KHz, 44.1KHz
AMR/AAC/WAV/WMA/MP3 codec
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
Page
REV.
A01
5 of 70
Connectivity & Interface
Bluetooth
Chipset: TI 6300
Compliant with v2.0
Class 2 transmit power
Supported profiles:
GAP (generic access profile)
SPP (serial port profile)
OPP (object push profile)
PAN (pan area profile)
GOEP (generic object exchange profile)
ActiveSync (legacy application via SPP)
HSP (headset profile)
HFP (handsfree profile)
A2DP (Advanced Audio Distribution profile)
AVRCP (Audio/Video Remote control Profile)
Service Discovery Profile
SAP (SIM Access Profile)
HID (Human interface device profile)
FTP (File Transfer profile)
WiFi
Chipset: TNETW1251
Internal WLAN antenna
IEEE 802.11b/g
Date rate auto fallback for extended range
ELP mode
Security 802.11i and AES
WPA/WPA 2 authentication – WEP (64 & 128bit), PSK, EAP-TLS, PEAP, LEAP
Signaling interfaces between the terminal device and the servers: mutually authenticated and
encrypted utilizing TLS (RFC 2246) with RC4 encryption with SGA1 used as the message integrity
check
QoS
802.11 WME QoS
802.11e
Fast AP to AP handover
Packet tagging & prioritization
Site Survey, Trace Route (Hidden Feature), Seamless-Secure Roaming, and VLAN Support
HTC ExtUSB 11-pin mini-USB
USB 1.1
Support Audio jack
Support ActiveSync to PC/NB
Support Charging capability
MicroSD card slot
External RF connector with cover
Power
Talk time: 3.2~7.3 hrs [base on RF power level 5~12]
Standby time: 120~175hrs [base on multi-frame 2~5]
Charging time: 2.5~3 hrs [base on OFF mode at 25℃]
WMA: 12 hours [base on NSTL test case]
WMV: 8 hours [base on NSTL test case]
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
Page
6 of 70
Battery
Rechargeable battery, Li-Polymer 1,050 mAh
AC Adapter:
AC input rating: 100 ~ 240 VAC, 50/60Hz
DC output: 5V, 1A
Hanger
Accessories
Standard
Travel Charger
USB Sync. Cable
Stereo wired headset with microphone
Standard Battery
User Manual, Quick Start Guide, & Software CD
Option
Mono Bluetooth Headset w/ microphone
Stereo Bluetooth Headset w/ microphone
Car adapter
Battery charger [TBD]
Carrying case
Charging docking (home use)
TTY adaptor
11 pin Y-Cable
Microsoft Windows Mobile 2005 Smartphone Applications
Pocket Outlook
Calendar, Contacts, Messaging, Tasks, & Voice Notes
Push Mail
Email Setup Wizard
Microsoft Internet Explorer Mobile
Microsoft Windows Media Player
Pictures & Video
Microsoft ActiveSync
Microsoft MSN Messenger
Device Management
Calculator
Games
File Manager
Smart Dialer for QWERTY keyboard as search input
Value Added Applications
Camera / Camcorder
Camera Mode
Encoding format: JPEG
Resolution: UXGA 1200x1600, SXGA 960x1280, VGA 480x640, QVGA 240x320, QQVGA
120x160
Night Mode
Digital Zooming: continuous 1x ~ 10x
Time & Date Stamp
Self Timer: 2/10 sec for Photo, Contacts Picture mode
Camcorder Mode
10 fps encoding up to QCIF resolution
Digital Zooming: 1x ~ 2x
Encoding format
REV.
A01
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
Page
H.263 + AMR-NB (.3gp)
MPEG4 + AMR-NB (.mp4)
Motion JPEG + PCM (.avi)
Ringtone
MIDI
Software polyphonic & Standard MIDI format 0 and 1 (SMF) / SP MIDI
MP3, AAC, AAC+, WMA, WAV and AMR-NB
Multimedia support format
Audio: AAC, AAC+, MP3, WMA, WAV, AMR-NB
Video: MPEG4, H.263, WMV, Motion JPEG (AVI)
Picture Enhancement for Pictures & Videos
Graphics: JPEG, GIF87a, GIF89a, PNG, WBMP
Video Thumbnail Preview: MPEG4, H.263, Motion JPEG (AVI)
MMS Client
Partial compliant to MMS 1.2
SMIL v2.0 supported
vCalendar v1.0 and vCard v2.1 supported
Task Manager
Unlock Screen Clock
Java virtual machine (MIDP 2.0)
Midlet display area: 220x300
JSR 75 File Connection
JSR 118 MIDP 2.0
JSR 139 CLDC 1.1
JSR 185 JTWI
JSR 135 Mobile Media API
JSR 120 Wireless Messaging API
Voice Dial/ Voice Command
Speaker Dependent
Voice Recorder (for AMR only)
Notes (Text notes)
T9 IME for Smartphone
SIM Manager
Comm. Manager
FOTA (Firmware OTA)
Document viewer
Word/ Excel/ PowerPoint
Adobe PDF Viewer
OMA DRM v1.0 (2.0 when available)
Audio Manager
HTC SIP/VoIP SDK
VoIP codec support
G.711 (64kbps, a-law/u-law)
G.729ab (G.729 with VAD support)
G.723.1
Carrier Specific Requirement
BlackBerry Client (Orange, T-Mobile)
SIP
Protocol support
SDP (RFC 3264)
DHCP or static IP addressing
7 of 70
REV.
A01
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
Page
8 of 70
Authentication (login/password)
DTMF transmission over RTP (RFC 2833)
No static IPv4 address configuration
DHCP locating
Security
802.11i compliant (WEP, WPA, WPA2)
Authentication by EAP-SIM should follow 3GPP TS 23.234
Generic Call service
Calling line identification presentation (CLIP)
Calling line identification restriction (CLIR)
Call forward unconditional (CFU)
Call forward on mobile subscriber busy (CFB)
Call forwarding on no reply (CFNRy)
Call forward on mobile subscriber not reachable (CFNRc)
Call waiting (CW)
Call Hold (HOLD)
Multiparty (MPTY)
Barring of all outgoing calls (BAOC)
Barring of all incoming calls (BIC)
Pre-dialing before sending
Redial
Call mute
Comfort noise generation (CNG), voice activity detection (VAD), adaptive jitter buffer, and echo
cancellation
Regulatory
GCF certification [Operator dependent]
R&TTE: EMC / EMI, Safety SAR
FCC Approval
FCC HAC (Hearing Aid Compatibility)
PTCRB Approval [Operator dependent]
WiFi Certification
BQB (Bluetooth Qualification Body) certification
Windows Mobile Logo (NTSL)
USB certification
REV.
A01
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
2.1 Definition
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
Page
9 of 70
REV.
A01
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
Page
10 of 70
REV.
A01
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
Page
11 of 70
REV.
A01
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
Page
12 of 70
REV.
A01
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
Page
13 of 70
REV.
A01
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
VOX Service Manual
Inserting the SIM card
Before you begin, make sure the phone is turned off.
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
Page
14 of 70
REV.
A01
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
15 of 70
2. DEVICE ASSEMBLING AND DISASSEMBLING PROCEDURE
2.1 Assembling procedure
TOOLS NEEDED FOR ASSEMBLING AND
DISASSEMBLING PROCESS.
LENS CLEANING CLOTH. (NO. 1)
TORX SCREW DRIVER T6X50. (NO. 2)
PHILIPS SCREW DRIVER 00X40. (NO. 3)
FLAT PLASTIC STICK. (NO. 4)
PLASTIC TWEEZERS. (NO. 5)
CAMERA MODULE UN-INSTALL TOOL
PREPARE NUMERIC KEYPAD AND NUMERIC
KEYPAD FPC.
REMOVE THE STICKER PROTECTOR (DOME
SIDE)
MAKE SURE NUMERIC KEYPAD GUIDE PINS GO
TROUGH THE FPC HOLES.
REMOVE STICKER PROTECTOR (FPC SIDE)
PASTE THE NUMERIC KEYPAD FPC ONTO THE
NUMERIC KEYPAD.
INSTALL THE NUMERIC KEYPAD ASSY TO THE
BEZEL.
HTC CONFIDENTIAL
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
16 of 70
AFTER INSTALL THE NUMERIC KEYPAD ONTO
THE DIPSLAY UPPER COVER, MAKE SURE YOU
CAN SEE TWO HOOKS FROM THE BACK SIDE.
PREPARE “LCD”
ASSEMBLE THE LCD.
PASTE EMI GASKETS.
HTC CONFIDENTIAL
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
17 of 70
INSTALL RECEIVER INTO ITS CONNECTOR ON
THE RIGID-FLEX BOARD.
ALIGN THE RECEIVER WIRES BESIDE THE
CONNECTOR AS SHOWN ON THE LEFT.
INSTALL THE LCD FPC INTO ITS CONNECTOR
ON THE RIGID-FLEX BOARD.
INSTALL THE KEYBOARD FPC PRE-ASSY
CONNECTOR ON THE RIGID-FLEX BOARD
HTC CONFIDENTIAL
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
18 of 70
ATTACH THE MICROSD RUBBER ONTO BEZEL.
PREPARE
SLIDER-HINGE
BOTTOM COVER BEZEL.
AND
DISPLAY
ASSEMBLE SLIDER-HINGE TO DISPLAY BOTTOM
COVER BEZEL.
FASTEN 4 SCREWS ON DISPLAY BOTTOM
COVER.
NOTE: SCREW TORQUE 1.2 ± 0.05 KGF-CM
HTC CONFIDENTIAL
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
ASSEMBLE
19 of 70
DISPLAY BOTOM
DISPLAY UPPER COVER.
COVER
TO
TURN THE DISPLAY BOTTOM COVER ABOUT 30
DEGREE TO LET THE RIGID-FLEX BOARD
CONNECTOR PASS TROUGH.
PRESS THE AREA AROUND THE DISPLAY
BOTOM COVER TO FIX THE DISPLAY BOTTOM
AND UPPER COVER.
FASTEN SCREW LOCATION NUMBER 1 & 2 BY
USING FIG. 1 SCREW AND SCREW LOCATION
NUMBER 3, 4, 5 & 6 BY USING FIG. 2 SCREW.
NOTE: 1. DON’T CLOSE OR LOCK MICROSD
AND SIM CARD DOOR
2. SCREW TORQUE 0.6 ± 0.05 KGF-CM
HTC CONFIDENTIAL
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
20 of 70
ASSEMBLE KEYBOARD UPPER COVER ONTO
LCD BOTOOM COVER AND FASTEN 4 SCREWS
ON IT.
NOTE: SCREW TORQUE 1.2 ± 0.05 KGF-CM
ATTACH
ALPHABETIC
KEYPAD
KEYBOARD UPPER COVER.
PREPARE SPEAKER AND SOUND BOX.
HTC CONFIDENTIAL
ONTO
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
21 of 70
ATTACH SPEAKER INTO SOUND BOX.
MAKE SURE THE SPEAKER IS ATTACHED IN THE
CORRECT DIRECTION.
PREPARE CAMERA MODULE AND MAIN BOARD.
ATTACH CAMERA MODULE INTO CAMERA
SOCKET ON THE MAIN BOARD (BE CAREFULL
WITH CAMERA AND SOCKET DIRECTION)
INSTALL CAMERA SHIELDING
HTC CONFIDENTIAL
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
22 of 70
SLIDE THE KEYBOARD BOTTOM COVER TO THE
CENTER POSITION.
CONNECT
THE
RIGID-FLEX
CONNECTOR WITH THE MAIN BOARD.
BOARD
PREPARE SOUND BOX
ATTACH SOUND BOX ONTO THE MAIN BOARD
FASTEN SCREW LOCATION NO.1 AND 2 WITH
FIG.2 SCREW THEN FASTEN SCREW LOCATION
NUMBER 3 WITH FIG. 1 SCREW.
NOTE: 1. SCREW TORQUE 1.0 ± 0.05 KGF-CM
(FIG.2)
2. SCREW TORQUE 0.4 ± 0.05 KGF-CM (FIG.1)
HTC CONFIDENTIAL
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
23 of 70
ATTACH MICROPHONE RUBER ONTO THE
MICROPHONE.
INSTALL VIBRATOR INTO KEYBOARD BOTTOM
COVER.
ASSEMBLE KEYBOARD BOTTOM COVER, START
FROM THE USB CONNECTOR SIDE.
PRESS THE AREA AROUND THE KEYBOARD
BOTTOM COVER TO FIX THE
BOTTOM AND UPPER COVER.
KEYBOARD
PREPARE THE “SCREWS”.
FASTEN TWO SCREWS ON THE KEYBOARD
BOTTOM COVER.
NOTE: SCREW TORQUE 1.0 ± 0.05 KGF-CM
HTC CONFIDENTIAL
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
24 of 70
PREPARE “ANTENNA RUBBER”.
INSERT THE ANTENNA RUBBER INTO THE
HOLE.
BE CAREFUL WITH THE DIRECTION.
PREPARE “BATTERY”
ALIGN THE EXPOSED METAL CONTACTS ON
THE EDGE OF THE BATTERY WITH THE PRONGS
IN THE BODY OF THE PHONE.
PUSH THE BOTTOM OF THE BATTERY INTO
PLACE.
PREPARE “BATTERY COVER”
HTC CONFIDENTIAL
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
25 of 70
REPLACE THE BATTERY COVER
ASSEMBLY PROCESS IS DONE, DEVICE IS
READY FOR INSPECTION
HTC CONFIDENTIAL
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
VOX Service Manual
Page
26 of 70
2.2 Disassembling procedure
SLIDE THE BATTERY COVER DOWN TO OPEN
IT
REMOVE THE BATTERY BY LIFTING IT UP
FROM THE BOTTOM END.
LOOSEN TWO SCREWS FROM KEYBOARD
BOTTOM COVER.
INSERT THE FLAT PLASTIC STICK BETWEEN
THE KEYBOARD BOTTOM AND UPPER COVER
THEN FOLLOW THE LEFT PICTURE TO
SEPARATE THE KEYBOARD BOTTOM COVER.
(DON’T DO THIS STEP TO THE BOTTOM PART /
USB CONNECTOR SIDE)
HTC CONFIDENTIAL
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
27 of 70
TAKE THE VIBRATOR OUT FROM KEYBOARD
BOTTOM COVER.
REMOVE MICROPHONE RUBBER.
LOOSEN AND TAKE OUT THREE SCREWS
FROM SOUND BOX AS SHOWN ON THE LEFT.
SLIDE THE KEYBOARD UPPER COVER TO THE
CENTER POSITION
THEN DISCONNECT
RIGID-FLEX BOARD CONNECTOR FROM THE
MAIN BOARD.
REMOVE ALPHABETIC KEYPAD.
LOOSEN 4 SCREWS FROM KEYBOARD UPPER
COVER.
HTC CONFIDENTIAL
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
28 of 70
OPEN MICROSD AND SIM CARD DOOR.
LOOSEN 6 SCREWS FROM DISPLAY BOTTOM
COVER.
INSERT THE FLAT PLASTIC STICK BETWEEN
THE DISPLAY BOTTOM AND UPPER COVER
THEN FOLLOW THE LEFT PICTURE TO
SEPARATE THE DISPLAY BOTTOM COVER.
TURN THE DISPLAY BOTTOM COVER ABOUT
30 DEGREE TO LET THE RIGID-FLEX BOARD
CONNECTOR PASS TROUGH.
TAKE OUT THE DISPLAY BOTTOM COVER.
REMOVE KAPTON TAPE ON THE TWO
LOCATION AS SHOWN ON THE LEFT PICTURE.
DISASSEMBLE “KEYPAD FPC”
HTC CONFIDENTIAL
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
29 of 70
DISASSEMBLE MICROSD COVER RUBBER.
DISASSEMBLE LCD FPC.
TAKE THE RIGID-FLEX BOARD OUT FROM THE
BEZEL (INCLUDING THE RECEIVER)
REMOVE KAPTON TAPE AND DISCONNECT
THE RECEIVER.
REMOVE THE EMI GASKET AS SHOWN ON
THE LEFT PICTURE.
TAKE THE LCD OUT FROM THE DISPLAY
UPPER COVER.
HTC CONFIDENTIAL
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
30 of 70
DISASSEMBLE NUMERIC KEYPAD AS SHOWN
ON THE LEFT.
SEPARATE THE NUMERIC KEYPAD AND
NUMERIC KEYPAD FPC.
UN-INSTALL SPEAKER FROM SOUND BOX.
LOOSEN 4 SCREWS TO SEPARATE
SLIDER-HINGE AND DISPLAY BOTTOM COVER.
REMOVE CAMERA SHIELDING.
USE SPECIAL TOOL AS SHOWN ON THE LEFT
BELLOW AND FOLLOW BELOW STEP TO
UN-INSTALL CAMERA MODULE
HTC CONFIDENTIAL
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
A01
Page
31 of 70
DISASSEMBLY PROCESS IS DONE
HTC CONFIDENTIAL
REV.
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
A01
VOX Service Manual
Doc. Title
REV.
Page
32 of 70
3. DIAGNOSTICS PROGRAM AND WINCE TEST ITEM
3.1 Test Plan
Mode
No
Item
Function Test
1 Auto Test
2 SDRAM Test
3 Display Test
4 LED Test
5
Key Test
Description
Full functions test automatically.
RAM memory test.
Color bar/R/G/B/Black/White/Gray pattern.
Green/Red/Blue/Key Pad.
Soft1/Soft2/Home/Back/Talk/End/5-way Navigation/
Remark
NA
Numeric / Alphabetic Keypad/Vol Up-Down/ESG /PC/
Diagnostic
Power/Camera, SIM door
WinCE
Mode
6 B. L Test
7 Timer Test
8 SD Card Test
9 Checksum Test
10 Battery Test
11 Vibrator
12 Speaker Play Test
13 Receiver Play Test
14 Headset Play Test
15 Int. Rec-Spk out Test
16 HST Rec-HST out Test
Run-in Test
1 1 Hour
2 2 Hours
3 4 Hours
4 8 Hours
Unit Information Check
Format Storage
No
Item
1 USB Test
2 Camera Test
3 Bluetooth Test
4 Wifi Test
HTC CONFIDENTIAL
Front light test (Dim/High/Off).
RTC (Real time clock) test.
SD card Read/Write test.
ROM checksum test.
Battery info check.
Vibrator on test.
Speaker out test.
Receiver out test.
Headset out test.
Internal MIC record and play to Speaker test.
External MIC record and play to Headset test.
1 Hour Run-in Test
2 Hours Run-in Test
4 Hours Run-in Test
8 Hours Run-in Test
NA
NA
NA
Option
Option
Option
Option
Description
USB link test (Microsoft ActiveSync).
Picture capture test.
Bluetooth test.
Wifi Test
Remark
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
A01
VOX Service Manual
Doc. Title
REV.
Page
33 of 70
3.2 How to enter diagnostic mode and boot-loader mode
Power OFF.
Insert Diagnostic Micro SD card (provide by HTC) to device.
Press and hold “Camera + Power” button simultaneously then release the power button first after
hold for about 1 seconds, and then the device will enter boot-loader mode.
On the test menu, use Navigation key to select the item then press Action key to test, and you could
use numeric key also to select the test item. Use Right/Left to change to go to the next page.
Remove the battery directly to exit the Diagnostic program when finish the testing.
If the system fails while testing, please also remove the battery directly to turn the power off.
HTC CONFIDENTIAL
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
3.3 Test Procedure
A.
Diagnostic test menu.
B.
Display test screen.
-
Color bar pattern.
-
Red pattern.
HTC CONFIDENTIAL
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
34 of 70
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
D.
-
Green pattern.
-
Blue pattern.
-
Black pattern.
-
White pattern.
QWERTY test screen
HTC CONFIDENTIAL
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
35 of 70
.
Doc. Title
C.
LED
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
LED test screen.
RED>GREEN>BLUE>WLAN>
BLINKING BLUE AND WLAN LED
>DIAL>FUNC>CAPS>QWERTY
Press<Act> to next
D.
Button test screen.
E.
SD Card Test
HTC CONFIDENTIAL
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
36 of 70
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
F.
Vibrator test screen.
G.
ROM checksum test screen.
H.
Slide and SIM door test screen.
I.
Speaker play test screen.
HTC CONFIDENTIAL
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
37 of 70
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. Title
J.
Receiver play test screen.
K.
Headset play test screen.
L.
Int. Record – SPK out test screen.
[Note]
The
recording
path
of
normal
distance for internal microphone is
around 15 to 30 cm.
M.
Ext. Record – Hst out test screen.
[Note]
The
recording
path
of
normal
distance for internal microphone is
around 15 to 30 cm.
HTC CONFIDENTIAL
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
38 of 70
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
VOX Service Manual
N.
Run-in test screen.
O.
Device information test screen.
P.
Format storage test screen.
Q.
USB link test screen (ActiveSync)
-
R.
Start->ActiveSync.
Bluetooth test screen.
-
Start->Settings->Connections
->Bluetooth->Bluetooth
S.
Camera test screen.
-
Start->Camera.
HTC CONFIDENTIAL
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
39 of 70
.
Doc. Title
T.
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Wi-Fi test screen.
- Start->Settings->Connections
-> WLAN Settings->Wi-Fi
HTC CONFIDENTIAL
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
40 of 70
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. Title
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
41 of 70
4. LEAKAGE CURRENT MEASUREMENT
Equipment need:
B
A
A. Power Supply (set at 4 V /1A).
B. Micro-Current Meter (support 0.5mA ~ 1A).
2. Fixture needed:
C. Cable
D. Battery with extension cable
E. Current series jig.( with black and red
cable)
3. Connect cable (C) to positive polarity of
power supply (A) and current meter (B)
HTC CONFIDENTIAL
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
42 of 70
4. Connect cable of fixture( E ) to negative
polarity of power supply (A) and current
meter (B)
5. Setting is Ready now for testing
( Don’t turn the power on at this moment )
6.Turn on power supply ( 4V) and current
meter ( 2A)
Unit setting:
* Flight mode
* Turn off Bluetooth
* Turn off Wi-Fi
HTC CONFIDENTIAL
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. Title
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
43 of 70
7. Measure flight mode current (condition:
Display & BL off/RF off/BT off)
Wait about 15 sec, back light will be off and
after 30 sec display will be off as well, in this
condition, please check current value on the
current meter.
Current value must be under TBD mA, if
over, it means M/B failed, please replace M/B
for repair.
8. Measure power off current
Check current value on the current meter,
Current value must be under 0.1 mA, if over,
it means M/B failed, please replace M/B for
repair.
Conclusions
If above measurement results are Pass both in
flight mode and power off mode, then the Main
board is judged as normal (Good)
If any of measurement modes is FAILED,
please replace the main board.
HTC CONFIDENTIAL
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
A01
VOX Service Manual
Doc. Title
REV.
44 of 70
Page
5. COSMETIC INSPECTION CRITERIA
5.1
Definition of Cosmetic Standard
5.2
5.3
Standard is for refurbishment inspection.
Visual Inspection Requirements
Examination of the device shall be made with workbench light turned on.
Ambient illumination is to be 500-1000 Lux.
The inspector shall examine the device at a distance of 30cm ±45degrees.
Inspection time: 2 seconds per surface.
Definitions of Inspection Defects and Areas
Scratch:A linear cut that penetrated beyond the surface of the material / a scratch can be felt by
running your finger over it.
Dot / Dent:A recessed spot or void in the surface of the material.
Lint: A linear foreign object beyond the surface of the LCD.
D: Diameter/ L: Length/ W: Width/ N: Number of defects/ S: Distance of dot to dot.
Area A: The front side of main unit.
Area B: Alphabetic keyboard area.
Area C: Five sides of device (Top, Bottom, Left, Right and Back view).
Area D: Internal area covered by battery cover and internal side of battery cover.
Area A
HTC CONFIDENTIAL
Area B
Area C
Area D
.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
45 of 70
Page
Cosmetic Criteria Table
Main unit inspection:
Description
Criteria
Area A
1.Exposure of substratum is not acceptable
2.Scratch : L 4mm ,W 0.2mm ,N 2 (ACCEPT), S 10mm
Area B
1.Exposure of substratum is not acceptable
2.Scratch : L 7mm ,W 0.25mm ,N 3 (ACCEPT), S 10mm
3. Unconscious scratch on IR window is ignored.
4.IR window conscious scratch: L 3mm,W 0.2mm,N 3 (ACCEPT)
5.Bright mark area should be less than 1 mm x 10 mm
Area C
1. Label area could be ignored..
2. Exposure of substratum is not acceptable.
3.Scratch : L 10mm ,W 0.4mm ,N 5 (ACCEPT), S 5mm
Area D
1. No broken, no interfere
2. No foreign particle
3. Surface rub scratch < 1cm2
4. Battery, SIM or microSD pin connector deform is not allowed
LCM inspection:
-
Electrical characteristic inspection standard
Symptom
Single
Bright Dots
Dark Dots
Standard
N 0
3 or more adjacent
N=0
Single
2 adjacent
Dark or Bright lines
All Allowable Dots Defects
Distance between defect dots
Red+ Green+ Blue
2 adjacent
Total Number
3
S 5 mm
2
S 5 mm
3
S 5 mm
N 0
N=0
Total Number
2 adjacent of dark dot and bright dot shall be counted as 1 bright dot.
* The total of LCM defect number must be less than 3 counts.
HTC CONFIDENTIAL
REV.
A01
VOX Service Manual
Doc. Title
5.4
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. No.
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. Title
6. OS, GSM ROM IMAGE RE-FLASH PROCEDURE
6.1
OS upgrade trough RUU
Requirement:
Windows 2000/XP.
Microsoft ActiveSync 4.5 or above.
USB Cable.
Firmware.
Procedure:
•
Boot up the device and entry WinCE mode.
•
Select “Allow USB connections” in Microsoft
ActiveSync.
•
Connect your device to desktop or laptop via
USB cable.
•
Check the pop-up message from Microsoft
ActiveSync when device is synchronized with
PC.
•
Execute RUU program from your PC.
HTC CONFIDENTIAL
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
46 of 70
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
•
VOX Service Manual
Read the pop-up message form ROM update
utility.
•
Click “Next” to proceed.
On the Welcome Screen, select the
“I
understand…” checkbox then click Next to
begin the ROM update installation
On the next screen, follow the listed
instructions in the dialog box first and select
the “I completed…” checkbox. When you
are done, click Next to proceed.
Note: You should read and follow all the
instructions listed before clicking Next.
HTC CONFIDENTIAL
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
47 of 70
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
The following message will then be
displayed, indicating that the utility is
verifying and acquiring information about
the device as preparation for the update
process. Wait for this verification process to
finish.
Current information about the device, such
as the model ID, image version and
language will then be displayed. Click
Update to proceed.
The information about the new ROM update
will then be displayed. If you are certain that
you want to install the Mobile Device with
the new ROM update, click Next to proceed
HTC CONFIDENTIAL
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
48 of 70
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
A confirmation message then appears and
shows the length of time it will take to copy
the necessary files (including radio image)
to the device. Click Next to begin the
update.
A progress bar will run through the screen
during the update process.
Note: In the middle of the update process,
the progress bar may stop running. This is
normal as the RUU is adjusting itself to
complete the update process automatically.
When you see the screen below, it means
update is complete. Click Finish to exit the
utility.
The OS update is completed.
HTC CONFIDENTIAL
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
49 of 70
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. Title
6.2
•
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
A01
Page
50 of 70
OS upgrade trough CD card procedure
Prepare a micro SD card and format as
FAT32 by your PC.
•
Copy image file XXX.nbh to the micro SD
card and rename to Vox0img.nbh.
Vox0img.nbh
•
Put this micro SD card in your device and
enter Boot-Loader mode.
•
Press
the
“Camera
+
Power”
button
simultaneously and release the Power button
first after hold for 2 seconds, and then the
device will enter boot-loader mode.
•
When enter boot-loader mode and see the
download message, follow the instruction on
display for download process.
HTC CONFIDENTIAL
REV.
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
51 of 70
7. GENERIC TROUBLESHOOTING
(1) Power related:
No Power / Can Not Boot
1. Charge the device or boot the device using AC adapter and check if work.
2. If Charge LED is not ON, fuse might be open, replace one.
3. If device stay in boot loader mode (Four color display), link device with PC and execute RUU.
4. Check battery connector with no damage
5. Check if LCM is connected properly.
6. Replace MB.
Cannot hold charge (low standby/operation)
1.
Check leakage current measured should be within spec.(Refer Chapter Leakage current measurement)
2.
Ensure abnormal current measured is not caused by camera.
3.
Replace MB.
Cannot charge
1.
Attach AC adapter, Charge LED has no indication.
2.
Check battery connector if damage
3.
Ensure charge LED is good (not defective)
4.
MB defective
5.
Device accessory such as AC adapter, battery defective.
Cannot switch off the phone
1.
Press power button for 3 seconds.
2.
Reset phone (Remove and re-attach the battery)
3.
Perform clear storage (all user data will be lost) by following either process 1 or process 2:
Process 1
>Power off device
>Hold APP1 (Start key) + APP2 (Contacts key) + Power button simultaneously around 3 seconds, and
release power button first.
Process 2
In Windows mode go to Setting>Accessory>Clear storage
Device will back to factory default and rebuild its configuration.
HTC CONFIDENTIAL
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
VOX Service Manual
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
A01
Page
Continue page for cannot switch off device:
4. Perform OS Re-flash
5. Possibly MB defective
Power off during operation
Power off automatically
1. Battery power runs out.
2. Battery cannot hold charge
3. MB defective
Shutdown immediately in anytime
1. Battery defective
2. MB defective
(2) Communication
USB port failure
1. Check connection setting in activesync.
2. Check cable is connected properly.
3. USB cable is defective
4. Connector in MB is defective
5. Replace MB
Defective IR
1. Ensure port is clean and within allowed distance
2. MB is defective.
(3) Audio
Dump speaker (No sound heard from internal speaker)/ Speaker faulty
1. Check the setting (sound, profile)
2. Something (foreign particle) stuck in audio jack.
3. Check pads of connecting speaker to PCB are clean.
4. Check speaker spring/pin is not bent or broken
5. Speaker is defective
HTC CONFIDENTIAL
REV.
52 of 70
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. Title
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
A01
Page
6. MB is defective
Microphone does not work (Defective recording)
No voice is recorded
1. Please check if any damage on microphone.
2. Microphone defective
3. MB is defective
Voice note function does not work under OS.
1. Perform Clear storage
2. Re-flash OS
Noisy, sound deformed during recording
1. Microphone defective
2. MB is defective
(4) Others
Camera malfunction
1.
Verify that the camera module is assembled properly.
2.
Ensure to tear off the protect film before testing.
System Hang on Booting
Reboot the device (Remove the battery and install it again)
Abnormal display
1.
Ensure device is not coming with liquid damage (check water indicator)
2.
Ensure device is not dismantled (abuse)
3.
Check LCM connection
4.
Replace LCM if necessary
5.
Replace Rigid-Flex board if necessary
HTC CONFIDENTIAL
REV.
53 of 70
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. Title
6.
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
54 of 70
Replace Main Board if necessary.
Buttons Do Not Respond
1.
Dismantle the unit, check the status of switches on the Main Board and the plastic parts of button of
the Button not responding.
2.
Try with another Main Board, rigid-Flex or keypad.
3.
Replace Main Board, rigid-Flex or keypad if necessary.
4.
Once the defective part has been identified, verify it again with the defective part whether the symptom
could be duplicated.
5.
Hard Reset The unit.
HTC CONFIDENTIAL
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Doc. Title
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
A01
Page
55 of 70
8. GENERIC SPARE PART LIST AND PICTURES
Item
Number
1
35H00082-00M
2
36H00486-00M
3
36H00523-00M
4
5
6
36H00524-00M
51H00386-00M
51H10053-00M
7
54H00211-00M
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
60H00087-00M
71H01810-00M
72H01548-00M
72H01875-00M
72H01876-00M
72H01889-00M
72H01892-00M
72H01893-00M
72H01894-00M
73H20099-41M
74H00816-00M
74H00817-00M
74H00818-00M
74H00819-00M
74H00820-00M
74H00822-00M
74H00823-00M
74H00824-00M
76H01719-00M
76H01721-00M
76H01723-00M
76H01724-00M
76H01728-00M
76H01729-00M
76H01730-00M
76H01777-00M
76H01778-00M
77H00474-00M
76H01734-00M
77H00460-01M
HTC CONFIDENTIAL
REV.
Description
BATTERY_LI-POLYMER,1050mAh,3.7V,A94CA010F,SIMPLO,60/20degC,54.1*39.7*5.25mm
Speaker,MERRY,DSH962-002
Vibrator,JT0406-30CSR1,JNTECH,Cylindrical,3V,100mA,12000+/-3000 rpm,60/20degC,11.2*5.1*5.8mm
Receiver,DTR882-002,MERRY
PCBA-MAIN BOARD,w/WIFI,Mega SIM,EU,VOX
Rigid-Flex Board ASSY,VOX
Camera Module,DCM-200MES,LITE-ON SEMICONDUCTOR,SOC2020
sensor,9*9*5.65mm,Vox
TFT-LCD Module,TX06D10VM0AAA,HITACHI,59.3*42.6*2.25mm
Cover,Battery,CHEW CHIENG,VOX
Screw,POINT SCREW,KH-M16-L14-NI,Libra
Shielding,Camera,JUN-YEN,Vox
Screw,M1.6,KH,D2.5*3,NI+NYLOK
EMI Gasket,LCD,CATERON,Vox
Screw,PHK14*3.8,BLACK
Screw,FPHM1.4-0.3*3.3(2.45,0.3),AISI-1018,BLACK
Screw,HAMA NAKA SHOUKIN,PH M1.6,T6,3.2D*4L,Nickel(Silver)
FPC Pre-Assy,numeric FPC,GLOBAL FLEX,VOX
Bezel Pre-Assy,Display bottom cover assy,CHEW CHIENG,VOX
Bezel Pre-Assy,keyboard upper cover assy,VOX
Bezel Pre-Assy,Display upper cover assy,CHEW CHIENG,VOX
Bezel Pre-Assy,keyboard bottom cover assy,CHEW CHIENG,VOX
Sound Box Pre-Assy,VOX
Slider-Hinge Pre-Assy,Semi-Auto,VOX
Keypad Pre-Assy,QWERTY KEY,VOX
Keypad Pre-Assy,Number key,VOX
ME Gasket,qwerty mylar,Vox
Rubber,Silicon,Microphone,VOX
Rubber,TPU,Micro-SD cover,UNITEL,VOX
Rubber,Silicon,B to B,5.5*2.5*0.85mm,VOX
Tape,RF_BD,insulation,T-TEK,VOX
Mylar,main-pcb-TP,FR1,VOX
Tape,LCDFPC,insulation,T-TEK,VOX
ME Gasket,Soundbox,Vox
Rubber,Silicon,A-Metal,Vox
Water Sensitive Label,5*5mm,MING JYE,ATLAS
Rubber,external antenna,UNITEL,VOX
Tamper-Evident Label,VOID wording,black background,3*3mm,MING JYE
Qty
1
1
1
1
1
1
1
1
1
8
1
1
1
2
4
4
1
1
1
1
1
1
1
1
1
2
1
1
2
2
1
1
1
1
1
1
1
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
A01
VOX Service Manual
Doc. Title
Page
Pictures
Part no
74H00817-00M
Part no
Desciption
Keyboard upper
cover assy
Desciption
73H20099-41M
Numeric FPC PreAssy
Quantity
1
Quantity
1
Part no
74H00816-00M
Part no
74H00822-00M
Desciption
Display bottom
cover assy
Desciption
Slider-Hinge PreAssy
Quantity
1
Quantity
1
Part no
74H00818-00M
Part no
72H01876-00M
Desciption
Display upper
cover assy
Desciption
Screw
Quantity
1
Quantity
1
Part no
74H00819-00M
Part no
74H00820-00M
Desciption
Sound Box PreAssy
Desciption
Keyboard bottom
cover assy
Quantity
1
Quantity
0.001
Part no
74H00824-00M
Part no
76H01723-00M
Desciption
Numeric Keypad
Quantity
HTC CONFIDENTIAL
1
Desciption
Quantity
REV.
Micro-SD Cover
Rubber
1
56 of 70
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
Desciption
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
71H01810-00M
Battery Cover
Page
Part no
35H00082-00M
Desciption
BATTERY_LIPOLYMER
1050mAh,3.7V
Quantity
1
Quantity
1
Part no
74H00823-00M
Part no
51H00386-00M
PCBA-MAIN
BOARD
Desciption QWERTY Keypad
Desciption
Quantity
1
Quantity
1
Part no
54H00211-00M
Part no
51H10053-00M
Desciption
Camera Module
Desciption
Rigid-Flex Board
Quantity
1
Quantity
1
Part no
60H00087-00M
Part no
72H01548-00M
Desciption
TFT-LCD Module
Desciption
Screw
Quantity
1
Quantity
8
Part no
72H01875-00M
Part no
36H00486-00M
Desciption
Camera Shielding
Desciption
Quantity
1
Quantity
Part no
36H00523-00M
Part no
Desciption
Vibrator
Desciption
Speaker
1
Receiver
Quantity
1
Quantity
1
Part no
76H01721-00M
Part no
77H00474-00M
Desciption
Water Sensitive
Label
Desciption
Microphone
Rubber
Quantity
HTC CONFIDENTIAL
1
Quantity
REV.
A01
VOX Service Manual
Doc. Title
Part no
Doc. No.
1
57 of 70
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
Desciption
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
72H01892-00M
Screw
Page
Part no
Desciption
72H01893-00M
Screw
Quantity
2
Quantity
4
Part no
72H01894-00M
Part no
76H01724-00M
Desciption
Screw
Desciption
B to B Silicon
Rubber
Quantity
4
Quantity
2
Part no
76H01734-00M
Part no
77H00460-01M
Desciption
Tamper-Evident
Label
Desciption
External Antenna
Rubber
Quantity
1
Quantity
1
Part no
72H01889-00M
Part no
76H01728-00M
Desciption
EMI Gasket,LCD
Desciption
Tape, RF_BD
Quantity
1
Quantity
2
Part no
76H01729-00M
Part no
76H01730-00M
Desciption
Tape, LCD FPC
Desciption
Main-PCB-TP
Mylar
Quantity
1
Quantity
1
Part no
76H01777-00M
Part no
76H01719-00M
Desciption
ME Gasket,
Soundbox
Quantity
HTC CONFIDENTIAL
1
Desciption
Quantity
REV.
A01
VOX Service Manual
Doc. Title
Part no
Doc. No.
ME Gasket,
qwerty mylar
2
58 of 70
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
VOX Service Manual
APPENDIX
A.GENERIC LABELING PLAN
1. Agency label
1.1.1 Agency label_VOX0101
HTC P/N: 77H00477-00M
Size: 50.54 X 38.75mm
HTC CONFIDENTIAL
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
59 of 70
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
1.1.2 Agency label_VOX0110
HTC P/N: 77H00477-01M
Size: 50.54 X 38.75mm
HTC CONFIDENTIAL
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
60 of 70
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
1.2 Unit label location explanation
Water sensitive label
HTC P/N: 77H00474-00M
Qty: 1
Tamper evident label
HTC P/N: 77H00460-01M
Qty: 1
HTC CONFIDENTIAL
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
61 of 70
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
1.3 Screen Protector
HTC P/N: 76H01681-00M
Size: 53.65 X 57.5mm
HTC CONFIDENTIAL
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
62 of 70
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
2. FRU label
2.1. IMEI Label for all Main Board Bulk PKG
HTC P/N: 77H00019-00
Size: 25.0 × 10.0 mm
Label Characteristic:
Material: Hi Fi printing paper
Color: pantone White
Ink: B110
HTC CONFIDENTIAL
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
63 of 70
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
A01
VOX Service Manual
2.2 FRU Box label (Bulk Packing)
HTC P/N: 77H30026-00M
Size:152.4 × 101.6 mm
Remark: Please refer above label description on the next page
Label Characteristic:
Material: Hi Fi printing paper
Color: pantone White
Ink: B110
HTC CONFIDENTIAL
REV.
Page
64 of 70
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Invoice
Carton
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
A01
65 of 70
Page
Shipping
Product
Description
Quantity
Note: Above printing contents is just for reference only
HTC CONFIDENTIAL
REV.
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
VOX Service Manual
2.3 FRU Pallet ID label
HTC P/N: 77H30026-00M
Size:101.6 × 152.4 mm
Label Characteristic:
Material: Hi Fi printing paper
Color: pantone White
Ink: B110
HTC CONFIDENTIAL
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
66 of 70
宏達國際電子股份有限公司
High Tech Computer, Corp.
.
Doc. Title
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
A01
VOX Service Manual
Page
67 of 70
B. RF Antenna Test Specification
Items
Test Name
TxLevel
TCH
lst Downlink
CellPower
Note
1
Camp @ DCS Band
0
512
-75
BCCH=600
2
BS Originate Call
0
512
E-GSM 900 ReceiverTest
5
975
5
42
5
124
E-GSM 900 Ttansmitter Test
5
975
5
975
5
975
5
42
5
42
5
42
5
124
5
124
5
124
5
975
5
42
5
124
DCS 1800 ReceiverTest
0
512
0
698
0
885
DCS 1800 Ttansmitter Test
0
512
0
512
0
512
0
698
0
698
0
698
0
885
0
885
0
885
0
512
0
698
0
885
PCS 1900 ReceiverTest
-75
3
4
5
Fast Bit Error Rate
Fast Bit Error Rate
Fast Bit Error Rate
6
7
8
9
10
11
12
13
14
15
16
17
TX Phase RMS Error
TX Phase Peak Error
TX Frequency Error
TX Phase RMS Error
TX Phase Peak Error
TX Frequency Error
TX Phase RMS Error
TX Phase Peak Error
TX Frequency Error
Check TX Power
Check TX Power
Check TX Power
1
2
3
Fast Bit Error Rate
Fast Bit Error Rate
Fast Bit Error Rate
4
5
6
7
8
9
10
11
12
13
14
15
TX Phase RMS Error
TX Phase Peak Error
TX Frequency Error
TX Phase RMS Error
TX Phase Peak Error
TX Frequency Error
TX Phase RMS Error
TX Phase Peak Error
TX Frequency Error
Check TX Power
Check TX Power
Check TX Power
HTC CONFIDENTIAL
REV.
-104
-104
-104
-75
-75
-75
-75
-75
-75
-75
-75
-75
-75
-75
-75
-104
-104
-104
-75
-75
-75
-75
-75
-75
-75
-75
-75
-75
-75
-75
.
宏達國際電子股份有限公司
High Tech Computer, Corp.
Doc. Title
1
2
3
Fast Bit Error Rate
Fast Bit Error Rate
Fast Bit Error Rate
4
5
6
7
8
9
10
11
12
13
14
15
TX Phase RMS Error
TX Phase Peak Error
TX Frequency Error
TX Phase RMS Error
TX Phase Peak Error
TX Frequency Error
TX Phase RMS Error
TX Phase Peak Error
TX Frequency Error
Check TX Power
Check TX Power
Check TX Power
1
2
3
Fast Bit Error Rate
Fast Bit Error Rate
Fast Bit Error Rate
4
5
6
7
8
9
10
11
12
13
14
15
TX Phase RMS Error
TX Phase Peak Error
TX Frequency Error
TX Phase RMS Error
TX Phase Peak Error
TX Frequency Error
TX Phase RMS Error
TX Phase Peak Error
TX Frequency Error
Check TX Power
Check TX Power
Check TX Power
C. BOARD LEVEL REPAIRS
HTC CONFIDENTIAL
VOX Service Manual
0
512
0
661
0
810
PCS 1900 Ttansmitter Test
0
512
0
512
0
512
0
661
0
661
0
661
0
810
0
810
0
810
0
512
0
661
0
810
GSM 850 ReceiverTest
5
128
5
189
5
251
GSM 850 Ttansmitter Test
5
128
5
128
5
128
5
189
5
189
5
189
5
251
5
251
5
251
5
128
5
189
5
251
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
-104
-104
-104
-75
-75
-75
-75
-75
-75
-75
-75
-75
-75
-75
-75
-104
-104
-104
-75
-75
-75
-75
-75
-75
-75
-75
-75
-75
-75
-75
68 of 70
.
Doc. Title
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
M/B TOP SIDE
RIGID-FLEX BOARD TOP SIDE
HTC CONFIDENTIAL
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
69 of 70
M/B BOTOM SIDE
RIGID-FLEX BOARD BOTOM SIDE
.
Doc. Title
Item
宏達國際電子股份有限公司
High Tech Computer, Corp.
VOX Service Manual
Part Number
Doc. No.
DOC- 00026415
Issued Date
2007/02/12
Revised Date
N/A
REV.
A01
Page
70 of 70
Description
Qty
1
75H00248-00M COAXIAL CONNECTOR,RF,WITH SWITCH,SMD,MM8430-2600RA1,MURATA
1
2
75H00276-00P
1
3
75H00465-01M Connector I/O,Reverse,11P,0.4mm Pitch,MJE21-11K7P21,ACON
1
4
75H00615-00M Connector Others,90mohm,24P,0.9Pitch,0.5A,60V,CAM-F94M09,MITSUMI
1
5
75H00633-00M Connector,Battery,4Pin,2.5mmPitch,250042MB004G315ZR,SUYIN
Connector B to B,80P,0.4Pitch,24 5801 080 002
75H00636-00P
829+,KYOCERA,Female,without position boss
1
36H00230-00M SWITCH,SOH-213HST,MITSUMI,70/-20degC
5
36H00440-00M Microphone,SPM0208HE5-SB,KNOWLES,100/-40degC,4.72*3.76*1.25mm
Connector B to
75H00535-00P
B,20P,0.4Pitch,0.5A,60V,70mohm,AXK720147G,MATSUSHITA,6.3*5.1*1.5mm
Connector B to C,female,2P,1.52mmPitch,KYOCERA,24-8005-502-10075H00572-00P
867+,receiver connector ,wire to board
75H00624-00M Connector FPC,39P,0.3pitch,0.2A,50V,DDK,FF12-.39A-R11B
1
6
7
8
9
10
11
12
13
14
15
16
Connector RF,5.8*5.4*3.9,Female,MS-147(06),4pin,HRS
75H00635-00M Connector SIM Card,8P,2.54 Pitch,4330816-SINR01,HAMBURG
Connector SD Card,8P,1.1Pitch,80mohm,0.5A,100V,s-060079,HONDA
75H00637-00M
TSUSHIN KOGYO,4.95*1.25*1.75mm
Connector B to B,80P,0.4Pitch,14 5801 080 012 829+,KYOCERA,Male,without
75H00638-00M
position boss
36H00522-00M Switch,DT24,ROKI
Gold Cap,0.07F,70ohm,3.3V,-25/+50%,XH414H
16H00012-00M
II02E,SEIKO,7.6*4.8*1.72mm,,70/-25degC
1
1
1
1
1
1
1
1
1
--------------------------------------------- END OF SERVICE MANUAL -----------------------------------------------------
HTC CONFIDENTIAL