JEEP / RAM .18
®
MOPAR PERFORMANCE TERMS AND CONDITIONS
NOTICE
Federal and many state laws prohibit the removal, modification or rendering inoperative
of any part or element of design affecting emissions or safety on motor vehicles used for
transporting persons or property on a public street or highway. Violation may result in a
fine of up to $32,500 per vehicle. Mechanical and/or electronic performance parts listed
in this catalog with a “1” cannot be used on vehicles used on public streets or highways.
These parts may be used only on vehicles used solely in sanctioned off-highway events. No other applications
are intended or implied. Those parts that have been granted an exemption by the California Air Resources Board
(CARB) or meet the EPA requirements of memorandum 1A are legal for highway use in California, New York, and
Massachusetts and are noted as such.
NO PARTS WARRANTY – “AS IS”
Mopar Performance parts beginning with a “P” prefix are sold “as is” unless otherwise noted. This means that
parts sold by Mopar Performance carry no warranty whatsoever. Implied warranties, such as warranties of merchantability, are excluded. (An implied warranty of merchantability means that the part is reasonably fit for the
general purpose for which it was sold). The entire risk as to quality and performance of such parts is with the
buyer. Should such parts prove defective following their purchase, the buyer and not the manufacturer, distributor
or retailer, assumes the entire cost of all necessary servicing or repair. Chrysler, Jeep® , Dodge and Ram vehicle
and parts warranties are voided if the vehicle or parts are used for competition. The addition of performance parts
does not by itself void a vehicle’s warranty. However, added performance parts (parts not originally supplied on
the vehicle from the factory) are not covered by the vehicle’s warranty, and any failure that they may cause is also
not covered by the vehicle’s warranty.
MOPAR PERFORMANCE CRATE ENGINE 90-DAY LIMITED WARRANTY
Mopar Performance Crate Engine Assemblies not used in competition are warranted for “parts only,” AS DELIVERED against defects in materials or workmanship for 90 days from the date of purchase. The following parts, if
defective, will be replaced on an exchange basis for 90 days: engine blocks and all internal parts; cylinder head
assemblies; intake manifold; core plugs; valve covers; oil pan; timing gear; water pump; gaskets and seals. See
your dealer for a copy of the limited warranty, which contains additional terms and limitations.
MOPAR PARTS 12-MONTH LIMITED WARRANTY
Except parts as listed above, certain parts from Mopar Performance sold over the counter or wholesaled are
warranted against defects in workmanship or materials for 12 months/unlimited miles for parts (exchange) only.
These parts are identified in this catalog as having a specific part number structure. Part numbers starting with
“P” are not covered under the 12-month warranty. Other parts listed in this catalog without a “P” prefix part number are covered under the 12-Month Limited Warranty described here. See your dealer for a copy of the limited
warranty, which contains additional terms and limitations. Parts installed on a Chrysler, Plymouth, Jeep® , Dodge
and Ram vehicle by an authorized Chrysler, Jeep® , Dodge and Ram dealer are warranted for 12 months/unlimited
miles for parts (exchange) only. See your dealer for a copy of the limited warranty, which contains additional terms
and limitations.
EMISSIONS STATEMENT
Federal law requires emissions parts on new vehicles to be warranted for at least two years or 24,000 miles,
whichever comes first. Federal and many state laws also prohibit the removal, modification or rendering inoperative any part that affects emissions or safety on motor vehicles used on public streets or highways. Many
Mopar Performance parts are designated for track use or off-road use only. Installation of certain components
may bring the vehicle out of compliance with safety and/or emissions standards. Mopar recommends that
vehicles with parts designated in this fashion not be operated on public roads. Mopar Performance customers
are responsible for complying with applicable state and local environmental regulations. Additionally, certain
performance parts may affect the emissions characteristics of the vehicle. If you install them on the vehicle,
and your vehicle consequently fails a required state or local I/M (inspection and maintenance) emissions
test, including any test required to maintain or renew your vehicle’s registration, or if your vehicle is subject
to an emissions recall, Chrysler Group LLC may not be required to repair your vehicle under the emissions
performance warranty, and you may be required to remove those parts at your own expense in order to obtain
repairs necessary to pass the I/M test or to perform the recall.
NOTE — CALIFORNIA ONLY
The emissions laws and regulations of the state of California apply to all non-racing vehicles operated in
California. Consequently, those parts marked in this catalog with a “1” and appropriately marked on their
packaging may legally be used in California only on a racing vehicle that will never be operated on public
roads.
PARTS ORDERING AND INQUIRIES
The parts in this catalog may be ordered from authorized Chrysler, Jeep® , Dodge and Ram dealerships or the
speed shops carrying the Mopar Performance line of products. When a part ordered has been superseded,
the replacing part will be shipped automatically. The price of the replacing part may differ from the ordered
part. All products, illustrations and specifications are based upon current information at the time of publication
approval. Although descriptions are believed correct, complete accuracy cannot be guaranteed. Chrysler
Group LLC reserves the right to make changes at any time, without notice or obligation, to the information
contained in this printed document, including and without limitation to prices, specifications, equipment,
colors, materials, and to change or discontinue products.
Select images in this catalog are used with permission of Mopar Nationals, Inc., Chrysler Historical Society, and the Walter P. Chrysler Museum.
TABLE OF CONTENTS
ENGINES . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Hemi®, Gen III . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
10
Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . .
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
Carburetors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transmission and Drivetrain . . . . . . . . . . . . . . . . . . . . . . . .
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
10
10
11
12
12
12
12
13
14
14
15
15
17
17
19
Hemi®, Gen II . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
22
Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Installation Components . . . . . . . . . . . . . . . . . . . . .
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .
Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . .
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
22
24
25
25
26
26
27
27
28
29
30
32
34
35
37
39
Big Block . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
42
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .
42
42
42
43
43
44
50
51
53
P. | 4
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
54
56
57
60
Small Block . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
64
Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
64
66
69
69
70
71
74
78
82
85
87
90
93
95
RESTORATION . . . . . . . . . . . . . . . . . . . . . . 100
Fuel Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
100
Carburetors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Pumps and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Vapor Separator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Six Pack Induction Systems . . . . . . . . . . . . . . . . . . . . . . . . .
Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Injection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
100
101
102
102
104
106
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . .
108
Distributors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . .
Electronic Ignition Systems . . . . . . . . . . . . . . . . . . . . . . . . .
Ballast Resistors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition Wires and Spark Plugs . . . . . . . . . . . . . . . . . . . . . .
Coils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Voltage Regulators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Alternators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
108
109
110
111
112
113
113
114
114
Automatic Transmission . . . . . . . . . . . . . . . . . . . . . . . . . .
116
Flex Plates and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifters and Shift Improvement Kits . . . . . . . . . . . . . . . . . . .
Automatic Transmission Components . . . . . . . . . . . . . . . . .
Transmission Overhaul Kits . . . . . . . . . . . . . . . . . . . . . . . . .
Transmission Pans and Hardware . . . . . . . . . . . . . . . . . . . .
116
116
116
118
119
TABLE OF CONTENTS
Torque Converters and Hardware . . . . . . . . . . . . . . . . . . . .
119
Manual Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . .
122
Flywheels and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bell Housing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Clutch Discs, Pressure Plates and Hardware . . . . . . . . . . .
Shifters and Shift Improvement Kits . . . . . . . . . . . . . . . . . . .
122
123
123
125
Drivetrain and Rear Axle Components . . . . . . . . . . . . . .
128
Universal Joint and Yoke Kits . . . . . . . . . . . . . . . . . . . . . . .
Rear Axle Components . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Differential Components . . . . . . . . . . . . . . . . . . . . . . . . . . .
128
129
130
Steering, Suspension, and Brakes . . . . . . . . . . . . . . . . . .
132
Leaf Springs and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Frame Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Torsion Bars and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Suspension Seals and Bushings . . . . . . . . . . . . . . . . . . . . .
Manual Steering Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Shocks and Struts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
132
135
135
135
136
136
136
Interior/Body . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
140
Underhood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Grilles and Headlamp Bezels . . . . . . . . . . . . . . . . . . . . . . . .
Hoods and Hood Components . . . . . . . . . . . . . . . . . . . . . .
Handles . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Trunk . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Racks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bumpers/ Bumperettes . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lamps and Lenses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sheetmetal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheelhouse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Valence . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emblems and Decals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheel Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
140
145
147
148
149
150
151
151
151
151
153
154
154
155
158
Transmission Components . . . . . . . . . . . . . . . . . . . . . . . . .
Suspension Upgrades and Components . . . . . . . . . . . . . . .
Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTS-R Engine Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . .
168
169
170
171
171
173
Eight-Cylinder Late Model Vehicles . . . . . . . . . . . . . . . . .
176
Electronic Control Modules . . . . . . . . . . . . . . . . . . . . . . . . .
Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . .
Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Suspension Upgrades and Components . . . . . . . . . . . . . . .
Drivetrain and Rear Axle Components . . . . . . . . . . . . . . . .
176
176
177
179
180
180
181
Four- and Six-Cylinder Late Model Vehicles . . . . . . . . . .
184
Turbo Service Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Engine Struts and Mounts . . . . . . . . . . . . . . . . . . . . . . . . . .
Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . .
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
Valve Train Hardware and Components . . . . . . . . . . . . . . .
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
Suspension Upgrades and Components . . . . . . . . . . . . . . .
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transaxle Components . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheel Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . .
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bearing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
184
185
186
186
186
186
187
187
188
188
192
194
195
196
197
197
198
198
198
RACING . . . . . . . . . . . . . . . . . . . . . . . . . . . . 202
CHRYSLER/DODGE . . . . . . . . . . . . . . . . . . 164
Viper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
164
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Viper SRT10 Power Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Differential Components . . . . . . . . . . . . . . . . . . . . . . . . . . .
164
164
165
165
166
167
Drag Racing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
202
LC22R Challenger Drag Pak Service Parts . . . . . . . . . . . . .
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gear Drives and Service Parts . . . . . . . . . . . . . . . . . . . . . .
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
Hemi Pro Stock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Race Bodies . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
202
203
207
207
207
208
208
208
P. | 5
TABLE OF CONTENTS
Sprint Car / Midget / Dirt Late Model . . . . . . . . . . . . . . . .
212
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
Valve Covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Gear Drives and Service Parts . . . . . . . . . . . . . . . . . . . . . .
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Books . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
212
212
213
214
214
215
215
215
216
217
217
NASCAR® / Late Model . . . . . . . . . . . . . . . . . . . . . . . . . . .
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
Oil, Fuel, and Water Pumps . . . . . . . . . . . . . . . . . . . . . . . . .
NASCAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Books . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
257
258
258
MISCELLANEOUS . . . . . . . . . . . . . . . . . . . 262
Performance Gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
262
Gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gauge Pods . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gauge Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
262
270
270
SilverStar Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
274
220
Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
274
220
220
221
221
221
223
223
223
223
224
Merchandise . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
278
Diecast . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Posters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Books . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fender Covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheel Covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Decals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
278
280
281
282
282
283
JEEP/RAM . . . . . . . . . . . . . . . . . . . . . . . . . . 230
Jeep/Ram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
230
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .
Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Suspension Upgrades and Components . . . . . . . . . . . . . . .
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Automatic Transmission Components . . . . . . . . . . . . . . . . .
Transmission/Transfer Cases . . . . . . . . . . . . . . . . . . . . . . .
Drivetrain and Rear Axle Components . . . . . . . . . . . . . . . .
Axle Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
230
230
230
230
231
231
232
232
232
233
234
238
241
242
252
253
254
255
256
P. | 6
Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . .
Hoods and Hood Components . . . . . . . . . . . . . . . . . . . . . .
Off Road Tools and Accessories . . . . . . . . . . . . . . . . . . . . .
JEEP/RAM
BLOCKS
A. Long Blocks
Need more power and low-end torque out of your 1991-06 Jeep Wrangler or
Cherokee inline six-cylinder engine? Mopar's new 4.7L Stroker Long Block
engine assembly is the solution to beef up the Jeep 4.0L I-6 for towing,
offroading, or rock crawling.
1
Block, Long, 4.7L Stroker, I6, 1991-97 Jeeps, 1998
P5155209
Cherokee/Wrangler
1
Block, Long, 4.7L Stroker, I6, 1999-04 Grand Cherokee,
P5155627
2000-06 Wrangler
1
Block, Long, 4.7L Stroker, I6, 2000-01 Cherokee
P5155210
ENGINE BLOCK HARDWARE
B. Engine Teardown Gasket Sets
All the gaskets needed for a complete engine teardown, including oil pan,
cylinder head, valve cover, timing chain cover, intake manifold, exhaust and oil
pump.
Gasket, Engine Teardown, 4.0L Jeep Engines, up to 1998
P4529245
A.
B.
C.
D.
E.
F.
TIMING CHAIN AND SPROCKETS
C. Timing Chain Tensioner
Stabilizes cam timing by reducing timing chain slack. Can be used instead of
Thrust Plate P5249637.
1
Timing Chain Tensioner, Small Block/ 3.9L/ 5.2L/ 5.9L
P5007709
Truck/Magnum/Jeep Engines
D. Double Roller Chain and Sprocket
High-strength Double Roller Chain and Sprocket Sets provide added durability
and decreased rotational friction compared to production silent chains. Sets
include Magna-Fluxed sprockets and roller timing chain.
1
Roller Chain and Sprocket, Double, 1-Bolt Mount, One
P5249519
Keyway, 2.5L/4.0L Jeep Engines up to 1998
VIBRATION DAMPERS
E. Vibration Damper
Compatible with production crankshaft and piston rod weight.
Vibration Damper, Production Replacement, V-Belt, 4.2L
P5249535
Jeep Engines
F. Damper Attachment Package
Contains all the parts necessary to attach the vibration damper to the crankshaft.
Hardware Kit, Damper, 2.5L/4.0L Jeep Engines
P4529677
P. | 230
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
JEEP/RAM
VIBRATION DAMPERS
A. Damper Degree Timing Tape
Improve timing accuracy with this Damper Degree Timing Tape. Marked in 90°
increments. Self-adhesive strip adheres to the crank vibration damper for clear
identification of marks. Permits initial total spark advance up to 60° instead of
only 10°-15° as on chain case timing tab.
P4529070AB Damper Degree Timing Tape
CAMSHAFTS, LIFTERS, AND HARDWARE
B. Camshafts
A.
Damper Not Included
Mopar Performance Camshafts are designed and engineered exclusively for
your engine. A wide range of profiles are available, from mild to wild. All
camshafts are developed, dyno'd and track-tested by Mopar engineers for
increased power and rpm potential while maintaining reliability and the best
possible low-speed characteristics, including torque and idle quality. Mopar
camshafts offer the best horsepower-to-dollar-spent value. Each package
contains the camshaft, camshaft lube, instruction sheet, and tappets.
1
P4529228AD Camshaft, Hydraulic, 4.0L Jeep Engines, up to 1998
.430/.430 Lift
1
P4529229AD Camshaft, Hydraulic, 4.0L Jeep Engines,.440/.440 Lift
B.
Note: For flat tappet camshafts, Mopar recommends the use of a high-zinc oil for
maximum performance.
C. Offset Camshaft Key
For centerlining your camshaft, these hardened keys are color coded in 1°, 2°,
3°, 4° and 5° increments. Production key is used for zero offset.
Camshaft Keys, Offset, 3.7L/ 3.9L/ 4.7L/ 5.2L/ 5.9L Truck
P5249600
Magnum/Jeep Engines
D. Hydraulic Flat Tappets
C.
1
D.
P4529220AB Tappet, Hydraulic, Small Block/ 2.5L/4.0L Jeep Engines,
Sold Individually
E. Pushrods
1
P4529675
Pushrod, 1987-89 4.0L Jeep Engines, Set of 12
CYLINDER HEADS, GASKETS, AND
HARDWARE
F. Cylinder Head Gaskets
1
E.
F.
F.
P4529242
Gasket, Cylinder Head, 4.0L Jeep Engines, Sold Individually
J
E
E
P
/
R
A
M
P4529242
P4876048
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
P. | 231
JEEP/RAM
ROCKER ARMS, SHAFTS, SUPPORTS, AND
HARDWARE
A. Rocker Arms, Roller
This single cylinder Roller Rocker Arm Set for Jeep vehicles includes two
rockers, two support stands, rocker shaft, and screws. Extruded, anodized
aluminum rockers. Can be used with hydraulic, mechanical or roller camshafts.
Roller tip and center pivot bearing reduce internal friction. Provides exact
geometry and 1.6:1 ratio. Adjustable, oil-through-pushrod-style. 2.5L and 4.0L
engines require aftermarket spacer for valve cover clearance.
1
Rocker Arm, Roller, 1.6:1 Ratio, Single Cylinder, 2.5L/ 4.0L/
P4529885
4.2L Jeep Engines
B. Rocker Arm, Heavy-Duty
Heavy-duty stamped rocker for use with hydraulic camshafts only. Can be used
to service stock Jeep® engines. Sold individually.
1
Rocker Arm, Roller, 2.5L/4.0L Jeep Engines
P4529221
VALVE COVERS AND HARDWARE
C. Valve Covers, Cast Aluminum, Black Wrinkle
A.
B.
C.
D.
Bold looking Black Wrinkle Cast Aluminum Valve Cover Sets for Mopar Magnum
trucks and Jeep vehicles. Magnum valve covers feature the Mopar Pentastar
Magnum logo, while the Jeep valve cover features the Jeep logo. Sets include
attaching screws, grommets, baffle and oil filler cap. Gaskets must be purchased
separately.
1
Valve Cover, Black Wrinkle, 1981-86 4.2L Jeep Engines
P4876388
1
P5007854
Gasket, Valve Cover, 4.2L Jeep Engines
VALVES AND VALVE TRAIN HARDWARE
D. Valve Spring Retainers
Restore worn or damaged valve train components to factory specifications with
these durable Valve Spring Retainers. Use with 7° locks. Features an 8 mm
valve stem diameter.
Retainer, Valve Spring, Chrome Moly, 7 Degree, 8mm Stem
P4452032
Diameter, Single, 2.2L/2.5L SOHC and 5.2L/5.9L Magnum
Engines
Retainer, Valve Spring, Jeep 4.2L and 5.9L Engines
P4529616
P4529217
Retainer, Valve Spring, Steel, use with Conical Springs
P4529215, 2.5L/4.0L Jeep Engines
E. Valves
These stainless steel Valves have swirl-polished underheads that have no flat or
ski jump areas. They feature an 8 mm stem and one square groove. Does not fit
P5153847 head.
1
Valve, Exhaust, 1.56" Diameter, 4.93" Stem Length,
P5249880
2.5L/4.0L Jeep Engines
E.
P. | 232
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
JEEP/RAM
VALVES AND VALVE TRAIN HARDWARE
A. Valve Springs
High-pressure Valve Springs can be used on exhaust and intake valves for all
high-performance applications. They feature a shorter fully-compressed height
and allow for increased valve lift. Springs maintain spring load at higher rpms. A
must for high-performance camshafts. With a single spring, the damper is
installed inside the main spring; with a dual spring, the damper is installed
between the inner and outer springs. There are no dampers in the triple springs.
The retainers listed are the basic recommendation. Check the actual retainer
listing for other options such as added installed height, materials and lock size.
Sold individually.
1
Valve Spring, Conical, 1988–02 2.5L/4.0L Jeep Engines
P4529215
1
P4529214
Valve Spring, Cylindrical, 1981–87 2.5L/4.0L Jeep Engines
B. Valve Seals
Made of high-temperature Viton material, these Valve Seals feature a full, or
semi-umbrella, shape for best dual-purpose use. Helps prevent oil seepage down
the valve guides. Not recommended for use with dual valve springs. Sold in sets
of 16.
1
Valve Seals, 8 mm Stem, 4.0L Jeep Engines
P4529240
A.
A.
C. Valve Keepers
These single-groove-style Valve Keepers are made from hardened steel. Each
features an 8° angle and an 8 mm stem diameter single groove. Used with
P4529616 and P4529217 retainers. They can be used for restoration or
performance applications. Sold in cylinder head sets of 16 (note that two sets are
required for all six-cylinder and V8 engines). Does not fit P5153847 Magnum
cylinder head.
1
Valve Keepers, For Retainers P4529216-17, 2.5/ 4.0L/ 5.2L/
P4529218
5.9L Truck Magnum/Jeep Engines
INTAKE MANIFOLDS, HARDWARE, AND
GASKETS
D. Intake/Exhaust Gaskets
Jeep six-cylinder engines use a common intake/exhaust manifold gasket design.
This gasket is designed for direct replacement (includes engine set).
Gasket, Intake/Exhaust Manifold, 4.0L Jeep Engines
P4529243
B.
C.
J
E
E
P
/
R
A
M
D.
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
P. | 233
JEEP/RAM
INTAKE MANIFOLDS, HARDWARE, AND
GASKETS
A. MPI Conversion Kits
Designed to make your 1981-90 Jeep® vehicle more efficient and powerful. The
kit replaces the stock carburetor, intake manifold and other major components
with multi-point injection (MPI). Each cylinder has its own injector that is activated
sequentially according to the firing order to precisely control individual fuel
requirements. These MPI Conversion Kits are self-compensating and run equally
well from sea level to terrain above 12,000 feet. Mechanical components are
based on production 1995 Jeep vehicle parts.
1
P5249686AE EFI Conversion Kit, Automatic Transmission, Emissions
Exempt D-265-21**, 1981-90 4.2L Jeep Engines
1
P5249610AE EFI Conversion Kit, Manual Transmission, Emissions
Exempt D-265-21**, 1981–90 4.2L Jeep Engines
1
Engine Controller, Automatic Transmission, 1981–90 4.2L
P5007146
Jeep Engines
1
Engine Controller, Manual Transmission, 1981–90 4.2L Jeep
P5007147
Engines
1
Fuel Pump, Auto/Manual Transmission, 1981–90 4.2L Jeep
P5007150
Engines
1
P5007148AB Wiring Harness, 1981–90 4.2L Jeep Engines
A.
B. MPI Conversion Service Parts
1
P5249687
P5249688
Vibration Damper, V Belt, 1981-90 4.2L Jeep Engines
P5007046
Crank Sensor Bracket, 4.2L Jeep Engines
Vibration Damper, Serpentine Belt, 1981-90 4.2L Jeep
Engines
1
Engine Controller, Automatic Transmission, 1981–90 4.2L
P5007146
Jeep Engines
1
Engine Controller, Manual Transmission, 1981–90 4.2L Jeep
P5007147
Engines
1
Fuel Pump, Auto/Manual Transmission, 1981–90 4.2L Jeep
P5007150
Engines
1
P5007148AB Wiring Harness, 1981–90 4.2L Jeep Engines
1
1
AIR SYSTEMS
C. Cast Air Cleaner Systems
Cast aluminum lid is painted black, with Mopar Pentastar or Jeep logo to match
the style of the Black Wrinkle Cast Aluminum Valve Covers. Includes 12-3/4"
element.
Air Cleaner, Cast, Jeep Vehicles
P5007067
B.
C.
P. | 234
P5007067
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
JEEP/RAM
AIR SYSTEMS
A. Cold Air Intake Systems - Jeep
Heat up your engine with a steady flow of cold air! These bolt-on systems are
designed to allow cooler outside air through a directional cone filter, directly into
the intake manifold. They provide noticeable horsepower and torque gains under
varying atmospheric conditions. Kits include all mounting hardware and a
washable/reusable filter. Do not oil dry media filters. CARB-approved E.O.#D265-22.
77060007AB Cold Air Intake System, Dry Media, 2004-06 Wrangler, 4.0L
77060013AB Cold Air Intake System, Dry Media, 2005-06 Liberty, 3.7L
77060010AB Cold Air Intake System, Dry Media, 2005-09 Grand
Cherokee/Comander, 5.7L
77060011AB Cold Air Intake System, Dry Media, 2006-09 Grand
A.
B.
77070008
Cherokee, 6.1L
77060012AB Cold Air Intake System, Dry Media, 2007-09
77060081
P5153368
Caliber/Compass/Patriot, 1.8L/2.0L/2.4L, Non-Turbo
Cold Air Intake System, Dry Media, 2007-10 Wrangler 3.8L
Cold Air Intake System, Oiled Filter, 1997-03 Wrangler, 4.0L
B. Cold Air Intake Systems - Truck
Heat up your engine with a steady flow of cold air! These bolt-on systems are
designed to allow cooler outside air through a directional cone filter, directly into
the intake manifold. They provide noticeable horsepower and torque gains under
varying atmospheric conditions. Kits include all mounting hardware and a
washable/reusable dry media filter. Do not oil dry media filters.
77060008AB Cold Air Intake System, Dry Media, 1998-00 Dakota 5.2L,
1998-02 Dakota 5.9L
77060020AB Cold Air Intake System, Dry Media, 2002-03 Ram, 4.7L
B.
77070005
B.
77060020AB
77060005AC
77060009AB
77070006
77070004
77070023
Cold Air Intake System, Dry Media, 2003-05 5.7L Ram 1500
Cold Air Intake System, Dry Media, 2004-06 5.7L Durango
Cold Air Intake System, Dry Media, 2006-08 5.7L Ram 1500
Cold Air Intake System, Dry Media, 2007-08 Durango/Aspen,
5.7L
Cold Air Intake System, Dry Media, 2009 5.7L Ram 1500
C. Cold Air Intake Systems - Truck- Diesel
77070030
77070028
77070027
B.
77070006
C.
77070030
B.
Cold Air Intake System, Dry Media, 2003-07 Ram (DR/DH)
2500/3500, 5.9L Diesel
Cold Air Intake System, Dry Media, 2007-09 Ram (DH/D1)
2500/3500, 6.7L Diesel
Cold Air Intake System, Dry Media, 2010 Ram (DJ/D2)
2500/3500, 6.7L Diesel
J
E
E
P
/
R
A
M
77070004
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
P. | 235
JEEP/RAM
AIR SYSTEMS
A. Air Filters- Cold Air Replacement
This filter offers high flow and low restriction, better throttle response, and
increased filtration and horsepower. Filters are made of a Dry Media material and
are washable and reusable. Do not oil dry media filters.
Air Filter, Cold Air Intake Replacement, Dry Media, Used to
77070015
Service Kit 77060012AB
Air Filter, Cold Air Intake Replacement, Dry Media, Used to
77070010
Service Kits 77060003AB, 77060006AB, 77060010AB,
77060011AB, 77070008
Air Filter, Cold Air Intake Replacement, Dry Media, Used to
77070012
Service Kits 77060005AB, 77060009AB, 77070004,
77070006
Air Filter, Cold Air Intake Replacement, Dry Media, Used to
77070013
Service Kits 77060007, 77060013AB, 77060021, 77060080
Air Filter, Cold Air Intake Replacement, Dry Media, Used to
77070014
Service Kits 77060008, 77060020AB
Air Filter, Cold Air Intake Replacement, Dry Media, Used to
77070018
Service Kits 77060081, 77070002
Air Filter, Cold Air Intake Replacement, Dry Media, Used to
77070017
service P4510921AB
B. Air Filters- O.E. Performance ReplacementJeep
Constructed with factory tight seals, engineering- level polyurethane, deep fourply pleats of oiled cotton gauze and two layers of aluminum screen. This filter
offers high flow and low restriction, better throttle response, and increased
filtration and horsepower. Filters are washable and reusable and come pre-oiled.
Air Filter, High Flow, O. E. Replacement, 1991–01 4.0L
P4510474
Cherokee
Air Filter, High Flow, O. E. Replacement, 1997-03 4.0L
P4510473
Wrangler
Air Filter, High Flow, O. E. Replacement, 1999–04 4.7L
P4510475
Grand Cherokee
Air Filter, High Flow, O. E. Replacement, 2007-09
P5153573
Compass/Patriot/Caliber, 2.4L/2.0L Non-Turbo
Air Filter, High Flow, O. E. Replacement, 2007-09 Wrangler
P5155085
3.8L, 2002-07 Liberty 3.7L
Air Filter, High Flow, O. E. Replacement, Oiled, 2005-10 3.5L
P4510472
Magnum/300/Charger/Challenger, 2002-03 3.7L Liberty
A.
B.
P. | 236
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
JEEP/RAM
AIR SYSTEMS
A. Air Filters- O.E. Performance ReplacementTruck
Constructed with factory tight seals, engineering- level polyurethane, deep fourply pleats of oiled cotton gauze and two layers of aluminum screen. This filter
offers high flow and low restriction, better throttle response, and increased
filtration and horsepower. Filters are washable and reusable and come pre-oiled.
Air Filter, High Flow, O. E. Replacement, 1994–01 5.2L/5.9L
P4510469
Ram
Air Filter, High Flow, O. E. Replacement, 1997–99 5.2L/5.9L
P4510467
Dakota/Durango
Air Filter, High Flow, O. E. Replacement, 1999–03 4.7L
P4510466
Dakota/Durango
Air Filter, High Flow, O. E. Replacement, 2000–03 5.9L
P4510468
Dakota/Durango
Air Filter, High Flow, O. E. Replacement, 2007-09
P5153573
Compass/Patriot/Caliber, 2.4L/2.0L Non-Turbo
B. Air Filter Service Kit
A.
Services all Mopar oiled filters that are both washable and reusable.
Air Filter Service Kit, For "Oiled" Air Filters
P5153376
B.
C. Ram Air Package
Creates a ram air effect at speeds of 40+ mph. Integrates seamlessly to the
underside of an SRT10 Ram Air Hood to route cool outside air into the included
Performance Cold Air Intake System. Constructed from lightweight material and
installs directly with minor modifications. CARB EO#D-265-23.
P4510921AB Ram Air Induction System, 2004-05 Ram SRT10
D. Ram Air Duct
This duct routes all the cool air your Ram can pull in through the SRT Ram Hood
(82208702) over to the Cold Air Intake System (77060005) for maximum
performance gains.
Ram Air Duct, 2003-08 Ram 5.7L
P5153307
E. Snorkels
Snorkel systems allow your engine to breathe in heavy dust or various water
crossings. Attaches to the vehicle using existing factory hardware. Combine with
the Heat Reduction Hood (P5155351) for a complete bolt-on package.
1
Snorkel, W/ Air Ram, 2007-09 Wrangler
P5155330
1
C.
P5155422
Snorkel, W/ Pre-Filter, 2007-09 Wrangler
D.
J
E
E
P
/
R
A
M
E.
P5155330
E.
P5155422
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
P. | 237
JEEP/RAM
EXHAUST SYSTEMS
A. Exhaust Headers
Bolt on a set of Mopar Exhaust Headers and feel the power. Manufactured from
heavy 14-gauge tubing with 3/8" thick flanges. True mandrel bends and triple
nickel-chrome finish make these headers the most durable on the market. Each
header is engineered to achieve maximum flow through minimum back pressure,
resulting in increased horsepower and torque. Kits include all necessary
installation hardware. No welding required.
1
Header, 2003-05 Ram 1500, 5.7L, Automatic Transmission,
P4510873
4 Wheel Drive
1
Header, 2003-05 Ram, 5.7L, Automatic Transmission, 2
P4510280
Wheel Drive
1
Header, 2007-09 Compass/Patriot/Caliber, FWD, Non-Turbo
P5153566
Note: For P4510280, Mopar Y-Pipe Package (P4510829) must be used on 2004
models. It is recommended that Y-Pipe Package (P4510364) be used with 2003
models.
A.
P4510280
A.
P5153566
B. Exhaust Header Y-Pipe Packages
These high-flow, low-restriction Y-pipe Exhaust Header Packages will boost
horsepower and torque by 10%. They feature T304 stainless steel construction
and include dual high-flow catalytic converters, as well as dual 2.5" into "two-intoone" Y-connections and 0.065" thick walls. Packages use all factory sensors and
require no welding for a direct, bolt-on fit. Kit includes all hardware, flanges and
stainless steel band clamps necessary for installation.
1
Exhaust Y-Pipe, 2003 5.7L Hemi Ram, 1500, 2WD,
P4510364
Automatic Transmission
1
Exhaust Y-Pipe, 2003 5.7L Hemi Ram, 1500, 4WD,
P4510872
Automatic Transmission
1
Exhaust Y-Pipe, 2004–05 5.7L Hemi Ram 1500, 2WD,
P4510829
Automatic Transmission
C. Exhaust Headers- Ram SRT10
Headers with Mid-Pipes, Race, Fits Standard and Extended Cab. Eliminates
catalysts. Recommend engine control modules: 2004 - P4510918, 2005P5153335, 2006-P5153591. Manual and Automatic Transmission, 2004-06 Ram
SRT10.
1
Headers, 2004-06, Ram SRT10
P5153168
B.
C.
P. | 238
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
JEEP/RAM
EXHAUST SYSTEMS
A. Cat-Back Exhaust Systems - Jeep
These Cat-back Exhaust Systems feature T304 stainless steel construction
(aircraft quality) with mandrel-bent tubing, stainless band Torca clamps, muffler,
and polished tips. These free-flow systems provide a horsepower and torque
gain, improved fuel economy and a deeper tone.
1
Cat-Back Exhaust System, Dual Rear Exit, 2002-05 Liberty
P5007792
3.7L
1
Cat-Back Exhaust System, Dual Rear Exit, Square Tips, 2.5"
P5155035
Pipe, 2009 3.7L Liberty
1
Cat-Back Exhaust System, Rear Exit, 2.25" Pipe, 2004
P4510858
Grand Cherokee 4.0L, 4.7L, 2/4 Wheel Drive
1
Cat-Back Exhaust System, Rear Exit, 2004-06 Wrangler, 4.0L
P4510857
A.
P5153364
1
P5155114
1
P5153589
1
P5155113
1
P5153858
1
P5153364
Cat Back Exhaust System, Single Exit With Square Tip,
2007-09 Compass/Patriot, AWD, 2.0L/2.4L
Cat-Back Exhaust System, Rear Exit, 2.5" Pipe, 2005 - 08
Commander, 5.7L, 2/4 Wheel Drive
Cat Back Exhaust System, Single Exit With Square Tip,
2007-09 Compass/Patriot, FWD, 2.0L/2.4L
Cat Back Exhaust System, Single Outlet, 2007-09 Wrangler
3.8L, 2/4 Door
Cat-Back Exhaust System, Rear Exit, 2.5" Pipe, 2005-08
Grand Cherokee, 5.7L, 2/4 Wheel Drive
B. Cat-Back Exhaust Systems- Jeep SRT8
Cat-back exhaust systems feature RSC no-drone technology, with 2.75" 304L
stainless steel mandrel bent tubing, stainless (Torca) clamps and polished 4" ProSeries tips. The patented Power-Pulse RSC™ muffer design delivers the throaty
exhaust tones that define your Hemi-Powered ride on the open road.
1
Cat-Back Exhaust System, Dual Center Rear Exit, 2006P5153453
2009 Grand Cherokee SRT8, 6.1L
A.
P5155113
A.
P5153589
B.
P5153453
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
J
E
E
P
/
R
A
M
P. | 239
JEEP/RAM
EXHAUST SYSTEMS
A. Cat-Back Exhaust Systems - Truck
These bolt-on systems feature heavy-wall 304 Stainless Steel tubing with true
mandrel bends, allowing for maximum flow and
minimum back pressure. Low restriction, aluminized case, and a flow-through
muffler with a 3.0" core produce a deep mellow
exhaust note. Includes straight through flow muffler.
1
Cat-Back Exhaust System, Rear Exit, 3.0" Pipe, 2004-08
P4510607
Durango, 4.7/5.7L, 2/4 Wheel Drive
1
Cat-Back Exhaust System, 45 Degree Passenger Side Exit,
P5153365
2.50" Pipe, 2005-08 Dakota 4.7L, 2/4 Wheel Drive
1
Cat Back Exhaust System, Dual Rear Exit, Round Chrome
P5155280
Tips, 2009 Ram 5.7L (With Bumper Cut-Outs), 6'/8' Bed,
4WD
1
Cat-Back Exhaust System, 45 Degree Passenger Exit in
P5153641
Front of Rear Wheels, 2.5" Pipe, 2006-08 Ram 1500, 5.7L,
Crew Cab, Short Bed, 2/4 Wheel Drive
1
Cat-Back Exhaust System, 45 Degree Passenger Exit in
P5153640
Front of Rear Wheels, 2.5" Pipe, 2006-08 Ram 1500, 5.7L,
Regular Cab, Short Bed, 2/4 Wheel Drive
1
Cat-Back Exhaust System, 90 Degree Passenger and Driver
P5153696
Exit, 2.5" Pipe, 2006-08 Ram 1500, 5.7L, Crew Cab, Short
Bed, 2/4 Wheel Drive
1
Cat-Back Exhaust System, 90 Degree Passenger and Driver
P5153695
Exit, 2.5" Pipe, 2006-08 Ram 1500, 5.7L, Regular Cab, Short
Bed, 2/4 Wheel Drive
1
Cat-Back Exhaust System, Rear Exit, 2.25" Pipe, 2006- 08
P5153674
Ram 1500, 5.7L, Regular Cab Short Bed, 2/4 Wheel Drive
1
Cat-Back Exhaust System, Single Rear Exit With Dual
P5155110
Square Tips, 2.5" Pipe, 2007-09 Nitro, 4.0L, V6
1
Cat Back Exhaust System, Single Rear Exit With Dual
P5155111
Square Tips, 2.5" Pipe, 2007-09 Nitro, 3.7L
1
Cat-Back Exhaust System, Rear Exit, 2.25" Pipe, 2006-08
P5153473
Ram 1500, 5.7L, Crew Cab, Short Bed, 2/4 Wheel Drive
1
Cat-Back Exhaust System, 45 Degree Passenger and Driver
P5007851
Exit, 2.5 pipe, 2002-05 Ram 1500 Regular/ Extended/ Crew
Cab, Short Bed, 2/4 Wheel Drive
1
Cat-Back Exhaust System, 45 Degree Passenger and Driver
P4510464
Exit, 2.5" Pipe, 2003 1500 Ram, Regular/Extended/Crew
Cab, Short Bed, 2 Wheel Drive
1
Cat-Back Exhaust System, 45 Degree Passenger and Driver
P4510465
Exit, 2.5" Pipe, 2003-05 Ram 2500, 5.7L,
Regular/Extended/Crew Cab, Short Bed, 2/4 Wheel Drive
1
Cat-Back Exhaust System, 45 Degree Passenger and Driver
P4510648
exit, 2.50" pipe, 2004 - 05 Ram 1500 Hemi 5.7L,
Regular/Crew Cab, Short Bed, 2/4 Wheel Drive.
1
Cat-Back Exhaust System, Rear Exit, 2003-05 Ram SRT10,
P4510856
8.3L, Regular Cab, Short Bed
1
Cat-Back Exhaust System, Rear Exit, 2006 Ram SRT 10,
P5153639
8.3L, Regular/Crew Cab, Short Bed
P. | 240
A.
P4510464
A.
P5007851
A.
P5153640
A.
P5153674
A.
P5153641
A.
P5153695
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
JEEP/RAM
OILING COMPONENTS
A. Oil Pump-High Volume
When the going gets tough, you'll want to be sure and supply as much oil to your
engine as possible. This high-volume Oil Pump will do the job and take the most
severe punishment. P4529241 requires pan rework for 4.0L applications.
1
Oil Pump, 4.0L/4.2L Jeep Vehicles
P4529241
B. Oil Pump-Heavy Duty
1
P4529227
Oil Pump, Heavy Duty, 4.0L Jeep, 1962 and Up
C. Oil Pump - Performance
This high-performance, high-output Oil Pump assembly provides a 25% increase
in oil volume. Ideal replacement for stock pump in high performance applications.
1
Oil Pump, 225 Slant 6
P4286740
A.
B.
J
E
E
P
/
R
A
M
C.
P4286740
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
P. | 241
JEEP/RAM
SUSPENSION UPGRADES AND
COMPONENTS
A. Lift Kits- JK (4WD)
Short Arm Lift Kits: 2" and 4"
These Mopar lifts offer exceptional ride comfort and control, on-road or off. Both
lift heights use the same basic components, except for coil springs, and yield all
the suspension travel the factory JK driveline offers. Coil spring rate is
wheelbase-specific (2 or 4-door), plus two Mopar shock absorber options allow
you to tailor the kit to your performance aspirations. Both kits also include a
replacement high-clearance, high capacity hydraulic steering stabilizer kit (white
color). The 2" lift is ideal for 33" to 35" diameter tires; the 4" is best suited for 35"
to 37" tires. Note that Rubicons (with 2" or 4" Lifts) require the Front Stabilizer
Bar Link Kit (P5155512).
Long Arm Lift Kits: 4.5"
The ultimate off-road performer. Mopar's Long Arm kit provides optimal
suspension travel by using longer, high-articulation axle-to-frame link arms.
Dampening is handled by Bilstein high-pressure monotube gas shocks. This kit
contains a vast array of components, including replacement front / rear
driveshafts. Best suited for 37" diameter tires.
Shock Options:
Performance shock is a twin-tube, high capacity hydraulic shock that features tenstage velocity sensitive valving. White enamel finish; includes black boot.
A.
P5155075
A.
P5155207
A.
P5155404AB
Mopar's premium shock, jointly tuned with Bilstein, allows you to realize the most
performance gain. The seamless monotube body contains a patented piston
design and a high-pressure gas charge to quickly dissipate heat and minimize
shock fade. Silver Zinc plated finish; includes black boot.
Lift Kit, 2" Lift, w/ Bilstein Shocks, 2007-11 Wrangler (JK), 4Door
1
Lift Kit, 2" Lift, w/ Performance Shocks, 2007-11 Wrangler
P5155789
(JK), 4- Door
1
Lift Kit, 2" Lift, w/ Bilstein Shocks, 2007-11 Wrangler (JK), 2P5155208
Door
1
Lift Kit, 2" Lift, w/ Performance Shocks, 2007-11 Wrangler
P5155790
(JK) 2- Door
1
P5155404AB Lift Kit, 4" Lift, Short Arm, w/ Bilstein Shocks, 2007-11
Wrangler (JK), 4-Door
1
P5155403AB Lift Kit, 4" Lift, Short Arm w/ Performance Shocks, 2007-11
Wrangler (JK), 4-Door
1
Lift Kit, 4.5" Lift, Long Arm w/ Bilstein Shocks, 2007-11
P5155075
Wrangler (JK), 4-Door
1
Stabilizer Bar Link Kit, Front, Use with 2" and 4" Lift Kits,
P5155512
2007-11 Wrangler (JK)
1
P5155207
P. | 242
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
JEEP/RAM
SUSPENSION UPGRADES AND
COMPONENTS
Lift Kits- JK (4WD)
WARNING: Lift Kits alter vehicle properties and affect handling. Lift kits are
intended to be used for off-road driving only. Your kit will come with more
detailed instructions and warnings. Contact the Mopar Direct Connection Tech
Line (888-528-4364) to obtain a copy.
NOTE: Vehicle RPM and speedometer readings are based on the stock vehicle's
tire and wheel combinations. Installing larger wheels and tires with your Mopar
Performance lift kit could result in incorrect RPM, speedometer and odometer
readings.
WARRANTY: Lift Kits work with all vehicle systems including the Electronic
Stability Program, and are covered (except P5155075) by a Limited Lifetime
Warranty. The warrantor is the Lift Kit manufacturer, not Mopar, Chrysler Group
LLC, or the dealership selling the product. Contact the Mopar Direct Connection
Tech Line (888-528-4364) for warranty details and installation instructions.
J
E
E
P
/
R
A
M
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
P. | 243
JEEP/RAM
SUSPENSION UPGRADES AND
COMPONENTS
A. Lift Kits- WK/XK (4WD)
The front lift is accomplished with strut towers; rear lift via new coil springs. Thin
preload plates install on top of the springs to boost spring rate slightly and offset
the increased load / leverage generated by heaver and wider tires and wheels.
The lower control arms and differential are relocated via bracketry then new
steering knuckles span the increased distance from the relocated lower control
arms to the upper arms, which remain in the stock location. Bracketry relocates
the affected rear suspension components. Lift Kits include a plug-in module to
ensure functionality of Jeep's Electronic Stability Program.
1
P5155383
1
P5155384
Lift Kit, 4" Lift w/ Shocks, 2005-07 Grand Cherokee/
Commander (WK/XK)
Lift Kit, 4" Lift w/ Shocks, 2008-10 Grand Cherokee/
Commander (WK/XK)
A.
P5155384
See chart for additional information.
WARNING: Lift Kits alter vehicle properties and affect handling. Lift kits are
intended to be used for off-road driving only. Your kit will come with more
detailed instructions and warnings. Contact the Mopar Direct Connection Tech
Line (888-528-4364) to obtain a copy.
NOTE: Vehicle RPM and speedometer readings are based on the stock vehicle's
tire and wheel combinations. Installing larger wheels and tires with your Mopar
Performance lift kit could result in incorrect RPM, speedometer and odometer
readings.
WARRANTY: Lift Kits work with all vehicle systems including the Electronic
Stability Program, and are covered (except P5155075) by a Limited Lifetime
Warranty. The warrantor is the Lift Kit manufacturer, not Mopar, Chrysler Group
LLC, or the dealership selling the product. Contact the Mopar Direct Connection
Tech Line (888-528-4364) for warranty details and installation instructions.
P. | 244
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
JEEP/RAM
SUSPENSION UPGRADES AND
COMPONENTS
A. Lift Kits- Ram 1500 (4WD)
Lift Kits 2" (excluding TRX4)
Fits Crew, Quad and Regular cabs, and provides lift for up to 35" diameter tires.
Front lift is via replacement Premium Performance Bilstein gas struts; new dual
Rate coil springs provide rear lift. Also includes components to address rear
stabilizer bar, brake hose length and compression travel, as well as Premium
Performance Bilstein rear shocks. Compatible with all vehicle systems, including
Electronic Stability Program.
A.
P5155797
A.
P5155393
Lift Kits 4" (excluding TRX4) and Lift Kits 3" (TRX4 models)
Fits Crew, Quad and Regular cabs, and provides lift for up to 37" diameter tires
while retaining factory turning radius. Lift kits for both the standard DS and TRX4
models contain the same basic components; there are only a few minor
differences. The TRX4 factory ride height is approximately 1" taller than the
standard DS, so ride height of a 3" Mopar lift-equipped TRX4 is as tall as a 4"
Mopar lift-equipped DS. Compatible with all vehicle systems, including Electronic
Stability Program.
Shock Options:
Performance shock is a twin-tube, high capacity hydraulic shock that features tenstage velocity sensitive valving. White enamel finish; includes black boot.
Mopar's premium shock, jointly tuned with Bilstein, allows you to realize the most
performance gain. The seamless monotube body contains a patented piston
design and a high-pressure gas charge to quickly dissipate heat and minimize
shock fade. Silver Zinc plated finish; includes black boot.
A.
P5155212
B.
P5155066
1
P5155258
1
P5155662
1
P5155797
1
P5155465
1
P5155466
1
P5155212
1
P5155393
Lift Kit, Pre-Runner, Stage 1, 2009-11 Ram (DS), N/A for
TRX
Lift Kit, Pre-Runner, Stage 2, 2009-11 Ram (DS), N/A for
TRX
Lift Kit, 2" Lift, w/ Bilstein Struts and Rear Shocks, 2009-11
Ram (DS) 1500, N/A for TRX
Lift Kit, 3" Lift w/ Bilstein Struts and Rear Shocks, 2009-11
Ram (DS) 1500, TRX Only
Lift Kit, 3" Lift, w/ Strut Spacers and Performance Rear
Shocks, 2009-11 Ram (DS) 1500, TRX Only
Lift Kit, 4" Lift, w/Bilstein Struts and Rear Shocks, 2009-11
Ram (DS) 1500, N/A for TRX
Lift Kit, 4." Lift w/ Strut Spacers and Performance Rear
Shocks, 2009-11 Ram (DS) 1500, N/A for TRX
B. Lowering Kit- Ram DR (2WD)
1
P5155066
Lowering Kit, Includes Springs, Shocks and Axle Flip Kit,
Front= 1.50" and Rear= 4.30", 2006-08 Ram, 2WD, SWB
J
E
E
P
/
R
A
M
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
P. | 245
JEEP/RAM
SUSPENSION UPGRADES AND
COMPONENTS
Lift Kits- Ram 1500 (4WD)
See chart for additional information.
WARNING: Lift Kits alter vehicle properties and affect handling. Lift kits are
intended to be used for off-road driving only. Your kit will come with more
detailed instructions and warnings. Contact the Mopar Direct Connection Tech
Line (888-528-4364) to obtain a copy.
NOTE: Vehicle RPM and speedometer readings are based on the stock vehicle's
tire and wheel combinations. Installing larger wheels and tires with your Mopar
Performance lift kit could result in incorrect RPM, speedometer and odometer
readings.
WARRANTY: Lift Kits work with all vehicle systems including the Electronic
Stability Program, and are covered (except P5155075) by a Limited Lifetime
Warranty. The warrantor is the Lift Kit manufacturer, not Mopar, Chrysler Group
LLC, or the dealership selling the product. Contact the Mopar Direct Connection
Tech Line (888-528-4364) for warranty details and installation instructions.
P. | 246
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
JEEP/RAM
SUSPENSION UPGRADES AND
COMPONENTS
A. Leveling Kits- Ram (4WD)
Fits all cab and bed configurations, including Duallies (except TRX4 models).
Leveling kits raise the front of the Ram, and eliminate the factory "nose low" rake,
to make room for tires 1" to 2" taller than stock. For 2500 / 3500 models, a 2"
rear block kit is offered for those who wish to retain the factory rake because of
load hauling and towing.
A.
P5155394
LEVELING KIT FEATURES:
· Front lift, depending on application, is via either coil spacers, strut spacers or
new torsion bar keys, so factory springs are retained and ride quality is
unaffected.
· Very economical.
· Can use factory wheels and allows clearance for tires 1" to 2" taller than stock.
· Easy installation - Most kits install in no more than a couple of hours. Front
end realignment is required.
· Ram 2500/3500 rear block kit (#P5155452) includes two U-bolt sets to
applicate both axle types found in these pickups, plus brackets to prevent
suspension over-compression.
1
Leveling Kit, 2" Lift, Front, 1994-11 Ram
P5155394
(BE/BR/DH/DJ/DR/D1/D2) 2500/3500
1
Lift Kit, 2" Block Lift, Rear, 2003-11 Ram (DR/DH/DJ/ D1/
P5155452
D2) 2500/3500
1
P5155388AB Leveling Kit, 2.0" Lift, Front, 2002-05 Ram (DR) 1500, 4WD
1
P5155387AB Leveling Kit, 2.5" Lift, Front, 1994-01 Ram (BR/BE) 1500,
1
P5155391AB Leveling Kit, 2.5" Lift, Front, 2006-08 Ram (DR) 1500, 4WD
4WD
WARNING: Lift Kits alter vehicle properties and effect handling. Lift kits are
intended to be used for off-road driving only. Your kit will come with more
detailed instructions and warnings. Contact the Mopar Direct Connection Tech
line (888-528-4364) to obtain a copy.
A.
P5155452
NOTE: Vehicle RPM and speedometer readings are based on the stock vehicle's
tire and wheel combinations. Installing larger wheels and tires with your Mopar
Performance lift kit could result in incorrect RPM, speedometer and odometer
readings.
WARRANTY: Lift Kits work with all vehicle systems including the Electronic
Stability Program, and are covered (except P5155075) by a Limited Lifetime
Warranty. The warrantor is the Lift Kit manufacturer, not Mopar, Chrysler LLC, or
the dealership selling the product. Refer to www.Mopar.com for warranty details
and installation instruction downloads.
A.
P5155387AB
A.
P5155391AB
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
J
E
E
P
/
R
A
M
P. | 247
JEEP/RAM
SUSPENSION UPGRADES AND
COMPONENTS
A. Lift Kits- Ram 2500/3500 (4WD)
New coil springs specifically rated for engine type, are matched with your choice
of Performance shocks (gas front / hydraulic rear) in a white enamel finish, or our
Bilstein monotube high-pressure gas shocks that feature a silver Zinc finish.
Includes a dual steering stabilizer kit with cylinders matched to your choice of lift
kit shocks.
Shock Options:
Performance shock is a twin-tube, high capacity hydraulic shock that features tenstage velocity sensitive valving. White enamel finish; includes black boot.
Mopar's premium shock, jointly tuned with Bilstein, allows you to realize the most
performance gain. The seamless monotube body contains a patented piston
design and a high-pressure gas charge to quickly dissipate heat and minimize
shock fade. Silver Zinc plated finish; includes black boot.
1
P5155496
1
P5155497
1
P5155498
1
P5155499
1
P5155398AB
1
P5155397AB
1
P5155402AB
1
P5155401AB
1
P5155641
1
P5155640
1
P5155643
1
P5155642
1
P5155396AB
1
P5155395AB
1
P5155400AB
1
P5155399AB
Lift Kit, 4" Lift, w/ Bilstein Shocks, 2010-11 Ram (DJ/D2)
2500/3500, 6.7L
Lift Kit, 4" Lift, w/ Performance Shocks, 2010-11 Ram
(DJ/D2) 2500/3500, 6.7L
Lift Kit, 4" Lift, w/ Bilstein Shocks, 2010-11 Ram (DJ/D2)
2500/3500, 5.7L
Lift Kit, 4" Lift, w/ Performance Shocks, 2010-11 Ram
(DJ/D2) 2500/3500, 5.7L
Lift Kit, 4" Lift, w/ Bilstein Shocks, 2009 Ram (DH/D1)
2500/3500, 6.7L
Lift Kit, 4" Lift, w/ Performance Shocks, 2009 Ram (DH/D1)
2500/3500, 6.7L
Lift Kit, 4" Lift, w/ Bilstein Shocks, 2009 Ram (DH/D1)
2500/3500, 5.7L
Lift Kit, 4" Lift, w/ Performance Shocks, 2009 Ram (DH/D1)
2500/3500, 5.7L
Lift Kit, 4" Lift, w/ Bilstein Shocks, 2008 Ram (DH/D1)
2500/3500, 6.7L
Lift Kit, 4" Lift, w/ Performance Shocks, 2008 Ram (DH/D1)
2500/3500, 6.7L
Lift Kit, 4" Lift, w/ Bilstein Shocks, 2008 Ram (DH/D1)
2500/3500, 5.7L
Lift Kit, 4" Lift, w/ Performance Shocks, 2008 Ram (DH/D1)
2500/3500, 5.7L
Lift Kit, 4" Lift, w/ Bilstein Shocks, 2003-08 Ram (DR/DH/D1)
2500/3500, 5.9L/8.0L/6.7L
Lift Kit, 4" Lift, w/ Performance Shocks, 2003-08 Ram
(DR/DH/D1) 2500/3500, 5.9L/8.0L/6.7L
Lift Kit, 4" Lift, w/ Bilstein Shocks, 2003-08 Ram (DH/DR/D1)
2500/3500, 5.7L
Lift Kit, 4" Lift, w/ Performance Shocks, 2003-08 Ram
(DH/DR/D1) 2500/3500, 5.7L
A.
P5155496
A.
P5155497
B.
P5155118
B. Prop Shafts- Jeep Lift Kits
1
P5155119
1
P5155120
1
P5155118
P. | 248
Prop Shaft, Front, 4.5" Lift Kit Service Part, 2007-11
Wrangler, 4-Door, 4WD
Prop Shaft, Rear, 4.5" Lift Kit Service Part, 2007-11
Wrangler, 2-Door, 4WD
Prop Shaft, Rear, 4.5" Lift Kit Service Part, 2007-11
Wrangler, 4-Door, 4WD
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
JEEP/RAM
SUSPENSION UPGRADES AND
COMPONENTS
Lift Kits- Ram 2500/3500 (4WD)
See chart for additional information.
WARNING: Lift Kits alter vehicle properties and affect handling. Lift kits are
intended to be used for off-road driving only. Your kit will come with more
detailed instructions and warnings. Contact the Mopar Direct Connection Tech
Line (888-528-4364) to obtain a copy.
NOTE: Vehicle RPM and speedometer readings are based on the stock vehicle's
tire and wheel combinations. Installing larger wheels and tires with your Mopar
Performance lift kit could result in incorrect RPM, speedometer and odometer
readings.
WARRANTY: Lift Kits work with all vehicle systems including the Electronic
Stability Program, and are covered (except P5155075) by a Limited Lifetime
Warranty. The warrantor is the Lift Kit manufacturer, not Mopar, Chrysler Group
LLC, or the dealership selling the product. Contact the Mopar Direct Connection
Tech Line (888-528-4364) for warranty details and installation instructions.
J
E
E
P
/
R
A
M
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
P. | 249
JEEP/RAM
SUSPENSION UPGRADES AND
COMPONENTS
A. Shocks- Jeep Lift Kits
These are the same Shocks packaged with Mopar's lift kits. Order when
upgrading from Performance series to Premium Bilstein, or when needing service
replacements. The Performance shock is a twin-tube, high capacity hydraulic
shock that features ten-stage velocity sensitive valving. White enamel finish;
includes black boot.
Mopar's premium shock, jointly tuned with Bilstein, allows you to realize the most
performance gain. The seamless monotube body contains a patented piston
design and a high-pressure gas charge to quickly dissipate heat and minimize
shock fade. Silver Zinc plated finish; includes black boot.
P5155116
Shock, Front, Bilstein, 2007-11 Wrangler (JK), 4.5" Lift Kits
P5155117
1
P5155262
Shock, Rear, Bilstein, 2007-11 Wrangler (JK), 4.5" Lift Kits
1
1
1
P5155263
1
P5155804
1
P5155805
Shock, Front, Bilstein, Replacement/ Upgrade for 2007-11
Wrangler (JK), 2" and 4" Lift Kits
Shock, Rear, Bilstein, Replacement/ Upgrade for 2007-11
Wrangler (JK), 2" and 4" Lift Kits
Shock, Front, Performance, Replacement for 2007-11
Wrangler (JK), 2" and 4" Lift Kits
Shock, Rear, Performance, Replacement for 2007-11
Wrangler (JK), 2" and 4" Lift Kits
A.
P5155117
A.
P5155116
B.
P5155264
B.
P5155415
C.
P5155419
B. Steering Stabilizers
These are some of the same kits included with Mopar's Lift Kits. Fits trucks from
stock height up to 4" of lift. Fits Jeep (JK) 2" and 4" lift kits. Available with
Performance hydraulic cylinders, or Premium Bilstein gas cylinders.
Stabilizer Kit, Dual Steering, Bilstein Cylinders, 2003-08 (thru
P5155413
to 03/01/08) Ram 2500/3500, 4WD
Stabilizer Kit, Dual Steering, Bilstein Cylinders, 2008 (from
P5155415
03/01/08) -11 Ram 2500/3500, 4WD
Stabilizer Kit, Dual Steering, Performance Cylinders, 2003-08
P5155412
(thru 03/01/08) Ram 2500/3500, 4WD
Stabilizer Kit, Dual Steering, Performance Cylinders, 2008
P5155414
(from 03/01/08) -11 Ram 2500/3500, 4WD
Stabilizer Kit, Steering, High-Clearance, High-Capacity, 2007P5155264
11 Wrangler (JK), 2" and 4" Lift Kits
C. Stabilizer Bar Disconnects- Jeep Lift Kits
Quick-Disconnects allow a considerable amount of increased front wheel travel
while off-roading. With Mopar's Quick-Disconnects, simply pull the pin, unscrew
the coupler, pivot it upward, strap it up and go! Do not operate the vehicle onroad with the stabilizer bar disconnected. Note that Quick-Disconnects are not
needed on Rubicon models since they are factory-equipped with electronic
disconnects.
1
Stabilizer Bar Quick-Disconnects, Front, Use with 2007-11
P5155419
Wrangler (JK) 2" and 4" Lift Kits
P. | 250
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
JEEP/RAM
SUSPENSION UPGRADES AND
COMPONENTS
A. Axle-to-Frame Links, High-Articulation
Mopar's replacement lower link arms coax the remaining twist out of your Mopar
2" or 4" lift kit. The tubular links incorporate a male / female threaded end that
reduces bind during articulation. The threaded feature also allows additional
driveline and steering alignment range. A combination of greasable Urethane
bushings (axle end), and factory type, press-fit rubber bushings (frame end)
provides superior durability, flexibility and service life compared to most other
replacement links. This bushing combination also results in quieter operation,
and less shock load transmission. Front Links feature an upwards bend for
improved ground clearance.
1
Axle-to-Frame Lower Links, Front, High-Articulation, Use
P5155420
with 2007-11 Wrangler (JK) 2" and 4" Lift Kits, Pair
1
Axle-to-Frame Lower Links, Rear, High-Articulation, Use with
P5155421
2007-11 Wrangler (JK) 2" and 4" Lift Kits, Pair
B. Traction Bars- 4" Lift Kits
A.
P5155420
A.
P5155421
Designed to combat torque loads and the resulting axle wrap-up. Effective axlewrap control starts with proper geometry. Leaf springs become longer as they
compress, so in order to prevent suspension bind the Traction Bars' arc of travel
must be in sync with the rear spring's movement. Mopar Traction Bars also
incorporate a threaded swivel-end (at the frame mount) to prevent destructive
torsional loads from stressing the truck's frame. Features a tubular main beam
brace with a brushed stainless steel insert and Mopar logo.
1
Traction Bars, 2003-11 Ram 2500/3500, Quad Cab, Short
P5155416
Bed, 4" Mopar Lift Kits Only
1
Traction Bars, 2003-11 Ram 2500/3500, Quad/ Mega Cab,
P5155417
Long Bed, 4" Mopar Lift Kits Only
C. Anti-Sway Bar Kit
Jeep Commander Anti-Sway Bar Kit includes both front and rear bars and
bushing sets. Bars are made of a high-quality material that ensures durability
and are powder-coated to protect them from the elements. Bars reduce body roll
and help to keep the tires firmly planted on the ground. Dimensions: Front 35
mm, Rear 22 mm.
1
Anti-Sway Bar, Stage 1, 2006-08 Jeep Commander, 5.7L
P5153727
D. Lowering Springs
Lowering kit includes all four springs, made of high-tensile material, to increase
spring performance without bind. These springs provide a .75" front drop and a
1.5" drop in the rear, to lower and even out your ride.
1
Lowering Springs, 2006-08, Jeep Commander, 5.7L
P5153728
E. Strut Tower Brace
B.
P5155416
Made of heavy gauge, powder coated steel, this MIG-welded Mopar Strut Tower
Brace reduces body flex in the front end, improving handling and drivability. Easy
bolt-on installation.
1
Strut Tower Brace, Front, Steel, 2007-09
P5153565
Compass/Patriot/Caliber, Non-Turbo
C.
J
E
E
P
/
R
A
M
D.
E.
P5153565
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
P. | 251
JEEP/RAM
SUSPENSION UPGRADES AND
COMPONENTS
A. Additional Rear Leaf Spring
Add-a-leaf kits allow for the installation of larger tires and help compensate for
heavy accessories. These kits will increase the ride height and spring rate for a
fraction of the cost of replacement springs. Sold individually.
1
Leaf Spring, Additional, Rear, 4WD,
P4349540
W100/W150/W200/W300/Ramcharger/Trailduster
IGNITION AND ELECTRONICS
B. Engine Controllers- Jeep
Direct replacement for the production computers. Provide increases in both
horsepower and torque without affecting driveability.
1
Engine Controller, 1993–94 5.2L 4x4 Automatic
P5249518
Transmission Grand Cherokee
1
Engine Controller, 1995 5.2L 4x4 Automatic Transmission
P5249702
Grand Cherokee
Note: Emissions exempt in California, Massachusetts and New York only.
Requires the use of premium unleaded fuels (92 octane or better). 1998 and later
models require Vehicle Identification Number (VIN) and Mileage encoding by a
Chrysler franchised dealer. Not recommended for towing applications.
IMPORTANT NOTICE: This device is not legal for use on pollution-controlled
vehicles certified for use on streets or highways. Once this device is installed,
use of the vehicle on a street or highway is a violation of the Clean Air Act,
potentially subjecting the operator and the installer to civil penalties of up to
$32,500 per vehicle depending on the circumstances.
A.
B.
P. | 252
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
JEEP/RAM
IGNITION AND ELECTRONICS
A. Engine Controllers- Truck
Direct replacement for the production computers. Provide increases in both
horsepower and torque without affecting driveability.
1
Engine Controller, 1992–93 5.2L Dakota
P5249516
Engine Controller, 1994–95 5.2L Ram/Dakota, Automatic
Transmission
1
Engine Controller, 1994–95 5.9L Ram, Automatic
P5249546
Transmission
1
Engine Controller, 1994–95 8.0L Ram, Automatic
P5249548
Transmission
1
P5249955AB Engine Controller, 1996 5.2L Ram, Automatic Transmission
1
P5249545
1
P5153734AC Engine Controller, 360 MPI Kit, Automatic Transmission
Engine Controller, 5.9L Magnum, Automatic Transmission
P5249935
1
NOTE: Emissions exempt in California, Massachusetts and New York only.
Requires the use of premium unleaded fuels (92 octane or better). 1998 and later
models require Vehicle Identification Number (VIN) and Mileage encoding by a
Chrysler franchised dealer. Not recommended for towing applications.
A.
IMPORTANT NOTICE: This device is not legal for use on pollution-controlled
vehicles certified for use on streets or highways. Once this device is installed,
use of the vehicle on a street or highway is a violation of the Clean Air Act,
potentially subjecting the operator and the installer to civil penalties of up to
$32,500 per vehicle depending on the circumstances.
B. Engine Controller- Ram SRT10
Plug in this performance-engineered Engine Controller and experience an
immediate increase in horsepower and torque. Fuel and spark settings are
adjusted for use with the required performance camshaft (P4510171) and
exhaust headers (P4510844 or P5153168). Manual transmission only.
1
Engine Controller, 2004 SRT10 Ram 1500
P4510918
1
P5153335
Engine Controller, 2005 SRT10 Ram 1500
IMPORTANT NOTICE: This device is not legal for use on pollution-controlled
vehicles certified for use on streets or highways. Once this device is installed,
use of the vehicle on a street or highway is a violation of the Clean Air Act,
potentially subjecting the operator and the installer to civil penalties of up to
$32,500 per vehicle depending on the circumstances.
AUTOMATIC TRANSMISSION
COMPONENTS
C. Flywheel Hardware Kit
B.
Contains all the bolts required to attach the flywheel and clutch to the engine
assembly. Includes six flywheel bolts, six clutch bolts, pilot bearing and seal.
P4529636AB Hardware Kit, Flywheel, 4.0L AMC 360 Jeep Manual
Transmission
J
E
E
P
/
R
A
M
C.
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
P. | 253
JEEP/RAM
TRANSMISSION/TRANSFER CASES
Transfer Case (Not Shown)
1
241 OR Transfer Case (Rubicon) Kit With Shift
1
Yoke Kit, 1330 Double Cardan, w/ U-Joint
P5155154
P5155082
1
P5155079
Chain and Sprocket Kit, 231 HD
Yokes (Not Shown)
1
Yoke Kit, 1310 Double Cardan, w/ U-Joint
1
Yoke Kit, 1330 Single Cardan, w/ U-Joint
P5155081
P5155080
1
P5155082
P. | 254
Yoke Kit, 1330 Double Cardan, w/ U-Joint
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
JEEP/RAM
DRIVETRAIN AND REAR AXLE
COMPONENTS
A. Axle Assemblies
A.
P5155084
A.
P5155256
A.
P5155257
A.
P5153826AB
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
These New Generation axle assemblies will provide the next level of off-road
performance for your Jeep or Ram vehicle. All axles are shipped with the current
suspension mounting brackets installed. Adaptation of these units into previous
models is the responsibility of the purchaser. These axles come completely
assembled and may include features such as disc brakes, and a Tru-Lok®
electric, selectable locking differential.
1
P5153825AD Axle, Front Assembly, Dana 44, 2007-10 Jeep Wrangler,
4.10 Ratio, Tru-Lok® electric, selectable locking differential,
5 on 5.0" JK Wheel Pattern, w/o Brakes
1
Axle, Front Assembly, Dana 44, JK Modified For 1997-2006
P5155256
TJ, 4.10 Ratio, Tru-Lok® electric, selectable locking
differential, 5 on 4.5" TJ Wheel Pattern, Includes JK Brakes
1
Axle, Front Assembly, Dana 44, Military J8 Wrangler, 4.10
P5155084
Ratio, with Open Differential, 5 on 5.5" Hub, Includes J8
Military Brakes
1
P5155087AB Axle, Front Assembly, Stock Ram 2500 Power Wagon, 4.56
Ratio, With Electric Selectable Locker, 8 on 6.5" Wheel
pattern, w/o Brakes
1
Axle, Partial Front Assembly, Dynatrac ProRock 44®, 2007P5155757
10 Jeep Wrangler. Includes 4.88 ratio, and Tru-Lok® electric,
selectable, locking differential. Includes Differential Cover,
OEM Ball Joints, HD 3" x ½" wall axle tubes and increased
pinion angle and caster angle for lifted suspension. Ready
To Accept Customer Supplied Wrangler JK knuckles, hubs,
and brakes. Accepts Customer Supplied Wrangler Rubicon
Dana 44 front axle shafts or P5155758 and P5155759 inner
shafts.
1
P5153826AB Axle, Rear Assembly, 2007-10 Jeep Wrangler Rubicon, 4.10
Ratio, Tru-Lok® electric, selectable locking differential, 5 on
5.0" JK Wheel Pattern, w/ Brakes
1
Axle, Rear Assembly, Dana 44, JK Modified For 1997-2006
P5155257
TJ, 4.10 Ratio, Tru-Lok® electric, selectable locking
differential, 5 on 4.5" TJ Wheel Pattern, w/ Brakes
1
Axle, Rear Assembly, Dana 60, Military J8 Wrangler, 4.10
P5155260
Ratio, Limited Slip Differential, 5 on 5.5"
and 5 on 5.0" Wheel Pattern, Modified For JK, w/ J8 Military
Brakes
1
Axle, Rear Assembly, Dana 60, Military J8 Wrangler, 4.10
P5155083
Ratio, Limited Slip Differential, 5 on 5.5" Wheel Pattern, Leaf
Spring, w/ J8 Brakes
1
P5155088AB Axle, Rear Assembly, Stock Ram 2500 Power Wagon, 4.56
Ratio, With Electric, Selectable
Locker, 8 on 6.5" Wheel Pattern, w/o Brakes
J
E
E
P
/
R
A
M
P. | 255
JEEP/RAM
DRIVETRAIN AND REAR AXLE
COMPONENTS
Portal Axles (Not Shown)
Off road use only. These heavy duty axle assemblies increase vehicle lift to 5"
and require 17" or greater size wheels. The bolt pattern is 8-lug and the track
width will be increased by 8" on each side.
1
Axle, Portal, Front, 8-Lug
P5155670
1
P5155671
Axle, Portal, Rear, 8-Lug
A. Differential Covers- Heavy Duty
Mopar's extreme heavy duty Differential Covers offer upgraded protection for
your axle's differential. Made from nodular castings, these covers provide
increased strength and protect your differential from severe impacts such as
rocks and off road obstacles. They also greatly enhance the rugged look of your
axles. Each cover comes with exclusive "Jeep" badging.
Cover, Differential, Dana 30, "Jeep" Badging
P5155445
P5155446
P5155447
A.
P5155446
B.
P5155678
B.
P5155442
C.
P5155359
Cover, Differential, Dana 44, "Jeep" Badging
Cover, Differential, Dana 60, "Jeep" Badging
B. Differential Cover Protectors
Rock rash insurance for your factory (O.E.) differential covers. Mopar's
differential protectors are laser-cut from .250" steel then coated with a durable
silver Zinc finish.
Guard, Differential, AMC 20, Laser Cut "Jeep"
P5155777
P5155442
P5155778
P5155443
P5155444
P5155780
P5155779
P5155781
P5155677
P5155678
Guard, Differential, Dana 30, Laser Cut "Jeep"
Guard, Differential, Dana 35, Laser Cut "Jeep"
Guard, Differential, Dana 44, Laser Cut "Jeep"
Guard, Differential, Dana 60 (J8), Laser Cut "Jeep"
Guard, Differential, Chrysler Axle, 8.25" Gear, w/o Electronic
Limited Slip, Laser Cut "Jeep"
Guard, Differential, Chrysler Axle, 8.25" Gear, Electronic
Limited Slip, Laser Cut "Jeep"
Guard, Differential, Chrysler Axle with 9.25" Gear, Laser Cut
"Ram"
Guard, Differential, AAM Axle with 10.5" Gear, Laser Cut
"RAM"
Guard, Differential, AAM Axle with 11.5" Gear, Laser Cut
"RAM"
AXLE COMPONENTS
C. Locker Wiring Harness
Jeep Rubicon Tru-Lok® locking differential activation wire harness. Facilitates
installation of axles equipped with Tru-Lok® in most vehicles.
Harness, Wiring, Allows Locker Axles To Be Powered
P5155359
P. | 256
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
JEEP/RAM
AXLE COMPONENTS
A. Dana 44 Components
P5155759
P5155760
P5155758
P5155756
Axle Shaft, DANA 44F, Left, Inner, 4340 Chrome Moly, JK
Axle Shaft, DANA 44F, Outer, 4340 Chrome Moly, JK
Axle Shaft, DANA 44F, Right Inner, 4340 Chrome Moly, JK
Housing Only, Front, Dynatrac ProRock 44®, 2007-10 Jeep
Wrangler. Includes Differential Cover, OEM Ball Joints, HD
3" x ½" wall axle tubes, increased pinion angle and caster
angle for lifted suspension. Accepts customer supplied
Wrangler JK knuckles, hubs, and brakes. Also accepts stock
Rubicon Dana 44 ring & pinion with Tru-Lok® electric,
selectable, locking differential. Re-uses stock Rubicon 44
front axle shafts or P5155758 and P5155759 inner axle
shafts.
B. Ram Locking Hub Conversion Kit
A.
P5155756
B.
P5155762
Free Spin® Hub Conversion by Dynatrac, includes Warn lockout hubs. This kit
reduces front axle wear and improves fuel efficiency by permitting the driver to
disengage the front axle shafts and driveshaft rotation when operating in 2WD.
For trucks with Single Rear Wheels (SRW).
Hub Conversion, Free Spin, 00-08 Ram 2500 4WD, SRW
P5155762
EXTERIOR BODY COMPONENTS
C. Hemi Hockey Stick Graphics Kits
Kit includes Hemi® Hockey Stick Graphics (driver and passenger bed sides) and
hood stripe. Fits both long and short bed trucks. Material is Avery two mil highperformance cast vinyl film, die-cut and pre-masked. Kit includes step-by-step
installation instructions and application squeegee.
Graphics Kit, Hemi Hockey Stick, Black, 2007 Dodge Ram
P4510272
6.5’ and 8.0’ Bed
Graphics Kit, Hemi Hockey Stick, Silver Metallic, 2007
P4510274
Dodge Ram 6.5' and 8.0' Bed
Graphics Kit, Hemi Hockey Stick, White, 2007 Dodge Ram
P4510273
6.5' and 8.0' Bed
D. Hemi Billboard Graphics Kits
C.
D.
Kit includes Hemi® Billboard Graphics (driver and passenger bed sides) and
hood stripe. For short bed trucks only. Material is Avery two mil high-performance
cast vinyl film, die-cut and pre-masked. Kit includes step-by-step installation
instructions and application squeegee.
Graphics Kit, Hemi Billboard, Black, 2007 Dodge Ram, 6.5’
P4510275
Bed
Graphics Kit, Hemi Billboard, Silver Metallic, 2007 Dodge
P4510277
Ram 6.5' Bed
E. Grille Assembly, Wire Mesh, Stainless
77DUB01023 Grille, Chrome, Wire Mesh, 2006 Commander
Grille, Chrome, Wire Mesh, 2007-09 Wrangler, 2/4DR
77070001
J
E
E
P
/
R
A
M
E.
E.
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
P. | 257
JEEP/RAM
EXTERIOR BODY COMPONENTS
A. Corner Guards
Help protect your wrangler's rear corners with these heavy duty Corner Guards.
Stamped from 1/8" steel, these guards fit the contours of your Jeep. Available for
2-door or 4-door.
Corner Guards, Rear, 2007-09 Wrangler 2-Dr.
P5155349
P5155350
Corner Guards, Rear, 2007-09 Wrangler 4-Dr.
B. Bumpers
P5155481
P5155352
P5155353
Bumper, Front, Integrated Winch Mount, 1982-01 Cherokee
(XJ)
Bumper, Front, Integrated Winch Mount, 2007-10 Wrangler
(JK)
Skid Plate, For Use With Bumper P5155352, 2007-10
Wrangler (JK)
A.
A.
Doors (Not Shown)
1
P5155495
Doors, Safari, 1984-01 Cherokee (XJ), 4-Dr.
Rock Rails (Not Shown)
P5155494
Rock Rails, 1984-01 Cherokee (XJ), 4-Dr.
C. Pre-Runner Body Components
1
Bumper, Front, 2009-10 Ram (DS) 1500, Pre-Runner
1
Fenders, Front, 2009-10 Ram (DS) 1500, Pre-Runner
P5155663
P5155665
1
P5155666
1
P5155664
B.
P5155481
B.
P5155352
Quarter Panels, 2009-10 Ram (DS) 1500, Pre-Runner
Tire Carrier, 2009-10 Ram (DS) 1500, Pre-Runner
HOODS AND HOOD COMPONENTS
D. Hoods
Add style and functionality with this stamped steel hood. Heavy gauge
galvanized hood is delivered E-coated and ready to paint. Complete bolt-on
package uses existing factory hardware.
1
Hood, Heat Reduction, 2007-09 Wrangler
P5155351
OFF ROAD TOOLS AND ACCESSORIES
C.
C.
C.
D.
D.
E.
E. Jack Base
Provides needed extra lift to your factory scissor jack when changing taller tires.
Stores neatly in your Wrangler's rear compartment.
Jack Base, 7.5" W x 10.5" L x 3.5" H
P5155336
P. | 258
(Jack Not Included)
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
PERFORMANCE CATALOG