MODEL
415.16108
• 640-810983-114
• PRODUCT
GUIDE
/_ CAUTION:
/_ WARNING:
Read and follow all safety statements, assembly
instructions, and use and care directions before
attempting to assemble and cook.
Failure to follow all manufacturer's
INSTALLER/ASSEMBLER:
/_ CAUTION:
Leave this manual with consumer.
Some parts may contain sharp edges especially as noted in the manual! Wear
protective gloves if necessary.
CONSUMER:
instructions
could result in serious personal injury and/or
property damage.
Keep this manual for future reference.
Printedin China • 463721108• 463721308 • 80013232 • 09-27-07
Installation
Safety Precautions
• Use grill only with LP (propane) gas and the regulator/valve
assembly supplied.
if you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. if odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
• Grill installation must conform with local codes, or in their
absence with National Fuel Gas Code, NFPA 54 / ANSI
Z223.1 and Natural Gas and Propane Installation Code,
CSA B149.1. Handling and storage of LP cylinders must
conform to LP Gas Code NFPNANSI 58. Grill is not for use in
or on recreational vehicles and/or boats.
, All electrical accessories (such as rotisserie) must be
electrically grounded in accordance with local codes, or
National Electrical Code, ANSI / NFPA 70 or Canadian
Electrical Code, CSA C22.1. Keep any electrical cords
and/or fuel supply hoses away from any hot surfaces.
. This grill is safety certified for use in the United States and/or
Canada only. Do not modify for use in any other location.
Modification will result in a safety hazard.
1. Do not store or use gasoline or other
flammable liquids or vapors in the vicinity of
this or any other appliance.
2. An LP cylinder not connected for use shall not
be stored in the vicinity of this or any other
appliance.
Call Grill Service Center for Help and Parts
. If you need assistance with your product or warranty parts call
1-800-241-7548. Hours of Service Center Operation are
8:00 A.M. To 6:00 P.M. EST Monday- Friday.
, To order non-warranty replacement parts or accessories
please visit us on the web at www.charbroil, com or call
1-800-241-7548 and one of our friendly and knowledgeable
agents will be glad to assist you.
CALIFORNIA PROPOSITION 65
1. Combustion by-products produced when using
this product contain chemicals known to the
State of California to cause cancer, birth defects,
and other reproductive harm.
2. This product contains chemicals, including lead
and lead compounds, known to the State of
California to cause cancer, birth defects or other
reproductive harm.
Wash your hands after handfinq this product.
Safety Symbols
Thesymbolsand boxesshownbelowexplainwhateachheading
means.Readandfollowallof the messagesfoundthroughout
the manual.
IMPORTANT: Fill out the product record information below.
DANGER: Indicates an imminently hazardous situation
which, if not avoided, will result in death or serious injury.
Model Number
Serial Number
See ratinglabel on grill for serialnumber.
WARNING: Indicatesan potentially hazardous situation
which, if not avoided, could result in death or serious
injury.
Date Purchased
D
__
CAUTION
For residential use only. Do not use for commercial
cooking.
2 " 463721108"463721308
T,o.
m
CAUTION: Indicates a potentially hazardous situation or
unsafe practicewhich, if not avoided, may result in minor
or moderate injury.
For Your Safety ......................................
2
Grill Service Center ...................................
2
Product Record Information ............................
2
Installation Safety Precautions ..........................
2
Safety Symbols ......................................
2
Use and Care ....................................
4-10
Parts List ..........................................
11
Parts Diagram ......................................
12
Assembly .......................................
13-23
Troubleshooting ..................................
24-25
Limited Warranty ....................................
26
Registration Card ...................................
27
Do not attempt to repair or alter the
hose/valve/regulatorfor any "assumed" defect. Any
modification to this assembly will void your warranty
and create the risk of a gas leak and fire. Use only
authorized replacement parts supplied by
manufacturer.
Certified Grill PartsAnd Accessories@,Char-Broil and Design@,Char-Broil (Gas Grill Briquettes)@,Char-Diamonds@,CookingZone and Design@,Diamond Flame@,Executive Chef@,Faststarf@,Flare
Fighter@,FlavorMaster@,Gas Grill Silouette and Design@,H20 Smoke@,Lava Flame@,MasterFlame@,MasterFlamePrecision CookingSystem@,PowerSpark@,Quantum@,VIP@,PrecisionFlameand
Design@,Sierra@,and TruFlame@are registeredTrademarksof the W,C. Bradley Company. TheeT_os@
is a registeredtrademarkof the Thermos Companyand its affiliates.
Artisan Collectionby Char-Broil T'_',C3 and DesignTM ,Char-Broil and Design_'_',FlameDesign_'_'
, FlavorTentsf'_', Grill 2 GoT'_'
, Grillin'Stick_'_',Keeperof the FJame_'_',Keepers of the Flame_'_',Natural Grip _'_'
,
OutdoorCooking Collectionand DesignTM, PatioBistro PrecisionFlameTM, Pro-Checkf'_',QuickSet Grills and DesignTM, SmokerTentsT'_',The Big EasyT'_',The Minute GdllT'',The Edge The Tuscan
Collection_'_',and The Urban GdllT'' are Trademarksof the W.C. Bradley Company. Universal GrillParts and DesignTM is a trademark of the TheeTIosCompanyand its affiliates.
Protectedunder one or moreof the following U.S. Patents: 4,598,692; 4,624,240;4,747,391; 4,747,391; 4,817,583; 4,924,846;4,989,579; 5,003,960; 5,076,256; 5,076,257;5,090,398; 5,109,834; 5,224,676;
5,277,106;5,421,319; 5,441,226; 5,452,707; 5,458,309;5,566,606; 5,566,606; 5,579,755; 5,582,094;5,613,486; 5,649,475; 5,706,797; 5,711,663;5,765,543; 5,931,149;5,996,573; 6,095,I32; 6,135,104;
6,173,644B1;6,279,566;6,397,73I; 6,418,923; 6,439,222;6,523,461; 6,935,327; D282,619;D339,714;D341,292;D343,337;D358,059;D361,466;D364,535;D372,637;D373,701; D377,735;D383,035;
D397,910;D405,643;D405,643;D406,005;D406,009;D413,043;D413,229;D413,229;D414,982;D415,388; D416,I64; D416,44I; D416,441;D417,587;D422,516;D423,274;D423,876;D428,303;D435,396;
D436,004;D438,059;D438,060;D438,427;D439,II0; D442,505;D443,I79; D443,354;D447,384;D447,385;D447,909;D448,610;D448,614;D448,615;D448,616; D448,975;D449,492; D451,759;D456,202S;
D460,313,D461,359and D504,048, Canada:87743; 87744; 92607; 92608 and 1,316,424, Other Patents Pending.Assembly instructions@2006,
TM,
TM,
463721108°463721308 • 3
LP Tank
• The LP tank used with your grill must meet the following
requirements:
• Use LP tanks only with these required measurements: 12"
(30.5cm) (diameter) x 18" (45.7 cm) (tall) with 20 lb. (9 kg.)
capacity maximum.
. LP tanks must be constructed and marked in accordance with
specifications for LP tank of the U.S. Department of
Transportation (DOT) or for Canada, CAN/CSA-B339,
cylinders, spheres and tubes for transportation of dangerous
goods, Transport Canada (TC). See LP tank collar for marking.
LP tank valve must have:
, Type 1 outlet compatible with
regulator or grill.
, Safety relief valve.
, UL listed Overfill Protection
OPDHand Wheel
Device (OPD). This OPD safety
feature is identified by a unique triangular hand wheel. Use
only LP tanks equipped with this type of valve.
, LP tank must be arranged for vapor withdrawal and include
collar to protect LP tank valve.
LP cylinder in upright position for vapor withdrawal
LP (Liquefied
LP Tank Removal, Transport And Storage
, Turn OFF all control knobs and LP tank valve. Turn coupling
nut counterclockwise by hand only - do not use tools to
disconnect. Lift LP tank wire upward off of LP tank collar, then
lift LP tank up and off of support bracket, install safety cap onto
LP tank valve. Always use cap and strap supplied with valve.
Failure to use safety cap as directed may result in serious
personal injury and/or property damage.
Petroleum Gas)
• LP gas is nontoxic, odorless and colorless when produced. For
Your Safety, LP gas has been given an odor (similar to rotten
cabbage) so that it can be smelled.
• LP gas is highly flammable and may ignite unexpectedly when
mixed with air.
LP Tank Filling
LP Tank Valve
• Use only licensed and experienced dealers.
• LP dealer must purge tank before filling.
• Dealer should NEVER fill LP tank more than 80% of LP tank
volume. Volume of propane in tank will vary by temperature.
Safety Cap
Retainer Strap
, A disconnected LP tank in storage or being transported must
have a safety cap installed (as shown). Do not store an LP tank
in enclosed spaces such as a carport, garage, porch, covered
patio or other building. Never leave an LP tank inside a vehicle
which may become overheated by the sun.
, Do not store an LP tank in an area where children play.
4 " 463721108"463721308
• A frosty regulator indicates gas overfill. Immediately close LP
tank valve and call local LP gas dealer for assistance.
, Do not release liquid propane (LP) gas into the atmosphere.
This is a hazardous practice.
, To remove gas from LP tank, contact an LP dealer or call a
local fire department for assistance. Check the telephone
directory under "Gas Companies" for nearest certified LP
dealers.
LP Tank Exchange
Connecting
o Many retailers that sell grills offer you the option of replacing
your empty LP tank through an exchange service. Use only
those reputable exchange companies that inspect, precision fill,
test and certify their cylinders. Exchange your tank only for
an OPB safety feature-equipped tank as described in the
"LP Tank" section of this manual.
1. LP tank must be properly secured onto grill. (Refer to
assembly section.)
Always keep new and exchanged LP tanks in upright position
during use, transit or storage.
Regulator To The LP Tank
2. Turn all control knobs to the OFF position.
3. Turn LP tank OFF by turning OPD hand wheel clockwise to a
full stop.
4. Remove the protective cap from LP tank valve. Always use
cap and strap supplied with valve.
, Leak test new and exchanged LP tanks BEFORE
connecting to grill,
LP Tank Leak Test
For your safety
• Leak test must be repeated each time LP tank is exchanged or
refilled.
Do not smoke during leak test.
• Do not use an open flame to check for gas leaks.
Grill must be leak tested outdoors in a well-ventilated area,
away from ignition sources such as gas fired or electrical
appliances. During leak test, keep grill away from open flames
or sparks.
, Use a clean paintbrush and a 50/50 mild soap and water
solution. Brush soapy solution onto areas indicated by arrows
in figure below. Leaks are indicated by growing bubbles.
Do not use a POL transport plug
(plastic part with external threads)!
it will defeat the safety feature of
the valve.
If "growing" bubbles appear do not use or move the LP tank.
Contact an LP gas supplier or your fire department!
A Do not use household cleaning agents. Damage to gas
train components can result.
5. Hold regulator and insert nipple into LP
tank valve. Hand-tighten the coupling
nut, holding regulator in a straight line
with LP tank valve so as not to crossthread the connection.
Nipple has to be centered
intothe LP tank valve.
O---*
463721108• 463721308• 5
Leak Testing Valves, Hose and Regulator
1. Turn all grill controlknobs to OFF.
2. Be sure regulator is tightly connected to LP tank.
3. Completely open LP tank valve by turning OPD hand wheel
counterclockwise. If you hear a rushing sound, turn gas off
immediately. There is a major leak at the connection. Correct
before proceeding.
Hold coupling nut and regulator
as shown for properconnection
to LP tank valve.
4. Brush soapy solution onto areas where bubbles are shown in
picture below:
A Never remove threaded
orifice at end of valve.
6. Turn the coupling nut clockwise and tighten to a full stop. The
regulator will seal on the back-check feature in the LP tank
valve, resulting in some resistance. An additional one-half to
three-quarters turn is required to complete the
connection. Tighten by hand only - do not use tools.
NOTE:
If you cannot complete the connection, disconnect regulator and
repeat steps 5 and 6. If you are still unable to complete the
connection, do not use this regulator!
, Do not insert any tool or foreign objects into the valve outlet
or safety relief valve. You may damage the valve and cause
a leak. Leaking propane may result in explosion, fire, severe
personal injury, or death..
if "growing" bubbles appear, there is a leak. Close LP tank
valve immediately and re-tighten connections. If leaks cannot
be stopped do not try to repair, Call for replacement parts.
Order new parts by giving the serial, model number, name and
part number of items needed (see parts list) to the Grill
Service Center at 1-800-241-7548.
, If a leak is detected at any time, STOP and call the fire
department.
, If you cannot stop a gas leak, immediately close LP tank
valve and call LP gas supplier or your fire department!
.
, Never attempt to attach this grill to the self-contained LP gas
system of a camper trailer or motor home.
, Do not use grill until leak-tested.
6 " 463721108"463721308
Always close LP tank valve after performing leak test by
turning hand wheel clockwise.
Safety Tips
,A. Before opening LP cylinder valve, check the coupling nut for
tightness.
For Safe Use Of Your Grill And To Avoid Serious
injury:
• Do not let children operate or play near grill.
• Keep grill area clear and free from materials that burn.
• Do not block holes in bottom or back of grill.
• Check burner flames regularly.
• Use grill only in well-ventilated space. NEVER use in
enclosed space such as carport, garage, porch, covered
patio, or under an overhead structure of any kind.
• Do not use charcoal or ceramic briquets in a gas grill.
(Unless briquets are supplied with your grill.)
• Use grill at least 3 ft. from any wall or surface. Maintain
10 ft. clearance to objects that can catch fire or sources of
ignition such as pilot lights on water heaters, live electrical
appliances, etc.
A When grill is not in use, turn offall control knobs and LP
cylinder valve.
A Never move grill while in operation or still hot.
A Use long-handled barbecue utensils and oven mitts to avoid
burns and splatters.
A Maximum load for sideburner and side shelf is 10 Ibs.
A The grease tray must be inserted into grill and emptied after
each use. Do not remove grease tray until grill has
completely cooled.
,A. Clean grill often, preferably after each cookout. If a bristle
brush is used to clean any of the grill cooking surfaces,
ensure no loose bristles remain on cooking surfaces prior to
grilling. It is not recommended to clean cooking surfaces
while grill is hot.
,A. If you notice grease or other hot material dripping from grill
onto valve, hose or regulator, turn off gas supply at once.
Determine the cause, correct it, then clean and inspect valve,
hose and regulator before continuing. Perform a leak test.
A Keep ventilation openings in cylinder enclosure (grill cart) free
and clear of debris.
,A. Do not store objects or materials inside the grill cart
enclosure that would block the flow of combustion air to the
underside of either the control panel or the firebox bowl.
,A. The regulator may make a humming or whistling noise during
operation. This will not affect safety or use of grill.
A If you have a grill problem see the "Troubleshooting Section".
,A. If the regulator frosts, turn off grill and LP cylinder valve
immediately.This indicates a problem with the cylinder and it
should not be used on any product. Return to supplier!
CAUTION
• Putting out grease fires by closing the lid is not
possible, Grills are well ventilated for safety reasons,
Apartment Dwellers:
Check with management to learn the requirements and fire
codes for using an LP gas grill in your apartment complex. If
allowed, use outside on the ground floor with a three (3) foot
clearance from walls or rails. Do not use on or under
balconies.
• Do not use water on a grease fire. Personal injury may
result, if a grease fire develops, turn knobs and LP
cylinder off,
• Do not leave grill unattended while preheating or
burning off food residue on Hi. if grill has not been
regularly cleaned, a grease fire can occur that may
damage the product,
• NEVER attempt to light burner with lid closed. A buildup
of non-ignited gas inside a closed grill is hazardous.
• Never operate grill with LP tank out of correct position
specified in assembly instructions,
• Always close LP tank valve and remove coupling nut
before moving LP tank from specified operation
position.
463721108"463721308 • 7
CAUTIO./t
ignitor Lighting
A Do not lean over grill while lighting.
1. Turn OFF all burner control valves.
• Putting out grease fires by closing the lid is not
possible. Grills are well ventilated for safety reasons.
2. Turn ON gas source or tank.
3. Open lid during lighting.
4. To ignite, turn LEFT knob to,_
High.
5. Push IGNITOR button rapidly.
6. If ignition does NOT occur in 5 seconds, turn the burner
controls OFF, wait 5 minutes and repeat the lighting
procedure.
7. To ignite right burner, turn knob to _.
If ignitor does not work, follow match lighting instructions.
After Lighting: Turn knobs to HI position for warm-up.
CAUTION
If burner does not light, turn knobs to OFF, wait 5
minutes, and try again. Always close valve during the 5
minute waiting period. If the burner does not ignite with
the valve open, gas will continue to flow out of the burner
and could accidentally ignite with risk of injury.
• Do not use water on a grease fire. Personal injury may
result. If a grease fire develops, turn knobs and LP tank
off.
• Do not leave grill unattended while preheating or
burning off food residue on high. if grill has not been
regularly cleaned, a grease fire can occur that may
damage the product. Follow instructions on General
Grill Cleaning and Cleaning The Burner Assembly to
prevent grease fires.
Before Your First Cookout
, Light burners, check to make sure they are lit, close the lid and
warm up grill on HIGH for 15 minutes. This curing of paint and
parts will produce an odor only on first lighting.
Burner Flame Check
, Light burner, rotate knobs from HIGH to LOW. You should see
a smaller flame in LOW position than seen on HIGH. Always
check flame prior to each use. If only low flame is seen refer to
"Sudden drop or low flame" in the Troubleshooting Section.
Match-Lighting
A Do not lean over grill while lighting.
1. Open lid during lighting.
2. Place match into match holder (hanging from side of cart).
3. Push in and turn left knob to _
burner lights and stays lit.
HIGH position. Be sure
4. Light right burner by pushing knob in and turning to _ HIGH
position.
Hose Check
• Before each use, check to see if hoses are cut, worn or kinked.
Replace damaged hoses before using grill. Use only
valve/hose/regulator specified in the Parts List.
Normal
Hose
8 " 463721108"463721308
Kinked
Hose
Turning Grill Off
CAUTION
, Turn all knobs to OFF position. Turn LP tank off by turning
OPD hand wheel clockwise to a full stop.
SPIDER
ignitor Check
• Turn gas off at LP tank. Press and hold ignitor button. "Click"
should be heard and spark seen each time between collector
box or burner and electrodes. See "Troubleshooting" if no click
or spark.
ALERT!
GASCOLLECTOR
Valve Check
• Important: Make sure gas is off at LP tank before checking
valves. Knobs lock in OFF position. To check valves, first
push in knobs and release, knobs should spring back. If knobs
do not spring back, replace valve assembly before using grill.
Turn knobs to LO position then turn back to OFF position.
Valves should turn smoothly.
General Grill Cleaning
VALVE
AIR
SHUTTER
VENTURI
If you notice that your grill is getting hard to light or that the
flame isn't as strong as it should be, take the time to check and
clean the venturi's.
, Keep the outside of your grill looking new by cleaning it once a
month with warm soap and water or a non-abrasive cleaner. If
you don't have a grill cover, wipe off dust and grime before
starting your grill.
LIFT OUT
BURNERASSEMBLY
, Coating the cooking grids with spray-on cooking oil will keep the
food from sticking and make clean up easier. After cooking,
scrape the grates with a long handled, brass wire bristle brush.
i
REMOVE
BURNER
CLIPS
, Check inside the grill bottom for grease build up and clean
often, especially after cooking fatty meat.
, Do not mistake brown or black accumulation of grease and
smoke for paint. Apply a strong solution of detergent and water
or use a grill cleaner with scrub brush on insides of grill lid and
bottom. Rinse and allow to completely air dry. Do not apply a
caustic grill/oven cleaner to painted surfaces.
• Plated wire grates: Wash grates with concentrated grill
cleaner or use soap and water solution. Dry thoroughly and
store indoors between cookouts.
, Plastic parts: Wash with warm soapy water and wipe dry.
A Do not use citrisol, abrasive cleaners, degreasers or a
concentrated grill cleaner on plastic parts. Damage to and
failure of parts can result.
i
?
6/
VENTURI
CLEAN
OUT
INSIDEVENTURI
SPIDERWEBS
Insome areasof thecountry,spidersor small insectshavebeen
knownto create"flashback"problems.Thespidersspinwebs,build
nestsand layeggsin thegrill'sventuritube(s)obstructingthe flow of
gas to the burner.The backed-upgas can ignitein the venturibehind
the controlpanel.This is knownas a flashbackand it can damage
your grill andeven causeinjury.
Topreventflashbacksand ensuregood performancethe burnerand
venturiassemblyshouldbe removedfrom thegrill andcleaned
beforeusewheneverthe grill has beenidle for an extendedperiod.
\
J
* Porcelain grates: Because of glass-like composition, most
residue can be wiped away with baking soda/water solution or
specially formulated cleaner. Use non-abrasive scouring
powder for stubborn stains.
• Cooking surfaces: If a bristle brush is used to clean any of
the grill cooking surfaces, ensure no loose bristles remain on
cooking surfaces prior to grilling. It is not recommended to
clean cooking surfaces while grill is hot.
463721108• 463721308• 9
Cleaning the Burner Assembly
Follow these instructions to clean and/or replace parts of burner
assembly or if you have trouble igniting grill.
1. Turn gas off at control knobs and LP cylinder,
2. Remove cooking grate and heat tent.
3. Under grill remove grease cup, disconnect ignitor wire from
burner.
Storing Your Grill
4.
Inside grill remove burner assembly (A), clean ceramic
portion of electrode with rubbing alcohol and a swab.
Clean outside of burner with soap and water. Lay burner
upside down on flat surface, insert garden hose to force
water through tubes. Make sure water comes out of all
burner holes. Open clogged holes with a thin wire. Shake
out excess water and examine holes. Due to normal wear
o Store grill indoors ONLY if LP tank is turned offand
disconnected, removed from grill and stored outdoors.
and corrosion some holes may become enlarged. If any
large cracks or holes are found replace burner.
If grill is to be stored, coat burner lightly with cooking oil.
Wrap in protective cover to keep insects out.
If not storing grill after cleaning, replace burner into grill
bottom.
Food safety is a very important part of enjoying the outdoor
cooking experience. To keep food safe from harmful bacteria,
follow these four basic steps:
5.
6.
7.
VERY IMPORTANT: Burner tubes must re-engage valve
openings. See illustration (A).
8. Reattach ignitor wire to electrode.
9. Reposition heat tent and cooking grate. Reattach clean
grease cup to grease clip.
10. Before cooking again on grill, perform a "Leak Test'and
"Burner Flame Check".
o Clean cooking grates.
o Store in dry location.
o When LP tank is connected to grill, store outdoors in wellventilated space and out of reach of children.
o Cover grill if stored outdoors.
, When removing grill from storage follow "Cleaning Burner
Assembly" instructions before starting grill.
Food Safety
Clean: Wash hands, utensils, and surfaces with hot soapy water
before and after handling raw meat and poultry.
Separate: Separate raw meats and poultry from ready-to-eat
foods to avoid cross contamination. Use a clean platter and
utensils when removing cooked foods.
Cook: Cook meat and poultry thoroughly to kill bacteria. Use a
thermometer to ensure proper internal food temperatures.
Chill: Refrigerate prepared foods and leftovers promptly.
For more information call: USDA Meat and Poultry Hotline at
1-800-535-4555 (In Washington, DC (202) 720-3333, 10:00 am4:00 pm EST).
How To Tell If Meat is Grilled Thoroughly
Correct burner-to-valve engagement
• Meat and poultry cooked on a grill often browns very fast on the
outside. Use a meat thermometer to be sure food has reached
a safe internal temperature, and cut into food to check for
visual signs of doneness.
A
• Whole poultry should reach 180° F; breasts, 170° F. Juices
should run clear and flesh should not be pink.
• Hamburgers made of any ground meat or poultry should reach
160° F,and be brown in the middle with no pink juices. Beef,
veal and lamb steaks, roasts and chops can be cooked to 145°
R All cuts of pork should reach 160 ° R
Burner Tube
Valve
• NEVER partially grill meat or poultry and finish cooking later.
Cook food completely to destroy harmful bacteria.
• When reheating takeout foods or fully cooked meats like hot
dogs, grill to 165° F, or until steaming hot.
10 • 463721108"463721308
Description ...................
Part#
2
Control Knobs ...............
80000035
EE
2
Hinges, Lower ...............
80010090
80010069
FF
2
Hinges, Upper ...............
80010091
Lid ........................
80010070
GG
1
Handle .....................
80010092
1
Logo Plate ..................
80005765
HH
1
Heat Tent ...................
80009840
F
2
Shelves ....................
80010072
II
1
Cooking Grate ...............
80013224
G
2
Mounting Brackets, RFt LB .....
80010073
JJ
1
Match Holder ................
80004320
H
2
Mounting Brackets, LFt RB .....
80010074
KK
1
Heat Shield .................
80010089
I
2
Upper Leg ..................
80010075
1
Assembly Instruction (English) .. 80013232
J
1
Side Brace, F/Tank Retainer.... 80010076
1
Assembly Instruction (Spanish).. 80013233
K
1
Leg, Right Front..............
80010077
1
Hardware Pack ..............
80015900
L
1
Leg, Right Back ..............
80010078
1
Wheel Bushing ...........
80009743
M
1
Leg, Left Back ...............
80010079
4
Hinge Pins...............
80003610
N
1
Leg, Left Front ...............
80010080
5
Hitch Pins ...............
80003661
O
2
Back Braces.................
80010081
1
Wing Screw, #10-24x3t8" ... 80008304
P
2
Support Bracket ..............
80010082
26
Screws, #10-24xlt2"
Q
1
Firebox Support, Left ..........
80010083
38
Flange Nuts, #10-24
R
1
Firebox Support, Right.........
80010084
2
Wing Nuts, 1t4"-20
S
1
Tank Exclusion Wire ..........
80010193
12
Screws, #10-24x1-1t4"
T
1
Valve/Hose/Regulator .........
80013769
12
Screws, #10-24x2"
U
1
Control Panel................
80013770
22
Fiber Washers, 5mm
V
1
Front Panel .................
80010087
4
Fiber Washers, 7mm
W
1
Axle Rod ...................
80012692
4
Screws, 1/4"-20x1/2"
X
2
Leg Extenders...............
80009820
4
Flange Nuts, 1/4"-20
Y
1
Grease Cup .................
80000270
4
Screws, 1t4"-20x1-1t4"
Z
1
Grease Cup Clip .............
80000271
1
Spacer
AA
1
Tank Retainer................
80009014
BB
1
Ignitor......................
80008322
CC
2
Wheels.....................
80010191
K_X_y
Description ...................
Part#
A
1
Firebox.....................
80012226
DD
B
1
Heat Shield Firebox ...........
80010068
C
1
BurnerAssembly .............
D
1
463721108°463721308 "11
FF_
B
E
"GG
Y,_
H
jJJ
/N
CC
W
CC
12 • 463721108"463721308
Left Leg
Placeupperleg as shown. NOTE:Left front and left back legsdo not haveleg extenders. Infront,attachupperleg,side brace
and left front leg (curve)with #10-24x!-1/4" screw and #10-24flange nut. In back,attachedupperleg,side braceand left back
leg (straight)with #10-24x1-1/4"screw and #10-24flange nut. Do not tighten.
Attachsupportbracketin secondholefrom bottomof leg with a hingepinsand hitch pins(A).
S
UpperLeg
HitchPin
Qty:2
_
8race
LeftFrontLeg
HingePin
Qty:2
(Curve)
_
............
_
(::_1
Left BackLeg
o/./
#10-24x1-1/4"
Screw
Qty:2
(Straight) _
SupPort
BraCket
#10-24FlangeNut
Qty:2
Right Leg
Placeupperleg as shown.Attachupperleg and rightfront leg (curve)with #10-24x1-1/4"screws and #10-24flange nuts. Then
attachupperleg and rightback leg (straight)with #10-24x1-1/4"screws and#10-24flange nuts. Do not tighten.
Attachsupportbracketwith #10-24x1-1/4"screws and #10-24flange nuts.
#10-24 FlangeNut
Qty:4
#10-24x1-1/4"
Screw
Qty:4
RightFront Leg
(Curve)
S_ort
RightBack Leg\
(Straight) _
Bracket
Leg Extender
463721108" 463721308 " 13
Hooktank exclusionwire into legswith openingfor LP cylinderon side braceside.
Tank Exclusion Wire
\
Side Brace
Largeropeningside
TankExclusionWire
D
Lay
front legs down on the floor,
Front Panel
Slidefront panel betweenlegs.Attachwith #I0-24x2" screwsand #10-24flange nuts.
FrontPanel
\
#10-24x2"Screw
Qty:4
#10-24Nut
Qty:4
14 " 463721108" 463721308
Back Braces to Cart
Removescrewsand nutsfrom upperlegs as shown.Attachback braceswith #10-24x1-1/4"screws and #10-24flange nuts.
#10-24x1-1/4"
Screw
Qty: 6
Remove screws and
nuts to attach brace
#10-24
FlangeNut
Qty:6
Back Brace
Wheels
Turnassemblyupsidedown.
Insertaxlerod intowheel, legs,spacerand otherwheel.Attachwith a wheel bushingand hitchpin.
HitchPin
Qty:l
WheelBushing
Qty:l
Spacer
Spacer
Qty:l
HitchPin
¢
WheelBushing
Axle Rod
Wheel
"Cone" side of wheel against leg
463721108• 463721308 o15
Control Panel and Upper FireboxSupports
Standcart upright.
Infront,slice controlpanelbetweenleftand rightlegs, attachcontrolpanelwith #10-24x2"screws. Placeupperfirebox
supportsontoscrewsand tightenwith #!0-24 flange nuts. Tightenall screws.
Inback,attachupperfireboxsupportwith #10-24x2"screws and #10-24flange nuts.
Chamferedc
ControlPanel
#10-24x2"
Screws
Qty:8
#10-24FlangeNut
Qty:8
Valve/Hose/Regulatorand Ignitor
Attachvalve/hose/regulator
assemblyto controlpanelwith #10-24x1/2"screws.
Attach ignitorto controlpanel usingthe stampednutthat'sprovided.
Ignitor
#10-24xl/2"Screw
Qty:2
16 " 463721108"463721308
Heat Shield
Attach heatshieldwith #10-24x1/2"screws and#10-24flange nuts.
HeatShield
#10-24xl/2' Screw
Qty: 2
#10-24FlangeNut
Qty:2
Tank Retainer
Inserttank retainerintoside braceand securewith wingscrew.
#10-24x3/8"WingScrew
Qty:l
TankRetainer
463721108" 463721308 " 17
Burner, Fireboxand Control Knobs
Placeburnerassemblyintofirebox(A). Fastenthe burnerassemblyto the fireboxusing5ramfiber washersand #10-24x 1/2"
machine screws.
Placefirebox ontoupperfireboxsupports.Makesure burnertubes are correctlyengaged(B).If burneris not leveledfrom left to
right,adjustthe two screwsattachingvalveto controlpanel.Attachignitorwire to ignitor(B).
Attachfireboxwith #10-24x1/2"screws, 5ramfiber washers and#10-24flange nuts (C).
Pushcontrolknobsontovalvestems (C).
5mm FiberWasher
Qty:6
#10-24xl/2"
Screw
Qty:6
#10-24
FlangeNut
Qty:4
i
i
i
i
C
Control
Knob
18 " 463721108"463721308
Shelves
Insertmountingbracketsintoshelf supportswith #!0-24x1/2" screws (A).
Attachmountingbracketsto frontof legwith 1/4"-20x1/2"screws, Backof leg with 1/4"-20x1-1/4"screw and1/4"-20flange nuts
(B).
Repeat above steps for other side shelf.
#10-24x1/2"
Screw
1/4"-20xl/2"
Screw
Qty:8
Qty:4
1/4"-20FlangeNut
Qty:4
1/4"-20xl-1/4"
Screw
Qty:4
A
\
Screw
MountingBracket
ShelfSupport
B
Side Shelf
/
1/4"-20x1-1/4"
Screw
1/4"-20xl/2"
Screw
463721108" 463721308 " 19
LowerHinges
Attachlowerhingesto backof firebox using#10-24x1/2"screws, 5mmfiber washers and #10-24flange nuts, Thecenter
flat portionof the hingeshouldbe at the bottom(seeinset).
#10-24xl/2"
Screw
Qty:4
5mm
FiberWasher
#10-24
FlangeNut
Qty: 8
Qty:4
LowerHinge
Lid Handleand Upper Hinges
Attachhandleto lid with 7ramfiber washersand 1/4-20wing nuts.
Attachupperhingesto backof lid using#10-24x1/2"screws, 5ramfiber washers and #10-24flange nuts, Hingesshould
curvedownwardwhenproperlyinstalled.Do not tightenupperhingescrews.
Handle
#10-24x1/2"
Screw
Qty:4
5mm
FiberWasher
Qty:8
7mm
FiberWasher
Qty:4
#10-24
FlangeNut
Qty:4
7mm FiberWasher
i
,_
1/4-20
Wing Nut
Qty: 2
5ramFiberWasher
_
t
J
20 • 463721108"463721308
UpperHinge
Lid
Place lid assembly onto firebox, aligning hinges. Hinges on lid fit inside hinges on firebox. Secure using two hinge pins
and hitch pins. Tighten lid hinge screws.
HitchPin
Qty:2
HingePin
Qty: 2
Heat Tent
Place heat tent into firebox.
HeatTent
463721108" 463721308" 21
Cooking Grate
Placegrateintofirebox.
CookingGrate
GreaseCup Clip and GreaseCup
Hanggreasecup clipfrom bottomof fireboxand placegreasecupintogreaseclip.
CAUT|ON
FaUureto installgreasecup clip and cup
will causehotgrease to drip from bottom
of grill with risk of fire or property damage,
GreaseCupClip
GreaseCup--
22 • 463721108"463721308
LP Tank
LP tank is soldseparately.Useonlywith an OPD(over-fillprotectiondevice)equippedLPtank. Filland leakcheck before
attachingto grill and regulator.See Use and Care section to correctly Leak Test and perform the Burner Flame Check.
Tankcollaropeningmustface to front of grill.Loosenwing nutfrom tank retainerbracket.Set bottomof tank ontonotchesin the
tank bracket.Placetank retainerbracketontotank collarand tightenthewing nut.
CAUTION
Tank
Cylinder valve must face to front of cart once
tank is attached. Failure to install cylinder
correctly may allow gas hose to be damaged
in operation, resulting in the risk of fire.
Correctly Installed
LP cylinder.
Regulator
Always keep LP cylinders in
upright position during use,
transport, and storage.
LP Tank
463721108• 463721308 • 23
Troubleshooting
EMERGENCIES:
if a gas leak cannot be stopped,
or a fire occurs due to gas leakage, call the fire department.
Gasleakingfrom
cracked/cut/burned
hose.
, Damagedhose.
, Turnoff gas at LP tank. If hoseis cut or cracked,replace
valve/hose/regulator.
See LP TankLeakTestand Connecting
RegulatorToThe LPTank.
Gasleakingfrom LP
tank.
, Mechanicalfailuredue to rustingor
mishandling.
, Turnoff LP tankvalve.
Gasleakingfrom LP
tank valve,
, Failureof tank valvefrom mishandlingor
mechanicalfailure.
, Turnoff LP tank valve.ReturnLP tank togas supplier.
Gasleakingbetween
LP tankand regulator
connection.
, Improperinstallation,connectionnot
tight,failureof rubberseal.
, Turnoff LP tankvalve.Removeregulatorfrom cylinderand visually
inspectrubbersealfor damage.See LP TankLeakTestand
ConnectingRegulatorToTheLP Tank.
Firecomingthrough
controlpanel.
, Fire in burnertubesectionof burnerdue
to partialblockage.
, Turnoff controlknobsand LP tankvalve.Leavelid open to allow
flamesto die down.After fire is out and grill is cold, removeburner
and inspectfor spidernestsor rust.See NaturalHazardand Cleaning
The BurnerAssemblypages.
Greasefire or
continuousexcessive
flamesabovecooking
surface.
Burner(s)will not light
usingignitor.
Continuedon next
page.
24 • 463721108"463721308
, Toomuchgreasebuildupin burnerarea.
, Turnoff LP tank valve.Leavelid opento allowflamesto die down.
After cooling,cleanfood particlesand excessgreasefrom inside
fireboxarea,greasecup/pan/tray,and othersurfaces.
GAS ISSUES:
, Tryingto lightwrongburner.
, See instructionson controlpaneland sectionin the Use and Care.
, Burnernotengagedwith controlvalve.
, Makesure valvesare positionedinsideof burnertubes.
, Obstructionin burner.
, Ensureburnertubes are notobstructedwith spiderwebs or other
matter.See cleaningsectionof Useand Care.
, No gasflow.
, Makesure LP tank is notempty.If LP tank is notempty,referto
"Suddendrop in gasflow."
, Vaporlockat couplingnut to LP tank.
, Turnoff knobsand disconnectcouplingnutfrom LP tank.Reconnect
and retry.
, Couplingnutand LP tank valve notfully
connected.
, Turnthecouplingnut approximatelyone-halfto three-quarters
additionalturnuntil solidstop.Tightenby hand only- do notusetools.
ELECTRICALISSUES:
, Electrodecrackedor broken;"sparksat
crack."
. Replaceelectrode.
, Electrodetip not in properposition.
, Tip of electrodeshouldbe pointingtowardport holein burner.The
distanceshouldbe 1/8"to 3/16".Adjust if necessary.
, Wireand/orelectrodecoveredwith
cookingresidue.
, Cleanwireand/orelectrodewith rubbingalcoholand cleanswab.
, Wires are looseor disconnected.
, Reconnectwiresor replaceelectrode/wireassembly.
, Wires are shorting(sparking)between
ignitorand electrode.
, Replaceignitorwire.
Troubleshooting (continued)
Burner(s)will not light
usingignitor.
Burner(s)will not
matchlight.
, Push-buttonsticksat bottom..
, Replaceignitor.
, Sparkingbetweenignitorand electrode.
, Inspectwireinsulationand properconnection.Replacewires if
insulationis broken.
, See "GAS ISSUES:"on previouspage.
, Impropermethodof match-lighting.
, See"Match-Lighting"sectionof Useand Care.
, Outof gas.
, Checkfor gas in LP tank.
, Excessflow valvetripped.
, Turnoff knobs,wait 30 secondsand light grill.If flamesare still low,
turnoff knobsand LPtank valve.Disconnectregulator.Reconnect
regulatorand leak-test.Turnon LP tank valve,wait 30 secondsand
thenlightgrill.
, Vaporlock at couplingnut/LPtank
connection.
, Turnoff knobsand LP tank valve.Disconnectcouplingnutfrom
tank.Reconnectand retry.
, Highor gustingwinds.
, Turnfront of grill to face windor increaseflame height.
, Lowon LP gas.
, RefillLP tank.
, Excessflow valvetripped.
, Referto "Suddendrop in gasflow"above.
, Greasebuildup.
, Cleanburnersand insideof grill/firebox.
, Excessivefat in meat.
, Trimfat from meat beforegrilling.
, Excessivecookingtemperature.
, Adjust (lower)temperatureaccordingly.
Persistentgreasefire.
, Greasetrappedbyfood builduparound
burnersystem.
, Turnknobsto OFF.Turngas off at LPtank. Leavelid in positionand
letfire burn out.After grill cools,removeand cleanall parts.
Flashback...
(firein burnertube(s)).
, Burnerand/orburnertubesare blocked.
, Turnknobsto OFF.Cleanburnerand/orburnertubes.See burner
cleaningsectionof Use andCare manual.
Unabletofill LP tank.
, Somedealershaveolder fill nozzles
with wornthreads.
, Thewornnozzlesdon'thaveenough"bite"to engagethe valve.Try
a secondLP dealer.
, Greasebuildupor foodparticlesin
end(s)of carryovertube(s).
, Cleancarry-overtube(s)with wire brush.
Suddendrop in gas
flow or lowflame.
Flamesblowout.
Flare-up.
Oneburnerdoesnot
lightfrom other
burner(s).
463721108• 463721308 • 25
Manufacturerwarrantsto theoriginalconsumer-purchaser
only that this productshall be freefrom defectsin workmanshipand materialsafter
correctassemblyand under normaland reasonablehomeusefor the periodsindicatedbelowbeginningon thedate of purchase.
The manufacturerreservesthe rightto requirethatdefectiveparts be returned,postageand or freight pre-paid,bythe consumer,for reviewand
examination.
1 YearLIMITED
warranty
Uponconsumersupplyingproofof purchaseas providedherein,Manufacturerwill repairor replacethe partslisted belowwhichare proven
defectiveduringthe applicablewarrantyperiod.Parts requiredto completesuchrepairor replacementshall be freeof chargeto youexceptfor
shippingcosts.Theoriginal consumer-purchaser will be responsible for all shipping charges of parts replaced under the terms of this
limited warranty,
This limitedwarrantyis applicablein the UnitedStatesand Canadaonly,is only availableto theoriginalownerof theproductand is not
transferable.Manufacturerrequiresreasonableproofof your dateof purchase.Therefore,you shouldretainyoursalesslip or invoiceand register
yournew productimmediately.Defectiveor missingpartssubjectto this limitedwarrantywill notbe replacedwithoutregistrationand proofof
purchase.Registeronlineat http://www.charbroil.com
or completeand returnvia mailthe ProductRegistrationCardlocatedon the last pageof the
Use & Caremanualincludedwith this productand retainyoursales receiptfor proofof purchase.
This limitedwarrantyappliesto the functionalityof the productONLYand doesnot covercosmeticissuessuch asscratches,dents,corrosions
or discoloringby heat,abrasiveand chemicalcleanersor any tools usedin the assemblyor installationof the appliance,surfacerust,or the
discolorationof stainlesssteelsurfaces.
This limitedwarrantywill not reimburseyoufor the costof anyinconvenience,food, personalinjuryor propertydamage.
If an originalreplacementpart is notavailable,a comparablereplacementpartwill be sent.Youwill be responsiblefor all shippingchargesof
parts replacedunder thetermsof this limitedwarranty.
iTEMSMANUFACTURERWILL NOTPAY FOR:
1. Servicecalls to yourhome.
2. Repairswhenyourproductis usedfor otherthannormal,single-familyhouseholdor residentialuse.
3. Damageresultingfrom accident,alteration,misuse,abuse,fire, flood, actsof God,improperinstallation,installationnot in accordancewith
electricalor plumbingcodes,or useof productsnotapprovedby the manufacturer.
4. Any foodloss due to productfailures.
5. Replacementparts or repairlaborcostsfor units operatedoutsidethe UnitedStatesor Canada.
6. Pickupand deliveryd yourproduct.
7. Repairsto parts or systemsresultingfrom unauthorizedmodificationsmadeto the product.
8. Theremovaland/orreinstallationof your product.
9. Shippingcost,standardor expedited,for warrantyand replacementparts.
DISCLAIMEROF IMPLIEDWARRANTIES;LIMITATIONOF REMEDIES
Repairor replacementof defectparts is yourexclusiveremedyunderthe termsof this limitedwarranty.Manufacturerwill not be responsiblefor
any consequentialor incidentaldamagesarisingfrom the breachof eitherthis limitedwarrantyor any applicablewarranty,or for failureor damage
resultingfrom actsof God,impropercareand maintenance,greasefire, accident,alteration,
replacementof partsby anyoneotherthan Manufacturer,misuse,transportation,commercialuse, abuse,hostileenvironments(inclementweather,
actsof nature,animaltampering),improperinstallationor installationnot in accordancewith localcodesor printedmanufacturerinstructions.
THISLIMITEDWARRANTYISTHE SOLEEXPRESSWARRANTYGIVENBYTHE MANUFACTURER.
NO PRODUCTPERFORMANCE
SPECIFICATIONOR DESCRIPTION
WHEREVERAPPEARINGIS WARRANTEDBY MANUFACTUREREXCEPTTOTHE EXTENTSET FORTH
INTHISLIMITEDWARRANTY.
ANY IMPLIEDWARRANTYPROTECTIONARISINGUNDERTHE LAWSOFANYSTATE,INCLUDINGIMPLIED
WARRANTYOF MERCHANTABILITY
OR FITNESSFORA PARTICULARPURPOSEOR USE,IS HEREBYLIMITEDIN DURATIONTOTHE
DURATIONOFTHISLIMITEDWARRANTY.
Neither dealers nor the retail establishment selling this product has any authority to make _ additional warranties or to promise
remedies in addition to or inconsistent with those stated above,
Manufacturer'smaximumliability,in anyevent,shallnot exceedthe documentedpurchasepriceof the productpaid by theoriginalconsumer.
This warranty only applies to units purchased from an authorized retailer and or re-seller,
NOTE:Somestatesdo notallowan exclusionor limitationof incidentalor consequentialdamages,so someof theabovelimitationsor
exclusionsmay notapplyto you. This limitedwarrantygives youspecificlegal rightsas set for herein.Youmay alsohaveotherrightswhich vary
from stateto state. Inthe stateof Californiaonly,if refinishingor replacementof the productis notcommerciallypracticable,the retailersellingthis
productor the Manufacturerwill refundthe purchasepricepaidfor the product,lessthe amountdirectlyattributableto use by theoriginalconsumerpurchaserpriorto discoveryof thenonconformity.In addition,in the stateof Californiaonly,youmay take the productto the retailestablishment
sellingthis productin orderto obtainperformanceunderthis limitedwarranty.
If you wish to obtain performanceof any obligation under this limited warranty, you should write to:
Char-Broil Consumer Relations
P,O. Box 1240
Columbus, GA 31902-!240
Consumerreturnswill not be acceptedunlessa validReturnAuthorizationis first acquiredbycalling1-800-241-7548and then clearlymarked
on the outsideof the packageand the packageis shippedfreight/postagepre-paidto the addressabove.
26 • 463721108"463721308
Pleaseregisteryour rill onlineat:
(if you register online, you do not need to send in this registration card.)
PLEASEPiLL OUTTHiS CARD AND RETURNiT WITHIN10 DAYSOF PURCHASE=FAILURETORETURN MAYAFFECTYOURWARRANTYCOVERAGE,
|
LLENE ESTA TARJETAY DEVU_:LVALADENTRODE LOS 10 DiAS DE LA COMPRA.SI NO LA DEVUELVE,PUEDE VERSEAFECTADASU COBERTURADE GARANT/A.
VEUILLEZCOMPLC:TERCETTE CARTEET LA RETOURNERDANSLES 10 JOURS SUIVANTL'ACHAT.
LA COUVERTUREDE VOTREGARANTIEPOURRAITEN ETREAFFECTEESI VOUSNE LE FAiTES PAS,
1
FirstHarne/Nombre/Pr_norn
Initioi/inicioi/initioieLastNamo/Apeiiida/Homdotamiiie
11111111111111111
I I
I!
! ! ! ! ! ! ! ! ! ! ! I ! ! ! ! ! ! ! I
Address(number and street)/Direcoi6n(namero y calJe)/Adrosso(numero et rue)
I ! I!
AptNumber/H-_de aport,/N-°d'appt,
! ! ! ! ! ! ! ! ! ! ! ! ! ! ! ! ! ! ! ! ! ! ! I
City/Ciadad/Ville
I ! !!
2
I !
Stoto/Estado/Province
! ! ! ! ! I ! ! ! ! ! ! ! ! ! ! ! ! ! I
I I I I
ZipCade/C6diga
zip/Codepostal
I I I
I !
! ! ! I
E-rnoil Address/Birecci6n
docorrooeiectr6oico/Adrosse
_lectroniquo
If you voluntarily provide us with your email address, you give us permission
to use your email address to send you offers that may interest you.
Si nos intorma voluntariamente
su direcci4n de correo electr4nico, nos da permiso pare usarlo a fin de enviarle ofertas que pueden interesarle.
Si vous cholsissez de nous fournir votre adresse 4tectronique,
vous nous donnez la permission
de Futihser pour vous faire part d'offres sp_ciales
de
susceptibles
VOUS int_ressel_
I
I
(Example: your name@your host.com) (Ejemplo: su nombre@su host,corn) (Exemple : votre nom@votre hSte.com)
3
PhoneNsrnber/N_merotelef6nico/Num6rode t_l_phone
I II
4
6 Dateat Purchaso/Fechode compro/Bote
doI'achot
I I I I I ! ! ! I
I I II
iMPORTAHTUiiMPORTANTE!/IMPORTANT!
Write Serial Number and Model Number in spaces below.
Escriba en los espacios de abajo et n_mero de serie y el n_mero
de modulo,
Inscrivez le numero de serie et le numero de modele dens los
espaces ci-deseous.
1.[]
5 YourGender/Sexo/Sexe:
9 Which product are your registering?
i,Qu_ predactoest_ registrando?
Quel produit enregistrez-vous?
1. [] Gas Grill/Parrila a gas/
Gril au gaz
2. [] Electric Grill/Parrilla electrica/
Charcoal Smoker/Ahumador
carbon/Fumoir au charbon
a
6.[]
Outdoor Fireplace/Chimenea para
exteriores/Foyer ext_rieur
7. [] Cooker/Fryer / Cocina/freidora /
CuiseuriFriteuse
8. [] Other/Otro/Autre
Mail to: / Envielo a:
Product Registration
PO BOX 1240
Columbus,
! ! ! !
StoreName/Nornbre
de la tienda/Norndumagasin
I ! !!
! !!
! ! ! !!
! ! ! ! ! I
8 PurchasePrice/Prociode compra/Prixd'achat
$!
! ! ! I .oo
2.[]
Female/Femenino/F6minin
1 _ Which of these sources influenced your decision to buy this product?(check all lhat apply)
i,Cu_l de estas fuentes infiuenci6 a su decisi6n de comprar este producto?(Marque todas las
que correspondan)
Parmi los _l_ments ci=dessuus, qu'est-ce qui a influenc6 votre d_cision d'echeter ce prodeit?
(Cuchez tous les _l_rnents s'oppliquant)
1.[]
Gril _lectrique
3. [] Smoker/Ahumador/Fumoir
4. [] Charcoal Grill/Parrila a carbon/
Barbecue au charbon
5.[]
Male/Masculino/Masculin
7
I II
Dept,
Georgia 31902=1240
Magazine/newspaper
advertisement / Propaganda en revista/peri6dico /
Publicit_ dans un magazine ou dans un journal
2. [] Television commercial/Oomercial
televisivo/Publicite
b. la t_16vision
3.[] Grill was assembled/La parrilla estaba ensamblada/Le gril 6tait d_jb. assembl6
4.[] In-store display/Exhibidor en la tienda/Promotion
sur le lieu de vente
5.[] Store circular/Circular de la tienda!Prospectus
de magasin
6.[] Brand name/Mama/Marque
7.[] Product style/Estilo del producto/Style du produit
8.[] Price/value / Precio/valor / Rapport prix/valeur
9.[] Product quality/Calidad del producto/Qualite
du produit
10.[] Friend!Relative recommendation / Recomendaci6n de amigo o pariente /
Recommandation
d'un(e) ami(e)/parent(e)
11. [] Salesperson recommendation/Recomendaci6n
del vendedori
Recommandation
d'un(e) prOpose(e) b. la vente
12. [] Grill size/TamaSo de la parrilla/Taille du gril
13. [] Product warranty/Garanfia
del producto/Garantie
du produit
14. [] Store demonstration/Demostracion
en la tienda/Demonstration
en magasin
15. [] Point of purchase/Punto de compra/Lieu de vente
16. [] OtheriOtras/Autre:
Thank you for completing
this questionnaire.
may interest you. If you prefer not to receive
Gracias por completar
este cuestionario.
usted con ofertas que puedan resultarle
Your answers will help us and other
these offers, please check here [].
companies
reach
you with offers
Sus respuestas
nos ayudaran,
a nosotros y a otras compa5ias,
de inter6s. Si prefiere no recibir estas ofertas,
por favor marque
that
a Ilegar a
aqui [].
Merci d'avoir bien voulu remplir ce questionnaire.
Vos reponses
nous aideront
et aideront
d'autres compagnies
& vous
communiquer
des offres speciales
susceptibles
de vous interesser.
Si vous preferez ne pas recevoir d'informations
concernant
ces offres speciales,
veuillez cocher ici [].
463721108
•463721308
• 27
Should you encounter a problem with our product
CALL US FIRST
Do not return this product to the store.
WE CAN HELP
GRILL SERVICE CENTER
1=800-241-7548
HOURS 8AM-6PM EST Mon-Fri
Please ensure your warranty
registration
is complete.
Grilling Safety Checklist
[]
Read and understand owners manual.
[]
Never overfill LP cylinder.Overfilled cylinders may cause freeze-up of
regulator.
[]
Check tubes for spider webs, Ensure valves are correctly installed in
burner tubes.
[]
Always ensure control knobs are in OFF position and regulator is
attached to tank BEFORE opening tank valve to avoid low flames,
[]
Perform leak test regularly.
Thank You for Your Purchase!
Char-Broil,LLC. Columbus,GA31902. Printedin China