Beper Humidifier User manual

User Manual
Perfecto2™Series
Oxygen Concentrators without SensO2®,
Oxygen Concentrators with SensO2
HomeFill®Compatible
Perfecto2 with SensO2
Model IRC5PO2
Model IRC5PO2W
Model IRC5PO2V
Perfecto2
Model IRC5P
Model IRC5PW
Dealer: This manual MUST be given to the end
user of this product.
User: BEFORE using this product, read this
manual and save for future reference.
For more information regarding
Invacare products, parts, and services,
please visit www.invacare.com
WARNING
WARNING
DO NOT USE THIS PRODUCT OR ANY AVAILABLE
OPTIONAL EQUIPMENT WITHOUT FIRST
COMPLETELY READING AND UNDERSTANDING
THESE INSTRUCTIONS AND ANY ADDITIONAL
INSTRUCTIONAL MATERIAL SUCH AS OWNER’S
MANUALS, SERVICE MANUALS OR INSTRUCTION
SHEETS SUPPLIED WITH THIS PRODUCT OR
OPTIONAL EQUIPMENT. IF YOU ARE UNABLE TO
UNDERSTAND THE WARNINGS, CAUTIONS OR
INSTRUCTIONS, CONTACT A HEALTHCARE
PROFESSIONAL, DEALER OR TECHNICAL
PERSONNEL BEFORE ATTEMPTING TO USE THIS
EQUIPMENT - OTHERWISE, INJURY OR DAMAGE
MAY OCCUR.
ACCESSORIES WARNING
Invacare products are specifically designed and manufactured
for use in conjunction with Invacare accessories. Accessories
designed by other manufacturers have not been tested by
Invacare and are not recommended for use with Invacare
products.
ACCESSORIES
There are many different types of humidifiers, oxygen tubing,
cannulas and masks that can be used with this device. You
should contact your local home care provider for
recommendations on which of these devices will be best for
you. They should also give you advice on the proper usage,
maintenance, and cleaning.
The supply accessories (nasal cannula, mask, tubing,
humidifier, etc.) used to deliver oxygen to the patient may
include a means to reduce the propagation of fire in the
accessories for the safety of the patient and others. If a
commercially available, fire-activated flow stop device is used
in the accessories setup, it should be placed as close to the
patient as practicable.
NOTE: Updated versions of this manual can be found at
www.invacare.com.
Perfecto2™Series
2
Part No 1143482
Table of Contents
TABLE OF CONTENTS
ACCESSORIES .................................................. 2
SPECIAL NOTES ............................................... 4
LABEL LOCATION ............................................ 6
SECTION 1—GENERAL GUIDELINES .....................7
To Reduce the Risk of Burns, Electrocution, Fire or Injury to
Persons .................................................................................................. 7
Operating Information ....................................................................... 8
Radio Frequency Interference.......................................................... 8
SECTION 2—FEATURES ......................................10
SECTION 3—HANDLING ....................................11
Unpacking............................................................................................ 11
Inspection............................................................................................ 11
Storage................................................................................................. 11
SECTION 4—TYPICAL PRODUCT PARAMETERS .12
SECTION 5—OPERATING INSTRUCTIONS ..........14
Introduction........................................................................................ 14
Select a Location ............................................................................... 14
Set Up .................................................................................................. 15
Power Switch ..................................................................................... 17
Flowrate............................................................................................... 18
Front Panel Indicators - Units with SensO2 ................................ 19
Front Panel Indicators - Units without SensO2 .......................... 20
SECTION 6—MAINTENANCE .............................22
Routine Maintenance........................................................................ 22
SECTION 7—TROUBLESHOOTING GUIDE ............25
LIMITED WARRANTY .................................... 27
Part No 1143482
3
Perfecto2™Series
SPECIAL NOTES
SPECIAL NOTES
Signal words are used in this manual and apply to hazards or
unsafe practices which could result in personal injury or
property damage. Refer to the following table for definitions
of the signal words.
SIGNAL WORD
MEANING
DANGER
Danger indicates an imminently hazardous situation
which, if not avoided, will result in death or serious
injury.
WARNING
Warning indicates a potentially hazardous situation
which, if not avoided, could result in death or
serious injury.
CAUTION
Caution indicates a potentially hazardous situation
which, if not avoided, may result in property
damage or minor injury or both.
NOTICE
The information contained in this document is subject to
change without notice.
DANGER
DO NOT SMOKE while using this device. Keep all
matches, lighted cigarettes or other sources of ignition
out of the room in which this product is located and away
from where oxygen is being delivered.
NO SMOKING signs should be prominently displayed.
Textiles and other materials that normally would not
burn are easily ignited and burn with great intensity in
oxygen enriched air. Failure to observe this warning can
result in severe fire, property damage and cause physical
injury or death.
Perfecto2™Series
4
Part No 1143482
SPECIAL NOTES
CAUTION
“Caution: Federal law restricts this device to sale or rental by
or on order of a physician, or any other practitioner licensed
by the law of the State in which he/she practices to use or
order the use of this device.”
Invacare recommends an alternate source of supplemental
oxygen in the event of a power outage, alarm condition or
mechanical failure. Consult your physician or equipment
provider for the type of reserve system required.
This equipment is to be used as an oxygen supplement and is
not considered life supporting or life sustaining.
Part No 1143482
5
Perfecto2™Series
LABEL LOCATION
LABEL LOCATION
CAUTION
Federal (USA) law restricts this device to sale by or on the order of a
physician.
P/N
114
792
0 R
ev.
B
Serial Number Label is
located on the resonator
intake assembly
Specification Label is
located on the back
near the bottom
Perfecto2™Series
6
Part No 1143482
SECTION 1—GENERAL GUIDELINES
SECTION 1—GENERAL GUIDELINES
In order to ensure the safe installation, assembly and
operation of the Perfecto2 concentrator these instructions
MUST be followed.
WARNING
This section contains important information for the safe
operation and use of this product.
To Reduce the Risk of Burns,
Electrocution, Fire or Injury to Persons
DANGER
Risk of electric shock. DO NOT disassemble. Refer servicing
to qualified service personnel. No user serviceable parts.
Avoid using while bathing. If continuous usage is required
by the physician’s prescription, the concentrator MUST be
located in another room at least 7 ft from the bath.
DO NOT come in contact with the concentrator while wet.
DO NOT place or store product where it can drop into
water or other liquid.
DO NOT reach for product that has fallen into water.
Unplug IMMEDIATELY.
If the concentrator has a damaged cord or plug, if it is not
working properly, if it has been dropped or damaged, or
dropped into water, call qualified technician for
examination and repair.
A spontaneous and violent ignition may occur if oil, grease
or greasy substances come in contact with oxygen under
pressure. These substances MUST be kept away from the
oxygen concentrator, tubing and connections, and all
other oxygen equipment. DO NOT use any lubricants
unless recommended by Invacare.
Avoid creation of any spark near medical oxygen
equipment. This includes sparks from static electricity
created by any type of friction.
Part No 1143482
7
Perfecto2™Series
SECTION 1—GENERAL GUIDELINES
Operating Information
For optimum performance, Invacare recommends that each
concentrator be on and running for a minimum of 30 minutes
at a time. Shorter periods of operation may reduce maximum
product life.
Keep the oxygen tubing, cord, and unit out from under such
items as blankets, bed coverings, chair cushions, clothing and
away from heated or hot surfaces, including space heaters,
stoves and similar electrical appliances.
DO NOT move or relocate concentrator by pulling on the
power cord.
NEVER drop or insert any object or liquid into any opening.
Invacare recommends that Crush-Proof oxygen tubing be
used with this product and not exceed 50 ft in length.
There are no user serviceable parts. This does not include
normal maintenance items. See maintenance section for user
maintenance items.
A product should NEVER be left unattended when plugged
in. Make sure the Perfecto2 is Off when not in use.
Close supervision is necessary when this product is used near
children or physically-challenged individuals.
Additional monitoring or attention may be required for
patients using this device who are unable to hear or see
alarms or communicate discomfort.
DO NOT connect the concentrator in parallel or series with
other oxygen concentrators or oxygen therapy devices.
Radio Frequency Interference
This equipment has been tested and found to comply with
EMC limits specified by IEC/EN 60601-1-2. These limits are
designed to provide a reasonable protection against
electromagnetic interference in a typical medical installation.
Perfecto2™Series
8
Part No 1143482
SECTION 1—GENERAL GUIDELINES
Other devices may experience interference from even the low
levels of electromagnetic emissions permitted by the above
standards. To determine if the emissions from the Perfecto2 is
causing the interference, turn the Perfecto2 Off. If the
interference with the other device(s) stops, then the Perfecto2
is causing the interference. In such rare cases, interference
may be reduced or corrected by one of the following
measures:
• Reposition, relocate, or increase the separation
between the equipment.
• Connect the equipment into an outlet on a circuit
different from that to which the other device(s) is
connected.
Part No 1143482
9
Perfecto2™Series
SECTION 2—FEATURES
SECTION 2—FEATURES
Oxygen Outlet
Oxygen Purity Indicator
Lights / Fault and Power
Indicator Lights
Flowmeter
Circuit Breaker
Elapsed Time
Meter
Power Switch
REAR VIEW
ACCESSORIES (NOT SHOWN):
PreciseRX™ Pediatric Humidifier/Flowmeter
Accessory - IRCPF16 (Perfecto2 5 Only)
HomeFill home oxygen compressor - IOH200
Cabinet Filter
Power
Cord
Perfecto2™Series
*Outlet
Fitting
*NOTE: This outlet fitting is to be
used only for filling oxygen cylinders
with the HomeFill home oxygen
compressor. The outlet fitting does not
affect concentrator performance.
Refer to the HomeFill owner's
manual, part number 1100873, for
connection and operating
instructions. When not in use, the
plug provided with the concentrator
should be inserted into the outlet
fitting. For more information about
the HomeFill, contact your Invacare
dealer.
10
Part No 1143482
SECTION 3—HANDLING
SECTION 3—HANDLING
The concentrator should ALWAYS be kept in the upright
position to prevent cabinet damage while being transported.
If the concentrator is to be reshipped by common carrier,
additional cartons are available from Invacare.
Unpacking
NOTE: For this procedure, refer to FIGURE 3.1.
1. Check for any obvious
damage to the carton or
its contents. If damage is
evident, notify the
carrier, or your local
dealer.
2. Remove all loose packing
from the carton.
3. Carefully remove all the
components from the
carton.
FIGURE 3.1 Unpacking
NOTE: Unless the oxygen concentrator is to be used immediately,
retain containers and packing materials for storage until use of the
concentrator is required.
Inspection
Inspect/examine exterior of the oxygen concentrator for nicks,
dents, scratches or other damages. Inspect all components.
Storage
1. Store the repackaged oxygen concentrator in a dry area.
2. DO NOT place objects on top of repackaged concentrator.
Part No 1143482
11
Perfecto2™Series
SECTION 4—TYPICAL PRODUCT PARAMETERS
SECTION 4—TYPICAL PRODUCT
PARAMETERS
Electrical Requirements:
Rated Current Input:
Sound Level:
Altitude:
*Oxygen Output
Concentration Levels:
Maximum Outlet Pressure:
Flow Range:
Potential Obstruction Alert:
Average Power
Consumption:
Pressure Relief Mechanism
Operational at:
Change in maximum
recommended flow :
Filters:
Perfecto2™Series
120 VAC ± 10% (132 VAC/108 VAC), 60 Hz
3A
43 ± 2 dBA Average for Perfecto2 Models and
Perfecto2V Model
40 ± 2 dBA Average for Perfecto2W Models
All Perfecto2 Models: Up to 8,000 ft (2438
meters) above sea level without degredation of
concentration levels.
All Perfecto2 Models while filling a
HomeFill System: Up to 6,000 ft (1828
meters) above sea level without degradation of
concentration levels.
87% to 95.6% for flows ranging at 0.5 to 5 L/min
5 psi ± 0.5 psi (34.5 kPa ± 3.45 kPa)
0.5 to 5 L/min
For flowrates less than 1 L/min, we recommend
the use of the Invacare Pediatric Flowmeter
IRCPF16 Accessory.
0 L/min to 0.5 L/min
The concentrator detects a condition that may
indicate a potential obstruction of the output
oxygen.
Rapid audible beeping alert (this alert is
deactivated when accessories are connected).
May be associated with flow setting of 0.5
L/min or less.
Perfecto2 and Perfecto2W Models: 280 W
(Operating @ 3 L/min)
Perfecto2V Model: 325 W
35 psi ± 3.5 psi (241 kPa ± 24.1 kPa)
0.7 L/min (Back Pressure of 7kPa applied)
Cabinet, Outlet HEPA and Compressor Inlet
12
Part No 1143482
SECTION 4—TYPICAL PRODUCT PARAMETERS
Safety System:
Current overload or line surge shutdown. High
temperature compressor shutdown. High
Pressure Alarm w/compressor shutdown. Low
Pressure Alarm w/compressor shutdown.
Battery Free Power Loss Alarm. SensO2
Oxygen System Possible Obstruction Alert.
Width:
15 in ± 3/8 in (38.1 cm ± 1 cm)
Height:
23 in ± 3/8 in (58.4 cm ± 1 cm)
Depth:
12 in ± 3/8 in (30.5 cm ± 1 cm)
Weight:
43 lbs ± 2 lbs (19.5 kg ± 1 kg) Perfecto2 Models
45 lbs ± 2 lbs (20.5 kg ± 1 kg) Perfecto2W
Models
40 lbs ± 2 lbs (18.1 kg ± 1 kg) Perfecto2V Model
Shipping Weight:
48 lbs ± 2 lbs (21.8 kg ± 1 kg) Perfecto2 Models
50 lbs ± 2 lbs (22.8 kg ± 1 kg) Perfecto2W
Models
45 lbs ± 2 lbs (20.4 kg ± 1 kg) Perfecto2V Model
Operating Ambient
50°F - 95°F (10°C - 35°C) at 20-60% relative
Temperature:
humidity Perfecto2 Models and Perfecto2V
Model
50°F - 90°F (10°C - 32°C) at 20-60% relative
humidity Perfecto2W Models
Exhaust:
Less than Ambient + 35°F (+19°C)
Oxygen Output Temperature: Less than Ambient + 6°F (+3°C)
Cabinet:
Impact Resistant flame-retardant plastic cabinet
that conforms to UL94V-0.
Regulatory Listing:
Double Insulated Product ETL certified
complying with UL1431 and UL1097 ETL
certified to CSA C22.2 No. 68.
Electrical:
No extension cords.
Placement:
No closer than twelve inches from any wall,
furniture, draperies, or similar surfaces.
Tubing:
7 ft cannula with a maximum 50 ft of
Crush-Proof Tubing (DO NOT pinch).
Relative Humidity:
20 to 60%
Time of Operation:
Up to 24 hours per day.
Recommended Storage and
-20°F to 150°F (-29°C to 65°C), at 15-95%
Shipping Temperature:
relative humidity.
NOTE: Stated concentration levels achieved after initial warm-up
period (approximately 30 minutes).
Part No 1143482
13
Perfecto2™Series
SECTION 5—OPERATING INSTRUCTIONS
SECTION 5—OPERATING
INSTRUCTIONS
Introduction
Your oxygen concentrator is intended for individual use
indoors. It is an electronically operated device that separates
oxygen from room air. It provides high concentration of oxygen
directly to you through a nasal cannula. Clinical studies have
documented that oxygen concentrators are therapeutically
equivalent to other types of oxygen delivery systems.
Your provider will show you how to use your oxygen
concentrator. He/She should be contacted with any questions
or problems regarding your oxygen concentrator. This
owner’s manual will tell you about your concentrator and will
serve as a reference as you use your concentrator.
Select a Location
WARNING
NEVER block the air openings of the product or place it on a
soft surface, such as a bed or couch, where the air opening may
be blocked. Keep the openings free from lint, hair and the like.
Move oxygen concentrator at least 12 inches away from walls,
draperies or furniture.
You may select a room where using your oxygen concentrator
would be most convenient. Your concentrator can be easily
rolled from room to room on its casters.
Your oxygen concentrator will perform best when operated
under the following conditions. Refer to Typical Product
Parameters on page 12. Usage in environments other than
those described may result in the need for increased
equipment maintenance. The air intake of the unit should be
located in a well ventilated area to avoid smoke, airborne
pollutants and/or fumes. DO NOT place in a closet.
Perfecto2™Series
14
Part No 1143482
SECTION 5—OPERATING INSTRUCTIONS
Set Up
Plug in Power Cord
Plug in power cord to an electrical outlet.
Connect Humidifier (If So Prescribed)
WARNING
DO NOT overfill humidifier.
DO NOT reverse the oxygen input and output connections.
Water from the humidifier bottle will travel through the
cannula back to the patient.
NOTE: For this procedure, refer to FIGURE 5.1, FIGURE 5.2 on
page 16, FIGURE 5.3 on page 17.
1. Remove cap from bottle.
2. Fill humidifier with distilled water to the level indicated
by the manufacturer. Replace the humidifier cap and
securely tighten.
Humidifier
Bottle w/o Cap
Humidifier
Bottle with Cap
FIGURE 5.1 Filling the Humidifier
3. Insert a flathead screwdriver in the plate groove on the top
edge of the filter access door and gently pry the filter
access door off (FIGURE 5.2).
4. Pull up and remove the humidifier bottle adapter
(FIGURE 5.2).
Part No 1143482
15
Perfecto2™Series
SECTION 5—OPERATING INSTRUCTIONS
Humidifier
Bottle Adapter
Insert Flat Head
Screwdriver
Here
Cabinet Filter
Filter Access Door
FIGURE 5.2
Humidifer Bottle Adapter
5. Attach the humidifier bottle adapter to the humidifier
bottle by turning the wing nut on the humidifier bottle
counterclockwise until it is securely fastened. See Detail
“A” in FIGURE 5.3.
6. Place the humidifier bottle/adapter assembly in the
humidifier compartment on the concentrator. See Detail
“B” in FIGURE 5.3.
7. Attach oxygen tubing from the humidifier bottle/adapter
assembly to oxygen outlet connector on the concentrator.
See Detail “B” in FIGURE 5.3.
8. Attach the cannula/patient supply tubing to the
humidifier bottle outlet. See Detail “B” in FIGURE 5.3.
9. After assembly, ensure that oxygen is flowing through the
cannula.
Perfecto2™Series
16
Part No 1143482
SECTION 5—OPERATING INSTRUCTIONS
DETAIL “A”
Humidifier
Bottle
Adapter
Humidifier
Bottle
Oxygen Outlet
Connector
DETAIL “B”
Oxygen
Tubing
Humidifier
Bottle
Outlet
Humidifier
Bottle
Humidifier
Compartment
FIGURE 5.3
Humidifier Compartment
Power Switch
NOTE: For this procedure, refer to FIGURE 5.4.
1. Press power switch to on
position. All the panel
lights and the audible
alarm will come on for
one second, indicating
that the unit is functioning
properly.
On/Off
(I/O)
Power
Switch
FIGURE 5.4 Power Switch
Part No 1143482
17
Perfecto2™Series
SECTION 5—OPERATING INSTRUCTIONS
Flowrate
NOTE: For this procedure, refer to FIGURE 5.5 on page 19.
1. Turn the flowrate knob to the setting prescribed by your
physician or therapist.
CAUTION
Never set the flow greater than 5 L/min.
WARNING
DO NOT change the L/min setting on the flowmeter unless a
change has been prescribed by your physician or therapist.
NOTE: To properly read the flowmeter, locate the prescribed flowrate
line on the flowmeter. Next, turn the flow knob until the ball rises to
the line. Now, center the ball on the L/min line prescribed.
NOTE: A Potential Obstruction Alert indicates a condition that
may be associated with a partial or complete obstruction of oxygen
output.
2. If the flowrate on the flowmeter ever falls below 0.5 L/min
more than about one minute, the Potential Obstruction
Alert will be triggered. This is a rapid beeping of the
audible alarm. Check your tubing or accessories for
blocked or kinked tubing or a defective humidifier bottle.
After rated flow is restored between 0.5 L/min and 0.75
L/min, the Potential Obstruction Alert will turn off.
NOTE: The use of some accessories such as the PreciseRx™
pediatric flowmeter and the HomeFill compressor will deactivate the
Potential Obstruction Alert.
Perfecto2™Series
18
Part No 1143482
SECTION 5—OPERATING INSTRUCTIONS
Flow Knob
Flowmeter
0.5 L/min
Ball
Front Panel
FIGURE 5.5
Flowrate
Front Panel Indicators - Units with
SensO2
The SensO2 feature monitors the purity of oxygen generated
by the oxygen concentrator. If purity falls below factory preset
standards, indicator lights on the control panel will
illuminate.
OXYGEN PURITY
Auto Shut Down
Use Backup
RED
Call Supplier
Below
Normal
Normal
FIGURE 5.6
Part No 1143482
YELLOW
O2
GREEN
Front Panel Indicators - Units with SensO2
19
Perfecto2™Series
SECTION 5—OPERATING INSTRUCTIONS
Initial Startup of the Concentrator
NOTE: Concentrator may be used during the initial start warm-up
time (approximately 30 min.) while waiting for the O2 purity to
reach maximum.
LABEL
SYMBOL
O2 PURITY
INDICATOR LIGHTS (LED)
GREEN Indicator Light
SYSTEM OKAY
O2 over 85%
O2
O2 Between 73% to 85% YELLOW Indicator light
A. YELLOW Solid
B. YELLOW Flashing Sensor
Failure
Call a qualified technician. Have a
back-up supply of oxygen ready.
RED Indicator Light
SYSTEM FAILURE
Continuous Audible Alarm
O2 Below 73%
Sieve-GARD™ Compressor Shutdown. Call a qualified technician.
Switch to a back-up supply of oxygen immediately.
Front Panel Indicators - Units without
SensO2
NOTE: For this procedure, refer to FIGURE 5.7.
Auto Shut Down
Use Backup
RED
Call Supplier
Normal
FIGURE 5.7
Perfecto2™Series
I/O
GREEN
Front Panel Indicators - Units without SensO2
20
Part No 1143482
SECTION 5—OPERATING INSTRUCTIONS
Initial Startup of the Concentrator
NOTE: Concentrator may be used during the initial start warm-up
time (approximately 30 min). O2 purity will build to a maximum
during this period.
LABEL
SYMBOL
I/O
Part No 1143482
STATUS
INDICATOR LIGHTS
(LED)
SYSTEM OKAY
GREEN Indicator Light
SYSTEM FAILURE
RED Indicator light
Continuous Audible Alarm
Sieve-GARD™Compressor
Shutdown
Call a qualified technician. Switch
to a back-up supply of oxygen
immediately.
21
Perfecto2™Series
SECTION 6—MAINTENANCE
SECTION 6—MAINTENANCE
WARNING
The Invacare concentrators are specifically designed to
minimize routine preventive maintenance. Only qualified
personnel should perform preventive maintenance on the
concentrator.
Unplug the concentrator when cleaning. To avoid electrical
shock, DO NOT remove cabinet.
NOTE: At a minimum, preventive maintenance MUST be
performed according to the maintenance record guidelines. In places
with high dust or soot levels, maintenance may need to be performed
more often. Refer to Preventive Maintenance Record on page 24.
Routine Maintenance
Cleaning the Cabinet Filter
CAUTION
DO NOT operate the concentrator without the filter installed.
NOTE: For this procedure, refer to FIGURE 6.1 on page 23.
NOTE: There is one cabinet filter located on the back of the cabinet.
1. Remove the filter and clean as needed.
NOTE: Environmental conditions that may require more frequent
cleaning of the filters include but are not limited to: high dust, air
pollutants, etc.
2. Clean the cabinet filter with a vacuum cleaner or wash in
warm soapy water and rinse thoroughly.
3. Dry the filter thoroughly before reinstallation.
Perfecto2™Series
22
Part No 1143482
SECTION 6—MAINTENANCE
FIGURE 6.1 Cleaning the Cabinet Filter
Cleaning the Cabinet
Clean the cabinet with a mild household cleaner and
non-abrasive cloth or sponge.
Cleaning the Humidifier
NOTE: To clean the oxygen humidifier, follow the instructions
provided by the manufacturer. If none are provided, follow these
STEPS:
1. Clean the humidifier every day.
2. Wash it in soapy water and rinse it with a solution of ten
parts water and one part vinegar.
3. Rinse thoroughly with hot water and refill with distilled
water to the level shown on the humidifier.
Part No 1143482
23
Perfecto2™Series
ON EACH INSPECTION
Perfecto2™Series
24
Check Compressor Inlet Filter*
*NOTE: Refer to Preventive Maintenance section of Service Manual.
NOTE:
4,380 hours are equivalent to usage 24 hours per day, 7 days per week, for 6 months.
26,280 hours are equivalent to usage 24 hours per day, 7 days per week, for 3 years.
Check Power Loss Alarm
Check Compressor Inlet Filter*
Check Outlet HEPA Filter*
Clean/Replace Cabinet Filter(s)
Check Oxygen Concentration
UNITS WITH SensO 2 - EVERY 26,280 HOURS OR 3 YEARS, WHICHEVER COMES FIRST
Check Power Loss Alarm
MODEL NO. IR C
Check Outlet HEPA Filter*
Clean/Replace Cabinet Filter(s)
Check Oxygen Concentration
UNITS WITHOUT SensO 2 - EVERY 4,380 HOURS
DURING PREVENTIVE MAINTENANCE SCHEDULE, OR BETWEEN PATIENTS
Check Prescribed L/min. Flow Rate
Clean Cabinet Filter(s)
Record Elapsed Hours On Hour Meter
Record Date of Service
PREVENTIVE MAINTENANCE RECORD
SECTION 6—MAINTENANCE
SERIAL NO.
FIGURE 6.2 Preventive Maintenance Record
Part No 1143482
SECTION 7—TROUBLESHOOTING GUIDE
SECTION 7—TROUBLESHOOTING
GUIDE
SYMPTOM:
Alarm:
Short beeps, long
pause
Concentrator not
operating,
power switch On.
Beep......Beep......
Alarm:
Continuous
PROBABLE CAUSE:
Main Power Loss:
1. Power cord not
plugged in.
1. Insert plug into outlet.
2. No power at outlet.
2. Inspect house circuit
breakers or fuses. If problem
recurs, use a different outlet.
3. Tripped circuit
breaker.
3. Call Service Provider.
System Failure:
1. Unit overheating due
to blocked air intake.
1a. Remove and clean cabinet
filters.
2. Insufficient power at
outlet.
2. DO NOT use extension
cords. Move to another
electrical outlet or circuit.
3. Internal repairs
required.
3. Call Service Provider.
Potential Obstruction
Alert:
1. Possible internal
obstruction in the oxygen
path.Kinked or blocked
tubing, cannula or
humidifier.
1. Inspect for kinks or
blockages. Correct, clean or
replace item. Once
corrected, turn power Off for
60 seconds and then turn
power back ON.
Concentrator not
operating, Power
Switch On.
Beeeeeeeep....
Alarm:
Rapid
Beep....Beep...
Beep...Beep
Part No 1143482
SOLUTION:
25
1b. Move oxygen
concentrator at least twelve
inches away from walls,
draperies or furniture.
Perfecto2™Series
SECTION 7—TROUBLESHOOTING GUIDE
SYMPTOM:
PROBABLE CAUSE:
2. Flowmeter set at 0.5
L/min or less.
SOLUTION:
2. Reset flowmeter to
prescribed flowrate. If
prescribed flowrate is below
0.5 L/min, use the Pediatric
Flowmeter IRCPF16 (Only
with Perfecto2 5).
NOTE: The use of the
pediatric flowmeter will
deactivate the Potential
Obstruction Alert.
YELLOW or RED
light Illuminated.
Alarm:
Continuous
On RED light
only.
* Only applies to
IRC5PO2.
1. Low oxygen purity.*
1. Clean or Replace filters.
2. Kinked or blocked
tubing, cannula or
humidifier.*
2. Inspect for kinks or
blockages. Correct, clean or
replace item. Once
corrected, turn power Off for
60 seconds and then turn
power back On.
3. Flowmeter set at 0.5
L/min or less.*
3. Check flowmeter is set to
1.0 L/min or more.
4. Unit overheating due
to blocked air intake.
4a. Remove and clean cabinet
filters.
4b. Move concentrator at
least twelve inches from
walls, draperies, and
furniture.
GREEN light with
YELLOW Light
Flashing.
Perfecto2™Series
5. Insufficient power at
outlet.
5. DO NOT use extension
cords. Move to another
electrical outlet or circuit.
6. Internal repairs
required.
6. Call Service Provider.
1. Internal repairs
required.
1. Call Service Provider.
26
Part No 1143482
LIMITED WARRANTY
LIMITED WARRANTY
NOTE: THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY
WITH FEDERAL LAW APPLICABLE TO PRODUCTS
MANUFACTURED AFTER JULY 4, 1975.
This warranty is extended only to the original purchaser who purchases
this product when new and unused from Invacare Corporation or a
dealer. This warranty is not extended to any other person or entity and it
is not transferable or assignable to any subsequent purchaser or owner.
Coverage under this warranty will end upon any such subsequent sale or
other transfer of title to any other person. This warranty gives you specific
legal rights and you may also have other legal rights which may vary from
state to state.
Invacare Corporation warrants its Perfecto2 Oxygen Concentrators when
purchased new and unused to be free from defects in materials and
workmanship for a period of three years from date of purchase from
Invacare or a dealer, with a copy of the seller’s invoice required for
coverage under this warranty.
DO NOT OPEN OR ATTEMPT TO SERVICE THE 4-WAY VALVE
BODY. This will void any and all warranty applicable to the valve body. If
within such warranty periods any such product shall be proven to Invacare
Corporation's satisfaction to be defective, such product shall be repaired
or replaced, at Invacare Corporation's option. This warranty only applies
to the labor for repairs performed by the Invacare Service Department or
Invacare Authorized Service Centers. It does not apply to the labor
performed by the purchaser or user. This warranty does not include
normal wear and tear or shipping charges. Invacare Corporation's sole
obligation and your exclusive remedy under this warranty shall be limited
to such repair or replacement. Routine maintenance items, such as filters,
are excluded from this warranty.
For warranty service, please contact Invacare Corporation's Service
Department at the toll free number on the back cover. Upon receiving
notice of an alleged defect in a product, Invacare Corporation will issue a
serialized return authorization. It shall then be the responsibility of the
purchaser to return the entire unit or remove, at purchaser's cost, the
defective component part(s) identified, pack the component part(s) in a
manner to avoid shipping damage and to ship the component part(s) to
either Invacare Corporation's plant or service center as specified by
Invacare Corporation in advance. Defective component part(s) MUST be
returned for warranty inspection using the serial number as identification
within thirty days of return authorization date. DO NOT return products
to our factory without prior consent. C.O.D. shipments will be refused;
please prepay shipping charges.
Part No 1143482
27
Perfecto2™Series
LIMITATIONS AND EXCLUSIONS: THE FOREGOING WARRANTY
SHALL NOT APPLY TO PRODUCTS SUBJECTED TO NEGLIGENCE,
ACCIDENT, IMPROPER OPERATION, MAINTENANCE OR STORAGE,
SOOT OR SMOKE-FILLED ENVIRONMENTS, OR OTHER THAN
NORMAL APPLICATION, USE OR SERVICE, OR TO PRODUCTS
MODIFIED WITHOUT INVACARE CORPORATION'S EXPRESS
WRITTEN CONSENT (INCLUDING, BUT NOT LIMITED TO,
MODIFICATION THROUGH THE USE OF UNAUTHORIZED PARTS
OR ATTACHMENTS) OR TO PRODUCTS DAMAGED BY REASON OF
REPAIRS MADE TO ANY COMPONENT WITHOUT THE SPECIFIC
CONSENT OF INVACARE CORPORATION OR TO PRODUCTS
DAMAGED BY CIRCUMSTANCES BEYOND INVACARE
CORPORATION'S CONTROL.
THE FOREGOING EXPRESS WARRANTY IS EXCLUSIVE AND IN
LIEU OF ANY OTHER WARRANTIES WHATSOEVER, WHETHER
EXPRESS OR IMPLIED, INCLUDING THE IMPLIED WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE,
AND THE SOLE REMEDY FOR VIOLATIONS OF ANY WARRANTY
WHATSOEVER, SHALL BE LIMITED TO REPAIR OR REPLACEMENT
OF THE DEFECTIVE PRODUCT PURSUANT TO THE TERMS
CONTAINED HEREIN. THE APPLICATION OF ANY IMPLIED
WARRANTY WHATSOEVER SHALL NOT EXTEND BEYOND THE
DURATION OF THE EXPRESS WARRANTY PROVIDED HEREIN.
INVACARE SHALL NOT BE LIABLE FOR ANY CONSEQUENTIAL OR
INCIDENTAL DAMAGES WHATSOEVER.
SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION
OF INCIDENTAL OR CONSEQUENTIAL DAMAGE, OR LIMITATION
OF HOW LONG AN IMPLIED WARRANTY LASTS, SO THE ABOVE
EXCLUSION AND LIMITATION MAY NOT APPLY TO YOU.
THIS WARRANTY SHALL BE EXTENDED TO COMPLY WITH
STATE/PROVINCIAL LAWS AND REQUIREMENTS.
Invacare Corporation
www.invacare.com
USA
One Invacare Way
Elyria, Ohio USA
44036-2125
800-333-6900
Technical Services
800-832-4707
© 2013 Invacare Corporation. All rights
reserved. Republication, duplication or
modification in whole or in part is
prohibited without prior written
permission from Invacare. Trademarks are
identified by ™ and ®. All trademarks are
owned by or licensed to Invacare
Corporation or its subsidiaries unless
otherwise noted.
Part No 1143482
Rev F - 08/13