OWNER’S MANUAL

ARP- 3012

PORTABLE AIR CONDITIONER

ACONDICIONADOR DE AIRE PORTÁTIL

Read and retain these instructions for future reference

For any Customer Support needs please choose the Customer Support tab on www.royalsovereign.com

Royal Centurian Inc.

PORTABLE AIR CONDITIONER

Model ARP-3012

INTRODUCTION

Thank you for choosing this air conditioner to provide you and your family with all of the "Home Comfort" requirements for your home, apartment, or office. This appliance can be moved from room to room and set-up in just minutes.

It is a multi-functional room air conditioner that offers you Cool, Dehumidify, and Independent Fan modes.

This manual will provide you with valuable information necessary for the proper care and maintenance for you new appliance.

Please take a few moments and read the instructions thoroughly. If properly maintained, your appliance will give you many years of trouble free operation.

Electrical Specifications

1. All wiring must comply with local and national electrical codes and be installed by a qualified electrician. If you have any questions regarding the following instructions,contact a qualified electrician.

2. Check available power supply and resolve any wiring problems before installation and operation of this unit.

3. For your safety and protection, this unit is grounded through the power cord plug when plugged into a matching wall outlet. If you are not sure whether the wall outlets in your home are properly grounded, please consult a electrician. Do not use plug adapters or extension cords with this unit.

ARP-3012

WARNING

Improper handling can cause serious damage to the appliance. Read this manual carefully before operating the unit.

Do not wet the housing or control panel.

Do not cover the air outlet while in use.

Do not allow children to play with the controls or drop any objects into the outlet.

Do not place objects or let any person sit on top of the unit.

Always turn the unit off and remove the power plug from the socket when cleaning.

Do not attempt to remove any part of the casing unless by an authorized technician.

Remove the plug from the socket if the unit is not being used for long period.

Use only the correct power supply AC

115V/60Hz.

Do not operate the unit with damaged plug or loose socket point.

Make sure that the back of the unit is at least 4" or more from a wall. Do not place the unit in front of curtains or drapes.

WARNING

If the power cord on this unit is damaged, it must be replaced by the manufacturer service agent or qualified electrician.

-This appliance is not intended for use by children or other persons without assistance or supervision.

3

DESCRIPTION OF COMPONENTS

1

6

4

2

3

7

5

8

1. Air Outlet(Up -Down)

2. Control Panel

3. Front panel

4. Handle

5. Casters

4

6. Screen filter

7. Air intake (Evaporator)

8. Air intake (Condenser)

9. Air outlet (Heat exchange)

10.Water drain with plug

9

10

ARP-3012

INSTALLATION INSTRUCTIONS

Connect exhaust hose assembly to the back of the unit. Extend hose to desired length and locate the exhaust nozzle through a window or wall for ventilation.

EXHAUST ASSEMBLY AND INSTALLATION

Window spacer Exhaust nozzle connector Exhaust hose Exhaust hose connector

1. Insert ends of exhaust hose into exhaust nozzle connector and exhaust hose connector by twisting clockwise until it stops.

2. Attach the exhaust hose connector onto the rear outlet of the unit and turn to the right.

3. Attach the exhaust nozzle to the window spacer with the 4 screws provided.

4. Connect the exhaust nozzle connector to the exhaust nozzle.

5. Extend the exhaust hose and close the window as far as possible trapping the exhaust nozzle as shown below .

INDOOR

INDOOR INDOOR

5

OPERATION

Control panel

Warning Light

Display

Mode Control

Timer / Temp Set Control

Power Control

Fan Speed Control

POWER CONTROL

The power control turns the unit on and off.

WARNING CONTROL

Condensed water may accumulate in the unit . If the internal tank becomes full, the Warning Light will shine and the unit will not operate until the unit has been drained.

FAN MODE

When fan mode is selected the indicator light will shine green. Air is circulated throughout the room with no cooling.

NOTE: Unit does not need to be vented in fan mode.

MODE CONTROL

The Mode Control has three settings:

Cool Dehumidify Fan

The settings are adjusted with the Mode Control button. A light will indicate which setting is currently being used.

FAN SPEED CONTROL

The Fan Speed Control has 3 settings: High, Medium, and Low.

6

ARP- 3012

DEHUMIDIFY MODE

When dehumidify mode is selected, the indicator light will shine green. Air is dehumidified as it passes through the unit, without being in full

Cooling mode.The fan will operate in Medium speed. Fan speed is not adjustable in Dehumidify mode.

NOTE: The air exchange hoses must vent inside the room when using Dehumidify mode.

COOL MODE

When Cool mode is selected, the indicator light will shine green. During the Cool mode the air is cooled and hot air is exhausted to the outside through the exhaust tube.

NOTE: The air exchange hoses must vent outside the room when using Cool mode.

TIMER / TEMP SET CONTROLS

Used for adjusting the timer and thermostat.

The default display is the room temperature.

In Cool mode, when "+" or "-"button is pressed, the set temperature is displayed and may be adjusted. After 5 seconds the display will revert back to room temperature . Temperature is only adustable in Cool mode . The time is adjustable between 1~24 hours.

NOTE: By pressing both Timer /Temp set buttons at the same time, the display will toggle between Celsius and Fahrenheit.

TIMER

Auto turn off:

With machine in Fan mode, press timer button to select number of hours you would like the unit to run in Cool mode until it automatically shuts off.

Auto turn on:

With machine powered off, press timer button to select number of hours until you would like the unit to automatically start running in Cool mode.

AUTOMETIC RESTART

When the power return, automatically returning to the previously set operating mode and parameters.

After switching the air conditioner off, you must wait 3 minutes before switching it back on again.

7

OPERATION

Air Conditioner Remote Control

The functions work the same as your air conditioner's touch controls.

Timer and thermostat

Setting Buttons

Power ON / OFF

Button

Fahrenheit / Celsius

Selector

Auto Swing

LCD Screen

A/C Fan Speed Button

(High,Medium or Low)

Mode Button

(Select Cool,Fan or Dehumidify)

Timer ON/OFF Button

TIMER PROGRAMMING

1. Press the button on the remote or the

"Timer Setting" button on the control panel to turn on the Timer Function.

2. Press the or buttons on the remote or the

+ or

- buttons on the control panel to set the desired shut-off period.

3. The unit will shut off when the set time elapses.

OSCILATING MODE

Press (SWING) on the oscilate wind direction left to right, right to left.

OPERATIONDEHUMIDIFICATION OPERATION

Press the button on the remote or the

"MODE" button on the control panel to select the Dehumidify mode. When the Dehumidify mode is on, the temperature buttons and the fan speed buttons do not function and the fan will operate on low speed. The Dehumidify indicator light will illuminate and stay solid while the unit is dehumidifying. When the humidity in the room is 50% or lower, the compressor will not run, the unit will not dehumidify, and the

Dehumidify light will blink. Remember, the exhaust hose does not need to be used in

Dehumidify mode.

8

ARP-3012

TROUBLESHOOTING

The following cases may not always be a malfunction. Please check it before asking for srvice.

Does not run

Trouble

Analysis

If the protector strip or fuse is blown:

Please wait for 3 minutes and start again, protector device may be preventing unit from working.

If batteries in the remote controller need replacement.

If the plug is not properly plugged in.

Operates for short time only

Runs but not cooling

Does not run and water full indicator lights

If the set temperature is close to room temperature, you should lower the set temperature.

Air outlet may be blocked by obstacle. Take the obstacle away.

If the door or window is open.

If there is other appliance heating room, such as heater or lamp,etc...

Check air filter, clean if necessary.

If the air outlet or intake is blocked.

If the set temperature is too high.

Drain the water into a prepared container by the drainage pipe on the rear panel of the unit.

If still doesn't work, please consult a qualified technician.

9

TROUBLESHOOTING

Appliance maintenance

1. Cut off the power supply

Turn off the appliance first before disconnecting from power supply

2. Wipe with a soft and dry cloth

Use lukewarm water to clean the appliance.

3. Never use volatile substance such as gasoline or polishing powder to clean the appliance.

4. Never sprinkle water onto the main unit.

Dangerous!

Electric shock!

Air filter maintenance

It is necessary to clean the air filter after using it for about 100 hours. Clean it as follows:

1. Stop the appliance and remove the air filter

Stop the appliance first, then pull back the air filter.

2. Clean and reinstall the air filter

Wash it with a solution of detergent in lukewarm water.

After cleaning, dry it, then reinstall it...

3. Clean the air filter every two weeks if the air conditioner operates in an extremely dusty environment.

Maintenance after using

1. If the appliance will not be used for a long time, be sure to pull out the rubber plug of the drain port in order to drain the water.

2. Keep the appliance running with fan only for a half day to dry the appliance inside and prevent mold.

3. Stop the appliance and pull out the power supply plug, then take out the batteries of remote controller.

4. Clean the air filter and reinstall it.

5. Remove the air hoses.

10

SPECIFICATIONS

Figures noted are for reference only; variation may result due to application in different countries or regions, and shall be based on the best of practical operation.

Description of product

Model

Voltage / Frequency

Input power

Operating cycle

Cooling capacity

Dehumidifying capacity

Coolant

Timer

Dimensions

(W) x (H) x (D)

Weight (N.W.)

Air Conditioner

ARP-3012

115V / 60Hz

1600W

14 A

12000 B.T.U./H

4.0 pints/Hour

R 22

12 hour

20.3 x 34.5 x 14.6 "

51.7cm x 87.6cm x 37.2cm

77lbs/35kg

Electrical waste products should not be disposed of with household waste.

Please recycle where facilities exist. Check with your local authority or retailer for recycling advice.

FULL ONE YEAR WARRANTY

Royal Sovereign warrants each Portable Air Conditioner to be free from defects in material and workmanship. Our obligation under this warranty is limited to the repair or replacement, free of charge, when delivered to an authorized Royal Sovereign service center, of any defective part(s) thereof, other than parts damaged in transit. This warranty is in effect to the original purchaser, for a period of one year from the date of purchase and is not transferable. This warranty shall apply only if the air conditioner is used on Alternating Current (AC) circuit, in accordance with the factory provided instructions which accompany it.

LIMITED FIVE YEAR WARRANTY (COMPRESSOR)

For a period of five years from the date of purchase, when this Royal Sovereign Portable Air Conditioner is operated and maintained according to the instruction manual provided with the product, Royal Sovereign will supply a replacement compressor (part only), free of charge, if the original compressor is determined to be defective in workmanship or material. If repair becomes necessary, please contact our customer service center. You will be responsible for all freight, insurance, and any other transportation charges to get the unit to our factory or service center. If shipping is required, be sure to pack the unit properly to avoid shipping damages, as we will not be responsible for such damages.

THIS WARRANTY IS VALID THROUGHOUT THE UNITED STATES AND PUERTO RICO ONLY

EXCLUSIONS

This warranty excludes and does not cover defects, malfunctions or failures of your Royal Sovereign Portable Air Conditioner, caused by repairs by unauthorized persons or service centers, mishandling, improper installation, modification or unreasonable use including incorrect voltage, acts of god, or failure to provide reasonable and necessary maintenance.

This warranty is in lieu of any and all expressed warranties. In no event shall Royal Sovereign be liable for consequential or incidental damages. Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not apply to you. This warranty gives you specific legal rights and you may also have other rights which vary from state to state.

ROYAL SOVEREIGN INTERNATIONAL, INC.

Royal Centurian Inc.

Royal Sovereign Qingdao Inc.

2 Volvo Drive Rockleigh, NJ 07647 USA

TEL : +1) 201-750-1020, +1) 800-397-1025 FAX : +1) 201-750-1022

Xia Zhuang Street, Liu Jia Xiao Shui Village, Cheng Yang District, Qingdao-City, Shan

Dong Province, P. R. of China

Tel : +86 532 8482 8200 Fax : +86 532 8482 8215

RS International Australia PTY. LTD.

30 Prime Drive, Seven Hills, NSW 2147, AUSTRALIA

TEL : +61) 2-9674-2127 FAX : +61) 2-9674-2027 www.royalsovereign.com / [email protected]

Royal Sovereign Canada

164 Oakdale Road, Toronto, Ontario M3N 2S5 CANADA

TEL: +1) 416-741-8400 FAX: +1) 416-741-8185