VHF FM Marine Transceiver
HX280S/E
SERVICE MANUAL
HX280S
HX280E
EM038N90A
1
Specifications (HX280S)
General
Frequency Ranges:
Channel Spacing:
Frequency Stability:
Emission Type:
Antenna Impedance:
Supply Voltage:
Current Consumption:
Operating Temperature:
Case Size (W x H x D):
Weight (Approx.):
TX: 156.025 MHz - 157.425 MHz
RX: 156.050 MHz - 163.275 MHz
25 kHz
±5 ppm (–4 °F to +140 °F [–20 °C to +60 °C])
16K0G3E
50 Ω
7.4V DC, Negative Ground (Battery Terminal)
320 mA (Receive, Typical at AF MAX.)
50 mA (Standby)
1.6 A / 0.7 A (TX: 5 W / 1W)
–4 °F to +140 °F (–20 °C to +60 °C)
2.20” x 5.24” x 1.08” (56 x 133 x 27.5 mm) w/o knob & antenna
10.9 oz (310 g) w/FNB-V105LI, Belt Clip, & Antenna
Transmitter
RF Power Output:
Modulation Type:
Maximum Deviation:
Spurious Emission:
Microphone Impedance:
5 W / 1 W (@7.4 V )
Variable Reactance
±5 kHz
–75 dBc typical
2 kΩ
Receiver
Circuit Type:
Intermediate Frequencies:
Adjacent Channel Selectivity:
Intermodulation:
Hum & Noise Ratio:
Sensitivity:
Selectivity:
AF Output (Internal SP):
Double-Conversion Superheterodyne
1st: 21.7 MHz, 2nd: 450 kHz
70 dB typical
68 dB typical
40 dB typical
0.25 μV for 12 dB SINAD
25 kHz (–70 dB)
700 mW @16 Ω for 10 % THD (@7.4 V)
Performance specifications are nominal, unless otherwise indicated, and are subject to change without notice.
Measured in accordance with TIA/EIA-603.
Important Note
The HX280S and HX280E was assembled using Pb (lead) free solder, based on the RoHS specification.
Only lead-free solder (Alloy Composition: Sn-3.0Ag-0.5Cu) should be used for repairs performed on this apparatus. The solder stated above utilizes the alloy composition required for compliance with the lead-free specification,
and any solder with the above alloy composition may be used.
2
Specifications (HX280E)
General
Frequency Ranges:
Channel Spacing:
Frequency Stability:
Emission Type:
Antenna Impedance:
Supply Voltage:
Current Consumption:
Operating Temperature:
Case Size (W x H x D):
Weight (Approx.):
156.025 MHz - 162.000 MHz
25 kHz
±5 ppm (–20 °C to +60 °C)
16K0G3E
50 Ω
7.4V DC, Negative Ground (Battery Terminal)
320 mA (Receive, Typical at AF MAX.)
50 mA (Standby)
1.6 A / 0.7 A (TX: 5 W / 1W)
–20 °C to +60 °C
56 x 133 x 27.5 mm (w/o knob & antenna)
310 g (w/FNB-V105LI, Belt Clip, & Antenna)
Transmitter
RF Power Output:
Modulation Type:
Maximum Deviation:
Spurious Emission:
Microphone Impedance:
5 W / 1 W (@7.4 V )
Variable Reactance
±5 kHz
Less than 0.25 μW
2 kΩ
Receiver
Circuit Type:
Intermediate Frequencies:
Adjacent Channel Selectivity:
Intermodulation:
Hum & Noise Ratio:
Sensitivity:
Selectivity:
AF Output (Internal SP):
Double-Conversion Superheterodyne
1st: 21.7 MHz, 2nd: 450 kHz
70 dB
68 dB
40 dB
1 μV for 20 dB SINAD
25 kHz (–70 dB)
700 mW @16 Ω for 10 % THD (@7.4 V)
Performance specifications are nominal, unless otherwise indicated, and are subject to change without notice.
Measured in accordance with EN301 178-2, EN300 698-3, EN301 843-2, EN60950-1
3
Exploded View & Miscellaneous Parts
CP9402001 (HX280S: USA)
CP9402002 (HX280S: EXP)
CP9402003 (HX280E: EU)
CP9402004 (HX280E: UK)
FRONT PANEL ASSY
RA0905300
COIL SPRING (C065)
RA1079100
LATCH NAIL
RA1079200
LATCH PLATE
RA1078700
KNOB (VOL)
RA1078800
HOLDER (PTT)
RA1079600
RUBBER KNOB (PTT)
RA1089500
SPONGE RUBBER (WINDOW)
RA1080100 (HX280S)
RA1101200 (HX280E)
RUBBER KNOB
G6090189
LCD
RA1078900
LIGHT GUID (LCD)
RA1081000
INTER CONNECTOR (LCD)
RA1089600
REFLECTOR SHEET
e
e
e
Unsolder the three battery terminals
to remove the MAIN Unit
from the Rear Case
e
e
e
RA1079400
RING NUT (VOL)
e
e
e
e
e
MAIN UNIT
RA1079500
RUBBER PACKING (VOL)
e
e
CS2020101
TERMINAL ASSY
RA1079800
RUBBER PACKING (CASE)
RA1089600
RUBBER PACKING (TERMINAL)
CP9401001
REAR PANEL ASSY
RA1078500
CASE COVER (REAR)
RA091970
O RING (6x2.2)
d
d
CP9403001
BELT CLIP ASSY
VXSTD P/N
Q3000176
AAG43X001
Q9500142
Q9500143
Q9500144
CB4777001
4
DESCRIPTION
CAT460 Antenna
FNB-V105LI Li-Ion Battery Pack
NC-90B 120VAC Wall Charger (Type-A plug)
NC-90C 230VAC Wall Charger (Type-C plug)
NC-90U 230VAC Wall Charger (Type-BF plug)
CD-46 Charger Cradle
Non-designated parts are available only
as part of a designated assembly.
c
REF.
c
d
e
VXSTD P/N
U02310020
U24106020
U9900068
DESCRIPTION
SEMS SCREW
SM3X10SUS
BIND HEAD TAPTITE-B M2X6SUS
PAN HEAD TAPTITE-B M2X4NI#3
QTY.
1
2
13
Block Diagram
5
Note
6
Circuit Description
1. Receive Signal Path
3. Squelch Control
Incoming RF from the antenna jack passes through a lowpass filter consisting of coils L1001, L1002, & L1004, capacitors C1005, C1014, C1015, & C1019, and antenna
switching diode D1004 (RLS135).
The squelch circuitry consists of a noise amplifier and
band-pass filter and noise detector within Q1026
(BA4116FV). When no carrier received, noise at the output of the detector stage in Q1026 (BA4116FV) is amplified and band-pass filtered by the noise amplifier section
of Q1026 (BA4116FV) and the network between pins 7
and 8, and then rectified by detection circuit in Q1026
(BA4116FV).
Signals within the frequency range of the transceiver enter a band-pass filter consisting of coils L1013 and L1016,
capacitors C1060, C1064, and C1067, then amplified by
Q1015 and enter a Varactor-tuned band-pass filter consisting of coils L1021 & L1022, capacitors C1106, C1107,
C1108, C1120, & C1221, and diodes D1025 & D1026 (both
HVC355B), before first mixing by Q1022 (3SK318).
Buffered output from the VCO is amplified by Q1007
(2SC5006) to provide a pure first local signal between
134.35 and 141.575 MHz for injection to the first mixer
Q1022 (3SK318).
The 21.7 MHz first mixer product then passes through
monolithic crystal filter XF1001/XF1002 to strip away all
but the desired signal, which is then amplified by Q1024
(2SC4915). The amplified first IF signal is applied to FM
IF subsystem IC Q1026 (BA4116FV), which contains the
second mixer, second local oscillator, limited amplifier,
noise amplifier, and RSSI amplifier.
A second local signal is produced from the PLL reference/
second local oscillator of X1001 (21.25 MHz). The 21.25
MHz reference signal is delivered to mixer section of FM
IF subsystem IC Q1026 (BA4116FV) which produce the
450 kHz second IF mixed with the first IF signal.
The second IF then passes through the ceramic filter
CF1001 to strip away unwanted mixer products, and is
then applied to the limited amplifier in the FM IF subsystem IC Q1026 (BA4116FV), which removes amplitude
variations in the 450kHz IF, before detection of the speech
by the ceramic discriminator CD1001.
2. Audio Amplifier
The demodulated audio signal from the Q1026
(BA4116FV) passes through a band-pass filter and Highpass filter, then applied to the de-emphasis of Q1005
(LM2902PWR). Then passes through the audio mute
switch Q1034 (SN74LVC1G66DCKR), the audio volume
VR1004 and the audio power amplifier Q1032 (TDA2822)
pin 7, providing up to 700 mW of audio power to the 16ohm loudspeaker.
The resulting DC squelch control voltage is passed to pin
64 of the microprocessor Q1025 (UPD78F0484GK). If no
carrier is received, this signal causes pin 38 of Q1025
(UPD78F0484GK) to go low and pin 67 to go high. Pin 67
signals of Q1025 (UPD78F0484GK) to disable the supply
voltage to the audio amplifier Q1032 (TDA2822).
Thus, the microprocessor blocks output from the audio
amplifier, and silences the receiver, while no signal is being received (and during transmission, as well).
4. Transmit Signal Path
The speech input from the microphone MC1001 passes
through the audio amplifier Q1003 (NJM12902V), which
is adjusted the microphone gain. The speech signal passes through pre-emphasis circuit to Q1003 (NJM12902V),
which contains the IDC, and low-pass filter. Then passes
through VR1001 which allows manual adjustment of the
transmitter deviation level.
The filtered audio signal is applied to varactor diode
D1014 (HVC306B), which frequency modulates the VCO
Q1008 (2SC5006).
The modulated signal from the VCO Q1008 (2SC5006) is
buffered by Q1007 (2SC5006). The low-level transmit signal is then passes through the TX switching diode D1017
(DAN235E) to the buffer amplifier Q1016 (2SC5226),
driver amplifier Q1013 (RQA0004PXDQS), then amplified transmit signal is applied to the final amplifier Q1009
(RQA0011DNS) up to 5.0 watts output power.
The transmit signal then passes through the antenna
switch D1003 (RLS135) and is low-pass filtered to suppress harmonic spurious radiation before delivery to the
antenna.
7
Circuit Description
4-1 Automatic Transmit Power Control
Current from the final amplifier is sampled by C1011 &
C1022, and R1004 & R1008, and is rectified by D1002
(RB715F). The resulting DC is fed back through Q1004
(LM2904PWR) to the drive amplifier Q1013
(R Q A 0 0 0 4 P X D Q S ) and final amplifier Q 1 0 0 9
(RQA0011DNS), for control of the power output.
When the microprocessor selects “High” or “Low” power levels, pin 66 of Q1025 (UPD78F0484GK) to go low at
“High” power selected or pin 66 of Q1025
(UPD78F0484GK) to go high at “Low” power selected.
5. PLL Frequency Synthesizer
The PLL circuitry on the Main Unit consists of VCO Q1008
(2SC5006), VCO buffer Q1007 (2SC5006), PLL subsystem IC Q1021 (LV2105V), which contains a reference
divider, serial-to-parallel data latch, programmable divider, phase comparator and charge pump, and crystal X1001
which frequency stability is ±5 ppm @ –20 °C to +60 °C.
While receiving, VCO Q1008 (2SC5006) oscillates between 134.35 and 141.575 MHz according to the transceiver version and the programmed receiving frequency.
The VCO output is buffered by Q1007 (2SC5006), then
applied to the prescaler section of Q1021 (LV2105V). There
the VCO signal is divided by 64 or 65, according to a control signal from the data latch section of Q1021 (LV2105V),
before being sent to the programmable divider section of
Q1021 (LV2105V).
The data latch section of Q1021 (LV2105V) also receives
serial dividing data from the microprocessor Q1025, which
causes the pre-divided VCO signal to be further divided
in the programmable divider section, depending upon the
desired receive frequency, so as to produce a 25.0 kHz
derivative of the current VCO frequency.
Meanwhile, the reference divider sections of Q1021
(LV2105V) divides the 21.25 MHz crystal reference from
the reference oscillator section ofQ1021 (LV2105V), by 850
to produce the 25.0 kHz loops reference.
8
The 25.0 kHz signal from the programmable divider (derived from the VCO) and that derived from the reference
oscillator are applied to the phase detector section of
Q1021 (LV2105V), which produces a pulsed output with
pulse duration depending on the phase difference between
the input signals.
This pulse train is filtered to DC and returned to the Varactor D1011 and D1012 (both HVC350B).
Changes in the level of the DC voltage applied to the Varactor, affecting the reference in the tank circuit of the VCO
according to the phase difference between the signals
derived from the VCO and the crystal reference oscillator.
The VCO is thus phase-locked to the crystal reference oscillator. The output of the VCO Q1008 (2SC5006) after
buffering by Q1007 (2SC5006) is applied to the first mixer as described previously.
For transmission, the VCO Q1008 (2SC5006) oscillates
between 156.025 and 157.425 MHz according to the model version and programmed transmit frequency. The remainder of the PLL circuitry is shared with the receiver.
However, the dividing data from the microprocessor is
such that the VCO frequency is at the actual transmit frequency (rather than offset for IFs, as in the receiving case).
Also, the VCO is modulated by the speech audio applied
to D1014 (HVC306B), as described previously.
6. Miscellaneous Circuits
Push-To-Talk Transmit Activation
When the PTT switch on the Main Unit is closed, pin 72 of
Q1025 (UPD78F0484GK) goes low. This signal disables
the receiver by disabling the 5 V supply bus at Q1011
(UMD5N) to the front-end, FM IF subsystem IC Q1026
(BA4116FV).
At the same time, Q1010 (UMD5N) activate the transmit 5
V supply line to enable the transmitter.
Alignment
The HX280S/E has been carefully aligned at the factory
for the specified performance across the marine band.
Realignment should therefore not be necessary except in
the event of a component failure.
All component replacement and service should be performed only by an authorized STANDARD HORIZON
representative, or the warranty policy may be voided.
The following procedures cover the sometimes critical and
tedious adjustments that are not normally required once
the transceiver has left the factory. However, if damage
occurs and some parts are replaced, realignment may be
required. If a sudden problem occurs during normal operation, it is likely due to component failure; realignment
should not be done until after the faulty component has
been replaced.
We recommend that servicing be performed only by authorized STANDARD HORIZON service technicians who
are experienced with the circuitry and fully equipped for
repair and alignment. Therefore, if a fault is suspected,
contact the dealer from whom the transceiver was purchased for instructions regarding repair. Authorized
STANDARD HORIZON service technicians realign all circuits and make complete performance checks to ensure
compliance with factory specifications after replacing any
faulty components. Those who do undertake any of the
following alignments are cautioned to proceed at their
own risk.
Problems caused by unauthorized attempts at realignment
are not covered by the warranty policy. Also, STANDARD
HORIZON must reserve the right to change circuits and
alignment procedures in the interest of improved performance, without notifying owners. Under no circumstances
should any alignment be attempted unless the normal
function and operation of the transceiver are clearly understood, the cause of the malfunction has been clearly
pinpointed and any faulty components replaced, and the
need for realignment determined to be absolutely necessary. The following test equipment (and thorough familiarity with its correct use) is necessary for complete realignment. Correction of problems caused by misalignment resulting from use of improper test equipment is
not covered under the warranty policy. While most steps
do not require all of the equipment listed, the interactions
of some adjustments may require that more complex adjustments be performed afterwards. Do not attempt to
perform only a single step unless it is clearly isolated electrically from all other steps. Have all test equipment ready
before beginning, and follow all of the steps in a section
in the order presented.
Required Test Equipment
ˆ RF Signal Generator with calibrated output level at
200 MHz
ˆ Frequency Counter: >0.1 ppm accuracy at 200 MHz
ˆ AF Signal Generator
ˆ Deviation Meter (linear detector)
ˆ VHF Sampling Coupler
ˆ Inline Wattmeter with 5% accuracy at 200 MHz
ˆ 50-ohm Non-reactive Dummy Load: 10W at 200 MHz
ˆ 7.4 VDC, 2A Regulated DC Power Supply
ˆ IBM® PC/compatible computer with Microsoft® Windows® 2000, XP, or Vista
ˆ Standard Horizon HX280 Service Flag Controller and
Alignment Jig.
Alignment Preparation & Precautions
A dummy load and inline wattmeter must be connected
to the main antenna jack in all procedures that call for
transmission, except where specified otherwise. Correct
alignment is not possible with an antenna. After completing one step, read the following step to determine whether the same test equipment will be required. If not, remove the test equipment (except dummy load and wattmeter, if connected) before proceeding.
Correct alignment requires that the ambient temperature
be the same as that of the transceiver and test equipment,
and that this temperature be held constant between 20 °C
and 30 °C (68 °F ~ 86 °F). When the transceiver is brought
into the shop from hot or cold air it should be allowed
some time for thermal equalization with the environment
before alignment. If possible, alignments should be made
with oscillator shields and circuit boards firmly affixed
in place. Also, the test equipment must be thoroughly
warmed up before beginning.
Note: Signal levels in dB referred to in this procedure are
based on 0 dBμ = 0.5 μV(closed circuit).
9
Alignment
Before Alignment
Main Reference Frequency Adjustment
ˆ Install the HX280 Service Flag Controller Program to
your computer.
ˆ Remove the Front Panel from the transceiver according to the following procedures:
1) Disconnect the antenna from the transceiver.
2) Remove the VOL knob and Battery Pack from the
transceiver
3) Remove the two screws which located at the bottom side on the battery compartment.
4) Carefully pull out the chassis from the Front Panel.
Refer to the “Exploded View“ on the page 4.
ˆ Set up the test equipment as shown below, and set the
DC Power Supply voltage to 7.4 V.
ˆ Execute the HX280 Service Flag Controller Program.
ˆ Select the COM port number which is connected to
the HX280 Alignment Jig.
ˆ Press and hold in the [PRESET] key
while turning the transceiver on to
enter the Alignment Mode.
ˆ Select “Alignment ON” Radio Button of the HX280 Service Flag Controller Program.
ˆ Click the left mouse button on the
[SET] button of the HX280 Service
Flag Controller Program.
ˆ
ˆ
ˆ
ˆ
Inline
Wattmeter
RF Sampling
Coupler
Turn the Antenna switch to the “TX Alignment” side.
Remove the solder jumper JP1001.
Set the channel to CH16.
Use the [H/L] key to set the transceiver to “LOW”
power.
ˆ With the PTT switch pressed, adjust TC1001 so the
Frequency Counter reading is 156.800 MHz ± 100 Hz.
Transmit Power Adjustment
ˆ
ˆ
ˆ
ˆ
ˆ
ˆ
ˆ
ˆ
ˆ
Antenna Switch
“TX” Alignment
“RX” Alignment
50 Ω
Dummy Load
Frequency
Counter
Turn the Antenna switch to the “TX Alignment” side.
Set the channel to CH16.
Increase the DC Power Supply voltage to 8.0 V.
Use the [H/L] key to set the transceiver to “HI” power.
With the PTT switch pressed, adjust VR1003 so that
RF output power is 5.0 W ± 0.1 W.
Release the PTT switch, then set the transceiver to
“LOW” power by the [H/L] key.
With the PTT switch pressed, adjust VR1002 so that
RF output power is 0.8 W ± 0.1 W.
Release the PTT switch.
Return the DC Power Supply voltage to 7.4 V.
RF Signal
Generator
Attention!
The HX280’s Audio output is BTL output.
16 Ω 1 W
Resistor
VR1002
AF Signal
Generator
VR1003
JP1001
TC1001
VR1005
VR1001
TP1018
( ) : RED
Regulated
Power Supply ( ) :
BLACK
HX280 Alignment Jig
10
D-SUB 9-pin Jack
Alignment
TX Deviation Adjustment
ˆ Turn the Antenna switch to the “TX Alignment” side.
ˆ Confirm that the solder jumper JP1001 is removed.
ˆ Set the AF Signal Generator output to 200 mVrms at 1
kHz.
ˆ Set the channel to CH16.
ˆ With the PTT switch pressed, adjust VR1001 so that
the maximum deviation is 4.4 kHz ± 0.1 kHz.
ˆ Release the PTT switch.
ˆ Solder the jumper JP1001.
Squelch Level Adjustment
ˆ Turn the Antenna switch to the “RX Alignment” side.
ˆ Set the channel to CH16.
ˆ Set the RF Signal Generator output to 156.800 MHz,
at a level of +0 dBμ (HX280S) or +3 dBμ (HX280E),
±3.0 kHz deviation with a 1 kHz audio tone.
ˆ Connect the DC voltmeter to TP1018, adjust VR1005
so that DC voltmeter reading is 0.2 V ± 0.02 V (HX280S)
or 0.45 V ± 0.02 V (HX280E).
Software Alignment/Confirmation Mode
Overview of Software Alignment Mode
ˆ The “Software Alignment Mode” has been build in
the microprocessor in order to adjust and confirm the
performance of transceiver.
ˆ The purpose is to adjust transceiver simply and to confirm the performance of transceiver smoothly.
Starting Software Alignment Mode
ˆ Set the channel to CH16, then turn the VOL knob
counter clockwise to turn off the radio.
ˆ Turn the Antenna switch to the “RX Alignment” side.
ˆ Turn the VOL knob clockwise to
turn on the radio while press and
holding the [PRESET ] keys. The
LCD will be shown the Alignment
AL
mode “AL
AL”.
ˆ Press the [SCAN] key. Then the LCD
will be shown the Alignment Item
tH
(1st Item is Threshold “tH
tH”).
ˆ Set the RF Signal Generator output
to 156.800 MHz, at a level of –8 dBμ (HX280S) or
–6 dBμ (HX280E), ±3.0 kHz deviation with a 1 kHz
audio tone.
ˆ Press the [PRESET] key to record a
threshold level.
ˆ Press the [MEM] key to save the new
setting.
ˆ Press the [SCAN] key to recall the
tI (TIGHT)”.
Alignment Item “tI
ˆ Set the RF Signal Generator output
to 156.800 MHz, at a level of +0 dBμ
(HX280S) or +3 dBμ (HX280E), ±3.0 kHz deviation
with a 1 kHz audio tone.
ˆ Press the [PRESET] key to record a
tight level.
ˆ Press the [MEM] key to save the new
setting.
This completes the Software Alignment Mode. To save
all settings and exit, press and hold the [16/9] key for one
second. Then turn off the transceiver.
After Alignment
ˆ Execute the HX280 Service Flag Controller Program
again.
ˆ Select the COM port number which is connected to
the HX280 Alignment Jig.
ˆ Press and hold in the [PRESET] key while turning
the transceiver on to enter the Alignment Mode.
ˆ Select “Alignment OFF” Radio Button of HX280 Service Flag Controller Program.
ˆ Click the left mouse button on the
[SET] button of the HX280 Service
Flag Controller Program.
ˆ Turn off the transceiver.
ˆ Assemble the transceiver while being carefully so that
Rubber Packing does not protrude from a Front Case.
Important Note: To ensure the radio is water proof,
make sure the gasket is installed on the chassis correctly and is not pinched when inserted into the front
case.
NOTICE
dC
Do not touch the Alignment Item “dC
dC”.
11
Note
12
MAIN Unit
RF AMP
Q1015
RX: 0 V
TX: 0.82 V
1st Mixer
Q1022
IF AMP
Q1024
Circuit Diagram
2nd Mixer / IF
Q1026
RX: 2.54 V
TX: 0 V
RX: 3.53 V RX: 4.18 V
TX: 0 V
TX: 0 V
RX: 4.67 V
TX: 0 V
RX: 1.82 V
TX: 0 V
RX: 2.48 V
TX: 0 V
RX: 2.33 V
TX: 0 V
RX: 1.09 V
TX: 0 V
BPF “LOW”: 0.01 V
BPF “HIGH”: 1.56 V
RX: 0 V
TX: 1.66 V
RX: 0 V
TX: 2.83 V
RX: 3.92 V
TX: 0 V
RX: 1.75 V
TX: 0 V
VCO Input
BPF “LOW”: 3.29 V
BPF “HIGH”: 0 V
RX SIGNAL “Non”: 1.15 V
RX SIGNAL “40 dBμ”: 0.02 V
RX: 0 V
TX: 0.91 V
RX: 0 V
TX: 1.13 V
RX: 0 V
TX: 1.41 V
RX: 0 V
TX: 2.21 V
RX: 7.35 V
TX: 0.40 V
7.40 V
3.11 V
RX: 2.77 V
TX: 0 V
RX: 2.75 V
TX: 1.84 V
3.44 V
RX: 6.62 V
TX: 7.12 V
RX: 1.41 V
TX: 1.41 V
4.12 V
2.28 V
1.78 V
1.93 V
RX: 1.69 V
TX: 3.37 V
RX: 3.29 V
TX: 0 V
RX: 4.90 V
TX: 0 V
RX: 0 V
TX: 4.78 V
3.30 V
RX: 0 V
TX: 3.29 V
RX: 3.29 V
TX: 0 V
7.39 V
0V
13
MAIN Unit
Note
14
MAIN Unit
Parts Layout (Side A)
A
B
C
D
E
F
G
H
1
2
3
4
μPD78F0484GK
(Q1025)
LM2904PWR
(Q1004)
DTC143ZE (E23)
(Q1035)
DTC144EE (26)
(Q1020, 1036)
VMZ6.8NT2L (6C)
(D1024)
15
MAIN Unit
Parts Layout (Side B)
a
b
c
d
e
f
g
h
1
2
3
4
BA4116FV
(Q1026)
LV2105V
(Q1021)
LM2902PWR
(Q1005)
NJM12902V
(Q1003)
BR24L08FVT
(Q1027)
TDA2822D013TR
(Q1032)
16
2SA1774 (FR)
(Q1017, 1031)
FMMTL718TA
(Q1033)
2SC4617 (BR)
(Q1014, 1018)
2SC4915 (QY)
(Q1024)
2SC5006 (24)
(Q1007, 1008)
2SC5226 (R22)
(Q1016)
3SK294 (UV)
(Q1022)
3SK318 (YB)
(Q1022)
DTC143ZE (E23)
(Q1023)
DTC144EE (26)
(Q1006, 1029,
1030)
RQA0004PXDQS (PX)
(Q1013)
SN74LVC1G66
(Q1034)
FMMTL618TA (L68)
(Q1012)
RQA0011DNS
(Q1009)
TAR5S33U
(Q1002)
TAR5S50U
(Q1001)
UMD5N
(Q1010, 1011)
DA221 (K)
(D1019)
DAN235E
(D1017)
RB715F (3D)
(D1002)
IMN10 (N10)
(D1020)
MAIN Unit
Parts List
REF
C 1001
C 1004
C 1005
C 1006
C 1007
C 1009
C 1010
C 1011
C 1012
C 1013
C 1014
C 1015
C 1017
C 1018
C 1019
C 1020
C 1021
C 1022
C 1024
C 1025
C 1026
C 1027
C 1028
C 1029
C 1030
C 1031
C 1033
C 1034
C 1035
C 1036
C 1038
C 1039
C 1040
C 1041
C 1043
C 1044
C 1045
C 1046
C 1047
C 1048
C 1049
C 1050
C 1052
C 1054
C 1055
C 1056
C 1057
C 1058
C 1060
C 1061
C 1062
C 1063
C 1064
C 1065
C 1066
C 1067
C 1068
C 1069
C 1070
C 1071
C 1072
C 1073
C 1074
C 1075
C 1076
C 1077
C 1079
C 1081
C 1082
C 1083
DESCRIPTION
VALUE
V/W
TOL.
MFR'S DESIG
PCB with Components (No adjustment. Requires the adjustment for use.)
Printed Circuit Board
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP TA.CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP TA.CAP.
CHIP CAP.
CHIP CAP.
CHIP TA.CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP TA.CAP.
CHIP CAP.
CHIP TA.CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP TA.CAP.
CHIP TA.CAP.
CHIP CAP.
CHIP CAP.
CHIP TA.CAP.
0.001uF
0.1uF
18pF
0.001uF
0.01uF
0.001uF
10uF
0.5pF
0.1uF
0.1uF
27pF
4pF
0.001uF
0.01uF
10pF
0.01uF
0.01uF
0.5pF
18pF
18pF
0.01uF
0.001uF
56pF
33pF
0.01uF
5pF
0.001uF
10uF
0.001uF
0.001uF
10uF
0.001uF
27pF
27pF
0.001uF
0.001uF
22pF
0.1uF
0.01uF
33pF
0.001uF
0.001uF
1pF
0.001uF
15pF
0.001uF
82pF
0.001uF
18pF
15pF
0.001uF
0.01uF
15pF
0.01uF
2.2uF
33pF
0.1uF
0.001uF
10uF
0.001uF
0.1uF
0.001uF
0.001uF
0.1uF
0.01uF
10uF
22uF
15pF
0.001uF
0.47uF
50V
10V
50V
50V
25V
50V
16V
50V
10V
10V
50V
25V
50V
25V
25V
25V
25V
50V
50V
50V
25V
50V
50V
50V
25V
25V
50V
10V
50V
50V
10V
50V
50V
50V
50V
50V
50V
10V
25V
50V
50V
50V
25V
50V
25V
50V
50V
50V
50V
25V
50V
25V
25V
25V
10V
50V
35V
50V
16V
50V
10V
50V
50V
10V
25V
10V
6.3V
25V
50V
35V
B
B
CH
B
B
B
CK
B
B
CH
CH
B
B
CH
B
B
CK
CH
CH
B
B
CH
CH
B
CH
B
B
B
B
CH
CH
B
B
CH
B
B
CH
B
B
CK
B
CH
B
CH
B
CH
CH
B
B
CH
B
B
CH
B
B
B
B
B
B
B
CH
B
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM1552C1H180JZ01D
GRM155B11H102KA01D
GRM155B11E103KA01D
GRM155B11H102KA01D
TEESVA1C106M8R
UMK105CK0R5CV-F
GRM155B11A104KA01D
GRM155B11A104KA01D
GRM1552C1H270JZ01D
TMK105CH040C-F
GRM155B11H102KA01D
GRM155B11E103KA01D
TMK105CH100D-F
GRM155B11E103KA01D
GRM155B11E103KA01D
UMK105CK0R5CV-F
GRM1552C1H180JZ01D
GRM1552C1H180JZ01D
GRM155B11E103KA01D
GRM155B11H102KA01D
GRM1552C1H560JD01D
GRM1552C1H330JZ01D
GRM155B11E103KA01D
TMK105CH050C-F
GRM155B11H102KA01D
TEESVA1A106M8R
GRM155B11H102KA01D
GRM155B11H102KA01D
TEESVA1A106M8R
GRM155B11H102KA01D
GRM1552C1H270JZ01D
GRM1552C1H270JZ01D
GRM155B11H102KA01D
GRM155B11H102KA01D
UMK105CH220JV-F
GRM155B11A104KA01D
GRM155B11E103KA01D
GRM1552C1H330JZ01D
GRM155B11H102KA01D
GRM155B11H102KA01D
TMK105CK010C-F
GRM155B11H102KA01D
TMK105CH150J-F
GRM155B11H102KA01D
GRM1552C1H820JD01D
GRM155B11H102KA01D
GRM1552C1H180JZ01D
TMK105CH150J-F
GRM155B11H102KA01D
GRM155B11E103KA01D
TMK105CH150J-F
GRM155B11E103KA01D
GRM188B31A225KE18D
GRM1552C1H330JZ01D
TEESVA1V104M8R
GRM155B11H102KA01D
TEESVA1C106M8R
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM155B11E103KA01D
TEESVA1A106M8R
TEESVA0J226M8R
TMK105CH150J-F
GRM155B11H102KA01D
TEESVA1V474M8R
VXSTD P/N
CB4645001
CB4645002
FR019200C
K22178809
K22108802
K22178218
K22178809
K22148834
K22178809
K78120077
K22178247
K22108802
K22108802
K22178222
K22148208
K22178809
K22148834
K22148214
K22148834
K22148834
K22178247
K22178218
K22178218
K22148834
K22178809
K22178230
K22178224
K22148834
K22148209
K22178809
K78100028
K22178809
K22178809
K78100028
K22178809
K22178222
K22178222
K22178809
K22178809
K22178266
K22108802
K22148834
K22178224
K22178809
K22178809
K22148205
K22178809
K22148218
K22178809
K22178234
K22178809
K22178218
K22148218
K22178809
K22148834
K22148218
K22148834
K22104805
K22178224
K78160025
K22178809
K78120077
K22178809
K22108802
K22178809
K22178809
K22108802
K22148834
K78100028
K78080047
K22148218
K22178809
K78160029
VERS.
HX280S
HX280E
LOT SIDE LAY ADR
11111111111111111111111111111111111111111111111111111111111111111111111-
B
B
B
B
B
B
A
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
A
B
B
A
B
B
B
B
B
B
B
B
B
A
A
B
B
B
A
B
A
B
B
B
B
B
B
B
B
B
B
B
B
A
B
B
B
B
B
B
B
B
B
h3
h3
h3
g1
f1
h3
A2
h3
e2
e1
h3
g3
c3
g1
g3
g1
g1
g3
g3
f3
g2
g1
g3
f3
f3
c3
g2
B1
c3
f3
B1
c3
c3
c3
f3
f3
g3
a3
f3
c3
C3
C3
c3
f3
g2
C3
e3
C3
g2
e3
c3
f1
g2
f1
c3
g2
d3
c2
g3
e3
A3
g2
e3
c2
e3
d3
c3
e3
c3
d3
17
MAIN Unit
Parts List
REF
C 1084
C 1086
C 1087
C 1088
C 1089
C 1090
C 1091
C 1092
C 1093
C 1094
C 1095
C 1097
C 1098
C 1099
C 1100
C 1100
C 1102
C 1104
C 1105
C 1106
C 1106
C 1107
C 1108
C 1108
C 1109
C 1110
C 1111
C 1112
C 1112
C 1113
C 1114
C 1115
C 1116
C 1118
C 1119
C 1120
C 1121
C 1122
C 1123
C 1124
C 1125
C 1126
C 1127
C 1128
C 1129
C 1129
C 1130
C 1131
C 1132
C 1134
C 1135
C 1136
C 1137
C 1139
C 1141
C 1142
C 1142
C 1143
C 1144
C 1145
C 1146
C 1147
C 1148
C 1149
C 1150
C 1151
C 1152
C 1153
C 1154
C 1155
C 1156
C 1157
C 1159
18
DESCRIPTION
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
VALUE
1uF
10pF
1uF
0.01uF
0.001uF
0.001uF
0.001uF
0.22uF
0.1uF
8pF
0.001uF
0.01uF
0.001uF
10pF
6pF
4pF
1uF
8pF
0.001uF
12pF
13pF
1pF
12pF
13pF
27pF
3pF
1pF
4pF
8pF
5pF
1uF
100pF
0.001uF
68pF
0.01uF
0.001uF
15pF
0.001uF
0.001uF
0.001uF
22pF
18pF
22pF
18pF
33pF
27pF
0.001uF
0.01uF
0.001uF
0.1uF
0.001uF
0.1uF
8pF
0.01uF
1uF
33pF
15pF
0.1uF
0.001uF
2pF
0.01uF
330pF
0.0056uF
0.47uF
0.0068uF
0.1uF
0.01uF
1uF
82pF
0.1uF
270pF
270pF
15pF
V/W
6.3V
25V
6.3V
25V
50V
50V
50V
10V
10V
50V
50V
25V
50V
25V
50V
25V
6.3V
50V
50V
25V
50V
25V
25V
50V
50V
25V
25V
25V
50V
25V
6.3V
25V
50V
50V
25V
50V
25V
50V
50V
50V
50V
50V
50V
50V
50V
50V
50V
25V
50V
10V
50V
10V
50V
25V
6.3V
50V
25V
10V
50V
50V
25V
50V
25V
6.3V
25V
10V
25V
6.3V
50V
10V
50V
50V
25V
TOL.
B
CH
B
B
B
B
B
B
B
CH
B
B
B
CH
CH
CH
B
CH
B
CH
CH
CK
CH
CH
CH
CJ
CK
CH
CH
CH
B
CH
B
CH
B
B
CH
B
B
B
CH
CH
CH
CH
CH
CH
B
B
B
B
B
B
CH
B
B
CH
CH
B
B
CK
B
B
B
B
B
B
B
B
CH
B
B
B
CH
MFR'S DESIG
GRM155B30J105KE18D
TMK105CH100D-F
GRM155B30J105KE18D
GRM155B11E103KA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B31A224KE18D
GRM155B11A104KA01D
GRM1552C1H8R0DZ01D
GRM155B11H102KA01D
GRM155B11E103KA01D
GRM155B11H102KA01D
TMK105CH100D-F
GRM1552C1H6R0DZ01D
TMK105CH040C-F
GRM155B30J105KE18D
GRM1552C1H8R0DZ01D
GRM155B11H102KA01D
TMK105CH120J-F
UMK105CH130JV-F
TMK105CK010C-F
TMK105CH120J-F
UMK105CH130JV-F
GRM1552C1H270JZ01D
TMK105CJ030C-F
TMK105CK010C-F
TMK105CH040C-F
GRM1552C1H8R0DZ01D
TMK105CH050C-F
GRM155B30J105KE18D
TMK105CH101J-F
GRM155B11H102KA01D
GRM1552C1H680JZ01D
GRM155B11E103KA01D
GRM155B11H102KA01D
TMK105CH150J-F
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
UMK105CH220JV-F
GRM1552C1H180JZ01D
UMK105CH220JV-F
GRM1552C1H180JZ01D
GRM1552C1H330JZ01D
GRM1552C1H270JZ01D
GRM155B11H102KA01D
GRM155B11E103KA01D
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM1552C1H8R0DZ01D
GRM155B11E103KA01D
GRM155B30J105KE18D
GRM1552C1H330JZ01D
TMK105CH150J-F
GRM155B11A104KA01D
GRM155B11H102KA01D
GRM1554C1H2R0CZ01D
GRM155B11E103KA01D
UMK105B331KW-F
TMK105B562KW-F
GRM155B30J474KE18D
TMK105B682KW-F
GRM155B11A104KA01D
GRM155B11E103KA01D
GRM155B30J105KE18D
GRM1552C1H820JD01D
GRM155B11A104KA01D
UMK105B271KW-F
UMK105B271KW-F
TMK105CH150J-F
VXSTD P/N
K22088803
K22148214
K22088803
K22148834
K22178809
K22178809
K22178809
K22108808
K22108802
K22178210
K22178809
K22148834
K22178809
K22148214
K22178208
K22148208
K22088803
K22178210
K22178809
K22148216
K22178261
K22148205
K22148216
K22178261
K22178222
K22148207
K22148205
K22148208
K22178210
K22148209
K22088803
K22148238
K22178809
K22178232
K22148834
K22178809
K22148218
K22178809
K22178809
K22178809
K22178266
K22178218
K22178266
K22178218
K22178224
K22178222
K22178809
K22148834
K22178809
K22108802
K22178809
K22108802
K22178210
K22148834
K22088803
K22178224
K22148218
K22108802
K22178809
K22178204
K22148834
K22178823
K22148832
K22088802
K22148833
K22108802
K22148834
K22088803
K22178234
K22108802
K22178822
K22178822
K22148218
VERS.
HX280E
HX280S
HX280E
HX280S
HX280E
HX280S
HX280E
HX280S
HX280E
HX280S
HX280E
HX280S
LOT SIDE LAY ADR
1- B
d1
1- B
g2
1- A
C3
1- B
c3
1- B
e3
1- B
e3
1- B
g2
1- A
B3
1- B
d3
1- B
g2
1- B
d3
1- B
f1
1- B
g2
1- B
e3
1- B
g2
1- B
g2
1- A
B3
1- B
g2
1- B
e3
1- B
f2
1- B
f2
1- B
f2
1- B
f2
1- B
f2
1- B
c2
1- B
c2
1- B
f2
1- B
f2
1- B
f2
1- B
d3
1- A
B3
1- B
c2
1- A
B3
1- B
d3
1- B
e2
1- B
f2
1- B
d3
1- B
e2
1- B
d3
1- B
f2
1- B
e2
1- B
e3
1- B
e3
1- B
e3
1- B
e2
1- B
e2
1- B
f2
1- B
d3
1- B
e3
1- B
d3
1- B
d3
1- B
d3
1- B
e2
1- B
d2
1- B
b3
1- B
d2
1- B
d2
1- A
D3
1- B
b2
1- B
c2
1- B
b1
1- B
b3
1- B
b3
1- A
E1
1- B
b3
1- B
b1
1- B
b1
1- B
b3
1- B
c2
1- B
c1
1- B
c1
1- B
c1
1- B
a3
MAIN Unit
Parts List
REF
C 1160
C 1161
C 1162
C 1163
C 1164
C 1165
C 1166
C 1167
C 1168
C 1169
C 1171
C 1172
C 1174
C 1175
C 1176
C 1177
C 1180
C 1181
C 1182
C 1183
C 1184
C 1185
C 1186
C 1187
C 1188
C 1189
C 1190
C 1191
C 1192
C 1193
C 1194
C 1195
C 1196
C 1197
C 1198
C 1199
C 1200
C 1201
C 1202
C 1203
C 1204
C 1205
C 1206
C 1207
C 1210
C 1211
C 1212
C 1213
C 1214
C 1215
C 1216
C 1217
C 1220
C 1221
C 1225
C 1230
C 1231
C 1235
C 1236
CD1001
CF1001
D 1002
D 1003
D 1004
D 1005
D 1006
D 1007
D 1008
D 1009
D 1010
D 1011
D 1012
D 1013
DESCRIPTION
CHIP CAP.
CHIP TA.CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP TA.CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP TA.CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP TA.CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP TA.CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CHIP CAP.
CERAMIC DISC
CERAMIC FILTER
DIODE
DIODE
DIODE
LED
LED
DIODE
LED
DIODE
LED
DIODE
DIODE
LED
VALUE
0.1uF
22uF
0.1uF
0.001uF
0.01uF
0.1uF
0.01uF
0.1uF
4.7uF
0.001uF
0.1uF
10uF
18pF
0.047uF
15pF
0.001uF
4.7uF
47pF
22pF
4.7uF
0.01uF
0.1uF
0.047uF
1uF
0.047uF
0.001uF
0.001uF
0.0056uF
0.047uF
1uF
1uF
0.001uF
0.1uF
0.1uF
10uF
0.01uF
0.01uF
270pF
0.1uF
0.0047uF
4.7uF
0.01uF
22uF
0.1uF
0.001uF
0.1uF
1uF
1uF
0.1uF
0.001uF
0.001uF
0.001uF
47pF
47pF
0.001uF
0.001uF
1uF
0.001uF
0.001uF
V/W
10V
6.3V
10V
50V
25V
10V
25V
10V
6.3V
50V
10V
10V
50V
16V
25V
50V
16V
50V
50V
6.3V
25V
10V
10V
6.3V
10V
50V
50V
25V
10V
6.3V
6.3V
50V
10V
10V
16V
25V
25V
50V
10V
50V
6.3V
25V
16V
10V
50V
10V
6.3V
6.3V
10V
50V
50V
50V
50V
50V
50V
50V
6.3V
50V
50V
TOL.
B
B
B
B
B
B
B
B
B
B
CH
F
CH
B
CH
CH
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
CH
CH
B
B
B
B
B
MFR'S DESIG
GRM155B11A104KA01D
TEESVA0J226M8R
GRM155B11A104KA01D
GRM155B11H102KA01D
GRM155B11E103KA01D
GRM155B11A104KA01D
GRM155B11E103KA01D
GRM155B11A104KA01D
C1608JB0J475KT
GRM155B11H102KA01D
GRM155B11A104KA01D
TEESVA1A106M8R
GRM1552C1H180JZ01D
GRM155F11C473ZA01D
TMK105CH150J-F
GRM155B11H102KA01D
TEESVA1C475M8R
GRM1552C1H470JZ01D
UMK105CH220JV-F
C1608JB0J475KT
GRM155B11E103KA01D
GRM155B11A104KA01D
GRM155B11A473KA01D
GRM155B30J105KE18D
GRM155B11A473KA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
TMK105B562KW-F
GRM155B11A473KA01D
GRM155B30J105KE18D
GRM155B30J105KE18D
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM155B11A104KA01D
TEESVA1C106M8R
GRM155B11E103KA01D
GRM155B11E103KA01D
UMK105B271KW-F
GRM155B11A104KA01D
GRM155B11H472KA01D
JMK107BJ475MA-T
GRM155B11E103KA01D
TEESVB21C226M8R
GRM155B11A104KA01D
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM155B30J105KE18D
GRM155B30J105KE18D
GRM155B11A104KA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM1552C1H470JZ01D
GRM1552C1H470JZ01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B30J105KE18D
GRM155B11H102KA01D
GRM155B11H102KA01D
JTBM450CX24
LTM450FW
RB715F T106
RLS135 TE-11
RLS135 TE-11
SML-512DWT86
SML-512DWT86
1SS400 TE61
SML-512DWT86
1SS400 TE61
SML-512DWT86
HVC350B-TRF-E
HVC350B-TRF-E
SML-512DWT86
VXSTD P/N
K22108802
K78080047
K22108802
K22178809
K22148834
K22108802
K22148834
K22108802
K22084804
K22178809
K22108802
K78100028
K22178218
K22129004
K22148218
K22178809
K78120031
K22178228
K22178266
K22084804
K22148834
K22108802
K22108801
K22088803
K22108801
K22178809
K22178809
K22148832
K22108801
K22088803
K22088803
K22178809
K22108802
K22108802
K78120077
K22148834
K22148834
K22178822
K22108802
K22178838
K22084803
K22148834
K78120028
K22108802
K22178809
K22108802
K22088803
K22088803
K22108802
K22178809
K22178809
K22178809
K22178228
K22178228
K22178809
K22178809
K22088803
K22178809
K22178809
H7901530
H3900572
G2070752
G2070128
G2070128
G2071116
G2071116
G2070634
G2071116
G2070634
G2071116
G2070596
G2070596
G2071116
VERS.
HX280E
HX280E
LOT SIDE LAY ADR
1- B
h1
1- B
c1
1- B
b1
1- B
b1
1- B
c1
1- B
a3
1- A
E1
1- B
b1
1- A
E1
1- B
b1
1- B
b1
1- B
b1
1- B
d1
1- B
a3
1- B
a3
1- B
b2
1- B
b2
1- B
b1
1- B
d1
1- B
e1
1- B
e1
1- B
b3
1- B
a1
1- B
b3
1- B
a1
1- B
b3
1- B
b3
1- B
a3
1- B
a1
1- B
b3
1- B
g2
1- B
h1
1- B
a1
1- B
a2
1- B
h2
1- B
h2
1- B
a2
1- B
b2
1- B
f1
1- B
a2
1- B
f1
1- B
h2
1- B
h2
1- B
h2
1- B
f3
1- B
h2
1- B
h1
1- B
h1
1- B
h2
1- B
f1
1- A
A1
1- A
A1
1- B
f2
1- B
f2
1- B
e3
1- B
h3
1- A
F3
1- B
d3
1- B
c4
1- B
c2
1- A
F2
1- B
g3
1- B
g3
1- B
g3
1- A
D4
1- A
D4
1- B
g3
1- A
E4
1- B
h2
1- A
G3
1- B
c3
1- B
c3
1- A
G2
19
Parts List
REF
D 1014
D 1015
D 1016
D 1017
D 1018
D 1019
D 1020
D 1023
D 1024
D 1025
D 1026
DS1001
F 1001
FB1001
FB1002
J 1001
J 1002
J 1003
L 1001
L 1002
L 1003
L 1004
L 1005
L 1006
L 1007
L 1008
L 1009
L 1010
L 1011
L 1012
L 1013
L 1014
L 1015
L 1016
L 1017
L 1017
L 1018
L 1019
L 1021
L 1022
L 1023
L 1024
L 1025
L 1026
L 1027
L 1029
MC1001
Q 1001
Q 1002
Q 1003
Q 1004
Q 1005
Q 1006
Q 1007
Q 1008
Q 1009
Q 1010
Q 1011
Q 1012
Q 1013
Q 1014
Q 1015
Q 1016
Q 1017
Q 1018
Q 1020
Q 1021
Q 1022
Q 1023
Q 1024
Q 1025
Q 1026
Q 1027
20
DESCRIPTION
DIODE
LED
LED
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
LCD
CHIP FUSE
FERRITE BEADS
FERRITE BEADS
SHIELD FINGER
SHIELD FINGER
SHIELD FINGER
COIL
COIL
M.RFC
COIL
COIL
COIL
M.RFC
COIL
M.RFC
M.RFC
M.RFC
CHIP COIL
M.RFC
M.RFC
M.RFC
M.RFC
M.RFC
M.RFC
M.RFC
M.RFC
M.RFC
M.RFC
M.RFC
M.RFC
M.RFC
M.RFC
M.RFC
M.RFC
MIC. ELEMENT
IC
IC
IC
IC
IC
TRANSISTOR
TRANSISTOR
TRANSISTOR
FET
TRANSISTOR
TRANSISTOR
TRANSISTOR
FET
TRANSISTOR
FET
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
IC
FET
TRANSISTOR
TRANSISTOR
IC
IC
IC
VALUE
V/W
TOL.
3.15A
0.15uH
4.7uH
4.7uH
0.039uH
0.022uH
0.033uH
0.082uH
4.7uH
0.068uH
0.056uH
0.18uH
0.22uH
0.1uH
0.068uH
0.039uH
0.039uH
0.082uH
0.056uH
0.056uH
1.5uH
1.5uH
0.047uH
2%
2%
2%
2%
2%
2%
2%
2%
MFR'S DESIG
HVC306B TRU-E
SML-512DWT86
SML-512DWT86
DAN235E TL
RB521S-30 TE61
DA221 TL
IMN10 T108
1SS400 TE61
VMZ6.8NT2L
HVC355B TRF-E
HVC355B TRF-E
AM038N
FHC16 322ADTP
BLM18PG330SN1D
BLM18PG330SN1D
3525 3100103
1674954-1
1674954-1
E2 0.25-1.9-6.5T-L
E2 0.25-1.9-6.5T-L
HK1608 R15J-T
E2 0.28-1.0-4.5T-R
E2 0.4-1.5-4T-L
E2 0.25-1.9-6.5T-L
LK1608 4R7K-T
E2 0.25-1.9-6.5T-L
LK2125 4R7K-T
HK1608 39NJ-T
HK1608 22NJ-T
C2520C-33NG
C1608CB-82NG-RF
LK1608 4R7K-T
C1608CB-68NG-RF
C1608CB-56NG-RF
C1608CB-R18G-RF
C1608CB-R22G-RF
HK1608 R10J-T
HK1608 68NJ-T
C1608CB-39NG-RF
C1608CB-39NG-RF
HK1608 82NJ-T
HK1608 56NJ-T
HK1608 56NJ-T
LK1608 1R5K-T
LK1608 1R5K-T
HK1608 47NJ-T
PF0-1055P
TAR5S50U(TE85L.F)
TAR5S33U(TE85L.F)
NJM12902V-TE1
LM2904PWR
LM2902PWR
DTC144EE TL
2SC5006-T1
2SC5006-T1
RQA0011DNS
UMD5N TR
UMD5N TR
FMMTL618TA
RQA0004PXDQS
2SC4617 TL R
3SK294(TE85L)
2SC5226-5-TL
2SA1774 TL R
2SC4617 TL R
DTC144EE TL
LV2105V-TLM
3SK318 TL
DTC143ZE TL
2SC4915-O(TE85L.F)
UPD78F0484GK(S)
BA4116FV-E2
BR24L08FVT-W(TAPE)
VXSTD P/N
G2070918
G2071116
G2071116
G2070612
G2070642
G2070178
G2070078
G2070634
G2071222
G2070588
G2070588
G6090189
Q0000118
L9190141
L9190141
S5000226
S5000255
S5000255
L0022401
L0022401
L1690938
L0022395
L0022475
L0022401
L1690688
L0022401
L1690327
L1690523
L1690520
L1691288
L1691044
L1690688
L1691042
L1691041
L1691102
L1691103
L1690528
L1690526
L1691039
L1691039
L1690527
L1690525
L1690525
L1690846
L1690846
L1690524
M3290045
G1094097
G1094549
G1093592
G1094010
G1094009
G3070075
G3350068
G3350068
G3070392
G3070343
G3070343
G3070334
G3070391
G3346178R
G4802948
G3352268E
G3117748R
G3346178R
G3070075
G1093191
G4803188
G3070102
G3349158O
Ú
G1092616
G1094519
VERS.
HX280E
HX280S
LOT SIDE LAY ADR
1- B
c3
1- A
H3
1- A
H2
1- B
e3
1- B
d3
1- B
d2
1- B
d1
1- B
a3
1- A
A1
1- B
f2
1- B
f2
1- A
D2
1- A
A1
1- A
A1
1- A
A1
1- B
h3
1- A
B3
1- A
B3
1- B
h3
1- B
g3
1- B
c3
1- B
g3
1- B
f3
1- B
g3
1- B
c3
1- B
f3
1- A
C3
1- B
g2
1- B
f3
1- B
c3
1- B
g2
1- B
c3
1- B
e3
1- B
g2
1- B
g2
1- B
g2
1- B
g2
1- B
e3
1- B
g2
1- B
f2
1- B
d3
1- B
f2
1- B
e3
1- B
e2
1- B
d2
1- B
g2
1- A
C1
1- B
g1
1- B
g1
1- B
b3
1- A
B3
1- B
a1
1- B
h3
1- B
c3
1- B
c3
1- B
f3
1- B
f2
1- B
f1
1- B
a2
1- B
e3
1- B
c3
1- B
g2
1- B
e3
1- B
d3
1- B
d3
1- A
A3
1- B
d3
1- B
e2
1- B
d3
1- B
d2
1- A
D1
1- B
c1
1- B
e1
Ú: Please contact Vertex Standard
Parts List
REF
Q 1029
Q 1030
Q 1031
Q 1032
Q 1033
Q 1034
Q 1035
Q 1036
R 1001
R 1002
R 1003
R 1004
R 1005
R 1006
R 1007
R 1008
R 1009
R 1010
R 1011
R 1012
R 1013
R 1014
R 1015
R 1016
R 1017
R 1018
R 1019
R 1020
R 1021
R 1022
R 1023
R 1024
R 1025
R 1026
R 1027
R 1028
R 1029
R 1030
R 1031
R 1032
R 1033
R 1034
R 1035
R 1036
R 1037
R 1038
R 1039
R 1040
R 1041
R 1042
R 1043
R 1044
R 1045
R 1046
R 1047
R 1048
R 1049
R 1052
R 1053
R 1055
R 1056
R 1057
R 1058
R 1059
R 1060
R 1061
R 1062
R 1063
R 1064
R 1065
R 1066
R 1068
R 1069
DESCRIPTION
TRANSISTOR
TRANSISTOR
TRANSISTOR
IC
TRANSISTOR
IC
TRANSISTOR
TRANSISTOR
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
VALUE
47k
330k
470k
10k
82k
150k
22k
10k
220
2.2k
22k
220
680
22
330
100
4.7k
4.7k
10k
22
2.7k
22
220
56k
33k
180
68
180
15k
1k
180
68k
4.7k
47k
180
2.2k
22k
100
330
470
180
220k
330k
4.7k
100
4.7k
82k
470k
2.2k
330
47k
2.2k
150
100
47k
100
22
47k
6.8k
10k
39k
220
47k
47k
0
V/W
TOL.
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/4W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
5%
0.5%
0.5%
5%
0.5%
0.5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
MFR'S DESIG
DTC144EE TL
DTC144EE TL
2SA1774 TL R
TDA2822D013TR
FMMTL718TA
SN74LVC1G66DCKR
DTC143ZE TL
DTC144EE TL
RMC1/16S 473JTH
MCR01MZPD3303
MCR01MZPD4703
RMC1/16S 103JTH
MCR01MZPD8202
MCR01MZPD1503
RMC1/16S 223JTH
RMC1/16S 103JTH
RMC1/16S 221JTH
RMC1/16S 222JTH
RMC1/16S 223JTH
RMC1/16S 221JTH
RMC1/16S 681JTH
RMC1/16S 220JTH
RMC1/16S 331JTH
RMC1/16S 101JTH
RMC1/16S 472JTH
RMC1/16S 472JTH
RMC1/16S 103JTH
RMC1/16S 220JTH
RMC1/16S 272JTH
RMC1/16S 220JTH
RMC1/16S 221JTH
RMC1/16S 563JTH
RMC1/16S 333JTH
RMC1/16S 181JTH
RMC1/4 680JATP
RMC1/16S 181JTH
RMC1/16S 153JTH
RMC1/16S 102JTH
RMC1/16S 181JTH
RMC1/16S 683JTH
RMC1/16S 472JTH
RMC1/16S 473JTH
RMC1/16S 181JTH
RMC1/16S 222JTH
RMC1/16S 223JTH
RMC1/16S 101JTH
RMC1/16S 331JTH
RMC1/16S 471JTH
RMC1/16S 181JTH
RMC1/16S 224JTH
RMC1/16S 334JTH
RMC1/16S 472JTH
RMC1/16S 101JTH
RMC1/16S 472JTH
RMC1/16S 823JTH
RMC1/16S 474JTH
RMC1/16S 222JTH
RMC1/16S 331JTH
RMC1/16S 473JTH
RMC1/16S 222JTH
RMC1/16S 151JTH
RMC1/16S 101JTH
RMC1/16S 473JTH
RMC1/16S 101JTH
RMC1/16S 220JTH
RMC1/16S 473JTH
RMC1/16S 682JTH
RMC1/16S 103JTH
RMC1/16S 393JTH
RMC1/16S 221JTH
RMC1/16S 473JTH
RMC1/16S 473JTH
RMC1/16S JPTH
VXSTD P/N
G3070075
G3070075
G3117748R
G1091542
G3070335
G1094046
G3070102
G3070075
J24189045
J24189330
J24189332
J24189037
J24189385
J24189328
J24189041
J24189037
J24189017
J24189029
J24189041
J24189017
J24189023
J24189005
J24189019
J24189013
J24189033
J24189033
J24189037
J24189005
J24189030
J24189005
J24189017
J24189046
J24189043
J24189016
J24245680
J24189016
J24189039
J24189025
J24189016
J24189047
J24189033
J24189045
J24189016
J24189029
J24189041
J24189013
J24189019
J24189021
J24189016
J24189053
J24189055
J24189033
J24189013
J24189033
J24189048
J24189057
J24189029
J24189019
J24189045
J24189029
J24189015
J24189013
J24189045
J24189013
J24189005
J24189045
J24189035
J24189037
J24189044
J24189017
J24189045
J24189045
J24189070
VERS.
LOT SIDE LAY ADR
1- B
b2
1- B
h2
1- B
h2
1- B
h2
1- B
h2
1- B
h1
1- A
A2
1- A
C2
1- B
h3
1- B
f2
1- B
f1
1- B
h3
1- B
e2
1- B
e1
1- B
f1
1- B
g3
1- B
c3
1- A
C3
1- B
c3
1- B
c3
1- B
c3
1- A
D3
1- A
C3
1- B
f3
1- B
e3
1- B
c3
1- B
c3
1- A
D3
1- B
e3
1- A
E3
1- A
C3
1- B
c3
1- B
c3
1- B
b2
1- B
a3
1- B
b2
1- B
c3
1- B
a2
1- B
a2
1- B
a2
1- B
e3
1- A
A3
1- B
a2
1- B
e3
1- A
A3
1- B
e3
1- B
d3
1- B
d3
1- B
d3
1- B
g2
1- B
g2
1- B
c3
1- B
d3
1- B
d1
1- B
g2
1- B
g2
1- A
C3
1- B
e3
1- B
e2
1- B
g2
1- B
g2
1- B
e3
1- B
d2
1- B
g2
1- B
d3
1- A
C2
1- B
e3
1- B
e3
1- A
B4
1- B
e3
1- B
d3
1- B
d3
1- B
e3
21
MAIN Unit
Parts List
REF
R 1070
R 1071
R 1072
R 1074
R 1075
R 1076
R 1077
R 1078
R 1079
R 1080
R 1081
R 1082
R 1083
R 1084
R 1085
R 1086
R 1087
R 1088
R 1089
R 1090
R 1091
R 1092
R 1093
R 1094
R 1095
R 1097
R 1098
R 1099
R 1100
R 1101
R 1102
R 1103
R 1104
R 1105
R 1106
R 1107
R 1108
R 1109
R 1110
R 1111
R 1112
R 1113
R 1114
R 1116
R 1117
R 1118
R 1120
R 1120
R 1121
R 1122
R 1123
R 1124
R 1125
R 1126
R 1128
R 1129
R 1130
R 1131
R 1134
R 1135
R 1136
R 1138
R 1139
R 1140
R 1141
R 1142
R 1143
R 1144
R 1145
R 1146
R 1149
R 1150
R 1151
22
DESCRIPTION
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
VALUE
47k
47k
47k
22k
22
100
100k
100k
2.2k
100k
120k
47
220
10k
2.2k
1k
2.2k
820
22
47k
820
1.2k
47k
1.8k
2.2k
1k
470k
10k
39k
39k
220k
100k
47k
22k
10k
4.7k
8.2k
0
100
1k
1k
1k
150k
10k
10k
330k
120k
100k
2.2k
22
470k
10k
10k
10k
15k
470k
33k
33k
18k
10k
2.2k
330k
0
4.7k
4.7k
0
22
22
180k
470k
2.2k
18k
22k
V/W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
TOL.
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
0.5%
0.5%
0.5%
0.5%
0.5%
0.5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
MFR'S DESIG
RMC1/16S 473JTH
RMC1/16S 473JTH
RMC1/16S 473JTH
RMC1/16S 223JTH
RMC1/16S 220JTH
RMC1/16S 101JTH
RMC1/16S 104JTH
RMC1/16S 104JTH
RMC1/16S 222JTH
RMC1/16S 104JTH
RMC1/16S 124JTH
RMC1/16S 470JTH
RMC1/16S 221JTH
RMC1/16S 103JTH
RMC1/16S 222JTH
RMC1/16S 102JTH
RMC1/16S 222JTH
RMC1/16S 821JTH
RMC1/16S 220JTH
RMC1/16S 473JTH
RMC1/16S 821JTH
RMC1/16S 122JTH
RMC1/16S 473JTH
RMC1/16S 182JTH
RMC1/16S 222JTH
RMC1/16S 102JTH
RMC1/16S 474JTH
RMC1/16S 103JTH
RMC1/16S 393JTH
RMC1/16S 393JTH
MCR01MZPD2203
MCR01MZPD1003
MCR01MZPD4702
MCR01MZPD2202
MCR01MZPD1002
MCR01MZPD4701
RMC1/16S 822JTH
RMC1/16S JPTH
RMC1/16S 101JTH
RMC1/16S 102JTH
RMC1/16S 102JTH
RMC1/16S 102JTH
RMC1/16S 154JTH
RMC1/16S 103JTH
RMC1/16S 103JTH
RMC1/16S 334JTH
RMC1/16S 124JTH
RMC1/16S 104JTH
RMC1/16S 222JTH
RMC1/16S 220JTH
RMC1/16S 474JTH
RMC1/16S 103JTH
RMC1/16S 103JTH
RMC1/16S 103JTH
RMC1/16S 153JTH
RMC1/16S 474JTH
RMC1/16S 333JTH
RMC1/16S 333JTH
RMC1/16S 183JTH
RMC1/16S 103JTH
RMC1/16S 222JTH
RMC1/16S 334JTH
RMC1/16S JPTH
RMC1/16S 472JTH
RMC1/16S 472JTH
RMC1/16S JPTH
RMC1/16S 220JTH
RMC1/16S 220JTH
RMC1/16S 184JTH
RMC1/16S 474JTH
RMC1/16S 222JTH
RMC1/16S 183JTH
RMC1/16S 223JTH
VXSTD P/N
J24189045
J24189045
J24189045
J24189041
J24189005
J24189013
J24189049
J24189049
J24189029
J24189049
J24189050
J24189009
J24189017
J24189037
J24189029
J24189025
J24189029
J24189024
J24189005
J24189045
J24189024
J24189026
J24189045
J24189028
J24189029
J24189025
J24189057
J24189037
J24189044
J24189044
J24189389
J24189386
J24189382
J24189378
J24189374
J24189370
J24189036
J24189070
J24189013
J24189025
J24189025
J24189025
J24189051
J24189037
J24189037
J24189055
J24189050
J24189049
J24189029
J24189005
J24189057
J24189037
J24189037
J24189037
J24189039
J24189057
J24189043
J24189043
J24189040
J24189037
J24189029
J24189055
J24189070
J24189033
J24189033
J24189070
J24189005
J24189005
J24189052
J24189057
J24189029
J24189040
J24189041
VERS.
HX280E
HX280E
HX280S
LOT SIDE LAY ADR
1- B
d3
1- B
d3
1- A
A3
1- A
B3
1- A
B3
1- B
c2
1- B
e2
1- B
f2
1- B
e3
1- B
e2
1- B
f2
1- B
f2
1- B
e2
1- A
B3
1- B
e3
1- B
e2
1- B
e3
1- B
e2
1- B
d3
1- B
d3
1- B
d2
1- B
d2
1- B
d2
1- A
E1
1- B
d2
1- A
D2
1- B
b3
1- B
b1
1- B
b3
1- B
b3
1- A
E1
1- A
E1
1- A
E1
1- A
E2
1- A
E2
1- A
E2
1- B
b3
1- A
E2
1- B
b1
1- B
c2
1- B
b3
1- B
b3
1- B
c1
1- B
h1
1- B
h1
1- B
a3
1- B
c1
1- B
c1
1- B
c1
1- B
b2
1- B
b3
1- A
E1
1- A
E1
1- A
E1
1- B
b1
1- B
a3
1- B
a3
1- B
b1
1- B
b2
1- B
b2
1- B
a3
1- B
a3
1- B
e1
1- B
e1
1- B
e1
1- B
b1
1- B
b3
1- B
b1
1- B
b1
1- B
b3
1- B
a1
1- B
b3
1- B
a3
MAIN Unit
Parts List
REF
R 1152
R 1153
R 1154
R 1155
R 1157
R 1159
R 1161
R 1163
R 1164
R 1165
R 1166
R 1167
R 1168
R 1169
R 1170
R 1171
R 1172
R 1173
R 1174
R 1175
R 1176
R 1179
R 1180
R 1181
R 1182
R 1183
R 1184
R 1185
R 1186
R 1187
R 1188
R 1189
R 1194
R 1195
R 1196
R 1197
R 1197
R 1198
R 1198
R 1199
R 1200
R 1201
R 1202
R 1204
RB1001
S 1010
TC1001
TH1001
TH1002
VR1001
VR1002
VR1003
VR1004
VR1005
X 1001
X 1002
XF1001
XF1002
DESCRIPTION
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
BLOCK RES.
TACT SWITCH
TRIMMER CAP.
THERMISTOR
THERMISTOR
POT.
POT.
POT.
POT.
POT.
XTAL S-6
XTAL HC-49/SS-SMD
XTAL FILTER
XTAL FILTER
INTER CONNECTOR
LIGHT GUIDE
REFLECTOR SHEET
MIC HOLDER RUBBER
VALUE
5.6k
10k
8.2k
18k
1.5k
150k
10k
1k
4.7k
39k
10k
2.2k
4.7k
0
180k
2.2
1M
1k
2.2k
0
47k
4.7
0
1k
330k
2.2k
22
4.7
100k
10k
100k
100k
330
0
33k
15k
27k
4.7k
15k
330k
330k
330k
0
220k
10pF
100k
50k
100k
10k
21.25MHz
9.8304MHz
V/W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/4W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
TOL.
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
0.5%
0.5%
0.5%
0.5%
0.5%
5%
5%
5%
5%
5%
MFR'S DESIG
RMC1/16S 562JTH
RMC1/16S 103JTH
RMC1/16S 822JTH
RMC1/16S 183JTH
RMC1/16S 152JTH
RMC1/16S 154JTH
RMC1/16S 103JTH
RMC1/16S 102JTH
RMC1/16S 472JTH
RMC1/16S 393JTH
RMC1/16S 103JTH
RMC1/16S 222JTH
RMC1/16S 472JTH
RMC1/16S JPTH
RMC1/16S 184JTH
RMC1/4 2R2JATP
RMC1/16S 105JTH
RMC1/16S 102JTH
RMC1/16S 222JTH
RMC1/16S JPTH
RMC1/16S 473JTH
RMC1/16S 4R7JTH
RMC1/16S JPTH
RMC1/16S 102JTH
RMC1/16S 334JTH
RMC1/16S 222JTH
RMC1/16S 220JTH
RMC1/16S 4R7JTH
RMC1/16S 104JTH
RMC1/16S 103JTH
RMC1/16S 104JTH
RMC1/16S 104JTH
RMC1/16S 331JTH
RMC1/16S JPTH
MCR01MZPD3302
MCR01MZPD1502
MCR01MZPD2702
MCR01MZPD4701
MCR01MZPD1502
RMC1/16S 334JTH
RMC1/16S 334JTH
RMC1/16S 334JTH
RMC1/16S JPTH
RMC1/16S 224JTH
MNR04M0ABJ102
PT-036-B2S-T
ECR-KN010C61X
TH05 4B473FR
TH05 4B473FR
EVN-5ESX50B15
EVN-5ESX50B54
EVN-5ESX50B15
WH8011AK-1 A20K 15/5
EVN-5ESX50B14
21.250MHZ
9.8304MHZ
21.700MHZ
21.700MHZ
(LCD)
(LCD)
VXSTD P/N
J24189034
J24189037
J24189036
J24189040
J24189027
J24189051
J24189037
J24189025
J24189033
J24189044
J24189037
J24189029
J24189033
J24189070
J24189052
J24245229
J24189061
J24189025
J24189029
J24189070
J24189045
J24189066
J24189070
J24189025
J24189055
J24189029
J24189005
J24189066
J24189049
J24189037
J24189049
J24189049
J24189019
J24189070
J24189380
J24189376
J24189379
J24189370
J24189376
J24189055
J24189055
J24189055
J24189070
J24189053
J42900039
N5090158
K91000226
G9090150
G9090150
J51811104
J51811503
J51811104
J60800300
J51811103
H0103315
H0103382
H1102395
H1102395
RA1081000
RA1078900
RA1089600
RA1080000
VERS.
HX280E
HX280S
HX280E
HX280S
LOT SIDE LAY ADR
1- B
a3
1- B
b3
1- B
a1
1- B
b2
1- B
a1
1- B
b1
1- B
g2
1- B
h2
1- B
a2
1- B
a2
1- B
h2
1- B
f1
1- B
a2
1- B
b2
1- B
b2
1- B
h2
1- B
b2
1- B
h2
1- B
f1
1- B
h1
1- B
h1
1- B
h2
1- B
h1
1- B
h2
1- B
h1
1- B
f1
1- A
A1
1- B
h2
1- A
A2
1- A
C2
1- B
f2
1- B
f2
1- B
e3
1- A
D2
1- A
B2
1- A
B2
1- A
B2
1- A
B2
1- A
B2
1- B
h1
1- B
h1
1- B
h1
1- B
f1
1- B
b1
1- A
E2
1- A
C4
1- A
F2
1- B
f3
1- B
b2
1- A
F3
1- A
A3
1- A
A3
1- B
h1
1- A
F2
1- B
c2
1- B
d1
1- B
e2
1- B
d2
1111-
23
MAIN Unit
Note
24
CD-46 Charger Cradle
Exploded View
RA1088800
CASE (CHARGER)
CHARGER UNIT
Ú: When removing the Charger Unit from the Case,
gently pull on the charger unit while pushing the three
charging terminals from the outside of the case.

RA1092900 (x 2 pcs)
SHEET (HEAT10t2)

RA1088900
BOTTOM PLATE

Ref.


VXSTD P/N
Description
Qty.
U23108020 BIND HEAD TAPTITE-P 2X8SUS
4
Circuit Diagram
25
CD-46 Charger Cradle
Parts Layout
(Side A)
(Side B)
26
BAJ2CC0FP
(Q3002)
2SB1201S
(Q3007)
NJM12903R
(Q3001)
2SA1774 (FR)
(Q3006)
DTC124EU (25)
(Q3008)
DTC144EE (26)
(Q3003, 3004, 3005)
CD-46 Charger Cradle
Parts List
REF
C 3001
C 3002
C 3003
C 3004
C 3006
C 3007
D 3001
D 3003
D 3004
F 3001
J 3001
Q 3001
Q 3002
Q 3003
Q 3004
Q 3005
Q 3006
Q 3007
Q 3008
R 3001
R 3003
R 3004
R 3005
R 3006
R 3008
R 3009
R 3010
R 3011
R 3012
R 3013
R 3014
R 3015
Z 3001
DESCRIPTION
Printed Circuit Board
CHIP CAP.
CHIP CAP.
CHIP CAP.
AL.ELECTRO.CAP.
CHIP CAP.
CHIP CAP.
LED
DIODE
DIODE
CHIP FUSE
CONNECTOR
IC
IC
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
CHIP RES.
TERMINAL
VALUE
0.1uF
0.1uF
0.1uF
47uF
0.1uF
0.1uF
V/W
TOL.
25V
16V
16V
16V
16V
16V
B
B
B
B
B
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/4W
1/16W
1/4W
5%
1%
5%
1%
1%
5%
1%
1%
5%
1%
5%
5%
5%
2A
3.3k
3.9k
100k
39k
39k
2.2k
120k
120k
10k
10k
2.4
1k
1k
MFR'S DESIG
GRM21BB11E104KA01L
GRM188B11C104KA01D
GRM188B11C104KA01D
UVR1C470MDD
GRM188B11C104KA01D
GRM188B11C104KA01D
FDL-322HRG-ZW1-CA
UDZS TE-17 6.8B
1SS355 TE-17
FCC16 202ADTP
LGP6501-0100C
NJM12903R-TE1
BAJ2CC0FP
DTC144EE TL
DTC144EE TL
DTC144EE TL
2SA1774 TL R
2SB1201S-TL
DTC124EU T106
RMC1/16 332JATP
RMC1/16 392FTP
RMC1/16 104JATP
RMC1/16 393FTP
RMC1/16 393FTP
RMC1/16 222JATP
RMC1/16 124FTP
RMC1/16 124FTP
RMC1/16 103JATP
RMC1/16 103FTP
RMC1/4 2R4JTE
RMC1/16 102JATP
RMC1/4 102JATP
(CHRG)
VXSTD P/N
FR019300D
K22140811
K22124805
K22124805
K40129107
K22124805
K22124805
G2090810
G2070888
G2070470
Q0000147
P0091422
G1093336
G1094174
G3070075
G3070075
G3070075
G3117748R
G3070195
G3070045
J24185332
J24183392
J24185104
J24183393
J24183393
J24185222
J24183124
J24183124
J24185103
J24183103
J24245249
J24185102
J24245102
RA0769800
VERS.
LOT SIDE LAY ADR
1111111111111111111111111111111111-
27
Note
28
HX280S/E Main Unit
Circuit Diagram
1 2 3 4
5 6 7 8
HX280S/E Main Unit
Circuit Diagram
1 2 3 4
5 6 7 8
HX280S/E Main Unit
Circuit Diagram
1 2 3 4
5 6 7 8
HX280S/E Main Unit
Circuit Diagram
1 2 3 4
5 6 7 8
HX280S/E Main Unit
Circuit Diagram
1 2 3 4
5 6 7 8
HX280S/E Main Unit
Circuit Diagram
1 2 3 4
5 6 7 8
HX280S/E Main Unit
Circuit Diagram
1 2 3 4
5 6 7 8
HX280S/E Main Unit
Circuit Diagram
1 2 3 4
5 6 7 8
HX280S/E Main Unit (Side “A”)
Parts Layout
1
2
HX280S/E Main Unit (Side “A”)
Parts Layout
1
2
HX280S/E Main Unit (Side “B”)
Parts Layout
1
2
HX280S/E Main Unit (Side “B”)
Parts Layout
1
2
Note
29
© 2009 VERTEX STANDARD CO., LTD.
Marine Division of VERTEX STANDARD
US Headquarters
10900 Walker Street, Cypress, CA 90630, U.S.A.
30
All rights reserved.
No portion of this manual
may be reproduced
without the permission of
VERTEX STANDARD CO., LTD.