productguide - Empire Heating Systems

P RO D U C T G U I D E
S U R R O U N D YO U R S E L F W I T H C O M F O RT
w w w . e m p i r e z o n e h e a t . c o m
Residential Heating Selection Guide
This guide is intended to present an overview of the broad range
of zone heating products we offer. For information about a
particular product, talk to your dealer or download the spec sheet
at www.empirezoneheat.com.
Empire Heating Systems Residential Zone Heaters allow you to turn down the central furnace
and heat just the rooms you use most. These systems also save your energy dollars by not
suffering the heat-loss common in a long vent run from the central furnace. The heat that’s
produced in the room gets projected into the room.
Empire offers a variety of gas-fired heaters, employing four different technologies –
Vent-Free, Power Vent, Direct-Vent, and B-Vent. Nearly all are available in LP and natural gas models.
Scan this code to visit
www.empirezoneheat.com
Unlike a conventional furnace, most Empire heaters provide heat even when electric
power fails.
The system you choose will depend on the amount of heat required, the efficiency you desire,
the location of the heater, and local codes.
VENT-FREE SYSTEMS
Vent-Free systems draw room air to support combustion in a clean burning blue-flame or radiant-plaque
system. Rated at 99.9 percent efficient, vent-free heaters release nearly all of the available heat energy into
the room.
To ensure safe operation, all vent-free systems include an Oxygen Depletion Sensor (ODS) to automatically
turn off the heater if room oxygen level drops to an unsafe level.
Vent-free systems are designed to provide supplemental heat and may not be used as a primary heat source.
Check local codes for installation requirements and ask your dealer to recommend a trained installation
technician.
HEARTHRITE BLUE FLAME & RADIANT heaters
HearthRite blue flame models are available in 6,000; 10,000; 20,000; and 30,000 Btu – manual
and thermostat. HearthRite radiant models are available in 6,000; 10,000; 15,000; and 25,000
Btu LP and in 6,000; 10,000; 18,000; and 30,000 Btu Natural Gas manual and thermostat.
HB30TN
HB20TN
HR30TN
HB10TN
• All Models Heat without Electricity
• Hear thRite Models Include 3-year Limited Warranty on Par ts and Labor
• Hear thRite Models Made in China
2
E m p i r e H e ati n g S y s t e m s • w w w .em p ir ez oneheat.com
HR18TN
HR10TN
Ve n t - F r e e S y s t e m s
EMPIRE
BLUE FLAME heaters
Think warm tropical breeze! Our
blue flame heaters warm the
air, which rises to create natural
circulation in the room. Ideal for
any supplemental heat application.
Made in the U.S.A.
BF Blue-Flame Heaters
BF-10 (10,000 Btu)
BF-20 (20,000 Btu)
BF-30 (30,000 Btu)
BF-30
EMPIRE
RADIANT heaters
Think cat on a windowsill! Our
radiant heaters project warmth
into the room like sunlight through
a window. Ideal for warming any
cold spot in a room. Made in the
U.S.A.
SR Radiant Heaters
(Manual and Thermostat Models)
SR-6 (6,000 Btu)
SR-10 and SR-10T (10,000 Btu)
SR-18 and SR-18T (18,000 Btu)
SR-30 and SR-30T (30,000 Btu)
SR-18T
•
•
•
•
•
•
Total Comfor t for Half the Cost of Electric Heat
Radiant or Blue Flame Design
99.9 Percent Efficient
Safe Operation with Auto Shut-off Safety Controls
Manual or Hydraulic Thermostatic Controls
Matchless Piezo Igniter LP or Natural Gas Models
•
•
•
•
Mounts on Floor or Wall
All Models Heat without Electricity
Optional Manual and Automatic Blowers
Empire BF and SR Models Include 5-year
Limited Warranty on Par ts and Labor
• Empire Models Made In USA
www. empi rezonehea t . c om • Empi re Heatin g Sy s te ms
3
P o w e r- Ve n t S y s t e m s
POWER-VENT SYSTEMS
This unique power-vent system uses an electric motor to deliver a precise change of air to support combustion
and force the exhaust to the outdoors. Power venting delivers maximum efficiency – 92 percent AFUE – which
reduces exhaust temperatures to 120-degrees or less and allows the US90 to vent with PVC or poly-vent pipe
up to 50 feet. Power-vent systems will not operate without electricity.
HIGH-EFFICIENCY
POWER-VENT wall furnace
Advanced technology makes the US90Plus wall furnace
92 percent efficient A.F.U.E. The clean, modern furnace
vents with low-cost PVC or poly pipe, is easy-to-operate,
and is ideal for zone heating. Easy to operate with builtin thermostat. Also works with most programmable
thermostats. Made in U.S.A.
PVS18 (17,500 Btu)
PVS35 (35,000 Btu)
PVS35
4
E m p i r e H e ati n g S y s t e m s • w w w .em p ir ez oneheat.com
D i r e c t - Ve n t S y s t e m s
DIRECT-VENT SYSTEMS
DV systems mount on an outside wall and have a vent-within-a-vent system to draw in outdoor air to support
combustion and exhaust flue products to the outdoors. The vent cap installs on the outside wall of the home.
Because they do not draw your already-heated room air to support combustion, DV systems are among the
most efficient of the vented heaters.
DV systems may be installed as the primary heating system.
DIRECT-VENT wall furnaces
Clean and cost-efficient comfort makes the DV-210/215
wall furnaces ideal for smaller rooms, such as bedrooms
or studies. The compact beige cabinet tucks out of
the way on any outside wall. Optional thermostat for
automatic temperature control included.
DV-210 (10,000 Btu)
DV-215 (15,000 Btu)
DV-210
Heat larger areas economically with
Empire’s DV-25/35 wall furnaces.
Delivering ample, room-filling warmth,
each furnace is stylishly crafted and
fits against an outside wall. Optional
thermostat for automatic temperature
control included.
DV-25 (25,000 Btu)
DV-35 (35,000 Btu)
DV-35
HIGH-EFFICIENCY
DIRECT-VENT wall furnaces
Advanced technology makes these heaters more
than 80 percent efficient A.F.U.E. The 20,000 Btu
DV-20E is ideal for heating basements, family
rooms or several small rooms. The DV-40E
and DV-55E are perfect for heating large family
rooms, offices, apartments or even entire homes.
DV-20E (20,000 Btu)
DV-40E (40,000 Btu)
DV-55E (55,000 Btu)
DV-40E
www. empi rezonehea t . c om • Empi re Heatin g Sy s te ms
5
D i r e c t - Ve n t a n d B - Ve n t W a l l F u r n a c e s
DIRECT-VENT
COUNTERFLOW
wall furnaces
Our counterflow wall furnaces heat large
areas and use minimum floor space.
Warm air exits at floor level for more
even distribution.
Choose standing pilot or electronic ignition.
DVC-35 may be recessed between
standard wall studs. Larger models surface
mount. Optional thermostat for automatic
temperature control included. Other
accessories available.
B-VENT GRAVITY
wall furnaces
B-VENT COUNTERFLOW
wall furnaces
Our economical Gravity Vented Furnaces
utilize state-of-the-art technology for
the highest fuel efficiency. This furnace
recesses into a wall or surface mounts
with the optional kit. Heat two adjoining
rooms with the GWT-50.
Counterflow wall furnaces circulate
warmth at floor level to provide comfort
at a fraction of the cost of electric heat.
The front panels remove easily for
cleaning and servicing.
GWT-25 (25,000 Btu)
GWT-35 (35,000 Btu)
GWT-50 (50,000 Btu Total;
25,000 Btu/Room)
DVC-35 (35,000 Btu)
GWT-25
DV-55 (55,000 Btu)
DVC-35
6
E m p i r e H e ati n g S y s t e m s • w w w .em p ir ez oneheat.com
Choose standing pilot or electronic
ignition.
Optional thermostat for
automatic temperature control included.
Other accessories available.
FAW-40 (40,000 Btu)
FAW-55 (55,000 Btu)
FAW-55
B - Ve n t S y s t e m s
B-VENT SYSTEMS
B-Vent systems use room air to support combustion and exhaust their flue products to the outdoors via a
single pipe. B-Vent heaters can mount anywhere you have access to an existing flue or where you can install
a vent run through the roof.
The ability to attach to an existing flue makes a B-Vent system an excellent replacement for an inefficient oil
or wood stove.
Though less efficient than other technologies – because they draw the already-heated room air to support
combustion – B-Vent systems may be installed as the primary heating system.
CONSOLE room heaters
Our console heaters feature an
open design to maximize heat
dispersion and a draft diverter
to eliminate pilot outages. The
RH-25 and RH-35 feature a more
compact cabinet – perfect for
smaller spaces – yet still allow use
of the optional blower.
Room Heaters install easily with
standard B-vent pipe.
RH-25 (25,000 Btu)
RH-35 (35,000 Btu)
RH-35
large CONSOLE room heaters
Choose an RH-50 or RH-65 in closed cabinet for heat
only or in visual-flame cabinet (with optional log set
or ceramic radiant package) for more of a fireplace
experience. Add the optional automatic blower to
enhance air circulation (included on RH50B/65B).
RH-50B, RH-50C (50,000 Btu)
RH-65B, RH-65C (65,000 Btu)
RH-50B
FLOOR furnaces
America’s most popular floor furnace provides whole-house comfort for
a fraction of the cost of electric heat and requires no electricity to operate.
Optional thermostat for automatic temperature control included.
3588 (32,500 Btu)
5088 (45,000 Btu)
7088 (65,000 Btu)
5088
www. empi rezonehea t . c om • Empi re Heatin g Sy s te ms
7
Works Without
Electricity
AFUE
Efficiency %
Use as Primary
Heat Source
Btu Input
Vent-Free Blue Flame Heaters
6,000 to 30,000
99.9
•
Vent-Free Radiant Heaters
6,000 to 30,000
99.9
•
Power-Vent High-Efficiency Wall Furnace
17,500 to 35,000
92
•
Direct-Vent DV Wall Furnaces
10,000 to 35,000
65-66
•
Direct-Vent High-Efficiency Wall Furnaces
20,000 to 55,000
80+
•
Direct-Vent Counterflow Wall Furnaces
35,000 to 55,000
75-76
•
B-Vent Console Room Heaters
25,000 to 65,000
66-68
•
•
B-Vent Floor Furnace
32,500 to 65,000
57-58
•
•
B-Vent Gravity Wall Furnaces
25,000 to 50,000
65-70
•
•
B-Vent Counterflow Wall Furnaces
40,000 to 55,000
75-76
•
Heater Type
•
Visit www.empirecomfort.com for information on our other products.
Gas Fireplaces
Empire Comfort Systems
918 Freeburg Ave.
Belleville, IL 62220-2623
E-mail: info@empirecomfort.com
Premium Grills
CERTIFIED
©Empire Comfort Systems, Inc. EHS-00778 10/15/14
w w w . e m p i r e z o n e h e a t . c o m