Lanier Worldwide, Inc.
2300 Parklake Drive, NE
Atlanta, GA USA 30345-2979
MATERIAL SAFETY DATA SHEET
Emergency Telephone: 800-526-4371
Section 1: Chemical Product and Company Information
Identity:
Product ID:
Toner Cartridge T1165
491-0321
Synonyms
& Common
Names:
Toner Cartridge for
Lanier LF115 Fax
T1165
Uses:
Lanier LF115 Fax
Chemical
Formula:
Mixture
MSDS No.
Issued:
Supersedes:
Date:
Prepared by:
Approved by:
European
Contact:
FX-080
07/07/2005
05/26/2003
07/07/2005
EH&S Department 770-496-9500
Larry Choskey, Manager, CEH&S
Walter Fricke, Manager, Safety &
Environment,
Lanier Worldwide, Inc.
Im Taubental D-41468 Neuss,
Germany +49-2131-387-177
Section 2: Composition / Information on Ingredients
PERCENT
Polyester resin
Carbon Black
80-95
6-7
Organic pigment
CAS No.
Confidential
1333-86-4
<5
Confidential
EXPOSURE LIMITS
SOURCE
Not listed
3
3.5 mg/m
3
3.5mg/m
Not listed
N/a
N/a
N/a
*PEL as the product: 15mg/m3 (total dust), 5mg/m3 (respirable dust)
*TLV as the product: 10mg/m3 (total dust), 5mg/m3 (respirable dust)
Section 3: Hazards Identification
HMIS Rating:
FLAMMABILITY = 1
REACTIVITY = 0
HEALTH = 1
SPECIAL = none
Health Hazards (Acute, Chronic, Immediate and Potential): Minimum irritation to respiratory tract may occur as with exposure
to any non-toxic dust. May cause gasping if inhaled. Inhalation should be avoided. May cause temporary eye discomfort.
Health Hazards of Long Term exposure (Chronic): Prolonged inhalation of excessive dust may cause lung damage. It is
attributed to “lung overloading”, a generic response to excessive amounts of any dust retained in the lungs for a prolonged interval.
Use of this product, as intended, does not result in inhalation of excessive dust.
Carcinogenicity: Carbon Black was reclassified as a Group 2B by the IARC in 1996 based upon the result of only the inhalation
study in rats. However, there was not observed the incidence of tumors on the test results on dermal or oral studies. Also, 2-years
inhalation study using a typical toner containing carbon black showed no association between toner exposure and animal tumors.
Section 4: First Aid Measures
Inhalation:
Remove to fresh air. Gargle with water. Get medical
attention if needed.
Eye Contact:
Skin Contact:
Wash with soap and water.
Ingestion:
In case of contact, immediately flush eyes with
water for 5 minutes. Get medical attention if
needed.
Dilute stomach contents with several
glasses of water. Get medical attention.
Section 5: Fire Fighting Measures
Suitable extinguishing media: CO2, dry chemical, foam or water.
Special protective equipment for fire fighters: none
UEL: n/a
LEL: n/a
your document management partner
Extinguishing media which may not be used for safety
reasons: none
MATERIAL SAFETY DATA SHEET
Page 2 of
3 FX-080
Section 6: Accidental Release Measures
Spill / leak Procedures: If spilled, sweep up using an approved toner vacuum with a 0.5 micron filter or smaller, such as the Atrix
AAA Toner Vacuum or 3M Toner Vacuum. Use of a vacuum cleaner not rated for toner particles, could result in a fire or personal
injury. Remove residue with soap and cold water.
Miscellaneous: Keep product out of sewers and watercourses.
Personal protection: Avoid inhalation of dust.
Section 7: Handling and Storage
Special Handling:
Special Storage:
Cleanse skin after contact before breaks or meals, and end of workday.
Do not handle in areas where the wind blows.
Minimize the breathing of dust.
Avoid direct sunlight. Keep out of reach of children. Store in a cool, dry place. Below 35C (95F)
Section 8: Exposure Control and Personal Protection Information:
Respiratory Protection: none required under normal use.
Hand Protection: none required under normal use.
Eye Protection: none required under normal use.
Skin Protection: none required under normal use.
Section 9: Physical and Chemical Properties
CHARACTERISTICS:
Appearance:
Form:
Odor:
Solubility in Water:
Specific gravity:
Density:
Black
Powder
Slight plastic odor
Insoluble
N/a
1.2 g/cm3
Melting point:
Vapor pressure:
Vapor density:
Evaporation rate:
Boiling point:
Other Solvent Solubility
N/a
N/a
N/a
N/a
N/a
Slightly soluble in toluene,
chloroform, tetrahydrofran
Section 10: Stability and Reactivity
Conditions to avoid: none
Materials to avoid: none
Hazardous decomposition products: will not occur
Stability: Stable
Section 11: Toxicological Information:
Ames test negative
Acute dermal toxicity: Not available
Acute oral toxicity: >2000mg/kg (rat)
Acute inhalation toxicity: not available
Acute Allergenic effects: non-skin sensitive
Special effects: Carcinogenicity: In 1996 the IARC reclassified Carbon Black as a Group 2B carcinogen (possible human
carcinogen). This evaluation is given to carbon black for which there is inadequate human evidence, but sufficient animal
evidence. The latter is based upon the development of lung tumors in rats receiving chronic inhalation exposures to free carbon
black at levels that induce particle overload of the lung. Studies performed in animal models other than rats have not
demonstrated an association between carbon black and lung tumors. Moreover, 2-years cancer bioassay using a typical toner
preparation containing carbon black did not demonstrate an association between toner exposure and tumor development in rats.
Section 12: Environmental / Ecological Information
Acute toxicity to fish: not available Bioaccumulation: Not known in bioaccumulation
Persistence/Degradability: Not known
Acute toxicity to daphnia: Not available
Algae inhibition test: Not available
Section 13: Disposal Consideration
Used Toner should be disposed of under conditions that meet all federal, state and local environmental regulations. Disposal
regulations vary from locality to locality; therefore consult your local Lanier office or the EPA to determine the proper method for
disposal. Do not incinerate loose or spilled Toner.
Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under
normal conditions. On the basis of the data available to us, this product is not a dangerous substance. One should, however, observe the
usual precautionary measures for dealing with chemicals.
MATERIAL SAFETY DATA SHEET
Page 3 of
3 FX-080
Section 14: Transportation Information
International regulations:
RID/ADR
Not applicable
DOT 49 CFR
Not applicable
ADNR
Not applicable
ICAO-TI/ATA-DGR
UN Classification Number
IMDG Code
Not applicable
Not applicable
Not applicable
Specific precautionary transport measures: Avoid direct sunlight. Do not keep over 35°C (95°F).
Specific material to avoid:
None in normal use.
Section 15: Regulatory Information
Regulation:
Not known
Section 16: Miscellaneous Information
Judgment as to the suitability of information contained herein for user’s purposes is the responsibility of the purchaser.
Therefore, although reasonable care has been taken in the preparation of this information, Lanier Worldwide, Inc. extends no
warranties, makes no representations, and assumes no responsibility as to the accuracy or suitability of such information for
application to user’s intended purposes or for consequences of its use. All materials may present unknown hazards and
should be used with caution. Although certain hazards are described herein, we do not guarantee that these are the only
hazards that exist.
Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under
normal conditions. On the basis of the data available to us, this product is not a dangerous substance. One should, however, observe the
usual precautionary measures for dealing with chemicals.