- Computers & electronics
- Print & Scan
- Printing supplies
- Toners & Laser Cartridges
- Lanier
- 4800053
- Data Sheet
advertisement
Identity:
Product ID:
Synonyms
& Common
Names:
Uses:
Chemical
Formula:
MATERIAL SAFETY DATA SHEET
Lanier Worldwide, Inc.
2300 Parklake Dr., N. E.
Atlanta, GA 30345-2979
Emergency Telephone: (800) 551-3087
Section 1: Chemical Product and Company Information
5635 / 5645 Toner
480-0053
Toner for Lanier 5635, 5645, 2145,
2045, 5235, 5245, 5435, 5445,LP145n
Lanier 5635, 5645, 2145, 2045, 5235,
5245, 5435, 5445,LP145n
Mixture
MSDS No. CP- 342
Issued: 11/08/2006
Date:
Prepared by:
Approved by:
11/08/2006
EH&S Department 770-496-9500
Larry Choskey, Health & Safety Manager
Polyester resin
Section 2: Composition / Information on Ingredients
PERCENT
< 60
Polyester resin
Polyester resin
< 60
< 30
Carbon black < 15
Carnauba wax
*PEL as the product: 15mg/m
3
*TLV as the product: 10mg/m
3
< 10
(total dust), 5mg/m
3
(respirable dust)
(total dust), 5mg/m
3
(respirable dust)
CAS No.
117581-13-2
116736-81-3
149367-99-7
1333-86-4
8015-86-9
EXPOSURE LIMITS
Not listed
Not listed
Not listed
3.5mg/m
3
3.5mg/m
3
Not listed
SOURCE
N/a
N/a
N/a
OSHA PEL ACGIH TWA
N/a
Section 3: Hazards Identification
HMIS Rating:
FLAMMABILITY = 1 HEALTH = 1
REACTIVITY = 0 SPECIAL = none
Health Hazards (Acute, Chronic, Immediate and Potential): Minimum irritation to respiratory tract may occur as with exposure to any non-toxic dust. May cause gasping if inhaled. Inhalation should be avoided. May cause temporary eye discomfort.
Health Hazards of Long Term exposure (Chronic): A manufacturer sponsored chronic inhalation study in rats using a special test toner revealed there were no lung changes at all in the lowest exposure level (1mg/m degree of fibrosis was noted in 25% of the animals at the middle exposure level (4mg/m highest exposure level (16mg/m
3
3
), the most relevant level to potential human exposures. A very slight
3
), while a slight degree of fibrosis was observed at the
) in all animals. These findings are attributed to “Lung Overloading”, a generic response to excessive amount of any dust retained in the lungs for a prolonged interval. The special test toner was ten times more respirable than commercially available toner to comply with EPA testing protocol and would not function properly in Xerographic equipment.
Carbon Black is listed on the IARC Monograph and the Massachusetts Substance List. The IARC has evaluated the evidence for the carcinogenicity of Carbon Black as inadequate to determine a carcinogenic risk for humans.
This product contains no known hazardous materials as defined by the OSHA Hazard Communication Standard 29 CFR 1910.1200.
Inhalation:
Skin Contact: Wash with soap and water.
Section 4: First Aid Measures
Remove to fresh air if effects occur. Get medical attention if needed. Eye Contact:
In case of contact, immediately flush eyes with water for 15 minutes. Get medical attention if needed.
Ingestion: Dilute stomach contents with several glasses of water. Get medical attention.
Section 5: Fire Fighting Measures
Suitable extinguishing media: CO
2
, dry chemical, foam or water.
Extinguishing media which may not be used for safety reasons: none
This material will burn in case of fire. The decomposition products are CO, CO
2
, and No x
. Avoid inhalation of smoke.
Special protective equipment for fire fighters: none
UEL: n/a LEL: n/a
MATERIAL SAFETY DATA SHEET
Page 2 of 2 CP-342
Section 6: Accidental Release Measures
Spill / leak Procedures: If spilled, sweep up using an approved toner vacuum with a 0.5 micron filter or smaller, such as the Atrix AAA Toner
Vacuum or 3M Toner Vacuum. Use of a vacuum cleaner not rated for toner particles, could result in a fire or personal injury. Remove residue with soap and cold water.
Miscellaneous: Keep product out of sewers and watercourses.
Personal protection: Avoid inhalation of dust.
Special Handling:
Special Storage:
Section 7: Handling and Storage
Cleanse skin after contact before breaks or meals, and end of workday.
Avoid direct sunlight. Keep out of reach of children. Store in a cool, dry place. Below 35C (95F)
Section 8: Exposure Control and Personal Protection Information:
Respiratory Protection: none required under normal use. Hand Protection: none required under normal use.
Eye Protection: none required under normal use. Skin Protection: none required under normal use.
Section 9: Physical and Chemical Properties
CHARACTERISTICS:
Appearance: Black
Form: Powder
Odor:
Solubility in Water:
Specific gravity:
Bulk Density:
Slight plastic odor
Insoluble
N/a
1.2 g/cm
3
Melting point:
Vapor density:
Evaporation rate:
Boiling point:
Section 10: Stability and Reactivity
Conditions to avoid: none Materials to avoid: none Stability: Stable
Hazardous decomposition products: CO and CO2 and other decomposition products when burned.
Section 11: Toxicological Information:
Ames test negative
Acute oral toxicity: >5000mg/kg (rat)
Acute toxicity to fish: >500 mg/kg/96hr.
Section 12: Environmental / Ecological Information
110 C n/a n/a n/a n/a
Section 13: Disposal Consideration
Used Toner should be disposed of under conditions that meet all federal, state and local environmental regulations. Disposal regulations vary from locality to locality, therefore consult your local Lanier office or the EPA to determine the proper method for disposal. Do not incinerate loose or spilled Toner.
Section 14: Transportation Information
None. This is not a hazardous product.
WHMIS Legislation (Canada):
Section 15: Regulatory Information
This is not a controlled product
Section 16: Miscellaneous Information
Judgment as to the suitability of information contained herein for user’s purposes is the responsibility of the purchaser. Therefore, although reasonable care has been taken in the preparation of this information, Lanier Worldwide, Inc. extends no warranties, makes no representations, and assumes no responsibility as to the accuracy or suitability of such information for application to user’s intended purposes or for consequences of its use. All materials may present unknown hazards and should be used with caution. Although certain hazards are described herein, we do not guarantee that these are the only hazards that exist.
Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions.
On the basis of the data available to us, this product is not a dangerous substance. One should, however, observe the usual precautionary measures for dealing with chemicals.
advertisement
* Your assessment is very important for improving the workof artificial intelligence, which forms the content of this project