Installing and Using the HAND

Installing and Using the HAND-HELD BARCODE
SCANNER
VITROS® 5600 Integrated System
VITROS® 3600 Immunodiagnostic System
VITROS® 5,1 FS Chemistry System
VITROS® 4600 Chemistry System
Pub. No.: J55820EN
Issued: 2013-12-05
Purpose:
Install and use the HAND-HELD BARCODE SCANNER to manually scan sample barcodes and
configured quality control barcodes when there is no Lab Information System (LIS) or to scan
®
®
VITROS MicroTip reagent pack barcodes and VITROS MicroWell reagent pack barcodes
during a manual load.
IMPORTANT:
THE BARCODE SCANNER CANNOT BE USED TO SCAN BARCODES ON SLIDE
CARTRIDGES.
Materials
required:



IMPORTANT:
WAIT UNTIL ASSAY PROCESSING COMPLETES BEFORE YOU PERFORM THIS
PROCEDURE.
BARCODE SCANNER with CABLES
BARCODE SCANNER STAND
BARCODE CONFIGURATION SHEET
1. Shut down the system.
2. Move the KEYBOARD aside, and then feed the 2 SCANNER CABLES up through the hole in the bottom of
the TRAY ARM.
3. Disconnect the KEYBOARD CABLE, and then connect each end
of the KEYBOARD CABLE to the
corresponding SCANNER CABLE.
4. Set the KEYBOARD back in place.
5. Restart the system.
6. From the Main Menu, touch Options & Configurations  Configure System  PSID.
7. When the system displays the “Configure PSID Checkdigit” dialog box, note which option or combination of
options (“Code 39”, ”Codabar”, and/or “IL 2 of 5”) are enabled for Checkdigit.
8. Scan the barcode(s) on the CONFIGURATION SHEET that correspond to selected Check Digit options on
your system. The CONFIGURATION SHEET has been included with the BARCODE SCANNER packaging
and is also presented below. Each pair of barcodes on the sheet is assigned a number and system dialog
screenshot as shown below:
2
Installing and Using the HAND-HELD BARCODE SCANNER
®
®
VITROS 5600 Integrated System, VITROS 3600 Immunodiagnostic System,
®
®
VITROS 5,1 FS Chemistry System, VITROS 4600 Chemistry System
Pub No.: J55820EN
Issued: 2013-12-05
Checkdigit not enabled
Checkdigit enabled
The numbers on the CONFIGURATION SHEET correspond to the numbers and descriptions in the following
table:
Note:
Code 39 without checkdigit (Scan
both barcodes)
Code 39 with checkdigit (Scan both
barcodes)
Codabar without checkdigit (Scan
both barcodes)
Codabar with checkdigit (Scan both
barcodes)
Interleaved 2 of 5 without checkdigit
(Scan both barcodes)
Interleaved 2 of 5 with checkdigit (Scan both
barcodes)
Scan from top to bottom if using more than one pair of barcodes.
Pub No.: J55820EN
Issued: 2013-12-05
Installing and Using the HAND-HELD BARCODE SCANNER
®
®
VITROS 5600 Integrated System, VITROS 3600 Immunodiagnostic System,
®
®
VITROS 5,1 FS Chemistry System, VITROS 4600 Chemistry System
3
Here are two examples that show how to use the “Configure PSID Checkdigit” dialog box and the table of
numbers and descriptions to determine which barcodes may be scanned:
Example 1 — The “Code 39” checkbox is checked, but the “Codabar” and "IL 2 of 5” checkboxes are not
checked.
In this situation, you can scan the following barcodes:
4
Installing and Using the HAND-HELD BARCODE SCANNER
®
®
VITROS 5600 Integrated System, VITROS 3600 Immunodiagnostic System,
®
®
VITROS 5,1 FS Chemistry System, VITROS 4600 Chemistry System
Pub No.: J55820EN
Issued: 2013-12-05
Example 2 — No checkboxes are checked.
In this situation, you can scan the following barcodes:
Pub No.: J55820EN
Issued: 2013-12-05
Installing and Using the HAND-HELD BARCODE SCANNER
®
®
VITROS 5600 Integrated System, VITROS 3600 Immunodiagnostic System,
®
®
VITROS 5,1 FS Chemistry System, VITROS 4600 Chemistry System
5
9. Place the SCANNER STAND where the SCANNER CABLE will not interfere with DOORS, COVERS, or
normal system operation.
Ortho Clinical Diagnostics
100 Indigo Creek Drive
Rochester, NY 14626
Pub. No.: J55820EN
All trademarks are registered to
Ortho-Clinical Diagnostics, Inc.
© Ortho-Clinical Diagnostics, Inc. 2013
6
Installing and Using the HAND-HELD BARCODE SCANNER
®
®
VITROS 5600 Integrated System, VITROS 3600 Immunodiagnostic System,
®
®
VITROS 5,1 FS Chemistry System, VITROS 4600 Chemistry System
Pub No.: J55820EN
Issued: 2013-12-05