Alamo MACHETE2 02986941P Operators Manual

Pub 12-08

PART'S MANUAL

Boom Arm Mower

Part No. 02986941 P

An Operator's Manual was shipped with the equipment in the Manual

Canister. This Operator's Manual is an integral part of the safe operation of this machine and must be maintained with the unit at all times. READ,

UNDERSTAND, and FOLLOW the Safety and Operation Instructions contained in this manual before operating the equipment. If the Operator's

Manual is not with the equipment, contact your dealer or Servis-Rhino (800-

446-5158) to obtain a Free copy before operating the equipment.

ALAMO INDUSTRIAL

1502 E. Walnut

Seguin, Texas 78155

210-372-3551

© 2008 Alamo Group Inc.

®

®

TO THE OWNER/OPERATOR/DEALER

1.

All implements with moving parts are potentially hazardous. There is no substitute for a cautious, safe-minded operator who recognizes the potential hazards and follows reasonable safety practices. The manufacturer has designed this implement to be used with all its safety equipment properly attached to minimize the chance of accidents.

BEFORE YOU START!!

Read the safety messages on the implement and shown in your manual.

Observe the rules of safety and common sense!

DANGER

OPERATORS.

READ

MANU

AL

RED

Install * Restrictor in folding circuit to slow down lowering and unfolding if action is faster than is desirable.

REFLECTORS.

*

RED

002369

WARRANTY INFORMATION:

Read and understand the complete Warranty Statement found in this Manual. Fill out the Warranty Registration Form in full and return it within 30 Days. Make certain the Serial Number of the Machine is recorded on the Warranty Card and on the Warranty Form that you retain. The use of "will-fit" parts will void your warranty and can cause catastrophic failure with possible injury or death.

Parts Section – 1

PARTS

SECTION

PARTS ORDERING GUIDE

The following instructions are offered to help eliminate needless delay and error in processing purchase orders for the equipment in this section.

1. The Parts Section is prepared in logical sequence and grouping of parts that belong to the basic machine featured in this manual. Part Numbers and Descriptions are given to help locate the parts and quantities required.

2. The Purchase Order must include the name and address of the person or organization ordering the parts, who should be charged, and if possible, the serial number of the machine for which the parts are ordered.

3. The Purchase Order must clearly list the quantity of each part, the complete and correct part number (be sure to include all periods), and the basic name of the part.

4. The Manufacturer reserves the right to substitute parts where applicable.

5. Some parts are unlisted items which are special production items not normally stocked and are subject to special handling. Request a quotation for such parts before sending a

Purchase Order.

6. The Manufacturer reserves the right to change prices without prior notice.

NOTE: Please refer to The Safety Section in the front of this Manual for the proper

Part Number when ordering Replacement Safety Decals.

For maximum safety and to guarantee optimum product reliability, always use genuine Servis-Rhino Parts. The use of inferior replacement parts may cause premature or catastrophic failure which could result in serious injury or death.

Direct any questions regarding parts to:


1502 E. Walnut

Seguin, Texas 78155

830-379-1480

©2008 Alamo Group Inc.

Parts Section – 2

®

®

PART NAME INDEX

50 IN ROTARY - BLADE BAR - HEAD ASY (SOLID MNT).................................................................................................................... 5

50 IN ROTARY - BLADE BAR - HEAD SUB-ASY (SOLID MNT).......................................................................................................... 7

50 IN ROTARY - BLADE BAR - HEAD ASY (SWIVEL MNT)............................................................................................................... 9

50 IN ROTARY - BLADE BAR - HEAD SUB-ASY (SWIVEL MNT).................................................................................................... 11

50 IN ROTARY - BLADE BAR ASY......................................................................................................................................................... 13

50 IN ROTARY - BLADE PAN - HEAD ASY (SOLID MNT)................................................................................................................. 15

50 IN ROTARY - BLADE PAN - HEAD SUB-ASY (SOLID MNT)........................................................................................................ 17

50 IN ROTARY - BLADE PAN - HEAD ASY (SWIVEL MNT).............................................................................................................. 19

50 IN ROTARY - BLADE PAN - HEAD SUB-ASY (SWIVEL MNT)..................................................................................................... 21

50 IN ROTARY - BLADE PAN ASY......................................................................................................................................................... 23

60 IN ROTARY - BLADE BAR ASY......................................................................................................................................................... 24

60 IN ROTARY - HEAD ASY (SOLID MNT)........................................................................................................................................... 25

60 IN ROTARY - HEAD SUB-ASY (SOLID MNT).................................................................................................................................. 27

60 IN ROTARY - HEAD ASY (SWIVEL MNT)....................................................................................................................................... 29

60 IN ROTARY - HEAD SUB-ASY (SWIVEL MNT).............................................................................................................................. 31

ROTARY - MOTOR AND SPINDLE ASY................................................................................................................................................ 33

ROTARY - MOTOR ASY (PART 1).......................................................................................................................................................... 35

ROTARY - MOTOR ASY (PART 2).......................................................................................................................................................... 37

ROTARY - SPINDLE ASY......................................................................................................................................................................... 39

BOOM ASY - 18 FT BOOM (PART 1)...................................................................................................................................................... 41






COMMON CRATE COMPONENTS......................................................................................................................................................... 53

DECALS - 18-22-25 FT BOOM.................................................................................................................................................................. 55

DECALS - 50 & 60 IN ROTARY HEAD................................................................................................................................................... 56

DECALS - HYD TANK AND PUMP......................................................................................................................................................... 57

FILTER ASY................................................................................................................................................................................................ 58

HIGH FRAME MOUNT ASY - 2WD......................................................................................................................................................... 59

HIGH FRAME MOUNT ASY - 4WD......................................................................................................................................................... 61

HIGH FRAME MOUNT SUB-ASY............................................................................................................................................................ 63

HOSE ROUTING - 18 FT BOOM............................................................................................................................................................... 65

HOSE ROUTING - 18 FT BOOM NOTES................................................................................................................................................. 66





HOSE ROUTING - HYDRAULIC KIT...................................................................................................................................................... 71

Machete 2 HF (11-08)

©2008 Alamo Group Inc.

Parts Section -3

PART NAME INDEX

HYDARULIC CYLINDER ASY - DIPPER 22-25 FT BOOM.................................................................................................................. 73

HYDARULIC CYLINDER ASY - LIFT BOOM........................................................................................................................................ 74

HYDRAULIC CYLINDER ASY - HEAD SWIVEL (OPTIONAL).......................................................................................................... 75

HYDRAULIC CYLINDER ASY - TILT.................................................................................................................................................... 76

HYDRAULIC TANK SUB-ASY................................................................................................................................................................ 77

HYDRAULIC TANK W/PUMP AND ELECT VALVE ASY................................................................................................................... 79

JOYSTICK CONSOLE ASY....................................................................................................................................................................... 81

PUMP ASY - SERVO CONTROLLED (PART 1)..................................................................................................................................... 83

PUMP ASY - SERVO CONTROLLED (PART 2)..................................................................................................................................... 85

PUMP-TANK-VALVE COVER................................................................................................................................................................. 87

VALVE ASSEMBLY - ELECTRO-HYDRAULIC VALVE..................................................................................................................... 89

WIRE HARNESS ELECT-HYD VALVE................................................................................................................................................... 91



Parts Section -4

50 IN ROTARY - BLADE BAR - HEAD ASY (SOLID MNT)



Parts Section -5

50 IN ROTARY - BLADE BAR - HEAD ASY (SOLID MNT)

Continued...

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

18

19

20

21

22

1

2

ITEM PART NO. QTY.

02986704 1

02961480A

02982914

1

1

02982915

99338S

02982919

02982918

02982920

02982921

00011100

00023100

00015800

00007000

02981757

02971702

02971701

165020

651102

02976448

00755153

02968837

02968836

02960018

2

1

2

2

34

9

2

2

1

36

11

2

1

1

2

1

1

1

2

2

DESCRIPTION

ASY, 50" ROT, PISTON, BAR

HYD CYLINDER 2BORE X 9-1/4 STROKE

WELDMENT, DOOR

ROD, HINGE

PIN ROLL 1/4 X 3/4

FLAP, 8 1/2 X 52 X 1/4 THK

BAR, HOLD DOWN, FLAP

FLAP, REAR 10 X 53 X 3/8 THK

BAR, CLAMP, REAR

FLATWASHER 3/8 STD

HHCS 3/8 X 1-1/2 NC PL GR5

LOCKNUT TLM 3/8 NC PLC

HHCS 3/8 NC 1-3/4 PL5

WELDMENT, PIN, HITCH POST

FLATWASHER, 1-3/8 TYPE B PL NARROW

NUT, SLOTTED 1-3/8 12NF PLB

PIN, COTTER 5/16 X 2-1/2 PL

PIN-DRILLED

PIN - MACHINED HEAD


PLASTIC TIE, YELLOW & WHITE

PLASTIC TIE, YELLOW

ADP, HYD, ELBOW, 4MB-4MJ90



Parts Section -6

50 IN ROTARY - BLADE BAR - HEAD SUB-ASY (SOLID MNT)



Parts Section -7

50 IN ROTARY - BLADE BAR - HEAD SUB-ASY (SOLID MNT)

Continued...

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

22

23

24

25

18

19

20

21

1

2


02986704 1

00015800

02891800

18

4

00019600

02982907

02981411

02961038

02982906

02964861

15B600

00003901

00059700

02968859A

03200269

02892100

00037200

5312316

02986200

02979881

02981819

02968894

02968896

02980236

00022200

02968895

02972817

8

16

16

1

14

1

8

1

4

14

4

1

1

4

2

1

1

8

8

1

1

1

2

DESCRIPTION

ASY, 50" ROT, PISTON, BAR


HHCS 1/2 NC 1-3/4 PL8

LOCKWASHER 1/2 HEAVY

SKID SHOE

WELDMENT, DECK 50" HEAD

GASKET

ASY, BLADE BAR W/BLADES

SHCS 3/4 NC 4" LG PL8

WASHER 3/8 SAE P


FSCS 3/8 NC X 1-1/4

ASSEMBLY, SPINDLE HOUSING-SPLINED

HHCS 3/4 NC 3 PL8

HHCS 3/4 NC X 1 3/4" LG

NUT 3/4 NC LOCKNUT

FLATWASHER 3/4 HARDENED

WELDMENT, HITCH POST

MOTOR PISTON 4.91 CID

ADP HYD STGHT 16FLH-16MJ SPCL

PLASTIC TIE, RED, 11LG

PLASTIC TIE, ORANGE, 11LG

HHCS 7/16 NC X 4 1/2"LG PL5

LOCKWASHER 7/16 PL

PLASTIC TIE, BLUE, 11LG

ADP HYD ELBOW 10MB - 8MJ 45 DEG



Parts Section -8

50 IN ROTARY - BLADE BAR - HEAD ASY (SWIVEL MNT)



Parts Section -9

50 IN ROTARY - BLADE BAR - HEAD ASY (SWIVEL MNT)

Continued...

30

31

32

33

26

27

28

29

22

23

24

25

18

19

20

21

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

1

2


02986197 1

02961480A

02982914

1

1

651102

02976448

00755153

03200267

02963646

00037200

02968837

02968836

02960018

02968832

02968833

03200762

02972817

02968894

02968895

02968896

02982915

99338S

02982919

02982918

02982920

02982921

00011100

00023100

00015800

00007000

02981315

02981757

02971702

02971701

165020

1

1

1

1

1

2

2

1

1

1

3

18

2

1

1

1

2

2

2

2

20

9

1

2

1

36

11

2

1

1

2

DESCRIPTION

ASY, 50" ROT, PISTON, BAR, SW


WELDMENT, DOOR

ROD, HINGE

PIN ROLL 1/4 X 3/4

FLAP, 8 1/2 X 52 X 1/4 THK



BAR, CLAMP, REAR

FLATWASHER 3/8 STD



HHCS 3/8 NC 1-3/4 PL5

CYLINDER, 2.5B X 1.5R X 14.38S





PIN-DRILLED

PIN - MACHINED HEAD


HHCS 3/4 NC 5 PL8

HHCS 3/4 NC 2-1/2 PL8

NUT 3/4 NC LOCKNUT


PLASTIC TIE, YELLOW


PLASTIC TIE, GREEN

PLASTIC TIE, GREEN & WHITE

ADP, HYD 6MB-4MJ 90







Parts Section -10

50 IN ROTARY - BLADE BAR - HEAD SUB-ASY (SWIVEL MNT)



Parts Section -11

50 IN ROTARY - BLADE BAR - HEAD SUB-ASY (SWIVEL MNT)

Continued...

22

23

24

25

18

19

20

21

26

27

28

29

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

1

2


02986197 1

00015800

02963646

20

3

02961038

02982906

02981752

02964861

15B600

00003901

00059700

02968859A

02892100

5312316

03200269

02984002

00037200

02968894

02968896

02980236

02891800

02979881

00022200

00019600

02981819

02980237

02982907

02981820

02981318

02985319

02981411

14

4

14

1

1

4

1

1

8

1

6

18

1

1

28

1

2

1

2

8

4

4

1

1

8

18

1

DESCRIPTION

ASY, 50" ROT, PISTON, BAR, SW


HHCS 3/4 NC 2-1/2 PL8

NUT 3/4 NC LOCKNUT




HHCS 1/2 NC 1-3/4 PL8


LOCKWASHER 7/16 PL



O-RING .139 DIA X 1.296 INSIDE

SKID SHOE

SHCS 1/2 NC X 1 1/2" LG PL8

SLEWING BEARING, 12 OD X 5.8 ID



GASKET


PLATE, HITCH POST BOTTOM, MAVERICK


WASHER 3/8 SAE P


FSCS 3/8 NC X 1-1/4


HHCS 3/4 NC X 1 3/4" LG


HHCS 3/4 NC 3 PL8

WLDMNT, STOP, SWIVEL



Parts Section -12

50 IN ROTARY - BLADE BAR ASY

7

8

9

10

5

6

3

4

11

1

2


02982906 1

02982912

02982913

1

1

02962635

02982934

02782900

02957089

00020900

00023200

15C2000

02969235

02969236

4

2

2

2

2

2

2

1

2

DESCRIPTION


LEAF, MIDDLE, BLADE BAR

LEAF, BOTTOM, BLADE BAR

BLADE, CW ROTATION

WLDMT. TOP BLADE BAR

BOLT, BLADE

LOCKWASHER 1-1/8 PL STD

NUT, SLOTTED, HVY,1-1/8NF PL GR5

PIN, ROLL, 3/16X1-3/4

WASHER, 1.375 X 2.50 X .165, HARDENED

HHCS, 1-1/4X3 PL GR8

HHCS, 1-1/4X2-1/4 PL GR8



Parts Section -13

THIS PAGE INTENTIONAL LEFT BLANK



Parts Section -14

50 IN ROTARY - BLADE PAN - HEAD ASY (SOLID MNT)



Parts Section -15

50 IN ROTARY - BLADE PAN - HEAD ASY (SOLID MNT)

Continued...

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

18

19

20

21

22

1

2


02986703 1

02961480A

02982914

1

1

02982915

99338S

02982919

02982918

02982920

02982921

00011100

00023100

00015800

00007000

02981757

02971702

02971701

165020

651102

02976448

00755153

02968837

02968836

02960018

2

1

2

2

34

9

2

2

1

36

11

2

1

1

2

1

1

1

2

2

DESCRIPTION

ASY, 50" ROT, PISTON, PAN


WELDMENT, DOOR

ROD, HINGE

PIN ROLL 1/4 X 3/4

FLAP, 8 1/2 X 52 X 1/4 THK



BAR, CLAMP, REAR

FLATWASHER 3/8 STD



HHCS 3/8 NC 1-3/4 PL5





PIN-DRILLED

PIN - MACHINED HEAD



PLASTIC TIE, YELLOW




Parts Section -16

50 IN ROTARY - BLADE PAN - HEAD SUB-ASY (SOLID MNT)



Parts Section -17

50 IN ROTARY - BLADE PAN - HEAD SUB-ASY (SOLID MNT)

Continued...

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

22

23

24

25

18

19

20

21

1

2


02986703 1

00015800

02891800

34

4

00019600

02982907

02981411

02961038

02964804

02964861

15B600

00003901

00059700

02968859A

03200269

02892100

00037200

5312316

02986200

02979881

02981819

02968894

02968896

02972817

02980236

00022200

02968895

8

16

16

1

14

1

8

1

4

14

4

1

1

4

2

8

1

1

8

1

1

1

2

DESCRIPTION

ASY, 50" ROT, PISTON, PAN


HHCS 1/2 NC 1-3/4 PL8


SKID SHOE


GASKET

PAN ASSY 50" HEAD


WASHER 3/8 SAE P


FSCS 3/8 NC X 1-1/4


HHCS 3/4 NC 3 PL8

HHCS 3/4 NC X 1 3/4" LG

NUT 3/4 NC LOCKNUT









LOCKWASHER 7/16 PL




Parts Section -18

50 IN ROTARY - BLADE PAN - HEAD ASY (SWIVEL MNT)



Parts Section -19

50 IN ROTARY - BLADE PAN - HEAD ASY (SWIVEL MNT)

Continued...

30

31

32

33

26

27

28

29

22

23

24

25

18

19

20

21

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

1

2


02986198 1

02961480A

02982914

1

1

651102

02976448

00755153

03200267

02963646

00037200

02968837

02968836

02960018

02968832

02968833

03200762

02972817

02968894

02968895

02968896

02982915

99338S

02982919

02982918

02982920

02982921

00011100

00023100

00015800

00007000

02981315

02981757

02971702

02971701

165020

1

1

1

1

1

2

2

1

1

1

3

18

2

1

1

1

2

2

2

2

34

9

1

2

1

36

11

2

1

1

2

DESCRIPTION

ASY, 50" ROT, PISTON, PAN,SW


WELDMENT, DOOR

ROD, HINGE

PIN ROLL 1/4 X 3/4

FLAP, 8 1/2 X 52 X 1/4 THK



BAR, CLAMP, REAR

FLATWASHER 3/8 STD



HHCS 3/8 NC 1-3/4 PL5






PIN-DRILLED

PIN - MACHINED HEAD


HHCS 3/4 NC 5 PL8

HHCS 3/4 NC 2-1/2 PL8

NUT 3/4 NC LOCKNUT


PLASTIC TIE, YELLOW


PLASTIC TIE, GREEN


ADP, HYD 6MB-4MJ 90







Parts Section -20

50 IN ROTARY - BLADE PAN - HEAD SUB-ASY (SWIVEL MNT)



Parts Section -21

50 IN ROTARY - BLADE PAN - HEAD SUB-ASY (SWIVEL MNT)

Continued...

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

22

23

24

25

18

19

20

21

26

27

1

2


02986198 1

00015800

02963646

34

3

00037200

02980236

02891800

02979881

00022200

00019600

02981819

02980237

02982907

02981820

02981318

02985319

02981411

02961038

02964804

02981752

02964861

15B600

00003901

00059700

02968859A

03200269

02892100

5312316

02984002

1

1

1

1

2

28

1

2

2

8

4

4

1

18

8

8

6

14

1

1

4

14

4

18

1

DESCRIPTION

ASY, 50" ROT, PISTON, PAN,SW


HHCS 3/4 NC 2-1/2 PL8

NUT 3/4 NC LOCKNUT


HHCS 1/2 NC 1-3/4 PL8


LOCKWASHER 7/16 PL




SKID SHOE


SLEWING BEARING, 12 OD X 5.8 ID



GASKET

PAN ASSY 50" HEAD



WASHER 3/8 SAE P


FSCS 3/8 NC X 1-1/4


HHCS 3/4 NC 3 PL8

HHCS 3/4 NC X 1 3/4" LG





Parts Section -22

50 IN ROTARY - BLADE PAN ASY

8

9

10

11

6

7

4

5

12

13

14

1

2

3


02964804 1

02964826

02964828

00755623

1

1

3

00020900

00023200

02964815

02964954

02965229

02964330

02962722

7A16824

00748547

02964162

02030300

1

3

3

3

4

3

3

3

6

3

3

DESCRIPTION

PAN ASSY

PAN,MACHINED 28.00 BC

SPIDER, MACHNED 28.00 BC

WASHER 2.200 OD1.218 1DX.250

NUT SLOT HVY 1-1/8 NF PL5

PIN ROLL 3/16X1-3/4

BUSHING, BLADE BOLT

KEY,5/16 SQ X 15/16 LONG

WASHER, 2-19/32 ID 5.0 OD 3/16

KEYED BLADE BOLT

BLADES-SET OF 3(50B/A HEAD)

HHCS 1 NC 3 PL5

FLATWASHER 1-1/32 X

SPACER BLADE PAN WITH SPIDER

NUT TOPLOCK 1 NC PLB



Parts Section -23

60 IN ROTARY - BLADE BAR ASY

8

9

10

11

6

7

4

5

12

13

14

1

2

3


02969230 1

00020900

00023200

02969234

2

2

4

02761500

02971387

02969232

02969233

02969235

02969236

02782900

02957089

00003901

02964861

02984572

2

2

2

2

1

1

1

1

4

4

1

DESCRIPTION

BLADE BAR ASY, W/ BLADES

HEX SLOTTED NUT, HVY 1-1/8"-NF PL GR5

ROLL PIN, 3/16" X 1-3/4"

FLATWASHER, 1-1/4" HARDENED PL

BLADE SET, MATCHED SET OF TWO

LEAF BLADE BAR, TOP

LEAF BLADE BAR, MIDDLE

LEAF BLADE BAR, BOTTOM

BOLT, HEX HEAD 1-1/4"-NC X 3" PL GR8

BOLT, HEX HEAD 1-1/4"-NC X 2-1/4" PL GR8

BLADE BOLT, SHOULDERED

LOCKWASHER, 1-1/8" PL STD

LOCKWASHER, 3/4" PL HEAVY

BOLT, SOCKET HEAD 3/4"-NC X 4" PL GR8

BLADE BOLTS, NUTS, ROLLPIN KIT (INCLUDES 2 EACH OF ITEMS 1, 2, & 10)



Parts Section -24

60 IN ROTARY - HEAD ASY (SOLID MNT)



Parts Section -25

60 IN ROTARY - HEAD ASY (SOLID MNT)

Continued...

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

18

19

20

21

22

1

2


02986205 1

02971963

99338S

1

2

02961480A

02981757

02971702

02967782

02971701

165020

651102

02976448

00755153

02885700

02885800

00759862

00756875

00023100

00011100

00015800

00007000

02960018

02968836

02968837

2

1

13

46

2

2

1

1

1

2

2

2

1

1

2

2

1

39

12

1

DESCRIPTION

ASY,60" ROT, PISTON, BAR

WELDMENT, DOOR

PIN ROLL 1/4 X 3/4




ROD-HINGE



PIN - DRILLED

PIN - MACHINED HEAD


REAR FLAP 10 X 63 X 3/8 THK

REAR CLAMP BAR

DEBRIS DEFLECTOR

FLAP HOLD DOWN BAR


FLATWASHER 3/8 STD


HHCS 3/8 NC 1-3/4 PL5


PLASTIC TIE, YELLOW




Parts Section -26

60 IN ROTARY - HEAD SUB-ASY (SOLID MNT)



Parts Section -27

60 IN ROTARY - HEAD SUB-ASY (SOLID MNT)

Continued...

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

22

23

24

25

18

19

20

21

26

1

2


02986205 1

02981410

02986200

1

1

5312316

02966899

02964861

00003901

00059700

15B600

02961038

03200269

02980237

02979881

02968859A

02969230

00015800

02981819

02968894

02968896

02980236

00022200

02968895

02972817

02891800

00019600

02892100

00037200

4

4

8

16

8

1

1

1

8

2

1

1

1

1

39

1

8

14

14

4

4

16

2

2

DESCRIPTION

ASY,60" ROT, PISTON, BAR

WELDMENT,60" ROTARY,SWIVEL










LOCKWASHER 7/16 PL



HHCS 1/2 NC 1-3/4 PL8


HHCS 3/4 NC X 1 3/4" LG

NUT 3/4 NC LOCKNUT


SKID SHOE



FSCS 3/8 NC X 1-1/4

WASHER 3/8 SAE P

GASKET

HHCS 3/4 NC 3 PL8




Parts Section -28

60 IN ROTARY - HEAD ASY (SWIVEL MNT)



Parts Section -29

60 IN ROTARY - HEAD ASY (SWIVEL MNT)

Continued...

22

23

24

25

18

19

20

21

26

27

28

29

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

1

2


02986191 1

02971963

99338S

1

2

00759862

00756875

00023100

00011100

00015800

00007000

02960018

03200762

02968836

02968837

02968832

02968833

02961480A

02981315

02981757

02971702

02967782

02971701

165020

651102

02976448

00755153

03200267

02963646

00037200

02885700

02885800

2

2

32

12

2

1

13

46

1

1

1

1

2

1

3

18

1

2

1

2

1

1

2

2

2

1

1

DESCRIPTION

ASY, 60" ROT,PISTON,BAR,SWIVEL

WELDMENT, DOOR

PIN ROLL 1/4 X 3/4





ROD-HINGE



PIN-DRILLED

PIN - MACHINED HEAD


HHCS 3/4 NC 5 PL8

HHCS 3/4 NC 2-1/2 PL8

NUT 3/4 NC LOCKNUT

REAR FLAP 10 X 63 X 3/8 THK

REAR CLAMP BAR

DEBRIS DEFLECTOR

FLAP HOLD DOWN BAR


FLATWASHER 3/8 STD


HHCS 3/8 NC 1-3/4 PL5


ADP, HYD 6MB-4MJ 90

PLASTIC TIE, YELLOW


PLASTIC TIE, GREEN




Parts Section -30

60 IN ROTARY - HEAD SUB-ASY (SWIVEL MNT)



Parts Section -31

60 IN ROTARY - HEAD SUB-ASY (SWIVEL MNT)

Continued...

26

27

28

29

30

31

22

23

24

25

18

19

20

21

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

1

2


02986191 1

02981410

02985319

1

1

02980237

00022200

02980236

02981819

15B600

00059700

00003901

02961038

02966899

02964861

03200269

02981752

02981820

02981318

02979881

02968859A

02969230

02963646

00037200

02972817

00015800

02968894

02968895

02968896

02892100

5312316

00019600

02984002

02891800

8

1

1

4

13

1

4

1

7

7

8

2

2

8

1

4

18

4

1

1

6

18

1

32

1

1

3

1

1

DESCRIPTION

ASY, 60" ROT,PISTON,BAR,SWIVEL

WELDMENT,60" ROTARY,SWIVEL





HHCS 3/4 NC 2-1/2 PL8

NUT 3/4 NC LOCKNUT






HHCS 3/4 NC X 1 3/4" LG




HHCS 1/2 NC 1-3/4 PL8


LOCKWASHER 7/16 PL



WASHER 3/8 SAE P

FSCS 3/8 NC X 1-1/4


GASKET

SKID SHOE


HHCS 3/4 NC 3 PL8



BEARING, 12OD X 5.8ID



Parts Section -32

ROTARY - MOTOR AND SPINDLE ASY


1 02979881 1

8

9

6

7

4

5

2

3

10

02968859A

02961038

02981819

02980237

02972817

02980236

00022200

02891800

00019600

8

4

1

8

2

2

1

1

4

DESCRIPTION

MOTOR ASY, PISTON TYPE 4.91 CID

SPINDLE & HOUSING ASY, SPLINED

GASKET-SPINDLE/MOTOR


O-RING

HYD ELBOW, 10MB - 8MJ45

BOLT

LOCKWASHER, STD 7/16" PL

BOLT, HEX HEAD 1/2"-NC X 1-3/4" PL GR8

LOCKWASHER, 1/2" HEAVY



Parts Section -33




Parts Section -34

ROTARY - MOTOR ASY (PART 1)



Parts Section -35


Continued...

25

26

27

28

32

33

34

29

30

31

15

16

17

18

12

13

14

8

9

10

11

6

7

4

5

19

20

21

22

23

24

1

2


02979881 1

02980529

02980530

1

1

02980552

02980553

02980554

02980555

02980556

02980557

02980558

02980559

02980560

02980561

02980562

02980563

02980564

02980565

02980547

02980571

02980536

02980537

02980538

02980539

02980540

02980541

02980542

02980543

02980544

02980545

02980546

02980548

02980549

02980550

02980551

02980570

02980568

02980569

02980237

02980531

02980532

02980533

1

1

4

1

1

1

1

1

1

1

1

1

1

1

1

1

1

2

2

1

2

1

1

1

1

7

21

1

1

1

1

1

1

1

1

1

1

1

DESCRIPTION

MOTOR ASY, PISTON TYPE 4.91 CID

BARREL HOUSING ASY

VALVE PLATE

NOZZLE PLUG 2.5MM

PLUG ASY, 7/8" HEXAGON

BEARING HOUSING

O-RING, 132 X 3

O-RING, 104.5 X 3

SEAL CARRIER

SHAFT SEAL

SPACER WASHER

RETAINING RING

RETAINING RING

SHAFT ASY, TYPE U

CYLINDER BARREL

BARREL SUPPORT

PISTON ASY

PISTON RING

RING GEAR

TAP ROL BEARING

BEARING, TAPERED ROLLER

SPACER WASHER

RETAINING RING

SHIM, 0.5

SHIM, 0.2

SHIM, 0.4

SHIM, 0.6

SHIM, 0.8

SHIM, 1.0

SHIM, 0.7

BOLT, SOCKET HEAD M12 X 50 10.9

LOCKWASHER, M13 X 19.5

GUIDE PIN

RELIEF MANIFOLD

RELIEF VALVE, SEAL KIT

RELIEF VALVE, 280 BAR

RELIEF VALVE, 330 BAR

O-RING

KEY, FLAT

STEEL BALL

PLUG, HEXAGON



Parts Section -36




Parts Section -37


Continued...

38

39

40


35 02980534 2

36

37

02980535

02980572

2

2

02980573

02980566

02980567

1

1

1

DESCRIPTION

O-RING

PLUG ASY, HEX SOCKET

PLUG ASY

PLUG ASY

REBUILD KIT

SEAL KIT, FOR 02979881 MTR



Parts Section -38

ROTARY - SPINDLE ASY



Parts Section -39

ROTARY - SPINDLE ASY

Continued...

7

8

9

5

6

3

4

1

2


02968859 1

02967204

02967126

1

1

02967197

02967196

02909500

02909600

02967198

02959018

00003500

1

1

1

2

1

1

1

DESCRIPTION

SPINDLE ASY

SPINDLE SHAFT, SPLINED

HOUSING, MACHINED SPINDLE

BEARING ASY, CUP & CONE, LOWER

BEARING ASY, CUP & CONE, UPPER

ADJUSTING NUT, 2.360-18 PITCH

TABBED LOCKWASHER, BEARING ADJUSTING NUT LOCK

SEAL

GREASE RELIEF FITTING, 1-5LBS

GREASE FITTING, 1/8" STRAIGHT



Parts Section -40

BOOM ASY - 18 FT BOOM (PART 1)



Parts Section -41


Continued...

30

31

32

33

26

27

28

29

22

23

24

25

18

19

20

21

38

39

40

34

35

36

37

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

1

2


02986858 1

02986896

02983707

1

1

02919600

165020

63149100

00002700

02975436

00001800

00023100

02970595

00015800

001921

000941

00752670

02968835

02968831

02968834

02968830

02981279

02984944

02983320

02971751

02981294

02982981

02981420

02981424

02981273

02981702

02984819

02984818

02984817

02985273

02965448

02968829

02968828

02968837

02968836

02968894

02968896

02968895

1

1

1

1

1

8

4

1

3

1

1

1

3

3

4

1

4

4

4

1

1

1

1

1

4

1

1

1

1

1

2

8

1

1

1

1

1

1

DESCRIPTION

ASY, 18 BOOM, PISTON

WELDMENT,18` LIFT

WELDMENT, DIPPER, 18`



CYL, 3.5B X 1.5R X 30.0S

PIN, 1-1/2 X 5-3/16 & 13/32 HOLE

WELDMENT, PIN, LIFT/ DIPPER

WELDMENT, CYLINDER PIN LONG, NEW BOOM

CONNEX BUSHING, 2 1/4 X 2 X 3

CONNEX BUSHING, 1 3/4 X 1 1/2 X 3

SPACER, PIN, DIPPER, MAVERICK

SLOTTED NUT, 1-1/2 NF

HYDRAULIC TUBE, #16

HYDRAULIC TUBE, #12

HYDRAULIC TUBE, #16

ASSEMBLY, TILT CYLINDER COVER

ADP, HYD 4MJ -4MJ BULKHEAD

CAP, HYD 4FJ


ADP, HYD ELBOW 6MB-6MJ 90

FLATWASHER, 1/2 PL STD

HHCS 1/2 NC X 2 1/4 PL8

LOCKNUT TLM 1/2 NC PLB


HHCS 3/8 NC 2-3/4 PL8


ADAPTER 6MJ - 6FJX 90

GREASE ZERK 1/4-28 90 BOLT THD

GREASE FITTING 1/4-28 BOLT THD

PLASTIC TIE, ORANGE & WHITE

PLASTIC TIE, BLUE & WHITE

PLASTIC TIE, ORANGE

PLASTIC TIE, BLUE

PLASTIC TIE, RED & WHITE

PLASTIC TIE, RED


PLASTIC TIE, YELLOW






Parts Section -42




Parts Section -43


Continued...

63

64

65

66

59

60

61

62

67

68

69

70

55

56

57

58

52

53

54

48

49

50

51

44

45

46

47


41 02968832 1

42

43

02968833

02984821

1

1

00751846

02985976

02976532

02962022

02956851

02981197

02972910

02742500

03101646

00024100

00024000

02970609

02956918

03200375

02984868

02985222

02986074

02985220

00011400

00769258

02982979

0381000

00019600

02983080

63161900

02985978

000860

1

1

1

1

2

2

3

1

4

1

3

4

1

4

2

2

2

2

2

3

3

1

3

2

2

2

4

DESCRIPTION

PLASTIC TIE, GREEN


COVER, LIFT TUBE COVER

CAP, 16 FJ

CLAMP, TUBE 1-POSTION

CLAMP, TUBE 1-POSTION, 3/4"

PLATE, LINKAGE

WELDMENT, LINKAGE

WELDMENT, PIN, LINKAGE

BOLT, HHCS 3/8 NC 1 PL5

RETAINING RING,1.5 SHAFT

WELDMENT, CYLINDER PIN, NEW BOOM

CARB 1/2 - 13 X 2.75


NUT, 1/2-13 ACORN

SPRING NUT 1/2

PLATE, BULKHEAD

BOLT, HHCS 1/4" X 7/8" LG

ADP HYD STGHT 16MJ - 16MJ BULKHEAD


ADP, HYD, 4MJ-4FJX 45

ADP HYD ELBOW 4MJ-4FJX90

ADP HYD ELBOW 16 MJ-16 JX 90

ADAPTER 12MJ - 12MJ 90 BULKHEAD

CAP, #8 FJ


LOCKWASHER 3/8

FLATWASHER STD 1/4 PL

NUT HEX 1/4" NC PL

ADP 12FJ - 8MJ



Parts Section -44




Parts Section -45


Continued...

30

31

32

33

26

27

28

29

22

23

24

25

18

19

20

21

38

39

40

34

35

36

37

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

1

2


02986859 1

02986897

02985124

1

1

00002700

02975436

00001800

02957042

00023100

00015800

00752670

000941

02968835

165020

02968834

02968831

02968830

02968829

02968828

02968837

02981294

02981279

02982979

02982980

02981273

02981277

02981702

63149100

02981420

02981424

02984853

02984854

02984855

02965448

02919600

02968836

02968894

02968896

001921

02968832

02968833

03200375

1

1

1

1

1

1

1

1

3

4

10

1

1

1

5

1

1

1

8

4

1

1

4

4

4

1

1

2

8

1

1

3

1

1

3

1

1

1

DESCRIPTION

ASY, 22 BOOM, PISTON

WELDMENT,LIFT SECTION 22` BOOM

WELDMENT, 22` DIPPER




WELDMENT, CYLINDER PIN SHORT, NEW BOOM







HYDRAULIC TUBE, #16

HYDRAULIC TUBE, #12

HYDRAULIC TUBE, #16


CAP, HYD 4FJ


HHCS 1/2 NC X 2 1/4 PL8


HHCS 3/8NC 1-3/4 PL GR8







PLASTIC TIE, ORANGE


PLASTIC TIE, BLUE


PLASTIC TIE, RED


PLASTIC TIE, YELLOW




PLASTIC TIE, GREEN





Parts Section -46




Parts Section -47


Continued...

63

64

65

66

59

60

61

62

67

68

69

70

55

56

57

58

52

53

54

48

49

50

51

44

45

46

47


41 02968895 4

42

43

02984856

02984857

1

1

02985976

02981197

02742500

02956851

02962022

02976532

02985978

000860

02970609

03101646

00024000

00024100

02984868

02956918

00011400

00769258

02986074

02985220

02985222

02985273

02984944

0381000

00019600

02983080

63161900

02972910

00751846

1

4

2

2

1

1

1

1

4

4

1

3

1

3

4

4

1

4

4

2

1

1

3

3

3

4

2

DESCRIPTION





CAP, 16 FJ



WELDMENT, LINKAGE


PLATE, LINKAGE



CARB 1/2 - 13 X 2.75


NUT, 1/2-13 ACORN

SPRING NUT 1/2

CAP, #8 FJ








PLATE, BULKHEAD


ADP 12FJ - 8MJ

LOCKWASHER 3/8

NUT HEX 1/4" NC PL




Parts Section -48




Parts Section -49


Continued...

30

31

32

33

26

27

28

29

22

23

24

25

18

19

20

21

38

39

40

34

35

36

37

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

1

2


02986860 1

02986898

02984895

1

1

02957042

00023100

00015800

000941

00752670

165020

02968835

02968834

02968831

02968830

02968828

02968829

02968836

02968837

02968894

02968896

02981279

02981277

02981420

02981424

02981294

02981273

02981702

02982979

02982980

02965448

02919600

63149100

00002700

02975436

00001800

001921

02968832

02968833

03200375

02984868

02984890

02984891

4

4

1

1

1

1

1

1

1

1

10

1

4

1

1

3

4

1

1

1

8

1

1

1

1

3

5

1

4

4

1

3

1

1

2

8

1

1

DESCRIPTION

25 FT BOOM ASY

WELDMENT, 25` LIFT

WELDMENT, 25` DIPPER









WELDMENT, CYLINDER PIN SHORT, NEW BOOM


CAP, HYD 4FJ



HHCS 1/2 NC X 2 1/4 PL8


HHCS 3/8NC 1-3/4 PL GR8







PLASTIC TIE, ORANGE


PLASTIC TIE, BLUE

PLASTIC TIE, RED


PLASTIC TIE, YELLOW





PLASTIC TIE, GREEN




HYDRAULIC TUBE, #16

HYDRAULIC TUBE, #12



Parts Section -50




Parts Section -51


Continued...

63

64

65

66

59

60

61

62

67

68

69

70

55

56

57

58

52

53

54

48

49

50

51

44

45

46

47


41 02984892 1

42

43

02968895

02984893

4

1

02956851

02962022

02981197

02972910

02742500

02985978

02985976

000860

03101646

02970609

00024100

00024000

02984894

02956918

02983080

00019600

0381000

63161900

02985222

02985220

00769258

02985273

02984944

02986074

00011400

02976532

00751846

1

4

1

1

1

1

1

2

4

4

3

1

2

3

1

3

3

1

1

2

3

4

4

4

4

1

2

DESCRIPTION

HYDRAULIC TUBE, #16




CAP, 16 FJ

NUT, 1/2-13 ACORN


CARB 1/2 - 13 X 2.75

SPRING NUT 1/2

PLATE, LINKAGE





WELDMENT, LINKAGE







CAP, #8 FJ


PLATE, BULKHEAD



LOCKWASHER 3/8

ADP 12FJ - 8MJ


NUT HEX 1/4" NC PL



Parts Section -52

COMMON CRATE COMPONENTS



Parts Section -53

COMMON CRATE COMPONENTS

Continued...


02987829 1

DESCRIPTION

PACKET, INST DWGS AND DECALS

KNOB 3/8NC X 1-1/2 STUD

ASSEMBLY JOYSTICK CONSOLE

CANISTER, PARTS MANUAL

BOOT,CABLE

ASSEMBLY OPERATORS & PARTS

ASSEMBLY CANISTER MANUAL

ASY, COMPLETE, TANK & VALVE

CABLE, PUMP COVER 36

CABLE, MANUAL CANISTER, 24

TUBE,FRAME MOUNTING

PLASTIC TIE 15 LG UV BLACK

MOUNT TIE ROD

ASY, HARNESS, MACHETE

BAR,MOUNT STRAP

ASY, PUMP COVER

BOOM TO FRAME HOSE BUNDLE

BAR,MOUNT STRAP 4-1/2



Parts Section -54

DECALS - 18-22-25 FT BOOM


43 02962764 6

59 02985831

02984939

02984940

2

2

2

DESCRIPTION

DECAL, PINCH POINT

DECAL, MACHETE 2 18`





Parts Section -55

DECALS - 50 & 60 IN ROTARY HEAD

7

8

5

6

9

10

2

3

4


1 00757139 2

00757140

00769736

00769737

1

1

2

11

12

02925100

02967827

02967867

2738332

2738333

02986679

02986112

3710151

02982927

02970889

1

4

1

1

1

1

1

1

1

1

DESCRIPTION

DECAL, LOGO (ALAMO BY T.K.)

DECAL, ALAMO INDUSTRIAL LOGO

DECAL, USE/REPAIR GUARDS

DECAL, BLADES THROWN OBJECTS

DECAL, REPLACEMENT PARTS

DECAL, MULTI HAZARD

DECAL, DANGER SAFETY SHIELD

DECAL, RED OBLONG REFLECTOR

DECAL, YELLOW OBLONG REFLECTOR

PLATE S/N 50", ROTARY, PISTON

PLATE S/N 60", ROTARY, PISTON

METAL TACK

DECAL, 50 ROTARY

DECAL, 60 ROTARY



Parts Section -56

DECALS - HYD TANK AND PUMP

3

4

5


1 02982828 1

2 02971943 1

02965262

02971123

02987402

1

1

1

DESCRIPTION

DECAL, TEMP RANGE

DECAL, LOGO RECT CLEAR Y/W, 2 7/8 X 20

DECAL - WARNING - HOSE BURST

DECAL WARNING PRESS TANK

DECAL, VALVE LAYOUT M2



Parts Section -57

FILTER ASY

8

9

6

7

4

5

2

3

10


02985828 1

1 02981713 1

02981714

02981715

02981716

02981717

02981718

02981719

02981720

02981721

02987302

1

1

1

1

1

1

1

1

1

DESCRIPTION

FILTER, RETURN

HEAD, FILTER RTB30

COVER, FILTER

SPRING, FILTER, ASY

KIT, SEAL, FILTER, RETURN

ELEMENT, FILTER, RETURN

BOWL, FILTER, RETURN

GUARD, FILTER, RETURN

BREATHER, ELEMENT, FILTER

COVER, BREATHER, FILTER

INDICATOR, FILTER BYPASS



Parts Section -58

HIGH FRAME MOUNT ASY - 2WD



Parts Section -59


Continued...

11

12

13

14

15

7

8

9

10

5

6

3

4

1

2


02978449 1

02978447

02978000

1

1

02978461

02975596

00013300

00002700

00001800

02960521

00037200

5312316

02968841

00725746

02742500

02962765

02965262

1

1

3

1

1

1

8

8

16

1

1

1

1

DESCRIPTION

ASY HIGH FRAME 2WD

WELDMENT FRAME 2WD

SUB-ASY KINGPOST FRAME

WLDMT PIN 1-1/2 OD X 6-3/4 LG CHROMED

TUBE SPACER 3/4 OD X .51 ID X .31 LG

HHCS 1/2 NC 2 PL5

FLATWASHER 1/2 PL STD

LOCKNUT 1/2 NC PLB

HHCS 3/4 NC 2-3/4 PL8

LOCKNUT 3/4 NC PLC

WASHER 25/32 X 1-7/16 X 1/8 HARDENED

ASSEMBLY LIFT CYLINDER

DECAL SPANISH TRANSL

ELBOW 16MJ -16MJ90 BULKHEAD

DECAL MULTI-HAZZARD

DECAL HOSE BURST



Parts Section -60




Parts Section -61


Continued...

11

12

13

14

15

7

8

9

10

5

6

3

4

1

2


02978450 1

02978448

02978000

1

1

02978461

02975596

00013300

00002700

00001800

02960521

00037200

5312316

02968841

00725746

02742500

02962765

02965262

1

1

3

1

1

1

8

8

16

1

1

1

1

DESCRIPTION

ASY HIGH FRAME 4WD

WELDMENT FRAME 4WD

SUB-ASY KINGPOST FRAME

WLDMT PIN 1-1/2 OD X 6-3/4 LG CHROMED

TUBE SPACER 3/4 OD X .51 ID X .31 LG

HHCS 1/2 NC 2 PL5


LOCKNUT 1/2 NC PLB

HHCS 3/4 NC 2-3/4 PL8

LOCKNUT 3/4 NC PLC

WASHER 25/32 X 1-7/16 X 1/8 HARDENED

ASSEMBLY LIFT CYLINDER

DECAL SPANISH TRANSL

ELBOW 16MJ -16MJ90 BULKHEAD

DECAL MULTI-HAZZARD

DECAL HOSE BURST



Parts Section -62

HIGH FRAME MOUNT SUB-ASY



Parts Section -63

HIGH FRAME MOUNT SUB-ASY

Continued...

02975508

02975493

02987739

02978477

00748823

02975596

00002700

00001800

02966088

02978476

02987636

02956765

02963646

02023900

02975429

00752670

14

15

16

17

11

12

13

18

7

8

9

10

5

6

3

4

1

2


02978000 1

02975491

02968840

1

1

1

1

1

1

1

1

2

3

2

3

2

2

2

1

1

1

DESCRIPTION

SUB-ASSEMBLY KINGPOST FRAME

MOUNTING KINGPOST MACHINED

ASSY,SWING CYLINDER

PIN 2-1/2 OD X 20-11/16 LONG

KINGPOST MACHINED

BUSHING CONNEX 1-3/4 X1 -1/2X3

WLDMT PIN 1-1/2 X 3-9/16 LG

HHCS 1/2-13UNC 1-1/2 PL5

TUBE SPACER 3/4 OD X .51 ID X



WASHER,THRUST-5OD X 2-9/16ID

WLDMT PIN 1-1/2 OD X 6 LG

BUSHING CONNEX 2-3/4 X2 -1/2X2

HHCS 1/2 NC 4-1/2 PL8

HHCS 3/4 NC 2-1/2 PL8

NUT 3/4 NC HEX PL JAM

SNAP RING INTERNAL 2.775 DIA X

FITTING,GREASE STRAIGHT 1/4-28



Parts Section -64

HOSE ROUTING - 18 FT BOOM



Parts Section -65

HOSE ROUTING - 18 FT BOOM NOTES

15

16

17

18

11

12

13

14

7

8

9

10

5

6

3

4

19

20

21

22

23

24


1 02983346 1

2 02983347 1

02983348

02983349

02983531

02983532

02983350

02983351

02983352

02983353

02983533

02983534

02984267

02984268

02984833

02984834

02984835

02986007

02986008

02986009

02961085

02982334

02983079

02986797

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

DESCRIPTION

HOSE #6-6FJX-6MJ-61LG














HOSE #16-16FJX-16FJX45-54LG

HOSE #16-16FJX-16FJX45-58-1/2

HOSE #12-12FJX-12FJX45-60-1/2

HOSE #16-16FJX-16FJX90-62-1/2

HOSE #16-16FJX-16FJX90-58-3/4

HOSE #12-12FJX-12FJX-60-1/8

CORDURA SLEEVING-54 LG

CORDURA SLEEVE, 2.54ID, 10LG

SLEEVE 66" CORDURA 2.54 ID




Parts Section -66




Parts Section -67


15

16

17

18

11

12

13

14

7

8

9

10

5

6

3

4

19

20

21

22

23

24


1 02983178 1

2 02983179 1

02983180

02983181

02983182

02983183

02983503

02983504

02983184

02983185

02983186

02983187

02983499

02983500

02986107

02986108

02986109

02986004

02986005

02986006

02986798

02982334

02983079

02986797

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

DESCRIPTION















HOSE #16-16FJX-16FJX-62LG



HOSE #16-16FJX-16FJX90-69-7/8

HOSE #16-16FJX-16FJX90-65-1/2

HOSE #12-12FJX-12FJX90-69-1/8







Parts Section -68




Parts Section -69


17

18

19

20

13

14

15

16

9

10

11

12

7

8

5

6

22

23

24

25

26

2

3

4


1 02983188 1

02983189

02983190

02983191

1

1

1

02983192

02983193

02983505

02983506

02983194

02983195

02983196

02983197

02983501

02983502

02986107

02986108

02986109

02986001

02986002

02986003

02986798

02982334

02983079

02986810

02986797

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

DESCRIPTION


















HOSE #16-16FJX-16FJX90-88

HOSE #16-16FJX-16FJX90-83-5/8

HOSE #12-12FJX-12FJX90-87-1/4








Parts Section -70

HOSE ROUTING - HYDRAULIC KIT



Parts Section -71

HOSE ROUTING - HYDRAULIC KIT

Continued...

6

7

4

5

8

9

2

3


1 02981427 1

02981428

02981429

1

1

02986726

02981431

02981432

02981433

02987742

02823600

1

1

1

1

1

1

DESCRIPTION








HOSE #12-12FJX-12FJX 36LG

HOSE #4 - 4FJX - 4FJX - 28LG



Parts Section -72

HYDARULIC CYLINDER ASY - DIPPER 22-25 FT BOOM

3

4

1

2

5


02981277 1

02981925

02981926

02982250

02982251

02982068

2

2

1

1

1

DESCRIPTION

HYD CYL ASY, 4" BORE X 21.5" STROKE (22 & 25 FT BOOM)

BARREL WLDMT

ROD WLDMT

BUSHING, ROD END 1-1/2" LG

BUSHING, BARREL END 2" LG

SEAL KIT



Parts Section -73

HYDARULIC CYLINDER ASY - LIFT BOOM

4

5

2

3


02981279 1

1 02981929 1

02981930

02982250

02982251

02982068

2

1

1

2

DESCRIPTION

CYLINDER ASY, 4" BORE X 24.63" STROKE

BARREL WELDMENT

ROD WELDMENT

BUSHING, ROD END 1-1/2" LG

BUSHING, BARREL END 2" LG

SEAL KIT



Parts Section -74

HYDRAULIC CYLINDER ASY - HEAD SWIVEL (OPTIONAL)


02961480A 1

8

9

10

11

12

6

7

4

5

1

2

3

5JRC12160

33309

02975865

02975866

02975867

* SEAL KIT 1

* SEAL KIT 1

1

1

1

1

1

* SEAL KIT 1

* SEAL KIT 1

* SEAL KIT 1

-----------2

02975528 1

DESCRIPTION

DOOR CYLINDER ASY.

LOCKNUT

PISTON

ROD WLD’MT

TUBE / BARREL WLD’MT

CYLINDER HEAD

ROD WIPER SEAL (IN ITEM 12)

ROD SEAL (IN ITEM 12)

O-RING (IN ITEM 12)

SEAL (IN ITEM 12)

PISTON SEAL (IN ITEM 12)

O-RING F/ O-RING BOSS FITTING

SEAL KIT (ITEMS 6 THRU 10)



Parts Section -75

HYDRAULIC CYLINDER ASY - TILT

1

2

3


02984944 1

02986266

02986287

02982250

1

1

2

4 02986288 1

DESCRIPTION

CYLINDER, 3.5B X 1.75R X16S

BARREL WLD`MT

ROD WLD`MT

BUSHING ROD END 1-1/2" LG

SEAL KIT



Parts Section -76

HYDRAULIC TANK SUB-ASY



Parts Section -77

HYDRAULIC TANK SUB-ASY

Continued...

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

22

23

24

25

18

19

20

21

26

27

1

2


02987800 1

02981389

02981413

1

1

02985828

02968166

02964345

00012101

00002000

02981400

02981412

02968880

02987786

65108000

02963659

02041800

02825900

02823200

00753642

02958316

02981386

00015800

00011100

02982876

02982877

02982871

02963662

00011400

03101646

1

6

1

1

1

1

1

1

1

10

1

1

1

1

12

1

1

1

1

4

4

4

4

1

1

DESCRIPTION

SUB-ASY HYDRAULIC TANK

TANK, WELDMENT, HYDRAULIC

WELDMENT, COVER, CLEANOUT

FILTER, RETURN, VISUAL INDICATOR

STRAINER, SUCTION 1-1/4 WITH 3/4" OULET

STRAINER, SUCTION 2 WITH 1-1/4 OUTLET

LOCKWASHER, 3/8" PL

HHCS 3/8 NC 3/4 PL5

O-RING, CLEANOUT SEAL

SENSOR, TEMPERATURE

GAUGE, TEMP LEVEL INDICATOR

ADP, HYD ELBOW 12MP - 12MP 90

ADP, HYD ELBOW 20MP - 20MP 90

PLUG, MAGNETIC 1" NPT

ADP, HYD ELBOW 12MP - 12MJ 90

ADP, HYD 8MP - 8MJ 90

ADP, HYD 4MP - 4MJ ST

HHCS 3/8 NC 1-1/4 PL5

ADP, HYD 16MB - 12MJ ST

ASY, SHIELD FORMED


FLATWASHER 3/8 STD

PLATE FILTER ADAPTER

PIPE PLUG 3"

DRIVER SIDE COVER WELDMENT

GASKET, FILTER ASY, FIBER


LOCKWASHER 3/8



Parts Section -78

HYDRAULIC TANK W/PUMP AND ELECT VALVE ASY



Parts Section -79

HYDRAULIC TANK W/PUMP AND ELECT VALVE ASY

Continued...

30

31

32

33

26

27

28

29

34

22

23

24

25

18

19

20

21

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

1

2


02987401 1

02985829

02984219

1

1

02981468

02981463

00749103

00001800

02090800

00753642

00011100

00015800

02962181

02968896

02968894

02982469

02970702

02983892

10119000

00011700

00023500

02978986

02981369

02043600

02981435

02968167

02822700

03200587

63042700

02968922

02161400

02968923

02981437

02892000

00001300

00759635

4

4

1

1

1

1

3

1

4

4

4

1

4

1

4

1

1

4

4

1

6

1

1

1

1

1

1

1

2

1

1

1

DESCRIPTION

ASY, COMPLETE, TANK & VALVE

ASY, TANK, HYDRAULIC

ASY, VALVE & FITTINGS

PUMP, HYDROSTAT

PUMP, LS VARIABLE DISP

ADP, HYD ELBOW 16MB - 16MJ 45

ADP, HYD ELBOW 10MB - 10FJX 90

ADP, HYD 16MB - 8MJ ST


ADP, HYD. 8MB PLUG

ADP, HYD ST 12MB - 8MJ

ASY, PRESSURE FILTER HEAD


ELEMENT, PRESSURE


HHCS 1/2NC 1-1/2 LG PL8

LOCKWASHER 1/2

FLATWASHER, 1/2 HARDENED

BRACKET, SHIPPING

FLANGE, ADP 1-1/4 X 20MJIC 45

#20 SPLIT FLANGE KIT



HHCS 3/8 NC 1-1/4 PL5

FLATWASHER 3/8 STD


ADP HYD STGHT 4MB-4MJ



O-RING 4"ID X 1/16"

ADP HYD TEE 4MJ-4MJ-4FJX

PLATE, ADP, PVG32

HHCS 5/16 NC 1 PL5

LOCKWASHER 5/16 PL STD

FLATWASHER 5/16, TYPE AW, ZP



Parts Section -80

JOYSTICK CONSOLE ASY



Parts Section -81

JOYSTICK CONSOLE ASY

Continued...

10

11

12

13

9

9A

9B

7

8

5

6

3

3A

4

4A

18

19

20

21

14

15

16

17

22

23

1

2


02987829 1

02981020

02981021

1

1

02981032

02981033

02981030

02977644

02977043

02983475

02983476

02983477

02983478

02963584

02987905

02981022

02983472

02981023

02983473

02981024

02981025

02981026

02981027

02977642

02977645

02977646

02977643

02981028

02981029

02981031

2

8

1

1

1

1

1

1

8

1

1

1

1

1

1

1

17

4

1

1

1

1

2

2

2

2

DESCRIPTION

JOYSTICK ASSEMBLY W/ COMPONENTS

LED RED 12VDC

DECAL JOYSTICK OPERATION CNSLE

SWITCH MOMNTRY PUSHBUTTON RED

PUSH BOTTOM CAP RED

SWITCH MOMNTRY PUSHBUTTON BLK

BOTTON COVER BLACK

SOCKET RELAY

RELAY SPDT 12VDC 20A

CIRCUIT BREAKER 10A PANEL MNT

BOOT CIRCUIT BREAKER COVER

CONNECTOR RECEPTACLE

PIN, 16-18 AWG

PIN, 12AWG

NUT, PANEL - 24 SHELL SIZE

SWITCH PUSH PULL

JOYSTICK ASSEMBLY

HANDLE ASSEMBLY

DECAL SWITCH OPERATION HANDLE

ASSEMBLY PUSHBUTTON FACE PLATE

SWITCH MOMENTARY PUSHBUTTON

LOCKWASHER - 24 SHELL SIZE

SWITCH ROCKER DPDT W/GREEN LED

POTENTIOMETER - SWING

POTENTIOMETER - LIFT & DIPPER

MACHINE SCREW #10-32 5/8 LG.

WASHER #10 NYLON

LOCKNUT 8-32 PL

TRIGGER SWITCH



Parts Section -82

PUMP ASY - SERVO CONTROLLED (PART 1)



Parts Section -83


Continued...

34

35

36

37

30

31

32

33

26

27

28

29

22

23

24

25

42

43

44

38

39

40

41

18

19

20

21

14

16

17

9

10

11

12

7

8

4

6

2

3


02969527A 1

02977418

02977419

1

1

02977525

02977434

02977436

02977437

02970208

02977439

02977440

02977526

02977527

02977528

02977529

02977530

02977531

02977532

02977533

02977534

02977420

02977421

02977422

02977423

02977424

02977425

02977426

02977427

02977428

02970209

02977430

02977431

02977432

02977433

02977434

02977535

02977441

02977536

02977537

02977325

02977551

02977442

1

2

2

1

1

1

1

1

1

1

6

1

2

2

2

1

1

1

1

1

1

2

1

1

2

1

2

1

1

1

1

2

1

1

8

1

2

1

DESCRIPTION

PISTON PUMP ASY, SERVO CONTROLLED

JAM NUT

RETAINING RING

RETAINING RING

SEAL WASHER

BOLT

ROTATING ASY

SERVO PISTON SUB-ASY

FOLLOWER, SERVO PISTON

COVER PLATE

GASKET, F/ COVER PLATE

GASKET, F/ HOUSING

GASKET, F/ CONTROL HOUSING

COVER PLATE

CAM PLATE SUB-ASY

RACE, THRUST

BEARING, THRUST

RELIEF VALVE SUB-ASY

O-RING

RELIEF VALVE SUB-ASY

BOLT

BOLT

BOLT

PLATE, VALVE

HOUSING, SUB-ASY

HOUSING

BEARING

PLUG, SUB-ASY

O-RING

CRADLE, SUB-ASY

DOWEL BUSHING

BUSHING

BOLT, BUTTON HEAD

BOLT

SEAL SUB-ASY

BACK PLATE SUB-ASY

BEARING, PRESS FIT

ROLL PIN

SHAFT, SPLINED DRIVE

KIT, A-FLANGE COVER PLATE

O-RING



Parts Section -84




Parts Section -85


Continued...

-

75

76

77

78

79

69

72

73

74

65

66

67

68

61

62

63

64

58

59

60

52

53

54

57

48

49

50

51


45 02977444 2

46

47

02977449

02977443

1

1

80

02977548

02970207

02977451

02977452

02977453

02977456

02977457

02977458

02977459

02977460

02977461

02977462

02972835

02983257

02972836

02983256

02977086

02977445

02977446

02977538

02977540

02977541

02977447

02977539

02977448

02977199

-----------

02977543

02977544

02977545

02977546

02977547

1

1

1

1

4

1

1

8

1

2

1

3

1

1

1

1

1

1

1

1

1

1

1

1

2

1

1

2

1

1

1

1

DESCRIPTION

BOLT

PLATE, COVER

O-RING

WASHER

PLUG SUB-ASY

O-RING

PLUG

O-RING

PLUG

O-RING

KEY

SEAL, SHAFT

CHARGE PUMP ADAPTER SUB-ASY

BUSHING, PRESS FIT, W/ 11 TOOTH SHAFT

PLUG

O-RING

SHIM

SPRING

POPPET

2 POSITION SERVO CONTROL SUB-ASY

GEROTOR, INNER RING

GEROTOR, OUTER RING

ORIFICE, CONTROL VALVE

COUPLER

RETAINING RING

PLUG SUB-ASY

WASHER

WASHER

WASHER

RING LOCK (NOT SHOWN)

CARTRIDGE VALVE ASY, W/O COIL - F/COILS W/RND METAL HSG (UNITS SHIPPED JUNE 2005 & UP)

CARTRIDGE VALVE ASY, W/O COIL - F/COILS W/SQ PLASTIC HSG (UNITS SHIPPED MAY 2005 & DOWN)

COIL ASY, COIL W/RND METAL HSG (UNITS SHIPPED JUNE 2005 & UP)

COIL ASY, COIL W/SQ PLASTIC HSG (UNITS SHIPPED MAY 2005 & DOWN)

SEAL KIT - PUMP



Parts Section -86

PUMP-TANK-VALVE COVER

-


1 02981381 1

02981441

02986111

00001000

2

3.3

2

DESCRIPTION

ASY, PUMP COVER

KNOB 3/8NC X 1-1/2 STUD

CABLE, PUMP COVER 36" LG

CABLE CLAMP



Parts Section -87




Parts Section -88

VALVE ASSEMBLY - ELECTRO-HYDRAULIC VALVE



Parts Section -89

VALVE ASSEMBLY - ELECTRO-HYDRAULIC VALVE

Continued...

14

15

16

17

11

12

13

7

8

9

10

5

6

3

4

1

2

-


02984219 1

02971378

02090800

1

2

02972179

02976532

02972177

02972113

02975438

00696800

02969398

02972209

02972210

02969399

02968850

02976531

02972178

02972208A

02822300

1

1

7

1

1

1

4

2

1

1

1

3

5

2

2

DESCRIPTION

ASY VALVE CCLS 5 SPOOL

VALVE, PVG32





ADP, HYD 10MB - 8FB

ADP, HYD STGHT 8FJX-8MB

ADP HYD STGHT 8MB-8MJ 90°

ORIFICE, .055 RESTRICTOR




ADP, HYD ST 8MB-6MJ

ADP HYD ELBOW 6MJ-6FJX 45


ASY, VALVE SOLENOID

ADP, HYD ST 8MB-4MJ



Parts Section -90

WIRE HARNESS ELECT-HYD VALVE



Parts Section -91

WIRE HARNESS ELECT-HYD VALVE

Continued...


1 02984735 1

DESCRIPTION

ASY, HARNESS, MACHETE



Parts Section -92


Limited Warranty

1. LIMITED WARRANTIES

1.01.

Alamo Industrial warrants for one year from the purchase date to the original non-commercial, governmental, or municipal purchaser (“Purchaser”) and warrants for six months to the original commercial or industrial purchaser

(“Purchaser”) that the goods purchased are free from defects in material or workmanship.

1.02.

1.03.

Manufacturer will replace for the Purchaser any part or parts found, upon examination at one of its factories, to be defective under normal use and service due to defects in material or workmanship.

This limited warranty does not apply to any part of the goods which has been subjected to improper or abnormal use, negligence, alteration, modification, or accident, damaged due to lack of maintenance or use of wrong fuel, oil, or lubricants, or which has served its normal life. This limited warranty does not apply to any part of any internal combustion engine, or expendable items such as blades, shields, guards, or pneumatic tires except as specifically found in your Operator’s Manual.

1.04.

Except as provided herein, no employee, agent, Dealer, or other person is authorized to give any warranties of any nature on behalf of Manufacturer.

2. REMEDIES AND PROCEDURES.

2.01.

This limited warranty is not effective unless the Purchaser returns the Registration and Warranty Form to Manufacturer within 30 days of purchase.

2.02.

2.03.

2.04.

Purchaser claims must be made in writing to the Authorized Dealer (“Dealer”) from whom Purchaser purchased the goods or an approved Authorized Dealer (“Dealer”) within 30 days after Purchaser learns of the facts on which the claim is based.

Purchaser is responsible for returning the goods in question to the Dealer.

If after examining the goods and/or parts in question, Manufacturer finds them to be defective under normal use and service due to defects in material or workmanship, Manufacturer will:

(a) Repair or replace the defective goods or part(s) or

(b) Reimburse Purchaser for the cost of the part(s) and reasonable labor charges (as determined by Manufacturer)

if Purchaser paid for the repair and/or replacement prior to the final determination of applicability of the warranty

by Manufacturer.

2.05.

cost for the goods or part(s) from the Dealer to the designated factory.

3. LIMITATION OF LIABILITY.

3.01.

MANUFACTURER DISCLAIMS ANY EXPRESS (EXCEPT AS SET FORTH HEREIN) AND IMPLIED WARRANTIES

WITH RESPECT TO THE GOODS INCLUDING, BUT NOT LIMITED TO, MERCHANTABILITY AND FITNESS

FOR A PARTICULAR PURPOSE.

3.02.

The choice of remedy shall belong to Manufacturer.

Purchaser is responsible for any labor charges exceeding a reasonable amount as determined by Manufacturer and for returning the goods to the Dealer, whether or not the claim is approved. Purchaser is responsible for the transportation

3.03.

MANUFACTURER MAKES NO WARRANTY AS TO THE DESIGN, CAPABILITY, CAPACITY, OR SUITABILITY FOR

USE OF THE GOODS.

EXCEPT AS PROVIDED HEREIN, MANUFACTURER SHALL HAVE NO LIABILITY OR RESPONSIBILITY TO

PURCHASER OR ANY OTHER PERSON OR ENTITY WITH RESPECT TO ANY LIABILITY, LOSS, OR DAMAGE

CAUSED OR ALLEGED TO BE CAUSED DIRECTLY OR INDIRECTLY BY THE GOODS INCLUDING, BUT NOT

LIMITED TO, ANY INDIRECT, SPECIAL, CONSEQUENTIAL, OR INCIDENTAL DAMAGES RESULTING FROM

THE USE OR OPERATION OF THE GOODS OR ANY BREACH OF THIS WARRANTY. NOT WITHSTANDING THE

3.04.

4.04.

ABOVE LIMITATIONS AND WARRANTIES, MANUFACTURER’S LIABILITY HEREUNDER FOR DAMAGES

INCURRED BY PURCHASER OR OTHERS SHALL NOT EXCEED THE PRICE OF THE GOODS.

NO ACTION ARISING OUT OF ANY CLAIMED BREACH OF THIS WARRANTY OR TRANSACTIONS UNDER

THIS WARRANTY MAY BE BROUGHT MORE THAN TWO (2) YEARS AFTER THE CAUSE OF ACTION HAS

OCCURRED.

4. MISCELLANEOUS.

4.01.

Proper Venue for any lawsuits arising from or related to this limited warranty shall be only in Guadalupe County,

Texas.

4.02.

Manufacturer may waive compliance with any of the terms of this limited warranty, but no waiver of any terms shall be deemed to be a waiver of any other term.

4.03.

If any provision of this limited warranty shall violate any applicable law and is held to be unenforceable, then the invalidity of such provision shall not invalidate any other provisions herein.

Applicable law may provide rights and benefits to purchaser in addition to those provided herein.

KEEP FOR YOUR RECORDS

ATTENTION: Purchaser should fill in the blanks below for his reference when buying repair parts and/or for proper machine identification when applying for warranty.

Alamo Industrial Implement Model ____________________________ Serial Number ________________________________

Date Purchased __________________________________________ Dealer ______________________________________

ATTENTION:

READ YOUR OPERATOR’S MANUAL


1502 E. Walnut

Seguin, Texas 78155

830-379-1480

TO THE OWNER/OPERATOR/DEALER

To keep your implement running efficiently and safely, read your manual thoroughly and follow these directions and the Safety Messages in this Manual. The Table of Contents clearly identifies each section where you can easily find the information you need.

The OCCUPATIONAL SAFETY AND HEALTH ACT (1928.51 Subpart C) makes these minimum safety requirements of tractor operators:

REQUIRED OF THE OWNER:

1. Provide a Roll-Over-Protective Structure that meets the requirements of this Standard; and

2. Provide Seatbelts that meet the requirements of this paragraph of this Standard and SAE J4C; and

3. Ensure that each employee uses such Seatbelt while the tractor is moving; and

4. Ensure that each employee tightens the Seatbelt sufficiently to confine the employee to the protected area provided by the ROPS.

REQUIRED OF THE OPERATOR

1. Securely fasten seatbelt if the tractor has a ROPS.

2. Where possible, avoid operating the tractor near ditches, embankments, and holes.

3. Reduce speed when turning, crossing slopes, and on rough, slick, or muddy surfaces.

4. Stay off slopes too steep for safe operation.

5. Watch where you are going - especially at row ends, on roads, and around trees.

6. Do not permit others to ride.

7. Operate the tractor smoothly - no jerky turns, starts, or stops.

8. Hitch only to the drawbar and hitch points recommended by the tractor manufacturer.

9. When the tractor is stopped, set brakes securely and use park lock, if available.

Keep children away from danger all day, every day...

Equip tractors with rollover protection (ROPS) and keep all machinery guards in place...

Please work, drive, play and live each day with care and concern for your safety and that of your family and fellow citizens.

Machete 2 HF Pub 11-08

Printed U.S.A

P/N 02986941P

Alamo MACHETE2 02986941P Operators Manual

PART'S MANUAL

Boom Arm Mower

ALAMO INDUSTRIAL

TO THE OWNER/OPERATOR/DEALER

DANGER

PARTS

SECTION

PARTS ORDERING GUIDE

ALAMO INDUSTRIAL

TO THE OWNER/OPERATOR/DEALER

Related manuals

Table of contents

Alamo MACHETE2 02986941P Operators Manual

PART'S MANUAL

Boom Arm Mower

ALAMO INDUSTRIAL

TO THE OWNER/OPERATOR/DEALER

DANGER

PARTS

SECTION

PARTS ORDERING GUIDE

ALAMO INDUSTRIAL

TO THE OWNER/OPERATOR/DEALER

Related manuals

Alamo

AXTREME2 02988075P

Alamo

SAMURAI 02986950P

Alamo

MACHETE 02968915P

Alamo Industrial

Axtreme FC-P-0002

Alamo

02981992P

Alamo Industrial

Maverick Boom Arm Mower

Alamo

02968915P

Alamo

Maverick Boom Arm Mower

Table of contents