APW DWC13-N Installation and Operating Instructions

Add to my manuals
4 Pages

advertisement

APW DWC13-N Installation and Operating Instructions | Manualzz

R

INSTALLATION AND OPERATING INSTRUCTIONS

Model:

DWC13-N

HEATED CABINET

INTENDED FOR OTHER THAN HOUSEHOLD USE

RETAIN THIS MANUAL FOR FUTURE REFERENCE

UNIT MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES

!

WARNING: Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death. Read the Installation, Operating and

Maintenance Instructions thoroughly before installing or servicing this equipment.

!

This equipment has been engineered to provide you with year-round dependable service when used according to the instructions in this manual and standard commercial kitchen practices.

P/N 66940 9/05

Phone: +1

Fax:

(214) 421-7366

+1 (214) 565-0976

Toll Free: +1 (800) 527-2100

Website: www.apwwyott.com

E-mail: [email protected]

APW WYOTT

729 Third Avenue

Dallas, TX 75226

1

1.

2.

3.

4.

1.

2.

3.

4.

5.

1.

2.

3.

4.

5.

6.

7.

INSTALLATION INSTRUCTIONS

UNPACK. There should be one cabinet and two shelves.

Check for loose or damaged parts.

Plug the unit into a 120V outlet.

Check to see that the light turns on and that the unit heats up.

OPERATING INSTRUCTIONS

Knob Setting

Turn on unit.

Set dial to "5” (see "KNOB SETTING" diagram).

Let warm up for 1 hour.

Thermometer should be between 115°F and 120°F.

If you need more heat, turn up the knob (e.g. to “6”). For less heat, turn it down (e.g. to “4”).

Use only for Nestlé pre-baked cookies. Do not use this cabinet with potentially hazardous foods.

This cabinet is not a food warmer and will not keep food at high enough temperature (140°F) to meet standard sanitation requirements for many foods.

When done, turn off unit.

DAILY CLEANING INSTRUCTIONS

Turn unit off and unplug the unit from the power outlet.

Doors may be removed for cleaning.

Clean the cabinet with soapy water and a soft cloth. Do not use chemicals such as ammonia, alcohol, or chlorine to clean the cabinet. The door and sides are made of plastic, and these chemicals will cause cracking. The plastic sides are easily scratched, so be sure to use something soft to wash them.

DO NOT IMMERSE CABINET IN WATER. DO NOT JET SPRAY CABINET. DO NOT PUT

CABINET INADISHWASHER.

The shelves are stainless steel, and may be machine washed.

SPECIFICATIONS

POWER: 120V, 120W, 60HZ

OVERALLDIMENSIONS: 12 3/4” Wide x 12 3/4” Deep x 20 1/2" High

INSIDE DIMENSIONS:

CORDSET:

APPROVALS:

12" Wide x 12 1/4” Deep x 11 5/8" High

NEMA5-15P Plug, 5 Feet, 3 GROUNDED WIRE CORD

ULListed (Canada & US), ULEPH (NSF 4)

REPLACEMENT PARTS LIST

ITEM PART NUMBER

7

7a

7b

8

8a

9

9a

1

2

3

5

6

4

4a

66922

75617

75916

89165

89029

66931

66923

66937

88984

88856

66933

88993

66936

88854

DESCRIPTION

Stainless Steel Shelf

Adjustment Knob (0-9)

Light Bulb, Coated (120V, 40W)

Door Knob

Screw for Door Knob

Door

Striker Plate (for Door Magnet)

Door Hinge

Screw for Door Hinge

Screw for Frame Hinge

Shelf Rod

Shelf Rod Screws

Door Magnet

Screw for Door Magnet

2

(Need 1/ea)

(Need 2/ea)

(Need 2/ea)

(Need 2/ea)

Notes:

3

APW WYOTT EQUIPMENT LIMITED WARRANTY

APW Wyott Foodservice Equipment Company warrants it's equipment against defects in materials and workmanship, subject to the following conditions:

This warranty applies to the original owner only and is not assignable.

Should any product fail to function in its intended manner under normal use within the limits defined in this warranty, at the option of

APW Wyott such product will be repaired or replaced by APW Wyott or its Authorized Service Agency. APW Wyott will only be responsible for charges incurred or service performed by its Authorized Service Agencies. The use of other than APW Wyott

Authorized Service Agencies will void this warranty and APW Wyott will not be responsible for such work or any charges associated with same. The closestAPW WyottAuthorized ServiceAgent must be used.

This warranty covers products shipped into the 48 contiguous United States, Hawaii, metropolitan areas of Alaska and Canada. There will be no labor coverage for equipment located on any island not connected by roadway to the mainland.

Warranty coverage on products used outside the 48 contiguous United States, Hawaii, and metropolitan areas of Alaska and Canada may vary. Contact the international APW Wyott distributor, dealer, or service agency for details.

Time Period

One year for parts and one year for labor, effective from the date of purchase by the original owner. The Authorized Service Agency may, at their option, require proof of purchase. Parts replaced under this warranty are warranted for the un-expired portion of the original product warranty only.

Exceptions

*Gas/Electric Cookline:

*Broiler Briquettes,

*Heat Strips:

Models GCB, GCRB, GF, GGM, GGT, CHP-H, EF, EG, EHP. Three (3) Year Warranty on all component parts, except switches and thermostats. (2 additional years on parts only. No labor on second or third year.)

Rock Grates, Cooking Grates, Burner Shields, Fireboxes: 90 Day Material Only. No Labor.

Models FD, FDL, FDD, FDDL. Two (2)Year Warranty on element only. No labor second year.

*Glass Windows, Doors, Seals, Rubber Seals, Light Bulbs: 90 Day Material Only. No Labor.

In all cases, parts covered by extended warranty will be shipped FOB the factory after the first year.

Portable Carry In Products

Equipment weighing over 70 pounds or permanently installed will be serviced on-site as per the terms of this warranty. Equipment weighing 70 pounds or under, and which is not permanently installed, i.e. with cord and plug, is considered portable and is subject to the following warranty handling limitations. If portable equipment fails to operate in its intended manner on the first day of connection, or use, atAPW Wyott's option or itsAuthorized ServiceAgency, it will be serviced on site or replaced.

From day two through the conclusion of this warranty period, portable units must be taken to or sent prepaid to the APW Wyott

Authorized ServiceAgency for in-warranty repairs. No mileage or travel charges are allowed on portable units after the first day of use.

If the customer wants on-site service, they may receive same by paying the travel and mileage charges. Exceptions to this rule: (1) countertop warmers and cookers, which are covered under the Enhanced Warranty Program, and (2) toasters or rollergrills which have in store service.

Exclusions

The following conditions are not covered by warranty:

*Equipment failure relating to improper installation, improper utility connection or supply and problems due to ventilation.

*Equipment that has not been properly maintained, calibration of controls, adjustments, damage from improper cleaning and water damage to controls.

*Equipment that has not been used in an appropriate manner, or has been subject to misuse or misapplication, neglect, abuse, accident, alteration, negligence, damage during transit, delivery or installation, fire, flood, riot or act of god.

*Equipment that has the model number or serial number removed or altered.

If the equipment has been changed, altered, modified or repaired by other than an Authorized Service Agency during or after the warranty period, then the manufacturer shall not be liable for any damages to any person or to any property, which may result from the use of the equipment thereafter.

This warranty does not cover services performed at overtime or premium labor rates. Should service be required at times which normally involve overtime or premium labor rates, the owner shall be charged for the difference between normal service rates and such premium rates.APW Wyott does not assume any liability for extended delays in replacing or repairing any items beyond its control.

In all cases, the use of other thanAPW WyottAuthorized OEM Replacement Parts will void this warranty.

This equipment is intended for commercial use only. Warranty is void if equipment is installed in other than commercial application.

Water Quality Requirements

Water supply intended for a unit that has in excess of 3.0 grains of hardness per gallon (GPG) must be treated or softened before being used. Water containing over 3.0 GPG will decrease the efficiency and reduce the operation life of the unit.

Note: Product failure caused by liming or sediment buildup is not covered under warranty.

“THE FOREGOING WARRANTY IS IN LIEU OF ANY AND ALL OTHER WARRANTIES EXPRESSED OR IMPLIED

INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR PARTICULAR PURPOSES

AND CONSTITUTES THE ENTIRE LIABILITY OF APW WYOTT. IN NO EVENT DOES THE LIMITED WARRANTY

EXTEND BEYOND THE TERMS STATED HEREIN.”

9/05

4

advertisement

Was this manual useful for you? Yes No
Thank you for your participation!

* Your assessment is very important for improving the workof artificial intelligence, which forms the content of this project

Related manuals

Download PDF

advertisement