Gestek GESTEK Gestek Gestek GESTEK Gestek estek GESTEK

Certificate of Test
March 2008
Quanta Computer
Inc.
Gestek
GESTEK
Gestek
Gestek GESTEK Gestek
estek GESTEK Gestek GEST
stek GESTEK Gestek GESTE
tek GESTEK Gestek GESTEK
ek GESTEK Gestek GESTEK
k GESTEK Gestek GESTEK
GESTEK Gestek GESTEK
Product Type
: Server
Model Number
: QR2-2700, QSSC-680
Brand Name
: Quanta
Test Report Number
: 0712109F-01
Date of Test
: February 21, 2008-February 25, 2008
This Product was tested to the following standards at the laboratory
of Global EMC Standard Tech. Corp., and found Compliance.
Standards:
FCC CFR 47, Part 15 Subpart B / CISPR 22 3rd Edition: 1997, Class A
ANSI C63.4: 2003
Canadian ICES-003
http : //www.gestek.com.tw
GesTek EMC Lab
Sharon Chang, President
N0. 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen,
Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
TEL:886-2-2603-5321
FAX:886-2-2603-5325
Date: March 18, 2008
NVLAP LAB CODE 200085-0
Certificate
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
Test Report
Application for
Verification
On Behalf Of
Quanta Computer Inc.
EUT: Server
Model Number: QR2-2700, QSSC-680
Prepared for:
Quanta Computer Inc.
No.188, Wen Hwa 2nd Rd., Kuei Shan Hsiang, Tao Yuan, Taiwan, R.O.C.
Report By :
Global EMC Standard Tech. Corp.
No.3 Pau-Tou-Tsuo Valley, Chia-Pau
Tsuen, Lin Kou Hsiang, Taipei County,
Taiwan, R.O.C.
Tel : 886-2-2603-5321
Fax : 886-2-2603-5325
Test results given in this report only relate to the specimen(s) tested, calibrated or measured.
This report shall not be reproduced other than in full without the written consent of Gestek.
This report must not be use to claim product endorsement by any agency of the U.S. Government.
All data in this report are traceable to national standard or international standard.
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 1 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
TABLE OF CONTENTS
DESCRIPTION
PAGE
1.
CERTIFICATION..................................................................................................... 3
2.
SUMMARY OF TEST RESULTS ............................................................................ 4
3.
GENERAL INFORMATION..................................................................................... 5
3.1
3.2
3.3
3.4
3.5
3.6
4.
PRODUCTION DESCRIPTION ............................................................................... 5
TEST MODES & EUT COMPONENTS DESCRIPTION ......................................... 6
CONFIGURATION OF THE TESTED SYSTEM ................................................... 10
BLOCK DIAGRAM OF CONNECTIONS BETWEEN EUT AND SIMULATORS .. 12
TEST METHODOLOGY ........................................................................................ 13
TEST FACILITY..................................................................................................... 13
CONDUCTED EMISSION MEASUREMENT ........................................................ 14
4.1
4.2
4.3
4.4
4.5
4.6
4.7
5.
TEST EQUIPMENTS............................................................................................. 14
BLOCK DIAGRAM OF TEST SETUP ................................................................... 14
CONDUCTED EMISSION LIMIT ........................................................................... 15
EUT CONFIGURATION ON MEASUREMENT ..................................................... 15
CONDUCTED EMISSION DATA .......................................................................... 15
OPERATING CONDITIONS OF THE EUT............................................................ 16
CONDUCTED EMISSION MEASUREMENT RESULTS...................................... 17
RADIATED EMISSION MEASUREMENT ............................................................ 21
5.1
5.2
5.3
5.4
5.5
5.6
5.7
6.
TEST EQUIPMENT ............................................................................................... 21
OPEN TEST SITE SETUP DIAGRAM .................................................................. 21
RADIATED EMISSION LIMIT................................................................................ 22
EUT CONFIGURATION ........................................................................................ 22
OPERATING CONDITION OF EUT ...................................................................... 23
RADIATED EMISSION DATA ............................................................................... 23
RADIATED EMISSIONS MEASUREMENT RESULTS ......................................... 24
PHOTOGRAPHS FOR TEST................................................................................ 28
6.1
6.2
TEST PHOTOGRAPHS FOR CONDUCTION....................................................... 28
TEST PHOTOGRAPHS FOR RADIATED............................................................. 29
7.
PHOTOGRAPHS FOR PRODUCT ....................................................................... 30
8.
EMI/EMS REDUCTION METHOD DURING COMPLIANCE TESTING................ 33
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 2 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
1.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
CERTIFICATION
Applicant
: Quanta Computer Inc.
EUT Description
Model Number
Brand Name
Serial Number
Tested Power Supply
: Server
: QR2-2700, QSSC-680
: Quanta
: N/A
: 120Vac/60Hz
MEASUREMENT PROCEDURES USED:
; CFR 47, Part 15
Radio Frequency Device Subpart B Unintentional Radiators Class A
rd
; CISPR 22 3 Edition:1997 Limits and methods of measurement of radio disturbance Characteristics
of information technology equipment: 1997
; ANSI C63.4
Methods of Measurements of Radio-Noise Emissions from Low- Voltage
Electrical and Electronic Equipment in the range of 9kHz To 40GHz:2003
; Canadian ICES-003
Implementation and Interpretation off the Interference-Causing
Equipment Standard for Digital Apparatus, ICES-003
THE MEASUREMENT SHOWN IN THE ATTACHMENT WAS MADE IN ACCORDANCE WITH
THE PROCEDURES INDICATED, AND THE MAXIMUM ENERGY EMITTED BY THE
EQUIPMENT WAS FOUND TO BE WITHIN THE ABOVE LIMITS APPLICABLE.
NVLAP LAB CODE 200085-0
Date of Test: February 21, 2008-February 25, 2008
In order to ensure the quality and accuracy of this document, the contents have been thoroughly
reviewed by the following qualified personnel from GesTek Lab.
Documented By :
Tested By :
Rini Chen / adm. Dept. Supervisor
Sky Chuang / eng. Dept. Engineer
Approved By :
Tonny Lin / General Manager
This test data shown below is traceable to National or international standard such as NIST/USA,
etc. The laboratory’s NVLAP accreditation in no way constitutes or implies product certification,
approval, or endorsement by NVLAP or the United States government.
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 3 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
2.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
SUMMARY OF TEST RESULTS
The Worst Emission data was found as following
TEST
STANDARD
TEST ITEM
RESULT
Conducted emission
(Mode 7)
(1)FCC Part 15
(2)CISPR 22 3rd
Edition:1997
(3)Canadian
ICES-003.
Class A
Radiated emission
(Mode 7)
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
REMARKS
PASS
The worst emission frequency is 2.0222 MHz.
And minimum passing margin is –18.72 dB.
The measurement uncertainty is 3.6 dB.
PASS
The worst emission frequency is 666.6803 MHz at
Vertical.
And minimum passing margin is –4.37 dB.
Height of antenna is 3.0 M.
Angle of turntable is 75°.
The measurement uncertainty is 5.1 dB.
Page 4 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
3.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
GENERAL INFORMATION
3.1 PRODUCTION DESCRIPTION
Product Name
Model Number
Brand Name
Serial Number
Applicant
Address
Manufacturer
Address
Power Supply
Power Cord
:
:
:
:
:
:
:
Server
QR2-2700, QSSC-680
Quanta
N/A
Quanta Computer Inc.
No.188, Wen Hwa 2nd Rd., Kuei Shan Hsiang, Tao Yuan, Taiwan, R.O.C.
1. Tech-Front (Shanghai) Computer Co., Ltd.
2. Quanta Manufacturing Nashville LCC
3. Tech-Com (Shanghai) Computer Co., Ltd.
: 1. No. 2, Lane 58, Sanzhuang Road, Songjiang Export Processing Zone,
Shanghai 201613, P. R. China
2. 1621 Heil Quaker Blvd., LaVergne TN 37086, USA
3. No. 68, Sanzhuang Road, Songjiang Export Processing Zone, Shanghai,
201613, P.R. China
: AC Input:100-127V~11.0A, 200-240V~5.5A,
DC Output:750W
: 3pins, 1.8m, Non-Shielded, Non-Core
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 5 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
3.2 TEST MODES & EUT COMPONENTS DESCRIPTION
Test Mode
Mode 1-Pre Scan Mode
Mode 2-Pre Scan Mode
CPU
Intel Harpertown 2.8G*2
Memory
Qimonda 2G*8
HDD
Hitachi 750G*8
Seagate 146G*8
Gigabit LAN*2
On Board (10/100/1000 Mbps)
LAN*1
S.P.S.
On Board (10/100 Mbps)
Quanta,
M/N: QME-2200, QSSC-680MB, P/N: 10-L SAS 21S87MB0000
Delta, M/N: DPS-750EB B, BSMI ID: R33030
Resolution
1280 x 1024, V-Sync: 75Hz
Mother Board
Test Mode
Mode 3-Pre Scan Mode
Mode 4-Pre Scan Mode
CPU
Intel Harpertown 2.8G*2
Memory
Qimonda 2G*8
HDD
Seagate 750G*8
Hitachi 750G*8
Gigabit LAN*2
On Board (10/100/1000 Mbps)
LAN*1
On Board (10/100 Mbps)
Mother Board
S.P.S.
Resolution
Test Mode
Quanta,
Quanta,
M/N: QME-2200, QSSC-680MB,
M/N: QME-2200, QSSC-680MB,
P/N: 8-L SAS 21S87MB0080 PCI
P/N: 10-L SAS 21S87MB0000
SLOT
Delta, M/N: DPS-750EB B, BSMI ID: R33030
1280 x 1024, V-Sync: 75Hz
Mode 5-Pre Scan Mode
Mode 6-Pre Scan Mode
CPU
Intel Harpertown 2.8G*2
Memory
Qimonda 2G*8
HDD
Hitachi 750G*8
Hitachi 750G*6
Gigabit LAN*2
On Board (10/100/1000 Mbps)
LAN*1
On Board (10/100 Mbps)
S.P.S.
Quanta,
Quanta,
M/N: QME-2200, QSSC-680MB,
M/N: QME-2200, QSSC-680MB,
P/N: 8-L SAS 21S87MB0060 NO P/N: 10-L SATA 21S87MB0020
PCI SLOT
NO PCI SLOT
Delta, M/N: DPS-750EB B, BSMI ID: R33030
Resolution
1280 x 1024, V-Sync: 75Hz
Mother Board
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 6 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Test Mode
Mode 7-Test Mode
Tel:886-2-2603-5321 Fax:886-2-2603-5325
Mode 8-Pre Scan Mode
CPU
Intel Harpertown 2.8G*2
Memory
Qimonda 2G*8
HDD
Hitachi 750G*6
Gigabit LAN*2
On Board (10/100/1000 Mbps)
LAN*1
On Board (10/100 Mbps)
S.P.S.
Quanta,
Quanta,
M/N: QME-2200, QSSC-680MB,
M/N: QME-2200, QSSC-680MB,
P/N: 8-L SATA 21S87MB0090
P/N: 8-L SATA 21S87MB0070
PCI SLOT
NO PCI SLOT
Delta, M/N: DPS-750EB B, BSMI ID: R33030
Resolution
1280 x 1024, V-Sync: 75Hz
Mother Board
Test Mode
CPU
Memory
Mode 9- Pre Scan Mode
Mode 10-Pre Scan Mode
Intel Harpertown 2.8G*2
Apacer 1G*8
Kingston 2G*4 Samsung 1G*4
HDD
Hitachi 750G*6
Gigabit LAN*2
On Board (10/100/1000 Mbps)
LAN*1
On Board (10/100 Mbps)
S.P.S.
Quanta,
Quanta,
M/N: QME-2200, QSSC-680MB,
M/N: QME-2200, QSSC-680MB,
P/N: 8-L SATA 21S87MB0090
P/N: 8-L SATA 21S87MB0090
PCI SLOT
PCI SLOT
Delta, M/N: DPS-750EB B, BSMI ID: R33030
Resolution
1280 x 1024, V-Sync: 75Hz
Mother Board
Test Mode
Mode 11- Pre Scan Mode
Mode 12-Pre Scan Mode
CPU
Woodcrest 3.0GHz*2
Intel Harpertown 2.8G*2
Memory
Qimonda 2G*8
HDD
Hitachi 750G*6
Gigabit LAN*2
On Board (10/100/1000 Mbps)
LAN*1
On Board (10/100 Mbps)
Mother Board
S.P.S.
Resolution
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Quanta,
Quanta,
M/N: QME-2200, QSSC-680MB,
M/N: QME-2200, QSSC-680MB,
P/N: 8-L SATA 21S87MB0090
P/N: 8-L SATA 21S87MB0090
PCI SLOT
PCI SLOT
Delta, M/N: DPS-750EB B, BSMI ID: R33030
1280 x 1024, V-Sync: 75Hz
Page 7 of 35
NVLAP Lab Code:200085-0
1024 x 768, V-Sync: 75Hz
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
Test Mode
Mode 13- Pre Scan Mode
CPU
Intel Harpertown 2.8G*2
Memory
Qimonda 2G*8
HDD
Hitachi 750G*6
Gigabit LAN*2
On Board (10/100/1000 Mbps)
LAN*1
S.P.S.
On Board (10/100 Mbps)
Quanta, M/N: QME-2200, QSSC-680MB,
P/N: 8-L SATA 21S87MB0090 PCI SLOT
Delta, M/N: DPS-750EB B, BSMI ID: R33030
Resolution
800 x 600, V-Sync: 75Hz
Mother Board
Note:
1.According to pre-scan data, we determine the data (Mode 7) shown in this test report,
which reflects the worst-case data for each operation mode.
2.The EUT has two model numbers, because of the requirement of marketing.
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 8 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
Keypart list
Item
Mother Board
Vendor
Quanta
Model Number
21S87MB0000
Part Number
21S87MB0020
10-L SAS
10-L SATA
21S87MB0080
8-L SAS PCI(e) SLOT
21S87MB0060
8-L SAS NO PCI(e) SLOT
21S87MB0090
8-L SATA PCI(e) SLOT
21S87MB0070
8-L SATA NO PCI(e) SLOT
Riser Board
Quanta
22S87RB0000
HDD BP
Quanta
22S58HB0020
CD-R BP
Quanta
3AS29CB0009
Front Panel
Quanta
27S58PB0008
CPU
Intel
Harpertown 2.8G FSB:1600MHz
12MB Dual771 Stepping C0 Wott
80W
Woocrest, 3.0GHz FSB:1333MHz
4MB Stepping G0 Wott65W
Memory
HDD
Apacer
1GB/667 FB-DIMM AP1024QTFE667
Kingston
2GB/FB-DIMM DGM431NABINTD1F
Samsung
1GB/FB-DIMM M395T2953CZ4
Qimonda
2GB/FB-DIMM HYS72T256420HFN3S-B
Hitachi
SATA HDD 750G
HUA721075KLA330
Seagate
SATA HDD 750G ST3750640NS
SAS HDD 146G ST3146855SS
S.P.S.*2
Delta
DPS-750EB B,
AC Input::100-127V~11.0A,
200-240V~5.5A,
DC Output:750W
CD-R/RW/
DVD-ROM
SONY NEC
OPTIARC INC
CRX880A
ADD ON CARD
adaptec
ICP5085BL
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 9 of 35
NVLAP Lab Code:200085-0
SAS CARD
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
3.3 CONFIGURATION OF THE TESTED SYSTEM
The FCC IDs/Types for all equipment, plus descriptions of all cables used in the tested system
(including inserted cards, which have grants) are:
Device
No.
21” COLOR
Monitor
M01-060
Modem
M03-018
PS2 Keyboard
K01-099
PS2 Mouse
M02-400
External USB 2.0
Hard Disk
External USB 2.0
Hard Disk
U02-079
U02-078
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Manufacturer
Model Number
Serial Number
BSMI ID
FCC ID
Data Cable
Power Cord
Manufacturer
Model Number
Serial Number
BSMI ID
FCC ID
Data Cable
Power Cord
Line
Phone
Manufacturer
Model Number
BSMI ID
FCC ID
Data Cable
Manufacturer
Model Number
Serial Number
BSMI ID
FCC ID
Data Cable
Manufacturer
Model Number
Serial Number
BSMI ID
Data Cable
AC Power Adaptor
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
:
Manufacturer
Model Number
Serial Number
BSMI ID
Data Cable
AC Power Adaptor
:
:
:
:
:
:
Configuration
COMPAQ
PE1143-41
N/A
R31708
N/A
Shielded, detachable, 1.5m, VGA Cable
3Pin, Shielded, Detachable, 1.5m
ACEEX
1414V
0046171
N/A
IFAXDM1414
T Type:RS232, Shielded, Detachable, 1.2m
Non-Shielded, Detachable, 1.5m
Type:RJ11(4P2C), Detachable, 1.8m
Type:RJ11(4P2C), Detachable, 1.8m
acer
T200-P
R41097
N/A
Shielded, Undetachable, 1.8 m
detrois
CanMouse CM-309
N/A
R63159
N/A
Shielded, Undetachable, 1.5m
TERASYS
F12-UF
A0100215-34P0030
4912A002
Shielded, detachable, 1.5m
YHI, M/N:YS-1015-U12A, BSMI ID:4872A185
Input: AC IN:100V 50/60Hz 35VA
Output: DC +12V ,1.25A
TERASYS
F12-UF
A0100215-34P0030
4912A002
Shielded, detachable, 1.5m
YHI, M/N:YS-1015-U12A, BSMI ID:4872A185
Input: AC IN: 100V 50/60Hz 35VA
Output: DC +12V ,1.25A
Page 10 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Device
No.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
External USB 2.0
Hard Disk
U02-100
External USB 2.0
Hard Disk
U02-066
Far End Network
Server
(For Gigabit LAN)
-----
Configuration
TERASYS
F12-UF
4912A002
Shielded, detachable, 1.5m
YHI, M/N:YS-1015-U12A, BSMI ID:4872A185
Input: AC IN: 100V 50/60Hz 35VA
Output: DC +12V,1.25A
Manufacturer
: TERASYS
Model Number
: F12-UF
Serial Number
: A0100215-34P0030
BSMI ID
: 4912A002
Data Cable
: Shielded, detachable, 1.5m
AC Power Adaptor : YHI, M/N:YS-1015-U12A, BSMI ID:4872A185
Input: AC IN: 100V 50/60Hz 35VA
Output: DC +12V ,1.25A
Manufacturer
: ASUS
Model Number
: AP160R
HUB
(For Gigabit LAN)
-----
Power Cord
Manufacturer
Model Number
: Non- Shielded, Detachable, 1.8m
: D-Link
: DGS-1005D
Power Cord
Mother Board
F.D.D.
H.D.D.
:
:
:
:
Non- Shielded, Detachable, 2.0m, 2pin
ASUS, M/N: TUSL2-C
Panasonic, M/N: JU-257A606P
Seagate, M/N: ST330621A
CD-ROM
VGA
Sound
LAN
SDRAM
CPU
S. P. S.
Power Cord
Manufacturer
Model Number
Data Cable to EUT
Power Cord
:
:
:
:
:
:
:
:
:
:
:
:
MITSUMI, M/N: CRMC-FX4830T
On Board
On Board
On Board
32MB PC100
Intel,733M/133MHz
DELTA, M/N: DTPS-200PB-109C
Non-Shielded, Detachable, 1.8m
D-Link
DES-1008D (10/100BASE-T Ethernet Hub)
Far End Network
Server
(For LAN)
-----
HUB
(For LAN)
-----
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Manufacturer
Model Number
BSMI ID
Data Cable
AC Power Adaptor
:
:
:
:
:
Type:RJ45(UTP/8P8C), Detachable, 12 m, Twisted Pairs
Non-Shielded, Detachable, 1.5m
Page 11 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
3.4 BLOCK DIAGRAM OF CONNECTIONS BETWEEN EUT AND SIMULATORS
Gigabit LAN
EUT: Server
HUB
Far End Network Server
HUB
Far End Network Server
LAN
21” COLOR Monitor
HHHHHHHH
HHHHHHHH
HHHHHHHH
HHHHHHHH
PS2
Keyboard
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Modem
PS2
Mouse
External USB 2.0 Hard Disk
Page 12 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
3.5 TEST METHODOLOGY
Both conducted and radiated testing were performed according to the procedures in
ANSI C63.4-2003.
Radiated testing was performed at an antenna to EUT distance of 10 meters.
(For frequencies below 1000MHz)
Radiated testing was performed at an antenna to EUT distance of
(For frequencies above 1000MHz)
3 meters.
3.6 TEST FACILITY
Ambient conditions in the laboratory:
ITEMS
Requirement
TEMPERATURE (°C)
HUMIDITY (%RH)
BAROMETRIC PRESSURE
(mbar)
FCC SITE DESCRIPTION
10-40
10-90
860-1060
Aug. 10, 1995 /Aug. 25, 1998 File on
FCC Engineering Laboratory
Federal Communication Commission
7435 Oakland Mills Road
Columbia, MD 21046
Reference 31040/SIT1300F2
NVLAP LAB. CODE
200085-0
United Stated Department of commerce
National Institute of Standards and Technology
National Voluntary Laboratory Accreditation Program
Accreditation on NVLAP effective through Sep. 30, 2008
For CISPR 22, FCC Method and AS/NZS CISPR 22
Measurement.
Taiwan Accreditation
Recognized by the Council of Taiwan Accreditation
Foundation (TAF)
Foundation and confirmed to meet the requirements of
ISO/IEC 17025.
Registration No.: 1082
Registration on TAF effective through Sep. 19, 2009
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 13 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
4.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
CONDUCTED EMISSION MEASUREMENT
4.1 TEST EQUIPMENTS
The following test equipment are used during the conducted power line tests:
Item
Instrument
Manufacturer
Model
Serial No.
Next Cal. Date
1
Test Receiver
R&S
ESCS30
825022/003
2008.05.25
2
LISN.(EUT)
R&S
ENV216
100006
2008.05.28
3
L.I.S.N.(AE)
ROLF HEINE
NNB-2/16Z
98091
2008.07.22
4
RF CABLE
GTK
N/A
GTK-E-A154-01
2008.11.26
5
50 Ohm Terminator
GTK
N/A
GTK-E-A130-01
N/A
6
Shielded Room
GTK
N/A
B5
N/A
4.2 BLOCK DIAGRAM OF TEST SETUP
EUT:
Server
Load
40cm
80cm
L.I.S.N.
(EUT)
Non-conducted table
80cm
L.I.S.N.
(AE)
Metal Ground Plane
Test Receiver
Transformer/ Convertor
Filter(EUT)
Filter(AE)
Note: This is a representative setup diagram for Table-top EUT.
For Floor-standing EUT, the table will be removed with all others setup condition remain the same.
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 14 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
4.3 CONDUCTED EMISSION LIMIT
FCC Limit
Frequency
Maximum RF Line Voltage
Class A
Class B
MHz
µV
dBµV
µV
dBµV
0.45 to 1.705
1000
60.0
250
48.0
1.705 to 30
3000
69.5
250
48.0
Remarks :
1. RF Line Voltage (dBµV) = 20 log RF Line Voltage (µV).
2. In the Above Table, the tighter limit applies at the band edges.
CISPR Limit
Frequency
Maximum RF Line Voltage dB(µV)
Class A
MHz
Class B
QUASI-PEAK AVERAGE QUASI-PEAK AVERAGE
0.15 to 0.50
79
66
66 to 56
56 to 46
0.50 to 5.0
73
60
56
46
5.0 to 30
73
60
60
50
Remarks : In the Above Table, the tighter limit applies at the band edges.
4.4 EUT CONFIGURATION ON MEASUREMENT
The equipments that are listed 4.1 are installed on Conducted Power Line Test to meet the
Commission requirement and operating in a manner, which tends to maximize its emission
characteristics in a normal application.
The device under test, installed in a representative system as described in section 4.2, was
placed on a non-conductive table whose total height equal to 80cm. Powered from one L.I.S.N.
which signal output to receiver, and the other peripherals was powered from another L.I.S.N.
which signal output was terminated by 50Ω.
4.5 CONDUCTED EMISSION DATA
The measurement range of conducted emission, which is from 0.15 MHz to 30 MHz, was
investigated. All readings are quasi-peak and average values with a resolution Bandwidth of 9
KHz. The initial step in collecting conducted data is a spectrum analyzer peak scan of the
measurement range for all the test modes. Then the worst modes were reported the following
data pages.
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 15 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
4.6 OPERATING CONDITIONS OF THE EUT
The EUT exercise program used during conducted testing was designed to exercise the
EUT in a manner similar to a typical use. The exercise sequence is listed as below:
1. Setup the EUT and simulators as shown on 4.2.
2. Turn on the power of all equipments.
3. Boot the Server from Hard Disk and setup the video to windows Server 2003, active all
devices.
4. Adjust to appropriate video resolution.
5. Connect the Far End Network Server and run test program “test.bat “.
6. The EUT exchange the information with the GesTek server via HUB.
7. Active other internal devices such as network function.
8. Run “DVD-Play” & “H.D.D. R/W” & “EMC” test program under windows Server 2003.
9. Server sent “H” pattern to monitor, make the “H” pattern full in the screen.
10. Server sent “H” pattern to parallel and serial port.
11. Repeat above steps.
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 16 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
4.7 CONDUCTED EMISSION MEASUREMENT RESULTS
February 25, 2008
Date of Test
Server
EUT
Mode 7 (Power 1)
Test Mode
Frequency
MHz
26 ℃
Humidity
60 %
H Pattern
Display Pattern
AC 120V/60Hz
Test Power Supply
No.
Temperature
Reading Level
dBµV
1
1.1980
2
1.1980
3
2.5220
4
2.5220
5
3.3197
6
3.3197
7
4.1170
8
4.1170
9
7.0825
10
7.0825
11
13.3117
12 ★13.3117
16.47
14.09
19.05
16.71
19.38
17.69
19.22
15.31
18.32
17.40
27.34
24.83
Line
Factor Measurement
dB
dBµV
9.64
9.64
9.65
9.65
9.66
9.66
9.65
9.65
9.70
9.70
9.82
9.82
26.11
23.73
28.70
26.36
29.04
27.35
28.87
24.96
28.02
27.10
37.16
34.65
Limit
dBµV
73.00
60.00
73.00
60.00
73.00
60.00
73.00
60.00
73.00
60.00
73.00
60.00
Over Limit
Detector
dB
-46.89
-36.27
-44.30
-33.64
-43.96
-32.65
-44.13
-35.04
-44.98
-32.90
-35.84
-25.35
Remarks :
1.
2.
3.
4.
5.
6.
All readings are Quasi-peak and Average values.
Measurement = Reading + Factor (Could have ±0.01 tolerance due to computer automatically round off calculation).
Over Limit (Margin Value)=Measurement level-Limit value.
Factor = L.I.S.N. insertion loss + cable loss
“ ★ ” means that this data is the worse case measurement level.
The measurement uncertainty is 3.6 dB.
Line
Remark:
1. The “Limit” in right-up corner in above diagram refers to Quasi-peak ; “AVG” refers to the limit of Average.
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 17 of 35
NVLAP Lab Code:200085-0
QP
AVG
QP
AVG
QP
AVG
QP
AVG
QP
AVG
QP
AVG
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
February 25, 2008
Date of Test
Server
EUT
Mode 7 (Power 1)
Test Mode
1
2
3
4
5
6
7
8
9
10
11
12
Frequency
MHz
1.9934
★1.9934
2.5222
2.5222
4.1172
4.1172
5.7143
5.7143
8.1924
8.1924
13.4198
13.4198
Temperature
26 ℃
Humidity
60 %
H Pattern
Display Pattern
AC 120V/60Hz
Test Power Supply
No.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
Reading Level
dBµV
21.65
21.26
19.72
18.51
19.87
15.56
17.18
13.24
21.26
18.86
19.18
14.15
Neutral
Factor Measurement
dB
dBµV
9.64
31.29
9.64
30.90
9.65
29.37
9.65
28.16
9.65
29.52
9.65
25.21
9.70
26.88
9.70
22.94
9.79
31.05
9.79
28.65
9.85
29.03
9.85
24.00
Limit
dBµV
73.00
60.00
73.00
60.00
73.00
60.00
73.00
60.00
73.00
60.00
73.00
60.00
Over Limit
Detector
dB
-41.71
QP
-29.10
AVG
-43.63
QP
-31.84
AVG
-43.48
QP
-34.79
AVG
-46.12
QP
-37.06
AVG
-41.95
QP
-31.35
AVG
-43.97
QP
-36.00
AVG
Remarks :
1.
2.
3.
4.
5.
6.
All readings are Quasi-peak and Average values.
Measurement = Reading + Factor (Could have ±0.01 tolerance due to computer automatically round off calculation).
Over Limit (Margin Value)=Measurement level-Limit value.
Factor = L.I.S.N. insertion loss + cable loss
“ ★ ” means that this data is the worse case measurement level.
The measurement uncertainty is 3.6 dB.
Neutral
Remark:
1. The “Limit” in right-up corner in above diagram refers to Quasi-peak ; “AVG” refers to the limit of Average.
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 18 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
February 25, 2008
Date of Test
Server
EUT
Mode 7 (Power 2)
Test Mode
Frequency
MHz
Temperature
26 ℃
Humidity
60 %
H Pattern
Display Pattern
AC 120V/60Hz
Test Power Supply
No.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
Reading Level
dBµV
1
2.0229
2
2.0229
3
2.8319
4
2.8319
5
4.0252
6
4.0252
7
8.1917
8
8.1917
9
11.9476
10
11.9476
11
13.3111
12 ★13.3111
25.81
24.65
20.55
20.52
18.66
17.79
24.11
21.71
24.56
23.78
27.54
25.29
Line
Factor Measurement
dB
dBµV
9.64
9.64
9.66
9.66
9.65
9.65
9.72
9.72
9.79
9.79
9.82
9.82
35.45
34.29
30.21
30.18
28.31
27.44
33.83
31.43
34.35
33.57
37.36
35.11
Limit
dBµV
73.00
60.00
73.00
60.00
73.00
60.00
73.00
60.00
73.00
60.00
73.00
60.00
Over Limit
Detector
dB
-37.55
-25.71
-42.79
-29.82
-44.69
-32.56
-39.17
-28.57
-38.65
-26.43
-35.64
-24.89
Remarks :
1.
2.
3.
4.
5.
6.
All readings are Quasi-peak and Average values.
Measurement = Reading + Factor (Could have ±0.01 tolerance due to computer automatically round off calculation).
Over Limit (Margin Value)=Measurement level-Limit value.
Factor = L.I.S.N. insertion loss + cable loss
“ ★ ” means that this data is the worse case measurement level.
The measurement uncertainty is 3.6 dB.
Line
Remark:
1. The “Limit” in right-up corner in above diagram refers to Quasi-peak ; “AVG” refers to the limit of Average.
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 19 of 35
NVLAP Lab Code:200085-0
QP
AVG
QP
AVG
QP
AVG
QP
AVG
QP
AVG
QP
AVG
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
February 25, 2008
Date of Test
Server
EUT
Mode 7 (Power 2)
Test Mode
1
2
3
4
5
6
7
8
9
10
11
12
Frequency
MHz
2.0222
★2.0222
2.8315
2.8315
3.6420
3.6420
8.1952
8.1952
11.9486
11.9486
13.3115
13.3115
Temperature
26 ℃
Humidity
60 %
H Pattern
Display Pattern
AC 120V/60Hz
Test Power Supply
No.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
Reading Level
dBµV
31.97
31.64
23.01
22.58
22.43
20.91
22.80
19.58
25.37
24.83
27.58
25.35
Neutral
Factor Measurement
dB
dBµV
9.64
41.61
9.64
41.28
9.66
32.67
9.66
32.24
9.65
32.08
9.65
30.56
9.79
32.59
9.79
29.37
9.85
35.22
9.85
34.68
9.85
37.43
9.85
35.20
Limit
dBµV
73.00
60.00
73.00
60.00
73.00
60.00
73.00
60.00
73.00
60.00
73.00
60.00
Over Limit
Detector
dB
-31.39
QP
-18.72
AVG
-40.33
QP
-27.76
AVG
-40.92
QP
-29.44
AVG
-40.41
QP
-30.63
AVG
-37.78
QP
-25.32
AVG
-35.57
QP
-24.80
AVG
Remarks :
1.
2.
3.
4.
5.
6.
All readings are Quasi-peak and Average values.
Measurement = Reading + Factor (Could have ±0.01 tolerance due to computer automatically round off calculation).
Over Limit (Margin Value)=Measurement level-Limit value.
Factor = L.I.S.N. insertion loss + cable loss
“ ★ ” means that this data is the worse case measurement level.
The measurement uncertainty is 3.6 dB.
Neutral
Remark:
1. The “Limit” in right-up corner in above diagram refers to Quasi-peak ; “AVG” refers to the limit of Average.
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 20 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
5.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
RADIATED EMISSION MEASUREMENT
5.1 TEST EQUIPMENT
The following test equipments are used during the radiated emission tests:
Item
Instrument
Manufacturer
Model
Serial No.
5.2
Next Cal. Date
1
Test Receiver
R&S
ESCS30
825022/003
2008.05.25
2
Spectrum Analyzer
ADVANTEST
R3172
150101278
2008.03.07
3
Pre-Amplifier
HP
8447D
2944A08607
2008.09.09
4
Pre-Amplifier
HP
8449B
3008A01264
2008.06.21
5
BILOG Antenna
CBL6112B
2812
2008.11.22
6
HORN ANTENNA
EM-6961
103329
2008.06.20
7
CABLE
SCHAFFNER
ELECTROMETRICS
GTK
N/A
GTK-E-A317-01
2008.11.06
8
Open Site
GTK
N/A
A1
2008.05.18
OPEN TEST SITE SETUP DIAGRAM
Note: This is a representative setup diagram for Table-top EUT.
For Floor-standing EUT, the table will be removed with all others setup condition remain the same.
10m/ 3m
FRP Dome
Broadband or
Dipole Antenna
Antenna height
can be moved
from 1m to 4m;
Antenna and
turntable distance
10m or 3m
Load
NonConductive
Table
1m to 4m
EUT
Antenna Mast
80cm
TO controller
Test
Receiver
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Metal Full Soldered Ground Plane
Page 21 of 35
NVLAP Lab Code:200085-0
To Receiver
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
5.3 RADIATED EMISSION LIMIT
FCC Class B Limit at 3m
Frequency
Distance
Field Strength
MHz
Meter
µV/m
dBµV/m
30 to 88
3
100
40.0
88 to 216
3
150
43.5
216 to 960
3
200
46.0
Above 960
3
500
54.0
Note: The frequencies above 1000MHz, as measured using instrumentation with a peak detector
function was corresponding to 20dB above the maximum permitted average limit.
(Refer 47CFR Ch. 1 (10-1-98 Edition §15.35(b))
FCC Class A Limit at 10m
Frequency
Distance
Field Strength
MHz
Meter
µV/m
dBµV/m
30 to 88
10
90
39.0
88 to 216
10
150
43.5
216 to 960
10
210
46.4
Above 960
10
300
49.5
Remark :1. The tighter limit shall apply at the edge between two frequency bands.
2. Distance refers to the distance in meters between the measuring instrument antenna and the closed
point of any part of the device or system.
3. The field-strength measurement above 1000MHz was made at a distance of 3m.
CISPR Class A Limit at 10m
Frequency
Distance
Field Strength
MHz
Meter
dB(µV/m)
30 to 230
10
40
230 to 1000
10
47
Remark :1. The tighter limit shall apply at the edge between two frequency bands.
2. Distance refers to the distance in meters between the measuring instrument antenna and the closed
point of any part of the device or system.
5.4 EUT CONFIGURATION
The equipment which is listed 5.1 are installed on Radiated Emission Test to meet the
Commission requirement and operating in a manner which tends to maximize its emission
characteristics in a normal application.
The device under test, installed in a representative system as described in section 5.2, was
placed on a non-conductive table whose total height equaled 80 cm. This table can be rotated
360 degree. The measurement antenna was mounted to a non-conductive mast capable of
moving the antenna vertically. Antenna height was varied from 1 meter to 4 meters and the
system under test was rotated from 0 degree through 360 degrees relative to the antenna
position and polarization (Horizontal and Vertical). Also the I/O cable position was investigated
to find the maximum emission condition.
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 22 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
5.5 OPERATING CONDITION OF EUT
Same as section 4.6.
5.6 RADIATED EMISSION DATA
The measurement range of radiated emission, which is from 30 MHz to 14 GHz, was
investigated. All readings are quasi-peak values with a resolution Bandwidth of 120 KHz. The
initial step in collecting radiated emission data is a spectrum analyzer peak scans of the
measurement range for all the test modes and then use test receiver for final measurement.
Then the worst modes were reported the following data pages.
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 23 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
5.7 RADIATED EMISSIONS MEASUREMENT RESULTS
Date of Test
EUT
Working Cond.
Antenna distance
Test Power Supply
No.
1
2
3
4
5
6
7
8
9
10
11
12
Frequency
MHz
49.3600
249.9963
480.0392
499.9930
★666.6810
720.0562
725.0070
750.0145
800.0163
833.3830
866.5782
900.0195
February 21, 2008
Server
Mode 7
10m at Horizontal
AC 120V/60Hz
Reading Level
dBµV
41.00
44.86
35.90
37.90
40.20
35.67
27.56
32.66
37.50
36.82
28.34
26.34
Temperature
Humidity
Display Pattern
Frequency Range
Factor
dB
-13.77
-9.60
-4.14
-3.71
-0.96
-0.28
-0.20
0.18
0.92
1.35
1.78
2.20
Measurement
dBµV/m
27.23
35.26
31.76
34.19
39.24
35.39
27.36
32.84
38.42
38.17
30.12
28.54
Limit
dBµV/m
40.00
47.00
47.00
47.00
47.00
47.00
47.00
47.00
47.00
47.00
47.00
47.00
25 deg/C
68 %RH
H Pattern
30-1000MHz
Over Limit
dB
-12.77
-11.74
-15.24
-12.81
-7.76
-11.61
-19.64
-14.16
-8.58
-8.83
-16.88
-18.46
Detector
QP
QP
QP
QP
QP
QP
QP
QP
QP
QP
QP
QP
Remarks:
1.
2.
3.
4.
5.
6.
All Readings below 1GHz are Quasi-Peak.
Measurement = Reading + Factor (Could have ±0.01 tolerance due to computer automatically round off calculation).
Over Limit (Margin Value)=Measurement level-Limit value.
Factor = antenna factor + cable loss – amplifier gain.
“ ★ ” means that this data is the worse case measurement level.
The measurement uncertainty is 5.1 dB.
Remark:
1. The “Limit” in right-up corner in above diagram refers to Quasi-peak ; “Margin” refers to the data under 6dB.
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 24 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Date of Test
EUT
Working Cond.
Antenna distance
Test Power Supply
No.
1
2
3
4
5
6
7
8
9
10
11
12
Frequency
MHz
50.0600
249.9977
480.1542
499.9927
640.0142
★666.6803
720.0570
725.4570
800.0169
833.3835
866.8605
900.0187
Temperature
Humidity
Display Pattern
Frequency Range
February 21, 2008
Server
Mode 7
10m at Vertical
AC 120V/60Hz
Reading Level
dBµV
42.31
45.49
33.57
39.21
30.41
43.59
34.21
28.73
40.50
39.62
38.16
30.31
Tel:886-2-2603-5321 Fax:886-2-2603-5325
Factor
dB
-13.71
-9.60
-4.13
-3.71
-1.26
-0.96
-0.28
-0.19
0.92
1.35
1.78
2.20
Measurement
dBµV/m
28.60
35.89
29.44
35.50
29.15
42.63
33.93
28.54
41.42
40.97
39.94
32.51
Limit
dBµV/m
40.00
47.00
47.00
47.00
47.00
47.00
47.00
47.00
47.00
47.00
47.00
47.00
25 deg/C
68 %RH
H Pattern
30-1000MHz
Over Limit
dB
-11.40
-11.11
-17.56
-11.50
-17.85
-4.37
-13.07
-18.46
-5.58
-6.03
-7.06
-14.49
Detector
QP
QP
QP
QP
QP
QP
QP
QP
QP
QP
QP
QP
Remarks:
1.
2.
3.
4.
5.
6.
All Readings below 1GHz are Quasi-Peak.
Measurement = Reading + Factor (Could have ±0.01 tolerance due to computer automatically round off calculation).
Over Limit (Margin Value)=Measurement level-Limit value.
Factor = antenna factor + cable loss – amplifier gain.
“ ★ ” means that this data is the worse case measurement level.
The measurement uncertainty is 5.1 dB.
Remark:
1. The “Limit” in right-up corner in above diagram refers to Quasi-peak ; “Margin” refers to the data under 6dB.
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 25 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
Date of Test
February 25, 2008
Temperature
25 deg/C
EUT
Server
Humidity
68 %RH
Working Cond.
Mode 7
Display Pattern
H Pattern
Antenna distance
Test Power Supply
3m at Horizontal
AC 120V/60Hz
Frequency Range
1GHz~14GHz
No.
1
2
3
4
5
6
7
8
Frequency
MHz
1000.0000
1000.0000
1280.0100
1280.0100
1500.0100
1500.0100
3000.0340
3000.0340
Reading Level
dBµV
56.74
53.66
48.78
46.96
54.55
51.13
40.72
37.77
Factor
dB
-8.00
-8.00
-5.81
-5.81
-4.10
-4.10
2.90
2.90
Measurement
dBµV/m
48.74
45.66
42.97
41.15
50.45
47.03
43.62
40.67
Limit
dBµV/m
80.00
60.00
80.00
60.00
80.00
60.00
80.00
60.00
Over Limit
dB
-31.26
-14.34
-37.03
-18.85
-29.55
-12.97
-36.38
-19.33
Detector
peak
AVG
peak
AVG
peak
AVG
peak
AVG
Remarks:
1.
2.
3.
4.
5.
All Readings are Peak and Average value.
Measurement = Reading + Factor (Could have ±0.01 tolerance due to computer automatically round off calculation).
Over Limit (Margin Value)=Measurement level-Limit value.
Factor = antenna factor + cable loss – amplifier gain.
The measurement uncertainty is 3.7 dB.
Remark:
1. The “Limit” in right-up corner in above diagram refers to peak ; “AVG” refers to the limit of Average.
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 26 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
Date of Test
February 25, 2008
Temperature
25 deg/C
EUT
Server
Humidity
68 %RH
Working Cond.
Mode 7
Display Pattern
H Pattern
Antenna distance
Test Power Supply
3m at Vertical
AC 120V/60Hz
Frequency Range
1GHz~14GHz
No.
1
2
3
4
5
6
7
8
Frequency
MHz
1000.0000
1000.0000
1201.8500
1201.8500
1500.0700
1500.0700
3000.1100
3000.1100
Reading Level
dBµV
53.70
50.23
53.59
50.64
59.11
54.99
45.75
40.67
Factor
dB
-8.00
-8.00
-6.43
-6.43
-4.10
-4.10
2.90
2.90
Measurement
dBµV/m
45.70
42.23
47.16
44.21
55.01
50.89
48.65
43.57
Limit
dBµV/m
80.00
60.00
80.00
60.00
80.00
60.00
80.00
60.00
Over Limit
dB
-34.30
-17.77
-32.84
-15.79
-24.99
-9.11
-31.35
-16.43
Detector
peak
AVG
peak
AVG
peak
AVG
peak
AVG
Remarks:
1.
2.
3.
4.
5.
All Readings are Peak and Average value.
Measurement = Reading + Factor (Could have ±0.01 tolerance due to computer automatically round off calculation).
Over Limit (Margin Value)=Measurement level-Limit value.
Factor = antenna factor + cable loss – amplifier gain.
The measurement uncertainty is 3.7 dB.
Remark:
1. The “Limit” in right-up corner in above diagram refers to peak ; “AVG” refers to the limit of Average.
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 27 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
6.
PHOTOGRAPHS FOR TEST
6.1 TEST PHOTOGRAPHS FOR CONDUCTION
Mode 7
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 28 of 35
NVLAP Lab Code:200085-0
Tel:886-2-2603-5321 Fax:886-2-2603-5325
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
6.2 TEST PHOTOGRAPHS FOR RADIATED
Mode 7
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 29 of 35
NVLAP Lab Code:200085-0
Tel:886-2-2603-5321 Fax:886-2-2603-5325
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
7.
PHOTOGRAPHS FOR PRODUCT
1. Front View Of Server (EUT)
2. Back View Of Server (EUT)
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 30 of 35
NVLAP Lab Code:200085-0
Tel:886-2-2603-5321 Fax:886-2-2603-5325
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
3. IO Port
4. IO Port
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 31 of 35
NVLAP Lab Code:200085-0
Tel:886-2-2603-5321 Fax:886-2-2603-5325
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
5. Inner View of Server (EUT)
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 32 of 35
NVLAP Lab Code:200085-0
Tel:886-2-2603-5321 Fax:886-2-2603-5325
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
8.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
EMI/EMS REDUCTION METHOD DURING COMPLIANCE TESTING
No. Component Name
Manufacturer
Standards
Quantity
Position
1
Gasket
CTN
156*31*3 mm
1
I/O GASKET
2
Gasket
TCT
104*3*1 mm
2
Riser bracket
3
Gasket
TCT
104*7*1 mm
2
Riser bracket
4
EMI FINGER
CTN
74*7*1.05 mm
8
HDD TRAY
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 33 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Tel:886-2-2603-5321 Fax:886-2-2603-5325
Appendix A
Circuit (Block) Diagram
(Shall be added by Applicant)
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 34 of 35
NVLAP Lab Code:200085-0
Report No.: 0712109F-01
GESTEK Lab
N0 3, Pau-Tou-Tsuo Valley, Chia-Pau Tsuen, Lin Kou Hsiang, Taipei County, Taiwan, R.O.C.
Appendix B
User Manual
(Shall be added by Applicant)
Accredited Lab. Of BSMI, NVLAP.
Listed Lab. of Commerce, FCC, VCCI.
Page 35 of 35
NVLAP Lab Code:200085-0
Tel:886-2-2603-5321 Fax:886-2-2603-5325