Discovery 1000R Series Instruction Manual

Australia
North America
Discovery Series Cabinet Trolley
Assembly and Operating Instructions
For outdoor use only
1
Discovery i-1000R
Content:
Index
1
2
3
4
5
6
7
8
9
10
11
12
13
2
Part
Top Panel
Shelf
Side Burner
RHS Panel and legs
LHS Panel and legs
Rear Panel
Base Panel
RHS Door
LHS Door
Cylinder Hook
Castors
Wheels
Wheel Spacers
Quantity
1
1
1
1
1
1
1
1
1
1
2
2
2
Bolt Pack:
Mrk
Qty
A
B
C
D
E
F
G
H
I
J
K
16
24
6
6
2
2
2
1
1
2
1
description
M6 x 40mm Screw
M6 washer
M6 Fiber Washer
M6 x 12mm screw
‘R’ Clips
M6 x 25mm Screw
M6 Nut
M4 x 12mm screw
M4 Washer
Rubber Grommet
Cylinder Strap
Assembly Procedure
Step 1
Remove all loose parts from inside the BBQ, close the hood, and turn it upside-down on a padded
surface (BBQ packaging can be used for this purpose).
Step 2
Use: 4 x ‘A’, 4 x ‘B’, 4 x ‘C’
Attach the Sides of the trolley (Parts 4, 5) to the BBQ body. Note the direction, position and
orientation:
Note: Only put in the 4 lower screws! Turn the screws all the way in, but do NOT tighten them. Other
4 screws and final tightening will only be done after installing the shelf and side-burner at a later
stage.
3
Step 3
Use: 4 x ‘A’, 4 x ‘B’
Attach the Top panel (Part 1) to the sides:
Step 4
Use: 3 x ‘D’, 3 x ‘B’
Attach the Back panel (Part 6) to the Top panel:
4
Step 5
Use: 4 x ‘A’, 7 x ‘B’, 3 x ‘D’, 1 x ‘H’, 1 x ‘I’
Attach the Base of the trolley (Part 7) to the Sides and Back panel:
Step 6
Use: 2 x ‘E’
Fit the Wheels (parts 12, 13) and the castors (parts 11):
Step 7
Carefully turn the trolley and Barbecue upright
5
Step 8
Use: 2 x ‘A’, 2 x ‘B’
To the Left Hand Side, install the shelf (Part 2). Insert over the two legs and between the barbecue
body and the leg, and secure with the screws.
Step 9
Use: 2 x ‘A’, 2 x ‘B’
To the Right Hand Side, install the Side-Burner (Part 3) . Insert over the two legs and between the
barbecue body and the leg, and secure with the screws.
Step 10
Ensure all screws are now tightened (but do not over-tighten)
6
Step 11
Assemble both doors (Parts 8, 9) over the hinge brackets:
Note: ensure that in each door, both hinge pins are inserted into the brackets simultaneously.
It may be required to assemble the handles onto the doors.
Step 12
Use: 2 x ‘F’, 2 x ‘G’, 2 x ‘B’, 2 x ‘C’
Assemble Cylinder Hook (Part 10), if required:
7
Step 13
Make Gas connections and perform a leak test (as described in the Barbecue instruction book, P.11).
Warranty
Our goods come with guarantees that cannot be excluded under the Australian
Consumer Law.
You are entitled to a replacement or refund for a major failure and for compensation for
any other reasonably foreseeable loss or damage. You are also entitled to have the
goods repaired or replaced if the goods fail to be of acceptable quality and the failure
does not amount to a major failure.
Warranty terms and condition in BBQ Instructions book P. 17 apply to this trolley as well.
All parts and workmanship of this trolley are covered for a period of 1 year from date of
purchase.
Technical Information
Note: Do not modify this appliance or any of its parts. Any deviation from
factory settings could result in a safety hazard.
Side Burner manifold inlet threads
Nozzle sizes: LPG – 1.05mm,
Australia Input Energy:
North America Input Energy:
8
are 3/8 SAE male flare fitting.
NG – 1.70mm
15Mj.
14,220BTU.
Distances to Combustible materials (min):
For your records:
Model Number:
Date of Purchase:
Place where purchased:
Serial Number:
9
________________________________________________________________________
________________________________________________________________________
________________________________________________________________________
_________________________________________________________________________
Spare Parts:
Images in this manual are for illustrative purposes only.
Due to constant improvement, BeefEater advises that
changes to the design, material, specifications and product
configuration may occur at any time without notice.
10
11
Discovery Series Cabinet Trolley
Woodland Home Products
P.O. Box 236, Chester Hill, NSW, Australia 2162
Phone: +61 2 9724 8888 Facsimile: +61 2 9724 8899
E-mail: mail@beefeaterbbq.com
Website: www.beefeaterbbq.com
Disc_CabTrol_Inst V0
12