RGB 580xi AAP and RGB 580xi CC AAP Series

Setup Guide ­— RGB 580xi AAP
and RGB 580xi CC AAP Series
This guide provides basic instructions for an experienced
installer to set up and operate the Extron RGB 580xi AAP
and RGB 580xi CC AAP.
Installation
The AAP device should be cabled before attaching the AAP
device to a faceplate or wall plate.
C Installation and service must be performed by authorized personnel only.
Step 1 — Power down
Turn off or disconnect all equipment from power sources.
Step 2 — Connect the rear panel cables
Connect the cables to the AAP device’s rear connectors.
N Although the control cable, LED, and audio assemblies come prewired to the captive screw
connectors, any subsequent cable assembly replacement requires the following instructions.
3
Red
Black
White
Yellow
Pink
Orange
Lt. Blue
Green Purple
Gray
Brown
1
2
Example of AAP device rear connectors
J4
J2
1
2
Example of Cable Cubby AAP device rear connectors
To cable the captive screw connectors, refer to the following diagrams and orient the wires
according to the view angle of the captive screws. Use the Extron VGA and control cable
assembly and refer to the color of each wire for signal identification.
Control connector (J4) — This connector is used for contact closure and horizontal shift a signals.
Wire the appropriate connector as shown below.
Pin 1
Horizontal shift + (green)
Horizontal shift ground (gray)
Horizontal shift – (brown)
Contact closure + (light blue)
Contact closure – (purple)
Pin 1
Horizontal shift + (green)
Horizontal shift ground (gray)
Horizontal shift – (brown)
Contact closure + (light blue)
Contact closure – (purple)
(Continued on reverse side.)
Setup Guide ­— RGB 580xi AAP and CC AAP Series
LED connector (J2) — This connector is used for powering the green/amber LED. Wire b the
appropriate connector as shown below.
Pin 1
Pin 1
Green LED (pink)
LED ground (yellow)
Amber LED (orange)
Green LED (pink)
LED ground (yellow)
Amber LED (orange)
output connector — This connector is used for unbalanced stereo c Audio
audio output. Wire the connector as shown below.
Pin 1
Audio right (red)
Audio ground (black)
Audio right (white)
Step 3 — Audio connect
Wire a 3.5 mm stereo plug for unbalanced audio input
as shown at right.
Tip (L)
Ring (R)
Sleeve ( )
Step 4 — Mount the AAP
Insert the AAP device’s screws through the holes in the AAP double-space faceplate, the AAP
wall plate, or the Cable Cubby AAP shelf bracket. Secure the AAP device to the faceplate/wall
plate/shelf bracket with the provided captive washers and #4-40 nuts. See the examples below.
RGB 580xi CCSI AAP
H
AAP 102
S INP
E U
L T
E
C
T
.S
H
IF
T
Cable
Clamp
Cable
2
P 10
AA
DIO
AU
ER
UT
MP
CO
P
UT
CT
INP
LE
SE
B
i SI
AA
0x
58
RG
IFT
H SH
RGB 580xi SI AAP
#4-40 Nut w/ Captive
Washer
Cable Cubby
Wall Plate
Operation
The RGB 580xi AAP models S, SI, CCS, and CCSI have a front panel horizontal shift control
knob. The SI and CCSI models also have an input select button.
Horizontal shift control knob — While viewing the displayed image, rotate this control to
move the image to the right or left on the screen. The power/signal LED will flash green
whenever the minimum and maximum limits of this control are reached.
Input select button — Pressing this button results in contact closure between pins A and B of
the contact closure connector on the front panel of the RGB 580xi remote interface. This button
can also be used for direct control of any Extron contact closure-controlled switcher, or as a
direct connection to an external control system.
Extron USA - West
Headquarters
+800.633.9876
Inside USA / Canada Only
+1.714.491.1500
+1.714.491.1517 FAX
Extron USA - East
Extron Europe
Extron Asia
Extron Japan
Extron China
Extron Middle East
+800.633.9876
+800.3987.6673
+800.7339.8766
+81.3.3511.7655
+81.3.3511.7656 FAX
+400.883.1568
+971.4.2991800
+971.4.2991880 FAX
+1.919.863.1794
+1.919.863.1797 FAX
+31.33.453.4040
+31.33.453.4050 FAX
+65.6383.4400
+65.6383.4664 FAX
Inside USA / Canada Only
Inside Europe Only
Inside Asia Only
© 2009 Extron Electronics. All rights reserved.
Inside China Only
+86.21.3760.1568
+86.21.3760.1566 FAX
68-537-50
Rev. A
11 09