Compaq D-1H Service manual

P75
P75
SERVICE MANUAL
US Model
Canadian Model
UK Model
AEP Model
N. Hemisphere Model
S. Hemisphere Model
Australian Model
Chassis No. SCC-L07E-A
D-1H CHASSIS
SPECIFICATIONS
Picture tube
0.25 mm aperture grill pitch
17 inches measured diagonally
90-degree deflection
Power Consumption
Maximum
Nominal
Video image area
(16" maximum viewing image)
Approx. 329.5 x 243 mm (w/h)
(13 x 9 5/8 inches)
Deflection frequency
Horizontal: 30 to 85 KHz
Vertical: 50 to150 Hz
AC input voltage / current
Max. resolution
Horizontal: Max. 1280 dots
Vertical: Max. 1024 lines
(at 75 Hz Refresh Rates)
100 to 120 V, 50/60 Hz, 1.8 A
220 to 240V, 50/60Hz, 1A
Dimensions
424 x 422 x 428 (w/h/d)
(16.7 x 16.6 x 16.9 inches)
Approx. 306 x 230 mm (w/h)(Mode 1-13)
Approx. 294 x 231 mm (w/h)(Mode 14-15)
Mass
Approx. 18.48 kg (40.8 lb.)
Standard image area
Input signal
Video
Sync
Analog RGB (75 ohms typical)
0.7 Vp-p, Positive
External HD/VD, Composite
Polarity Free TTL
Video Composite (Sync on Green)
0.286 Vp-p, Negative
115W
100W, 341 BTU/h
Design and specifications are subject to change without notice.
COLOR MONITOR
—1—
If no video signal is input to the monitor, the "NO INPUT SIGNAL" message appears.
After about 30 seconds, the Power Saving function automatically puts the monitor into
active-off mode and the indicator lights up orange. Once the monitor detects horizontal and vertical sync signals, the monitor automatically resumes normal operation mode.
NOTE:
This monitor has three Power Saving modes.
By sensing the absence of a video signal from the
computer, it reduces power consumption as follows:
Power
Consumption
Required Recovery
Time
u Power Indicator
1 Normal Operation
<110W

Green on
2 Standby (1st mode)
<15W
approx. 3 sec.
Yellow
3 Suspend (2nd mode)
<15W
approx. 3 sec.
Yellow
4 Active-off (3rd mode)
<8W
approx. 10 sec.
Amber
5 Power-off
0W

Off


Orange flashing
State
—2—
6 Failure mode
TIMING SPECIFICATION
MODE
Resolution (H x V)
Dot Clock (MHz)
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
640x350 640X480 640x480 640x480 720x400 800x600 800x600 800x600 832x624 1024x768 1024x768 1024x768 1152x870 1280x1024 1280x1024
25.175
25.175
31.500
36.000
28.321
40.000
49.500
56.250
57.283
65.000
78.750
94.500
100.000
108.000
135.000
HORIZONTAL
Hor. Freq. (kHz)
H-Total
H-Blanking
H-Front Porch
H-Sync.
H-Back Porch
H-Active (msec)
31.469
31.778
6.356
0.636
3.813
1.907
25.422
31.469
31.778
6.356
0.636
3.813
1.907
25.422
37.500
26.667
6.349
0.508
2.032
3.810
20.317
43.269
23.111
5.333
1.556
1.556
2.222
17.778
31.468
31.779
6.356
0.636
3.813
1.907
25.423
37.879
26.400
6.400
1.000
3.200
2.200
20.000
46.875
21.333
5.172
0.323
1.616
3.232
16.162
53.674
18.631
4.409
0.569
1.138
2.702
14.222
49.725
20.111
5.586
0.559
1.117
3.910
14.524
48.363
20.677
4.923
0.369
2.092
2.462
15.754
60.023
16.660
3.657
0.203
1.219
2.235
13.003
68.677
14.561
3.725
0.508
1.016
2.201
10.836
68.681
14.560
3.040
0.320
1.280
1.440
11.520
63.981
15.630
3.778
0.444
1.037
2.296
11.852
79.976
12.504
3.022
0.119
1.067
1.837
9.481
VERTICAL
Ver. Freq. (Hz)
V-Total
V- Blanking
V-Front Porch
V-Sync.
V- Back Porch
V-Active (lines)
70.086
449
99
38
2
59
350
59.940
525
45
10
2
33
480
75.000
500
20
1
3
16
480
85.008
509
29
1
3
25
480
70.084
449
49
12
2
35
400
60.317
628
28
1
4
23
600
75.000
625
25
1
3
21
600
85.061
631
31
1
3
27
600
74.550
667
43
1
3
39
624
60.004
806
38
3
6
29
768
75.029
800
32
1
3
28
768
84.997
808
40
1
3
36
768
75.062
915
45
3
3
39
870
60.020
1066
42
1
3
38
1024
75.025
1066
42
1
3
38
1024
SYNC.
Int(G)
Ext(H/V)/Polarity
Ext (CS)/Polarity
Int/Non Int
NO
YES +/NO
Non Int
NO
YES -/NO
Non Int
NO
YES -/NO
Non Int
NO
YES -/NO
Non Int
NO
YES -/+
NO
Non Int
NO
YES +/+
NO
Non Int
NO
YES +/+
NO
Non Int
NO
YES +/+
NO
Non Int
NO
YES -/NO
Non Int
NO
YES -/NO
Non Int
NO
YES +/+
NO
Non Int
NO
YES +/+
NO
Non Int
NO
YES -/NO
Non Int
NO
YES +/+
NO
Non Int
NO
YES +/+
NO
Non Int
P75
POWER SAVING FUNCTION
P75
SAFETY CHECK-OUT
(US Model only)
After correcting the original service problem, perform
the following safety checks before releasing the set to the
customer:
1. Check the area of your repair for unsoldered or
poorly-soldered connections. Check the entire board
surface for solder splashes and bridges.
2. Check the interboard wiring to ensure that no wires
are “pinched” or contact high-wattage resistors.
3. Check that all control knobs, shields, covers, ground
straps, and mounting hardware have been replaced.
Be absolutely certain that you have replaced all the
insulators.
4. L o o k f o r u n a u t h o r i z e d re p l a c e m e n t p a r t s ,
particularly transistors, that were installed during
a previous repair. Point them out to the customer
and recommend their replacement.
5. Look for parts which, though functioning, show
obvious signs of deterioration. Point them out to
the customer and recommend their replacement.
6. Check the line cords for cracks and abrasion.
Recommend the replacement of any such line cord
to the customer.
7. Check the B+ and HV to see if they are specified
values. Make sure your instruments are accurate;
be suspicious of your HV meter if sets always have
low HV.
8. C h e c k t h e a n t e n n a t e r m i n a l s , m e t a l t r i m ,
“metallized" knobs, screws, and all other exposed
metal parts for AC Leakage. Check leakage as
described below.
LEAKAGE TEST
The AC leakage from any exposed metal part to earth ground
and from all exposed metal parts to any exposed metal part having
a return to chassis, must not exceed 0.5 mA (500 microampere).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or
RCA WT-540A. Follow the manufacturers' instructions to
use these instructions.
2. A battery-operated AC milliammeter. The Data Precision
245 digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of
a VOM or battery-operated AC voltmeter. The "limit"
indication is 0.75 V, so analog meters must have an accurate
low voltage scale. The Simpson's 250 and Sanwa
SH-63Trd are examples of passive VOMs that are suitable.
Nearly all battery operated digital multimeters that have a
2V AC range are suitable. (See Fig. A)
WARNING!!
NEVER TURN ON THE POWER IN A CONDITION IN WHICH THE
DEGAUSS COIL HAS BEEN REMOVED.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY SHADING AND MARK ¡ ON
THE SCHEMATIC DIAGRAMS, EXPLODED VIEWS AND IN THE
PARTS LIST ARE CRITICAL FOR SAFE OPERATION. REPLACE
THESE COMPONENTS WITH SONY PARTS WHOSE PART
NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN
SUPPLEMENTS PUBLISHED BY SONY. CIRCUIT ADJUSTMENTS
THAT ARE CRITICAL FOR SAFE OPERATION ARE IDENTIFIED
IN THIS MANUAL. FOLLOW THESE PROCEDURES WHENEVER
CRITICAL COMPONENTS ARE REPLACED OR IMPROPER
OPERATION IS SUSPECTED.
AVERTISSEMENT!!
To Exposed Metal
Parts on Set
NE JAMAIS METTRE SOUS TENSION QUAND LA BOBINE DE
DEMAGNETISATION EST ENLEVEE.
ATTENTION AUX COMPOSANTS RELATIFS A LA
SECURITE!!
0.15 µF
1.5 k W
Earth Ground
AC
Voltmeter
(0.75 V)
LES COMPOSANTS IDENTIFIES PAR UNE TRAME ET PAR UNE
MARQUE ¡ SUR LES SCHEMAS DE PRINCIPE, LES VUES
EXPLOSEES ET LES LISTES DE PIECES SONT D'UNE
IMPORTANCE CRITIQUE POUR LA SECURITE DU
FONCTIONNEMENT. NE LES REMPLACER QUE PAR DES
COMPOSANTS SONY DONT LE NUMERO DE PIECE EST
INDIQUE DANS LE PRESENT MANUEL OU DANS DES SUPPLEMENTS PUBLIES PAR SONY. LES REGLAGES DE CIRCUIT
DONT L'IMPORTANCE EST CRITIQUE POUR LA
SECURITE DU FONCTIONNEMENT SONT IDENTIFIES DANS
LE PRESENT MANUEL. SUIVRE CES PROCEDURES LORS DE
CHAQUE REMPLACEMENT DE COMPOSANTS CRITIQUES, OU
LORSQU'UN MAUVAIS FONTIONNEMENT SUSPECTE.
—3—
P75
TABLE OF CONTENTS
Section
Title
Page
1. GENERAL ................................................................................... 5
2. DISASSEMBLY
2-1.
2-2.
2-3.
2-4.
Cabinet Removal ............................................................8
Service Position .............................................................. 8
A, D, H, S Board Removal............................................. 8
Picture Tube Removal ................................................... 9
3. SAFETY RELATED ADJUSTMENT................................. 10
4. ADJUSTMENTS ........................................................................ 11
5. DIAGRAMS
5-1. Block Diagram ................................................................15
5-2. Circuit Boards Location ................................................. 18
5-3. Schematic Diagrams and Printed Wiring Boards ...... 18
1. D Board - Schematic Diagram ................................. 19
2. A Board - Schematic Diagram ................................. 23
3. H, S, U1, U2 - Schematic Diagram...............................26
5-4. Semiconductors ..............................................................27
6. EXPLODED VIEWS
6-1. Chassis (US/CANADIAN, AEP, NH, SH, AUS
models made in US) ...................................................... 29
6-2. Chassis (AEP, UK models made in UK) ..................... 30
6-3. Packing Materials .......................................................... 31
7. ELECTRICAL PARTS LIST ................................................ 32
—4—
SECTION 1
GENERAL
The instructions given here are partial abstracts from the Operating Instruction
Manual. The page numbers shown reflect those of the Operating Instruction Manual.
USB Connectors
The base of the monitor has two Universal Serial Bus (USB)
connectors. Use USB connector ❶ to connect the USB signal
cable∗ to the computer. Use USB Connector ❷ to connect USB
compatible plug and play devices such as a keyboard, mouse, or
joystick if supported by your computer. This feature provides
USB pass-through and does not support USB host requirements.
Operating the
Monitor
CAUTION: This USB connector is not designed for use with high
speed USB devices such as a video camera, scanner, etc.
Compaq recommends connecting high speed devices directly to
the computer.
—5—
Front Control Panel
No./ Icon
−
+
✎ These USB connectors operate as a pass-through system. Your
computer must have a USB host controller installed for any
USB-connected devices to operate.
∗
A USB signal cable is not supplied with this monitor.
English 1-5
Function
Contrast
Adjusts contrast by turning control to left or
right.
Brightness
Adjusts brightness by turning control to left or
right.
Select button
1. Launches on-screen display.
2. Selects function adjustments.
3. Exits menus and on-screen display.
Minus button
Selects and adjusts the functions.
Plus button
Selects and adjusts the functions.
Power switch
Turns the monitor on and off.
Power LED
1. Green indicates monitor is turned on.
2. Yellow indicates suspend mode.
3. Amber indicates sleep mode.
P75
CAUTION: To prevent deterioration of signal transfer or
malfunction of USB devices, USB cables should not exceed the
combined length of 9.75 feet (3 meters). This length includes both
the USB signal cable and the USB peripheral cable.
Control
1-6 English
P75
On-Screen Display Settings
The adjustments for screen settings are located in the on-screen
display and can be viewed in one of five available languages.
The on-screen Main Menu displays the following ten functions:
Size and Position
Adjusts width, height, and horizontal and vertical
positions of the screen.
Geometry
Adjusts pincushion, pincushion balance, trapezoid,
parallelogram, and tilt.
Overscan
Zooms in and enlarges a selected portion of the screen.
Color
Displays the following selections for screen color
temperature: 9300° K; 6500° K; Custom
Color/Enhancement Color; and Convergence.
Enhancement
Enhances screen for screen presentations or viewing
motion video applications.
—6—
Moiré
Minimizes irregular or wavy lines on the screen raster.
Degauss
Corrects image distortion or color impurity caused by
external magnetic fields.
Language
Lists the following five language selections for onscreen display: English, Dutch, French, German, and
Spanish.
Management
Adjusts power saver and display modes and displays
monitor serial number.
Factory Reset
Resets the screen to its factory settings.
Monitor with On-Screen Display
4. A second level menu displays with expanded menu items.
Again, to make a selection, press the Minus (-) button to
scroll down or press the Plus (+) button to reverse or
back up.
IMPORTANT: The Overscan and Degauss selections do not
display menus. When you select Overscan, the choices are to
turn it on or off. When you select Degauss, the monitor corrects
color impurities on the screen. The monitor screen
automatically degausses when the monitor is turned on.
How to Adjust Settings
To launch the on-screen display Main Menu:
5. Highlight your choice and select Save and Return, or to
advance to the third level menu, highlight your choice and
press the Select button. To void any changes made, select
Cancel instead of Save and Return.
1. Press the Select button on the monitor front panel to
display the Main Menu on the monitor screen.
2. To make a selection from the Main Menu, scroll down by
pressing the Minus (-) button and reverse or back up by
pressing the Plus (+) button ❸ located on the monitor front
panel.
3. Highlight your choice and press the Select button
6. The third level displays a sizing window for adjusting the
selected function. To adjust, press the Minus button to
decrease the degree of adjustment, or press the Plus button
to increase the degree of adjustment.
again.
For example, if your selection is Size and Position, press
the Minus button until Size and Position is highlighted,
then press the Select button to choose it.
English 1-7
7. Press the Select button after the adjustment is made.
IMPORTANT: Selections under the Management Menu, Power
Saver and Mode Display, turn on and off at the third level. The
Serial No. selection displays the monitor serial number at the
third level.
1-8 English
Display Resolutions
Connector Pin Assignments
The display resolutions listed below are the most commonly
used modes and are set as factory defaults. The monitor
automatically recognizes these preset modes when they are
requested by a software program and will provide the user with
a properly sized and centered display.
Signal Cable
Connector
5
4
10
15
3
KEY
14
2
8
13
1
7
12
6
11
Display Resolutions
Preset Modes
1. VGA Compatible
Resolutions
640 X 350 at 31.5 kHz/70 Hz
2. VGA Compatible
640 X 480 at 31.5 kHz/60 Hz
3. VESA Standard
640 X 480 at 37.5 kHz/75 Hz
4. VESA Standard
640 X 480 at 43.3 kHz/85 Hz
—7—
5. VGA Compatible
720 X 400 at 31.5 kHz/70 Hz
6. VESA Standard
800 X 600 at 37.8 kHz/60 Hz
7. VESA Standard
800 X 600 at 46.9 kHz/75 Hz
8. VESA Standard
800 X 600 at 53.7 kHz/85 Hz
9. Macintosh Compatible
10. VESA Standard
Pin
Signal
1
2
3
4
5
6
7
8
9
10
11
12*
13
14
15*
Red Video
Green Video
Blue Video
Open
Return
Red Gnd
Green Gnd
Blue Gnd
Reserved (No Pin)
Sync Return
Open
Bidirectional Data (SDA)
H-Sync/Composite Sync
V-Sync
Data Clock (SCL)
* DDC Signals
Color Display Values
832 X 624 at 49.72 kHz/74.5 Hz
1024 X 768 at 48.4 kHz/60 Hz
11. VESA Standard
1024 X 768 at 60.0 kHz/75 Hz
12. VESA Standard
1024 X 768 at 68.7 kHz/85 Hz
13. Macintosh Compatible
1152 X 870 at 68.7 kHz/75 Hz
14. VESA Standard
1280 X 1024 at 63.9 kHz/60 Hz
Red
0.625
0.340
15. VESA Standard
1280 X 1024 at 80.0 kHz/75 Hz
Green
0.285
0.605
Blue
0.150
0.065
White Point (9300 K)
0.281 (+/- .015)
0.311 (+/- .015)
White Point (6500 K)
0.313 (+/- .015)
0.329 (+/- .015)
CIE* Chromaticity Coordinates
x
channels 9 and 13 are Macintosh-compatible display
✎ Memory
modes for use with a Macintosh-compatible computer. If your
computer has this requirement, you will need to purchase a
special adapter connector to attach to the monitor signal cable.
y
Gamma: 2.25
*Commission International d’Eclairage, 1931 Standard.
P75
English 1-11
1-20 English
P75
SECTION 2
DISASSEMBLY
2-2. SERVICE POSITION
2-1. CABINET REMOVAL
2 Two claws
PUSH
3 Cabinet
PUSH
A board
1
3
D board
2
1 Two screws
(BVTP 4 x 16)
2-3. A, D, H, S BOARD REMOVAL
2 H board
3 A board
4 Cable stopper
5 Cable bracket
7 Five screws
(BVTP 3 x 12)
6 One screw
(BVTT 4 x 8)
1 S board
8 D board
—8—
P75
8 Demagnetization coil
2-4. PICTURE TUBE REMOVAL
9 Two screws
(BVTP 4 x 16)
7 Tension spring
6 A board
5 Neck assy
4 Deflection yoke
3 Four screws
(Tapping screw 5)
10 Stand assy
(D board)
2 Picture tube shield
1 Anode cap
Cushion
REMOVAL OF THE ANODE-CAP
NOTE: Short circuit the anode of the picture tube and the anode cap to the metal chassis, CRT shield or carbon painted on the CRT, after
removing the anode.
REMOVAL PROCEDURES
Turn up one side of the rubber cap in
the direction indicated by arrow .
Use your thumb to pull the rubber cap
firmly in the direction indicated by
arrow .
HOW TO HANDLE AN ANODE-CAP
Do not use sharp objects which may cause damage to the surface
of the anode-cap.
Do not squeeze the rubber covering too hard to avoid damaging
the anode-cap. A material fitting called a shatter-hook terminal is
built into the rubber.
Do not force turn the foot of the rubber cover. This may cause the
shatter-hook terminal to protrude and damage the rubber.
—1—
When one side of the rubber cap separates from the anode button, the anodecap can be removed by turning the rubber cap and pulling it in the direction of
arrow .
P75
SECTION 3
SAFETY RELATED ADJUSTMENT
When replacing parts shown in the table below, the
following operational checks must be performed as a
safety precaution against X-ray emissions from the unit.
D - BOARD
b) HV Hold-Down Check
1) Using an external DC Power supply, apply the
voltage shown below between cathode of D517
on
" D " Board and GND, and confirm that the
HV Hold-Down circuit works. (Raster disappears)
Apply DC Voltage: 31.4 + 0.01 VDC
Part Replaced ([)
Check Condition
• Input voltage : 120 + 2 VAC
• Input signal
: (fH = 64 kHz), White Cross Hatch
• Controls
: CONT (max) & BRT (center)
RV501
Part Replaced (])
RV501, T501, R545, R546, R548, R550, R547, R549, R552,
D517, IC605, IC901, C540, C542, C544, C541, C535,
IC501, C558, R567, R564, C555, C553, C554, C561
• B+ Voltage
: 185 + 3.0 VDC
c) Beam Protector Check (Software logic)
1) Using an external DC power supply, apply the
voltage 8.8 + 0.01 VDC between pin 11 of FBT
(T501) and GND, and confirm that the voltage
across C541 is 3.7 VDC or less.
Allow the unit to warm up for one minute prior to
checking the following conditions:
Check Condition
• Input voltage : 120 + 2 VAC
• Input signal
: (fH = 64 kHz), White Cross Hatch
• Controls
: CONT (max) & BRT (center)
a) HV Regulator Check
1)
2)
3)
4)
5)
Input white cross hatch signal. (fH = 64 kHz)
Minimum CONT and BRT controls.
Cut off Screen VR (G2).
Input voltage: 120 + 2 VAC
Confirm that the voltage is within the voltage range
shown below.
Standard voltage: 25.0KV + 0.5KV
6) When replacing components identified by ], make
sure to recheck the High Voltage.
7) Verify the High Voltage as shown above (25.0KV + 0.5KV)
is within specification. If not, set H. SIZE data at
minimum (-127) and then adjust RV501 on "D" Board.
8) After adjusting the High Voltage within specification,
put the RV cover on RV501 as shown below and apply
sufficient amount of RTV around RV501.
d) B+ MAX. Check
1) Input white cross hatch (fH = 64 kHz) signal.
2) CONT (max) & BRT (center)
3) Input voltage: 120 + 2 VAC
Note: Use NF power supply or make sure that
distortion factor is 3% or less.
4) Confirm that the voltage is within the voltage
range shown below.
Standard voltage: 185 + 3.0 VDC
10
RV501
— 10 —
4
P75
SECTION 4
ADJUSTMENTS
Connect the communication cable of the connector located on the D board on the monitor. Run the service software and
then follow the instructions.
1 1-690-391-21
2 A-1500-819-A
Interface Unit
3 3-702-691-01
Connector Attachment
IBM AT Computer
as a Jig
To BUS CONNECTOR
D-sub
(9 Pin [female])
mini Din
(8Pin)
4 Pin
4 Pin
4 Pin
*The parts above ( 1 ~ 3 ) are necessary for DAS adjustment.
Allow a 30 minute warm-up period prior to making the following adjustments:
Landing Rough Adjustment
Enter the full white signal.
Adjust the contrast to the maximum.
Input full green signal.
Moving the DY backward, and adjust coarsely the purity
magnet sothat a green raster positions in the center of
screen.
5. Moving the DY forward, adjust so that an entire screen
becomes pure green.
6. Adjust the tilt of DY, and tighten lightly with a clamp.
Convergence Fine Adjustment
Set DY four-pole magnet to mechanical center
before adjustment.
Set the
This should be prime mode.
finger
1.
2.
3.
4.
•
1.
2.
3.
4.
5.
6.
7.
Landing Fine Adjustment
Place the set in the Helmholtz coil.
Enter a green signal only.
Degauss the entire screen with hand-degausser. Then autodegauss it.
Attach a wobbling coil to the specified position of CRT
neck.
Attach a landing adjuster sensor on the CRT.
Using a landing checker, adjust the DY position, purity,
tilt of DY.
Clamp the DY screw.
Clamping torque: 22 + 2 kgcm (2.2+ 0.2 N.m)
•
1.
2.
3.
Convergence Rough Adjustment
All digital convergence data should be zero by MCP.
Enter the white crosshatch signal.
Adjust roughly the horizontal and vertical
convergence at four-pole magnet.
4. Adjust roughly HMC and VMC at six-pole
magnet.
NECK Assy
P.S
Mg
XBV
P.S Mg
6-pole Mg
DY
CRT
4-pole Mg
1.
2
Receive R.B. cross-hatch.
Adjust H.STAT and V.STAT at four-pole magnet.
4 Pole Magnet
2
1
1
R
B
1 + 2
R
B
R
2
B
2
1
R
B
1 + 2
R
B
1
2
— 11 —
Mechanical
Center
RB
P75
3.
4.
Receive White cross-hatch.
Adjust HMC and VMC at six-pole magnet.
Convergence Specification
Horizontal and Vertical
< 6 Pole Magnet>
2
A
B
B
G
1
0.30mm
0.24mm
0.30mm
0.30mm
A
2
G
1
5.
6.
7.
Focus adjustment
Adjust focus (V) and focus (H) for optimum focus.
Receive R.B. cross-hatch.
Adjust H.TILT by swinging the DY neck right and left.
Adjust XCV with XCV core.
XCV movement
B
R
8.
Focus (V)
Adjust V.TILT with TLV VR.
TLV movement
B
R
R
B
B
R
R
B
9.
Focus (H)
FBT
Adjust Y.CROSS with YCH VR.
11.
Digital Convergence Adjustment
YCH movement
A. Horizontal Convergence
YBH-T
R
10.
CBH-LT
0
MBH-LT
12
2
9CBH-RT
11 MBH-RT
B
Paint lock the four-pole and six-pole Mg.
APH-L
4
MBH-LB
8
CBH-LB
6
VR Adjustment on DY
XCV
YCH
TLV
H STAT
3APH-R
7MBH-RB
1
5CBH-RB
YBH-B
Adjust each misconvergence point in sequence.
Zero Position NECK Ass'y
Purity
4-Pole Mg
B. Vertical Convergence
6-Pole Mg
V STAT-T
Vertical and Horizontal Position and Size
Specification
CCV-LT
0
MCV-LT
12
XBV-L
4
MCV-LB
8
CCV-LB
6
2
9CCV-RT
11 MCV-RT
V STAT
3XBV-R
7MCV-RB
1
5CCV-RB
V STAT-B
a
Adjust each misconvergence point in sequence.
a
a < 2.5 mm
b < 2.5 mm
C. Repeat the procedure of A and B so that the
convergence of the whole screen is within the
specification.
A
B
b
A
B
202
270
b
— 12 —
P75
5-2. CIRCUIT BOARDS LOCATION
A
H
S
D1
U1
D
U2
5-3. SCHEMATIC DIAGRAMS AND PRINTED WIRING BOARDS
Note:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytic.
• Indication of resistance, which does not have one for rating
electrical power, is as follows.
•
When replacing parts shown in the table below,
be sure to perform the safety related adjustment.
D - BOARD
Pitch: 5 mm
Rating electrical power 1/4 W (CHIP: 1/10 W)
Part Replaced ([)
RV501
• All resistors are in ohms.
• f : nonflammable resistor.
• F : fusible resistor.
•
∆ : internal component.
• p : panel designation and adjustment for repair.
• All variable and adjustable resistors have characteristic curve B,
unless otherwise noted.
•
•
e
E
Part Replaced (])
RV501, T501, R545, R546, R548,
R550, R547, R549, R552, D517,
IC605, IC901, C540, C542, C544,
C541, C535, IC501, C558, R567,
R564, C555, C553, C554, C561
: earth-ground.
: earth-chassis.
The components identified by [ in this basic schematic
diagram have been carefully factory-selected for each set
in order to satisfy regulations regarding X-ray radiation.
Should replacement be required, replace only with the
value originally used.
• When replacing components identified by ], make the necessary
adjustments by using RV501 ([) as indicated. (See page 10Z)
•
Note: The components identified by shading and
mark ¡ are critical for safety. Replace only
with part number specified.
•
•
•
•
•
•
•
•
Note: Les composants identifies per un trame et une
marque ¡ sont critiques pour la securite. Ne les
remplacer que par une piece portant le numero specifie.
— 18 —
— 16 —
All voltages are in volts.
Readings are taken with a 10 ΜΩ digital multimeter
Readings are taken with a color-bar signal input.
Voltage variations may be noted due to normal
production tolerances.
*
: Cannot be measured.
Circled numbers are waveform references.
: B +bus.
: B - bus.
CN305
8P
CN307
BLUE
2
GGND
3
GREEN
4
RGND
5
RED
6
GND
7
VD
8
5
BIN
22
GND
+12V
19
8
17
10
18
G-IN
G-OUT
GIN
G-OUT
IC002
11
B-OUT
1
B-IN
4
B-OUT
H
CLAMP
12
&
LEVEL
10
CN301
12
15
R-OSD
OSD
IC003
VSOUT
5
R-OSD
1P
3
1
4
2
R-BKG
G-OSD
13
G-OUT
IC004
B-OSD
3
B-BKG
15
12
OSD-BLK
1.2KV
8
G-IN
14
5
1
1
R-OUT
CUTOFF AMP
G-BKG
B-OSD
9
R-IN
13
14
G-OSD
4
3
+185V
G2
BLK
Q005
2
NC
1
KB
RGB PRE-AMP
16
T-SW
BUFFER
7
6
CBLK
2
KR
KG
GND
SHRP1
+185V
7
9
CLAMP
IC001
9
CN309
7P
BPCLP
GND
+80V
8
11
SYN-OUT
HSYNC
CSYNC
H1
4
3
J001
B-IN
B-OUT
RIN
14
HD
G-IN
3
+80V
13
6
7
6
5
CRT DRIVER
9
G-OUT
R-IN
R-OUT
1
11
6
21
+5V
8
5
R-OUT
R-IN
1
3
SIGNAL IN
1
CONNECTOR
15PIN D-SUB
8
R-OUT
BGND
5
25
SHARPNESS
STBY
+5V
+12V
IC006
9P
WHT
7
VIP
B-IN
B-OUT
OSD-BLK
SCL
2
SDA
G2
5
28
1
CN306
6P
+12V
10
VRTRC
1
VFLB
SDA
HFLB
SCL
7
5
HRTRC
2
SWITCH
GND
3
Q004
IICSCL
4
8
TO
5
6
JOO1
PICTURE TUBE
A
GND
IICSDA
BOARD
HV
G2-CUT OFF
CONTROL
CN310
4P
SPOT
HOSTGND
4
DDCSDA
3
DDCSCL
2
NC
1
KILLER
(TO
IC005
FBT)
CN302
Q001
1P
1
GND
CN303
CN311
1P
3P
DDCSCL
3
DDCSDA
2
CPUGND
1
1
(VIDEO)
GND
CN9901
5V
CN9101
3P
5V
1
2
NC
CONT
2
3
GND
BRIGHT
3
GND
4
1
BRIGHT
1
5V
CN1301
1
VR9101
TO
USB
PNP
CN1303
CN1302
5V
1
1
DMO
2
2
DPO
3
3
GND
4
4
5V
CN1304
5V
DMO
DM1
1
1
5V
2
2
DM1
3
3
DP1
4
4
GND
TO
DEVICES
2
1
VR9102
3
CONT
2
DPO
DP
5
2
CN9902
2P
DPO
GND
DP
GND
GND
GND
PORT
(USB2)
(USB1)
B-#SV9055<COMPAQ-D1H>-U1..
(CONT/BRITE CNTL)
COMPUTER
USB
5
B-#SV9055<COMPAQ-D1H>-U2..
CONV-CONTROL
CN701
CY
IC701
8P
CY4-
8
CY4+
7
CY3-
6
CY3+
5
CY2-
4
15
10
CONV AMP
IC702
2
6
5
7
11
8
V.REF
IN
V-CONVOUT
3
CY1-
2
14
CY1+
1
13
2
(
3
VPOSIN
16
17
1
SDL
4 12 13
BUFFER
5
27
3
10
V.DIV
V-OUT
4
SCL
+IN
8
23
EPROM
PB7
3
4
VSYNC
5
OUT
12
B3O
7
H-REG
TO
B1O
IC503
PWM-CONT
RV501
Q520
IC501
3
19
1
HV-OUT
30
BUFF
13
Q510
H-SYNC
4
H-DRIVE
PH2
REF
CPU
8
54
RESET
IC904
CN902
10P
WHT
RESET
2
GND
}
DDCSDA
HOST
23
2
26
28
LOCK
1
}
3
FOCUS
13
HDT
T504
17
LOCK
DDCSCL
V-OUT
DDCSDA
H-OUT
12
V.
H.DRIVE
DEF
H-IN
H.DRIVE
Q903,Q501,Q502
14
26
27
17
H.OUT
V-IN
35
33
4
IC901
34
DDCSCL
CRT
20
B2O
IC900
SYN
HV
14
4
V-SYNC
1
T501
Q503
OP2+
H-CENTER
2
5
6
2
HV-REG
18
B4+
IC902
DA4
BPCLAMP
C-SYNC
20
HSYNC
2
FBT
3
DEF. CONTROL
CBLANK
5
22
28
GND
3
2
IC401
-IN
V-REF
PB6
PB4
2
OUT
Q511
CN501
H.OUT
4
H.FLY
16
6P
Q507
DY
6
PCI
32
1
HFB
NC
4
IICDATA
5
37
KV
IC905
13
15
46
1
1
5
V.SAW
7P
1.2
V.SIN
SDA
4
CN903
5
Q521
5V
CSYNC
1
HD.IN
OUT
12
BPCLAMP
CN510
1P
HST
SCL
SWITCH
SHRP1
)
T505
FUNCTION
CBLANK
POWER
DEFLECTION
14
V.REF
3
GND
1
H-STATICOUT
V-SIN
9
V-STATICOUT
6
CY2+
CN512
1P
H-CONVOUT
SYNC
11
8
LOCK
DATA
Q522,Q523
H
DY+
ABL
2
H
DY+
3
H
DY-
4
H
DY-
5
V
DY-
6
V
DY+
6
1
6
GND
36
IICCLK
7
GND
8
HRTRC
9
CLK
4
H.
BUFFER
CENT
CNTL
5
DA3
Q506
H.
9
26
VRTRC
Q518
10
CENT
4
SW
DA8
V-DRIVE
8
BUFFER
Q517
18
PB1
Q508
39
TXD
4
RXD
3
TXD
CN901
4P
WHT
6
ON/OFF
12
24
RXD
HTR
+5V
2
DGND
1
15
DRIVERS
48
47
ABL
PA5
PA6
RED
3
GREEN
GREEN
2
1
GND
GND
1
ROTATION
S0-S4
DEGAUSS
RED
2
STDBY
+5V
CN904
3P
3
7
TO
9
10
185V
8
11
80V
7
12
15V
6
13
5
14
T601
3
SRT
49-53
D9201
SWITCH
S-CAP
CHANGE
CN502
Q519
9P
WHT
CN603
4P
D9202
9
38
Q901,Q902
CN9201
3P
REMOTE
RY500
1
1
AC
LIVE
CN6601
1P
S901
(PWR SWITCH AND LED)
1
AC
IN
1
SWITCH
OUT
4
NC
2
3
NC
3
2
LIVE
Vcc SW-REG
IC601
5
OUT
4
SWITCH
IN
1
OUT
SW-REG
3
+80V
Q602
EA
CIS
4
15
3
16
2
17
1
18
-15V
DGC1
DFT
T503
H.CENTER
IC503
1,2
2
1
DISABLE
+15V
TO
H.CENTER
IC503
IN1,2
AC-RECT
4
LF602
3
LINE
2
N
EMI
LINE
FILTER
1
THP601
2
3
15V
DF-AMP
Q504
1
11
+5V
H1
7
+12V
8
GND
9
+5V
10
9
+5V
5
8
7
S-CAP
CHANGE
Q512,Q513,Q514,Q515,Q516
D601
3
ERROR
IC604
AMP
1
STBY. CONTROL
CN503
2P
Q604
LFT
ROTATION
DRIVE
CN602
2P
THP601A
1
4
+12V
7
OUT
5
BUFF
Q505
6
OUT
IC605
IC603
L
AC
NC
GND
6
5V,12V REG
CN604
4P
TO
+12V
12
3
NC
+80V
SW
Q605,Q606
TO
DRIVE
Q601
DGC2
NC
3
5
HEATER
DGC
+185V
2
4
7
RELAY
+12V
CN601
3P
1
OUT
FLDBK
13
CN6602
1P
+185V
CONT
IC502
1
ROT+
2
ROT-
2
1
B-#SV9055<COMPAQ-D1H>-BLK..
12
11
G3
4
3
B_OUT
G_OUT
5
GND1
R_OUT
24
6
27
26
R104 C055
0.1
68
:CHIP 100V
:CHIP
47
R111
:FPRD
47
2
1
C102
0.1
FB101
0
FB201
0
D204
HSS82
PROT
D304
HSS82
PROT
R_IN
+5V
S/H_G
C204
0.1
25V
0.1
100V
:PT
47
25V
G_GND
G_IN
SYNC_CAP
B_IN
CLAMP
B_OUT
R_OSD
B_GND
VCC
100V
:MPS
D104
HSS82
PROT
C013
47
16
13
D205
HSS82
PROT
BLK
G_OSD
D105
HSS82
PROT
D206
HSS82
PROT
R043
D106
HSS82
PROT
OSD.BLK
B_OSD
15
14
IC004
TDA6103Q
CUT OFF AMP
25V
B:CHIP
1
1/2W
:RC
R209
1M
:CHIP
VCC
B_OUT
G_OUT
R_OUT
FB310
GND
B_IN
R151
100
R309
1M
:CHIP
4
5
6
7
8
9
FB210
CN302
R109
1M
:CHIP
+185V
FB110
R306
10k
:CHIP
C054
0.1
250V
:MPS
250V
R033
15k
:RN
CN303
R_OSD
R003
5.6k
:CHIP
RP
:RN
G_OSD
R005
C046
0.01
B:CHIP
R032
3.9k
470k
:CHIP
B:CHIP
220k
4
HFLB
12
5
C205
0.1
25V
7
10
SDA
6
OUT
VCC
0.1
25V
B:CHIP
STBY+5V
4
FL002
R308
6.8k
:CHIP
C105
0.1
25V
B:CHIP
C028
47
25V
R208
6.8k
:CHIP
82k
:CHIP
R031
1k
:CHIP
C027
0.01
B:CHIP
EMI
8
2
C017
C090
7
0.1
0.01
B:CHIP
1
STBY+5V
6
FB012
R046
C016
470
16V
C001
0.001
500V
C002
0.1
100V
R047
10k
CN306
6P
WHT
:S-MICRO
:CHIP
FB010
10k
:CHIP
3
+80V
2
NC
1
+185V
R006
100
C005
0.001
B:CHIP
:CHIP
1
D.BOARD
CN902
HOSTGND
4
SIGNAL
DDCSDA
3
IN
DDCSCL
2
NC
B-#SV9055<COMPAQ-D1H>-A..
1
CN310
4P
WHT
2
3
1
DDCSDA
DDCSCL
CN311
3P
WHT
:S-MICRO
HOSTGND
:S-MICRO
TO
D.BOARD
CN902
D.BOARD
CN502
Q004
2SC2412K
SWITCH
4
R020
100 :CHIP
GND
:CHIP
R052
FB009
H1
4
R051
1k
5
2
+12V
+12V
5
TO
R021
100 :CHIP
6
3
GND
FB006
+12V
+12V
R017
100
:CHIP
100k
:CHIP
GND
CN305
8P
WHT
:S-MICRO
STBY+5V
CN903
HRTRC
+12V
FB011
3
STBY+5V
VRTRC
CN308
STBY+5V
100
:CHIP
D.BOARD
IICSCL
GND
B:CHIP
R018
TO
-
R049
C305
C022
47
25V
C092
0.1
25V
+
:CHIP
R014
100
:CHIP
9
8
VDD
IC005
NJM4558M
CUT-OFF-CTRL
C029
0.1
25V
B:CHIP
Q001
2SC5022
SPOT KILLER
R307
5.6k
B:CHIP
VFLB
SCL
R053
22M
:RN
R045
2.2k
:CHIP
R207
5.6k
:CHIP
11
6
INT
D014
1SS119-25TD
PROT
6.8k
:CHIP
R310
220k
OSD_BLK
SS
7
R029
120k
:CHIP
R110
220k
R108
L002
FB007
JW(5)
R210
5.6k
:CHIP
B_OSD
C047
47
25V
C053
0.1
25V
R107
VDDA
13
R025
4.7k
:CHIP
D306
HSS82
PROT
+80V
B:CHIP
3
1/2W
:RC
L101
+185V
0.068
25V
3
1.8k
:CHIP
15
2
R004
4.7k
:CHIP
R206
10k
:CHIP
VCO
C044
R024
2
C018
10
VSS
R002
1.5k
:CHIP
:CHIP
1
R133
1k
R106
10k
:CHIP
VSSA
16
STBY+5V
STBY+5V
Q005
MPS3646
R056
2.2k
14
R011
220
IC003
CXD8758P
OSD
C042
0.1
G_IN
C050
0.1
R_IN
12
11
B2_IN
VIP
CLAMP
13
10
GND
R251
100
L201
C106
0.1
250V
:MPS
FB004
G2_IN
15
DEFF.
:MPS
C051
47
25V
14
8
9
VCC2
C049
0.01
B:CHIP
GND
R233
1k
0.1
250V
+12V
25V
B:CHIP
6
3
R2_IN
R351
100
1/2W
:RC
L301
C206
C304
0.1
16
0.01
B:CHIP
D305
HSS82
PROT
16V
S/H_B
19
B_OUT
17
6
B:CHIP
VCC
+80V
+12V
0.01
B:CHIP
C031
SG
R333
1k
FB001
C004
0.1
25V
D.BOARD
CN510
L005
SG101
4
C302
20
18
:CH
7
C019
0.1
VCC
SG201
+80V
C306
0.1
250V
C014
47
C011
25V
B:CHIP
GND
1.2KV
TO
1W
:RN
3
G_OUT
B1_IN
T_SW&LEVEL
IICSDA
1
R048
2.2M
12
B:CHIP
G_OUT
C009
R054
2.2k
:CHIP
CBLK
11
SG301
0
BPCLP
R064
10k
1/2W
:RC
470p
2kV
B
FB301
0
2
GND
SIGNAL_SW
SHRP1
CN301
1P
4
1
C202
0.1
25V
B:CHIP
22
GND
C312
15p
C048
TO
3
KR
5
21
10p
:CH
5
R312
47
:CHIP
R026
10k
:CHIP
R007
100
CSYNC
6
KR
FB005
R_OUT
18
:CHIP
D003
RD5.6ESB2
R016
10k
:CHIP
5
7
6
5
G1_IN
2
VSOUT
8
KG
C035
0.1
25V
B:CHIP
25V
B:CHIP
GND
C212
17
R212
47
GND
7
6
GND
5
D001
RD5.6ESB2
HSYNC
H
9
KB
10
SG001
7
R1_IN
1
CN309
7P
WHT
:S-MICRO
5
10
G2
:FPRD
R211
:FPRD
H 2
4
11
8
:CHIP
C112
15p
:CH
23
R112
47
6
D101
1SS226
C101
0.1
25V
B:CHIP
7
75
:RN-CP
FB103
8
9
7
R311
:CHIP
G1
3
9 G2
47
R204
68
C015
1
13
FB203
R101
9
8
HD
8
R304
C104
0.1
25V
B:CHIP
J001
1
RCV
9
GND2
R_GND
VCC
25
B_BKG
4
10
7
VD
IC006
CXA2093S
RGB PRE-AMP
11
GND
R201
FB102 75
0
:RN-CP
R_IN
R_OUT
9
GND3
G_BKG
S/H_R
12
6
0.1
25V
B:CHIP
1
IN
D201
1SS226
C201
22
5
SIGNAL
FB303
21
RGND
R301
75
FB202
0 :RN-CP
20
GREEN
4
C_SYNC
68
:CHIP
19
3
10
8
7
8
STBY+5V
2
GGND
D301
1SS226
C301
0.1
25V
B:CHIP
FB302
0
3
2
4
1
BLUE
IC002
LM2405T
RGB OUTPUT
G_IN
B_IN
3
R_BKG
4
28
1
2
SCL
11
BGND
RED
G2
SDA
5
CN307
9P
WHT
:S-MICRO
VBIAS
10
IC001
CXA2055P
PRE-AMP
(VIDEO)
CN901
4P
WHT
:S-MICRO
5V
R903
KEY SCAN
IIC CLK
IIC DATA
5V-2
C929
1000p
B:CHIP
IIC CLK
IIC DATA
FOR TEST
VSO
VDD
HSO
HSI1
CSI
VSS
4
13
ABL
THERMAL
9
DATA
CLK
5VDET
IIC
DDC
10k
R954
VSS
C909
1000
10V
H-SYNC
C908
0.01
B:CHIP
D914
1SS119
C931
470p
:CHIP
R730
33
1W
R925
4.7k
:CHIP
5
V-SYNC
H-SYNC
CENT
HV
FLY
3
12V
C546
220p
:CH
4
3
10
3
3
R628
270k
:RN
R627
0.1
Q605
2SB1375
PROT
R636
1k
C625
100K
:PT
RV601
5k
Q505
2SA1309A
C644
47
25V
R506
330k
:RN
BUFFER
FB610
100p
4.7
250V
C604
0.47
560k
C601
250V
250V
5V-2 12V
R507
2.7k
:RN
C503
0.01
B:CHIP
6
80V 185V
-15V
FB614
R604
1/2W
C504
1000p
500V
B
C563
470p
B:CHIP
7
C550
100
16V
10
11
C554
0.1
25V
B
C576
47p
CH
C548
0.001
:PT
C552
0.01
B:CP
9
8
12
C561
0.001
B
R583
10k
:CHIP
12V
R584
4.7k
:CHIP
L507
ROTATION
THERMAL
IC501
BLK
H
V-REF
D401
EGP10G
PWM-CONT
R553
100k
:RN-CP
5mm
C539
0.022
100V
THERMAL
BLK
R540
200k
:RN
16
RV501
100k
C556
220p
:CHIP
R568
47k
+12V
R542
1k
:RN
C532
0.47
100V
R544
1M
:RN
R560
15k
:RN
R520
22
:FPRD
AMP
3
C570
100
25V
5
R574
10k
5
R546
33k
:RN
7
4 6
C541
4.7
5MM
R510
22k
:CHIP
12
9
CN503
2P
R566
22
1W
:RS
C549
0.068
:PT
D517
RD27ES
5V-2
8 9
12
C547
1
R562
12k
:RN
R543
4.7
:FPRD
D515
ERA34
FB503
R571
33k
3W
:RS
R550
1.8k
:RN
6
C519
S 0.001
2kV
:PP
D504
MTZJ-T-77-18
C559
0.0047
:PT
R570
1k
R572
47k
R573
220k
R548
1.8k
:RN-CP
C535
0.01
:PT
R545
47k
:RN-CP
HV-OUT
R579
150k
4
SW
C571
10
D514
HSS82
11
STP5NA80FI
2
R547
560k C542
1
:RN
10
C540
0.01
630V
:PP
R549
82k
:RN
R552
56k
:RN
4
R563
1.5
:FPRD
IC502
LA6500-FA
ROTATION DRIVE
C544
0.01
:PT
15V
R558
10k
:RN
1
3
5
D511
RD5.1ES-TIB2
R580
15k
:CHIP
Q518
2SC3209LK
H-CENT CNTL
Q517
2SC2611
H-CENT SW
R559
2.7k
C513
10
-15V
3
10
4
9
5
8
6
7
T503
3
4
5
D510
ERA34
C528
0.01
2kV
F
C516
0.36
250V
:PP
R512
4.7
0.3
C511
200V
R521
1k
:FPRD
S
C507
0.3
400V
C525
0.082
200V
:PP
C523
0.12
200V
C529
0.047
400V
:PP
CN512
1P
:TUB
+5V
S
C515
0.01
B:CHIP
Q514
IRLI530GLF33
S-CAP CHANGE
R524
47k
:CHIP
Q513
IRLI540GLF33
S-CAP CHANGE
5V
R533
1k
:FPRD
R525
1k
:FPRD
R519
47k
:CHIP
S
C520
0.01
B:CHIP
R536
1k
:FPRD
R523
47k
:CHIP
S
C536
0.01
B:CHIP
Q512
IRLI520GLF33
S-CAP CHANGE
R528
22k
R535
47k
:CHIP
S
C538
0.01
B:CHIP
R537
47k
:CHIP
Q515
IRLI520GLF33
S-CAP CHANGE
TH501
10K
Q516
IRLI520GLF33
S-CAP CHANGE
R532
2.2
:FPRD
CN0002
CN510
1P
CN513
1P
:TUB
SV9055<COMPAQ-D1H>-D..
12V
R515
1k
:FPRD
C512
0.01
B:CHIP
C531
0.068
250V
:PP
C530
0.12
200V
:PP
1
2
6
V DY+
CN501
6P
:DY
1.2KV
1
V DY-
2
NC
H DY-
3
+80V
H DY-
4
H DY+
5
H DY+
6
CN305
1
7
TO A-BOARD
+185V
9
8
H1
NC
N
TO
EMI FILTER-
CN502
9P
WHT
:S-MICRO
GND
FB613
1
2
3
4
FB612
CN605
CN604
4P
C577
0.01
2kV
F
8
+5V
C608
250V
R541
1k
:RN
13
D513
MUR-160
Q510
12
:DFT
D521 D520
ERA34 ERA34
7
5
AC LINE
1000p
2kV
:R
FB615
:RC
100p
R
REF
6
R557
18k
:CHIP
1 1
SG501
L505
2.2mH
C501
10
R501
100
VA601
B
5
HV
L502
C580
0.01
:PT
R575
68
1/2W
:FPRD
C514
0.91
200V
:PP
L506
4
11
Q604
DTC114ESA
STDBY CONTROL
C505
22p
2kV
FB608
C572
4.7
250V
R576
47k
R578
27
2W
:RS
C573
C526
2200p
500V
2
12
Q519
2SC3311A
SW
Q521
2SA1309A
BUFFER
C578
FB611
F601
4A
250V
R531
3W :RS
2
17
H-CENTER
D519
1SS119
-15V
1
Q504
2SC3941A
AMP
82
IC503
LA6500-FA
R565
330k
:RN
13
16
12V
1SS119
R505
10k
:CHIP
3
C551
0.01
B:CP
R538
10
3W
:RS
D507
RD5.1ES
JW117
5MM
2
ABL
3
2
D512
R590
22k
:RN
C517
0.01
:PT
12V
R502
180k
:RN-CP
R643
3.9k
1
2
R630
4.7k
:RN
1/2W
1/2W
14
B4
R
R
FOCUS
R539
10
3W
:RS
H FLY
1
1/2W
150
150
15
R
R
:FBT
FB502
0.45UH
RY500
L509
HLC2
150
R592
R516
16
CP3
14 13
L510
D506
PG124S15
C584
0.1
B:CHIP
R511
1
:FPRD
R589
4.7k
R591
TH502
R593
1.2k
5V
D624
1SS119
DTC114ESA
HEATER SW
2
D505
ERB91-02TP1
R577
27
2W
:RS
ERA82
R637
1.5
1W
:RS
Q606
R629
15k
IC604
TL431CLP
ERROR AMP
C508
100
25V
LF602
:LFT
FB609
R518
3W :RS
17
B3
T501
1/2W
D527
RD5.1ES
R526
4.7k
T505
C662
100
D626
13
2
6
18
B2
R
R585
1k
H BLK
2.2
R530
3W :RS
R587
1k
:CHIP
4
19
CP2
R
R
R551
22k
:RN
C543
100p
CH
11
H
D625
ERA82
R503
10k
:RN-CP
4
D524
HSS82
R586
2.2k
1/2W
C522
0.0022
100V
:PT
2
R635
1k
C643
4700p
250V
1
FB504
C518
4300pF
1.8kV
C510
470p
500V
S
R509
22k
L508
HCL1
D605
1SS119
1
CN603
2P
SAW
V
C502
0.01
:PT
2
R600
1
10W
C605
1
250V
C521
100p
2kV
:SL
H-OUT
20
R
D509
RD10ES
S
82
C583
0.1
:PT
D654
RD2.7ES-TIB2
GND
IN
R522
47
R513
220
2W
15V
R631
220
D622
MTZJ-T-77-8.2
1
+12V
SW
R517
3W :RS
9
5
BU2527AX
2.2
4
2
CN6601/
CN6602
C642
4700p
250V
:PT
D618
EGP20D
D525
HSS82
D516
3DL41A
Q507
6
10
2
S1
OUT
C637
0.1
R626
R620
22k
3
SW
S-BOARD
L
TO
C606
4700p
250V
E
C602
4700p
250V
E
CN602
2P
D502
SB340L
3
Q511
IRFU110
H-DRIVE OUT
D501
RD12ES
R508
100
C579
22p
2kV
:SL
FB505
5MM(JW)
7
-15V
C624
470
16V
C574
0.01
250V
21
CP1
1
L501
2SC3311A
BUFF
C615
0.001
:PT
4
TH600
5.1
300V
D617
EGP20D
2
L606
470
16V
IC603
MOC8105TV
PHOTO COUPLER
RY601
2
R624
0.12
:RF
C623
1000
25V
C633
C645
0.0001
TH601
300V
:POS
1
C575
100
200V
8
22
R569
:RN-CP
R561
3W :RS
CENT
18
FB617
C524
100
200V
12V
Q508
R582
1 56
:FPRD
S2
3
THP600
THP600A
1
23
DP1
R534
100
:FPRD
470
Q503
C407
R411 R409
0.022
6.8k
36k
:PT
:RN-CP:RN-CP
R406
12k
:RN-CP
R405
1.5
1/2W
:RN
C527
0.01
250V
2SJ449(1)
HV-REG
L503
Q520
IRFI9620GS
H-REG
S3
2
17
1
R623
0.12
1/2W
R625
0.12
:RF
D601
GBU4JL
CN601
3P
FB506
:HDT
S4
NC
DGC1
16
2
R403
1.5
1/2W
:RN
14
D518
RD10ES
T504
R641
10k
C632
C558
1
SAW GEN1 AGC TYPE
R527
10k
R410
12k
:RN
S
D616 1000
25V
EGP20DL
R567
10k
:CHIP
B4
185V
C560
0.36
250V
:PP
220
C618
100p
B
5
VA600
3
D611
HSS82
6
1
C622
470
25V
Q522
2SA1309A
SYNC LOCK
C582
10
S4
C617
0.0022
:PT
8
STBYLSET
DEMAGIN
185V
R581
10k
R616
5MM
6
R614
0.22
3W
:RS
R617
1k
R564
47k
:RN-CP
SAW GEN2 NON AGC TYPE
C506
1
C406
0.0047
:PT
R404
5.6k
:RM
L605
1
12
5
D610
RGP10G
R554
150k
:RN-CP
R
82
3
D649
RD13ES-T1B2
R619
2.2k
OVP
CT
9
C661
27p
630V
1W
D602
1SS119
R618
390
C555
0.1
:PT
C562
100
16V
H CENT
C405
0.047
:PT
D402
RD4.7ES
R402
330
1W
:RS
Q523
2SA1309A
SYNC LOCK
R514
22k
:CHIP
C509
100p
500V
B
D403
1SS119
15V
15
C613
10000p
630V
R615
180k
R634
15k
CUR SENSE IN
R649
100k
12V
FB607
D609
RB441Q
4
C611
150p
2kV
4
13
GND
FOLDBACK IN
C553
0.001
B
R556
47k
:RN-CP
H
2
C545
0.022
B
B1
Q506
2SA1309A
BUFF
R529
10k
:FPRD
R500
0.47
:FPRD
R408
10k
:CHIP
R407
2.2k
100
25V
15V
D614
EGP30DL
C621
2200
CN903
7P
WHT
:S-MICRO
IC900
24
C404
470
25V
C403
R401
1.5
:FPRD
C628
D615 25V
EGP20D
R622
0.12
1/2W
INPUT1
HSYNC
R959
3.3k
+5V
E/W
ABL
7
S0
R613
10k
E/AOUT
SFTSTRT
R621
0.1
1/2W
14
INPUT2
4
3
14
C616
470p
B
R603
68
S
CLAMP E/AIN
11
C614
1
:MPS
R612
8.2
OUTPUT
7
R644
3.9k
:CHIP
E/AIN
10
R638
3.9
D648
1SS133
R639
0.1
1/2W
13
5
6
220
R646
100k
GND
7
SHRP1
4
1
H
D607
UF4007
G23
FB604
Q601
DTC143ESA-TP
RELAY DRIVER
12
6
FB606
0.45UH
2
VC
C635
0.01
50V
:PT
7
FB605
5
C408
100p
:PT
FLY
Q602
IRFIBC40G
SW REG
VCC
STBYMNG
15
C634
330
25V
C620
100
100V
4
H
C630
0.1
11
D608
MTZJ-T-77-18
1
16
RREF
R645
47k
8
3
80V
L604
VSYNC
6
ROTATION
D917
UDZ-TE17-5.6B
12V
15V
2
C402
0.22
100V
:PT
470
25V
5
IC601
MC44603P
SW-REG CONTROL
DGC2
:HT
D613
EGP10G
5
C557
22
C401
R601
JW(7.5MM)
L603
R642
220k
1/2W
220
D612
FMC-26UA200V
10
FB602
0.45UH
1
185V
C619
FB601
0.45UH
T601
CSYNC
HV
H-SYNC
C932
0.01
:B
LA7840L
V-OUT
1
R633
10k
9
R611
10k
C934
47p
BPCLAMP
V-SYNC
DEGAUSS
HEATER
4
GND
DISABLE
FB603
1UH
D606
RB441Q
C627
220
25V
-15V
C629
470p
250V
B
BPCLAMP
4
R937
1k
IC401
C626
220
25V
3
V FLY
REMOTE
7
6
NC
5
OUTPUT1
V.DF
HEATER
OUTPUT2
SHRP1
:CHIP
REMOTE ON/OFF
ON/OFF
DEGAUSS
FB616
CBLANK
2
H CENT
R961
100
:CHIP
D916
1SS119
5V-2
L902
C640
4700p
250V
E
JW601
JW(10MM)
1
100
+5V
+5V
5V
12V
100
C912
100
16V
1
E/W
IC605
TDA8138A
5V, 12V REG
R938
C933
0.01
IC904
PST600D-T
RESET
2
V
DEGAUSS
HEATER
TO Q602
HEATSINK
100
C907
1
REMOTE ON/OFF
R609
47k
3W
CN309
100
1k
R935
3
3
TC7SET08F
SYNC BUFF
500V
E
5V
NC
GND
CN9901
TO A-BOARD
2
H FLY
C647
470p
3
C911
0.01
:PT
R927
0
:CHIP
C910
0.1
:PT
H CENT
H BLK
15
2
H BLK
H BLK
15
1
IC905
CAT24C08P
EPROM
FB902
V-SYNC
15
8
R958
:CHIP
ROTATION
HV
SHRP1
IC702
C711
0.1
:PT
7
R924
10k
R729
2.2
1W
:RS
STK392-910A
CONV AMP
6
CN9101
V FLY
V-REF
15
5
5V
CSYNC
BUFF
14
1
D522
1SS119
12
2
D523
1SS119
11
3
CPU
R728
100
1W
:RS
10
RED
GREEN
CN904
FLY
18
17
16
3
R919
IC901
CDX8757S
Q502
2SA1309A
R727
15k
L702
9
GND
2
BPCLAMP
V FLY
C710
470
25V
8
CN9201
1
15V
C708
0.1
:PT
VRTRC
ROTATION
SAW
BLK
V.DF
E/W
V
CSYNC
Q501
2SC3311A
H-DRIVE
15V
7
H-USYNC
HRTRC
D910
RD5.6ES
R936
V-USYNC
D924
MA111-TX
220
:CHIP
9
10
R957
47 :CHIP
R632
R504
0.47
:FPRD
H
R719
15k
D909
RD5.6ES
+5V-2
29
6
HFB
3
30
5
PD3
31
R724
27
1W
C709
470
25V
4
HOST GND
32
2.2
1W
:RS
L701
3
DDC CLK
28
R717
15
2
DDC DATA
PC1
27
12V
100
1W
:RS
1
HEATER
GND
CN902
10P
WHT
:S-MICRO
H FLY
R713
0.68
1W
R718
-15V
IIC CLK
26
R716
33
1W
:RS
IIC DATA
SCL
DDCSCL
8
1k
CBLANK
D923
MA111-TX
D925
MA111-TX
C707
100p
:CH
SDA
DDCSDA
V-REF
V-REF
C706
100p
:CH
R712
33
1W
:RS
R911
390
R910
220
47
LOCK
IICCLK
H
19
D922
MA111-TX
C918
10
R707
10k
RXD
7
TO S-BOARD
A0
PD4
TXD
RDI
R918
A1
ITA
NC
TDO
GND
DDC CLK
R922
10k
:CHIP
A2
22
21
20
10
11
12
13
14
15
R710
10k
V-SYNC
C924
22
Q903
2SC3311A
H-DRIVE
C926
470
16V
YOKE
R711
0.56
1W
HV
V FLY
NC
IICDATA
6
Q902
3311A
DRIVER
Q901
3311A
DRIVER
THERMAL
33
D903
RB441Q
C921
470
16V
34
VCC
C920
0.01
B:CHIP
35
C935
1
DDCSDA
5
TO H-BOARD
36
H.OUT
12V R931
100
5MM
R917
15k
:CHIP
R916
15k
:CHIP
4
37
TO CONV
D919
RD5.6ES
C916
22
25
R709
10k
C928
0.01
C922
1.0
C927
0.01
9V
AFC2
NC
38
H.GND
ABL
39
H.FLY
DELAY CAP
R934
10k
C923
470p
:CHIP
NC
DDCSCL
100
D908
1SS119
WC
CLP
FB904
40
H.DF
D918
RD5.6ES
D907
1SS119
S2
VCC
VSI2
R920
1k
:CHIP
X901
24MHz
C915
22p
CH
41
V.DF
1
47k
3W
:RS
CN9101
HOST GND
4
SCL
H-USYNC
V-USYNC
KEY SCAN
VSI1
CBLANK
C914
22p CH
2
42
R708
10k
R610
TO H-BOARD
1k
3
R914
S4
5V-2
43
SHRP1
24
23
VFB
CLKOUT
2
R912
R913
IIC CLK
R953 10k
28
27
26
25
7
8
PB1
44
PB2
CBLK
OSCIN
45
9
LED GREEN
46
H.AGC
2.2k
C610
390
400V
BRIGHTNESS
1
D901
1SS119
R909
2.2k
:CHIP
S1
D928 UDZ-TE-17-5.6B
30
29
1
2
3
4
5
6
1
18
2
17
3
16
4
15
5
14
6
13
7
LED RED
PA6
47
12
PA5
48
8
PA4
49
11
PA3
OSCOUT
R908
2.2k
:CHIP
IIC DATA
D931
UDZ-TE-17-5.6B S3
50
R.F/V
V.SIN
C925
0.01
B:CHIP
R605
0.1
1/2W
:RF
CONT
1
FB901
:CHIP
R929
4.7k
:CHIP
R933
1k
JW602
JW(10MM)
CN9902
D932
51
9
52
10
53
CY1+
54
2
55
CY1-
PB3
24
4
3
PB4
23
5
PB5
22
6
PB6
21
8
7
CY2+
PB7
D9911
5.6B
D9913
5.6B
DDC 5VDET
C917
0.01
B:CHIP
CY2-
VDD2
20
C913
0.1
:PT
CN701
8P
CY3+
D902
5.6B
C930
0.01
:PT
19
V-REF
18
V.SIN
WHT
:S-MICRO
CY3-
TXD
2
S0
D933
UDZ-TE-17-5.6B
KEY SCAN
V.SIN
CY4+
VSS2
17
VCO.FI
E/W
DA8
16
REF
DA7
15
AFC1
V.SAW
DA6
14
+5V-2
V.AGC
L901
V SAW
C715
470
16V
D934
UDZ-TE-17-5.6B
1
12V
C705
0.1
:PT
A_VCC
R706
4.7k
E/W
CY4-
DEGAUSS
H-USYNC
13
3
H.IN
12
IN
V.DIV
H.PH.FI
11
H-CONV
V.OSC
C906
1.0
:MPS
C703
0.22
:MPS
H-AGC_CAP
V_STATICOUT
2
V.GND
C905
0.068
:PT
C704
220p
CH
H_STATICOUT
1
C713
2200
10V
56
H-SAW_CAP
R705
4.7k
CN703
3P
IN
SCL
10k
C701
0.1
25V
PA1
PA2
DA5
10
V.CONVOUT
GND
REMOTE ON/OFF
D920
RB441QT-77
IIC CLK
R704
C714
390p
CH:CHIP
V_REFIN
2
1
PA0
V-USYNC
D704
1SS119
9
3
V-CONV
4
1k
10k
:CHIP
D906
1SS119
D905
1SS119
RESET
UDZ-TE-17-5.6B
8
H_CONVOUT
OUT
X902
HD.IN
C702
10
OUT
GND
DA4
IR
7
VREF OUT
CN702
3P
V-CONV
V.IN
SDA
DA3
TEST
RESET
+5V
R951
100
:CHIP
IIC DATA
C712
0.1
:PT
D_VCC
SHRP1
DA2
6
V_DF
MENU
R915
4.7k
:CHIP
R703
270
1/2W
DA1
5
SDL
H.CENT
DA0
4
R943
680
:RN-CP
S903
SW
X5
LOCK
ROTATION
3
VPOSIN
D.GND
D VCC
C903
0.01
B:CHIP
C902
470
16V
SCL
AUDIO
C936
220p
2
V_SIN
-
IC902
CXA8071AP
DEF CONTROL
R907
100
1/2W
D935
5.1B
IIC
LOCK
D_GND
1
R941
1k
SDA
+5V
CXA8070P
CONV-CONTROL
A_GND
H-CONV
R904
R906
IC701
+
S902
SW
RXD
5V-2
D929 UDZ-TE-17-5.6B
S901
SW
+5V
3
DDC 5VDET
5V
R940
2.7k
:RN
D930 UDZ-TE-17-5.6B
DEFLECTION)
D GND
2
KEY SCAN
TXD
(POWER
1
1k
RXD
2
ROTATION-
1
ROTATION+
TO A-BOARD
CN306 & CN311
1VR9101
10K
CN9101
FB9101 5MM
2
1VR9102
10K
3
1
5V
2
CONT
3
BRIGHT
4
GND
TO
FB9102 5MM
CN9901
FB9103 5MM
2
(CONT/BRITE
D-BOARD
CNTL)
B-#SV9055<COMPAQ-D1H>-H..
&
CN990
(PWR
SWITCH
AND
LED)
CN9201
3P
3
RED
2
GREEN
1
GND
TO
D9201
D-BOARD
CN904
D9202
1
AC
LIVE
IN
CN6601
1P
TO
D-BOARD
CN603
S901
1
AC
LIVE
CN6602
1P
B-#SV9055<COMPAQ-D1H>-S..
OUT
CN1301
TO
USB
PNP
CN1302
5V
1
1
5V
DMO
2
2
DMO
DPO
3
3
DPO
GND
4
4
TO
DEVICES
U2-BOARD
CN1303
5
(USB1)
B-#SV9055<COMPAQ-D1H>-U1..
DP
GND
GND
CN1303
TO
U1-BOARD
CN1302
CN1304
5V
1
1
5V
DM1
2
2
DM1
DPO
3
3
DP1
4
4
GND
DP
GND
GND
5
(USB2)
B-#SV9055<COMPAQ-D1H>-U2..
TO
COMPUTER
USB
PORT
P75
Note:
Note:
The components Identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
Les composants identifies per un trame et
SECTION
6
une marque ¡ sont critiques pout la
EXPLODED
VIEWS
securite.
Ne les remplacer que par une
piece
•
portant
le
numero
Note:
Note: specifie.
Items with no part number and no descrip- • Items marked " * " are not stocked
tion are not stocked because they are sel- since they are seldom required for routine
The components identified by shading
dom required for routine service.
service. Some delay should be anticipated
and
mark ¡ a re critical for
safety.
REF.NO. PART NO.
DESCRIPTION
REMARK
REF.NO.
PART
NO.
DESCRIPTION
REMARK
when ordering these items.
Replace only with part number specified.
• The component parts of an assembly are
indicated by the reference numbers in the
remarks column.
Note:
6-1. CHASSIS (US/CANADIAN, AEP, NH, SH, AUS models made in US)
r 7-685-648-79
¢ 7-685-663-71
7-685-646-79
7-685-647-79
7-685-882-09
SCREW +BVTP 3x12
SCREW +BVTP 4x16
SCREW +BVTP 3x8
SCREW +BVTP 3x10
SCREW +BVTP 4x10
22
Les composants identifies per un trame
et une marque ¡ sont critiques pour la
securite. Ne les remplacer que par une
piece portant le numero specifie.
23
24
20
19
16
18
21
15
9
7
43
11
36
34
12
27
5
33
29
13
8
35
28
25
3
4
44
37
26
38
2
39
1
PART NO.
32
30
14
6
REF.NO.
31
17
10
DESCRIPTION
40
41
REMARK
REF.NO.
42
PART NO.
DESCRIPTION
REMARK
23 *
24
25 *
26 *
27 ¡
4-063-226-01
4-063-219-01
A-1390-837-A
A-1346-730-A
1-453-241-11
BADGE, COMPAQ
LABEL, INFORMATION
S BOARD, MOUNTED
D BOARD, COMPLETE
TRANSFORMER ASSY, FLYBACK (NX-4400//X4L4)
H BOARD, MOUNTED
ITC ASSY, 17FRFM-R3 (US/CND, AEP, NH) 8-11
ITC ASSY, 17FRFM-RS2 (AUS, SH)
8-11
CRT, 17FRFM (M41LKN50X) (US/CND, AEP, NH)
CRT, 17FRFM (M41LKN15X) ( AUS, SH)
28 *
29
30
31
32 *
1-900-802-2
4-045-121-01
4-046-901-01
1-784-638-11
1-783-562-11
CONNECTOR ASSY. 4P
STOPPER (A), STAND
SPRING, TENSION
INLET, AC
CABLE ASSY VIDEO (15P D-SUB)
4-040-897-01
1-452-923-21
8-451-490-21
1-500-386-11
A-1298-503-A
SPACER, DY
NECK ASSY
DY Y17FRJ3-M
FILTER CLAMP (FERRITE CORE)
A BOARD, COMPLETE
33 *
34 *
35 *
36
37
4-045-131-01
4-063-213-01
X-4035-361-1
4-389-025-01
4-063-237-01
STOPPER, CABLE
BRACKET, CABLE
BOTTOM COVER ASSY
SCREW (M4x8)(EXT.TOOTHWASHER)
BASE, STAND UPPER
14 *
15 *
16
17 ¡
18
4-061-571-01
4-061-573-01
3-704-372-31
1-416-282-21
4-041-021-02
CUSHION (A)
SPRING, TENSION
HOLDER, HV CABLE
COIL, DEMAGNETIC
HOLDER, DGC
38
39 *
40 *
41 *
42
4-048-148-01
A-1373-668-A
A-1373-669-A
4-060-533-01
4-063-238-01
STOPPER (B)
U1 BOARD, MOUNTED
U2 BOARD, MOUNTED
CUSHION
BASE, STAND LOWER
19 *
20
21 *
22
4-056-260-01
4-365-808-01
4-041-758-02
4-063-225-01
DGC, SPACER
SCREW (5), TAPPING
HOLDER, DGC
CABINET
43
44
1-452-032-00
4-045-471-01
MAGNET, DISC
LABEL, ENERGY STAR
1 *
2
3
4
5
X-4035-359-1
4-063-224-01
4-063-220-01
4-063-222-01
4-063-212-01
BEZEL ASSY
SPRING, COMPRESSION
BUTTON, POWER
GUIDE, LIGHT
DIAL, ROTARY
6
7
7
8
8
*
¡
¡
¡
¡
A-1372-451-A
8-738-733-83
8-738-728-81
8-738-726-05
8-738-728-05
9
10 ¡
11 ¡
12
13 *
2-4
— 29 —
P75
Note:
SECTION 6
EXPLODED VIEWS
Note:
The components Identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
•
Les composants identifies per un trame et
une marque ¡ sont critiques pout la
securite. Ne les remplacer que par une
piece portant le numero specifie.
Note:
Items with no part number and no descrip- • Items marked " * " are not stocked
tion are not stocked because they are sel- since they are seldom required for routine
The components identified by shading
dom required for routine service.
service. Some delay should be anticipated
and
mark ¡ a re critical for
safety.
REF.NO.
PART
NO.
DESCRIPTION
REMARK
REF.NO. PART NO.
DESCRIPTION
REMARK
when ordering these items.
Replace only with part number specified.
• The component parts of an assembly are
indicated by the reference numbers in the
remarks column.
Note:
Les composants identifies per un trame
et une marque ¡ sont critiques pour la
securite. Ne les remplacer que par une
piece portant le numero specifie.
6-2. CHASSIS (AEP, UK models made in UK)
r 7-685-648-79
¢ 7-685-663-71
7-685-646-79
7-685-647-79
7-685-882-09
SCREW +BVTP 3x12
SCREW +BVTP 4x16
SCREW +BVTP 3x8
SCREW +BVTP 3x10
SCREW +BVTP 4x10
22
23
24
20
19
16
18
21
15
9
7
43
11
36
34
12
27
5
33
29
13
8
35
28
25
3
4
44
37
26
38
2
39
1
PART NO.
32
30
14
6
REF.NO.
31
17
10
41
DESCRIPTION
1 *
2
3
4 *
5
X-4035-526-1
4-063-224-01
4-064-196-01
4-064-198-01
4-064-219-01
BEZEL ASSY
SPRING, COMPRESSION
BUTTON, POWER
GUIDE, LIGHT
DIAL, ROTARY
6 *
7 ¡
8 ¡
9
10 ¡
A-1372-473-A
8-738-733-83
8-738-726-05
4-040-897-01
1-452-923-21
H BOARD, MOUNTED
ITC ASSY, 17FRFM-R3
CRT, 17FRFM (M41LKN50X)
SPACER, DY
NECK ASSY
11 ¡
12
13 *
14 *
15 *
8-451-490-11
1-500-386-11
A-1298-545-A
4-062-321-01
4-047-316-01
16
17 ¡
18
19 *
20
21 *
22
40
REMARK
2-4
REF.NO.
42
PART NO.
DESCRIPTION
REMARK
23 *
24
25 *
26 *
27 ¡
4-064-201-01
4-064-206-01
A-1390-846-A
A-1346-743-A
1-453-241-11
BADGE, COMPAQ
LABEL, INFORMATION
S BOARD, MOUNTED
D BOARD, COMPLETE
TRANSFORMER ASSY, FLYBACK (NX-4400//X4L4)
28
29
30
31
32 *
1-900-802-21
4-045-121-01
4-046-901-01
1-784-638-11
1-783-562-11
CONNECTOR ASSY. 4P
STOPPER (A), STAND
SPRING, TENSION
INLET, AC
CABLE ASSY VIDEO (15P D-SUB)
DY Y17FRJ3-M
FILTER CLAMP (FERRITE CORE)
A BOARD, COMPLETE
CUSHION (A)
SPRING, TENSION
33 *
34 *
35 *
36
37
4-045-131-11
4-063-213-01
X-4035-528-1
4-389-025-01
4-064-210-01
STOPPER, CABLE
BRACKET, CABLE
BOTTOM COVER ASSY
SCREW (M4x8)(EXT.TOOTHWASHER)
BASE, STAND UPPER
3-704-372-31
1-416-282-21
4-041-021-02
4-056-260-01
4-365-808-01
HOLDER, HV CABLE
COIL, DEMAGNETIC
HOLDER, DGC
DGC, SPACER
SCREW (5), TAPPING
38
39 *
40 *
41 *
42
4-048-148-01
A-1394-885-A
A-1394-886-A
4-060-533-01
4-064-211-01
STOPPER (B)
U1 BOARD, MOUNTED
U2 BOARD, MOUNTED
CUSHION
BASE, STAND LOWER
4-041-758-02
4-064-200-01
HOLDER, DGC
CABINET
43
44
1-452-032-00
4-045-471-01
MAGNET, DISC
LABEL, ENERGY STAR
8-11
— 30 —
P75
Note:
The components Identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
6-3. PACKING MATERIALS
REF.NO.
Note:
PART NO.
DESCRIPTION
Les composants identifies per un trame et
une marque ¡ sont critiques pout la
securite. Ne les remplacer que par une
piece portant le numero specifie.
REMARK
REF.NO.
PART NO.
DESCRIPTION
53
52
54
55
56
REF.NO.
PART NO.
DESCRIPTION
REMARK
52
52
53 ¡
53 ¡
53 ¡
4-063-231-01
4-064-213-01
1-776-027-41
1-558-481-11
1-765-719-11
CUSHION, UPPER (US/CND, AEP, NH, SH, AUS models made in US)
CUSHION, UPPER (AEP, UK models made in UK)
CORD SET, POWER (US/CND models made in US)
CORD SET, POWER (AUS model made in US)
CORD SET, POWER (AEP models made in US and UK))
54
55
55
56
56
4-041-927-11
4-063-232-01
4-064-214-01
4-063-233-01
4-064-215-01
BAG, POLYETHYLENE
CUSHION, LOWER (US/CND, AEP, NH, SH, AUS models made in US)
CUSHION, LOWER (AEP, UK models made in UK)
INDIVIDUAL CARTON (US/CND, AEP, NH, SH, AUS models made in US)
INDIVIDUAL CARTON (AEP, UK models made in UK)
— 31 —
REMARK
P75
A
Note:
SECTION 7 Note:
ELECTRICAL PARTS LIST
The components Identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
Note:
The components
Identified
REF.NO.
PART NO.
DESCRIPTIONby shading
and mark ¡ a re critical for safety.
Replace only with part number specified.
The components identified by [ in this manual
have been carefully factory-selected for each
set in order to satisfy regulations
REF.NO. regarding
PART NO. XREMARK
ray radiation. Should replacement be required,
replace only with the value originally used.
Les composants identifies per un trame et
une marque ¡ sont critiques pout la
securite. Ne les remplacer que par une
piece portant le numero specifie.
RESISTORS
• All resistors are in ohms
DESCRIPTION
REMARK
• F : nonflammable
*
Note:
Les composants identifies per un trame
et une marque ¡ sont critiques pout la
securite. Ne les remplacer que par une
piece portant le numero specifie.
REF.NO.
PART NO.
DESCRIPTION
REMARK
A-1298-503-B A BOARD, COMPLETE
(US/CANADIAN, AEP, NH, SH, AUS models made in US)
*
INDUCTORS
MF = µF
UH = µH
MMH = MH
When indicating parts by reference
number, please include the board name.
• All variable and adjustable resistors have
characteristic curve B, unless otherwise
noted.
A
*
CAPACITORS
•
• Items marked " " are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
A-1298-545-B A BOARD, COMPLETE
(AEP, UK models made in UK)
4-382-854-11 SCREW (M3X10), P, SW (+)
CAPACITOR
REF.NO.
PART NO.
DESCRIPTION
REMARK
C053
C054
C055
C090
C092
1-164-004-11
1-137-528-11
1-104-503-12
1-164-232-11
1-164-004-11
CERAMIC CHIP
FILM
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1MF
0.1MF
0.1MF
0.01MF
0.1MF
10%
10%
10%
10%
10%
25V
250V
100V
50V
25V
C093
C101
C102
C104
C105
1-163-251-11
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
CERAMIC
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.1MF
0.1MF
0.1MF
0.1MF
5%
10%
10%
10%
10%
50V
25V
25V
25V
25V
C001
C002
C004
C005
C009
1-162-318-11
1-106-220-00
1-164-232-11
1-163-009-11
1-107-888-11
CERAMIC
MYLAR
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.001MF
0.1MF
0.01MF
0.001MF
47MF
10%
10%
10%
10%
20%
500V
100V
50V
50V
25V
C106
C112
C201
C202
C204
1-137-528-11
1-163-231-11
1-164-004-11
1-164-004-11
1-164-004-11
FILM
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1MF
15PF
0.1MF
0.1MF
0.1MF
10%
5%
10%
10%
10%
250V
50V
25V
25V
25V
C011
C013
C014
C015
C016
1-106-220-00
1-107-909-11
1-107-932-11
1-164-004-11
1-128-528-11
MYLAR
ELECT
ELECT
CERAMIC CHIP
ELECT
0.1MF
47MF
47MF
0.1MF
470MF
10%
20%
20%
10%
20%
100V
16V
100V
25V
16V
C205
C206
C212
C301
C302
1-164-004-11
1-137-528-11
1-163-227-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
FILM
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1MF
0.1MF
10PF
0.1MF
0.1MF
10%
10%
5%
10%
10%
25V
250V
50V
25V
25V
C017
C018
C019
C022
C027
1-130-495-00
1-107-961-91
1-130-495-00
1-104-664-11
1-164-232-11
FILM
ELECT
FILM
ELECT
CERAMIC CHIP
0.1MF
10MF
0.1MF
47MF
0.01MF
5%
20%
5%
20%
10%
50V
250V
50V
25V
50V
C304
C305
C306
C312
1-164-004-11
1-164-004-11
1-137-528-11
1-163-231-11
CERAMIC CHIP
CERAMIC CHIP
FILM
CERAMIC CHIP
0.1MF
0.1MF
0.1MF
15PF
10%
10%
10%
5%
25V
25V
250V
50V
C028
C029
C031 ¡
C035
C042
1-104-664-11
1-164-004-11
1-517-499-21
1-162-134-11
1-164-004-11
ELECT
CERAMIC CHIP
GAP, SPARK
CERAMIC
CERAMIC CHIP
47MF
0.1MF
20%
10%
25V
25V
470PF
0.1MF
10%
10%
2KV
25V
C044
C046
C047
C048
C049
1-164-344-11
1-164-232-11
1-104-664-11
1-164-232-11
1-164-232-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.068MF
0.01MF
47MF
0.01MF
0.01MF
10%
10%
20%
10%
10%
25V
50V
25V
50V
50V
C050
C051
1-164-004-11 CERAMIC CHIP
1-104-664-11 ELECT
0.1MF
47MF
10%
20%
25V
25V
CONNECTOR
CN301
CN302
CN303
CN305
CN306 *
1-506-108-41
1-695-915-11
1-695-915-11
1-564-511-11
1-564-509-11
PIN, CONNECTOR (TERMINAL PIN)
TAB (CONTACT)
TAB (CONTACT)
PLUG, CONNECTOR 8P
PLUG, CONNECTOR 6P
CN307 *
CN308
CN309 *
CN310 *
CN311 *
1-564-512-11
1-695-915-11
1-564-510-11
1-564-507-11
1-564-506-11
PLUG, CONNECTOR 9P
TAB (CONTACT)
PLUG, CONNECTOR 7P
PLUG, CONNECTOR 4P
PLUG, CONNECTOR 3P
— 32 —
P75
Note:
REF.NO.
The components Identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
PART NO.
DESCRIPTION
DIODE
D001
D003
D014
D101
D104
8-719-109-89
8-719-109-89
8-719-911-19
8-719-800-76
8-719-970-83
DIODE RD5.6ESB2
DIODE RD5.6ESB2
DIODE 1SS119-25
DIODE 1SS226
DIODE HSS82
D105
D106
D201
D204
D205
8-719-970-83
8-719-970-83
8-719-800-76
8-719-970-83
8-719-970-83
DIODE HSS82
DIODE HSS82
DIODE 1SS226
DIODE HSS82
DIODE HSS82
D206
D301
D304
D305
D306
8-719-970-83
8-719-800-76
8-719-970-83
8-719-970-83
8-719-970-83
DIODE HSS82
DIODE 1SS226
DIODE HSS82
DIODE HSS82
DIODE HSS82
Note:
REMARK
A
Les composants identifies per un trame et
une marque ¡ sont critiques pout la
securite. Ne les remplacer que par une
piece portant le numero specifie.
REF.NO.
PART NO.
IC003
IC004
IC005
IC006
8-759-530-14
8-759-434-40
8-759-100-96
8-752-082-65
DESCRIPTION
REMARK
IC CXD8758P
IC TDA6103Q/N3,112
IC UPC4558G2
IC CXA2093S
JACK
J001¡
1-251-598-11 SOCKET, CRT
COIL
L002
L005
L101
L102
L201
1-410-682-31
1-412-529-11
1-410-750-41
1-216-296-91
1-410-750-41
INDUCTOR
INDUCTOR
INDUCTOR
SHORT
INDUCTOR
470UH
22UH
0.47UH
L301
1-410-750-41 INDUCTOR
0.47UH
0.47UH
FERRITE BEAD
TRANSISTOR
FB001
FB004
FB005
FB006
FB009
1-412-911-11
1-412-911-11
1-412-911-11
1-412-911-11
1-412-911-11
FERRITE
FERRITE
FERRITE
FERRITE
FERRITE
FB010
FB011
FB012
FB101
FB102
1-412-911-11
1-412-911-11
1-412-911-11
1-216-295-91
1-216-295-91
FERRITE
FERRITE
FERRITE
SHORT
SHORT
FB103 ¡
FB110
FB201
FB202
FB203 ¡
1-500-104-21
1-412-911-11
1-216-295-91
1-216-295-91
1-500-104-21
FERRITE
FERRITE
SHORT
SHORT
FERRITE
FB210
FB301
FB302
FB303 ¡
FB310
1-412-911-11
1-216-295-91
1-216-295-91
1-500-104-21
1-412-911-11
FERRITE
SHORT
SHORT
FERRITE
FERRITE
Q001
Q004
Q005
8-729-032-61 TRANSISTOR 2SC5022-02
8-729-120-28 TRANSISTOR 2SC1623-L5L6
8-729-045-08 TRANSISTOR NPS3646
RESISTOR
R002
R003
R004
R005
R006
1-216-053-00
1-216-067-00
1-216-055-00
1-216-113-00
1-216-025-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1.5K
5.6K
1.8K
470K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R007
R011
R014
R016
R017
1-216-025-91
1-216-033-00
1-216-025-91
1-216-073-00
1-216-025-91
RES,CHIP
RES, CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
220
100
10K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R018
R020
R021
R024
R025
1-216-025-91
1-216-025-91
1-216-025-91
1-216-065-91
1-216-065-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
100
100
4.7K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R026
R029
R031
R032
R033
1-216-073-00
1-216-099-00
1-216-049-91
1-216-063-91
1-216-077-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10K
120K
1K
3.9K
15K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
FILTER
FL002
1-412-911-11 FERRITE
IC
IC001
IC002
8-752-076-89 IC CXA2055P
8-759-435-33 IC LM2405T
— 33 —
P75
AD
Note:
Note:
The components Identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
DESCRIPTION
REF.NO.
REF.NO.
PART NO.
REMARK
R043
R045
R046
R047
R048
1-216-295-91
1-216-057-00
1-216-097-91
1-216-073-00
1-211-885-21
SHORT
RES,CHIP
RES,CHIP
RES,CHIP
METAL
0
2.2K
100K
10K
2.2M
5%
5%
5%
5%
1/10W
1/10W
1/10W
1W
R049
R051
R052
R053
R054
1-216-697-91
1-216-049-91
1-216-073-00
1-219-621-91
1-216-057-00
METAL CHIP
RES,CHIP
RES,CHIP
METAL
RES,CHIP
82K
1K
10K
22M
2.2K
0.50%
5%
5%
10%
5%
1/10W
1/10W
1/10W
1/4W
1/10W
Les composants identifies per un trame et
une marque ¡ sont critiques pout la
securite. Ne les remplacer que par une
piece portant le numero specifie.
PART NO.
DESCRIPTION
REMARK
SPARK GAP
R055
R056
R064
R101
R104
1-247-815-91
1-216-057-00
1-202-830-00
1-215-394-00
1-216-021-00
CARBON
RES,CHIP
SOLID
METAL
RES,CHIP
220
2.2K
10K
75
68
5%
5%
20%
1%
5%
1/4W
1/10W
1/2W
1/4W
1/10W
R106
R107
R108
R109
R110
1-216-073-00
1-216-067-00
1-216-069-00
1-216-121-91
1-215-477-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
METAL
10K
5.6K
6.8K
1M
220K
5%
5%
5%
5%
1%
1/10W
1/10W
1/10W
1/10W
1/4W
R111
R112
R133
R151
R201
1-249-401-11
1-216-017-91
1-249-417-11
1-202-549-00
1-215-394-00
CARBON
RES,CHIP
CARBON
SOLID
METAL
47
47
1K
100
75
5%
5%
5%
20%
1%
1/4W F
1/10W
1/4W
1/2W
1/4W
R204
R206
R207
R208
R209
1-216-021-00
1-216-073-00
1-216-067-00
1-216-069-00
1-216-121-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
68
10K
5.6K
6.8K
1M
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R210
R211
R212
R233
R251
1-215-477-00
1-249-401-11
1-216-017-91
1-249-417-11
1-202-549-00
METAL
CARBON
RES,CHIP
CARBON
SOLID
220K
47
47
1K
100
1%
5%
5%
5%
20%
1/4W
1/4W F
1/10W
1/4W
1/2W
R301
R304
R306
R307
R308
1-215-394-00
1-216-021-00
1-216-073-00
1-216-067-00
1-216-069-00
METAL
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
75
68
10K
5.6K
6.8K
1%
5%
5%
5%
5%
1/4W
1/10W
1/10W
1/10W
1/10W
R309
R310
R311
R312
R333
1-216-121-91
1-215-477-00
1-249-401-11
1-216-017-91
1-249-417-11
RES,CHIP
METAL
CARBON
RES,CHIP
CARBON
1M
220K
47
47
1K
5%
1%
5%
5%
5%
1/10W
1/4W
1/4W F
1/10W
1/4W
R351
1-202-549-00 SOLID
100
20%
1/2W
SG001¡
SG101¡
SG201¡
SG301¡
1-519-422-11
1-517-499-21
1-517-499-21
1-517-499-21
GAP, SPARK
GAP, SPARK
GAP, SPARK
GAP, SPARK
D
— 34 —
*
A-1346-730-A D BOARD, COMPLETE
(US/CANADIAN, AEP, NH, SH, AUS models made in US)
*
A-1346-743-A D BOARD, COMPLETE
(AEP, UK models made in UK)
1-533-223-11
1-564-506-11
1-691-960-11
2-371-561-00
4-060-555-01
4-382-854-01
4-382-854-11
4-382-854-21
CLIP, FUSE
PLUG, CONNECTOR 3P
PIN, CONNECTOR (PC BOARD) 3P
BUSHING (P), INSULATING
SHEET, INSULATOR
SCREW (M3X8), P, SW (+)
SCREW (M3X10), P, SW (+)
SCREW (M3X14), P, SW (+)
CAPACITOR
C401
C402
C403
C404
C405
1-107-914-11
1-106-228-00
1-126-969-11
1-126-941-11
1-137-374-11
ELECT
MYLAR
ELECT
ELECT
FILM
1000MF
0.22MF
220MF
470MF
0.047MF
20%
10%
20%
20%
5%
25V
100V
50V
25V
50V
C406
C407
C408
C501
C502
1-137-368-11
1-137-372-11
1-102-973-00
1-126-964-11
1-137-370-11
FILM
FILM
CERAMIC
ELECT
FILM
0.0047MF
0.022MF
100PF
10MF
0.01MF
5%
5%
5%
20%
5%
50V
50V
50V
50V
50V
C503
C504
C505
C506
C507
1-164-232-11
1-164-645-11
1-109-879-11
1-126-960-11
1-117-964-11
CERAMIC CHIP
CERAMIC
CERAMIC
ELECT
FILM
0.01MF
1000PF
22PF
1MF
0.3MF
10%
10%
5%
20%
5%
50V
500V
2KV
50V
400V
C508
C509
C510
C511
C512
1-104-665-11
1-162-117-00
1-102-228-00
1-119-862-11
1-164-232-11
ELECT
CERAMIC
CERAMIC
FILM
CERAMIC CHIP
100MF
100PF
470PF
0.3MF
0.01MF
20%
10%
10%
5%
10%
25V
500V
500V
200V
50V
C513
C514
C515
C516
C517
1-126-964-11
1-119-861-11
1-164-232-11
1-117-206-21
1-137-370-11
ELECT
FILM
CERAMIC CHIP
FILM
FILM
10MF
0.91MF
0.01MF
0.36MF
0.01MF
20%
5%
10%
5%
5%
50V
200V
50V
250V
50V
P75
Note:
Note:
The components Identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
REF.NO.
PART NO.
DESCRIPTION
REMARK
C518
C519
C520
C521
C522
1-117-954-11
1-136-538-11
1-164-232-11
1-107-444-11
1-136-481-11
FILM
FILM
CERAMIC CHIP
CERAMIC
MYLAR
4300PF
0.001MF
0.01MF
100PF
0.0022MF
3%
3%
10%
5%
10%
C523
C524
C525
C526
C527
1-115-511-11
1-107-955-11
1-119-860-11
1-164-646-11
1-117-879-91
FILM
ELECT
FILM
CERAMIC
CAPACITOR
0.12MF
100MF
0.082MF
2200PF
0.01MF
C528
C529
C530
C531
C532
1-115-349-51
1-136-060-00
1-115-511-11
1-115-509-11
1-137-426-11
CERAMIC
FILM
FILM
FILM
FILM
C535
C536
C538
C539
C540
1-137-370-11
1-164-232-11
1-164-232-11
1-137-418-11
1-136-203-11
C541
C542
C543
C544
C545
D
Les composants identifies per un trame et
une marque ¡ sont critiques pout la
securite. Ne les remplacer que par une
piece portant le numero specifie.
REF.NO.
PART NO.
1.8KV
2KV
50V
2KV
100V
C576
C577
C578
C579
C580
1-163-243-11
1-115-349-51
1-161-754-00
1-109-879-11
1-137-370-11
CERAMIC CHIP
CERAMIC
CERAMIC
CERAMIC
FILM
47PF
0.01MF
0.001MF
22PF
0.01MF
5%
10%
5%
5%
50V
2KV
2KV
2KV
50V
5%
20%
5%
10%
10%
200V
200V
200V
500V
250V
C582
C583
C584
C601 ¡
C602 ¡
1-126-964-11
1-130-495-00
1-130-495-00
1-117-693-11
1-117-703-11
ELECT
FILM
FILM
CERAMIC
CERAMIC
10MF
0.1MF
0.1MF
100PF
0.0047MF
20%
5%
5%
10%
20%
50V
50V
50V
250V
250V
0.01MF
0.047MF
0.12MF
0.068MF
0.47MF
5%
5%
5%
10%
2KV
400V
200V
250V
100V
C604 ¡
C605 ¡
C606 ¡
C608 ¡
C610
1-104-708-11
1-107-533-11
1-117-703-11
1-117-693-11
1-109-984-11
FILM
FILM
CERAMIC
CERAMIC
ELECT(BLOCK)
0.47MF
1MF
0.0047MF
100PF
390MF
20%
20%
20%
10%
20%
250V
250V
250V
250V
400V
FILM
CERAMIC CHIP
CERAMIC CHIP
FILM
FILM
0.01MF
0.01MF
0.01MF
0.022MF
10000PF
5%
10%
10%
10%
5%
50V
50V
50V
100V
630V
C613
C614
C615
C616
1-136-203-11
1-136-177-00
1-137-364-11
1-130-014-00
FILM
FILM
FILM
CERAMIC
10000PF
1MF
0.001MF
470PF
5%
5%
5%
5%
630V
50V
50V
50V
1-126-963-11
1-126-964-11
1-102-973-00
1-137-370-11
1-163-037-11
ELECT
ELECT
CERAMIC
FILM
CERAMIC CHIP
4.7MF
10MF
100PF
0.01MF
0.022MF
20%
20%
5%
5%
10%
50V
50V
50V
50V
50V
C617
C618
C619
C620
C621
1-137-366-11
1-102-106-00
1-125-700-11
1-107-933-11
1-107-890-11
FILM
CERAMIC
ELECT(BLOCK)
ELECT
ELECT
0.0022MF
100PF
220MF
100MF
2200MF
5%
10%
20%
20%
20%
50V
50V
200V
100V
25V
C546
C547
C548
C549
C550
1-163-259-91
1-126-960-11
1-137-364-11
1-137-375-11
1-126-933-11
CERAMIC CHIP
ELECT
FILM
FILM
ELECT
220PF
1MF
0.001MF
0.068MF
100MF
5%
20%
5%
5%
20%
50V
50V
50V
50V
16V
C622
C623
C624
C625
C626
1-126-941-11
1-126-942-61
1-126-935-11
1-249-441-11
1-107-889-11
ELECT
ELECT
ELECT
CARBON
ELECT
470MF
1000MF
470MF
100K
220MF
20%
20%
20%
5%
20%
25V
25V
16V
1/4W
25V
C551
C552
C553
C554
C555
1-164-232-11
1-164-232-11
1-163-009-11
1-164-004-11
1-130-495-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
FILM
0.01MF
0.01MF
0.001MF
0.1MF
0.1MF
10%
10%
10%
10%
5%
50V
50V
50V
25V
50V
C627
C628
C629
C630
C632
1-107-889-11
1-104-665-11
1-117-703-11
1-130-495-00
1-107-914-11
ELECT
ELECT
CERAMIC
FILM
ELECT
220MF
100MF
0.0047MF
0.1MF
1000MF
20%
20%
20%
5%
20%
25V
25V
250V
50V
25V
C556
C557
C558
C559
C560
1-163-259-91
1-126-965-11
1-126-960-11
1-137-368-11
1-117-206-21
CERAMIC CHIP
ELECT
ELECT
FILM
FILM
220PF
22MF
1MF
0.0047MF
0.36MF
5%
20%
20%
5%
5%
50V
50V
50V
50V
250V
C633
C634
C635
C637
C640
1-126-935-11
1-126-940-11
1-137-370-11
1-130-495-00
1-117-703-11
ELECT
ELECT
FILM
FILM
CERAMIC
470MF
330MF
0.01MF
0.1MF
0.0047MF
20%
20%
5%
5%
20%
16V
25V
50V
50V
250V
C561
C562
C563
C570
C571
1-163-009-11
1-126-933-11
1-163-005-11
1-104-665-11
1-126-964-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
ELECT
0.001MF
100MF
470PF
100MF
10MF
10%
20%
10%
20%
20%
50V
16V
50V
25V
50V
C642 ¡
C643 ¡
C644
C645
C647
1-117-703-11
1-117-703-11
1-104-664-11
1-137-358-11
1-102-228-00
CERAMIC
CERAMIC
ELECT
FILM
CERAMIC
0.0047MF
0.0047MF
47MF
0.0001MF
470PF
20%
20%
20%
5%
10%
250V
250V
25V
50V
500V
C572
C573
C574
C575
1-107-651-11
1-107-651-11
1-117-879-91
1-107-955-11
ELECT
ELECT
CAPACITOR
ELECT
4.7MF
4.7MF
0.01MF
100MF
20%
20%
10%
20%
250V
250V
250V
200V
C661
C662
C701
C702
C703
1-102-516-11
1-126-933-11
1-164-004-11
1-126-964-11
1-136-169-00
CERAMIC
ELECT
CERAMIC CHIP
ELECT
FILM
27PF
100MF
0.1MF
10MF
0.22MF
5%
20%
10%
20%
5%
50V
16V
25V
50V
50V
— 35 —
DESCRIPTION
REMARK
P75
D
Note:
The components Identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
REF.NO.
PART NO.
DESCRIPTION
REMARK
C704
C705
C706
C707
C708
1-163-259-91
1-130-495-00
1-102-973-00
1-102-973-00
1-130-495-00
CERAMIC CHIP
FILM
CERAMIC
CERAMIC
FILM
220PF
0.1MF
100PF
100PF
0.1MF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C709
C710
C711
C712
C713
1-126-941-11
1-126-941-11
1-130-495-00
1-130-495-00
1-126-927-11
ELECT
ELECT
FILM
FILM
ELECT
470MF
470MF
0.1MF
0.1MF
2200MF
20%
20%
5%
5%
20%
25V
25V
50V
50V
10V
C714
C715
C902
C903
C905
1-163-131-00
1-126-935-11
1-126-935-11
1-164-232-11
1-137-375-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
FILM
390PF
470MF
470MF
0.01MF
0.068MF
5%
20%
20%
10%
5%
50V
16V
16V
50V
50V
C906
C907
C908
C909
C910
1-136-177-00
1-126-960-11
1-164-232-11
1-126-926-11
1-130-495-00
FILM
ELECT
CERAMIC CHIP
ELECT
FILM
1MF
1MF
0.01MF
1000MF
0.1MF
5%
20%
10%
20%
5%
50V
50V
50V
10V
50V
C911
C912
C913
C914
C915
1-137-370-11
1-126-933-11
1-130-495-00
1-102-514-11
1-102-514-11
FILM
ELECT
FILM
CERAMIC
CERAMIC
0.01MF
100MF
0.1MF
22PF
22PF
5%
20%
5%
5%
5%
50V
16V
50V
50V
50V
C916
C917
C918
C920
C921
1-126-965-11
1-164-232-11
1-126-964-11
1-164-232-11
1-126-935-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
22MF
0.01MF
10MF
0.01MF
470MF
20%
10%
20%
10%
20%
50V
50V
50V
50V
16V
C922
C923
C924
C925
C926
1-126-960-11
1-163-133-00
1-126-965-11
1-164-232-11
1-126-935-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
1MF
470PF
22MF
0.01MF
470MF
20%
5%
20%
10%
20%
50V
50V
50V
50V
16V
C927
C928
C929
C930
C931
1-164-232-11
1-164-232-11
1-163-009-11
1-137-370-11
1-163-133-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
FILM
CERAMIC CHIP
0.01MF
0.01MF
0.001MF
0.01MF
470PF
10%
10%
10%
5%
5%
50V
50V
50V
50V
50V
C932
C933
C934
C935
C936
1-164-232-11
1-164-232-11
1-163-243-11
1-136-177-00
1-163-259-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
FILM
CERAMIC CHIP
0.01MF
0.01MF
47PF
1MF
220PF
10%
10%
5%
5%
5%
50V
50V
50V
50V
50V
REF.NO.
Note:
Les composants identifies per un trame et
une marque ¡ sont critiques pout la
securite. Ne les remplacer que par une
piece portant le numero specifie.
PART NO.
DESCRIPTION
CONNECTOR
CN501 *
CN502
CN512
CN513
CN602
1-580-798-11
*1-564-512-11
1-695-915-11
1-695-915-11
*1-506-371-00
CONNECTOR PIN (DY) 6P
PLUG, CONNECTOR 9P
TAB (CONTACT)
TAB (CONTACT)
PIN, CONNECTOR 2P
CN603 ¡ *1-580-690-11 PIN, CONNECTOR (PC BOARD) 2P
CN604 ¡ *1-580-689-11 PIN, CONNECTOR (PC BOARD) 4P
CN605 1-695-915-11 TAB (CONTACT)
CN701 1-564-511-11 PLUG, CONNECTOR 8P
CN901 *1-508-879-11 BASE POST 4P
CN902 1-564-513-11 PLUG, CONNECTOR 10P
CN903 *1-564-510-11 PLUG, CONNECTOR 7P
CN904 *1-564-506-11 PLUG, CONNECTOR 3P
CN0002 1-695-915-11 TAB (CONTACT)
CN9901 1-900-802-23 CONNECTOR ASSY, 4P
CN9902 1-900-802-23 CONNECTOR ASSY, 4P
DIODE
— 36 —
D401
D402
D403
D501
D502
8-719-979-58
8-719-109-81
8-719-911-19
8-719-110-31
8-719-975-77
DIODE EGP10D
DIODE RD4.7ESB2
DIODE 1SS119-25
DIODE RD12ESB2
DIODE SB340
D504
D505
D506
D507
D509
8-719-110-49
8-719-941-74
8-719-061-21
8-719-109-85
8-719-110-17
DIODE RD18ESB2
DIODE ERB91-02
DIODE FMQ-G5FMS
DIODE RD5.1ESB2
DIODE RD10ESB2
D510
D511
D512
D513
D514
8-719-018-82
8-719-109-85
8-719-911-19
8-719-066-40
8-719-970-83
DIODE ERA34-10TPI
DIODE RD5.1ESB2
DIODE 1SS119-25
DIODE MUR160
DIODE HSS82
D515
D516
D517 ¡
D518
D519
8-719-018-82
8-719-051-97
8-719-110-67
8-719-110-17
8-719-911-19
DIODE RGP02-20EL-6394
DIODE 3DL41A(LC6-15)
DIODE RD27ESB2
DIODE RD10ESB2
DIODE 1SS119-25
D520
D521
D522
D523
D524
8-719-018-82
8-719-018-82
8-719-911-19
8-719-911-19
8-719-970-83
DIODE ERA34-10TP1
DIODE ERA34-10TPI
DIODE 1SS119-25
DIODE 1SS119-25
DIODE HSS82
D525
D527
8-719-970-83 DIODE HSS82
8-719-109-85 DIODE RD5.1ESB2
REMARK
P75
Note:
The components Identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
REF.NO.
PART NO.
DESCRIPTION
D601 ¡
D602
D605
D606
D607
8-719-025-88
8-719-911-19
8-719-911-19
8-719-986-73
8-719-053-19
DIODE GBU4JL-6088
DIODE 1SS119-25
DIODE 1SS119-25
DIODE RB441Q
DIODE UF4007G23
D608
D609
D610
D611
D612
8-719-110-49
8-719-986-73
8-719-302-43
8-719-970-83
8-719-067-68
DIODE RD18ESB2
DIODE RB441Q
DIODE EL1Z
DIODE HSS82
DIODE FMC-26UA
D613
D614
D615
D616
D617
8-719-979-58
8-719-058-38
8-719-051-97
8-719-048-61
8-719-979-84
DIODE EGP10D
DIODE FMN-G12S
DIODE 3DL41A(LC6-15)
DIODE EGP20DL-6349
DIODE EGP20DPKG23
D618
D622
D624
D625
D626
8-719-979-84
8-719-110-08
8-719-911-19
8-719-987-87
8-719-987-87
DIODE EGP20DPKG23
DIODE RD8.2ESB2
DIODE 1SS119-25
DIODE ERA85-009
DIODE ERA85-009
D648
D649
D654
D704
D901
8-719-110-36
8-719-991-33
8-719-109-60
8-719-911-19
8-719-911-19
DIODE RD13ES-T1B2
DIODE 1SS133T-77
DIODE RD2.7ESB2
DIODE 1SS119-25
DIODE 1SS119-25
D902
D903
D905
D906
D907
8-719-109-89
8-719-986-73
8-719-911-19
8-719-911-19
8-719-911-19
DIODE RD5.6ESB2
DIODE RB441Q
DIODE 1SS119-25
DIODE 1SS119-25
DIODE 1SS119-25
D908
D909
D910
D914
D916
8-719-911-19
8-719-109-89
8-719-109-89
8-719-911-19
8-719-911-19
DIODE 1SS119-25
DIODE RD5.6ESB2
DIODE RD5.6ESB2
DIODE 1SS119-25
DIODE 1SS119-25
D917
D918
D919
D920
D922
8-719-158-15
8-719-109-89
8-719-109-89
8-719-986-73
8-719-404-49
DIODE RD5.6SB
DIODE RD5.6ESB2
DIODE RD5.6ESB2
DIODE RB441Q
DIODE MA111
D923
D924
D925
D928
D929
8-719-404-49
8-719-404-49
8-719-404-49
8-719-158-15
8-719-158-15
DIODE MA111
DIODE MA111
DIODE MA111
DIODE RD5.6SB
DIODE RD5.6SB
D930
D931
D932
8-719-158-15 DIODE RD5.6SB
8-719-158-15 DIODE RD5.6SB
8-719-158-15 DIODE RD5.6SB
Note:
REMARK
D
Les composants identifies per un trame et
une marque ¡ sont critiques pout la
securite. Ne les remplacer que par une
piece portant le numero specifie.
REF.NO.
PART NO.
D933
D934
D935
D9911
D9913
8-719-158-15
8-719-158-15
8-719-976-99
8-719-158-15
8-719-158-15
DESCRIPTION
REMARK
DIODE RD5.6SB
DIODE RD5.6SB
DIODE DTZ5.1B
DIODE RD5.6SB
DIODE RD5.6SB
FUSE
F601 ¡ 1-576-231-11 FUSE (H.B.C.) 4A/250V
FERRITE BEAD
FB502
FB504
FB506
FB601
FB602
1-410-396-41
1-412-911-11
1-412-911-11
1-410-396-41
1-410-396-41
FERRITE
FERRITE
FERRITE
FERRITE
FERRITE
0.45UH
FB603
FB604
FB605
FB606
FB607
1-414-487-41
1-412-911-11
1-412-911-11
1-410-396-41
1-412-911-11
INDUCTOR
FERRITE
FERRITE
FERRITE
FERRITE
1UH
FB608 ¡
FB609 ¡
FB610 ¡
FB611 ¡
FB612 ¡
1-412-911-11
1-412-911-11
1-412-911-11
1-412-911-11
1-412-911-11
FERRITE
FERRITE
FERRITE
FERRITE
FERRITE
FB613 ¡
FB614 ¡
FB615 ¡
FB616
FB617
1-412-911-11
1-412-911-11
1-412-911-11
1-412-911-11
1-412-911-11
FERRITE
FERRITE
FERRITE
FERRITE
FERRITE
FB902
FB904
1-247-807-31 CARBON
1-543-961-11 FERRITE
IC
IC401
IC501 ¡
IC502
IC503
IC601 ¡
8-759-444-83
8-759-478-76
8-759-803-42
8-759-803-42
8-759-399-81
IC LA7840L
IC UPC5021-109
IC LA6500-FA
IC LA6500-FA
IC MC44603P
IC603 ¡
IC604 ¡
IC605 ¡
IC701
IC702
8-749-012-59
8-759-908-15
8-759-072-98
8-759-478-66
8-749-014-32
IC MOC8105TV
IC TL431CLP
IC TDA8138A
IC CXA8070P
IC STK392-910A
— 37 —
0.45UH
0.45UH
0.45UH
100
5%
1/4W
P75
D
REF.NO.
PART NO.
IC900
IC901
IC902
IC904
IC905
8-759-525-10
8-759-529-90
8-759-537-27
8-759-165-81
8-759-370-34
Note:
The components Identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
DESCRIPTION
REMARK
Note:
Les composants identifies per un trame et
une marque ¡ sont critiques pout la
securite. Ne les remplacer que par une
piece portant le numero specifie.
REF.NO.
PART NO.
L901
L902
1-412-537-31 INDUCTOR
1-412-537-31 INDUCTOR
IC TC7SET08F(TE85L)
IC CXD8757S
IC CXA8071AP
IC PST600D-T
IC ST24C08FB6
DESCRIPTION
REMARK
100UH
100UH
FILTER
LF602 ¡ 1-429-180-11 TRANSFORMER, LINE FILTER
CHIP CONDUCTOR
JR001
JR002
JR003
JR004
JR005
1-216-296-91
1-216-296-91
1-216-295-91
1-216-296-91
1-216-296-91
SHORT
SHORT
SHORT
SHORT
SHORT
JR007
JR008
JR009
JR010
JR011
1-216-296-91
1-216-296-91
1-216-296-91
1-216-296-91
1-216-296-91
SHORT
SHORT
SHORT
SHORT
SHORT
JR013
JR015
JR016
JR017
JR018
1-216-296-91
1-216-296-91
1-216-296-91
1-216-296-91
1-216-296-91
SHORT
SHORT
SHORT
SHORT
SHORT
JR019
JR020
JR022
JR023
JR024
1-216-296-91
1-216-296-91
1-216-296-91
1-216-296-91
1-216-296-91
SHORT
SHORT
SHORT
SHORT
SHORT
JR025
JR026
JR027
JR030
1-216-296-91
1-216-296-91
1-216-296-91
1-216-296-91
SHORT
SHORT
SHORT
SHORT
TRANSISTOR
COIL
L501
L502
L503
L505
L506
1-412-531-31
1-412-531-31
1-411-594-41
1-412-552-11
1-412-545-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
33UH
33UH
L508
L509
L510
L603
L604
1-416-394-11
1-416-393-11
1-416-367-11
1-412-537-31
1-412-537-31
COIL, HORIZONTAL LINEARITY
COIL, HORIZONTAL LINEARITY
COIL, HORIZONTAL CENTER
INDUCTOR
100UH
INDUCTOR
100UH
L605
L606
L701
L702
1-406-665-11
1-406-665-11
1-412-537-31
1-412-537-31
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
2.2MMH
470UH
Q501
Q502
Q503
Q504
Q505
8-729-119-78
8-729-119-76
8-729-035-54
8-729-031-89
8-729-119-76
TRANSISTOR 2SC2785-HFE
TRANSISTOR 2SA1175-HFE
TRANSISTOR 2SJ449
TRANSISTOR 2SC3941A-Q(TA)
TRANSISTOR 2SA1175-HFE
Q506
Q507
Q508
Q510
Q511 ¡
8-729-119-76
8-729-041-64
8-729-119-78
8-729-042-45
8-729-042-34
TRANSISTOR 2SA1175-HFE
TRANSISTOR BU2527AX-ON5020
TRANSISTOR 2SC2785-HFE
TRANSISTOR STP5NA80FI
TRANSISTOR IRFU110A
Q512
Q513
Q514
Q515
Q516
8-729-043-16
8-729-041-95
8-729-041-93
8-729-043-16
8-729-043-16
TRANSISTOR IRLI520GLF33
TRANSISTOR IRLI540GLF33
TRANSISTOR IRLI530GLF33
TRANSISTOR IRLI520GLF33
TRANSISTOR IRLI520GLF33
Q517
Q518
Q519
Q520
Q521
8-729-326-11
8-729-140-50
8-729-119-78
8-729-042-23
8-729-119-76
TRANSISTOR 2SC2611
TRANSISTOR 2SC3209LK
TRANSISTOR 2SC2785-HFE
TRANSISTOR IRFI9620GSLF35
TRANSISTOR 2SA1175-HFE
Q522
Q523
Q601
Q602 ¡
Q604 ¡
8-729-119-76
8-729-119-76
8-729-029-92
8-729-926-79
8-729-029-66
TRANSISTOR 2SA1175-HFE
TRANSISTOR 2SA1175-HFE
TRANSISTOR DTC143ESA
TRANSISTOR IRFIBC40
TRANSISTOR DTC114ESA
Q605
Q606
Q901
Q902
Q903
8-729-141-83
8-729-029-66
8-729-119-78
8-729-119-78
8-729-119-78
TRANSISTOR 2SB1094-LK
TRANSISTOR DTC114ESA
TRANSISTOR 2SC2785-HFE
TRANSISTOR 2SC2785-HFE
TRANSISTOR 2SC2785-HFE
RESISTOR
R401
R402
R403
R404
R405
100UH
100UH
— 38 —
1-249-383-11
1-215-866-11
1-214-796-00
1-215-439-00
1-214-796-00
CARBON
METAL OXIDE
METAL
METAL
METAL
1.5
330
1.5
5.6K
1.5
5%
5%
1%
1%
1%
1/4W F
1W F
1/2W
1/4W
1/2W
P75
Note:
Note:
The components Identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
DESCRIPTION
REMARK
D
Les composants identifies per un trame et
une marque ¡ sont critiques pout la
securite. Ne les remplacer que par une
piece portant le numero specifie.
REF.NO.
PART NO.
R406
R407
R408
R409
R410
1-216-677-11
1-249-421-11
1-216-073-00
1-216-671-11
1-215-447-00
METAL CHIP
CARBON
RES,CHIP
METAL CHIP
METAL
12K
2.2K
10K
6.8K
12K
0.50%
5%
5%
0.50%
1%
1/10W
1/4W
1/10W
1/10W
1/4W
R544
R545
R546
R547
R548
METAL
METAL CHIP
METAL
METAL
METAL CHIP
1M
47K
33K
560K
1.8K
1%
0.50%
1%
1%
0.50%
1/4W
1/10W
1/4W
1/4W
1/10W
R411
R500
R501
R502
R503
1-216-688-11
1-249-377-11
1-247-807-31
1-218-758-11
1-216-675-11
METAL CHIP
CARBON
CARBON
METAL CHIP
METAL CHIP
36K
0.47
100
180K
10K
0.50%
5%
5%
0.50%
0.50%
1/10W
1/4W F
1/4W
1/10W
1/10W
R504
R505
R506
R507
R508
1-249-377-11
1-216-073-00
1-215-481-00
1-215-431-00
1-247-807-31
CARBON
RES,CHIP
METAL
METAL
CARBON
0.47
10K
330K
2.7K
100
5%
5%
1%
1%
5%
1/4W F
1/10W
1/4W
1/4W
1/4W
R549 ¡ 1-215-467-00 METAL
R550 ¡ 1-215-427-00 METAL
R551
1-215-453-00 METAL
R552 ¡ 1-215-463-00 METAL
R553
1-216-699-11 METAL CHIP
R554
1-218-756-11 METAL CHIP
R556
1-216-691-11 METAL CHIP
R557
1-216-079-00 RES,CHIP
R558
1-215-445-00 METAL
82K
1.8K
22K
56K
100K
150K
47K
18K
10K
1%
1%
1%
1%
0.50%
0.50%
0.50%
5%
1%
1/4W
1/4W
1/4W
1/4W
1/10W
1/10W
1/10W
1/10W
1/4W
R509
R510
R511
R512
R513
1-247-863-91
1-216-081-00
1-249-381-11
1-249-389-11
1-215-888-00
CARBON
RES,CHIP
CARBON
CARBON
METAL OXIDE
22K
22K
1
4.7
220
5%
5%
5%
5%
5%
1/4W
1/10W
1/4W F
1/4W
2W F
R559
R560
R561
R562
R563
1-215-431-00
1-215-449-00
1-216-474-11
1-215-447-00
1-249-383-11
METAL
METAL
METAL OXIDE
METAL
CARBON
2.7K
15K
82
12K
1.5
1%
1%
5%
1%
5%
1/4W
1/4W
3W F
1/4W
1/4W F
R514
R515
R516
R517
R518
1-216-081-00
1-249-417-11
9-910-999-31
1-216-393-00
1-216-393-00
RES,CHIP
CARBON
METAL
METAL OXIDE
METAL OXIDE
22K
1K
150
2.2
2.2
5%
5%
1%
5%
5%
1/10W
1/4W F
1/2W
3W F
3W F
R564
R565
R566
R567
R568
1-216-089-91
1-215-481-00
1-215-859-00
1-216-073-00
1-249-437-11
RES,CHIP
METAL
METAL OXIDE
RES,CHIP
CARBON
47K
330K
22
10K
47K
5%
1%
5%
5%
5%
1/10W
1/4W
1W F
1/10W
1/4W
R519
R520
R521
R522
R523
1-216-089-91
1-249-397-11
1-249-417-11
1-249-401-11
1-216-089-91
RES,CHIP
CARBON
CARBON
CARBON
RES,CHIP
47K
22
1K
47
47K
5%
5%
5%
5%
5%
1/10W
1/4W F
1/4W F
1/4W
1/10W
R569
R570
R571
R572
R573
1-216-643-11
1-249-417-11
1-215-926-00
1-249-437-11
1-247-887-00
METAL CHIP
CARBON
METAL OXIDE
CARBON
CARBON
470
1K
33K
47K
220K
0.50%
5%
5%
5%
5%
1/10W
1/4W
3W F
1/4W
1/4W
R524
R525
R526
R527
R528
1-216-089-91
1-249-417-11
1-249-425-11
1-249-429-11
1-247-863-91
RES,CHIP
CARBON
CARBON
CARBON
CARBON
47K
1K
4.7K
10K
22K
5%
5%
5%
5%
5%
1/10W
1/4W F
1/4W
1/4W
1/4W
R574
R575
R576
R577
R578
1-249-429-11
1-260-314-11
1-249-437-11
1-216-447-00
1-216-447-00
CARBON
CARBON
CARBON
METAL OXIDE
METAL OXIDE
10K
68
47K
27
27
5%
5%
5%
5%
5%
1/4W
1/2W
1/4W
2W F
2W F
R529
R530
R531
R532
R533
1-249-429-11
1-216-474-11
1-216-474-11
1-249-385-11
1-249-417-11
CARBON
METAL OXIDE
METAL OXIDE
CARBON
CARBON
10K
82
82
2.2
1K
5%
5%
5%
5%
5%
1/4W
3W
3W
1/4W
1/4W
R579
R580
R581
R582
R583
1-247-883-00
1-216-077-00
1-249-429-11
1-249-402-11
1-216-073-00
CARBON
RES,CHIP
CARBON
CARBON
RES,CHIP
150K
15K
10K
56
10K
5%
5%
5%
5%
5%
1/4W
1/10W
1/4W
1/4W F
1/10W
R534
R535
R536
R537
R538
1-249-405-11
1-216-089-91
1-249-417-11
1-216-089-91
1-215-905-11
CARBON
RES,CHIP
CARBON
RES,CHIP
METAL OXIDE
100
47K
1K
47K
10
5%
5%
5%
5%
5%
1/4W F
1/10W
1/4W F
1/10W
3W F
R584
R585
R586
R587
R589
1-216-065-91
1-260-099-11
1-260-103-11
1-216-049-91
1-249-425-11
RES,CHIP
CARBON
CARBON
RES,CHIP
CARBON
4.7K
1K
2.2K
1K
4.7K
5%
5%
5%
5%
5%
1/10W
1/2W
1/2W
1/10W
1/4W
R539
R540
R541
R542
R543
1-215-905-11
1-215-476-00
1-215-421-00
1-215-421-00
1-249-389-11
METAL OXIDE
METAL
METAL
METAL
CARBON
10
200K
1K
1K
4.7
5%
1%
1%
1%
5%
3W F
1/4W
1/4W
1/4W
1/4W F
R590
R591
R592
R593
R600 ¡
1-215-453-00
9-910-999-31
9-910-999-31
1-215-423-00
1-205-998-11
METAL
METAL
METAL
METAL
CEMENTED
22K
150
150
1.2K
1
1%
1%
1%
1%
5%
1/4W
1/2W
1/2W
1/4W
10W
REF.NO.
F
F
F
F
F
— 39 —
¡
¡
¡
¡
PART NO.
1-215-493-00
1-216-691-11
1-215-457-00
1-215-487-00
1-216-657-11
DESCRIPTION
REMARK
P75
D
REF.NO.
PART NO.
Note:
The components Identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
DESCRIPTION
REMARK
Note:
REF.NO.
PART NO.
Les composants identifies per un trame et
une marque ¡ sont critiques pout la
securite. Ne les remplacer que par une
piece portant le numero specifie.
DESCRIPTION
REMARK
R603
1-249-403-11 CARBON
R604 ¡ 1-202-847-00 SOLID
R605 ¡ 1-202-933-61 FUSIBLE
R609
1-215-927-00 METAL OXIDE
R610
1-215-927-00 METAL OXIDE
68
560K
0.1
47K
47K
5%
20%
10%
5%
5%
1/4W
1/2W
1/2W F
3W F
3W F
R710
R711
R712
R713
R716
1-249-429-11
1-216-346-00
1-215-860-11
1-216-347-11
1-215-860-11
CARBON
METAL OXIDE
METAL OXIDE
METAL OXIDE
METAL OXIDE
10K
0.56
33
0.68
33
5%
5%
5%
5%
5%
1/4W
1W
1W
1W
1W
R611
R612
R613
R614
R615
1-215-445-00
1-249-392-11
1-249-429-11
1-216-381-11
1-247-885-00
METAL
CARBON
CARBON
METAL OXIDE
CARBON
10K
8.2
10K
0.22
180K
1%
5%
5%
5%
5%
1/4W
1/4W
1/4W
3W F
1/4W
R717
R718
R719
R724
R727
1-216-353-00
1-215-863-11
1-249-431-11
1-216-423-11
1-249-431-11
METAL OXIDE
METAL OXIDE
CARBON
METAL OXIDE
CARBON
2.2
100
15K
27
15K
5%
5%
5%
5%
5%
1W F
1W F
1/4W
1W F
1/4W
R617
R618
R619
R620
R621 ¡
1-249-417-11
1-215-411-00
1-249-421-11
1-247-863-91
1-211-761-11
CARBON
METAL
CARBON
CARBON
FUSIBLE
1K
390
2.2K
22K
0.1
5%
1%
5%
5%
10%
1/4W
1/4W
1/4W
1/4W
1/2W
R728
R729
R730
R903
R904
1-215-863-11
1-216-353-00
1-215-860-11
1-249-417-11
1-249-417-11
METAL OXIDE
METAL OXIDE
METAL OXIDE
CARBON
CARBON
100
2.2
33
1K
1K
5%
5%
5%
5%
5%
1W F
1W F
1W F
1/4W
1/4W
R622 ¡
R623 ¡
R624 ¡
R625 ¡
R626
1-211-874-11
1-211-874-11
1-219-154-11
1-219-154-11
1-215-405-00
FUSIBLE
FUSIBLE
FUSIBLE
FUSIBLE
METAL
0.12
0.12
0.12
0.12
220
10%
10%
10%
10%
1%
1/2W
1/2W
1/4W
1/4W
1/4W
R906
R907
R908
R909
R910
1-216-073-00
1-260-087-11
1-216-057-00
1-216-057-00
1-247-815-91
RES,CHIP
CARBON
RES,CHIP
RES,CHIP
CARBON
10K
100
2.2K
2.2K
220
5%
5%
5%
5%
5%
1/10W
1/2W
1/10W
1/10W
1/4W
R627
R628
R629
R630
R631
1-130-495-00
1-215-479-00
1-215-449-00
1-215-437-00
1-215-405-00
CARBON
METAL
METAL
METAL
METAL
0.1MF
270K
15K
4.7K
220
5%
1%
1%
1%
1%
50V
1/4W
1/4W
1/4W
1/4W
R911
R912
R913
R914
R915
1-249-412-11
1-249-417-11
1-247-807-31
1-247-807-31
1-216-065-91
CARBON
CARBON
CARBON
CARBON
RES,CHIP
390
1K
100
100
4.7K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/10W
R632
R633
R634
R635
R636
1-216-033-00
1-249-429-11
1-249-431-11
1-216-049-91
1-216-049-91
RES,CHIP
CARBON
CARBON
RES,CHIP
RES,CHIP
220
10K
15K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/4W
1/4W
1/10W
1/10W
R916
R917
R918
R919
R920
1-216-077-00
1-216-077-00
1-249-417-11
1-249-417-11
1-216-049-91
RES,CHIP
RES,CHIP
CARBON
CARBON
RES,CHIP
15K
15K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/4W
1/4W
1/10W
R637
R638
R639 ¡
R641
R642
1-216-351-00
1-215-435-00
1-211-761-11
1-249-429-11
1-260-127-11
METAL OXIDE
METAL
FUSIBLE
CARBON
CARBON
1.5
3.9K
0.1
10K
220K
5%
1%
10%
5%
5%
1W F
1/4W
1/2W
1/4W F
1/2W
R922
R924
R925
R927
R929
1-216-073-00
1-249-429-11
1-216-065-91
1-216-295-91
1-216-065-91
RES,CHIP
CARBON
RES,CHIP
SHORT
RES,CHIP
10K
10K
4.7K
0
4.7K
5%
5%
5%
1/10W
1/4W
1/10W
5%
1/10W
R643
R644
R645
R646
R649
1-215-435-00
1-216-665-11
1-216-691-11
1-249-441-11
1-218-642-11
METAL
METAL CHIP
METAL CHIP
CARBON
METAL OXIDE
3.9K
3.9K
47K
100K
100K
1%
0.50%
0.50%
5%
5%
1/4W
1/10W
1/10W
1/4W
1W F
R931
R933
R934
R935
R936
1-216-659-11
1-249-417-11
1-249-429-11
1-247-807-31
1-247-807-31
METAL CHIP
CARBON
CARBON
CARBON
CARBON
2.2K
1K
10K
100
100
0.50%
5%
5%
5%
5%
1/10W
1/4W
1/4W
1/4W
1/4W
R675
R703
R704
R705
R706
1-249-401-11
1-260-092-11
1-215-445-00
1-249-425-11
1-249-425-11
CARBON
CARBON
METAL
CARBON
CARBON
47
270
10K
4.7K
4.7K
5%
5%
1%
5%
5%
1/4W
1/2W
1/4W
1/4W
1/4W
R937
R938
R940
R941
R943
1-249-417-11
1-247-807-31
1-215-431-00
1-216-651-11
1-216-647-11
CARBON
CARBON
METAL
METAL CHIP
METAL CHIP
1K
100
2.7K
1K
680
5%
5%
1%
0.50%
0.50%
1/4W
1/4W
1/4W
1/10W
1/10W
R707
R708
R709
1-249-429-11 CARBON
1-249-429-11 CARBON
1-249-429-11 CARBON
10K
10K
10K
5%
5%
5%
1/4W
1/4W
1/4W
R951
R953
R954
R957
1-216-025-91
1-216-073-00
1-216-073-00
1-216-017-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
10K
10K
47
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
— 40 —
F
F
F
F
P75
Note:
Note:
The components Identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
REF.NO.
PART NO.
DESCRIPTION
R958
R959
R961
1-216-017-91 RES,CHIP
1-216-061-00 RES,CHIP
1-216-025-91 RES,CHIP
REMARK
47
3.3K
100
5%
5%
5%
Les composants identifies per un trame et
une marque ¡ sont critiques pout la
securite. Ne les remplacer que par une
piece portant le numero specifie.
REF.NO.
1/10W
1/10W
1/10W
PART NO.
D H
S U1
DESCRIPTION
H
*
A-1372-451-A H BOARD, MOUNTED
*
A-1372-473-A H BOARD, MOUNTED
VARIABLE RESISTOR
(US/CANADIAN, AEP, NH, SH, AUS models made in US)
[ RV501¡ 1-241-767-21 RES, ADJ, CERMET 100K
3-710-578-01 COVER, VOLUME, 6 MOLD (for RV501)
RV601 1-223-480-11 RES, ADJ, CERMET 5K
(AEP, UK models made in UK)
CONNECTOR
CN9101* 1-900-802-24 CONNECTOR ASSY, 4P
RELAY
RY500 1-755-137-11 RELAY
RY601¡ 1-755-031-11 RELAY
VARISTOR
VR9101 1-237-979-11 RES, VAR, CARBON 10K
VR9102 1-237-979-11 RES, VAR, CARBON 10K
SWITCH
S901
S902
S903
1-692-431-21 SWITCH, TACTILE
1-692-431-21 SWITCH, TACTILE
1-692-431-21 SWITCH, TACTILE
S
*
A-1390-837-A S BOARD, MOUNTED
*
A-1390-846-A S BOARD, MOUNTED
(US/CANADIAN, AEP, NH, SH, AUS models made in US)
SPARK GAP
(AEP, UK models made in UK)
SG501¡ 1-519-422-11 GAP, SPARK
DIODE
TRANSFORMER
T501 ¡ 1-453-241-11 TRANSFORMER ASSY, FLYBACK (NX-4400//X4L4)
T503
1-429-109-11 TRANSFORMER, FERRITE (DFT)
T504 ¡ 1-429-103-11 TRANSFORMER, FERRITE (HDT)
T505
1-429-211-11 TRANSFORMER, FERRITE (HST)
T601 ¡ 1-431-534-11 TRANSFORMER, CONVERTER (SRT)
THERMISTOR
TH501
TH502
TH600¡
TH601¡
1-807-796-11
1-807-796-11
1-809-827-11
1-809-827-11
D9201
D9202
8-719-070-70 DIODE EL1224UGC
8-719-070-71 DIODE EL1224UYC/S190
SWITCH
S6601¡ 1-571-433-21 SWITCH, PUSH (AC POWER)
U1
THERMISTOR
THERMISTOR
THERMISTOR
THERMISTOR, POSITIVE
*
A-1373-668-A U1 BOARD, MOUNTED
*
A-1394-885-A U1 BOARD, MOUNTED
(US/CANADIAN, AEP, NH, SH, AUS models made in US)
(AEP, UK models made in UK)
VARISTOR
CONNECTOR
VA600¡ 1-810-622-11 VARISTOR
VA601¡ 1-810-271-21 VARISTOR ZNR-14DK471U
CN1301 1-779-642-12 CONNECTOR, USB (A)
CN1302 1-900-802-69 CONNECTOR ASSY, 5P BOARD IN
CRYSTAL
X901
X902
1-767-641-21 VIBRATOR, CRYSTAL
1-767-933-11 OSCILLATOR, CERAMIC
— 41 —
REMARK
P75
Note:
U2
REF.NO.
PART NO.
The components Identified by shading
and mark ¡ are critical for safety.
Replace only with part number specified.
DESCRIPTION
REF.NO.
REMARK
U2
*
A-1373-669-A U2 BOARD, MOUNTED
*
A-1394-886-A U2 BOARD, MOUNTED
(US/CANADIAN, AEP, NH, SH, AUS models made in US)
(AEP, UK models made in UK)
CONNECTOR
CN1303 1-900-802-69 CONNECTOR ASSY, 5P BOARD IN
CN1304 1-779-677-11 CONNECTOR, USB (B)
MISCELLANEOUS
¡
¡
¡
¡
¡
¡
*
¡
¡
¡
1-416-282-21
1-452-923-21
1-453-241-11
1-500-386-11
1-558-481-11
COIL, DEMAGNETIC
NECK ASSY
TRANSFORMER ASSY, FLYBACK (NX-4400//X4L4)
FILTER CLAMP (FERRITE CORE)
CORD SET, POWER (AUS model made in US)
1-765-719-11
1-776-027-41
1-783-562-11
3-704-372-31
4-041-021-02
CORD SET, POWER (AEP models made in US and UK)
CORD SET, POWER (US/CND models made in US)
CABLE ASSY VIDEO (15P D-SUB)
HOLDER, HV CABLE
HOLDER, DGC
4-041-758-02 HOLDER, DGC
4-812-134-21 RIVET
8-451-490-11 DY Y17FRJ3-M (AEP, UK models made in UK)
8-451-490-21 DY Y17FRJ3-M
(US/CANADIAN, AEP, NH, SH, AUS models made in US)
8-738-733-83 ITC ASSY, 17FRFM-R3
(US/CND, AEP, NH models made in US) / (AEP, UK models made in UK)
¡
¡
8-738-728-81 ITC ASSY, 17FRFM-RS2 ( AUS, SH models made in US)
8-738-726-05 CRT, 17FRFM (M41LKN50X)
¡
8-738-728-05 CRT, 17FRFM (M41LKN15X) ( AUS, SH models made in US)
(US/CND, AEP, NH models made in US) / (AEP, UK models made in UK)
— 42 —
Note:
PART NO.
Les composants identifies per un trame et
une marque ¡ sont critiques pout la
securite. Ne les remplacer que par une
piece portant le numero specifie.
DESCRIPTION
REMARK