MJ50 Gas Fryers with Filtration -- CE MJ50 G as

Item
Quantity
CSI Section 11400
MJ50 Gas Fryers with
Filtration -- CE
Models
FMJ250
FMJ350
• Open-pot design is easy to clean
• 50-lb (25-liter*) oil capacity per full frypot
• 97,271 Btu/hr. input (24,502 kcal) (28.5
kw) per full frypot
• Frying area 14” x 15” x 5” (35.6 x 38.1 x
12.7 cm) per full frypot
• Master Jet burner system distributes heat
evenly for efficient heat exchange and
quick recovery
• Digital Control Standard
• Stainless steel frypot, door and cabinet
• Reliable, centerline, fast-action
temperature probe
• Deep cold zone, 1-1/4 in. (3.2 cm) IPS balltype drain valve
• Two twin baskets per frypot
• Casters
• Gas connection -- see chart
• EZSpark™ push-button ignitor
•O
ver-the-flue basket hangers
• Frypot cover(s)
Specifications
Designed for versatililty, proven
performance and trouble-free filtering of
fryer batteries without wasting valuable
space
The MJ50 gas fryers are unsurpassed in their
versatility, controlled performance and low
maintenance needs. The MJ50 fryers offer
options that accommodate a wide range of
frying needs -- everything from French fries, prebreaded products to specialty foods.
The Master Jet burner system distributes heat
evenly around the frypot, generating a large
heat-transfer area for efficient exchange and
quick recovery. They have earned a legendary
reputation for durability and reliability. The
MJ burners require no burner cleaning or air
shutter adjustment. The reliable centerline
fast-action temperature probe assures accurate
temperatures for efficient heat-up, cooking and
recovery.
The filtering process is fast and easy,
encouraging frequent filtering -- a critical part
of maximizing oil life, especially with trans-fat
Filter Standard Features
•5
0-lb (25 liter*) oil capacity
• Space-saving filter which fits inside fryer
cabinet housing two full or qualifying
split frypots in two left most cabinets of
the battery
• Filter pan designed on rails to clear
floormats for easy cleaning
• Sloped drain pan leaves minimal residue
oil behind after filtering
• Large 3” (8.0 cm) round drain line allows
oil to drain freely
• Filter cycle is complete from start to
finish in less than 5 minutes, while other
frypots in the system are in use
• Filters up to 4 fryers in one battery
• 1/3 H.P. filter motor
• 4 GPM (15 LPM) pump
• Stainless steel crumb catcher
• Filter starter kit
• Drain safety switch
• Front oil flush
free oils. It is also sequential, so one fryer may
be filtered while the others are still in use. It
is engineered with features that allow added
convenience, easier serviceability and allows for
using three different filter mediums with one
pan.
This system is enhanced with a gravity draining
system that allows residual oil to drain into the
filter pan so that drain lines are always open. The
filter, housed beneath two Frymaster fryers or
one fryer and a spreader, is capable of filtering
up to four fryers, individually, without having
to be moved from fryer to fryer, saving valuable
labor. One fifty-pound fryer can be filtered in
about four minutes, while other fryers in the
battery keep on cooking.
Large sump with secure hold-down ring ensures
proper vacuum and superior oil filtration. The
stainless steel filter pan slides out easily over
floor mats and uneven floor tiles.
*Liter conversions are fol solid shortening @ 70° F.
8700 Line Avenue
Tel: 318-865-1711
www.frymaster.com
Shreveport, LA 71106-6814
Tel: 1-800-221-4583
Bulletin No. 6276_FRY_MJ50CE_BI
USA
Fax: 318-868-5987
Revised 3/9/17
E-mail: info@frymaster.com
Date
FMJ450
Fryer Standard Features
Model FMJ250
Shown with optional CM3.5 controller
Approval
Meets CE
food contact
requirements.
MJ50 Gas Fryers with Filtration
Project
MJ50 Gas Fryers with Filtration -- Domestic & Export
OPTIONS & ACCESSORIES
E xternal oil discharge -- available on built-in filter batteries with 2 or
more frypots -- must specify front or rear connection. Front connection
not available on 2-battery models.
Basket lifts (only available with CM3.5)
CM3.5
Spreader cabinet(s) -- must fit within a 4-cabinet fryer battery
Triplet basket
Full basket
Chicken/Fish tray
Sediment tray(s)
Fish plate
Splash shields
Center spreader
POWER REQUIREMENTS
MODEL NO.
FMJ250
FMJ350
FMJ450
ELECTRICAL SPECIFICATIONS
230V 50Hz 1Ph
CLEARANCE INFORMATION
A minimum of 24” (61 cm) should be provided at the front of the unit for
servicing and proper operation, and 6” (15.2 cm) between the sides and
rear of the fryer to any combustible material.
NOTES:
• 1-1/2” (3.8 cm) kitchen main manifold gas supply line required. Should
flexible gas line be used, it must be CSA approved, commercial type and
sized per the gas line size in above drawing. See service manual and/or
plumbing codes for proper pipe sizing. Recommended minimum store
supply pressure to be 6” W.C. for NAT Gas, and 11” W.C. for L.P. Check
plumbing codes for proper supply line sizing to attain burner manifold
pressure of 3.0” W.C. natural or 8.25” W.C. L.P.
• DO NOT CURB MOUNT
8700 Line Avenue
Tel: 318-865-1711
www.frymaster.com
Shreveport, LA 71106-6800
Tel: 1-800-221-4583
Bulletin No. 6276_FRY_MJ50CE_BI
USA
Fax: 318-868-5987
Revised 3/9/17
E-mail: info@frymaster.com
We reserve the right to change specifications appearing in this bulletin without incurring any obligation for equipment previously or subsequently sold.
Check www.frymaster.com for updates.
CORDSET
6.00
(152)
15.63
(397)
1" GAS CONNECTION
(2, 3, & 4 BATTERY)
Frymaster Gas Connection Requirements
1" GAS CONNECTION
(4 BATTERY)
No. of Fryers
Gas Connection Size
(With or Without
Filtration)
2-3
One 1”
4
Two 1”
INCHES
(MM)
31.24
(793)
46.86
(1190)
62.58
(1590)
31.55
(801)
36.50
(927)
46.00
(1168)
35.75
(908)
1" GAS
CONNECTION
8.40
(213)
6.10
(155)
12.85
(326)
CORDSET
DIMENSIONS
(FP FILTER PAN ONLY IS 25-1/2” W x 16” D x 12-1/2” H )
FP FILTER WITH FRYERS
MODEL
NO.
OIL
CAPACITY/
FRYPOT
FMJ250
FMJ350
50 lbs. (25 L)
full pot
FMJ450
OVERALL SIZE (cm)
FULL OR SPLIT FRYPOTS
SHIPPING INFORMATION
DRAIN
HEIGHT
(cm)
WEIGHT
CLASS
CUBE
DIMENSIONS (cm)
W
D
H
52.84
38”
(96.5)
44-1/2”
(113.0)
54”
(137.2)
77.5
74.39
53”
(135.9)
44-1/2”
(113.0)
54”
(137.2)
77.5
100.12
72”
(182.9)
44-1/2”
(113.0)
54”
(137.2)
WIDTH
DEPTH
HEIGHT
31-1/4”
(79.3)
31-1/2”
(80.1)
46”*
(116.8)
10-5/8”
(26.9)
525 lbs.
(238 kg)
77.5
46-7/8”
(119)
31-1/2”
(80.1)
46”*
(116.8)
10-5/8”
(26.9)
658 lbs.
(298 kg)
62-1/2”
(159)
31-1/2”
(80.1)
46”*
(116.8)
10-5/8”
(26.9)
896 lbs.
(406 kg)
8700 Line Avenue
Tel: 318-865-1711
www.frymaster.com
Shreveport, LA 71106-6800
Tel: 1-800-221-4583
Bulletin No. 6276_FRY_MJ50CE_BI
USA
Fax: 318-868-5987
Revised 3/9/17
E-mail: info@frymaster.com
We reserve the right to change specifications appearing in this bulletin without incurring any obligation for equipment previously or subsequently sold.
Check www.frymaster.com for updates.
Model #_______________
CSI Section 11400
*Without basket lifts.
MJ50 Gas Fryers with Filtration -- Domestic & Export
15.63
(397)
MJ50 Gas Fryers with Filtration -- Domestic & Export
BUILT-IN FILTRATION COMBINATIONS
FMJ250
FPP245
FMJ350
FPP345
FMJ450
FPP445
HOW TO SPECIFY -- EXAMPLE
The following description will assist with ordering the features desired for this equipment:
FMJ350Three 50-lb. (25 L), open full frypot gas fryer with controllers and built-in filtration.
C
CM3.5 controller
BL
Basket Lifts
Model #_______________
CSI Section 11400
8700 Line Avenue
Shreveport, LA 71106 -6800
USA
Tel: 318-865-1711
Tel: 1-800-221-4583
Fax: 318-868-5987
E-mail: info@frymaster.com
www.frymaster.com
Bulletin No. 6276_FRY_MJ50CE_BI
Revised 3/9/17
Printed in U.S.A. ©Frymaster
We reserve the right to change specifications appearing in this bulletin without incurring any obligation for equipment previously or subsequently sold.
Check www.frymaster.com for updates.
Download PDF
Similar pages