Contents Environmental protection

Please read and comply with
these original instructions prior
to the initial operation of your appliance and
store them for later use or subsequent owners.
– Before first start-up it is definitely necessary to read the safety indications Nr.
5.956-249!
– The non-compliance of the operating
and safety instructions may lead to
damages of the appliance and to dangers for the operator and other persons.
– In case of transport damage inform vendor immediately
– When unpacking the product, make
sure that no accessories are missing
and that none of the package contents
have been damaged.
Contents
Environmental protection . . . .
Danger or hazard levels . . . . .
Proper use . . . . . . . . . . . . . . .
Safety instructions. . . . . . . . . .
Device elements . . . . . . . . . . .
Start up . . . . . . . . . . . . . . . . . .
Operation . . . . . . . . . . . . . . . .
Transport. . . . . . . . . . . . . . . . .
Storage . . . . . . . . . . . . . . . . . .
Maintenance and care . . . . . .
Troubleshooting . . . . . . . . . . .
Warranty . . . . . . . . . . . . . . . . .
Accessories and Spare Parts .
EC Declaration of Conformity .
Technical specifications . . . . .
EN
EN
EN
EN
EN
EN
EN
EN
EN
EN
EN
EN
EN
EN
EN
Environmental protection
The packaging material can be
recycled. Please do not throw
the packaging material into
household waste; please send it
for recycling.
Old appliances contain valuable
materials that can be recycled;
these should be sent for recycling. Batteries, oil, and similar
substances must not enter the
environment. Please dispose of
your old appliances using appropriate collection systems.
Notes about the ingredients (REACH)
You will find current information about the
ingredients at:
www.kaercher.com/REACH
1
2
2
2
3
4
4
4
4
4
5
6
6
6
7
EN – 1
11
Danger or hazard levels
Safety instructions
! DANGER
Immediate danger that can cause severe
injury or even death.
" WARNING
Possible hazardous situation that could
lead to severe injury or even death.
" CAUTION
Pointer to a possibly dangerous situation,
which can lead to minor injuries.
ATTENTION
Pointer to a possibly dangerous situation,
which can lead to property damage.
Proper use
" WARNING
The appliance is not suitable for vacuuming
dust which endangers health.
ATTENTION
This unit is only to be used indoors.
– This universal vacuum cleaner is intended for dry cleaning of floor and wall
surfaces.
– This appliance is suited for the commercial use, e.g. in hotels, schools, hospitals, factories, shops, offices, and rental
companies.
12
! DANGER
– If you are wearing a pacemaker, we
recommend that you contact your physician or the manufacturer of the pacemaker regarding possible cautions before you operate this appliance.
– Not all pacemakers are radiation-proof
to emitted high frequency/electrical
magnetic fields in a close vicinity, which
could lead to problems while operating
this appliance.
– If your physician is not able to guarantee its flawless operation, do not use
this appliance!
EN – 2
Device elements
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
Suction support (exterior)
Filter cover latch
Filter cover
Fleece filter bag
Main filter basket
Grid of the motor protection filter
Motor protection filter
Handle
Shoulder carrier with middle and end
tensioners
Hip belt
Suction pipe holder
Back cushion
Casing
Nameplate
Cover
Exhaust filter
Power cord
Main switch
Mains cable hook (foldable)
Suction force regulator (continuous)
Bender
Colour coding
–
–
EN – 3
The operating elements for the cleaning
process are yellow.
The controls for the maintenance and
service are light gray.
13
Adjust the position of the appliance on
your back by pulling on the end tensioners.
Start up
The appliance can be operated in 2 ways:
1 Operation with fleece filter bag or paper
filter bag (option)
2 Operation without filter bag
Check whether main filter basket has
been inserted into the appliance.
Operation
ATTENTION
Risk of damage! If the suction decreases,
immediately turn off the motor.
Adjusting the hip belt and the
shoulder carrier
Turning on the Appliance
Plug in the mains plug.
Switch on the appliance at the main
switch.
Put appliance on your back.
Cleaning operations
Set the selection switch of the floor nozzle to hard surface or carpet.
Regulate the suction force on the suction force regulator (continuous).
Perform the cleaning operation.
Turn off the appliance
Switch off the appliance at the main
switch.
Pull out the mains plug.
Latch the closure and adjust the hip
belt.
After each operation
Empty main filter basket if necessary.
Use a moist cloth to clean the appliance, the accessories and the cable after use.
Transport
Adjust the appliance to your body by
pulling on the middle tensioners. Do not
pull too tight, the main load should be
on the hip belt.
" CAUTION
Risk of injury and damage! Observe the
weight of the appliance when you transport it.
When transporting in vehicles, secure
the appliance according to the guidelines from slipping and tipping over.
Storage
" CAUTION
Risk of injury and damage! Note the weight
of the appliance in case of storage.
This appliance must only be stored in interior rooms.
Maintenance and care
! DANGER
First pull out the plug from the mains before
carrying out any tasks on the machine.
14
EN – 4
Push the grids of the motor protection
filter down, turn and remove.
Remove the motor protection filter.
Insert the new motor protection filter.
Insert the grid of the motor protection filter and lock it into place.
Insert main filter basket.
Insert and lock the filter cover.
Replace the fleece filter bag or
paper filter bag (option)
Troubleshooting
Release and remove the filter cover.
Remove the fleece filter bag or paper filter bag (option).
! DANGER
First pull out the plug from the mains before
carrying out any tasks on the machine.
Note: In case of a failure (e.g. filter breakage) the appliance must be turned off immediately. The failure must be remedied
before the appliance is put into operation
again.
The appliance shuts off during the
operation
–
Pull a new fleece filter bag or paper filter
bag (option) with rubber flange over the
suction support (interior).
Insert and lock the filter cover.
Motor thermal protector has responded.
Replace the fleece filter bag or paper filter bag (option).
Replace motor protection filter.
Check all parts for plugging.
Switching back on after the motor turbine
has cooled off, after approx. 30 to 40 minutes.
Dust comes out while vacuuming
Clean main filter basket
Main filter basket (washable), clean it
under running water if necessary.
ATTENTION
Risk of damage! Never insert the main filter
basket while wet.
Replace exhaust filter
Replace the defective fleece filter bag
or paper filter bag (option).
Check the fleece filter bag or paper filter
bag (option).
Insert/lock the filter cover correctly.
Insert undamaged main filter basket.
Reinsert motor protection filter correctly.
Suction capacity decreases
Exhaust filter: Change once a year
Remove cover.
Unlock the exhaust filter and remove.
Insert and lock the new exhaust filter
into place.
Replace cover.
Replace the fleece filter bag or paper filter bag (option).
Clean the main filter basket under running water.
Insert/lock the filter cover correctly.
Replace motor protection filter
No or insufficient suction
Release and remove the filter cover.
Remove the main filter basket.
Remove choking of suction nozzle, suction tube or suction hose.
Replace defective suction hose.
EN – 5
15
Replace the fleece filter bag or paper filter bag (option).
Insert/lock the filter cover correctly.
Clean the main filter basket under running water.
Insert undamaged main filter basket.
Replace motor protection filter.
Suction turbine does not run
Check the receptacle and the fuse of
the power supply.
Check the power cable and the power
plug of the device.
Turn on the appliance.
Customer Service
If malfunction can not be fixed, the device must be checked by customer service.
Warranty
The warranty terms published by the relevant sales company are applicable in each
country. We will repair potential failures of
your appliance within the warranty period
free of charge, provided that such failure is
caused by faulty material or defects in manufacturing. In the event of a warranty claim
please contact your dealer or the nearest
authorized Customer Service centre.
Please submit the proof of purchase.
Accessories and Spare Parts
–
–
–
Only use accessories and spare parts
which have been approved by the manufacturer. The exclusive use of original
accessories and original spare parts
ensures that the appliance can be operated safely and trouble free.
At the end of the operating instructions
you will find a selected list of spare parts
that are often required.
For additional information about spare
parts, please go to the Service section
at www.kaercher.com.
EC Declaration of Conformity
We hereby declare that the machine described below complies with the relevant
basic safety and health requirements of the
16
EU Directives, both in its basic design and
construction as well as in the version put
into circulation by us. This declaration shall
cease to be valid if the machine is modified
without our prior approval.
Product:
Dry vacuum cleaner
Type:
1.394-xxx
Relevant EU Directives
2006/42/EC (+2009/127/EC)
2004/108/EC
2011/65/EU
2009/125/EC
Applied harmonized standards
EN 55014–1: 2006+A1: 2009+A2: 2011
EN 55014–2: 1997+A1: 2001+A2: 2008
EN 60335–1
EN 60335–2–69
EN 61000–3–2: 2006+A1: 2009+A2: 2009
EN 61000–3–3: 2013
EN 62233: 2008
EN 50581
EN 60312: 2013
Applied national standards
Applied regulations
666/2013
5.957-678
The undersigned act on behalf and under
the power of attorney of the company management.
CEO
Head of Approbation
Authorised Documentation Representative
S. Reiser
Alfred Kärcher GmbH Co. KG
Alfred-Kärcher-Str. 28 - 40
71364 Winnenden (Germany)
Phone: +49 7195 14-0
Fax: +49 7195 14-2212
Winnenden, 2014/02/01
EN – 6
Technical specifications
Mains voltage
Frequency
Container capacity
Air volume (max.)
Negative pressure (max.)
Protective class
V
Hz
l
l/s
kPa (mbar)
BV 5/1
220-240
1~ 50/60
5
61
24,4 (244)
II
Suction hose connection (C-DN/C-ID)
Length x width x height
Typical operating weight
Max. ambient temperature
Values determined to EN 60335-2-69
Sound pressure level LpA
Uncertainty KpA
Hand-arm vibration value
Uncertainty K
Eco design as per 666/2013
Energy efficiency category
Indicative annual energy consumption
Carpet cleaning class
Hard floor cleaning class
Dust emission class
Sound power level LWA,
Rated power input
mm
mm
kg
°C
32
400 x 320 x 540
6,5
+40
dB(A)
dB(A)
m/s2
m/s2
62
1
<2,5
0,2
-kWh/a
---dB(A)
W
E
47,8
D
D
B
78
1150
Power cord
EU
GB
CH
H05VV-F 2x1,0 mm2
Part no.:
Cable length
6.649-372.0 15 m
6.649-503.0 15 m
6.649-500.0 15 m
EN – 7
17
Download PDF
Similar pages