advertisement
▼
Scroll to page 2
of 7
ATLANTIS THERMOSTATIC ELECTRIC HEATING ELEMENT FOR HEATED TOWEL RAILS (WATER TEMPERATURE CONTROLLER) USER AND INSTALLATION MANUAL FOR TOWEL RAIL MANUFACTURER OR PROFESSIONAL INSTALLER ONLY The image is for illustration purposes only SUPPLIED PARTS IN EACH PACKAGING ATLANTIS I 2 spacer I APPLICABLE EUROPEAN STANDARD Electrical tests according to CEI EN 60335-1 Applicable directives: 2011/65/EU RoHS Directive, 2006/95/EC Low Voltage Directive, 2004/108/EC EMC Directive COD. 571357670 REV. 06/2015 CE: THANK YOU FOR PURCHASING “ATLANTIS” Electric towel radiator heating element with capillary thermostat for water temperature regulation CAUTION A GENERAL CAUTION !" and national safety regulations and laws in force in the country where the product is installed. ! dangerous. # $ ! ! % ! # ! #& ! % ! !'** +; ! < $ !!"!=$ # ! ! >$ ! !=$ !?& ! # >$@? ! !B !" ! !# > $ JKQXXZ[\[@X?J $>; J+]'"^%J"+_`?& $ !# " JKQXXZ[\[@X to determine the correct ATLANTIS power to be installed in the towel rail. * <" j # " j ATLANTIS is not intended for use by persons (including children) with reduced physical, sensory or mental " ; ; !$" # " monitoring or instruction on the use of the appliance. You should monitor children to ensure that they do not play with the appliance. A SAFETY WARNINGS $!$ $ kq@$ !!# B $ k$ $ B " & public institution. ! "[ Fig. 1 _ zone2 •, t. .L.Zone3 I ..L .., ZoneO 1 I .: _ Zone3 •• ' Zone2', 6m • Zone3 2.2Sm Zone 1 Zone2 ~ Zone3 60cm radius from tap I Zoneo I• ATLANTIS 2 0.6m •I MAINTENANCE Ordinary At regular periods of time, depending on the usage of the product ATLANTIS: [$$; & ;! ;$ [k & !;$;$& & " %$ ; Extraordinary > # !?&Z CLEANING To clean ATLANTIS, use only a dry and clean soft cloth. +; &. Apply a light pressure especially to the chrome plastic surfaces to avoid potential scratches. DIAGNOSTIC $ ! " indicates operation failure and the product must be replaced. J%' ! "!$\ $" service. SPARE PARTS SAFETY INFORMATION % !#x'JQ x'Jz>*$z? +k'{! $ !! ;! !! ; $>$ ! #? ^& $ & $ +; $ |; $ +|} >+$ | };? ||}>||};?& +~'}Jk'JJ% ! ; <>!? ! % ! [ ! the necessary time to ensure it is cold after it is switched off. J !+~&#$ ! ! MAIN RECOMMENDATION ON ELECTRICAL TOWEL RAIL (Applicable standard EN 60335-2-43) ! !!! J "# !!$ ! $ ! $ "! # ! Q!! ! ;$$ ! $ " $ >J % ?&& >;X}&&? ! && & "< <! k"; into consideration. %[ !$" &&! open, when the electrical element is switched on. * " JKQXXZ[zJKQXXZ[\[@X ATLANTIS must be replaced totally as it has no spare parts. IMPORTANT: In case of doubts, please, contact the Seller or refer to Contacts section. IMPORTANT: Please, retain these instructions for future reference GUARANTEE NOTES FOR DISPOSAL OF THIS PRODUCT VALID FOR THE EUROPEAN UNION CONTACTS DETAILS The crossed-out wheeled-bin symbol on your product reminds you that in the European Union all electrical and electronic products and batteries must be taken to separate collection at the end of their working life. Do not dispose of these products as unsorted municipal waste. Return the products to collection to prevent possible harm to the environment or human health from uncontrolled waste disposal and to promote the sustainable reuse of material resources. Collection information is available from the product retailer, local waste authorities or national producer responsibility The manufacturer declines all responsibility for any inaccuracies in this document due to printing or transcription errors. It reserves the right to make any alterations to its products deemed necessary or useful. This document or any part of it cannot be copied, edited or reproduced without written authorization from the manufacturer. ATLANTIS 10 $ z\ $" ; The guarantee of ATLANTIS is not valid in case of improper use or installation. Carlton Technologies Ltd. ~@|^!}k;"| || "|#"@Z } {QQ@@>Q?z\@KKzXXQ*{QQ@@>Q?z\@K\Zz@KK {jj!!! ;j PRODUCT PRESENTATION ATLANTIS is a self regulating PTC heating element integrating a thermomechanic capillary thermostat to regulate ! !! !k||$ $;$X k^| connected to a fully electric towel radiator or a hybrid electric-hot water heater (dual fuel, central heating radiator). $; !"!! towel rails. ATLANTIS is complete with: [ J%!'! $! ;$ [ $; !! ATLANTIS senses the water temperature around the area where the capillary bulb is located and is not intended to create a uniform thermal distribution over the whole electrical towel rail surface. 'J{ $ $ "" <>! !$ ? # # !! $#* # " ! # 3 ATLANTIS SYMBOLS AND GLOSSARY USAGE ATLANTIS: is a PTC heating element integrating a capillary thermostat to regulate water temperature in electric towel rails. J ~ }'q{! ATLANTIS NIPPLE: the metallic part of ATLANTIS connecting the ATLANTIS heating element and ATLANTIS regulating |k}~}{ $ !! J%{ &; ! |'{!!! B towel rail. X}^^J{&&!X SPACER{;! TECHNICAL DATASHEET USAGE WARNINGS The ATLANTIS incorporates a capillary thermostat bulb sensor to measure the water temperature. The LED is ON when the heater is working. WORKING DESCRIPTION HOW TO USE ; ! !!{$ between [ 5°C ÷ 70°C ] ± 5°C (Fig. 16). J%'!! ;$ SPECIFICATION White or Chrome regulating box Power (W) Length (mm) 150 370 300 500 600 750 800 850 0 0 0 9· Min. position 5°C ± 5°C Intermediate position + 70°C ± 5°C Fig. 16 TECHNICAL SPECIFICATION TABLE Operating voltage \XQ^zQ|ZQB Heating Element Power 150W-300W-600W-800W Insulation class Class I IP Degree of protection kq@ Operating Ambient Temperature 0°C ÷ 50°C Storage Temperature - 20°C ÷ 80°C +& 85% at 25°C without condenses Water Temperature Regulation ON/OFF [5°C ÷ 70°C]±5°C with bimetallic capillary thermostat Nipple thread ½” Gas cylindrical INSTALLATION BEFORE YOU START |;; & $z! &$ $ $ or appears damaged, you should return them to the point of purchase. |; & B !JJ B ! ;$$ !|J*J%}J~'kJ RECOGNISED APPROVAL INSTITUTE. IF YOU ARE NOT SURE OF THAT, PLEASE REFER TO CONTACT SECTION OR FOLLOW GENERAL WARNINGS SECTION. "; &$ " !! ! installed. +; ! #>zQ? !$ $; ATLANTIS 4 IMPROPER USE All different usages which are not described in the “PRODUCT PRESENTATION” section according to the USAGE section, are to be intended as improper usage. In case of doubts refer to the seller. Never switch the ATLANTIS ON if the towel rail is empty. } "&!' &$& DANGEROUS CONDITION AND RISKS %$ "[ "! ;$ % & ; ; ; $ ! ;$ & $ $ &$ $$ ! ;"" ATLANTIS power supply cable cannot be repaired. If it is damaged, contact the seller to replace the complete ATLANTIS unit. Never try to modify or repair the ATLANTIS in any of its parts by yourself. & &; !$ $; ;&; ;$$!$& && it in wet areas. 9 ATLANTIS INSTALLATION WARNINGS ATLANTIS POSITION #$ >*$ z\? ! ATLANTIS. Any other position is the responsibility of the installer and must be tested. This appliance can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved. Children shall not play with the appliance. Cleaning and user maintenance shall not be made by children without supervision. ! ensure all-pole disconnection must be directly connected with the supply terminals and must have a contacts distance of at least 3 mm in each pole. J ! !$$ $ $ !; # * ! & !$ $ Fig. 12 'J{$ $ !" it is possible to rotate the element until it faces the correct >*$zX? !& $ zQ$ $" $; |;$ < Fig. 13 TO UNINSTALL IN ELECTRIC ONLY ATLANTIS INSTALLATION 1. Disconnect the cable from the mains power. 2. Remove the electrical towel rail from the wall and reverse it carefully leaning it on a soft cloth/surface. 3. Using a 27 mm spanner unscrew the ATLANTIS, rotating it ;! towel rail ½”GAS female thread (Fig. 14). 4. Remove the ATLANTIS from the towel rail. } ! Live Wire } Neutral Wire Yellow - Green Earth < < ! k !||}>||};?& !#! ! $ JKQXXZ[\[@X ; continuously powers the heating element. !j$ ! $ !j$ $ ! electricity supply at the mains. (THIS PRODUCT MUST BE EARTHED) % $$ ! $ !!; ; $ ! & & !JJ$$ >}Kz? bathroom, the Fused Connection Unit must be located out of reach of persons using the basin, shower or bath. If " <# | $}*| ~ *| ~ #!Z }zXK\ TOWEL RAIL INSTALLATION WARNINGS Fig. 14 DUAL FUEL INSTALLATION (CENTRAL HEATING AND ATLANTIS) 1. Disconnect the cable from the mains power. 2. Close both rail valves, remove the water from the towel rail and dry ! ;$ 3. Remove the towel rail from the wall and reverse it carefully leaning it on a soft cloth/surface. 4. Using a 27 mm spanner unscrew the T-piece with screwed " $ ;! [ completely off from towel rail ½”GAS female thread (Fig. 15). 5. Remove spacer. 6. Remove T-piece with screwed the ATLANTIS from the towel rail. 60-90 mm Fig. 2 WARNING: Fig. 15 *J%|'J| "|'}JJ~J% REPLACE THE PRODUCT WITH A NEW ONE. Fig. 3 ATLANTIS 8 ! !$; by the towel rail manufacturer. The distance between ATLANTIS and the wall must be !KQQ>*$\? & B $" electrical towel rail should be installed so that its bottom part is at least 600mm above $ JKQXXZ[\[@Xjz # ! $ ! < k*J $ T-piece thread (in case of Dual Fuel installation). +; !#! >;X}^&?! ; & X}&&>*$X? ! % " [ @Q $ > ?< >}? " & &$ ! heater (electric only ATLANTIS installation). The Spacer must not be torn, and must show no imperfections. 3 bar valve 5 ATLANTIS $;>? screwed into towel rail thread DUAL FUEL INSTALLATION CENTRAL HEATING AND ATLANTIS 1. Reverse the empty towel rail carefully leaning it on a soft cloth/ surface. 2. ; ;$"$! 3. Remove the spacer without damaging it (Fig. 9a). Do not use tools or lubricants. Use gloves. Ensure that the pipe and the resistor are not bent and stay parallel to each other. 4. Insert the T-piece in the ATLANTIS (Fig. 9b), screw and tighten it #>*$?% 5. Insert the spacer to the distance shown in the Figure (Fig. 9d). If the spacer is damaged, replace it. Do not use tools or lubricants. Ensure that the pipe and the resistor are not bent and stay parallel to each other. 6. Insert the tip of the ATLANTIS heating element into the bottom hole ! !; ! & !X} valve is installed. 7. Then using a 27 mm spanner turn the T-piece with screwed ATLANTIS heating element until the last nipple thread turn and if necessary &$$ $ !>*$zQ? 8. +; $; thread of the towel rail. 9. # ! ! the wall and connect it to the central heating system according to ! +; ! # 10. ^ !;$ [$ +; $ ! > !;$ % J'~ CONDITION AND RISK section). 11. Connect the ATLANTIS cable to the mains power according to current wiring regulation in force in the country where the product is installed. a A Fig. 4 INSTALLATION STEPS ELECTRIC ONLY ATLANTIS INSTALLATION } b 1. Reverse the empty towel rail carefully leaning it on a soft cloth/ # 2. ; ;$"$! 3. Insert the tip of ATLANTIS heating element into the bottom hole of ! !; thread of the towel rail in the opposite vertical tube to where the 3 }&&>*$Z? 4. Insert the ATLANTIS heating element all the way. 5. Then using a 27 mm spanner screw the ATLANTIS heating element until the last nipple thread turn and if necessary continue in order &$$ $ !>*$K? 6. +;$; thread of the towel rail (Fig. 4). 7. # !! ! $ ! +; that the towel rail has the ATLANTIS bottom side. 8. ^ ! ;$ [$ +; $ ! > ! ;$ refer to DANGEROUS CONDITION AND RISK section). 9. +; ! < 10. Connect the ATLANTIS cable to the mains power according to current wiring regulations in force in the country where the product is installed. A Fig. 5 c JT d Fig. 9 Fig. 10 Fig. 6 ATLANTIS ATLANTIS T-piece Spacer Radiator Radiator Resistor Pipe 3 bar valve 3 bar valve Fig. 7 Fig. 8 ATLANTIS 6 Fig. 11 7 ATLANTIS Check out our full range of Bathroom Accessories Bathroom Accessory Sets Heated Towel Rails Bathroom Extractor Fans Bathroom Lighting Shower Seats Grab Rails Shower Curtains Toilet Brushes Bathroom Cleaning Products Wall Mounted Bathroom Accessories Robe Hooks Bathroom Tumblers Toilet Roll Holders Soap Dishes Towel Rings Shower Caddies Bathroom Mirrors Standard Bathroom Mirrors LED Bathroom Mirrors Shaving Mirrors
advertisement
* Your assessment is very important for improving the workof artificial intelligence, which forms the content of this project