Warning: ! Warning - Restoration Hardware

Style # 26100117
Laguna Propane Tank Cover
Owner’s Manual
! Warning:
For outdoor use only
DO NOT use for cooking
DO NOT use under any
overhead enclosure
! Warning:
! If the information in this manual is not
followed exactly, a fire or explosion
may result causing property damage,
personal injury or loss of life.
! Do not store or use gasoline or other
Manufactured as
Model # 6561 in China for:
Restoration Hardware
15 Koch Rd
Suite J
Corte Madera, CA 94925
Customer Service:
1-800-816-0901 or
1-800-654-1704
flammable vapors and liquids in the
vicinity of this or any other appliance.
! WHAT TO DO IF YOU SMELL GAS:
1. Shut off gas to the appliance
2. Extinguish any open flame
3. Open lid
4. If odor continues, keep away from
the appliance and immediately call your
gas supplier or fire department.
! Installation and service must be
performed by a qualified installer,
service agency or gas supplier.
! Improper installation, adjustment,
alteration, service or maintenance
can cause injury or property damage.
! Read the installation, operation and
maintenance instructions thoroughly
before installing or servicing this
equipment.
Save these instructions for future
! reference. If you are assembling this
unit for someone else, give this
manual to him or her to read and
save for future reference.
Rev1
Table of Contents
Dangers and Warnings
3
Propane (LP) Gas Warnings
5
Hose and Regulator Assembly
6
Parts List and Descriptions
7
Pre-Use Instructions
8
Insert Propane Hose/Attach Feet
Place Propane Tank
Secure Propane Tank
Connect Propane Tank
Disconnect Propane Tank
Attach Top
9
9
10
10
10
11
Care, Cleaning and Maintenance
11
2
DANGERS and WARNINGS: FOR YOUR SAFETY
GENERAL WARNINGS
FOR OUTDOOR USE ONLY - DO NOT SIT or STAND ON PROPANE TANK COVER
• Warning – For your Safety:
o If the information in this instruction manual is not followed exactly, a fire or explosion may result causing property
damage, personal injury or loss of life.
• IMPORTANT NOTICE: Read and understand all warnings and precautions prior to assembly and use of your gas firepit.
• NOTE: The use and installation of this product must conform to local codes. In the absence of local codes, use the National
Fuel Gas Code, ANSI Z223.1/ NFPA54. Reference to Natural Gas and Propane Installation code CSA B149.1 or Propane
Storage and Handling code B149.2
• DANGER: Failure to follow the dangers, warning and cautions in this manual may result in serious bodily injury or death, or
in a fire or an explosion causing damage to property.
• Minimum Clearance From Unit To Combustible Construction:
72” (182.9cm) from the top; 48” (121.9cm) from all sides and back. Do not locate this appliance under overhead
unprotected combustible surfaces.
IF YOU SMELL GAS:
• Shut off gas supply to the fire table.
• Extinguish any open flame.
• Do not try lighting any appliance.
• Do not touch any electrical switch; do not use any phone in your building.
• Immediately call your gas supplier from a neighbor’s phone.
• Follow the gas supplier’s instructions.
• If you cannot reach your gas supplier, call the fire department.
• Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Read the
installation, operation and maintenance instructions thoroughly before installing or servicing this equipment.
• Keep these instructions for future reference. If you are assembling this unit for someone else, give this manual to him or
her to read and keep for future reference.
• This gas firepit shall be used ONLY outdoors in a well-ventilated space and shall NOT be used inside a building, garage, or
any other enclosed area.
• Do NOT use this outdoor gas firepit for indoor heating. TOXIC carbon monoxide fumes can accumulate and cause
asphyxiation
• Never LEAVE this gas firepit unattended when in use.
• Children and pets should be alerted to the hazards of high surface temperatures and kept at a safe distance while firepit is
in use
• Do NOT operate, light or use this firepit within 8 feet of walls, structures or buildings.
• Storage of this firepit indoors is permissible only if it has been disconnected from its fuel supply (natural gas line or LP gas
cylinder).
• Do not store or use gasoline or other flammable vapors and liquids within 25 feet (7.62m) of this or any other appliance
• Do NOT store any combustible materials in the base enclosure.
• The use of alcohol, prescription or non-prescription drugs may impair an individual’s ability to properly assemble or safely
operate this outdoor firepit.
• Do not use in an explosive atmosphere. Keep gas firepit area clear and free from combustible materials, gasoline and other
flammable vapors and liquids.
• This outdoor firepit is NOT to be operated by children. Young children should be closely supervised when in the vicinity of
this outdoor firepit.
• This outdoor firepit is not to be installed or used in or on recreation vehicles and/or boats.
• Always use in accordance with all applicable local, state and national codes. Contact your local fire department for details
on outdoor burning.
• Use the same precautions you would with any open fire when using this outdoor firepit.
• Do NOT burn solid fuels such as: wood, charcoal briquettes, lump charcoal, manufactured logs, driftwood, trash, leaves,
paper, cardboard, plywood, painted or stained or pressure treated wood in this outdoor firepit.
• Do NOT alter this outdoor firepit in any manner.
• Do NOT use this outdoor firepit until it is COMPLETELY assembled and all parts are securely fastened and tightened.
• Do NOT store another LP gas tank within 10 feet (3.05 m) of this outdoor firepit while it is in operation.
• Do NOT use this outdoor firepit near automobiles, trucks, vans or recreational vehicles.
• Do NOT use this outdoor firepit under any overhead or near any unprotected combustible constructions. Avoid using near
or under overhanging trees and shrubs.
• Always use this outdoor firepit on a hard, level, non-combustible surface such a concrete, rock or stone. An asphalt or
blacktop surface may not be acceptable for this purpose.
• Do NOT use this outdoor firepit if any part has been under water. Immediately call a qualified service technician to inspect
the firepit and to replace any part or control system and any gas control which has been under water.
3
DANGERS and WARNINGS: FOR YOUR SAFETY (Continued)
• Do NOT wear flammable or loose clothing when operating this outdoor firepit.
• Do NOT use in windy conditions.
• Keep all electrical cords away from a hot outdoor firepit.
• Certain areas of this outdoor firepit when in use will become too hot to touch. Do not touch hot surfaces until the unit has
cooled unless you are wearing protective gear such as insulated pot holders or heat resistant gloves or mittens to avoid
burns.
• Children and adults should be alerted to the hazards of high surface temperatures and should stay away to avoid burns or
clothing ignition.
• Do NOT hang or place clothing or other flammable materials on or near the gas firepit.
• Any guard or other protective device removed for servicing the firepit must be replaced prior to operating the firepit.
• Do NOT attempt to move or store this outdoor firepit until all parts are cool.
• Do NOT lean over this outdoor firepit when lighting or when in use.
• Use only the regulator and hose assembly provided. The replacement regulator and hose assembly shall be that specified
by the manufacturer.
• Storage of this outdoor firepit indoors is permissible only if the tank is disconnected, removed from the outdoor firepit and
properly stored outdoors.
• Do not attempt to disconnect the gas regulator from the tank or any gas fitting while the outdoor firepit is in use.
• Always shut off gas supply at the tank valve and disconnect regulator from the tank when the fire table is not in use
• Do NOT sit on the mantle when the unit is in operation.
• Do not throw anything onto the fire when the unit is in operation.
• Lava rocks are very hot; please keep children or pets away at a safe distance.
• It is essential to keep the outdoor firepit’s valve compartment, burners, and circulating air passages clean. Inspect outdoor
firepit before each use.
• Prior to each gas fireplace operation, check the hose for evidence of excessive abrasion or wear by looking through the
visual check hole. If the hose is damaged, cut or cracked, it must be replaced before using the gas fireplace. The hose
assembly can only be replaced by a hose assembly specified by the manufacturer at 1-800-816-0901.
• Before each use, remove the lava rocks. Examine the burner and its components. If dirty, clean with a soft brush and soapy
water solution. Also examine the area around the burner. Any dirt or foreign material, such as spider webs or nests in this
area should be removed. If it is evident that the burner is damaged, it must be replaced before the gas fireplace is used.
The burner assembly can only be replaced by a burner specified by the manufacturer at 1-800-816-0901.
• Place the hose out of the pathways where people may trip over it. Do not place the hose in areas where it may be
subjected to accidental damage.
DANGER – Gas Safety
This outdoor fire table is for use with liquid propane (LP) gas only. The conversion to or attempted use of natural gas in
this outdoor firepit is dangerous and will void your warranty.
4
Propane (LP) Dangers and Warnings
LP GAS
LP gas is flammable and hazardous if handled improperly. Become aware of the characteristics before using any LP
gas product.
Propane Characteristics:
o Flammable, explosive under pressure, heavier than air and settles in pools in low areas.
o In its natural state, propane has no odor. For your safety, an odorant has been added.
o Contact with propane could burn the skin.
LP GAS WARNINGS:
• Cylinders must be stored outdoors in a well-ventilated area out of reach of children.
• Disconnected cylinders must have threaded valve plugs tightly installed and must not be stored in a building, garage
or any other enclosed area.
• Never use a propane cylinder with a damaged body, valve, collar or footing.
• Dented or rusted propane cylinders may be hazardous and should be checked by your propane gas supplier.
• Only tanks marked “propane” may be used.
• The LP gas supply tank must be constructed and marked in accordance with the Specifications for LP gas LP gas
tanks of the U.S. Department of Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339, LP gas
tanks, Spheres and Tubes for the Transportation of Dangerous Goods; and Commission.
• LP gas tank must be arranged for vapor withdrawal.
• The LP gas tank must have a listed overfilling prevention device (OPD) and a QCCI or Type I (CGA810) LP gas tank
connection.
• The LP gas tank must have a tank collar to protect the tank valve.
• Never use an LP gas tank with a damaged body, valve, collar, or footing. Dented or rusted LP gas tanks may be
hazardous and should be checked by your LP gas supplier prior to use.
• The LP gas tank should not be dropped or handled roughly.
• Tanks must be stored outdoors out of the reach of children. Do NOT store in a building, garage, or any other
enclosed area.
• Never store your LP gas tank where temperatures can reach over 125°F.
• Never keep a filled LP gas tank in a hot car or car trunk. Heat will cause the gas pressure to increase, which may
open the relief valve and allow gas to escape.
• Place dust cap on valve outlet whenever the LP gas tank is not in use. Only install the type of dust cap on the LP gas
tank valve outlet that is provided with the LP gas tank valve. Other types of caps or plugs may result in leakage of
propane.
• Do not store a spare LP gas tank under or near this gas firepit.
• Never fill the tank beyond 80 percent full.
• The pressure regulator is set for ___11___ inches of water column (pressure).
• The maximum inlet gas pressure for this outdoor firepit is __14___ inches of water column pressure.
Connecting your gas cylinder:
Before connection, be sure that there is no debris caught in the head of the gas cylinder, head of the regulator valve
or in the head of the burner and burner ports. Connect regulator valve and hand-tighten firmly. Disconnect the
propane cylinder from the regulator valve when the grill is not in use. DO NOT obstruct the flow of combustion air
and ventilation air to the burner.
Need section relating to tank holder and tank installation.
5
Hose & Regulator Assembly
1. This fireplace comes equipped with a standard LP gas hose and regulator including the appliance side connection
for a CGA No 791 Cylinder Connection Device. The LP gas hose and regulator supplied with this appliance must be
used. Only a hose and regulator specified by manufacturer can be used for replacement.
a. The CGA No 791 connection incorporates a magnetic flow limiting device that acts to limit the flow of gas if a
leak is detected between the regulator and the burner valve.
b. If the burner valve is open prior to the LP gas cylinder service valve being opened, the connection will interpret
this free flow of gas to be a leak.
c. The connection safety feature will reduce gas flow from the regulator to the appliance to a minimal level.
d. Be sure that the burner control valve is closed prior to opening the LP gas cylinder service valve to ensure that
the connection flow limiting device is not triggered mistakenly.
e. If the connection flow limiting device is triggered mistakenly, close the LP gas cylinder service valve and the
burner valve, wait 10 seconds to allow the device to reset, open the cylinder service valve, then open the burner
valve and light the fireplace as per lighting instructions.
2. Be sure to protect the hose from any hot surfaces. Serious danger may result if the hose contacts any hot surface.
3. Regular maintenance of the hose and regulator:
a. Inspect the hose before each use of the appliance. If the hose shows signs of cracks, abrasions, cuts or damage
of any kind, do not operate the appliance. Fix or replace the hose as required before using the appliance.
For assistance with repair or replacement of the hose, call our customer service line at 1-800-816-0901.
Use only replacement parts from manufacturer.
b. Inspect the seal inside the CGA No 791 service valve on the LP gas cylinder when replacing the cylinder or at least
once per year. If there is any indication of damage, have the seal replaced by a certified gas dealer before
operating the appliance.
4. Do not use tools to tighten the CGA No 791 connection nut onto the LP gas cylinder service valve.
Hand tighten only.
5. Be careful to not cross the threads on the connection when tightening the CGA No 791 connection on to the LP gas
cylinder service valve.
6. “Leak Test” should always be performed after attaching the connection to the LP gas cylinder service valve.
(See “Checking for Leaks” section of this manual on page 9)
7. For the connection of the hose and regulator to the LP tank, refer to the “Connection” section of the LP gas cylinder
section above.
6
Parts List
1
Tank Holder Top
0561-01
1
2
Tank Holder Base
0561-02
1
3
Feet
0560-06
4
1
2
3
7
Pre-Use Instructions
1
Before beginning assembly you should check that all gas connection are still tight.
A leak checking solution can be made by mixing 1 part dishwashing soap with 3
parts water. Mix together in a spray bottle.
Checking for leaks
!
Warning: Before using this outdoor fireplace,
make sure you have read, understand and are
following all information provided in the Dangers and
Warnings section of this manual. Failure to follow
those instructions can cause death, serious injury or
property damage.
Burner Connections
Make sure the regulator valve and hose connections
are securely fastened to the burner and the tank.
If your unit was assembled for you, visually check the
connection between the burner pipe and orifice.
Make sure the burner pipe fits over the orifice.
Check for leaks at valve under table.
!
Warning: Failure to inspect this connection or
follow these instructions could cause a fire or an
explosion, which can cause death, serious bodily
injury, or damage to property.
Please refer to diagram for proper installation.
If the burner pipe does not rest flush to the orifice
please contact 1.800.816.0901 for assistance.
Tank/Gas line connection
Make sure control knob is OFF.
Turn LP gas tank ON at valve.
Check for leaks at gas connection.
Spray leak solution on valve connections paying
particular attention to the areas indicated by arrows.
If any bubbles appear turn LP gas tank OFF, reconnect
and re-test. If you continue to see bubbles after
several attempts, disconnect LP gas source and
contact 1.800.816.0901 for assistance.
If no bubbles appear after one minute turn tank OFF,
wipe away solution and proceed.
8
Assembly Instructions
2
Screw the Feet (3) onto the Base (2).
Feed the propane tank end connection of the hose up through the bottom of the
Tank Holder Base (2). Be sure to not feed the hose through the center of the base
(this is where the propane tank will be seated).
2
To Propane
Fireplace
3
3
Place the propane tank in the base.
To Propane
Fireplace
9
4
Place the propane tank in the base and secure the tank by tightening the screw at the
bottom of the base.
5
Connecting the LP Gas Tank
6
Check to make sure there is no debris
in the head of the LP gas tank or in the
head of the regulator valve. Make sure
you check the burner and burner ports
as well.
Connect gas line to tank by turning
knob clockwise. Hand tighten only.
Disconnecting the LP Gas Tank
Make sure the valve on the LP gas tank
is OFF.
Disconnect by turning the knob counter
clockwise until it is off the valve.
10
7
With the propane tank secured and the regulator hose connected, place the Top (1)
onto the Base (2).
Do not sit on top of Tank Holder.
1
To Propane
Fireplace
2
Care and Cleaning
Cleaning
This outdoor fireplace should be cleaned regularly to ensure safe use and extend product life.
WARNING: DO NOT atempt to clean this outdoor fireplace unless the fire is COMPLETELY out and the unit is cool to
the touch.
WARNING: DO NOT use oven cleaner or abrasive cleaners as they will damage this product.
1. Wipe exterior surfaces with a mild dishwashing soap or baking soda.
2. Rinse clean with water.
Storage
WARNING: DO NOT move or store this outdoor fireplace unless the fire is COMPLETELY out and is cool to the touch.
1. Turn gas OFF at tank connection. Remove tank and store in a cool dry location outdoors away from children.
2. Carefully disassemble log set and store components flat in the fire bowl area to protect them from breakage.
3. Store in a cool dry location away from children and pets.
11
Download PDF
Similar pages