AuCS®
Automatic Cleaning System
An efficient, dependable, and affordable
accessory that schedules and performs
routine ice machine cleaning automatically.
The innovative AuCS® accessory virtually
eliminates the need to have a service technician
perform manual cleaning procedures on the
water distribution system of your Manitowoc
ice machine.
It is a known fact that regularly scheduled
preventative maintenance (cleaning) reduces
the total operating cost of any ice machine.
With AuCS, you simply select the cleaning
frequency (2, 4, or 12 weeks); AuCS does the
rest...automatically. AuCS is also affordable, as
the entire system costs less than the expense
of 3 manual cleanings. AuCS-SI and AuCS-SO
are designed for use with only Manitowoc
S-Series ice machines.
AuCS – SI (Internal Mounting)
Cleaning or Sanitizing: The AuCS accessory can
dispense either cleaner or sanitizer. It can not
dispense both at the same time. Refer to the
Installation Use and Care Manual supplied with
the AuCS accessory to determine the type of
solution needed and proper procedure for
changing solutions. Use only Manitowoc ice
machine cleaner or sanitizer.
• Cleaner is used to remove and control build
up of lime scale or other mineral deposits.
• Sanitizer is used to control algae (slime)
and other air borne bacteria (yeast).
AuCS – SI
• Internally mounted on S-Series Manitowoc
ice machines.
• Electricity drawn directly from ice machine.
• Can be ordered separately or installed at
the factory for no additional cost.
AuCS – SO
• Electricity drawn from ice machine directly.
• Exterior finish is stainless steel.
• Only 12" (30.48 cm) wide, 3.43" (8.7 cm) deep,
12.12" (30.78 cm) high.
Warranty
• 3-year warranty covering all parts and labor
from the date of original installation.
AuCS – SO (External Mounting)
ISO 9001:2000
Quality System Certified
America's #1 Selling Ice Machine
Ice Cube & Flake Machines • Ice Storage Bins • Ice Dispensers
Manitowoc AuCS® Accessory
Compatibility: The S-Model AuCS (AuCS – SI and AuCS – SO)
accessory can be used only on S-Series ice machines.
AuCS-SI Installation: The AuCS-SI mounts internally in S-Series ice machines.
S-Series ice machines can be ordered direct
AuCS-SO
from the factory with the AuCS-SI installed.
S-300
If the AuCS-SI is not factory installed, a trained
S-322
and qualified technician must perform installation.
S-422
Note: Line voltage is obtained from the ice
S-1470C
machine. Refer to the Model/Serial Plate on
S-1870C
the ice machine and the AuCS-SI to verify both
S-2070C
voltages are the same.
AuCS-SO Installation: The AuCS-SO is
AuCS-SI
mounted on the wall near the ice machine or on
S-450
the bin with the included bracket and hardware.
through
Note: Line voltage is obtained from the ice
S-1800
machine. Refer to the Model/Serial Plate on the
ice machine and the AuCS-SO to verify both
voltages are the same.
Setting Run Frequency: AuCS is set to run once approximately every 2 weeks.
For less frequent cleanings, set selector switch as needed:
WEEKS
CYCLES
2
1,120
4
2,240
12
6,720
4.75"
(12.06 cm)
10.00" (25.4 cm)
5.00" (12.7 cm)
AuCS – SI
(Internal Mounting)
3.43"
(8.71 cm)
AuCS – SO
(External Mounting)
12.00" (30.48 cm)
Automatic Operation: Automatic cleaning initiated by the AuCS system takes
approximately 30 minutes to complete. The cleaning procedure includes a
1-minute cleaning cycle followed by 6 rinse cycles.
9' (2.73 m)
Base Of
Ice Machine
NO!
(Too High)
2.0
0" (
5
cm
)
2.0
0" (
5. c
m)
Box Base
Or Box Top
Must Be Within
2" Of Ice Machine
Base
NO!
(Too Low)
NOTE: Box must also mount within reach of 9 foot (274 cm)
tubing and low voltage modular wire.
MANITOWOC ICE, INC.
2110 South 26th Street, P.O. Box 1720
Manitowoc, WI 54221-1720, USA
Ph: 920-682-0161 • Fax: 920-683-7589
Visit us online at www.manitowocice.com
©2007 Manitowoc 10/07 Continuing product improvement may necessitate change of specifications without notice.
Electric: 115/60/1. 208-230/50/60/1 also available for both
SI and SO models.
Total Amps: 0.3
Max Fuse Size: 15 amps
Replenishment: AuCS cleaning or sanitizing fluid is provided in either
16 oz. replacement bottles or 1 gallon containers for refilling.
12.12"
(30.78 cm)
2379C
Sequence of Operation:
Cleaning or Sanitizing Cycle
The cleaner or sanitizer is dispensed from the AuCS accessory for 10-20
seconds during the beginning of the cycle. The water pump circulates water
over the evaporator for 10 minutes. After 10 minutes of cleaning, the water
dump valve energizes for 45 seconds to dump the wash water down the
drain.
Rinse Cycles
The entire rinse cycle is repeated 6 times. The water pump circulates water
over the evaporator for 90 seconds. The water dump valve energizes to dump
the rinse water down the drain for 45 seconds.
Download PDF
Similar pages