Parts
Drying Tumblers
Stacked 30 Pound (300 Liter) Capacity
Refer to Page 2 for Model Numbers
HIGH
TEMP
MED
TEMP
STAR
T
LOW
TEMP
NO
HEAT
25 C
1
SELEC
TEMP T
2
INSER
COIN T
3
PUSH
START
1
SELEC
TEMP T
2
INSER
COIN T
3
PUSH
START
HIGH
TEMP
MED
TEMP
STAR
T
LOW
TEMP
NO
HEAT
25 C
T464PZ3A
Part No. 70185001R2
January 2000
Table of Contents
Title
Page
Parts Ordering Information ....................................................................................................................... 2
Nameplate Location .................................................................................................................................. 2
Model Identification................................................................................................................................... 3
Electronic Coindrop Models ...................................................................................................................... 4
Card Reader Control Components ........................................................................................................... 6
Rotary Coindrop Components .................................................................................................................. 8
Manual Dual Timer Control ..................................................................................................................... 10
Front Panel Components........................................................................................................................ 12
Upper Cylinder Support Components ..................................................................................................... 14
Lower Cylinder Support Components ..................................................................................................... 16
Lint Drawer Components ........................................................................................................................ 18
Door and Hinge Components ................................................................................................................. 20
Cylinder, Trunnion and Bearing .............................................................................................................. 22
Drive Motor Components........................................................................................................................ 24
Blower and Exhaust Components .......................................................................................................... 26
Gas Burner Components ........................................................................................................................ 28
Gas Valve and Piping ............................................................................................................................. 30
Electric Heater Components................................................................................................................... 32
Steam Heater Components .................................................................................................................... 34
Rear Control Box – Gas.......................................................................................................................... 36
Rear Control Box – Steam ...................................................................................................................... 38
Rear Control Box – Electric .................................................................................................................... 40
Rear Control Box – Gas.......................................................................................................................... 42
Rear Control Box – Steam ...................................................................................................................... 44
Rear Control Box – Electric .................................................................................................................... 46
Gas Burner Housing ............................................................................................................................... 48
Coindrop Assemblies for EC Models ...................................................................................................... 50
Rotary Coin Meter Assemblies for CD Models ....................................................................................... 50
Timer Motors for Rotary Coin Meter Assemblies (CD Models)............................................................... 51
Gas Burner Orifice Table† ...................................................................................................................... 52
L. P. Gas Kit Table†................................................................................................................................ 52
Motor Usage Table ................................................................................................................................. 53
Front Panel Assemblies†........................................................................................................................ 54
Wire Harness Table ................................................................................................................................ 55
Parts Index.............................................................................................................................................. 57
© Copyright 2000, Alliance Laundry Systems LLC
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without
the expressed written consent of the publisher.
70185001
1
Parts Ordering Information
If literature or replacement parts are required, contact
the source from whom the machine was purchased or
contact Alliance Laundry Systems at (920) 748-3950
for the name and address of the nearest authorized
parts distributor.
For technical assistance, call (920) 748-3121.
Nameplate Location
When calling or writing about your product, be sure to
mention model and serial numbers. Model and serial
numbers are located on nameplate(s) as shown.
ANS 72152
CLOTHES DRYER.
VOL II
MODEL NO:
TESTED FOR NATURAL &
LIQUID PETROLEUM GASSES
SERIAL NO:
V-/
HERTZ/
AMPS,
PHASE
CGA 72
WIRES + GROUND
TOTAL kW,
MOTOR kW
AMPLFIEDRER
REQ'D CIRCUIT BREAKER:
AMPS
FAN OUTPUT:
@MAX
"WC STATIC PRESSURE
EQUIPPED FOR:
MIN SUPPLY
PRESSURE:
INPUT:
"WC.
BTU/hr @
GAS@
"WC MANIFOLD PRESS.
MAX SUPPLY
PRESSURE:
"WC.
BTU/cu.ft.
MADE IN U.S.A./FABRIQUE AU ETATS UNIS/FABRICADO EN LOS ESTADOS UNIDOS
70051001
MODEL NO:
SERIAL NO:
T435i
2
70185001
Model Identification
Information contained in this manual is applicable to these tumbler models:
Stacked 30 Pound Tumbler
(300 Liter)
Gas:
High Output Steam
(4 coil)
Low Output Steam
(2 coil)
Electric
DC0300DFG
DC0300DSH
DC0300DSL
DC0300DEL
DC0300DRG
DT0300DSH
DT0300DSL
DT0300DEL
DT0300DFG
JC0300DSH
JC0300DSL
JC0300DEL
DT0300DRG
JT0300DSH
JT0300DSL
JT0300DEL
JC0300DFG
SC0300DSH
SC0300DSL
SC0300DEL
JC0300DRG
ST0300DSH
ST0300DSL
ST0300DEL
JT0300DFG
JT0300DRG
SC0300DFG
SC0300DRG
ST0300DFG
ST0300DRG
70185001
3
Notes
Electronic Coindrop Models
4
6
5
3
7
2
8
1
9
HI
G
TE H
MP
MED
TE
MP
ST
AR
T
LO
TE W
MP
NO
HE
AT
25 C
9
T428PZ3B
4
70185001
Electronic Coindrop Models
REF
1
PART #
DESCRIPTION
COMMENTS
70113601
Overlay, Electronic Control
Text – ST Models
70113901
Overlay, Electronic Control
Text with IR – JT Models (Export – English)
70135501
Overlay, Electronic Control
EU Icon – SC Models
70135701
Overlay, Electronic Control
With IR EU Icon – JC Models
70136101
Overlay, Electronic Control
Text Non IR – JT Models (USA)
70129301
Overlay, Electronic Control
Upper – PT/PC Models
70129401
Overlay, Electronic Control
Lower – PT/PC Models
70129501
Overlay, Single Coindrop
Upper – PT/PC Models
70129601
Overlay, Dual Coindrop
Upper – PT/PC Models
70129701
Overlay, Single Coindrop
Lower – PT/PC Models
70129801
Overlay, Dual Coindrop
Lower – PT/PC Models
70175901
Assembly, Door, Control with studs
SC/ST Models
70175902
Assembly, Door, Control with studs
JC/JT Models
3
70119101
Bracket, Latch Mounting
4
501524
Screw
5
431318
Latch, Door–control
6
M414049P
Assembly, Dryer Control & Tape
24 Volt
Coindrop
Refer to Table Page 50
2
7
8
70054
Nut
9
70107001
Switch, Push Button
38571
Dual Drop Multiplier Kit
For Dual Coindrops (Not Shown)
M4691P3
Electronic Coin Control Kit
ST (Non–European only)
M4692P3
Electronic Coin Control Kit
SC (European only)
M4721P3
Electronic Coin Control Kit
JT (Non–European only)
M4722P3
Electronic Coin Control Kit
JC (European only)
REF
70185001
5
Card Reader Control Components
4
5
3
6
7
8
2
9
1
10
HIGH
TE
MP
ME
TE D
MP
STA
RT
LO
TE W
MP
CardM
ate Sy
st
IN
SE
RT
CA
RD
11
NO
HE
AT
em
HE
RE
9
T429PZ3A
6
70185001
Card Reader Control Components
REF
PART #
DESCRIPTION
COMMENTS
70136201
Overlay, Card Reader
ST Models
70115701
Overlay, Card Reader
JT Models
70175903
Assembly, Control Door with studs
ST Models
70175904
Assembly, Control Door with studs
JT Models
3
70119101
Bracket, Latch Mounting
4
501524
Screw
5
431318
Latch, Control Door
6
M414049P
Electronic Control
7
M414120
Mounting Bracket, Card Reader
8
39685
Card Reader Control
9
1
2
70054
Nut
10
70119001
Bracket, Chassis Mounting
11
430497
Screw
70185001
7
Rotary Coindrop Components
3
2
4
PRIOR TO SERIAL
NO. 9806013547
1
5
4
18
17
5
15
16
6
7
6
8
14
13
12
HIG
PU
S
STTOH
AR
T
H
LO
W
TE
MP
ER
AT
UR
E
9
11
8
10
T427pz3d
70185001
Rotary Coindrop Components
REF
PART #
DESCRIPTION
COMMENTS
1
70118901
Bracket, Temperature Control
Prior to Serial No. 9806013547
2
M402797
Screw
3
M412534
Relay
4
431347P
Temperature Control Board
5
34896
Support, Temperature Control
6
70054
Nut
7
431353
Temperature Switch
9
70061701
Shroud, Rotary Coindrop
10
70080601
Temperature Knob
SC/ST Models
431357
Temperature Knob
JC/JT Models
70175907
Assembly, Control Door with studs
SC/ST Models
70175908
Assembly, Control Door with studs
JC/JT Models
12
70108501
Start Switch
13
70082201
Run Light
14
70115501
Overlay, Coin Drop
JT Models (USA & NON EU)
70128201
Overlay, Coin Drop
SC/ST Models
JC Models
Rotary Coindrop
8
11
Prior to Serial No. 9806013547 (4)
Starting with Serial No. 9806013547 (8)
Refer to Table on page 50
70136801
Overlay, Coin Drop–icon
15
70119801
Bracket, Latch Mounting
16
70108001
Bracket, Temperature Switch
17
70179001
Bracket, Temperature Control
18
70175301
Time Delay Circuit Board
Starting with Serial No. 9806013547
REF
M405535
Washer for Coindrop Mounting
Not Shown
M4693P3
Rotary Coin Meter Control Kit
ST/SC Models
M4723P3
Rotary Coin Meter Control Kit
JT/JC Models
70185001
Starting with Serial No. 9806013547
9
Manual Dual Timer Control
2
3
4
Prior to
Serial No.
9806013547
1
5
20
6
17
6
19
7
18
16
4
1
10
HE
AT
4
0
30
60
50
2
15
40
CO
DOOL
WN
5
PU
SH
STTO
AR
T
5
3
0
LO
W
15
10
HIG
H
8
14
10
12
13
11
9
T426pz3d
10
70185001
Manual Dual Timer Control
REF
PART #
DESCRIPTION
COMMENTS
1
70131301
Bracket, Temperature Control
Prior to Serial No. 9806013547
2
M402797
Screw
3
M412534
Relay
4
431347P
Temperature Control Board
5
34896
Support, Temperature Control
6
70054
Nut
7
431353
Temperature Switch
8
70175301
Time Delay Circuit Board
9
70179101
Bracket, Temperature Control
10
70131801
Timer, Cooling
11
431357
Temperature Knob
12
13
2 Required For Each Control
Prior to Serial No. 9806013547 (4 required)
Starting with Serial No. 9806013547 (8 required)
Starting with Serial No. 9806013547
JC/JT Models
70080601
Temperature Knob
DC/DT/SC/ST Models
70175905
Assembly, Control Door with studs
DC/DT/SC/ST Models
70175906
Assembly, Control Door with studs
JC/JT Models
70114401
Overlay, Manual Timer
JT Models (USA & non EU)
70128101
Overlay, Manual Timer
DT/ST Models (USA & non EU)
70129901
Overlay, Manual Timer
Upper – PT/PC Models
70130001
Overlay, Manual Timer
Lower – PT/PC Models
70135401
Overlay, Manual Timer
Icon (EU) – DC/SC Models
70135601
Overlay, Manual Timer
Icon (EU) – JC Models
14
70108501
Start Switch
15
70082101
Timer Knob
DC/DT/SC/ST Models
M410927
Timer Knob
JC/JT Models
16
70082201
Light, Heat & Cooling
17
M411052
Screw
18
70119801
Latch Mounting
19
70131701
Timer, Heat
20
70108001
Bracket, Temperature Switch
REF
M4694P3
Manual Timer Control
ST/SC Models
M4724P3
Manual Timer Control
JT/JC Models
70185001
11
Front Panel Components
4
5
6
8
10
7
3
9
2
11
1
12
13
18
21
3
14
22
1
SELE
CT
TEM
P
2
INSE
RT
COIN
3
PUS
H
STA
RT
10
1
SELE
CT
TEM
P
2
INSE
RT
COIN
3
PUS
H
STA
RT
20
23
7
19
17
11
12
9
18
15
14
T433pz3c
16
12
70185001
Front Panel Components
REF
PART #
DESCRIPTION
COMMENTS
1
70155601
Key for Lock (RL001)
See Note Below
2
70155501
Lock, Control Door (RL001)
See Note Below
3
70033502
Screw
Assembly, Upper Front Panel
4
Refer to Table on page 54
5
M401223
Door Catch
6
M400003
Pop Rivet
7
70132301
Screw
JC/SC Models
8
H88510516
Washer
JC/SC Models
9
70119301
Bracket, Door Switch
European, JC/SC Models
10
70072901
Nut
JC/SC Models
11
70125101
Door Switch
European, JC/SC Models
12
M401938
Screw
JC/SC Models
13
70119901
Control Housing
14
70107001
Door Switch
Assembly, Lower Front Panel
Refer to Table on page 54
70117605
Kickplate
SC/ST Models
JC/JT Models
15
16
70117606
Kickplate
17
70117901
Gasket, Lint Drawer
18
M411097
Screw
19
70116901
Trim, Control
20
Right; SC/ST Models
70117001
Trim, Control
Left & Right; JC/JT Models
70114601
Overlay, Yoke
SC/ST Models
70137001
Overlay, Yoke
PT/PC Models
21
70116902
Trim, Control
Left; SC/ST Models
22
70120501
Trim, Control
Center; SC/ST Models
23
70117501
Trim, Coin Vault
Gray; JC/JT Models
REF
70117502
Trim, Coin Vault
Black; SC/ST Models
70117503
Trim, Coin Vault
White; PC/PT Models
M4009712
Clips for Retaining Trim Pieces
(Not Shown)
M412232
Knob, Emergency Stop
European Models, JC/SC–MT (Not Shown)
M412235
Label, Yellow for Emergency Stop
European Models, JC/SC–MT (Not Shown)
70116701
Switch, Emergency Stop
European Models, JC/SC–MT (Not Shown)
70069901
Screw, 10 x 1.25 Inch
Mounted Vertically to Secure Top of Lower Front Panel
(Not Shown)
NOTE: Locks with key codes H2133, H2141 are no longer available. When replacing these items, order both lock and key.
70185001
13
Upper Cylinder Support Components
2
1
3
4
5
4
1
9
4
13
14
6
10
12
8
11
9
7
T434PZ3C
14
70185001
Upper Cylinder Support Components
REF
PART #
DESCRIPTION
1
70015701
Gasket, Baffle
11.38
2
70022101
Baffle, Partition
Upper Left
3
70015702
Gasket, Baffle
8.75
4
70036601
Thermal Shield
Discontinued after Serial No. 9807017397
5
70022001
Baffle, Partition
Upper Right
6
70030401
Clip
7
70056601*L
Side Panel
8
70057101
Baffle, Partition
9
431159
Switch, Lint Drawer
10
70015701
Gasket, Baffle
11
70052601
Roller
12
430576
Nut
13
70198801
Baffle, Partition
14
70017701
Roller Shaft
REF
70058561
Rivets
70185001
COMMENTS
Lower Right
11.38
Lower Left
31 per Side Panel
15
Lower Cylinder Support Components
2
1
3
8
4
7
9
5
6
19
3
17
4
15
18
6
14
16
10
13
12
11
T435pz3b
16
70185001
Lower Cylinder Support Components
REF
PART #
DESCRIPTION
COMMENTS
1
70015701
Gasket, Baffle
11.38
2
70215302
Baffle, Partition
Upper Left
3
70015702
Gasket, Baffle
8.75
4
70036601
Thermal Shield
5
70198801
Baffle, Partition
6
430576
Nut
7
70215303
Baffle, Partition
8
70180101
Coin Vault
9
70066001
Cylinder Seal
10
70056601*L
Side Panel
11
34319
Leveling Leg
12
21899
Nut
13
431159
Switch, Lint Drawer
14
70198701
Baffle, Partition
15
70030501
Clip
16
70052601
Roller
17
70017701
Roller Shaft
18
7055001
Roller Support Bracket
19
70198801
Gasket, Baffle
11.38
REF
70058502
Rivets
13 per Coin Vault
70058501
Rivets
31 per Side Panel
70216201P
Kit, Coin Chute and Plate
70014003
Center Seal Clip
Lower Left
Upper Right
Center
Lower Right
Not Shown
* Add letter to designate color.
V – Orange
K – Red
L – Almond
W – White
70185001
B – Battina Green
H – Harvest Gold
X – Electric Blue
P – Turquoise
17
Lint Drawer Components
6
5
4
3
7
2
1
SE
TE LECT
MP
2
INS
CO ERT
IN
3
PU
ST SH
AR
T
8
1
SE
TE LECT
MP
2
INS
CO ERT
IN
3
PU
ST SH
AR
T
10
1
11
9
T430pz3b
18
70185001
Lint Drawer Components
REF
PART #
DESCRIPTION
COMMENTS
1
70155602
Key (RL002)
See Note below
2
70155502
Lock (RL002)
See Note below
3
70114701
Overlay, Upper Lint Drawer
ST Models
70115101
Overlay, Upper Lint Drawer
JT Models
70136501
Overlay, Upper Lint Drawer
SC European Models
70136401
Overlay, Upper Lint Drawer
JC European Models
4
70173801
Assembly, Front Plate with studs
JC/JT Models
70173802
Assembly, Front Plate with studs
SC/ST Models
5
70109201
Gasket, Lint Frame
6
70173201
Assembly, Lint Screen
7
29786
Nut
8
70026901
Bracket
9
70115301
Overlay, Lower Lint Drawer
ST Models
70115201
Overlay, Lower Lint Drawer
JT Models
70136601
Overlay, Lower Lint Drawer
JC European Models
70136401
Overlay, Lower Lint Drawer
SC European Models
10
20852
Screw
11
70051201
Plate
NOTE: Locks with key codes H2133, H2141 are no longer available. When replacing these items, order both lock and key.
70185001
19
Door and Hinge Components
5
4
2
6
7
3
1
8
9
10
11
12
15
17
13
16
14
T439PZ3A
20
70185001
Door and Hinge Components
REF
1
PART #
DESCRIPTION
COMMENTS
70176501
Door Assembly Complete
ST/SC Models
70176502
Door Assembly Complete
JT/JC Models
70176503
Door Assembly Complete
DC/DT Models
70176504
Door Assembly Complete
GC/GT/PC/PT Models
2
70211601
Door Rim Gasket
3
70115901*
Door Hinge
Painted
70115902
Door Hinge
Stainless Steel
4
61199
Screw
5
501524
Screw
6
70174801
Hinge Cam
7
70071401
Hinge Pin
8
70071101
Hinge Bushing
9
70174701
Hinge Lug
10
70113001
Screw
11
70033502
Screw, Internal Hex
12
70211901
Door Glass Seal
13
70133601P
Door Glass
JT/JC Models
M400784P
Door Glass
DC/DT/ST/SC Models
14
70215001P
Door Switch Actuator
15
70113001
Screws for Door Handle
DT/DC/ST/SC Models (4 used)
M409385
Screws for Door Handle
JT/JC Models (4 used)
GC/GT/PC/PT Models (2 used)
70024801
Door Handle
ST/SC Models
70133501
Door Handle
JT/JC Models
16
17
REF
Long
430117
Door Handle
DC/DT Models
M400133
Door Handle
PC/PT Models
M400661
Door Strike Screw
70054
Nut
M400645
Acorn Nut for Door Strike
(Not Shown)
* Add letter to designate color.
V – Orange
K – Red
L – Almond
W – White
70185001
B – Battina Green
H – Harvest Gold
X – Electric Blue
P – Turquoise
21
Cylinder, Trunnion and Bearing
4
8
9
10
7
11
6
3
5
12
2
13
1
T390PZ3C
22
70185001
Cylinder, Trunnion and Bearing
REF
PART #
DESCRIPTION
1
70070101
End Cap–Cylinder Baffle
2
70175101
Cylinder Assembly
Galvanized
70175102
Cylinder Assembly
Stainless Steel
70227301
Cylinder Assembly, with Channel
(Perforated Rib)
Galvanized; Gas and Steam Models Starting with Serial
No. 9906019882
70027302
Cylinder Assembly, with Channel
(Perforated Rib)
Stainless Steel; Gas and Steam Models Starting with
Serial No. 9906019882
3
62588
Screw
4
70013701
Rear Cylinder Seal
5
70189301
Trunnion Assembly
6
70193801
Felt Seal
7
430352
Stud Plate
8
430038
Bearing
Bearing Housing
9
70013901
10
M400991
Washer
11
M400034
Palnut
12
M400022
Jamnut
13
M412986
Nut
70185001
COMMENTS
Use 22506P Adhesive
Not Required for RG Models
23
Drive Motor Components
1
2
3
4
5
6
17
16
15
7
14
8
13
9
10
12
T522PZ3A
11
24
70185001
Drive Motor Components
REF
PART #
DESCRIPTION
1
70053103
Belt
2
70189103
Motor Pulley
70189101
Motor Pulley
60 Hertz
Motor
See Table Page 114
3
4
70062401
Bolt
5
70202501
Cover
6
27222
Clip
7
M412986
Nut
8
70127301
Bracket, Motor Mount
9
70179501
Channel, Motor
10
70179601
Bracket
11
70045301
Spring
12
430782
Washer
13
431539
Screw
14
430648
Screw
15
70050401
Idler Roller
16
70059201
Idler Arm
17
52566
Nut
70173701
Bracket, Idler Lock
70179701
Tab
REF
70185001
COMMENTS
50 Hertz
25
Blower and Exhaust Components
1
2
3
4
5
11
6
10
7
8
9
T523PZ3A
26
70185001
Blower and Exhaust Components
REF
PART #
DESCRIPTION
COMMENTS
Fan Motor
See Table Page 114
2
70144101
Key
3
430497
Screw
4
70112801
Cover
5
M411307
Thermostat, High–Limit
Close 175 – All Except Australia
70186401
Thermostat, High–Limit
Manual Reset – Australia
6
M411758
Assembly, Thermistor
7
70123301
Assembly, Fan
1
8
M400022
Jamnut
9/16–18
9
M400034
Palnut
9/16 x 18
10
70126101
Screw
3/8–16x 5/8 Hex Washer Head
11
70017401
Washer
REF
70056201
Exhaust Damper
Not Shown; Prior to Serial Number 9903028340
70017801
Exhaust Thimble
6 inch
70200301
Stabilizer Bracket
Not Shown
34319
Leveling Leg
Not Shown
21899
Nut
Not Shown
70185001
27
Gas Burner Components
5
6
4
3
2
4
7
4
12
8
1
11
9
10
28
T501PZ3A
70185001
Gas Burner Components
REF
PART #
DESCRIPTION
COMMENTS
70184801
Gas Burner
All RG Models starting with Serial No. 980717398 and
downrated PG Models
70032710
Gas Burner †
FG Models
2
05161
Screw
3
70032801
Spark Electrode
4
430497
Screw
5
M402797
Screw
6
M409219
Thermostat, Stove Limit
70186301
Thermostat, Stove Limit
7
M401938
Screw
8
70188301
Bracket
9
M400979
Twin Speed Nut
10
70068901
Air Flow Vane
11
70068701
Air Flow Switch
12
70188201
Cover, Air Flow Switch
1
Australia
† Original Burner is replaced by M4729P3 Downrate Kit on FG Models
70185001
29
Gas Valve and Piping
7
8
9
6
5
4
3
10
2
1
11
12
14
13
T499PZ3A
30
70185001
Gas Valve and Piping
REF
PART #
DESCRIPTION
COMMENTS
Burner Orifice
See Table Page 51
2
431484
Screw, Socket Head
3
70034201
Spud Adapter
4
431482
O Ring
5
70186701
Gas Valve Coil
24 Volts
6
M4733P3
Gas Valve–Regulated
Natural Gas
M4734P3
Gas Valve–Unregulated
L.P. Gas
7
M412562
Shutoff Valve
Upper Unit Only
8
431486
Close Nipple
9
H86000031
Union
1
Spud Adapter to Valve
Upper Unit Only
10
70139601
Pipe Nipple
9.5 – Upper Unit Only
11
70071801
Pipe Tee
Upper Unit Only
12
70131901
BPT to NPT Adapter
2 Required
13
70112901
Flex Gas Line
Lower To Upper Gas Valve; Prior to Serial No.
9903028340
14
430497
Screw
70079601
Elbow, 90 Degree
REF
70185001
Lower Unit Only; Not Shown
31
Electric Heater Components
3
1
2
7
6
3
5
4
T443PZ3D
32
70185001
Electric Heater Components
REF
PART #
DESCRIPTION
1
M402797
Screw
2
M410220
Thermostat, High Limit
3
430497
Screw
4
70214901
Grill
COMMENTS
70034401
Heater Element
7kw – 208 Volt
70034402
Heater Element
7kw – 220 Volt, 380 Volt
70034403
Heater Element
7kw – 230 Volt, 240 Volt, 415 Volt and 480 Volt
6
M400869
Jumper Bar
7
Q6163
Nut
5
70185001
33
Steam Heater Components
1
2
3
T482PZ3B
34
70185001
Steam Heater Components
REF
1
2
3
REF
70185001
PART #
DESCRIPTION
COMMENTS
70035801
Steam Coil
2 Row; SL Models
70035901
Steam Coil
4 Row; SH Models
70205701
Steam Valve Solenoid
60 Hertz
M412258
Steam Valve Solenoid
50 Hertz
70205601
Steam Solenoid Valve
60 Hertz
M413445
Steam Solenoid Valve
50 Hertz
M409443
Thermostat, High Limit
(Not Shown)
35
Rear Control Box – Gas
(Non European)
6
4
5
3
2
1
8
7
10
12
14
36
13
9
11
T425pz3d
70185001
Rear Control Box – Gas
(Non European)
REF
PART #
DESCRIPTION
COMMENTS
M414228
Transformer
200-240 Volt 60 Hertz 3 Phase
200-240 Volt 50 Hertz 1/3 Phase
M414229
Transformer
380-480 Volt 50-60 Hertz 3 Phase
M414230
Transformer
60 Hertz 1 Phase
2
M405824
Screw
3
430640
Terminal Block
4
M413863
Insulator
5
M413433
Ignition Control
Australia
M413532
Ignition Control
USA and Non-European 50 Hertz
70086301
Bracket, Fuse Holder
Low Voltage
70086401
Bracket, Fuse Holder
Voltages 380 and Above
91024
Fuse Holder
1
6
7
8
M413544
Fuse Holder
All 380 Volt or Higher
M413118
Fuse
2 Amp – 120 to 240 Volt Models
M413621
Fuse
0.5 Amp – All Voltages 380 Volt and Above
M414232
Fuse
3.5 Amp – All Except Australia
2 Amp - All 100 Volt Models
M414240
Fuse
9
70006201
Ignition Cable
10
70210901
Motor Relay
1 Phase
M413614
Contactor
3 Phase
11
51778
Screw for Relay
51780
Screw for Contactor
12
M401902
Screw
13
70126601
Fuse Access Cover
14
51780
Screw
M413431
Lighted Push Button Switch
REF
70185001
Australian Models Only (Not Shown)
37
Rear Control Box – Steam
(Non European)
5
4
3
2
1
7
6
8
10
9
12
38
11
T425pz3e
70185001
Rear Control Box – Steam
(Non European)
REF
PART #
DESCRIPTION
COMMENTS
M414228
Transformer
200-240 Volt 60 Hertz 3 Phase
200-240 Volt 50 Hertz 1 or 3 Phase
M414229
Transformer
380-480 Volt 50-60 Hertz 3 Phase
M414230
Transformer
60 Hertz 1 Phase
2
M405824
Screw
3
430642
Terminal Block
4
M413862
Insulator
5
70086301
Bracket, Fuse Holder
Low Voltage
70086401
Bracket, Fuse Holder
Voltages 380 and Above
91024
Fuse Holder
1
6
7
8
9
M413544
Fuse Holder
All 380 Volt or Higher
M413118
Fuse
2 Amp – 120 to 240 Volt Models
M413621
Fuse
0.5 Amp – All Voltages 380 and Above
M414232
Fuse
3.5 Amp; All Except Australia
M414240
Fuse
2 Amp; All 100 Volt Models
70210901
Motor Relay
1 Phase
M413614
Contactor
3 Phase
51778
Screw for Relay
51780
Screw for Contactor
10
M401902
Screw
11
70126601
Fuse Access Cover
12
51780
Screw
70185001
39
Rear Control Box – Electric
(Non European)
6
7
5
4
3
2
1
9
40
8
T425pz3f
70185001
Rear Control Box – Electric
(Non European)
REF
1
PART #
DESCRIPTION
COMMENTS
M414230
Transformer
60 Hertz 1 Phase
M414228
Transformer
200-240 Volt 60 Hertz 3 Phase
200-240 Volt 50 Hertz 1/3 Phase
M414229
Transformer
380-480 Volt 50-60 Hertz 3 Phase
2
32671
Screw
3
M413865
Power Distribution Block
4
M413616
Heater Contactor
5
M413118
Fuse
2 Amp – All Voltages 240 Volt or Lower
M414232
Fuse
3.5 Amp – All Except Australia
M413621
Fuse
0.5 Amp – All Voltages 380 and Above
91024
Fuse Holder
M413544
Fuse Holder
All 380 Volt or Higher
70086301
Bracket, Fuse Holder
Low Voltage
Voltages 380 and Above
6
7
70086401
Bracket, Fuse Holder
8
M413614
Fan Contactor
9
51780
Screw for Contactor
70185001
2 for 200-240 Volt
1 for 380-480 Volt
41
Rear Control Box – Gas
(European)
2
1
16
4
15
5
3
9
14
6
9
13
7
12
9
8
10
11
7
T459PZ3C
42
70185001
Rear Control Box – Gas
(European)
REF
PART #
DESCRIPTION
1
M413433
Ignition Control
2
M405824
Screw
3
M413621
Fuse
0.5 Amp – 2 Required – 380 Volt and Above
M413867
Fuse
2 Amp – 2 Required – Voltages 240 or Under
M413889
Fuse
4 Amp – 1 Required – All Voltages
502591
Fuse Holder
M413544
Fuse Holder
All 380 Volt or Higher
70124101
Bracket, Fuse Holder
Voltages 240 and Below
Voltages 380 and Above
4
5
COMMENTS
70124201
Bracket, Fuse Holder
6
M413614
Contactor
7
33562
Screw
8
M414228
Transformer
60 Hertz 1 Phase
M414229
Transformer
380-480 Volt/50-60 Hertz/3 Phase
9
70121001
End Stop
3 Required
10
M412368
Interlock Assembly
11
M412208
Handle
12
70121101
End Cover
1 Required
13
70120001
Terminal Block
3 Required
14
M412187
Disconnect Switch
20 Amp
15
70144401
Din Rail
101mm
16
430497
Screw
70006201
High Voltage Lead
REF
70185001
43
Rear Control Box – Steam
(European)
3
2
1
4
5
9
14
6
9
13
7
12
9
8
10
11
44
7
T459PZ3
70185001
Rear Control Box – Steam
(European)
REF
PART #
DESCRIPTION
COMMENTS
1
70144401
Din Rail
101mm
2
430497
Screw
3
70124101
Bracket, Fuse Holder
Voltages 240 and Below
70124201
Bracket, Fuse Holder
Voltages 380 and Above
4
5
502591
Fuse Holder
M413544
Fuse Holder
All 380 Volt or Higher
M413621
Fuse
0.5 Amp – 2 Required – 380 Volt and Above
M413867
Fuse
2 Amp – 2 Required – Voltages 240 or Under
4 Amp – 1 Required – All Voltages
M413889
Fuse
6
M413614
Contactor
7
33562
Screw
8
M414228
Transformer
60 Hertz/1 Phase
M414229
Transformer
380-480 Volt/50-60 Hertz/3 Phase
9
70121001
End Stop
3 Required
10
M412368
Interlock Assembly
11
M412208
Handle
12
70121101
End Cover
1 Required
13
70120001
Terminal Block
3 Required
14
M412187
Disconnect Switch
20 Amp
70185001
45
Rear Control Box – Electric
(European)
6
5
7
4
3
2
15
1
8
14
13
12
11
9
10
46
T452PZ3D
70185001
Rear Control Box – Electric
(European)
REF
PART #
DESCRIPTION
1
M412207
Handle
2
M412118
Gasket
3
M412368
Interlock Assembly
4
M412186
Disconnect Switch
5
M413621
Fuse
0.5 Amp 600 Volt
M413889
Fuse
4 Amp 250 Volt
502591
Fuse Holder
250 Volt
M413544
Fuse Holder
600 Volt
7
70124201
Bracket, Fuse Holder
8
M413614
Fan Contactor
9
6
COMMENTS
M414229
Transformer
10
430497
Screw
11
M412756
Buss Bar Assembly
9 Pos.
12
M412407
Circuit Breaker
8 Amp
13
M412045
Terminal Block
3 Pole (2 required on 380-415 Volt Models)
14
33562
Screw
15
M413616
Heater Contactor
REF
70172301
Din Rail
For Circuit Breaker – 51mm (Not Shown)
M412692
Din Rail
For Terminal Blocks – 89mm (Not Shown)
M412406
Circuit Breaker
40 Amp (2 required on 240 Volt Only)
70185001
47
Gas Burner Housing
2
1
3
5
4
T465PZ3E
48
70185001
Gas Burner Housing
REF
PART #
DESCRIPTION
COMMENTS
70071501
Cover, Gas Valve
Upper; FG Models prior to Serial No. 9807017398
70133401
Cover, Gas Valve
Lower; FG Models prior to Serial No. 9807017398
70210101
Cover, Gas Valve
RG Models after Serial No. 9807017398
2
430497
Screw
3
70194601
Stove Top & Sides
4
70068601
Burner Grill
5
70183001
Stove Back
1
70185001
49
Coindrop Assemblies for EC Models
PART #
DESCRIPTION
38462
Assembly, Coindrop–Token 118–1
38463
Assembly, Coindrop–Token 118–5
38464
Assembly, Coindrop–Canada $.25
38465
Assembly, Coindrop–Canada $.25/1.00
38467
Assembly, Coindrop–Australia $.20/1.00
38469
Assembly, Coindrop–Belgium 5/20 BEF
38472
Assembly, Coindrop–England 20p/1£
38479
Assembly, Coindrop–U.S.A. $.25
38517
Assembly, Coindrop–Denmark 1/5 DKK
38518
Assembly, Coindrop–France 2/10 FRF
38519
Assembly, Coindrop–Japan 100/500 yen
38475
Assembly, Coindrop–Japan 100 yen
38520
Assembly, Coindrop–Italy 500 lira
38521
Assembly, Coindrop–Korea 100/500 won
38522
Assembly, Coindrop–New Zealand $.20/1.00
38963
Assembly, Coindrop–Token 118–16
38964
Assembly, Coindrop–dual–Taiwan
38478
Assembly, Coindrop–Taiwan–10NT
39157
Assembly, Coindrop–Israel shekel
Rotary Coin Meter Assemblies for CD Models
PART #
50
DESCRIPTION
70112401
Coinmeter, 24 Volt Australia $.20
70112501
Coinmeter, 24 Volt Australia $1
70112701
Coinmeter, 24 Volt U.S.A. $.25 60 Hertz
70137301
Coinmeter, 24 Volt Standard Token 118–1 60 Hertz
70137401
Coinmeter, 24 Volt Standard Token 118–5 60 Hertz
70138401
Coinmeter, 24 Volt U.S.A. $.25 50 Hertz
70151301
Coinmeter, 24 Volt South Africa .20
M412542
Coinmeter, 24 Volt England 20p
M412543
Coinmeter, 24 Volt France 2 FRF
M412544
Coinmeter, 24 Volt Denmark 1 DKK
M412545
Coinmeter, 24 Volt Belgium 5 BEF
M412546
Coinmeter, 24 Volt Standard Token 118–1 50 Hertz
M412547
Coinmeter, 24 Volt Standard Token 118–5 50 Hertz
M413195
Coinmeter, 24 Volt France 5 FRF
70185001
Timer Motors for Rotary Coin Meter Assemblies (CD Models)
PART #
70185001
DESCRIPTION
DESCRIPTION
70218301
Timer Motor
24 Volt, 50 Hertz
70218201
Timer Motor
24 Volt, 60 Hertz
51
Gas Burner Orifice Table†
MODEL NO.
0300DFG
0300DRG
ALTITUDE
GAS TYPE
FEET
METERS
0–2,000
0-609
2,001–4,000
610-1220
4,001–6,000
1221-1830
6,001–8,000
1831-2440
8,001–10,000
PART
NUMBER
DRILL SIZE
70070902
7/64
M411375
#36
M401024
#37
M411376
#38
2441-3050
M406361
#40
0–2,000
0-609
M411511
#15
2,001–4,000
610-1220
M411373
#16
4,001–6,000
1221-1830
M411374
#17
6,001–8,000
1831-2440
M402995
#19
8,001–10,000
2441-3050
M401002
#20
0–2,000
0-609
M406361
#40
2,001–4,000
610-1220
M403017
#42
4,001–6,000
1221-1830
M403017
#42
6,001–8,000
1831-2440
M406184
#43
8,001–10,000
2441-3050
M401011
#44
0–2,000
0-609
M401002
#20
2,001–4,000
610-1220
M402996
#22
4,001–6,000
1221-1830
M402980
#24
6,001–8,000
1831-2440
M401000
#26
8,001–10,000
2441-3050
M401014
#28
L.P.
(Propane)
Gas
Natural Gas
L.P.
(Propane)
Gas
Natural Gas
† These tables DO NOT apply to European models.
NOTE: Each kit contains parts to convert both gas valves.
L. P. Gas Kit Table†
MODEL NO
0300DFG
0300DRG
ALTITUDE
PART NUMBER
BTU INPUT
0–2,000
M4707P3‡
176000
2,001–4,000
M4708P3‡
176000
4,001–6,000
M4708P3‡
176000
6,001–8,000
M4709P3‡
176000
8,001–10,000
M4710P3‡
176000
0–2,000
M4707P3
145000
2,001–4,000
M4708P3
145000
4,001–6,000
M4708P3
145000
6,001–8,000
M4709P3
145000
8,001–10,000
M4710P3
145000
‡Order two Rerate Kits (M4729P3) in addition to this kit.
52
70185001
Motor Usage Table
SERIAL PLATE VOLTAGE
ELECTRIC
BLOWER
MOTOR
RG
CYLINDER
MOTOR
FG
PRE-RERATE
CYLINDER
MOTOR
GAS
STEAM
100 Volt/ 50-60 Hertz/ 1 Phase
✓
✓
70020201
70168301
70168301
120 Volt/ 60 Hertz/ 1 Phase
✓
✓
70020201
70168301
70168301
200-208 Volt/ 60 Hertz/ 3 Phase
✓
70020201
70168301
70168301
200 Volt/ 50 Hertz/ 1 or 3 Phase
✓
70020201
70168301
70168301
70069501
70062801
70062801
✓
70020201
70168301
70168301
✓
70070001
70171601
70171601
✓
70070001
70171601
70171601
70069501
70062901
70062901
✓
70070001
70171601
70171601
✓
70070001
70171601
70171601
70069501
70062901
70062901
70020201
70168301
70168301
200 Volt/ 50 Hertz/ 3 Phase
✓
✓
200-208 Volt/ 60 Hertz/ 1 Phase
230-240 Volt/ 50 Hertz/ 1 Phase
✓
✓
230-240 Volt/ 50 Hertz/ 3 Phase
230 Volt/ 50 Hertz/ 1 Phase
✓
✓
✓
✓
230 Volt/ 50 Hertz/ 3 Phase
✓
✓
✓
240 Volt/ 60 Hertz/ 1 or 3 Phase
240 Volt/ 60 Hertz/ 3 Phase
✓
✓
70069501
70062801
70062801
380 Volt/ 50 Hertz/ 3 Phase
✓
✓
70069501
70062801
70062801
✓
70069501
70062801
70062801
✓
70069501
70062801
70062801
✓
70069501
70062801
70062801
70185901
70185801
400-415 Volt/ 50 Hertz/ 3 Phase
460-480 Volt/ 60 Hertz/ 3 Phase
✓
✓
120-208-240 Volt/60 Hertz/ 1
Phase, starting with Serial No.
9903002218 (20 Amp Motor)
✓
✓
NOTE: The following capacators are available for 20 Amp tumblers:
70211401
Run Capacitor for 70185801 Drive Motor
70211502
Start Capacitor for 70185801 Drive Motor
70211501
Start Capacitor for 70185901 Blower Motor
70185001
53
Front Panel Assemblies†
PART NO
UPPER/LOWER
DESCRIPTION
70176001*
Upper
Painted; JT/ST Models
70176002
Upper
Stainless Steel; JT/ST Models
70176003*
Upper
Painted; European JC/SC Models
70176004
Upper
Painted; European JC/SC Models
70176101*
Lower
Painted; JT/ST Coin Models
70176102
Lower
Stainless Steel; JT/ST Coin Models
70176103*
Lower
Painted; JT/ST OPL Models
70176104
Lower
Stainless Steel; JT/ST OPL Models
70176105*
Lower
Painted, European JC/SC Coin Models
70176106
Lower
Stainless Steel; European JC/SC Coin Models
70176107*
Lower
Painted; European JC/SC OPL Models
71076108
Lower
Stainless Steel; European JC/SC OPL Models
* Add letter to designate color.
V – Orange
K – Red
L – Almond
W – White
B – Battina Green
H – Harvest Gold
X – Electric Blue
P – Turquoise
†All Front Panel Assemblies inlcude M401223 (Door Catch) and M400003 (Pop Rivet)
54
70185001
Wire Harness Table
Part No.
431611
431613
70055801
70082501
70082601
70082701
70082801
70082901
70067001
70083001
70083201
70083301
70084101
70084102
70084201
70084202
70084301
70084302
70084303
70113101
M413997
70055901
70120201
70138601
70138701
70139401
70142501
M413504
M413505
M413506
M413507
M413508
70185001
Description
From - To
Used On
Dual Drop Harness Assembly
Dual Drop to EDC Control
Card Reader Harness Assembly Card Reader to EDC Control
EDC Control Panel Harness
Control Panel to Main Harness
All Dual Drop EDC Models
All Card Reader EDC Models
All Non–European models with
EDC Controls
MT Control Panel Harness
Control Panel to Main Harness
All Manual Timer models
CD Control Panel Harness
Control Panel to Main Harness
All Rotary Coindrop models
EU EDC Control Panel Harness Control Panel to Main Harness
All European models with EDC
Control
OM/RM Control Panel Harness
Control Panel to Main Harness
All OM and RM Models (Non
EU)
OM/RM Control Panel Harness
Control Panel to Main Harness
All European OM and RM
Models
Main Interlock Harness
Front to Rear Control Tray
All Models
Control Tray Harness
Connects Control Tray to Interlock Harness All Non-Reversing Models
Ignition Control Harness
Interlock Harness to Ignition Control
All Gas Models except
European and Australian
Ignition Control Harness
Interlock Harness to Ignition Control
All European and Australian
Gas Models
MT/CD Temperature Board
Temperature Control Board to Temperature All 0220S & 0270S MT and CD
Configuration Harness
Switch
Models
MT/CD Temperature Board
Temperature Control Board to Temperature All 0350S MT and CD Models
Configuration Harness
Switch
EDC Temperature Board
Temperature Control Board to Temperature All 0220S & 0270S EDC Models
Configuration Harness
Switch
EDC Temperature Board
Temperature Control Board to Temperature All 0350S EDC Models
Configuration Harness
Switch
OM Temperature Board
Temperature Control Board to Temperature All 0350S OM Models
Configuration Harness
Switch
Temperature Control Board to Temperature All 0350S RM Models
RM Temperature Board
Configuration Harness
Switch
OM Temperature Board
Temperature Control Board to Temperature All 0220S & 0270S OM Models
Configuration Harness
Switch
Steam Jumper Harness
Plugs Into Junction Box Harness
All Steam Models
Steam Valve Harness
Junction Box Harness to Steam Valve
All Steam Models
1 Phase Electric Power Harness Terminal Block to Relay
All 1 Phase Electric Models
3 Phase Electric Power Harness Terminal Block to Relay
All 3 Phase Electric Models
Electric Heater Cable Set (H1Heater Contactor to Elements
All Electric Models
H3)
Electric Heater Cable Set (H4Heater Contactor to Elements
All Electric Models
H6)
Electric Power Buss Harness
Control Tray to Accessory Box
All Electric Models
Electric Power Buss Harness
Connects Power Buss to Interlock Harness All Electric Models
100 Volt Transformer
Transformer Primary to Junction Box
100 Volt/ 50-60 Hertz/ 1 Phase
Configuration Harness
Harness
Gas and Steam Models
120 Volt Transformer
Transformer Primary to Junction Box
120 Volt/ 50-60 Hertz/ 1 Phase
Configuration Harness
Harness
Gas and Steam OM/RM Models
208 Volt Transformer
Transformer Primary to Junction Box
208 Volt/ 60 Hertz/ 1 and 3
Configuration Harness
Harness
Phase Gas and Electric
Models
240 Volt Transformer
Transformer Primary to Junction Box
EU Gas and Steam
Configuration Harness
Harness
230 Volt/ 50 Hertz/ 1 Phase;
Gas, Steam and Electric
230-240 Volt/ 50-60 Hertz/
3 Phase
380 Volt Transformer
Transformer Primary to Junction Box
380 Volt/ 50 Hertz/ 3 Phase
Configuration Harness
Harness
Gas, Steam and Electric Models
55
Part No.
M413509
M413510
70083401
70083501
70053601
70083701
70083801
70084001
70120101
70083901
70120901
70121201
M413650
70083101
70083601
70120701
70120801
70139201
M413883
M413933
M413934
M414121
M413624
M413694
M413625
M413695
70138801
70138901
70139001
70139101
56
Description
415 Volt Transformer
Configuration Harness
480 Volt Transformer
Configuration Harness
1 Phase Fan Motor Harness
3 Phase Fan Motor Harness
1 Phase Cylinder Motor Harness
3 Phase Cylinder Motor Harness
Coin Vault Switch Harness
Bypass Jumper Assembly
From - To
Transformer Primary to Junction Box
Harness
Transformer Primary to Junction Box
Harness
Junction Box to Fan Motor
Junction Box to Fan Motor
Junction Box to Cylinder Motor
Junction Box to Cylinder Motor
Main Harness to Coin Vault Switch
Plugs into Main Harness- Eliminates Coin
Vault Circuitry
Emergency Stop Switch Harness Main Harness to Emergency Stop Switch
(2 Pole)
Emergency Stop Switch Harness Main Harness to Emergency Stop Switch
Jumper Disconnect Assembly
Disconnect Switch to Terminal Block
Used On
415 Volt/ 50 Hertz/ 3 Phase
Gas, Steam and Electric Models
480 Volt/ 60 Hertz/ 3 Phase
Gas, Steam and Electric Models
1 Phase Models
3 Phase Models
1 Phase Non-reversing Models
3 Phase Models
All Coin Models with EDC
All MT and OM Non–European
and all Cardreader models
All EU Manual Timer Models
All EU MT, OM and RM Models
All European Gas and Steam
Models
EU Door Switch Harness
All European Models
Gas Valve Harness
Gas Models
Control Tray Harness
Connects Control Tray to Interlock Harness All 0350S Reversing Models
Reversing Cylinder Motor
Junction Box to Fan Motor
All 1 Phase 0350S Reversing
Harness - 1 Phase
Models
Low Voltage Motor Configuration
100-120 Volt 0350S RM Models
Jumper
200-240 Volt 0350S RM Models
High Voltage Motor
Configuration Jumper
Light Blue Jumper Wire
All 1 Phase 0350S Reversing
Models
2 Wire Jumper Set Assembly
All 200-240 Volt Electric models
8 Gauge Jumper Wire (7.5)
200-240 Volt Non European
Electric Models;1 Phase (2
required)
3 Phase (3 required)
8 Gauge Jumper Wire (8.00)
380-415 Volt European Electric
Models; 1 Phase (1 Required)
3 Phase (3 Required)
8 Gauge Jumper Wire (6.75)
All Electric Models with 1 Phase
Motors
3 Phase Reversing Control
3 Phase 0350S Reversing
Jumper (Upper)
Models except 240 Volt or less
1 Phase Reversing Control
1 Phase 0350S Reversing
Jumper (Upper)
Models except 240 Volt or less
3 Phase Reversing Control
3 Phase 0350S Reversing
Jumper (Lower)
Models except 240 Volt or less
1 Phase Reversing Control
1 Phase 0350S Reversing
Jumper (Lower)
Models except 240 Volt or less
All 3 Phase Electric European
6 Gauge Single Wire Jumper
(8.00)
Models
2 Gauge Single Wire Jumper
All 230 Volt/ 50 Hertz/ 1 Phase
(7.5)
Electric European Models
8 Gauge Single Wire Jumper
All 200-240 Volt Electric Non
(10.00)
European Models 1 Phase (2
Required) 3 Phase (3 Required)
8 Gauge Single Wire Jumper
All 1 Phase Electric
(11.00)
Non-European Models
70185001
Parts Index
A
Acorn Nut for Door Strike
M400645 ................................................................. 21
Air Flow Switch
70068701 ................................................................ 29
Air Flow Vane
70068901 ................................................................ 29
Assembly, Coindrop
38462 (token) .......................................................... 50
38463 (token) .......................................................... 50
38464 (Canada) ...................................................... 50
38465 (Canada) ...................................................... 50
38467 (Australia)..................................................... 50
38469 (Belgium)...................................................... 50
38472 (England) ..................................................... 50
38475 ...................................................................... 50
38478 ...................................................................... 50
38479 (U.S.A.)......................................................... 50
38517 (Denmark) .................................................... 50
38518 (France)........................................................ 50
38519 (Japan) ......................................................... 50
38520 (Italy) ............................................................ 50
38521 (Korea) ......................................................... 50
38522 (New Zealand).............................................. 50
38963 (token) .......................................................... 50
38964 (Taiwan)........................................................ 50
39157 (Israel) .......................................................... 50
Assembly, Control Door with studs
70175903 .................................................................. 7
70175904 .................................................................. 7
70175905 ................................................................ 11
70175906 ................................................................ 11
70175907 .................................................................. 9
70175908 .................................................................. 9
Assembly, Door, Control with studs
70175901 .................................................................. 5
70175902 .................................................................. 5
Assembly, Dryer Control & Tape
M414049P................................................................. 5
Assembly, Fan
70123301 ................................................................ 27
Assembly, Front Plate with studs
70173801 ................................................................ 19
70173802 ................................................................ 19
Assembly, Lint Screen
70173201 ................................................................ 19
Assembly, Thermistor
M411758 ................................................................. 27
B
Baffle, Partition
70022001 ................................................................ 15
70022101 ................................................................ 15
70057101 ................................................................ 15
70198701 ................................................................ 17
70198801 .......................................................... 15, 17
70215302 ................................................................ 17
70215303 ................................................................ 17
70185001
Bearing
430038 ....................................................................23
Bearing Housing
70013901 ................................................................23
Belt
70053103 ................................................................25
Bolt
70062401 ................................................................25
BPT to NPT Adapter
70131901 ................................................................31
Bracket
70026901 ................................................................19
70179601 ................................................................25
70188301 ................................................................29
Bracket, Chassis Mounting
70119001 ..................................................................7
Bracket, Door Switch
70119301 ................................................................13
Bracket, Fuse Holder
70086301 ....................................................37, 39, 41
70086401 ....................................................37, 39, 41
70124101 ..........................................................43, 45
70124201 ....................................................43, 45, 47
Bracket, Idler Lock
70173701 ................................................................25
Bracket, Latch Mounting
70119101 ..............................................................5, 7
70119801 ..................................................................9
Bracket, Motor Mount
70127301 ................................................................25
Bracket, Temperature Control
70118901 ..................................................................9
70131301 ................................................................11
70179001 ..................................................................9
70179101 ................................................................11
Bracket, Temperature Switch
70108001 ............................................................9, 11
Burner Grill
70068601 ................................................................49
Burner Orifice
See Table Page 51
Buss Bar Assembly
M412756 .................................................................47
C
Card Reader Control
39685 ........................................................................7
Center Seal Clip
70014003 ................................................................17
Channel, Motor
70179501 ................................................................25
Circuit Breaker
M412406 .................................................................47
M412407 .................................................................47
Clip
27222 ......................................................................25
70030401 ................................................................15
70030501 ................................................................17
Clips for Retaining Trim Pieces
M4009712 ...............................................................13
57
Close Nipple
431486 .................................................................... 31
Coin Vault
70180101 ................................................................ 17
Coindrop
Also see Table Page 50
Coinmeter
M412542 (England) ................................................ 50
M412543 (France)................................................... 50
M412544 (Denmark) ............................................... 50
M412545 ( Belgium)................................................ 50
M412546 (Standard) ............................................... 50
M412547 (Standard) ............................................... 50
M413195 (France)................................................... 50
70112401 (Australia)............................................... 50
70112501 (Australia)............................................... 50
70112701 (U.S.A.)................................................... 50
70137301 (Standard) .............................................. 50
70137401 ( Standard) ............................................. 50
70138401 (U.S.A.)................................................... 50
70151301 (South Africa) ......................................... 50
Contactor
M413614 ............................................... 37, 39, 43, 45
Control Housing
70119901 ................................................................ 13
Cover
70112801 ................................................................ 27
70202501 ................................................................ 25
Cover, Air Flow Switch
70188201 ................................................................ 29
Cover, Gas Valve
70071501 ................................................................ 49
70133401 ................................................................ 49
70210101 ................................................................ 49
Cylinder Assembly
70175101 ................................................................ 23
70175102 ................................................................ 23
Cylinder Assembly with Channel (Perforated Rib)
70227301 ................................................................ 23
Cylinder Assembly, with Channel (Perforated Ribs)
70027302 ................................................................ 23
Cylinder Motor
70062801 ................................................................ 53
70062901 ................................................................ 53
70168301 ................................................................ 53
70171601 ................................................................ 53
70185801 ................................................................ 53
Cylinder Seal
70066001 ................................................................ 17
Door Catch
M401223 .................................................................13
Door Glass
M400784P ...............................................................21
70133601P ..............................................................21
Door Glass Seal
70211901 ................................................................21
Door Handle
M400133 .................................................................21
430117 ....................................................................21
70024801 ................................................................21
70133501 ................................................................21
Door Hinge
70115901* ...............................................................21
70115902 ................................................................21
Door Rim Gasket
70211601 ................................................................21
Door Strike Screw
M400661 .................................................................21
Door Switch
70107001 ................................................................13
70125101 ................................................................13
Door Switch Actuator
70215001P ..............................................................21
Dual Drop Multiplier Kit
38571 ........................................................................5
E
Elbow, 90 Degree
70079601 ................................................................31
Electronic Coin Control
M4721P3 ...................................................................5
M4722P3 ...................................................................5
Electronic Coin Control Kit
M4691P3 ...................................................................5
M4692P3 ...................................................................5
Electronic Control
M414049P .................................................................7
End Cap–Cylinder Baffle
70070101 ................................................................23
End Cover
70121101 ..........................................................43, 45
End Stop
70121001 ..........................................................43, 45
Exhaust Damper
70056201 ................................................................27
Exhaust Thimble
70017801 ................................................................27
D
Din Rail
M412692 ................................................................. 47
70144401 .......................................................... 43, 45
70172301 ................................................................ 47
Disconnect Switch
M412186 ................................................................. 47
M412187 ........................................................... 43, 45
Door Assembly Complete
70176501 ................................................................ 21
70176502 ................................................................ 21
70176503 ................................................................ 21
70176504 ................................................................ 21
58
F
Fan Contactor
M413614 ...........................................................41, 47
Fan Motor
Also See Table Page 114
70020201 ................................................................53
70069501 ................................................................53
70070001 ................................................................53
70185901 ................................................................53
Felt Seal
70193801 ................................................................23
70185001
Flex Gas Line
70112901 ................................................................ 31
Front Panel Assembly
70176001*............................................................... 54
70176002 ................................................................ 54
70176003*............................................................... 54
70176004 ................................................................ 54
70176101*............................................................... 54
70176102 ................................................................ 54
70176103*............................................................... 54
70176104 ................................................................ 54
70176105*............................................................... 54
70176106 ................................................................ 54
70176107*............................................................... 54
71076108 ................................................................ 54
Fuse
M413118 ..................................................... 37, 39, 41
M413621 ................................... 37, 39, 41, 43, 45, 47
M413867 ........................................................... 43, 45
M413889 ..................................................... 43, 45, 47
M414232 ..................................................... 37, 39, 41
M414240 ........................................................... 37, 39
Fuse Access Cover
70126601 .......................................................... 37, 39
Fuse Holder
M413544 ................................... 37, 39, 41, 43, 45, 47
502591 ........................................................ 43, 45, 47
91024 .......................................................... 37, 39, 41
G
Gas Burner
70184801 ................................................................ 29
Gas Burner Orifice
M401000 ................................................................. 52
M401002 ................................................................. 52
M401011 ................................................................. 52
M401014 ................................................................. 52
M401024 ................................................................. 52
M402980 ................................................................. 52
M402995 ................................................................. 52
M402996 ................................................................. 52
M403017 ................................................................. 52
M406184 ................................................................. 52
M406361 ................................................................. 52
M411373 ................................................................. 52
M411374 ................................................................. 52
M411375 ................................................................. 52
M411376 ................................................................. 52
M411511 ................................................................. 52
70070902 ................................................................ 52
Gas Valve Coil
70186701 ................................................................ 31
Gas Valve–Regulated
M4733P3................................................................. 31
Gas Valve–Unregulated
M4734P3................................................................. 31
Gasket
M412118 ................................................................. 47
Gasket, Baffle
70015701 .......................................................... 15, 17
70015702 .......................................................... 15, 17
70198801 ................................................................ 17
Gasket, Lint Drawer
70117901 ................................................................ 13
70185001
Gasket, Lint Frame
70109201 ................................................................19
Grill
70214901 ................................................................33
H
Handle
M412207 .................................................................47
M412208 ...........................................................43, 45
Heater Contactor
M413616 ...........................................................41, 47
Heater Element
70034401 ................................................................33
70034402 ................................................................33
70034403 ................................................................33
High Voltage Lead
70006201 ................................................................43
Hinge Bushing
70071101 ................................................................21
Hinge Cam
70174801 ................................................................21
Hinge Lug
70174701 ................................................................21
Hinge Pin
70071401 ................................................................21
I
Idler Arm
70059201 ................................................................25
Idler Roller
70050401 ................................................................25
Ignition Cable
70006201 ................................................................37
Ignition Control
M413433 ...........................................................37, 43
M413532 .................................................................37
Insulator
M413862 .................................................................39
M413863 .................................................................37
Interlock Assembly
M412368 .....................................................43, 45, 47
J
Jamnut
M400022 ...........................................................23, 27
Jumper Bar
M400869 .................................................................33
K
Key
70144101 ................................................................27
70155602 ................................................................19
Key for Lock
70155601 ................................................................13
Kickplate
70117605 ................................................................13
59
70117606 ................................................................ 13
Kit, Coin Chute and Plate
70216201P.............................................................. 17
Knob, Emergency Stop
M412232 ................................................................. 13
L
Label, Yellow for Emergency Stop
M412235 ................................................................. 13
Latch Mounting
70119801 ................................................................ 11
Latch, Control Door
431318 ...................................................................... 7
Latch, Door–control
431318 ...................................................................... 5
Leveling Leg
34319 ................................................................ 17, 27
Lighted Push Button Switch
M413431 ................................................................. 37
Light, Heat & Cooling
70082201 ................................................................ 11
Lock
70155502 ................................................................ 19
Lock, Control Door
70155501 ................................................................ 13
L. P. Gas Kit
M4707P3................................................................. 52
M4708P3................................................................. 52
M4709P3................................................................. 52
M4710P3................................................................. 52
M
Manual Timer Control
M4694P3................................................................. 11
M4724P3................................................................. 11
Motor
See Table Page 114
Motor Pulley
70189101 ................................................................ 25
70189103 ................................................................ 25
Motor Relay
70210901 .......................................................... 37, 39
Mounting Bracket, Card Reader
M414120 ................................................................... 7
O
O Ring
431482 ....................................................................31
Overlay, Card Reader
70115701 ..................................................................7
70136201 ..................................................................7
Overlay, Coin Drop
70115501 ..................................................................9
70128201 ..................................................................9
70136801 ..................................................................9
Overlay, Dual Coindrop
70129601 ..................................................................5
70129801 ..................................................................5
Overlay, EC
70113601 ..................................................................5
70113901 ..................................................................5
70129301 ..................................................................5
70129401 ..................................................................5
70135501 ..................................................................5
70135701 ..................................................................5
70136101 ..................................................................5
Overlay, Lower Lint Drawer
70115201 ................................................................19
70115301 ................................................................19
70136401 ................................................................19
70136601 ................................................................19
Overlay, Manual Timer
70114401 ................................................................11
70128101 ................................................................11
70129901 ................................................................11
70130001 ................................................................11
70135401 ................................................................11
70135601 ................................................................11
Overlay, Single Coindrop
70129501 ..................................................................5
70129701 ..................................................................5
Overlay, Upper Lint Drawer
70114701 ................................................................19
70115101 ................................................................19
70136401 ................................................................19
70136501 ................................................................19
Overlay, Yoke
70114601 ................................................................13
70137001 ................................................................13
P
Palnut
N
Nut
M412986 ........................................................... 23, 25
Q6163 ..................................................................... 33
21899 ................................................................ 17, 27
29786 ...................................................................... 19
430576 .............................................................. 15, 17
52566 ...................................................................... 25
70054 .................................................... 5, 7, 9, 11, 21
70072901 ................................................................ 13
60
M400034 ...........................................................23, 27
Pipe Nipple
70139601 ................................................................31
Pipe Tee
70071801 ................................................................31
Plate
70051201 ................................................................19
Pop Rivet
M400003 .................................................................13
Power Distribution Block
M413865 .................................................................41
70185001
R
Rear Cylinder Seal
70013701 ................................................................ 23
Relay
M412534 ............................................................. 9, 11
Rivets
70058501 ................................................................ 17
70058502 ................................................................ 17
70058561 ................................................................ 15
Roller
70052601 .......................................................... 15, 17
Roller Shaft
70017701 .......................................................... 15, 17
Roller Support Bracket
7055001 .................................................................. 17
Rotary Coin Meter Control Kit
M4693P3................................................................... 9
M4723P3................................................................... 9
Rotary Coindrop
Refer to Table on page 52
Run Light
70082201 .................................................................. 9
S
Screw
M401902 ........................................................... 37, 39
M401938 ........................................................... 13, 29
M402797 ................................................. 9, 11, 29, 33
M405824 ..................................................... 37, 39, 43
M411052 ................................................................. 11
M411097 ................................................................. 13
05161 ...................................................................... 29
20852 ...................................................................... 19
32671 ...................................................................... 41
33562 .......................................................... 43, 45, 47
430497 ...................... 7, 27, 29, 31, 33, 43, 45, 47, 49
430648 .................................................................... 25
431539 .................................................................... 25
501524 ............................................................ 5, 7, 21
51780 ................................................................ 37, 39
61199 ...................................................................... 21
62588 ...................................................................... 23
70033502 ................................................................ 13
70069901 ................................................................ 13
70113001 ................................................................ 21
70126101 ................................................................ 27
70132301 ................................................................ 13
Screw for Contactor
51780 .......................................................... 37, 39, 41
Screw for Relay
51778 ................................................................ 37, 39
Screw, Internal Hex
70033502 ................................................................ 21
Screw, Socket Head
431484 .................................................................... 31
Shroud, Rotary Coindrop
70061701 .................................................................. 9
Shutoff Valve
M412562 ................................................................. 31
Side Panel
70056601*L....................................................... 15, 17
70185001
Spark Electrode
70032801 ................................................................29
Spring
70045301 ................................................................25
Spud Adapter
70034201 ................................................................31
Stabilizer Bracket
70200301 ................................................................27
Start Switch
70108501 ............................................................9, 11
Steam Coil
70035801 ................................................................35
70035901 ................................................................35
Steam Solenoid Valve
M413445 .................................................................35
70205601 ................................................................35
Steam Valve Solenoid
M412258 .................................................................35
70205701 ................................................................35
Stove Back
70183001 ................................................................49
Stove Top & Sides
70194601 ................................................................49
Stud Plate
430352 ....................................................................23
Support, Temperature Control
34896 ..................................................................9, 11
Switch, Emergency Stop
70116701 ................................................................13
Switch, Lint Drawer
431159 ..............................................................15, 17
Switch, Push Button
70107001 ..................................................................5
T
Tab
70179701 ................................................................25
Temperature Control Board
431347P ..............................................................9, 11
Temperature Knob
431357 ................................................................9, 11
70080601 ............................................................9, 11
Temperature Switch
431353 ................................................................9, 11
Terminal Block
M412045 .................................................................47
430640 ....................................................................37
430642 ....................................................................39
70120001 ..........................................................43, 45
Thermal Shield
70036601 ..........................................................15, 17
Thermostat, High Limit
M409443 .................................................................35
M410220 .................................................................33
Thermostat, High–Limit
M411307 .................................................................27
70186401 ................................................................27
Thermostat, Stove Limit
M409219 .................................................................29
70186301 ................................................................29
Time Delay Circuit Board
70175301 ............................................................9, 11
61
Timer Knob
M410927 ................................................................. 11
70082101 ................................................................ 11
Timer Motor
70218201 ................................................................ 51
70218301 ................................................................ 51
Timer, Cooling
70131801 ................................................................ 11
Timer, Heat
70131701 ................................................................ 11
Transformer
M414228 ......................................... 37, 39, 41, 43, 45
M414229 ................................... 37, 39, 41, 43, 45, 47
M414230 ..................................................... 37, 39, 41
Trim, Coin Vault
70117501 ................................................................ 13
70117502 ................................................................ 13
70117503 ................................................................ 13
Trim, Control
70116901 ................................................................ 13
70116902 ................................................................ 13
70117001 ................................................................ 13
70120501 ................................................................ 13
Trunnion Assembly
70189301 ................................................................ 23
Twin Speed Nut
M400979 ................................................................. 29
U
Union
H86000031 ............................................................. 31
W
70067001 ................................................................55
70082501 ................................................................55
70082601 ................................................................55
70082701 ................................................................55
70082801 ................................................................55
70082901 ................................................................55
70083001 ................................................................55
70083101 ................................................................56
70083201 ................................................................55
70083301 ................................................................55
70083401 ................................................................56
70083501 ................................................................56
70083601 ................................................................56
70083701 ................................................................56
70083801 ................................................................56
70083901 ................................................................56
70084001 ................................................................56
70084101 ................................................................55
70084102 ................................................................55
70084201 ................................................................55
70084202 ................................................................55
70084301 ................................................................55
70084302 ................................................................55
70084303 ................................................................55
70113101 ................................................................55
70120101 ................................................................56
70120201 ................................................................55
70120701 ................................................................56
70120801 ................................................................56
70120901 ................................................................56
70121201 ................................................................56
70138601 ................................................................55
70138701 ................................................................55
70138801 ................................................................56
70138901 ................................................................56
70139001 ................................................................56
70139101 ................................................................56
70139201 ................................................................56
70139401 ................................................................55
70142501 ................................................................55
Washer
H88510516 ............................................................. 13
M400991 ................................................................. 23
430782 .................................................................... 25
70017401 ................................................................ 27
Washer for Coindrop Mounting
M405535 ................................................................... 9
Wire Harness
M413504 ................................................................. 55
M413505 ................................................................. 55
M413506 ................................................................. 55
M413507 ................................................................. 55
M413508 ................................................................. 55
M413509 ................................................................. 56
M413510 ................................................................. 56
M413624 ................................................................. 56
M413625 ................................................................. 56
M413650 ................................................................. 56
M413694 ................................................................. 56
M413695 ................................................................. 56
M413883 ................................................................. 56
M413933 ................................................................. 56
M413934 ................................................................. 56
M413997 ................................................................. 55
M414121 ................................................................. 56
431611 .................................................................... 55
431613 .................................................................... 55
70053601 ................................................................ 56
70055801 ................................................................ 55
70055901 ................................................................ 55
62
70185001
Download PDF
Similar pages