HCD-LV80
SERVICE MANUAL
E Model
HCD-LV80 is the tuner, deck, CD and
amplifier section in LBT-LV80.
CD
SECTION
TAPE DECK
SECTION
Model Name Using Similar Mechanism
HCD-VR50/VR70
CD Mechanism Type
CDM37L-5BD34L
Base Unit Type
BU-5BD34L
Optical Pick-up Type
KSS-213D/Q-NP
Model Name Using Similar Mechanism
NEW
Tape Transport Mechanism Type
TCM-230PWR12
SPECIFICATIONS
Amplifier section
The following measured at AC 120/220/240 V,
50/60 Hz
DIN power output (Rated)
240 + 240 watts
(4 ohms at 1 kHz, DIN)
Continuous RMS power output (Reference)
300 + 300 watts
(4 ohms at 1 kHz, 10 %
THD)
Inputs
PHONO IN (phono jacks): sensitivity 3 mV,
impedance 47 kilohms
MIC 1/2 (phono jack):
sensitivity 1 mV,
impedance 10 kilohms
VIDEO 1 IN (phono jacks):sensitivity 250 mV,
impedance 47 kilohms
VIDEO 2 IN (phono jacks):sensitivity 250 mV,
impedance 47 kilohms
MD IN (phono jacks):
sensitivity 450 mV,
impedance 47 kilohms
FRONT SPEAKER :
accepts impedance of 4 to
16 ohms
Video section
Inputs
VIDEO1 IN (phono jacks): 1 V p-p, 75 ohms
VIDEO2 IN (phono jacks): 1 V p-p, 75 ohms
Outputs
VIDEO OUT (phono jack): 1 V p-p, 75 ohms
S-VIDEO OUT (4-pin/mini-DIN jack):
Y: 1 V p-p, unbalanced,
Sync negative,
C: 0.286 V p-p,
load impedance 75 ohms
VIDEO CD/CD player section
System
Laser
Laser output
Outputs
PHONES (stereo phone jack):
accepts headphones of
8 ohms or more
VIDEO OUT (phono jack): voltage 250 mV,
impedance 1 kilohm
MD OUT (phono jacks): voltage 250 mV,
impedance 1 kilohm
Wavelength
Frequency Response
Compact disc, digital
audio and video system
Semiconductor laser
(λ = 780 ohm), Emission
duration : continuous
Max. 44.6 µW*
* This output is the value
measured at a distance of
200 mm from the
objective lens surface on
the Optical Pick-up Block
with 7 mm aperture.
780 - 790 nm
2 Hz - 20 kHz (±0.5 dB)
Signal-to-noise ratio
More than 90 dB
Dynamic range
More than 90 dB
CD DIGITAL OUT
(square optical connector jack, rear panel)
Video color system format
NTSC, PAL
Wave length:
660 nm
Output level:
–18 dBm
Tape player section
Recording system
4-track 2-channel stereo
Frequency Response (DOLBY NR OFF)
40 - 13,000 Hz (±3 dB),
using a Sony TYPE I
cassette
40 - 14,000 Hz (±3 dB),
using a Sony TYPE II
cassette
— Continued on next page —
COMPACT Hi-Fi STEREO SYSTEM
1
Tuner section
FM Stereo, FM/AM superheterodyne tuner
FM tuner section
Tuning range
Antenna:
Antenna terminals
Intermediate frequency
87.5 - 108.0 MHz (50 kHz
step)
FM Wire antenna
75 ohm unbalanced
10.7 MHz
AM tuner section
Tuning range
Middle Eastern models:
Other models:
Antenna
Intermediate frequency
531 - 1,602 kHz (with the
tuning interval set at
9 kHz)
531 - 1,602 kHz (with the
tuning interval set at
9 kHz)
530 - 1,701 kHz (with the
tuning interval set at
10 kHz)
AM loop antenna,
External antenna
terminals
450 kHz
General
Power Requirements
120 V, 220 V, or 230 - 240
V AC, 50/60 Hz
Adjustable with voltage
selector
Power Consumption
300 watts
Dimensions(w/h/d)
Approx. 356 × 423 × 446
incl. projecting parts and
controls
Mass
Approx. 15.9 kg
Supplied Accessories
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation exposure.
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be
damaged by heat.
Flexible Circuit Board Repairing
• Keep the temperature of soldering iron around 270˚C
during repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
Laser component in this product is capable of emitting radiation
exceeding the limit for Class 1.
This appliance is classified as
a CLASS 1 LASER product.
The CLASS 1 LASER PRODUCT MARKING is located on
the rear exterior.
This caution
label is located
inside the unit.
AM loop antenna (1)
FM wire antenna (1)
Speaker cords (2)
Remote (1)
R6(size AA) batteries (2)
Video connecting cable
(1)
Design and specifications are subject to change
without notice.
SAFETY-RELATED COMPONENT WARNING !!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS
WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS
MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
2
MODEL IDENTIFICATION
— BACK PANEL —
Parts No.
MODEL
MY, SP model
EA model
PARTS No.
4-227-751-2s
4-227-751-3s
• Abbreviation
SP
: Singapore model
EA : Saudi Arabia model
MY : Malaysia model
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
break-down because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
LASER DIODE AND FOCUS SEARCH OPERATION
CHECK
Carry out the “S curve check” in “CD section adjustment” and check
that the S curve waveform is output four times.
3
TABLE OF CONTENTS
1. SERVICING NOTE .......................................................... 5
2. GENERAL .................................................................... 9
3. DISASSEMBLY
3-1. Front Panel and Video Board .............................................. 11
3-2. Main Board ......................................................................... 11
3-3. Sub Panel ............................................................................ 12
3-4. CD LID Assembly .............................................................. 12
3-5. Tape Mechanism Deck and Cassette LID ........................... 12
3-6. CD Mechanism Deck .......................................................... 13
3-7. Base Unit ............................................................................. 13
3-8. Disc Table ........................................................................... 13
4. TEST MODE .............................................................. 14
5. MECHANICAL ADJUSTMENTS .......................... 15
6. ELECTRICAL ADJUSTMENTS ............................... 15
7. DIAGRAMS
7-1. Circuit Boards Location ...................................................... 19
7-2. Block Diagrams
• BD Section ....................................................................... 20
• Deck Section .................................................................... 21
• Main (1/2) Section ........................................................... 22
• Main (2/2) Section ........................................................... 23
• Video Section ................................................................... 24
• Power Section .................................................................. 25
• Display Section ................................................................ 26
7-3. Printed Wiring Board – BD Section – ................................. 28
7-4. Schematic Diagram – BD Section – ................................... 29
7-5. Schematic Diagram – Deck Section – ................................. 30
7-6. Printed Wiring Board – Deck Section – .............................. 31
7-7. Printed Wiring Board – Video Section – ............................. 32
7-8. Schematic Diagram – Video (1/3) Section – ....................... 33
7-9. Schematic Diagram – Video (2/3) Section – ....................... 34
7-10. Schematic Diagram – Video (3/3) Section – ..................... 35
7-11. Printed Wiring Board – Main Section – ............................ 36
7-12. Schematic Diagram – Main (1/3) Section – ...................... 37
7-13. Schematic Diagram – Main (2/3) Section – ...................... 38
7-14. Schematic Diagram – Main (3/3) Section – ...................... 39
7-15. Printed Wiring Board – Power Section – ......................... 40
7-16. Schematic Diagram – Power Section – ............................ 41
7-17. Printed Wiring Board – Panel FL Section – ..................... 42
7-18. Schematic Diagram – Panel FL Section – ........................ 43
7-19. Printed Wiring Board – Panel VR Section – .................... 44
7-20. Schematic Diagram – Panel VR Section – ....................... 45
7-21. Printed Wiring Board – TC Panel Section – ..................... 46
7-22. Schematic Diagram – TC Panel Section – ....................... 47
7-23. Printed Wiring Board – CD Panel Section – .................... 48
7-24. Schematic Diagram – CD Panel Section – ....................... 49
7-25. Printed Wiring Board – CD Motor Section – ................... 50
7-26. Schematic Diagram – CD Motor Section – ...................... 51
7-27. Schematic Diagram – Trans Section – ............................. 52
7-28. Printed Wiring Board – Trans Section – ........................... 53
7-29. Schematic Diagram – Leaf SW Section – ........................ 53
7-30. Printed Wiring Board – Leaf SW Section – ..................... 53
7-31. IC Block Diagrams ........................................................... 54
7-32. IC Pin Functions ............................................................... 56
4
8. EXPLODED VIEWS
8-1. Case and Back Panel Section .............................................. 66
8-2. Front Panel Section 1 .......................................................... 67
8-3. Front Panel Section 2 .......................................................... 68
8-4. Chassis Section ................................................................... 69
8-5. TC Mechanism Section 1 (TCM230PWR12) ..................... 70
8-6. TC Mechanism Section 2 (TCM230PWR12) ..................... 71
8-7. CD Mechanism Section (CDM37L-5BD34L) .................... 72
8-8. Base Unit Section (BU-5BD34L) ....................................... 73
9. ELECTRICAL PARTS LIST ........................................ 74
SECTION 1
SERVICING NOTE
About CD-TEXT display
This unit is provided with a simple CD-TEXT display function.
The CD-TEXT contents of 20 tracks are displayed on the fluorescent display tube.
Since the function is simple, some special characters may not be displayed, or may be displayed as other characters.
MC Cold Reset
• The cold reset clears all data including preset data stored in the RAM to initial conditions. Execute this mode when returning the set to the
customer.
Procedure:
1. Press three buttons c/CLOCK SET , ENTER , and "/1 simultaneously.
2. “COLD RESET” is displayed on the fluorescent display tube and reset is executed.
CD Delivery Mode
• This mode moves the pick-up to the position durable to vibration. Use this mode when returning the set to the customer after repair.
Procedure:
1. Press "/1 button to turn the set ON.
2. Press LOOP button and "/1 button simultaneously.
3. A message “LOCK” is displayed on the fluorescent indicator tube, and the CD delivery mode is set.
MC Hot Reset
• This mode resets the set with the preset data kept stored in the memory. The hot reset mode functions same as if the power cord is plugged
in and out.
Procedure:
1. Press three buttons c/CLOCK SET , ENTER , and DISC 1 simultaneously.
2. The fluorescent indicator tube becomes blank instantaneously, and the set is reset.
Sled Servo Mode
• This mode can run the CD sled motor freely. Use this mode, for instance, when cleaning the pick-up.
Procedure:
1. Press "/1 button to turn the set ON.
2. Press three buttons c/CLOCK SET , ENTER , and DISC 5 simultaneously.
3. The Sled Servo mode is selected, if “CD” is blanking on the fluorescent indicator tube.
4. With the CD in stop status, When the M button is pressed, the optical pick-up moves outside. When m button is pressed, it moves
inside.
5. To exit from this mode, perform as follows:
1) Move the pick-up to the most inside track.
2) Execute MC cold reset. (Press the three buttons c/CLOCK SET , ENTER , and "/1 button simultaneously.)
Note:
• Always move the pick-up to most inside track when exiting from this mode. Otherwise, a disc will not be unloaded.
• Do not run the sled motor excessively, otherwise the gear can be chipped.
Change-over of AM Tuner Step between 9kHz and 10kHz
• A step of AM channels can be changed over between 9kHz and 10kHz.
Procedure:
1. Press "/1 button to turn the set ON.
2. Select the function “TUNER”, and press TUNER/BAND button to select the BAND “AM”.
3. Press "/1 button to turn the set OFF.
4. Press ENTER and "/1 buttons simultaneously, and the display of fluorescent indicator tube changes to “AM 9k STEP” or “AM 10k
STEP”, and thus the channel step is changed over.
LED and Fluorescent Indicator Tube All Lit, Key Check Mode
Procedure:
1. Press three buttons c/CLOCK SET , ENTER , and DISC 2 simultaneously.
2. LEDs and fluorescent indicator tube are all turned on.
Press DISC 2 button, and the key check mode is activated.
3. In the key check mode, the fluorescent indicator tube displays “K @ V0 J0”. Each time a button is pressed, “K”value increases. However,
once a button is pressed, it is no longer taken into account.
“J” Value increases like 1, 2, 3 ... if rotating . AMS > knob in “+” direction, or it decreases like 0, 9, 8 ... if rotating in “-”
direction.
“V” Value increases like 1, 2, 3 ... if rotating VOLUME knob in “+” direction, or it decreases like 0, 9, 8 ... if rotating in “-” direction.
4. To exit from this mode, press three buttons in the same manner as step 1, or disconnect the power cord.
5
AMS Test Mode
• This mode is used for checking the AMS operations of the tape deck.
JIG
7-819-039-12 Alignment tape, AMS-110A
Procedure:
1. Press the "/1 button to turn the set ON.
2. Set the tape (AMS-110A).
3. Press the three buttons c/CLOCK SET , ENTER , and DISC 3 button simultaneously.
4. “TEST MODE” is displayed on the fluorescent display tube.
5. Press the FUNCTION button and switch the function to the deck with the tape (AMS-110A).
6. Press the CD SYNC button. “AMS CHECK” is displayed on the fluorescent display tube and the tape is rewound.
7. AMS starts in the normal direction. If the AMS count is 2 at shut down, proceed to step 8.
“NG” is displayed at other times, and the deck stops.
8. AMS starts in the opposite direction. If the AMS count is 2 at shut down again, “OK” is displayed.
“NG” is displayed at other times.
Aging Mode
During the aging mode, both the CD player and tape deck are executed together.
• If an error occurs:
Aging stops, and the error state is displayed on the fluorescent display tube.
• If no error occurs:
Aging is repeated.
Procedure:
1. Press the "/1 button to turn the set ON.
2. Load 10 minute tapes with unbent rec-proof tabs in decks A and B.
3. Set CDs on the DISC 1 and DISC 4 tables.
4. Set the CD mode REPEAT to OFF and PLAY MODE to ALL DISCS.
(Press the PLAY MODE and REPEAT buttons to set these modes.)
5. Press the FUNCTION button to switch the function to “CD”.
6. Press the three buttons c/CLOCK SET , ENTER , and DISC 4 button simultaneously.
7. Aging starts.
8. To end aging, press the "/1 button to turn the set OFF.
Aging Sequence:
Aging is performed in the following sequence.
• Tape Deck
1. The tape in deck A is rewound. “TAPE A AG-1” is displayed.
2. The FWD side of deck A is played for two minutes.
“TAPE A AG-2” is displayed.
3. The tape in deck A is fast forwarded. “TAPE A AG-3” is displayed. Fast forward is carried out for 20 seconds or to the tape end.
4. The RVS side of deck A is played for two minutes.
“TAPE A AG-4” is displayed.
5. The tape in deck A is rewound. “TAPE A AG-5” is displayed.
6. The FWD side of deck B is played for two minutes.
“TAPE B AG-2” is displayed.
7. The tape in deck B is fast forwarded. “TAPE B AG-3” is displayed. Fast forward is carried out for 20 seconds or to the tape end.
8. The RVS side of deck B is played for two minutes.
“TAPE B AG-4” is displayed.
9. The tape in deck A is rewound. “TAPE A AG-5” is displayed.
10. Repeated from step 2.
6
• CD
1. The tray rotates.
2. DISC 1 is chucked.
3. The TOC is read.
4. The first track is played for 2 seconds.
5. The last track is played for 2 seconds.
6. The tray rotates.
7. DISC 4 is chucked.
8. The TOC is read.
9. The first track is played for 2 seconds.
10. The last track is played for 2 seconds.
11. Repeated from step 1.
• Display when ended abnormally
When the tape deck is abnormal:
The state when ended abnormally is displayed.
The contents of display are the same as that during aging.
When the CD player is abnormal:
A message indicating that errors such as “CD MEC ERR” have occurred.
Check the error contents in the following error history display mode.
Error History Display Mode
Mode which enables the history of error occurring in the CD player to be checked.
Execute this mode after ending the aging mode.
Procedure:
1. Press the "/1 button to turn the set ON.
2. Press the three buttons c/CLOCK SET , ENTER , and CD SYNC simultaneously.
3. A message such as “EMC@@EDC**” is displayed.
@@ : Number of mechanical errors (Up to three past errors)
** : Number of errors (NO DISC ERROR) which occurs after chucking (Up to three past errors)
4. When checking the history of mechanical errors, press the PLAY MODE button. When checking errors after chucking, press the
REPEAT button to switch the display.
5. Press the "/1 button to end and turn the set OFF.
6. To erase the error history, perform COLD reset.
(Press the three buttons c/CLOCK SET , ENTER , and DISC 1 simultaneously.
• Viewing the mechanical error history display
(Switch the history by pressing the PLAY MODE button.)
7
Display
E@@M#*****
@@ : Error number. 00 is the newest.
#
: Operating state of table
0
7
8
A
B
: Currently in the INITIAL mode
: Currently rotating to the right
: Currently rotating to the left
: Currently chucking down
: Currently chucking up
*
: Invalid
• Viewing the NO DISC ERROR history display
(Switch the history by pressing the REPEAT button.)
Display
E@@D##$$%*
@@ : Error number. 00 is the newest
##
: Error contents
01: Focus error
02: GFS error
03: Setup error
$$
: Retries
00: NO DISC is determined without attempting chucking retry
02: NO DISC is determined after chucking retry.
%
1
2
3
4
5
6
7
8
*
: State when determined as NO DISC
: When stopped
: At setup
: At TOC READ
: When accessing
: When playing
: When pausing
: When manual searching (during play)
: When manual searching (during pausing)
: Invalid
SELF-DIAGNOSIS
This model has the self-diagnosis function for the VIDEO and AUDIO decoder sections.
Immediately after the power on, the self-diagnosis function searches each operation of IC’s around the mechanism control microcomputer
(IC701).
The results can be checked by D502 of the VIDEO board.
Oscilloscope (Waveform)
Symptom
H
[VIDEO BOARD] (SIDE A)
D502
No error
L
Light
100
91
1
90
H
IC505
MPEG decoder (IC505)
error
L
2 time blinking
H
L
3 time blinking
8
MPEG decoder (IC505)
or
DRAM (IC507) error
32
65
33
64
SECTION 2
GENERAL
Front Panel
1
2 3
4
5
6
7
8
9
10 11 12 13
14
15
16
17
74
18
75
73
72
71
70
19
69
20
68
67
64
60
65
66
63
61 62
58
21
59
56
22
23
24 25
57
26
53 54 55
51 52
27 28
29 30
31 32
33
34
50
35
49
48
47
36
37
38
39
46 45 44 43 42
80 79 41 40
76
77
78
9
LOCATION OF PARTS AND CONTROLS
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
"/1 (Power) button and indicator
c/CLOCK SET button
SLEEP button
REC button and indicator
DAILY button and indicator
TUNING - button
TUNING + button
Display window
ENTER/NEXT button and indicator
TUNER MEMORY button
STEREO/MONO button
TUNING MODE button
GEQ control button
Remote sensor
SYNC EQ button
SYNC BASS button
SURROUND button and indicator
KARAOKE PON button
FUNCTION button
VOLUME knob
Z (A Deck) button
Z (B Deck) button
PHONES jack
h (B Deck) button and indicator
H (B Deck) button and indicator
x (B Deck) button
m (B Deck) button
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
M (B Deck) button
X (B Deck) button and indicator
z REC (B Deck) button and indicator
H SPEED DUB button
CD SYNC button
. AMS > knob
HX (CD) button and indicator
x (CD) button
m (CD) button
M (CD) button
DISK SKIP button
VIDEO2 INPUT jacks
REPEAT button
PLAY MODE button
DISC 1 button
DISC 2 button
DISC 3 button
DISC 4 button
DISC 5 button
EDIT button
NON-STOP button and indicator
FLASH button
LOOP button
DIRECTION button
DOLBY NR button
x (A Deck) button
m (A Deck) button
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
M (A Deck) button
h (A Deck) button
H (A Deck) button
MIX MIC jack
GUITAR jack
MIC LEVEL knob
GUITAR LEVEL knob
SUPER WOOFER MODE button
SUPER WOOFER button and indicator
FILE MENU button
GEQ CTRL button
ENTER button and indicator
GROOVE button and indicator
Equalizer indicators
EFFECT button and indicator
TUNER/BAND button
SPECTRUM ANALYZER button
DISPLAY button
DEMO (STANDBY) button
KEY CONTROL # button
KEY CONTROL 2 button
RETURN button
PREV button
NEXT button
SELECT button
ACTIVE button
• AMS is the abbreviation for Automatic
Music Sensor.
10
The clock starts.
Press ENTER/NEXT.
5
Press TUNING +/ – to set the
minute.
4
Press ENTER/NEXT.
3
The minute indication flashes.
Press TUNING +/ – to set the hour.
2
The hour indication flashes.
Press c/CLOCK SET.
1
1 2,4 3,5
Note
The clock setting is canceled when you disconnect
the power cord or if a power failure occurs.
Press c/CLOCK SET.
Press TUNING +/ – to select SET CLOCK.
Press ENTER/NEXT.
Perform steps 2 through 5 in the previous
explanation.
1
2
3
4
The previous explanation shows you how to set the
time while the power is off. To change the time
while the power is on, do the following:
You must set the time before using the timer
functions.
To change the time
If you make a mistake, start over from step 1.
Step 2: Setting the
time
Tip
7
This section is extracted from
instruction manual.
SECTION 3
DISASSEMBLY
Note: Follow the disassembly procedure in the numerical order given.
3-1. FRONT PANEL AND VIDEO BOARD
9Connector(CN452)
0Connector(CN702)
8Flat type wire(CN303)
7Flat type wire(CN304)
4Screw(BVTP3x8)
6Flat type wire
(CN431)
1Screw(BVTP3x8)
5Two earth wirs
2Earth wire
qf Screw (BVTP 3x8)
wa Bracket (VCD)
w; Connector (CN301)
qdFront panel
qj Video board
3Connector
(CN802)
qh Screw
(BVTP 3x8)
qaScrew(BVTP3x8) qg Screw
(BVTP 3x8)
qsFour screws(BVTP3x8)
3-2. MAIN BOARD
qk Flat type wire
(CN501)
ql Flat type wire (CN503)
4Screw(BVTP3x8)
0Back panel
1Two screws(BVTP3x8)
8Three screws(BVTP3x8)
qaTwo screws(BVTP3x8)
qsFan motor
7Two screws(BVTP3x8)
6Two screws(BVTP3x8)
5Seven screws(BVTP3x8)
9Connector(CN903)
3Tuner
2Flat type wire(CN1)
qdTwo screws(BVTP3x8)
qfMain board
11
3-4. CD LID ASSEMBLY
3-3. SUB PANEL
5Five screws
(BVTP2.6x8)
1Three screws
(BVTP2.6x8)
2Spring(CD lid)
7Screw
(BVTP2.6x8)
2Ornamental
plate
3Connector
(CN812)
8Four screws
(BVTP2.6x8)
Claw
4Connector
(CN703)
9Front input board
0Sub panel block
6Screw
(BVTP2.6x8)
3 Sab panel assembly
1CD lid assembly
3-5. TAPE MECHANISM DECK AND CASSETTE LID
qsHolder(deck B)
qfHolder(deck A)
4Mechanism deck
1Two screws(BVTP3x8)
2Screw(BVTP3x8)
qdSpring(deck A)
7Screw
(BVTP3x8)
qaSpring(deck B)
9Spring(TC- lid)
5Two screws
(BVTP3x8)
3Screw(BVTP3x8)
6Screw(BVTP3x8)
0Bracket
8Spring(TC- lid)
12
3-6. CD MECHANISM DECK
3-7. BASE UNIT
1Five screws (BVTP3x8)
2CD mechanism
deck
3Base unit
2Boss
1Yoke fitting
3-8. DISC TABLE
Note:
When the disc table is installed, adjust the positions of
roller cam and mark B as shown in the figure, then set to
the groove of disc table.
4Stop screw
A
2Screw (BVTP3X8
1Screw (BVTP3X8)
3Bracket (BU)
5Disc table
A
13
SECTION 4
TEST MODE
VIDEO CD COLOR-BARS MODE
On this mode, the data of the color-bars signal as a picture signal and the 1kHz sine wave signal as a sound signal are output by the
mechanism control microcomputer (IC502) for video CD signal check. When measurement of the voltage and waveform on the VIDEO
board, perform it in this mode.
For reference, the color-bars signal can be observed at J302 (VIDEO OUT) and the sound signal can be observed at J101 (VIDEO/MD
(AUDIO) OUT) using an oscilloscope.
1. Connect the lead wire to both ends of the land of SL503 of the VIDEO board.
2. Turn the power on. Press FUNCTION button to select CD.
3. After 2 or 3 seconds later, connect the lead wire.
4. After measuring, remove the lead wire connected.
[VIDEO BOARD] (SIDE A)
D502
SL501 SL502 SL503
TEST MODE
IC505
CT503
VIDEO
FREQUENCY
[VIDEO BOARD] (SIDE B)
TEST
MODE
14
SL503
SL502
SL501
IC502
IC507
SECTION 5
MECHANICAL ADJUSTMENTS
Precaution
1. Clean the following parts with a denatured alcohol-moistened
swab:
record/playback heads
pinch rollers
erase head
rubber belts
capstan
idlers
2. Demagnetize the record/playback head with a head demagnetizer.
3. Do not use a magnetized screwdriver for the adjustments.
4. After the adjustments, apply suitable locking compound to the
parts adjusted.
5. The adjustments should be performed with the rated power supply voltage unless otherwise noted.
Torque Measurement
Mode
FWD
FWD
back tension
Torque meter
CQ-102C
CQ-102C
REV
CQ-102RC
REV
back tension
CQ-102RC
FF/REW
CQ-201B
FWD tension
CQ-403A
REV tension
CQ-403R
Meter reading
3.04 – 6.96 N • m
(31 to 71 g • cm)
(0.43 – 0.98 oz • inch)
0.20 – 0.58 N • m
(2 to 6 g • cm)
(0.02 – 0.08 oz • inch)
3.04 – 6.96 N • m
(31 to 71 g • cm)
(0.43 – 0.98 oz • inch)
0.20 – 0.58 N • m
(2 to 6 g • cm)
(0.02 – 0.08 oz • inch)
6.97 – 14.02 N • m
(71 to 143 g • cm)
(0.98 – 1.99 oz • inch)
0.98 N • m or more
(100 g or more)
(3.53 oz or more)
0.98 N • m or more
(100 g or more)
(3.53 oz or more)
SECTION 6
ELECTRICAL ADJUSTMENTS
DECK SECTION
0 dB=0.775V
1. Demagnetize the record/playback head with a head demagnetizer.
2. Do not use a magnetized screwdriver for the adjustments.
3. After the adjustments, apply suitable locking compound to the
parts adjusted.
4. The adjustments should be performed with the rated power supply voltage unless otherwise noted.
5. The adjustments should be performed in the order given in this
service manual. (As a general rule, playback circuit adjustment
should be completed before performing recording circuit adjustment.)
6. The adjustments should be performed for both L-CH and R-CH.
7. Switches and controls should be set as follows unless otherwise
specified.
Tape
Signal
P-4-A100
10 kHz, –10 dB
Azimuth Adjustment
WS-48B
3 kHz, 0 dB
Tape Speed Adjustment
P-4-L300
315 Hz, 0 dB
Level Adjustment
Used for
Record/Playback Head Azimuth Adjustment
(Deck A, Deck B)
Note: Perform this adjustments for both decks.
Procedure:
1. Mode : Playback
test tape
P-4-A100
(10kHz, –10dB)
main board
CN301
Pin 1 (R-ch)
Pin 3 (L-ch)
set
level meter
+
–
2. Turn the adjustment screw and check output peaks. If the peaks
do not match for L-CH and R-CH, turn the adjustment screw so
that outputs match within 1 dB of peak.
L-CH
peak
screw
position
output
level
within
1 dB
within 1dB
R-CH
peak
L-CH
peak
R-CH
peak
screw
position
15
Tape Speed Adjustment (Deck A)
3. Mode: Playback
test tape
P-4-A100
(10kHz, –10dB)
main board
CN301
Pin 3 (L-ch)
oscilloscope
Pin 2 (GND)
Note: Set the test mode using the following method and begin tape
speed adjustment.
In the test mode, the speed will switch to double speed or
normal speed each time the HI-SPEED DUB button is pressed.
L
Procedure:
With the power turned ON, press the c/CLOCK SET button,
ENTER button, and DISC 3 button simultaneously.
(The “VOLUME” on the fluorescent display tube will blink while
in the test mode.)
To exit the test mode, press the "/1 button.
set
R
Pin 1 (R-ch)
Waveform of oscilloscope
in phase
45°
good
90°
135°
180°
wrong
4. After the adjustments, apply suitable locking compound to the
parts adjusted.
1.
2.
3.
4.
Insert the WS-48B into deck B.
Press the H button of deck B.
Press the HI-SPEED DUB button and play the tape at double speed.
Adjust RV1001 of the LEAF SW board so that the reading of
the frequency counter becomes 6000 ± 180 Hz.
5. Press the HI-SPEED DUB button and play the tape at normal speed.
6. Adjust RV1002 of the LEAF SW board so that the reading of
the frequency counter becomes 3000 ± 90 Hz.
Adjustment Location: LEAF SW board
Adjustment Location: Playback Head (Deck A)
Record/Playback/Erase Head (Deck B)
Remove the cassette lid.
Sample Value of Wow and flutter
W.RMS (JIS) less than 0.3%
(test tape: WS-48B)
Playback Level Adjustment (Deck A, Deck B)
Procedure:
Mode: Playback
test tape
P-4-L300
(315Hz, 0dB)
level meter
set
Reverse
Foward
main board
CN301
Pin 1 (R-ch)
Pin 3 (L-ch)
Deck A is RV311 (L-CH) and RV411 (R-CH), deck B is RV301
(L-CH) and RV401 (R-CH)
so that adjustment within the following adjustment level.
Adjustment level:
CN301 playback level: 301.5 to 338.3 mV (–8.2 to –7.2 dB)
level difference between the channels: within ± 0.5 dB
Adjustment Location: AUDIO board
Adjustment Location
[LEAF SW BOARD]
RV1001(High Speed)
RV1002(Normal Speed)
RV1002
16
RV1001
Record Bias Adjustment (Deck B)
Record Level Adjustment (Deck B)
Procedure:
Procedure:
INTRODUCTION
When set to the test mode performed in Tape Speed Adjustment, when the tape is rewound after recording, the “REC memory
mode” which rewinds only the recorded portion and playback is
set.
This “REC memory mode” is convenient for performing this adjustment. During recording, the input signal FUNCTION will automatically switch to VIDEO 1.
(After recording, press the m button without stopping will return to the position where recording was started.)
INTRODUCTION
When set to the test mode performed in Tape Speed Adjustment, when the tape is rewound after recording, the “REC memory
mode” which rewinds only the recorded portion and playback is
set.
This “REC memory mode” is convenient for performing this
adjustment. During recording, the input signal FUNCTION will automatically switch to VIDEO 1.
(After recording, press the m button without stopping will return to the position where recording was started.)
1. Press FUNCTION button to select VIDEO 1. (This step is not
necessary if the above test mode has already been set.)
2. Insert a tape into deck B, press the z REC button, and then
press the H button to start recording.
3. Mode: Record
1. Press FUNCTION button to select VIDEO 1. (This step is not
necessary if the above test mode has already been set.)
2. Insert a tape into deck B, press the z REC button, and then
press the H button to start recording.
3. Mode: Record
VIDEO 1 (AUDIO) IN
1) 315 Hz
} 50 mV (–23.8 dB)
2) 10 kHz
VIDEO 1 (AUDIO) IN
315Hz 50 mV (–23.8 dB)
AF OSC
AF OSC
blank tape
CS-123
600 Ω
blank tape
CS-123
600 Ω
attenuator
attenuator
set
set
4. Mode: Playback
4. Mode: Playback
recorded
position
recorded
position
level meter
set
level meter
set
main board
CN301
Pin 1 (R-ch)
Pin 3 (L-ch)
main board
CN301
Pin 1 (R-ch)
Pin 3 (L-ch)
5. Confirm playback the signal recorded in step 2 become adjustment level as follows.
If these levels do not adjustment level, adjust the RV341 (L-CH)
and RV441 (R-CH) on the AUDIO board to repeat steps 3 and 4.
5. Confirm playback the signal recorded in step 2 become adjustment level as follows.
If these levels do not adjustment level, adjust the RV301 (L-CH)
and RV351 (R-CH) on the MAIN board to repeat steps 3 and 4.
Adjustment level: The playback output of 10 kHz level difference
against 315 Hz reference should be ± 1.0 dB.
Adjustment level:
CN301 playback level: 47.2 to 53.0 mV (–24.3 to –23.3 dB)
Adjustment Location: AUDIO board
Adjustment Location: MAIN board
Adjustment Location:
[AUDIO BOARD] (Conductor Side)
RV341(Lch),RV441(Rch)
Record Bias
[MAIN BOARD] (Conductor Side)
RV311(Lch),RV411(Rch)
Playback Level (Deck A)
RV301 RV401
RV441 RV341
RV301(Lch),RV401(Rch)
Playback Level (Deck B)
RV311
RV411
CN301
3
1
Record Level (Lch)
RV301
43 42
29
IC301 56
28
1
14 15
RV351
Record Level (Rch)
17
Note: Clear RF signal waveform means that the shape “◊” can be
clearly distinguished at the center of the waveform.
CD SECTION
Note:
1. CD Block is basically constructed to operate without adjustment.
Therefore, check each item in order given.
2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated.
3. Use an oscilloscope with more than 10MΩ impedance.
4. Clean the object lens by an applicator with neutral detergent when
the signal level is low than specified value with the following
checks.
S Curve Check
oscilloscope
RF signal waveform
VOLT/DIV : 200mV
TIME/DIV : 500ns
level : 1.75 ± 0.25 Vp-p
E-F Balance (Traverse) Check
oscilloscope
BD board
BD board
TP (FE)
TP (VC)
+
–
TP (TE)
TP (VC)
Adjustment Location: BD board
+
–
Adjustment Location: BD board
Procedure :
1. Connect the oscilloscope to test points TP (FE) and TP (VC).
2. Connect TP (FEI) and GND, and TP (AGCCON) and GND of
the BD board with lead wires.
3. Press the "/1 button to turn the set ON.
4. With the disc (YEDS-18) loaded, press the 7 button and
perform focus search. (Focus search will be performed in the
same way even while the disc table is pushed in and out.)
5. Check the symmetry and peak to peak level of the oscilloscope
waveform (S curve) at this time.
S-curve waveform
symmetry
Procedure :
1. Connect oscilloscpe to test point TP (TE) on BD board.
2. Short-circuit SL502 of the video board to GND.
3. Turned Power switch on. Press FUNCTION button to select
CD.
4. Put disc (YEDS-18) in to play the number five track.
5. Press the PLAY MODE button. (The tracking servo and the
sledding servo are turned OFF.)
6. Check the level B of the oscilliscope's waveform and the A (DC
voltage) of the center of the Traverse waveform.
Confirm the following :
A/B x 100 = less than ± 22%
Traverse waveform
Center of the waveform
A
Within 4.0 ± 1.0 Vp-p
B
B
A (DC voltage)
0V
6. After check, remove the lead wire connected in step 2.
Note: • Try to measure several times to make sure than the ratio of
A : B or B : A is more than 10 : 7.
• Take sweep time as long as possible and light up the brightness to obtain best waveform.
Adjustment Location: BD board
level : 1.3 ± 0.6 Vp-p
7. Press the PLAY MODE button. (The tracking servo and sledding servo are turned ON.) Confirm the C (DC voltage) is almost equal to the A (DC voltage) is step 7.
Traverse waveform
RF Level Check
oscilloscope
BD board
TP (RF)
TP (VC)
+
–
Procedure :
1. Connect oscilloscope to test point TP (RF) and TP (VC) on BD
board.
2. Connect TP (AGCCON) and GND of the BD board with lead
wires.
3. Press the "/1 button to turn the set ON.
4. Put disc (YEDS-18) in and playback 5track.
5. Confirm that oscilloscope waveform is clear and check RF signal level is correct or not.
6. After check, remove the lead wire connected in step 2.
18
C (DC
voltage)
0V
Tracking servo
Sled servo
OFF
Tracking servo
Sled servo
ON
8. Desolder the short-land (SL502) short-circuited at step 2.
Adjustment Location: BD board
HCD-LV80
SECTION 7
DIAGRAMS
Adjustment Location :
7-1. CIRCUIT BOARDS LOCATION
[ BD BOARD ] — SIDE B —
TUNER UNIT
PANEL-FL board
TP
(RF)
TP
(VC)
VIDEO board
MIC board
TP
(AGCCON)
TP
(FE)
TP
(TE)
TRANS board
TC-A board
MAIN board
TP
(IOP)
PANEL-VR board
TC-B board
HEADPHONE board
VIDEO SECTION
Frequency adjustment
frequency counter
1. Connect the frequency counter to check point of the VIDEO
board.
2. Adjust CT503 of the VIDEO board so that the frequency counter
read 27MHz ± 80Hz at STOP condition.
VIDEO board
(27 MHz)
+
–
CD-L board
PA board
Adjustment Location :
CD-R board
[ VIDEO BOARD ] – SIDE A –
[ VIDEO BOARD ] – SIDE B –
TABLE SENSOR board
D502
SL501 SL502 SL503
TEST MODE
(27MHz)
LEAF SW board
IC506
(GND)
IC505
(27MHz)
CT503
VIDEO
FREQUENCY
(GND)
SL503
TEST SL502
MODE SL501
AUDIO board
IC502
BD board
IC507
CD MOTOR board
LED board
19
19
FRONT INPUT board
HCD-LV80
7-2. BLOCK DIAGRAMS
– BD SECTION –
IC781
OPTICAL PICK-UP BLOCK
(KSS-213D/Q-NP)
DETECTOR
IC101
DIGITAL SERVO
DIGITAL SIGNAL PRCESSOR
IC103
RF AMP
VCC
MD2
E
A
A
C
B
D
5
C
7
D
8
B
6
32K
RAM
A
C
RFD
RF
SUMMING
AMP
D
B
RF EQ
AMP
RF AC
16
EFM
DEMODULATOR
50
RFI 17
REGISTER
ERROR
CORRECTOR
D OUT
DIGITAL
OUT
INTEGRATOR
14
49
ASYI
ASYMMETRY
CORRECTION
1 DOUT
PCM-D
D/A
INTERFACE
LRCK
C2PO
MUTE
FE
D+5V
64
BCLK
SUB CODE
PROCESSOR
F
FOCUS
ERROR
AMP
DATA BUS
VC
63
CD DIGITAL
OUT
OPTICAL
DIGITAL
PLL
66
ADATA
67
BCLK
65
LRCK
14
C2PO
3
MUTE
ASYO
48
E
11
F
10
LD
DRIVE
Q101
E
TE
TRACKING
ERROR
AMP
F
13
DIGITAL
CLV
LD
3
LD
VC
BUFFER
LASER
DIODE
PD
4
PD
APC LD
AMP
LD
POWER
VC
43
39
21
T+
TRACKING
COIL
T
F+
F
SD+
M102
SLED
MOTOR
M101
SPINDLE
MOTOR
SP+
13
5
40
DETECTOR
FE
TE
CE
MIRR
DFCT
FOK
OP AMP
A/D
ANALOG SW CONVERTER
DATA
SERVO
AUTO
SEQUENCER
SE
TFDR
XLAT
CLOK
CPU
INTERFACE
SCOR
SQSO
PWM
GENERATOR
TRDR
31
32
2
3
18
FRDR
33
34
24
23
TFDR
TRDR
FFDR
17
SFDR
29
SRDR
CTRL1
7
SENS
30
FFDR
FRDR
SFDR
SRDR
S STOP
SERVO DSP
TRACKING
PWM
GENERATOR
TRACKING
SERVO
FOCUS
PWM
GENERATOR
FOCUS
SERVO
SLED
PWM
GENERATOR
SLED
SERVO
4
DATA
5
XLT
6
CLK
15
SCOR
76
SUBQ
77
SQCK
16
A
(Page 24)
A+5V
26
S101
LIMIT SW
SERVO
INTERFACE
SCLK
SCLK
8
LPH
XRST
XRST
82
LD ON
• SIGNAL PATH
15
M
SP
INTEGRATOR
14
M
SD
41
VC 42
RFDC
12
11
69
VIDEO
SECTION
SQCK
6
FOCUS
COIL
SENS
(XTAL 33.8MHz)
MCK
2
22
REF
IC102
FOCUS/TRACKING COIL DRIVE
SPINDLE/SLED MOTOR DRIVE
XTSL
SERVO
BLOCK
38
IC104
71
4
CONTROL SIGNAL
BLOCK
VC
LD ON
XTAI
CLOCK
GENERATOR
12
25
25
: CD
MDP
: VIDEO
VC
27
: Digital out
MUTE 20
XRST
DISC
SENSOR
IC202
TRAY SENS
UP SW
S201
(UP SWITCH)
M201
TABLE
MOTOR
IC201
MOTOR DRIVER
3 OUT 2
IN 2 1
TBL-R
C
TBL-L
MAIN
SECTION (2/2)
M
7 OUT 1
IN 1 9
(Page 23)
09
LED SW
Q201
+5V
D201
(DISC No.)
20
20
LED
HCD-LV80
– DECK SECTION –
PB A/B
S1008
B CrO2
S1004
A CrO2
MS OUT
CN301
3
RV311
IC611
16
PLAYBACK
LEVEL
DECK A
PB-A/B
L
70
A IN
48
B IN
46
A 120/70 B NORM/CROM/
METAL
PAS
120
IC601
L
3
HRPE101
IC602
R
4
REC/PB
NR ON/OFF
24
REC/PB/PASS
43
TC REC L
BIAS ON/OFF
20
RM ON/OFF 22
ALC ON/OFF 15
BIAS ON/OFF
RM ON/OFF
ALC ON/OFF
32 31, 33
RELAY
RV341
REC
BIAS
REC BIAS
ERASE BIAS
LIN
BIAS SW
38
1
P
DOLBY
TYPE B
RECOUT
D
36
EQIN
NORM/HIGH
PB
39
EQOUT
LM ON/OFF
NORM/
HIGH 18
NR ON/
OFF 23
RV301
REC LEVEL
R CH
TC PB L
40
LM ON/ 25
OFF
PLAYBACK
LEVEL
DECK B
REC/PB HEAD
(DECK B)
R
1
PB OUT
DOLBY NR
DOLBY NR
IC301
RV301
R CH
26
MS
DOL
R CH
R
ERASE HEAD
28 27
19
M
HP101
PB HEAD
(DECK A)
17
CAPM CNT1
CAP MOTOR
CONTROL
Q336-343
+7.5V
Q623
M1
CAPSTAN
MOTOR
M
CAPM CNT2
SPEED
CONTROL
Q1001
SWITCH
Q335
CAP M H / L
B
BIAS OSC
T621, Q621, 622
X
RV1002
NORMAL
SPEED
MAIN (1/2), (2/2)
SECTION
RV1001
HIGH
SPEED
REEL
DETECT
IC1001
A SHUT
REEL
DETECT
IC1002
B SHUT
S1001 (A PLAY)
• R CH : Same as L ch
• SIGNAL PATH
: PB (DECK A)
: PB (DECK B)
: REC (DECK B)
+5V
A PLAY
S1002 (B PLAY)
B PLAY
S1003
(A HALF)
A HALF
+5V
+5V
S1005
(REC A)
09
B HALF/REC A/REC B
S1006
(B HALF)
S1009
(REC B)
• PLUNGER SOLENOID is supplied
as the MECHANICAL BLOCK ASSY.
A DECK/
B DECK
PLUNGER
TRIGGER
MOTOR
CONTROL
Q331-334
21
B TRIG
A TRIG
21
(Page 22, 23)
HCD-LV80
– MAIN (1/2) SECTION –
IC191
AV SWITCH
J804
VIDEO 2
IN
VIDEO
SECTION
(Page 24)
6
IN3
8
IN4
1
IN1
J702
O
VCD VIDEO
VIDEO
OUT
VD OUT 10
J702
VIDEO
IN
2
3
46
IC101
SOUND PROCESSOR 1
C
B
A
5
45
28
IC601
PHONO AMP
L+R
30
J701
J701
3
PHONO
(L IN)
FM/AM TUNER
TUNER UNIT IS
SUPPLED AS THE
ASSEMBLED
BLOCK
DECK
SECTION
(Page 21)
VIDEO
SECTION
(Page 24)
B
ST-L
1
69 IN A2
REC B2
67 IN C2
CD-L
BBA2 39
66 IN D2
BBB2
E
MUTE
SWITCH
Q113
TC REC L
MD (L IN)
(Page 25)
L-CH SIG
TC REC L
TC PB L
DISPLAY
SECTION
(Page 26)
MD OUT
BUS OUT2 36
68 IN B2
J701
POWER
SECTION
57
REC A2 58
M
D
SPEANA
B
POWER
SECTION
(Page 25)
DECK
SECTION
(Page 21)
38
65 IN E2
SWITCH
Q112
SWITCH
Q111
Q
MIC-SIG
2
MIC IN
7
IC181 SELECTOR
J701
V1, AU
(L IN)
12 X0
BUF IN2 37
J804
V2, AU,
L-CH IN
14 X1
X 13
B
A
10
46
SWITCH
Q115
64 IN F2
LATCH
DATA
CLOCK
34
33
32
34
9
45
38
47
48
MAIN CONTROL
IC501 (1/2)
DBFB-H/L
V-MUTE
SW-MODE
493-LAT
MUTE
SWITCH
Q803
09
• R CH: Same as L ch
• SIGNAL PATH
: FM
: CD
: PB
: REC
: VIDEO/MD
: VIDEO
D807
MUTE
SWITCH
Q804
6
LINE-MUTE
3
F-RELAY
FUNC-SEL1
FUNC-SEL0
493-DATA
493-MUTE
RESET
12
AC-CUT
7
28
28
34
34
38
38
45
45
46
46
47
47
48
48
22
RESET
SWITCH
Q801
RESET
SWITCH
Q802
RESET
IC801
22
22
7
RESET
DBFB
F-RELAY
D805
+5v
F
G
DISPLAY
SECTION
(Page 26)
POWER
SECTION
(Page 25)
HCD-LV80
– MAIN (2/2) SECTION –
IC931
N
I2 C
CLK
I2C DATA
30
+UNREG, 17V
1
+10V
REG
ST +10V
2
LX7
(Page 24)
STK-POWER
FAN DET
HP.SW
36
1
1
H/P IN
PROTECT 27
POWER
SECTION
27
43
42
93
1
27
POWER
ECO
HP MUTE
STK POWER
PROTECT
42
FL OFF 42
43
STBY RELAY 43
93
HP MUTE 93
(Page 25)
PL A+10V
3
MAIN CONTROL
IC501 (2/2)
VIDEO
SECTION
H
Q931
SWITCH
29
I
Q932
SWITCH
1
+12V
REG
FAN
FAN SWITCH
Q961, 963
IC932
POWER
SECTION
M901
TC MOTOR+12V
3
IC933
(Page 25)
+7V
REG
1
M+7V (UNSW)
3
7V
P
18
WAKE UP 18
29
IIC-CLK 29
30
IIC-DATA 30
X-RST
59
XRST
(Page 20)
B
DECK
SECTION
(Page 21)
DATA
CLOCK
WAKE UP
J
UN–12V
2
–7V
REG
Q903
SWITCH
3
ST A-7V
LED-7V
Q904
SWITCH
(Page 26)
(Page 24)
BD
SECTION
IC951
DISPLAY
SECTION
VIDEO
SECTION
C
30
29
18
TC–7V
TRAY.SENS
TBL.L
TBL.R
UP SW
LED
61
63
65
68
69
DISC-SENS
TBL-L
TBL-R
ENC 3/UP-SW
ENC 2/DISC-LED
B TRG
A TRG
CAPM-CNT 2
CAPM-CNT 1
CAP-M-H/L
MS OUT
LM ON/OFF
REC/PB/PASS
NR ON/OFF
RM ON/OFF
BIAS ON/OFF
NORM/HIGH
PB A/B
ALC ON/OFF
B PLAY
A PLAY
A-HALF
B-HALF/REC A/REC B
B SHUT
A SHUT
RELAY
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
100
B-TRG
A-TRG
CAPM-CNT 2
CAPM-CNT 1
CAP-M-H/L
AMS IN
TC-MUTE
R/PB/PAS
NR-ON/OFF
REC-MUTE
BIAS
EQ-H/N
PB-A/B
ALC
B-PLAY-SW
A-PLAY-SW
A-HALF
B-HALF
B-SHUT
A-SHUT
TC-RELAY
–7V
DETECTOR
Q905
IC901
1
UN+12V
+7V
REG
Q911
SWITCH
ST A+7V
3
(LED+7V)
2
LED+7V
Q912
SWITCH
Q902
SWITCH
TC+7V
+7
X501
32.768kHz
XC-IN 10
IC911
XC-OUT 11
1
X502
16MHz
+5V
REG
LED 5V
3
EVER +5V
X-OUT 13
X-IN 15
D+5V UNSW
Q911
SWITCH
(D+5V SW)
5V
AU D+5V
FM/AM TUNER
TUNER UNIT IS
SUPPLED AS THE
ASSEMBLED
BLOCK
ST-MUTE
STEREO
TUNED
ST-CE
ST-DOUT
ST-DIN
ST-CLK
49
50
51
52
53
54
55
ST-MUTE
STEREO
TUNED
ST-CE
ST-DOUT
ST-DIN
ST-CLK
2
POWER
2
Q914
SWITCH
5
CD-POWER
Q912
SWITCH
EVER +5V
Q913
SWITCH
5
(CD D+5V SW)
D+5V (SW)
(CD A+5V SW)
IC921
1
09
• R CH : Same as L ch
23
23
+5V
REG
3
A+5V (SW)
L
POWER
SECTION
(Page 25)
HCD-LV80
– VIDEO SECTION –
10 - 29
CE
A10
A17
A0
58 - 44
37
MCE
40
12 - 5 27 26 23 22
MA0
I
MA10
38 42
MD0
I
MD15
25 4 28 29 3 2 14 10
CAS
13 - 15 17 - 21
A11
O7
O0
31 - 39
MWE
RASO
2 - 10
DQ16
16 - 19 22 - 26
ROM
IC506
DQ1
A0
13 14 28 29
A8
WE
RAS
UCAS
LCAS
D-RAM
IC507
LEVEL SHIFT
IC501
ADATA
BCLK
LRCK
1
13
5
OUTPUT AMP
IC401
4
10
8
4
3
5
CD-DATA
CD-BCK
CD-LRCK
6
CD-C2P0
Y-OUT 69
BUFFER
Q301
TRAP
Q302,306,307
MIX AMP
Q308,310
VCD VIDEO
4
VIDEO/CD DECODER
IC505
DATAI
INT
HSEL
RST
INVERTER
Q502
93
DA-DATA 110
108
111
106
86
DA-LRCK
DA-BCK
VCK-IN
DA-XCLK
PGIO2/VSYNC/CSYNC
DIGITAL FILTER & D/A CONVERTER
IC509
DATA0
CLK1
A
VIDEO CD CONTROL
IC502
14
D/A
CONV
11
MODE
1
CLOCK
DIVIDER
24
21 20
31
32
33
20
21
23
24
45
DATA
XLT
CLK
3
4
5
1
SENS
SCLK
MUTE
2
DATA1O
DATA1I
CLK1
CL680 INT
CL680 HSEL
CL680 HRDY
680 RESET
BUS
DSP DATA
DSP LATCH
DSP CLK
SENSE
SENSE CLK
10 DSP MUTE
11 CTRL1(L:DOUBLE)
27 CTRL2
28 LDON
18 SCOR
CTRL1
LPH
LDON
SCOR
SUBQ
SQCK
SHARPNESS
R-CH
M
(Page 22)
X503
27MHz
34
DF LATCH
22
A7
65
XIN
15
XOUT
13
NT/PAL
93
LEVEL SHIFT
IC504
X501
10MHz
+5V
S501
NTSC
SYSTEM
SELECT
AUTO
3
11
1
27MHz
6
384FS
8
12 768FS
PAL
TEST LED
73
D502
I2C.DATA
I2C.CLK
XRESET
12
X-RST
36 SUBQ DATA
D5V
37 SUBQ CLK
77 DEVICE RESET
I2C.DATA
I2C.CLK
XRST
CD-L
(L - CH)
1
VIDEO
FREQUENCY
4
RSTB
CLK1
INT
HSEL
HRDY
RESET
3
PLM
MAIN (1/2)
SECTION
9
8
7
10
(Page 20)
09
AMP
IC101
CT503
CD
SECTION
DATA0
DATAI
1
27MHz
18
19
17
CLK1, DATA0
(Page 22)
BUFFER
Q303,304
C-OUT 75
114 HINT
121 HSEL
60 RESET
MAIN (1/2)
SECTION
S VIDEO
OUT
3
2
112 HD-OUT
119 HD-IN
117 HCK
113 HRDY
DATAO
CLK1
HRDY
O
J301
MUTE
Q453
1
3
C2P0
MUTE
Q454
7
5
3.3V REG
Q531
N
P
+3.3V
• R CH: Same as L ch
• SIGNAL PATH
: CD
: CHROMA
:Y
: VIDEO
30
29
(XTAL 33.8MHz)
MCK
24
24
MAIN (2/2)
SECTION
(Page 23)
MAIN (2/2)
SECTION
(Page 23)
HCD-LV80
– POWER SECTION –
K
MIC-SIG
MIC AMP
IC850 (1/2)
MIC LEVEL
RV750
ECHO CONTROL
IC851
ECHO LEVEL
RV751
MIC AMP
IC850 (2/2)
J801
MIC 1
J802
1
LPF 1 IN
LPF 1 OUT
2
9
LPF 2 IN
LPF 2 OUT
8
Q
MIC-SIG
DISPLAY
SECTION
(Page 26)
MAIN (1/2)
SECTION
(Page 22)
MIC 2
11 OP 2 IN
OP 2 OUT 10
J803
MAIN (1/2)
SECTION
(Page 22)
G
DBFB
PHONES
F-RELAY
R-ch
HP.SW
POWER AMP & VOLUME CONTROL
IC801
MAIN (1/2)
SECTION
RY401
E
(Page 22)
FAN DETECTOR
D405
L-CH IN
18
FRONT
RELAY
DRIVER
Q401-402
6 3 4
L
(Page 23)
D804
EVER +5V
HP-MUTE
MAIN (2/2)
SECTION
(Page 23)
I
(Page 23)
TM401
L
11
VOLUME
CONTROL
MAIN (2/2)
SECTION
H
FAN DET
MAIN (2/2)
SECTION
STK-POWER
MUTE
CONTROL
Q834
VOLUME
CONTROL
D802, 852
PROTECT
DC AMP
Q433-434
THERMAL
SENSOR
Q831-832
L-CH THERMAL
PROTECT SWITCH
Q801
R
LATCH
DRIVER
Q432
LATCH
DRIVER
Q437
PROTECT
SWITCH
Q431
TH831
MUTE
SW
Q805
PROTECT
SWITCH
Q439
HEAD PHONE
MUTE
Q833
MUTE
DRIVE
Q804
R-CH
MUTE
SWITCH
Q803
VF
POWER
TRANSFORMER
T951
VF
PROTECT
+UNREG. 12V
RECT
D833-836
240V
UN +10V
UN –10V
VOLTAGE
SELECTOR
VS901
RECT
D841-844
230V JW971
120V
• R CH : Same as L ch
09
• SIGNAL PATH
: FM
+VH
VF (–35V)
SWITCH
Q908
AC-L
RECT
D831
–35V REG
Q903
AC-L
RECT
D832
F951
AC
IN
25
25
HCD-LV80
– DISPLAY SECTION –
DISPLAY CONTROL
IC601
REMOTE
CONTROL
RECIEVE
IC702
SIRCS 1
S701
JOG
JOG A 2
JOG B 8
. AMS >
LED SCK 3
LED LATCH 4
LED DAT 5
SERIAL
PARALLEL
CONVERTER
IC701
14 CLK
15 STB
13 DATA
70 X IN
X601
12.5MHz
S691
72 X OUT
(Page
22)
D-SW 80
Z
OPEN
F
MAIN (1/2) SECTION
MAIN (2/2) SECTION
(Page
23)
J
73
78
79
22
RESET
DATA
CLOCK
WAKE UP
D
Q601 – Q603
LED POWER
SWITCH
LED SEL 7
P1
•
P2
+5VH
+5VL
S701
REC LEVEL
OUTPUT
DISPLAY CONTROL (FOR MIC)
IC603
K
POWER SECTION
MAIN (1/2) SECTION
RESET
I2C DATA
I2C CLK
WAKE UP
VOLUME A 9
VOLUME B 10
(Page 25)
VOLUME
KEY 0 11
KEY MATRIX
KEY 4 15
MIC–SIG
SPEANA
3
4
6
5
LINE NF
LINE IN
REC IN
REC NF
REC LEVEL
F06
F05
F04
F02
F01
11
12
13
14
16
17
21
20
19
18
17
16
P3
P5
•
P7
•
P9
P16
ALL BAND
BPF 4
BPF 3
BPF 2
BPF 1
BPF 0
Q605 – Q607
LED DRIVER
DAILY LED 74
REC LED 75
LED-EC0 77
Q608 – Q610
DRIVER
GR-1 43
GR-15 28
GR-16 27
(Page 22)
SEG-1
45
23
67
GR-3
29
14, 2
40, 42
FLUORESCENT INDICATOR TUBE
FL601
VF
09
26
26
D601 – D603
D604 – D607, D611, D612, D615 – D621,
D623 – D627, D635 – D638
1
•
3
5
•
7
11
•
20
22
D700
17
•
19
D631, D632, D641
HCD-LV80
THIS NOTE IS COMMON FOR PRINTED WIRING
BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is printed
in each block.)
1
B C
•
•
•
•
•
4Vp-p
4.6Vp-p
These are omitted.
1.3Vp-p
10MHz
44.1kHz
IC502 qd XOUT
B C
E
IC101 t; RFAC
These are omitted.
IC509 ql LRCK
8
2
2
C
Q
2.11MHz
H
These are omitted
IC101 ra TE
B E
IC509 qj BCLK
IC505 ug COUT
APPROX 500mVp-p
9
3
3
2Vp-p
4.8Vp-p
2.5V
U : B+ Line.
V : B– Line.
H : adjustment for repair.
Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
Circled numbers refer to waveforms.
Signal path.
F : FM
g : VIDEO/MD
E : PB (DECK A)
d : PB (DECK B)
G : REC (DECK B)
m : CHROMA
n :Y
o : VIDEO
J : CD
c : digital out
I : PHONO
Abbreviation
EA
: Saudi Arabia model.
SP
: Singapore model.
MY
: Malaysia model.
H
APPROX 200mVp-p
33.8MHz
IC505 yl YOUT
IC101 el FE
IC504 8 384FS
0
4
4
3.8Vp-p
1Vp-p
2.6Vp-p
27MHz
H
7.5µsec
IC101 wg MDP
IC504 6 27M
Q303 E COUT
qa
5
2Vp-p
H
IC504 qs
6
5.8Vp-p
27MHz
IC509 1 XT1
– MAIN (2/3) SECTION –
1
Note:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
a
•
: Through hole.
• b : Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
5.5Vp-p
16MHz
IC501 qd XC-OUT
2
Parts on the pattern face side seen from the
pattern face are indicated.
Parts on the parts face side seen from the
parts face are indicated.
5.2Vp-p
32.768kHz
IC501 qa X-OUT
– PANEL FL SECTION –
1
3.4Vp-p
12.5MHz
IC601 us X OUT
27
27
2.8Vp-p
33.8MHz
IC401 4 YOUT
For printed wiring boards.
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
4.8Vp-p
1Vp-p
2.5V
Note: The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
•
•
•
•
7
1
E
For schematic diagrams.
Note:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
f
•
: internal component.
• 2 : nonflammable resistor.
• 1 : fusible resistor.
• C : panel designation.
– VIDEO SECTION –
WAVEFORMS
– CD SECTION –
• Indication of transistor
HCD-LV80
7-3. PRINTED WIRING BOARD – BD SECTION –
• See page 19 for Circuit Boards Location.
(Page 32)
28
28
HCD-LV80
7-4. SCHEMATIC DIAGRAM – BD SECTION –
• See page 27 for Waveforms.
• See page 54 for IC Block Diagrams.
• See page 56 for IC Pin Functions.
PIN
FUNCTION
(Page 33)
29
29
HCD-LV80
7-5. SCHEMATIC DIAGRAM – DECK SECTION –
• See page 54 for IC Block Diagrams.
(Page 38)
30
30
HCD-LV80
7-6. PRINTED WIRING BOARD – DECK SECTION –
• See page 19 for Circuit Boards Location.
31
31
HCD-LV80
7-7. PRINTED WIRING BOARD – VIDEO SECTION –
• See page 19 for Circuit Boards Location.
(Page 36)
(Page 28)
• Semiconductor
Location
• Semiconductor
Location
Ref. No.
Location
Ref. No.
Location
D301
D501
D502
E-1
D-3
A-3
IC501
IC502
IC506
C-2
B-1
C-3
IC101
IC401
IC504
IC505
IC507
IC509
A-1
E-3
B-1
C-2
C-1
B-1
Q302
Q303
Q453
Q454
Q531
E-3
D-1
E-2
E-2
D-1
Q301
Q304
Q306
Q307
Q308
Q310
Q502
E-1
D-3
E-1
E-2
E-2
E-2
D-3
32
32
J
(Page 36)
HCD-LV80
7-8. SCHEMATIC DIAGRAM – VIDEO (1/3) SECTION –
• See page 27 for Waveforms.
• See page 58 for IC Pin Functions.
(Page
35)
(Page 29)
PIN
FUNCTION
LPH
(Page 38)
(Page 34)
(Page 34)
(Page 35)
33
33
HCD-LV80
7-9. SCHEMATIC DIAGRAM – VIDEO (2/3) SECTION –
• See page 27 for Waveforms.
• See page 32 for Printed Wiring Board.
• See page 60 for IC Pin Functions.
(Page 33)
(Page 33)
(Page
35)
UDZ–TE–17–3.9B
PIN
FUNCTION
MSM514260C-60JS
34
34
(Page
35)
HCD-LV80
7-10. SCHEMATIC DIAGRAM – VIDEO (3/3) SECTION –
• See page 27 for Waveforms.
• See page 32 for Printed Wiring Board.
• See page 54 for IC Block Diagrams.
CLAMP
CLAMP
C472
22
6.8V
(Page 33)
6.2dB 75Ω
AMP DRIVER
6.2dB
AMP
75Ω
DRIVER
C472
22
6.8V
R337 R335
4.7k 18k
(Page 33)
(Page 34)
J
(Page 37)
(Page 34)
35
35
HCD-LV80
7-11. PRINTED WIRING BOARD – MAIN SECTION –
• See page 19 for Circuit Boards Location.
• Semiconductor
Location
Ref. No.
Location
D191
D192
D193
D194
D333
D334
D335
D336
D401
D501
D534
D801
D802
D803
D804
D805
D806
D807
D808
D911
D912
D913
D931
D951
H-6
I-6
I-7
I-7
A-11
A-11
A-9
A-9
A-2
B-7
C-6
A-7
B-6
B-5
B-6
B-5
B-6
A-5
A-8
E-3
D-4
E-3
C-5
I-3
IC101
IC181
IC191
IC301
IC501
IC601
IC781
IC801
IC901
IC911
IC921
IC931
IC932
IC933
IC951
G-10
I-8
I-6
C-11
C-7
I-12
I-1
B-6
C-2
E-4
D-3
C-3
C-3
B-2
I-2
Q111
Q112
Q113
Q115
Q161
Q162
Q163
Q165
Q331
Q332
Q333
Q334
Q335
Q336
Q337
Q338
Q339
Q340
Q341
Q342
Q343
Q801
Q802
Q803
Q804
Q901
Q902
Q903
Q904
Q905
Q906
Q911
Q912
Q914
Q921
Q931
Q932
Q961
Q962
G-10
G-8
F-8
F-9
F-8
F-8
E-8
F-10
A-11
A-11
A-11
A-11
A-9
A-11
A-10
A-9
A-9
A-10
A-10
A-10
A-10
B-6
A-5
A-5
B-5
H-2
H-2
H-2
H-2
H-2
H-2
D-4
E-4
D-4
D-3
C-4
C-4
I-3
I-3
(Page 50)
(Page 32)
(Page 42)
(Page 53)
(Page 40)
(Page 31)
(Page 44)
(Page 40)
(Page 32) (Page 47)
36
36
HCD-LV80
MICON
INTERFACE
7-12. SCHEMATIC DIAGRAM – MAIN (1/3) SECTION –
• See page 54 for IC Block Diagrams.
37
37
HCD-LV80
7-13. SCHEMATIC DIAGRAM – MAIN (2/3) SECTION –
• See page 27 for Waveforms.
• See page 63 for IC Pin Functions.
• See page 36 for Printed Wiring Board.
PIN
FUNCTION
38
38
HCD-LV80
7-14. SCHEMATIC DIAGRAM – MAIN (3/3) SECTION –
• See page 36 for Printed Wiring Board.
39
39
HCD-LV80
7-15. PRINTED WIRING BOARD – POWER SECTION –
• See page 19 for Circuit Boards Location.
(Page 53)
(Page 53)
(Page 48)
• Semiconductor
Location
(Page 36)
(Page 36)
40
40
Ref. No.
Location
D401
D402
D405
D406
D801
D802
D803
D804
D805
D831
D833
D834
D835
D836
D841
D842
D843
D844
D851
D852
D911
D912
C-8
H-9
I-10
I-10
D-8
F-7
E-5
C-9
E-9
B-4
A-6
A-6
A-6
A-6
A-9
A-9
A-9
A-8
D-7
E-6
A-3
A-3
IC801
F-7
Q401
Q402
Q431
Q432
Q433
Q434
Q437
Q439
Q801
Q803
Q804
Q805
Q831
Q832
Q833
Q834
Q851
Q855
Q903
Q908
G-10
G-10
D-3
C-3
D-4
C-4
D-3
C-3
D-8
D-5
D-6
B-8
D-9
D-9
C-9
D-8
D-7
B-8
A-1
A-2
HCD-LV80
7-16. SCHEMATIC DIAGRAM – POWER SECTION –
41
41
HCD-LV80
7-17. PRINTED WIRING BOARD – PANEL FL SECTION –
• See page 19 for Circuit Boards Location.
(Page 36)
(Page 46)
(Page 44)
(Page 46)
• Semiconductor
Location
Ref. No.
Location
Ref. No.
Location
D601
D602
D603
D604
D605
D608
D615
D617
A-13
A-10
B-10
A-3
B-3
B-12
B-1
B-3
Q601
Q602
Q603
Q605
Q606
Q607
Q608
Q609
Q610
B-12
B-12
B-12
A-13
A-10
B-10
B-9
B-8
B-6
IC601
IC603
C-7
C-9
42
42
HCD-LV80
7-18. SCHEMATIC DIAGRAM – PANEL FL SECTION –
• See page 27 for Waveforms.
• See page 65 for IC Pin Functions.
• See page 55 for IC Block Diagrams.
PIN
FUNCTION
43
43
HCD-LV80
7-19. PRINTED WIRING BOARD – PANEL VR SECTION –
• See page 19 for Circuit Boards Location.
(Page 36)
(Page 42)
(Page 48)
• Semiconductor
Location
Ref. No.
Location
D606
D607
D611
D612
D616
D618
D619
D620
D621
D623
D624
D625
D626
D627
A-10
A-7
B-11
C-12
C-8
A-12
B-6
B-6
B-6
B-7
B-8
B-8
B-9
B-10
IC701
IC702
C-7
A-3
44
44
HCD-LV80
7-20. SCHEMATIC DIAGRAM – PANEL VR SECTION –
• See page 55 for IC Block Diagrams.
45
45
HCD-LV80
7-21. PRINTED WIRING BOARD – TC PANEL SECTION –
• See page 19 for Circuit Boards Location.
(Page 42)
(Page 42)
(Page 48)
(Page 48)
(Page 36)
46
46
HCD-LV80
7-22. SCHEMATIC DIAGRAM – TC PANEL SECTION –
47
47
HCD-LV80
7-23. PRINTED WIRING BOARD – CD PANEL SECTION –
• See page 19 for Circuit Boards Location.
(Page 46)
(Page 46)
(Page 44)
(Page 40)
48
48
HCD-LV80
7-24. SCHEMATIC DIAGRAM – CD PANEL SECTION –
• See page 54 for IC Block Diagrams.
49
49
2.5
2.5
2.5
2.5
0.7
0.7
4.8
0.9
2.5
2.5
2.5
2.5
2.5
HCD-LV80
7-25. PRINTED WIRING BOARD – CD MOTOR SECTION –
• See page 19 for Circuit Boards Location.
(Page 36)
50
50
HCD-LV80
7-26. SCHEMATIC DIAGRAM – CD MOTOR SECTION –
(Page 38)
51
51
HCD-LV80
7-27. SCHEMATIC DIAGRAM – TRANS SECTION –
52
52
HCD-LV80
7-28. PRINTED WIRING BOARD – TRANS SECTION –
• See page 19 for Circuit Boards Location.
7-29. SCHEMATIC DIAGRAM – LEAF SW SECTION –
7-30. PRINTED WIRING BOARD – LEAF SW SECTION –
• See page 19 for Circuit Boards Location.
M
A DECK
PLUNGER
M1
CAPSTAN
MOTOR
B DECK
PLUNGER
(Page 36)
(Page 40)
(Page 40)
53
53
HCD-LV80
7-31. IC BLOCK DIAGRAMS
• BD Board
• VIDEO Board (3/3)
• BD Board
IC103 CXA2568M-T6
IC509 PCM1727E-2/T2
80 79 78 77 76 75 74 73
VCC
APC PD AMP
DVSS2
XTSL
EMPH
BCK
PCMD
XTA0
XTA1
XOLT
SOCK
SOUT
EXCK
EXCK
SCSY
SQCK
SQSO
IC101 CXD3008Q
23 LC/PD
22 LD_ON
VCC
VEE
72 71 70 69 68 67 66
384fs
24 VCC
CLOCK MANAGER
•
DUAL PLL
XT1 1
24 XT2
HOLD 1
VEE
DIGITAL
OUT
MUTE 3
60 VPC0
59 V16M
58
CLOCK
GENERATOR
57 BIAS
EFM
DEMODURATOR
SERVO
AUTO
SEQUENCER
56 DVDD2
32K
RAM
55
54
53
52
DIGITAL
PLL
SERVO
INTERFACE
SUB
CODE
PROCESSOR
ASYMMETY
CORRECTOR
DVSS 18
MIRR
DFCT
FOK
PWM GENERATOR
FOCUS PWM
GENERATOR
TRACKING PWM
GENERATOR
SLED PWM
GENERATOR
MIRR 20
DFCT 21
FDK 22
PWM1 23
LOCK 24
MDP 25
4
19 RF_BOT
A
5
B
6
C
7
D
8
VC
VEE
RF SUMMING AMP
VC
TRACKING
SERVO
OP
AMP
A/D
CONVERTER ANALOG
SW
SLED SERVO
18 RFTC
17 RF_1
16 RFO
VEE
9
VC
VEE
NCKO 4
RSV 5
SCKO3 6
ML
MC
MC
RSTB
7
8
9
10
8 TIME OVER
SAMPLING DIGITAL
FILTER
•
FUNCTION
CONTROL
VC
BPZ
CONTROL
VC
MULTI LEVEL
∆Σ
MODULATOR
MULTI LEVEL
∆Σ
MODULATOR
5 LEVEL
DAC
5 LEVEL
DAC
CR LPF
•
OUTPUT
AMP
CR LPF
•
OUTPUT
AMP
13 TE
VC
1GEN
AVSS0
AD10
RFDC
TRACKING
ERROR AMP
VC
VC BUFFER
VCC
VC 12
VOUTR 11
VC
VEE
CE
TE
VC
IC181 MC14052BF
• MIC Board
16 VDD
2X0
1
2X2
2
2XCOM
3
14 X1
2X3
4
13 XCOM
IC851 M65850P
LPF2IN
LPF2OUT
IC602 UPC1330HA
OP2OUT
15 X2
OP2IN
• AUDIO Board
14
13
12
11
10
9
8
OSCILLATOR
12 X0
2X1 5
D/A
LPF2
1/2 VCC
INVERTER
INH
6
11 X3
VEE
7
10 A
VSS
8
9
DO1
CLOCK
AUTO
RESET
RESET
MAIN
CONTROL
D1
DO0
MO
20KBIT
SRAM
MI
B
COMPARATOR
A/D
75Ω
8db
LOGIC
54
1
2
3
4
5
54
6
7
8
9
10
VOUT
7
GND
SW R2
6
CC2
GND
5
CC1
SW P2
4
OP1IN
VCC
3
OP1OUT
GND
2
LPF1OUT
CONT
1
LPF1IN
SW P1
MUTE
IN4
GND
IC191 BA7615N
CTLC
9
IN3
8
VCC
7
IN2
6
CTLC
5
CTLB
4
IN1
3
CTLA
2
SW R1
LPF1
1
15 CAP
13 VCA
AGND 12
REF
VC
FE
SE
SFDR
SRDR
38 39 40
TES1
TES1
DVDD1
35 36 37
DVSS1
SSTP
FST0
TFDR
TRDR
FFDR
FRDR
29 30 31 32 33 34
16 ZERO
E 11
• MAIN Board (1/3)
28
OPEN
14 VOUTL
DIGITAL
PLL
26 27
18 DATA
17 BCK
MODE
CONTROL
F 10
46
45
44
43
42
41
DGND
VDD
SCKO1
SCKO2
19 LRCK
AUDIO
DATA INPUT
INTERFACE
14 FE
CLTV
50 RFAC
49 ASY1
48 ASY0
23
22
21
20
POWER
SUPPLY
ERROR AMP
FOCUS
47 AVDD
SERVO DSP
FOCUS SERVO
RF_EQ_AMP
VC
PGND 2
VCP 3
15 RFE
PCO
FIL1
FIL0
51 AVSS1
C4M 16
WDCK 17
COUT 19
VCC
21 HOLD_SW
20 AGCCONT
(50%/30%
OFF)
61
ERROR
CORRECTOR
8
9
10
11
12
13
14
15
VC
PD
62 ASYE
D/A
INTERFACE
CPU
INTERFACE
APC LD AMP
64 DOUT
63 MD2
CLOCK
SCLK
ATSK
WFCK
XUGF
XPCK
GFS
C2P0
SCOR
4
5
6
7
VREF
3
LD
VCC
DATA
XLAT
CLOK
SENS
AGCVTH 2
65 LRCK
VDD 1
XRST 2
• PANEL FL Board
IC603 BA3830F
R02 1
REFFERENCE
CURRENT
P01 2
REFFERENCE
CURRENT
17 f01
LINE 3
NF
LINE
4
IN
BPF
DET
BPF
DET
BPF
DET
BPF
DET
BPF
DET
BPF
DET
16 f02
15 f03
REC 5
NF
REC 6
IN
14 f04
13 f05
RESET 7
C
BIAS 8
C
18 RESET
RESET
12 f06
DET
11 REC
LEVEL
Bias
GND1 9
10 VCC
• PANEL VR Board
IC604 NJU3716L
12 SO
11 P16
DATA 13
10 P15
9 P14
CLK 14
8 P13
4
P10
3
P9
2
P8
1 P7
17 18 19
20
21
22
23
24
P3
P4
P5
P6
VDD
CONTROL
P1
GND
P2
STB 15
CLR 16
LATCH
SHIFT REGISTER
7 P12
6 GND
5 P11
55
7-32. IC PIN FUNCTIONS
• IC101 DIGITAL SIGNAL PROCESSOR (CXD3008Q) (BD Board)
Pin No.
1
56
Pin Name
DVDD0
I/O
—
Function
Digital power supply
2
XRST
I
System reset
3
MUTE
I
Muting selection pin
4
DATA
I
Serial data input, supplied from CPU
5
XLAT
I
Latch input, supplied from CPU
6
CLOK
I
Serial data transfer clock input, supplied from CPU
7
SENS
O
SENS output
8
SCLK
I
SENS serial data read-out clock
9
ATSK
I/O
10
WFCK
O
Input pin for anti-shock (Ground)
WFCK (Write Frame Clock) output (Not used)
11
XUGF
O
XUGF output (Not used)
12
XPCK
O
XPCK output (Not used)
13
GFS
O
GFS output (Not used)
14
C2P0
O
C2PO output
15
SCOR
O
Sub-code sync output
16
CM4
O
4.2336MHz output (Not used)
17
WDCK
O
48-bit slot D/A interface word clock (Not used)
18
DVSS
—
Digital ground
19
COUT
O
Numbers of track counted signal output (Not used)
20
MIRR
O
Mirror signal output (Not used)
21
DFCT
O
Defect signal output (Not used)
22
FOK
O
Focus OK output (Not used)
23
PWM1
I
(Not used)
24
LOCK
I/O
GFS in sampled by 460Hz (Not used)
25
MDP
O
Output to control spindle motor servo
26
SSTP
I
Input signal to detect disc inner most trak
27
FST0
O
2/3 divider output (Not used)
28
DVDD1
—
Digital power supply
29
SFDR
O
30
SRDR
O
31
TFDR
O
32
TRDR
O
33
FFDR
O
34
FRDR
O
35
DVSS1
—
Sled drive output
Tracking drive output
Focus drive output
Digital ground
36
TEST
I
37
TES1
I
38
VC
I
Center voltage input
39
FE
I
FOCUS error signal input
40
SE
I
Sled error signal input
TEST pin connected normally ground
TE
I/O
I
Tracking error signal input
42
CE
I
Center servo analog input
43
RFDC
I
RF signal input
44
ADI0
O
Test pin (Not used)
45
AVSS0
—
Analog ground
46
IGEN
I
47
AVDD
—
Analog power supply
48
ASYO
O
EFM full swing output
49
ASYI
I
Asymmetry comparate voltage input
50
RFAC
I
EFM signal input
51
AVSS1
—
52
CLTV
I
53
FILO
O
Filter output for master PLL
54
FILI
I
Filter input for master PLL
55
PCO
O
Charge-pump output for master PLL
56
AVDD1
—
Analog power supply
57
BIAS
I
Asymmetry circuit constant current input
58
VCTL
I
Control voltage input for variable pitch PLL
59
V16M
I/O
60
VPCO
O
Charge-pump output for variable pitch PLL (Not used)
61
DVDD2
—
Digital power supply
62
ASYE
I
Asymmetry circuit ON/OFF
63
MD2
I
Digital-out ON/OFF control
64
DOUT
O
Digital-out output
65
LRCK
O
48-bit slot D/A interface, LR clock output
66
PCMD
O
48-bit slot D/A interface, Serial deta output
67
BCLK
O
48-bit slot D/A interface, bit clock output
68
EMPH
O
Playback disc output in emphasis mode (Not used)
X’tal selection input pin
Pin No.
41
Pin Name
Function
Power supply pin operational amplifiers
Analog ground
Control voltage input for master VCO
16.9344MHz output (Not used)
69
XTSL
I
70
DVSS2
—
71
XTAI
I
X’tal oscillator circuit input
72
XTAO
O
X’tal oscillator circuit output (Not used)
73
SOUT
O
74
SOCK
O
75
XOCT
O
76
SQSO
O
Sub-Q serial output
77
SQCK
I
Clock input for SQSO read-out
78
SCSY
I
Sub-code input
79
SBSO
O
Sub-P through Sub-W serial output (Not used)
80
EXCR
I
Clock input for SBSO read-out
Digital ground
(Not used)
57
• IC502 MPEG DECODER, MECHANISM CONTROL (M30620MC-A17FP) (VIDEO Board (1/3))
Pin No.
1
Pin Name
SENSE
I/O
I
Function
Internal state (SENSE) monitor input (IC101)
2
SENSE CLK
O
Serial data reading clock output (IC101)
3
DSP DATA
O
Serial data output (IC101)
4
DSP LATCH
O
Lach output (IC101)
5
DSP CLK
O
Serial data clock output (IC101)
6
TSENS
I
Not used
7
REMOTE IN
I
Not used
8
BYTE
I
External bus width change input (Connected to ground)
9
VSS
–
Ground
10
DSP MUTE
O
Mute output (IC101) “H” : mute
11
CTRL1 (L : DOUBLE)
O
Double change output (IC101) “L” : double
12
XRESET
I
System reset input “L” : reset
13
XOUT
O
Main clock output (10MHz)
14
VSS
–
Ground
15
XIN
I
Main clock input (10MHz)
16
VCC
–
+5V power supply
17
NMI
I
Requests mask disable interruption input (Connected to +5V)
18
SCOR
I
Subcode sync input (IC101)
19
D SENS
I
Not used
20
CL680 INT
I
Video CD interruption input (IC505)
21
CL680 HSEL
O
Video CD select data of the host MPU (IC505)
22
DF LATCH
O
Digital filter latch output (IC509)
23
CL680 HRDY
I
Ready signal input for communication to the host MPU (IC505)
24
680 RESET
O
Video CD reset output (IC505) “L” : reset
25
JOG1
I
Not used
26
JOG2
I
Not used
27
CTRL2
O
Double control output (IC101) “H” : double
28
LD ON
O
Laser diode ON/OFF output
29
IIC1
I/O
IIC clock input from master control
30
IIC0
I/O
IIC data input from master control
31
DATA1O
O
Serial 1 data output (IC505, 509)
32
DATA1I
I
Serial 1 data input (IC505, 509)
33
CLK1
O
Serial 1 clock output
34
SHARPNESS
O
Sharpness output L : normal, H : sharpness
35
XVLEVEL. DOWN
O
Fix the video signal output level output
36
SUBQ DATA
I
Serial 2 data input for subcode sync reading
37
SUBQ CLK
I
Serial 2 clock input for subcode sync reading
38
P. ON
I
Not used
39
BUS XRDY
I
Not used
40
BUS
I
Not used
41
BUS XHOLD
I
Not used
BUS
I
Not used
44
BUS XRD
I
Model selection input “L” : chinese model, “H” : except chinese model
45
BUS
I
V sync signal input
42, 43
58
Pin No.
46
Pin Name
BUS XWRL
I/O
I
Not used
Function
47
LO. BOOST
I
Not used
48
AUDIO MUTE
O
Audio mute output “L” : mute
49
LOAD OUT
I
Not used
50
LOAD IN
I
Not used
51
INSW
I
Not used
52
OUTSW
I
Not used
53
MODEL 1
I
L : System input (Fixed at “L”)
54
MODEL 2
I
L : System input (Fixed at “L”)
55
TBLL
I
Not used
56
TBLR
I
Not used
57
ENC 1
I
Not used
58
ENC 2
I
Not used
59
ENC 3
I
Not used
60
—
I
Not used
61
—
I
Not used
62
VCC
–
+5V power supply
63
—
I
Not used
64
VSS
–
Ground
65
A7
O
Video mute output “L”
66 to 71
A6 to A1
I
Not used
U to I
I
IIC convertion microcomputor transmittion input
73
TEST LED
O
TEST LED for MPEG decoder
74
TEST 1
I
Test mode for Video CD check
75
TEST 2
I
Test mode for servo check
76
TEST 3
I
Not used
77
DEVICE RESET
O
Device system rest output “L” : reset
78
STANDBY
I
Not used
79
FL CS
I
Not used
80
FL
I
Not used
D7 to D0
I
Not used
72
81 to 88
89
MIC CTRL
I
Not used
90
KEY 1
I
Not used
91
KEY 2
I
Not used
92
KEY 3
I
Not used
93
NY/PAL
I
NTSC/PAL select switch input
94
MUSIC VOL
I
Not used
95
KEY 4
I
Not used
96
AVSS
–
A/D converter ground
97
MODE. SW
I
Not used
98
VREF
I
A/D converter reference voltage input (Connected to +5V)
99
AVCC
–
A/D converter +5V power supply
100
AMP. ON
I
Not used
59
• IC505 CD DECODER, SYSTEM CONTROL (CL680T-D1) (VIDEO Board (2/3))
Pin No.
1
NC
I/O
–
Not used
2
VSS
–
Ground
3
CD-BCK
I
CD Decode bit clock
4
CD-DATA
I
CD Decode data
5
CD-LRCK
I
CD Decode Left or Right channel selection clock
6
CD-C2PO
I
CD Decode C2 error data
7
NC
–
Not used
8
NC
–
Not used
60
Pin Name
–
Function
9
NC
10
MD0
I/O
Data bus between Microcode ROM/DRAM and CL680
Not used
11
MD1
I/O
Data bus between Microcode ROM/DRAM and CL680
12
MD2
I/O
Data bus between Microcode ROM/DRAM and CL680
13
MD3
I/O
Data bus between Microcode ROM/DRAM and CL680
14
MD4
I/O
Data bus between Microcode ROM/DRAM and CL680
15
MD5
I/O
Data bus between Microcode ROM/DRAM and CL680
16
VSS
–
17
MD6
I/O
Ground
Data bus between Microcode ROM/DRAM and CL680
18
VDD3
–
19
MD7
I/O
+3.3V Power supply
20
VSS
–
21
MD8
I/O
22
VDD3
–
23
MD9
I/O
Data bus between Microcode ROM/DRAM and CL680
24
MD10
I/O
Data bus between Microcode ROM/DRAM and CL680
25
MD11
I/O
Data bus between Microcode ROM/DRAM and CL680
26
MD12
I/O
Data bus between Microcode ROM/DRAM and CL680
27
MD13
I/O
Data bus between Microcode ROM/DRAM and CL680
28
MD14
I/O
Data bus between Microcode ROM/DRAM and CL680
29
MD15
I/O
Data bus between Microcode ROM/DRAM and CL680
30
NC
–
Not used
31
NC
–
Not used
32
NC
–
Not used
33
NC
–
Not used
34
NC
–
Not used
35
NC
–
Not used
36
NC
–
Not used
37
MCE
O
Chip enable signal to Microcode ROM
38
MWE
O
Write enable signal to DRAM
39
VSS
–
Ground
40
CAS
O
Column address strove : Latch the column address to DRAM
41
VDD3
–
+3.3V power supply
42
RAS0
O
Row address strove : Latch row address to DRAM
43
RAS1
–
Not used
44
MA10
O
Address data from CL680 to Microcode ROM
45
MA9
O
Address data from CL680 to Microcode ROM
Data bus between Microcode ROM/DRAM and CL680
Ground
Data bus between Microcode ROM/DRAM and CL680
+3.3V Power supply
Pin No.
46
MA8
I/O
O
47
VSS
–
Ground
48
MA7
O
Address data from CL680 to Microcode ROM/DRAM
49
VDD3
–
+3.3V Power supply
50
MA6
O
Address data from CL680 to Microcode ROM/DRAM
51
MA5
O
Address data from CL680 to Microcode ROM/DRAM
52
MA4
O
Address data from CL680 to Microcode ROM/DRAM
53
VSS
–
Ground
54
MA3
O
Address data from CL680 to Microcode ROM/DRAM
Pin Name
Function
Address data from CL680 to Microcode ROM/DRAM
55
VDD3
–
+3.3V Power supply
56
MA2
O
Address data from CL680 to Microcode ROM/DRAM
57
MA1
O
Address data from CL680 to Microcode ROM/DRAM
58
MA0
O
Address data from CL680 to Microcode ROM/DRAM
59
PGIO7
I/O
60
RESET
I
Not used
Reset signal input from the host MPU
61
VDDMAX-IN
I
Fix the maxium input voltage each input pin and I/O pin
62
NC
–
Not used
63
NC
–
Not used
64
NC
–
Not used
65
AGND DAC
–
Ground
66
AVDD DAC
–
+3.3V Power supply
67
COMPOS OUT
O
Not used
68
AGND DAC
–
Ground
69
Y-OUT
O
Luminance signal out
70
AVDD DAC
–
+3.3V Power supply
71
AGND DAC
–
Ground
72
RREF
I
Fix the video signal output level
73
(1.235V) VREF
O
Reference voltage (+1.235V)
74
AVDD DAC
–
+3.3V Power supply
75
C-OUT
O
Chrominance signal out
76
AGND DAC
–
Ground
77
(GCK INT) CLK SEL
I
GCK selection “H”; Internal, “L”; External
78
CLK SEL
I
DA-XCK selection (1)
79
CLK SEL
I
DA-XCK selection (2)
80
VSS
–
Ground
81
RESERVED
I
Selection the operation clock 42.336MHz
82
VDD3
–
+3.3V Power supply
83
DA-EMP
–
Not used
84
RESERVED
–
Not used
85
AGND PLL
–
Ground
86
DA-XCLK
I
Main reference clock input (16.9344MHz=384fs)
87
AVDD PLL
–
+3.3V
88
PGIO4
I/O
Not used
89
PGIO5
I/O
Not used
90
PGIO6
I/O
Not used
61
Pin Name
PGIO0
I/O
I/O
Not used
92
PGIO8
I/O
Not used
93
PGIO2/VSYNC/CSYNC
O
Vertical synchronized signal of video signal
94
AVDD PLL
–
+3.3V Power supply
95
NC
–
Not used
96
NC
–
Not used
97
NC
–
Not used
98
AGND PLL
–
Ground
Pin No.
91
62
Function
99
VSS
–
Ground
100
NC
–
Not used
101
PGIO3/HSYNC
I/O
Not used
102
VDD3
–
+3.3V Power supply
103
PGIO1/VCK-OUT
104
VSS
I/O
Not used
–
Ground
105
GCK
I
Not used
106
VCK-IN
I
Main clock for video signal processer
107
GCKOUT/DA-EMP
O
Not used
108
DA-LRCK
O
Digital Audio Left or Right channel selection clock
109
VDDMAX-OUT
O
Fix the maxium output voltage certain output pins (Connected to +5V)
110
DA-DATA
O
Digital Audio data
111
DA-BCK
O
Digital Audio bit clock
112
HD-OUT
O
Serial Data output from CL680 to the host MPU
113
HRDY
O
Ready signal CL680 is ready for communication to the host MPU
114
HINT
O
Request signal for interrupting the host MPU
115
CDG-SCK
116
VSS
–
Ground
117
HCK
I
Host clock : referance signal for the host bus interface
118
VDD3
–
+3.3V Power supply
I/O
Not used
119
HD-IN
I
Serial Data output ftom the host MPU to CL680
120
VDD3
–
+3.3V Power supply
121
HSEL
I
Select data or address of the host MPU
122
CDG-SDATA
I
Ground (Not used)
123
CDG-VFSY
I
Ground (Not used)
124
CDG-SOS1
I
Ground (Not used)
125
NC
–
Not used
126
NC
–
Not used
127
NC
–
Not used
128
NC
–
Not used
• IC501 MAIN CONTROL (M30622MA-A26FP) (MAIN BOARD (2/3))
Pin No.
1
Pin Name
POWER
I/O
O
Function
Power amp ON/OFF signal output
2
POWER
O
Power ON/OFF signal output
3
F-RELAY
O
Front speaker relay control output
4
REAR-RELAY
O
Rear speaker relay control output (Not used)
5
CD-POWER
O
CD power on signal output
6
LINE-MUTE
O
Line mute signal output
7
DBFB-H/L
O
DBFB H/L select signal output
8
–
–
Connected to ground
Connected to ground
9
–
–
10
XC-IN
I
11
XC-OUT
O
12
RESET
I
System reset signal input
13
X-OUT
O
X’tal (16MHz) (MAIN SYSTEM CLOCK)
14
VSS
–
Ground
15
X-IN
I
X’tal (16MHz) (MAIN SYSTEM CLOCK)
16
VDD
–
Power supply (+5V)
17
NMI
I
Not used
18
WAKE UP
I
WAKE UP signal input
19
SCOR
I
CD Q-data request signal input
20
RDS-INT
I
RDS data interrupt input
21
RDS-DATA
I
RDS data interrupt input
22
AC-CUT
I
AC cut ON (L)/OFF (H) check
23
PL-CLK
O
Clock output to pro-logic (Not used)
24
PL-DATA
O
Data output to pro-logic (Not used)
25
PL-LAT
O
Latch signal output to pro-logic (Not used)
26
TIMER LED
O
Not used
X’tal (32.768 KHz) (SUB CLOCK)
27
PROTECT
I
Speaker protect signal input
28
V MUTE
O
Video mute signal output
29
IIC-CLK
O
I2C SCL
30
IIC-DATA
O
I2C SDA
31
–
–
Not used
32
SQ-DATA
I
Subcode Q data clock input (CD data)
33
SQ-CLK
I
Subcode Q data clock input (CD data clock)
34
SW-MODE
O
SW-MODE music/movie select signal output
35
CD-DATA
O
CD data output
36
H/P IN
I
Head phone detect
37
CD-CLK
O
CD clock output
38
493-LAT
O
Latch signal output for IC101 (M62493FP)
39
CLOCK-OUT
O
Clock out signal check
40
NO-USE
–
Not used
41
NO-USE
–
Not used
42
FL OFF
O
Fluorescent indicator tube filament on/off signal output
43
STBY RELAY
O
Main POWER on/off signal output
44
BASS FREQ
O
FREQ high/low signal output (Not used)
45
FUNC SEL 1
O
Function select signal output
46
FUNC SEL 0
O
Function select signal output
47
493-DATA
O
Data signal output for IC101 (M62493FP)
48
493-CLK
O
Clock signal output for IC101 (M62493FP)
49
ST-MUTE
O
Tuner mute signal output
63
Pin No.
50
64
Pin Name
STEREO
I/O
I
Stereo detection for tuner
Function
51
TUNED
I
Tuned detection for tuner
52
ST-CE
O
Tuner chip enable output
53
ST-DOUT
O
Tuner data output
54
ST-DIN
I
Tuner data input
55
ST-CLK
O
Tuner clock output
56
SENS
I
BD Condition signal input
57
HOLD
O
MODE signal output
58
XLT
O
CD latch signal output
59
XRST
O
CD reset signal output
60
DISC-SENS
I
Slit sensor of disc table input (Connected to ground)
61
T-SENS
I
CD table detection signal input
62
VDD
–
Power supply (+5V)
63
TBL-L
O
Table motor control output
64
VSS
I
Ground
65
TBL-R
O
Table motor control output
66
LOAD-OUT
O
Loading motor control signal output (Not used)
67
LOAD-IN
O
(not used)
68
ENC 3/UP-SW
I
Disc tray address detect encoder input
69
ENC 2/DISC-LED
O
Disc tray address LED drive signal output
70
ENC 1
I
(Connected to ground)
71
OUT-OPEN
O
(Connected to ground) Loading out detection signal output
72
B-TRG
O
B deck trigger motor control output
73
A-TRG
O
A deck trigger motor control output
74
CAP-M-COT2
O
Capstan motor REW/FWD/STOP signal output
75
CAP-M-COT1
O
Capstan motor REW/FWD/STOP signal output
76
CAP-M-H/L
O
Capstan motor High/Low speed select signal output
77
AMS-IN
I
AMS signal input
78
TC-MUTE
O
TC line mute ON/OFF selection output
79
R/PB/PAS
O
REC/PB/PASS selection output
80
NR-ON/OFF
O
DOLBY NR ON/OFF signal output
81
REC-MUTE
O
REC mute ON/OFF selection output
82
BIAS
O
Bias ON/OFF signal output
83
EQ-H/N
O
Equalizer High/Normal select output
84
PB-A/B
O
PB A deck/B deck select output
85
ALC
O
ALC ON/OFF output signal
86
B-PLAY-SW
I
B deck play detect
87
A-PLAY-SW
I
A deck play detect
88
A-HALF
I
A Deck half detector signal input
89
B-HALF
I
B Deck half detector signal input
90
B-SHUT
I
B Deck reel pulse detector
91
A-SHUT
I
A Deck reel pulse detector
92
SOFT-TEST
O
Software test port (Not used)
93
HP-MUTE
O
Head phone mute signal output
94
KEY/CD-ADJ
I
KEY (use the jig)/CD adjust point port
95
MODEL IN
I
MODEL input
96
AVSS
–
Analog ground
97
SPEC-IN
I
Specifications input
98
VREF
I
Analog reference voltage input
99
AVCC
–
Analog power supply (+5V)
100
TC-RELAY
O
REC/PB head selection output for IC602
• IC601 DISPLAY CONTROL (TMP88CS76F-1A25) (PANEL FL BOARD)
Pin No.
1
Pin Name
SIRCS
I/O
I
I
Function
Remote commander signal input
2
JOG A
Rotary encoder (S701) pulse input
3
LED SCK
O
LED clock signal output
4
LED LATCH
O
LED latch signal output
5
LED DAT
O
LED serial data output
6
LED POWER
–
Not used
7
LED SEL
O
LED select signal output
8
JOG B
I
Rotary encoder (S701) pulse input
9
VOLUME A
I
10
VOLUME B
I
11 to 15
KEY 0 to KEY 4
I
Key input
16 to 20
Rotary encoder (S701) pulse input
BPF 0 to BPF 4
I
Rec level signal input
21
ALL BAND
O
Rec level signal output for auto DBDF
22
WAKE UP
O
Gradation right/WAKE UP signal output
23
Vss
–
24
VAss
–
25
VAref
I
Analog reference voltage input
26
VDD
–
Power supply (+5V)
GR 3 to GR 16
O
FL gride signal output
VDD VFT
–
Power supply (+5V) for VFT
27 to 40
41
42, 43
Ground
GR 1, GR 2
O
FL gride signal output
SEG 0
O
FL segment signal output (Not used)
SEG 1 to SEG 23
O
FL segment signal output
Vkk
–
Power supply (-35V) for FL segment signal output
69
Vdd
–
Power supply (+5V)
70
X in
I
X’tal (12.5MHz)
44
45 to 67
68
71
Vss
–
Ground
72
X out
O
X’tal (12.5MHz)
73
RESET
I
Reset signal input from main controller
74
DAILY LED
O
75
REC LED
O
76
TEST
I
Connected ground
77
LED-ECO
O
LED driver output
78
I2C DATA
I
I2C SDA input from master controller
2
LED driver output
79
I C CLK
I
I2C SCL input from master controller
80
D-SW
I
Door switch signal input
65
SECTION 8
EXPLODED VIEWS
NOTE:
• Items marked “*” are not stocked since they are
seldom required for routine service. Some delay
should be anticipated when ordering these items.
• The mechanical parts with no reference number in
the exploded views are not supplied.
• Hardware (# mark) list and accessories and packing materials are given in the last of this parts list.
• Abbreviation
SP
: Singapore model
EA
: Saudi Arabia model
MY
: Malaysia model
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
8-1. CASE AND BACK PANEL SECTION
#1
5
#1
#1
#1
4
3
#3
#2
#3
#3
4
4
4
#3
#3
6
#3
#3
#3
#3
#3
7
7
6
1
2
M901
#3
FRONT PANEL
#3
Ref. No.
1
2
3
3
4
66
Part No.
Description
1-769-977-11
1-693-488-11
4-227-751-21
4-227-751-31
3-363-099-01
WIRE(FLAT TYPE) (13 CORE)
TUNER(FM/AM)
PANEL, BACK (MY,SP)
PANEL, BACK (EA)
SCREW(CASE 3 TP2)
Remark
Ref. No.
5
6
7
M901
Part No.
Description
4-214-777-51
4-225-517-01
4-951-620-01
1-763-072-11
CASE
HOLDER (CASE)
SCREW (2.6X8), +BVTP
FAN, D.C.
Remark
8-2. FRONT PANEL SECTION 1
69
67
69
69
69
69
65
63
68
69
66
69
not supplied
69
69
68
69
61
FL601
not supplied
64
60
69
54
69
69
59
62
58
53
57
69
56
69
70
69
71
51
69
52
55
FRONT PANEL
Ref. No.
Part No.
Description
51
52
53
54
55
4-225-501-01
4-948-236-21
4-225-502-11
1-773-150-11
1-676-275-11
KNOB(VOL)
CUSHION (107)
KNOB(MIC)
WIRE(FLAT TYPE) (21 CORE)
TC-B BOARD
56
57
58
59
60
1-676-281-11
4-226-883-01
4-226-881-01
4-226-882-01
4-226-880-01
HEADPHONE BOARD
COVER (EJECT)
LEVER (EJECT-B)
LEVER (EJECT-C)
LEVER (EJECT-A)
61
4-226-889-01 SPRING (LEVER)
Remark
Ref. No.
Part No.
Description
62
63
64
65
A-4428-116-A
4-225-511-01
1-751-688-11
A-4428-159-A
PANEL VR BOARD, COMPLETE
HOLDER (FL)
WIRE(FLAT TYPE) (13 CORE)
PANEL FL BOARD, COMPLETE
66
67
* 68
69
70
1-676-274-11
A-4428-233-A
4-949-935-81
4-951-620-01
4-226-887-01
TC-A BOARD
MIC BOARD, COMPLETE
CUSHION (FL)
SCREW (2.6X8), +BVTP
KNOB (EJECT-A)
71
FL601
Remark
4-226-888-01 KNOB (EJECT-B)
1-517-940-11 INDICATOR TUBE, FLUORESCENT
67
8-3. FRONT PANEL SECTION 2
120
118
119
120
115
113
116
117
112
#3
#3
107
112
121
114
#3
#3
#3
111
107
121
#3
110
121
107
108
not supplied
121
106
121
102
121
105
103
109
101
104
121
Ref. No.
Part No.
Description
101
102
103
104
105
X-4952-528-1
4-225-524-01
4-040-472-01
A-4428-119-A
X-4952-463-1
LID(CD) ASSY
SPRING (CD)
LATCH, D.C.
CD-R BOARD, COMPLETE
PANEL (CD) ASSY, SUB
106
107
108
109
110
4-225-503-01
4-224-104-21
A-4428-176-A
1-676-276-11
4-226-062-11
KNOB (CD)
DAMPER
CD-L BOARD, COMPLETE
FRONT INPUT BOARD
PLATE, ORNAMENTAL
111
X-4952-504-1 LID(TC) ASSY
68
Remark
Ref. No.
Part No.
Description
112
113
114
115
4-225-521-01
X-4952-626-1
4-225-523-01
4-225-510-01
SPRING (TC-LID)
PANEL ASSY, FRONT
SPRING (DECK-B)
HOLDER (DECK-B)
116
117
118
119
120
X-4952-465-1
4-225-522-01
4-225-509-01
X-4952-464-1
4-959-229-11
HOLDER (DECK-B) ASSY
SPRING (DECK-A)
HOLDER (DECK-A)
HOLDER (DECK-A) ASSY
DETENT, CASSETTE
121
4-951-620-01 SCREW (2.6X8), +BVTP
Remark
8-4. CHASSIS SECTION
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
#3
not supplied
#4
161
#3
160
not supplied
T951
163
#3
159
162
#8
#3
not supplied
#3
154
158
#3
CDM37M-5BD32L
#3
#3
156
not supplied
157
153
#3
not supplied
#3
not supplied
164
#3
166
165
#3
151
not supplied
#3
Ref. No.
Part No.
Description
151
153
* 154
156
157
X-4941-228-1
1-790-660-11
4-988-533-01
1-773-056-11
A-4428-161-A
FOOT (F22125H-M)
WIRE (FLAT TYPE) (23 CORE)
HOLDER, PWB
WIRE (FLAT TYPE) (17 CORE)
MAIN BOARD, COMPLETE
158
159
160
1-773-032-11 WIRE (FLAT TYPE) (15 CORE)
A-4428-748-A PA BOARD, COMPLETE
3-703-244-00 BUSHING (FBS001), CORD
#3
#3
not supplied
Remark
Ref. No.
Part No.
Description
161
0 162
1-676-267-11 TRANS BOARD
1-569-008-21 ADAPTOR, CONVERSION 2P
0 163
164
165
* 166
0T951
1-777-071-51
1-790-288-11
A-4724-882-A
3-703-150-11
1-435-246-11
Remark
CORD,POWER
WIRE (FLAT TYPE) (13 CORE)
VIDEO BOARD, COMPLETE
CLAMP
TRANSFORMER, POWER
69
8-5. TC MECHANISM SECTION 1 (TCM230PWR12)
408
408
407
406
404
HP101
403
407
HRPE101
403 405
406
404
405
409
402
402
401
Ref. No.
Part No.
Description
401
402
403
404
405
3-376-464-11
3-911-116-42
3-016-574-01
X-3374-156-4
X-3374-155-4
SCREW(+PTT 2.6X6),GROUND POINT
RIVET, PUSH
SPRING (HEAD), TENSION
PINCH LEVER (REV) ASSY
PINCH LEVER (FWD) ASSY
406
3-017-365-01 BASE (PINCH LEVER FWD)
Remark
Ref. No.
407
408
409
HP101
Part No.
Description
3-017-366-01
3-016-567-02
A-2007-849-A
A-2004-765-A
BASE (PINCH LEVER REV)
SPRING (CASSETTE), LEAF
AUDIO BOARD, COMPLETE
BASE (A) ASSY, HEAD
HRPE10 A-2004-766-A BASE (B) ASSY, HEAD
70
Remark
8-6. TC MECHANISM SECTION 2 (TCM230PWR12)
451
465
461
463
462
466
460
455
463
458
#11
460
452
456
464
458
454
452
M1
457
453
not supplied
Ref. No.
Part No.
Description
451
452
453
454
455
X-4952-881-1
3-041-946-01
4-227-239-01
X-3378-247-1
X-3378-249-1
CHASSIS ASSY, MAIN
BELT (CAPSTAN B)
BELT (CAPSTAN C)
FLYWHEEL (A-FWD) ASSY
FLYWHEEL (B-FWD) ASSY
456
457
458
X-3378-250-1 FLYWHEEL (B-REV) ASSY
X-3378-248-1 FLYWHEEL (A-REV) ASSY
3-041-947-01 BELT (FR)
Remark
Ref. No.
Part No.
Description
460
461
3-016-566-01 SLIDER, REVERSE
A-2007-852-A LEAF SW BOARD, COMPLETE
462
463
464
465
466
4-228-450-01
3-019-208-01
A-2004-752-A
1-454-887-21
A-2004-753-A
Remark
SPRING(REVERSE SLIDER),TORSION
WASHER, STOPPER
BLOCK (A) ASSY, MECHANICAL
SOLENOID, PLUNGER
BLOCK (B) ASSY, MECHANICAL
71
8-7. CD MECHANISM SECTION (CDM37L-5BD34L)
501
508
501
505
511
504
507
#3
not
supplied
506
510
509
502
501
510
523
510
503
525
512
522
524
518
502
518
M201
517
#3
not
supplied
519
519
515
516
#3
511
520
#3
Ref. No.
514
Part No.
Description
4-987-976-01
4-944-490-01
A-4660-978-A
4-978-421-01
4-978-425-01
SCREW, STEP
BELT (TIMING)
GEAR (PULLEY) ASSY
GEAR (MID)
ROLLER (CAM)
506
507
508
509
510
4-978-420-01
1-452-925-21
4-978-417-01
4-993-142-03
X-4947-960-1
CAM(HOLDER)
MAGNET ASSY
TABLE, DISC
PULLEY (L), PRESS
ROLLER ASSY
72
521
#3
501
502
503
504
505
* 511
512
* 514
#3
4-978-583-01 BRACKET (BU)
4-978-418-01 CHASSIS
A-4673-765-A CD MOTOR BOARD, COMPLETE
Remark
Ref. No.
Part No.
515
* 516
4-978-426-01 INDICATOR (NO.)
1-659-059-13 LED BOARD
* 517
518
519
* 520
521
1-659-058-13
4-985-672-01
4-958-593-01
4-978-419-01
4-998-716-01
TABLE SENSOR BOARD
SCREW (+PTPWHM2.6), FLOATING
SPRING (BU), COMPRESSION
HOLDER (BU-5)
SCREW, BU FITTING
4-989-493-01
4-989-494-01
4-989-819-02
4-989-491-01
A-4660-977-A
SLIDER (37)
SCREW (SLIDER), STEP
SPRING, TENSION
COVER, LENS
MOTOR ASSY
522
523
524
525
M201
Description
Remark
8-8. BASE UNIT SECTION (BU-5BD34L)
601
602
609
603
605
M101
604
M102
604
606
607
608
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Ref. No.
Part No.
Description
0 601
602
603
604
605
8-820-020-02
1-769-069-11
4-917-567-21
4-951-940-01
4-917-565-01
OPTICAL PICK-UP KSS-213D/Q-NP
WIRE (FLAT TYPE) (16 CORE)
GEAR (M)
INSULATOR (BU)
SHAFT, SLED
606
4-917-564-01 GEAR (P), FLATNESS
Remark
Ref. No.
Part No.
Description
607
608
609
M101
A-4724-653-A
4-951-620-01
3-713-786-51
X-4917-504-1
BD BOARD, COMPLETE
SCREW (2.6X8), +BVTP
SCREW +P 2X3
MOTOR ASSY (SLED)
M102
M201
X-4917-523-3 MOTOR ASSY (SPINDLE)
A-4660-977-A MOTOR ASSY
Remark
73
SECTION 9
ELECTRICAL PARTS LIST
AUDIO
Note:
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
When indicating parts by reference
number, please include the board
name.
Ref. No.
Part No.
• Due to standardization, replacements in the parts list
may be different from the parts specified in the
diagrams or the components used on the set.
• -XX, -X mean standardized parts, so they may have
some difference from the original one.
• Items marked “*” are not stocked since they are
seldom required for routine service. Some delay
should be anticipated when ordering these items.
• RESISTORS
All resistors are in ohms
METAL: Metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F : nonflammable
Description
Remark
Ref. No.
Part No.
A-2007-849-A AUDIO BOARD, COMPLETE
********************
IC601
IC602
IC611
C301
C302
C303
C304
C305
1-162-289-31
1-126-968-11
1-162-282-31
1-130-483-00
1-107-715-11
CERAMIC
ELECT
CERAMIC
MYLAR
ELECT
390PF
100uF
100PF
0.01uF
22uF
10.00%
20.00%
10%
5%
20.00%
50V
6.3V
50V
50V
16V
C311
C313
C314
C315
C331
1-162-289-31
1-162-282-31
1-130-487-00
1-126-233-11
1-137-427-11
CERAMIC
CERAMIC
MYLAR
ELECT
MYLAR
390PF
100PF
0.022uF
22uF
120PF
10.00%
10%
5%
20%
5.00%
50V
50V
50V
50V
50V
C332
C333
C401
C402
C403
1-162-288-31
1-162-209-31
1-162-289-31
1-126-968-11
1-162-282-31
CERAMIC
CERAMIC
CERAMIC
ELECT
CERAMIC
330PF
27PF
390PF
100uF
100PF
10%
5.00%
10.00%
20.00%
10%
50V
50V
50V
6.3V
50V
C404
C405
C411
C413
C414
1-130-483-00
1-107-715-11
1-162-289-31
1-162-282-31
1-130-487-00
MYLAR
ELECT
CERAMIC
CERAMIC
MYLAR
0.01uF
22uF
390PF
100PF
0.022uF
5%
20.00%
10.00%
10%
5%
50V
16V
50V
50V
50V
C415
C431
C432
C433
C601
1-126-233-11
1-136-434-11
1-162-288-31
1-162-209-31
1-104-396-11
ELECT
FILM
CERAMIC
CERAMIC
ELECT
22uF
120PF
330PF
27PF
10uF
20%
5.00%
10%
5.00%
20.00%
50V
630V
50V
50V
16V
C602
C611
C612
C621
C622
1-104-396-11
1-104-396-11
1-104-396-11
1-137-150-11
1-126-961-11
ELECT
ELECT
ELECT
FILM
ELECT
10uF
10uF
10uF
0.01uF
2.2uF
20.00%
20.00%
20.00%
5.00%
20.00%
16V
16V
16V
100V
50V
C623
C624
C625
C627
C628
1-136-155-00
1-130-481-00
1-130-481-00
1-124-903-11
1-136-153-00
FILM
MYLAR
MYLAR
ELECT
FILM
0.015uF
0.0068uF
0.0068uF
1uF
0.01uF
5%
5%
5%
20.00%
5%
50V
50V
50V
50V
50V
C642
1-104-664-11 ELECT
47uF
20.00% 16V
< CONNECTOR >
74
Description
Remark
< IC >
< CAPACITOR >
CN601
• SEMICONDUCTORS
In each case, u: µ , for example:
uA...: µ A..., uPA...: µ PA..., uPB...: µ PB...,
uPC...: µ PC..., uPD...: µ PD...
• CAPACITORS
uF : µ F
• COILS
uH : µ H
• Abbreviation
SP
: Singapore model
EA : Saudi Arabia model
MY : Malaysia model
1-695-338-11 PIN, CONNECTOR (PC BOARD) 15P
8-759-111-44 IC uPC4570C-1
8-759-143-54 IC uPC1330HA
8-759-111-44 IC uPC4570C-1
< COIL >
L331
L431
1-410-780-11 INDUCTOR 27MH
1-410-780-11 INDUCTOR 27MH
< TRANSISTOR >
Q621
Q622
Q623
8-729-142-46 TRANSISTOR 2SC2001TP-LK
8-729-142-46 TRANSISTOR 2SC2001TP-LK
8-729-801-93 TRANSISTOR 2SD1387-34-TP
< RESISTOR >
R301
R302
R303
R304
R305
1-247-881-00
1-247-815-91
1-247-863-91
1-247-889-00
1-247-858-11
CARBON
CARBON
CARBON
CARBON
CARBON
120K
220
22K
270K
13K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R311
R312
R314
R315
R331
1-247-881-00
1-247-807-31
1-247-882-11
1-247-850-11
1-249-430-11
CARBON
CARBON
CARBON
CARBON
CARBON
120K
100
130K
6.2K
12K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R401
R402
R403
R404
R405
1-247-881-00
1-247-815-91
1-247-863-91
1-247-889-00
1-247-858-11
CARBON
CARBON
CARBON
CARBON
CARBON
120K
220
22K
270K
13K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R411
R412
R414
R415
R431
1-247-881-00
1-247-807-31
1-247-882-11
1-247-850-11
1-249-430-11
CARBON
CARBON
CARBON
CARBON
CARBON
120K
100
130K
6.2K
12K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R601
R602
R608
R609
R611
1-247-815-91
1-247-815-91
1-247-815-91
1-247-863-91
1-247-815-91
CARBON
CARBON
CARBON
CARBON
CARBON
220
220
220
22K
220
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
1-247-815-91 CARBON
1-212-851-00 FUSIBLE
1-212-851-00 FUSIBLE
220
5.6
5.6
5%
5%
5%
1/4W
1/4W
1/4W
R612
0 R621
0 R622
AUDIO
Ref. No.
Part No.
Description
Remark
R623
R624
1-249-432-11 CARBON
1-249-432-11 CARBON
18K
18K
5%
5%
1/4W
1/4W
R625
1-249-429-11 CARBON
10K
5%
1/4W
Ref. No.
Part No.
1-238-598-11
1-238-598-11
1-241-768-11
1-238-598-11
1-238-598-11
RV441
1-241-768-11 RES, ADJ, CARBON 220K
Remark
< CONNECTOR >
CN101
CN102
1-770-706-11 CONNECTOR, FFC/FPC 23P
1-777-937-11 CONNECTOR, FFC/FPC 16P
< VARIABLE RESISTOR >
RV301
RV311
RV341
RV401
RV411
Description
BD
< IC >
RES, ADJ, CARBON 2.2K
RES, ADJ, CARBON 2.2K
RES, ADJ, CARBON 220K
RES, ADJ, CARBON 2.2K
RES, ADJ, CARBON 2.2K
IC101
IC102
IC103
IC104
8-752-397-42
8-759-549-28
8-752-085-51
8-759-398-25
IC
IC
IC
IC
CXD3008Q
BA5974FP-E2
CXA2568M-T6
TC7SH04F(TE85L)
< COIL >
L101
L102
< TRANSFORMER >
T621
1-414-234-22 INDUCTOR CHIP 0uH
1-410-377-31 INDUCTOR CHIP 4.7uH
1-423-980-11 TRANSFORMER, BIAS OSCILLATION
< TRANSISTOR >
**************************************************************
Q101
8-729-049-31 TRANSISTOR 2SB710-RTX
A-4724-653-A BD BOARD, COMPLETE
*****************
< RESISTOR >
< CAPACITOR >
C101
C102
C103
C105
C106
1-163-005-11
1-163-038-91
1-163-005-11
1-126-206-11
1-164-346-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
470PF
0.1uF
470PF
100uF
1uF
10%
C107
C108
C109
C110
C111
1-164-346-11
1-164-004-11
1-163-145-00
1-164-161-11
1-163-251-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.1uF
0.0015uF
0.0022uF
100PF
10%
5%
10%
5.00%
C112
C113
C115
C116
C117
1-163-038-91
1-163-038-91
1-126-607-11
1-126-607-11
1-126-209-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
0.1uF
0.1uF
47uF
47uF
100uF
25V
25V
20%
4V
20%
4V
20.00% 4V
C118
C119
C120
C121
C122
1-163-275-11
1-163-110-00
1-109-982-11
1-109-982-11
1-163-009-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
51PF
1uF
1uF
0.001uF
5.00%
5%
10.00%
10.00%
10%
C123
C124
C126
C130
C140
1-163-021-91
1-164-005-11
1-124-779-00
1-163-038-91
1-163-038-91
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.47uF
10uF
0.1uF
0.1uF
10.00% 50V
25V
20%
16V
25V
25V
C141
C151
C153
C154
C156
1-163-038-91
1-163-235-11
1-163-038-91
1-110-501-11
1-163-235-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
22PF
0.1uF
0.33uF
22PF
25V
5.00% 50V
25V
10.00% 16V
5.00% 50V
C157
C159
C161
C162
C170
1-163-009-11
1-163-017-00
1-163-038-91
1-128-065-11
1-163-038-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.001uF 10%
0.0047uF 5%
0.1uF
68uF
20.00%
0.1uF
50V
50V
25V
10V
25V
C171
1-163-038-91 CERAMIC CHIP
0.1uF
25V
10%
20%
50V
25V
50V
6.3V
16V
16V
25V
50V
100V
50V
50V
50V
10V
10V
50V
R101
R102
R103
R104
R105
1-216-077-91
1-216-097-91
1-216-077-91
1-216-085-00
1-216-073-00
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
15K
100K
15K
33K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R106
R107
R108
R109
R110
1-216-049-91
1-216-073-00
1-216-061-00
1-216-121-91
1-216-295-91
RES-CHIP
METAL CHIP
METAL CHIP
RES-CHIP
SHORT 0
1K
10K
3.3K
1M
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R112
R123
R124
R125
R126
1-216-049-91
1-216-073-00
1-216-097-91
1-216-037-00
1-216-037-00
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
1K
10K
100K
330
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R127
R131
R135
R136
R137
1-216-037-00
1-216-037-00
1-216-295-91
1-216-295-91
1-216-295-91
METAL CHIP
METAL CHIP
SHORT 0
SHORT 0
SHORT 0
330
330
5%
5%
1/10W
1/10W
R138
R143
R144
R145
R146
1-216-295-91
1-216-103-00
1-216-103-00
1-216-121-91
1-216-121-91
SHORT 0
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
180K
180K
1M
1M
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R147
R148
R149
R150
R154
1-216-041-00
1-216-001-00
1-216-003-11
1-216-073-00
1-216-025-91
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
470
10
12
10K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R155
R156
R157
R158
R159
1-216-025-91
1-216-025-91
1-216-025-91
1-216-111-00
1-216-089-91
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
RES-CHIP
100
100
100
390K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R161
R162
R171
R172
1-216-308-00
1-216-101-00
1-216-025-91
1-216-025-91
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
4.7
150K
100
100
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
75
BD
Ref. No.
CD MOTOR
Part No.
CD-L
CD-R
Description
Remark
Ref. No.
Part No.
Description
Remark
R173
1-216-025-91 RES-CHIP
100
5%
1/10W
R733
1-249-427-11 CARBON
6.8K
5%
1/4W F
R175
R203
R204
R205
R206
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-295-91
100
100
100
100
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R734
R735
R736
R745
1-249-429-11
1-249-431-11
1-249-434-11
1-249-408-11
10K
15K
27K
180
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
SHORT 0
CARBON
CARBON
CARBON
CARBON
< SWITCH >
< SWITCH >
S101
1-572-085-11 SWITCH, LEAF (LIMIT SW)
**************************************************************
A-4673-765-A CD MOTOR BOARD, COMPLETE
***********************
*
4-980-385-01 HOLDER (SW)
*
< CAPACITOR >
C201
C202
C203
1-126-964-11 ELECT
1-164-159-21 CERAMIC
1-126-964-11 ELECT
10uF
0.1uF
10uF
20.00% 50V
50V
20.00% 50V
S651
S652
S653
S654
S655
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (LOOP)
SWITCH, KEYBOARD (NON-STOP)
SWITCH, KEYBOARD (EDIT)
SWITCH, KEYBOARD (DISC 1)
SWITCH, KEYBOARD (DISC 2)
S656
S657
S658
S659
S691
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-587-11
SWITCH, KEYBOARD (DISC 3)
SWITCH, KEYBOARD (DISC 4)
SWITCH, KEYBOARD (DISC 5)
SWITCH, KEYBOARD (FLASH)
SWITCH, PUSH (1 KEY)(DOOR SW)
**************************************************************
A-4428-119-A CD-R BOARD, COMPLETE
********************
< CONNECTOR >
< CAPACITOR >
* CN201
1-568-947-11 PIN, CONNECTOR 9P
C613
C614
< IC >
IC201
8-759-365-94 IC TA8409S
CN703
1-249-427-11 CARBON
1-249-425-11 CARBON
< DIODE >
D700
6.8K
4.7K
5%
5%
8-719-056-13 DIODE SML79423C-TP15 (u)
1/4W F
1/4W F
< SWITCH >
S201
30.00% 16V
30.00% 16V
1-785-334-11 PIN, CONNECTOR (LIGHT ANGLE)8P
1-408-117-00 INDUCTOR 10uH
< RESISTOR >
R205
R206
0.01uF
0.01uF
< CONNECTOR >
< COIL >
L201
1-162-306-11 CERAMIC
1-162-306-11 CERAMIC
1-762-587-11 SWITCH, PUSH (1 KEY) (UP SWITCH)
< RESISTOR >
R737
R738
R739
R740
R741
1-249-420-11
1-249-422-11
1-247-843-11
1-249-425-11
1-249-427-11
CARBON
CARBON
CARBON
CARBON
CARBON
1.8K
2.7K
3.3K
4.7K
6.8K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
R751
R752
R753
R754
R755
1-247-843-11
1-249-425-11
1-249-427-11
1-249-429-11
1-249-431-11
CARBON
CARBON
CARBON
CARBON
CARBON
3.3K
4.7K
6.8K
10K
15K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W F
1/4W
1/4W
R756
R757
R758
R759
1-249-434-11
1-249-438-11
1-249-403-11
1-249-403-11
CARBON
CARBON
CARBON
CARBON
27K
56K
68
68
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W F
F
F
**************************************************************
A-4428-176-A CD-L BOARD, COMPLETE
*******************
< CAPACITOR >
C691
1-162-306-11 CERAMIC
0.01uF
30.00% 16V
< CONNECTOR >
CN812
1-785-332-11 PIN, CONNECTOR (LIGHT ANGLE)6P
< SWITCH >
< DIODE >
D641
8-719-058-04 DIODE SEL5223S-TP15 (NON-STOP)
< RESISTOR >
R729
R730
R731
R732
76
1-249-420-11
1-249-422-11
1-247-843-11
1-249-425-11
CARBON
CARBON
CARBON
CARBON
1.8K
2.7K
3.3K
4.7K
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W F
S667
S668
S669
S670
S671
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (NEXT)
SWITCH, KEYBOARD (PREV)
SWITCH, KEYBOARD (RETURN)
SWITCH, KEYBOARD (SELECT)
SWITCH, KEYBOARD (ACTIVE)
S676
S677
S678
1-762-875-21 SWITCH, KEYBOARD (M)
1-762-875-21 SWITCH, KEYBOARD (u)
1-762-875-21 SWITCH, KEYBOARD (m)
CD-R
Ref. No.
Part No.
FRONT INPUT
Description
Remark
S679
S680
1-762-875-21 SWITCH, KEYBOARD (DISK SKIP)
1-762-875-21 SWITCH, KEYBOARD (x)
S681
S682
S701
1-762-875-21 SWITCH, KEYBOARD (PLAY MODE)
1-762-875-21 SWITCH, KEYBOARD (REPEAT)
1-473-393-11 ENCODER, ROTARY (.AMS>)
HEADPHONE
Ref. No.
Part No.
LEAF SW
Description
LED
Remark
< CONNECTOR >
CN1001 1-568-860-21 SOCKET, CONNECTOR 17P
< DIODE >
D1001
D1002
**************************************************************
8-719-991-33 DIODE 1SS133T-77
8-719-991-33 DIODE 1SS133T-77
< IC >
1-676-276-11 FRONT INPUT BOARD
****************
IC1001
IC1002
< CAPACITOR >
C801
C802
C811
C812
C813
1-162-294-31
1-162-294-31
1-162-282-31
1-164-159-21
1-126-960-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
ELECT
0.001uF
0.001uF
100PF
0.1uF
1uF
< TRANSISTOR >
10%
10%
10%
50V
50V
50V
50V
20.00% 50V
Q1001
1-424-228-11 FILTER, NOISE
< JACK >
J804
1-764-592-41 JACK 3P (VIDEO 2)
< RESISTOR >
R801
R802
R803
R804
R805
1-249-417-11
1-249-437-11
1-249-417-11
1-249-437-11
1-247-804-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
47K
1K
47K
75
5%
5%
5%
5%
5%
8-729-029-56 TRANSISTOR DTA144ESA-TP
< RESISTOR >
< FILTER >
FL803
8-749-016-76 IC RPI-321
8-749-016-76 IC RPI-321
1/4W F
1/4W
1/4W F
1/4W
1/4W
R907
R1001
R1002
R1003
R1004
1-249-441-11
1-247-815-91
1-247-815-91
1-249-414-11
1-247-834-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
220
220
560
1.3K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W
R1005
R1006
R1007
R1008
1-247-818-91
1-247-864-11
1-247-852-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
300
24K
7.5K
1K
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
< VARIABLE RESISTOR >
RV1001 1-241-785-11 RES, ADJ, CARBON 10K (TAPE SPEED(NORMAL))
RV1002 1-241-785-11 RES, ADJ, CARBON 10K (TAPE SPEED(HIGH))
< SWITCH >
**************************************************************
1-676-281-11 HEADPHONE BOARD
**************
< CAPACITOR >
C891
C892
C893
1-162-294-31 CERAMIC
1-162-294-31 CERAMIC
1-164-159-21 CERAMIC
0.001uF
0.001uF
0.1uF
10%
10%
50V
50V
50V
S1001
S1002
S1003
S1004
S1005
1-570-953-11
1-570-953-11
1-771-333-11
1-771-536-11
1-771-536-11
SWITCH, PUSH (1 KEY) (DECK A PLAY)
SWITCH, PUSH (1 KEY) (DECK B PLAY)
SWITCH, LEAF (DECK A HALF)
SWITCH, LEAF (DECK A 120/70)
SWITCH, LEAF (DECK A REC)
S1006
S1008
S1009
1-771-333-11 SWITCH, LEAF (DECK B HALF)
1-771-536-11 SWITCH, LEAF (DECK B 120/70)
1-771-536-11 SWITCH, LEAF (DECK B REC)
< CONNECTOR >
**************************************************************
CN802
1-785-330-11 PIN, CONNECTOR (LIGHT ANGLE)4P
1-659-059-13 LED BOARD
********
*
< JACK >
J803
< DIODE >
1-770-226-41 JACK (LARGE TYPE)(PHONES)
D201
< RESISTOR >
R810
1-247-807-31 CARBON
100
5%
< TRANSISTOR >
1/4W
**************************************************************
Q201
R201
R202
R203
< CAPACITOR >
1-107-716-11 ELECT
33uF
8-729-119-78 TRANSISTOR 2SC2785TP-HFE
< RESISTOR >
A-2007-852-A LEAF SW BOARD, COMPLETE
**********************
C1001
8-719-032-98 DIODE SEL5820A-TP15
1-247-863-91 CARBON
1-249-411-11 CARBON
1-249-437-11 CARBON
22K
330
47K
5%
5%
5%
1/4W
1/4W
1/4W
20.00% 10V
**************************************************************
77
MAIN
Ref. No.
Part No.
Description
Remark
A-4428-161-A MAIN BOARD, COMPLETE
*******************
4-875-327-31 HEAT SINK
7-685-646-79 SCREW +BVTP
3X8
Part No.
Description
C311
C312
C313
C314
1-126-964-11
1-126-959-11
1-163-009-11
1-126-964-11
ELECT
ELECT
CERAMIC CHIP
ELECT
10uF
0.47uF
0.001uF
10uF
20.00%
20.00%
10%
20.00%
50V
50V
50V
50V
Remark
C315
C316
C317
C320
C333
1-126-963-11
1-104-665-11
1-104-665-11
1-163-005-11
1-163-017-00
ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
4.7uF
100uF
100uF
470PF
0.0047uF
20.00%
20.00%
20.00%
10%
5%
50V
10V
10V
50V
50V
C334
C351
C352
C353
C354
1-163-017-00
1-126-960-11
1-130-479-00
1-136-165-00
1-136-165-00
CERAMIC CHIP
ELECT
MYLAR
MYLAR
MYLAR
0.0047uF
1uF
0.0047uF
0.1uF
0.1uF
5%
20.00%
5%
5.00%
5.00%
50V
50V
50V
50V
50V
C355
C356
C357
C358
C359
1-126-964-11
1-126-960-11
1-126-959-11
1-126-964-11
1-137-194-81
ELECT
ELECT
ELECT
ELECT
MYLAR
10uF
1uF
0.47uF
10uF
0.47uF
20.00%
20.00%
20.00%
20.00%
5.00%
50V
50V
50V
50V
50V
C401
C411
C412
C413
C414
1-126-961-11
1-163-033-91
1-163-033-91
1-126-916-11
1-126-916-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
2.2uF
0.022uF
0.022uF
1000uF
1000uF
20.00% 50V
50V
50V
20.00% 6.3V
20.00% 6.3V
C415
C416
C431
C451
C510
1-163-005-11
1-126-925-11
1-163-038-91
1-126-961-11
1-163-233-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
470PF
470uF
0.1uF
2.2uF
18PF
10%
50V
20.00% 10V
25V
20.00% 50V
5.00% 50V
C511
C516
C562
C564
C598
1-163-235-11
1-163-038-91
1-163-038-91
1-104-665-11
1-163-038-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
22PF
0.1uF
0.1uF
100uF
0.1uF
5.00% 50V
25V
25V
20.00% 10V
25V
C599
C601
C602
C603
C604
1-104-665-11
1-163-003-11
1-163-251-11
1-163-251-11
1-126-961-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
100uF
330PF
100PF
100PF
2.2uF
20.00%
10%
5.00%
5.00%
20.00%
C605
C606
C607
C608
C609
1-130-479-00
1-130-473-00
1-136-159-00
1-163-031-11
1-126-933-11
MYLAR
MYLAR
MYLAR
CERAMIC CHIP
ELECT
0.0047uF
0.0015uF
0.033uF
0.01uF
100uF
5%
50V
5%
50V
5.00% 50V
50V
20.00% 16V
C651
C652
C653
C654
C655
1-163-003-11
1-163-251-11
1-163-251-11
1-126-961-11
1-130-479-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
MYLAR
330PF
100PF
100PF
2.2uF
0.0047uF
10%
5.00%
5.00%
20.00%
5%
C656
C657
C658
C659
C701
1-130-473-00
1-136-159-00
1-163-031-11
1-126-933-11
1-163-001-11
MYLAR
MYLAR
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.0015uF
0.033uF
0.01uF
100uF
220PF
5%
50V
5.00% 50V
50V
20.00% 16V
10%
50V
C702
C703
C721
C722
1-163-001-11
1-163-001-11
1-126-960-11
1-126-926-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
220PF
220PF
1uF
1000uF
10%
10%
20.00%
20.00%
TYPE2 N-S
< CAPACITOR >
C111
C112
C113
C114
C115
1-137-195-11
1-130-488-00
1-136-167-00
1-130-480-00
1-130-489-00
MYLAR
MYLAR
MYLAR
MYLAR
MYLAR
0.56uF
0.027uF
0.15uF
0.0056uF
0.033uF
5.00%
5%
5.00%
5%
5%
50V
50V
50V
50V
50V
C116
C117
C118
C119
C120
1-130-473-00
1-130-483-00
1-163-129-00
1-130-479-00
1-130-477-00
MYLAR
MYLAR
CERAMIC CHIP
MYLAR
MYLAR
0.0015uF
0.01uF
330PF
0.0047uF
0.0033uF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C121
C122
C123
C124
C125
1-126-964-11
1-163-006-11
1-136-169-00
1-136-169-00
1-126-964-11
ELECT
CERAMIC CHIP
MYLAR
MYLAR
ELECT
10uF
560PF
0.22uF
0.22uF
10uF
20.00%
10.00%
5.00%
5.00%
20.00%
50V
50V
50V
50V
50V
C131
C132
C135
C161
C162
1-104-664-11
1-104-664-11
1-126-964-11
1-137-195-11
1-130-488-00
ELECT
ELECT
ELECT
MYLAR
MYLAR
47uF
47uF
10uF
0.56uF
0.027uF
20.00%
20.00%
20.00%
5.00%
5%
16V
16V
50V
50V
50V
C163
C164
C165
C166
C167
1-136-167-00
1-130-480-00
1-130-489-00
1-130-473-00
1-130-483-00
MYLAR
MYLAR
MYLAR
MYLAR
MYLAR
0.15uF
0.0056uF
0.033uF
0.0015uF
0.01uF
5.00%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C168
C169
C170
C171
C172
1-163-129-00
1-130-479-00
1-130-477-00
1-126-964-11
1-163-006-11
CERAMIC CHIP
MYLAR
MYLAR
ELECT
CERAMIC CHIP
330PF
0.0047uF
0.0033uF
10uF
560PF
5%
5%
5%
20.00%
10.00%
50V
50V
50V
50V
50V
C173
C174
C175
C176
C177
1-136-169-00
1-136-169-00
1-126-964-11
1-130-493-00
1-130-483-00
MYLAR
MYLAR
ELECT
MYLAR
MYLAR
0.22uF
0.22uF
10uF
0.068uF
0.01uF
5.00%
5.00%
20.00%
5%
5%
50V
50V
50V
50V
50V
C181
C182
C183
C191
C192
1-163-038-91
1-163-038-91
1-163-038-91
1-163-031-11
1-163-038-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.01uF
0.1uF
C193
C301
C302
C303
C304
1-126-964-11
1-126-960-11
1-130-479-00
1-136-165-00
1-136-165-00
ELECT
ELECT
MYLAR
MYLAR
MYLAR
10uF
1uF
0.0047uF
0.1uF
0.1uF
20.00%
20.00%
5%
5.00%
5.00%
50V
50V
50V
50V
50V
C305
C306
C307
C308
C309
1-126-964-11
1-126-960-11
1-126-959-11
1-126-964-11
1-137-194-81
ELECT
ELECT
ELECT
ELECT
MYLAR
10uF
1uF
0.47uF
10uF
0.47uF
20.00%
20.00%
20.00%
20.00%
5.00%
50V
50V
50V
50V
50V
C310
1-163-005-11 CERAMIC CHIP
470PF
10%
50V
78
Ref. No.
25V
25V
25V
50V
25V
10V
50V
50V
50V
50V
50V
50V
50V
50V
50V
50V
50V
50V
10V
MAIN
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
C724
1-163-005-11 CERAMIC CHIP
470PF
10%
50V
D333
8-719-988-61 DIODE 1SS355TE-17
C725
C751
C752
C753
C772
1-126-960-11
1-163-001-11
1-163-001-11
1-163-001-11
1-163-038-91
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
220PF
220PF
220PF
0.1uF
20.00%
10%
10%
10%
50V
50V
50V
50V
25V
D334
D335
D336
D401
D501
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
C774
C777
C778
C782
C803
1-163-038-91
1-163-038-91
1-163-038-91
1-104-665-11
1-126-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.1uF
0.1uF
0.1uF
100uF
10uF
25V
25V
25V
20.00% 10V
20.00% 50V
D534
D801
D802
D803
D804
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
C804
C805
C806
C808
C902
1-136-165-00
1-136-165-00
1-126-916-11
1-109-953-11
1-126-939-11
MYLAR
MYLAR
ELECT
ELECT
ELECT
0.1uF
0.1uF
1000uF
2.2uF
10000uF
5.00%
5.00%
20.00%
20.00%
20.00%
50V
50V
6.3V
50V
16V
D805
D806
D807
D808
D911
8-719-988-61
8-719-988-61
8-719-988-61
8-719-210-33
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SS355TE-17
EC10DS2-TE12L5
1SS355TE-17
C903
C904
C905
C911
C912
1-126-964-11
1-126-964-11
1-126-924-11
1-126-964-11
1-126-916-11
ELECT
ELECT
ELECT
ELECT
ELECT
10uF
10uF
330uF
10uF
1000uF
20.00%
20.00%
20.00%
20.00%
20.00%
50V
50V
10V
50V
6.3V
D912
D931
D951
8-719-210-33 DIODE EC10DS2-TE12L5
8-719-210-33 DIODE EC10DS2-TE12L5
8-719-988-61 DIODE 1SS355TE-17
C913
C914
C921
C922
C932
1-104-665-11
1-104-656-11
1-126-964-11
1-126-964-11
1-126-964-11
ELECT
ELECT
ELECT
ELECT
ELECT
100uF
2200uF
10uF
10uF
10uF
20.00%
20.00%
20.00%
20.00%
20.00%
10V
6.3V
50V
50V
50V
FB411
FB412
FB413
FB415
C933
C934
C935
C936
C937
1-126-933-11
1-126-964-11
1-126-767-11
1-126-964-11
1-104-665-11
ELECT
ELECT
ELECT
ELECT
ELECT
100uF
10uF
1000uF
10uF
100uF
20.00%
20.00%
20.00%
20.00%
20.00%
16V
50V
16V
50V
10V
C938
C952
C953
C954
C955
1-126-933-11
1-126-943-11
1-126-964-11
1-126-964-11
1-126-924-11
ELECT
ELECT
ELECT
ELECT
ELECT
100uF
2200uF
10uF
10uF
330uF
20.00%
20.00%
20.00%
20.00%
20.00%
16V
25V
50V
50V
10V
C961
1-163-038-91 CERAMIC CHIP
Remark
< FERRITE BEAD >
1-414-772-11
1-414-772-11
1-414-551-11
1-414-772-11
FERRITE
FERRITE
FERRITE
FERRITE
0UH
0UH
0UH
0UH
< FILTER >
FL501
FL502
FL503
1-233-289-21 FILTER, EMI (SMD)
1-233-289-21 FILTER, EMI (SMD)
1-233-289-21 FILTER, EMI (SMD)
< IC >
0.1uF
< CONNECTOR >
CN303
CN304
CN411
CN412
CN431
1-784-776-11
1-784-778-11
1-750-745-11
1-785-321-11
1-784-774-11
CONNECTOR, FFC 15P
CONNECTOR, FFC 17P
CONNECTOR, FFC/FPC 13P
PIN, CONNECTOR (STRAIGHT) 9P
CONNECTOR, FFC 13P
CN441
CN452
* CN701
CN702
CN901
1-750-745-11
1-785-316-11
1-564-505-11
1-691-767-11
1-778-982-11
CONNECTOR, FFC/FPC 13P
PIN, CONNECTOR (STRAIGHT) 4P
PLUG, CONNECTOR 2P
PLUG (MICRO CONNECTOR) 5P
CONNECTOR, BOARD TO BOARD 13P
CN902
* CN903
1-778-982-21 CONNECTOR, BOARD TO BOARD 13P
1-564-506-11 PLUG, CONNECTOR 3P
IC101
IC181
IC191
IC301
IC501
8-759-571-54
8-759-009-06
8-759-571-53
8-759-495-26
8-759-653-44
IC
IC
IC
IC
IC
M62493FP
MC14052BFEL
BA7615N
HA12215F
M30622MA-A26FP
IC601
IC781
IC801
IC901
IC911
8-759-636-55
8-749-923-04
8-759-635-63
8-759-604-86
8-759-231-53
IC
IC
IC
IC
IC
M5218AFP-T1
TOTX178A (CD DIGITAL OUT)
M51943BSL-TP
M5F7807L
M5F7805L
IC921
IC931
IC932
IC933
IC951
8-759-231-53
8-759-604-38
8-759-701-79
8-759-604-86
8-759-604-90
IC
IC
IC
IC
IC
M5F7805L
M5F78M10L
NJM7812FA
M5F7807L
M5F7907L
25V
< JACK >
J701
J702
1-766-558-41 JACK, PIN 8P (PHONO,MD,VIDEO 1(AUDIO))
1-770-336-11 JACK, PIN 2P (VIDEO 1(VIDEO))
< JUMPER RESISTOR >
< DIODE >
D191
D192
D193
D194
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
JR1
JR2
JR3
JR4
JR5
1-216-295-91
1-216-296-91
1-216-296-91
1-216-295-91
1-216-295-91
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
79
MAIN
Ref. No.
Part No.
Description
JR6
JR7
JR8
JR9
JR10
1-216-296-91
1-216-296-91
1-216-296-91
1-216-295-91
1-216-296-91
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR11
JR181
JR182
JR192
JR519
1-216-296-91
1-216-295-91
1-216-295-91
1-216-295-91
1-216-295-91
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR532
JR533
JR556
JR594
JR703
1-216-295-91
1-216-295-91
1-216-295-91
1-216-295-91
1-216-295-91
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR907
JR911
JR921
1-216-295-91 SHORT 0
1-216-295-91 SHORT 0
1-216-296-91 SHORT 0
Remark
Ref. No.
Q931
Q932
Q961
Q962
Part No.
Description
8-729-040-20
8-729-029-86
8-729-620-05
8-729-140-04
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Remark
RT1P137L-TP
DTC124ESA-TP
2SC2603TP-EF
2SB1116-TP-LK
< RESISTOR >
< COIL >
L781
1-216-073-00
1-216-121-91
1-216-103-00
1-216-043-91
1-216-073-00
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
10K
1M
180K
560
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R116
R117
R118
R119
R120
1-216-091-00
1-216-073-00
1-216-089-91
1-216-057-00
1-216-097-91
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
56K
10K
47K
2.2K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R121
R122
R123
R124
R125
1-216-073-00
1-216-295-91
1-216-107-00
1-216-057-00
1-216-061-00
METAL CHIP
SHORT 0
METAL CHIP
METAL CHIP
METAL CHIP
10K
5%
1/10W
270K
2.2K
3.3K
5%
5%
5%
1/10W
1/10W
1/10W
R126
R127
R129
R131
R132
1-216-057-00
1-216-111-00
1-216-121-91
1-216-025-91
1-216-025-91
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
2.2K
390K
1M
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R133
R161
R162
R163
R164
1-216-025-91
1-216-073-00
1-216-121-91
1-216-103-00
1-216-043-91
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
100
10K
1M
180K
560
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R165
R166
R167
R168
R169
1-216-073-00
1-216-091-00
1-216-073-00
1-216-089-91
1-216-057-00
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
10K
56K
10K
47K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R170
R171
R172
R173
R174
1-216-097-91
1-216-073-00
1-216-295-91
1-216-107-00
1-216-073-00
RES-CHIP
METAL CHIP
SHORT 0
METAL CHIP
METAL CHIP
100K
10K
5%
5%
1/10W
1/10W
270K
10K
5%
5%
1/10W
1/10W
R175
R177
R178
R179
R301
1-216-097-91
1-216-111-00
1-216-057-00
1-216-121-91
1-216-085-00
RES-CHIP
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
100K
390K
2.2K
1M
33K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R302
R303
R304
R305
R306
1-216-057-00
1-216-025-91
1-216-025-91
1-216-057-00
1-216-071-00
METAL CHIP
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
2.2K
100
100
2.2K
8.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R307
R308
R309
R311
R312
1-216-071-00
1-216-065-91
1-216-081-00
1-216-121-91
1-216-102-00
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
RES-CHIP
8.2K
4.7K
22K
1M
160K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R313
R315
1-216-097-91 RES-CHIP
1-216-073-00 METAL CHIP
100K
10K
5%
5%
1/10W
1/10W
1-412-032-11 INDUCTOR CHIP 100uH
< TRANSISTOR >
Q111
Q112
Q113
Q115
Q161
8-729-620-05
8-729-620-05
8-729-141-30
8-729-029-86
8-729-620-05
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2603TP-EF
2SC2603TP-EF
2SC3623ATP-LK
DTC124ESA-TP
2SC2603TP-EF
Q162
Q163
Q165
Q331
Q332
8-729-620-05
8-729-141-30
8-729-029-86
8-729-140-04
8-729-029-66
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2603TP-EF
2SC3623ATP-LK
DTC124ESA-TP
2SB1116-TP-LK
DTC114ESA-TP
Q333
Q334
Q335
Q336
Q337
8-729-140-04
8-729-029-66
8-729-029-66
8-729-116-59
8-729-045-21
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1116-TP-LK
DTC114ESA-TP
DTC114ESA-TP
2SB1068TP
2SD1513TP-LK
Q338
Q339
Q340
Q341
Q342
8-729-029-21
8-729-029-66
8-729-116-59
8-729-045-21
8-729-029-21
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA114ESA-TP
DTC114ESA-TP
2SB1068TP
2SD1513TP-LK
DTA114ESA-TP
Q343
Q801
Q802
Q803
Q804
8-729-029-66
8-729-620-05
8-729-029-21
8-729-029-21
8-729-029-40
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114ESA-TP
2SC2603TP-EF
DTA114ESA-TP
DTA114ESA-TP
DTA124ESA-TP
Q901
Q902
Q903
Q904
Q905
8-729-040-20
8-729-029-40
8-729-040-19
8-729-029-86
8-729-119-76
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
RT1P137L-TP
DTA124ESA-TP
RT1N137L-TP
DTC124ESA-TP
2SA1115TP-EF
Q906
Q911
Q912
Q914
Q921
8-729-029-68
8-729-040-20
8-729-029-86
8-729-029-86
8-729-018-59
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114TSA-TP
RT1P137L-TP
DTC124ESA-TP
DTC124ESA-TP
2SB1375(LB-SONY)
80
R111
R112
R113
R114
R115
MAIN
Ref. No.
Part No.
Description
Remark
R316
R317
R318
1-216-079-00 METAL CHIP
1-216-073-00 METAL CHIP
1-216-073-00 METAL CHIP
18K
10K
10K
5%
5%
5%
1/10W
1/10W
1/10W
R319
R321
R322
R332
R333
1-216-111-00
1-216-059-00
1-216-071-00
1-216-045-00
1-216-057-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
390K
2.7K
8.2K
680
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R334
R335
R336
R337
R338
1-216-045-00
1-216-057-00
1-216-089-91
1-216-057-00
1-216-045-00
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
680
2.2K
47K
2.2K
680
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R339
R340
R341
R342
R343
1-216-089-91
1-216-089-91
1-216-045-00
1-216-089-91
1-216-061-00
RES-CHIP
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
47K
47K
680
47K
3.3K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R344
R345
R346
R347
R348
1-216-061-00
1-216-061-00
1-216-057-00
1-216-045-00
1-216-045-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
3.3K
2.2K
680
680
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R351
R352
R353
R354
R355
1-216-085-00
1-216-057-00
1-216-025-91
1-216-025-91
1-216-057-00
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
METAL CHIP
33K
2.2K
100
100
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R356
R357
R358
R359
R371
1-216-071-00
1-216-071-00
1-216-065-91
1-216-085-00
1-216-089-91
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
8.2K
8.2K
4.7K
33K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R372
R373
R374
R375
R376
1-216-065-91
1-216-049-91
1-216-089-91
1-216-094-00
1-216-065-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
4.7K
1K
47K
75K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R377
R378
R401
R402
R411
1-216-089-91
1-216-094-00
1-216-025-91
1-216-061-00
1-216-085-00
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
47K
75K
100
3.3K
33K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R413
R414
R451
R452
R501
1-216-295-91
1-216-295-91
1-216-025-91
1-216-061-00
1-216-025-91
SHORT 0
SHORT 0
RES-CHIP
METAL CHIP
RES-CHIP
100
3.3K
100
5%
5%
5%
1/10W
1/10W
1/10W
R503
R505
R511
R513
R517
1-216-025-91
1-216-025-91
1-216-109-00
1-216-295-91
1-216-073-00
RES-CHIP
RES-CHIP
METAL CHIP
SHORT 0
METAL CHIP
100
100
330K
5%
5%
5%
1/10W
1/10W
1/10W
10K
5%
1/10W
R518
R522
R526
R527
R528
1-216-025-91
1-216-065-91
1-216-065-91
1-216-025-91
1-216-025-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
4.7K
4.7K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Ref. No.
Part No.
Description
R529
R530
R532
R533
R536
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
Remark
1/10W
1/10W
1/10W
1/10W
1/10W
R538
R540
R541
R542
R543
1-216-025-91
1-216-061-00
1-216-073-00
1-216-025-91
1-216-025-91
RES-CHIP
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
100
3.3K
10K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R545
R546
R547
R548
R549
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-041-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
100
100
100
100
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R550
R551
R552
R553
R554
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R555
R556
R557
R559
R561
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R563
R565
R567
R568
R569
1-216-025-91
1-216-025-91
1-216-073-00
1-216-025-91
1-216-025-91
RES-CHIP
RES-CHIP
METAL CHIP
RES-CHIP
RES-CHIP
100
100
10K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R570
R572
R573
R574
R575
1-216-089-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
47K
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R576
R577
R578
R579
R580
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R581
R582
R583
R584
R585
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R586
R587
R588
R589
R590
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R591
R593
R594
R595
R596
1-216-025-91
1-216-025-91
1-216-053-00
1-216-089-91
1-216-089-91
RES-CHIP
RES-CHIP
METAL CHIP
RES-CHIP
RES-CHIP
100
100
1.5K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R597
R600
R601
1-216-069-00 METAL CHIP
1-216-025-91 RES-CHIP
1-216-049-91 RES-CHIP
6.8K
100
1K
5%
5%
5%
1/10W
1/10W
1/10W
81
MAIN
Ref. No.
MIC
Part No.
Description
Remark
R602
R603
1-216-049-91 RES-CHIP
1-216-089-91 RES-CHIP
1K
47K
5%
5%
1/10W
1/10W
R604
R605
R606
R607
R608
1-216-049-91
1-216-115-00
1-216-089-91
1-216-049-91
1-216-097-91
RES-CHIP
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1K
560K
47K
1K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R609
R651
R652
R653
R654
1-216-033-00
1-216-049-91
1-216-049-91
1-216-089-91
1-216-049-91
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
220
1K
1K
47K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R655
R656
R657
R658
R659
1-216-115-00
1-216-089-91
1-216-049-91
1-216-097-91
1-216-033-00
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
560K
47K
1K
100K
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R701
R702
R703
R704
R705
1-216-049-91
1-216-097-91
1-216-049-91
1-216-097-91
1-216-049-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1K
100K
1K
100K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R706
R721
R722
R724
R725
1-216-097-91
1-216-022-00
1-216-015-00
1-216-073-00
1-216-022-00
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
75
39
10K
75
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R751
R752
R753
R754
R755
1-216-049-91
1-216-097-91
1-216-049-91
1-216-097-91
1-216-049-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1K
100K
1K
100K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R756
R801
R802
R803
R804
1-216-097-91
1-216-049-91
1-216-065-91
1-216-025-91
1-216-089-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100K
1K
4.7K
100
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R805
R806
R807
R808
R809
1-216-089-91
1-216-073-00
1-216-073-00
1-216-049-91
1-216-097-91
RES-CHIP
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
47K
10K
10K
1K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R810
R811
R901
R902
R903
1-216-033-00
1-216-097-91
1-216-065-91
1-216-081-00
1-216-049-91
METAL CHIP
RES-CHIP
RES-CHIP
METAL CHIP
RES-CHIP
220
100K
4.7K
22K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R916
R917
R919
R920
R961
1-216-057-00
1-216-037-00
1-216-037-00
1-216-037-00
1-216-065-91
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
2.2K
330
330
330
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R962
R963
1-216-079-00 METAL CHIP
1-216-057-00 METAL CHIP
18K
2.2K
5%
5%
1/10W
1/10W
Ref. No.
Part No.
Description
Remark
< VIBRATOR >
X501
X502
1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)
1-781-107-21 VIBRATOR, SERAMIC (16MHz)
**************************************************************
A-4428-233-A MIC BOARD, COMPLETE
******************
< CAPACITOR >
C801
C802
C803
C804
C805
1-162-306-11
1-162-306-11
1-126-960-11
1-126-959-11
1-162-294-31
CERAMIC
CERAMIC
ELECT
ELECT
CERAMIC
0.01uF
0.01uF
1uF
0.47uF
0.001uF
30.00%
30.00%
20.00%
20.00%
10%
16V
16V
50V
50V
50V
C806
C810
C817
C818
C821
1-162-215-31
1-162-290-31
1-126-961-11
1-162-215-31
1-104-664-11
CERAMIC
CERAMIC
ELECT
CERAMIC
ELECT
47PF
470PF
2.2uF
47PF
47uF
5%
10%
20.00%
5%
20.00%
50V
50V
50V
50V
16V
C822
C823
C825
C826
C827
1-104-664-11
1-104-664-11
1-161-494-00
1-104-664-11
1-162-294-31
ELECT
ELECT
CERAMIC
ELECT
CERAMIC
47uF
47uF
0.022uF
47uF
0.001uF
20.00%
20.00%
25V
20.00%
10%
16V
16V
C828
C829
C830
C831
C832
1-136-495-11
1-126-959-11
1-126-959-11
1-162-305-11
1-136-167-00
MYLAR
ELECT
ELECT
CERAMIC
MYLAR
0.068uF
0.47uF
0.47uF
0.0068uF
0.15uF
5.00%
20.00%
20.00%
30.00%
5.00%
50V
50V
50V
16V
50V
C833
C834
C835
C836
C865
1-162-294-31
1-162-305-11
1-136-495-11
1-162-306-11
1-126-960-11
CERAMIC
CERAMIC
MYLAR
CERAMIC
ELECT
0.001uF
0.0068uF
0.068uF
0.01uF
1uF
10%
30.00%
5.00%
30.00%
20.00%
50V
16V
50V
16V
50V
C878
1-126-960-11 ELECT
1uF
20.00% 50V
< CONNECTOR >
CN813
1-785-320-11 PIN, CONNECTOR (STRAIGHT) 8P
< DIODE >
D801
8-719-109-85 DIODE MTZJ-5.1B
< EARTH TERMINAL >
* EPT802 1-537-738-21 TERMINAL, EARTH
< FILTER >
FL801
1-424-228-11 FILTER, NOISE
< IC >
IC850
IC851
8-759-634-50 IC M5218AL
8-759-450-96 IC M65850P
< JACK >
< VARIABLE RESISTOR >
RV301
RV351
82
1-238-600-11 RES, ADJ, CARBON 10K
1-238-600-11 RES, ADJ, CARBON 10K
J801
J802
1-770-226-41 JACK (LARGE TYPE)(MIC 1)
1-770-222-21 JACK (LARGE TYPE)(MIC 2)
16V
50V
MIC
Ref. No.
Part No.
Description
Remark
< RESISTOR >
R806
R807
R808
R809
R850
1-249-429-11
1-249-429-11
1-249-417-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
1K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W F
1/4W F
R852
R853
R854
R855
R856
1-249-441-11
1-249-417-11
1-249-437-11
1-249-429-11
1-247-889-00
CARBON
CARBON
CARBON
CARBON
CARBON
100K
1K
47K
10K
270K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W
1/4W
R857
R858
R859
R860
R861
1-247-807-31
1-247-863-91
1-247-863-91
1-247-863-91
1-247-881-00
CARBON
CARBON
CARBON
CARBON
CARBON
100
22K
22K
22K
120K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R862
R863
R864
R865
R866
1-247-863-91
1-247-863-91
1-247-863-91
1-249-437-11
1-249-431-11
CARBON
CARBON
CARBON
CARBON
CARBON
22K
22K
22K
47K
15K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R867
R874
R875
1-249-431-11 CARBON
1-249-429-11 CARBON
1-247-807-31 CARBON
15K
10K
100
5%
5%
5%
1/4W
1/4W
1/4W
**************************************************************
A-4428-748-A PA BOARD, COMPLETE
*****************
< CAPACITOR >
C401
C412
C413
C432
C433
1-126-963-11
1-161-494-00
1-161-494-00
1-104-665-11
1-126-962-11
ELECT
CERAMIC
CERAMIC
ELECT
ELECT
4.7uF
0.022uF
0.022uF
100uF
3.3uF
20.00% 50V
25V
25V
20.00% 10V
20.00% 50V
C801
C802
C803
C804
C807
1-128-582-11
1-162-292-31
1-162-286-21
1-126-967-11
1-128-560-11
ELECT
CERAMIC
CERAMIC
ELECT
ELECT
10uF
680PF
220PF
47uF
22uF
20.00% 100V
10%
50V
10.00% 50V
20.00% 50V
20.00% 100V
C808
C809
C810
C811
C812
1-130-777-00
1-130-777-00
1-128-562-11
1-130-493-00
1-130-493-00
MYLAR
MYLAR
ELECT
MYLAR
MYLAR
0.1uF
0.1uF
47uF
0.068uF
0.068uF
10.00% 100V
10.00% 100V
20.00% 100V
5%
50V
5%
50V
C813
C814
C815
C830
C831
1-161-494-00
1-162-294-31
1-126-959-11
1-107-714-11
1-126-964-11
CERAMIC
CERAMIC
ELECT
ELECT
ELECT
0.022uF
0.001uF
0.47uF
10uF
10uF
25V
10%
20.00%
20.00%
20.00%
C832
C841
C842
C844
C845
1-126-967-11
1-127-752-11
1-127-755-11
1-130-777-00
1-126-943-11
ELECT
ELECT
ELECT
MYLAR
ELECT
47uF
3300uF
3300uF
0.1uF
2200uF
20.00% 50V
20%
63V
20%
100V
10.00% 100V
20.00% 25V
C847
C848
1-164-159-21 CERAMIC
1-164-159-21 CERAMIC
50V
50V
50V
50V
Ref. No.
Part No.
Description
PA
Remark
C849
C850
C851
1-164-159-21 CERAMIC
1-107-721-11 ELECT
1-128-582-11 ELECT
0.1uF
4.7uF
10uF
50V
20.00% 100V
20.00% 100V
C852
C853
C854
C857
C858
1-162-292-31
1-162-286-21
1-126-967-11
1-128-560-11
1-164-159-21
CERAMIC
CERAMIC
ELECT
ELECT
CERAMIC
680PF
220PF
47uF
22uF
0.1uF
10%
50V
10.00% 50V
20.00% 50V
20.00% 100V
50V
C859
C861
C862
C891
C892
1-164-159-21
1-130-493-00
1-130-493-00
1-127-752-11
1-127-755-11
CERAMIC
MYLAR
MYLAR
ELECT
ELECT
0.1uF
0.068uF
0.068uF
3300uF
3300uF
5%
5%
20%
20%
C894
C895
C904
C905
C909
1-130-777-00
1-107-721-11
1-126-964-11
1-126-968-11
1-164-159-21
MYLAR
ELECT
ELECT
ELECT
CERAMIC
0.1uF
4.7uF
10uF
100uF
0.1uF
10.00% 100V
20.00% 100V
20.00% 50V
20.00% 50V
50V
50V
50V
50V
63V
100V
< CONNECTOR >
CN803
CN804
1-778-981-21 CONNECTOR, BOARD TO BOARD 13P
1-778-981-21 CONNECTOR, BOARD TO BOARD 13P
< DIODE >
D401
D402
D405
D406
D801
8-719-991-33
8-719-991-33
8-719-991-33
8-719-991-33
8-719-991-33
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
1SS133T-77
1SS133T-77
1SS133T-77
1SS133T-77
D802
D803
D804
D805
D831
8-719-110-49
8-719-991-33
8-719-991-33
8-719-991-33
8-719-060-53
DIODE
DIODE
DIODE
DIODE
DIODE
MTZJ-T-77-18A
1SS133T-77
1SS133T-77
1SS133T-77
RBV-2506
D833
D834
D835
D836
D841
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2-NTA1B
11ES2-NTA1B
11ES2-NTA1B
11ES2-NTA1B
11ES2-NTA1B
D842
D843
D844
D851
D852
8-719-200-82
8-719-200-82
8-719-200-82
8-719-991-33
8-719-110-49
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2-NTA1B
11ES2-NTA1B
11ES2-NTA1B
1SS133T-77
MTZJ-T-77-18A
D911
D912
8-719-982-37 DIODE MTZJ-T-77-39C
8-719-109-89 DIODE MTZJ-T-77-5.6
< IC >
IC801
8-749-017-07 IC STK412-170
< TRANSISTOR >
0.1uF
0.1uF
50V
50V
Q401
Q402
Q431
Q432
Q433
8-729-140-82
8-729-140-84
8-729-140-84
8-729-119-76
8-729-620-05
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA988TP-PAFAEA
2SC1841TP-PAFAEA
2SC1841TP-PAFAEA
2SA1115TP-EF
2SC2603TP-EF
Q434
8-729-620-05 TRANSISTOR 2SC2603TP-EF
83
PA
Ref. No.
PANEL FL
Part No.
Description
Q437
Q439
Q801
Q803
8-729-620-05
8-729-620-05
8-729-140-84
8-729-140-82
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2603TP-EF
2SC2603TP-EF
2SC1841TP-PAFAEA
2SA988TP-PAFAEA
Remark
Q804
Q805
Q831
Q832
Q833
8-729-140-84
8-729-231-55
8-729-029-86
8-729-620-05
8-729-029-40
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1841TP-PAFAEA
2SC2878AB-TPE2
DTC124ESA-TP
2SC2603TP-EF
DTA124ESA-TP
Q834
Q851
Q855
Q903
Q908
8-729-140-84
8-729-140-84
8-729-231-55
8-729-141-83
8-729-119-76
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1841TP-PAFAEA
2SC1841TP-PAFAEA
2SC2878AB-TPE2
2SB1375
2SA1115TP-EF
< RESISTOR >
0 R401
R406
R407
R429
R431
1-215-867-00
1-249-437-11
1-249-437-11
1-249-437-11
1-249-438-11
METAL OXIDE
CARBON
CARBON
CARBON
CARBON
470
47K
47K
47K
56K
5%
5%
5%
5%
5%
1W
1/4W
1/4W
1/4W
1/4W
R432
R434
R435
R437
R439
1-249-437-11
1-247-863-91
1-249-425-11
1-249-429-11
1-249-425-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
22K
4.7K
10K
4.7K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W
1/4W F
R440
R441
R446
R447
R460
1-247-863-91
1-249-435-11
1-249-429-11
1-249-437-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
22K
33K
10K
47K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R801
R802
R803
R804
R805
1-249-417-11
1-249-437-11
1-249-412-11
1-249-435-11
1-216-436-00
CARBON
CARBON
CARBON
CARBON
METAL OXIDE
1K
47K
390
33K
3.9K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W
1W
R806
0 R807
R808
R809
R810
1-216-436-00
1-212-881-11
1-214-789-00
1-260-076-11
1-249-437-11
METAL OXIDE
FUSIBLE
METAL
CARBON
CARBON
3.9K
100
0.1
10
47K
5%
5%
10%
5%
5%
1W
1/4W
5W
1/2W
1/4W
R811
R812
R813
R814
R815
1-249-417-11
1-249-431-11
1-249-441-11
1-249-421-11
1-247-863-91
CARBON
CARBON
CARBON
CARBON
CARBON
1K
15K
100K
2.2K
22K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W F
1/4W
R816
R817
R818
R819
0 R820
1-249-429-11
1-249-421-11
1-249-417-11
1-249-439-11
1-202-972-61
CARBON
CARBON
CARBON
CARBON
FUSIBLE
10K
2.2K
1K
68K
1
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W F
1/4W
1/4W
R821
R822
R823
R824
R825
1-249-435-11
1-247-863-91
1-247-863-91
1-249-418-11
1-215-891-11
CARBON
CARBON
CARBON
CARBON
METAL OXIDE
33K
22K
22K
1.2K
680
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
2W
R827
R828
1-249-441-11 CARBON
1-247-903-00 CARBON
100K
1M
5%
5%
1/4W
1/4W
Ref. No.
Part No.
Description
Remark
R831
R832
R833
1-249-441-11 CARBON
1-249-441-11 CARBON
1-247-856-00 CARBON
100K
100K
11K
5%
5%
5%
1/4W
1/4W
1/4W
R834
R835
R836
R837
R838
1-249-429-11
1-249-437-11
1-249-417-11
1-249-435-11
1-249-435-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
47K
1K
33K
33K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W
1/4W
R839
R840
R851
R852
R853
1-215-877-11
1-249-402-11
1-249-417-11
1-249-437-11
1-249-412-11
METAL OXIDE
CARBON
CARBON
CARBON
CARBON
22K
56
1K
47K
390
5%
5%
5%
5%
5%
1W
1/4W F
1/4W F
1/4W
1/4W F
0 R855
0 R857
R858
R859
R860
1-215-891-11
1-212-881-11
1-214-789-00
1-260-076-11
1-249-437-11
METAL OXIDE
FUSIBLE
METAL
CARBON
CARBON
680
100
0.1
10
47K
5%
5%
10%
5%
5%
2W
1/4W
5W
1/2W
1/4W
R861
R862
R863
R868
R880
1-249-417-11
1-249-431-11
1-249-441-11
1-249-417-11
1-249-402-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
15K
100K
1K
56
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W F
1/4W F
R888
R889
R898
R903
R904
1-214-789-00
1-215-877-11
1-214-789-00
1-249-429-11
1-249-417-11
METAL
METAL OXIDE
METAL
CARBON
CARBON
0.1
22K
0.1
10K
1K
10%
5%
10%
5%
5%
5W
1W
5W
1/4W
1/4W F
R905
R906
R907
R915
R916
1-249-429-11
1-247-807-31
1-247-807-31
1-247-791-91
1-215-890-11
CARBON
CARBON
CARBON
CARBON
METAL OXIDE
10K
100
100
22
470
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
2W
< RELAY >
RY401
1-755-168-11 RELAY
< THERMISTOR >
TH831
1-807-796-11 THERMISTOR
< TERMINAL >
TM401
1-537-842-11 TERMINAL BOARD (FRONT SPEAKER)
**************************************************************
A-4428-159-A PANEL FL BOARD, COMPLETE
***********************
4-225-511-01 HOLDER (FL)
4-949-935-81 CUSHION (FL)
*
< CAPACITOR >
84
C601
C602
C603
C604
C606
1-124-589-11
1-162-306-11
1-164-159-21
1-126-960-11
1-126-960-11
ELECT
CERAMIC
CERAMIC
ELECT
ELECT
C616
1-162-294-31 CERAMIC
47uF
0.01uF
0.1uF
1uF
1uF
20%
16V
30.00% 16V
50V
20.00% 50V
20.00% 50V
0.001uF
10%
50V
PANEL FL
Ref. No.
Part No.
Description
C617
C621
C622
C623
1-162-306-11
1-126-964-11
1-162-303-11
1-126-964-11
CERAMIC
ELECT
CERAMIC
ELECT
0.01uF
10uF
0.0033uF
10uF
30.00%
20.00%
30.00%
20.00%
16V
50V
16V
50V
Remark
C624
C625
C626
C641
C642
1-104-664-11
1-126-963-11
1-126-964-11
1-162-286-21
1-162-286-21
ELECT
ELECT
ELECT
CERAMIC
CERAMIC
47uF
4.7uF
10uF
220PF
220PF
20.00%
20.00%
20.00%
10.00%
10.00%
16V
50V
50V
50V
50V
C643
C644
C645
C646
C647
1-162-286-21
1-162-286-21
1-162-286-21
1-162-286-21
1-162-286-21
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
220PF
220PF
220PF
220PF
220PF
10.00%
10.00%
10.00%
10.00%
10.00%
50V
50V
50V
50V
50V
C648
C649
C650
C651
C652
1-162-286-21
1-162-286-21
1-162-286-21
1-162-286-21
1-162-286-21
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
220PF
220PF
220PF
220PF
220PF
10.00%
10.00%
10.00%
10.00%
10.00%
50V
50V
50V
50V
50V
C653
C654
C655
C656
1-162-286-21
1-162-286-21
1-162-286-21
1-162-286-21
CERAMIC
CERAMIC
CERAMIC
CERAMIC
220PF
220PF
220PF
220PF
10.00%
10.00%
10.00%
10.00%
50V
50V
50V
50V
< CONNECTOR >
CN601
CN602
1-784-735-11 CONNECTOR, FFC 13P
1-568-838-11 SOCKET, CONNECTOR 21P
Ref. No.
Part No.
Description
Remark
Q605
Q606
8-729-029-23 TRANSISTOR DTA114TSA-TP
8-729-029-23 TRANSISTOR DTA114TSA-TP
Q607
Q608
Q609
Q610
8-729-029-23
8-729-047-58
8-729-047-58
8-729-047-58
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA114TSA-TP
DTC114TLTL2
DTC114TLTL2
DTC114TLTL2
< RESISTOR >
R601
R602
R603
R604
R605
1-247-893-11
1-247-893-11
1-249-441-11
1-249-441-11
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
390K
390K
100K
100K
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R608
R609
R611
R612
R613
1-249-435-11
1-247-895-91
1-249-429-11
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
33K
470K
10K
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R614
R615
R616
R617
R618
1-247-807-31
1-249-429-11
1-249-429-11
1-249-429-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R619
R620
R621
R622
R623
1-249-429-11
1-249-429-11
1-249-429-11
1-249-429-11
1-247-903-00
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
10K
10K
1M
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R624
R625
R626
R627
R628
1-247-807-31
1-247-807-31
1-249-429-11
1-247-807-31
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
10K
100
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R629
R630
R631
R632
R633
1-247-807-31
1-249-429-11
1-249-410-11
1-249-411-11
1-249-413-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
10K
270
330
470
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W
1/4W F
R634
R642
R644
R645
R646
1-249-414-11
1-249-415-11
1-249-418-11
1-249-420-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
560
680
1.2K
1.8K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R647
R648
R649
R650
R652
1-249-410-11
1-249-411-11
1-249-413-11
1-249-414-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
270
330
470
560
47K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W F
1/4W
R653
R654
R655
R656
R659
1-249-417-11
1-249-437-11
1-249-417-11
1-249-438-11
1-249-411-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
47K
1K
56K
330
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W
1/4W
R660
R661
R662
R665
R666
1-249-411-11
1-249-407-11
1-249-407-11
1-249-441-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
330
150
150
100K
100K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W F
1/4W
1/4W
< DIODE >
D601
D602
D603
D604
D605
8-719-071-44
8-719-058-04
8-719-058-04
8-719-058-04
8-719-058-04
DIODE
DIODE
DIODE
DIODE
DIODE
SELS5223C-TP15 ("/1)
SEL5223S-TP15 (DAILY)
SEL5223S-TP15 (zREC)
SEL5223S-TP15 (SYNC EQ)
SEL5223S-TP15 (SYNC BASS)
D608
D615
D617
8-719-050-84 DIODE RB441Q-40T-77
8-719-058-04 DIODE SEL5223S-TP15 (KEY CONTROL)
8-719-058-04 DIODE SEL5223S-TP15 (SURROUND)
< FILTER >
FL601
1-517-940-11 INDICATOR TUBE, FLUORESCENT
< IC >
IC601
IC603
8-759-653-43 IC TMP88CS76F-1A25
8-759-083-77 IC BA3830F
< COIL >
L601
L602
L603
1-410-517-11 INDUCTOR 47uH
1-410-517-11 INDUCTOR 47uH
1-410-517-11 INDUCTOR 47uH
< LINE FILTER >
LF601
1-424-228-11 FILTER, NOISE
< TRANSISTOR >
Q601
Q602
Q603
8-729-620-05 TRANSISTOR 2SC2603TP-EF
8-729-140-04 TRANSISTOR 2SB1116-TP-LK
8-729-140-04 TRANSISTOR 2SB1116-TP-LK
F
F
F
F
F
85
PANEL FL
Ref. No.
PANEL VR
Part No.
Description
Remark
Ref. No.
R667
R680
R681
R682
R683
1-249-441-11
1-249-411-11
1-249-440-11
1-249-420-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
330
82K
1.8K
47K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W
D616
8-719-058-04 DIODE SEL5223S-TP15 (ENTER)
R684
R685
R686
R687
R688
1-249-440-11
1-249-429-11
1-249-410-11
1-249-410-11
1-249-413-11
CARBON
CARBON
CARBON
CARBON
CARBON
82K
10K
270
270
470
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W F
1/4W F
D618
D619
D620
D621
D623
8-719-058-04
8-719-301-60
8-719-301-60
8-719-301-60
8-719-301-60
DIODE
DIODE
DIODE
DIODE
DIODE
SEL5223S-TP15 (EFFECT)
SEL2910A-C-TP2 (MENU 1)
SEL2910A-C-TP2 (MENU 2)
SEL2910A-C-TP2 (P.FILE)
SEL2910A-C-TP2 (FILE 5)
D624
D625
D626
D627
8-719-301-60
8-719-301-60
8-719-301-60
8-719-301-60
DIODE
DIODE
DIODE
DIODE
SEL2910A-C-TP2 (FILE 4)
SEL2910A-C-TP2 (FILE 3)
SEL2910A-C-TP2 (FILE 2)
SEL2910A-C-TP2 (FILE 1)
R689
R690
R691
R699
1-249-411-11
1-249-407-11
1-249-407-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
330
150
150
10K
5%
5%
5%
5%
1/4W
1/4W F
1/4W F
1/4W
Part No.
Description
Remark
< IC >
IC701
IC702
8-759-567-59 IC NJU3716L
8-759-459-86 IC NJL64H400A
< SWITCH >
< COIL >
S601
S602
S603
S604
S612
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD ("/1)
SWITCH, KEYBOARD (DEMO(STAND BY))
SWITCH, KEYBOARD (DISPLAY)
SWITCH, KEYBOARD (SPECTRUM ANALYZER)
SWITCH, KEYBOARD (FUNCTION)
S614
S615
S616
S617
S618
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (SYNC EQ)
SWITCH, KEYBOARD (SYNC BASS)
SWITCH, KEYBOARD (KEY CONTROL 2)
SWITCH, KEYBOARD (DAILY)
SWITCH, KEYBOARD (zREC)
S619
S620
S631
S632
S635
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (SLEEP)
SWITCH, KEYBOARD (CLOCK SET)
SWITCH, KEYBOARD (KEY CONTROL #)
SWITCH, KEYBOARD (KARAOKE PON)
SWITCH, KEYBOARD (SURROUND)
< VIBRATOR >
X601
1-781-312-11 VIBRATOR, CERAMIC (12.5MHz)
L704
1-410-509-11 INDUCTOR 10uH
< RESISTOR >
R724
R725
R726
R727
R728
1-249-422-11
1-247-843-11
1-249-425-11
1-249-427-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.7K
3.3K
4.7K
6.8K
10K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W F
1/4W
R729
R730
R731
R732
R733
1-249-431-11
1-249-434-11
1-249-438-11
1-247-804-11
1-249-407-11
CARBON
CARBON
CARBON
CARBON
CARBON
15K
27K
56K
75
150
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W F
R734
R735
R736
R737
R738
1-249-429-11
1-249-393-11
1-249-393-11
1-249-393-11
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10
10
10
100
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W F
1/4W F
1/4W
R739
R740
R741
R742
R743
1-247-807-31
1-247-807-31
1-249-393-11
1-249-393-11
1-249-393-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
10
10
10
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W F
1/4W F
**************************************************************
A-4428-116-A PANEL VR BOARD, COMPLETE
***********************
< CAPACITOR >
C701
C702
C703
C704
C708
1-162-600-11
1-162-301-11
1-162-302-11
1-104-664-11
1-104-665-11
CERAMIC
CERAMIC
CERAMIC
ELECT
ELECT
C709
C710
C711
1-162-294-31 CERAMIC
1-162-306-11 CERAMIC
1-162-306-11 CERAMIC
0.0047uF
0.0015uF
0.0022uF
47uF
100uF
30.00%
30.00%
30.00%
20.00%
20.00%
16V
16V
16V
16V
10V
R744
R750
R751
R761
R762
1-249-401-11
1-249-393-11
1-249-393-11
1-249-411-11
1-249-413-11
CARBON
CARBON
CARBON
CARBON
CARBON
47
10
10
330
470
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
0.001uF
0.01uF
0.01uF
10%
50V
30.00% 16V
30.00% 16V
R763
R764
R765
R766
R767
1-249-414-11
1-249-415-11
1-249-429-11
1-249-427-11
1-249-425-11
CARBON
CARBON
CARBON
CARBON
CARBON
560
680
10K
6.8K
4.7K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
R768
R769
R772
R773
R775
1-249-417-11
1-249-418-11
1-249-420-11
1-249-422-11
1-249-431-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1.2K
1.8K
2.7K
15K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R776
R777
1-247-843-11 CARBON
1-249-407-11 CARBON
3.3K
150
5%
5%
1/4W
1/4W F
< CONNECTOR >
* CN701
1-568-864-11 SOCKET, CONNECTOR 21P
< DIODE >
D606
D607
D611
D612
86
8-719-058-03
8-719-058-04
8-719-058-04
8-719-058-04
DIODE
DIODE
DIODE
DIODE
SEL5423E-TP15 (TUNER/BAND)
SEL5223S-TP15 (ENT/NEXT)
SEL5223S-TP15 (GROOVE)
SEL5223S-TP15 (SUPER WOOFER)
F
F
F
F
F
F
F
PANEL VR
Ref. No.
Part No.
Description
Remark
R778
R782
R784
1-249-407-11 CARBON
1-249-407-11 CARBON
1-249-407-11 CARBON
150
150
150
5%
5%
5%
1/4W F
1/4W F
1/4W F
R785
R786
R787
R789
R790
1-249-407-11
1-249-407-11
1-249-407-11
1-249-407-11
1-249-407-11
CARBON
CARBON
CARBON
CARBON
CARBON
150
150
150
150
150
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
F
R791
R792
R793
R794
R795
1-249-407-11
1-249-407-11
1-249-407-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
150
150
150
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
F
< VARIABLE RESISTOR >
RV750
RV751
1-225-739-31 RES, VAR CARBON 50K (MIC LEVEL)
1-225-739-11 RES, VAR CARBON 50K (ECHO LEVEL)
< SWITCH >
S606
S607
S608
S609
S610
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (TUNINNG MODE)
SWITCH, KEYBOARD (ST/MONO)
SWITCH, KEYBOARD (ENT/NEXT)
SWITCH, KEYBOARD (TUNER/BAND)
SWITCH, KEYBOARD (+)
S611
S613
S621
S622
S623
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (–)
SWITCH, KEYBOARD (TUNER MEMORY)
SWITCH, KEYBOARD (V)
SWITCH, KEYBOARD (b)
SWITCH, KEYBOARD (v)
S624
S626
S627
S628
S633
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (B)
SWITCH, KEYBOARD (GROOVE)
SWITCH, KEYBOARD (SUPER WOOFER)
SWITCH, KEYBOARD (SUPER WOOFER MODE)
SWITCH, KEYBOARD (ENTER)
S634
S636
S637
S701
1-762-875-21
1-762-875-21
1-762-875-21
1-473-392-11
SWITCH, KEYBOARD (GEQ CTRL)
SWITCH, KEYBOARD (EFFECT)
SWITCH, KEYBOARD (FILE MENU)
ENCODER, ROTARY (VOLUME)
**************************************************************
1-659-058-13 TABLE SENSOR BOARD
*****************
*
< IC >
IC202
Ref. No.
TABLE SENSOR
Part No.
TC-A
TC-B
Description
Remark
< RESISTOR >
R700
R701
R702
R703
R704
1-249-410-11
1-249-411-11
1-249-413-11
1-249-414-11
1-249-415-11
CARBON
CARBON
CARBON
CARBON
CARBON
270
330
470
560
680
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
R705
R706
R707
R708
1-249-417-11
1-249-418-11
1-247-804-11
1-247-804-11
CARBON
CARBON
CARBON
CARBON
1K
1.2K
75
75
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W
F
F
F
< SWITCH >
S641
S642
S643
S644
S645
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (G)
SWITCH, KEYBOARD (g)
SWITCH, KEYBOARD (x)
SWITCH, KEYBOARD (m)
SWITCH, KEYBOARD (M)
S646
S647
1-762-875-21 SWITCH, KEYBOARD (DOLBY NR)
1-762-875-21 SWITCH, KEYBOARD (DIRECTION)
*************************************************************
1-676-275-11 TC-B BOARD
*********
< DIODE >
D635
D636
D637
D638
8-719-058-03
8-719-058-03
8-719-057-97
8-719-058-04
DIODE
DIODE
DIODE
DIODE
SEL5423E-TP15 (g)
SEL5423E-TP15 (G)
SEL5923A-TP15 (X)
SEL5223S-TP15 (zREC)
< RESISTOR >
R711
R712
R713
R714
R715
1-249-415-11
1-249-417-11
1-249-418-11
1-249-414-11
1-249-415-11
CARBON
CARBON
CARBON
CARBON
CARBON
680
1K
1.2K
560
680
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
F
R716
R717
R718
R719
R720
1-249-417-11
1-249-418-11
1-249-420-11
1-249-422-11
1-247-804-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1.2K
1.8K
2.7K
75
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
R721
R722
R723
1-247-804-11 CARBON
1-247-807-31 CARBON
1-249-407-11 CARBON
75
100
150
5%
5%
5%
1/4W
1/4W
1/4W F
8-749-924-18 PHOTO INTERRUPTER RPI-1391
< SWITCH >
< RESISTOR >
R207
1-249-416-11 CARBON
820
5%
1/4W F
**************************************************************
1-676-274-11 TC-A BOARD
*********
< DIODE >
D631
D632
8-719-058-03 DIODE SEL5423E-TP15 (G)
8-719-058-03 DIODE SEL5423E-TP15 (g)
S651
S652
S653
S654
S655
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (G)
SWITCH, KEYBOARD (g)
SWITCH, KEYBOARD (x)
SWITCH, KEYBOARD (m)
SWITCH, KEYBOARD (M)
S656
S657
S658
S659
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (x)
SWITCH, KEYBOARD (zREC)
SWITCH, KEYBOARD (H SPEED DUB)
SWITCH, KEYBOARD (CD SYNC)
*************************************************************
87
TRANS
Ref. No.
VIDEO
Part No.
Description
Remark
1-676-267-11 TRANS BOARD
**********
1-533-233-2 HOLDER, FUSE
7-685-646-79 SCREW +BVTP3X8 TYPE2 N-S
< CAPACITOR >
C834
C893
C961
C963
1-130-777-00
1-130-777-00
1-162-306-11
1-162-306-11
MYLAR
MYLAR
CERAMIC
CERAMIC
0.1uF
0.1uF
0.01uF
0.01uF
10.00% 100V
10.00% 100V
30.00% 16V
30.00% 16V
Ref. No.
Part No.
Description
Remark
C311
1-216-295-91 SHORT 0
C313
C314
C318
C319
C401
1-165-319-11
1-165-319-11
1-124-778-00
1-165-319-11
1-165-319-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
22uF
0.1uF
0.1uF
20%
50V
50V
6.3V
50V
50V
C402
C403
C404
C405
C406
1-124-778-00
1-124-778-00
1-126-206-11
1-126-206-11
1-126-206-11
ELECT CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
22uF
22uF
100uF
100uF
100uF
20%
20%
20%
20%
20%
6.3V
6.3V
6.3V
6.3V
6.3V
C409
C410
C411
C412
C413
1-126-603-11
1-165-319-11
1-165-319-11
1-165-319-11
1-126-601-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
4.7uF
0.1uF
0.1uF
0.1uF
2.2uF
20%
20%
35V
50V
50V
50V
50V
C452
C471
C472
C501
C502
1-165-319-11
1-124-778-00
1-124-778-00
1-163-251-11
1-163-251-11
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
22uF
22uF
100PF
100PF
20%
20%
5.00%
5.00%
50V
6.3V
6.3V
50V
50V
C503
C504
C505
C506
C507
1-163-251-11
1-165-319-11
1-126-206-11
1-165-319-11
1-126-206-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
100PF
0.1uF
100uF
0.1uF
100uF
5.00% 50V
50V
20%
6.3V
50V
20%
6.3V
C509
C510
C531
C532
C535
1-163-275-11
1-165-319-11
1-126-206-11
1-165-319-11
1-165-319-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.1uF
100uF
0.1uF
0.1uF
5.00% 50V
50V
20%
6.3V
50V
50V
C536
C537
C539
C540
C541
1-126-193-11
1-126-206-11
1-165-319-11
1-126-206-11
1-165-319-11
ELECT
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
1uF
100uF
0.1uF
100uF
0.1uF
20%
20%
C542
C543
C544
C545
C546
1-126-206-11
1-126-206-11
1-165-319-11
1-165-319-11
1-165-319-11
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100uF
100uF
0.1uF
0.1uF
0.1uF
20%
20%
6.3V
6.3V
50V
50V
50V
C547
C548
C549
C550
C551
1-126-193-11
1-165-319-11
1-165-319-11
1-163-141-00
1-165-319-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.1uF
0.1uF
0.001uF
0.1uF
20%
50V
50V
50V
50V
50V
C552
C553
C555
C556
C559
1-165-319-11
1-126-206-11
1-124-779-00
1-165-319-11
1-126-206-11
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
0.1uF
100uF
10uF
0.1uF
100uF
C560
C561
C562
C563
C564
1-163-235-11
1-163-233-11
1-163-235-11
1-165-319-11
1-165-319-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
18PF
22PF
0.1uF
0.1uF
< CONNECTOR >
CN905
* CN951
* CN952
1-564-321-00 PIN, CONNECTOR 2P
1-564-214-11 PIN, CONNECTOR (B3PS-VH) 3P
1-564-526-11 PLUG, CONNECTOR 11P
< DIODE >
D832
8-719-510-68 DIODE D5SBA204101
< FUSE >
0 F951
0 F961
0 F962
0 F963
0 F964
1-533-949-31
1-533-949-31
1-533-949-31
1-532-506-31
1-532-506-31
FUSE, CYLINDRICAL (TIME LUG)(T8AL/250V)
FUSE, CYLINDRICAL (TIME LUG)(T8AL/250V)
FUSE, CYLINDRICAL (TIME LUG)(T8AL/250V)
FUSE (T6.3AL/250V)
FUSE (T6.3AL/250V)
< RESISTOR >
0 R951
0 R952
0 R953
1-219-121-11 FUSIBLE
1-219-121-11 FUSIBLE
1-219-119-81 FUSIBLE
0.22
0.22
0.1
5%
5%
5%
1/4W
1/4W
1/4W
< SWITCH >
0 VS901
1-771-291-11 SWITCH, POWER (VOLTAGE SELECT)
< TRANSFORMER >
0 T951
1-435-246-11 TRANSFORMER, POWER
**************************************************************
A-4724-882-A VIDEO BOARD, COMPLETE
********************
< CAPACITOR >
C101
C102
C103
C104
C201
20%
50V
6.3V
50V
6.3V
50V
1-124-778-00
1-163-143-00
1-163-017-00
1-126-206-11
1-124-778-00
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
22uF
0.0012uF
0.0047uF
100uF
22uF
20%
5%
5%
20%
20%
6.3V
50V
50V
6.3V
6.3V
C202
C203
C301
C302
C303
1-163-143-00
1-163-017-00
1-163-127-00
1-163-127-00
1-163-235-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0012uF
0.0047uF
270PF
270PF
22PF
5%
5%
5%
5%
5.00%
50V
50V
50V
50V
50V
C304
C305
C306
C310
1-163-235-11
1-163-263-11
1-163-263-11
1-163-137-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
330PF
330PF
680PF
5.00%
5.00%
5.00%
5%
50V
50V
50V
50V
5%
20%
20%
20%
50V
6.3V
16V
50V
6.3V
5.00% 50V
5.00% 50V
5.00% 50V
50V
50V
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
88
VIDEO
Ref. No.
Part No.
Description
C565
C566
C568
C569
C570
1-126-206-11
1-165-319-11
1-126-206-11
1-126-206-11
1-126-206-11
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
100uF
0.1uF
100uF
100uF
100uF
20%
20%
20%
20%
6.3V
50V
6.3V
6.3V
6.3V
Remark
C573
C574
C576
C577
1-163-235-11
1-163-235-11
1-163-235-11
1-163-235-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
22PF
22PF
22PF
5.00%
5.00%
5.00%
5.00%
50V
50V
50V
50V
Ref. No.
Part No.
Description
L502
L503
1-216-296-91 SHORT 0
1-216-296-91 SHORT 0
L504
L505
L506
L507
L508
1-410-375-11
1-216-296-91
1-216-296-91
1-216-296-91
1-216-296-91
L509
L510
1-216-296-91 SHORT 0
1-216-296-91 SHORT 0
Remark
INDUCTOR CHIP 3.3uH
SHORT 0
SHORT 0
SHORT 0
SHORT 0
< CONNECTOR >
< TRANSISTOR >
* CN301
CN501
CN503
1-564-506-11 PLUG, CONNECTOR 3P
1-770-706-11 CONNECTOR, FFC/FPC 23P
1-779-416-11 CONNECTOR,FFC(LIF(NON-ZIF))13P
< TRIMMER >
CT503
8-719-054-23 DIODE RB706D-40-T146
8-719-422-12 DIODE UDZ-TE-17-3.9B
8-719-018-51 DIODE CL-170R-CD-T
< IC >
IC101
IC401
IC501
IC502
IC504
8-759-701-40
8-759-177-02
8-759-269-92
8-759-672-41
8-759-269-92
IC
IC
IC
IC
IC
NJM2100M(TE2)
NJM2267M(TE2)
SN74HCU04ANSR
M30620MC-A17FP
SN74HCU04ANSR
IC505
IC506
IC507
IC509
8-759-535-48
8-759-573-23
8-759-342-01
8-759-535-62
IC
IC
IC
IC
CL680T-D1
LC372100PM-J48-TLA
MSM514260C-60JS
PCM1727E-2/T2
< JACK >
J301
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2712-GL-TE85L
2SC2712-GL-TE85L
2SC2712-GL-TE85L
2SC2712-GL-TE85L
DTC114TKA-T146
Q307
Q308
Q310
Q453
Q454
8-729-024-91
8-729-024-91
8-729-024-91
8-729-026-50
8-729-026-50
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2712-GL-TE85L
2SC2712-GL-TE85L
2SC2712-GL-TE85L
2SA1037K-T-146-QR
2SA1037K-T-146-QR
Q502
Q531
8-729-024-91 TRANSISTOR 2SC2712-GL-TE85L
8-729-140-75 TRANSISTOR 2SD999-T1-CLCK
< RESISTOR >
R101
R102
R103
R105
R201
1-216-073-00
1-208-441-61
1-208-441-61
1-216-295-91
1-216-073-00
METAL CHIP
RES-CHIP
RES-CHIP
SHORT 0
METAL CHIP
10K
1.5K
1.5K
5%
2%
2%
1/10W
1/10W
1/10W
10K
5%
1/10W
R202
R203
R205
R301
R302
1-208-441-61
1-208-441-61
1-216-295-91
1-216-624-11
1-216-624-11
RES-CHIP
RES-CHIP
SHORT 0
METAL CHIP
METAL CHIP
1.5K
1.5K
2%
2%
1/10W
1/10W
75
75
0.5%
0.5%
1/10W
1/10W
R305
R306
R307
R308
R309
1-216-041-00
1-216-073-00
1-216-049-91
1-216-049-91
1-216-057-00
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
METAL CHIP
470
10K
1K
1K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R312
R313
R314
R315
R316
1-216-073-00
1-216-033-00
1-216-033-00
1-216-047-91
1-216-651-11
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
10K
220
220
820
1K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R317
R318
R319
R320
R321
1-216-669-11
1-216-033-00
1-216-049-91
1-216-643-11
1-216-031-00
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
5.6K
220
1K
470
180
0.5%
5%
5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R324
R325
R327
R328
R329
1-216-022-00
1-216-295-91
1-216-031-00
1-216-649-11
1-216-643-11
METAL CHIP
SHORT 0
METAL CHIP
METAL CHIP
METAL CHIP
75
5%
1/10W
180
820
470
5%
0.5%
0.5%
1/10W
1/10W
1/10W
R332
1-216-645-11 METAL CHIP
560
0.5%
1/10W
1-537-943-11 TERMINAL, S (S VIDEO OUT)
< JUMPER RESISTOR >
JW101
JW201
JW401
JW402
JW403
1-216-295-91
1-216-295-91
1-216-295-91
1-216-295-91
1-216-295-91
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JW404
JW405
JW413
JW421
JW422
1-216-295-91
1-216-295-91
1-216-295-91
1-216-295-91
1-216-295-91
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JW502
JW503
JW504
JW505
1-216-295-91
1-216-295-91
1-216-295-91
1-216-295-91
SHORT
SHORT
SHORT
SHORT
0
0
0
0
< COIL >
L301
L302
L501
8-729-024-91
8-729-024-91
8-729-024-91
8-729-024-91
8-729-027-44
1-141-539-11 CAP, ADJ 10PF
< DIODE >
D301
D501
D502
Q301
Q302
Q303
Q304
Q306
1-410-372-21 INDUCTOR CHIP 1.8uH
1-410-372-21 INDUCTOR CHIP 1.8uH
1-216-296-91 SHORT 0
89
Ref. No.
Part No.
Description
R333
R335
R336
R337
1-216-031-00
1-216-079-00
1-216-073-00
1-216-667-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
180
18K
10K
4.7K
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
R340
R341
R342
R403
R404
1-216-022-00
1-216-121-91
1-216-022-00
1-216-057-00
1-216-057-00
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
75
1M
75
2.2K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R405
R406
R411
R412
R414
1-216-073-00
1-216-079-00
1-216-073-00
1-216-073-00
1-216-081-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
18K
10K
10K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R415
R423
R424
R425
R426
1-216-081-00
1-216-055-00
1-216-049-91
1-216-073-00
1-216-073-00
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
22K
1.8K
1K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R457
R458
R459
R461
R462
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R463
R464
R501
R502
R503
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R504
R505
R506
R507
R508
1-216-025-91
1-216-025-91
1-216-025-91
1-216-073-00
1-216-081-00
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
100
100
100
10K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R509
R510
R511
R512
R513
1-216-081-00
1-216-081-00
1-216-081-00
1-216-081-00
1-216-081-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
22K
22K
22K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R514
R516
R517
R518
R519
1-216-081-00
1-216-073-00
1-216-073-00
1-216-073-00
1-216-025-91
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
22K
10K
10K
10K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R520
R523
R530
R531
R532
1-216-057-00
1-216-013-00
1-216-081-00
1-216-025-91
1-216-025-91
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
2.2K
33
22K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R533
R534
R535
R536
R537
1-216-025-91
1-216-073-00
1-216-073-00
1-216-033-00
1-216-025-91
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
100
10K
10K
220
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R538
R542
R543
1-216-073-00 METAL CHIP
1-216-049-91 RES-CHIP
1-216-685-11 METAL CHIP
10K
1K
27K
5%
5%
0.5%
1/10W
1/10W
1/10W
90
Remark
Ref. No.
Part No.
Description
Remark
R544
R545
1-216-659-11 METAL CHIP
1-216-025-91 RES-CHIP
2.2K
100
0.5%
5%
1/10W
1/10W
R546
R547
R548
R549
R550
1-216-049-91
1-216-295-91
1-216-049-91
1-216-025-91
1-216-025-91
RES-CHIP
SHORT 0
RES-CHIP
RES-CHIP
RES-CHIP
1K
5%
1/10W
1K
100
100
5%
5%
5%
1/10W
1/10W
1/10W
R551
R552
R554
R555
R556
1-216-025-91
1-216-025-91
1-216-025-91
1-216-121-91
1-216-025-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
1M
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R557
R558
R559
R560
R561
1-216-025-91
1-216-073-00
1-216-073-00
1-216-051-00
1-216-049-91
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
100
10K
10K
1.2K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R562
R563
R564
R565
R566
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R567
R568
R569
R571
R572
1-216-073-00
1-216-073-00
1-216-073-00
1-128-065-11
1-216-073-00
METAL CHIP
METAL CHIP
METAL CHIP
ELECT CHIP
METAL CHIP
10K
10K
10K
68UF
10K
5%
5%
5%
20.00%
5%
1/10W
1/10W
1/10W
10V
1/10W
R573
R574
R577
R578
R579
1-216-073-00
1-216-073-00
1-216-081-00
1-216-081-00
1-216-073-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
22K
22K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R580
1-216-073-00 METAL CHIP
10K
5%
1/10W
< SWITCH >
S501
1-571-395-11 SWITCH, SLIDE (SYSTEM SELECT)
< VIBRATOR >
X501
X503
1-767-510-41 VIBRATOR, CERAMIC (10MHz)
1-767-519-11 VIBRATOR, CRYSTAL (27MHz)
**************************************************************
Ref. No.
Part No.
Description
1
2
54
64
153
1-769-977-11
1-693-488-11
1-773-150-11
1-751-688-11
1-790-660-11
MISCELLANEOUS
*************
WIRE (FLAT TYPE) (13 CORE)
TUNER (FM/AM)
WIRE (FLAT TYPE) (21 CORE)
WIRE (FLAT TYPE) (13 CORE)
WIRE (FLAT TYPE) (23 CORE)
156
158
0 162
0 163
164
1-773-056-11
1-773-032-11
1-569-008-21
1-777-071-51
1-790-288-11
WIRE (FLAT TYPE) (17 CORE)
WIRE (FLAT TYPE) (15 CORE)
ADAPTOR, CONVERSION 2P
CORD, POWER
WIRE (FLAT TYPE) (13 CORE)
465
507
0 601
602
M901
1-454-887-21
1-452-925-21
8-820-020-02
1-769-069-11
1-763-072-11
SOLENOID, PLUNGER
MAGNET ASSY
OPTICAL PICK-UP KSS-213D/Q-NP
WIRE (FLAT TYPE) (16 CORE)
FAN, D.C.
0 T951
FL601
1-435-246-11 TRANSFORMER, POWER
1-517-940-11 INDICATOR TUBE, FLUORESCENT
Remark
**************************************************************
**********
HARDWARE LIST
**********
SCREW +BVTT 3X6 (S)
SCREW +BVTT 3X8 (S)
SCREW +BVTP 3X8 TYPE2 N-S
SCREW +BVTT 4X8 (S)
SCREW +BVTP 3X16 TYPE2 IT-3
#1
#2
#3
#4
#8
7-685-871-01
7-685-872-09
7-685-646-79
7-685-881-09
7-685-650-79
#11
7-628-254-05 SCREW +PS 2.6X5
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
91
HCD-LV80
9-929-222-11
Sony Corporation
Home Audio Division Company
92
2000C0923-1D
Printed in Japan © 2000. 3
Published by Quality Assurance Dept.
Download PDF
Similar pages