Untitled - Webcollage.net

TABLE OF CONTENTS
A Electric Car Specifications
2
B List of Parts
4
CAssembly
5
D Battery Charging
7
E How to Use
9
F Safety Precautions
9
G Simple Repairs
10
H Maintaining your Vehicle
10
I
11
About Thermal Fuses
THIS VEHICLE MUST BE ASSEMBLED BY AN ADULT.
PLEASE READ THE MANUAL CAREFULLY BEFORE OPERATION.
A
Electric car specifications
SUITABLE AGE
18-36 Months
CAPACITY
under 45 lbs (20 kg)
SPEED
2.5km/H
CHARGER/INPUT
100-240V AC 0.16A 50/60HZ
CHARGING TIME
8-10 Hours
BATTERY
6V 4.5Ah, 1xBattery
SIZE OF CAR
70 x 42 x 47cm
CHARGING TIMES
300 times
OUTPUT
DC 7.3V 500mA
!
WARNING
CALIFORNIA PROPOSITION 65 WARNING
This product’s battery contains or emits chemicals known to the State of California to cause
cancer and birth defects or other reproductive harm.
If you have any questions, please call the Winston service phone number
1-877-901-8811 instead of returning to the retailer where purchased.
2
0811
WARNINGS AND CAUTIONS
!
WARNING
•To reduce the risk of injury, adult supervision is required. Never use in roadways, near
motor vehicles, on or near steep inclines or steps, swimming pools or other bodies of
water. Always wear shoes and a helmet.
• Never allow more than 1 rider.
ELECTRICAL HAZARD
!
WARNING
TO PREVENT FIRE AND ELECTRIC SHOCK:
•Only use battery and charger provided and specified by manufacturer.
Use of the wrong type of battery for charger could cause a fire or explosion.
•DO NOT use the battery or charger for any other product. Overheating, fire or
explosion could occur.
•NEVER modify the electric circuit system. Alterations could cause a shock, fire or explosion.
•DO NOT allow any type of liquid on the battery or its components. Explosive gases are
created during charging. DO NOT charge near heat or flammable materials. Charge in a
well ventilated area ONLY.
•Charge the battery in a dry area ONLY.
•DO NOT open the battery. Battery contains lead acid and other materials that
are toxic and corrosive.
•ONLY ADULTS may handle or charge the battery. NEVER allow child to handle or charge
the battery. Battery is heavy and contains lead acid (electrolyte).
•DO NOT drop the battery. Permanent damage to the battery could occur or
cause serious injury.
•Before charging the battery, check for wear and damage to the battery, charger and the
connectors. DO NOT charge the battery if any damage to parts has occurred. Replace
with manufacturer’s parts ONLY.
•DO NOT allow the battery to drain completely. Recharge the battery after each use or
once a month if not used regularly.
•DO NOT charge battery upside down.
•Always secure the battery with the bracket. Battery can fall out and injure a child
if vehicle tips over.
•If a battery leak develops, avoid contact with skin or eyes. Flush with cool water for at
least 15 minutes and call a physician.
•If acid comes in contact with skin or eyes, flush with cool water for at least 15 minutes
and call a physician.
•If acid is internally ingested, give water, milk of magnesia or egg white immediately.
Never give emetics or induce vomiting. Call a physician.
0811
3
B
LIST OF PARTS
(1) Body
(2) Front Wheel Assembly
(3) Handlebar
(4) Seat
(5) Self-Tapping Screw
(6) Machine Screw
(7) Lock Nut Wrench
(8) Charger
(9) Manual
(2)
(1)
(3)
(4)
(5)
X2
(6)
(7)
(9) Manual
(8)
Tools Needed: Phillips Head Screwdriver
4
040611
0811
0811
C
ASSEMBLY
1
3
• Remove the locknut and washer off the Handlebar
steering column.
• Locate the Front Wheel Assembly.
• Flip the vehicle upside down and insert the Front
Wheel Assembly into the Body as indicated.
• Keeping vehicle upright assemble Handlebar by
placing it down into the large opening on front
of vehicle.
4
Lock Nut
Steering Linkage
2
Steering
Column
Rounded Side Up
Lock Nut Wrench
• Use the Self-Tapping screw to secure the Wheel
Assembly to the Body.
• Turning vehicle over, ensure steering column is
placed through the steering linkage.
• Repeat this step for the other side of the vehicle.
• Place the lock nut (rounded side up) and washer
onto the end of the steering column. Tighten the
lock nut firmly with provided Lock Nut Wrench.
0811
5
C
ASSEMBLY
5
6
6
• Connect Handlebar and motor connectors.
• Use Machine Screw to securely fasten the
Seat to the Body of the vehicle as indicated.
0811
BATTERY CHARGING
D
IMPORTANT! Before first time use, charge the battery for at least 10 hours.
DO NOT recharge the battery after power is drained or the vehicle stops completely.
ALWAYS recharge the battery when the vehicle begins to slow down or shows signs of a
low battery. Recharge the battery after each use or once a month if not used regularly.
To maintain battery life never charge the battery longer than 15 hours.
1
2
DC Charging Outlet
• Locate the DC charging outlet on the back of the
quad under the left rear wheel fender.
0811
• Connect DC pin from provided charger to DC
charging outlet.
7
BATTERY CHARGING
D
3
4
Charger Indicator light.
• Plug DC charger into wall outlet.
NOTE: A red light on the charger indicates the
battery is charging. Quad will not work while the
battery is charging!
8
• The red light on the charger turns green
when the battery is fully charged.
• Disconnect the DC pin from the DC
charging socket.
0811
E
HOW TO USE
! WARNING
Press
•This quad is equipped with a self-resetting
external built-in thermal fuse.
Please see page 11 for more details.
• Press button to go, release button to stop.
Safety PRECAUTIONS
f
•Your new battery must be charged for at least 10 hours before you use it in your vehicle for
the first time. We recommend that you start charging your battery before beginning assembly
of your vehicle.
•The child must have adult supervision at all times.
•Do not ride on the road, footpaths, near pools, or bodies of water.
•Do not allow children under the suitable age to ride the vehicle; please refer to
the age grading.
•Do not allow rider greater than the recommended weight rating or overaged children to
use the vehicle.
•To “stop“ you must take your hand off the button.
•Charging should only be done by an adult.
•An adult must teach the child how to operate the vehicle.
•Do not ride on slopes greater than 15 degrees, sand, or other soft, wet, or slippery surfaces.
•Do not use a different size battery.
•The vehicle is designed to load only one person. Overload is prohibited.
•This product should be assembled and checked by adults before use.
•Do not wash the vehicle with water. Just clean it with a cloth.
0811
9
G
SIMPLE REPAIRS
PROBLEM
H
POSSIBLE SOLUTION
Car won’t start
Make sure all wires are connected.
Make sure the button on the handlebar is pressed down to the ON position.
Speed is too slow
Battery needs to be charged.
Battery won’t charge
Make sure you are using one 6-Volt battery in
the vehicle.
Battery may need to be replaced
Check to see if charger is damaged.
Never use a charger with torn wires.
MAINTAINING YOUR VEHICLE
•Occasionally use a lightweight oil to lubricate moving parts such as wheels and
the steering linkages.
•Park the vehicle indoors or cover it with a tarp to protect it from wet weather.
•Keep the vehicle away from sources of heat, such as stoves and heaters.
Plastic parts may melt.
•ADULTS ONLY: Recharge the battery after each use. Recharge the battery at least once a
month when the vehicle is not being used.
•DO NOT wash the vehicle with a hose. DO NOT wash the vehicle with soap and water. DO
NOT drive the vehicle in rainy or snowy weather. Water will damage the motor electric
system and battery.
•Clean the vehicle with a soft, dry cloth. To restore shine to plastic parts, use a non wax
furniture polish. DO NOT use car wax. DO NOT use abrasive cleaners.
•DO NOT drive the vehicle in loose dirt, sand or fine gravel, which could damage moving
parts, motors or the electric system.
10
0811
0811
ABOUT THERMAL FUSES
I
Your PowerQuad 6-Volt battery is equipped with an external built-in thermal fuse. The thermal
fuse is a self-resetting safety device which automatically “trips” and shuts down operation of
the vehicle if the vehicle is overloaded or the driving conditions are too severe. Once a fuse has
“tripped,” DO NOT CONTINUOUSLY PUSH ON THE POWER BUTTON. It will automatically
reset itself after approximately 2 minutes and allow the vehicle to resume normal operations. To
avoid repeated automatic shut-downs, do not overload the vehicle by exceeding the 45 lbs (20
kg) maximum weight capacity or by towing anything behind the vehicle. Avoid severe driving
conditions, such as driving up slopes or running into fixed objects, which can cause the wheels
to stop spinning while power is still being supplied to the motors.
Disposal of battery
•Your battery is a non-spillable sealed lead-acid battery. It must be recycled or disposed of in
an environmentally sound manner.
•Do not dispose of a lead-acid battery in a fire. The battery may explode or leak.
•Do not dispose of a lead-acid battery in your regular, household trash. The incineration,
land filling or mixing of sealed lead-acid batteries with household trash is prohibited by law
in most areas.
•Return an exhausted battery to a federal or state approved lead-acid battery recycler.
Contact your local waste management officials for other information regarding the
environmentally sound collection, recycling and disposal of lead-acid batteries. If you live in
the State of Florida or the State of Minnesota, it is prohibited by law for anyone to throw
away lead-acid batteries in the municipal waste system.
0811
11
11
WARRANTY
Your Electric Vehicle is warrantied by Winston Company, Inc. for 90 days from date of original
purchase against defects in materials or workmanship. This warranty covers normal use and
the coverage is not extended if the unit was damaged by unreasonable use, neglect,
accident, abuse, misuse, improper service or other causes not arising out of defects in
material or workmanship. This warranty does not cover any liability claims for breach of warranty.
PLEASE SAVE YOUR ORIGINAL SALES RECEIPT.
Should you need service or assistance with your vehicle during the warranty period, do not
return the vehicle to the store. Please call our Customer Care Center at: 1-877-901-8811,
Fax 1-479-271-6549, 9 a.m. – 5 p.m. CST Monday through Friday, or visit our web site
www.winstonintl.com.
Do not send any vehicles back to Winston Company, Inc. without a pre-approved
authorization number. All returns must be sent pre-paid and customer is responsible for all
other related shipping and handling charges.
This warranty gives you specific legal rights.
before first time use, charge the battery for at least 10 hours.
Never charge the battery longer than 15 hours.
!
WARNING
•Adult Assembly Required.
•To reduce the risk of injury, adult supervision is required.
•Always wear your helmet when riding.
•Riding at night or dusk is prohibited.
•Never use in roadways or traffic, near cars, on or near steep inclines or steps, narrow
passages, swimming pools or other bodies of water.
•One child per vehicle only! Never allow more than 1 rider.
•Teach appropriate safety rules to your child before allowing operation of this vehicle.
•Always wear proper protective footwear.
•Only ride on smooth, flat, dry surfaces.
•In un-assembled state, this package contains potentially hazardous small parts.
Please keep out of reach of small children.
Enjoy your riding!
If you have any questions, please call the Winston service phone number
1-877-901-8811 instead of returning to the retailer where purchased.
OUR PRODUCTS ARE SUITABLE FOR ASTM F963.
Download PDF
Similar pages