INTERIOR COMPONENT
SYSTEM
S1000
SERVICE
INTERIOR COMPONENT SYSTEM
Manual
CONTENTS
1. Precautions
2. Specifications
3. Disassembly and Reassembly
4. Alignment and Adjustments
5. Special Circuit Descriptions
6. Troubleshooting
7. Exploded Views and Parts List
8. Electrical Parts List
9. Block Diagrams
10. PCB Diagrams
11. Wiring Diagram
12. Schematic Diagrams
© Samsung Electronics Co.,Ltd. Jan. 1997
Code no. AH68-20149A
1. Precautions
Follow these safety, servicing and ESD precautions to prevent damage and protect against potential hazards
such as electrical shock and X-rays.
1-1 Safety Precautions
1. Be sure that all of the built-in protective
devices are replaced.
2. When reinstalling the chassis and its
assemblies, be sure to restore all protective
devices, including control knobs and
compartment covers.
3. Make sure that there are no cabinet
openings through which people-particularly children--might insert fingers
and contact dangerous voltages. Such
openings include the spacing between the
picture tube and the cabinet mask,
excessively wide cabinet ventilation slots,
and improperly fitted back covers.
4. Design Alteration Warning:
Never alter or add to the mechanical or
electrical design of the unit. Example: Do
not add auxiliary audio or video connectors. Such alterations might create a safety
hazard. Also, any design changes or additions will void the manufacturer's warranty.
5. Leakage Current Hot Check (Figure 1-1):
Warning: Do not use an isolation
transformer during this test. Use a leakagecurrent tester or a metering system that
complies with American National Standards
Institute (ANSI C101.1, Leakage Current for
Appliances), and Underwriters Laboratories
(UL Publication UL1410, 59.7).
With the unit completely reassembled, plug
the AC line cord directly into a 120V AC
outlet. With the unit's AC switch first in
the ON position and then OFF, measure the
current between a known earth ground
(metal water pipe, etc.) and all exposed
metal parts. Examples: Handle brackets,
metal cabinets, screwheads and control
shafts. The current measured should not
exceed 0.5 milliamp. Reverse the powerplug prongs in the AC outlet and repeat.
(Reading should
not be above
0.5mA)
Device
Under
Test
Leakage
Currant
Tester
Test all
exposed metal
surfaces
2-Wire Cord
Also test with
plug reversed
(using AC adapter
plug as required)
Earth
Ground
Fig. 1-1 AC Leakage Test
6. Insulation Resistance Cold Check:
(1) With the unit's AC plug disconnected
from the AC source, connect an electrical
jumper across the two AC prongs. (2) Set
the power switch to ON. (3) Measure the
resistance between the shorted AC plug and
any exposed metallic parts. Example:
Screwheads, antenna, control shafts or
handle brackets.
If any of the exposed metallic parts has a
return path to the chassis, the measured
resistance should be between 1 and 5.2
megohms. If there is no return path, the
measured resistance should be "infinite." If
the resistance is outside these limits, a shock
hazard might exist. See Figure 1-2
Antenna
Terminal
Exposed
Metal Part
ohm
Ohmmeter
Fig. 1-2 Insulation Resistance Test
Samsung Electronics
1-1
Precautions
1-1 Safety Precautions (Continued)
7. Components, parts and wiring that appear
to have overheated or that are otherwise
damaged should be replaced with parts
that meet the original specifications.
Always determine the cause of damage or
overheating, and correct any potential
hazards
8. Observe the original lead dress, especially
near the following areas: Antenna
wiring, sharp edges, and especially the
AC and high voltage power supplies.
Always inspect for pinched, out-of-place,
or frayed wiring. Do not change the
spacing between components and the
printed circuit board. Check the AC
power cord for damage. Make sure that
no wires or components touch thermally
hot parts.
9. Product Safety Notice:
Some electrical and mechanical parts
have special safety-related characteristics
which might not be obvious from visual
inspection. These safety features and the
protection they give might be lost if the
replacement component differs from the
original--even if the replacement is rated
for higher voltage, wattage, etc.
10 Components that are critical for safety are
indicated in the circuit diagram by
shading,
or
. Use replacement
components that have the same ratings,
especially for flame resistance and
dielectric strength specifications. A
replacement part that does not have the
same safety characteristics as the original
might create shock, fire or other hazards.
1-2 Servicing Precautions
Warning1:
First read the "Safety Precautions" section of this manual. If some unforeseen circumstance creates a conflict
between the servicing and safety precautions, always follow the safety precautions.
1. Servicing precautions are printed on the
cabinet. Follow them.
2. Always unplug the unit's AC power cord
from the AC power source before
attempting to: (a) Remove or reinstall any
component or assembly, (b) Disconnect an
electrical plug or connector, (c) Connect a
test component in parallel with an
electrolytic capacitor.
3. Some components are raised above the
printed circuit board for safety. An
insulation tube or tape is sometimes used.
The internal wiring may be clamped to
prevent contact with thermally hot
components. Reinstall all such elements to
their original position.
4. After servicing, always check that the
screws, components and wiring have been
correctly reinstalled. Make sure that the
portion around the serviced part has not
been damaged.
1-2
5. Check the insulation between the blades of
the AC plug and accessible conductive parts
(examples: metal panels, input terminals
and earphone jacks).
6. Insulation Checking Procedure: Disconnect
the power cord from the AC source and
turn the power switch ON. Connect an
insulation resistance meter (500V) to the
blades of the AC plug.
The insulation resistance between each
blade of the AC plug and accessible
conductive parts (see above) should be
greater than 1 megohm.
7. Never defeat any of the B+ voltage
interlocks. Do not apply AC power to the
unit (or any of its assemblies) unless all
solid-state heat sinks are correctly installed.
8. Always connect a test instrument's ground
lead to the instrument chassis ground
before connecting the positive lead; always
remove the instrument's ground lead last.
Samsung Electronics
Precautions
1-3 Precautions for Electrostatically Sensitive Devices (ESDs)
1. Some semiconductor ("solid state") devices
are easily damaged by static electricity.
Such components are called Electrostatically
Sensitive Devices (ESDs). Examples include
integrated circuits and some field-effect
transistors. The following techniques will
reduce the occurrence of component
damage caused by static electricity.
5. Use only a grounded-tip soldering iron
when soldering or unsoldering ESDs.
2. Immediately before handling any
semiconductor components or assemblies,
drain the electrostatic charge from your
body by touching a known earth ground.
Alternatively, wear a discharging
wrist-strap device. (Be sure to remove it
prior to applying power--this is an electric
shock precaution.)
7. Do not remove a replacement ESD from its
protective package until you are ready to
install it. Most replacement ESDs are
packaged with leads that are electrically
shorted together by conductive foam,
aluminum foil or other conductive
materials.
6. Use only an anti-static solder removal
device. Many solder removal devices are
not rated as "anti-static" (these can
accumulate sufficient electrical charge to
damage ESDs).
8. Immediately before removing the protective
material from the leads of a replacement
ESD, touch the protective material to the
chassis or circuit assembly into which the
device will be installed.
3. After removing an ESD-equipped assembly,
place it on a conductive surface such as
aluminum foil to prevent accumulation of
electrostatic charge.
9. Minimize body motions when handing
unpackaged replacement ESDs. Motions
such as brushing clothes together, or lifting
a foot from a carpeted floor can generate
enough static electricity to damage an ESD.
4. Do not use freon-propelled chemicals.
These can generate electrical charges that
damage ESDs.
1-4 Special Precautions and Warning Labels for Laser Products
(UL)
(EU)
(CSA)
This Product Complies with
DHHS Rules 21CFR, Sub
chapter J.At date of Manufacture
CERTIFIED ONLY TO CANADIAN
ELECTRICAL CODE.
CLASS 1
LASER PRODUCT
CERTIFIE EN VERTU DU CODE
CANADIAN DE LELETRICITE
SEULEMENT
Fig. 1-3 Warning Labels (Location: Enclosure Block)
(SCAN)
CAUTION : INVISIBLE LASER RADIATION WHEN OPEN
AND INTERLOCKS DEFEATEO AVOIDEXPOSURE TO BEAM
ADVARSEL: USYNLIG LASERSTRÅLING VED ABNING
NÅR SIKKERHEDSAFBRYDERE ER UDE AF FUNKTION
UNDGA UDSAETTELSE FOR STRALING
VARO:AVATTAESSA JA SUOJALUKITUS OHITETTAESSA
OLET ALTTINA NAKYMATTÖMALLE LASERSATEILYLLE ALA
KATSO SATEESEEN!
VARNING:OSYNLIG LASERSTRÅLNING NAR DENNA DEL
(EU)
UL
CSA
EU
SCAN
: Manufactured for U.S.A. Market.
: Manufactured for Canadian Market.
: Manufactured for European Market.
: Manufactured for Scandinavian
Market.
AR OPPNAD OCH SPARREN AR URKOPPLAD BETRAKTA
EJSTRÅLEN!
Fig. 1-4 Warning Labels (Location: Disc Clamper, Inner Side of Unit Door or Nearby Unit Chassis )
Samsung Electronics
1-3
Precautions
1-4 Special Precautions and Warning Labels for Laser Products (Continued)
1-4-1 Warnings
1. When servicing, do not approach the LASER
exit with the eye too closely. In case it is
necessary to confirm LASER beam emission,
be sure to observe from a distance of more
than 30 cm from the surface of the objective
lens on the optical pick-up block.
2. Do not attempt to handle the objective lens
when the DISC is not on the tray.
1-4-2 Laser Diode Specifications
Material: GaAs+ GaAlAs
Wavelength: 760-800 nm
Emission Duration: Continuous
Laser Output: 0.2 mw (measured at a
1.6 mm distance from the objective lens
surface on the optical pick-up block.)
1-4-3 Handling the Optical Pick-up
1. Static electricity from clothing or the body
may cause electrostatic breakdown of the
laser diode in the Optical Pickup. Follow
this procedure:
2. Place a conductive sheet on the work bench
(i.e., the black sheet used for wrapping
repair parts.) Note: The surface of the work
bench should be covered by a copper
ground plane, which is grounded.
3. The repair technician must wear a wrist
strap which is grounded to the copper sheet.
4. To remove the Optical Pickup block:
Place the set on the conductive sheet, and
momentarily touch the conductive sheet
with both hands. (While working, do not
allow any electrostatic sources--such as
clothes--to touch the unit.)
5. Ground the "Short Terminal" (located on the
PCB, inside the Pickup Assembly) before
replacing the Pickup. This terminal should
be shorted whenever the Pickup Assembly
is lifted or moved.
6. After replacing the Pickup, reopen the Short
Terminal. See diagrams below:
1M
THE UNIT
(1) WRIST-STRAP
FOR GROUNDING
short
terminal
SOH91VI(LDP)
1-4
short terminal
SOH91CI(CAR,walkman)
short
terminal
SOH-A1
(CMS-V10,CMS-V30)
CONDUCTIVE SHEET
1M
short
terminal
SOH94T4N
(CMS-V10,CMS-V30)
Samsung Electronics
2. Product Specfications
General
Amp
FM
Power source
230V
Power consumption
160W
Dimensions (mm)
825(W) x 330(H) x 118(D)
Power output
30W / Ch(6Ω),THD1%
Total harmonic distortion
0.08%
Frequency range
20Hz ~ 20kHz
Signal to noise ratio
80 dB
Channel separation
50 dB (1kHz)
Input sensitivity
250mV
Frequency range
87.5 ~ 108MHz
Usable sensitivity
1µV
Signal to noise ratio
64 dB
IF rejection ratio
70 dB
Total harmonic distoration
0.45%
Separation (Stereo)
35 dB
Frequency range
522 ~ 1611KHz
Usable sensitivity
600µV
Signal to noise ratio
40 dB
IF rejection ratio
30 dB
Total harmonic distortion
2%
Frequency range
125Hz ~ 12.5KHz
WOW FLUTTER
0.15%
Erasing effect
60 dB
Signal to noise ratio
40 dB
Total harmonic distortion
2.5%
Frequency response
20Hz ~ 20KHz(±1dB)
Signal to noise ratio
95 dB(1kHz 0dB)
Channel separation
90 dB(1kHz 0dB)
Total harmonic distortion
0.004%(1kHz 0dB)
Tuner
AM
Cassette
Compact Disc
Specifications are subject to change without notice.
Samsung Electronics
2-1
3. Disassembly and Reassembly
3-1 Frame-Jersey
1. Remove 4 screws ! holding the Frame-Jersey, and disassemble the Frame-Jersey (Arrow ÔAÕ).
2. Remove 2 screws @.
3. Remove 2 screws # and disassemble the Base-Set.
1
2
3
Base-Set
1
A
A
Frame-Jersey
Figure 3-1
Samsung Electronics
3-1
Disassembly and Reassembly
3-2 Front
1.
2.
3.
4.
5.
Disassemble the AssÕy-Glass (Arrow ÔAÕ).
Remove 4 screws !.
Remove 4 screws @ and disassemble the AssÕy-CD (Arrow ÔBÕ).
Remove 4 screws # and disassemble Decoration-Cassette (Arrow ÔCÕ).
Remove 4 screws $ and disassemble the Housing-Cassette (Arrow ÔCÕ).
Ass'y CD
2
B
1
Ass'y-Glass
4
Housing-Cassette
3
A
C
Decoration-Cassette
Figure 3-2
3-2
Samsung Electronics
3-3 Frame-Main Ass’y
1. Remove 3 screws @.
2. Remove 11 screws !.
3. Disassemble the Frame-Main AssÕy (Arrow ÔAÕ).
2
1
A
Frame-Main Ass'y
Figure 3-3
Samsung Electronics
3-3
Disassembly and Reassembly
3-4 Key-Ass’y
1. Move the Gear (part of Gear-Box) to open the door. (Arrow ÔAÕ).
2. Disassemble the Knob-AssÕy (Arrow ÔCÕ).
A
Gear-Box
B
C
D
Door
Knob-Ass'y
Figure 3-4
3-4
Samsung Electronics
4. Alignment and Adjustments
4-1 Tuner
FM THD Adjustment
SSG FREQ.
MVR1
IFT2
Adjustment
point
(IFT6)
98 MHz
FM
Antenna SET
Terminal
Output
GND
FM SSG
FM DETECTOR COIL
Oscilloscope
Input
Speaker
Terminal
output
Minimum Distortion (Figure 4-1)
Distortion Meter
Input
IFT4
Figure4-1 IF CENTER and THD Adjustment
FM Antenna
30 dB
FM Search Level Adjustment
SSG FREQ.
Adjustment
point
(MSR1)
75Ω
SET
Dummy
98 MHz
GND
FM IN
FM SSG
SEMI-VR(5KB)
5 kB
“TUNED” is shown on FLT (Figure 4-2)
* Note : Adjust FM S.S.G Level to
EMF 21dB(Included Loss)
Figure4-2 FM Auto Search Level Adjustment
60 cm
AM IF Adjustment
SSG FREQ.
594 MHz
Adjustment
point
(IFT2)
AM IF COIL
FM
Antenna
Terminal
AM SSG
Level : Maximum (Figure 4-3)
Oscilloscope
VTVM
Figure4-3 AM IF Level Adjustment
Samsung Electronics
4-1
Alignment and Adjustments
4-2 Cassette Deck
4-2-2 To Adjust Playback Head
4-2-1 To Adjust Tape Speed
Recording /Play head
Notes
Notes
Frequency Counter
Cassette Deck
1) Measuring tape: i) MTT-111 (or equivalent)
(Tapes recorded with 3kHz)
2) Connect the cassette deck to the frequency counter
as shown in figure 4-4.
TP3
LINE OUT
output
Figure 4-4
Step
1
Item
Control
counter
Pre-Setup
Condition
Output
(connected
to the frequency
counter)
Reverse Play
1) Before the actual adjustment, clean the play/recording
head.
2) Measuring tape :
i) MTT-114NA(or equivalent 12.5kHz AZIMUTH control)
ii) MTT-150(or equivalent : Dolby level 200nwb/m)
3) Dolby NR SW OFF
4) The cassette deck is connections as shown in figure 4-6.
AZIMUTH control knob
Figure 4-5
VTVM
Pre-Setup
1) Deck:MTT-111
2) Press PLAY
SW button
To Adjust
Standard
Turn DSR3 to
left and right
3KHz ±1%
Oscilloscope
Cassette Deck
Remark
VH
DWA2
In Out
Figure 4-6
! Adjust Deck Replay Level
Step
Item
AZIMUTH
DWA2
Output
(VTVM is
connected to
the scope)
Replay
out Level
Same as
above
DWA2
1
DL4
DL5R
DSR1L
DWA3
DSR3
DSR2R
DSR4
DSR1R
DL5L
4-2
2
Pre-Setup
Condition
Pre-Setup
After putting MTT114NA into Deck 1
1) Press FWD PLAY
button.
2) Press REV PLAY
button.
PLAY MTT-150
on Deck .
To Adjust
1) Turn the control
knob to as shown
in Figure4-5.
2) Adjust the right
control screw to
playback REV. Mode
L-CH:Turn DSR1L
to the right and
left
R-CH:Turn DSR1R
to the right and
left
Standard
Max output
and same phase
(both channels)
25mV ±0.5dB
Remark
After
adjustment
secure it with
REGION
LOCK.
See the
diagram for
adjustment
locations.
DSR2L
Samsung Electronics
Alignment and Adjustments
4-2-3 To Adjust Recording PLAY
NOTES
1) Connect the measuring instruments as shown in Figure 4-7.
2) Set the DOLBY NR Switch off.
3) Measuring tape:
i) MTT-5562(or equivalent CrO2 recording)
ii) MTT-5512 (or equivalent: normal recording)
4) The input signals supply 1kHz 250mV into AUX IN of AMP (AUDIO OSC.)
Step
Pre-Setup
Insert MTT-5562
into Deck, then
press REC Pause
button.
To Adjust
Standard
Turn BIAS oscillator frequency coil
(DL4) to the
right and left
105kHz ±5%
See diagram
for
adjustment
locations
VTVM
Maximum
See diagram
for
adjustment
locations
BIAS OSC.
Frequency
Connect the
frequency
counter to
DWA3
Recording
play OSC.
level
Connect to DWA3 Insert MTT-5562 into Turn: DSR5R,5L
as shown in
the right and
Deck, then press
Figure4-7 and
left.
REC Pause button.
read VTVM
(DSR2L,2R: MAX
Condition)
1
2
Pre-Setup
Condition
Item
3
CrO2 REC Connect to
Insert MTT-5562 into
level
DWA3 as shown Deck, then press
adjustment in Figure 4-7 and
REC Pause button.
read the VTVM
4
Normal
REC.
level
adjustment
Connect to
DWA3 as shown
in Figure 4-7
and read the
VTVM
Audio OSC.
AUDIO
OSC
L-CH: Turn DSR2L VTVM
and
(27V ±5%)
R-CH: DSR2R to
the right and left
Insert MTT-5512 into DSR4 turn DSR4
to the right and
Deck, then press
left
REC Pause button.
Cassette Deck
VTVM
VTVM
VTVM
(14V ±5%)
Remark
See diagram
for
adjustment
locations
See diagram
for
adjustment
locations
Oscilloscope
LINE OUT
IN
AUX IN
IN
AUX
TP
DWA3
IN OUT
Figure 4-7
Samsung Electronics
4-3
Alignment and Adjustments
4-3 CD
4-3-2 To Adjust Tracking Gain (PLAY mode)
1.
2.
3.
Connect the ground terminal of the oscilloscope to Vref and (+) terminal to TE2.
Load and play the disc.
While the disc is running adjust the gain with WVR4 as shown below.
Low Frequency
Normal Frequency
0V
High Frequency
VOLT/DIV : 0.2V
TIME/DIV : 2mS
VOLT/DIV : 0.2V
TIME/DIV : 2mS
0V
0V
VOLT/DIV : 0.2V
TIME/DIV : 2mS
4-3-3 To Adjust Focus Gain (PLAY mode)
1.
2.
3.
Connect the ground terminal of the oscilloscope to Vref and (+) terminal to FE2.
Load and play the disc.
While the disc is running adjust the gain with WVR3 as shown in the following figure.
Low Frequency
Normal Frequency
High Frequency
250mV
100mV
100mV
0V
0V
0V
VOLT/DIV : 0.1V
TIME/DIV : 2mS
VOLT/DIV : 0.1V
TIME/DIV : 2mS
VOLT/DIV : 0.1V
TIME/DIV : 2mS
4-3-4 To Adjust E/F Balance (PLAY mode)
1.
2.
3.
4-3-1 To Adjust FOCUS BIAS (STOP mode)
1.
2.
3.
4.
Set Volt/Div of the oscilloscope to DC 100mV.
Ground the scope input and set the waveform to 0v, DC range.
Connect the GND terminal of the oscilloscope to Vref,
and (+) terminal to center of FE2.
Set WVR1 to 0mV.
4.
5.
6.
7.
8.
4-4
Set Time/Div of the oscilloscope to 2mS.
Set Volt/Div of the oscilloscope to 0.5V.
Ground the scope input and set to DC, and then
set the DC range.
Connect the ground terminal of the oscilloscope to Vref
and (+)terminal to TE2.
Load and play the disc.
Turn WVR4 counterclockwise to the minimum value.
Raise WVR2 and adjust the waveform so that its middle
comes to ground of the oscilloscope. (Or, until the upper half
of waveform becomes symmetrical to the bottom half,A=B)
Ajdut WVR4 (arrow) for normal sound.
0V
A=B
Samsung Electronics
5. Special Circuit Descriptions
5-1 CD
5-1-1 RF Amp (KA9220) : WIC01
58K
A
C
D
PD1
66
RFO
66
74
RF I-V AMP(1)
58K
PD2
Photo Detector
RF SUMMING
V1 AMP
R1
10K
65
B
R3
10K
R2
73
V2
RF
RF I-V AMP(2)
RF I-V Amp(I-1) and RF I-V Amp (I-2) are converted to voltage (via
internal resistance of 58k½) from the current of PD1 (A+C) and
PD2 (B+D):
These voltages are added by the RF summing amplifier.
The signal (A+B+C+D) is applied to RFO (No.2 terminal)
RF output voltage is calculated as follows :
VRF = -R3 x (iPD1 + iPD2)
= -R3 x (V1/R1 + V2/R2)
V2
V1
= -R3 x ( 10K + 10K )
R3
= 10K x (V1 + V2)
5-1-2 Focus Error Amp (KA9220) : WIC01
FOCUS ERROR Amp AMPLIFIES the difference
between RF I-V Amp (1) output (A+C) and RF I-V Amp (2) output (B+D)
These two signals are supplied to (-) and (+) input terminals of the
FOCUS ERROR Amp. The FOCUS ERROR signal resulting from this
difference voltage is applied to FE (Terminal No. 57).
The FE output voltage of this low frequency component varies according
to {(A+C) - (B+D)}.
VFE is calculated as follows:
VFE=(R2/R1) X (V2-V1) = 5.4(V2-V1)
This FOCUS ERROR voltage is sent to FOCUS SERVO.
R2
174K
C1 25P
-(B+D)
R1
V1 32K
FE
59
-(A+C)
32K
164K
C2 25P
FOCUS
ERROR
AMP
5-1-3 Focus Servo System (KA9220) : WIC01
When FS3 is ON, high-frequency gain decreases (time constant is set by pin17, pin19, and capacitor connected to
internal resistance). The capacitor between pin18 and GND sets the time constant to pass low freqencies in PLAY
mode.
3.6K
60K
FZC
FE1
58
20K
FSEO
FE2
0.0022
20K
48K
470K
60
DFCT
92K
PHASE
COMPENSATION
FS4
62
0.1UF
HFGD
10K
50K
470K
61
EFR
20
46K
580K
FCE
5.5U 11U
130K
FS2
FOCUS
COIL
120K
47
40K
FDFCT
0.1UF
48
ISET
180K
FS1
FS3
40K
FSW
0.1UF
27
21
VREG
6
PFSET
3
FSCH
4.7UF
The maximum frequency of focus phase compensation is inversely proportional to the resistance connected to pin 7.
Focus search peak is about 1.1 Vp-p, and is inversely proportional to the resistance connected to pins 22,23
(if this resistance changes, the peak of track jump and sled kick change). The inversion input of FZC comparator is set
to 5.7% of the difference between Vcc and VC (pin69) {(5.7% x (Vcc-Vc)}.
Note : If the resistance connected to pin 7 changes, the phase compensation peak of focus,tracking,sled servos change.
At the same time, Ôop-ampÕ dynamic range and offset voltage also change.
Samsung Electronics
5-1
Special Circuit Descriptions
5-1-4 Tracking Sled Servo System (KA9220) : WIC01
The capacitor between pins 15 and 16 attenuates high frequencies when TG2 is off. The maximum frequency of
tracking phase compensation is inversely proportional to the resistance connected to pin 7 (about 1.2kHz at 470k).
The tracking jump (FWD and REV) is determined when TM3 and TM4 are ON, and the peak voltage induced from
tracking coil is decided by both TM3 and TM4 current values and feedback resistance of pin 47.
Tracking jump max voltage = TM3 (TM4) current x feedback reisistance.
180K
0.022UF
22
23
ISET
VREG
TZC
51
TZC
100K
100K
S STOP
100K
0.047UF
S STOP
1K
50
BPF
TM6
150K
TE 1
470K
DFCT
TDFC1
PHASE
COMPENSATION
15
5.5U
56K SLED
DRIVER
39
110K
20K
TM2
TKEI
TM3
10K
0.1UF
10K
TM4
66PF
RTG
41
680K
54
16
40
SLEN
TM5
TE2
0.1UF
SLEI
100K
52
20K
SLED
1K
ATS
1K
ATC
8
5.5U
10K
TKEO
90K
47
120K
100K
48
TRACKING
COIL
TM7
82K
TGSW
470K
TG2
7
PFSET
470K
FWD or REV sled kick occurs when TM5 or TM6 is ON, and the peak voltage added to sled motor is decided by
TM5 or TM6 current and the feedbadk resistance of pin 41.
Sled jump max voltage= TM5 (TM6) current x feedback resistance
Each SW current is decided by the resistance connected to pin 22 and 23.
When the resistance is about 150½,
TM3 or TM4 = 11µA,
TM5 or TM6 = 22µA,
This current is inversely proportional to the resistor, variable within a range of 5 to 40µA for TM3.
STOP is the ON/OFF detection signal for the limit SW (or the sled motorÕs innermost cirumference).
5-1-5 Motor Drive (LB1649) : UIC4
1
OUT1
OUT2
10
3
OUT3
OUT4
4
9
Pre-Driver
Pre-Driver
VCC1
11
IN 1
8
Input Logic
Input Logic
Fin
2
IN 2
5-2
7
VCC2
12
VZ1
6
VZ2
5
IN3
IN4
IN 1
2
OUT1
OUT1
0
1
0
1
0
0
1
1
L
H
L
L
L
L
H
L
IN 3
4
OUT3
OUT4
0
1
0
1
0
0
1
1
L
H
L
L
L
L
H
L
Samsung Electronics
6. Troubleshooting
6-1 Amplifier
6-1-1 Power Malfunction
Malfunction of Audio Output
Yes
Check voltage of XIC3
No
Replace XIC03
Yes
Check waveform of XIC1
pins 16,18,25,27
No
Check XIC1 soldering condition
Yes
Check waveform of WIC41
pins 8,11,12
No
Replace WIC41
Check WIC41 soldering condtion
No
Replace XIC2L,2R
Check XIC2L,2R soldering condition
Yes
Check waveform of XIC2L,2R
pins 2,7
Yes
Check Amp operation
Samsung Electronics
6-1
Troubleshooting
6-1-2 FLT Malfunction
Connector inserted
correctly?
No
Reinsert the connector
Yes
Check voltage : AC 5V
at FRONT-PCB FLT?
No
Check Main-PCB Front PCB
connection and the voltage of
RWA3, pins2,3(AC 5V)
Yes
Check voltage at FIC1
pin 54(-33V)
No
Check the voltage of RZD5(-30V)
Yes
Replace FIC1(LC75710)
6-2
Samsung Electronics
Troubleshooting
6-1-3 No Output
Main PCB RC1,RC2
(STK4181V) pins 12,14
B+,B- circuits
No
Check the Fuse
No
Replace Fuse
Yes
Yes
Check the Power-Trans
Yes
Check the AQ1L,1R
Base B+ ?
Check for TR short
Replace it.
No
Yes
Is relay opened ?
Replace relay
No
Yes
Is mute selected ?
Restore sound with remocon
No
No
Check the RWA4 TR(B1566)
out : -12V
Replace TR(B1566)
Yes
Yes
Main PCB µ-com pins 82,83
Check the "H"
No
Samsung Electronics
Replace µ-com
Check if the output line is
short.
6-3
Troubleshooting
6-2 Cassette Deck
6-2-1 Power Malfunction
Main PCB µ-com VDD(5V)
normal?
UIC1 pins 18,47,90
No
Main PCB RIC1(BA3950A)
OUT: pin 3(5V) output
voltage normal
No
Yes
Yes
Main PCB
Does UX2(12MHz)
oscillate ?
No
Fuse OK ?
Replace Fuse
Yes
Replace µ-com
Replace RIC1(BA3950A)
No
Main PCB POSNS
voltage normal ?
(pin 29 ; 4.5V)
No
No
Check the Main PCB
RZD5 : 30V
normal ?
No
Check the Main PCB :
DWA6
Yes
Check the FIC1(LC75710) :
pin 54 Vp(30V)
Yes
Replace µ-com
6-4
Replace RZD5 30V
Yes
Replace FIC1(LC75710)
Samsung Electronics
Troubleshooting
6-2-2 FLT Malfunction
Connector inserted
correctly?
No
Reinsert the connector
Yes
Check voltage : AC 5V
at FRONT-PCB FLT?
No
Check Main-PCB Front PCB
connection and the voltage of
RWA3, pins2,3(AC 5V)
Yes
Check voltage at FIC1
pin 54(-33V)
No
Check the voltage of RZD5(-30V)
Yes
Replace FIC1(LC75710)
Samsung Electronics
6-5
Troubleshooting
6-2-3 No Output
No
Check the B-(RWA4 : B1566)
OUT : -12V
Replace TR(B1566)
Yes
No
Check the RIC1(BA3950A)
normal ?
Replace RIC1(BA3950A)
No
Yes
Is relay opened ?
Replace relay
No
Yes
Is mute selected ?
Restore sound with remocon
No
Yes
Main PCB µ-com pins 82,83
Check for "H"
No
6-6
Replace µ-com
Check if the output line is
shorted.
Samsung Electronics
Troubleshooting
6-3 CD
6-3-1 Disc Revolution Malfunction
Power On and CD Function
Yes
Check disc sensor voltage
WCW4(SENI) condition
No
Check PC1,WQ91,92
Yes
Is Focus search done properly?
No
Check oscillation of XX1
(33.8688MHz)
Yes
Does Laser function during
Focus Search ?
No
Replace Pick-up
Yes
Check WIC41 pin73 voltage
during Focucs search : 5V
No
Replace WIC41
Yes
Replace NIC9220 or NIC9258
Samsung Electronics
6-7
Troubleshooting
6-3-2 Audio Output Malfunction
Malfunction of Audio Output
Yes
Check voltage of XIC3
No
Replace XIC03
Yes
Check waveform of XIC1
pins 16,18,25,27
No
Check XIC1 soldering condition
Yes
Check waveform of WIC41
pins 8,11,12
No
Replace WIC41
Check WIC41 soldering condtion
No
Replace XIC2L,2R
Check XIC2L,2R soldering condition
Yes
Check waveform of XIC2L,2R
pins 2,7
Yes
Check Amp operation
6-8
Samsung Electronics
7.Exploded Views and Parts List
7-1 Cassette Deck Exploded View and Parts List
No.
New Code No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
AH59-20002V
AH81-10021W
AH81-10022J
AH81-10031U
AH81-10031V
AH81-10031W
AH81-10031Z
AH81-10032A
AH81-10032B
AH81-10032C
AH81-10032H
AH81-10032J
AH81-10032C
AH81-10032L
AH81-10032N
AH81-10032Y
AH81-10032Q
AH81-10032R
AH81-10032T
AH81-10032U
AH81-10033E
AH81-10033H
AH81-10033J
AH81-10033K
AH81-10033L
AH81-10033M
2
3
5
4
3
7
12
9
13
20
8
21 14
20
11
6
16
24
Description
DECK CASSETTE
MOTOR
ASS’Y HOLDER HEAD
CAP REEL
ASS’Y PINCH ARM L
ASS’Y PINCH ARM R
ASS’Y SUB REEL L
SOLENOID
GEAR FF
ASS’Y ARM FR
ARM BRAKE
ASS’Y SUB REEL R
ARM TRIGER
GEAR-CAM
WIRE(13P)
SWITCH-MODE
SWITCH LEAF
HALL IC
P.C.BOARD
HOUSING
GEAR-PLAY
ASS’Y PULLEY FR
BELT FR
ASS’Y FLYWHEEL L
ASS’Y FLYWHEEL R
BELT MAIN
Specification
CRF452
SHW2L
YK56RAB4N3
22-222-4041
22-093-4149
22-093-4150
22-093-3071
07-W021C
22-222-4048
22-093-4061
22-093-3028
22-093-4151
22-268-3008
22-221-2090
22-072-4080
04-SW150
04-MT510041MVJ1
00-LB9051A
22-070-4046
00-S5BEH
22-222-4282
CRF452 22-093-3918
CRF452 02-083-4127
CRF452 22-220-3738
CRF452 22-093-3917
CRF452 22-084-4128
Old Code No.
17159-0038-00
10000-503-004
10000-524-023
10000-611-009
10000-611-010
10000-611-012
10000-611-017
10000-611-018
10000-611-021
10000-611-022
10000-611-028
10000-611-029
10000-611-030
10000-611-031
10000-611-035
10000-611-051
10000-611-039
10000-611-040
10000-611-046
10000-611-047
10000-611-057
10000-611-063
10000-611-064
10000-611-065
10000-611-066
10000-611-067
10
15
17
23
25
22
18 19
1
Samsung Electronics
7-1
Exploded Views and Parts List
7-2 Main Exploded View and Parts List
7-2-1 Exploded View
60
56
57
59
62
63
41
58
42
53
56
52
57
51
8
44
55
64
54
45
43
46
41
30
50
29
47
26
26
48
9
13
7
49
12
14
16
15
18
19
23
41
61
39
28
27
11
40
31
38
37
25
24
32
17
POWER
33
34
TAPE
FUNCTION
TUNER/CD/TAPE/AUX
35
36
65
5
4
1
20
+
VOLUME
_
TUNING
BAND
1
4
6
TUNING
PRESET/
MANUAL
7
22
MUTE
CD
+10
CLOCK
2
3
REC PAUSE
6
MEMORY
8
9
MONO/ST
REPEAT
PROGRAM
AI SLEEP
5
TIMER CHECK TIMER ON/OFF
DOOR
SRS
KEY
LAMP ON/OFF
BASS
SLEEP
TREBLE
21
3
2
7-2
Samsung Electronics
Exploded Views and Parts List
7-2-2 Parts List
No.
1
2
3
4
5
6
7
8
9
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
New Code No.
AH61-10634A
AH61-10635A
AH95-50221A
AH64-40380A
AH63-30196A
AH61-20381A
AH64-11090A
AH61-20382A
AH64-40374A
AH64-40375A
AH67-20013B
AH61-60310A
AH61-60308A
AH61-60309A
AH61-80031A
AH64-40377A
AH64-50314A
AH64-20130A
AH64-11073A
AH64-11074A
AH64-11071A
AH64-11072A
AH64-11075A
AH66-20173A
AH66-60031A
AH66-10022A
AH61-50253A
AH66-20174A
AH95-50210A
AH61-10636A
AH66-80021A
AH66-30084A
AH61-60324A
AH61-60307A
AH61-80033A
AH66-10021A
AH66-20175A
AH61-80034A
AH61-20386A
Samsung Electronics
Description
FRAME-JERSEY,L
FRAME-JERSEY,R
ASS’Y-GLASS
WINDOW-FLT
COVER-FLT
HOLDER-FLT
KNOB-FUNCTION
HOLDER-AC JACK
DECORATION-CASS
DECORATION-CD
REFELECTOR-DECK
SPRING-GUIDE
SPRING-TAPE,L
SPRING-TAPE,R
HOUSING-CASS
DECORATION-WINDDOW, R
DOOR-R
PANEL-WINDOW,R
KNOB-VOLUME
KNOB-OPEN
KNOB-TUNER
KNOB-DOLBY
KNOB-DECK
GEAR-DOOR
BELT-PULLEY
PULLEY-DOOR
GUIDE-RACK
GEAR-RACK
ASS’Y HOLDER DOOR
BRACKET-BOTTOM
LINK-GEAR
LEVER-DOOR
SPRING-LEVER
SPRING-SW
HOUSING-BOTTOM
PULLEY-WINDOW
GEAR-WINDOW
HOUSING-TOP
BASE-SET
Specification
-,MIPS,94HB,T3.0 L330.9 W49.3
-,MIPS,94HAB,T3.0 L330.9 W49.3
MM-S1000,GLASS
-,PMMA,94HB,T2.5,VIOLET
ABS,94HB,BLK
-,ABS,94HB,BLK,-,MM-S1000
-,ABS,94HB,BLK,-,MM-S1000
-,ABS,94HB,BLK,-,S1000
-,ABS,94HB,T2.0,BLK
-,ABS,94HB,T2.5,BLK
-,T,PAPER,-,-,-,SILVER
-,PS,SUS304,PI0.4,-,-,MM-S1000
-,PS,SUS304,PI0.5,-,-,MM-S1000
-,PS,SUS304,PI0.5,-,-,MM-S1000
-,ABS,T2.0 X L162 X W110.5 BLK
-,AL,-,T1.0,BLK,SPRAY
-,ABS,94HB,T4.8,L239 X 43.5 BLK
-,ABS,94HB,L260.5 X W47,BLK
-,ABS,94HB,BLK,-,MM-S1000
-,ABS,94HB,BLK,-,MM-S1000
-,ABS,94HB,BLK,-,MM-S1000
-,ABS,94HB,BLK,-,MM-S1000
-,ABS,94HB,BLK,DOUBLE
-,POM,M0.5/M0.8,Z86/Z22
-,RUBBER,T1.2,8%,L44.5
-,POM,BLK
-,ABS,94HB,T3.0,BLK,G/F20%
-,POM,M0.8,-,BLK,-,MM-S1000
MM-S1000,ABS
-,SECC,-,T1.6,NTR,BLK
-,POM,T3.0,-,MM-S1000
-,SECC,-,T1.0,-,-,MM-S1000
-,PS,SUS304,PI1.0,OD8
-,PS,SUS304,PI0.2,-,-,MM-S1000
-,ABS,T2.5 X L123.5 X W72,BLK
-,POM,PCD6,MM-S1000
-,POM,M0.5,Z120,BLK
-,ABS,T2.5 X L123.5 X 72,BLK
-,MIPS, 94HB,BLK,-,MM-S1000
Old Code No.
No.
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
New Code No.
AH63-60020A
AH61-10633A
AH63-70114A
AH61-80032A
AH73-10012B
AH67-10125A
AH64-40376A
AH63-40156A
AH61-10637A
AH61-10638A
AH31-10020A
AH62-30109A
AH62-30108A
AH63-70121A
AH61-20389A
AH67-10126A
AH61-20383A
AH64-30366A
AH64-40379A
AH64-40378A
AH81-10628B
AH81-10628A
AH63-30081A
AH91-60004A
AH59-10080W
Description
SPACER-CD
FRAME-MAIN
SHEET-RACK
HOUSING-CD
RUBBER-MECHA
LENS-CD
DECORATION-WINDOW,L
SHIELD-DECK
BRACKET-DECK,L
BRACKET-DECK,R
FAN-DC
HEAT SINK-TR
HEAT SINK-MAIN
SHEET-HANGER
HANGER-IN
LENS-SIDE
HOLDER-LENS
CABINET-REAR
DECORATION-TOP,R
DECORATION-TOP,L
SPEAKER ASS’Y(R)
SPEAKER ASS’Y(L)
COVER-VOLTAGE
ASS’Y-DECK CDP
REMOCON-ASS’Y
Specification
Old Code No.
-,RUBBER,T10.5,BLK,BR,MM-S1000
-,MIPS,94HB,T3.0,L698.5 W105.5
-,PVC,T0.3,L130,W15,BLK
-,ABS,T3.0 X L206 X W122,BLK
SILICON,-,MM-S1000,BLK
-,+,PMMA,T2.0,69X12.5,-,AL,-,T1.0,-,BLK,SPRAY
-,ET,T0.3,-,MM-S1000
-,SECC,-,T1.2,NTR,-,SECC,-,T1.2,NTR,D0620B-12M,12VDC/0.16A
-,AL,V0,T3.0,-,WHT,EXTR
-,AL,V0,T6.0,-,WHT,EXTR
PVC T0.15 BLK
-,SECC,-,T1.2,BLK,SPRAY
-,+,PMMA,-,220 X13,-,ABS,94HB,WHT
-,MIPS,94HB,T3.0,L825
-,ABS,94HB,T5.0,BLK
-,ABS,94HB,T5.0,BLK
PSS1000
PSS1000
ABS,94HB,-,BLK,-,D21SG
-,S1000,LC7464M,50
7-3
8. Electrical Parts List
Location No.
New Code No.
SPKR-MAIN,SPKL-MAIN
FRONT-MAIN
KEY-MAIN
3809-001021
AC39-32001A
AH26-80142G
AH39-10060G
AH39-20559A
AH39-20559S
AH39-20559U
AH39-20559V
AH90-10612A
AH90-40444A
KLD1,2,3,4,5,6
KJW1,2
KR7,8,17,18
KR9,19
KR10,20
KR1,2,3,4,5,6
KR16,26
KR11,21
KR12,22
KR13,23
KR27
KR14,24
KR15,25
KSW1,2,3,4,5,6,7,8,9,10
KSW11,12,13,14,15,16
KSW17,18,19
KSW20,21,22,23
KWA1
Samsung Electronics
Old Code No.
CABLE-FLAT;30V,80C,150MM,21P,1.25MM
CABLE-COAXIAL ASSY;SD-C123-14A,FTZ,
TRANS-POWER;EI74X53,230V,50HZ,S1000
POWER-CORD;-,CP2,KLCE-2F 0.75MM,3MT
LEAD CONNECTOR-ASSY;-,5239-03,5239LEAD CONNECTOR-ASSY;-,51004,51004,2
LEAD CONNECTOR-ASSY;-,51004,51004,1
LEAD CONNECTOR-ASSY;-,51004,51004,1
0601-000141
2007-000029
2007-000221
2007-000241
2007-000267
2007-000401
2007-000409
2007-000493
2007-000515
2007-000686
2007-000774
2007-000981
2007-001177
3404-000165
LED;ROUND,GRN,3.1MM,555NM
R-CHIP;0OHM,5%,1/10W,DA,TP,2012
R-CHIP;1.2KOHM,5%,1/10W,DA,TP,2012
R-CHIP;1.5KOHM,5%,1/10W,DA,TP,2012
R-CHIP;1.8KOHM,5%,1/10W,DA,TP,2012
R-CHIP;150OHM,5%,1/10W,DA,TP,2012
R-CHIP;15KOHM,5%,1/10W,DA,TP,2012
R-CHIP;2.2KOHM,5%,1/10W,DA,TP,2012
R-CHIP;2.7KOHM,1%,1/10W,DA,TP,2012
R-CHIP;3.3KOHM,5%,1/10W,DA,TP,2012
R-CHIP;33KOHM,5%,1/10W,DA,TP,2012
R-CHIP;5.6KOHM,5%,1/10W,DA,TP,2012
R-CHIP;8.2KOHM,5%,1/10W,DA,TP,2012
SWITCH-TACT;12V,50MA,160GF+-50GF,6
11119-101-332
11119-101-333
11119-101-562
11119-101-822
13559-901-100
3711-000595
CONNECTOR-HEADER;BOX,10P,1R,2MM
13349-139-100
A4150-0290
11119-101-000
11119-101-122
11119-101-152
11119-101-182
11119-101-151
11119-101-153
11119-101-222
ASSY-LED PCB;MM-S1000,LED
0601-000146
LED;ROUND,GRN,3.1MM,563NM
A4150-0123
2007-000401
R-CHIP;150OHM,5%,1/10W,DA,TP,2012
11119-101-151
3711-000827
CONNECTOR-HEADER;BOX,2P,1R,2MM
13349-119-020
AH90-40446A
DD4,5,6,7
DD1L,1R,2L,2R,3L,3R
DQ9,10
DQ13,14
Specification
ASSY-FRONT PCB;MM-S1000,DOM
ASS’Y-KEY PCB;MM-S1000,KEY
AH90-40445A
LD1L,1R,2L,2R,3L,3R
LD4L,4R,LD5L,5R,6L
LD6R,7L,7R,8L,8R
LD9L,9R,10L,10R
LD11L,11R,12L
LD12R,13L,13R,14L
LD14R,15L,15R
LR1L,1R,2L,2R,3L,3R
LR4L,4R,5L,5R,6L,6R
LR4L,4R,5L,5R,6L,6R
LWA1L,1R
Description
ASSY-DECK PCB;MM-S1000,DECK
0401-000101
DIODE-SWITCHING;1N4148,100V,200MA,5
0501-000369
0501-000610
TR-SMALL SIGNAL;KSC2331-Y,NPN,1W,TO
TR-SMALL SIGNAL;KSA928A-Y,PNP,1W,TO
12149-301-910
8-1
Electrical Parts List
Location No.
DQ2L,2R,5L,5R,6L,6R
DQ7,8,11,12,15
DQ4L,4R,16L,16R
DQ3
DQ1L,1R
DIC1,2
DR2
DR81L
DR4
DR1
DR3
DR6
DR7,8
DR51L,51R,56L,56R
DR68L,68R,74,76
DR81R
DR78L,78R
DR69L,69R
DR61L,61R,80
DR52L,52R,62L,62R
DR65L,65R
DR73,75,5
DR54L,54R
DR57L,57R
DR66L,66R,70L,70R
DR64L,64R,79L,79R
DR67R
DR58L,58R,60L,60R,72
DR77
DR55L,55R
DR63L,63R
DR71L,71R
DR53L,53R
DSR4
DSR1L,1R
DSR3
DSR2L,2R
DC16L,16R
DC10
DC15
DC67,70L,70R
DC52L,52R
DC58L,58R,62L,62R
DC69
DC55L, 55R,63L,63R
DC68,73L,73R
DC60L,60R
DC71L,71R
DC65L,65R
DC59L,59R,64L,64R
DC54,61L,61R,72,74L,74R
8-2
New Code No.
Description
Specification
Old Code No.
0504-000118
TR-DIGITAL;KSR1003,NPN,300MW,22K-22
12159-301-780
0504-000122
0504-001003
0505-000197
1201-000163
2001-000273
2001-000302
2001-000429
2001-000734
2001-000780
2001-001146
2001-001178
2007-000282
2007-000300
2007-000307
2007-000395
2007-000409
2007-000493
2007-000565
2007-000572
2007-000586
2007-000653
2007-000686
2007-000710
2007-000774
TR-DIGITAL;KSR1009Y,NPN,300MW,4.7K,
12159-301-790
TR-DIGITAL;KSR2003,PNP,300MW,22K-22
FET-SILICON;2SK373Y,N,-,-,-,400MW,T
B4054-0023
IC-OP AMP;4560,SOP,8P,150MIL,DUAL,1
12119-401-300
R-CARBON;100KOHM,5%,1/8W,AA,TP,1.8X
11018-877-104
R-CARBON;10OHM,5%,1/8W,AA,TP,1.8X3.
11018-877-100
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.
11018-877-102
R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X
11018-877-472
R-CARBON;470OHM,5%,1/8W,AA,TP,1.8X3
11018-877-471
R-CARBON(S);4.7OHM,5%,1/2W,AA,TP,2.
11018-377-479
R-CARBON(S);680OHM,5%,1/2W,AA,TP,2.
11018-377-681
R-CHIP;100KOHM,5%,1/10W,DA,TP,2012
11119-101-104
R-CHIP;10KOHM,5%,1/10W,DA,TP,2012
11119-101-103
R-CHIP;10OHM,1%,1/10W,DA,TP,2012
R-CHIP;150KOHM,5%,1/10W,DA,TP,2012
11119-101-154
R-CHIP;15KOHM,5%,1/10W,DA,TP,2012
11119-101-153
R-CHIP;2.2KOHM,5%,1/10W,DA,TP,2012
11119-101-222
R-CHIP;220KOHM,5%,1/10W,DA,TP,2012
11119-101-224
R-CHIP;220OHM,5%,1/10W,DA,TP,2012
11119-101-221
R-CHIP;22KOHM,5%,1/10W,DA,TP,2012
11119-101-223
R-CHIP;27KOHM,5%,1/10W,DA,TP,2012
11119-101-273
R-CHIP;3.3KOHM,5%,1/10W,DA,TP,2012
11119-101-332
R-CHIP;3.9KOHM,5%,1/10W,DA,TP,2012
11119-101-392
R-CHIP;33KOHM,5%,1/10W,DA,TP,2012
11119-101-333
2007-000872
R-CHIP;4.7KOHM,5%,1/10W,DA,TP,2012
11119-101-472
2007-001024
2007-001039
2007-001071
2007-001216
2103-000171
2103-000290
2103-000341
2103-000461
2201-000470
2201-000693
2202-000824
2203-000260
2203-000295
2203-000374
2203-000495
2203-000595
2203-000609
2203-000727
2203-000787
2203-000892
2203-000953
2203-000979
R-CHIP;560KOHM,5%,1/10W,DA,TP,2012
R-CHIP;56KOHM,5%,1/10W,DA,TP,2012
R-CHIP;6.8KOHM,5%,1/10W,DA,TP,2012
R-CHIP;82OHM,5%,1/10W,DA,TP,2012
VR-SEMI;10KOHM,30%,1/10W,TOP
VR-SEMI;20KOHM,30%,1/10W,TOP
VR-SEMI;2KOHM,30%,1/10W,TOP
VR-SEMI;50KOHM,30%,1/10W,TOP
C-CERAMIC,DISC;330PF,10%,50V,SL,8X4
C-CERAMIC,DISC;8PF,5%,50V,NPO,5X3,5
C-CERAMIC,MLC-AXIAL;6.8PF,10%,50V,C
C-CERAMIC,CHIP;10NF,10%,50V,X7R,201
C-CERAMIC,CHIP;10PF,5%,50V,NPO,2012
C-CERAMIC,CHIP;15NF,5%,50V,X7R,2012
C-CERAMIC,CHIP;2.2NF,10%,50V,X7R,20
C-CERAMIC,CHIP;220PF,5%,50V,NPO,201
C-CERAMIC,CHIP;22NF,10%,50V,X7R,201
C-CERAMIC,CHIP;3.9NF,10%,50V,X7R,20
C-CERAMIC,CHIP;330PF,5%,50V,NPO,201
C-CERAMIC,CHIP;4.7NF,10%,50V,X7R,20
C-CERAMIC,CHIP;470PF,5%,50V,NPO,201
C-CERAMIC,CHIP;47NF,10%,50V,X7R,201
11119-201-564
11119-101-563
11119-101-682
11119-201-820
11249-102-034
11249-102-044
11249-102-104
11249-102-064
11407-018-331
11407-057-809
11449-118-689
11129-004-103
11129-009-100
11129-004-153
11129-004-222
11129-001-221
11129-004-223
11129-004-392
11129-004-471
Samsung Electronics
Electrical Parts List
Location No.
New Code No.
DC57L,57R
DC75L,75R
DC53L,53R
DC66L,66R
DC56L,56R
DC9
DC3L,3R,13L,13R,7
DC1L,1R,5,6
DC2L,2R
DC4L,4R,11,12,14,17,18
DL6
DWA1
DWA5
DWA4
DWA2,3
DR67L
DIC3
DL2L,2R
DL3L,3R
DL4
DL5L,5R
DW1
2203-001036
2203-001058
2203-001135
2203-001214
2203-001611
2301-000442
2401-000419
2401-000907
2401-001954
2401-001975
2701-000298
3708-000219
3708-000447
3711-000820
3711-003107
61048-177-333
AH14-10007J
AH26-10002X
AH27-10001D
AH27-80060D
AH27-80060E
AH39-20557A
AH90-40447A
FD1,2
FR4,5
FR3
FR2
FR1
FJW51,52,53,54,55
FR51
FR52
FR53,54,55
FR56
FC51,53
FC7
FC54,55
FC52
FC4
FC1
FC5
FC2,6
FC3
FB1,2
FSW1,2,3,4,5,6
FAW1
FJW1,2,3,4,5,6,7
V,F,DISPLAY
FIC1
R-EYE
Samsung Electronics
Description
Specification
Old Code No.
C-CERAMIC,CHIP;5.6NF,10%,50V,X7R,20
C-CERAMIC,CHIP;560PF,5%,50V,NPO,201
11129-019-561
C-CERAMIC,CHIP;680PF,5%,50V,SL,2012
C-CERAMIC,CHIP;8.2NF,10%,50V,X7R,20
11129-004-822
C-CERAMIC,CHIP;22PF,5%,50V,NPO,2012
C-FILM,PEF;4.7NF,10%,50V,5.5X7X3MM,
C-AL;10UF,20%,16V,GP,5X11,5,C-AL;22UF,20%,16V,GP,5*11,2MM,
11608-103-223
C-AL;4.7UF,20%,50V,GP,5X11MM,5,TP
C-AL;47UF,20%,16V,GP,5X11MM,5,TP
INDUCTOR-AXIAL;470UH,10%,4.2X9.8MM
12429-070-130
CONNECTOR-FPC/FC/PIC;21P,1.25MM,STR
B6010-0972
CONNECTOR-FPC/FC/PIC;13P,1.5MM,STRA
B6010-0399
CONNECTOR-HEADER;BOX,2P,1R,2.5MM
13349-512-561
CONNECTOR-HEADER;BOX,3P,1R,2.5MM,ST
R-CARBON;RD 1/8 T 333-J
IC;UPC1297CA,DIP,STICK HX PRO
COIL-TRAP;KS940830-05,BIAS-TRAP,30D
12429-206-102
COIL-CHOKE;5.6MH,K,Q80,-,-,-,-,-,
12429-010-210
COIL-OSC;126QN-K5274YCT,-,105KHZ BI
COIL-OSC;126QN-K5275ACM,-,HX-PRO
LEAD CONNECTOR-ASSY;-,EHR,51088,5P,
ASSY-FLT PCB;MM-S1000,FLT
0401-000101
DIODE-SWITCHING;1N4148,100V,200MA,5
2001-000221
R-CARBON;1.2KOHM,5%,1/8W,AA,TP,1.8X
2001-000241
R-CARBON;1.5KOHM,5%,1/8W,AA,TP,1.8X
2001-000258
R-CARBON;1.8KOHM,5%,1/8W,AA,TP,1.8X
2001-000449
R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X
2007-000029
R-CHIP;0OHM,5%,1/10W,DA,TP,2012
2007-000282
R-CHIP;100KOHM,5%,1/10W,DA,TP,2012
2007-000300
R-CHIP;10KOHM,5%,1/10W,DA,TP,2012
2007-000468
R-CHIP;1KOHM,5%,1/10W,DA,TP,2012
2007-000586
R-CHIP;22KOHM,5%,1/10W,DA,TP,2012
2201-000565
C-CERAMIC,DISC;47nF,20%,50V,Y5V,12.
2202-000781
C-CERAMIC,MLC-AXIAL;100PF,10%,50V,Y
2203-000239
C-CERAMIC,CHIP;100PF,5%,50V,NPO,201
2203-000818
C-CERAMIC,CHIP;33PF,5%,50V,NPO,2012
2401-000244
C-AL;100UF,20%,10V,GP,6.3*7,2.5MM,T
2401-001474
C-AL;47UF,20%,10V,GP,6.3*7,2.5MM,TP
2401-001572
C-AL;47UF,20%,50V,GP,6.3*11,2.5MM,
2401-001919
C-AL;2.2UF,20%,50V,-,4X7MM,5,TP
2401-001931
C-AL;220NF,20%,50V,-,4X7MM,5,TP
3301-000325
CORE-FERRITE BEAD;AB,3.2X2.5X1.3MM,
3404-000165
SWITCH-TACT;12V,50MA,160GF+-50GF,6X
3711-000606
CONNECTOR-HEADER;BOX,11P,1R,2.0MM
3811-000389
WIRE-NO SHEATH CU;SPCW,300V,52.4MM,
AH07-20002P
V.F.DISPLAY;SVA-12MM06,-,-,AUDIO
AH14-10007K
IC-VFD;LC75710,QFP,
AH59-60001J
MODULE-REMOCON;GP1U271R,38KHZ,-,
AH61-20381A
HOLDER-FLT;-,ABS,94HB,BLK,-,MM-S100
11018-877-122
11018-877-152
11018-877-182
11018-877-222
11119-101-000
11119-101-104
11119-101-103
11119-101-102
11119-101-223
11417-344-473
11449-518-101
11129-009-101
11129-008-330
11608-152-104
11608-152-470
11608-106-470
B1144-0034
13559-901-100
13349-119-110
A4153-0115
B1294-0043
8-3
Electrical Parts List
Location No.
New Code No.
AH90-40448A
PSC1,2
FU2
FUC1,2
PSW1
PSL1,2
PSW2
AH90-40449A
AH90-10728E
8-4
Old Code No.
C-CERAMIC,DISC;4.7NF,+80-20%,400VAC
FUSE-FERRULE;250V,1A,TIME LAG,GLASS
FUSE-CLIP;250V,7.5A,30MOHM
JACK-AC POWER;2P,-,NI,BLK,#16~22
COIL-CHOKE;27UH,K,Q30,-,-,DR(6.5*7.
PIN-GT;D2.35,L14.2,-,-,
11469-501-070
14709-241-200
13164-101-913
13359-010-110
12429-010-330
13349-442-010
ASSY-TERMINAL PCB;MM-S1000,TERMINAL
0401-000101
2007-000468
2007-000941
3711-000190
3711-003108
3722-000376
AH37-20001S
AD1L,1R,3L,3R,4,5
ID3,4,5,6,7,8
MD1,2,RD3,4,8
UD1,2,14,16,17
RD7,9,10,11,12,13
RD14,15,16,17,18
RD19,20,21,22,23,71
UD8,9,10,13,15
RD50,51
RD6
RD1,2
AZD1
HZD1
ZZD1
ZZD2
FZD1
RZD3
RZD5
RZD4
MZD1
AQ6,RQ3L,3R
AQ7,HQ5,RQ1
AQ5,8
AQ2L,2R
IQ1,2
AQ1L,1R,3,4,FQ2L,2R
RQ2,UQ7
RIC2,HEAT-SINK
DQ23L,23R
DQ21L,21R,22L,22R,FQ3,4
UQ1,2,3,4,5,6
SQ2
Specification
ASSY-POWER PCB;MM-S1000,POWER
2201-000520
3601-000207
3602-000147
3722-000337
AH27-10001F
AH60-40027A
OD1,2,3,4
OR3,4
OR1,2
CWA1L,2L
OWA1
OWA3
OWA2
Description
DIODE-SWITCHING;1N4148,100V,200MA,5
R-CHIP;1KOHM,5%,1/10W,DA,TP,2012
11119-101-102
R-CHIP;47KOHM,5%,1/10W,DA,TP,2012
11119-101-473
CONNECTOR-HEADER;1WALL,2P,1R,7.92MM 13349-156-020
CONNECTOR-HEADER;BOX,7P,1R,2.5MM,ST
JACK-RCA;4P/2C,3.5MM,SN,BLK,#16~22
13339-544-040
JACK-ANT TERMINAL;SP-031S,BLK
ASSY-MAIN PCB;S1000,CE
0401-000101
DIODE-SWITCHING;1N4148,100V,200MA,5
0402-000125
DIODE-RECTIFIER;1N4001,50V,1A,DO-41
A4104-0001
0402-000127
0402-000157
0402-000450
0403-000352
0403-000357
0403-000365
0403-000369
0403-000372
0403-000379
0403-000389
0403-000392
0403-000396
0501-000010
0501-000294
0501-000303
0501-000331
0501-000392
0501-000398
DIODE-RECTIFIER;1N4002,100V,1A,DO-4
DIODE-RECTIFIER;1N5402,200V,3A,DO-2
DIODE-BRIDGE;PBL403,200V,4.0A,DIP-4
DIODE-ZENER;UZ4.7BM,4.7V,4.4-5.0V,5
DIODE-ZENER;UZ5.6BM,5.6V,5.4-5.8V,5
DIODE-ZENER;UZ6.8BSB,6.8V,6.52-6.79
DIODE-ZENER;UZ8.2BM,8.2V,7.9-8.5V,5
DIODE-ZENER;UZ9.1BM,9.1V,8.5-9.6V,5
DIODE-ZENER;UZP12B,12V,11.4-12.6V,1
DIODE-ZENER;UZP30B,30V,28-33V,1W,DO
DIODE-ZENER;UZP4.7B,4.7V,4.4-5.0V,1
DIODE-ZENER;UZP6.8B,6.8V,6.4-7.2V,1
TR-SMALL SIGNAL;KSC1008-Y,NPN,80V,6
TR-SMALL SIGNAL;KSA708-Y,PNP,800MW,
TR-SMALL SIGNAL;KSA733-Y,PNP,250MW,
TR-SMALL SIGNAL;KSC1009-Y,NPN,800MW
TR-SMALL SIGNAL;KSC838-O,NPN,250MW,
TR-SMALL SIGNAL;KSC945-Y,NPN,250MW,
A4104-0053
12169-209-260
12169-219-330
12169-403-200
12169-404-130
12169-404-810
12169-403-290
12169-403-320
12169-403-910
A4106-0121
12169-403-210
12169-404-100
12149-301-050
12149-101-560
12149-101-520
12139-301-310
12149-301-860
12149-301-900
0502-000424
0504-000121
0504-000122
TR-POWER;2SB1566-F,PNP,2W,TO-220FN,
TR-DIGITAL;KSR1007,NPN,300MW,22K-47
TR-DIGITAL;KSR1009Y,NPN,300MW,4.7K,
B4052-0086
12159-301-800
12159-301-790
0504-000146
TR-DIGITAL;KSR2004,PNP,300MW,47K-47
12159-301-760
Samsung Electronics
Electrical Parts List
Location No.
SQ1,3
DQ24,FQ1,AQ10
ZIC1
DIC9,FIC2,SIC2
AIC1
DIC8
SIC1
RIC1
DIC7
SIC3
THM1
RR2
DR112L,112R
RR10,11
MR6
AR8L,8R,9L,9R
RR8
RR12
RR14
HR9
RR9
AR13L,13R,DR102,107L
DR107R,MR7,UR2
DR110,SR34,35
AR18,21,HR12,UR32
RR17,UR7,8,9
UR10,11,12,13,14
UR18,19,20,FR6R
MR10
FR11L,11R
AR3L,3R,11L,11R
HR1,2,3,4
UR21,22
UR50,51,52
AR19,23,RR16L
UR53,54
UR53,54
AR5L
AR10L,10R,SR30
UR15,16,17
DR118,MR4
RR3
HR13
MR11L,11R
UR1,RR50
HR14
RR4
RR7
SR23
AR22,24
Samsung Electronics
New Code No.
Description
Specification
Old Code No.
0504-000203
0504-001003
1003-000293
1201-000163
1201-000344
1201-000357
1201-000463
1203-000166
1204-000134
1205-000529
1404-000172
2001-000005
2001-000008
2001-000020
2001-000028
2001-000052
2001-000058
2001-000066
2001-000071
2001-000109
2001-000241
2001-000273
TR-DIGITAL;KSR1004,NPN,300MW,47K-47
TR-DIGITAL;KSR2003,PNP,300MW,22K-22
IC-MOTOR DRIVER;LB1649,DIP,14P,-,-,
IC-OP AMP;4560,SOP,8P,150MIL,DUAL,1
IC-POWER AMP;4181,SIP,18P,-,DUAL,-,
IC-PREAMP;3312,SIP,10P,-,-,55V/MV,P
IC-OP AMP;074,SOP,14P,196MIL,SINGLE
IC-POSI.ADJUST REG.;3950,SIP,12P,-,
IC-DNR PROCESSOR;KA2271B,DIP,16P,-,
IC-SWITCH;LC4966,DIP,14P,-,-,40V,30
THERMISTOR-NTC;100OHM,-,-,-,BK
R-CARBON;390OHM,5%,1/8W,AA,TP,1.8X3
R-CARBON;15KOHM,5%,1/8W,AA,TP,1.8X3
R-CARBON(S);22OHM,5%,1/2W,AA,TP,2.4
R-CARBON(S);100OHM,5%,1/2W,AA,TP,2.
R-CARBON(S);3.3KOHM,5%,1/2W,AA,TP,2
R-CARBON;5.6KOHM,5%,1/4W,AA,TP,2.4X
R-CARBON(S);10KOHM,5%,1/2W,AA,TP,2.
R-CARBON;22KOHM,5%,1/4W,AA,TP,2.4X6
R-CARBON(S);470OHM,5%,1/2W,AA,TP,2.
R-CARBON;1.5KOHM,5%,1/8W,AA,TP,1.8X
R-CARBON;100KOHM,5%,1/8W,AA,TP,1.8X
2001-000281
2001-000290
R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3
11018-877-101
11018-877-103
2001-000331
2001-000411
2001-000429
R-CARBON;12KOHM,5%,1/8W,AA,TP,1.8X3
R-CARBON;18KOHM,5%,1/8W,AA,TP,1.8X3
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.
11018-877-123
11018-877-183
11018-877-102
2001-000449
2001-000472
2001-000515
2001-000522
2001-000527
2001-000563
2001-000591
2001-000734
2001-000793
2001-000802
2001-000890
2001-000975
2001-001000
2001-001088
R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X
R-CARBON;2.7KOHM,5%,1/8W,AA,TP,1.8X
R-CARBON;220OHM,5%,1/8W,AA,TP,1.8X3
R-CARBON;22KOHM,5%,1/8W,AA,TP,1.8X3
R-CARBON;22OHM,5%,1/8W,AA,TP,1.8X3.
R-CARBON;27KOHM,5%,1/8W,AA,TP,1.8X3
R-CARBON;3.3KOHM,5%,1/8W,AA,TP,1.8X
R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X
R-CARBON;47OHM,5%,1/8W,AA,TP,1.8X3.
R-CARBON;5.6KOHM,5%,1/8W,AA,TP,1.8X
R-CARBON;6.8KOHM,5%,1/8W,AA,TP,1.8X
R-CARBON;8.2KOHM,5%,1/4W,AA,TP,2.4X
R-CARBON;82KOHM,5%,1/8W,AA,TP,1.8X3
R-CARBON(S);1KOHM,5%,1/2W,AA,TP,2.4
12119-401-300
12119-205-040
12119-102-050
B4008-1198
12109-323-990
11018-877-391
11018-877-153
11018-377-220
11018-377-101
11018-377-332
11018-277-562
11018-377-103
11018-277-223
11018-377-471
11018-877-152
11018-877-104
11018-877-222
11018-877-272
11018-877-221
11018-877-223
11018-877-220
11018-877-273
11018-877-332
11018-877-472
11018-877-470
11018-877-682
11018-277-822
11018-877-823
11018-377-102
8-5
Electrical Parts List
Location No.
RR1
AR17L,17R
FR12
RR13
AR12L,12R
SR15,16
IR31,FC6L,6R
AR6L,6R,SR8,17,18
DR104L,104R
SR19
AR2L,2R,DR108L,108R,OR4
DR111L,111R,119,120,121
FR7L,7R,SR24,25
DR124
DR101
AR20,FR6L
HR5,7,22,23
IR8,UR31
MR14
SR11,22
FR8L,8R
DR123
SR6,27
DR122,MR2
HR11,IR9,OR1
RR16R
DR117
AR5R,DR116L,116R
IR6,SR9
SR31
AR14,DR105
SR12,20,28,29,HR18
IR4,10
SR26
DR113L,113R,MR12L,12R
MR5
MR8L,8R,SR14,DR103L
DR103R,SR2L,2R
SR3L,3R,4L,4R,5,7
IR30
DR125
IR3,7,12
DR115L,115R
AR1L,1R,15,16
FR13L,13R
MR9L,9R,OR3
SR1L,1R,MR1
DR106,SR13,21,32
SR33,40L,40R
SR33,40L,40R
IR5,11,13
8-6
New Code No.
Description
Specification
Old Code No.
2001-001144
2001-001146
2001-001153
2003-000732
2006-000266
2007-000001
2007-000029
2007-000030
2007-000221
2007-000241
2007-000282
R-CARBON(S);4.7KOHM,5%,1/2W,AA,TP,2
R-CARBON(S);4.7OHM,5%,1/2W,AA,TP,2.
R-CARBON(S);47OHM,5%,1/2W,AA,TP,2.4
R-METAL OXIDE(S);560OHM,5%,1W,AA,TP
R-CEMENT;0.22OHM,5%,7W,CA,BK,9.5X35
R-CHIP;68KOHM,5%,1/10W,DA,TP,2012
R-CHIP;0OHM,5%,1/10W,DA,TP,2012
R-CHIP;560OHM,5%,1/10W,DA,TP,2012
R-CHIP;1.2KOHM,5%,1/10W,DA,TP,2012
R-CHIP;1.5KOHM,5%,1/10W,DA,TP,2012
R-CHIP;100KOHM,5%,1/10W,DA,TP,2012
11018-377-472
11018-377-479
11018-377-470
11048-477-561
11039-757-228
11119-101-683
11119-101-000
11119-101-561
11119-101-122
11119-101-152
11119-101-104
2007-000290
2007-000300
R-CHIP;100OHM,5%,1/10W,DA,TP,2012
R-CHIP;10KOHM,5%,1/10W,DA,TP,2012
11119-101-101
11119-101-103
2007-000308
2007-000338
2007-000355
2007-000409
2007-000457
2007-000468
R-CHIP;10OHM,5%,1/10W,DA,TP,2012
R-CHIP;120KOHM,5%,1/10W,DA,TP,2012
R-CHIP;12KOHM,5%,1/10W,DA,TP,2012
R-CHIP;15KOHM,5%,1/10W,DA,TP,2012
R-CHIP;18KOHM,5%,1/10W,DA,TP,2012
R-CHIP;1KOHM,5%,1/10W,DA,TP,2012
11119-101-100
11119-101-124
11119-101-123
11119-101-153
11119-101-183
11119-101-102
2007-000493
2007-000498
2007-000518
R-CHIP;2.2KOHM,5%,1/10W,DA,TP,2012
R-CHIP;2.2MOHM,5%,1/10W,DA,TP,2012
R-CHIP;2.7KOHM,5%,1/10W,DA,TP,2012
11119-101-222
11119-101-225
11119-101-272
2007-000572
2007-000586
R-CHIP;220OHM,5%,1/10W,DA,TP,2012
R-CHIP;22KOHM,5%,1/10W,DA,TP,2012
11119-101-221
11119-101-223
2007-000593
2007-000653
2007-000686
R-CHIP;22OHM,5%,1/10W,DA,TP,2012
R-CHIP;27KOHM,5%,1/10W,DA,TP,2012
R-CHIP;3.3KOHM,5%,1/10W,DA,TP,2012
11119-101-220
11119-101-273
11119-101-332
2007-000710
R-CHIP;3.9KOHM,5%,1/10W,DA,TP,2012
11119-101-392
2007-000774
R-CHIP;33KOHM,5%,1/10W,DA,TP,2012
11119-101-333
2007-000778
2007-000822
2007-000830
2007-000872
R-CHIP;33OKOHM,5%,1/10W,DA,TP,2012
R-CHIP;390OHM,5%,1/10W,DA,TP,2012
R-CHIP;39KOHM,5%,1/10W,DA,TP,2012
R-CHIP;4.7KOHM,5%,1/10W,DA,TP,2012
11119-101-334
11119-101-391
11119-101-393
11119-101-472
2007-000941
R-CHIP;47KOHM,5%,1/10W,DA,TP,2012
11119-101-473
2007-000947
R-CHIP;47OHM,5%,1/10W,DA,TP,2012
11119-101-470
Samsung Electronics
Electrical Parts List
Location No.
DR109L,109R,UR6
AR4L,4R,FR10L,10R,UR33
FR14L,14R
MR3-1
HR10
DR114L,114R
SR10
FR15L,15R
AFR1,2
MVR1
HC5
UC7,8
UC9,10,HC6
RC6,7
AC14
UC16
ZC4,MC3,UC71,MC10
UC72
DC122,HC9
UC51
IC4,FC32,UC53
MC5
HC1,SC1L,1R
IC2,3,UC2
DC111L,111R
MC17L,17R,FC5L,5R
SC5
MC26L,26R
MC20
FC7L,7R,UC5
AC2L,2R,4L,4R
IC5,6,7,MC1,23
UC4,12,13,14,HC2
ZC2,3,5,OC1,DC123
FC4L,4R
MC19
OC2
UC52
DC113L,113R,HC10,MC8
SC6L,6R
DC112L,112R
AC10L,10R
UC6,11,20,21
FC21,MC2,4,9
MC16L,16R,ZC6
AC11,13
DC105,FC19L,19R,23L
FC23R,25L,25R,UC1
RC5,11,12,14,16
AC9
DC103,MC22,RC10
Samsung Electronics
New Code No.
Description
Specification
Old Code No.
2007-000981
2007-001039
R-CHIP;5.6KOHM,5%,1/10W,DA,TP,2012
R-CHIP;56KOHM,5%,1/10W,DA,TP,2012
11119-101-562
11119-101-563
2007-001071
2007-001118
2007-001177
2007-001208
R-CHIP;6.8KOHM,5%,1/10W,DA,TP,2012
R-CHIP;680OHM,5%,1/10W,DA,TP,2012
R-CHIP;8.2KOHM,5%,1/10W,DA,TP,2012
R-CHIP;82KOHM,5%,1/10W,DA,TP,2012
11119-101-682
11119-101-681
11119-101-822
11119-101-823
2008-000121
2103-000492
2201-000247
2201-000273
2201-000423
2201-000520
2201-000783
2202-000781
2202-000854
2203-000199
2203-000239
R-FUSIBLE;100OHM,5%,1/4W,AA,TP,2.6X
VR-SEMI;5KOHM,30%,1/10W,TOP
C-CERAMIC,DISC;15PF,5%,50V,NPO,4X3.
C-CERAMIC,DISC;18PF,5%,50V,NPO,5.0X
C-CERAMIC,DISC;27PF,5%,50V,NPO,5.0X
C-CERAMIC,DISC;4.7NF,+80-20%,400VAC
C-CERAMIC,DISC;100NF,+80%,-20%,50V,
C-CERAMIC,MLC-AXIAL;100PF,10%,50V,Y
C-CERAMIC,MLC-AXIAL;47NF,0.3,50V,Y5
C-CERAMIC,CHIP;100NF,+80-20%,50V,Z5
C-CERAMIC,CHIP;100PF,5%,50V,NPO,201
11058-223-101
11249-102-024
11407-057-150
11407-057-180
11407-057-270
11469-501-070
11417-104-104
11449-518-101
2203-000260
2203-000408
2203-000595
2203-000609
2203-000727
2203-000802
2203-000892
C-CERAMIC,CHIP;10NF,10%,50V,X7R,201
C-CERAMIC,CHIP;180PF,5%,50V,NPO,201
C-CERAMIC,CHIP;220PF,5%,50V,NPO,201
C-CERAMIC,CHIP;22NF,10%,50V,X7R,201
C-CERAMIC,CHIP;3.9NF,10%,50V,X7R,20
C-CERAMIC,CHIP;33NF,10%,50V,X7R,201
C-CERAMIC,CHIP;4.7NF,10%,50V,X7R,20
11129-004-103
11129-008-181
11129-001-221
11129-004-223
11129-004-392
11129-001-333
2203-000919
2203-000953
2203-000979
C-CERAMIC,CHIP;470NF,+80-20%,16V,Y5
C-CERAMIC,CHIP;470PF,5%,50V,NPO,201
C-CERAMIC,CHIP;47NF,10%,50V,X7R,201
2203-001105
2203-001135
2203-001517
2203-001524
2203-001537
C-CERAMIC,CHIP;6.8NF,10%,50V,X7R,20
C-CERAMIC,CHIP;680PF,5%,50V,SL,2012
C-CERAMIC,CHIP;15PF,5%,50V,NPO,2012
C-CERAMIC,CHIP;47PF,5%,50V,NPO,2012
C-CERAMIC,CHIP;1NF,10%,50V,X7R,2012
2203-001550
2301-000375
2401-000240
2401-000419
C-CERAMIC,CHIP;1.2NF,10%,50V,X7R,20
C-FILM,PEF;100NF,5%,50V,11X12.5X6.5
C-AL;100UF,20%,10V,GP,6*11MM,5MM,TP
C-AL;10UF,20%,16V,GP,5X11,5,-
11505-713-104
11608-102-104
2401-000475
2401-000759
C-AL;10UF,20%,50V,GP,5*11,2MM,
C-AL;220NF,20%,50V,GP,5X11,2MM,
11608-106-100
11608-106-221
2401-000907
2401-000968
2401-001022
C-AL;22UF,20%,16V,GP,5*11,2MM,
C-AL;22UF,20%,50V,BP,8X11.5,-,C-AL;3.3UF,20%,50V,GP,5*11,2MM,
11608-103-223
11608-206-220
11608-106-332
11129-009-101
11129-004-471
11129-004-682
8-7
Electrical Parts List
Location No.
FC27
HC11,MC14
DC117L,121
AC7L,7R
DC107L,107R
DC114,115,120
AC6L,6R,RC4
ZC1
MC11,13,18,RC13,15
DC108L
DC109L,110L,110R
DC116L,116R
DC106L,106R,109R,118L
DC118R,FC31L,31R
MC15L,15R,SC7L,7R
SC8L,8R,2L,2R
FC10L,10R
AC8L,8R
DC104,MC25,SC3L,3R,4
UC3
DC101,117R,MC21,SC9,10
FC22,DC119
AC12,RC8,9,81
AC1L,1R,3L,3R,DC102
DC108R,HC8,AC15
FC24L,24R
RC1,2,3
BACK-UP
FL1,2,3L,3R
HX1
UX1
UX2
IFT5
IFT1,7
IFT3
DLPF11L,11R
RELAY
DWA6
OWA1L,1R
RWA2
RWA3
UWA1
AWA2
RWA4L,4R
ZWA1
ZWA2
FWA1
RWA1
FM
A-A
8-8
New Code No.
2401-001364
2401-001465
2401-001511
2401-001572
2401-001645
2401-001893
2401-001895
2401-001904
2401-001912
2401-001919
2401-001952
2401-001954
Description
Specification
Old Code No.
C-AL;470UF,20%,16V,GP,10X12MM,5MM,T
C-AL;47UF,20%,10V,GP,5*11,2MM,
C-AL;47UF,20%,16V,GP,6X7,5,C-AL;47UF,20%,50V,GP,6.3*11,2.5MM,
C-AL;680NF,20%,50V,GP,5*11,2MM,
C-AL;100UF,20%,16V,-,6.3X7MM,5,TP
C-AL;100UF,20%,16V,GP,6.3X11MM,2.5M
C-AL;10UF,20%,16V,-,4X7MM,5,TP
C-AL;1UF,20%,50V,GP,5X11MM,2MM,BK
C-AL;2.2UF,20%,50V,-,4X7MM,5,TP
C-AL;4.7UF,20%,50V,-,4X7MM,5,TP
11608-103-471
11608-102-473
11608-106-470
11608-106-688
C-AL;4.7UF,20%,50V,GP,5X11MM,5,TP
2401-001967
2401-001968
C-AL;470NF,20%,50V,BP,6X11MM,2MM,BK
C-AL;470NF,20%,50V,GP,5X11MM,5,TP
2401-001975
C-AL;47UF,20%,16V,GP,5X11MM,5,TP
2401-002168
2401-002180
C-AL;100UF,0.2,50V,GP,10X12.5,5MM,T
C-AL;2.2UF,0.2,50V,GP,5X11,5MM,TP
2401-002258
2409-000123
2701-000114
2801-000734
2801-001382
2801-001394
2802-000215
2903-000106
2903-000148
2909-000210
3501-000125
3708-000219
3711-000190
3711-000596
3711-000606
3711-000724
3711-000820
3711-000827
3711-001018
3711-001062
3711-001137
3711-003112
3722-000372
3811-000123
C-AL;4700UF,20%,50V,GP,22X40MM,5MM,
C-EDL;47000UF,4UA,5.5V,-,-,5MM,BK
B1104-0540
INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM
12429-411-100
CRYSTAL-UNIT;7.2MHZ,50PPM,28-AAM,12
14539-501-140
CRYSTAL-UNIT;12MHZ,50PPM,28-AAM,10P
A1280-0017
CRYSTAL-UNIT;32.768KHZ,20PPM,28-AAY
14539-502-350
RESONATOR-CERAMIC;19KHZ,+-38HZ,-,7.
14539-504-100
FILTER-CERAMIC;BP,10.7MHZ+-25KHZ
14529-301-763
FILTER-CERAMIC;BP,450KHZ+-1KHZ
A1243-0049
FILTER-LC;LP,-,1DB,30DB/19KHZ,50DB/
14529-414-050
RELAY-MINIATURE;12V,500MW,5A,DPST,1
14729-501-050
CONNECTOR-FPC/FC/PIC;21P,1.25MM,STR
B6010-0972
CONNECTOR-HEADER;1WALL,2P,1R,7.92MM 13349-156-020
CONNECTOR-HEADER;BOX,10P,1R,2MM,STR 13349-119-100
CONNECTOR-HEADER;BOX,11P,1R,2.0MM,S 13349-119-110
CONNECTOR-HEADER;BOX,15P,1R,2MM,STR
A6010-0169
CONNECTOR-HEADER;BOX,2P,1R,2.5MM,ST 13349-512-561
CONNECTOR-HEADER;BOX,2P,1R,2MM,
13349-119-020
CONNECTOR-HEADER;BOX,5P,1R,2MM
13349-119-050
CONNECTOR-HEADER;BOX,6P,1R,2MM
13349-119-060
CONNECTOR-HEADER;BOX,8P,1R,2MM
13349-119-080
CONNECTOR-HEADER;BOX,8P,1R,2.5MM,-,
JACK-RCA;2P/1C,3.5MM,SN,BLK,#16~22
A3040-0179
WIRE-PVC CU;BCWA,300V,200MM,7/0.16M
13049-011-120
Samsung Electronics
Electrical Parts List
Location No.
RR15
AR7L,7R
UIC1
DIC6
FIC1
HIC1
MIC1
LPF1L,1R
IFT2
IFT4
MW ANT/OSC
AL1L,1R
FAN-DC
RWA4
MWA1
TO FRONT
UD6
IR2
IR1
IC1
FM-PACK
New Code No.
61048-177-333
61048-177-563
AH09-10061B
AH14-10002H
AH14-10006X
AH14-10007G
AH14-10007H
AH26-10001A
AH26-10001E
AH26-10020A
AH27-80060C
AH27-90001B
AH31-10020A
AH39-20019M
AH39-20558A
AH39-50001N
0401-000101
2001-000290
2007-000300
2203-000199
AH40-10001T
AH91-10250A
MDWA1,2
MDW1
MWWA1,2
MWW1
Samsung Electronics
Specification
Old Code No.
R-CARBON;RD 1/8 T 333-J
R-CARBON;RD 1/8 T 563-J
IC-MASK ROM;LC866224V-5082
B4000-0017
IC;LA2010,-,
IC;TEA6320T,SOP,STICK
IC;LC72131,DIP,STICK PLL
IC;LA1836,DIP,STICK IF+MPX
TRANS-IF;FV-AD-BASE19K/38K,LOW PASS 12450-304-040
TRANS-IF;KS940228-09,-,-,7.6X12.0,12619-030-005
TRANS-DET;-,7KLL,DET,-,7.8MM,91PF,1
COIL-OSC;RBW07VB-K5012,350•ÏH,MW(RF
COIL-SPRING;,2.2UH,-,-,SPRING
12429-060-031
FAN-DC;D0620B-12M,12VDC/0.16A,
A3070-0112
LEAD-CONNECTOR ASS’Y;5051,5395,3P,2
16439-0124-00
LEAD CONNECTOR-ASSY;-,5264,51088,7P
LEAD-FASTEN;RING,1007#24,250MM,BLK
13059-202-253
DIODE-SWITCHING;1N4148,100V,200MA,5
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3
11018-877-103
R-CHIP;10KOHM,5%,1/10W,DA,TP,2012
11119-101-103
C-CERAMIC,CHIP;100NF,+80-20%,50V,Z5
TUNER;FE415-G11,-,75OHM
B1290-0001
ASSY-RACK;MM-S1000,DOM
3711-000826 CONNECTOR-HEADER;BOX,2P,1R,2MM,ANGL
3711-000988 CONNECTOR-HEADER;BOX,5P,1R,2.0MM,AN
AH39-20555A
LEAD CONNECTOR-ASSY;-,51004,-,2P,35
AH39-20556A
LEAD CONNECTOR-ASSY;-,51004,-,2P,10
AH39-20559R
LEAD CONNECTOR-ASSY;-,51004,51004,5
3711-000826
CONNECTOR-HEADER;BOX,2P,1R,2MM,
3711-001061
CONNECTOR-HEADER;BOX,6P,1R,2MM
AH39-20556A
LEAD CONNECTOR-ASSY;-,51004,-,2P,10
AH39-20559N
LEAD CONNECTOR-ASSY;-,51004,-,2P,15
AH39-20559T
LEAD CONNECTOR-ASSY;-,51004,51004,6
MMS1000CD
PC1
XIC2L,2R
XX1
WCW1
WCW7
WCW5,12
WCW3
WCW2
LAMP1,2,3,4
WCW4
WCW11
WCW10
WCW6
WIC61
Description
0604-001005
1201-000462
2801-000261
3708-001030
3711-000826
3711-000907
3711-002425
3711-002426
4713-001016
AH39-20018R
AH39-20020A
AH39-20020B
AH39-20021W
AH62-30048A
13349-139-020
13349-139-050
13349-139-020
13349-139-061
CD PACK ASSY;MMS1000CD
PHOTO-INTERRUPTER;TR,-,-,DIP-4,BK
IC-OP AMP;2068,SIP,8P,-,DUAL,120DB,
CRYSTAL-UNIT;33.8688MHZ,50PPM,28-AA
CONNECTOR-FPC/FC/PIC;16P,1MM,ANGLE,
CONNECTOR-HEADER;BOX,2P,1R,2MM,
CONNECTOR-HEADER;BOX,3P,1R,2MM
CONNECTOR-HEADER;BOX,2P,1R,2.0MM
CONNECTOR-HEADER;BOX,4P,1R,2.0MM
LAMP-PILOT;6.3V,70MA,-,GRN,-,-,3.9X
LEAD-CONNECTOR ASS’Y;51004,35023,15
LEAD-CONNECTOR ASS’Y;51004,35023,3P
LEAD-CONNECTOR ASS’Y;51004,35023,2P
LEAD-CONNECTOR ASS’Y;51004,5295,8P,
HEAT SINK;PBSS,-,T0.8,-,-,-,KCD-11/
A1280-0153
13349-139-020
13349-119-030
A6010-1739
A6010-1740
16439-0103-00
16439-0138-00
16439-0139-00
16439-0193-00
11124-0062-00
8-9
Electrical Parts List
Location No.
New Code No.
AH90-10716Y
WD1
WQ93
WQ94
WQ1
WQ61
WQ91,92
WIC41
XIC1
WIC61
WIC01
WR93
WR91
WR92
WR94
XR1
WR10,27
XR7L,7R,8L,8R
WR11,19,21
XR10L,10R
WR3,5
WR25
WR4,18
WR12,28
WR14
WR20
WR1,17,29,46,31,32,33
WR15
WR95
WR96
WR22,24,41,XR3L,3R
XR4L,4R
WR2
WR7,8,42,43
WR23,26,XR1L,1R,2L,2R
XR5L,5R,6L,6R
XR11L,11R
WR16
WR13
WR9
WR61
WVR1,2,3,4
XC23
WC3,XC8,9
WC41
WC12,13,14,22,30,32
WC39,47,50,46
XC4,5,6,7,21,22
WC10,11,19,29
XC24
WC5
8-10
Description
Specification
Old Code No.
ASSY-PCB CD;MMS1000,-
0401-000101
0501-000010
0501-000303
0501-000323
0501-000610
0504-000118
0904-000158
1002-001014
1003-000179
1204-001041
2001-000290
2001-000323
2001-000331
2001-000429
2007-000001
2007-000068
2007-000238
2007-000282
2007-000290
2007-000300
2007-000338
2007-000355
2007-000395
2007-000444
2007-000457
2007-000468
2007-000477
2007-000493
2007-000586
2007-000653
DIODE-SWITCHING;1N4148,100V,200MA,5
TR-SMALL SIGNAL;KSC1008-Y,NPN,80V,6
TR-SMALL SIGNAL;KSA733-Y,PNP,250MW,
TR-SMALL SIGNAL;KSB564Y,PNP,800MW,T
TR-SMALL SIGNAL;KSA928A-Y,PNP,1W,TO
TR-DIGITAL;KSR1003,NPN,300MW,22K-22
IC-DSP;9283,-,QFP,80P,-,16.9344MHZ,
IC-D/A CONVERTER;CXD2565M,18/16BIT,
IC-MOTOR DRIVER;KA9258D,SOP,28P,-,S
IC-ASP;KA9220B,QFP,80P,-,PLASTIC,6V
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3
R-CARBON;120OHM,5%,1/4W,AA,TP,2.4X6
R-CARBON;12KOHM,5%,1/8W,AA,TP,1.8X3
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.
R-CHIP;68KOHM,5%,1/10W,DA,TP,2012
R-CHIP;470KOHM,5%,1/10W,DA,TP,2012
R-CHIP;1.5KOHM,1%,1/10W,DA,TP,2012
R-CHIP;100KOHM,5%,1/10W,DA,TP,2012
R-CHIP;100OHM,5%,1/10W,DA,TP,2012
R-CHIP;10KOHM,5%,1/10W,DA,TP,2012
R-CHIP;120KOHM,5%,1/10W,DA,TP,2012
R-CHIP;12KOHM,5%,1/10W,DA,TP,2012
R-CHIP;150KOHM,5%,1/10W,DA,TP,2012
R-CHIP;180KOHM,5%,1/10W,DA,TP,2012
R-CHIP;18KOHM,5%,1/10W,DA,TP,2012
R-CHIP;1KOHM,5%,1/10W,DA,TP,2012
R-CHIP;1MOHM,5%,1/10W,DA,TP,2012
R-CHIP;2.2KOHM,5%,1/10W,DA,TP,2012
R-CHIP;22KOHM,5%,1/10W,DA,TP,2012
R-CHIP;27KOHM,5%,1/10W,DA,TP,2012
2007-000658
2007-000686
2007-000735
2007-000938
2007-001039
2007-001177
2007-001195
2007-001213
2008-000141
2103-000290
2202-000780
2203-000001
2203-000206
2203-000222
R-CHIP;27OHM,5%,1/10W,DA,TP,2012
R-CHIP;3.3KOHM,5%,1/10W,DA,TP,2012
R-CHIP;30KOHM,1%,1/10W,DA,TP,2012
R-CHIP;47KOHM,1%,1/10W,DA,TP,2012
R-CHIP;56KOHM,5%,1/10W,DA,TP,2012
R-CHIP;8.2KOHM,5%,1/10W,DA,TP,2012
R-CHIP;820KOHM,5%,1/10W,DA,TP,2012
R-CHIP;82OHM,1%,1/10W,DA,TP,2012
R-FUSIBLE;2.2OHM,5%,1/4W,AA,TP,2.6X
VR-SEMI;20KOHM,30%,1/10W,TOP
C-CERAMIC,MLC-AXIAL;100NF,+80-20%,5
C-CERAMIC,CHIP;5PF,0.5PF,50V,NPO,20
C-CERAMIC,CHIP;100NF,10%,50V,X7R,20
C-CERAMIC,CHIP;100NF,20%,50V,Z5U,20
2203-000222
2203-000260
2203-000295
2203-000335
C-CERAMIC,CHIP;100NF,20%,50V,Z5U,20
C-CERAMIC,CHIP;10NF,10%,50V,X7R,201
C-CERAMIC,CHIP;10PF,5%,50V,NPO,2012
C-CERAMIC,CHIP;12PF,5%,50V,NPO,2012
12149-301-050
12149-101-520
12149-202-050
12159-301-780
A4012-0292
11018-877-103
11018-277-121
11018-877-123
11018-877-102
11119-101-683
11119-101-474
11119-101-104
11119-101-101
11119-101-103
11119-101-124
11119-101-123
11119-101-154
11119-101-184
11119-101-183
11119-101-102
11119-101-105
11119-101-222
11119-101-223
11119-101-273
11119-101-332
11119-102-303
11119-102-473
11119-101-563
11119-101-822
11119-101-824
11119-102-820
11058-277-229
11249-102-044
11449-010-104
11129-014-104
11129-004-103
11129-009-100
11129-001-120
Samsung Electronics
Electrical Parts List
Location No.
New Code No.
WC21
WC28
WC25
XC2L,2R,3L,3R
WC24
WC8,18,26
WC4
WC17,20
WC27
XC1L,1R
WC1,31
WC42
XC4L,4R
XC5L,5R
WC2,7,45,XC3
XC1,2,6L,6R
WC6,9
WC15,16,23
WC61,62
WL1,XL1,2,3
WB1,2
WB3,XB1,2,3,5,6
XIC3
2203-000417
2203-000495
2203-000575
2203-000749
2203-000787
2203-000802
2203-000892
2203-000919
2203-001105
2203-001246
2203-001537
2203-001551
2301-000361
2301-000445
2401-000243
2401-000407
2401-000868
2401-001238
2401-001355
2703-000001
3301-000297
3301-000325
AC14-12001G
UD6
IR2
IR1
IC1
FM-PACK
0401-000101
2001-000290
2007-000300
2203-000199
AH40-10001T
UD4,6
IR1
FM-PACK
0401-000101
2007-000029
AH40-10025H
Description
Specification
C-CERAMIC,CHIP;18NF,10%,50V,X7R,201
C-CERAMIC,CHIP;2.2NF,10%,50V,X7R,20
C-CERAMIC,CHIP;220NF,10%,50V,X7R,20
C-CERAMIC,CHIP;30PF,5%,50V,NPO,2012
C-CERAMIC,CHIP;330PF,5%,50V,NPO,201
C-CERAMIC,CHIP;33NF,10%,50V,X7R,201
C-CERAMIC,CHIP;4.7NF,10%,50V,X7R,20
C-CERAMIC,CHIP;470NF,+80-20%,16V,Y5
C-CERAMIC,CHIP;6.8NF,10%,50V,X7R,20
C-CERAMIC,CHIP;82PF,5%,50V,NPO,2012
C-CERAMIC,CHIP;1NF,10%,50V,X7R,2012
C-CERAMIC,CHIP;1.5NF,10%,50V,X7R,20
C-FILM,PEF;1.2NF,10%,50V,-,5MM,TP
C-FILM,PEF;4.7NF,5%,50V,5.5X7X3MM,5
C-AL;100UF,20%,10V,GP,6.3*5,2.5MM,T
C-AL;10UF,20%,16V,GP,3.5*5,-,TP
C-AL;220UF,20%,4V,GP,6.3*5,2.5MM,TP
C-AL;4.7UF,20%,25V,GP,3*5,1MM,TP
C-AL;470UF,20%,10V,GP,8X11.5,5MM,
INDUCTOR-SMD;10UH,10%,2.5X3.2X2MM
CORE-FERRITE BEAD;AA,3.6X1.2X5.7MM,
CORE-FERRITE BEAD;AB,3.2X2.5X1.3MM,
IC;KA78L05,T,-
Old Code No.
11129-004-183
11129-004-222
11129-004-224
11129-009-300
11129-001-333
11129-004-682
11608-152-101
11608-173-100
11608-171-221
11608-154-479
11176-600-050
14049-033-420
B1144-0034
MAIN OPTION PARTS
DIODE-SWITCHING;1N4148,100V,200MA,5
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3
R-CHIP;10KOHM,5%,1/10W,DA,TP,2012
C-CERAMIC,CHIP;100NF,+80-20%,50V,Z5
TUNER;FE415-G11,-,75OHM
11018-877-103
11119-101-103
B1290-0001
MAIN OPTION PARTS
Samsung Electronics
DIODE-SWITCHING;1N4148,100V,200MA,5
R-CHIP;0OHM,5%,1/10W,DA,TP,2012
TUNER-FM;FTAW501VA,3G,75OHM (OIRT)
11119-101-000
8-11
Electrical Parts List
Location No.
8-12
New Code No.
Description
Specification
Old Code No.
Samsung Electronics
Samsung Electronics
µPC1297A
DIC6
FIC1
SIC1
AIC1
ZIC1
V.F.D
FIC1
RIC1
BA3950A
9. Block Diagrams
9-1 Main
9-1
Block Diagrams
CXD2565M
XIC2R
XIC1
9-2 CD
WIC61
WIC01
WIC41
XIC2L
9-2
Samsung Electronics
Block Diagrams
9-3 IC & TR Internal Diagrams
9-3-1 Main
TEA6320T : FIC1
2.2 k
8.2 nF
3.3 nF
C
KVL
10
100 F
+
220 nF
20 k
8
5.6 nF
150 nF
9
7
6
5
31
2
GND
+
VOLUME I
+20 to -31 dB
LOUDNESS
LEFT
47F
TREBLE
RIGHT
12 dB
BASS
LEFT
15 dB
VOLUME II
0 to -55 dB
BALANCE
FADER FRONT
16
3
4
32
15
IL
VOLUCE II
0 +to -55 dB
BALANCE
FADER REAR
POWER
SUPPLY
19
9 X 220 nF
fast mute
12
MUTE
FUNCTION
ZERO CROSS
DETECTOR
21
Vcc
Cm
10 nF
IIC BUS
REC
LOGIC
1
SCL
SDA
13
11
14
I MO
SOURCE
SELECTOR
VOLUME I
+20 to -31 dB
LOUDNESS
RIGHT
22
VOLUME II
0 to -55 dB
BALANCE
FADER FRONT
TREBLE
RIGHT
12 dB
BASS
RIGHT
15 dB
29
20
IR
VOLUME II
O to -55 dB
BALANCE
FADER REAR
18
17
C
KIN
30
TEA6320
23
C
KVL
25
24
220 nF
26
27
28
5.6 nF
150 nF
33 nF
8.2 nF
20 k
2.2 k
NJM074 : SIC1
V+
-INPUT
OUTPUT
+INPUT
V-
Samsung Electronics
9-3
Block Diagrams
STK4181V : AIC1
12
11
R1
TR8
TR4
C1
R5
TR9
TR1
1
R2
16
R6
TR2
TR7
2
17
TR10 D2
R3
TR3
R7
TR11
D1
R1
TR12
7
R8
TR13
R9
3
5
6
8 9 101314
4
15
16
LB1649 : ZIC1
1
OUT1
OUT2
10
3
OUT3
OUT4
4
9
11
IN 1
7
VCC2
Pre-Driver
Pre-Driver
VCC1
8
Input Logic
Input Logic
IN4
Fin
2
IN 2
9-4
12
VZ1
6
VZ2
5
IN3
Samsung Electronics
Block Diagrams
LC72131 : HIC1
XIN
1
XOUT
22
FMIN
16
18 PD
PHASE DETECTOR
CHARGE PUMP
REFERENCE
DIVIDER
1/2
AMIN
15
CE
3
DI
4
CL
5
DO
6
VDD
17
Vss
21
19 AIN
SWALLOW COUNTER
1/16, 1/17 4D1ts
UNLOCK
DETECTOR
20 ADUT
12bita PROGRAMMABLE
DIVIDER
2
C B
1/F
DATA SHIFT REGISTER
LATCH
UNIVERSAL
COUNTER
12 IFIN
P0WER
ON
RESET
7
8
9
10
11
13
BO1
BO2
BO3
BO4
IO1
IO2
LA1836 : MIC1
29
29
ALC
28
AM
MIX
AM
OSC
27
26
25
24
23
22
21
AM
IF
STEREO
DRIVE
AM
DET
FF
S-CURVE
AM/FM
IF
BUFF
FM
DET
2
Samsung Electronics
FF
TRIG
16
MUTE
FF
PILOT
DET
AM/FM
SW
PHASE DET
AM
PM
REG
1
17
VCC
COMP
TUNING
DRIVE
FM
IF
18
STERO
SW
AGC
SMFT
19
DECODER
AM
RF AMF
DUFF
LEVEL
DET
20
3
4
VCC
GND
5
6
7
8
9
10
11
12
13
14
15
9-5
Block Diagrams
LC4966 : SIC3
14
13
SW A
12
11
10
SW B
1
2
3
9
8
SW C
4
5
SW D
6
7
KA2271B : DIC1
REC IN2 PB IN2
9
PB OUT2
REC OUT2
14
16
11
BUFFER
Vcc
10
R/R
12
VCA & HPF
VOLTAGE
REGULATOR
NR SW
13
R/P SW
4
GND
CONTROL
SWITCH
15
GAIN
FACTOR
5
R.CONST
RMS
DETECTOR
2
RIPPLE
FILTER
7
BUFFER
9-6
RIPPLE
FILTER
RMS
DETECTOR
VCA & HPF
8
6
3
1
REC IN1
PB 1N1
PB OUT1
REC OUT1
Samsung Electronics
Block Diagrams
BA3950A : RIC1
VCC
ST.BY
MODE
Selector
PRE GND
GND
6
10
9
11
12
Vref
8
1
2
5
3
MAIN
SIGNAL 12V
0.8A
CDP 10V
600mA
MOTOR
13.3V
µ-COM 5.6V
250 mA
C1297CA : DIC1
Vcc
VR 2
VIN(R) 2
PH
CIN 2
COUT 2
VOUT 21
VOUT 22
VON(0)
18
17
16
15
14
13
12
11
10
ABSO
DET
VCA
Comparator
PEAK
DET
Pre-Drive
ABSO
DET
Samsung Electronics
Comparator
PEAK
DET
VCA
1
2
3
4
5
6
7
8
9
VsT
VR 1
VIN(R) 1
PH 1
CIN 1
COUT 1
VOUT 11
VOUT 12
GND
9-7
Block Diagrams
LC75710 : FIC1
DI
CL
CE
C
O
N
T
R
O
L
VDD
VSS
DC
RAM
SHIFT REGISTER
ADDRESS
REGISTER
ADDRESS
COUNTER
BLINKCYCLE
REGISTER
BLINK
GENERATOR
DISPLAY
REGISTER
DISPLAY
CONTROL
DUTYCYCLE
REGISTER
DUTY
GENERATOR
GRID
REGISTER
GRID
CONTROL
INSTRUCTION
DECODER
CONTROL
L
A
T
C
H
CG
ROM
CG
RAM
L
A
T
C
H
AD
RAM
A
N
O
D
E
D
R
I
V
E
R
VFL
RES
TEST
OSCI
OSCO
9-8
OSG
DIVIDER
TIMMING
GENERATOR
D
E
C
O
D
E
R
G
R
I
D
D
R
I
V
E
R
AM1
AM2
AM35
AA1
AA2
AA3
AA4/G16
AA5/G15
AA6/G14
AA7/G13
AA8/G12
G11
G10
G2
G1
Samsung Electronics
Block Diagrams
9-3-2 CD
1 2 3
TR
1
2
3
KSC1008
KSA733
KSB564
DSR1003
A928
XIC3
E
E
E
E
E
OUT
B
B
B
C
C
GND
C
C
C
B
B
IN
X OUT
6
21 22
TIMING
CIRCUIT
INIT 1
SYSM 2
MUTEL
384 fs
7
MUTER
TEST 1
9
X IN
TEST 2
CXD2565M : XIC1
14 13
CLOCK
GENERATOR
"0" DETECT
MUTE
CIRCUIT
27 L 1(+)
LRCK 12
BCK 10
DATA 11
S/P
ATT
ATT
FIR 2
FIR 3
SAMPLE
/HOLD
(X4)
DC
DITHER
AC
DITHER
FIR 3
SAMPLE
/HOLD
(X4)
3rd order
NOISE
SHAPER
PLM
25 L 2(+)
IIR
LATCH 5
SHIFT 4
ATT 3
MODE
16 R 1(+)
ATT
FIR 1
FIR 2
3rd order
NOISE
SHAPER
PLM
18 R 2(+)
IIR
KA9258 : WIC61
26
25
24
23
22
GND
21
VCC
20
19
18
17
16
15
12
13
14
10K
27
10K
28
VCC
10K
10K
50K
10K
REGULATOR
MUTE
10K
+
LEVEL SHIFT
+
LEVEL SHIFT
T¥S¥D
10K
10K
1
Samsung Electronics
2
3
4
5
6
7
GND
8
9
10
11
9-9
Block Diagrams
24
21
LOQP
FILTER
N/C
SLSTP
3
2
5
8
COMS
TO
TTL
EFM
COMPARATOR
36
N/C
14
LOCK
31
SMPD
12
SMON
13
SMEF
25
DVCC (S)
SPDI
SPDLO
WDCH
VREO & VIC
VCO
1-TIME
VCO
2-TIMES
MICOM TO SERVO CONTROL
AUTO SEQUENCER
CLV
LPF
55
FS1 TG4
FM1 TG7
TG1 TG2
Ð +
43
WINDOW
COMPARATOR
PS1 TG2
TRACKING
ERROR AMP
DEFECT AMP
& COMPARATOR
44
TRACKING
PHASE
COMPENSATION
Ð +
23
FBM
Ð +
VREO
41 40 39 42
MIROR
AMP
&
COMPA
-RATOR
TTL TO COMS
TEST2
CPH
7
SLEN
CBH
33
SLEO
PFSET
6
SLEI
ISTAT
32 34
TRCNT
N/C
9
Ð +
FVC
VREOI
AVEE (S)
22 35 28 38 37 84 27 28 20 30
DIRC
RESET
MDAT
MLT
MCK
DVEE (S)
AASC
EFMO
BPF
APDI
ISET
KA9220(ASSP) : WIIC01
FOCUS
PHASE
COMPENSATION
DEFECT AMP
& COMPARATOR
11
10
AVCC (S)
54
TDFCT
47
TKEI
48
TKEO
72
AVCC(RF)
15
TGSW
16
RTG
50
ATS
51
TZC
52
TE2
53
TE1
49
N/C
20
FSCH
58
FDFCT
45
FCE
46
FSEO
ARC AMP
Ð +
4
FOCUS
ERROR AMP
RF AMP
60
LFR
FSW
HF GO
FE2
FE1
FBIAS
DCC1
1 33 57 56 19 18 17
AVEE (RF)
DCC2
EI
RV
F
EO
E
N/C
CV
70 71 75 74 69 73 74 76 62 61 68 79 80
PD2
RF
P/N
RFI
RFO
65 66 67 78
PD1
LDON
59
PD
N/C
LD
FOK
CXD2565M : XIC1
A
1
+
-B
+
2
3
1. A OUTPUT
2. A- INPUT
3. A+ INPUT
4. V-
9-10
4
5
6
7
8
5. B+ INPUT
6. B- INPUT
7. B OUTPUT
8. V+
Samsung Electronics
Block Diagrams
SOS1
SBGK
SDAT
KS9283 : WIC41
26
32
33
SUBCODE
SYNC
DETECTOR
EFN1
APDO2
APDO1
8 6
VCOLO1
CONTVOL
DPFIN
70
DPFOUT
DPDO
4
SMEF
SMON
SMDP
SMSD
72
77
75
76
EFM
PHASE
DETECTOR
80
67
5
23 BITS
SHIFT
REGISTER
SUBCODE
OUTPUT
SUBCODE Q
REGISTER
30
SODT
29
SOCK
EFM
DEMODULATOR
DPLL
3
FRAME SYNC
DETECTOR
PROTECTOR
INSERTOR
2
ECC
CLV SERVO
18K
SRAM
10
LOCX
X-TAL
TIMING
OSCILATOR
9
XIN
8
MDAT
MCK
MLT
DSPEED
37
38
36
CPU
INTERFACE
TRACK
COUNTER
MODE
SELECTOR
DIGITAL
OUTPUT
SRAM
ADDRESS
CENERATOR
79
CNIN
/ISTAT
68
DSPEED
78
Samsung Electronics
7
SEL3
SEL4
TEST
DATX
15
12
21
11
20
LRCH2
65
LRCH1
64
ADATA1
63
ADATA2
62
INTERPOLATOR
C2P0
61
SEL2
69
SEL1
XOUT
9-11
Block Diagrams
9-4 µ-com(LC866224V-5082) : UIC1
Description
No.
Port
Name
I/O
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
P5 2
PWM
P2 0
1
2
3
4
5
6
7
TEST1
RESET
XT 1
XT 2
VSS
CF 1
CF 2
VDD
P8 0
1
2
3
4
5
6
7
P7 0
1
2
3
S0 / T0
S1 / T1
S2 / T2
S3 / T3
S4 / T4
S5 / T5
S6 / T6
S7 / T7
S8 / T8
S9 / T9
S10 / T10
S11 / T11
S12 / T12
S13 / T13
S14 / T14
S15 / T15
Vdd / Vpp
Vp
S16
S17
DOLBY
O
TAPE DOLBY ON/OFF
MOTOR
SOL
HALF
HALL
REC S/W(FWD)
F.DATA
F.CLK
F.CE
NON USED
RESET
O
O
I
I
I
O
O
O
TAPE MOTOR CONTROL
TAPE SOLENOID CONTROL
TAPE EXISTENCE OR NOTHING (L : EXISTENCE)
TAPE AUTO STOP COUNT CHECK
REC ENABLE SWITCH
FLT DRIVE IC DATA
FLT DRIVE IC CLOCK
FLT DRIVE IC CHIP ENABLE
9-12
REC S/W(RVS)
MODE
A/D KEY I/P
“
“
I
I
I
I
I
OPTION I/P
SCOR
D.SENSE
POSNS
REMOCON
POCNT
LED ON
CDB+
RECTUNER MUTE
I
I
I
I
I
O
O
O
O
SUB CLOCK OSC
SUB CLOCK OSC
DIGITAL GND
MAIN CLOCK OSC
MAIN CLOCK OSC
+5V
REC ENABLE SWITCH
TAPE FUNCTION CHECK (STOP MODE : HIGH)
RESET OPTION CHECK PORT
CD DSP
CD DISC IN CHECK SENSE
POWER CORD ON/OFF(HOLD) CHECK
REMOCON INPUT
POWER ON/OFF
CD PART POWER ON
TAPE REC
TUNER PART MUTE CONTROL
Samsung Electronics
Block Diagrams
No.
Port
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
S18
S19
S20
S21
S22
S23
S24
S25
S26
S27
S28
S29
S30
S31
P00
P01
P02
P03
P04
P05
P06
P07
P10/S00
P11/S01
P12/SCK0
P13/S03
P14/S04
P15/SCK1
P16/BUZ
P17/PWM0
P30
P31
P32
P33
P34
P35
P36
P37
VSS
VDD
P40
P41
P42
P43
P44
P45
P46
P47
P50
P51
Samsung Electronics
Name
LED(REW)
LED(R.PLAY)
LED(F.PLAY)
LED(F.F)
LED(STOP)
LED(PAUSE)
LED(CD ON)
LD ON
SRS ON
D4
D3
D2
D1
D0
DACXLT
MCLK
MDATA
CD MUTE
STEREO
FOK
ISTAT
SD
SENSE OUTPUT
SQDT
SQCK
LKFS
XLT
CLK
P.CE
P.DO
P.DI
F.MUTE
A.MUTE
RELAY
SHORT SENCE
DC SENSE
XRST
WINDOW OPEN DRIVE IC
GND
VDD
WINDOW OPEN SENSOR
WINDOW CLOSE SENSOR
HIDDEN KEY OPEN DRIVE IC
HIDDEN KEY OPEN DRIVE IC
WINDOW CLOSE DRIVE IC
HIDDEN KEY OPEN SENSOR
HIDDEN KEY CLOSE SENSOR
AMPS IN
TAPE MUTE
REC MUTE
I/O
O
O
O
O
O
O
O
O
O
O
O
O
O
I
I
I
I
O
I
O
I
O
O
O
O
I
O
O
O
I
I
O
O
I
I
O
O
O
I
I
I
O
O
Function
LD LASER DIODE ON
SRS ON/OFF
OPTION DIODE
OPTION ‘H’ MODE : 24H
OPTION ‘H’ MODE : 24H
OPTION ‘H’ MODE : 24H
OPTION ‘H’ MODE : 24H
DAC IC LATCH
CD DSP / DAC CLK
CD DSP / DAC DATA
CD MUTE ON/OFF
DTS STEREO INPUT
CD FOCUS OK INPUT
CD DSP SENSE
DTS TUNED INPUT
CD DISC SENSE OUTPUT SIGNAL CONTROL
CD DSP SUBQ DATA INPUT
CD DSP SIO CLOCK
GFS
CD DSP XLT
PLL/FUNCTION CLOCK
PLL CHIP ENABLE
PLL/FUNCTION DATA OUTPUT
PLL DATA INPUT
FUNCTION MUTE
AUDIO MUTE
TAPE AMPS INPUT CHECK
TAPE FUNCTION MUTE
TAPE REC MUTE(REC MUTE ON ‘H’)
9-13
10 PCB Diagrams
10-1 Main
Samsung Electronics
10-1
PCB Diagrams
10-2
Samsung Electronics
PCB Diagrams
10-2 Front
Samsung Electronics
10-3
PCB Diagrams
10-3 CD
10-3-1 Main
10-3-2 Lamp
10-4
Samsung Electronics
11. Wiring Diagram
MWWA1
MWWA2
LWA1R
LWA1L
KAW1
Samsung Electronics
FAW1
11-1
12. Schematic Diagrams
12-1 Main
AIC1
DIC8
ZIC1
DIC9
DIC6
SIC3
RIC1
SIC1
FIC2
Samsung Electronics
SIC2
12-1
Schematic Diagrams
12-2 Front
TAPE DECK PCB
FIC1
DIC1
DIC3
DIC2
12-2
Samsung Electronics
Schematic Diagrams
12-3 CD
1
2
1
WIC01
2
3
WIC41
3
WIC61
Samsung Electronics
12-3
Download PDF
Similar pages