Instruction Manual Gas Fryer Foot Long Dogs

Instruction Manual
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
10700 Medallion Drive, Cincinnati, Ohio 45241-4807 USA
© 2017 Gold Medal Products Co.
Part No. 88847
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
SAFETY PRECAUTIONS
DANGER
Gas is safe when used properly, but can be very dangerous when used
improperly. We suggest that installation be carefully made by qualified
personnel only. Gas companies have competent service personnel to
provide safe installation.
001_010914
DANGER
DO NOT use a match or flame to check for gas leaks – you may cause a fire
or explosion!
003_010914
DANGER
Never add water to hot oil. When water is added to hot oil a stream explosion
may ensue spattering hot oil resulting in serious burns or more seriously hot
oil in someone’s eyes.
024_010914
DANGER
Hot oil is dangerous – severe burns can result when hot oil contacts the skin.
Hot oil is flammable – keep open flames away from hot oil and its vapors.
Keep a fire extinguisher near this unit.
Instruct personnel on what to do if there is a grease fire. DO NOT USE
WATER ON A GREASE FIRE! Use only fire extinguishers approved for
grease, oil, and electric fire.
002_102214
DANGER
Improper installation, adjustment, alteration, service, or maintenance can
cause property damage, injury, or death. Any alterations to this equipment
will void the warranty and may cause a dangerous condition. This appliance
is not intended to be operated by means of an external timer or separate
remote-control system. NEVER make alterations to this equipment. Read the
Installation, Operating, and Maintenance Instructions thoroughly before
installing, servicing, or operating this equipment.
014_020416
WARNING
DO NOT store or use gasoline, or other flammable vapors and liquids, in the
vicinity of this equipment.
004_010914
Page 2
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
SAFETY PRECAUTIONS (continued)
WARNING
Instructions on what to do when a user smells gas can be obtained from the
local gas supplier. These instructions must be posted in a prominent location
where the unit is to be operated.
005_010914
WARNING
To avoid burns, DO NOT touch heated surfaces.
DO NOT place or leave objects in contact with heated surfaces.
009_092414
WARNING
ALWAYS wear safety glasses when servicing this equipment.
010_010914
WARNING
No user serviceable parts inside. Refer servicing to qualified service
personnel.
011_051514
WARNING
Read and understand operator’s manual and all other safety instructions
before using this equipment. To order copies of the operator’s manual go to
gmpopcorn.com or write to Gold Medal Products Co., 10700 Medallion Drive,
Cincinnati, OH 45241 USA 1-(800)-543-0862
022_060215
WARNING
DO NOT allow direct contact of this equipment by the public when used in
food service locations. Only personnel trained and experienced in the
equipment operation may operate this equipment.
Carefully read all instructions before operation.
012_010914
Page 3
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
SAFETY PRECAUTIONS (continued)
WARNING
This machine is NOT to be operated by minors.
007_010914
Note: Improvements are always being made to Gold Medal’s equipment. This information
may not be the latest available for your purposes. It is critical that you call Gold Medal’s
Technical Service Department at 1-800-543-0862 for any questions about your
machine operations, replacement parts, or any service questions. (Gold Medal
Products Co. does not assume any liability for injury due to careless handling and/or
reckless operation of this equipment.) General images may be used in manual for
reference only.
Page 4
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
INSTALLATION INSTRUCTIONS
Inspection of Shipment
After unpacking, check thoroughly for any damage which may have occurred in transit. Claims
should be filed immediately with the transportation company. The warranty does not cover
damage that occurs in transit, or damage caused by abuse, or consequential damage due to the
operation of this machine, since it is beyond our control (reference warranty in back of manual).
Manual
Read and understand the operator’s manual and all other safety instructions before using this
equipment. To order copies of the operator’s manual go to gmpopcorn.com or write to Gold
Medal Products Co., 10700 Medallion Drive, Cincinnati, OH 45241 USA 1-(800)-543-0862.
Model Description
8065NSD: Gas Fryer, Foot Long Dogs
Items Included with this Unit
Tank Hose
Tank Regulator
Fine Mesh Skimmer
Dial Type Thermometer
Optional Accessories – Not Included
The following accessories are available for purchase separately.
Dog on a Stick Kit – Gold Medal Item No. 8054
Single Large Fry Basket – Gold Medal Item No. 8072
Page 5
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Setup
This unit is fully assembled and has been tested at the factory.
1. Remove all packaging and tape prior to operation.
2. This unit is for outdoor use only.
3. Place the fryer in a protected location on a level, sufficiently stable base or table,
where it cannot be knocked off. The base or table must be strong enough to support
the fryer when full of oil. Adjust the Case Levelers as needed (see image below).
4. Observe the following clearances to ensure proper air supply and maintenance:
•
Minimum of 6 inches clearance on each side of unit.
•
Minimum of 30 inches clearance for the front, back, and top of unit.
5. Bolt the unit to the counter to secure it from tipping. To restrain the fryer,
use 3/8-16 bolts through the counter into tapped holes in the bottom of the fryer.
6. Set the thermometer bracket on the rim of the tank in a convenient location, where the
dial thermometer can be inserted and monitored without reaching over the tank.
7. After setup, the unit should be cleaned prior to use (see Care and Cleaning section of
this manual).
Case Levelers (4)
Page 6
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Gas Installation Instructions
Gas Requirements
The 8065NSD is designed for Propane only. Converting this unit to an alternate fuel source will
void the warranty and may cause a dangerous condition.
8065NSD: Propane Gas, 65,000 BTU/HR
NOTE: The unit must be attached to a minimum of 40 pound LPG cylinder. For outdoor
use only.
Gas Installation
DANGER
Gas is safe when used properly, but can be very dangerous when used
improperly. We suggest that installation be carefully made by qualified
personnel only. Gas companies have competent service personnel to
provide safe installation.
001_010914
When installing this gas unit in the United States, you must conform with local codes, or in the
absence of local codes, with National Fuel Gas Code, ANSI Z223.1 (latest edition).
NOTE: Some local codes may require ventilation hoods or automatic fire systems. During
any pressure testing of the gas supply piping system at pressure equal to or less
than 1/2 psig (3.45 kPa), the appliance must be isolated from the gas supply piping
system by closing its individual manual shutoff valve.
After installation, all gas connections must be checked for leaks with a soap
solution (see Checking for Gas Leaks section of this manual).
CAUTION
Be sure to observe all clearances for this unit. Refer to the Setup Section of
this manual to ensure proper air supply and adequate clearance for servicing
and installation of this gas unit.
033_042814
Page 7
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Important Fire Safety Notice
Consult your local fire protection agency for your area’s requirements. Check local fire protection
requirements regularly to ensure compliance with local codes and proper operation. Have a fire
extinguisher near the fryer. (Use only fire extinguishers approved for grease, oil, and electrical
fires.)
A thermometer (capable of 500°F or higher) should be immersed in the oil to monitor the oil
temperature and make sure the unit is operating properly.
DANGER
Hot oil is dangerous – severe burns can result when hot oil contacts the skin.
Hot oil is flammable – keep open flames away from hot oil and its vapors.
Keep a fire extinguisher near the fryer.
Instruct personnel on what to do if there is a grease fire. DO NOT USE
WATER ON A GREASE FIRE! Use only fire extinguishers approved for
grease, oil, and electric fire.
002_020314
Advanced Safety Measures
KEEP FRYER AREA CLEAN AND MAINTAINED
• Keep your floors clean and free of grease to prevent slips, accidents, and contact with a
hot fryer.
•
Keep filters and areas above the fryer clean. Oil-soaked lint or dust can ignite easily
and flames spread quickly in an oily environment.
EDUCATE PERSONNEL
• Ensure all personnel understand the hazards of hot oil. Instruct them on proper
actions to take if they suspect any part of the fryer is malfunctioning.
If your fryer malfunctions, have it serviced by Qualified Service Personnel.
IMPORTANT: If the fryer starts to smoke or boil abnormally, shut off gas supply and
determine the reason why the fryer is overheating before attempting to use it.
•
Ensure all personnel understand procedures to follow if the High Limit Control is
tripped. (See High Limit Control description in the Controls and Their Functions
section of this manual.)
•
Educate all personnel on proper procedures to follow if a grease fire should occur.
DO NOT USE WATER ON A GREASE FIRE! Never direct the extinguisher in a manner
that would blow grease out of the tank.
Ensure a fire extinguisher is readily available to extinguish a grease, oil, and
electric fire. Make sure all personnel are properly trained in the use of the fire
extinguisher.
Page 8
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Checking For Gas Leaks
After making any gas connection, or after performing any work on the gas train, ALWAYS check
ALL gas connections for leaks with a soap solution.
DANGER
DO NOT use a match or flame to check for gas leaks – you may cause a fire
or explosion! When gas connections are complete, have a qualified
professional wire the unit to a power source which will carry the current
specified on the unit’s data plate.
034_042814
1. Apply SOAP BUBBLES to all connections and pressurize the gas line to check for leaks.
Perform this test outdoors away from any flames or sparks.
DO NOT use a flame to check for gas leaks.
2. It is recommended to check your flexible gas lines and gas fittings for wear and tear on
a frequent basis. Stop using the appliance immediately if damage is found, and contact
a qualified professional to inspect and correct any issue.
3. Securely route all gas lines away from flames and high temperature areas.
4. Contact Gold Medal Technical Support, or a qualified Gas Service Technician with any
questions.
Gas Pressure
We have determined that optimum frying occurs when the gas pressure is adequate. For
propane gas, we recommend a manifold pressure setting of 11 inches of water column. The
pressure is measured at the appliance when the main burner is ignited.
Lighting and Shutdown Instructions
The igniter for this unit requires a AAA Battery. To install/replace the battery, see Igniter Battery
Replacement Instructions on next page. For pilot and burner lighting and shutdown instructions,
refer to the Operating Instruction section.
Page 9
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Igniter Battery Replacement Instructions
The igniter for this unit requires a AAA Battery. DO NOT install the battery until gas installation
is complete (reference the Gas Installation Instructions section).
To install/replace igniter battery, make sure all machine switches and gas valves are OFF, then a
five minute shutdown period is required before attempting to install/replace the battery.
(Reference the Lighting and Shutdown instructions located in the Operating Instruction section.)
Step 1: Locate igniter and remove the
plastic retaining nut.
Igniter
Retaining Nut
Step 2: Remove old battery from igniter,
and replace with new AAA Battery.
Step 3: Replace retaining nut to its
original position.
AAA Battery
Page 10
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
OPERATING INSTRUCTIONS
Controls and Their Functions
COMBINATION VALVE
The Combination Valve has three settings used to control gas flow; PILOT, ON, and OFF
positions. (Reference the Lighting and Shutdown Instructions in the Operating Instruction
section of this manual.)
PILOT position - When the Combination Valve is in the PILOT position, the Combination
Valve may be pressed “IN” to provide gas for lighting the pilot.
ON position - Once the pilot is lit, turn the Combination Valve to the ON position to ignite
the main burner for use.
OFF position – The Combination Valve must be pulled “OUT” to rotate the valve into the
OFF position.
IGNITER SWITCH
The igniter is operated by (1) AAA Battery. When pushed, the ignitor provides spark for
lighting the pilot.
HEAT CONTROL KNOB
This device controls the temperature of the cooking oil. Normal range is from 200°F to
400°F. Use an independent thermometer immersed in the oil to monitor and ensure the
accuracy of the oil cooking temperature.
HIGH LIMIT RESET SWITCH
The High Limit Control will shut-off the unit if the temperature exceeds 450°F. The High
Limit Control can only be reset after the fryer has cooled to normal operating
temperatures. (Reference the Lighting and Shutdown Instructions in the Operating
Instruction section of this manual.)
DRAIN VALVE/DRAIN PLUG
The Drain Valve and Drain Plug open to allow efficient draining of the cooking oil from the
tank. Always allow hot cooking oil to cool below 140°F before attempting drain the unit.
Note: The Drain Valve has a Safety Collar on the handle. Slide the collar up to allow the
drain valve handle to be rotated.
Page 11
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Control Locations
Heat Control Knob
Reset Switch
Drain Valve
with Safety
Collar
Drain Plug
Igniter Button
Gas Safety Valve
Page 12
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Tank Preparation
Before operating for the first time, the inside of the fryer tank should be rinsed and thoroughly
dried before adding oil. See the Cleaning and Care section of this manual for cleaning instructions.
Prior to each use, check the drain valve to make sure it is securely closed and the drain plug is
fully tightened into place.
Filling the Tank with Oil
Tank Capacity: The tank will hold 87.5 lbs. of cooking oil, this is equivalent to (2½) 35 lb. boxes
of oil.
Initially fill the tank to the minimum oil fill line. DO NOT operate this unit with the cooking oil
below the minimum oil level.
IMPORTANT: Cooking oil expands upon heating. To safely bring the oil level up to the
maximum fill level, carefully add additional increments of oil as it heats until it
reaches the maximum fill line. DO NOT overfill the tank, as overfilling could result
in a dangerous situation.
Hot oil is dangerous - be sure you have thoroughly read the Safety Precautions of
this manual.
DO NOT allow water to contact oil. Only cook product intended for this
appliance. Do not attempt to cook products with high water content or with
surface moisture present. Do not operate in the rain or near any source of water.
Failure to keep water away from oil may result in explosion and severe burns.
Make sure appliance is completely dry after cleaning, including inside any drain
valves.
Page 13
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Lighting and Shutdown Instructions
Steps to Light the Pilot and Burner:
1. Turn the Combination Valve to the PILOT position.
2. Press the Combination Valve “IN”. While holding the Combination Valve in, press and
hold the Igniter Button “IN” until pilot flame lights. Continue holding Combination
Valve for 30-45 seconds then release.
Note: Pilot flame should remain light.
3. Turn the Combination Valve Handle to the ON position. The main burner will ignite.
Steps to Shut Down the Pilot and Burner:
1. To extinguish both the pilot and the main burner flames, turn the Combination Valve
and push “IN”, turn to the OFF position.
2. Should the burner become extinguished because of the high-limit tripping, shut off the
gas supply until the unit cools down, then re-ignite.
CAUTION
If pilot is turned off, a five minute shutdown period is required before
attempting to re-light.
035_042814
NOTE: The igniter is operated by (1) AAA Battery (included). If the igniter does not work,
reference the Igniter Battery Replacement Instructions in the Gas Installation
section. We recommend that the battery be replaced annually.
If the Flame Goes Out
If the flame goes out, a five minute shutdown period is required before attempting to re-light.
1. Check to see if you are out of gas.
2. Check to see if the thermocouple is in the proper position.
Page 14
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Operating the Fryer
Important Operating Information and Quality Control Tips
•
•
•
•
•
•
•
•
•
Don't overheat. Don't fry if the oil temperature exceeds 400°F.
Don't waste money, use only high quality heavy duty frying shortening.
Don't fry food in broken-down frying shortening; broken down oil is thinned, darkened.
Don't overload the frying tank.
Don't fill the basket more than half full.
Don't shake breaded items over fryer.
Don't salt items over fryer.
Don't introduce water to fryer.
Don't thaw frozen foods before frying.
Operating the Fryer
1. Fill the tank to the minimum oil level with cooking oil, then turn the Main Burner ON
(follow the Steps to Light the Pilot and Burner in the Lighting and Shutdown section of
this manual).
2. Set the Heat Control Knob to desired cooking temperature. As the cooking oil heats
and expands, carefully add additional increments of oil until it reaches the maximum
fill line. DO NOT overfill the tank, as overfilling could result in a dangerous
situation.
3. Once the oil has reached the desired cooking temperature, the fryer is ready for use.
4. To help maintain oil quality, periodically skim off excess batter (food) particles.
Shutdown Procedure and Draining the Tank
1. Once frying is complete, turn both the pilot and main burner OFF (follow the Steps to
Shut Down the Pilot and Burner in the Lighting and Shutdown section of this manual).
2. Remove any forms, the thermometer, and allow the unit to cool completely.
3. DO NOT move this unit when filled with oil! Allow hot cooking oil to cool below
140°F before attempting drain the unit.
4. To drain the unit, have an appropriate container in place to receive the oil.
5. With the drain valve CLOSED, remove the drain plug.
6. Slide the safety collar up on the drain valve handle, then OPEN the drain valve to
empty the cooking oil from the fryer tank.
7. For unit cleaning instructions, see Care and Cleaning Section.
Page 15
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Care and Cleaning
WARNING
Hot surface and hot oil inside unit. DO NOT touch! Always allow unit to cool
before cleaning, servicing, or draining oil.
026_031914
Good sanitation practice demands that all food preparation equipment be cleaned regularly (only
use non-toxic, food grade cleaners). A clean looking, well-kept machine is one of the best ways of
advertising your product.
Follow the directions below to clean and sanitize the unit each day after use.
1. Follow burner shutdown instructions to turn the unit OFF, then allow it to cool before
attempting to clean.
DO NOT move this unit when filled with oil! Allow hot cooking oil to cool below
140°F before attempting drain the unit.
2. Make sure to clean all pans/accessories in order to sanitize them before each use.
3. Make sure the drain valve is securely closed and the drain plug is fully tightened into
place, then fill the tank with water to the MINIMUM oil level. DO NOT FILL above the
minimum oil level or equipment damage may occur.
4. Add appropriate amount of dish soap. [To deep clean a tank which has a build-up of
cooking oil, instead of soap, add appropriate amount of Gold Medal’s Heat’n Kleen
(Item No. 2095) per amount of water used (see Heat’n Kleen product instructions)].
5. Bring solution to a boil (DO NOT heat above 250°F), then turn unit OFF, and allow
solution to cool to below 100°F.
6. Once cooled, drain and remove all solution.
7. Clean the outside of the unit with a soft cloth, dampened with soap and hot water.
8. Wipe the stainless steel parts with a clean cloth and cleaner designed for stainless
steel, such as Gold Medal Watchdog Stainless Cleaner (Item No. 2088).
DO NOT use oven cleaners or abrasive materials as they will damage parts of the
machine.
9. Thoroughly dry the unit after cleaning, including inside any drain valves.
Page 16
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Troubleshooting
Issue
Possible Cause
Solution
A. For gas issues refer to the initial Gas Setup
Instructions.
Gas Issues
Cooking Issues
A. Product cooking issues
A. Reference the Important Operating
Information and Quality Control Tips located
in the Operating the Fryer section of this
manual.
High Limit Control
Tripping (powers down
machine)
A. Oil level too low
A. Check that the oil level has not fallen below
the minimum oil level. DO NOT operate this
unit with the oil below the minimum oil level
(see Filling the Tank with Oil section).
B. Oil too hot
B. Allow oil to cool down to normal operating
temperatures, then reference the burner
Lighting and Shutdown Instructions in the
Operating Instruction section of this manual.)
If the High Limit is still tripping call a qualified
service person for inspection/repair.
A. Qualified Service Personnel reference the
Wiring Diagram section of this manual.
Thermocouple Issues,
Lighting Issues
Page 17
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
MAINTENANCE INSTRUCTIONS
DANGER
Improper installation, adjustment, alteration, service, or maintenance can
cause property damage, injury, or death. Any alterations to this equipment
will void the warranty and may cause a dangerous condition. This appliance
is not intended to be operated by means of an external timer or separate
remote-control system. NEVER make alterations to this equipment. Read the
Installation, Operating, and Maintenance Instructions thoroughly before
installing, servicing, or operating this equipment.
014_020416
WARNING
Hot surface and hot oil inside unit. DO NOT touch! Always allow unit to cool
before cleaning, servicing, or draining oil.
026_031914
WARNING
No user serviceable parts inside. Refer servicing to qualified service
personnel.
011_051514
CAUTION
THE FOLLOWING SECTIONS OF THIS MANUAL ARE INTENDED ONLY
FOR QUALIFIED SERVICE PERSONNEL WHO ARE FAMILIAR WITH GAS
EQUIPMENT. THESE ARE NOT INTENDED FOR THE OPERATOR.
027b_051514
Page 18
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
ORDERING SPARE PARTS
1. Identify the needed part by checking it against the photos, illustrations, and/or
parts list. (General images may be used in manual for reference only.)
2. Use only approved replacement parts when servicing this unit.
3. When ordering, please include part number, part name, and quantity needed.
4. Please include your model number, serial number, and date of manufacture (located
on the machine nameplate/data plate) with your order.
5. Address all parts orders to:
Parts Department
Gold Medal Products Co.
10700 Medallion Drive
Cincinnati, Ohio 45241-4807
Or, place orders by phone or online:
Phone: (800) 543-0862
(513) 769-7676
Fax:
(800) 542-1496
(513) 769-8500
E-mail: info@gmpopcorn.com
Web Page: gmpopcorn.com
Page 19
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Cabinet Exterior
1
2
3
4
5
Item
1
3
3
4
5
Part Description
SKEWER CLIP ASSY
BALL KNOB
GLASS INSPECTION COVER
LEVELERS CASE
THERMOSTAT KNOB
Page 20
Part No.
8065NSD
89837
89146
89662
45047
89005
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Gas Line Assembly
1
2
5
Item
1
2
3
4
5
6
7
8
9
10
11
6
4
3
7
8
Part Description
THERMOSTAT KNOB
THERMOSTAT
HI LIMIT CONTROL
WIRE ASSEMBLY
3/8 IN NPT PIPE PLUG
IGNITER
IGNITER BRACKET
COMBINATION CONTROL
IGNITER WIRE
1/4 IN O.D. ALUMINUM TUBING
ADAPTER, GAS LINE 3/8 NPT (Flare Pipe
Fitting, use with Gas Hose P/N 109000)
Page 21
9
10
11
Part No.
8065NSD
89005
88844
89615
89767
89770
88854
88853
88843
88855
27010-20
74595
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Gas Line Assembly (continued)
1
2
3
Item
1
2
3
4
5
6
7
8
4
5
6
Part Description
DRAIN VALVE
DRAIN PLUG ASSEMBLY
3/4 X 90 DEGREE STREET ELBOW
3/8 BLK IRON ELBOW 90
3/8" BLK PIPE 6 1/4"
THERMOPILE
3/8 NPT UNION
T-FITTING
Page 22
7
8
Part No.
8065NSD
89014
89440
89416
62510
63242
88845
89759
89764
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Burner Assembly
1
2
3
Item
1
2
3
4
Part Description
S-85 BURNER
3/8 BLK IRON ELBOW 90
PILOT ORIFICE
PILOT BURNER
Page 23
4
Part No.
8065NSD
88836
62510
74050
74028
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Accessories
1
3
2
4
Item
1
2
3
4
Part Description
TANK REGULATOR
GAS HOSE (has a Flared Hose Fitting)
FINE MESH SKIMMER
DIAL TYPE THERMOMETER
Page 24
Part No.
8065NSD
89920
109000
8055
4300
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
Wiring Diagram
Model No. 8065NSD
Page 25
gmpopcorn.com
Gas Fryer
Foot Long Dogs
Model No. 8065NSD
WARRANTY
WARRANTY
Gold Medal Products Co. warrants to the original purchaser each item of its manufacture to
be free of defects in workmanship and material under normal use and service. Gold Medal
Products Co.’s obligation under this warranty is limited solely to repairing or replacing parts,
f.o.b. Cincinnati, Ohio, which in its judgment are defective in workmanship or material and
which are returned, freight prepaid, to its Cincinnati, Ohio factory or other designated point.
Except for “Perishable Parts” on specific machines, the above warranty applies for a period
of two (2) years from the date of original sale to the original purchaser of equipment when
recommended operating instructions and maintenance procedures have been followed. These
are packed with the machine. Parts warranty is two (2) years, labor is six (6) months.
THIS WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES EXPRESSED OR
IMPLIED, AND OF ALL OTHER OBLIGATIONS OR LIABILITIES ON OUR PART,
INCLUDING THE IMPLIED WARRANTY OF MERCHANTABILITY. THERE ARE
NO WARRANTIES WHICH EXTEND BEYOND THE DESCRIPTION ON THE FACE
HEREOF. In no event shall Gold Medal Products Co. be liable for special, incidental or
consequential damages. No claim under this warranty will be honored if the equipment covered
has been misused, neglected, damaged in transit, or has been tampered with or changed in any
way. No claim under this warranty shall be honored in the event that components in the unit at
the time of the claim were not supplied or approved by Gold Medal Products Co. This warranty
is effective only when electrical items have been properly attached to city utility lines only at
proper voltages. This warranty is not transferable without the written consent of Gold Medal
Products Co.
The term “Original Purchaser” as used in this warranty shall be deemed to mean that person,
firm, association, or corporation who was billed by the GOLD MEDAL PRODUCTS CO.,
or their authorized distributor for the equipment.
THIS WARRANTY HAS NO EFFECT AND IS VOID UNLESS THE ORIGINAL
PURCHASER FIRST CALLS GOLD MEDAL PRODUCTS CO. AT 1-800-543-0862 TO
DISCUSS WITH OUR SERVICE REPRESENTATIVE THE EQUIPMENT PROBLEM,
AND, IF NECESSARY, FOR INSTRUCTIONS CONCERNING THE REPAIR OR
REPLACEMENT OF PARTS.
NOTE: This equipment is manufactured and sold for commercial use only.
10700 Medallion Drive, Cincinnati, Ohio 45241-4807 USA
gmpopcorn.com
Phone: (800) 543-0862
(513) 769-7676
Fax: (800) 542-1496
(513) 769-8500
© 2017 – The text, descriptions, graphics, layout, and other material in this publication are the exclusive property of
Gold Medal Products Co. and shall not be used, copied, reproduced, or published in any fashion, including website
display, without its express written consent.
Page 26
gmpopcorn.com
Download PDF
Similar pages