http://www.xiaoyu163.com
XR-4740RDS/C430RDS/C440RDS
QQ 376315150 892498299
SERVICE MANUAL
AEP Model
UK Model
Ver 1.1 2001.06
TEL
TEL
For RM-X2S (Remote Commander),
please refer to RM-X2S/X3S Service
Manual (9-960-039-∏) previously issued.
(XR-C440RDS ONLY)
Model Name Using Similar Mechanism
Tape Transport Mechanism Type
NEW
MG-25B-136
Cassette player section
Tape track
4-track 2-channel stereo
Wow and flutter
0.08% (WRMS)
Frequency response
30 – 18,000 Hz
Signal-to-noise ratio
Power amplifier section
Outputs
Speaker outputs
(sure seal connectors)
Speaker impedance
4 – 8 ohms
Maximum power output 35 W × 4 (at 4 ohms)
Tuner section
FM
Tuning range
Antenna terminal
Intermediate frequency
Usable sensitivity
Selectivity
Signal-to-noise ratio
General
Outputs
(XR-C430RDS/C440RDS):
Power amplifier control lead
Rear line out (1)
Tone controls
Bass ± 8 dB at 100 Hz
Treble ± 8 dB at 10 kHz
Power requirements
12 V DC car battery (negative ground)
Dimensions
Approx. 188 × 58 × 181 mm (w/h/d)
Mounting dimensions
Approx. 182 × 53 × 164 mm (w/h/d)
Mass
Approx. 1.2 kg
Supplied accessories
Parts for installation and connections (1 set)
Front panel case (1)
XR-C440RDS: Rotary commander RM-X2S
87.5 – 108.0 MHz
External antenna connector
10.7 MHz
8 dBf
75 dB at 400 kHz
65 dB (stereo),
70 dB (mono)
Harmonic distortion at 1 kHz
0.5% (stereo),
0.3% (mono)
Separation
35 dB at 1 kHz
Frequency response
30 – 15,000 Hz
Capture ratio
4 dB
Design and specifications are subject to change without notice.
MW/LW
Tuning range
Antenna terminal
Intermediate frequency
Sensitivity
www
9-925-541-12
2001F0500-1
C 2001.6
MW: 531 – 1,602 kHz
LW: 153 – 281 kHz
External antenna connector
10.71 MHz/450 kHz
MW: 30 µV
LM: 50 µV
– Continued on next page –
x ao y u163. co m
FM/MW/LW CASSETTE CAR STEREO
.Sony Corporation
i
e Vehicle Company
Shinagawa Tec Service Manual Production Group
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 3763 1515 0 89 2498 299
TEL 13942296513
QQ
QQ
SPECIFICATIONS
13942296513
13942296513
Photo: XR-C430RDS
http://www.xiaoyu163.com
QQ 376315150 892498299
TABLE OF CONTENTS
1.
SERVICING NOTES
GENERAL
Location of Controls ..........................................................
Setting the Clock ...............................................................
Using the rotary remote .....................................................
Adjusting the sound characteristics ...................................
Muting the sound ...............................................................
Changing the sound and beep tone ....................................
Installation .........................................................................
Connections .......................................................................
3
3
3
4
4
4
5
6
3.
ASSEMBLY OF MECHANISM DECK ............. 11
4.
MECHANICAL ADJUSTMENTS ......................... 14
5.
ELECTRICAL ADJUSTMENTS
13942296513
13942296513
DISASSEMBLY ............................................................ 9
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
TEL
TEL
2.
Flexible Circuit Board Repairing
• Keep the temperature the soldering iron around 270° C during
repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering or
unsoldering.
Tape Deck Section ............................................................. 14
Tuner Section ..................................................................... 15
DIAGRAMS
6-1.
6-2.
6-3.
6-4.
6-5.
Printed Wiring Boards – Main Section – ...........................
Schematic Diagram – Main Section – ...............................
Printed Wiring Board – Key Section – ..............................
Schematic Diagram – Key Section – .................................
IC Pin Description .............................................................
8.
TEL 13942296513
EXPLODED VIEWS ................................................... 37
QQ 3763 1515 0 89 2498 299
ELECTRICAL PARTS LIST .................................... 40
www
.
x iao y u163. co m
–2–
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
7.
23
25
30
32
35
QQ
QQ
6.
http://www.xiaoyu163.com
SECTION 1
GENERAL
This section is extracted
from instruction manual.
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
.
x iao y u163. co m
–3–
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 3763 1515 0 89 2498 299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
.
x iao y u163. co m
–4–
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 3763 1515 0 89 2498 299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
.
x iao y u163. co m
–5–
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 3763 1515 0 89 2498 299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
.
x iao y u163. co m
–6–
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 3763 1515 0 89 2498 299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
.
x iao y u163. co m
–7–
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 3763 1515 0 89 2498 299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
.
x iao y u163. co m
–8–
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 3763 1515 0 89 2498 299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
SECTION 2
DISASSEMBLY
QQ 376315150 892498299
Note: Follow the disassembly procedure in the numerical order given.
FRONT PANEL ASS’Y
TEL
TEL
13942296513
13942296513
1 Push the button
(release).
A
2 Remove the front panel ass’y
to the direction of the arrow A.
COVER ASS’Y
2
1
3 cover ass’y
2
www
.
x iao y u163. co m
–9–
http://www.xiaoyu163.com
1
376315150 892498299
376315150 892498299
QQ 3763 1515 0 89 2498 299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
QQ 376315150 892498299
SUB PANEL, MECHANISM DECK (MG-25B-136)
5 screw
(PTT2.6 × 6)
3 connector
(CN302)
6 mechanism deck
(MG-25B-136)
4 flexible flat cable
(CN301)
TEL
TEL
13942296513
13942296513
2 sub panel
1 three screws
(PTT2.6 × 8)
QQ 3763 1515 0 89 2498 299
4 seven screws
(PTT2.6 × 8)
MAIN BOARD, HEAT SINK
2 two ground point
screws
1 screw
(PTT2.6 × 8)
5 heat sink
3 main board
www
x iao y u163. co m
1 two screws
(PTT2.6 × 8)
.
– 10 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
1 three screws
(PTT2.6 × 8)
http://www.xiaoyu163.com
SECTION 3
ASSEMBLY OF MECHANISM DECK
QQ 376315150 892498299
Note: Follow the assembly procedure in the numerical order given.
HOUSING
5 Fit projection on C part.
7 Hold the hanger by bending the claw.
2 Install the hanger onto
two claws of the housing.
4 Fit claw on B part.
1 Install the catch to the hanger.
hanger
6 Fit projection on D part.
3 Put the housing
under A part.
TEL
TEL
housing
C part
D part
B part
QQ 3763 1515 0 89 2498 299
ARM (SUCTION)
2 Move the arm (suction) in the arrow
direction and fit on projection.
1 Fit the arm (suction) on the shaft.
projection
www
.
x iao y u163. co m
– 11 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
A part
13942296513
13942296513
8 Hold the hanger by
bending the claw.
http://www.xiaoyu163.com
QQ 376315150 892498299
LEVER (LDG-A) / (LDG-B)
shaft A
shaft A shaft B
shaft C
shaft C
TEL
TEL
4 type-E stop ring 2.0
2 Pull the lever in the
arrow direction.
3 Fit the lever (LDG-B) on
shafts A and C and
install it.
4 gear (LDG-FT)
1 tension spring (lever LDG)
gear (LDG-D)
hole
www
x iao y u163. co m
2 Move the lever (LDG-B)
in the arrow direction.
hole
.
lever (LDG-A)
gear (LDG-FB)
3 Align hole in the gear (LDG-D)
with hole in the lever (LDG-A).
– 12 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
5 polyethylene washer
QQ
QQ
QQ 3763 1515 0 89 2498 299
TEL 13942296513
GEAR (LDG-FT)
13942296513
13942296513
1 Fit the lever (LDG-A) on
shafts A – C and install it.
http://www.xiaoyu163.com
QQ 376315150 892498299
GUIDE (C)
2 guide (C)
1 three claws
TEL
TEL
13942296513
13942296513
.
x iao y u163. co m
– 13 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 3763 1515 0 89 2498 299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
QQ 376315150 892498299
SECTION 4
MECHANICAL ADJUSTMENTS
SECTION 5
ELECTRICAL ADJUSTMENTS
1. Clean the following parts with a denatured-alcohol-moistened
swab:
playback head
pinch roller
rubber belt
capstan
idlers
2. Demagnetize the playback head with a head demagnetizer.
3. Do not use a magnetized screwdriver for the adjustments.
4. After the adjustments, apply suitable locking compound to the
parts adjusted.
5. The adjustments should be performed with the power supply
voltage unless otherwise noted.
TEST MODE
This set have the test mode function. In the test mode, FM Auto
Scan/Stop Level and AM (MW) Auto Scan/Stop Level adjustments
can be performed easier than it in ordinary procedure.
• Torque Measurement
Meter Reading
Forward
CQ-102C
30 – 65 g•cm
(0.42 – 0.90 oz•inch)
Forward
Back Tension
CQ-102C
0.5 – 4.5 g•cm
(0.01 – 0.06 oz•inch)
CQ-102RC
30 – 65 g•cm
(0.42 – 0.90 oz•inch)
CA-102RC
0.5 – 4.5 g•cm
(0.01 – 0.06 oz•inch)
CQ-201B
60 – 200 g•cm
(0.83 – 2.78 oz•inch)
Reverse
Reverse
Back Tension
FF, REW
See the adjustment location from on page 17 for the adjustment.
TAPE DECK SECTION
0 dB=0.775 V
Tension Meter
Meter Reading
Forward
CQ-403A
more than 90 g
(more than 3.18 oz)
Reverse
CQ-403R
more than 90 g
(more than 3.18 oz)
QQ 3763 1515 0 89 2498 299
speed checker
or
frequency counter
test tape
WS-48A
(3 kHz, 0 dB)
4Ω
set
–
+
speaker out terminal
Specification: Constant speed
Speed checker
Frequency counter
–1.5 to +2.5%
2,955 to 3,075Hz
Adjustment Location: See page 17.
www
.
x iao y u163. co m
– 14 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
Tape Speed Adjustment
Procedure:
1. Put the set into the FWD PB mode.
• Tape Tension Measurement
Mode
<Release the Test mode>
1. Push the OFF button.
2. Set the “power select” switch (S801) is “original” position.
13942296513
13942296513
Torqu Meter
TEL
TEL
Mode
<Set the Test Mode>
1. Set the “power select” switch (S801) is “A” position.
2. Turn ON the regulated power supply. (All LEDs on the set lights
up, and the clock is displayed.)
Note:Press the OFF button, if the clock is not displayed.
3. Push the preset 4 button.
4. Push the preset 5 button.
5. Press the preset 1 button for more than two seconds.
6. Then the display indicates all lights, the test mode is set.
http://www.xiaoyu163.com
QQ 376315150 892498299
TUNER SECTION
0dB=1µV
Cautions during repair
When the tuner unit is defective, replace it by a new one because
its internal block is difficult to repair.
Carrier frequency
Output level
Mode
Modulation
4Ω
+
–
: 98.00 MHz
: 70 dB (3.2 mV) Speaker out terminal
: stereo
: main: 1 kHz, 20 kHz deviation (22.6%)
sub: 1 kHz, 20 kHz deviation (22.6%)
19 kHz pilot: 7.5 kHz deviation (10%)
TEL
TEL
Procedure:
antenna jack (J1)
0.01µF
set
: 98.00 MHz
: 22 dB (12.6 µV)
: mono
: 1 kHz, 22.5 kHz deviation (30%)
Level meter
connection
Level meter
reading (dB)
L-CH
L-CH
A
R-CH
L-CH
B
Adjust RV4 on TU1
for minimum reading.
R-CH
R-CH
C
L-CH
R-CH
D
Adjust RV4 on TU1
for minimum reading.
L-CH Stereo separation: A-B
R-CH Stereo separation: C-D
The separations of both channels should be equal.
Display
Specification: Separation more than 30 dB
REG
INTRO
3. Adjust with the volume RV2 on TU1 so that the “FM” indication turns to “FM0” indication on the display window.
But, in case of already indicated “FM0”, turn the RV2 so that
put out light “0” indication and adjustment.
Display
Adjustment Location: See page 17.
FM Noise Focus Adjustment
Setting:
SOURCE button: FM
FM RF signal
generator
0.01µF
REG
level meter
antenna jack (J1)
4Ω
set
INTRO
Adjustment Location: See page 17.
www
Carrier frequency
Output level
Mode
Modulation
+
–
: 98.00 MHz
speaker out terminal
: 60 dB (1 mV)
: mono
: 1 kHz, 75 kHz deviation (100%)
Procedure:
1. Tune the 98.00 MHz.
2. The then output level is supposing that (B) dB.
3. Adjust with the volume RV3 on TU1 so that the output level is
(B) –32 dB then signal generator input set to –20 dB.
x iao y u163. co m
Adjustment Location: See page 17.
.
– 15 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 3763 1515 0 89 2498 299
QQ
QQ
Procedure:
1. Set to the test mode. (See page 14).
2. Push the SOURCE button and set to FM.
FM Stereo
signal generator
output channel
13942296513
13942296513
FM RF signal
generator
FM
level meter
antenna jack (J1)
set
FM Auto Scan/Stop Level Adjustment
Setting:
SOURCE button: FM
TEL 13942296513
FM RF signal
generator
0.01µF
[Note]
Adjust the tuner section in the sequence shown below.
1. FM Auto Scan/Stop Level Adjustment
2. FM Stereo Separation Adjustment
3. FM Noise Focus Adjustment
4. FM signal Meter Adjustment
5. MW Auto Scan/Stop Level Adjustment
Carrier frequency
Output level
Mode
Modulation
FM Stereo Separation Adjustment
Setting:
SOURCE button: FM
http://www.xiaoyu163.com
QQ 376315150 892498299
FM Signal Meter Adjustment
Setting:
SOURCE button: FM
MW Auto Scan/Stop Level Adjustment
Make this adjustment after “FM Auto Scan/Stop Level Adjustment”.
Setting:
SOURCE button: MW
FM RF signal
generator
30 Ω 15 pF
antenna jack (J1)
0.01µF
65 pF
set
Carrier frequency
Output level
Mode
Modulation
: 98.00 MHz
: 35 dB (56.2 µV)
: mono
: no modulation
MW RF signal
generator
MW dummy antenna
(50 Ω)
Display
antenna jack (J1)
13942296513
13942296513
Carrier frequency : 999 kHz
30% amplitude
modulation by
1 kHz signal
Output level
: 33 dB (44.7 µV)
set
REG
INTRO
Procedure:
1. Set to the test mode. (See page 14.)
2. Push the SOURCE button and set to MW.
3. Push the preset 6 button.
4. Adjust RV1 on MAIN BOARD so that the display indication is
“160”.
REG
QQ 3763 1515 0 89 2498 299
3. Adjust with the volume RV1 on TU1 so that the “MW” indication turns to “MW0” indication on the display window.
But, in case of already indicated “MW0”, turn the RV1 so that
put out light “0” indication and adjustment.
Display
Adjustment Location: See page 17.
999
Adjustment Location: See page 17.
www
.
INTRO
x iao y u163. co m
– 16 –
http://www.xiaoyu163.com
INTRO
376315150 892498299
376315150 892498299
Specification: Display indication: 158 to 162
INTRO
999
QQ
QQ
TEL 13942296513
Display
MW
Display
TEL
TEL
Procedure:
1. Set to the test mode. (See page 14.)
2. Push the SOURCE button and set to FM.
http://www.xiaoyu163.com
QQ 376315150 892498299
Adjustment Location:
Tape Speed
Adjustment
– SET UPPER VIEW –
RV2 FM Auto Scan/Stop level Adjustment
RV4 FM Stereo separation Adjustment
.
x iao y u163. co m
– 17 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 3763 1515 0 89 2498 299
QQ
QQ
TEL 13942296513
RV1
FM Signal Meter
Adjustment
13942296513
13942296513
RV3 FM Noise Focus Adjustment
TEL
TEL
TU1
RV1 MW Auto Scan/Stop level Adjustment
http://www.xiaoyu163.com
QQ 376315150 892498299
SECTION 6
DIAGRAMS
• IC Block Diagrams
– MAIN Section –
VCC
AM CP OUT
VT
FM CP OUT
D-GND
AM IN
FM IN
VDD
24 23
22
21 20
19
18
17
16
15 14 13
RIPPLE
FILTER VCC
– +
– +
AM/FM IF
RF
TB2114F (EL)
XTIN
A-GND
IC1
VDD
SEEK/RECP
AMP
AMP
AMP
SEEK/RECP
TEL
TEL
PSC
REF
REFERENCE
COUNTER
OSC IN
OR
X'TAL OSC
SIG
PHASE
COMPARATOR
18BIT
2
MODULAS
PRESCALER
12BIT
PROGRAMABLE
COUNTER
22BIT
18BIT
13942296513
40BIT
SHIFT
RESISTER
20BIT
IF COUNTER
ON/OFF
BUFFER
N
DATA
I/O PORTS
OUT PORTS
8 9
10 11 12
I/O-1
I/O-2
OUT-1
OUT-2
OUT-3
CE
DIN
CK
DOUT
7
SR
OSC OUT
XTOUT
3 4 5 6
TM
FSEL
T7
VCC
ARI
OUAL
RODA
ROCL
T57
TDA7330BD-013TR
POR
IC3
2
20
19
18
17
16
15 14
13
12
11
8th ORDER
SC-BANDPASS
FILTER
2nd ORDER
ANTIALIAS
FILTER
COSTAS
LOOP
PLL
57kHz
+
–
PHASE
DECODER
DIFF
DECODER
CLOCK
RECOVERY
PLL
1.4675kHz
TEST LOGIC
ON/OFF
OSCILLATOR
fx DIVIDER
.
7
8
9
10
OSCIN
6
OSCOUT
CMP
5
T4
VREF
www
4
T3
3
T1
2
FILOUT
1
MPXIN
VCC
x iao y u163. co m
– 18 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 3763 1515 0 89 2498 299
TEL 13942296513
1
QQ
QQ
BUS INTERFACE
GND
13942296513
4BIT
SWALLOW
COUNTER
http://www.xiaoyu163.com
QQ 376315150 892498299
LCOM
LT1
LT2
LT3
LTOUT
LSIN
LS1
LS2
LS3
LSOUT
LC75373ED
LVRIN
IC151
33
32
31 30
29
28 27 26
25 24
23
+
–
+
–
34
35
36
37
38
+
–
22 LFIN
–
+
–
+
LSELO
L4
L3
L2
L1
–
+
–
+
+
–
21 LFOUT
+
–
20 LROUT
19 VREF
VDD 39
–
+
–
+
CONTROL
+
–
–
+
–
+
+
–
+
–
2
3 4
5
6 7 8
RCOM
RT1
RT2
RT3
RTOUT
RSIN
RS1
CE
DI
CL
VSS
14 RROUT
13 RFOUT
12 RFIN
9 10
11
RS2
RS3
1
RVRIN
–
+
18
17
16
15
RSOUT
–
+
TAPEIN2
AUXIN2
DIREF
LINEOUT2
26
25
24
MSSW
GND
28 27
NC
PBOUT2
29
NC
PBEQ2
30
23 22 21
24dB
120µ/70µ
T2
+ –
20 MSMODE
– +
NR BIAS
PBFB2 31
PBRIN2 32
MS
MODE
X1
TAPE/AUX
18 TAPESW
17 INSW
F2
PBREF2 33
TAPE EQ
PBFIN2 34
16 NC
FWD/RVS
VCT 35
PBGND 36
VCT
MS ON/ 15 NC
OFF
DETECT
VCC
+
LPF
19 DRSW
+
–
14 MSOUT
PBFIN1 37
F3
F1
PBREF1 38
13 DGND
X1
PBRIN1 39
PBFB1 40
12 MSTC
+ –
7
8
LINEOUT1
NC
9
10
G2FB
6
NC
4 5
MSLPF
VCC
.
24dB
TAPEIN1
AUXIN1
3
PBOUT1
PBEQ1
x iao y u163. co m
120µ/70µ
2
11 G1FB
– +
www
1
T1
– 19 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
CXA2509AQ-T4
QQ
QQ
QQ 3763 1515 0 89 2498 299
TEL 13942296513
IC351
SHIFT
REGISTER
13942296513
13942296513
40
41
42
43
44
LATCH
TEL
TEL
R1
R2
R3
R4
RSELO
DECODER
http://www.xiaoyu163.com
QQ 376315150 892498299
IC360
MM1322XFBE
GND 1
8 OUT2
7 VS
CONTROL CIRCUIT
IN2 2
VCC 3
IN1 4
6 OUT1
5 GND
TEL
TEL
BA3918-V2
13942296513
REGULATOR
10
AM
11
12
GND
9
FM
8
ANT
AMP
7
COM
6
VCC
5
VDD
NC
MODE2
MODE1
STB
IC701
+
–
2 3 4
+
–
1
QQ 3763 1515 0 89 2498 299
BA8270F-E2
BUS ON 1
BUS ON
SWITCH
RST 2
RESET
SWITCH
BATT 3
BATTERY
SWITCH
CLK 4
VREF 5
DATA 6
GND 7
www
14 VCC
13
12
11
10
RST
BUS ON
CLK IN
BU IN
9 DATA IN
8 DATA OUT
.
x iao y u163. co m
– 20 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
–
+
QQ
QQ
OVER VOLTAGE
PROTECT
+
–
13942296513
IC601
http://www.xiaoyu163.com
QQ 376315150 892498299
• Waveforms
1 IC1 @¢ XI
3 IC501 8 X_IN
752 mVp-p
3.08 Vp-p
138 nsec
124 nsec
4 IC501 !¡ XT_IN
.
QQ 3763 1515 0 89 2498 299
x iao y u163. co m
– 21 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
30.4 µsec
230 nsec
13942296513
13942296513
2.2 Vp-p
2.68 Vp-p
www
TEL
TEL
2 IC3 !º XI
http://www.xiaoyu163.com
Q Q
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
w w w
.
x
i
Q Q
3 7 6 3 1 5 1 5 0
a o y u 1 6 3
http://www.xiaoyu163.com
.
c o
m
8 9 2 4 9 8 2 9 9
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
http://www.xiaoyu163.com
Q
Q
7
3
6
1
3
5
1
5
0
8
2
9
4
9
2
8
9
9
TEL
TEL
13942296513
13942296513
L
1
w
w
3
9
4
.
2
2
x
9
6
5
i
a
1
Q
3
o
y
u
1
Q
3
6
http://www.xiaoyu163.com
3
7
6
.
3
1
c
5
1
o
5
0
m
8
9
2
4
9
8
2
9
9
376315150 892498299
376315150 892498299
w
E
QQ
QQ
T
http://www.xiaoyu163.com
Q
Q
7
3
6
1
3
5
1
5
0
8
2
9
4
9
2
8
9
9
TEL
TEL
13942296513
13942296513
L
1
w
w
3
9
4
.
2
2
x
9
6
5
i
a
1
Q
3
o
y
u
1
Q
3
6
http://www.xiaoyu163.com
3
7
6
.
3
1
c
5
1
o
5
0
m
8
9
2
4
9
8
2
9
9
376315150 892498299
376315150 892498299
w
E
QQ
QQ
T
http://www.xiaoyu163.com
QQ 376315150 892498299
6-5.
IC PIN FUNCTION DESCRIPTION
MAIN BOARD IC501 MN1884820S4G (4740RDS) (MASTER CONTROLLER)
IC501 MN1886426S4H (C430RDS/C440RDS) (MASTER CONTROLLER)
Pin Name
I/O
Function
1
TUNMUT
O
Tuner muting control pin
2
AMPON
O
Power amp power supply control pin
3
ILLON
O
Illumination power supply control pin
At PW SEL on: ACC on: “H”
At PW SEL off: Power on: “H”
4
PW_ON
O
System power supply control pin
5
AMPMUT
O
Power amp muting control pin
6
RCIN1
I
Rotary remote commander input pin (A/D input)
7
VDD
–
Power supply
At muting: “H”
At muting: “L”
X_IN
I
Main system clock input pin (8 MHz)
9
X_OUT
O
Main system clock output pin (8 MHz)
10
GND
–
GND
XT_IN
I
Sub system clock input pin (32 kHz)
12
XT_OUT
O
Sub system clock output pin (32 kHz)
13
EX2
–
Connected to GND
14
RESET
I
Reset input pin
15
RDSCKI
I
RDS clock input pin
16
BU_IN
I
Back up power supply detection pin
17
KEYACK
O
Key acknowledge signal input pin
18
VOLSO
O
Data output pin to electrical volume
19
VOLCKO
O
Clock output pin to electrical volume
20
VOLCE
O
Chip enable output pin to electrical volume
21
TAPEMUT
O
Tape muting control pin. At muting: “H”
22
LMLOD
O
Loading motor control pin (loadig direction)
23
LMEJ
O
Loading motor control pin (eject direction)
24
AMSON
O
At AMS: “L”
25
N_ROUT
O
Forward/reverse control pin
26
AMSIN
I
Tape music with/without detection pin
27
PLLSO
O
PLL data output pin
28
PLLCKO
O
PLL clock output pin
29
PLLCE
O
PLL chip enable output pin
30
RDSSI
I
RDS data input pin
31
AD_ON
O
Power supply control pin for A/D conversion
32
DOLON
I/O
DOLBY control input/output pin (Fixed at “H” in this set)
At initial mode: valid/invalid selection input of DOLBY function
At normal mode: DOLBY on/off output
33
MTLON
I/O
METAL control input/output pin (Fixed at “H” in this set)
At initial mode: valid/invalid selection input of METAL function
At normal mode: METAL on/off output “H” : on
www
34
CMON
35
TAPON
36
ACCON
37
PLLSI
38
BEEP
.
“L”: with music
x iao y u163. co m
O
Capstan motor control pin
O
Tape power supply control pin
I
Accessory voltage detection pin
I
PLL data input pin
O
Beep sound output pin
– 35 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 3763 1515 0 89 2498 299
TEL 13942296513
QQ
QQ
11
13942296513
13942296513
8
TEL
TEL
Pin No.
http://www.xiaoyu163.com
QQ 376315150 892498299
Pin No.
Pin Name
I/O
Function
39
LCDCKO
O
LCD clock output pin
40
LCDSO
O
LCD data output pin
41
LCDINH
O
LCD brank indication control pin
42
LCDCE
O
LCD chip enable output pin
43
UNICKO
O
Clock output pin (for SONY BUS) (C430RDS/C440RDS only)
44
UNICI
I
Clock input pin (for SONY BUS) (C430RDS/C440RDS only)
I
Data input pin (for SONY BUS) (C430RDS/C440RDS only)
TEL
UNISO
O
Data output pin (for SONY BUS) (C430RDS/C440RDS only)
47
VDD
–
Power supply
13942296513
48
AVDD
–
Power supply
49
AVREF+
–
A/D reference voltage input pin
I
Key input pin (A/D input)
50,51 KEYIN1,KEYIN0
13942296513
UNISI
46
I
D-BASS switch input pin (A/D input)
53
KEYSEL
I
Key function setting pin (A/D input)
54
DSTSEL
I
Destination setting pin (A/D input)
55
RCIN0
I
Rotary remote commander input pin (A/D input)
56
VSM1
I
FM/AM multi-pass detection pin
57
VSM0
I
FM/AM signal meter voltage detection pin (A/D input)
58
AVREF-
–
A/D reference voltage input pin (connected to GND in this set)
59
AVSS
–
GND
60
GND
–
GND
61
BUSON
O
BUS ON control signai output pin (for SONY BUS) (C430RDS/C440RDS only)
QQ 3763 1515 0 89 2498 299
62
SYSRST
O
System reset signal output pin (for SONY BUS) (C430RDS/C440RDS only)
63
SEKOUT
O
SEEK control signal output pin
64
TUNON
O
Tuner power supply control pin
65
FM_ON
O
FM power supply control pin
66
MUT
O
System muting control pin At muting : “H”
67
AF_SEK
O
AF seek control signal output pin
68
COLOR
I
Illumination color setting pin
69
NOSESW
I
Front panel removal or attaching detection pin
70
ST IN
I/O
71
SD_IN
I
“L” : amber, “H”: green
Station detection signal input pin
72
REL_T
I
Reel table rotation detection pin
POS3-POS0
I
Tape position detection pin
77
PW_SEL
I
Power select switch input pin
78
TELMUT
I
Telephone muting detection pin
79
TEST
I
Test mode setting pin
I
ILLIN signal detection pin
www
ILLIN
.
Not used (Open)
Stereo detection signal input and forced monaural signal output pin
73-76
80
Not used (Open)
“L”: 20dB audio muting (Fixed at “H” in this set)
x iao y u163. co m
– 36 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
D-BASS
QQ
QQ
52
TEL 13942296513
TEL
45
http://www.xiaoyu163.com
SECTION 7
EXPLODED VIEWS
QQ 376315150 892498299
NOTE:
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• Color Indication of Appearrance Parts
Example:
KNOB, BALANCE (WHITE) . . . (RED)
↑
↑
Parts Color Cabinet's Color
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Hardware (# mark) list and accessories and
packing materials are given in the last of
the electrical parts list.
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
8
(1) CHASSIS SECTION
17
F901
#3
14
TEL
TEL
MG-25B-136
13942296513
13942296513
16
19
10
7
15
9
#2
#2
6
C430RDS/C440RDS
#2
12
3
11
#2
18
2
Front panel ass’y
13
#1
#2
#2
1
Ref. No.
Part No.
Description
1
2
3
4
* 5
3-009-294-01
3-935-003-01
3-932-205-21
X-3367-636-1
3-009-306-01
PANEL, SUB
SPRING, TORSION
DOOR, CASSETTE
LOCK ASSY
SHEET, INSULATING
6
6
6
6
6
A-3309-818-A
A-3309-824-A
A-3309-830-A
A-3309-834-A
A-3309-880-A
MAIN BOARD, COMPLETE (C440RDS: AEP, UK)
MAIN BOARD, COMPLETE (C440RDS: German)
MAIN BOARD, COMPLETE (4740RDS: AEP, UK)
MAIN BOARD, COMPLETE (4740RDS: German)
MAIN BOARD, COMPLETE (C430RDS: AEP, UK)
*
*
*
*
*
www
* 6
7
* 8
.
Remark
Ref. No.
9
* 10
* 11
* 11
12
Part No.
Description
1-777-989-21 CORD (WITH CONNECTOR) (AMP REM)
(C430RDS/C440RDS)
3-009-307-01 BRACKET (IC)
3-009-293-01 HEAT SINK (C430RDS/C440RDS)
3-010-471-01 HEAT SINK (4740RDS)
9-911-840-XX CUSHION (U)
x iao y u163. co m
A-3309-884-A MAIN BOARD, COMPLETE (C430RDS: German)
3-915-923-01 SCREW, GROUND POINT
X-3373-269-1 COVER ASSY (ISO)
Remark
* 13
14
* 15
16
17
3-009-813-01
3-937-650-01
A-3309-740-A
1-782-092-11
1-782-093-11
18
* 19
F901
3-012-859-01 CAP, RUBBER (25)
3-012-105-01 BRACKET (HS)
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) (10A)
– 37 –
http://www.xiaoyu163.com
CHASSIS
PLATE (C), GROUND
POWER BOARD, COMPLETE
CORD (WITH CONNECTOR) (POWER)
CORD (WITH CONNECTOR) (SPEAKER)
376315150 892498299
376315150 892498299
QQ 3763 1515 0 89 2498 299
4
QQ
QQ
TEL 13942296513
5
#2
http://www.xiaoyu163.com
QQ 376315150 892498299
(2) FRONT PANEL SECTION
not supplied
(KEY board)
#5
#5
TEL
TEL
57
55
13942296513
13942296513
56
64
58
63
59
62
61
54
376315150 892498299
60
53
51
Ref. No.
Part No.
Description
51
53
54
55
55
3-010-396-01
3-010-398-01
3-010-395-01
X-3373-671-1
X-3373-672-1
KNOB (D-BASS)
BUTTON (RELEASE)
SPRING (RELEASE)
PANEL SUB ASSY (C440RDS)
PANEL SUB ASSY (C430RDS)
55
56
57
X-3373-673-1 PANEL SUB ASSY (4740RDS)
3-010-383-01 BUTTON (SOURCE)
3-010-384-01 BUTTON (M. O. S) (r. OFF. – = 0.
SEEK AMS. + ) +)
3-010-385-01 BUTTON (S.M.+/–)(–. SEL. +. MUTE. SENS)
58
www
.
Remark
Ref. No.
59
60
60
Part No.
Description
3-010-387-01 BUTTON (PRESET)
(6 . 1. 2. 3. 4. 5. 6. DSPL)
3-010-388-01 BUTTON (P. A. D)
(PTY. AF/TA. –DISC +) (C430RDS/C440RDS)
3-010-389-01 BUTTON (P. A. P)
(PTY. AF/TA. –DISC +) (4740RDS)
x iao y u163. co m
* 61
* 62
* 63
64
LCD901
Remark
3-010-375-01
3-010-393-01
3-010-394-01
3-010-382-01
1-801-587-11
– 38 –
http://www.xiaoyu163.com
SHEET (REFLECTOR)
PLATE (LCD), LIGHT GUIDE
HOLDER (LCD)
PANEL, FRONT BACK
DISPLAY PANEL, LIQUID CRYSTAL
376315150 892498299
QQ 3763 1515 0 89 2498 299
TEL 13942296513
QQ
QQ
LCD901
http://www.xiaoyu163.com
QQ 376315150 892498299
(3) MECHANISM DECK SECTION
(MG-25B-136)
209
210
213
208
A
TEL
TEL
211
HP901
13942296513
13942296513
205
207
212
#6
206
A
M901
214
204
215
#7
202
202
216
217
201
Ref. No.
Part No.
Description
201
202
* 203
* 204
205
A-3291-667-A
3-701-437-21
3-008-883-01
3-008-884-01
3-008-890-01
CLUTCH (FR) ASSY
WASHER
LEVER (LDG-A)
LEVER (LDG-B)
SPRING (LEVER LDG), TENSION
206
207
208
* 209
210
3-933-335-01
3-341-753-11
3-008-861-01
3-008-882-01
3-008-860-01
GEAR (LDG-FT)
WASHER, POLYETHYLENE
HOUSING
ARM (SUCTION)
HANGER
www
.
Remark
Ref. No.
Part No.
Description
211
212
213
214
215
3-008-874-02
3-933-344-01
3-927-100-01
3-364-151-01
A-3291-919-A
CATCHER
GUIDE (C)
SCREW (+PS 2X10), SPECIAL
WASHER
CHASSIS ASSY (A)
216
217
HP901
M901
3-928-675-01
3-936-853-01
1-500-196-21
A-3291-665-A
BELT (52)
FLYWHEEL (F)
HEAD, MAGNETIC (PLAYBACK)
MOTOR ASSY, MAIN (CAPSTAN/REEL)
x iao y u163. co m
– 39 –
http://www.xiaoyu163.com
Remark
376315150 892498299
376315150 892498299
203
QQ
QQ
QQ 3763 1515 0 89 2498 299
TEL 13942296513
http://www.xiaoyu163.com
SECTION 8
ELECTRICAL PARTS LIST
QQ 376315150 892498299
KEY
NOTE:
• Due to standardization, replacements in the
parts list may be different from the parts specified in the diagrams or the components used on
the set.
• SEMICONDUCTORS
In each case, u: µ, for example:
uA. . : µA. .
uPA. . : µPA. .
uPB. . : µPB. .
uPC. . : µPC. .
uPD. . : µPD. .
• -XX and -X mean standardized parts, so they
may have some difference from the original one.
• CAPACITORS
uF: µF
• Abbreviation
G: German
AMB: Amber Illuminaton Type
GRN: Green Illuminaton Type
Description
Remark
Part No.
Description
Remark
KEY BOARD
*********
LSW901 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (OFF)
(C440RDS)
3-010-375-01 SHEET (REFLECTOR)
3-010-393-01 PLATE (LCD), LIGHT GUIDE
3-010-394-01 HOLDER (LCD)
LSW902 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (SOURCE)
(4740RDS: TYPE1, UK, G, TYPE2 (AMB)/C430RDS)
LSW902 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (SOURCE)
(4740RDS: TYPE2 (GRN))
LSW902 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (SOURCE)
(C440RDS)
< CAPACITOR >
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
0.1uF
0.1uF
100PF 5%
TEL 13942296513
50V
50V
50V
50V
< CONNECTOR >
LSW903 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (MODE 9 | ()
(4740RDS: TYPE1, UK, G, TYPE2 (AMB)/C430RDS)
LSW903 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (MODE 9 | ()
(4740RDS: TYPE2 (GRN))
LSW903 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (MODE 9 | ()
(C440RDS)
QQ 3763 1515 0 89 2498 299
CNP901 1-764-423-11 PIN, CONNECTOR 12P
LSW904 1-762-617-11 SWITCH, KEY BOARD (WITH LED)
(SEEK +/AMS ) +) (4740RDS: AMB/C430RDS)
LSW904 1-762-619-11 SWITCH, KEY BOARD (WITH LED)
(SEEK +/AMS ) +) (4740RDS: GRN)
LSW904 1-762-620-11 SWITCH, KEY BOARD (WITH LED)
(SEEK +/AMS ) +) (C440RDS)
< DIODE >
D901
D902
D903
D904
D905
8-719-420-90
8-719-422-64
8-719-422-64
8-719-422-64
8-719-422-64
DIODE
DIODE
DIODE
DIODE
DIODE
MA8051-M
MA8062-M-TX
MA8062-M-TX
MA8062-M-TX
MA8062-M-TX
LSW905 1-762-617-11 SWITCH, KEY BOARD (WITH LED)
(SEEK –/AMS = 0) (4740RDS: AMB/C430RDS)
LSW905 1-762-619-11 SWITCH, KEY BOARD (WITH LED)
(SEEK –/AMS = 0) (4740RDS: GRN)
LSW905 1-762-620-11 SWITCH, KEY BOARD (WITH LED)
(SEEK –/AMS = 0) (C440RDS)
< IC >
IC901
8-759-365-90 IC LC75824W
< JUMPER RESISTOR >
JC901
1-216-295-00 CONDUCTOR, CHIP
LSW906 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (–)
(4740RDS: AMB/C430RDS)
LSW906 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (–)
(4740RDS: GRN)
LSW906 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (–) (C440RDS)
(2012)
< LIQUID CRYSTAL DISPLAY >
LCD901 1-801-587-11 DISPLAY PANEL, LIQUID CRYSTAL
< SWITCH >
www
x iao y u163. co m
LSW901 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (OFF)
(4740RDS: AMB/C430RDS)
LSW901 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (OFF)
(4740RDS: GRN)
.
LSW907 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (SEL)
(4740RDS: AMB/C430RDS)
LSW907 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (SEL)
(4740RDS: GRN)
LSW907 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (SEL)
(C440RDS)
LSW908 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (+)
(4740RDS: AMB/C430RDS)
– 40 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
1-163-033-00
1-165-319-11
1-165-319-11
1-163-251-11
QQ
QQ
C901
C902
C903
C904
Ref. No.
13942296513
13942296513
*
*
*
Part No.
• COILS
uH: µH
TEL
TEL
• RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
• Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when ordering these items.
Ref. No.
When indicating parts by reference
number, please include the board.
http://www.xiaoyu163.com
QQ 376315150 892498299
KEY
Ref. No.
Part No.
Description
Remark
LSW908 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (+)
(4740RDS: GRN)
LSW908 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (+) (C440RDS)
LSW909 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (MUTE)
(4740RDS: AMB/C430RDS)
LSW909 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (MUTE)
(4740RDS: GRN)
LSW909 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (MUTE)
(C440RDS)
LSW924 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (3)
(4740RDS: AMB)
LSW924 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (SHUF 3)
(C430RDS)
LSW924 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (3)
(4740RDS: GRN)
LSW924 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (SHUF 3)
(C440RDS)
LSW925 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (BL.SKIP 6)
(4740RDS: AMB/C430RDS)
LSW925 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (BL.SKIP 6)
(4740RDS: GRN)
LSW925 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (BL.SKIP 6)
(C440RDS)
LSW926 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (ATA 5)
(4740RDS: AMB/C430RDS)
LSW926 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (ATA 5)
(4740RDS: GRN)
.
LSW927 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (4) (C440RDS)
LSW928 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (PTY)
(4740RDS: AMB/C430RDS)
LSW928 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (PTY)
(4740RDS: GRN)
LSW928 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (PTY)
(C440RDS)
LSW929 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (AF/TA)
(4740RDS: AMB/C430RDS)
LSW929 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (AF/TA)
(4740RDS: GRN)
LSW929 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (AF/TA)
(C440RDS)
LSW930 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (PRST +)
(4740RDS: AMB)
LSW930 1-762-617-11 SWITCH, KEY BOARD (WITH LED)
(PRESET +/DISC +) (C430RDS)
LSW930 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (PRST +)
(4740RDS: GRN)
LSW930 1-762-620-11 SWITCH, KEY BOARD (WITH LED)
(PRESET +/DISC +) (C440RDS)
LSW931 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (PRST –)
(4740RDS: AMB)
QQ 3763 1515 0 89 2498 299
LSW923 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (REPEAT 2)
(4740RDS: AMB/C430RDS)
LSW923 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (REPEAT 2)
(4740RDS: GRN)
LSW923 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (REPEAT 2)
(C440RDS)
www
LSW926 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (ATA 5)
(C440RDS)
LSW927 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (4)
(4740RDS: AMB/C430RDS)
LSW927 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (4)
(4740RDS: GRN)
LSW931 1-762-617-11 SWITCH, KEY BOARD (WITH LED)
(PRESET –/DISC –) (C430RDS)
LSW931 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (PRST –)
(4740RDS: GRN)
LSW931 1-762-620-11 SWITCH, KEY BOARD (WITH LED)
(PRESET –/DISC –) (C440RDS)
LSW932 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (DSPL)
(4740RDS: AMB/C430RDS)
LSW932 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (DSPL)
(4740RDS: GRN)
LSW932 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (DSPL)
(C440RDS)
< PILOT LAMP >
PL903
PL904
1-517-633-21 LAMP, PILOT (LCD BACK LIGHT)
1-517-633-21 LAMP, PILOT (LCD BACK LIGHT)
< TRANSISTOR >
Q901
Q902
Q903
Q904
8-729-106-60
8-729-106-60
8-729-900-53
8-729-900-53
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1132-T101-R (C440RDS)
2SB1132-T101-R (C440RDS)
DTC114EKA-T146 (C440RDS)
DTC114EKA-T146 (C440RDS)
x iao y u163. co m
– 41 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
Remark
QQ
QQ
LSW922 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (INTRO 1)
(4740RDS: AMB/C430RDS)
LSW922 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (INTRO 1)
(4740RDS: GRN)
LSW922 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (INTRO 1)
(C440RDS)
Description
13942296513
13942296513
LSW921 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (6)
(4740RDS: AMB/C430RDS)
LSW921 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (6)
(4740RDS: GRN)
LSW921 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (6) (C440RDS)
Part No.
TEL
TEL
LSW910 1-762-617-11 SWITCH, KEY BOARD (WITH LED) (BTM/SENS)
(4740RDS: AMB/C430RDS)
LSW910 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (BTM/SENS)
(4740RDS: GRN)
LSW910 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (BTM/SENS)
(C440RDS)
Ref. No.
http://www.xiaoyu163.com
QQ 376315150 892498299
KEY
Ref. No.
MAIN
Part No.
Description
Remark
Ref. No.
< RESISTOR >
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R906
R907
R908
R909
R910
1-216-053-00
1-216-057-00
1-216-061-00
1-216-065-00
1-216-069-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
2.2K
3.3K
4.7K
6.8K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R921
R922
R923
R924
R925
1-216-045-00
1-216-045-00
1-216-045-00
1-216-049-00
1-216-053-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL GLAZE
METAL CHIP
680
680
680
1K
1.5K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R926
R927
R928
R929
R930
1-216-053-00
1-216-057-00
1-216-061-00
1-216-065-00
1-216-069-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
2.2K
3.3K
4.7K
6.8K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R931
R932
R951
R952
R953
1-216-073-00
1-216-077-00
1-216-041-00
1-216-109-00
1-216-049-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL GLAZE
10K
15K
470
330K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R954
R955
R956
R957
1-216-049-00
1-216-049-00
1-216-049-00
1-216-073-00
METAL GLAZE
METAL GLAZE
METAL GLAZE
METAL CHIP
1K
1K
1K
10K
5%
5%
5%
5%
R958
1-216-065-00 METAL CHIP
4.7K
5%
1/10W
1/10W
1/10W
1/10W
(C440RDS)
1/10W
(C440RDS)
1-216-037-00 METAL CHIP
330
5%
1/10W
(4740RDS: AMB/C430RDS/C440RDS)
R966
1-216-033-00 METAL CHIP
220
5%
1-216-021-00 METAL CHIP
68
5%
1-216-021-00 METAL CHIP
68
5%
R972
1-216-021-00 METAL CHIP
68
5%
R981
R982
R983
1-216-053-00 METAL CHIP
1-216-061-00 METAL CHIP
1-216-069-00 METAL CHIP
1.5K
3.3K
6.8K
5%
5%
5%
R984
R999
1-216-081-00 METAL CHIP
1-216-308-00 METAL CHIP
22K
4.7
5%
R967
R967
R968
TEL
R969
R969
13942296513
R970
R971
QQ
376315150 892498299
TEL 13942296513
R959
R960
R961
R961
1-216-073-00 METAL CHIP
10K
1/10W
(C440RDS)
1-216-065-00 METAL CHIP
4.7K
5%
1/10W
(C440RDS)
1-216-025-00 METAL GLAZE
100
5%
1/10W
(4740RDS: GRN)
1-216-029-00 METAL CHIP
150
5%
1/10W
(4740RDS: AMB/C430RDS/C440RDS)
R971
R963
R963
1-216-025-00 METAL GLAZE
100
1-216-033-00 METAL CHIP
220
R965
1-216-033-00 METAL CHIP
220
1/10W
(C440RDS)
1/10W
1/10W
1/10W
R999
1/10W
1/10W
(4740RDS: GRN)
1-216-295-00 CONDUCTOR, CHIP
(2012)
(4740RDS: AMB/C430RDS)
< SWITCH >
SW951 1-762-937-11 SWITCH, ROTARY (D-BASS)
*************************************************************
*
*
*
*
5%
*
*
*
*
*
A-3309-818-A MAIN BOARD, COMPLETE
(C440RDS: EXCEPT G)
A-3309-824-A MAIN BOARD, COMPLETE (C440RDS: G)
A-3309-834-A MAIN BOARD, COMPLETE (4740RDS: G)
A-3309-830-A MAIN BOARD, COMPLETE
(4740RDS: EXCEPT G)
A-3309-880-A MAIN BOARD, COMPLETE
(C430RDS: EXCEPT G)
A-3309-884-A MAIN BOARD, COMPLETE (C430RDS: G)
*********************
3-009-293-01
3-009-307-01
3-010-471-01
3-012-105-01
7-685-793-09
HEAT SINK (C430RDS/C440RDS)
BRACKET (IC)
HEAT SINK (4740RDS)
BRACKET (HS)
SCREW +PTT 2.6X8 (S)
x iao y u163. co m
R964
.
1/10W
(C440RDS)
1-216-021-00 METAL CHIP
68
5%
1/10W
(4740RDS: GRN)
1-216-029-00 METAL CHIP
150
5%
1/10W
(4740RDS: AMB/C430RDS/C440RDS)
5%
1/10W
(C440RDS)
1-216-033-00 METAL CHIP
220
5%
1/10W
(4740RDS: GRN)
1-216-037-00 METAL CHIP
330
5%
1/10W
(4740RDS: AMB/C430RDS/C440RDS)
www
1/10W
(C440RDS)
1-216-021-00 METAL CHIP
68
5%
1/10W
(4740RDS: GRN)
1-216-029-00 METAL CHIP
150
5%
1/10W
(4740RDS: AMB/C430RDS/C440RDS)
QQ 3763 1515 0 89 2498 299
*
R962
1/10W
(C440RDS)
1-216-021-00 METAL CHIP
68
5%
1/10W
(4740RDS: GRN)
1-216-029-00 METAL CHIP
150
5%
1/10W
(4740RDS: AMB/C430RDS/C440RDS)
5%
1/10W
(C440RDS)
5%
1/10W
(4740RDS: GRN)
– 42 –
http://www.xiaoyu163.com
376315150 892498299
680
680
680
1K
1.5K
R965
QQ
METAL CHIP
METAL CHIP
METAL CHIP
METAL GLAZE
METAL CHIP
Remark
13942296513
1-216-045-00
1-216-045-00
1-216-045-00
1-216-049-00
1-216-053-00
Description
TEL
R901
R902
R903
R904
R905
Part No.
http://www.xiaoyu163.com
QQ 376315150 892498299
MAIN
Ref. No.
Part No.
Description
Remark
< CAPACITOR >
5%
10%
20%
20%
20%
50V
50V
16V
16V
16V
C6
C9
C11
C12
C13
1-164-232-11
1-163-009-11
1-163-251-11
1-107-823-11
1-163-037-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.001uF
100PF
0.47uF
0.022uF
10%
5%
10%
10%
50V
50V
50V
16V
25V
C14
C15
C16
C17
C18
1-164-161-11
1-124-584-00
1-163-809-11
1-124-463-00
1-164-232-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.0022uF 10%
100uF 20%
0.047uF 10%
0.1uF
20%
0.01uF
100V
10V
25V
50V
50V
C19
C20
C21
C22
C23
1-163-251-11
1-163-251-11
1-163-251-11
1-163-077-11
1-126-933-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
100PF
100PF
100PF
0.1uF
100uF
5%
5%
5%
10%
20%
50V
50V
50V
25V
16V
C24
C25
C26
C28
C29
1-163-099-00
1-163-099-00
1-163-133-00
1-126-157-11
1-164-232-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
18PF
18PF
470PF
10uF
0.01uF
5%
5%
5%
20%
50V
50V
50V
16V
50V
C30
C31
C32
C34
C35
1-163-231-11
1-163-229-11
1-126-160-11
1-163-251-11
1-164-232-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
15PF
12PF
1uF
100PF
0.01uF
5%
5%
20%
5%
50V
50V
50V
50V
50V
C36
C101
C102
C103
C111
1-163-251-11
1-163-037-11
1-126-160-11
1-126-160-11
1-126-160-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT
100PF
0.022uF
1uF
1uF
1uF
5%
10%
20%
20%
20%
50V
25V
50V
50V
50V
C112
C113
C114
C115
C116
1-164-182-11
1-126-160-11
1-163-037-11
1-164-492-11
1-164-492-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0033uF 10%
1uF
20%
0.022uF 10%
0.15uF 10%
0.15uF 10%
50V
50V
25V
16V
16V
C118
C119
C120
C121
C122
1-126-157-11
1-126-157-11
1-126-157-11
1-126-157-11
1-163-251-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
10uF
10uF
10uF
10uF
100PF
TEL 13942296513
www
.
C123
1-163-251-11 CERAMIC CHIP
100PF
C124
1-126-096-11 ELECT
C151
1-107-823-11 CERAMIC CHIP
5%
50V
(C430RDS/C440RDS)
10uF
20%
35V
(C430RDS/C440RDS)
0.47uF 10%
16V
C152
C153
C155
C157
C158
1-163-809-11
1-163-037-11
1-124-234-00
1-124-584-00
1-163-031-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
0.047uF
0.022uF
22uF
100uF
0.01uF
10%
10%
20%
20%
25V
25V
16V
10V
50V
C201
C202
C203
C211
C212
1-163-037-11
1-126-160-11
1-126-160-11
1-126-160-11
1-164-182-11
CERAMIC CHIP
ELECT
ELECT
ELECT
CERAMIC CHIP
0.022uF 10%
1uF
20%
1uF
20%
1uF
20%
0.0033uF 10%
25V
50V
50V
50V
50V
C213
C214
C215
C216
C218
1-126-160-11
1-163-037-11
1-164-492-11
1-164-492-11
1-126-157-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
1uF
0.022uF
0.15uF
0.15uF
10uF
50V
25V
16V
16V
16V
C219
C220
C221
C222
1-126-157-11
1-126-157-11
1-126-157-11
1-163-251-11
ELECT
ELECT
ELECT
CERAMIC CHIP
10uF
10uF
10uF
100PF
C223
1-163-251-11 CERAMIC CHIP
C224
1-126-096-11 ELECT
C301
C302
C303
C304
1-163-009-11
1-163-263-11
1-163-263-11
1-164-232-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
20%
35V
(C430RDS/C440RDS)
0.001uF 10%
50V
330PF 5%
50V
330PF 5%
50V
0.01uF
50V
C305
C308
C309
C310
C350
1-164-489-11
1-126-160-11
1-163-009-11
1-164-161-11
1-124-234-00
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.22uF 10%
1uF
20%
0.001uF 10%
0.0022uF 10%
22uF
20%
16V
50V
50V
100V
16V
C351
C353
C354
C356
C357
1-163-251-11
1-124-465-00
1-164-232-11
1-164-004-11
1-124-584-00
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
100PF
0.47uF
0.01uF
0.1uF
100uF
10%
20%
50V
50V
50V
25V
10V
C362
C363
C365
C366
1-165-319-11
1-165-319-11
1-126-157-11
1-126-157-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.1uF
0.1uF
10uF
10uF
20%
20%
50V
50V
16V
16V
20%
10%
10%
10%
20%
20%
16V
20%
16V
20%
16V
5%
50V
(C430RDS/C440RDS)
100PF 5%
50V
(C430RDS/C440RDS)
QQ 3763 1515 0 89 2498 299
20%
16V
20%
16V
20%
16V
20%
16V
5%
50V
(C430RDS/C440RDS)
x iao y u163. co m
– 43 –
http://www.xiaoyu163.com
10uF
5%
20%
376315150 892498299
376315150 892498299
22PF
0.001uF
10uF
10uF
10uF
Remark
QQ
QQ
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT
Description
13942296513
13942296513
1-163-235-11
1-163-009-11
1-126-157-11
1-126-157-11
1-126-157-11
Part No.
TEL
TEL
C1
C2
C3
C4
C5
Ref. No.
http://www.xiaoyu163.com
QQ 376315150 892498299
MAIN
Ref. No.
Part No.
Description
Remark
16V
C401
C402
C403
C404
C405
1-163-009-11
1-163-263-11
1-163-263-11
1-164-232-11
1-164-489-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
330PF
330PF
0.01uF
0.22uF
10%
5%
5%
50V
50V
50V
50V
16V
C408
C409
C410
C501
C502
1-126-160-11
1-163-009-11
1-164-161-11
1-124-584-00
1-109-982-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
1uF
20%
0.001uF 10%
0.0022uF 10%
100uF 20%
1uF
10%
50V
50V
100V
10V
10V
C503
C504
C505
C506
C507
1-163-099-00
1-163-235-11
1-165-319-11
1-164-232-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
18PF
22PF
0.1uF
0.01uF
0.1uF
5%
5%
50V
50V
50V
50V
25V
C582
C583
C584
C601
C603
1-124-257-00
1-124-589-11
1-163-243-11
1-164-222-11
1-125-710-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CAPACITOR
2.2uF
47uF
47PF
0.22uF
0.1F
20%
20%
5%
C605
C606
C607
C609
C610
1-126-157-11
1-126-157-11
1-126-157-11
1-124-589-11
1-124-234-00
ELECT
ELECT
ELECT
ELECT
ELECT
10uF
10uF
10uF
47uF
22uF
20%
20%
20%
20%
20%
C611
C612
C614
C615
1-163-809-11
1-109-982-11
1-163-251-11
1-163-251-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.047uF
1uF
100PF
100PF
C617
1-126-157-11 ELECT
10uF
C618
C650
C701
1-164-232-11 CERAMIC CHIP
1-126-936-11 ELECT
1-163-009-11 CERAMIC CHIP
0.01uF
3300uF 20%
0.001uF 10%
C701
1-163-037-11 CERAMIC CHIP
C702
1-165-319-11 CERAMIC CHIP
C703
1-163-037-11 CERAMIC CHIP
C704
1-164-004-11 CERAMIC CHIP
10%
< JACK >
CNJ150 1-774-699-12 JACK, PIN 4P (LINE OUT/BUS AUDIO IN)
(C430RDS/C440RDS)
< SPARK GAP CAPACITOR >
CP1
TEL
13942296513
10%
QQ
376315150 892498299
TEL 13942296513
50V
16V
50V
25V
5.5V
16V
16V
16V
16V
16V
10%
25V
10%
10V
5%
50V
5%
50V
(C430RDS/C440RDS)
20%
16V
50V
16V
25V
(4750RDS)
0.002uF 10%
25V
(C430RDS/C440RDS)
0.1uF
50V
(C430RDS/C440RDS)
0.022uF 10%
25V
(C430RDS/C440RDS)
0.1uF
10%
25V
(C430RDS/C440RDS)
< CONNECTOR >
CN351
* CN352
CN602
CN701
1-766-260-11
1-506-995-11
1-764-422-11
1-580-907-31
CONNECTOR, FFC/FPC (ZIF) 7P
PIN, CONNECTOR (PC BOARD) 13P
PLUG, CONNECTOR 12P
PLUG, CONNECTOR 8P (BUS CONTROL IN)
(C430RDS/C440RDS)
www
.
1-517-422-11 GAP, DISCHARGE
< DIODE >
D2
D3
D150
D350
D361
8-719-991-65
8-719-423-07
8-719-057-80
8-719-404-49
8-719-423-07
DIODE
DIODE
DIODE
DIODE
DIODE
SB02W03C-TB
MA8100-L-TX
MA8180-M-TX (C430RDS/C440RDS)
MA111-TX
MA8100-L-TX
D362
D501
D504
D506
D583
8-719-911-19
8-719-422-12
8-719-400-20
8-719-911-19
8-719-404-49
DIODE
DIODE
DIODE
DIODE
DIODE
1SS119-25TD
MA8039-TX
MA152WA-TX
1SS119-25TD
MA111-TX
D584
D601
D605
D606
D607
8-719-422-12
8-719-423-32
8-719-977-03
8-719-017-67
8-719-801-78
DIODE
DIODE
DIODE
DIODE
DIODE
MA8039-TX
MA8120-M-TX
MA8056-M-TX
MA8068-H-TX
MA152WK-TX
D609
D610
D611
D612
D613
8-719-422-64
8-719-422-64
8-719-109-97
8-719-109-97
8-719-034-94
DIODE
DIODE
DIODE
DIODE
DIODE
MA8062-M-TX
MA8062-M-TX
MA4068-M (TA)
MA4068-M(TA)
MA4180-M(TA)
D614
D615
D616
D617
D621
8-719-109-97
8-719-109-97
8-719-422-64
8-719-422-64
8-719-970-02
DIODE
DIODE
DIODE
DIODE
DIODE
MA4068-M(TA)
MA4068-M(TA)
MA8062-M-TX
MA8062-M-TX
1SR139-400T-32
D622
D624
D651
D652
D653
8-719-970-02
8-719-404-49
8-719-018-04
8-719-018-04
8-719-422-76
DIODE
DIODE
DIODE
DIODE
DIODE
1SR139-400T-32 (C430RDS/C440RDS)
MA111-TX
MA8240-TX (C430RDS/C440RDS)
MA8240-TX
MA8075-M-TX
D701
D702
D703
D704
D705
8-719-057-80
8-719-422-80
8-719-422-67
8-719-422-64
8-719-422-64
DIODE
DIODE
DIODE
DIODE
DIODE
MA8180-M-TX
MA8075-H-TX (4740RDS)
MA8062-H-TX (C430RDS/C440RDS)
MA8062-M-TX (C430RDS/C440RDS)
MA8062-M-TX (C430RDS/C440RDS)
D706
8-719-422-64 DIODE MA8062-M-TX (C430RDS/C440RDS)
QQ 3763 1515 0 89 2498 299
< IC >
x iao y u163. co m
IC1
IC3
IC151
8-759-448-88 IC TB2114F(EL)
8-759-163-63 IC TDA7330BD-013TR
8-759-443-67 IC LC75373ED
– 44 –
http://www.xiaoyu163.com
376315150 892498299
20%
Remark
QQ
220uF
Description
13942296513
1-126-934-11 ELECT
Part No.
TEL
C367
Ref. No.
http://www.xiaoyu163.com
QQ 376315150 892498299
MAIN
Ref. No.
Part No.
Description
Remark
IC351
IC360
8-752-079-78 IC CXA2509AQ-T4
8-759-395-97 IC MM1322XFBE
IC501
IC501
IC571
IC571
IC601
8-759-451-03
8-759-451-04
8-759-363-81
8-759-940-45
8-759-347-49
IC701
8-759-449-89 IC BA8270F-E2 (C430RDS/C440RDS)
IC
IC
IC
IC
IC
MN1884820S4G (4740RDS)
MN1886426S4H (C430RDS/C440RDS)
XC61AN4002PR (C430RDS/C440RDS)
S-8054HN-CB-T1 (4740RDS)
BA3918-V2
< JACK >
1-764-808-14 JACK (ANT) (FM/AM ANTENNA)
1-566-822-41 JACK (REMOTE IN)
Part No.
Description
Remark
(3216)
JC57
1-216-296-00 CONDUCTOR, CHIP
JC58
JC59
JC60
JC62
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
(3216)
(C430RDS/C440RDS)
(3216)
(3216)
(3216)
(3216)
JC63
JC65
JC66
JC67
JC68
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
(3216)
(3216)
(3216)
(3216)
(3216)
JC69
1-216-296-00 CONDUCTOR, CHIP
JC70
JC71
JC73
JC74
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
JC75
JC76
JC77
JC78
JC79
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
< JUMPER RESISTOR >
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
(2012)
(2012)
(2012)
(2012)
(2012)
JC11
JC14
JC15
JC16
JC17
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
(2012)
(2012)
(2012)
(2012)
(2012)
JC18
JC20
JC21
JC22
JC23
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
(2012)
(2012)
(2012)
(2012)
(2012)
JC24
JC27
JC28
JC29
JC30
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
(2012)
(2012)
(2012)
(2012)
(2012)
JC31
JC32
JC33
1-216-295-00 CONDUCTOR, CHIP
1-216-295-00 CONDUCTOR, CHIP
1-216-295-00 CONDUCTOR, CHIP
JC34
1-216-295-00 CONDUCTOR, CHIP
JC35
1-216-295-00 CONDUCTOR, CHIP
JC36
JC37
JC38
JC50
JC51
1-216-295-00
1-216-295-00
1-216-295-00
1-216-296-00
1-216-296-00
TEL 13942296513
www
JC52
JC53
JC54
JC55
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
.
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
QQ 3763 1515 0 89 2498 299
(2012)
(2012)
(2012)
(C430RDS/C440RDS)
(2012)
(C430RDS/C440RDS)
(2012)
(C430RDS/C440RDS)
(2012)
(2012)
(2012)
(3216)
(3216)
JC80
JC81
1-216-296-00 CONDUCTOR, CHIP
1-216-296-00 CONDUCTOR, CHIP
(3216)
(3216)
(3216)
(3216)
(3216)
(3216)
< COIL >
L1
L2
L4
L501
1-412-006-31
1-410-509-11
1-410-509-11
1-410-509-11
INDUCTOR, CHIP 10uH
INDUCTOR
10uH
INDUCTOR
10uH
INDUCTOR
10uH
< TRANSISTOR >
Q2
Q101
Q102
Q103
Q201
8-729-120-28
8-729-920-21
8-729-920-21
8-729-920-21
8-729-920-21
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2412K-T-146-QR
DTC314TK-T-146
DTC314TK-T-146
DTC314TK-T-146
DTC314TK-T-146
Q202
Q203
Q361
Q362
Q364
8-729-920-21
8-729-920-21
8-729-015-11
8-729-020-67
8-729-106-60
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC314TK-T-146
DTC314TK-T-146
2SD1802FAST-TL
XN1A312-TX
2SB1132-T101-R
Q365
Q501
Q503
Q581
Q603
8-729-900-53
8-729-020-67
8-729-120-28
8-729-020-67
8-729-423-99
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EKA-T146
XN1A312-TX
2SC2412K-T-146-QR
XN1A312-TX
2SD2137-OP-TA
Q605
8-729-020-67 TRANSISTOR XN1A312-TX
x iao y u163. co m
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
(3216)
(3216)
(3216)
(3216)
(3216)
(C430RDS/C440RDS)
– 45 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
JC5
JC7
JC8
JC9
JC10
(3216)
(C430RDS/C440RDS)
(3216)
(3216)
(3216)
(3216)
QQ
QQ
1-216-296-00 CONDUCTOR, CHIP
13942296513
13942296513
JC56
TEL
TEL
J1
J501
Ref. No.
http://www.xiaoyu163.com
QQ 376315150 892498299
MAIN
Ref. No.
Part No.
Description
Remark
Q606
Q608
Q609
Q610
8-729-027-23
8-729-027-23
8-729-015-11
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Q701
Q702
8-729-900-53 TRANSISTOR DTC114EKA-T146
8-729-020-67 TRANSISTOR XN1A312-TX (4740RDS)
DTA114EKA-T146
DTA114EKA-T146
2SD1802FAST-TL
2SC2412K-T-146-QR
< RESISTOR >
1K
4.7K
10K
100K
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R6
R7
R8
R9
R11
1-216-077-00
1-216-075-00
1-216-025-00
1-216-057-00
1-216-049-00
METAL CHIP
METAL CHIP
METAL GLAZE
METAL CHIP
METAL GLAZE
15K
12K
100
2.2K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R14
R15
R16
R17
R18
1-216-057-00
1-216-073-00
1-216-071-00
1-216-129-00
1-216-049-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL GLAZE
2.2K
10K
8.2K
2.2M
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1-216-073-00
1-216-065-00
1-216-085-00
1-216-061-00
1-216-190-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL GLAZE
10K
4.7K
33K
3.3K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/8W
R105
R108
R109
R110
R111
1-216-190-00
1-216-077-00
1-216-077-00
1-216-077-00
1-216-077-00
METAL GLAZE
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
15K
15K
15K
15K
5%
5%
5%
5%
5%
1/8W
1/10W
1/10W
1/10W
1/10W
R112
R113
R118
1-216-129-00 METAL CHIP
1-216-129-00 METAL CHIP
1-216-061-00 METAL CHIP
2.2M
2.2M
3.3K
R119
1-216-073-00 METAL CHIP
10K
R151
R201
R202
R203
R204
1-216-065-00
1-216-214-00
1-216-085-00
1-216-061-00
1-216-041-00
METAL CHIP
METAL GLAZE
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
33K
3.3K
470
5%
5%
5%
5%
5%
1/10W
1/8W
1/10W
1/10W
1/10W
R205
R208
R209
R210
R211
1-216-041-00
1-216-077-00
1-216-077-00
1-216-077-00
1-216-077-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
15K
15K
15K
15K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
www
.
5%
1/10W
5%
1/10W
5%
1/10W
(C430RDS/C440RDS)
5%
1/10W
(C430RDS/C440RDS)
R212
R213
R218
1-216-129-00 METAL CHIP
1-216-129-00 METAL CHIP
1-216-061-00 METAL CHIP
2.2M
2.2M
3.3K
5%
1/10W
5%
1/10W
5%
1/10W
(C430RDS/C440RDS)
5%
1/10W
(C430RDS/C440RDS)
R219
1-216-073-00 METAL CHIP
10K
R303
R305
R306
R307
R308
1-216-077-00
1-216-109-00
1-216-190-00
1-216-057-00
1-216-073-00
METAL CHIP
METAL CHIP
METAL GLAZE
METAL CHIP
METAL CHIP
15K
330K
470
2.2K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/8W
1/10W
1/10W
R351
R352
R353
R354
R355
1-208-812-11
1-216-105-00
1-216-065-00
1-216-077-00
1-216-009-00
METAL GLAZE
METAL GLAZE
METAL CHIP
METAL CHIP
METAL CHIP
18K
220K
4.7K
15K
22
2%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R361
R362
R363
R364
R365
1-216-049-00
1-249-389-11
1-249-389-11
1-216-073-00
1-216-065-00
METAL GLAZE
CARBON
CARBON
METAL CHIP
METAL CHIP
1K
4.7
4.7
10K
4.7K
5%
5%
5%
5%
5%
1/10W
1/4W
1/4W
1/10W
1/10W
R403
R405
R406
R407
R408
1-216-077-00
1-216-109-00
1-216-190-00
1-216-057-00
1-216-073-00
METAL CHIP
METAL CHIP
METAL GLAZE
METAL CHIP
METAL CHIP
15K
330K
470
2.2K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/8W
1/10W
1/10W
R501
R505
R506
R507
R508
1-216-097-00
1-216-049-00
1-216-109-00
1-216-198-00
1-216-206-00
METAL GLAZE
METAL GLAZE
METAL CHIP
METAL GLAZE
METAL GLAZE
100K
1K
330K
1K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/8W
1/8W
R509
R510
R511
R512
R513
1-216-198-00
1-216-097-00
1-216-097-00
1-216-097-00
1-216-097-00
METAL GLAZE
METAL GLAZE
METAL GLAZE
METAL GLAZE
METAL GLAZE
1K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/8W
1/10W
1/10W
1/10W
1/10W
R514
R515
R516
R517
R518
1-216-198-00
1-216-198-00
1-216-198-00
1-216-198-00
1-216-246-00
METAL GLAZE
METAL GLAZE
METAL GLAZE
METAL GLAZE
METAL GLAZE
1K
1K
1K
1K
100K
5%
5%
5%
5%
5%
1/8W
1/8W
1/8W
1/8W
1/8W
R521
R522
R523
R524
R525
1-216-246-00
1-216-097-00
1-216-097-00
1-216-097-00
1-216-097-00
METAL GLAZE
METAL GLAZE
METAL GLAZE
METAL GLAZE
METAL GLAZE
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/8W
1/10W
1/10W
1/10W
1/10W
R526
R528
R531
1-216-097-00 METAL GLAZE
1-216-097-00 METAL GLAZE
1-216-246-00 METAL GLAZE
100K
100K
100K
5%
5%
5%
1/10W
1/10W
1/8W
QQ 3763 1515 0 89 2498 299
x iao y u163. co m
– 46 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
R19
R101
R102
R103
R104
Remark
QQ
QQ
METAL GLAZE
METAL CHIP
METAL CHIP
METAL GLAZE
METAL CHIP
Description
13942296513
13942296513
1-216-049-00
1-216-065-00
1-216-073-00
1-216-097-00
1-017-013-00
Part No.
TEL
TEL
R1
R2
R3
R4
R5
Ref. No.
http://www.xiaoyu163.com
QQ 376315150 892498299
MAIN
Ref. No.
R534
R535
Part No.
Description
1-216-246-00 METAL GLAZE
1-208-518-41 METAL GLAZE
100K
22K
5%
2%
Ref. No.
1/8W
1/10W
(C430RDS)
R615
1-208-806-11 METAL GLAZE
R616
R617
R618
R619
R620
1-216-295-00
1-216-025-00
1-208-806-11
1-208-806-11
1-216-025-00
R624
R625
R626
R627
R701
1-249-383-11
1-249-383-11
1-249-383-11
1-249-383-11
1-216-073-00
R702
22K
R535
1-216-097-00 METAL GLAZE
100K
R536
1-208-575-51 METAL GLAZE
100K
R537
R538
1-216-097-00 METAL GLAZE
1-216-246-00 METAL GLAZE
100K
100K
5%
5%
1/10W (G)
1/8W
(AEP, UK)
R539
R540
R544
R545
R546
1-208-806-11
1-216-097-00
1-216-049-00
1-216-097-00
1-216-097-00
METAL GLAZE
METAL GLAZE
METAL GLAZE
METAL GLAZE
METAL GLAZE
10K
100K
1K
100K
100K
0.50%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R548
R549
R551
R562
R570
1-216-222-00
1-216-222-00
1-249-429-11
1-216-097-00
1-216-097-00
METAL GLAZE
METAL GLAZE
CARBON
METAL GLAZE
METAL GLAZE
10K
10K
10K
100K
100K
5%
5%
5%
5%
5%
1/8W
1/8W
1/4W
1/10W
1/10W
(4740RDS)
1/10W
(4740RDS)
5%
1/10W
(C440RDS)
2%
1/8W
(4740RDS/C430RDS)
R571
1-216-097-00 METAL GLAZE
100K
5%
R572
1-216-246-00 METAL GLAZE
100K
5%
R573
1-216-097-00 METAL GLAZE
100K
5%
10K
0.5%
1/10W
CONDUCTOR, CHIP
METAL GLAZE
100
METAL GLAZE
10K
METAL GLAZE
10K
METAL GLAZE
100
(2012)
5%
0.5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
CARBON
CARBON
CARBON
CARBON
METAL CHIP
1.5
1.5
1.5
1.5
10K
5%
5%
5%
5%
5%
1-216-113-00 METAL CHIP
470K
5%
R704
1-216-246-00 METAL GLAZE
100K
R705
1-216-073-00 METAL CHIP
10K
R706
1-216-025-00 METAL GLAZE
100
R707
1-216-174-00 METAL GLAZE
100
R708
1-216-017-00 METAL GLAZE
47
1/6W
1/6W
1/6W
1/6W
1/10W
(4740RDS)
1/10W
(4740RDS)
5%
1/8W
(C430RDS/C440RDS)
5%
1/10W
(C430RDS/C440RDS)
5%
1/10W
(C430RDS/C440RDS)
5%
1/8W
(C430RDS/C440RDS)
5%
1/10W
(C430RDS/C440RDS)
QQ 3763 1515 0 89 2498 299
1/10W
(4740RDS)
1/8W
(4740RDS)
1/10W
(4740RDS)
R574
1-216-097-00 METAL GLAZE
100K
5%
R582
R583
R584
1-216-198-00 METAL GLAZE
1-216-166-00 METAL GLAZE
1-216-238-00 METAL GLAZE
1K
47
47K
5%
5%
5%
R585
R599
R601
R602
R603
1-216-097-00
1-216-295-00
1-216-057-00
1-216-097-00
1-216-089-00
METAL GLAZE
100K
CONDUCTOR, CHIP
METAL CHIP
2.2K
METAL GLAZE
100K
METAL GLAZE
47K
5%
(2012)
5%
5%
5%
1/10W
R604
R606
R607
R608
R609
1-216-089-00
1-216-206-00
1-216-073-00
1-216-097-00
1-216-037-00
METAL GLAZE
METAL GLAZE
METAL CHIP
METAL GLAZE
METAL CHIP
47K
2.2K
10K
100K
330
5%
5%
5%
5%
5%
1/10W
1/8W
1/10W
1/10W
1/10W
R610
R612
R613
R614
1-216-073-00
1-216-025-00
1-216-025-00
1-208-806-11
METAL CHIP
METAL GLAZE
METAL GLAZE
METAL GLAZE
10K
100
100
10K
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
< VARIABLE RESISTOR >
RV1
< SWITCH >
S601
1/10W
(4740RDS)
1/8W
1/8W
1/8W
1/10W
1/10W
1/10W
1-241-768-11 RES, ADJ, CARBON 220K
1-692-431-21 SWITCH, TACTILE (RESET)
< TUNER UNIT >
TU1
1-693-373-11 TUNER UNIT
< VIBRATOR >
X1
1-567-848-11 VIBRATOR, CRYSTAL (7.2MHz)
X2
1-579-242-41 VIBRATOR, CRYSTAL (4.332MHz)
X501
1-579-125-11 VIBRATOR, CERAMIC (8MHz)
X502
1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)
************************************************************
A-3309-740-A POWER BOARD, COMPLETE
**********************
*
< CAPACITOR >
www
.
C801
C802
C803
1-126-157-11 ELECT
1-126-157-11 ELECT
1-126-157-11 ELECT
x iao y u163. co m
– 47 –
http://www.xiaoyu163.com
10uF
10uF
10uF
20%
20%
20%
16V
16V
16V
376315150 892498299
376315150 892498299
TEL 13942296513
2%
Remark
QQ
QQ
1-208-814-11 METAL GLAZE
Description
13942296513
13942296513
R535
Part No.
TEL
TEL
Remark
POWER
http://www.xiaoyu163.com
QQ 376315150 892498299
POWER
Ref. No.
Part No.
Description
Remark
C804
C805
1-124-589-11 ELECT
1-136-165-00 FILM
47uF
0.1uF
20%
5%
16V
50V
C806
C811
C812
C821
C822
1-164-506-11
1-163-009-11
1-163-009-11
1-163-009-11
1-163-009-11
4.7uF
0.001uF
0.001uF
0.001uF
0.001uF
10%
10%
10%
10%
16V
50V
50V
50V
50V
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
Ref. No.
Part No.
Description
Remark
MISCELLANEOUS
**************
9
16
17
F901
HP901
1-777-989-21 CORD (WITH CONNECTOR) (AMP REM)
(C430RDS/C440RDS)
1-782-092-11 CORD (WITH CONNECTOR) (POWER)
1-782-093-11 CORD (WITH CONNECTOR) (SPEAKER)
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) (10A)
1-500-196-21 HEAD, MAGNETIC (PLAYBACK)
< CONNECTOR >
M901
A-3291-665-A MOTOR ASSY, MAIN (CAPSTAN/REEL)
*************************************************************
1-778-985-11 PIN, CONNECTOR (ISO)
1-778-983-11 CONNECTOR 13P
1-778-983-11 CONNECTOR 13P
ACCESSORIES & PACKING MATERIALS
*******************************
< DIODE >
DIODE
DIODE
DIODE
DIODE
DIODE
1N5404TU
1SR139-400
1SR139-400
1SR139-400
1SR139-400
D823
D824
D825
D826
8-719-970-02
8-719-970-02
8-719-970-02
8-719-970-02
DIODE
DIODE
DIODE
DIODE
1SR139-400
1SR139-400
1SR139-400
1SR139-400
< IC >
1-216-296-00 CONDUCTOR, CHIP
(3216)
< COIL >
L801
3-859-486-21 MANUAL, INSTRUCTION INSTALL (FRENCH,
GERMAN, DUTCH, ITALIAN) (C430RDS: AEP, German)
3-859-493-11 MANUAL, INSTRUCTION (ENGLISH, SPANISH,
SWEDISH, PORTUGUESE) (4740RDS: AEP/UK)
3-859-493-21 MANUAL, INSTRUCTION (FRENCH, GERMAN,
DUTCH, ITALIAN) (4740RDS: AEP)
3-859-493-31 MANUAL, INSTRUCTION (GERMAN)
(4740RDS: German)
3-859-494-11 MANUAL, INSTRUCTION INSTALL (ENGLISH,
SPANISH, SWEDISH, PORTUGUESE) (4740RDS: AEP/UK)
1-416-046-11 COIL, CHOKE
< RESISTOR >
R801
R802
R803
R804
R811
1-216-198-00
1-216-198-00
1-216-049-00
1-216-049-00
1-216-296-00
METAL GLAZE
1K
METAL GLAZE
1K
METAL GLAZE
1K
METAL GLAZE
1K
CONDUCTOR, CHIP
5%
5%
5%
5%
(3216)
R812
R813
R814
R821
R822
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
(3216)
(3216)
(3216)
(3216)
(3216)
R823
R824
1-216-296-00 CONDUCTOR, CHIP
1-216-296-00 CONDUCTOR, CHIP
(3216)
(3216)
www
1/8W
1/8W
1/10W
1/10W
**************
HARDWARE LIST
**************
x iao y u163. co m
< SWITCH >
S801
1-571-478-11 SWITCH, SLIDE (POWER SELECT)
************************************************************
.
3-859-494-21 MANUAL, INSTRUCTION INSTALL (FRENCH,
GERMAN, DUTCH, ITALIAN) (4740RDS: AEP, German)
X-3373-412-1 CASE ASSY (for FRONT PANEL)
*************************************************************
#1
#2
#3
7-621-772-10 SCREW +B 2X4
7-685-793-09 SCREW +PTT 2.6X8 (S)
7-685-792-09 SCREW +PTT 2.6X6 (S)
– 48 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
8-759-448-48 IC HA13157
< JUMPER RESISTOR >
JC801
3-859-484-21 MANUAL, INSTRUCTION INSTALL (FRENCH,
GERMAN, DUTCH, ITALIAN) (C440RDS: AEP, German)
3-859-485-11 MANUAL, INSTRUCTION (ENGLISH, SPANISH,
SWEDISH, PORTUGUESE) (C430RDS: AEP/UK)
3-859-485-21 MANUAL, INSTRUCTION (FRENCH, GERMAN,
DUTCH, ITALIAN) (C430RDS: AEP)
3-859-485-31 MANUAL, INSTRUCTION (GERMAN)
(C430RDS: German)
3-859-486-11 MANUAL, INSTRUCTION INSTALL (ENGLISH,
SPANISH, SWEDISH, PORTUGUESE) (C430RDS: AEP/UK)
QQ 3763 1515 0 89 2498 299
TEL 13942296513
IC801
1-473-067-31 REMOTE COMMANDER (RM-X2S) (C440RDS)
3-859-483-11 MANUAL, INSTRUCTION (ENGLISH, SPANISH,
SWEDISH, PORTUGUESE) (C440RDS: AEP/UK)
3-859-483-21 MANUAL, INSTRUCTION (FRENCH, GERMAN,
DUTCH, ITALIAN) (C440RDS: AEP)
3-859-483-31 MANUAL, INSTRUCTION (GERMAN)
(C440RDS: German)
3-859-484-11 MANUAL, INSTRUCTION INSTALL (ENGLISH,
SPANISH, SWEDISH, PORTUGUESE) (C440RDS: AEP/UK)
QQ
QQ
8-719-049-38
8-719-970-02
8-719-970-02
8-719-970-02
8-719-970-02
13942296513
13942296513
D801
D813
D814
D815
D816
TEL
TEL
CN801
CN802
CN803
http://www.xiaoyu163.com
QQ 376315150 892498299
Ref. No.
#5
#6
Part No.
Description
Remark
7-685-106-19 SCREW +P 2X10 TYPE2 NON-SLIT
7-624-104-04 STOP RING 2.0, TYPE -E
#7
7-627-553-17 PRECISION SCREW +P 2X2 TYPE 3
************************************************************
PARTS FOR INSTALLATION AND CONNECTIONS
**************************************
FRAME ASSY
SCREW ASSY (AE.KEY), FITTING
SCREW, FITTING
BUSHING
KEY
506
507
508
509
1-777-989-21 CORD (WITH CONNECTOR) (AMP REM)
(C430RDS/C440RDS)
1-782-093-11 CORD (WITH CONNECTOR) (SPEAKER)
1-782-092-11 CORD (WITH CONNECTOR) (POWER)
1-775-543-11 CORD, GROUND (C430RDS/C440RDS)
510
511
X-3369-817-1 BRACKET ASSY (C440RDS)
1-465-459-21 ADAPTER, ANTENNA
501
502
504
(C430RDS/C440RDS)
506
www
(C430RDS/C440RDS)
507
510
508
(C440RDS)
.
QQ 3763 1515 0 89 2498 299
509
511
x iao y u163. co m
– 49 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
505
QQ
QQ
503
13942296513
13942296513
3-916-161-31
X-3370-077-1
3-386-828-01
3-349-410-01
3-388-078-01
TEL
TEL
501
502
503
504
505
http://www.xiaoyu163.com
QQ 376315150 892498299
MEMO
TEL
TEL
13942296513
13942296513
.
x iao y u163. co m
– 50 –
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 3763 1515 0 89 2498 299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
XR-4740RDS/C430RDS/C440RDS
QQ 376315150 892498299
AEP Model
UK Model
SERVICE MANUAL
Ver 1.1 2001.06
File this supplement with the service manual.
(SPM-01012)
In this set, following board has been changed in the midway of production.
NEW/FORMER TYPE DISCRIMINATION
– MAIN Board (Component Side) –
www
.
QQ 376315150 892498299
xiaoy u163. com
Former Type : 1-663-959-11 to -13
New Type : 1-663-959-14
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
1.
13942296513
13942296513
Subject: MAIN Board Modification
TEL
TEL
SUPPLEMENT-1
http://www.xiaoyu163.com
XR-4740RDS/C430RDS/C440RDS
QQ 376315150 892498299
2.
DIAGRAMS
2-1.
NOTE FOR PRINTED WIRING BOARD AND SCHEMATIC DIAGRAMS
Note on Printed Wiring Board:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
f
: internal component.
•
•
: Pattern of the rear side.
2
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
xiaoy u163. com
QQ
QQ
.
13942296513
13942296513
www
QQ 376315150 892498299
TEL
TEL
TEL 13942296513
Note on Schematic Diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
f
•
: internal component.
• C : panel designation.
• A : B+ Line.
• Power voltage is dc 14.4V and fed with regulated dc power
supply from ACC and BATT cords.
• Voltages are dc with respect to ground under no-signal
(detuned) conditions.
no mark : FM
(
) : MW/LW
〈〈
〉〉 : TAPE PLAYBACK
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F : FM
f : MW/LW
E : TAPE PLAYBACK
L : BUS AUDIO IN
http://www.xiaoyu163.com
XR-4740RDS/C430RDS/C440RDS
2-2.
PRINTED WIRING BOARD – MAIN Board –
QQ 3 7 6 3 1 5 1 5 0
1
2
3
4
5
6
7
8
9
10
11
12
LINE OUT
REAR
L
L
R
R
• Semiconductor
Location
BUS CONTROL IN
(FOR SONY BUS)
(ORIGINAL SERVICE MANUAL Page 24)
TO
POWER BOARD
CN803
J1
FM/AM
ANTENNA
B
8 9 2 4 9 8 2 9 9
15
CN701
CNJ150
BUS AUDIO
IN
14
(C430RDS/C440RDS)
(C430RDS/C440RDS)
A
13
(ORIGINAL SERVICE MANUAL Page 24)
TO
POWER BOARD
CN802
6
5
4
8
7
3
2
1
J501
REMOTE IN
(FRONT VIEW)
MAIN BOARD
C224
JW133
JW132
(4740RDS)
JC28
R112
R110
Q103
JC29
R113
13
R209
R208
Q203
1
C120
R7
CP1
JC31
R205
R204
C12
C11
L2
C121
R1
JW3
13
X1
C430RDS/
C440RDS
C5
C35
34
Q2
C153
JC38
JC10
C152
JW8
R18
C202
JW12
R151
C303
C309
JC16
1
C201
R355
JC17
2
21
20
R305 C305
C301
R101
30
11
31
10
C101
C401
7
6
C356
40
C403
R3
R353
C503
R507
JW38
R506
JW31
1
80
R508
JW40
C701
JW42
C32
C28
IC501
20
21
JC21
R551
C26
R4
RV1
C29
X2
C30
IC3
C501
JW44
40
D611
R517 R516
R614
www
D617
R511
R549
JW51
JW54
D506
JW55
JW57
R512
R363
R361
JC73
R572
R571
JW59
x ia o y u 1 6 3
D504
Q608
C366
R626
R627
A
C603
R616
(ORIGINAL SERVICE MANUAL Page 32)
3
3
http://www.xiaoyu163.com
c o
S601
RESET
.
m
1-663-959-
R608
IC571
JW58
KEY BOARD
CNP901
(CHASSIS)
R625
C601
R515 R514
JW68 JW69
JC37
Q606
JW56
Q605
D361
(4740RDS)
JC71
JW53
D601
JC75
Q364 R364
(German)
JW64
L501
JW52
C365
Q603
R624
R539
JW61 (4740RDS)
R531 R534
JC36
JW65
JC74
R540
R535
JC20
.
JW70
Q362
JW47
R544
IC1
IC3
IC151
IC351
IC360
IC501
IC571
IC601
IC701
F-5
L-6
G-9
J-5
I-14
K-10
M-13
G-14
E-14
Q2
Q3
Q101
Q102
Q103
Q201
Q202
Q203
Q361
Q362
Q364
Q365
Q501
Q503
Q581
Q603
Q605
Q606
Q608
Q609
Q610
Q701
Q702
H-6
G-14
H-7
D-7
D-8
H-7
D-9
D-9
J-13
K-13
L-13
I-13
G-7
L-3
E-10
K-14
L-14
M-11
M-11
F-6
D-10
C-11
C-10
MECHANISM
BLOCK
R362
JW63
JC70
JW46
D610
(CHASSIS)
Q361
R365
(AEP, UK)
R510
R621
CN602
JW75
R570
JW48
R613
R612
R615
D609
JC52
JW45
C31
D616
JW10 JW11
JW76
JW74
JC81
41
JC23
D613 D612
IC360
D362
C505
JC22
JW50
D614
JW77
R537
R548
R16
D615
R524
R518
JW49
M
C363
60
JC53
R17
N
61
R509
L4
JW43
JC51
JW78
R526
JC14
Q503
R522
JW62
R14
L
Q365
JW79
R525
JW202
C507
R610
R405
M901
(CAPSTAN/REEL)
JW39
C351
JW41
JC50 R528
JW80
R523
C504
JW37
C502
C353
R2
JC77
C367
JW81
R546
X501
JW36
R513
C409
K
JW203
JW85 JW84
X502
JC55
R403
JW91
JW35
C402
R406
JW82
JC24
1
C605
JW83
C211
C430RDS/
C440RDS
JW88 JW87 JW86
C308
JW34
R352
IC351 C405
C404
C203
R407
C350
JC15
CN351
C9
JC56
JC18
R308
R354
HP901
PLAYBACK
HEAD
JC40
JW139
JC54
C213
D350
R307
C302
R201
C212
1
D624
R545
JC69
JW32
C357
JW30
JW200
44
Q3
JW95 C606
C214
C103
C310
C151
I
JW93
C157
JW27
JW28
R351
R303
C304
JW97
C215
D4
JW98 C607
R562
R521
C158
C102
R306
JW99
C218
Q201
JC11
JW138
C362
JW9
3 7 6 3 1 5 1 5 0IC601 8 9 2 4 9 8 2 9 9
C216
C408
JW23
R202 R102
JW114
JW94
C219
11
D623
JC76
C6
12
R203
CN352
C3
Q101
JW25
JC9
JW24
H
IC151
33
JC58
JW101 C617
JC65
QQ
C118
C111
C410
JW26
C15
JC8
D2
JW105
R609
C4
JW5
R9
D3
C25
C24
C112
JC59
JC66
22
JW71
R19
R11
23
14
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
C17
JW104
C119
C114
Q501
D501 JW22
JC57
R408
JW136
JW102
QQ
QQ
TEL
C115
JC7
JW135
JC67
JW103
JW21
JW6
C155
JC78
C609
JW110
C116
JC27
C506
JW122
(4740RDS)
JW121
JC63
R103
C16
L1
JW7
JW15
R584
JW89
JC5
JW13 JW14
R501
R5
JW123
R573
D703
JC68
C113
R574
C704
JW90
C21
Q609
JW201
IC1
C20
C23
C430RDS/
C440RDS
R15
C703
JW118
JW119
C610
JW124
JC34 JC35
JW120
JW111
JW73
C1
JW117
C220
R505
JW4
JC32
JW112
R708
R705
C650
JW116
R582
JW18 JW19 JW20
JW16 JW17
R601
C19
F
M
C615 D622
JW107 JW108 JW109
JW106
JC79
JC62
JW60
C18
12
TU1
FM/AM
TUNER UNIT
D605
Q581
C430RDS/
C440RDS
D621
R538
C2
C582
D705
D652
JW113
C221
JC80
R619
C583
C36
R618
JC33
R707
D651
C430RDS/
C440RDS
D584
C14
R704
C614
D583
R8
C13
JW134
J
JC30
R617
D704
1
JW204
E
G
R105
JW128
13
R603 D653
Q610
R104
R607
JW130
Q202
R620
R706
JW125
D706
R583
R6
JW126
C618
H-2
G-5
G-14
D-5
D-3
D-4
I-7
L-12
K-13
G-7
M-10
L-9
E-9
E-9
K-14
F-6
D-10
D-11
M-3
M-3
L-5
L-5
L-5
L-4
L-4
L-4
M-4
E-11
E-12
G-13
H-13
D-11
E-11
D-10
C-11
C-11
E-14
D-13
D-13
D-13
13942296513
13942296513
C34
C612 D606
D607
Q102
JW1
C702
R606
R604
R602
Location
D2
D3
D4
D150
D151
D152
D350
D361
D362
D501
D504
D506
D583
D584
D601
D605
D606
D607
D609
D610
D611
D612
D613
D614
D615
D616
D617
D621
D622
D623
D624
D651
D652
D653
D701
D702
D703
D704
D705
D706
TEL
TEL
D
R212
R210
C430RDS/
C440RDS
D152
D151
R213
D150
R211
JW127
JW129
R109
R108 R111
JW96
CNJ150
R585
C584
JC60
CN701
JW131
IC701
C222
C122
R536
C223
Q701
D702 D701
R701 R702
R219
R218
C123
Q702
JW92
JW999
C
JW72
R118
R119
C124
Ref. No.
http://www.xiaoyu163.com
XR-4740RDS/C430RDS/C440RDS
2-3.
QQ 3 7 6 3 1 5 1 5 0
SCHEMATIC DIAGRAM – MAIN Board (1/3) –
8 9 2 4 9 8 2 9 9
(C430RDS/C440RDS)
TU1
CNJ150
IFC-FM
ST
FM-DET
BUS AUDIO IN
SD
S-METER
LCH-OUT
GND-AF
RCH-OUT
IF-AM
AM-DET
SEEK
IFC-AM
+8V-AM
+8V-TU
+8V-FM
VT
GND-VOC
VOC
LO/ DX
GND-RF
ANT-FM
ANT-AM
FM/AM TUNER UNIT
L
LINE OUT REAR
R
L
R
Z3
R151 C151
4.7k 0.47
C153
0.022
C103
1 50V
R101 C102
4.7k 1 50V
CP1
R18
1k
JC69
0
JC57 C224
0
10 25V
R113
2.2M
C201
0.022
VDD
FM.VCO
AM.VCO
C21 100p
FM/AM PLL
D.GND
SR
R15 10k
PLL1
DATA
OUT
CLK
AM.CPOUT
VT
C36
100p
PLL2
JC21 0 PLL3
VCC
C157
100
10V
D584
MA8039
DATA_IN
C215
0.15
C213
1
50V
JC59
0
JC68
0
R203
3.3k
CPU7
D610
MA8062-M
(CHASSIS)
8 9 2 4 9 8 2 9 9
R612
100
AD1
R584
47k
CN602
12P
R562
100k
ILL
D609
MA8062-M
R613 100
AD0
LCD1
LCD2
XO
R621 100
-1
MUX
D4
MA8062-M
C601
0.22
VREF
CMP
-2
RDS1
XI
D617 MA8062-M
JC23
0
Q605
REGULATOR CONTROL
C506
0.01
QUAL
Q501
-1
JC27
0
Q501
XN1A312
RCLK
B1
SWITCH
TUNER MUTE
RDATA
XO
D614 MA4068-M
D501
MA8039
VDD
RDS2
C30
X2
R16
15p 4.332MHz 8.2k
D615 MA4068-M
JC20
0
ON5
L4
10µH
ARI
T1
ON2
D601
MA8120-M
T2
FO
GND
R615 10k
C583
47
16V
JC63
0
-1
R614 10k
C582
2.2
50V
RESET
Q605
XN1A312
R609
330
JC40
0
IC3
TDA7330BD
C29
0.01
-2
REGULATOR
(FOR ILLUMINATION)
RDS DECODER
D616 MA8062-M
REGULATOR
(FOR FM/AM PLL)
C28
10 16V
Q603
2SD2137-OP
Q603
D611 MA4068-M
R627 R626 R625 R624
1.5
1.5
1.5
1.5
-2
-1
Q2
D612 MA4068-M
C25
18p
D613 MA4180-M
X1
7.2MHz
ORIGINAL
SERVICE
MANUAL
Page 32
B+ SWITCH
CONTROL SWITCH
-2
C24
18p
0
C17 0.1
LCD4
Q3
IMD3
LINE MUTE
R582
1k
C16
0.047
C35
0.01
Q581
XN1A312
R11
1k
LCD3
R583
47
D583
MA111
JC51
XI
R544 1k
50V
L1
10µH
R9
2.2k
C31
12p
R585
100k
JC66
JC31
0
A.GND
C26
470p
Z5
R209
15k
CE
RF
JC7
0
D3
MA8100-L
R205
470
PLL4
Q2
2SC2412K-QR
C15
100
10V
Q202,203
LINE MUTE
3 7 6 3 1 5 1 5 0
C216
0.15
C212 C214 C218
3300p 0.022 10
16V
C221
10
16V
B2
CONTROL SWITCH
B3
B4
T57
C32
1
50V
R17
2.2M
B5
B6
B7
B8
B10
B11
B13
www
x ia o y u 1 6 3
(Page 5)
.
4
4
http://www.xiaoyu163.com
.
c o
A16
A14
m
A15
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
B12
(Page 6)
376315150 892498299
376315150 892498299
C158
0.01
C22 0.1
FM.CPOUT
QQ
C211
1
50V
1 3 9 4 2 2 9 6 5 1 3
C23
100
16V
C219
10
16V
DX /LO
C20 100p
(C430RDS/C440RDS)
C584 47p
C14 2200p
C11 100p
Q203
DTC314TK
R14
2.2k
FM.IFRQ
ORIGINAL
SERVICE
MANUAL
Page 28
QQ
QQ
C12 0.47
IC1
TB2114F
IF.IN
R210 15k
Q202
DTC314TK
R212 2.2M
L2
10µH
R211 15k
JC30
0
C19 100p
R5
47
C650
3300
16V
Z6
R7
12k
C18 0.01
D652 MA8240
R208 15k
C614 100p CH
C120 R204
10 16V 470
R528 100k
C615 100p
R108 15k
C220
10
16V
JC5
0
0
Z3
LINE MUTE
D651 MA8240
R201 C202
4.7k 1 50V
R110 15k
Q102,103
R104
470
JC62 0
PW
D653 MA8075-M
CLK
IC151
LC75373ED
C9
1000p
BUFFER
R4 100k
DATA
ELECTRICAL VOLUME
TU6
METER
JC50
0
0
C203
1
50V
Q503
R213 2.2M
R19
10k
JC29
0
CE
13942296513
13942296513
Q102
DTC314TK
C155 22 16V
SIGNAL
C618
0.01
R111
15k
Q201
DTC314TK
Q503
2SC2412K-QR
TEL
TEL
R8
100
Z4
Q103
DTC314TK
RV1
220k
D2
SB02W03C
JC9
0
ORIGINAL
SERVICE
MANUAL
Page 28
R109
15k
Q101
DTC314TK
R202
33k
JC11
0
TEL
D150
MA8180
-M
D151
D152
MA8180-M MA8180-M
TU3
C6 0.01
C13
0.022
JC28
0
ON4
R218
3.3k
C121
10
16V R105
C101
0.022
TU2
C5
JC10
10 16V
0
R6
15k
C223
100p
C222
100p
JC60
JC8
0
C4 10 16V
JC38
0
C119
C116 10
0.15 16V
R102
33k
(CHASSIS)
C34
100p
R219
10k
C122
100p
R2 4.7k
R3 10k
TU1
C3
10 16V
C123
100p
R112 2.2M
C2
1000p
R103
3.3k
C115
0.15
C118
C112 C114 10
3300p 0.022 16V
Q101,201
TUNER MUTE
R1 1k
C1
22p
R119
10k
ON1
C113
1
50V
C111
1
50V
JC67
J1
FM/AM
Z5
Z6
C152
0.047
JC14
0
ANTENNA
Z4
C124
10 R118
25V 3.3k
http://www.xiaoyu163.com
XR-4740RDS/C430RDS/C440RDS
QQ 3 7 6 3 1 5 1 5 0
C308
1
50V
A14
A15
A16
A13
A12
A11
A10
A9
A8
A7
A5
JC58
0
R351
18k
C309
1000p
C408
1
50V
R408
10k
R307
2.2k
C1
C410
2200p
R510 100k
R306
470
R526 100k
R407
2.2k
(PLAYBACK)
R524 100k
JC17
0
HP901
R525 100k
JC18
0
R545 100k
C310
2200p
R522 100k
R308
10k
R523 100k
R303
15k
R546 100k
C305
0.22
(Page 4)
R521 100k
R305
330k
8 9 2 4 9 8 2 9 9
A6
A4
A3
A2
SCHEMATIC DIAGRAM – MAIN Board (2/3) –
A1
2-4.
6
C304
0.01
F-L(CH)
MODE2
7
TAPE EQUALYZER AMP/
C3
BUSON
6
7
MD1
RESET
2
L(CH)-COM
MODE1
5
C403 330p
ON5
C303 C350
330p
22
16V
R-L(CH)
C2
TU1
GND
TU2
R-R(CH)
4
L
MD10
3
4
R551 10k
MD14
R(CH)-COM
MD4
TU6
R574
100k
L501
10µH
C4
DOLBY NR AMP
REV
3
R
MD3
IC351
CXA2509AQ
JC15 0
* R535
R573
100k
22k (4740RDS/C430RDS)
100k (C440RDS)
C401
1000p
C404
0.01
C356
0.1
R352
220k
R354
15k
C354
0.01
JC70
0
(4740RDS)
JC24
0
R535
*
DS
R537
100k
(German)
DBB
(AEP,UK)
ON1
R536
100k
ON3
C502
1
R355
22
C409
1000p
R353
4.7k
C357
100
10V
D350
MA111
QQ
JC56
0
C353
0.47
50V
C351
100p
X501
8MHz
ON4
(4740RDS/C430RDS)
3 7 6 3 1 5 1 5 0
X502 32.768kHz
8 9 2 4 9 8 2 9 9
C8
KS
D504
MA152WA
DBB
D506
1SS119
AD0
C9
AD1
SYSTEM CONTROLLER
R518
100k
IC501
R506 330k
C504
22p
C7
DS
R505 1k
C503
18p
R538
100k
R540
100k
MN1884820S4G (4740RDS)
(Page 6)
C505
0.1
MN1886426S4H (C430RDS/C440RDS)
MECHANISM BLOCK
CN352
13P
(TAPE DET)
REEL2
CPU2
REEL1
R511
100k
MD14
LOADING/TAPE
R508 2.2k
POS3
MD11
POS1
MD13
POS2
Q361
2SD1802FAST
LM+
GND
LCD4
JC54
0
R509
1k
R515
1k
C10
R572
100k
(4740RDS)
Q364,365
Q362
REGULATOR
REGULATOR CONTROL
(TAPE ON)
SWITCH
CAPSTAN/REEL
JC36
0
MOTOR DRIVE
R516
1k
LCD2
LCD3
JC77
0
.
R365
4.7k
-1
D361
MA8100-L
GND
LOADING/TAPE
C366
10
16V
JC74
0
OPERATION MOTOR DRIVE
MD7
C365
10
16V
PLL1
CPU7
MD8
C11
CPU6
MD9
CPU4
PLL4
PLL2
PLL3
MD5
R363
4.7
R517 1k
R501
100k
R361
1k
IN2
MD6
C362 0.1
C363 0.1
OUT2
R362
4.7
MD4
VCC
VS
-2
MD7
OUT1
Q362
XN1A312
MD1
IN1
MD6
GND
JC75
0
D362 1SS119
JC76
0
IC360
MM1322XFBE
R531
100k
R364
10k
C12
RDS2
MD9
C367
220
16V
Q365
DTC114EKA
R534
100k
JC52
0
R513
100k
R512
100k
C13
MD8
M901
(CAPSTAN/REEL)
Q364
2SB1132-R
MD3
C-MOTOR
www
R571
100k
LCD1
MD12
LM-
REEL SENSOR
R514
1k
CE
GND
OPERATION
TAKE-UP/SUPPLY
UNICLK
R507 1k
CLK
JC22 0
TAPE
OPERATION
CPU3
DATA
POS4
MD10
R570
100k
UNISI
AUTO.MTL
ROTARY
SLIDE
UNISO
RDS1
(METAL DET)
SWITCH
C507 0.1
CPU1
+B(8.5V)
C14
x ia o y u 1 6 3
5
5
http://www.xiaoyu163.com
.
c o
m
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
R406 R405
470 330k
R539
10k
QQ
QQ
C405 0.22
ON2
R403
15k
C6
KS
C501
100
10V
TEL
JC81
0
C5
C402
330p
13942296513
13942296513
2
R549 10k
JC55 0
JC16 0
F-R(CH)
MD11
C302 330p
1
MD5
MD12
CN351
7P
R
R548 10k
MD13
1
PW
TU3
C301
1000p
ILL
5
FWD
TEL
TEL
L
http://www.xiaoyu163.com
XR-4740RDS/C430RDS/C440RDS
B1
B3
B5
B2
8 9 2 4 9 8 2 9 9
(Page 4)
B6
B7
B8
B12
B13
B11
B10
SCHEMATIC DIAGRAM – MAIN Board (3/3) –
B4
QQ 3 7 6 3 1 5 1 5 0
2-5.
R616
0
R608
100k
CPU3
IC571
S-8054HN-CB-T1
(4740RDS)
XC61AN4002PR
(C430RDS/C440RDS)
O
CPU1
JC37
0
I
D624
MA111
Q608
DTA114EKA
Q606
DTA114EKA
B+ SWITCH
G
B+ SWITCH
R610
10k
C1
GENERATOR
TEL
TEL
C603
0.1F
5.5V
RESET SIGNAL
S601
RESET
CPU4
13942296513
13942296513
REGULATOR
GND
AM8V
FM8V
COM8V
VCC
ANT+B
BU+B
AMP+B
NC
STB
MODE2
C2
C3
MODE1
IC601
BA3918-V2
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
C8
C606
10
16V
C609
47
16V
C617
10
16V
C607
10
16V
JC73
0
D622 1SR139
C605
10
16V
C7
(C430RDS/C440RDS)
D623
1SR139
D621
1SR139
ON3
C6
MODE1
QQ
1 3 9 4 2 2 9 6 5 1 3
JC80
0
R618
10k
R619
10k
R617
100
JC78
0
C9
(Page 5)
JC65
0
R602
100k
J501
REMOTE IN
R620
100
Q609
REGULATOR(FOR TUNER)
JC53
0
CPU2
C10
JC32
0
CPU6
Q610
ACCESSORY CHECK
(4740RDS)
Q609
2SD1802FAST
-2
Q701
DTC114EKA
BATTERY
CHECK
R701
10k
* C701
1000p
(4740RDS)
0.022
(C430RDS/C440RDS)
C701
*
R601
2.2k
R604
47k
D606
MA8068-H
D607
MA152WK
R606
2.2k
-1
Q610
2SC2412K-QR
Q702
XN1A312
R702
470k
D605
MA8056-M
BATTERY
D701
MA8180-M
CHECK
C610
22
16V
R607
10k
D702
DTZ7.5C
R603
47k
C612
1
C11
(C430RDS/C440RDS)
CN701
BUS CONTROL IN
C12
UNISI
UNISO
www
R708
47
(FOR SONY BUS)
JC33
0
R704
100k
JC34 0
UNICLK
x ia o y u 1 6 3
BUSON
JC79 0
JC35 0
RESET
C13
C14
.
IC701
BA8270F
C704
0.1
BUS INTERFACE
(FOR SONY BUS)
D706
MA8062-M
6
6
http://www.xiaoyu163.com
c o
D703 MA8062-H
.
D705
MA8062-M
D704
MA8062-M
C703
0.022
m
BUS.ON
B.DATA
B.CLK
+BATT
R705 10k
R706 100
RESET
R707 100
(FRONT VIEW)
C702
0.1
(CHASSIS)
376315150 892498299
376315150 892498299
TEL
JC71
0
QQ
QQ
C5
MODE2
C4
http://www.xiaoyu163.com
XR-4740RDS/C430RDS/C440RDS
QQ 376315150 892498299
MAIN
3. ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in the
parts list may be different from the parts specified in the diagrams or the components used
on the set.
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
• Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when ordering these items.
• SEMICONDUCTORS
In each case, u: µ, for example:
uA. . : µA. .
uPA. . : µPA. .
uPB. . : µPB. .
uPC. . : µPC. .
uPD. . : µPD. .
• CAPACITORS
uF: µF
• COILS
uH: µH
*
A-3309-818-A MAIN BOARD, COMPLETE
(C440RDS: AEP, UK)
A-3309-824-A MAIN BOARD, COMPLETE
(C440RDS: German)
A-3309-830-A MAIN BOARD, COMPLETE
(4740RDS: AEP, UK)
A-3309-834-A MAIN BOARD, COMPLETE
(4740RDS: German)
A-3309-880-A MAIN BOARD, COMPLETE
(C430RDS: AEP, UK)
*
*
*
*
Description
Remark
HEAT SINK (C430RDS/C440RDS)
BRACKET (IC)
HEAT SINK (4740RDS)
BRACKET (HS)
SCREW +PTT 2.6X8 (S)
C1
C2
C3
C4
C5
1-163-235-11
1-163-009-11
1-124-233-11
1-124-233-11
1-124-233-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT
22PF
0.001uF
10uF
10uF
10uF
5%
10%
20%
20%
20%
50V
50V
16V
16V
16V
C6
C9
C11
C12
C13
1-163-021-11
1-163-009-11
1-163-251-11
1-107-823-11
1-163-037-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.001uF
100PF
0.47uF
0.022uF
10%
5%
10%
10%
50V
50V
50V
16V
50V
C14
C15
C16
C17
C18
1-164-161-11
1-124-584-00
1-163-809-11
1-124-463-00
1-163-021-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
2200PF
100uF
0.047uF
0.1uF
0.01uF
5%
20%
10%
20%
100V
10V
25V
50V
50V
C19
C20
C21
C22
C23
1-163-251-11
1-163-251-11
1-163-251-11
1-163-077-00
1-126-933-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
100PF
100PF
100PF
0.1uF
100uF
5%
5%
5%
10%
20%
50V
50V
50V
50V
16V
C24
C25
C26
C28
C29
1-163-099-00
1-163-099-00
1-163-133-00
1-124-233-11
1-163-021-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
18PF
18PF
470PF
10uF
0.01uF
5%
5%
5%
20%
50V
50V
50V
16V
50V
.
Remark
C30
C31
C32
C34
C35
1-163-231-11
1-163-229-11
1-126-160-11
1-163-251-11
1-163-021-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
15PF
12PF
1uF
100PF
0.01uF
5%
5%
20%
5%
50V
50V
50V
50V
50V
C36
C101
C102
C103
C111
1-163-251-11
1-163-037-11
1-126-160-11
1-126-160-11
1-126-160-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT
100PF
0.022uF
1uF
1uF
1uF
5%
10%
20%
20%
20%
50V
25V
50V
50V
50V
C112
C113
C114
C115
C116
1-164-182-11
1-126-160-11
1-163-037-11
1-164-492-11
1-164-492-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0033uF
1uF
0.022uF
0.15uF
0.15uF
10%
20%
10%
10%
10%
50V
50V
25V
16V
16V
C118
C119
C120
C121
C122
1-124-233-11
1-124-233-11
1-124-233-11
1-124-233-11
1-163-251-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
10uF
10uF
10uF
10uF
100PF
20%
20%
20%
20%
5%
16V
16V
16V
16V
50V
C123
C124
C128
C151
C152
1-163-251-11
1-126-096-11
1-163-251-11
1-107-823-11
1-163-809-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
10uF
100PF
0.47uF
0.047uF
5%
20%
5%
10%
10%
50V
35V
50V
16V
25V
C153
C155
C157
C158
C201
1-163-037-11
1-124-234-00
1-124-584-00
1-163-031-11
1-163-037-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.022uF
22uF
100uF
0.01uF
0.022uF
10%
20%
20%
25V
16V
10V
50V
25V
C202
C203
C211
C212
C213
1-126-160-11
1-126-160-11
1-126-160-11
1-164-182-11
1-126-160-11
ELECT
ELECT
ELECT
CERAMIC CHIP
ELECT
1uF
20%
50V
1uF
20%
50V
1uF
20%
50V
0.0033uF 10%
50V
1uF
20%
50V
(C430RDS/C440RDS)
C214
1-163-037-11 CERAMIC CHIP
0.022uF 10%
25V
(C430RDS/C440RDS)
0.15uF
10%
16V
(C430RDS/C440RDS)
0.15uF
10%
16V
10uF
20%
16V
10uF
20%
16V
QQ 376315150 892498299
< CAPACITOR >
www
Description
xiaoy u163. com
C215
1-164-492-11 CERAMIC CHIP
C216
C219
C220
1-164-492-11 CERAMIC CHIP
1-124-233-11 ELECT
1-124-233-11 ELECT
10%
376315150 892498299
376315150 892498299
TEL 13942296513
3-009-293-01
3-009-307-01
3-010-471-01
3-012-105-01
7-685-793-09
*
*
*
*
Part No.
QQ
QQ
A-3309-884-A MAIN BOARD, COMPLETE
(C430RDS: German)
*********************
*
Ref. No.
13942296513
13942296513
Part No.
TEL
TEL
Ref. No.
When indicating parts by reference
number, please include the board.
7
http://www.xiaoyu163.com
http://www.xiaoyu163.com
XR-4740RDS/C430RDS/C440RDS
QQ 376315150 892498299
MAIN
Ref. No.
Part No.
Description
Remark
10uF
100PF
C224
1-126-096-11 ELECT
C301
1-163-009-11 CERAMIC CHIP
C302
C303
C304
C305
C308
1-163-263-11
1-163-263-11
1-163-021-11
1-164-489-11
1-126-160-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
330PF
330PF
0.01uF
0.22uF
1uF
10%
20%
50V
50V
50V
16V
50V
C309
C310
C350
C351
C353
1-163-009-11
1-164-161-11
1-124-234-00
1-163-251-11
1-124-465-00
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.001uF
0.0022uF
22uF
100PF
0.47uF
10%
10%
20%
5%
20%
50V
100V
16V
50V
50V
C354
C356
C357
C362
C363
1-163-021-11
1-164-004-11
1-124-584-00
1-165-319-11
1-165-319-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.1uF
100uF
0.1uF
0.1uF
C365
C366
C367
C401
C402
1-124-233-11
1-124-233-11
1-126-934-11
1-163-009-11
1-163-263-11
ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
220uF
0.001uF
330PF
20%
20%
20%
10%
5%
16V
16V
16V
50V
50V
C403
C404
C405
C408
C409
1-163-263-11
1-163-021-11
1-164-489-11
1-126-160-11
1-163-009-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
330PF
0.01uF
0.22uF
1uF
0.001uF
5%
10%
20%
10%
50V
50V
16V
50V
50V
C410
C501
C502
C503
C504
1-164-161-11
1-124-584-00
1-109-982-11
1-163-099-00
1-163-235-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0022uF
100uF
1uF
18PF
22PF
10%
20%
10%
5%
5%
100V
10V
10V
50V
50V
C505
C506
C507
C582
C583
1-165-319-11
1-163-021-11
1-164-004-11
1-124-257-00
1-124-589-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.1uF
0.01uF
0.1uF
2.2uF
47uF
10%
20%
20%
50V
50V
25V
50V
16V
C584
C601
C603
C605
C606
1-163-243-11
1-164-222-11
1-125-710-11
1-124-233-11
1-124-233-11
CERAMIC CHIP
CERAMIC CHIP
DOUBLE LAYER
ELECT
ELECT
47PF
0.22uF
0.1F
10uF
10uF
20%
20%
50V
25V
5.5V
16V
16V
C607
C609
C610
C612
C614
1-124-233-11
1-124-589-11
1-124-234-00
1-109-982-11
1-163-251-11
ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
10uF
47uF
22uF
1uF
100PF
20%
20%
20%
10%
5%
16V
16V
16V
10V
50V
5%
5%
Part No.
Description
C701
1-163-037-11 CERAMIC CHIP
C702
1-165-319-11 CERAMIC CHIP
C703
1-163-037-11 CERAMIC CHIP
C704
1-164-004-11 CERAMIC CHIP
Remark
0.022uF 10%
25V
(C430RDS/C440RDS)
0.1uF
50V
(C430RDS/C440RDS)
0.022uF 10%
25V
(C430RDS/C440RDS)
0.1uF
10%
25V
(C430RDS/C440RDS)
< CONNECTOR/JACK >
CN351
* CN352
CN602
CN701
1-766-260-11
1-506-995-11
1-764-422-11
1-580-907-31
CONNECTOR, FFC/FPC (ZIF) 7P
PIN, CONNECTOR (PC BOARD) 13P
PLUG, CONNECTOR 12P
PLUG, CONNECTOR (BUS CONTROL IN)
(C430RDS/C440RDS)
CNJ150 1-774-699-12 JACK, PIN 4P (BUS AUDIO IN/LINE OUT REAR)
(C430RDS/C440RDS)
13942296513
< DISCHARGE GAP >
10%
20%
QQ
376315150 892498299
TEL 13942296513
www
* CP1
1-517-422-11 GAP, DISCHARGE
< DIODE >
D2
D3
D4
D150
D151
8-719-991-65
8-719-423-07
8-719-422-64
8-719-057-80
8-719-057-80
DIODE
DIODE
DIODE
DIODE
DIODE
SB02W03C
MA8100-L-TX
MA8062-M
MA8180-M-TX (C430RDS/C440RDS)
MA8180-M-TX (C430RDS/C440RDS)
QQ 376315150 892498299
D152
D350
D361
D362
D501
8-719-057-80
8-719-404-49
8-719-423-07
8-719-911-19
8-719-422-12
DIODE
DIODE
DIODE
DIODE
DIODE
MA8180-M-TX (C430RDS/C440RDS)
MA111
MA8100-L-TX
1SS119
MA8039
D504
D506
D583
D584
D601
8-719-400-20
8-719-911-19
8-719-404-49
8-719-422-12
8-719-423-32
DIODE
DIODE
DIODE
DIODE
DIODE
MA152WA
1SS119
MA111
MA8039
MA8120-M
D605
D606
D607
D609
D610
8-719-977-03
8-719-017-67
8-719-801-78
8-719-422-64
8-719-422-64
DIODE
DIODE
DIODE
DIODE
DIODE
DTZ5.6B
MA8068H
1SS184
MA8062-M
MA8062-M
D611
D612
D613
D614
D615
8-719-109-97
8-719-109-97
8-719-034-94
8-719-109-97
8-719-109-97
DIODE
DIODE
DIODE
DIODE
DIODE
RD6.8ES-B2
RD6.8ES-B2
MA4180-M (QZ)
RD6.8ES-B2
RD6.8ES-B2
D616
D617
D621
D622
D623
8-719-422-64
8-719-422-64
8-719-970-02
8-719-970-02
8-719-970-02
DIODE
DIODE
DIODE
DIODE
DIODE
MA8062-M
MA8062-M
1SR139-400
1SR139-400 (C430RDS/C440RDS)
1SR139-400
D624
D651
D652
D653
D701
8-719-404-49
8-719-018-04
8-719-018-04
8-719-422-76
8-719-057-80
DIODE
DIODE
DIODE
DIODE
DIODE
MA111
MA8240-TX (C430RDS/C440RDS)
MA8240-TX
MA8075-M
MA8160-M-TX
D702
8-719-977-17 DIODE DTZ7.5C (4740RDS)
xiaoy u163. com
C615
1-163-251-11 CERAMIC CHIP
C617
C618
C650
C701
1-124-233-11
1-163-021-11
1-126-936-11
1-163-009-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
.
5%
50V
25V
10V
50V
50V
100PF
5%
50V
(C430RDS/C440RDS)
10uF
20%
16V
0.01uF
50V
3300uF
20%
16V
0.001uF 10%
50V
(4740RDS)
8
http://www.xiaoyu163.com
376315150 892498299
1-163-251-11 CERAMIC CHIP
Ref. No.
QQ
C223
20%
16V
5%
50V
(C430RDS/C440RDS)
100PF
5%
50V
(C430RDS/C440RDS)
10uF
20%
35V
(C430RDS/C440RDS)
0.001uF 10%
50V
13942296513
1-124-233-11 ELECT
1-163-251-11 CERAMIC CHIP
TEL
TEL
C221
C222
http://www.xiaoyu163.com
XR-4740RDS/C430RDS/C440RDS
QQ 376315150 892498299
MAIN
Ref. No.
D703
D704
D705
D706
Part No.
Description
< IC >
JC56
JC57
JC58
JC59
JC60
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP (C430RDS/C440RDS)
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
Part No.
Description
8-719-422-67
8-719-422-64
8-719-422-64
8-719-422-64
DIODE
DIODE
DIODE
DIODE
Remark
MA8062-H (C430RDS/C440RDS)
MA8062-M (C430RDS/C440RDS)
MA8062-M (C430RDS/C440RDS)
MA8062-M (C430RDS/C440RDS)
Ref. No.
Remark
IC
IC
IC
IC
IC
TB2114F (EL)
TDA7330BD-013TR
LC75373ED
CXA2509AQ-T4
MM1322XFBE
JC62
JC63
JC65
JC66
JC67
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
IC501
IC501
IC571
IC571
IC601
8-759-451-03
8-759-451-04
8-759-363-81
8-759-940-45
8-759-347-49
IC
IC
IC
IC
IC
MN1884820S4G (4740RDS)
MN1886426S4H (C430RDS/C440RDS)
XC61AN4002PR (C430RDS/C440RDS)
S-8054HN-CB (4740RDS)
BA3918-V2
JC68
JC69
JC70
JC71
JC73
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP (C430RDS/C440RDS)
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
IC701
8-759-449-89 IC BA8270F-E2 (C430RDS/C440RDS)
JC74
JC75
JC76
JC77
JC78
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
JC79
JC80
JC81
1-216-296-00 CONDUCTOR, CHIP (C430RDS/C440RDS)
1-216-296-00 CONDUCTOR, CHIP
1-216-296-00 CONDUCTOR, CHIP
< JACK >
J1
J501
1-764-808-21 JACK (FM/AM ANTENNA)
1-566-822-41 JACK (REMOTE IN)
< CHIP CONDUCTOR >
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
JC11
JC14
JC15
JC16
JC17
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
JC18
JC20
JC21
JC22
JC23
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
JC24
JC27
JC28
JC29
JC30
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
JC31
JC32
JC33
JC34
JC35
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP (C430RDS/C440RDS)
CONDUCTOR, CHIP (C430RDS/C440RDS)
CONDUCTOR, CHIP (C430RDS/C440RDS)
JC36
JC37
JC38
JC40
JC50
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-296-00
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
JC51
JC52
JC53
JC54
JC55
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
TEL 13942296513
www
.
< COIL >
L1
L2
L4
L501
1-412-006-31
1-410-509-11
1-410-509-11
1-410-509-11
INDUCTOR, CHIP 10uH
INDUCTOR, MICRO 10uH
INDUCTOR, MICRO 10uH
INDUCTOR
10uH
QQ 376315150 892498299
< TRANSISTOR >
Q2
Q3
Q101
Q102
Q103
8-729-120-28
8-729-907-28
8-729-920-21
8-729-920-21
8-729-920-21
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1623-L5L6
IMD3
DTC314TKH04
DTC314TKH04
DTC314TKH04
Q201
Q202
Q203
Q361
Q362
8-729-920-21
8-729-920-21
8-729-920-21
8-729-015-11
8-729-020-67
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC314TKH04
DTC314TKH04
DTC314TKH04
2SD1802FAST-TL
XN1A312-TX
Q364
Q365
Q501
Q503
Q581
8-729-106-60
8-729-900-53
8-729-020-67
8-729-120-28
8-729-020-67
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1115A
DTC114EK
XN1A312-TX
2SC1623-L5L6
XN1A312-TX
Q603
Q605
Q606
Q608
Q609
8-729-423-99
8-729-020-67
8-729-027-23
8-729-027-23
8-729-015-11
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD2137-OP
XN1A312-TX
DTA114EKA-T146
DTA114EKA-T146
2SD1802FAST-TL
Q610
Q701
Q702
8-729-120-28 TRANSISTOR 2SC1623-L5L6
8-729-900-53 TRANSISTOR DTC114EK
8-729-020-67 TRANSISTOR XN1A312-TX (4740RDS)
xiaoy u163. com
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
CONDUCTOR, CHIP
376315150 892498299
376315150 892498299
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
QQ
QQ
JC5
JC7
JC8
JC9
JC10
13942296513
13942296513
8-759-448-88
8-759-163-63
8-759-443-67
8-752-079-78
8-759-395-97
TEL
TEL
IC1
IC3
IC151
IC351
IC360
< RESISTOR >
R1
1-216-049-00 METAL CHIP
1K
5%
1/10W
9
http://www.xiaoyu163.com
http://www.xiaoyu163.com
XR-4740RDS/C430RDS/C440RDS
QQ 376315150 892498299
MAIN
Ref. No.
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
Remark
R6
R7
R8
R9
R11
1-216-077-00
1-216-075-00
1-216-025-00
1-216-057-00
1-216-049-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
12K
100
2.2K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R14
R15
R16
R17
R18
1-216-057-00
1-216-073-00
1-216-071-00
1-216-129-00
1-216-049-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
10K
8.2K
2.2M
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R19
R101
R102
R103
R104
1-216-073-00
1-216-065-00
1-216-085-00
1-216-061-00
1-216-190-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
4.7K
33K
3.3K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/8W
R105
R108
R109
R110
R111
1-216-190-00
1-216-077-00
1-216-077-00
1-216-077-00
1-216-077-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
15K
15K
15K
15K
5%
5%
5%
5%
5%
1/8W
1/10W
1/10W
1/10W
1/10W
R112
R113
R118
1-216-129-00 METAL CHIP
1-216-129-00 METAL CHIP
1-216-061-00 METAL CHIP
2.2M
2.2M
3.3K
R119
1-216-073-00 METAL CHIP
10K
R151
1-216-065-00 METAL CHIP
4.7K
R201
R202
R203
R204
R205
1-216-214-00
1-216-085-00
1-216-061-00
1-216-041-00
1-216-041-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
33K
3.3K
470
470
5%
5%
5%
5%
5%
1/8W
1/10W
1/10W
1/10W
1/10W
R208
R209
R210
R211
R212
1-216-077-00
1-216-077-00
1-216-077-00
1-216-077-00
1-216-129-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
15K
15K
15K
2.2M
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R213
R218
1-216-129-00 METAL CHIP
1-216-061-00 METAL CHIP
2.2M
3.3K
R219
1-216-073-00 METAL CHIP
R303
R305
1-216-077-00 METAL CHIP
1-216-109-00 METAL CHIP
5%
1/10W
5%
1/10W
(C430RDS/C440RDS)
10K
5%
1/10W
(C430RDS/C440RDS)
15K
5%
1/10W
330K
5%
1/10W
R306
R307
R308
R351
R352
1-216-190-00
1-216-057-00
1-216-073-00
1-208-812-11
1-216-105-00
470
2.2K
10K
18K
220K
5%
1/10W
5%
1/10W
5%
1/10W
(C430RDS/C440RDS)
5%
1/10W
(C430RDS/C440RDS)
5%
1/10W
TEL 13942296513
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
www
R353
R354
R355
R361
R362
1-216-065-00
1-216-077-00
1-216-009-00
1-216-049-00
1-249-389-11
1/8W
1/10W
1/10W
1/10W
1/10W
Part No.
Description
R363
R364
R365
R403
R405
1-249-389-11
1-216-073-00
1-216-065-00
1-216-077-00
1-216-109-00
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7
10K
4.7K
15K
330K
5%
5%
5%
5%
5%
1/4W
1/10W
1/10W
1/10W
1/10W
Remark
R406
R407
R408
R501
R505
1-216-190-00
1-216-057-00
1-216-073-00
1-216-097-00
1-216-049-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
2.2K
10K
100K
1K
5%
5%
5%
5%
5%
1/8W
1/10W
1/10W
1/10W
1/10W
R506
R507
R508
R509
R510
1-216-109-00
1-216-198-00
1-216-206-00
1-216-198-00
1-216-097-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330K
1K
2.2K
1K
100K
5%
5%
5%
5%
5%
1/10W
1/8W
1/8W
1/8W
1/10W
R511
R512
R513
R514
R515
1-216-097-00
1-216-097-00
1-216-097-00
1-216-198-00
1-216-198-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/8W
1/8W
R516
R517
R518
R521
R522
1-216-198-00
1-216-198-00
1-216-246-00
1-216-246-00
1-216-097-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
100K
100K
100K
5%
5%
5%
5%
5%
1/8W
1/8W
1/8W
1/8W
1/10W
R523
R524
R525
R526
R528
1-216-097-00
1-216-097-00
1-216-097-00
1-216-097-00
1-216-097-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R531
R534
R535
1-216-246-00 METAL CHIP
1-216-246-00 METAL CHIP
1-208-814-11 METAL CHIP
100K
100K
22K
R535
1-216-097-00 METAL CHIP
R536
1-216-246-00 METAL CHIP
R537
1-216-097-00 METAL CHIP
100K
5%
R538
1-216-246-00 METAL CHIP
100K
5%
R539
R540
R544
1-208-806-11 METAL CHIP
1-216-097-00 METAL CHIP
1-216-049-00 METAL CHIP
10K
100K
1K
0.5%
5%
5%
R545
R546
R548
R549
R551
1-216-097-00
1-216-097-00
1-216-222-00
1-216-222-00
1-249-429-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
100K
100K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/8W
1/8W
1/4W
R562
R570
1-216-097-00 METAL CHIP
1-216-097-00 METAL CHIP
100K
100K
5%
5%
R571
1-216-097-00 METAL CHIP
100K
5%
R572
1-216-097-00 METAL CHIP
100K
5%
R573
1-216-097-00 METAL CHIP
100K
5%
1/10W
1/10W
(4740RDS)
1/10W
(4740RDS)
1/10W
(4740RDS)
1/10W
(4740RDS)
QQ 376315150 892498299
5%
1/8W
5%
1/8W
2%
1/10W
(4740RDS/C430RDS)
100K
5%
1/10W
(C440RDS)
100K
5%
1/8W
(4740RDS/C430RDS)
xiaoy u163. com
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
.
5%
5%
5%
2%
5%
Ref. No.
4.7K
15K
22
1K
4.7
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/4W
10
http://www.xiaoyu163.com
1/10W
(German)
1/8W
(AEP, UK)
1/10W
1/10W
1/10W
376315150 892498299
376315150 892498299
4.7K
10K
100K
47
QQ
QQ
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
13942296513
13942296513
Description
1-216-065-00
1-216-073-00
1-216-097-00
1-216-017-00
TEL
TEL
Part No.
R2
R3
R4
R5
http://www.xiaoyu163.com
XR-4740RDS/C430RDS/C440RDS
QQ 376315150 892498299
MAIN
Ref. No.
Part No.
Description
Remark
R582
R583
R584
R585
1-216-198-00
1-216-166-00
1-216-238-00
1-216-097-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
47
47K
100K
5%
5%
5%
5%
1/10W
(4740RDS)
1/8W
1/8W
1/8W
1/10W
R601
R602
R603
R604
R606
1-216-057-00
1-216-097-00
1-216-089-00
1-216-089-00
1-216-206-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
100K
47K
47K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/8W
R607
R608
R609
R610
R612
1-216-073-00
1-216-097-00
1-216-037-00
1-216-073-00
1-216-025-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100K
330
10K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R613
R614
R615
R616
R617
1-216-025-00
1-208-806-11
1-208-806-11
1-216-295-00
1-216-025-00
METAL CHIP
100
METAL CHIP
10K
METAL CHIP
10K
CONDUCTOR, CHIP
METAL CHIP
100
5%
0.5%
0.5%
1/10W
1/10W
1/10W
5%
1/10W
R618
R619
R620
R621
R624
1-208-806-11
1-208-806-11
1-216-025-00
1-216-025-00
1-249-383-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
10K
10K
100
100
1.5
0.5%
0.5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/6W
R625
R626
R627
R701
1-249-383-11
1-249-383-11
1-249-383-11
1-216-073-00
CARBON
CARBON
CARBON
METAL CHIP
1.5
1.5
1.5
10K
5%
5%
5%
5%
R702
1-216-113-00 METAL CHIP
470K
5%
R704
1-216-246-00 METAL CHIP
100K
R705
1-216-073-00 METAL CHIP
10K
R706
1-216-025-00 METAL CHIP
100
R707
1-216-174-00 METAL CHIP
100
R708
1-216-017-00 METAL CHIP
47
TEL 13942296513
Ref. No.
Part No.
Description
Remark
1/6W
1/6W
1/6W
1/10W
(4740RDS)
1/10W
(4740RDS)
QQ 376315150 892498299
376315150 892498299
376315150 892498299
5%
QQ
QQ
100K
13942296513
13942296513
1-216-097-00 METAL CHIP
TEL
TEL
R574
5%
1/8W
(C430RDS/C440RDS)
5%
1/10W
(C430RDS/C440RDS)
5%
1/10W
(C430RDS/C440RDS)
5%
1/8W
(C430RDS/C440RDS)
5%
1/10W
(C430RDS/C440RDS)
< VARIABLE RESISTOR >
RV1
1-241-768-11 RES, ADJ, CARBON 220K
< SWITCH >
S601
1-692-431-21 SWITCH, TACTILE (RESET)
< TUNER UNIT >
TU1
1-693-373-11 FM/AM TUNER UNIT
www
X1
X2
X501
X502
< VIBRATOR >
1-567-848-11
1-579-242-41
1-579-125-11
1-567-098-41
.
xiaoy u163. com
VIBRATOR, CRYSTAL (7.2MHz)
VIBRATOR, CRYSTAL (4.332MHz)
VIBRATOR, CERAMIC (8MHz)
VIBRATOR, CRYSTAL (32.768kHz)
11
http://www.xiaoyu163.com
http://www.xiaoyu163.com
XR-4740RDS/C430RDS/C440RDS
QQ 376315150 892498299
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
1.1
1.0
Date
2001.06
1997.02
Description of Revision
MAIN board modification
New
(SPM-01012)
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
Download PDF
Similar pages