- No category
advertisement
Applies To:
See VEHICLES AFFECTED
Service Bulletin
06-059
July 20, 2007
Buzzing From the Engine at Low RPM
(Supersedes 06-059, dated November 10, 2006, to update the information by the black bar)
SYMPTOM
There is buzzing from the engine under light throttle
(1,300 to 1,700 rpm) or at idle while in gear.
PROBABLE CAUSE
The drive belt layout allows drive belt tensioner noise to be heard in the passenger compartment.
VEHICLES AFFECTED
2006 Civic 2-Door except SI and DX –
From VIN 2HGFG....6H500001 thru
2HGFG....6H577124
2006 Civic DX 2-Door and 4-Door with A/C – ALL
2006 Civic 4-Door –
From VIN 1HGFA....6L000001 thru
1HGFA....6L136885
From VIN 2HGFA....6H500001 thru
2HGFA....6H526510
2006 Civic 4-Door (Japan-produced) – ALL
2006 Civic GX – ALL
REPAIR PROCEDURE
1. Remove the original drive belt:
• Refer to page 4-40 of the 2006–2007 Civic
Service Manual, or
• Online, enter keywords DRIVE BELT, and select
Drive Belt Removal/Installation (R18A1 and
R18A4 Engine) from the list.
2. Install the new drive belt, and route it as shown.
CORRECTIVE ACTION
Install a longer, re-routed drive belt.
PARTS INFORMATION
Belt Kit: P/N 04301-RNA-307, H/C 8503310
NOTE: Use an appropriate tool for added leverage when setting the wrench on the auto-tensioner. The tensioner is hydraulic and should be moved slowly to relieve pressure on the belt. Applying excessive force to the tensioner can cause breakage.
WARRANTY CLAIM INFORMATION
In warranty: The normal warranty applies.
Operation Number: 118130
Flat Rate Time: 0.3 hour
Failed Part:
Defect Code:
Symptom Code:
P/N 56992-RNA-A01
H/C 8051104
00301
04501
Template ID:
Skill Level:
06-059A
Repair Technician
Out of warranty: Any repair performed after warranty expiration may be eligible for goodwill consideration by the District Parts and Service Manager or your Zone
Office. You must request consideration, and get a decision, before starting work.
© 2007 American Honda Motor Co., Inc. – All Rights Reserved ATB 33114-37464 (0707)
1 of 1
CUSTOMER INFORMATION: The information in this bulletin is intended for use only by skilled technicians who have the proper tools, equipment, and training to correctly and safely maintain your vehicle. These procedures should not be attempted by “do-it-yourselfers,” and you should not assume this bulletin applies to your vehicle, or that your vehicle has the condition described. To determine whether this information applies, contact an authorized Honda automobile dealer.
advertisement
* Your assessment is very important for improving the workof artificial intelligence, which forms the content of this project