Gymax GYM05798 1500-Watt Electric Oil Filled Radiator Space Heater Use and Care Manual

PRODUCT ORIENTATION
ES
IMPORTANT INSTRUCTIONS
Carry Нап4е {ft ‘
\®7
Power Indicator O
Main Control Knob
Thermostat Control Knob
Plug and cord storage
E
Figure A Figure B
Caster_— \
4
OPERATION INSTRUCTIONS
WARNING: Do not operate the product until fully assembled (including Casters).
1. Place the product upright on a flat, level, stable, heat-resistant surface, and then
uncoil the Power Cord, removing it completely from the Cord Storage Spool.The
power indicator will illuminate after plugged.
WARNING: Operate the product in an upright position only.
2. Turn the Thermostat Control Knob clockwise to its maximum range (Figure B).
3. Main Control Knob: Use this knob to set the heat setting (Figure B):
"1" — Low Heat Setting (600 Watts)
"2" — Medium Heat Setting (900 Watts)
"3" - High Heat Setting (1500 Watts)
4. When the desired ambient temperature is reached, slowly turn the Thermostat Knob
back toward MIN until it clicks. The product will cycle on and off to maintain that setting.
= =
—
ı =
I {
> y
USER'S MANUAL
Oil-filled Radiator
When using electrical appliances, basic precautions should always be followed to reduce the
risk of fire, electrical shock, and injury to persons including the following:
READ ALL INSTRUCTIONS BEFORE USE.
1. Keep the product out of the reach of children and pets. This product is not intended for
use by children. Extreme caution is necessary when any heater is used near children or the
physically challenged and whenever the heater is left operating and unattended.
2. Do not let bare skin touch hot surfaces, as heater is hot! To avoid burns, use the handle
when moving this heater. Keep combustible materials, such as furniture, pillows, bedding,
papers, clothes, and curtains at least 3 feet (0.9m) from all sides of the heater.
3. Always unplug the heater when not in use.
4. Do not use this product in bathrooms, laundry areas, or similar damp/wet indoor locations.
Do not place the product where it may fall into a bathtub or other water container.
5. Do not run the power cord under carpeting or cover it with throw rugs, runners, or similar
coverings. Arrange the cord away from traffic areas where it will not be tripped over.
6. To disconnect the product from an electrical outlet, turn any controls to the off position,
and then pull directly on the plug to remove it from the outlet; do not pull on the power
cord.
7. Do not insert or allow foreign objects to enter any ventilation or exhaust opening of the
product as this may cause electric shock or fire, or damage the heater.
8. Do not block air intakes or exhaust, as this may cause a risk of fire. Do not use the product
on soft surfaces, such as a bed, where openings may become blocked.
9. Do not use this product in an area where gasoline, paint, or flammable liquids are used or
stored, as this product has hot and arcing or sparking parts inside.
10.Do not place the product near a bed because objects, such as pillows or blankets, can fall
off and be ignited by the product.
11.Use this product only as described in this manual. Any other use not recommended by the
manufacturer may cause fire, electric shock, or injury to persons.
12.Do not immerse or expose the power cord, plug, or product to water or other liquids.If the
product falls into water, immediately unplug it from the electrical outlet; do not touch or
reach into the water. If water or other liquids reach any internal areas of this product,
permanently discontinue its use.
13.Ensure the product is unplugged from the electrical outlet and allowed to cool before
relocating or cleaning it.
14.Use the heater in a vertical position only.
15.Do not place the product in or near an open window. Rain, snow, or other weather
elements could cause electrical short-circuiting in the product.
16.Do not use outdoors.
17.To disconnect heater, turn controls to the off position, then remove plug from outlet.
SAFETY TERMS USED IN THIS MANUAL
A Danger: Indicates an imminently hazardous situation, which if not avoided, will result in
death or serious injury.
A Warning: Indicates a potentially hazardous situation, which, if not avoided, will result in death
or serious injury.
A Caution: Indicates a potentially hazardous situation, which, if not avoided, could result in
death or serious injury.
Notice: Addresses practices not related to personal injury, such as product and/or property
damage.
CONSUMER SAFETY INFORMATION
A Warning: If the information in this manual is not followed exactly, an electric shock or fire may
result causing property damage, personal injury or loss of life.
Notice: Do not store or use gasoline or other flammable vapors and liquids in the vicinity of
this or any other appliance.
Notice: For Household use only.
Notice: Read all instructions before use.
PRODUCT SPECIFICATIONS
Voltage Frequency Wattage (Max) Max. Amperage
120 V~ 60 Hz 1500W 12.5A
1
IMPORTANT INSTRUCTIONS
18. Do not plug into or unplug the product from the electrical outlet with a wet hand.
19. Do not operate this product if it has a damaged power cord or plug, if it malfunctions,or if
it has been dropped or damaged. This product has no user-serviceable parts. Do not
attempt to examine or repair this product yourself. Only qualified service personnel
should perform any servicing; take the product to an appliance repair shop of your choice
for inspection and repair.
20. This appliance is not intended for use by persons (included children) with reduced
physical, sensory or mental capability, or lack of experience and knowledge, unless they
have been given supervision or instruction concerning use of the appliance by a person
responsible for their safety.
21. Children should be supervised to ensure that they do not play with the appliance.
22. This product is intended solely for indoor, non-commercial, non-industrial use in
temporarily heating rooms. Do not use this product outdoors.
23. Do not operate the product continuously. Portable electric heaters are designed for finite
space heating or as a supplementary heat source. They are not intended to be main
sources of heat during the normal heating season.
24. Do not hang or wall-mount the product.
25. Place the product upright on a flat, level, stable, heat-resistant surface.
WARNING: This product is equipped with a polarized plug (one blade is wider than the other
blade). To reduce the risk of electrical shock, this plug will fit into a polarized outlet only one
way. This is a safety feature. If you are unable to insert the plug into the electrical outlet, try
reversing the plug. If the plug still does not fit, contact a qualified electrician. Always plug
heaters directly into a wall outlet/receptacle. Never use with an extension cord or relocatable
power tap, power strip.
SAVE THESE INSTRUCTIONS
NOTE: The product may emit an odor during first use; this is normal. Ventilate the area as needed.
5. Turn off the product by rotating the Main Control Knob to the "O" position, and then unplug
the product from the electrical outlet.
WARNING: Always unplug the product when it will be left unattended or not in use.
SAFETY PROTECTION SYSTEMS
This product has protection safeguards that shut off the product when parts become excessively
hot or if it tips over. If the product shuts off, immediately turn the Control to the "O" position and
unplug it from the electric outlet.
If tipped over:
Place the product on a flat, level, stable surface in order to prevent the product from tipping over
again.
TIP: Always install and maintain at least one smoke detector in good operating condition on each
floor of your home. Periodically check and/or replace the battery in your smoke detector with a
new battery.
CARE AND MAINTENANCE
WARNING: Do not attempt to disassemble this product for any reason, as incorrect
re-assembly could cause a risk of fire or electric shock. Only qualified service personnel should
perform any servicing.
WARNING: Always unplug the product from the electrical outlet and allow it to cool before
cleaning or storing it.
NOTICE: This product is permanently lubricated at the factory before shipping and will not require
further lubrication for the life of the product.
Clean only the exterior surface by wiping with a soft, damp cloth, and allow the product to dry
completely before storing or using. Dust can be removed from any vents using a small vacuum.
WARNING: Do not allow water or other liquids to enter the interior of the product.
NOTICE: Do not use abrasive cleaners/pads to clean the product.
To store, wind and secure the power cord using a twist tie or rubber band, and then place the
product in a cool, dry location.
TROUBLESHOOTING
PROBLEM POSSIBLE CAUSE
CORRECTIVE ACTION
Your heater shuts off 1. No electric power. 1. Be sure the power cord is
unexpectedly or fails t0| 2. One of the safety features plugged into a working
; electrical outlet.
operate. may have activated to
prevent overheating,
including the tip-over
safety switch.
2. Check your thermostat setting.
The heater may be off because
it has reached the desired
temperature setting.
INSTALLATION INSTRUCTIONS
NOTE: It is normal for the oil to move inside the radiator when moving the product.
1. Place the product upside down on a flat, stable surface, ensuring it will not tip over.
>
2. Remove the Wing Nuts from the U-Bolts.
3. Place a U-Bolt between the last and
second-to-last Fin of the product,
align the center holes in the rounded
side of the Caster Bracket with the
U-Bolt, and then tightly secure using
the Wing Nuts (Figures 1-3).
NOTICE: Do not over-tighten the Wing
Nuts.
4. Repeat Step 3 for the remaining —
U-Bolt/Caster Bracket between the
first and second Fin, ensuring the IL a
holes in the side of the Bracket align ww aa я wv M
with the protruding Bolts of the
product.
5. Set the product upright and wait at least three minutes for the oil to settle before
turning on.