Product Guide
Stainless Steel
Tabletop Grill
Model 465640212
For support and to register your grill,
please visit us at www.charbroil.com
If you have questions or need
assistance during assembly, please
call 1-800-241-7548.
IMPORTANT: Fill out the product record information below.
Serial Number
See rating label on grill for serial number.
Date Purchased
THIS GRILL IS FOR OUTDOOR USE ONLY.
DANGER
WARNING
If you smell gas:
This manual contains important information necessary
for the proper assembly and safe use of the appliance.
1.
2.
3.
4.
Read and follow all warnings and instructions before
assembling and using the appliance.
Shut off gas to the appliance.
Extinguish any open flame.
Open lid.
If odor continues, keep away from the appliance
and immediately call your gas supplier or your
fire department.
Failure to follow these instructions could result in
fire or explosion which could cause property
damage, personal injury or death.
WARNING
1. Do not store or use gasoline or other
flammable liquids or vapors in the vicinity of
this or any other appliance.
2. An LP cylinder not connected for use shall not
be stored in the vicinity of this or any other
appliance.
© 2012 Char-Broil, LLC • Columbus, GA 31902 • Printed in China • Assembly Instructions © 2012
Follow all warnings and instructions when using the
appliance.
Keep this manual for future reference
CAUTION
Some parts may contain sharp edges — especially as
noted in the manual! Wear protective gloves if necessary.
INSTALLER/ASSEMBLER: Leave these instructions with
consumer.
CONSUMER: Keep this manual for future reference.
42804977 • 07-13-12
TABLE OF CONTENTS
Product Record Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Safety Symbols. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Installation Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Use and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-6
Food Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Limited Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Parts List/ Parts Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-11
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13-14
Hardware List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
DANGER
1. Never operate this appliance unattended.
2. Never operate this appliance within 10ft (3m) of
any structure, combustible material or other gas
cylinder.
3. Never operate this appliance within 25 ft (7.5 m)
of any flammable liquid.
4. If a fire should occur, keep away from the
appliance and immediately call your fire
department. Do not attempt to extinguish an oil
or grease fire with water.
Failure to follow these instructions could result in
fire, explosion or burn hazard, which could cause
property damage, personal injury or death.
Registration Card . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Safety Symbols
CAUTION
The symbols and boxes shown below explain what each heading
means. Read and follow all of the messages found throughout
the manual.
For residential use only. Do not use for commercial
cooking.
WARNING
THIS GRILL IS FOR OUTDOOR USE ONLY.
WARNING: Indicates an potentially hazardous situation
which, if not avoided, could result in death or serious injury.
WARNING
DANGER
DANGER: Indicates an imminently hazardous situation
which, if not avoided, will result in death or serious injury.
CAUTION
CAUTION: Indicates a potentially hazardous situation or
unsafe practice which, if not avoided, may result in minor
or moderate injury.
CAUTION
• For residential use only. Not intended for commercial use.
• Do not leave appliance unattended. Keep children and
pets away from appliance at all times.
2
CALIFORNIA PROPOSITION 65
1. Combustion by-products produced when using
this product contain chemicals known to the State of
California to cause cancer, birth defects, and other
reproductive harm.
2. This product contains chemicals, including lead
and lead compounds, known to the State of
California to cause cancer, birth defects or other
reproductive harm.
Wash your hands after handling this product.
WARNING
Do not attempt to repair or alter the regulator/valve
for any “assumed” defect. Any modification to this
assembly will void your warranty and create the risk
of a gas leak and fire. Use only authorized
replacement parts supplied by manufacturer.
Installation Safety Precautions
• Use grill, as purchased, only with LP (propane) gas and the
regulator/valve assembly supplied.
• Grill installation must conform with local codes, or in their
absence of local codes, with either the National Fuel Gas
Code, ANSI Z223.1/ NFPA 54, Natural Gas and Propane
Installation Code, CSA B149.1, or Propane Storage and
Handling Code, B149.2. Storage and handling of liquefied
petroleum gasses must conform to LP Gas Code
ANSI /NFPA 58. Grill is not for use in or on recreational
vehicles and/or boats.
• All electrical accessories (such as rotisserie) must be
electrically grounded in accordance with local codes, or
National Electrical Code, ANSI / NFPA 70. Keep any
electrical cords and/or fuel supply hoses away from any hot
surfaces.
• This grill is safety certified for use in the United States and/or
Canada only. Do not modify for use in any other location.
Modification will result in a safety hazard.
• Do not leave appliance unattended. Keep children and
pets away from appliance at all times.
Safety Tips
 The use of alcohol, prescription or nonprescription drugs
may impair the consumer’s ability to properly assemble or
safely operate the appliance.
 When grill is not in use, disconnect 1 lb. cylinder.
 Never move grill while in operation or still hot. Allow the
appliance to cool before moving or storing.
 The regulator may make a humming or whistling noise
during operation. This will not affect safety or use of grill.
 If you have a grill problem see the Troubleshooting Section.
 Light burners. Check to make sure they are lit, close the lid
and warm up grill on high for 10 minutes. Curing of paint
and parts will produce an odor only on first lighting.
 Grill is not intended for and should never be used as a
heater.
 Clean grill often, preferably after each cookout. If a bristle
brush is used to clean any of the grill cooking surfaces,
ensure no loose bristles remain on cooking surfaces prior to
grilling. It is not recommended to clean cooking surfaces
while grill is hot.
 Use long-handled barbecue utensils and oven mitts to avoid
burns and splatters.
 If the regulator frosts, turn off grill and LP cylinder valve
immediately. This indicates a problem with the cylinder and it
should not be used on any product. Return to supplier!
USE AND CARE
WARNING
For Safe Use of Your Grill and to Avoid Serious
Injury:
• Do not let children operate or play near grill.
• Keep grill area clear and free from materials that burn (i.e.
gasoline, propane, or any other flammable liquid or gas).
• Do not block holes in bottom or back of grill.
• Check burner flames regularly.
• Never use regulator from this grill with any other LP
appliance.
• When cooking, the appliance must be on a level surface in
an area clear of combustible material.
• Use grill only in well-ventilated space. NEVER use in
Enclosed space such as carport, garage, porch, covered
patio, or under an overhead
structure
of any kind.
o
o
• Do not use charcoal or ceramic briquets in a gas grill.
• This appliance is not intended for and should never be used
as a heater.
• Use grill at least 3 ft. from any wall or surface.Maintain
10 ft. clearance to objects that can catch fire or sources of
ignition such as pilot lights on water heaters, live electrical
appliances, etc..
A
3 ft. (.6m) minimum
10 ft. recommended
• Apartment Dwellers:
Check with management to learn the requirements and fire
codes for using an LP gas grill in your apartment complex.
If allowed, use outside on the ground floor with a three (3)
foot clearance from walls or rails. Do not use on or under
balconies.
• NEVER attempt to light burner with lid closed. A
buildup of non-ignited gas inside a closed grill is
hazardous.
• Never operate grill with LP cylinder out of correct
position specified in assembly instructions
3
LP (Liquefied Petroleum Gas)
• Is nontoxic, odorless and colorless when produced. For Your
Safety, LP gas has been given an odor (similar to rotten
cabbage) so that it can be smelled.
• LP gas is highly flammable and may ignite unexpectedly
when mixed with air.
Propane Cylinder Use (1 lb. Disposable)
• Use only cylinder marked “Propane Fuel”.
• Cylinder must be constructed and marked in accordance with
the specifications for LP-gas cylinders of the U.S. Department
of Transportation (DOT) or the National Standard of Canada,
CAN/CSA-B339, Cylinders, Spheres and Tubes for the
Transportation of Dangerous Goods.
• Save cylinder cap and reinstall when not in use.
• Cylinder supply system must be arranged for vapor
withdrawal. Gas cylinder must be upright in use.
Propane Cylinder Installation/Removal
Propane Cylinder Installation:
1. Remove cap from end of Propane cylinder (sold separately).
2. Cap should be kept on cylinder when not in use to prevent dirt
and debris from entering Regulator/Valve.
3. Check end of cylinder attachment for dirt and debris. Clean out
if necessary.
4. Insert threaded end of Propane Cylinder into Regulator/Valve
and hand-tighten turning cylinder clockwise as shown below.
DO NOT USE TOOLS! Over tightening can damage threads
on Regulator/Valve.
5. Perform a leak test.
Turn propane
cylinder
CLOCKWISE to
install.
Propane Cylinder
(not included)
Propane Cylinder Removal:
Propane Gas Cylinders
1. Turn regulator OFF.
- Your grill is designed to operate with one 16.4 oz. disposable
cylinder (Dot 39 Cylinder) that is 7 3/8” high (not included).
Do not attempt to refill any 16.4 oz. disposable fuel
cylinders.
2. Allow Grill to cool.
- The cylinder must be installed, transported and stored in an
upright position and should not be dropped or handled
roughly.
- For outdoor use only, If stored indoors, Detach and leave
cylinder outdoors.
- When the propane gas cylinder is not disconnected from the
appliance, the appliance and cylinder must be stored
outdoors in a well-ventilated space.
- The cylinder should never be transported or stored where
temperature can reach 125 F (51 C).
- Cylinders must be stored outdoors out of the reach of
children.
- A disconnected LP cylinder in storage or being transported
must have a safety cap installed. Failure to use safety cap as
directed may result in serious personal injury and/or property
damage.
- Do not store an LP cylinder in enclosed spaces such as a
4
3. Remove the propane cylinder by turning counter-clockwise until
disengaged from the Regulator/Valve.
4. Install cap on cylinder. Cap should be kept on cylinder when not in
use to prevent dirt and debris from entering Regulator/Valve.
Leak Testing (1 lb. Disposable) IMPORTANT!
• During leak test, keep grill away from open flames or sparks
and do not smoke. Grill must be leak tested outdoors in a well
ventilated area.
• Leak test must be repeated each time gas cylinder is replaced
or after storage.
Materials needed include clean paint brush and 50/50 soap and
water solution. Use mild soap and water.
Do not use
household cleaning agents. Damage to components can
result.
1. Be sure control knob on regulator is in "OFF" position.
2. Brush soapy solution onto connection between gas cylinder
and regulator at (A).
If growing bubbles appear, there is a leak. Retighten
connection and repeat steps 1 and 2.
A
If you cannot stop a leak, remove gas
cylinder from regulator and check for
damaged threads, dirt and debris on
regulator and gas cylinder. Also check to
see if anything is obstructing flow of gas at
regulator and gas cylinder openings.
Remove any obstruction that may be
found and repeat leak test. If threads are
damaged on either regulator or gas
cylinder, replace. Order new parts by
giving the serial, model number and name
of items needed to the Grill Service Center
at 1-800-232-3398.
CAUTION
SPIDER ALERT!
If you notice that your grill is getting hard to light or that the
flame isn’t as strong as it should be, take the time to check and
clean the burner.
In some areas of the country, spiders or small insects have been
known to create “flashback” problems. The spiders spin webs, build
nests and lay eggs in the grill’s burner tube obstructing the flow of
gas to the burner. The backed-up gas can ignite in the burner tube.
This is known as a flashback and it can damage your grill and even
cause injury.
Match Lighting Instructions
Important! Raise lid to open position.
Attempting to light burner with lid closed may cause an
explosion. Do not expose any part of your body or clothing
directly above cooking area when lighting.
1. Read all instructions before lighting.
2. From the right side of the grill, place lighted wooden match
through lighter/ventilation holes in right side of the grill.
3. While holding match next to the burner, turn control knob to
the HIGH position. Grill will ignite.
4. If ignition does NOT occurs in 5 seconds, turn the burner
controls OFF, wait 5 minutes and repeat the lighting
procedure.
5. Observe burner flames through openings in heat distribution
plate. Make sure burner ignites and stays lit on both sides.
6. Preheat grill for 10 minutes with lid closed. Using control
knob on Regulator/Valve, adjust flame to desired height for
cooking.
To prevent flashbacks and ensure good performance the burner and
burner tube should be removed from the grill and cleaned before
use whenever the grill has been idle for an extended period.
IF YOU EXPERIENCE THE FOLLOWING:
1. Smell gas.
2. Burner will not light.
3. A small yellow flame from burner (should be blue).
4. Fire coming from around or behind control knob.
STOP!
IMMEDIATELY TURN OFF GAS AT LP CYLINDER!
1. Wait for grill to cool.
2. Use a 12” pipe cleaner to clean out the burner tube.
Igniter Lighting Instructions
Important! Raise lid to open position.
Do not lean over the grill while lighting.
Attempting to light burner with lid closed may cause an
explosion. Do not expose any part of your body or clothing
directly above cooking area when lighting.
1. Read all instructions before lighting.
2. Open lid during lighting
3. Turn control knob to HIGH position.
4. Push igniter button rapidly.
5. If ignition does NOT occurs in 5 seconds, turn the burner
controls OFF, wait 5 minutes and repeat the lighting
procedure.
6. Observe burner flames through openings in heat distribution
plate. Make sure burner ignites and stays lit on both sides.
7. Preheat grill for 10 minutes with lid closed. Using control
knob on Regulator/Valve, adjust flame to desired height for
cooking.
CAUTION
If the burner flame should be extinguished
accidentally, turn the control knob to the
OFF position and open the lid. DO NOT
press the ignitor button. Wait 5 minutes
before attempting to relight the grill.
CAUTION
If ignition does NOT occur in 5 seconds, turn the
burner control OFF, wait 5 minutes and repeat the
lighting procedure. If the burner does not ignite with
the valve open, gas will continue to flow out of the
burner and could accidently ignite with risk of injury.
Burner Flame Check
Light burner. Make sure burner stays lit while rotating the
control knob from HIGH to LOW. Always check flame prior
to each use.
High
Low
5
Grill Maintenance
CAUTION
• Putting out grease fires by closing the lid is not possible.
Grills are well ventilated for safety reasons.
• Do not use water on a grease fire. Personal injury may
result. If a grease fire develops, turn knobs and LP
cylinder off.
• Do not leave grill unattended while preheating or burning
Off food residue on HIGH. If grill has not been regularly
cleaned, a grease fire can occur that may damage the
product.
- Allow grill to cool before cleaning. Frequency of cleaning is
determined by how often grill is used.
- DO NOT use self-cleaning oven to clean any grill part.
Extreme heat would remove any chrome plating and cause
premature rusting.
- Meat drippings will solidify in bottom of grill after a few uses.
This residue should be removed regularly. Failure to do so
could cause overflow at the grease cup and increase
the chance of a grease fire.
• This appliance will be hot during and after use. Use
insulated oven mitts or gloves for protection from hot
surfaces or splatter from cooking liquids.
Before Cooking For The First Time
Operate grill for 15 minutes with the grill lid closed and the gas
control on HIGH. This will heat-clean internal components and
Turning Grill Off
- After cooking, turn the grill off by rotating the control knob to
OFF. Control knob should pop up in the OFF position. If
control knob does not pop up, disconnect cylinder to turn grill
off and replace the Regulator/Valve.
Storing Grill
- Allow grill to cool completely.
- Remove Propane Cylinder and install protective cap over
outlet threads.
- Store the Propane Cylinder outside.
- Remove Regulator/Valve from grill to help keep dirt out of the
propane cylinder probe.
- Store Regulator/Valve in a heavy plastic bag and place inside
- When cleaning grill, cover work area with newspaper.
Open the grill lid and remove cooking grate and flame tamer
bar. Loosen residue with scraper or putty knife. Wipe away
loosened residue with paper towels.
- Inside surface of grill may be cleaned with a strong solution
of detergent and water applied with a scrub brush. Cooking
grate may be cleaned with a wire brush. Thoroughly rinse
grill with water and allow to completely air-dry before using
Again.
- Clean grill often, preferably after each cookout. If a bristle
brush is used to clean any of the grill cooking surfaces,
ensure no loose bristles remain on cooking surfaces prior to
Grilling. It is not recommended to clean cooking surfaces while
grill is hot.
Food Safety
Food safety is a very important part of enjoying the outdoor
cooking experience. To keep food safe from harmful bacteria,
follow these four basic steps:
Clean: Wash hands, utensils, and surfaces with hot soapy
water before and after handling raw meat and poultry.
Separate: Separate raw meats and poultry from ready-to
eat foods to avoid cross contamination. Use a clean platter
and utensils when removing cooked foods.
Cook: Cook meat and poultry thoroughly to kill bacteria.
Use a thermometer to ensure proper internal food
temperatures.
Chill: Refrigerate prepared foods and leftovers promptly.
For more information call: USDA Meat and Poultry
Hotline at 1-800-535-4555 In Washington, DC (202)
720-3333, 10:00 am-4:00 pm EST.
6
LIMITED WARRANTY
This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this
product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods
indicated below beginning on the date of purchase*. The manufacturer reserves the right to require that defective parts be returned, postage and or
freight pre-paid by the consumer for review and examination.
SCOPE OF COVERAGE
All Parts
PERIOD OF COVERAGE
90 days from date of purchase*
TYPE OF FAILURE COVERAGE
PERFORATION, MANUFACTURING,
AND MATERIAL DEFECTS ONLY
*Note: A dated sales receipt WILL be required for warranty service.
The original consumer-purchaser will be responsible for all shipping charges for parts replaced under the terms of this limited warranty.
This limited warranty is applicable in the United States and Canada only, is only available to the original owner of the product and is not transferable.
Manufacturer requires proof of your date of purchase. Therefore, you should retain your sales slip or invoice. Registering your product is not a
substitute for proof of purchase and the manufacturer is not responsible for or required to retain proof of purchase records.
This limited warranty applies to the functionality of the product ONLY and does not cover cosmetic issues such as scratches, dents, corrosions or
discoloring by heat, abrasive and chemical cleaners or any tools used in the assembly or installation of the appliance, surface rust, or the
discoloration of stainless steel surfaces. RUST is not considered a manufacturing or materials defect.
This limited warranty will not reimburse you for the cost of any inconvenience, food, personal injury or property damage.
ITEMS MANUFACTURER WILL NOT PAY FOR:
1. Shipping cost, standard or expedited, for warranty and replacement parts
2. Service calls to your home.
3. Repairs when your product is used for other than normal, single-family household or residential use.
4. Damage, failures, or operating difficulties resulting from accident, alteration, careless handling, misuse, abuse, fire, flood,
acts of God, improper installation or maintenance, installation not in accordance with electrical or plumbing codes, or use
of products not approved by the manufacturer.
5. Any food loss due to product failures or operating difficulties.
6. Replacement parts or repair labor costs for units operated outside the United States or Canada.
7. Pickup and delivery of your product.
8. Repairs to parts or systems resulting from unauthorized modifications made to the product.
9. The removal and/or reinstallation of your product.
DISCLAIMER OF IMPLIED WARRANTIES and LIMITATION OF REMEDIES
Repair or replacement of defective parts is your exclusive remedy under the terms of this limited warranty. In the event of parts availability issues,
the manufacturer reserves the right to substitute like or similar parts that are equally functional.
Manufacturer will not be responsible for any consequential or incidental damages arising from the breach of either this limited warranty or any
applicable implied warranty, or for failure or damage resulting from acts of God, improper care and maintenance, grease fire, accident, alteration,
replacement of parts by anyone other than Manufacturer, misuse, transportation, commercial use, abuse, hostile environments (inclement weather,
acts of nature, animal tampering), improper installation or installation not in accordance with local codes or printed manufacturer instructions.
THIS LIMITED WARRANTY IS THE SOLE EXPRESS WARRANTY GIVEN BY THE MANUFACTURER. NO PRODUCT PERFORMANCE
SPECIFICATION OR DESCRIPTION WHEREVER APPEARING IS WARRANTED BY MANUFACTURER EXCEPT TO THE EXTENT SET
FORTH IN THIS LIMITED WARRANTY. ANY IMPLIED WARRANTY PROTECTION ARISING UNDER THE LAWS OF ANY STATE,
INCLUDING IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR USE, IS HEREBY
LIMITED IN DURATION TO THE DURATION OF THIS LIMITED WARRANTY.
Neither dealers nor the retail establishment selling this product has any authority to make any additional warranties or to promise remedies
in addition to or inconsistent with those stated above. Manufacturer's maximum liability, in any event, shall not exceed the purchase price of the
product paid by the original consumer.
NOTE: Some states do not allow an exclusion or limitation of incidental or consequential damages, so some of the above limitations or exclusions
may not apply to you. This limited warranty gives you specific legal rights as set foth herein. You may also have other rights which vary from state
to state. In the state of California only, if refinishing or replacement of the product is not commercially practicable, the retailer selling this product or
the Manufacturer will refund the purchase price paid for the product, less the amount directly attributable to use by the original consumer-purchaser
Prior to discovery of the nonconformity. In addition, in the state of California only, you may take the product to the retail establishment selling this
product in order to obtain performance under this limited warranty.
If you wish to obtain performance of any obligation under this limited warranty, you should
write to:
Consumer Relations
P. O. Box 1240
Columbus, GA 31902-1240
Consumer returns will not be accepted unless a valid Return Authorization is first acquired. Authorized returns are clearly marked on the outside of
the package with an RA number and the package is shipped freight/postage pre-paid. Consumer returns that do not meet these standards will be
refused.
WS_1 Rev03
7
Parts List
A
K
G
B
C
H
I
J
D
H
E
F
L
R
P
O
M
S
N
Q
Key
Qty
Key
Qty
A
1
Description
GRILL LID, W/ TOP HINGES
L
2
Description
FLAME TAMER SUPPORT
B
1
COOKING GRATE
M
1
GREASE TRAY RAIL
C
1
FLAME TAMER
N
1
GREASE TRAY
D
1
HEAT SHIELD
O
1
LEG, RIGHT FRONT, F/ IGNITOR
E
1
FIREBOX
P
1
LEG, LEFT REAR
F
1
BURNER ASSEMBLY
Q
2
LEG, RIGHT REAR, LEFT FRONT
G
2
HINGE, F/ GRILL LID, BOTTOM
R
1
IGNITOR
H
2
SIDE HANDLE
S
1
ELECTRODE, W/ WIRE
I
1
REGULATOR
J
1
LID HANDLE
K
2
LID HANDLE BEZEL
NOT Pictured
8
…
1
HARDWARE PACK
…
1
ASSEMBLY MANUAL, ENGLISH
…
1
ASSEMBLY MANUAL, FRENCH
…
1
LID HARDWARE
Tools required for assembly:
Adjustable Wrench - Not provided
Phillips screwdriver - Not provided
Assembly
1
Open lid and remove all parts packed inside the grill. Using 8 M6 x 10mm screws, 8 m6 lock washers and 8 M6 flat washers, install the legs
onto the firebox as shown.
NOTE: the leg with the large igniter mounting hole must be on the front, RH side.
CAUTION
Some parts may contain sharp edges! Wear protective
gloves if necessary.
Leg with igniter mounting hole
2
Using 2 M6x15mm screws and 2 M6 flange nuts, attach the side handle and flame tamer support bracket to one side of the firebox.
Repeat for the opposite side of the firebox.
9
Assembly (Con’t.)
Bezel
3
Attach the lid handle and handle bezels to the lid using
2 handle sleeves and 2 M6x20mm screws as shown
4
Remove the igniter nut from the pushbutton igniter. Insert the pushbutton igniter through the mounting hole in the
right, front leg. Secure the igniter with the igniter nut from behind the leg.
Next push the igniter wire onto the pushbutton igniter.
Next, place the flame Tamer onto the flame tamer brackets as shown. Place the cooking grate into the firebox.
NOTE: the center support wire on the cooking grate should be under the grate when installed.
10
Handle
Sleeve
Assembly (Con’t.)
5
- Before assembly, inspect Regulator for damage, dirt or debris
accumulation. Clean out if present.
- With knob pointing down, insert Regulator/Valve into end of
Burner.
Notch in Regulator/Valve MUST engage dimple in end of
Burner.
Rotate clockwise to lock
- Once Regulator/Valve has completely engaged Burner, turn
Regulator/Valve clockwise to lock in position with knob pointing
Up.
Regulator/Valve
- Install the grease tray onto the grease tray rails as shown below.
Regulator/Valve
Locked in position
6
- Remove cap from end of Propane cylinder (sold separately). Cap
should be kept on cylinder when not in use to prevent dirt and debris
from entering Regulator/Valve. Check end of cylinder attachment
for dirt and debris. Clean out if necessary.
- Insert threaded end of Propane Cylinder into Regulator/Valve and
hand-tighten. DO NOT USE TOOLS! Over tightening can damage
threads on Regulator/Valve.
- Perform a leak test.
Propane Cylinder
(not included)
11
NOTES:
12
EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.
Emergencies
Possible Cause
Prevention/Solution
Gas leaking from LP
cylinder.
•Mechanical failure due to rusting or
mishandling.
•Replace LP cylinder.
Grease fire or
continuous excessive
flames above cooking
surface.
• Too much grease buildup in burner area.
• Turn off control knob. Leave lid open to
Allow flames to die down. After cooling, clean food particles and
excess grease from inside firebox area, grease cup, and other
surfaces.
Possible Cause
Prevention/Solution
Troubleshooting
Problem
Burner(s) will not light
using ignitor.
GAS ISSUES:
• Obstruction in burner.
• Ensure burner tubes are not obstructed with spider webs or other
matter. See cleaning section of Use and Care.
Continued on next
page.
• No gas flow.
Burner will not Light.
• Out of Propane
• Replace Cylinder.
• Regulator not fully tightened to cylinder.
• Retighten cylinder.
• Inspect burner for obstructions.
• See ‘Care and Use’ for burner cleaning instructions.
• Grill not sufficiently preheated before
turning to “LOW”.
• See ‘Care and Use’ section “Before Cooking For The First Time’.
Flames burns out on
“LOW”.
ELECTRICAL ISSUES:
•Electrode cracked or broken; “sparks at
crack.”
• Make sure LP cylinder is not empty. If LP cylinder is not empty,
refer to “Sudden drop in gas flow.”
• Replace electrode(s).
•Electrode tip not in proper position.
Main Burner:
• Tip of electrode should be pointing toward gas port opening on
burner. The distance should be 1/8” to 1/4”. Adjust if necessary.
•Wire and/or electrode covered with
cooking residue.
•Clean wire and/or electrode with rubbing alcohol and clean swab.
•Wires are loose or disconnected.
•Reconnect wires or replace electrode/wire assembly.
•Wires are shorting (sparking) between
ignitor and electrode.
•Replace ignitor wire/electrode assembly.
13
Troubleshooting (continued)
Problem
Possible Cause
Prevention/Solution
Burner(s) will not light
using ignitor.
•Push-button sticks at bottom.
•Replace ignitor.
•Sparking between ignitor and electrode.
•Inspect wire insulation and proper connection. Replace wires if
insulation is broken.
Burner(s) will not
match light.
•See “GAS ISSUES:” on previous page.
•Match will not reach.
•Use long-stem match (fireplace match).
•Improper method of match-lighting.
•See “Match-Lighting” section of Use and Care.
Low flame, drop in gas
flow.
•Out of gas.
•Check for gas in LP cylinder.
Flames blow out.
•High or gusting winds.
•Turn front of grill to face wind or increase flame height.
•Low on LP gas.
•Replace LP cylinder.
•Grease buildup.
•Clean burners and inside of grill/firebox.
•Excessive fat in meat.
•Trim fat from meat before grilling.
•Excessive cooking temperature.
•Adjust (lower) temperature accordingly.
Persistent grease fire.
•Grease trapped by food buildup around
burner system.
•Turn knob to OFF. Leave lid in position
and let fire burn out. After grill cools, remove and clean all parts.
Flashback...
(Fire in burner tube).
•Burner and/or burner tubes are blocked.
•Turn knob to OFF. Clean burner tube. See burner
cleaning section of Use and Care.
Flare-up.
Hardware
Lid Handle Bezel
Qty. 2
M6x 15mm Screw
Qty. 4
14
M6x 10mm Screw
Qty. 8
M6 Flange Nut
Qty. 4
M6x20mm Screw
Qty. 2
M6 Flat Washer
Qty. 8
Handle Sleeve
Qty. 2
M6 lock Washer
Qty. 8
Please register your product online at:
Registre su producto en línea en:
Veuillez enregistrer votre produit à l'adresse:
www.charbroil.com/register
(If you register online, you do not need to send in this registration card.)
(Si registra en línea, no es necesario enviar esta tarjeta de registro.)
(Si vous enregistrez votre produit en ligne, il n'est pas nécessaire d'envoyer la carte
PLEASE FILL OUT THIS CARD AND ATTACH A COPY OF YOUR SALES RECEIPT. RETURN IT WITHIN10 DAYS OF PURCHASE.FOR WARRANTYSERVICEPROOF OF PURCHASE
WILL BE REQUIRED.THIS WARRANTYIS NON‐TRANSFERABLE.
LLENE ESTA TARJETA Y DEVUELVALADENTRO DE LOS 10 DIAS DE LA COMPRA.PARA EL SERVICIODE GARANTIAES NECESARIOQUE PRESENTESU COMPROBANTEDE
COMPRA.CONSERVELA FACTURA. ESTA GARANTIAES INTRANSFERIBLE.
VEUILLEZCOMPLETERCETTE CARTE ET LA RETOURNERDANS LES 10 JOURS SUIVANTL’ACHAT. POUR OBTENIRLE SERVICESOUS GARANTIE,UNE PREUVED’ACHAT DOIT
ETRE PRESENTEE.VEUILLEZCONSERVERVOTRE FACTURE. LA PRESENTEGARANTIEN’EST PAS TRANSFERABLE.
~ PLEASE PRINT ~ IMPRIMAPOR FAVOR ~ S'IL VOUS PLAÎT IMPRIMER~
*Required | Necesario | Exigé
*❶ First Name | Nombre | Prénom
Initial | Inicial | Initiale
Last Name | Apellido | Nom de Famillie
Address (number & street) | Dirección (número y calle) | Adresse (numéro et rue)
Apt Number | Nº de apart | Nº d’appt.
City | Cludad | Ville
Zip Code | Código Zip | Code Postal
State | Estado | Province
*❷ E‐mail Address | Dirección de correo electrónico | Adresse électronique
* ❸ Phone Number | Número telefónico | Numéro de téléphone
*❹ Model Number | Número de modelo | Numéro de modèle
STICKERON PRODUCT
Serial Number | Número de serie| Numéro de série
❻
Date of Purchase | Fecha de compra | Date de l’achat
❼
Store Name | Nombre de la tienda | Nom du magasin
❾
Your Gender | Sexo | Sexe:
$
❽
Purchase Price | Precio de compra | Prix d’achat
 Male | Masculino | Masculin
 Female | Femenino | Féminin
❿
1.
2.
3.
4.
5.
6.
Which product are you registering?
¿Qué producto está registrando?
Quel produit enregistrez‐vous?
 Gas Grill | Parrilla a gas | Gril au gaz
 Electric Grill | Parrilla eléctrica | Gril électrique
 Smoker | Ahumador | Fumoir
 Charcoal Grill | Parrilla a carbón | Barbecue au charbon
 Cooker/Fryer | Cocina/freidora | Cuiseur/Friteuse
 Other | Otro | Autre
*❺Attachcopyofyour
salesreceipthere.
Adjunteaquilacopia
desurecibode
compra
Veuillezattacherune
copiedevotrereçu
ici.
Mail to: / Enviar a: / Envoyer à :
Char‐Broil Warranty Registration
P.O. Box 1240
Columbus, GA 31902‐1240
We respect your privacy. | Respetamos su privacidad. | Nous respectons votre vie privée.



If you prefer not to receive special offers and promotions from Char‐Broil, please check here:
Marque aquí si no desea recibir ofertas y promociones especiales de Char‐Broil:
Si vous préférez ne pas recevoir d’informations concernant des offres spéciales et des
promotions de Charbroil, veuillez cocher ici:
Thank you for completing this questionnaire. | Gracias por completer este cuestionario. | Merci d’avoir bien voulu remplir ce questionnaire.
REGTEMP REV06