Project ________________________________
™
Cleveland
Item __________________________________
STEAMCUB™ BOILERLESS
CONNECTIONLESS STEAMER
Approval _______________________________
Quantity _______________________________
FCSI Section ____________________________
Date __________________________________
MODEL: 1SCE
TM
SteamCub Plus
PRESSURELESS STEAM COOKER,
RETHERMALIZER & HOLDING CABINET
Cleveland Standard Features
I Boilerless Pressureless Steam Cooker, Holding Cabinet and
Rethermalizer.
I Capacity: Full Size Steam Table Pans:
• Five: 2 1/2" x 12" x 20" (1/1 GN, 65mm)
I
I
I
I
I
I
I
I
I
I
• Ten: 1" x 12" x 20" (1/1GN, 40mm)
Easy installation, no drain line or water connections are
required.
Programmable Preheat and Holding Cycle Temperature
Controls with Compensating Thermostat.
• Timer settings for 10 minute, 1 minute or 10 second intervals
• Digital Time-Temperature and Low Water Indicator Display
Three Versatile Operating Modes.
• Steam and Hold
• Holding Only: Preset at 160˚ F (71˚ C)
• Constant Steaming
6" (152mm) Skid Resistant Stainless Steel Adjustable Legs
with Flanged Feet.
8 gauge stainless steel inner cooking compartment, 14
gauge stainless steel outer compartment with two piece
compartment door for an airtight, leak-proof seal.
12 kW total output, with easy to remove 1 kW heating
elements (9ea) cast into aluminum bocks.
Electronic Low-Water Shut-Off Safety Indicator with audible
alarm, High Temperature Safety Shut-Off and LED "Heat On"
Indicator Light.
Separate Power ON/OFF Control includes an Automatic PreHeat when power is turned "ON".
Easy-Access Manual Drain Valve located in front, Pan Slide
Guides located under unit to fit 12" x 20" (1/1GN) Pans.
Includes one 4" x 12" x 20
Approvals: cUL, NSF #4.
Short Form Specifications
Shall be a Cleveland SteamCub Plus™ , Model 1SCE, one compartment
counter top steamer, holding cabinet and rethermalizer model number 1SCE.
Electronic controls with three operating modes: constants steaming, steamhold and holding only. 12 kW, 208 volts, 3 phase. Audible low water and high
temperature safety indicator. 8 gauge stainless steel inner cooking compartment, 14 gauge stainless steel outer compartment with two piece compartment door.
Options & Accessories
Ë Equipment Stand Model UniStand34.
Ë POSK Pull-Out Shelf Kit for UniStands (P/N 111724).
Ë URK Pan Rack Kit UniStands (P/N 111726).
Ë Optional Voltages, 480 Volt (VOS2).
Ë 6 kW total Output Six - 1kW heating elements.
Ë Single Phase Operation.
SECT.
1333 East 179 St.,
Tel: 1-216-481-4900
Web Site: www.ClevelandRange.com
Cleveland, Ohio, U.S.A. 44110
Fax: 1-216-481-3782
Email: Steam@ClevelandRange.com
I
3
PAGE
0511
WATER QUALITY REQUIREMENT
The recommended minimum water quality standards whether
untreated or pre-treated, based upon 10 hours of use per day,
and a Daily Blowdown, are as follows:
TOTAL DISSOLVED SOLIDS less than 60 parts per million
TOTAL ALKALINITY
less than 20 parts per million
SILICA
less than 13 parts per million
pH FACTOR
greater than 7.5
CHLORINE
less than 30 parts per million
Consult a local water treatment specialist for an on site water
analysis for recommendations concerning steam generator
feed water treatment (if required), in order to remove or
reduce harmful concentrations of minerals. The use of highly
mineralized water will mean that more frequent servicing of
the steam generator will be necessary. The fact that a water
supply is potable is not proof that it will be suitable for the
generator.
• Compartment has capacity for:
Five, 12˝ x 20˝ x 21⁄2˝ deep Cafeteria Pans.
21.625"
549mm
23.100"
587mm
17.434"
443mm
24.858"
631mm
FRONT
VIEW
RIGHT
SIDE VIEW
REAR
VIEW
30.890"
785mm
1.500"
38mm
25.361"
644mm
1.574"
40mm
ELECTRICAL
WATTS
2.100"
53mm
(Contact factory if installed above 3,500 feet)
VOLTS PHASE
WIRES
D
Standard Wattage
Three Phase - 12 kW Standard
10,725
208
3C
12,000
220
3
14,280
240
3H
10,085
440
3
12,000
480
3
C13C2
3
3
3
3
CYCLE
HERTZ
60
60
60
60
60
AMPS
29.8
31.5
34.4
13.2
14.4
SUPPLY CONNECTION
WIRE SIZE (COPPER)*
8
8
8
12
12
WATTS
VOLTS PHASE
Standard Wattage
Single Phase - 12 kW Standard
10,725
208
1
12,000
220
1
14,280
240
1
10,085
440
1
12,000
480
1
WIRES
CYCLE
HERTZ
AMPS
SUPPLY CONNECTION
WIRE SIZE (COPPER)*
2
2
2
2
2
60
60
60
60
60
51.6
54.5
59.5
22.9
25.0
6
4
4
10
8
* For supply connection use only copper wire suitable for at least 75˚C. (167˚F).
Note: Consult local authorities for venting and installation requirements.
∗ For supply connection use only copper wire suitable for at least 75°C (167°F).
NOTES:
Cleveland Range reserves right of design improvement or modification, as warranted.
Many regional, state and local codes exist and it is the responsibility of the owner and installer to comply with the codes.
Cleveland Range equipment is built to comply with applicable standards for manufacturers. Included among those approval agencies are U.L/NSF#4 and CSA (AGA, CGA).
I
4
(NOT TO SCALE)
SECT. PAGE
0511
Litho in U.S.A.