Packing List
Specifications
Before you begin installing your card, please make
sure that the following materials have been shipped:
Standard SBC Functions
• CPU: Intel LGA 775 Celeron D up to 3.06 GHz, Pentium
4 up to 3.4 GHz, FSB 533/800 MHz.
• 1 PCA-6009 Pentium® 4/Celeron® D processorbased single board computer
• BIOS: Award 4 Mb Flash memory BIOS
• 1 PCA-6009 Startup Manual
• System Memory: Up to 2 GB; two 240-pin DIMM sockets. Supports dual channel DDRII 400/533 SDRAM.
• 1 CD with driver utility and manual (in PDF format)
• Chipset: Intel 915GV with ICH6
• 1 FDD cable
p/n: 1700340640
• 1 Ultra ATA 66/100 HDD cables
p/n: 1701400452
• 2 Serial ATA HDD data cables
p/n: 1700071000
• 2 Serial ATA HDD power cables
p/n: 1703150102
• SATA/IDE Interface: Two on-board serial ATA connectors with data transmission rate up to 150 MB/Sec and
supporting Advanced Host controller interface (AHCI)
technology. One IDE hard disk drives or two enhanced
IDE devices. Supports PIO mode 4 (16.67MB/s data
transfer rate) and ATA 33/66/100 (33/66/100MB/s data
transfer rate.) BIOS enabled/disabled.
• 1 ATX 12V power converter
cable
p/n: 170304015K
• FDD interface: Supports one FDD
• 1 Printer (parallel) port & COM
port cable kit
p/n: 1701260305
• Parallel port: One parallel port, supports SPP/EPP/
ECP mode
• 1 Y cable for PS/2 keyboard and
PS/2 mouse
p/n: 1700060202
• Keyboard/mouse connector: Supports one standard
PS/2 keyboard and mouse
• 1 USB cable with 4 ports
p/n:1700000719
• Serial ports: Two serial RS-232 ports
• Watchdog timer: 255 level timer intervals
• Warranty Card
Warning: Advantech highy recommends attaching only
the dedicated LGA775 CPU coolers, Advantech
part numbers ,1750000332 or 1750000334 both of
which have a high MTBF and reliability. Using nonrecommended CPU coolers, like Intel boxed CPU
coolers, may result in PCB warping and CPU card
overheating.
If any of these items are missing or damaged, contact
your distributor or sales representative immediately.
Note:
Acrobat Reader is required to view any PDF file.
Acrobat Reader can be downloaded at:
www.adobe.com/Prodindex/acrobat/readstep.html
(Acrobat is a trademark of Adobe)
For more information on this and other Advantech
products, please visit our website at:
http://www.advantech.com
• USB (2.0): Supports up to four USB 2.0 ports with the
one USB 2.0 cable kits included
VGA/LCD Interface
• Chipset: Chipset integrated VGA controller
• Display memory: Dynamically shared system memory
up to 128 MB.
• Resolution: Up to 2048x1536@ 85 MHz refresh
Ethernet Interface
• Controller: Broadcom BCM5721
• Single 10/100/1000Base-T:Broadcom BCM5721
Note: PCA-6009VG uses on-board LAN2 controller
Mechanical and Environmental
• Dimensions (L x W): 338 x 122 mm
• Power supply voltage: +5 V ± 12 V
• Power requirements: Maximum: +5V:6.64A,
+12V:12.59A (Intel Pentium4 3.4GHz with 800MHz
FSB, 2 X256 MB, 2 X 512 MB DDRII 533 SDRAM)
• Operating temperature: 0 ~ 60° C (depending on
CPU)
• Weight: 0.5 kg (weight of board)
http://www.advantech.com/eplatform
For technical support and service, please visit our
support website at:
http://www.advantech.com/support
This manual is for the PCA-6009 series Rev. A1
Part No. 2002600910
Printed in Taiwan
1st Edition
June 2006
PCA-6009 Startup Manual
1
PCA-6009 Full-sized PCI/ISA-bus LGA775 Pentium® 4/Celeron® D Processor
Card with VGA/Gigabit LAN/HISA (800 MHz FSB)CA-6184-B1 Socket 478 Pentium
PCA-6009 Full-sized PCA/ISA-bus LGA775
Pentium® 4/Celeron® D Processor Card with
VGA/Gigabit LAN/HISA (800 MHz FSB)
Jumpers and Connectors
The board has a number of jumpers that allow you to
configure your system to suit your application.The
table below lists the function of each of the jumpers
and connectors.
Label
Function
J1:
J2:
CN1
CN3
CMOS clear function
Watchdog timer output option
Primary IDE connector
FDD connector, Supports 360K/1.2M/720K/
1.44M FDD x 2
Parallel port, Parallel port x 1, supports SPP/
EPP/ECP mode
USB port 1,2
VGA connector
Ethernet connector 1
Serial port: COM1; RS232 (D-sub 9-pin connector)
Serial port: COM2; RS232 (9-pin connector)
PS/2 keyboard and mouse connector
Cable length: 20 meters
External keyboard connector (6-pin)
Infrared connector
Power LED
External speaker
Reset connector
HDD LED connector
ATX feature connector
ATX soft power switch (PS_ON)
HW Monitor Alarm
Close: Enable OBS Alarm
Open: Disable OBS Alarm
AC97 Audio connector
USB ports 3,4
Case Open
Front Panel LAN indicator connector
CPU FAN connector (4-pin)
Serial ATA0
Serial ATA2
ATX 12V Auxiliary power connector
(for CPU)
CN4
CN6
CN7
CN8
CN9
CN10
CN11
CN12
CN13
CN16
CN17
CN18
CN19
CN20
CN21
CN22
CN43
CN63
CN64
CN65
CN68
SA0
SA2
ATX1
J1: CMOS clear function
Pins
Result
1-2 (closed) Keep CMOS data*
2-3 (short) Clear CMOS
*default setting
J2: Watchdog timer output option
Closed pins Result
1-2
IRQ11
2-3
System reset *
IRQ11
1 - 2 closed
System Reset
2 - 3 closed
*default setting
Software Installation
The CD disc contains a driver installer program that
will lead you through the installation of various device
drivers needed to take full advantage of your CPU
card.
Caution
The computer is supplied with a battery-powered
Real-time Clock circuit. There is a danger of explosion if battery is incorrectly replaced. Replace only
with same or equivalent type recommended by the
manufacturer. Discard used batteries according to
manufacturer's instructions.
2
PCA-61009 Startup Manual
1. This device may not cause harmful interference,
and
Safety Information
2. This device must accept any interference received,
including interference that may cause undesired operation
This device complies with the requirements in Part 15
of the FCC rules. Operation is subject to the following
two conditions:
CN19
CN17
CN16
CN21CN18
CN68
ATX1
B
DDRII 4
DDRII 2
SA0
CN3 SA2
CN1
CN6 CN63
CN4
CN20
J2
CN13 J1
CN22
CN43
CN12
CN10
CN65
CN9
CN7
CN11
Board Layout: Jumper and Connector Locations
PCA-6009 Startup Manual
3