Page 1 of 3
EQUIPMENT PERFORMANCE INSPECTION
.
- . .( Authorhed
.. -Submit A l l Completed Forms To:
Service Company
I
1
Vulcan-Hart / Wolf Range
P O . Box 696
Louisville. KY 40201
Ann: Product Service Department
-
--
Name:
Address:
City: -Phone # ( )
-
State
ZIP: -
-.
.
Section 1 -Customer Information
Customer: Address:
City:
A
-
--.
Contact Name:
Phone #:
State: -__ Zip:
--
Caution: The following procedures should only be preformed by qualified and authorized service te,
is assumed that the servicing technician is aware of safety precautions and familiar with equipment
.
.
;..
.
...
.,, . .-. , ..::., . :..,:,, ,:..;,:, : .,:r: ,;~tiy,,2~+~q~p$;p+%Iate;tnS~~.1::
- .,: . '
,; .,..
Type of Gas:
Voltage: __
Model #:
Serial #:
Phase
BTU Rating:
Date Installed.
__
to the shipping company within 15 days afler receipt of machine or else
forfeit possible claims?)
Comments:
2.
3. Gas Connections
Electrical Connections
a. Voltage
-
Volts
-Volts
-- Volts
--
Amps
.--Amps
__Amps
a. Operating pressure
"wcChecked operating gas pressure with all equi
___ "WC.
I
e following columns If applicable
a. Verify equipment is level.
b. Verify proper type of gas.
c Verify proper pressure regulators installed.
d. Verify gas pipe line supply size i s adequate.
e. Verify gas supply pressure i s adequate.
g. Verify proper operating gas pressure with a//
equipment on - adjust if requ~red.
I. Verify electrical connections are correct.
I
t operation -calibrate i f needed.
--
1 YES I
NO
I
Con
Page 2 o f 3
VHL.9029
--
I.Check pilot and burner adjustments.
m. Check functional operation of doors, I~ds,valves, etc.
n. Check overall operalional performance of equipment.
o. Advise customer of cleaning and mainfenance procedures.
-p. Advise customer of water qualify requiremenls.
--
q. Explained warranty terms.
~---CONTINUED ON PAGE 2
F-32064 Rev. 6 (6-06)
5.
Water Connections
a. What is the filter ModellName:
b. Is the water fllter connected to an un-sonenea cola water the?
c Is lhe filtered water connected to the TREATED WATER fntet on the unll"
e Is the cold unfiltered water connected to the UNTREATED WATER nlet on tne unrt?
g What is the water pressure golng Into lhe filter?
h. Is thc drain connected independently to an open gap type noor drain?
Note: if is very important that the drain run independently to an open gap floor drain as described
Installation Manual. There should be no restrictions or other equipment coupled to the drain line.
to conform to these specifications may cause the unit to not work properly. Drain connect must n
located under the unit.
I
1
i. Was the filter water checked wlth the test strip provded?
Cornplel
Were the results sent to Vutcan-Harl?
Complel
- - .
.
Acceptance
--
We understand that in order to qualify for warranty coverage, only servlce companies authonzed by Vulcan-Hart
Range and genulne 0.E.M parts shall be used for any repalm.
I
1
I
Date: __
Customer Acceptance Signature
I verity that I have conducted a complete checkout of the above equipment
Service Representative Signature:
A
A
p
,D
e
:a
t
NOTE: Additional manuals are available from: www.vulcanhart.com and www.woIfrange.com
-