Eagle Power II Owner`s manual

INSTALLATION & OWNER'S
MANUAL
THE EAGLE POWER II BATTERY BACK UP
Control Box
Battery Box
PHONE (818) 764-6690 / TOLL FREE (800) 708-8848
PRE INSTALLATION INSTRUCTIONS
!
CAUTION!
BEFORE PROCEEDING WITH INSTALLATION
READ THIS MANUAL THOROUGHLY AND
CAREFULLY FOLLOW ALL THE OPERATION
INSTRUCTIONS.
The Eagle-Power II Battery Back up is designed to provide back up power to a gate operator when the
main AC supply voltage is interrupted or disconnected. There are two operations to the Eagle-Power II.
First, (and recommended) when experiencing a power failure the back-up system not only supplies
continuous power to run the gate operator, but will supply all of the the AC accessories (i.e. Loop
Detectors, MAG lock, Photo Eyes and Edge Sensors) with all the power required to keep their full
functions uninterrupted. Secondly, in the occurrence of power failure the gate can be opened by the
Power I "hold open" relay and left open until power is restored. However, with the availability of
continuous power available to the operator, this would not be necessary unless desired.
Using the Power II battery back up system with its 115V continuous power, enables the gate operator
and all of its safety features to continue to be UL 325 / 991 compliant.
IMPORTANT: THE PHONE SYSTEM TRANSFORMER SHOULD BE INSTALLED DIRECTLY
TO THE OPERATOR OUTLETS AND NOT TO THE EAGLE POWER I UNIT.
IMPORTANT: MONTHLY TESTS MUST BE PERFORMED ON BATTERY.
WARNING - HIGH VOLTAGE
ONLY A QUALIFIED TECHNICIAN SHOULD SERVICE THIS GATE OPERATOR
BATTERY TEST LOG
BATTERY TEST DATES
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
OPERATOR SERVICES DATES
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
/
(1)
THE EAGLE POWER II INFORMATION & WARNINGS
The following items are included with the POWER II:
(A)
Power II Control Box
(B)
1 - 70 AH Battery Box (in a second box)
(C)
1 - N/O Relay Output
(D)
2 - 3/4" Raintight Flexible Conduits
(E)
2 - 3/4" Raintight Conduit Connectors
(F)
1 - 12VDC Output (Optional)
(G)
1 - Instruction Manual
Power II Approximate Dimensions: Control Box : 13 3/8" (h) x 18 5/8" (w) x 11" (d)
Battery Box : 14 1/2" (h) x 12 1/2" (w) x 9" (d)
(SEE PAGE #6 FOR FURTHER MEASUREMENTS)
The Eagle-Power II is a indoor & outdoor unit
!
CAUTION!
THE POWER II IS DESIGNEDTO PROVIDE
POWER TO A GATE OPERATOR IN CASE
OF A POWER FAILURE OR THE POWER
IS SHUT OFF. THE OPERATOR CAN
START UNEXPECTEDLY WHEN THE AC
POWER IS NOT SUPPLIED. PRIOR TO
THE SERVICING OF GATE OPERATOR,
BE SURE TO DISCONNECT THE
BATTERY PACK OR TURN
THE POWER OFF
!
CAUTION!
THE POWER II PRODUCES LETHAL VOLTAGES.
THE BATTERY CAN CARRY HAZARDOUS
CURRENTS. THE ASPS SHOULD BE INSTALLED
BY A QUALIFIED TECHNICIAN.
!
CAUTION!
DO NOT SHORT THE BATTERY
TERMINALS!
(2)
INSTALLATION OF THE EAGLE POWER- II
EAGLE POWER- II
Eagle-2000-1HP
Eagle-200-1HP
Gate Size
10'
80**
160
15'
50**
100
20'
30**
60
70**
140
E-POWER II
E-POWER II
E-POWER II
Eagle Operator
Cycles Per 12 Hour
Period
Cycles Per 12 Hour
Period With Extra
Battery *
* An extra 70AH battery comes with separate mounting box and cables - Weight: 65 lbs
** All ratings are for operators (including The Diamond Control Board) and three of the following
accessories: Loop Detector, Receiver, MAG Lock, Phone System and Electric Eye. Additional
accessories will reduce the amount of cycles. Testing was only performed on the above specified
Eagle Operators. All cycle estimates are based on properly installed gates and operators.
(3)
INSTALLATION OF THE EAGLE POWER- II
CONNECTING THE AC LINE VOLTAGE:
Electrically, the Power II is wired in series with the incoming AC supply
from the breaker box to the operator. The connector labeled "AC In" is
connected to the main AC supply. The "AC Out" is connected to the
operator.
Connect the incoming AC line to the AC In as follows:
L - AC Line In (Live): Black
N - AC neutral (Common): White
G - AC Ground (Earth): Green
Connect the outgoing AC Out line to the Operator as follows:
L - AC Line Out: Black
N - AC neutral: White
G - AC Ground: Green
Refer to the installation manual provided with operator for the
proper connections to the operator
APPLYING THE POWER AND CONNECTING THE SYSTEM RELAY
With the power to the operator and breaker box turned off and all of the AC line
connections are complete, install the provided relay. After 5 to 10 seconds the
green inverter light will turn on. Then run the operator with the main breaker off
to test the Power I. When testing is completed, turn on the breaker and the green
inverter light will go off, then the charger green or yellow light will go on.
FOR HOLD OPEN APPLICATION
Connect the two orange wires from the sub panel to the "exit open" on the operator.
Using this connection will immediatly open the gate upon power failure. The operator
will resume normal operation when power is resumed.
REMINDER: There is a time delay of approximately 1-3 seconds between a power
failure and the initial functioning of the Power II.
IMPORTANT!
Eagle recommends surge protection be installed on the
incoming 110 AC Line to the battery back-up unit.
(4)
INSIDE OF THE EAGLE POWER II
Control Box
Battery
Charger
+
2000 Watt Inverter
-
Control Sub Panel
AC OUT
Hold
Open
AC IN
Battery
Terminals
Battery Box
-
+
70 Ah
Battery
(5)
MOUNTING
INSTALLATION
THE EAGLE
OF POWER
THE E-I PS
I
21"
Mounting Bracket Holes 3/8" Diameter
13 3/8"
10" OC
Rear View of Control Box
1"
18 1/2"
20" OC
Drawings Not To Scale
16"
2 1/2"
Mounting Bracket Holes 3/8" Diameter
12 1/2"
7 1/2" OC
Rear View of Battery Box
2 1/2"
13 3/4"
14 1/2" OC
(6)
THE EAGLE POWER II
Recommended Installation with flex conduit
Control Box
Battery Box
3/4" Water-tight
flexible conduit
with fittings
(7)
T E C HNIC AL S P E C IF IC AT IONS
S P E C IF IC AT IONS & WAR R ANT Y
INP UT V OLTAG E :
B AT T E R Y:
R E C HAR G E T IME :
OUT P UT V OLTAG E :
OUT P UT F R E QUE NC Y:
OUT P UT C UR R E NT:
S UR G E C UR R E NT:
AC OUT P UT P OWE R :
S UR G E P OWE R :
R E LAY OUT P UT S :
105 - 125 VAC
12V DC / 70AH
8 HOUR S
115 VAC
60 Hz
15 AMP S
3 0 AMP S
2000 WAT T S
4000 WAT T S
10 AMP S
!
C A UT ION!
DO NOT E XC E E D T HE
OUT P UT C APAC IT Y
OF T HE P OWE R II.
C ONNE C T ING A
MOTOR LOAD LAR G E R
T HAN R E C OMME NDE D
MAY DAMAG E T HE
P OWE R II AND V OID
T HE WAR R ANT Y.
MA NUFA C T UR E R 'S L IMIT E D WA R R A NT Y
E agle Acces s C ontrol S ys tems , Inc. warrants its P ower II to be free from defect in material and workmans hip for a period of one(1) year
from the date of purchas e for s ingle family home or multi-family and commercial us e. To obtain s ervice contact your dealer.
To obtain s ervice under this warranty the buyer mus t obtain authorization ins tructions for the return of any goods from E agle before
returning the goods . T he goods mus t be returned with complete identification, with copy of proof-of-purchas e, freight prepaid and in
accordance with E agle's ins tructions or they will not be accepted. In no event will E agle be res pons ible for goods returned without proper
authorization or identification.
G oods returned to E agle for warranty repair within the warranty period , which upon receipt by E agle are confirmed to be defective and
covered by this limited warranty, will be repaired or replaced at E agle's s ole option, at no cos t and returned prepaid. Defective parts will
be repaired or replaced with new or factory rebuilt parts E agle's s ole option.
T his limited warranty does not cover non-defect damage, damage caus ed by unreas onable us e, damage caus ed by improper ins tallation
or care, vandalis m, or lightning, fire or exces s ive heat or other acts of G od (including, but not limited to mis us e, abus e or alterations , failure
to provide reas onable and neces s ary maintenance), labor charges for dis mantling or reins talling a repaired or replaced unit, or
replacement batteries .
T hes e warranties are in lieu of all other warranties , either expres s ed or implied. All implied warranties of merchantability and/or a particular
purpos e are hereby dis claimed and excluded. Under no circums tances s hall E agle be liable for cons equential , incidental or s pecial
damages aris ing in connection with the us e or inability to us e this product. In no event s hall E agle's liability for breach of warranty, breech
of contract, negligence or s trict liability exceed the cos t of this product hereby. No pers on is authorized to as s ume for E agle any other
liability in connection with the s ale of this product.
F or F urther Information: P hone (800) 708-8848 / F ax (818) 764-6869
(8)