Sportster® II
Dual-Fuel™
Stove
®
CSA B140.9.2-2008 Proposed
Portable Pressurized Type Liquid
Petroleum Fuelled Camp Stoves
Dual-FuelTM Stove
Instructions for use
®
© 2008 The Coleman Company, Inc.
www.coleman.com
533 Series
IMPORTANT
CONSUMER/USER: This instruction manual
contains important information necessary for the
proper assembly and safe use of the appliance.
Read and follow all warnings and instructions before
assembling and using the appliance. Follow all
warnings and instructions when using the appliance.
Keep this manual for future reference.
If you have questions about assembly, operation, servicing or repair of this
appliance, please call Coleman at 1-800-835-3278 or TDD: 316-832-8707. In
Canada call 1-800-387-6161.
English
FOR YOUR
SAFETY
Do not store or use
gasoline or other liquids
with flammable vapors in
the vicinity of this or any
other appliance.
DANGER
This manual contains important information about
the assembly, operation and maintenance of this
outdoor liquid fueled appliance. General safety
information is presented on this page and is also
located throughout these instructions. Particular
attention should be paid to information accompanied by the safety alert symbol “ DANGER”,
“ WARNING”, “ CAUTION”.
Keep this manual for future reference and
to educate new users of this product. This manual
should be read in conjunction with the labeling on
the product.
Safety precautions are essential when any
Coleman® fueled equipment is involved. These
precautions are necessary when using, storing,
and servicing. Using this equipment with the
respect and caution demanded will reduce the
possibilities of personal injury or property damage.
The following symbols shown below are used
extensively throughout these instructions. Always
heed these precautions, as they are essential when
using any Coleman® fueled equipment.
DANGER
DANGER indicates an imminently hazardous
situation which, if not avoided, will result in
death or serious injury.
CARBON MONOXIDE
HAZARD
• This appliance can produce carbon monoxide
which has no odor.
• Using it in an enclosed
space can kill you.
• Never use this appliance
in an enclosed space
such as a camper, tent,
car or home.
WARNING
WARNING indicates a potentially hazardous
situation which, if not avoided, could result in
death or serious injury.
CAUTION
CAUTION indicates a potentially hazardous
situation which, if not avoided, may result in
minor or moderate personal injury, or
property damage.
DANGER
Failure to comply with the precautions and
instructions provided with these stoves can
result in death, serious bodily injury and property loss or damage from hazards of fire, explosion, burn, asphyxiation, and/or carbon
monoxide poisoning.
Only persons who can understand and follow
the instructions should use or service
these stoves.
If you need assistance or information such
as an instruction manual or labels, contact
The Coleman Company, Inc.
CALIFORNIA PROPOSITION 65:
WARNING: This fuel, and byproducts of combustion of this fuel, contain chemicals known to the
state of California to cause cancer, birth defects,
or other reproductive harm.
English-1
WARNING
WARNING
This multi-fuel appliance may be fueled by
Coleman® Liquid Fuel or unleaded gasoline.
• Never use kerosene or leaded automotive fuel.
• Store fuel in a clean, properly marked
container away from flame (including pilot
lights), other sources of ignition, or
excessive heat.
• BURN HAZARD
• Never leave stove unattended when hot
or in use.
• Keep out of reach of children.
DANGER
DANGER
• CARBON MONOXIDE HAZARD
• EXPLOSION - FIRE HAZARD
• During lighting and operation, this product can
be a source of ignition. Never use the stove in
spaces that contain or may contain volatile or
airborne combustibles, or products such as
gasoline, solvents, paint thinner, dust particles
or unknown chemicals. Minimum clearances
from combustible materials: 24 inches from the
sides and 48 inches from the top.
• Provide adequate clearances around air
openings into the combustion chamber.
DANGER
• EXPLOSION - FIRE HAZARD
• Coleman® fuel and gasoline are extremely
flammable; handle with care. Fuel vapors are
invisible, explosive, and can be ignited by
ignition sources may feet away.
• Always fill outdoors.
• Never open a pressurized Coleman® fuel tank
or fill fuel tank near flame (including pilot
lights), or other ignition sources. It is normal
for a pressurized fuel tank to vent a small
amount of fuel mist when unscrewing the fuel
cap. Be sure stove has no flame before
unscrewing the fuel cap.
WARNING
Not for home or recreational vehicle use.
We cannot foresee every use which may be
made of our products.
Check with your local fire safety authority
if you have questions about use.
Other standards govern the use of fuel and
heat producing products for specific uses.
Your local authorities can advise you about
these.
• Use only Coleman® accessories or parts.
• During stove set-up, check all fittings for
leaks using soapy water. Never use a flame.
• This stove is a combustion appliance. All combustion appliances produce carbon monoxide
(CO) during the combustion process. This
product is designed to produce extremely
minute, non-hazardous amounts of CO if used
and maintained in accordance with all warnings and instructions. Do not block air flow into
or out of the stove.
• Carbon Monoxide (CO) poisoning produces
flu-like symptoms, watery eyes, headaches,
dizziness, fatigue and possibly death. You
can’t see it and you can’t smell it. It’s an invisible killer. If these symptoms are present during operation of this product get fresh
air immediately!
• For outdoor use only.
• Never use inside house, camper, tent, vehicle or other unventilated or enclosed
areas. This stove consumes air (oxygen).
Do not use in unventilated or enclosed
areas to avoid endangering your life.
CAUTION
• SERVICE SAFETY
• Keep all connections and fittings clean.
Inspect fuel cap for dirt or damage after refilling the fuel tank. Wipe up any spilled fuel and
dispose of in a safe place.
• Use as a cooking appliance only. Never alter
in any way or use with any device or part not
expressly approved by Coleman.
• Clean stove frequently to avoid grease
accumulation and possible grease fires.
• Check all connections for leaks. Liquid
Coleman® fuel present at connections
indicates a leak.
English-2
Technical
Characteristics
Input: 10,500 BTU/HR Coleman® fuel
or unleaded gasoline.
Category: Direct pressure
multi-fuel stove
Fuel: Coleman® fuel or
unleaded gasoline
WARNING
1. Coleman Fuel is extremely
flammable, handle with extreme
care. Fuel vapors are invisible,
explosive, and can be ignited by
ignition sources many feet away.
2. Always fill outdoors. Never open or
fill fuel tank near flame (including
pilot lights), or other ignition
sources. It is normal for a pressurized fuel tank to vent a small
amount of fuel mist when
unscrewing the fuel cap.
3. Always light and use stove
outdoors; never inside house,
camper, tent, or other unventilated
or enclosed areas.
4. This stove consumes air
(oxygen). Do not use in
unventilated or enclosed areas
to avoid endangering your life.
5. This stove is designed to use
Coleman® Fuel or unleaded
gasoline.
6. Store fuel in a clean, properly
marked container away from
flame (including pilot lights),
other sources of ignition, or
excessive heat.
7. Use for cooking only. Never alter
in any way or use with any device
or part not expressly approved
by Coleman. Never use as a
space heater. Never leave stove
unattended while burning.
8. Keep stove away from flammables. Never allow fabric, clothing,
or any flammable material come
within 48 inches of the top and 24
inches of all sides of the stove.
9. When stove is in use, all metal
parts of the stove assembly and
generator become extremely hot.
DO NOT TOUCH.
10. Never place heavy or large
capacity utensils on stove.
11. Keep out of reach of children.
®
Thank you for purchasing your new
Coleman® multi-fuel stove. We
recommend operating your new stove
in a safe location outside your home
to familiarize yourself with its multi-fuel
operation before your next outdoor
experience.
Helpful Hints
• Liquid Coleman® fuel is recommended
when using the stove in temperatures
below 40° F or in high elevation.
• For best results, always use Coleman®
Filter/Funnel Part No. 5103A700T.
• If necessary, unleaded gasoline may
be substituted for liquid Coleman® fuel.
• Do not use kerosene in this stove.
To Set Up
DANGER
• CARBON MONOXIDE HAZARD
• For outdoor use only.
• Never use inside house, camper, tent, vehicle
or other unventilated or enclosed areas. This
lantern consumes air (oxygen). Do not use in
unventilated or enclosed areas to avoid
endangering your life.
Filling the tank
Always fill outdoors. Never fill tank,
loosen or remove fuel cap near flame
(including pilot lights), or other ignition
sources.
■ With stove on level surface, move red
fuel lever to off position. (Fig. 1)
English-3
Fig. 1
■ Close PUMP KNOB firmly. (Fig. 2)
■ Close PUMP KNOB. (Fig. 7)
Fig. 7
Fig. 2
■ Remove FUEL CAP. Using a funnel
or suitable filling device, fill with
clean, fresh fuel (Fig. 3). Do not tip
stove.
■ Replace FUEL CAP on fuel container.
Tighten firmly. Move fuel container
away from stove. WIPE UP ANY
SPILLED FUEL AND DISPOSE OF
IN A SAFE PLACE.
Leak Check
■ Make sure FUEL VALVE is fully
“OFF”.
■ CHECK FOR LEAKS in one or more
ways. Look for fuel mist or a wet
appearance of fuel on surfaces. Listen
for hiss of escaping gas. Smell for fuel
odor. Never use a flame. Do not use if
leaking. (Fig. 8)
CHECK FOR
LEAKS
Fig. 3
CHECK
FOR
LEAKS
CHECK
FOR
LEAKS
Pumping
Fig. 8
Be sure RED FUEL LEVER is in off
position. (Fig. 4)
■ Open PUMP KNOB one full turn.
(Fig. 5)
To Light
WARNING
• Perform leak test outdoors.
• Extinguish all open flames.
• NEVER leak test when smoking.
• Do not use the outdoor stove until connection
has been leak tested and does not leak.
Fig. 4
WARNING
Fig. 5
■ With thumb over hole in PUMP
KNOB, pump approximately 30 full
strokes. (Fig. 6)
• BURN HAZARD
• Never leave stove unattended
when hot or in use.
• Keep out of reach of children.
Fig. 6
English-4
NEVER FILL OR LIGHT STOVE INSIDE
HOUSE, CAMPER, OR TENT.
■ Hold lit match at BURNER, then turn
RED FUEL LEVER to high (LIGHT)
position. (Fig. 9)
■ Additional pumping may be required
for full heat output (Fig. 14)
Fig. 14
For temperatures below
freezing
Fig. 9
■ When burner lights, open PUMP
KNOB one turn (Fig. 10) and pump for
30 full strokes (Fig. 11).
Fig. 10
■ Note: In temperatures below freezing
preheating paste may be required.
Place a generous amount of PREHEATING PASTE on BURNER CAP
beneath the GENERATOR. (Fig. 15)
Fig. 11
■ Close PUMP KNOB. (Fig. 12)
Fig. 15
■ Light the paste (Fig. 16). After the
paste is almost consumed, follow the
previous lighting instructions.
Fig. 12
■ CAUTION: If fuel or flames appear
below BURNER, immediately turn
RED FUEL LEVER off. Allow stove to
cool. Turn stove upside down to
empty any fuel accumulated in burner
and wipe dry. Review instructions
then relight stove.
■ Adjust flame to desired heat with
RED FUEL LEVER. (Fig. 13)
Fig. 16
To Turn Off
■ Move RED FUEL VALVE from off to
high” several times. (Fig. 17)
Fig. 17
Fig. 13
English-5
■ Latch Red FUEL VALVE in off
position. (Fig. 18)
To Store
■ Make sure stove is cool.
■ Move stove away from flame (including pilot lights) and other ignition
sources.
Fig. 18
■ Be sure flame is extinguished. Flame
will linger on burner for 1-2 minutes
after fuel valve is “OFF”.
WARNING
• Always turn fuel valve off before
unscrewing fuel cap from fuel tank. Never
remove fuel cap near ignition sources,
while stove is lit, or hot to touch.
• MAINTENANCE
• Keep stove area clear and free
from combustible materials,
gasoline and other flammable
vapors and liquids.
• Do not obstruct the flow of
combustion and ventilation air.
• A good flame should be blue with
minimal yellow tip. Some yellow
tips on flames are acceptable as
long as no carbon or soot deposits
appear.
• Wipe clean with soft cloth and mild
dish detergent. Do not use abrasives.
English-6
Troubleshooting
Symptom
Problem
Solution
Burner will not
light or flame selfextinguished.
Fuel tank empty.
Refill fuel tank with clean and
fresh Coleman® fuel or unleaded
fuel.
Burner will not
light or flame is
low or flame selfextinguished.
Little or no pressure in fuel
tank.
Check that fuel cap is tight and
pump 30 strokes.
Burner selfextinguishes
during one minute
warm-up.
Generator is not fully
warmed up.
In temperatures below freezing
preheating paste may be
required. Place a generous
amount of preheating paste on
burner cap beneath the generator.
Yellow flame.
Excess fuel in burner.
Low heat.
Generator tip plugged.
Low heat.
Faulty generator.
Persistent small
yellow flame.
Faulty generator.
Replace with a new generator.
Persistent high
yellow flame.
Failure in the fuel delivery
system.
May need to replace pump
assembly. Please contact
Consumer Service (see page 9).
Yellow smokey
flame.
Spider webs, insects, or
other obstruction in the
burner and air tube.
Remove burner to inspect and
clean the burner and air tube.
Pump does not
pressurize the
liquid fuel
canister.
Pump seals are dry or
worn.
Intermittent yellow
flame after
extended use on
low heat setting.
Flame requires adjustment.
English-7
A yellow flame is normal until the
generator warms up. If yellow
flame persists, turn off stove,
allow flame to self-extinguish and
the stove to cool. If necessary,
invert stove to remove excess
liquid fuel from the burner. Follow
lighting instructions.
Turn red fuel lever back and forth
several times to clean generator
tip. Be sure to use only fresh and
clean fuel.
Replace with a new generator.
This is a normal periodic
maintenance procedure. The
generator life is dependent on the
type of fuel used. Generator life is
extended by using clean
Coleman® fuel.
Squirt a few drops of oil in the
OIL HOLE in the pump cap. This
will keep the pump functioning
properly (Fig. 19). If this does not
correct the problem, replace the
pump seals or purchase a new
pump assembly.
Adjust the flame to a slightly
higher level with the red fuel lever.
Replacement Parts List
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
Part No.
220C1401
220A6201
533-5891
508A5571
400-3451
413C3021
400-5401
639-1091
400-5261
400A1261
400-0601
200-6381
400B5151
Description
Fuel Cap
Pump Repair Kit
Generator
Valve Assembly
Burner Ring Set
Burner Bowl
Grate
Pump Cup & Nut
Burner Box Assembly
Generator Bracket
Screw Pkg. (6)
Check Valve & Stem Assy.
Valve Stem Assy.
7
5
3
13
10
6
8
2
4
11
9
1
12
English-8
Things You Should Know
Warranty
Limited Five Year Warranty
The Coleman Company, Inc. (“Coleman”) warrants that
for a period of five years from the date of original retail
purchase, this product will be free from defects in material
and workmanship. Coleman, at its option, will repair or
replace this product or any component of the product found
to be defective during the warranty period. Replacement
will be made with a new or remanufactured product or
component. If the product is no longer available, replacement
may be made with a similar product of equal or greater value.
This is your exclusive warranty.
This warranty is valid for the original retail purchaser from
the date of initial retail purchase and is not transferable. Keep
the original sales receipt. Proof of purchase is required to
obtain warranty performance. Coleman dealers, service
centers, or retail stores selling Coleman® products do not
have the right to alter, modify or in any way change the terms
and conditions of this warranty.
What This Warranty Does Not Cover
This warranty does not cover normal wear of parts, parts
that are not genuine Coleman® parts, or damage resulting
from any of the following: negligent use or misuse of the
product; use on improper voltage or current; commercial use
of the product; use contrary to the operating instructions;
disassembly, repair or alteration by anyone other than
Coleman or an authorized service center. Further, the
warranty does not cover Acts of God, such as fire, flood,
hurricanes and tornadoes. Warranty void if damage to
product results from the use of a part other than a genuine
Coleman® part.
COLEMAN SHALL NOT BE LIABLE FOR DEFECTS THAT
ARE CAUSED BY THE USE OF UNAUTHORIZED PARTS
OR SERVICE. COLEMAN SHALL NOT BE LIABLE FOR
ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES
CAUSED BY THE BREACH OF ANY EXPRESS OR
IMPLIED WARRANTY OR CONDITIONS. EXCEPT TO THE
EXTENT PROHIBITED BY APPLICABLE LAW, ANY
IMPLIED WARRANTY OF MERCHANTABILITY OR
FITNESS FOR A PARTICULAR PURPOSE IS LIMITED IN
DURATION TO THE DURATION OF THE ABOVE
WARRANTY OR CONDITIONS. SOME STATES,
PROVINCES, OR JURISDICTIONS DO NOT ALLOW THE
EXCLUSION OR LIMITATION OF INCIDENTAL OR
CONSEQUENTIAL DAMAGES OR LIMITATIONS ON HOW
LONG AN IMPLIED WARRANTY LASTS, SO THE ABOVE
LIMITATIONS OR EXCLUSION MAY NOT APPLY TO YOU.
THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS,
AND YOU MAY ALSO HAVE OTHER RIGHTS THAT VARY
FROM STATE TO STATE OR PROVINCE TO PROVINCE.
How to Obtain Warranty Service
Take the product to an authorized Coleman service center.
You can find the nearest authorized Coleman service center
by visiting www.coleman.com or calling 1-800-835-3278 or
TDD 316-832-8707 in the United States or 1 800 387-6161 in
Canada. If a service center is not conveniently located, attach
to the product a tag that includes your name, address,
daytime telephone number and description of the problem.
Include a copy of the original sales receipt. Carefully package
the product and send either by courier or insured mail with
shipping and insurance prepaid to:
For products purchased in the United States:
The Coleman Company, Inc.
3600 North Hydraulic
Wichita, KS 67219
1. Preheating paste is available at most stores
that sell backpacking equipment.
2. Rinse tank twice a year with fresh fuel to
remove sediment, gum formations, and
moisture accumulations.
3. Seasonally or before storage, squirt a few
drops of oil into the OIL HOLE in the pump
cap. This will keep the pump functioning
properly. (Fig. 19)
4. The red fuel lever moves a small needle in
and out of the generator gas tip. If stove is
hard to light or does not produce full heat
output, turn red fuel lever back and forth
several times to clean generator.
5. Unleaded fuels may vary in quality and can
affect generator life and performance. If you
are having a problem with your stove or
generator using unleaded fuel, replace the
generator and try a different brand of
unleaded fuel.
6. The usual storage areas for camping and
picnic equipment are the basement, attic, or
garage. To avoid the accumulation of dust,
cobwebs, etc., that is common in these
areas, place your stove in a plastic bag and
seal it with a rubber band.
7. For repair service call one of the numbers
listed below for location of your nearest
Coleman Service Center. If stove must be
mailed to a Service Center, attach to the
product a tag that includes your name,
address, daytime telephone number and a
description of problem. Do NOT send LPG
canister. Carefully package the product and
send either by courier or insured mail with
shipping and insurance prepaid to:
For products purchased in the United States:
The Coleman Company, Inc.
3600 N. Hydraulic • Wichita, KS 67219 U.S.A.
1-800-835-3278 • TDD: 316-832-8707
For products purchased in Canada:
Sunbeam Corporation (Canada) Limited
DBA Jarden Consumer Solutions
20B Hereford Street
Brampton, ON L6Y 0M1
1-800-387-6161
8. If not completely satisfied with the
performance of this product, please call one
of the numbers listed above.
For products purchased in Canada:
Sunbeam Corporation (Canada) Limited
DBA Jarden Consumer Solutions
20B Hereford Street
Brampton, ON L6Y 0M1
OIL HOLE
The costs of transporting the product to Coleman or an
authorized service center for warranty service is the
responsibility of the purchaser.
Do not mail products with fuel in tanks, or with disposable
LPG canisters. Remove glass globes from lanterns and wrap
separately.
DO NOT RETURN THIS PRODUCT TO THE PLACE OF
PURCHASE.
If you have any questions regarding this warranty please
call 1-800-835-3278 or TDD 316-832-8707 in the United
States or 1 800 387-6161 in Canada.
English-9
Fig. 19
Notes:
English-10
The Coleman Company, Inc. • 3600 North Hydraulic • Wichita, KS 67219 U.S.A.
1-800-835-3278 • TDD: 316-832-8707
Sunbeam Corporation (Canada) Limited • DBA Jarden Consumer Solutions
20B Hereford Street
Brampton, ON L6Y 0M1 • 1 800 387-6161
© 2008 The Coleman Company, Inc. All rights reserved. Coleman®, Sportster®, and
are registered trademarks and Dual Fuel™ is a trademark of The Coleman Company, Inc.
© 2008 The Coleman Company, Inc. Tous droits réservés. Coleman®, Sportster®, et
sont des marques déposées alors que Dual Fuel™ est une marque de commerce de The Coleman Company, Inc.
© 2008 The Coleman Company, Inc. Todos los derechos reservados. Coleman®, Sportster®, y
son marcas registradas y Dual Fuel™ es una marca de la compañía The Coleman Company, Inc.
www.coleman.com
4010003165 (20080310)