Samsung CA17J* Service manual

CONFIDENTIAL
COLOR MONITOR
CA17K*
CA17J*
SERVICE
Manual
COLOR MONITOR
CONTENTS
1. Precautions
2. Product Specifications
3. Disassembly & Reassembly
4. Alignment & Adjustments
5. Troubleshooting
6. Exploded View & Parts List
7. Electrical Parts List
8. Block Diagram
9. Wiring Diagram
10. Schematic Diagrams
CONFIDENTIAL
1 Precautions
1-1 Safety Precautions
WARNINGS
1. For continued safety, do not attempt to modify the
circuit board.
2.
Disconnect the AC power before servicing.
3.
When the chassis is operating, semiconductor
heatsinks are potential shock hazards.
1-1-1
1.
When servicing the high voltage system, remove
the static charge by connecting a 10 kohm resistor
in series with an insulated wire (such as a test
probe) between the chassis and the anode lead.
2.
When troubleshooting a monitor with excessively
HV, avoid being unnecessarily close to the monitor.
Do not operate the monitor for longer than is
necessary to locate the cause of excessive voltage.
4.
5.
6.
7.
High voltage should always be kept at the rated
value, no higher. Only when high voltage is
excessive are X-rays capable of penetrating the shell
of the CRT, including the lead in glass material.
Operation at high voltages may also cause failure of
the CRT or high voltage circuitry.
When the HV regulator is operating properly, there
is no possibility of an X-ray problem. Make sure the
HV does not exceed its specified value and that it is
regulating correctly.
The CRT is especially designed to prohibit
X-ray emissions. To ensure continued X-ray
protection, replace the CRT only with one that is
the same or equivalent type as the original.
Handle the CRT only when wearing shatterproof
goggles and after completely discharging the high
voltage anode.
Do not lift the CRT by the neck.
1-1-2
Leakage Current Hot Check (Figure 1-1):
WARNING: Do not use an isolation transformer during
this test.
Use a leakage current tester or a metering system
that complies with American National Standards
Institute (ANSI C101.1, Leakage Current for
Appliances), and Underwriters Laboratories (UL
Publication UL1410, 59.7).
4.
With the unit completely reassembled, plug the AC
line cord directly into a 120V AC outlet. With the
unit’s AC switch first in the ON position and then
OFF, measure the current between a known earth
ground (metal water pipe, conduit, etc.) and all
exposed metal parts, including: metal cabinets,
screwheads and control shafts. The current
measured should not exceed 0.5 milliamp. Reverse
the power-plug prongs in the AC outlet and repeat
the test.
Servicing the High Voltage and CRT :
WARNING:A high voltage adjusted to the wrong
value may cause excessive X-ray
emissions.
3.
3.
Fire and Shock Hazard :
Before returning the monitor to the user, perform the
following safety checks:
1.
Inspect each lead dress to make certain that the
leads are not pinched or that hardware is not
lodged between the chassis and other metal parts in
the monitor.
2.
Inspect all protective devices such as nonmetallic
control knobs, insulating materials, cabinet backs,
adjustment and compartment covers or shields,
isolation resistor-capacitor networks, mechanical
insulators, etc.
CA17K*/CA17J*
(READING SHOULD
NOT BE ABOVE 0.5mA)
LEAKAGE
CURRENT
TESTER
DEVICE
UNDER
TEST
TEST ALL
EXPOSED METAL
SURFACES
2-WIRE CORD
ALSO TEST WITH
PLUG REVERSED
(USING AC ADAPTER
PLUG AS REQUIRED)
EARTH
GROUND
Figure 1-1. Leakage Current Test Circuit
1-1-3 Product Safety Notices
Some electrical and mechanical parts have special
safety-related characteristics which are often not
evident from visual inspection. The protection they give
may not be obtained by replacing them with
components rated for higher voltage, wattage, etc. Parts
that have special safety characteristics are identified by
! on schematics and parts lists. A substitute
replacement that does not have the same safety
characteristics as the recommended replacement part
might create shock, fire and / or other hazards. Product
safety is under review continuously and new
instructions are issued whenever appropriate.
Components identified by
on schematics and parts
lists must be sealed by a soldering iron after
replacement and adjustment.
1-1
CONFIDENTIAL
2 Product Specifications
2-1 Specifications
Description
Item
CA17K*
CA17J*
Picture Tube
17-Inch (43 cm): 16-inch (40.6 cm) viewable,
Flat-face, 90˚ Deflection, 0.20 mm (Horizontal) Dot pitch,
Silica coated with anti-electrostatic properties (TCO: Multilayer coating),
Medium-short persistence phosphor
Scanning Frequency
Horizontal : 30 kHz ~ 70 kHz
Vertical : 50 Hz ~ 160 Hz
Display Colors
Unlimited colors
Maximum Resolution
Horizontal : 1280 Dots
Vertical : 1024 Lines
Input Video Signal
Analog, 0.7 Vp-p positive at 75 Ω, internally terminated
Input Sync Signal
Separate Sync: TTL level, positive/negative
Maximum Pixel Clock rate
110 MHz
Active Display
Horizontal : 312 mm ± 4 mm, Vertical : 234 mm ± 4 mm
Input Voltage
AC 90 ~ 264 Volts, 60 Hz or 50 Hz ± 3 Hz
Power Consumption
90 Watt (max)
Dimensions (W x D x H)
Unit ; 15.7 x 16.2 x 15.7 Inches (398 x 412 x 400 mm)
Carton ; 20.4 x 22.8 x 18.42 Inches (517 x 580 x 468 mm)
Weight (Net/Gross)
35.1 lbs (15.9kg) / 41.2 lbs (18.68kg)
Environmental Considerations
Operating Temperature : 32°F ~ 104°F (0°C ~ 40°C)
Humidity : 10 % ~ 80 %
Storage Temperature : -4°F ~ 113°F (-20°C ~ 45°C)
Humidity : 5 % ~ 95 %
30 kHz ~ 85 kHz
50 Hz ~ 160 Hz
1600 Dots
1200 Lines
185 MHz
100 Watt (max)
• Above models comply with SWEDAC (MPR II) recommendations for reduced electromagnetic fields.
• Designs and specifications are subject to change without prior notice.
CA17K*/CA17J*
2-1
CONFIDENTIAL
3 Disassembly and Reassembly
This section of the service manual describes the disassembly and reassembly procedures for the
CA17K*/CA17J* monitor.
WARNING: This monitor contains electrostatically sensitive devices. Use with caution when
handling these components.
3-1 Disassembly
Cautions:1. Disconnect the monitor from the power source before disassembly.
2. To remove the Rear Cover, you must use the special opening jig tool.
3-1-1 Before making Disassembly
1. Disconnect or power cord from the monitor.
2. With a pad beneath it, stand the monitor on its
front with the screen facing downward and
the base close to you.
4. Push the Opening jig each groove along the
Side of the monitor till it makes a “ttak”
sound. (2 grooves : Left and Right, Make sure
each snap is disengaged.)
3-1-2 Cabinet Disassembly
1. Remove the Stand from the monitor.
(Refer to Stand manual)
2. Remove 2 screws on the Rear cover.
Figure 3
5. Pull the Rear Cover up off the monitor.
Figure 1
3. Incline the monitor by lifting the rear of the
monitor.
Figure 4
Figure 2
CA17K*/CA17J*
3-1
CONFIDENTIAL
4 Alignment and Adjustments
This section of the service manual explains how to make permanent adjustments to the monitor. Directions
are given for adjustments using the monitor Interface Board Ver. 2.0 and software (Softjig).
4-1 Adjustment Conditions
Caution: Changes made without the Softjig are saved only to the user mode settings. As such, the
settings are not permanently stored and may be inadvertently deleted by the user.
4-1-1 Before Making Adjustments
4-1-2 Required Equipment
4-1-1 (a) ORIENTATION
When servicing, always face the monitor to the
east.
The following equipment may be necessary for
adjustment procedures:
4-1-1 (b) WARM-UP TIME
The monitor must be on for 30 minutes before
starting alignment. Warm-up time is especially
critical in color temperature and white balance
adjustments.
4-1-1 (c) SIGNAL
Analog, 0.7 Vp-p positive at 75 ohm, internal
termination
Sync: Separate
(TTL level negative/positive)
4-1-1 (d) SCANNING FREQUENCY
Horizontal : 30 kHz to 70 kHz (Automatic) CA17K*
: 30 kHz to 85 kHz (Automatic) CA17J*
Vertical
: 50 Hz to 160 Hz (Automatic)
Unless otherwise specified, adjust at the
1024 x 768 mode (68 kHz/85 Hz),
Refer to Table 2-1 on page 2-3.
CA17K*/CA17J*
4-1-2 (a) DISPLAY CONTROL ADJUSTMENT
1. Non-metallic (–) screwdriver:
1.5, 2.5, 3 mm
2. Non-metallic (+) screwdriver:
1.5, 2.5, 3 mm
3. Digital Multimeter (DMM), or
Digital Voltmeter
4. Signal generator, or
DM200 software
5. Personal computer
4-1-2 (b) COLOR ADJUSTMENTS
1. All equipment listed in 4-1-2 (a), above
2. Color analyzer, or any luminance
measurement equipment
4-1
CONFIDENTIAL
5 Troubleshooting
5-1 Parts Level Troubleshooting
Notes: Check the following circuits.
• No raster appears: Power circuit, Horizontal output circuit.
• High voltage develops but no raster appears: Video output circuits.
• High voltage does not develop: Horizontal output circuits.
5-1-1 No Power Supply
WAVEFORMS
Check and replace D601 and FH1
1 100 V (IC601, #1)
Chirping noise exists?
Yes
Check and replace IC601.
No
Repeating start?
Yes
Check and replace D606.
CH1 P-P = 100 V CH1 RMS = 350.2 V
No
1
IC601 Pin 1 waveform is right?
No
Check and replace D614, IC601,
Q602, and ZD601.
No
Check and replace IC201, IC301,
IC401, Q402, and Q404.
Yes
C622 Voltage is 13 V ± 0.5V?
Yes
Operate normally?
No
Replace Main board.
Yes
Verify voltages.
Done.
CA17K*/CA17J*
5-1
CONFIDENTIAL
6 Exploded View and Parts List
CA17K*/CA17J*
6-1
CONFIDENTIAL
7 Electrical Parts List
7-1 Main PCB Parts
Loc. No.
C409
C430
C506
C601
C602
C608
CIS
CIS
CIS
CIS
CIS
CIS
CIS
CIS
CN201
CN202
CN205
CN403
CN501
CN601
D406
D601
D609
FBT+H/S
FUSE
HS501_CLAMP
IC201_SOCK
IC401
IC602
IC604
JW2
L401
L402
L403
L601
OP201
R428
RL601
SH/BTM+M/PCB
SH/BTM+SH/LMF
SIGNAL
SW401
SW601
T401
T402
T501
T502
T601
T602
TH601
TH602
-
CA17K*/CA17J*
Code No.
BH94-00704B
2306-000147
2306-000249
2201-000154
2301-001195
2301-001195
2401-003391
3301-000233
BH39-00191A
BH68-00001A
BH71-00110A
BH72-00025A
BH72-00026A
BH72-00261A
BH73-60304C
3711-003895
3711-003873
3711-004379
3711-003989
BH39-00232A
3721-001028
0402-001313
0402-001407
0402-000005
6003-000122
3601-000004
6502-000001
3704-001071
1204-001611
1203-000165
1203-000001
BH39-40306D
BH27-00005A
BH27-00022A
BH27-20342U
BH27-00061A
0601-001147
2003-000653
3501-001111
6003-000010
6003-000010
BH39-00145A
3406-000002
3403-001116
BH26-00090A
BH27-00103A
BH26-00109A
BH26-00137A
BH26-00135A
BH26-30302S
1404-000002
1404-001020
BH97-00202K
Description
ASSY PCB MAIN
C-FILM,MPPF
C-FILM,MPPF
C-CERAMIC,DISC
C-FILM,MPPF
C-FILM,MPPF
C-AL
CORE-FERRITE
CBF-HARNESS
LABEL/MARK-CDT
SHIELD BOTTOM
GUIDE-POWER
SHAFT-POWER
SHEET-LMF
RUBBER-SUPPORT
CONNECTOR-HEADER
CONNECTOR-HEADER
CONNECTOR-HEADER
CONNECTOR-HEADER
CBF-HARNESS
PLUG-AC POWER
DIODE-RECTIFIER
DIODE-BRIDGE
DIODE-RECTIFIER
SCREW-TAPTITE
FUSE-CARTRIDGE
CABLE CLAMP
SOCKET-IC
IC-DEF. PROCESSOR
IC-POSI.ADJUST REG.
IC-POSI.FIXED REG.
CBF-HARNESS
COIL-CHOKE
COIL-CHOKE
COIL-CHOKE
COIL FILTER
LED
R-METAL OXIDE(S)
RELAY-POWER
SCREW-TAPTITE
SCREW-TAPTITE
CBF SIGNAL
SWITCH-ROTARY
SWITCH-PUSH
TRANS HORIZ.DRIVE
COIL LINEARITY
TRANS FBT
TRANS-FOCUS
TRANS SWITCHING
TRANS-SYNC.
THERMISTOR-PTC
THERMISTOR-NTC
ASSY MICOM
Specification
CA17JS
1uF,5%,250V,BK,26x24x15,22.5mm
680nF,5%,250V,TP,26x20.5x12,20
10nF,+80-20%,2kV,Y5P,TP,20x5,10
150nF,10%,275VAC,BK,26x16.5x7,
150nF,10%,275VAC,BK,26x16.5x7,
220uF,20%,450V,GP,BK,25x50,10
ZZ,18x9.5x28mm,-,TC17LO,8*0.16TA*16,-,-,120MM,-,-,35068-9822,-,-,-,-,-,-,-,CRT-GND ASS’Y
ART-PAPER 100G,-,WHT,BLK,-,ALL,CDT
PN15VT,SECC ,T1.0,-,-,CDA4507,ABS+PC,5V,IV16,-,CDA4507,ABS+PC,5V,IV16,-,IB10LO,AL+PET,-,-,-,-,-,DP15LT,CR V0,GRAY,-,14*7*10,-,BOX,13P,1R,2mm,STRAIGHT,SN
BOX,7P,1R,2mm,STRAIGHT,SN
BOX,4P,1R,2MM,STRAIGHT,SN
NOWALL,4P,1R,8mm,STRAIGHT,SN
DP17MO,UL1032,UL/CSA,1P,290MM,RED,AWG22,YHF800-1,-,-,-,-,-,-,-,CBF-CONN ASS’Y
3P,-,-,NI
ERD07-15AL,1.7VK,1.5A,-,BK
G2SB60,600V,1.5A,SIP-4,BK
31DF4,400V,3A,DO-201AD,BK
BH,+,B,M4,L12,ZPC(YEL),SWRCH18
250V,3.15A,SLOW-BLOW,CERAMIC,5x20mm
DAWH-5NB,D15,L35,NYLON66,NTR
42P,DIP,SN,1.778mm
TDA4856,SDIP,32P,400MIL,PLASTIC,16V,-,-20to+70C,ST,H/V DEF. PROCESSOR
78R12,TO-220,4P,-,PLASTIC,11.7/12.3V,1.5W,-20TO+80C,1A,-,ST
7805,TO-220,3P,-,PLASTIC,4.8/5
,80MM,BLK,1015,AWG22,-,-,-,-,CH-0630,120uH,10%,AR-06*30,-,PHENAL,-,-,0.20,37.0*16.2,-,-,BULK
CH-1523S,100uH,+/-10%,DR1523(C:9.8),-,PHELOLIC,-,-,0.16ohm MAX,32*17.3,-,-,BK
-,8.2MH(250KHz),10%,DR8*11,-,-,-,-,10.5OHM,-,-,-,BULK
-,33.0mH,0.1ohm,72Ts,28.*28,-,BK,SQE-2828,3A,-,ROUND,GRN,4.75mm,565nm
330ohm,5%,3W,AA,TP,6x16mm
12Vdc,250mW,5A,1FormA,15mS,5mS
BWH,+,B,M3,L10,ZPC(YEL),SWRCH1
BWH,+,B,M3,L10,ZPC(YEL),SWRCH1
ATT,1500MM,15P/6P,7P,IVORY(IV01),-,D-SUB/MALE
36Vdc,200mA,SP3T,30VDC,0.1A,2C2P,SELF LOCK,EI-1916,AQ17HS,6P,35.0mH,-,-,73.0uH,-,-,7.5ohm/0.04ohm,-,PL-3,DMR30,J2A-1,EI1916
HL-1527C,4.5uH/50mH,DR15*27.5,3.7*11.0,17*15.5*47,15*8T,5P,BK,10%,19.5ohm/0.04,0
LC-13,CF1781,PN17L,1.12mH,HV45,FUR3556,375.0mohm,71.0Vdc,14P,-10 ~60,BK,27.0KV
EE-1916,AP17JS,8P,1.0MH MIN,-,-,450MH MIN,-,-,0.70OHM/450OHM,-,PL3,DMR30,PM2A,EE
EER3541(16P),DF(85KHZ),-,90~264V,PL3,DMR30,-,EER3541,-,-,390UH,-,110UH,-,80V,-,-,-,-,-,3-1(250UH),4-6(250UH,-,-,-,0.13OHM,-,SB-5S,UU1116,-,-,-,B,9ohm,20%,-,-,TR,RECT,8ohm,15%,-,17mW/C,BK
CA17KS,-,-,-,-,-,-,-,-
Remarks
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
! SNA
SNA
SNA
SNA
SNA
SNA
!
!
SNA
7-1
CONFIDENTIAL
8 Block Diagrams
CA17K*/CA17J*
8-1
CONFIDENTIAL
9 Wiring Diagram
MAIN PCB
CRT SOCKET PCB
CRT SOCKET
FOCUS1 (WHT)
FOCUS2 (RED)
G2
2 x 3p DY
2 x 3p DY
YELLOW
BROWN
BLUE
RED
V–
V+
H–
H+
1
1
2
3
4
2
3
4
V–
V+
H–
H+
YELLOW
BROWN
BLUE
RED
CN501
FBT
CN403
CN102
CN201
80 V
GND
6.3 V
G1
GND
12 V
V-SYNC
ACL
IICDATA
IICCLK
HS_OUT(CLAMP)
OSD 5 V
AFC
DEGAUSSING COIL
AC
AC
1
1
2
2
AC INPUT
AC
AC
1
GND
2
AC INPUT
3
AC INPUT
CN603
IS601
FOCUS
(WHT)
1
1
2
3
4
5
6
7
8
9
2
3
4
5
6
7
8
9
10
11
12
13
10
11
12
13
14
80 V
GND
6.3 V
BLANK
G1
GND
12 V
V-SYNC (V_BLK)
ACL
IICDATA
IICCLK
HS_OUT (CLAMP)
OSD 5 V
AFC
CN204
BLUE
WHITE
WHITE
WHITE
CN101
R
GND
G
GND
B
GND
GND
KEY
GND
KEY
1
SIGNAL CABLE
1
GND
HS-IN
VS-IN
DDC DATA
DDC CLK
S-RASTER
DDC 5V
1 R_IN
2 GND_R
3 G_IN
4 GND_G
5 B_IN
6 GND_B
1
2
3
4
2
3
4
5
6
2
3
4
5
6
7
SIGNAL CABLE
5
6
7
1
GND
KEY
GND
KEY
CONTROL PCB
1
3
2
2
3
4
1 TILT+(BLK)
2 NC
GND_RED
3
4
TILT + 1
NC 2
GND 3
TILT
15 PIN
D-SUB
refer to pin
assignment
of
product spec.
BLUE
WHITE
WHITE
WHITE
CN1
CA17K*/CA17J*
GND
HS-IN
VS-IN
DDC DATA
DDC CLK
S-RASTER
DDC 5V
CN304
CN202
9-1
CONFIDENTIAL
10 Schematic Diagrams
10-1 Main Part Schematic Diagram
210V
12V
CN202
slcon7p
1
13V_1
COIL_5V
R557 DELETE
HS_IN
CN304
slcon3p
3
4
Q301
2N3904
B
4 VCC
DDCCLK
6
C
LM324N
DDCDATA
5
10
TILT
Q551
KSP44
E
R555
1K
1/2W
R552
20K
1/4W
1
C312
10uF
16V
E
B
Q302
2N3906
FBT
C
B
2
11 VSS
DDC5V
R554
240K
1/2W
CC
1/4W
D_F
3
E
Q1
8
Q0
9 Q2
S_RASTER
7
C551
10uF
16V
R556
3.9K
1/6W
IC603-3
VS_IN
R553
330K
1/2W
R551
240K
2
C558
100PF
1KV
C557
680nF
100V
MF
C
50V
ZD208
UZ6.2BSB
E
5V
56 1/8W
17
18
1/8W
L_SENSE
R209
19
20
21
H_LIN
R210
2.7K
1/6W
R206
10K
1/6W
C212
1nF
50V
32
31
C402
HSYNC_IN
R216
100 1/6W
29
R215
100
100NF
63V
MP
27
G2-ADJ
R213
SIZE-ADJ
22
R212
HV-ADJ
H_LIN
1/8W
SGND
HDRV
VCAP
XSEL
VREF
VCC
7
Vin+
VCC_H
VOUTPUT
C502
5.60NF
100V
P
C205
1uF
50V
V_OUT
13
17
R225
56
B
C509
2.2uF
250V
D501
1N4148
56
C207
4.7uF
50V
C408 DELETE
BD404 TO R401
Q417
KSC945-Y
50V
D431
TVR10G
1.2UH,3.5_5.7MM
C
E
56
1/8W
D
Q402
IRF740A
Q423
KSA733-Y
S
R413
0.56
1/2W
100V
P
1/8W
7
10
AP17KS:DELETE
ZD603
P6KE200ATA
Q416
2.2K
1/8W
2.2K
1/8W
KSP42
1
2
3
C609
22uF
50V
C607
100nF
50V
MO
F_B DRAIN
D605
UF4007
1 B
R627
5.6K
1/6W
2
17
3
16
D614
TVR10G 4
BD601
1.2UH
GND
Vcc SYNC
5
C630
47uF
35V
C613
100pF
1KV
C623
1000uF
16V
ZD604
UZ24BSC
14
6
13
7
12
R607
10K
3W
slcon3p
MO
D604
UF4007
8
11
9
10
4
EY608
EYE1.5
EY612
EYE1.5
D608
UG2D
FH1
BH26-00135A
FUSE
1
EY602
Q0
7V
13V_2
12V
13V_2
E
E
2
R618
1K
1/8W
C626
100UF
16V
3
Vout
Vin
GND
Vc
1
AC90V~AC264V
ZD606
MTZ7.5C
R614
220
1/2W
SK501
S-23(1KV),5MM
C445
10NF
500V
T502
EE-1916
MO
R445
82
2W
13
C431
220nF
250V
MPS
S
R433
680
3W
MO
RADIAL
470nF,5,250V,TP,18x16x8,7.5
C-FILM,MPPF
Q411
S
R428
330
3W
MO
CN409
1
slcon1p
C444
10nF
630V
PP
HS401
COIL_5V
R437
47K
1/6W
C429
1uF
50V
IC603-4
LM324N
R439
47K
1/6W
4 VCC
H_LIN
BD401
1.2UH
D407
UF1G
C435
.15NF
500V
Q412
2N3904
Q1
14
Q0
13 Q2
11 VSS
C421
3.3nF
HS409
heat_sink
C
B
12
C421(KS) 4nF 630V
B
4
D409
31DF6
BD403
1.2UH
R440
10K
1/8W
5
EY404
EYE1.5
1
R429
3.3K
R621
820K
1/6W
R630
47K
1/6W
D421
1N4148
2
5
3
1/2W
G
S
Q403
IRFU210A
T401(jS):00090A
T401(KS):00027A
R432
22
1/2W
D412
TVR10G
HL-1425
C434
C438
10uF
16V
100uF
16V
EY402
SNAME
4
3
2
1
0.68 3W
C
C450
1uF
63V
MP
6
Q404
2SC5583
B
D405
EK-04
C436
820PF
500V
1
VERT2
CN403
slcon4p
D406
ERD07-15AL
6
2
VERT1
C419(ks) 2.5nF 1.6kv
R431(KS):0.6 2W
R430
15K
1/2W
MO
KS:5.2uH
R441
10K
1/8W
D408
DTV56F
C419
2.2NF
1.6KV
OT
C420
2.2nF
1.6KV
PP
R431
0.68
3W
WW
3
JS:4.5uH
C
Q413
2N3906
630V
P
R443
150
3W
T402
E
E
6
T401
EI-1916
1
SW401
JRS-1301
1
13V_1
Q411(KS):IRF630
G
2 3 4
EY403
SNAME
1
D
IRF640A
D410
TVR10G
D411
TVR10G
C431(KS): 200NF
C430_1
680nF
250V
MPS
C426
1uF
50V
C443
10nF
630V
PP
Q422
IRF740
EY401
BH27-20342U
R446
15
1/2W
D413
TVR10G
L403
7.1MH
(8.2mH)
C446
68pF
500V
C433
10nF
250V
MP
C
B
Q410
G
c432(js):18nf 250v
c432(ks):15nf
C432
22nF
250V
MP
E
Q404(KS):FJAF6910
H-DY
R460
5.6
3W
MO
R427
3.3K
1/8W
Q609
KTA1281-Y
B
IC602
PQ12RD11
R631
1K
1/2W
4
C
5
OFF_MODE
Q610
4
250V
MP
C430(KS): 470NF
D404
1N4007GP
D
4
C415
4.7uF
100V
D
D420
1N4148
0.39
1/2W
KSC945-Y
3
D422
1SS244
R444
4.7M
R426
10
1/4W
R622
3.3K
1/4W
C618
1000uF
16V
R530
10K
1/8W
Q410(KS):IRF630
S
R428(KS):270
7
R617
2
CN601
100nF
100V
P
13V_1
13V
slcon3p
AC INPUT
C416
R425
680
1/4W
100uF
16V
CN408
slcon1p
1
C220
B
3
2
1
2
R615
1K
1/2W
T602
BH26-30302S
1
1
6.3V
C
3
Q1
Q2 2
EYE2.2
EY601
EYE2.2
R641
56
2W
MO
C622
1000uF
16V
REG
E
IRF640A
S
BD402
1.2UH
470nF
50V
1
125V
R533
15M
1/2W
CC
jp72ks
C414
KSD1616-Y
VSS 11
1
G
HS403
1/6W
C617
2.2nF
VCC 4
C
D
120uH
E Q408
KTD2058-Y
H_OUT
B
IC603-1
LM324N
R601
330K
1/2W
C427
270nF
250V
MPS
A
R435
47K
1/6W
50V
B
Q604
CN602 : JP64(JUMPER)
R600
330K
1/2W
C620
150uF
63V
1/6W
FBT
C457
5.6nF
250V
MP
C457(JS):DELETE
C457(KS):5.6NF
IRF630
G
S
C423
1uF
L401:120uH
330pF
500V
EY610
EYE1.5
R527
BH26-00137A
C456
5.6nF
Q409
47K
1/6W
B
1/6W
C619
C616
2.2nF
125V
C611
50V
1uF
R424
12K
1/4W
MF
12V
47uF
50V
SHL
D609
321DF4
V_REG
D512
1N4148
D515
1N4148
50V
UF4007(T)
10
2W
MO
10K
P 1/8W
68K
C455
5.6nF
250V
MP
Q410(ks)IRF630
D
E
2
3
1.8K
1/4W
MF
C621
EY611
EYE1.5
14
B
R453
10K
D403
1N4007GP
D
1.2UH
15
5
C511
3.3nF
100V
P
C513
1nF
500V
E
C425
150nF
250V
MPS
D402
1N4007GP
R457
50V
Q607
C 2N3906
11
VSS
BD602
R619
1
C601
150nF
275VAC
INOUT
GND
BD603
1.2UH
R423
R452
10K
400V
P
G
C441
1uF
L401
C
UG2D
D611
D610
ZD600
MTZJ27D-T-72
CN602
C
D414
1N4148
E
ER-3541
18
COIL_5V
B
T601
R526
18K
1/8W
R524
R454
330
2W
MO
CC
C
S1
C
S2
B
EYE1.5
R532
3.3M
1/2W
R416
150K
1/2W
B
E
Q421
IRF630
E
R422
82
C
VCC
IC603-2
4
LM324N
5
7
Q1
Q0
6 Q2
IC604
KIA7805P
1
4
EY603
EYE2.2
3
EY607
R612
56K
2W MO
C624
120pF
1KV
IC601
DP104C
220uF
450V
C602
150nF
275VAC
2
1
C614
10nF
500V
Q608
KSD1616-Y
C413
3.3UF
50V
B
13V_1
80V
13V
D612
UF4004
1
C608
L601
EY606
1
EY604
EYE2.2
C604
4.70NF
250V
C603
4.70NF
250V
EY605
1
R531(KS)130K
R531
68K
1/6W
D516
1N4148
SCREEN
12V
R436
Q415
KSP42
C442
68nF
D430
1N4007GP
Q407
2N5551C-Y
C
1
TH602
SCK-083
1
50V
1
4
R610
180K
1/2W
CC
EY502
EYE2.2
R525
12K
1/6W
A
C427(KS): 180NF
C412
3.3nF
100V
P
C411
56NF
100V
P
L_SENSE
-10V
EY609
EYE1.5
HS601
BH62-00004A
D606
TVR10G
EY501
EYE2.2
1
H/V
12V
R434
C
R451
10K
10K
1/6W
B
1
1
3
C625
220nF
63V
MP
GT603
C615
1nF
500V
1
2
1
D601
G2SB60L-5700
R609
180K
1/2W
CC
R611
15
1/6W
B
ZD602
UZ4.7BSA
GT604
C
S3
E
R456
7V
C631
100nF
50V
MO
R608
100
1/6W
Q601
KSC945-Y
R602
47
1/4W
E
C
1N4148
E
47nF
100V P
B
E
C409
1uF
250V
MPS
47NF
250V
MP
BD405
1.2UH,3.5*5.7MM
B
R420
180K
1/4W
MF
8.2nF
100V
P
D615
B
C610
1/8W
C
D602
1N4148
1
E
B
C458
R417
12K
1/6W
B
4
2
Q406
KSA733-Y
Q414
KSP42
C
B
S4
R419
200K
1/6W
R418
1.2K
1/4W
EW_OUT
5V
1
3
RL601
G5PA-1
R605
4.7K
1/8W
ZD601
UZ6.2BSB
C
R603
10K
1
1
FOCUS
B
3
7
8
6
2
5
1
4
R613
10K
1/8W
Q602
2N3904
1
D-COIL
R604
560
1/8W
TH601
500V
14
R438
2.2K
1/8W
R455
2.2K
1/8W
Q405
1
1
500V
B
R450
22K
1/6W
SIZE_ADJ
KSA733-Y
C635
10nF
2
13
R414
0.56
1/2W
12V
12V
12V
Q420
DEGAUSS
12
2
V_REG_1
KSP42
3
1
EY506
EYE1.5
D401
UF4004
HS402
heat_sink
AP17KS:2.2K
13V_2
EY505
EYE1.5
1
B
8
SW601
KPJ-2S1BB
3
C531
10nF
500V
C408
G
Q402(KS):IRF634A
R442
10K
1/8W
R412
10K
1/8W
11
C447
330pF
1.5K
2W
MO
R406
22K
1/6W
B
Q401
2N3904
10
4
R421
100UH
R401
1/2W
2.2
5
L402
C
E
E
B
C406
4.7nF
AP17JS:DEL
CN603
slcon3p
C510
27nF
100V
9
C407
150uF
63V
HS_OUT
R402
16
HUNLOCK CLBL
R205
2.2K
1/8W
C225
4.7uF
50V
1
EY512
EYE1.5
$P
11
B
R408
1K
1/8W
VS_OUT
15
IICCLK HSYNC
C410
100UF
16V
1/8W
D502
RGP02-12(T)
D517
RGP02-12(T)
C506
10NF
2KV
C505
220nF
63V
MP
C
R409
5.6K
1/6W
V_REF
R301
14
4
C210
4.7uF
50V
EY511
EYE1.5
EY504
EYE1.5
8
RGP02-16E
AP17JS(85Khz)ONLY
R210
47K
1/2W
7
D503
D508
1N4148
1/2W
R410
HV_ADJ 1.5K
1/4W
C459
270pF
50V
jp138 delete(ic201#19~26)
R628
1/8W
1.2K
C507
1nF
500V
210V
R458
22
12V
R407
470
1/2W
V_BLK
C215
100pF
50V
R201
1M
1/6W
EY503
EYE2.2
R529
24K
1/6W
6
MF
12V
R505
15K
1/4W
MF
EW_OUT
12
IICDATA VSYNC
18
R504
15K 1/6W
P
H_OUT
11
21
19
R502
47K
1/4W
MF
1/4W
MF
R506
270K
1/4W
10
EWDRV
VAGC
1/8W
IICCLK
HV_ADJ
PGND
ASCOR VOUT1
SIZE_ADJ
33K
BDRV
HPLL1
C503
1uF
50V
C504
3.3nF
100V
VSMOD VOUT2
IICDATA
1/8W
1K
HBUF
20
24
TILT
MF
R224
56
REG
23
1
ACL
T501
R513
240K
1/4W
MF
AFC
R511
2.7
1/4W
R507
10K
5
9
22
V_REG
1/8W
BIN
8
23
MP
R239 10K
25
LATCH
R501
2.7K
1/6W
1/6W
C501
22nF
100V
P
1M
1/6W
6
24
63V
26
BSENSE 4
HREF
25
1/4W
C302
220nF
HS_OUT
ACL
REG
R519
150K
D513
1N4148
C530
1nF
500V
3
BOP
HCAP
26
R302
CLAMP
DDCCLK
RESET
C401
8.2nF
100V
P
22K
VS_OUT
HSYNC_OUT
DDCDATA
28
R500
2
XRAY
HPLL2
29
VS_IN
1/6W
28
TEST
30
3
1
HFLB
HSMOD
27
C301
100nF
63V
MP
HS_IN
30
VSYNC_IN
1
1
1
C211
100pF
50V
VSYNC_OUT
X-IN
4.7K 1/8W
TILT
C204
4.7uF
50V
NC
X-OUT
FOCUS
31
R403
750
1/4W
MF
R405
3.3K
1/8W
KEY3
33
GND
EY507
EYE1.5
EY508
EYE1.5
HS501
BH62-00015A
1
16
R207
R208
56
1/4W
MF
34
GND
32
100V
PP
KEY1
35
5V
EY510
EYE2.2
V_REG_1
C512
1nF
500V
C508
1nF
500V
D514
1N4148
C514
470nF
50V
R510
100K 1/8W
TDA4856
C403
10NF
R404
2.7K
MODEL-SEL
NC
1/2W
CC
4
15
IC401
100V
P
KEY1
R534
30M
330K
1/2W
D511
1N4148
B
E
D416
1N4148
Q1
Q0
14
5V
AVREF
R508
SIZE_REG
OP201
LTL-10233W
270
1/4W
R509
330K
1/2W
C515
100nF
50V
ZD501
UZ4.7BSA
C
OFF_MODE
UZ5.1BSB
---------
C404
2.2nF
36
SELFRASTER
13
DDCCLK
12
SIZE_REG
KEY2
V_MUTE
12
DDCDATA
12V
ZD206
UZ6.2BSB
37
8
11
R223
38
KEY3
7
10
X201
8MHz
100
1/6W
D415
1N4148
39
POWER_KEY
9 NC
C203
22pF
50V
Q503
KSA733-Y
R510(ks):150k
IICCLK
100
1/6W
R560
330K
1/2W
D_F
IICDATA
1/8W
G2
R514
47K
1/6W
AFC_SENSE
IICDATA
ZD207
UZ6.2BSB
R217
40
6 OFF_MODE
C202
22pF
50V
2.7
MF
41
5 S4
R204
4.7K
1/8W
5.6K
1/4W
MF
C521
2.20UF
160V
R309
2.7
MF
D507
1N4148
LED
4 DEGAUSS
R203
4.7K
1/8W
R315
5
IIC_CLK
3 S3
R512
47K
1/2W
6
2 S2
S3
G1
1
IIC_DATA
S2
21
R306
CN502
slcon3p
D506
RGP02-12(T)
VERT1
470
1/2W
IICCLK
JP125KS
R218
100
1/6W
1
TP501
8
S1
AFC_SENSE
R219JS
10K
1/8W
1/6W
2.7K
R221
42
1 S1
V_MUTE
1/6W
2.7K
R222
-140V
B
R570
10K
1/2W
R308
ZD401
R236
10K
1/8W
IC201
25
E
V_BLK
MP
R220
C217
100nF
50V
MO
JS(85K):R219JS/KS(70K):JP125KS=JUMPER
S_RASTER
R303
6.8K
1/6W
1/6W
MODE SELETE
56
C310
3.3nF
100V
P
V_OUT
R229
100
D201DDC
SB020
R214
47K
1/6W
R316
100
1/6W
R312
5.6K
1/6W
VERT2
R304
6.8K
1/6W
8
7
6
5
R310
6.8K
1/4W
MF
1uF
63V
C308
4.7nF
100V P
100V
P
D210
UZ6.2BSB
IC202
R200
D301
UF4004
AFC
KS24C081C
S4
R307
1.2
1/2W
C313
100nF
ZD209
UZ6.2BSB
V_MUTE
C Q501
2N6520
1
12
R311
6.8K
1/6W
4.7nF
50V
MO
10
C307
C305
470uF
16V
R232
100
1/6W
DDC5V
9
1
KEY1
IICCLK
1
2
3
4
8
C306
220uF
35V
HS_OUT
5V
7
1.2UH
C627
470uF
16V
3
2
IICDATA
13
6
B
9
11
5
V_REF
4
ACL
10
4
D518
1N4148
D505
1N4148
1
1K
1/8W
R231
100
1/6W
KEY3
VS_OUT
8
3
2
BD301
R642
1
1/2W
slcon4p
CN205
R233
1K
1/8W
D519
1N4148
R515
47K
1/6W
C309
3
R230
C516 delete
7
GND
1
9
V-H/S WING TYPE
BH62-00047A
HS301
BH62-00003A
F.G
Vin-
6
C214
100uF
16V
C213
10uF
100V
G1
C516G1
1nF
1KV
5
DEGAUSS
1
B
4
OFF_MODE
EY302
IC301
KA2142
-10V
13V_2
13V_1
5V
3
R202
10K
1/6W
1
Vcc_L
2
C201
100uF
16V
EY301
R518
12K
1/2W
Q502
KSC945-Y
6.3V
80V
CN201
slcon13p
1
2
12V
R324
6.2K
1/6W
R320
10K
1/8W
D521
RGP02-16E
ZD204
UZ6.2BSB
1
ZD203
UZ6.2BSB
ZD202
UZ6.2BSB
C
ZD201
UZ6.2BSB
ZD205
UZ6.2BSB
AFC
OFF_MODE
E
R632
10K
5
1/8W
C612
1uF
50V
FUSE : T3.15A OR T4.0A
CA17K*/CA17J*
10-1
CONFIDENTIAL
Copyright
Trademarks
© 2002 by Samsung Electronics Co., Ltd.
Samsung is the registered trademark of Samsung
Electronics Co., Ltd.
All rights reserved.
This manual may not, in whole or in part, be
copied, photocopied, reproduced, translated, or
converted to any electronic or machine readable
form without prior written permission of
Samsung Electronics Co., Ltd.
CA17K*/CA17J* Service Manual
First edition January 2002.
CA17K*/CA17J* and MacMaster Cable Adapter
are trademarks of Samsung Electronics Co., Ltd.
Macintosh, Centris, Quadra, Duo Douk, and
Power Macintosh are trademarks of Apple
Computer, Inc.
All other trademarks are the property of their
respective owners.
Printed in Korea.
ii
CA17K*/CA17J*
CONFIDENTIAL
10 Schematic Diagrams
1 100 V (IC601, #1)
CH1 P-P = 100 V CH1 RMS = 350.2 V
7 1.00 V (IC401, #11)
2 100 V (IC601, #1)
CH1 P-P = 100 V
CH1 RMS = 325.8 V
8 500 V (IC401, #12)
3 2.00 V (IC401, #6)
CH1 P-P = 2.00V CH1 RMS = 5.868V
9
10.0 V (IC301, #6)
5 20.0 V (Q403, Collector)
6 200 V (Q404, Collector)
CH1 P-P = 2.00V CH1 RMS = 5.868V
CH1 P-P = 20.0 V CH1 RMS = 46.80V
CH1 P-P = 200V CH1 RMS = 387.2V
10 2.00 V (Q402, Gate)
11 50.0 V (Q402, Drain)
12 2.00 V (IC401, #32)
CH1 P-P = 50.0 V CH1 RMS = 73.7V
CH1 P-P = 2.00V CH1 RMS = 6.124V
4 2.00V (IC401, #8)
CH1 P-P = 1.00V CH1 RMS = 3.008 V
CH1 P-P = 500 V CH1 RMS = 1.425 V
CH1 P-P = 10.0 V CH1 RMS = 5.06 V
CH1 P-P = 2.00 V CH1 RMS = 7.692V
13 50.0 V (T502, #6)
14 100 V (T502, #1)
21 1.00 V (IC201, #13, 14)
25 5.00V (Q501, Emitter)
CH1 P-P = 50.0V CH1 RMS = 75.6V
CH1 P-P = 100V CH1 RMS = 124.0V
CH1 P-P = 1.00 V
CH1 P-P = 5.00V
10-2
CH1 RMS = 2.108V
CH1 RMS = 28.33V
CA17K*/CA17J*
CONFIDENTIAL
10 Schematic Diagrams
10-2 CA17K* Video Part Schematic Diagram
80V
12V
12V_A
CRT1
12V
DG03
1SS244
DR03
1SS244
DB03
1SS244
RR09
RB09
330K
330K
1/4W
1/4W
RG09
330K
1/4W
BD103
B
L101
0.47uH
C102
100nF
50V
C112
220uF
16V
C108
22PF
50V
MO
2
CG01
100nF
RG02
GIN
3
OSDSW
25V
MO
22
1/10W
4
BIN
6
RG01
75
1/10W
RB01
75
1/10W
DR02
1N4148
7
15
CB01
100nF
25V
MO
8
9
C106
100nF
25V
MO
12V
10
11
RR01
75
1/10W
12
13
C107
10nF
50V
MO
+5V
14
15
OSD-SW G_CLP
RIN
G_OUT
VCC1
VCC2
gnd1
GND2
GIN
B_OUT
VCC2
BCLP
BIN
H_BLK
CLAMP
GND
ABL
RCT
SCL
GCT
SDA
BCT
VDDOUT
NC
R117
100
27
VIN2
GND2
RG06
22
1/10W
25
24
Q102
2N3904
VCC
21
H_FLB1
19
18
17
16
CB02 CR02
100nF 100nF
25V
25V
MO
MO
CG02 RR05 RG05
390
100nF 390
1/10W 1/10W
25V
MO
RB05
390
1/10W
LR10
0.47UH
LG10
0.47UH
LB10
0.47UH
CR10
15PF
50V
MO
CG10
15PF
50V
MO
CB10
15PF
50V
MO
RR10
220
1/10W
RG10
220
1/10W
RB10
220
1/10W
RB07
18K
1/10W
RG07
18K
1/10W
BD106
1.2UH,3.5*5.7MM
B
2
H
B
G
C
1/6W
F
4
D
E
6
5
E
C
R122
10K
1/10W
SCL
ZD104
C122
100uF
16V
ZD103
UZ6.2BSB
L102
4.7uH
4.7uH
ACL
ZD102
UZ6.2BSB
13
12
14
AFC
5V
11
SCL
CLAMP
9
8
7
6
5
4
10
SDA
ACL
V_BLK
12V
GND
G1
3
2
GND
6.3V
C135
100UF
16V
MO
R128
5.6K
1/10W
24
1A
2E
1B
2F
1C
1D
R130
5
6.8K
1/10W
6
1E
2I
1F
2J
1H
2L
1I
2M
C129
C130
100PF
50V
MO
330
1/10W
R141
330
1/10W
GOSD
BOSD
OSDSW
330
1/10W
R143
220
1/10W
V_BLK
16
15
1J
2N
1K
1N
1L
1M
12
100PF
50V
MO
1/10W
17
10
R133
1K
1/10W
330
2K
9
SCL
20
R140
18 R142
1G
11
R139
19
8
SDA
ROSD
21
2H
7
R132
1K
1/10W
INT
2G
4
R129
12K
1/10W
23
OSD SMD IC
22
3
H_FLB2
S5D2509X09-S0
23
2
C128
10nF
50V
MO
22
IC103
1
80V
CB05
100nF
100V
P
L111
1.5uH
C134
100nF
25V
CN102
slcon14p
CA17K*/CA17J*
CG05
100nF
100V
P
R123
1.5K
1/10W
SDA
C146
100UF
16V
1
10nF
500V
CR05
100nF
100V
P
C118
10uF
100V
*Note : Pedestal Level :06H
UZ6.2BSB
C117
SK108
SSG-102B2
+5V
L104
100uH
B
C125
2.7nF
2KV
7
H_FLB2
80V
CN_GND
1
A
1/6W
H_FLB1
AFC
BD115
1.2UH,3.5*5.7MM
1
8
Cutoff IC
C113
8.2nF
100V
P
C138
390pF
50V
MO
C121
100uF
16V
G1
SK104
WSP-401M
R151
390
1/2W
BD104
1.2UH,3.5*5.7MM
IC104
LM2480NA
12V
6.3V
EY8
SNAME
C126
100nF
50V
G1
1/6W
3
R121
2.2K
1/10W
C140
1NF
1KV
FOCUS
BD112
1.2UH,3.5*5.7MM
CN_G2
+5V
B
ZD101
BZX79C5V6
EY7
SNAME
1
1/10W
RB03 43K
E
R124
1K
1/10W
EY6
SNAME
1
12V
R119
100
1/10W
CLAMP
L103
1.5uH
EY5
SNAME
1
B
ACL
Q103
KSD1616-Y
1
6.3V
RG03 43K
E
SKR01
SKB01
DMS-200D
DMS-200D
SKG01
DMS-200D
C119
10nF
500V
C116
10uF
100V
20
RR03 43K
R115
8.2K
1/8W
Q101
2N3904
DB05
1N4148
RB06
22
1/10W
22
RR07
18K
1/10W
C
C
DG05
1N4148
DB04
1SS244
DG04
1SS244
DR04
1SS244
1
B
4 5 6 7 8 9 10 11
H H2IC1IC2 G1G2 G3G4
RB12
39
1/2W
VIN1
R116
100
1/10W
R114
12K
1/6W
V_BLK
VOUT3
DR05
1N4148
17
26
j_c11p
80V
12V
B
ACL_ADJ
VBB
B_OUT
SK101
23
D102
1N4148
R112
100
1/10W
GND1
VOUT2
26
1/10W
R118 100
R113
10K
1/10W
VOUT1
VIN3
1
GND
28
RB11
1K
1/2W
CB06
470nF
100V
MP
1 RK
2GK
3 BK
G_OUT
2
RR06
22
1/10W
29
R_OUT
RG12
39
1/2W
C127
1.8nF
1KV
C120
4.7uF
50V
12V
6
R_OUT
1/2W
B
DG02
1N4148
DB02
1N4148
5
C105
4.7uF
50V
5
RB02
22
1/10W
4
R_CLP
BOSD
3
BOSD
GOSD
RB08
22
1/10W
4
1
3
RG11
1K
1/2W
RR12
39
LB11
0.22uH
LM2413T
INT
7
2
30
8
ROSD
GOSD
INT
ROSD
9
RR02
22
1/10W
RIN
1
10
CR01
100nF
25V
MO
11
CN101
slcon6p
DR01
1N4148
IC105
16
IC102
S1D2518X01
DG01
1N4148
LG11
0.22uH
EY1
1
EY2
1
KA2518
DB01
1N4148
RR11
470
1/2W
CG06
470nF
100V
MP
RG08
22
1/10W
HS103
heat_sink
5
C139
100nF
25V
MO
C131
220UF
16V
R106
33
1/10W
C104
470uF
16V
LR11
180NH
CR06
470nF
100V
MP
RR08
22
1/10W
24
AP17JS(85K)
M41QCJ761X174(T4)
BH03-00024U
130uH SDI DF CDT
M41QCJ761X173(T4)
BH03-00024T
180uH SDI DF CDT
6
+5V
AP17KS(70K)
14
13
R144
3.9K
1/10W
ACL_ADJ
C137
4.7uF
50V
CN_GTP1
1
10-3
CONFIDENTIAL
10 Schematic Diagrams
15 1.00 V (IC102,#5, 8, 10)
16 1.00 V (IC102, #25,28,30)
17 20.0 V (IC105, #1, 3, 5)
22 1.00 V (IC103, #5, 24)
CH1 P-P = 1.00V
10-4
CH1 RMS = 4.516V
23 1.00 V (IC103, #20, 21, 22)
24 10.0 V (R,G,B, Video)
CH1 P-P = 10.0V
CH1 RMS = 17.02V
26 20.00V (CRT Socket, G1)
CH1 P-P = 20.0V CH1 RMS = 66.68V
CA17K*/CA17J*
CONFIDENTIAL
10 Schematic Diagrams
10-3 CA17J* Video Part Schematic Diagram
80V
12V
12V_A
12V
CRT1
+5V
+5V
DG03
1SS244
DR03
1SS244
DB03
1SS244
RR09
RB09
330K
330K
1/4W
OSDSW
1/4W
L101
0.47uH
5
RB02
22
1/10W
4
BIN
6
5
6
RB01
75
1/10W
RG01
75
1/10W
RR01
75
1/10W
3
1
7
3
2
1
DG01
MMBD4148SE
CB01
100nF
25V
MO
2
8
9
DB01
MMBD4148SE
R145
11M
0.100W
C145
6.8nF
50V
MO
R101
6.8K
1/10W
VCOIN
1H
VREF
1I
11
VDDA
1K
SDA
1L
S1D2520
L106
1.5uH
D101
1N4148
R102
12K
1/10W
C148
100UF
16V
5
15
28
C147
100nF
25V
MO
G_CLP
G_OUT
VCC1
VCC2
GND2
B_OUT
RG06
22
1/10W
Q102
2N3904
BCLP
BIN
H_BLK
21
C
Q101
2N3904
H_FLB1
GND
19
ABL
RCT
13
18
SCL
GCT
SDA
BCT
VDDOUT
NC
14
17
15
16
CB02
100nF
25V
MO
CR02
100nF
25V
MO
CG02 RR05 RG05
100nF 390
390
25V
1/10W 1/10W
MO
RB05
390
1/10W
100
RG07
18K
1/10W
1
LR10
0.47UH
LG10
0.47UH
LB10
0.47UH
CR10
15PF
50V
MO
CG10
15PF
50V
MO
CB10
15PF
50V
MO
RR10
220
1/10W
RG10
220
1/10W
RB10
220
1/10W
1/6W
1
A
1/6W
2
B
E
C
BD104
1.2UH,3.5*5.7MM
1
7
R122
10K
1/10W
SCL
L104
100uH
F
5
E
CR05
100nF
100V
P
C118
10uF
100V
CB05
100nF
100V
P
L111
1.5uH
C134
100nF
25V
ZD104
C135
100UF
16V
MO
22
ZD103
UZ6.2BSB
L102
4.7uH
4.7uH
ACL
13
12
14
AFC
5V
11
SCL
CLAMP
9
8
7
6
5
4
10
SDA
ACL
V_BLK
12V
GND
G1
3
2
GND
6.3V
CG05
100nF
100V
P
R123
1.5K
1/10W
IC103
24
1
1
SK108
SSG-102B2
6
SDA
C146
100UF
16V
C125
2.7nF
2KV
G
Cutoff IC
C113
8.2nF
100V
P
CN_GND
*Note : Pedestal Level :06H
ZD102
UZ6.2BSB
80V
R151
390
1/2W
1
H
C
1/6W
4
D
UZ6.2BSB
R128
5.6K
1/10W
CN102
slcon14p
1A
2E
1B
2F
3
1C
1D
R130
5
6.8K
1/10W
6
1E
1F
10
C130
C129
100PF 100PF
50V
50V
MO
MO
330 1/10W
19
R141
330 1/10W
ROSD
330
1/10W
GOSD
BOSD
OSDSW
330
2K
17
1H
2L
1I
2M
1/10W
R143
220
1/10W
V_BLK
16
15
1J
2N
1K
1N
1L
1M
14
13
12
R133
1K
1/10W
R140
18 R142
11
SCL
20
2J
9
SDA
R139
2I
7
1G
INT
23
21
2H
8
R132
1K
1/10W
OSD SMD IC
22
2G
4
H_FLB2
S5D2509X09-S0
23
2
C128
10nF
50V
MO
R129
12K
1/10W
CA17K*/CA17J*
SK104
WSP-401M
+5V
C122
100uF
16V
B
C126
100nF
50V
B
H_FLB2
C117
10nF
500V
B
BD106
1.2UH,3.5*5.7MM
12V
80V
EY8
H_FLB1
AFC
BD115
1.2UH,3.5*5.7MM
FOCUS
G1
8
3
C138
390pF
50V
MO
C121
100uF
16V
G1
EY7
SNAME
BD112
1.2UH,3.5*5.7MM
C119
10nF
500V
C116
10uF
100V
IC104
LM2480NA
R119
100
1/10W
V_BLK
6.3V
EY6
SNAME
1
SNAME
RB07
18K
1/10W
RR03 43K
R121
2.2K
1/10W
C140
1NF
1KV
DB04
1SS244
CN_G2
+5V
B
ZD101
BZX79C5V6
SKB01
SKR01
DMS-200D
DMS-200D
SKG01
DMS-200D
1
ACL
E
R124
1K
1/10W
EY5
SNAME
1
1/10W
RB03 43K
L103
1.5uH
1
12V
RG03 43K
Q103
KSD1616-Y
DB05
1N4148
6.3V
CLAMP
12
RR07
18K
1/10W
CLAMP
R114
12K
1/6W
4 5 6 7 8 9 10 11
H H2IC1IC2 G1G2 G3G4
80V
R115
8.2K
1/8W
E
DG04
1SS244
DR04
1SS244
DG05
1N4148
26
j_c11p
C127
1.8nF
1KV
C
B
ACL_ADJ
17
20
R116
100
1/10W
B
VCC
DR05
1N4148
SK101
RB12
39
1/2W
RB06
22
1/10W
22
VCC2
D102
1N4148
R112
100
1/10W
VOUT3
B_OUT
VIN1
R117 100 1/10W
12V
R113
10K
1/10W
VBB
RB11
1K
1/2W
CB06
470nF
100V
MP
1RK
2GK
3 BK
G_OUT
23
11
19
GND2
24
gnd1
GIN
10
C106
100nF
V_BLK
25V
1/10W
MO
C107
SCL
1/10W
10nF
SDA
50V
+5V
MO
VOUT2
VIN2
25
9
CLAMP
GND1
26
RIN
8
1/10W
VOUT1
VIN3
27
7
12V
GND
R_OUT
RG12
39
1/2W
2
R_OUT
7
R_CLP
BOSD
6
C105
4.7uF
50V
R118
12V
OSDSW
RR06
22
1/10W
29
GOSD
OSD-SW
20
C120
2.2uF
50V
L105
1.5uH
4
1/10W
L107
1.5uH
R103
6.8K
1/10W
BOSD
19
L108
18
FBLK
1.5uH
2K
17
VSS
2L
16
VDD
2M
R107 100
HFLB 15
2N
R108 100
VFLB
14
1N
R109 100
SCL
13
1M
R110 100
VSSA
1G
VICTL
1J
20
3
3
TEST
2J
RB04
470
1/10W
21
2
RB08
22
1/10W
8
RIN
1F
10
12
R111
11M
0.100W
GND
1E
22
CB04
100nF
25V
MO
ROSD
GOSD
LM2413T
INT
INT
1/2W
B
4
GIN
3
23
IC105
30
ROSD
4
2
3
RG04
470
1/10W
24
1
RG11
1K
1/2W
RR12
39
LB11
0.22uH
5
RG02
22
1/10W
2E
VCC
2F
GOUT
2G
GND
2H
ROUT
2I
16
IC102
S1D2518X01
CG04
100nF
25V
MO
LG11
0.22uH
CG06
470nF
100V
MP
EY1
1
EY2
1
KA2518
18
RR11
470
1/2W
6
2
BOUT
VCC
1A
BIN
1B
CLP
1C
GIN
1D
CR04
100nF
25V
MO
9
1
1
2
CG01
100nF
25V
MO
C149
100uF
16V
IC101
1201-001791
1
3
RIN
RR04
470
1/10W
470nF
100V
MP
RG08
22
1/10W
HS103
heat_sink
10
R104
100
1/10W
C108
22PF
50V
MO
L109
1.5uH
11
RR02
22
1/10W
DR01
MMBD4148SE
CN101
slcon6p
CR01
100nF
25V
MO
C139
100nF
25V
MO
C131
220UF
16V
CLAMP
R106
33
1/10W
C104
470uF
16V
RR08
22
1/10W
AP17JS(85K)
M41QCJ761X174(T4)
BH03-00024U
130uH SDI DF CDT
M41QCJ761X173(T4)
BH03-00024T
180uH SDI DF CDT
LR11
180NH
CR06
C102
100nF
50V
C112
220uF
16V
R105
330
1/10W
24
RG09
330K
1/4W
BD103
B
AP17KS(70K)
R144
3.9K
1/10W
ACL_ADJ
C137
4.7uF
50V
CN_GTP1
1
10-5
CONFIDENTIAL
10 Schematic Diagrams
15 1.00 V (IC102,#5, 8, 10)
16 1.00 V (IC102, #25,28,30)
17 20.0 V (IC105, #1, 3, 5)
18 1.00 V (IC101, #20, 22, 24)
22 1.00 V (IC103, #5, 24)
23 1.00 V (IC103, #20, 21, 22)
24 10.0 V (R,G,B, Video)
26 20.00V (CRT Socket, G1)
CH1 P-P = 1.00V
10-6
CH1 RMS = 4.516V
CH1 P-P = 10.0V
CH1 RMS = 17.02V
19 1.00 V (IC101, #14)
20 1.00 V (IC101, #15)
CH1 P-P = 20.0V CH1 RMS = 66.68V
CA17K*/CA17J*
9 PCB Diagrams
CONFIDENTIAL
Memo
9-2
CA17K*/CA17J*
8 Block Diagrams
CONFIDENTIAL
Memo
8-2
CA17K*/CA17J*
CONFIDENTIAL
7 Electrical Parts List
Loc. No.
IC201
CIS
BD301
BD401
BD402
BD403
BD405
BD601
BD602
BD603
C201
C202
C203
C204
C205
C207
C210
C211
C212
C213
C214
C215
C217
C220
C225
C301
C302
C305
C306
C307
C308
C309
C310
C312
C313
C401
C402
C403
C404
C406
C407
C408
C410
C411
C412
C413
C414
C415
C416
C419
C420
C421
C423
C425
7-2
Code No.
0903-001194
BH46-00005K
BH97-00234B
3301-000011
3301-000011
3301-000011
3301-000011
3301-000011
3301-000011
3301-000011
3301-000011
2401-000025
2201-000389
2201-000389
2401-002075
2401-000603
2401-002075
2401-002075
2201-000146
2201-000017
2401-000029
2401-000025
2201-000146
2202-002009
2401-000025
2401-002075
2305-000665
2305-001041
2401-000037
2401-002274
2305-000237
2301-000013
2202-000252
2301-000519
2401-000050
2301-000010
2301-000312
2305-000665
2303-000119
2301-000004
2301-000013
2401-000540
2305-000428
2401-000025
2301-000294
2301-000519
2401-001012
2401-001334
2401-001218
2301-000010
2309-000106
2309-000106
2301-001341
2401-000603
2306-000131
Description
IC-MICROCONTROLLER
MICOM-S/W
ASSY AUTO-MAIN
CORE-FERRITE BEAD
CORE-FERRITE BEAD
CORE-FERRITE BEAD
CORE-FERRITE BEAD
CORE-FERRITE BEAD
CORE-FERRITE BEAD
CORE-FERRITE BEAD
CORE-FERRITE BEAD
C-AL
C-CERAMIC,DISC
C-CERAMIC,DISC
C-AL
C-AL
C-AL
C-AL
C-CERAMIC,DISC
C-CERAMIC,DISC
C-AL
C-AL
C-CERAMIC,DISC
C-CERAMIC,MLC-AXIAL
C-AL
C-AL
C-FILM,MPEF
C-FILM,MPEF
C-AL
C-AL
C-FILM,MPEF
C-FILM,PEF
C-CERAMIC,MLC-AXIAL
C-FILM,PEF
C-AL
C-FILM,PEF
C-FILM,PEF
C-FILM,MPEF
C-FILM,PPF
C-FILM,PEF
C-FILM,PEF
C-AL
C-FILM,MPEF
C-AL
C-FILM,PEF
C-FILM,PEF
C-AL
C-AL
C-AL
C-FILM,PEF
C-FILM,MPE-PPF
C-FILM,MPE-PPF
C-FILM,PPF
C-AL
C-FILM,MPPF
Specification
Remarks
3P863,8Bit,SDIP,42P,600MIL,12MHz,ST,CMOS,PLASTIC,5V,-,-40to+85C,1040BYTE,48KBYTE
CA17KS,-,-,-,-,-,CA17JS
AA,3.5x1.0x5.7mm,1500,2375G
AA,3.5x1.0x5.7mm,1500,2375G
AA,3.5x1.0x5.7mm,1500,2375G
AA,3.5x1.0x5.7mm,1500,2375G
AA,3.5x1.0x5.7mm,1500,2375G
AA,3.5x1.0x5.7mm,1500,2375G
AA,3.5x1.0x5.7mm,1500,2375G
AA,3.5x1.0x5.7mm,1500,2375G
100uF,20%,16V,GP,TP,6.3x11,5
0.022nF,5%,50V,NP0,TP,5x3,5
0.022nF,5%,50V,NP0,TP,5x3,5
4.7uF,20%,50V,GP,TP,5x11,5
1uF,20%,50V,GP,TP,5x11,5
4.7uF,20%,50V,GP,TP,5x11,5
4.7uF,20%,50V,GP,TP,5x11,5
0.1nF,5%,50V,SL,TP,5x3.5,5
1nF,10%,50V,Y5P,TP,5x3.5,5
10uF,20%,100V,GP,TP,6.3x11,5
100uF,20%,16V,GP,TP,6.3x11,5
0.1nF,5%,50V,SL,TP,5x3.5,5
100nF,+80-20%,50V,Y5V,TP,2.3X3
100uF,20%,16V,GP,TP,6.3x11,5
4.7uF,20%,50V,GP,TP,5x11,5
100nF,5%,63V,TP,7.5x4.0x5.0mm,
220nF,5%,63V,TP,7.5x4.5x13.5,5
470uF,20%,16V,GP,TP,8x11.5,5
220uF,20%,35V,WT,TP,10x12.5,5
1uF,5%,63V,TP,7.5x15.5mm,5mm
4.7nF,5%,100V,TP,10.5x12.5x6.5
4.7nF,10%,50V,X7R,TP,2.5x4.3,3.3nF,5%,100V,TP,5.8x3x12.5,5m
10uF,20%,16V,GP,TP,5x11,2.5
100nF,5%,100V,TP,11.5x12.5mm,5
8.2nF,5%,100V,TP,6x12.5mm,5mm
100nF,5%,63V,TP,7.5x4.0x5.0mm,
10nF,5%,100V,TP,7x10x4.5,5
2.2nF,5%,100V,TP,5.5X10X2.9,5m
4.7nF,5%,100V,TP,10.5x12.5x6.5
150uF,20%,63V,LZ,TP,10x25,5
47nF,5%,250V,TP,11x9x4.5,5mm
100uF,20%,16V,GP,TP,6.3x11,5
56nF,5%,100V,TP,9.5x12.5mm,5mm
3.3nF,5%,100V,TP,5.8x3x12.5,5m
3.3UF,20%,50V,BP,TP,16X25,7.5
470nF,20%,50V,GP,TP,5x11,2.5
4.7uF,20%,100V,WT,TP,5x11,5
100nF,5%,100V,TP,11.5x12.5mm,5
2.2nF,5%,1.6KV,TP,23x16x9,7.5m
2.2nF,5%,1.6KV,TP,23x16x9,7.5m
3.3nF,5%,630V,TP,17.4x10x5.4mm,7.5
1uF,20%,50V,GP,TP,5x11,5
150nF,5%,250V,TP,19x16x7.5,7.5
SNA
SNA
SNA
!
!
CA17K*/CA17J*
CONFIDENTIAL
7 Electrical Parts List
Loc. No.
C426
C427
C429
C431
C432
C433
C434
C435
C436
C438
C441
C442
C443
C444
C445
C446
C447
C450
C455
C456
C458
C459
C501
C502
C503
C504
C505
C507
C508
C509
C510
C511
C512
C513
C514
C515
C521
C530
C531
C551
C557
C558
C603
C604
C607
C609
C610
C611
C612
C613
C614
C615
C616
C617
C618
CA17K*/CA17J*
Code No.
2401-000603
2306-000171
2401-000603
2306-000164
2305-000207
2305-001003
2401-000050
2201-002079
2201-000672
2401-000025
2401-000603
2301-001249
2303-000122
2303-000122
2201-000019
2201-000647
2201-000469
2305-000237
2305-000012
2305-000012
2301-000312
2201-000411
2301-000016
2301-000287
2401-000603
2301-000519
2305-001041
2201-000291
2201-000291
2401-002267
2301-000020
2301-000519
2201-000291
2201-000291
2401-001334
2201-000119
2401-002267
2201-000291
2201-000019
2401-000050
2401-001643
2201-000129
2201-000024
2201-000024
2202-002009
2401-000970
2301-000284
2401-000613
2401-000613
2201-000129
2201-000019
2201-000291
2201-000023
2201-000023
2401-000039
Description
C-AL
C-FILM,MPPF
C-AL
C-FILM,MPPF
C-FILM,MPEF
C-FILM,MPEF
C-AL
C-CERAMIC,DISC
C-CERAMIC,DISC
C-AL
C-AL
C-FILM,MPPF
PEF CAPACITOR
PEF CAPACITOR
C-CERAMIC,DISC
C-CERAMIC,DISC
C-CERAMIC,DISC
C-FILM,MPEF
C-FILM,MPEF
C-FILM,MPEF
C-FILM,PEF
C-CERAMIC,DISC
C-FILM,PEF
C-FILM,PEF
C-AL
C-FILM,PEF
C-FILM,MPEF
C-CERAMIC,DISC
C-CERAMIC,DISC
C-AL
C-FILM,PEF
C-FILM,PEF
C-CERAMIC,DISC
C-CERAMIC,DISC
C-AL
C-CERAMIC,DISC
C-AL
C-CERAMIC,DISC
C-CERAMIC,DISC
C-AL
C-AL
C-CERAMIC,DISC
C-CERAMIC,DISC
C-CERAMIC,DISC
C-CERAMIC,MLC-AXIAL
C-AL
C-FILM,PEF
C-AL
C-AL
C-CERAMIC,DISC
C-CERAMIC,DISC
C-CERAMIC,DISC
C-CERAMIC,DISC
C-CERAMIC,DISC
C-AL
Specification
Remarks
1uF,20%,50V,GP,TP,5x11,5
270nF,5%,250V,TP,21.5x12.5mm,7
1uF,20%,50V,GP,TP,5x11,5
220nF,5%,250V,TP,19x22x10,7.5m
18nF,5%,250V,TP,13*9*4.5,5mm
10nF,5%,250V,TP,13x4.5x9mm,7.5
10uF,20%,16V,GP,TP,5x11,2.5
0.15nF,10%,500V,Y5P,TP,6.3x4mm,5
0.82nF,10%,500V,Y5P,TP,6.5x3,5
100uF,20%,16V,GP,TP,6.3x11,5
1uF,20%,50V,GP,TP,5x11,5
68nF,5%,400V,TP,19x7x15mm,7.5
10nF,5%,630V,TP,19x12.5mm,7.5m
10nF,5%,630V,TP,19x12.5mm,7.5m
10nF,+80-20%,500V,Y5V,TP,13.5x4mm,5
0.068nF,5%,500V,NP0,TP,8x3.5mm,5
0.33nF,10%,500V,Y5P,TP,5.5x3,5
1uF,5%,63V,TP,7.5x15.5mm,5mm
5.6NF,10%,250V,TP,14.5X9.0X6.0MM,7.5
5.6NF,10%,250V,TP,14.5X9.0X6.0MM,7.5
8.2nF,5%,100V,TP,6x12.5mm,5mm
0.27nF,10%,50V,Y5P,TP,4x3.5,5
22nF,5%,100V,TP,7.2x4.5x9.0mm,
5.6nF,5%,100V,TP,10.5x12.5x6.5
1uF,20%,50V,GP,TP,5x11,5
3.3nF,5%,100V,TP,5.8x3x12.5,5m
220nF,5%,63V,TP,7.5x4.5x13.5,5
1nF,10%,500V,Y5P,TP,7.5x3.5,5
1nF,10%,500V,Y5P,TP,7.5x3.5,5
2.2uF,20%,250V,GP,TP,8x11.5,5
27nF,5%,100V,TP,7.3x4x12.5mm,5
3.3nF,5%,100V,TP,5.8x3x12.5,5m
1nF,10%,500V,Y5P,TP,7.5x3.5,5
1nF,10%,500V,Y5P,TP,7.5x3.5,5
470nF,20%,50V,GP,TP,5x11,2.5
100nF,+80-20%,50V,Y5V,TP,8x3,5
2.2uF,20%,250V,GP,TP,8x11.5,5
1nF,10%,500V,Y5P,TP,7.5x3.5,5
10nF,+80-20%,500V,Y5V,TP,13.5x4mm,5
10uF,20%,16V,GP,TP,5x11,2.5
0.68uF,20%,50V,GP,TP,5x11mm,5
0.1nF,10%,1kV,Y5P,TP,7x4,5
4.7nF,20%,250VAC,Y5U,TP,16x7,7
4.7nF,20%,250VAC,Y5U,TP,16x7,7
100nF,+80-20%,50V,Y5V,TP,2.3X3
22uF,20%,50V,WT,TP,5x11,5
47nF,5%,100V,TP,8.5x12.5mm,5mm
1uF,20%,50V,WT,TP,5x11,5
1uF,20%,50V,WT,TP,5x11,5
0.1nF,10%,1kV,Y5P,TP,7x4,5
10nF,+80-20%,500V,Y5V,TP,13.5x4mm,5
1nF,10%,500V,Y5P,TP,7.5x3.5,5
2.2nF,20%,125V,Y5U,TP,11x7,5
2.2nF,20%,125V,Y5U,TP,11x7,5
1000uF,20%,16V,GP,TP,10x16,5
7-3
CONFIDENTIAL
7 Electrical Parts List
Loc. No.
C619
C620
C621
C622
C623
C624
C625
C626
C627
C630
C631
C635
CA17JS
CN304
CN408
CN409
CN603
ZD210
D301
D401
D402
D403
D404
D405
D407
D410
D411
D412
D413
D414
D415
D416
D420
D421
D422
D430
D431
D501
D502
D503
D505
D506
D507
D508
D511
D512
D513
D514
D515
D516
D517
D518
D519
D520
D602
7-4
Code No.
2201-000469
2401-000540
2401-001585
2401-000039
2401-000039
2201-000210
2305-001041
2401-000025
2401-000037
2401-001561
2202-002009
2201-000019
BH39-40305U
3711-000197
BH71-40300A
BH71-40300A
3711-000217
0403-000361
0402-000274
0402-000274
0402-000006
0402-000006
0402-000006
0402-000208
0402-001118
0402-000546
0402-000546
0402-000546
0402-000546
0401-000005
0401-000005
0401-000005
0401-000005
0401-000005
0401-000004
0402-000006
0402-000546
0401-000005
0402-000017
0402-000252
0401-000005
0402-000017
0401-000005
0401-000005
0401-000005
0401-000005
0401-000005
0401-000005
0401-000005
0401-000005
0402-000017
0401-000005
0401-000005
0402-000252
0401-000005
Description
C-CERAMIC,DISC
C-AL
C-AL
C-AL
C-AL
C-CERAMIC,DISC
C-FILM,MPEF
C-AL
C-AL
C-AL
C-CERAMIC,MLC-AXIAL
C-CERAMIC,DISC
CBF HARNESS
CONNECTOR-HEADER
PIN HINGE
PIN HINGE
CONNECTOR-HEADER
DIODE-ZENER
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-SWITCHING
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-SWITCHING
DIODE-RECTIFIER
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-RECTIFIER
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-RECTIFIER
DIODE-SWITCHING
Specification
0.33nF,10%,500V,Y5P,TP,5.5x3,5
150uF,20%,63V,LZ,TP,10x25,5
47uF,20%,50V,WT,TP,8x11.5,5
1000uF,20%,16V,GP,TP,10x16,5
1000uF,20%,16V,GP,TP,10x16,5
0.12NF,10%,1KV,Y5P,TP,6.3X4MM,5
220nF,5%,63V,TP,7.5x4.5x13.5,5
100uF,20%,16V,GP,TP,6.3x11,5
470uF,20%,16V,GP,TP,8x11.5,5
47uF,20%,35V,WT,TP,8x11.5,5
100nF,+80-20%,50V,Y5V,TP,2.3X3
10nF,+80-20%,500V,Y5V,TP,13.5x4mm,5
52MM,AWG22(0.6PI),-,-,AWG22(0.
1WALL,3P,1R,2.5mm,STRAIGHT,SN
-,BRASS,D2.36,SN,HEAT/SINK
-,BRASS,D2.36,SN,HEAT/SINK
1WALL,3P,1R,3.96mm,STRAIGHT,SN
UZ6.2BSB,6.2V,5.99-6.24V,500mW
UF4004,400V,1A,DO-41,TP
UF4004,400V,1A,DO-41,TP
1N4007GP,1000V,1A,DO-41,TP
1N4007GP,1000V,1A,DO-41,TP
1N4007GP,1000V,1A,DO-41,TP
EK-04,40V,1.5A,DO-41
UF1G,400V,1.2A,DO-204AL,TP
TVR10G,400V,1.0A,DO-41,TP
TVR10G,400V,1.0A,DO-41,TP
TVR10G,400V,1.0A,DO-41,TP
TVR10G,400V,1.0A,DO-41,TP
1N4148,100V,200mA,DO-35,TP
1N4148,100V,200mA,DO-35,TP
1N4148,100V,200mA,DO-35,TP
1N4148,100V,200mA,DO-35,TP
1N4148,100V,200mA,DO-35,TP
1SS244,250V,625mA,DO-34,TP
1N4007GP,1000V,1A,DO-41,TP
TVR10G,400V,1.0A,DO-41,TP
1N4148,100V,200mA,DO-35,TP
RGP02-12,1200V,0.5A,DO-204AL,T
RGP02-16E,1.6KV,0.5A,DO-41,TP
1N4148,100V,200mA,DO-35,TP
RGP02-12,1200V,0.5A,DO-204AL,T
1N4148,100V,200mA,DO-35,TP
1N4148,100V,200mA,DO-35,TP
1N4148,100V,200mA,DO-35,TP
1N4148,100V,200mA,DO-35,TP
1N4148,100V,200mA,DO-35,TP
1N4148,100V,200mA,DO-35,TP
1N4148,100V,200mA,DO-35,TP
1N4148,100V,200mA,DO-35,TP
RGP02-12,1200V,0.5A,DO-204AL,T
1N4148,100V,200mA,DO-35,TP
1N4148,100V,200mA,DO-35,TP
RGP02-16E,1.6KV,0.5A,DO-41,TP
1N4148,100V,200mA,DO-35,TP
Remarks
SNA
SNA
SNA
SNA
CA17K*/CA17J*
CONFIDENTIAL
7 Electrical Parts List
Loc. No.
D604
D605
D606
D608
D610
D611
D612
D614
EY301
EY302
EY401
EY402
EY403
EY501
EY502
EY503
EY504
EY505
EY506
EY507
EY508
EY510
EY511
EY512
EY601
EY602
EY603
EY604
EY605
EY606
EY607
EY608
EY609
EY610
FH1
GT603
GT604
IC202
IC603
J142
J144
J145
JP1
JP10
JP100
JP102
JP103
JP104
JP106
JP107
JP11
JP110
JP111
JP112
JP113
CA17K*/CA17J*
Code No.
0402-000012
0402-000012
0402-000546
0402-001194
0402-000012
0402-001194
0402-000274
0402-000546
6042-000001
6042-000001
6042-000002
6042-000002
6042-000002
6042-000001
6042-000001
6042-000001
6042-000002
6042-000002
6042-000002
6042-000002
6042-000002
6042-000001
6042-000002
6042-000002
6042-000001
6042-000001
6042-000001
6042-000001
6042-000001
6042-000001
6042-000002
6042-000002
6042-000002
6042-000002
3602-000001
BH71-40300A
BH71-40300A
1103-001150
1201-000229
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
Description
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-RECTIFIER
DIODE-RECTIFIER
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
FUSE-CLIP
PIN HINGE
PIN HINGE
IC-EEPROM
IC-OP AMP
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
Specification
UF4007,1KV,1A,DO-41,TP
UF4007,1KV,1A,DO-41,TP
TVR10G,400V,1.0A,DO-41,TP
UG2D,200V,2A,DO-204AC,TP
UF4007,1KV,1A,DO-41,TP
UG2D,200V,2A,DO-204AC,TP
UF4004,400V,1A,DO-41,TP
TVR10G,400V,1.0A,DO-41,TP
ID2.2,OD2.7,L3.1,SN,BSS3-E/EH
ID2.2,OD2.7,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
ID2.2,OD2.7,L3.1,SN,BSS3-E/EH
ID2.2,OD2.7,L3.1,SN,BSS3-E/EH
ID2.2,OD2.7,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
ID2.2,OD2.7,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
ID2.2,OD2.7,L3.1,SN,BSS3-E/EH
ID2.2,OD2.7,L3.1,SN,BSS3-E/EH
ID2.2,OD2.7,L3.1,SN,BSS3-E/EH
ID2.2,OD2.7,L3.1,SN,BSS3-E/EH
ID2.2,OD2.7,L3.1,SN,BSS3-E/EH
ID2.2,OD2.7,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
-,-,30mohm
-,BRASS,D2.36,SN,HEAT/SINK
-,BRASS,D2.36,SN,HEAT/SINK
524C80D81,8KBit,DIP,8P,300MIL,10mS,5V,10%,PLASTIC,-25to+70C,10uA,CMOS,ST
324,DIP,14P,300MIL,QUAD,100V/m
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
Remarks
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
7-5
CONFIDENTIAL
7 Electrical Parts List
Loc. No.
JP114
JP120
JP122
JP126
JP127
JP128
JP13
JP130
JP133
JP134
JP136
JP137
JP139
JP14
JP140
JP141
JP16
JP17
JP18
JP19
JP2
JP20
JP22
JP23
JP24
JP26
JP29
JP3
JP31
JP32
JP34
JP35
JP36
JP4
JP40
JP42
JP44
JP46
JP47
JP5
JP50
JP51
JP52
JP55
JP58
JP59
JP6
JP60
JP63
JP64
JP66
JP67
JP68
JP7
JP70
7-6
Code No.
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
Description
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
Specification
Remarks
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
CA17K*/CA17J*
CONFIDENTIAL
7 Electrical Parts List
Loc. No.
JP8
JP82
JP85
JP87
JP9
JP93
JP94
JP95
JP96
MP1.0
Q301
Q302
Q401
Q405
Q406
Q407
Q412
Q413
Q414
Q415
Q416
Q417
Q420
Q423
Q501
Q502
Q503
Q551
Q601
Q602
Q604
Q607
Q608
Q609
Q610
R200
R201
R202
R203
R204
R206
R207
R208
R209
R210
R211
R212
R213
R214
R215
R216
R217
R218
R219JS
R220
CA17K*/CA17J*
Code No.
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH41-00208A
0501-000122
0501-000581
0501-000122
0501-000303
0501-000303
0501-000140
0501-000122
0501-000581
0501-000412
0501-000412
0501-000412
0501-000586
0501-000412
0501-000303
0501-000143
0501-000586
0501-000303
0501-000413
0501-000586
0501-000122
0501-000404
0501-000581
0501-000404
0501-002228
0501-000586
2001-000869
2001-000435
2001-000290
2001-000734
2001-000734
2001-000290
2001-000869
2001-000869
2001-000734
2001-000472
2001-000812
2001-000660
2001-000429
2001-000786
2001-000281
2001-000281
2001-000281
2001-000281
2001-000290
2001-000281
Description
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
PCB MAIN
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
Specification
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
CA17JS,FR-1,247*247*T1.6,0.0,1.6T,247*247*1.6T,09B1,1ARRAY,MAIN-PCB,2N3904,NPN,625mW,TO-92,TP,100-300
2N3906,PNP,625mW,TO-92,TP,100-300
2N3904,NPN,625mW,TO-92,TP,100-300
KSA733,PNP,250mW,TO-92,TP,120-240
KSA733,PNP,250mW,TO-92,TP,120-240
2N5551,NPN,625mW,TO-92,TP,80-250
2N3904,NPN,625mW,TO-92,TP,100-300
2N3906,PNP,625mW,TO-92,TP,100-300
KSP42,NPN,625mW,TO-92,-,40
KSP42,NPN,625mW,TO-92,-,40
KSP42,NPN,625mW,TO-92,-,40
KSC945,NPN,250mW,TO-92,TP,120-240
KSP42,NPN,625mW,TO-92,-,40
KSA733,PNP,250mW,TO-92,TP,120-240
2N6520,PNP,625mW,TO-92,TP,30-200
KSC945,NPN,250mW,TO-92,TP,120-240
KSA733,PNP,250mW,TO-92,TP,120-240
KSP44,NPN,625mW,TO-92,TP,50-200
KSC945,NPN,250mW,TO-92,TP,120-240
2N3904,NPN,625mW,TO-92,TP,100-300
KSD1616-Y,NPN,750mW,TO-92,TP,135-270
2N3906,PNP,625mW,TO-92,TP,100-300
KSD1616-Y,NPN,750mW,TO-92,TP,135-270
KTA1281,PNP,1000mW,TO-92L,TP,120-240
KSC945,NPN,250mW,TO-92,TP,120-240
56OHM,5%,1/8W,AA,TP,1.8X3.2MM
1MOHM,5%,1/8W,AA,TP,1.8X3.2MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
4.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM
4.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
56OHM,5%,1/8W,AA,TP,1.8X3.2MM
56OHM,5%,1/8W,AA,TP,1.8X3.2MM
4.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM
2.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM
4.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM
33KOHM,5%,1/8W,AA,TP,1.8X3.2MM
1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
47KOHM,5%,1/8W,AA,TP,1.8X3.2MM
100OHM,5%,1/8W,AA,TP,1.8X3.2MM
100OHM,5%,1/8W,AA,TP,1.8X3.2MM
100OHM,5%,1/8W,AA,TP,1.8X3.2MM
100OHM,5%,1/8W,AA,TP,1.8X3.2MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
100OHM,5%,1/8W,AA,TP,1.8X3.2MM
Remarks
SNA
!
!
!
7-7
CONFIDENTIAL
7 Electrical Parts List
Loc. No.
R221
R222
R223
R224
R225
R229
R230
R231
R232
R233
R236
R239
R301
R302
R303
R304
R306
R307
R308
R309
R310
R311
R312
R315
R316
R320
R324
R401
R402
R403
R404
R405
R406
R407
R408
R409
R410
R412
R413
R414
R416
R417
R418
R419
R420
R421
R422
R423
R424
R425
R426
R427
R429
R430
R431
7-8
Code No.
2001-000734
2001-000734
2001-000552
2001-000869
2001-000869
2001-000281
2001-000429
2001-000281
2001-000281
2001-000429
2001-000290
2001-000290
2001-000869
2004-000580
2001-000890
2001-000890
2004-001022
2001-001048
2001-000109
2004-001409
2004-001136
2001-000890
2001-000812
2004-001409
2001-000281
2001-000290
2001-000878
2001-001096
2001-000869
2004-001226
2004-000498
2001-000591
2001-000522
2001-000109
2001-000429
2001-000812
2001-000105
2001-000290
2001-001038
2001-001038
2001-000107
2001-000331
2001-000044
2001-000004
2004-000398
2003-000429
2001-001006
2004-000176
2004-000284
2001-000119
2001-000110
2001-000591
2001-000052
2001-001078
2005-001163
Description
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-METAL
R-CARBON
R-CARBON
R-METAL
R-CARBON(S)
R-CARBON(S)
R-METAL
R-METAL
R-CARBON
R-CARBON
R-METAL
R-CARBON
R-CARBON
R-CARBON
R-CARBON(S)
R-CARBON
R-METAL
R-METAL
R-CARBON
R-CARBON
R-CARBON(S)
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON(S)
R-CARBON(S)
R-CARBON(S)
R-CARBON
R-CARBON
R-CARBON
R-METAL
R-METAL OXIDE(S)
R-CARBON
R-METAL
R-METAL
R-CARBON
R-CARBON
R-CARBON
R-CARBON(S)
R-CARBON(S)
R-WIRE WOUND,NON
Specification
4.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM
4.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM
270OHM,5%,1/4W,AA,TP,2.4X6.4MM
56OHM,5%,1/8W,AA,TP,1.8X3.2MM
56OHM,5%,1/8W,AA,TP,1.8X3.2MM
100OHM,5%,1/8W,AA,TP,1.8X3.2MM
1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
100OHM,5%,1/8W,AA,TP,1.8X3.2MM
100OHM,5%,1/8W,AA,TP,1.8X3.2MM
1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
56OHM,5%,1/8W,AA,TP,1.8X3.2MM
22Kohm,1%,1/4W,AA,TP,2.4x6.4mm
6.8KOHM,5%,1/8W,AA,TP,1.8X3.2MM
6.8KOHM,5%,1/8W,AA,TP,1.8X3.2MM
5.6Kohm,1%,1/4W,AA,TP,2.4x6.4m
1.2OHM,5%,1/2W,AA,TP,2.4X6.4MM
470OHM,5%,1/2W,AA,TP,2.4X6.4MM
2.7ohm,1%,1/4W,AA,TP,2.4x6.4mm
6.8Kohm,1%,1/4W,AA,TP,2.4x6.4m
6.8KOHM,5%,1/8W,AA,TP,1.8X3.2MM
5.6KOHM,5%,1/8W,AA,TP,1.8X3.2MM
2.7ohm,1%,1/4W,AA,TP,2.4x6.4mm
100OHM,5%,1/8W,AA,TP,1.8X3.2MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
6.2KOHM,5%,1/8W,AA,TP,1.8X3.2MM
2.2OHM,5%,1/2W,AA,TP,2.4X6.4MM
56OHM,5%,1/8W,AA,TP,1.8X3.2MM
750ohm,1%,1/4W,AA,TP,2.4x6.4mm
2.7Kohm,1%,1/4W,AA,TP,2.4x6.4m
3.3KOHM,5%,1/8W,AA,TP,1.8X3.2MM
22KOHM,5%,1/8W,AA,TP,1.8X3.2MM
470OHM,5%,1/2W,AA,TP,2.4X6.4MM
1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
5.6KOHM,5%,1/8W,AA,TP,1.8X3.2MM
1.5KOHM,5%,1/4W,AA,TP,2.4X6.4MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
0.56OHM,5%,1/2W,AA,TP,2.4X6.4MM
0.56OHM,5%,1/2W,AA,TP,2.4X6.4MM
150KOHM,5%,1/2W,AA,TP,2.4X6.4MM
12KOHM,5%,1/8W,AA,TP,1.8X3.2MM
1.2KOHM,5%,1/4W,AA,TP,2.4X6.4MM
200KOHM,5%,1/8W,AA,TP,1.8X3.2MM
180Kohm,1%,1/4W,AA,TP,2.4x6.4m
1.5Kohm,5%,2W,AA,TP,4x12mm
82OHM,5%,1/8W,AA,TP,1.8X3.2MM
1.8Kohm,1%,1/4W,AA,TP,2.4x6.4m
12Kohm,1%,1/4W,AA,TP,2.4x6.4mm
680OHM,5%,1/4W,AA,TP,2.4X6.4MM
10OHM,5%,1/4W,AA,TP,2.4X6.4MM
3.3KOHM,5%,1/8W,AA,TP,1.8X3.2MM
3.3KOHM,5%,1/2W,AA,TP,2.4X6.4MM
15KOHM,5%,1/2W,AA,TP,2.4X6.4MM
0.68ohm,1%,3W,AA,TP,5.5x15mm
Remarks
!
!
CA17K*/CA17J*
CONFIDENTIAL
7 Electrical Parts List
Loc. No.
R432
R433
R434
R435
R436
R437
R438
R439
R440
R441
R442
R443
R444
R445
R446
R450
R451
R452
R453
R454
R455
R456
R457
R458
R460
R500
R501
R502
R504
R505
R506
R507
R508
R509
R510
R511
R512
R513
R514
R515
R518
R519
R524
R525
R526
R527
R529
R530
R531
R532
R533
R534
R551
R552
R553
CA17K*/CA17J*
Code No.
2001-000020
2003-000769
2001-000449
2001-000786
2001-000449
2001-000786
2001-000449
2001-000786
2001-000290
2001-000290
2001-000290
2003-000505
2001-000739
2003-000807
2001-001079
2001-000522
2001-000290
2001-000290
2001-000290
2003-000650
2001-000449
2001-000290
2001-000786
2001-000020
2003-000724
2001-000435
2001-000472
2004-000979
2001-000008
2004-000344
2004-000643
2004-000216
2001-001129
2001-001129
2001-000273
2001-000478
2001-000085
2001-000087
2001-000786
2001-000786
2001-001071
2001-000356
2001-000290
2001-000331
2001-000411
2001-000837
2001-000539
2001-000290
2001-000010
2002-000133
2002-001073
2002-001075
2001-000530
2004-000532
2001-000642
Description
R-CARBON(S)
R-METAL OXIDE(S)
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-METAL OXIDE(S)
R-CARBON
R-METAL OXIDE(S)
R-CARBON(S)
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-METAL OXIDE(S)
R-CARBON
R-CARBON
R-CARBON
R-CARBON(S)
R-METAL OXIDE(S)
R-CARBON
R-CARBON
R-METAL
R-CARBON
R-METAL
R-METAL
R-METAL
R-CARBON(S)
R-CARBON(S)
R-CARBON
R-CARBON
R-CARBON(S)
R-CARBON(S)
R-CARBON
R-CARBON
R-CARBON(S)
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-COMPOSITION
R-COMPOSITION
R-COMPOSITION
R-CARBON
R-METAL
R-CARBON
Specification
22OHM,5%,1/2W,AA,TP,2.4X6.4MM
680ohm,5%,3W,AA,TP,6x16mm
2.2KOHM,5%,1/8W,AA,TP,1.8X3.2MM
47KOHM,5%,1/8W,AA,TP,1.8X3.2MM
2.2KOHM,5%,1/8W,AA,TP,1.8X3.2MM
47KOHM,5%,1/8W,AA,TP,1.8X3.2MM
2.2KOHM,5%,1/8W,AA,TP,1.8X3.2MM
47KOHM,5%,1/8W,AA,TP,1.8X3.2MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
150ohm,5%,3W,AA,TP,6x16mm
4.7MOHM,5%,1/8W,AA,TP,1.8X3.2MM
82ohm,5%,2W,AA,TP,4x12mm
15OHM,5%,1/2W,AA,TP,2.4X6.4MM
22KOHM,5%,1/8W,AA,TP,1.8X3.2MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
330ohm,5%,2W,AA,TP,4x12mm
2.2KOHM,5%,1/8W,AA,TP,1.8X3.2MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
47KOHM,5%,1/8W,AA,TP,1.8X3.2MM
22OHM,5%,1/2W,AA,TP,2.4X6.4MM
5.6ohm,5%,3W,AA,TP,6x16mm
1MOHM,5%,1/8W,AA,TP,1.8X3.2MM
2.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM
47Kohm,1%,1/4W,AA,TP,2.4x6.4mm
15KOHM,5%,1/8W,AA,TP,1.8X3.2MM
15Kohm,1%,1/4W,AA,TP,2.4x6.4mm
270Kohm,1%,1/4W,AA,TP,2.4x6.4m
10Kohm,1%,1/4W,AA,TP,2.4x6.4mm
330KOHM,5%,1/2W,AA,TP,2.4X6.4MM
330KOHM,5%,1/2W,AA,TP,2.4X6.4MM
100KOHM,5%,1/8W,AA,TP,1.8X3.2MM
2.7OHM,5%,1/4W,AA,TP,2.4X6.4MM
100KOHM,5%,1/2W,AA,TP,2.4X6.4MM
120KOHM,5%,1/2W,AA,TP,2.4X6.4MM
47KOHM,5%,1/8W,AA,TP,1.8X3.2MM
47KOHM,5%,1/8W,AA,TP,1.8X3.2MM
12KOHM,5%,1/2W,AA,TP,2.4X6.4MM
150KOHM,5%,1/8W,AA,TP,1.8X3.2MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
12KOHM,5%,1/8W,AA,TP,1.8X3.2MM
18KOHM,5%,1/8W,AA,TP,1.8X3.2MM
51KOHM,5%,1/8W,AA,TP,1.8X3.2MM
24KOHM,5%,1/8W,AA,TP,1.8X3.2MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
68KOHM,5%,1/8W,AA,TP,1.8X3.2MM
3.3Mohm,5%,1/2W,AA,TP,3.5x9.5m
15Mohm,5%,1/2W,AA,TP,4.0x10mm
30Mohm,5%,1/2W,AA,TP,4.0x10mm
240KOHM,5%,1/4W,AA,TP,2.4X6.4MM
20Kohm,1%,1/4W,AA,TP,2.4x6.4mm
330KOHM,5%,1/2W,AA,TP,3.3X9MM
Remarks
!
!
!
!
!
!
!
SNA
7-9
CONFIDENTIAL
7 Electrical Parts List
Loc. No.
Code No.
Description
Specification
R554
R555
R556
R560
R570
R600
R601
R602
R603
R604
R605
R607
R608
R609
R610
R611
R612
R613
R614
R615
R617
R618
R619
R621
R622
R627
R628
R630
R631
R632
R641
R642
SDI_CDT
SK501
TP501
X201
ZD201
ZD202
ZD203
ZD204
ZD205
ZD206
ZD207
ZD208
ZD209
ZD401
ZD501
ZD600
ZD601
ZD602
ZD603
ZD604
ZD606
2002-001049
2001-001088
2001-000613
2001-001129
2001-001108
2001-001129
2001-001129
2001-000023
2001-000290
2001-000857
2001-000734
2003-000014
2001-000281
2002-001068
2002-001068
2001-000376
2003-000738
2001-000290
2001-001107
2001-001088
2001-001037
2001-000429
2003-000471
2001-000989
2001-000588
2001-000812
2001-000221
2001-000786
2001-001088
2001-000290
2003-000744
2001-000016
BH39-40305U
4715-000001
6042-000002
2801-000005
0403-000361
0403-000361
0403-000361
0403-000361
0403-000361
0403-000361
0403-000361
0403-000361
0403-000361
0403-000355
0403-001068
0403-000753
0403-000361
0403-001068
0406-001062
0403-001274
0403-000367
R-COMPOSITION
R-CARBON(S)
R-CARBON
R-CARBON(S)
R-CARBON(S)
R-CARBON(S)
R-CARBON(S)
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-METAL OXIDE(S)
R-CARBON
R-COMPOSITION
R-COMPOSITION
R-CARBON
R-METAL OXIDE(S)
R-CARBON
R-CARBON(S)
R-CARBON(S)
R-CARBON(S)
R-CARBON
R-METAL OXIDE(S)
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON(S)
R-CARBON
R-METAL OXIDE(S)
R-CARBON(S)
CBF HARNESS
SURGE ABSORBER
EYELET
CRYSTAL-UNIT
DIODE-ZENER
DIODE-ZENER
DIODE-ZENER
DIODE-ZENER
DIODE-ZENER
DIODE-ZENER
DIODE-ZENER
DIODE-ZENER
DIODE-ZENER
DIODE-ZENER
DIODE-ZENER
DIODE-ZENER
DIODE-ZENER
DIODE-ZENER
DIODE-TVS
DIODE-ZENER
DIODE-ZENER
240Kohm,5%,1/2W,AA,TP,3.9x9mm
1KOHM,5%,1/2W,AA,TP,2.4X6.4MM
3.9KOHM,5%,1/8W,AA,TP,1.8X3.2MM
330KOHM,5%,1/2W,AA,TP,2.4X6.4MM
22KOHM,5%,1/2W,AA,TP,2.4X6.4MM
330KOHM,5%,1/2W,AA,TP,2.4X6.4MM
330KOHM,5%,1/2W,AA,TP,2.4X6.4MM
47OHM,5%,1/4W,AA,TP,2.4X6.4MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
560OHM,5%,1/8W,AA,TP,1.8X3.2MM
4.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM
10Kohm,5%,3W,AA,TP,6x16mm
100OHM,5%,1/8W,AA,TP,1.8X3.2MM
180Kohm,5%,1/2W,AA,TP,3.9x9mm
180Kohm,5%,1/2W,AA,TP,3.9x9mm
15OHM,5%,1/8W,AA,TP,1.8X3.2MM
56Kohm,5%,2W,AA,TP,4x12mm
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
220ohm,5%,1/2W,AA,TP,2.4x6.4mm
1KOHM,5%,1/2W,AA,TP,2.4X6.4MM
0.39OHM,5%,1/2W,AA,TP,2.4X6.4MM
1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
10ohm,5%,2W,AA,TP,4x12mm
820KOHM,5%,1/8W,AA,TP,1.8X3.2MM
3.3KOHM,5%,1/4W,AA,TP,2.4X6.4MM
5.6KOHM,5%,1/8W,AA,TP,1.8X3.2MM
1.2KOHM,5%,1/8W,AA,TP,1.8X3.2MM
47KOHM,5%,1/8W,AA,TP,1.8X3.2MM
1KOHM,5%,1/2W,AA,TP,2.4X6.4MM
10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
56ohm,5%,2W,AA,TP,4x12mm
1OHM,5%,1/2W,AA,TP,2.4X6.4MM
52MM,AWG22(0.6PI),-,-,AWG22(0.
1KV,+50-10%,-,-,
ID1.5,OD2,L3.1,SN,BSS3-E/EH
8MHz,50ppm,28-AAM,S,35ohm,TP
UZ6.2BSB,6.2V,5.99-6.24V,500mW
UZ6.2BSB,6.2V,5.99-6.24V,500mW
UZ6.2BSB,6.2V,5.99-6.24V,500mW
UZ6.2BSB,6.2V,5.99-6.24V,500mW
UZ6.2BSB,6.2V,5.99-6.24V,500mW
UZ6.2BSB,6.2V,5.99-6.24V,500mW
UZ6.2BSB,6.2V,5.99-6.24V,500mW
UZ6.2BSB,6.2V,5.99-6.24V,500mW
UZ6.2BSB,6.2V,5.99-6.24V,500mW
UZ5.1BSB,4.97-5.18V,500MW,DO-35,TP
UZ4.7BSA,4.7V,4.47-4.65V,500mW
MTZJ27D,27V,26.29-27.64V,500mW
UZ6.2BSB,6.2V,5.99-6.24V,500mW
UZ4.7BSA,4.7V,4.47-4.65V,500mW
P6KE200A,190/200/210V,600W,CAS
UZ24BSC,23.29-24.27V,500MW,DO-34,TP
UZ7.5BSC,7.5V,7.33-7.64V,500mW
HS301
BH99-00002G
ASSY HEAT/SINK
H/S V.IC,SCREW+NUT,KA2142,-,-,OIL SILICON
7-10
Remarks
!
SNA
SNA
CA17K*/CA17J*
CONFIDENTIAL
7 Electrical Parts List
Loc. No.
Code No.
Description
Specification
Remarks
SNA
SNA
SNA
CIS
CIS
CIS
CIS
1204-001508
6006-001097
6021-000118
BH62-00047A
IC-VERTICAL DEF.
SCREW-ASS’Y MACH
NUT-HEXAGON
HEAT SINK-V.IC
KA2142,SIP,10P,-,PLASTIC,35V,15W,-20TO+70C,ST,VERTICAL DEFLECTION
WSP,BH,+,M3,L8,ZPC(YEL),SWRCH18A
1C,M3,ZPC(YEL),SM20C
PS17NO(DELL),A1050S,T1.0,70,77,-,-,-
HS601
CIS
CIS
CIS
CIS
BH99-00003A
BH13-00004A
BH61-00004A
BH62-00004A
BH62-20001B
ASSY,HEAT/SINK
IC-HYBRID
SPRING-TR
HEAT/SINK-POWER
TUBE-RUBBER
H/S POWER,SPRING,DP104,-,-,RUBBER,-,-,DP104C,TO-220-5L,5P,POWER SWITCH,-,CDA,CDB,SUS304,-,-,-,-,-,T0.5,-,-,-,T1,-,A1050S,DA/DB
CSQ4357,W25*L20*T0.45,-,-,-,-
SNA
HS403
CIS
CIS
BH99-00005G
BH61-00004A
BH62-00008A
ASSY,HEAT/SINK
SPRING-TR
HEAT SINK-TR
HS TR,SPRING,IRF740A,-,-,OIL SILICON,-,CDA,CDB,SUS304,-,-,-,-,-,T0.5,-,-,-,SPC-1 L20*H45*T1,-,CDB
SNA
SNA
SNA
HS401
CIS
CIS
CIS
BH99-00006G
6006-001008
6021-000118
BH62-30024A
ASSY HEAT/SINK
SCREW-ASS’Y MACH
NUT-HEXAGON
HEAT/SINK-TR
HS TR,SCREW+NUT,IRF640A,-,-,OIL SILICON
WSP,BH,+,M3,L10,ZPC(YEL),SWRCH
1C,M3,ZPC(YEL),SM20C
SPC,T1,SN,CFX1577L
SNA
SNA
SNA
SNA
HS402
CIS
CIS
BH99-00010A
BH61-00004A
BH62-00016A
ASSY,HEAT/SINK
SPRING-TR
HEAT SINK-TR
HS TR,SPRING,IRF634A,-,-,OIL SILICON,-,CDA,CDB,SUS304,-,-,-,-,-,T0.5,-,-,A1050S,T1.0,-,DP17MO
SNA
SNA
SNA
HS501
CIS
CIS
CIS
CIS
CIS
CIS
BH99-00033C
0402-001255
0502-000465
0502-001143
BH61-70003A
BH62-00001A
BH62-00038A
ASSY HEAT/SINK
DIODE-RECTIFIER
TR-POWER
TR-POWER
SPRING ETC
INSULATION-MICA
HEAT SINK-FBT
HS FBT,SPRING,2SC5583,DTV56F,KTD2058,OIL,MICA
DTV56F,1.5KV,10A,TO-220AC,BK
KTD2058,NPN,25000mW,TO-220IS,ST,100-200
2SC5583,NPN,150W,TOP-3L,ST,6-1
CVT4857,STS304-W1/2H,W3.8,-,L30,L30,-,T0.5,DEGRE,W3.8,STS304-W1/2H
CSM920B,MICA,-,-,-,-,-,-,POWER-TR
TS17JS,A1050S,T2.0,-,-,-,-,-
SNA
HS409
CIS
CIS
BH99-00045C
0402-001289
BH62-00051A
ASSY,HEAT/SINK
DIODE-RECTIFIER
HEAT/SINK-IC
HS,-,31DF6,-,-,SOLDER,-,31DF6,600V,3A,DO-201AD,BK
SPC-1,T1,SN COATING,-
CA17K*/CA17J*
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
7-11
CONFIDENTIAL
7 Electrical Parts List
7-2 Video PCB Parts
Loc. No.
CIS
CIS
CIS
CIS
CIS
CIS
CIS
CIS
CN101
CN102
IC102
JW1
JW2
JW3
SH/VID
SH/VID+H/S
SK101
C106
C107
C108
C128
C129
C130
C134
C138
C139
C145
C147
CB01
CB02
CB04
CB10
CG01
CG02
CG04
CG10
CR01
CR02
CR04
CR10
DB01
DG01
DR01
IC101
IC103
L103
L105
L106
L107
L108
L109
L111
R101
7-12
Code No.
BH94-00806A
BH75-00047A
BH71-00006B
BH71-10311A
BH75-00192H
BH61-00002A
BH71-00007A
BH72-00024A
BH73-00014A
3711-004228
BH39-00015A
1201-001832
BH39-40306C
BH39-40306D
BH39-40306D
6502-000001
6003-000010
3704-001142
BH97-00331A
2203-000204
2203-000260
2203-000634
2203-000260
2203-000239
2203-000239
2203-000204
2203-000839
2203-000204
2203-001105
2203-000204
2203-000204
2203-000204
2203-000204
2203-000389
2203-000204
2203-000204
2203-000204
2203-000389
2203-000204
2203-000204
2203-000204
2203-000389
0401-001056
0401-001056
0401-001056
1201-001791
1204-001864
2703-001334
2703-001334
2703-001334
2703-001334
2703-001334
2703-001334
2703-001334
2007-001071
Description
ASSY PCB VIDEO
UNIT/SHIELD-VIDEO/CAP
SHIELD VIDEO-CAP
EARTH PLATE
UNIT/SHIELD-VIDEO
SPRING-VIDEO
SHIELD VIDEO
HOLDER-VIDEO
HOLDER RUBBER-(NORMAL)
CONNECTOR-HEADER
CBF-HARNESS
IC-VIDEO AMP
CBF-HARNESS
CBF-HARNESS
CBF-HARNESS
CABLE CLAMP
SCREW-TAPTITE
SOCKET-CRT
ASSY SMD-VIDEO
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
IC-VIDEO AMP
IC-OSD PROCESSOR
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
R-CHIP
Specification
Remarks
CA17JS
CL17LO,SPTE T0.3,-,-,CL17LO,SPTE,0.2,-,PBS 3/4H,T0.2
DEL,-,SPTE,-,-,14,15,17,CDB7907,STS H14 ,-,-,-,-,-,T1.0,-,-,CDA4507,SPTE,T0.2,-,CDA4507,ABS+PC,5V,IV16,-,NORMAL CRT
DEL,SILICON V2,GRAY,-,-,-,NORMAL
BOX,6P,1R,2MM,ANGLE,SN
13P/14P,200MM,WHT/BLK/RED/BLU,UL1007,AWG26,SMH200-13/YBNH200-14
S1D2518X01,SDIP,30P,-,-,18DB,PLASTIC,12V,1.2W,-25TO+75C,-,-,-,-,-,ST
,60MM,BLK,1015,AWG22,-,-,-,-,,80MM,BLK,1015,AWG22,-,-,-,-,,80MM,BLK,1015,AWG22,-,-,-,-,DAWH-5NB,D15,L35,NYLON66,NTR
BWH,+,B,M3,L10,ZPC(YEL),SWRCH1
10P,22.5PI,25.6PI,NI,CA17JS
100nF,10%,25V,X7R,TP,2012
10nF,10%,50V,X7R,TP,2012
0.022nF,5%,50V,NP0,TP,2012
10nF,10%,50V,X7R,TP,2012
0.1nF,5%,50V,NP0,TP,2012
0.1nF,5%,50V,NP0,TP,2012
100nF,10%,25V,X7R,TP,2012
0.39nF,5%,50V,NP0,TP,2012
100nF,10%,25V,X7R,TP,2012
6.8nF,10%,50V,X7R,TP,2012
100nF,10%,25V,X7R,TP,2012
100nF,10%,25V,X7R,TP,2012
100nF,10%,25V,X7R,TP,2012
100nF,10%,25V,X7R,TP,2012
0.015nF,5%,50V,NP0,TP,2012
100nF,10%,25V,X7R,TP,2012
100nF,10%,25V,X7R,TP,2012
100nF,10%,25V,X7R,TP,2012
0.015nF,5%,50V,NP0,TP,2012
100nF,10%,25V,X7R,TP,2012
100nF,10%,25V,X7R,TP,2012
100nF,10%,25V,X7R,TP,2012
0.015nF,5%,50V,NP0,TP,2012
MMBD4148SE,75V,200MA,SOT-23,TP
MMBD4148SE,75V,200MA,SOT-23,TP
MMBD4148SE,75V,200MA,SOT-23,TP
-,SOP,24P,375MIL,-,-,PLASTIC,7V,0.8W,-20TO+80C,-,-,-,-,-,TR
S5D2509X09-S0,SOP,24P,295MIL,PLASTIC,6.5V,1200MW,-20+70C,TR,10LANGUAGES
1.5uH,10%,2x1.25x0.85mm
1.5uH,10%,2x1.25x0.85mm
1.5uH,10%,2x1.25x0.85mm
1.5uH,10%,2x1.25x0.85mm
1.5uH,10%,2x1.25x0.85mm
1.5uH,10%,2x1.25x0.85mm
1.5uH,10%,2x1.25x0.85mm
6.8KOHM,5%,1/10W,DA,TP,2012
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
CA17K*/CA17J*
CONFIDENTIAL
7 Electrical Parts List
Loc. No.
R102
R103
R104
R105
R106
R107
R108
R109
R110
R111
R112
R113
R116
R117
R118
R119
R121
R122
R123
R124
R128
R129
R130
R132
R133
R139
R140
R141
R142
R143
R144
R145
RB01
RB02
RB04
RB05
RB06
RB07
RB08
RB10
RG01
RG02
RG04
RG05
RG06
RG07
RG08
RG10
RR01
RR02
RR04
RR05
RR06
RR07
RR08
CA17K*/CA17J*
Code No.
2007-000355
2007-001071
2007-000290
2007-000766
2007-000781
2007-000290
2007-000290
2007-000290
2007-000290
2007-008393
2007-000290
2007-000300
2007-000290
2007-000290
2007-000290
2007-000290
2007-000493
2007-000300
2007-000241
2007-000468
2007-000981
2007-000355
2007-001071
2007-000468
2007-000468
2007-000766
2007-000766
2007-000766
2007-000766
2007-000572
2007-000710
2007-008393
2007-001166
2007-000593
2007-000931
2007-000822
2007-000593
2007-000457
2007-000593
2007-000572
2007-001166
2007-000593
2007-000931
2007-000822
2007-000593
2007-000457
2007-000593
2007-000572
2007-001166
2007-000593
2007-000931
2007-000822
2007-000593
2007-000457
2007-000593
Description
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
Specification
Remarks
12KOHM,5%,1/10W,DA,TP,2012
6.8KOHM,5%,1/10W,DA,TP,2012
100OHM,5%,1/10W,DA,TP,2012
330OHM,5%,1/10W,DA,TP,2012
33OHM,5%,1/10W,DA,TP,2012
100OHM,5%,1/10W,DA,TP,2012
100OHM,5%,1/10W,DA,TP,2012
100OHM,5%,1/10W,DA,TP,2012
100OHM,5%,1/10W,DA,TP,2012
11MOHM,5%,0.100W,DA,TP,2012
100OHM,5%,1/10W,DA,TP,2012
10KOHM,5%,1/10W,DA,TP,2012
100OHM,5%,1/10W,DA,TP,2012
100OHM,5%,1/10W,DA,TP,2012
100OHM,5%,1/10W,DA,TP,2012
100OHM,5%,1/10W,DA,TP,2012
2.2KOHM,5%,1/10W,DA,TP,2012
10KOHM,5%,1/10W,DA,TP,2012
1.5KOHM,5%,1/10W,DA,TP,2012
1KOHM,5%,1/10W,DA,TP,2012
5.6KOHM,5%,1/10W,DA,TP,2012
12KOHM,5%,1/10W,DA,TP,2012
6.8KOHM,5%,1/10W,DA,TP,2012
1KOHM,5%,1/10W,DA,TP,2012
1KOHM,5%,1/10W,DA,TP,2012
330OHM,5%,1/10W,DA,TP,2012
330OHM,5%,1/10W,DA,TP,2012
330OHM,5%,1/10W,DA,TP,2012
330OHM,5%,1/10W,DA,TP,2012
220OHM,5%,1/10W,DA,TP,2012
3.9KOHM,5%,1/10W,DA,TP,2012
11MOHM,5%,0.100W,DA,TP,2012
75OHM,5%,1/10W,DA,TP,2012
22OHM,5%,1/10W,DA,TP,2012
470OHM,5%,1/10W,DA,TP,2012
390OHM,5%,1/10W,DA,TP,2012
22OHM,5%,1/10W,DA,TP,2012
18KOHM,5%,1/10W,DA,TP,2012
22OHM,5%,1/10W,DA,TP,2012
220OHM,5%,1/10W,DA,TP,2012
75OHM,5%,1/10W,DA,TP,2012
22OHM,5%,1/10W,DA,TP,2012
470OHM,5%,1/10W,DA,TP,2012
390OHM,5%,1/10W,DA,TP,2012
22OHM,5%,1/10W,DA,TP,2012
18KOHM,5%,1/10W,DA,TP,2012
22OHM,5%,1/10W,DA,TP,2012
220OHM,5%,1/10W,DA,TP,2012
75OHM,5%,1/10W,DA,TP,2012
22OHM,5%,1/10W,DA,TP,2012
470OHM,5%,1/10W,DA,TP,2012
390OHM,5%,1/10W,DA,TP,2012
22OHM,5%,1/10W,DA,TP,2012
18KOHM,5%,1/10W,DA,TP,2012
22OHM,5%,1/10W,DA,TP,2012
7-13
CONFIDENTIAL
7 Electrical Parts List
Loc. No.
RR10
BD103
BD104
BD106
BD112
BD115
C102
C104
C105
C112
C113
C116
C117
C118
C119
C120
C121
C122
C125
C126
C127
C131
C135
C137
C140
C146
C148
C149
CB05
CB06
CG05
CG06
CN_G2
CN_GND
CN_GTP1
CR05
CR06
D101
D102
DB03
DB04
DB05
DG03
DG04
DG05
DR03
DR04
DR05
EY1
EY2
EY5
EY6
EY7
EY8
7-14
Code No.
2007-000572
BH97-00332A
3301-000011
3301-000011
3301-000011
3301-000011
3301-000011
2201-000119
2401-003224
2401-002075
2401-003034
2301-000312
2401-003484
2201-000019
2401-000393
2201-000019
2401-000661
2401-000025
2401-000025
2201-000341
2201-000119
2201-002110
2401-000010
2401-000042
2401-002075
2201-000285
2401-000042
2401-000042
2401-000025
2301-000010
2305-000407
2301-000010
2305-000407
BH71-40300A
BH71-40300A
BH71-40300A
2301-000010
2305-000407
0401-000005
0401-000005
0401-000004
0401-000004
0401-000005
0401-000004
0401-000004
0401-000005
0401-000004
0401-000004
0401-000005
6042-000001
6042-000001
6042-000002
6042-000002
6042-000002
6042-000002
Description
R-CHIP
ASSY AUTO-VIDEO
CORE-FERRITE BEAD
CORE-FERRITE BEAD
CORE-FERRITE BEAD
CORE-FERRITE BEAD
CORE-FERRITE BEAD
C-CERAMIC,DISC
C-AL
C-AL
C-AL
C-FILM,PEF
C-AL
C-CERAMIC,DISC
C-AL
C-CERAMIC,DISC
C-AL
C-AL
C-AL
C-CERAMIC,DISC
C-CERAMIC,DISC
C-CERAMIC,DISC
C-AL
C-AL
C-AL
C-CERAMIC,DISC
C-AL
C-AL
C-AL
C-FILM,PEF
C-FILM,MPEF
C-FILM,PEF
C-FILM,MPEF
PIN HINGE
PIN HINGE
PIN HINGE
C-FILM,PEF
C-FILM,MPEF
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
DIODE-SWITCHING
EYELET
EYELET
EYELET
EYELET
EYELET
EYELET
Specification
220OHM,5%,1/10W,DA,TP,2012
CA17JS
AA,3.5x1.0x5.7mm,1500,2375G
AA,3.5x1.0x5.7mm,1500,2375G
AA,3.5x1.0x5.7mm,1500,2375G
AA,3.5x1.0x5.7mm,1500,2375G
AA,3.5x1.0x5.7mm,1500,2375G
100nF,+80-20%,50V,Y5V,TP,8x3,5
470uF,20%,16V,WT,TP,8X11.5,5mm
4.7uF,20%,50V,GP,TP,5x11,5
220uF,20%,16V,WT,TP,8x11.5,5
8.2nF,5%,100V,TP,6x12.5mm,5mm
10uF,20%,100V,LZ,TP,6.3X11,5
10nF,+80-20%,500V,Y5V,TP,13.5x4mm,5
10uF,20%,100V,WT,TP,8x11.5,5
10nF,+80-20%,500V,Y5V,TP,13.5x4mm,5
2.2uF,20%,50V,GP,TP,5x11,5
100uF,20%,16V,GP,TP,6.3x11,5
100uF,20%,16V,GP,TP,6.3x11,5
2.7nF,10%,2kV,Y5P,TP,14x6,7.5
100nF,+80-20%,50V,Y5V,TP,8x3,5
1.8nF,10%,1kV,Y5P,TP,10x5mm,5
220uF,20%,16V,GP,-,6.3x11mm,2.
100uF,20%,16V,GP,TP,6.3x7,5
4.7uF,20%,50V,GP,TP,5x11,5
1nF,10%,1kV,Y5P,TP,8x5,5
100uF,20%,16V,GP,TP,6.3x7,5
100uF,20%,16V,GP,TP,6.3x7,5
100uF,20%,16V,GP,TP,6.3x11,5
100nF,5%,100V,TP,11.5x12.5mm,5
470nF,5%,100V,TP,-,5mm
100nF,5%,100V,TP,11.5x12.5mm,5
470nF,5%,100V,TP,-,5mm
-,BRASS,D2.36,SN,HEAT/SINK
-,BRASS,D2.36,SN,HEAT/SINK
-,BRASS,D2.36,SN,HEAT/SINK
100nF,5%,100V,TP,11.5x12.5mm,5
470nF,5%,100V,TP,-,5mm
1N4148,100V,200mA,DO-35,TP
1N4148,100V,200mA,DO-35,TP
1SS244,250V,625mA,DO-34,TP
1SS244,250V,625mA,DO-34,TP
1N4148,100V,200mA,DO-35,TP
1SS244,250V,625mA,DO-34,TP
1SS244,250V,625mA,DO-34,TP
1N4148,100V,200mA,DO-35,TP
1SS244,250V,625mA,DO-34,TP
1SS244,250V,625mA,DO-34,TP
1N4148,100V,200mA,DO-35,TP
ID2.2,OD2.7,L3.1,SN,BSS3-E/EH
ID2.2,OD2.7,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
ID1.5,OD2,L3.1,SN,BSS3-E/EH
Remarks
SNA
!
!
!
SNA
SNA
SNA
!
SNA
SNA
SNA
SNA
SNA
SNA
CA17K*/CA17J*
CONFIDENTIAL
7 Electrical Parts List
Loc. No.
IC104
JP16
JP20
JP21
JP23
JP24
JP25
JP26
JP27
JP28
JP29
JP30
JP31
JP32
JP33
JP34
JP36
JP37
JP39
JP40
JP41
JP43
JP47
JP48
JP49
JP51
JP52
JP53
JP54
JP55
JP57
JP61
JP62
JP66
JP70
JP71
JP73
JP74
JP75
JP76
JP77
JP85
JP86
JP87
JP88
L101
L102
L104
LB10
LB11
LG10
LG11
LR10
LR11
MP1.2
CA17K*/CA17J*
Code No.
BH13-00022A
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
BH39-40305U
2701-000319
2701-001014
2701-000112
2701-000190
2701-001065
2701-000190
2701-001065
2701-000190
2701-001069
BH41-00189A
Description
IC-BIAS CLAMP
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
CBF HARNESS
INDUCTOR-AXIAL
INDUCTOR-AXIAL
INDUCTOR-AXIAL
INDUCTOR-AXIAL
INDUCTOR-AXIAL
INDUCTOR-AXIAL
INDUCTOR-AXIAL
INDUCTOR-AXIAL
INDUCTOR-AXIAL
PCB DISPLAY-VIDEO
Specification
Remarks
LM2480NA,PN15H/17L,8P,0to+70C,DIP,3mA,85V,ST
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
52MM,AWG22(0.6PI),-,-,AWG22(0.
470NH,10%,3X7MM
4.7uH,10%,3x7mm
100uH,10%,3x7mm
470nH,10%,4x9.8mm
0.22UH,10%,3X7MM
470nH,10%,4x9.8mm
0.22UH,10%,3X7MM
470nH,10%,4x9.8mm
180NH,10%,3X7MM
AP17JS,FR-1,123.5*100*1.6T,0.0,1.6T,123.5*100*1.6T,09B1,1ARRAY,VIDEO,-
SNA
7-15
CONFIDENTIAL
7 Electrical Parts List
Loc. No.
Code No.
Description
Specification
Remarks
Q101
Q102
Q103
R114
R115
RB03
RB09
RB11
RB12
RG03
RG09
RG11
RG12
RR03
RR09
RR11
RR12
SK104
SK108
SKB01
SKG01
SKR01
ZD101
ZD102
ZD103
ZD104
0501-000122
0501-000122
0501-000404
2001-000331
2001-000890
2001-000766
2001-000643
2001-001088
2001-000705
2001-000766
2001-000643
2001-001088
2001-000705
2001-000766
2001-000643
2001-000109
2001-000705
1405-001064
4715-001055
4715-000102
4715-000102
4715-000102
0403-000509
0403-000361
0403-000361
0403-000361
TR-SMALL SIGNAL
TR-SMALL SIGNAL
TR-SMALL SIGNAL
R-CARBON
R-CARBON
R-CARBON
R-CARBON
R-CARBON(S)
R-CARBON
R-CARBON
R-CARBON
R-CARBON(S)
R-CARBON
R-CARBON
R-CARBON
R-CARBON(S)
R-CARBON
SURGE ABSORBER
SURGE ABSORBER
SURGE ABSORBER
SURGE ABSORBER
SURGE ABSORBER
DIODE-ZENER
DIODE-ZENER
DIODE-ZENER
DIODE-ZENER
2N3904,NPN,625mW,TO-92,TP,100-300
2N3904,NPN,625mW,TO-92,TP,100-300
KSD1616-Y,NPN,750mW,TO-92,TP,135-270
12KOHM,5%,1/8W,AA,TP,1.8X3.2MM
6.8KOHM,5%,1/8W,AA,TP,1.8X3.2MM
43KOHM,5%,1/8W,AA,TP,1.8X3.2MM
330KOHM,5%,1/4W,AA,TP,2.4X6.4MM
1KOHM,5%,1/2W,AA,TP,2.4X6.4MM
39OHM,5%,1/2W,AA,TP,3.3X9MM
43KOHM,5%,1/8W,AA,TP,1.8X3.2MM
330KOHM,5%,1/4W,AA,TP,2.4X6.4MM
1KOHM,5%,1/2W,AA,TP,2.4X6.4MM
39OHM,5%,1/2W,AA,TP,3.3X9MM
43KOHM,5%,1/8W,AA,TP,1.8X3.2MM
330KOHM,5%,1/4W,AA,TP,2.4X6.4MM
470OHM,5%,1/2W,AA,TP,2.4X6.4MM
39OHM,5%,1/2W,AA,TP,3.3X9MM
400V,20%,-,-,AXIAL
1kV,+50-10%,-,-,RADIAL
200V,20%,1000A,-,RADIAL
200V,20%,1000A,-,RADIAL
200V,20%,1000A,-,RADIAL
MTZJ5.6B,5.6V,5.45-5.73V,500mW
UZ6.2BSB,6.2V,5.99-6.24V,500mW
UZ6.2BSB,6.2V,5.99-6.24V,500mW
UZ6.2BSB,6.2V,5.99-6.24V,500mW
HS103
CIS
CIS
CIS
CIS
CIS
CIS
BH99-00004K
6006-001008
6021-000118
BH13-00025A
BH61-70003A
BH62-00002A
BH62-00006A
ASSY HEAT/SINK
SCREW-ASS’Y MACH
NUT-HEXAGON
IC HYBRID
SPRING ETC
HEAT/SINK-FBT
HEAT SINK-VIDEO
HS VIDEO,SCREW+NUT,LM2415T,-,-,OIL SILICON
WSP,BH,+,M3,L10,ZPC(YEL),SWRCH
1C,M3,ZPC(YEL),SM20C
LM2415T,LM2415T,11,-20 TO +100,TO-220,13MA,90V,ST
CVT4857,STS304-W1/2H,W3.8,-,L30,L30,-,T0.5,DEGRE,W3.8,STS304-W1/2H
-,T1.0,-,A1050S,DA/DB
-,A1050S T2.0,-,DB
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
SNA
7-3 Others
Part Name
CRT
CRT
ASSY PBA UNIT
ASSY PBA UNIT
ASSY MAIN UNIT
ASSY MAIN UNIT
ASSY VIDEO UNIT
ASSY VIDEO UNIT
SIGNAL
DEGAUSSING
7-16
Code No.
BH03-00066D
BH03-00066E
BH91-00616A
BH91-00616B
BH94-00704A
BH94-00704B
BH94-00705A
BH94-00806A
BH39-00145A
BH27-00054A
Description & Specification
M41QCJ761X700(T4),70,17,0.25,-,29.1,IFT,H/C,NH,-,TCO,TILT,4
M41QCJ761X850(T4),84,17,0.25,-,29.1,IFT,H/C,NH,-,TCO,TILT,4
ASSY CHASSIS;CA17KS
ASSY CHASSIS;CA17JS
ASSY PCB MAIN;CA17KS
ASSY PCB MAIN;CA17JS
ASSY PCB VIDEO ;CA17KS
ASSY PCB VIDEO;AP17JS
CBF SIGNAL;ATT,1500MM,15P/6P,7P,IVORY(IV01),-,D-SUB/MALE
COIL DEGAUSSING-ASS’Y;320*250*1100mm,9.6mH,-,100Ts,10%
Remarks
CA17KS
CA17JS
CA17K*/CA17J*
7 Electrical Parts List
CONFIDENTIAL
7-4 Main Different Part List
CA17K*/CA17J*
7-17
7 Electrical Parts List
CONFIDENTIAL
7-5 Video Different Part List
7-18
CA17K*/CA17J*
6 Exploded View & Parts List
CONFIDENTIAL
Memo
6-2
CA17K*/CA17J*
CONFIDENTIAL
5 Troubleshooting
5-1-2 DPMS Failure
Check signal source
H/V Sync. video level.
WAVEFORMS
2 100 V (IC601, #1)
Make No H/V Sync.
(power off mode)
LED blinks?
No
Check IC201 Pin 40.
CH1 P-P = 100 V
CH1 RMS = 325.8 V
Yes
+12 V line off?
No
Check IC201 Pin 6.
Yes
2
IC601 Pin 1 output
voltage exists?
No
Refer to 5-1-1 No Power Supply.
Yes
Done.
5-2
CA17K*/CA17J*
CONFIDENTIAL
5 Troubleshooting
5-1-3 H_Deflection Failure
3
Does PWM output signal appear
at Pin 6 (B_out) of IC401?
No
Yes
Does DC 12V appear at
Pin 10 of IC401?
No
Check 12 V line.
Yes
WAVEFORMS
Check IC401.
3 2.00 V (IC401, #6)
4
Does Horizontal pluse signal
appear at Pin 8 of IC401?
No
Check IC401.
Yes
5
Does 110 Vp-p signal appear
at Collector of Q403?
No
Check Q403.
CH1 P-P = 2.00V CH1 RMS = 5.868V
4 2.00V (IC401, #8)
Yes
Check Q402, Q404 and T401.
CH1 P-P = 2.00V CH1 RMS = 5.868V
5 20.0 V (Q403, Collector)
5-1-4 S Correction Failure
Check S1 ~ S4 signal.
S1~S4 signals are right at each
frequency block?
No
Check and replace IC201.
CH1 P-P = 20.0 V CH1 RMS = 46.80V
Yes
Check and replace Q404, Q409,
Q410, Q411, Q414, Q415, Q416,
Q420, and Q421.
CA17K*/CA17J*
5-3
CONFIDENTIAL
5 Troubleshooting
5-1-5 H_Lin. Failure
IC201 Pin 21 voltage varies with
different H_Lin. DAC values?
No
Replace IC201.
Yes
IC603 Pin 9 voltage varies with
different H_Lin. DAC values?
No
Check +13V, Coil_5V line.
Check some parts around IC603.
Yes
Check Q412, Q413 and T402.
5-1-6 Invariable H_Size
IC401 Pin 6 voltage varies with
different B_Out DAC values?
No
Check and replace IC401.
Yes
Q402 Gate output duty varies with
different B_Out DAC values?
No
Check some parts around Q402,
IC401 Pin 3 ~ 6.
5-1-7 Abnormal H_Size
IC401 Pin 11 output duty
varies with different B+ offset
DAC values?
No
WAVEFORMS
Check and replace IC201.
6 200 V (Q404, Collector)
Yes
6
Q404 Collector waveform is
right?
Yes
No
Check and replace Q405,
Q406, Q407, and Q408.
CH1 P-P = 200V CH1 RMS = 387.2V
Check some parts
around D409 and L401.
5-4
CA17K*/CA17J*
CONFIDENTIAL
5 Troubleshooting
5-1-8 Side Pin or Trap Failure
7
IC401 Pin 11 output exists?
No
WAVEFORMS
Check and replace IC401.
7 1.00 V (IC401, #11)
Yes
Refer to 5-1-7 Abnormal H_Size.
CH1 P-P = 1.00V CH1 RMS = 3.008 V
5-1-9 Para. or Pin Balance Failure
IC401 Pin 11 output varies with
different DAC values?
Yes
Refer to 5-1-7 Abnormal H_Size.
No
Replace IC401.
5-1-10 Tilt Failure
Check tilt connector connection
IC201 Pin 20 output duty varies
with different DAC values?
No
Check and replace IC201.
Yes
IC603 Pin 13 output varies with
different DAC values?
No
Check and replace IC603.
Yes
Check and replace Q301 and Q302.
CA17K*/CA17J*
5-5
CONFIDENTIAL
5 Troubleshooting
5-1-11 V Deflection Failure
WAVEFORMS
13V and –10V lines are on?
No
Refer to 5-1-1 No Power Supply.
8 500 V (IC401, #12)
Yes
8
IC401 Pin 12 output exists?
No
Check and replace IC401.
Yes
9
IC301 Pin 6 output exists?
CH1 P-P = 500 V CH1 RMS = 1.425 V
No
Check and replace some parts
around IC301.
9
10.0 V (IC301, #6)
Yes
Check DY connector connection.
CH1 P-P = 10.0 V CH1 RMS = 5.06 V
5-1-12 V Size or Position Variation Failure
IC401 Pin 12 output varies with
different DAC values?
No
Check and replace IC201 and IC401.
Yes
Check and replace IC301.
5-6
CA17K*/CA17J*
CONFIDENTIAL
5 Troubleshooting
5-1-13 High Voltage Failure
WAVEFORMS
3
IC401 Pin 6 OSC pulse exists?
No
Check and replace IC401
and +12 V line.
3 2.00 V (IC401, #6)
Yes
10
Q402 Gate driving pulse exists?
No
Check and replace Q401 and Q423.
Yes
11
Q402 Drain pulse exists?
CH1 P-P = 2.00 V CH1 RMS = 5.868 V
No
Check and replace
D401, Q403 and L402.
10 2.00 V (Q402, Gate)
Yes
Done.
CH1 P-P = 2.00 V CH1 RMS = 7.692V
11 50.0 V (Q402, Drain)
5-1-14 ABL Failure
Input full white pattern to monitor.
IC101 Pin 8 input exists and
varies with different patterns?
No
Check and replace IC101.
CH1 P-P = 50.0 V CH1 RMS = 73.7V
Yes
Check CN102.
T501 Pin 8 output exists?
No
Check and replace T501.
Yes
IC201 Pin 26 output exists and
varies with different patterns?
No
Check and replace IC201.
Yes
Done.
CA17K*/CA17J*
5-7
CONFIDENTIAL
5 Troubleshooting
5-1-15 Dynamic Focus Failure
12
IC401 Pin 32 output is right?
No
WAVEFORMS
Replace the IC401.
12 2.00 V (IC401, #32)
Yes
Some parts around Q551 are right?
No
Replace failed part.
Yes
13
T502 Pin 6 input is right?
CH1 P-P = 2.00V CH1 RMS = 6.124V
No
Check and replace C432.
13 50.0 V (T502, #6)
Yes
14
T502 Pin 1 output is right?
Yes
Check the connection between FBT
Focus pin and CRT Socket PCB.
No
Replace the T502.
CH1 P-P = 50.0V CH1 RMS = 75.6V
14 100 V (T502, #1)
CH1 P-P = 100V CH1 RMS = 124.0V
5-8
CA17K*/CA17J*
CONFIDENTIAL
5 Troubleshooting
5-1-16 No Video
WAVEFORMS
Check signal cable and connection.
15 1.00 V (IC102,#5, 8, 10)
15
IC102 Pin 5, 8 and 10
inputs are right?
No
Check the signal cable connection.
Yes
16
IC102 Pin 25, 28 and 30
outputs are right?
No
Check I2C bus and +12 V line.
16 1.00 V (IC102, #25,28,30)
Yes
17
IC105 Pin 1, 3 and 5
outputs are right?
No
Check +12 V, +80 V line.
Check and replace IC105.
No
Check +80 V line.
Check and replace IC104
Check IC102 Pin 19, 20, 21.
Yes
Cathode DC levels are right?
17 20.0 V (IC105, #1, 3, 5)
Yes
G2 voltage is right?
No
Check G2 wire,
CRT Socket board and FBT.
Yes
Change CRT.
Yes
Done.
CA17K*/CA17J*
5-9
CONFIDENTIAL
5 Troubleshooting
5-1-17 No Highlight Zone (CA17J* Only)
WAVEFORMS
18 1.00 V (IC101, #20, 22, 24)
IC101 Pin 2, 4 and 6
inputs are right?
Yes
IC101 Pin 20, 22 and 24
outputs are right?
18
No
Check +5V IC101 pin 1, 23.
Yes
19 20
19 1.00 V (IC101, #14)
IC101 Pin 12, 13 are right?
2
(I C Data / Clock Line)
No
IC101 Pin 14, 15 and
V_FLB, CLAMP
waveforms are right?
No
Check Micom (IC201)
2
I C Data / Clock Line.
Check CLAMP, V_FLB waveforms.
20 1.00 V (IC101, #15)
Done.
5-1-18 Micom Failure
IC201 Pin 11 input voltage is 5V?
No
Check IC604.
Yes
21
IC201 Pin 13 and 14
inputs are right?
No
Check C202, C203 and X201.
WAVEFORMS
21 1.00 V (IC201, #13, 14)
Yes
IC201 Pin 18 input is right?
No
Check IC605 and 5V.
Yes
All in/output values are right?
No
CH1 P-P = 1.00 V
CH1 RMS = 2.108V
Replace IC201.
Yes
Done.
5-10
CA17K*/CA17J*
CONFIDENTIAL
5 Troubleshooting
5-1-19 OSD Failure
22
IC103 Pin 5, 24 input is 5V?
No
WAVEFORMS
Check +5V Line.
22 1.00 V (IC103, #5, 24)
Yes
2
Check IC103 Pin 7, 8 I C
Data / Clock Line?
No
2
Check I C wavefroms.
Yes
CH1 P-P = 1.00V
IC103 Pin 6 and 17
inputs are right?
No
Check H-FLB 2, V_BLK.
CH1 RMS = 4.516V
23 1.00 V (IC103, #20, 21, 22)
Yes
23
IC103 Pin 20, 21 and 22
outputs are right?
No
Check and replace IC101.
Yes
Check and replace IC103.
Done.
CA17K*/CA17J*
5-11
CONFIDENTIAL
5 Troubleshooting
5-1-20 User Control Failure
Does the DC level change at
Pin 36 of IC201 when you
push the button S/W?
No
Check the button.
(SW201 ~ SW204)
Yes
Check IC201, CN2 and CN206.
5-1-21 Degaussing Failure
Check degaussing connector.
RL601 operation is right?
Yes
Check D-coil and TH601.
No
Q601 base input is right?
Yes
Check 13V Line.
Check and replace Q601.
No
IC201 Pin 4 output is right?
No
Check and replace IC201.
Yes
Done.
5-12
CA17K*/CA17J*
CONFIDENTIAL
5 Troubleshooting
5-2 General Troubleshooting
5-2-1 No Picture
LED blinks?
Yes
Refer to 5-2-2 Shut down.
No
LED is green color?
Yes
Check Micom.
No
Check G2 voltage, high voltage
and R, G, B cathode voltage.
5-2-2 Shut Down
Blinking LED’s?
No
Check power supply.
Yes
Scan failure?
Yes
Check horizontal, vertical deflection
system and check power
supply secondary voltages.
No
Video failure?
Yes
Check Video board.
No
Check and replace IC201.
Done.
CA17K*/CA17J*
5-13
CONFIDENTIAL
5 Troubleshooting
5-2-3 Missing Color
WAVEFORMS
Proper Video levels are
on CN101 (D-Sub) Pin 1, 3 and 5?
No
Check signal generator.
24 10.0 V (R,G,B, Video)
Yes
24
Proper Video signal is
on all cathodes?
No
Refer to 5-1-16 No Video.
CH1 P-P = 10.0V
CH1 RMS = 17.02V
Yes
Proper DC voltage is
on all cathodes?
No
Check IC101 Pin 18, 21 and 24.
Check QR01, QR02, QG01,
QG02, QB01, and QB02.
No
Check D502, D518, Q501,
D520, D521, and CN501.
Yes
G2 voltage is right?
Yes
Heater voltage is right?
No
Check D608, Q604 and T601.
Yes
Is G2 voltage right?
No
Check D504, Q502 and T501.
Yes
Replace CRT.
Yes
Done.
5-14
CA17K*/CA17J*
CONFIDENTIAL
5 Troubleshooting
5-2-4 Visible Retrace
WAVEFORMS
Check white balance adjustment.
25 5.00V (Q501, Emitter)
G2 voltage is right?
No
Check D502, D518, Q501, Adjust G2.
Yes
Blank pulse is on Pin 17 of IC401?
No
Check IC401.
V_FLB pulse is on
Collector of Q501?
CH1 RMS = 28.33V
26 20.00V (CRT Socket, G1)
Yes
25
CH1 P-P = 5.00V
No
Check Blank pulse is on
Pin 17 of IC401 and Q303.
Yes
26
Does approve the Vertical pulse
on the CRT Socket G1?
No
Check CN102 and CN201.
CH1 P-P = 20.0V CH1 RMS = 66.68V
Yes
Done.
CA17K*/CA17J*
5-15
CONFIDENTIAL
5 Troubleshooting
5-2-5 Unsynchronized Image
Check input signals
Pin 2 and 3 of CN202.
Signals are right?
No
Check Video Cable.
Yes
Signals at Pin 28 and 29 of
IC201 are right?
No
Check IC201.
Yes
Signals at Pin 14 and 15 of
IC401 are right?
No
Check IC401.
Yes
Check circuits on Main board.
Done.
5-16
CA17K*/CA17J*
CONFIDENTIAL
5 Troubleshooting
5-2-6 Misconvergence
Try readjusting convergence.
The convergence is
now within spec.?
Yes
Done.
No
Readjust convergence.
The convergence is
now within spec.?
Yes
Done.
No
Change CRT and readjust
convergence.
Done.
CA17K*/CA17J*
5-17
CONFIDENTIAL
5 Troubleshooting
5-2-7 Poor Focus
Adjust focus VR of FBT.
Improved focus?
Yes
Aging monitor and check for focus
change.
No
Refer to 5-1-15 Dynamic
Focus Failure.
No
Check focus leads from FBT
to CRT Socket.
Check the CRT Socket.
Dynamic focus circuit is right?
Yes
Replace the CRT and verify focus.
5-2-8 Purity Failure
Degaussing
Purity is right?
Yes
Done
No
Degaussing circuit is right?
No
Refer to 5-1-20 Degaussing Failure.
Yes
Replace CRT and verify purity.
5-18
CA17K*/CA17J*
CONFIDENTIAL
4 Alignment and Adjustments
4-2 Display Control Adjustments
4-2-1 HIGH VOLTAGE ADJUSTMENT
Signal:
1024 x 768 (68 kHz/85 Hz)
Display image: Don’t care
Contrast:
Minimum
Brightness:
Minimum
Limit:
26.0 kV ± 0.3 kV
Measure the hight voltage level at the anode cap.
High voltage should be within the limit as above.
4-2-2 CENTER RASTER
Adjust SW401 so that the back raster comes to the
center when you apply basic mode for 17”.
4-2-3 Centering
Centering means to position the center point of
the display in the middle of the display area.
Horizontal size and position and vertical size and
position control the centering of the display.
Use control bar after selecting “H-SIZE” in the left
menu to adjust the horizontal size of the display
pattern to 312 mm (Tolerance : ±3 mm)
Run the All Mode save in the Right Menu.
Caution : Do not Run the All mode Save at the
other scannig times except for 1024x768
(68 kHz/85 Hz).
4-2-4 (b) VERTICAL SIZE ADJUSTMENT
CONDITIONS
Scanning frequency:
Display image:
Brightness:
Contrast:
68 kHz/85 Hz
Crosshatch pattern
Maximum
Maximum
Use control bar after selecting “V-SIZE” in left
menu to adjust the vertical size of the display
pattern to 234 mm.(Tolerance: ± 3 mm.)
Adjust the horizontal size and vertical size to their
optimal settings: 312 mm (H) x 234 mm (V).
4-2-4 (c) HORIZONTAL POSITION ADJUSTMENT
Adjust the horizontal position and vertical
position to ≤ 4.0 mm of the center point of the
screen.
CONDITIONS
Scanning frequency:
Display image:
|A-B| ≤ 4.0 mm.
Use control bar after selecting “H-POSITION” in
left menu to center the horizontal image on the
raster.
|C-D| ≤ 4.0 mm.
C
68 kHz/85 Hz
Crosshatch pattern
DISPLAY AREA
A
4-2-4 (d) VERTICAL POSITION ADJUSTMENT
B
EDGE OF BEZEL
D
CONDITIONS
Scanning frequency:
Display image:
68 kHz/85 Hz
Crosshatch pattern
Figure 4-3. Centering
* In Softjig window, “Geometry” has to be
selected for GD adjustment.
Use control bar after selecting “V-POSITION” in
left menu to center the vertical image on the
raster.
4-2-4 (a) HORIZONTAL SIZE ADJUSTMENT
CONDITIONS
Scanning frequency:
Display image:
Brightness:
Contrast:
68 kHz/85 Hz
Crosshatch pattern
Maximum
Maximum
Click Standard Dump on the right Menu in the
general field.
Use control bar after selecting “SIZE B+” in the
left Menu to adjust the horizontal minimum size
of the display, Pattern to 285 mm
(Tolerance : ±3 mm.)
4-2
CA17K*/CA17J*
CONFIDENTIAL
4 Alignment and Adjustments
4-2-4 Linearity
4-2-5 Trapezoid Adjustment
Linearity affects the symmetry of images as they
appear on the screen. Unless each row or column
of blocks in a crosshatch pattern is of equal size,
or within the tolerances shown in Tables 4-2 and
4-3, an image appears distorted, elongated or
squashed.
CONDITIONS
Scanning frequency:
Display image:
Brightness:
Contrast:
Table 4-1. Standard Modes Linearity: 640x480/85Hz,
800x600/85Hz and 1024x768/85Hz
68 kHz/85 Hz
Crosshatch pattern
Maximum
Maximum
Use control bar after selecting “TRAPEZOID” in
left menu to make the image area rectangular.
| A - B | < 4 mm
Standard Modes Linearity
A
A
B
B
Difference between
adjacent blocks (4 %)
Horizontal: 20.9~23.1 Horizontal: Less than 0.88 mm
Vertical : 20.9~23.1 Vertical : Less than 0.88 mm
Each block (10 %)
4:3
5:4
Horizontal: 19.60~21.65 Horizontal: Less than 0.82 mm
Vertical : 20.9~23.1 Vertical : Less than 0.88 mm
Table 4-2. Other Modes Linearity: VGA, SVGA, XGA,
MAC, etc.
Supported Timing Mode
Each block (14 %)
Difference between
adjacent blocks (5 %)
Horizontal: Less than 1.10 mm
Vertical : Less than 1.10 mm
4:3
Horizontal: 20.5~23.5
Vertical : 20.5~23.5
5:4
Horizontal: 19.18~22.07 Horizontal: Less than 1.03 mm
Vertical : 20.5~23.5 Vertical : Less than 1.10 mm
Figure 4-4. Trapezoid
4-2-6 Pinbalance Adjustment
CONDITIONS
Scanning frequency:
Display image:
Brightness:
Contrast:
D1
4-2-4 (a) HORIZONTAL LINEARITY ADJUSTMENT
CONDITIONS
Scanning frequency:
68 kHz/85 Hz
Display image:
Crosshatch pattern
Brightness:
Maximum
Contrast:
Maximum
To adjust the Horizontal Linearity, refer to Tables
4-2 and 4-3 for the tolerance range.
Increase or decrease H_LIN to optimize the
image.
68 kHz/85 Hz
Crosshatch pattern
Maximum
Maximum
D2
D1
Figure 4-5. Pinbalance
Use control bar after selecting “PINBALANCE” in
left menu to optimize the image.
4-2-4 (b) VERTICAL LINEARITY ADJUSTMENT
CONDITIONS
Scanning frequency:
68 kHz/85 Hz
Display image:
Crosshatch pattern
Brightness:
Maximum
Contrast:
Maximum
To adjust the Vertical Linearity, refer to Tables 4-2
and 4-3 for the tolerance range.
Use control bar after selecting “V-LINEARITY
BAL” in left menu to optimize the image.
CA17K*/CA17J*
4-3
CONFIDENTIAL
4 Alignment and Adjustments
4-2-7 Parallelogram Adjustment
4-2-9 Degauss
CONDITIONS
Scanning Frequency:
Display image:
Brightness:
Contrast:
No adjustments are available for the degaussing
circuit. The degaussing circuit can effectively
function only once per 30 minutes.
68 kHz/85 Hz
Crosshatch pattern
Maximum
Maximum
Use control bar after selecting “PARALLEL” in
left menu to make the image area rectangular.
4-2-10 To Delete the User Mode Data
To delete the adjustment data from the user
modes, click “@4: USER DELETE” in right ment.
4-2-11 Save the Data
To save the adjustment data for a mode, press
“@3: ALL MODE SAVE” in right ment.
4 mm
Figure 4-6. Parallelogram
4-2-8 Side Pincushion Adjustment
CONDITIONS
Scanning frequency:
Display image:
68 kHz/85 Hz
Crosshatch pattern
Use control bar after selecting “PINCUSHION” in
left menu to straighten the sides of the image area.
| C1 |, | C2 | ≤ 2.0 mm, | D1 |, | D2 | ≤ 2.0 mm.
C2
D1
D2
C1
Figure 4-7. Pincushion
4-4
CA17K*/CA17J*
CONFIDENTIAL
4 Alignment and Adjustments
4-3 Color Adjustments
CAUTION:Check below condition before color
adjustment
Video signal : Analog 0.7 Vp-p (at 75 Ω)
Sync : TTL level (H, V seperate signal)
* Select “Color” in Softjig menu for color adjustment.
4-3-1 Color Coordinates (Temperature)
Color temperature is a measurement of the
radiant energy transmitted by a color. For
computer monitors, the color temperature refers
to the radiant energy transmitted by white. Color
coordinates are the X and Y coordinates on the
chromaticity diagram of wavelengths for the
visible spectrum.
CONDITIONS
Measurement instrument: Color analyzer
Scanning frequency: 68 kHz/85 Hz
Display image:
White flat field at
center of display area
Luminance:
Maximum
PROCEDURE
Use the directions in sections 4-3-2 through 4-3-3
to adjust the color coordinates for:
9300K to x = 0.283 ± 0.02, y = 0.298 ± 0.02
6500K to x = 0.313 ± 0.02, y = 0.329 ± 0.02
4-3-2 Color Adjustments for 9300K
4-3-2 (b) WHITE BALANCE ADJUSTMENT
CONDITIONS
Scanning frequency:
68 kHz/85 Hz
Display image:
White box pattern
Brightness:
0.06ft-L at Back Raster
Pattern Display
Contrast:
Maximum
1/3H-1/2H
FRONT BEZEL OPENING
BACK RASTER
1/3V-1/2V
WHITE WINDOW
Figure 4-8. White Box Pattern
1. Use control bar after selecting “RED GAIN”,
“GREEN GAIN” and “BLUE GAIN” to adjust
the luminance to 43 ft-L with the color
coordinates ranged for
9300K to x = 0.283 ± 0.02, y = 0.298 ± 0.02.
4-3-2(c) HIGH LIGHT ZONE ADJUSTMENT
CONDITIONS
Scanning frequency:
68 kHz/85 Hz
Display image:
White box pattern
Brightness:
0.06ft-L at Back Raster
Pattern Display
Contrast:
Maximum
4-3-2 (a) BACK RASTER COLOR ADJUSTMENT
1/3H-1/2H
CONDITIONS
Scanning frequency:
Display image:
Brightness:
Contrast:
FRONT BEZEL OPENING
68 kHz/85 Hz
Back raster pattern
Maximum
Maximum
1. Select “@1: CHANNEL 1” in right menu to
control the color for 9300K.
2. Adjust the luminance of the back raster to
between 0.5 to 0.7 ft-L using contron bar after
selecting “GREEN CUTOFF” in the menu.
3. Use control bar after selecting “BLUE
CUTOFF” in left menu to set the “y”
coordinate to 0.298 ± 0.02.
4. Use control bar after selecting “RED
CUTOFF” in left menu to 0.283 ± 0.02.
* If color values would not be matched desirable
values, repeat sequence 3 and 4 after readjusting
“GREEN CUTOFF” control a little different.
CA17K*/CA17J*
BACK RASTER
1/3V-1/2V
WHITE WINDOW
Figure 4-9. High Light Box Pattern
1. Select “@9: BMFULL” in right menu.
2. Use control bar after selecting “ BM CONT”
to adjust the luminance to
85ft - L (±5ft-L)
3. Select “@0: BM OFF” in right menu.
CA17J* Only
4-5
CONFIDENTIAL
4 Alignment and Adjustments
4-3-2 (d) ABL ADJUSTMENT
CONDITIONS
Scanning frequency:
Display image:
Brightness:
Contrast:
68 kHz/85 Hz
Full white pattern
Maximum
Maximum
FRONT BEZEL OPENING
BACK RASTER
WHITE WINDOW
Figure 4-10. Full White Pattern
1. Check the ABL. If it is not within the
specifications, use the ABL controls to adjust
it. (32 ± 1 ft-L )
2. Select “@4: COLOR SAVE” to save the data.
3. Select “@6: ALL COLOR SAVE” to save the
CH2.
5. Check whether the white coordinates of the
video meet the above coordinates spec.
6. Select “@8: 24-ft “ in right menu.
7. Check whether the white coordinates of the
video satisfies the above spec.
If they do not, return to 4-3-2 (a) and readjust
all settings.
Select “Color” and click “@2: CHANNEL 2”
for color ajdustment for 6500K
Repeat the sequence of 9300K adjustment.
The luminance values the same as 9300K, but
the color coordinated of back raster and white
box are : x = 0.313 ± 0.02 y = 0.329 ± 0.02
4-3-3 Luminance Uniformity Check
Luminance is considered uniform only if the ratio
of lowest to highest brightness areas on the screen
is not less than 7.5:10.
4-3-2 (e) WHITE BALANCE ADJUSTMENT VERIFICATION
CONDITIONS
Scanning frequency:
CONDITIONS
Scanning frequency:
Display image:
Display image:
Brightness:
Contrast:
X-Y Coordinates:
ABL Luminance
Brightness:
Contrast:
68 kHz/85 Hz
Back raster pattern
Full White Pattern
x = 0.283 ± 0.02,
y = 0.298 ± 0.02
Refer to 4-3-2(c)
Maximum
5 ft-L, 24 ft-L
68 kHz/85 Hz
(1024 x 768)
White flat field
Cut off point at 24 ft-L
Maximum
1. Check whether the color coordinates of the
back raster satisfy the above spec.
If they do not, return to 4-3-2 (a) and readjust
all settings.
2. Display a full white pattern.
3. Select “Geometry” in softjig menu.
4. Select “@7: 5-ft “ in right menu.
4-6
CA17K*/CA17J*
CONFIDENTIAL
4 Alignment and Adjustments
PROCEDURE
Measure luminance at nine points on the display
screen (see figure below).
Figure 4-10. Luminance Uniformity Check Locations
4-3-4 Focus Adjustment
CONDITIONS
Scanning frequency:
Display image:
Brightness:
Contrast:
68 kHz/85 Hz
(1024 x 768)
“H” character pattern
Cut off point
Maximum
PROCEDURE
1. Adjust the Focus VR on the FBT to display the
sharpest image possible.
2. Use Locktite to seal the Focus VR in position.
4-3-5 Color Purity Adjustment
Color purity is the absence of undesired color.
Conspicuous mislanding (unexpected color in a
uniform field) within the display area shall not be
visible at a distance of 50 cm from the CRT
surface.
CONDITIONS
Orientation:
Scanning frequency:
Display image:
Luminance:
PROCEDURE
For trained and experienced service technicians
only.
Use the following procedure to correct minor
color purity problems:
1. Make sure the display is not affected by
external magnetic fields.
2. Make sure the spacing between the PCM
assembly and the CRT stem is 29 mm ± 1 mm.
3. Display a green pattern over the entire display
area.
4. Adjust the purity magnet rings on the PCM
assembly to display a pure green pattern.
(Optimum setting: x = 0.295 ± 0.015,
y = 0.594 ± 0.015)
5. Repeat steps 4 and 5 using a red pattern and
then again, using a blue pattern.
Table 4-4. Color Purity Tolerances
Red:
x = 0.640 ± 0.015
y = 0.323 ± 0.015
Green:
x = 0.295 ± 0.015
y = 0.594 ± 0.015
Blue:
x = 0.142 ± 0.015
y = 0.066 ± 0.015
(For 9300K color adjustment: x = 0.283 ± 0.02, y = 0.298 ± 0.02)
6. When you have the PCMs properly adjusted,
carefully glue them together to prevent their
movement during shipping.
Monitor facing east
68 kHz/85 Hz
White flat field
Cut off point at the center
of the display area
Note: Color purity adjustments should only be
attempted by qualified personnel.
CA17K*/CA17J*
4-7
4 Alignment and Adjustments
CONFIDENTIAL
Memo
4-8
CA17K*/CA17J*
CONFIDENTIAL
3 Disassembly and Reassembly
6. Remove the Shield.(TCO 99)
3-1-4 Removing the Main PCB
1. Complete all previous steps.
2. Disconnect the Degaussing Coil at CN603 on
the Main PCB.
3. Disconnect all easily accessible ground wires
on the PCB and Bottom Chassis.
4. Disconnect the DY connector at the CN401
connector on the Main .
5. Using the jig, release the snaps (2) connecting
the Front Cover and the PCB then lift up the
Bottom to separate the two Shield.
Figure 5
7. Using pinch-nose pliers or ling-nose pliers,
acrefully disconnect the Anode Cap from the
CRT.
Warning: Do not touch the Anode contact
on the CRT (High Voltage may
remain).
3-1-3 Removing the CRT Socket PCB
1. Complete all previous steps.
2. Lift up the Video Spring and remove the CRT
Socket PCB from the CRT.
Figure 7
6. Disconnect the Tilt connector at the CN304
connector on the Main PCB.
7. Disconnect the Sub PCB connector at the
CN205 connector on the Main PCB.
8. Remove the screws on the back and along
each side of the Bottom Chassis.
9. Carefully lift the Main PCB Ass’y and remove
the remaining ground wires.
10. Place the Main PCB Ass’y on a flat, level
surface that is protected from static electricity.
Figure 6
3. Disconnect all connectors on the CRT Socket
PCB.
4. Using a solder iron, disconnect Ground (GND)
on the back of the Video Shield and remove
the Shield Cap.
5. Remove the screw on the front of the Shield
Socket.
6. Desolder the 4 tabs on the CRT Socket PCB
and remove Shield.
7. Place the Video PCB on a flat, level surface
that is protected from static electricity.
3-1-5 CRT Ass’y Disassembly
1. Complete all previous steps.
2. Straighten the Degaussing Coil Assembly
coated metal ties and lift the Coil Ass’y from
the CRT.
3. Remove the four corner screws and lift the
CRT up and away from the Front Cover
Assembly and place it on a padded surface.
Caution: Do not lift the CRT by the neck.
If you will be returning this CRT to
the monitor, be sure to place the CRT
face downward on a protective pad.
3-2 Reassembly
Reassembly procedures are in the reverse order of Disassembly procedures.
3-2
CA17K*/CA17J*
CONFIDENTIAL
2 Product Specifications
2-2 Pin Assignments
Sync
Type
Separate
Macintosh
Pin No.
1
Red
GND-R
2
Green
Red
3
Blue
H/V Sync
4
N-C
Sense 0
5
DDC Return
Green
6
GND-R
GND-G
7
GND-G
Sense 1
8
GND-B
Reserved
9
N-C
Blue
10
GND-Sync/Self-raster
Sense 2
11
N-C
GND
12
DDC Data
V-Sync
13
H-Sync
GND-B
14
V-Sync
GND
15
DDC Clock
H-Sync
5
15
Figure 2-1. Male Type
2-2
Figure 2-2. Male Type
CA17K*/CA17J*
CONFIDENTIAL
2 Product Specifications
2-3 Timing Chart
This section of the service manual describes the timing that the computer industry recognizes as standard
for computer-generated video signals.
Table 2-1. Timing Chart
Mode
IBM
VGA3/60 Hz 640/75 Hz 640/85 Hz
640 x 480
640 x 480 (CA17K* Only) 640 x 480
VGA2/70 Hz
720 x 400
Timing
VESA
800/75 Hz
800 x 600
800/85 Hz 1024/75 Hz 1024/85 Hz 1280/75 Hz
1280 x 1024
800 x 600 1024 x 768 1024 x 768 (CA17J* Only)
fH (kHz)
31.469
31.469
37.500
43.269
46.875
53.674
60.023
68.677
79.976
A µsec
31.778
31.777
26.667
23.111
21.333
18.631
16.660
14.561
12.504
B µsec
3.813
3.813
2.032
1.556
1.616
1.138
1.219
1.016
1.067
C µsec
1.907
1.907
3.810
2.222
3.232
2.702
2.235
2.201
1.837
D µsec
25.422
25.422
20.317
17.778
16.162
14.222
13.003
10.836
9.481
E µsec
0.636
0.636
0.508
1.556
0.323
0.569
0.203
0.508
0.119
fV (Hz)
59.940
70.087
75.000
85.008
75.000
85.061
75.029
84.997
75.025
O msec
16.683
14.268
13.333
11.764
13.333
11.756
13.328
11.765
13.329
P msec
0.064
0.064
0.080
0.671
0.064
0.056
0.050
0.044
0.038
Q msec
1.048
1.080
0.427
0.578
0.448
0.503
0.466
0.524
0.475
R msec
15.253
12.711
12.800
11.093
12.800
11.179
12.795
11.183
12.804
S msec
0.318
0.413
0.027
0.023
0.021
0.019
0.017
0.015
0.013
25.175
28.322
31.500
36.000
49.500
56.250
78.750
94.500
135.000
Polarity
H.Sync
Negative
Negative
Negative
Negative
Positive
Positive
Positive
Positive
Positive
V.Sync
Negative
Positive
Negative
Negative
Positive
Positive
Positive
Positive
Positive
Remark
Separate
Separate
Separate
Separate
Separate
Separate
Separate
Separate
Separate
Clock
Frequency
(MHz)
Separate Sync
Horizontal
Vertical
Video
Video
Video
Video
CC
DD
E
E
Q
RR
Q
S S
Sync
Sync
Sync
Sync
BB
PP
AA
O O
A : Line time total
B : Horizontal sync width
O : Frame time total
P : Vertical sync width
C : Back porch
D : Active time
Q : Back porch
R : Active time
E : Front porch
CA17K*/CA17J*
S : Front porch
2-3
2 Product Specifications
CONFIDENTIAL
Memo
2-4
CA17K*/CA17J*
CONFIDENTIAL
1 Precautions
1-2 Servicing Precautions
WARNING1: First read the “Safety Precautions” section of this manual. If unforeseen circumstances
create conflict between the servicing precautions and safety precautions, always
follow the safety precautions.
WARNING2: A high voltage adjusted to the wrong value may cause excessive X-ray emissions.
WARNING3: An electrolytic capacitor installed with the wrong polarity might explode.
1.
Servicing precautions are printed on the cabinet,
and should be followed closely.
2.
Always unplug the unit’s AC power cord from the
AC power source before attempting to: (a) remove
or reinstall any component or assembly, (b)
disconnect PCB plugs or connectors, (c) connect all
test components in parallel with an electrolytic
capacitor.
3.
4.
Some components are raised above the printed
circuit board for safety. An insulation tube or tape
is sometimes used. The internal wiring is
sometimes clamped to prevent contact with
thermally hot components. Reinstall all such
elements to their original position.
After servicing, always check that the screws,
components and wiring have been correctly
reinstalled. Make sure that the area around the
serviced part has not been damaged.
5.
Check the insulation between the blades of the AC
plug and accessible conductive parts (examples:
metal panels, input terminals and earphone jacks).
6.
Insulation Checking Procedure: Disconnect the
power cord from the AC source and turn the power
switch ON. Connect an insulation resistance meter
(500 V) to the blades of the AC plug.
The insulation resistance between each blade of the
AC plug and accessible conductive parts (see
above) should be greater than 1 megohm.
7.
Never defeat any of the +B voltage interlocks. Do
not apply AC power to the unit (or any of its
assemblies) unless all solid-state heat sinks are
correctly installed.
8.
Always connect a test instrument’s ground lead to
the instrument chassis ground before connecting
the positive lead; always remove the instrument’s
ground lead last.
1-3 Electrostatically Sensitive Devices (ESD) Precautions
Some semiconductor (solid state) devices can be easily damaged by static electricity. Such components are commonly
called Electrostatically Sensitive Devices (ESD). Examples of typical ESD devices are integrated circuits and some fieldeffect transistors. The following techniques will reduce the incidence of component damage caused by static electricity.
1.
Immediately before handling any semiconductor
components or assemblies, drain the electrostatic
charge from your body by touching a known earth
ground. Alternatively, wear a discharging wriststrap device. To avoid a shock hazard, be sure to
remove the wrist strap before applying power to
the monitor.
6.
Do not remove a replacement ESD from its
protective package until you are ready to install it.
Most replacement ESDs are packaged with leads
that are electrically shorted together by conductive
foam, aluminum foil or other conductive materials.
7.
2.
After removing an ESD-equipped assembly, place it
on a conductive surface such as aluminum foil to
prevent accumulation of an electrostatic charge.
Immediately before removing the protective
material from the leads of a replacement ESD,
touch the protective material to the chassis or
circuit assembly into which the device will be
installed.
3.
Do not use freon-propelled chemicals. These can
generate electrical charges sufficient to damage
ESDs.
Caution: Be sure no power is applied to the
chassis or circuit and observe all
other safety precautions.
4.
Use only a grounded-tip soldering iron to solder or
desolder ESDs.
5.
Use only an anti-static solder removal device. Some
solder removal devices not classified as “anti-static”
can generate electrical charges sufficient to damage
ESDs.
1-2
8.
Minimize body motions when handling
unpackaged replacement ESDs. Motions such as
brushing clothes together, or lifting your foot from
a carpeted floor can generate enough static
electricity to damage an ESD.
9.
Indicates ESDs on the Schematic Diagram in
this manual.
CA17K*/CA17J*
Samsung Electronics Co.,Ltd.
416, Maetan-3Dong, Paldal-Gu, Suwon City, Kyungki-Do, Korea.
Printed in Korea
P/N : BH81-00018A-00
http://www.samsungmonitor.com (SyncMaster Worldwide)
http://www.samsung-monitor.com (SyncMaster USA)
http://www.sec.co.kr/monitor (Korea)