BCR8FM-20LA Data Sheet (1000V-8A

BCR8FM-20LA Data Sheet (1000V-8A
Preliminary Datasheet
BCR8FM-20LA
R07DS1326EJ0100
Rev.1.00
Feb 24, 2016
1000V-8A-Triac
Medium Power Use
Features




 Insulated Type
 Planar Passivation Type
IT (RMS) : 8 A
VDRM : 1000 V
IFGTI, IRGTI, IRGT III : 30 mA
Viso : 2000 V
Outline
RENESAS Package code: PRSS0003AG-A
(Package name: TO-220FP)
2
1. T1 Terminal
2. T2 Terminal
3. Gate Terminal
3
1
1
2 3
Applications
Washing machine, inversion operation of capacitor motor, and other general controlling devices
Maximum Ratings
Parameter
Voltage class
20
1000
1200
Symbol
voltageNote1
Repetitive peak off-state
Non-repetitive peak off-state voltageNote1
VDRM
VDSM
Parameter
RMS on-state current
Symbol
IT (RMS)
Ratings
8
Unit
A
Surge on-state current
ITSM
80
A
I2t
26
A2s
PGM
PG (AV)
VGM
IGM
Tj
Tstg
—
Viso
5
0.5
10
2
– 40 to +125
– 40 to +125
2.0
2000
W
W
V
A
C
C
g
V
I2t for fusing
Peak gate power dissipation
Average gate power dissipation
Peak gate voltage
Peak gate current
Junction temperature
Storage temperature
Mass
Isolation voltage
Unit
V
V
Conditions
Commercial frequency, sine full wave
360° conduction, Tc = 88C
60Hz sinewave 1 full cycle, peak value,
non-repetitive
Value corresponding to 1 cycle of half
wave 60Hz, surge on-state current
Typical value
Ta = 25C, AC 1 minute,
T1·T2·G terminal to case
Notes: 1. Gate open.
R07DS1326EJ0100 Rev.1.00
Feb 24, 2016
Page 1 of 7
BCR8FM-20LA
Preliminary
Electrical Characteristics
Parameter
Repetitive peak off-state current
On-state voltage
Symbol
IDRM
VTM
Min.
—
—
Typ.
—
—
Max.
2.0
1.6
Unit
mA
V
Test conditions
Tj = 125C, VDRM applied
Tc = 25C, ITM = 12 A,
Instantaneous measurement
Gate trigger voltageNote2



VFGT
VRGT
VRGT
—
—
—
—
—
—
1.5
1.5
1.5
V
V
V
Tj = 25C, VD = 6 V, RL = 6 ,
RG = 330 
Gate trigger currentNote2



IFGT
IRGT
IRGT
—
—
—
—
—
—
30
30
30
mA
mA
mA
Tj = 25C, VD = 6 V, RL = 6 ,
RG = 330 
VGD
Rth (j-c)
0.2
—
—
—
—
3.7
V
C/W
Tj = 125C, VD = 1/2 VDRM
Junction to caseNote3
(dv/dt)c
10
—
—
V/s
Tj = 125C
Gate non-trigger voltage
Thermal resistance
Critical-rate of rise of off-state
commutating voltageNote4
Notes: 2. Measurement using the gate trigger characteristics measurement circuit.
3. The contact thermal resistance Rth (c-f) in case of greasing is 0.5°C/W.
4. Test conditions of the critical-rate of rise of off-state commutating voltage is shown in the table below.
Test conditions
1. Junction temperature
Tj = 125C
2. Rate of decay of on-state commutating current
(di/dt)c = – 4.0 A/ms
3. Peak off-state voltage
VD = 400 V
R07DS1326EJ0100 Rev.1.00
Feb 24, 2016
Commutating voltage and current waveforms
(inductive load)
Supply Voltage
Time
Main Current
(di/dt)c
Time
Main Voltage
(dv/dt)c
Time
VD
Page 2 of 7
BCR8FM-20LA
Preliminary
Performance Curves
102
7
5
3
2
Rated Surge On-State Current
100
Tj = 125°C
101
7
5
3
2
Tj = 25°C
100
7
5
3
2
Surge On-State Current (A)
On-State Current (A)
Maximum On-State Characteristics
60
50
40
30
20
10
2 3 4 5 7 101
2 3 4 5 7 102
Gate Characteristics (I, II and III)
Gate Trigger Current vs.
Junction Temperature
PG(AV) = 0.5W
PGM = 5W
IGM = 2A
VGT = 1.5V
100
7
5
3
2
IFGT I IRGT I, IRGT III
VGD = 0.2V
10–1
7
5
101 2 3 5 7 102 2 3 5 7 103 2 3 5 7 104
Gate Trigger Current (Tj = t°C)
× 100 (%)
Gate Trigger Current (Tj = 25°C)
Conduction Time (Cycles at 60Hz)
103
7
5
4
3
2
102
7
5
4
3
2
Typical Example
IRGT III
IRGT I, IFGT I
101
–60 –40 –20 0 20 40 60 80 100 120 140
Gate Current (mA)
Junction Temperature (°C)
Gate Trigger Voltage vs.
Junction Temperature
Maximum Transient Thermal Impedance
Characteristics (Junction to case)
103
7
5
4
3
2
Typical Example
102
7
5
4
3
2
101
–60 –40 –20 0 20 40 60 80 100 120 140
Junction Temperature (°C)
R07DS1326EJ0100 Rev.1.00
Feb 24, 2016
Transient Thermal Impedance (°C/W)
Gate Voltage (V)
70
On-State Voltage (V)
3
2 VGM = 10V
Gate Trigger Voltage (Tj = t°C)
× 100 (%)
Gate Trigger Voltage (Tj = 25°C)
80
0
100
10–1
0.6 1.0 1.4 1.8 2.2 2.6 3.0 3.4 3.8
101
7
5
3
2
90
102 2 3 5 7 103 2 3 5
4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0
10–1 2 3 5 7 100 2 3 5 7 101 2 3 5 7 102
Conduction Time (Cycles at 60Hz)
Page 3 of 7
BCR8FM-20LA
Preliminary
103
7
5
3
2
Maximum On-State Power Dissipation
16
No Fins
On-State Power Dissipation (W)
Transient Thermal Impedance (°C/W)
Maximum Transient Thermal Impedance
Characteristics (Junction to ambient)
102
7
5
3
2
101
7
5
3
2
100
7
5
3
2
10–1
6
4
2
0
2
4
6
8
10
12
14
16
RMS On-State Current (A)
Allowable Case Temperature vs.
RMS On-State Current
Allowable Ambient Temperature vs.
RMS On-State Current
160
Ambient Temperature (°C)
Curves apply regardless
140 of conduction angle
120
100
80
60
40
360° Conduction
20 Resistive,
inductive loads
0
0
2
4
6
8
10
12
14
All fins are black painted
140 aluminum and greased
120
120 × 120 × t2.3
100 × 100 × t2.3
100
60 × 60 × t2.3
80
60
Curves apply
regardless of
conduction angle
Resistive,
inductive loads
Natural convection
40
20
0
16
0
2
4
6
8
10
12
14
16
RMS On-State Current (A)
RMS On-State Current (A)
Allowable Ambient Temperature vs.
RMS On-State Current
Repetitive Peak Off-State Current vs.
Junction Temperature
160
Natural convection
No Fins
Curves apply regardless
of conduction angle
Resistive, inductive loads
140
120
100
80
60
40
20
0
0.5
1.0
1.5
2.0
2.5
RMS On-State Current (A)
R07DS1326EJ0100 Rev.1.00
Feb 24, 2016
3.0
Repetitive Peak Off-State Current (Tj = t°C)
× 100 (%)
Repetitive Peak Off-State Current (Tj = 25°C)
Case Temperature (°C)
8
Conduction Time (Cycles at 60Hz)
160
Ambient Temperature (°C)
12 360° Conduction
Resistive,
10 inductive loads
0
101 2 3 5 7 102 2 3 5 7 103 2 3 5 7 104 2 3 5 7 105
0
14
105
7 Typical Example
5
3
2
104
7
5
3
2
103
7
5
3
2
102
–60 –40 –20 0 20 40 60 80 100 120 140
Junction Temperature (°C)
Page 4 of 7
BCR8FM-20LA
Preliminary
103
7
5
4
3
2
Latching Current vs.
Junction Temperature
Latching Current (mA)
Typical Example
102
7
5
4
3
2
101
–60 –40 –20 0 20 40 60 80 100 120 140
103
7
5
3
2
Distribution
T2+, G–
Typical Example
102
7
5
3
2
101
7
5
3 T +, G+
2
2
Typical Example
T2–, G–
100
–40
0
40
80
120
160
Junction Temperature (°C)
Breakover Voltage vs.
Junction Temperature
Breakover Voltage vs.
Rate of Rise of Off-State Voltage
160
Typical Example
140
120
100
80
60
40
20
0
–60 –40 –20 0 20 40 60 80 100120 140
Breakover Voltage (dv/dt = xV/μs)
× 100 (%)
Breakover Voltage (dv/dt = 1V/μs)
Junction Temperature (°C)
160
Typical Example
Tj = 125°C
140
120
III Quadrant
100
80
60
40
I Quadrant
20
0
101 2 3 5 7 102 2 3 5 7 103 2 3 5 7 104
Junction Temperature (°C)
Rate of Rise of Off-State Voltage (V/μs)
Commutation Characteristics
Gate Trigger Current vs.
Gate Current Pulse Width
3 Typical Example
2 Tj = 125°C
102 IT = 4A
7 τ = 500μs
5 VD = 200V
3 f = 3Hz
2
Time
Main Voltage
(dv/dt)c
VD
Main Current
(di/dt)c
IT
τ
Time
101
7
5
3 Minimum
2 Characteristics
Value
I Quadrant
III Quadrant
100
7
5
100 2 3 5 7 101 2 3 5 7 102 2 3 5 7 103
Rate of Decay of On-State
Commutating Current (A/ms)
R07DS1326EJ0100 Rev.1.00
Feb 24, 2016
Gate Trigger Current (tw)
× 100 (%)
Gate Trigger Current (DC)
Critical Rate of Rise of Off-State
Commutating Voltage (V/μs)
Breakover Voltage (Tj = t°C)
× 100 (%)
Breakover Voltage (Tj = 25°C)
Holding Current (Tj = t°C)
× 100 (%)
Holding Current (Tj = 25°C)
Holding Current vs.
Junction Temperature
103
7
5
4
3
2
Typical Example
IFGT I
IRGT I
IRGT III
102
7
5
4
3
2
101 0
10
2 3 4 5 7 101
2 3 4 5 7 102
Gate Current Pulse Width (μs)
Page 5 of 7
BCR8FM-20LA
Preliminary
Gate Trigger Characteristics Test Circuits
6Ω
6Ω
A
6V
V
A
6V
330Ω
Test Procedure I
V
330Ω
Test Procedure II
6Ω
A
6V
V
330Ω
Test Procedure III
R07DS1326EJ0100 Rev.1.00
Feb 24, 2016
Page 6 of 7
BCR8FM-20LA
Preliminary
Package Dimensions
Package Name
TO-220FP
JEITA Package Code
⎯
RENESAS Code
PRSS0003AG-A
Previous Code
⎯
MASS[Typ.]
1.9g
Unit: mm
10.16 ± 0.20
2.54 ± 0.20
6.68 ± 0.20
3.3 ± 0.2
1.28 ± 0.30
3.18 ± 0.20
12.98 ± 0.30
15.87 ± 0.20
φ 3.18 ± 0.10
Max 1.47
2.76 ± 0.20
0.80 ± 0.20
0.50
4.7 ± 0.2
5.08 ± 0.20
Ordering Information
Orderable Part Number
BCR8FM-20LA#BB0
BCR8FM-20LA-#BB0
Packing
Tube
Tube
Quantity
50 pcs.
50 pcs.
Remark
Straight type
:Lead forming type
Note : Please confirm the specification about the shipping in detail.
R07DS1326EJ0100 Rev.1.00
Feb 24, 2016
Page 7 of 7
Notice
1.
Descriptions of circuits, software and other related information in this document are provided only to illustrate the operation of semiconductor products and application examples. You are fully responsible for
the incorporation of these circuits, software, and information in the design of your equipment. Renesas Electronics assumes no responsibility for any losses incurred by you or third parties arising from the
use of these circuits, software, or information.
2.
Renesas Electronics has used reasonable care in preparing the information included in this document, but Renesas Electronics does not warrant that such information is error free. Renesas Electronics
3.
Renesas Electronics does not assume any liability for infringement of patents, copyrights, or other intellectual property rights of third parties by or arising from the use of Renesas Electronics products or
assumes no liability whatsoever for any damages incurred by you resulting from errors in or omissions from the information included herein.
technical information described in this document. No license, express, implied or otherwise, is granted hereby under any patents, copyrights or other intellectual property rights of Renesas Electronics or
others.
4.
You should not alter, modify, copy, or otherwise misappropriate any Renesas Electronics product, whether in whole or in part. Renesas Electronics assumes no responsibility for any losses incurred by you or
5.
Renesas Electronics products are classified according to the following two quality grades: "Standard" and "High Quality". The recommended applications for each Renesas Electronics product depends on
third parties arising from such alteration, modification, copy or otherwise misappropriation of Renesas Electronics product.
the product's quality grade, as indicated below.
"Standard": Computers; office equipment; communications equipment; test and measurement equipment; audio and visual equipment; home electronic appliances; machine tools; personal electronic
equipment; and industrial robots etc.
"High Quality": Transportation equipment (automobiles, trains, ships, etc.); traffic control systems; anti-disaster systems; anti-crime systems; and safety equipment etc.
Renesas Electronics products are neither intended nor authorized for use in products or systems that may pose a direct threat to human life or bodily injury (artificial life support devices or systems, surgical
implantations etc.), or may cause serious property damages (nuclear reactor control systems, military equipment etc.). You must check the quality grade of each Renesas Electronics product before using it
in a particular application. You may not use any Renesas Electronics product for any application for which it is not intended. Renesas Electronics shall not be in any way liable for any damages or losses
incurred by you or third parties arising from the use of any Renesas Electronics product for which the product is not intended by Renesas Electronics.
6.
You should use the Renesas Electronics products described in this document within the range specified by Renesas Electronics, especially with respect to the maximum rating, operating supply voltage
range, movement power voltage range, heat radiation characteristics, installation and other product characteristics. Renesas Electronics shall have no liability for malfunctions or damages arising out of the
use of Renesas Electronics products beyond such specified ranges.
7.
Although Renesas Electronics endeavors to improve the quality and reliability of its products, semiconductor products have specific characteristics such as the occurrence of failure at a certain rate and
malfunctions under certain use conditions. Further, Renesas Electronics products are not subject to radiation resistance design. Please be sure to implement safety measures to guard them against the
possibility of physical injury, and injury or damage caused by fire in the event of the failure of a Renesas Electronics product, such as safety design for hardware and software including but not limited to
redundancy, fire control and malfunction prevention, appropriate treatment for aging degradation or any other appropriate measures. Because the evaluation of microcomputer software alone is very difficult,
please evaluate the safety of the final products or systems manufactured by you.
8.
Please contact a Renesas Electronics sales office for details as to environmental matters such as the environmental compatibility of each Renesas Electronics product. Please use Renesas Electronics
products in compliance with all applicable laws and regulations that regulate the inclusion or use of controlled substances, including without limitation, the EU RoHS Directive. Renesas Electronics assumes
no liability for damages or losses occurring as a result of your noncompliance with applicable laws and regulations.
9.
Renesas Electronics products and technology may not be used for or incorporated into any products or systems whose manufacture, use, or sale is prohibited under any applicable domestic or foreign laws or
regulations. You should not use Renesas Electronics products or technology described in this document for any purpose relating to military applications or use by the military, including but not limited to the
development of weapons of mass destruction. When exporting the Renesas Electronics products or technology described in this document, you should comply with the applicable export control laws and
regulations and follow the procedures required by such laws and regulations.
10. It is the responsibility of the buyer or distributor of Renesas Electronics products, who distributes, disposes of, or otherwise places the product with a third party, to notify such third party in advance of the
contents and conditions set forth in this document, Renesas Electronics assumes no responsibility for any losses incurred by you or third parties as a result of unauthorized use of Renesas Electronics
products.
11. This document may not be reproduced or duplicated in any form, in whole or in part, without prior written consent of Renesas Electronics.
12. Please contact a Renesas Electronics sales office if you have any questions regarding the information contained in this document or Renesas Electronics products, or if you have any other inquiries.
(Note 1)
"Renesas Electronics" as used in this document means Renesas Electronics Corporation and also includes its majority-owned subsidiaries.
(Note 2)
"Renesas Electronics product(s)" means any product developed or manufactured by or for Renesas Electronics.
http://www.renesas.com
SALES OFFICES
Refer to "http://www.renesas.com/" for the latest and detailed information.
Renesas Electronics America Inc.
2801 Scott Boulevard Santa Clara, CA 95050-2549, U.S.A.
Tel: +1-408-588-6000, Fax: +1-408-588-6130
Renesas Electronics Canada Limited
9251 Yonge Street, Suite 8309 Richmond Hill, Ontario Canada L4C 9T3
Tel: +1-905-237-2004
Renesas Electronics Europe Limited
Dukes Meadow, Millboard Road, Bourne End, Buckinghamshire, SL8 5FH, U.K
Tel: +44-1628-585-100, Fax: +44-1628-585-900
Renesas Electronics Europe GmbH
Arcadiastrasse 10, 40472 Düsseldorf, Germany
Tel: +49-211-6503-0, Fax: +49-211-6503-1327
Renesas Electronics (China) Co., Ltd.
Room 1709, Quantum Plaza, No.27 ZhiChunLu Haidian District, Beijing 100191, P.R.China
Tel: +86-10-8235-1155, Fax: +86-10-8235-7679
Renesas Electronics (Shanghai) Co., Ltd.
Unit 301, Tower A, Central Towers, 555 Langao Road, Putuo District, Shanghai, P. R. China 200333
Tel: +86-21-2226-0888, Fax: +86-21-2226-0999
Renesas Electronics Hong Kong Limited
Unit 1601-1611, 16/F., Tower 2, Grand Century Place, 193 Prince Edward Road West, Mongkok, Kowloon, Hong Kong
Tel: +852-2265-6688, Fax: +852 2886-9022
Renesas Electronics Taiwan Co., Ltd.
13F, No. 363, Fu Shing North Road, Taipei 10543, Taiwan
Tel: +886-2-8175-9600, Fax: +886 2-8175-9670
Renesas Electronics Singapore Pte. Ltd.
80 Bendemeer Road, Unit #06-02 Hyflux Innovation Centre, Singapore 339949
Tel: +65-6213-0200, Fax: +65-6213-0300
Renesas Electronics Malaysia Sdn.Bhd.
Unit 1207, Block B, Menara Amcorp, Amcorp Trade Centre, No. 18, Jln Persiaran Barat, 46050 Petaling Jaya, Selangor Darul Ehsan, Malaysia
Tel: +60-3-7955-9390, Fax: +60-3-7955-9510
Renesas Electronics India Pvt. Ltd.
No.777C, 100 Feet Road, HAL II Stage, Indiranagar, Bangalore, India
Tel: +91-80-67208700, Fax: +91-80-67208777
Renesas Electronics Korea Co., Ltd.
12F., 234 Teheran-ro, Gangnam-Gu, Seoul, 135-080, Korea
Tel: +82-2-558-3737, Fax: +82-2-558-5141
© 2016 Renesas Electronics Corporation. All rights reserved.
Colophon 5.0
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement