InEx Sprayer 30 Leaflet

Add to my manuals
6 Pages

advertisement

InEx Sprayer 30 Leaflet | Manualzz

Sprayer 30 Pt.No 1111

(Leaflet 2400-1450 Issue 2, October 2015)

DESCRIPTION

The In-Ex SPRAYER 30 is an entry-level spot sprayer which can be used in a variety of applications. It is especially suitable for use with small vehicles or anywhere where there is a flat surface to attach it to and a source of 12VDC power. The Sprayer 30 is supplied ready to use and includes a sturdy tie down strap and 2.2metre power cable.

(pump size 7.6Lpm)

WARRANTY

1 WARRANTY AND LIABILITY

Use of the equipment

1.1

You must satisfy yourself as to the suitability of the equipment for your intended use(s) of the equipment.

Your relationship with the retailer

1.2

Where you consider you have a warranty claim (or any other claim) in relation to the equipment, you must contact the retailer who sold you the equipment, not C-Dax directly. The retailer is responsible for liaising with C-Dax in respect of your claim.

Warranty

1.3

C-Dax warrants to the original purchaser that the equipment is sold free from defects in materials and workmanship for a period of 12 months from date of first retail sale (6 months from date of first retail sale if the equipment is sold in the U.K.) subject to the terms set out below.

1.4

C-Dax will at its option repair or replace the defective equipment (or part of the equipment) or notify the retailer of the equipment to refund the purchase price for such defective equipment to you in the event of a breach of this warranty, subject to the terms set out below.

Liability

1.5

Except for the warranty set out in clause 1.2 above, all warranties and representations (including those expressed or implied by law) in respect of the equipment or advice relating to the equipment provided to you by C-Dax are excluded to the extent permitted by law.

1.6

Notwithstanding anything else in this manual, C-Dax’s maximum liability to you (in the event that such liability exists) in respect of any breach of warranty, any matter set out in this manual, or for defective equipment or advice relating to the equipment provided is limited at C-Dax’s option to:

(a) repairing or replacing the equipment (or part of the equipment); or

(b) notifying the retailer of the equipment to refund the price for the equipment paid by you.

1

1.7

Notwithstanding anything else in this manual, in no event will C-Dax be liable, whether in contract, tort (including negligence) or otherwise:

(a) where you have altered or modified the equipment, misused or misapplied the equipment, or the equipment has been subjected to any unusual, excessive or non-recommended use, service or handling (including as set out in this manual);

(b) where the equipment is not transported, stored, handled or used in accordance with any directions given by C-Dax (or the retailer) to you (including as set out in this manual);

(c) where the equipment:

(i) has been subject to neglect, accident or hireage, or the damage arises from fair wear and tear, battery damage or chemical attack;

(ii) has been built to a customer’s specifications; or

(iii) has been dismantled, repaired or serviced other than by an authorised service agent of

C-Dax;

(d) for loss or damage caused by any factors beyond C-Dax’s control; or

(e) for any loss of profit or revenue, or for any special, indirect, incidental or consequential damage, loss or injury of any kind suffered by you.

1.8

Where C-Dax elects to repair or replace the equipment it will use reasonable endeavours to do so as soon as practicable but will not be liable for any delay in doing so.

1.9

You agree that the transactions entered into between you and the retailer (and C-Dax) are for the purposes of trade and that, having regard to all relevant circumstances of the transactions, it is fair and reasonable that the provisions of the Consumer Guarantees Act 1993 (NZ) do not apply to those transactions to the fullest extent permitted by law.

2

CONTENTS

Part No.

N/A

Description

Tank assembly complete with; lid, pump, suction filter, spray gun and hose.

8410-8450 Strap-Ratchet

1500-3700 Cable ASY-Battery-2.2M

Quantity

1

1

1

INSTALLATION

Place the Sprayer 30 on the vehicle with the switch facing the operator. Secure the tank in place using the ratchet strap. Connect the cable assembly to the male connector on the pump then attach to the vehicle battery ensuring that the red wire is connected to the positive terminal.

OPERATING INSTRUCTIONS

Place fluid in the tank then turn the switch on. The pump will run. Place the end of the spray gun in the tank and press the trigger until all of the air has been expelled from the hose. The pump will stop running when the trigger is released.

Operate the spray gun and adjust the tip until the pump runs smoothly and the desired spray pattern is obtained.

MAINTENANCE

Cleaning Tank and Spray Gun

W hen spraying is finished rinse the tank with clean water and pump the contents out through the spray gun. A triple rinse is recommended. Do not leave spray in the tank between uses.

Filter Maintenance

After each use or when the tank has been emptied (whichever comes first) it is recommended that the suction filter located under the unit be removed and cleaned.

TROUBLE SHOOTING

Pump will not prime

Check that the suction filter is tightly in place.

Operate the spray gun to release air from the pump.

Check that the suction filter is not blocked.

Pump pulses

Adjust the spray tip to increase pump flow.

Pump will not run

Check electrical connections and fuse.

3

FLOJET SPRAY PUMP RELACEMENT PARTS

The following replacement parts for the 12V Flojet 7.6 L/Min pump are available from any C-Dax dealer:

Quadport Type:

ITEM PART NO.

1 6800-5160

DESCRIPTION

Pumphead Kit (includes pressure switch)

To Suit QuadportType

6800-5000 Replacement Pump

Quadport Type

4

RELACEMENT PARTS

5

Item

No.

1

2

3

4

5

6

7

8

9

QTY. e9 part no

1 1500-3700 e9 description

Cable-Electrical-Loom-Battery Feed-2M

1 1500-7300 Cable-Electrical-Single Core-1mm2-1000VDC-Red

2 2000-2014 Clamp-Hose-Oetiker-Single Ear Stepless-14.5<>7.0mm-S/S

2 2000-2017 Clamp-Hose-Oetiker-Single Ear Stepless-16.6<>19.8mm-S/S

1 2250-8200 Cover-Switch-Water Proof Boot-Toggle Lever-Rubber-Black

3 3110-0516 Fastener-Machine-Screw-Pan-M5x16-Pozi-ZP

4 3110-0520 Fastener-Machine-Screw-Pan-M5x20-Pozi-ZP

4 3170-0005 Fastener-Nut-Nyloc-M5-ZP

6 3270-8012 Fastener-Self Tap-Screw-CSK-8Gx1/2"-Pozi-Stainless

10 11 3310-6005 Fastener-Washer-Flat-M5-ZP

11

12

13

14

15

16

17

1 3400-1110 Filter-Basket-D150-Mesh

1 4000-6020 Hand Gun-Teejet-Trigger Jet X18-Shank 10mm

1 4100-0008 Hose-Spray-Delivery-40 Bar-8.5mm ID-Yellow

1 4100-3013 Hose-Suction-Wire Reinforced-13mm ID-Clear Plastic

2 6200-2980 Pipe-Fitting-Flojet-Elbow-10 ShankxQuad Port Pump-Nylon

1 6250-3001 Plug-Electrical-2 Pin-Male-20 Amp-With Cover

1 6800-5000 Pump-Flojet-Triplex-12 Volt-7.6LPM-Quad Ports

18

19

20

21

22

23

1 6800-5150 Pump-Flojet-Triplex-Filter-In Line-Quad Ports

1 7500-3350 Rota-Tank-& Base-35L-Spray-Natural/Red-MDPE

1 8410-8450 Strap-Tie Down-Ratchet-Blue

1 8427-6000 Sub-Lid & Ring Assembly-D150-In-Ex Vented-Nylon-Black

1 8450-2410 Switch-Electrical-Toggle-SPST-250V-16Amp

2 8790-8020 Terminal-Spade-Female-6.3mm-Blue

6

advertisement

Was this manual useful for you? Yes No
Thank you for your participation!

* Your assessment is very important for improving the workof artificial intelligence, which forms the content of this project

Related manuals

Download PDF

advertisement